You are on page 1of 24

FOR REFRIGERATION APPLICATIONS

.
. Before
Before
operatingthe
thecanned
cannedmotor
motorpump,
pump,read
readthis
this"Instruction
"InstructionManual"
Manual"and
and"Caution
"Cation
operating
Your
Safety"
avoid
improper
operation.It is
It is
essential
your
safety
and
Notes
Notes
forfor
Your
Safety"
to to
avoid
improper
operation.
essential
forfor
your
safety
and
avoiding
disaster.
avoiding disaster.
.
is imperative that the pump be shut down immediately if the bearing wear monitor
. It It
is
that the pump
be shut
down
thered
bearing
wear
monitor is in
the red. Operating
the pump
while
theimmediately
monitor is inifthe
will void
the
is inimperative
thewarranty.
red. Operating the pump while the monitor is in the red will void the warranty.

__ 4 __

__

__

ABRIDGED STARTUP PROCEDURES


(For further instructions, please see Section 5. Installation and Operation)

Sample Inspection Report

BEFORE YOU BEGIN


x
x
x
x
x

Obtain a copy of the Teikoku Inspection Report (shown above) to verify flow conditions.
Verify the liquid level in the vessel is sufficient to not cause dry running or cavitation.
Verify the reverse circulation piping is per Teikokus Reverse Circulation Piping Connection
as shown on the previous two pages.
Verify the supplied reverse circulation orifice is installed between the reverse circulation
flange at the rear of the motor and the reverse circulation piping.
Verify that the number stamped on the orifice handle matches the product code on the pump
nameplate.

PRIMING THE PUMP


Step 1: Open the reverse circulation valve and discharge valve to 100% open
Step 2: Open the suction valve to 100% open to fill the pump with liquid
Step 3: Let pump fill for a minimum of ten (10) minutes to allow vapor to vent from pump and
motor. On sub-freezing applications, wait until a layer of frost has developed on the entire motor
before starting.

__

6 __

ROTATION CHECK
Step 1: Pump must be primed before checking rotation.
Step 2: Check if suction valve, discharge valve, and reverse circulation valve are all 100% open.
Step 3: Start motor. If the Bearing Wear Monitor (TRG) swings immediately to the red, the pump
is most likely running backwards. Stop the motor, reverse the leads, and then repeat rotation
check.
(Alternate Step 3: You should also check if the discharge pressure matches the Teikoku
Inspection Report curve. If it does, the pump is rotating correctly. If the discharge pressure is
65% or less than what is shown on the curve, the pump is rotating in the reverse direction. Swap
the leads and repeat rotation check.)
STARTING THE PUMP
Step 1: Make sure the pump is primed and is running in the correct rotation. Also, verify that the
suction valve and the reverse circulation valve is 100% open.
Step 2: Close the discharge valve to 20% open
Step 3: Start the motor.
Step 4: Slowly open the discharge valve till you reach the desired flow rate.
CHECKS DURING PUMP OPERATION
x
x
x
x

Pump should be operating without excessive noise or vibration.


Compare the amperage draw to the Teikoku Inspection Report. If the amperage is above
the values shown on the chart, close the discharge valve until the amperage drops.
Confirm that the Bearing Wear Monitor (TRG) is running in the green (if bearings are
new).
Confirm the pump is running at the rated discharge pressure.

IMPORTANT: DO NOT OPERATE THE


PUMP IF THE BEARING WEAR MONITOR
IS RUNNING IN THE RED. DOING SO WILL
VOID THE WARRANTY.

__

7 __

__ 8 __

__ 9 __

__ 10 __

__ 11 __

__ 12 __

REVERSE CIRCULATION TYPE (R-TYPE, VERTICAL CONFIGURATION)

__ 13 __

__ 14 __

PUMP CIRCULATION PATH

__ 15 __

__ 16 __

__ 17 __

__ 18 __

__ 19 __

__ 20 __

__ 21 __

__ 22 __

THIS PAGE IS INTENTIONALLY LEFT BLANK

You might also like