Professional Documents
Culture Documents
What should be the minimum value of PIV for each diode of a full-wave bridge
rectifier when connected to an ac source of 30Vrms?
2.
What is the average of a half-wave rectified voltage with a peak value of 15V?
3.
4.
A half-wave rectifier develops 20Vdc, what is the value of the ripple voltage?
5.
What is the rms ripple voltage of a full-wave rectifier with output voltage of
8Vdc?
6.
A certain full-wave rectifier has a peak output voltage of 30V. A 50uF capacitor
filter is connected to the rectifier. Calculate the rms ripple and the dc output
voltage developed across a 600-Ohms load resistance? What is the percentage of
ripple?
7.
Calculate the output voltage and zener diode current in the regulator given in
figure 1-1.
Figure 1-1
8.
A voltage regulator circuit is given in figure 1-2. Explain how voltage regulation
is achieved. Determine the value of the regulated output voltage and the power
rating of transistor Q1
Figure 1-2
9.
A shunt voltage regulator is give in figure 1-3. Determine the regulated output
voltage, collector current, load current and current through the 33-Ohm resistor.
Figure 1-3
10.
Determine the output voltage for the circuit give in figure 1-4. If R3 is increased to
4700-Ohm, what happens to the output voltage?
Figure 1-4
2
11.
Explain how the voltage regulator in figure 1-5 is protected against overload.
Determine the value of R4 if the load current is to be limited to a maximum of
250mA. What power rating must R4 have?
Figure 1-5
12.
If the maximum allowable input voltage in figure 1-6 is 25V, what is the
maximum possible output current when the output short-circuited? What power
rating should R1 have?
Figure 1-6
13.
Figure 1-7
14.
Determine the regulated output voltage from the circuit given in figure 1-8
Figure 1-8
15.
For the voltage regulator circuit given in figure 1-9, determine the value of Rext if
the maximum internal regulator current is to be 250mA.
Figure 1-9
4