You are on page 1of 21

Peak Oil Theory Brian Towler

p1

The Future of Oil and Hubberts Peak Oil Theory


Introduction
Oil is the number one source of energy in the world and has been so since the middle of the
twentieth century. But ever increasing demand has caused the price to spike in recent years and
only the world economic crisis was able to temper demand and bring the price down to more
reasonable levels. However the demand and price have been increasing again as the world
economy recovers. At the same time, the peak oil theory of Hubbert1,2 predicts that world oil
supply has already peaked or is likely to peak soon. That puts even more upward pressure on the
price of oil. The theories of Hubbert have garnered a lot of credibility after his successful
prediction of the rise and fall of oil production in the United States. However, his prediction that
the world oil production would peak in 2000 and fall rapidly after that has not proven true and
fourteen years later the world oil production continues to rise according to the demands of the
world economy. But Hubberts theories still have a lot of support and many people still are
expecting that oil production is about to peak and will fall rapidly in the immediate future. They
then expect that the world will be starved of energy and resource wars will follow that will
plunge the world into a bitter struggle for control of the remaining resources that are rapidly
depleting. It is obvious that oil is a finite resource and that eventually world oil production will
peak and at some point in the distant future we will run out of it. But in this paper I will show
that the world still has plenty of oil and that if and when it does eventually peak it will not
decline as rapidly as Hubbert predicts.
Probably the leading exponent of Hubberts theories is Ken Deffeyes, a geologist who worked at
the Shell Research Labs in the early 60s as a colleague and protg of Hubbert and he has
published three books3,4,5 that espouse his theories, Hubberts Peak, The Impending World Oil
Shortage(2001)3 and Beyond Oil, The View from Hubberts Peak (2005)4 and When Oil
Peaked (2010)5. After his early work with Hubbert, Deffeyes became a Professor of Geology,
first at the University of Minnesota and then in 1967 at Princeton University. His first book
(Hubberts Peak) forecast in 2001 that the oil shortage was about to start and forecast dire
consequences for the world economy. His actual projection for the peak at that time was August,
2004. His second book (Beyond Oil) slightly revised the forecast for the world oil production
peak to occur in late 2005, and in the preface to the paperback edition (written in 2006), he
nominated December 16, 2005, as the actual date that world oil production peaked. In his third
book (When Oil Peaked) he ignores that fact that the world oil production was still rising and
continues to insist that production peaked in 2005. He points to the rapid increase in the oil price
over the last six years and, in the preface to the 2008 edition of Hubberts Peak, he
triumphantly says, I told you so.
USA and World Oil Production and Peak Oil Theory
The idea of Peak Oil Theory grew out of a 1956 paper published by Marion King Hubbert1,
who was a geologist/geophysicist who worked at the Shell Research Lab in Houston, Texas. In
his landmark paper if 1956, he proposed that any finite resource, such as oil, gas, coal or uranium
follows a bell shaped curve in its production history. At some point it reaches a peak and begins
Brian Towler 2014

Property of Reed Elsevier. Not for resale or redistribution.

Peak Oil Theory Brian Towler

p2

to decline and the decline in production will mirror the rise in production on the way up. The
peak production rate and the timing of the peak production depend on the total reserves that exist
and are to be discovered in the future. Since the bell shaped curve is a mirror image of itself,
when half of the worlds reserves are produced, the production rate will begin to decline from
that point. Hubbert asked two of his colleagues, Wallace Pratt and Lewis Weeks (both from
ExxonMobil subsidiaries), to give him estimates for the ultimate recovery of oil and gas in the
world and USA. He used these estimates to project the forecasts that he published. But
determining the ultimate reserves that are to be discovered and produced in the future was
somewhat of a guessing game, that Hubbert was not comfortable with. He then realized that if he
had the right model he did not need to guess, the production data itself could be fitted to the
model to determine what the ultimate reserves would be. From this model he worked out some
mathematical methods for forecasting the ultimate reserves. These reserves methods depended
on the model he assumed for production, and the exact equations for the bell shaped curve, but
this technique removed some of the uncertainty about the ultimate reserves.
Three of Hubberts bell shaped curves that he presented are reproduced as figs 1, 3 and 4 below.
Fig. 1 (which is fig 21 from Hubberts 1956 paper) shows his forecast for oil production in the
USA. He used two estimates of the ultimate oil reserves (150 billion and 200 billion barrels).
One of these was from Wallace Pratt and the other was the estimate from Lewis Weeks. Using
the higher estimate he forecast that USA oil production would peak in 1970 at a production rate
of 3 billion barrels per year (8.2 million b/d). Fig. 2 shows the actual oil rate in the USA on a
monthly basis. USAs oil rate did actually peak in November 1970 at 10 million b/d and in 1970
USA actually produced 3.5 billion barrels. So, Hubberts prediction was remarkably successful
and this gave a lot of credence to his methodology of what has now come to be known as Peak
Oil Theory or Hubberts Peak. Two deviations on the monthly oil plot in fig. 2 deserve some
explanation. After peaking in November 1970 the USA oil production declined for six years in
the manner predicted by Hubbert. But from January 1977 to February 1986 the oil production
rose again forming a secondary peak in that month at 9.14 million b/d. This deviation and
secondary peak was due to the discovery and production of oil in the Prudhoe Bay and Kuparuk
oil fields on the north slope of Alaska. Hubbert might argue that he did not take this area into
consideration and that, excluding the Alaska oil production, the USA oil production from 1970
did decline in the manner that he predicted. The other deviation on the plot is the incline that has
been occurring since late 2008 until the present time. This is due to oil production that is
ramping up in the deep water of the Gulf of Mexico and the unconventional oil that is coming
from the Bakken oil play in North Dakota. If allowed to continue these oil sources are likely to
cause the USA oil production to keep increasing to form a tertiary peak sometime after 2020.
Once again, Hubbert might argue that he was talking about conventional onshore oil and he did
not take these unconventional plays into consideration. Despite these two deviations Hubberts
predictions for USA production proved to be remarkably accurate.

Brian Towler 2014

Property of Reed Elsevier. Not for resale or redistribution.

Peak Oil Theory Brian Towler

Fig. 1 Hubberts fig 21 shows his 1956 Forecast for USA Oil Production. (Hubbert, 1956)1

Brian Towler 2014

Property of Reed Elsevier. Not for resale or redistribution.

p3

Peak Oil Theory Brian Towler

p4

10000

Crude Oil Production (Thousands of barrels per day)

9000
8000
7000
6000
5000
4000
3000
2000

Monthly Crude Oil Production, USA

1000
0
1920

1930

1940

1950

1960

1970

1980

1990

2000

2010

Fig. 2 Actual Monthly USA Oil Production (Data Source: EIA)


When Hubbert turned his attention to the forecast of world oil production he produced the
estimate shown in fig 4 (his figure 20). This was based on ultimate oil reserves of 1.25 trillion
barrels. His forecast showed a peak production of 12.5 billion barrels per year (34.25 million
b/d) and it occurred in the year 2000. Later in his 1969 paper2 he revised his numbers to show
two estimates of ultimate recovery, 1.35 trillion barrels and 2.1 trillion barrels. The more
optimistic 2.1 trillion barrel estimate again peaked in the year 2000 at 37.5 billion barrels per
year (103 million b/d).

Brian Towler 2014

Property of Reed Elsevier. Not for resale or redistribution.

Peak Oil Theory Brian Towler

Fig. 3 Hubberts 1956 Forecast for World Oil Production. (Hubbert, 1956)1

Brian Towler 2014

Property of Reed Elsevier. Not for resale or redistribution.

p5

Peak Oil Theory Brian Towler

p6

Fig. 4 Hubberts 1969 Forecast of World Oil Production. (Hubbert, 1969)2


It is obvious that the Hubbert forecasts depend on knowing how much oil can be discovered and
produced in the world and critics of his method say that this number is only a guess. Can we
really know how much oil is going to be eventually discovered and produced in the world?
Supporters point out that the timing of the peak is not sensitive to the actual number assumed for
the ultimate recovery. Indeed if you examine figs 4 and 5 where three numbers are assumed for
the ultimate recovery, ranging from 1.25 trillion to 2.1 trillion barrels, the peak still occurs
around the year 2000. Hubbert himself tackled this problem and, borrowing from the
mathematics of biological population growth and decay, he devised the mathematical method for
forecasting the number for ultimate recovery, which I designate here as Qmax. The equations he
used starts with the equation for the cumulative production, Qt, at any time (t). The production
rate, qt, at any time t is the derivative of Qt with respect to time, t:

Where

(1)

1+

Qt = cumulative production at time, t, usually in barrels


qt = production rate at time, t, usually in barrels/day
Qmax = ultimate cumulative production, usually in barrels
a = growth or decline coefficient, dimensionless
Brian Towler 2014

Property of Reed Elsevier. Not for resale or redistribution.

Peak Oil Theory Brian Towler

p7

b = growth or decline exponent, dimensions are the reciprocal of time, e.g. 1/days
The production rate, qt at any time (t) is the derivative of the cumulative and so is given by

(2)

1+

Equation 2 is the equation for the production plots shown in figs 1-4. If this model is the correct
model for the production data then, as long as we have some early time data, we can fit the data
to the model and determine the ultimate recovery, Qmax, as well as the parameters a and b. There
are several ways to determine the parameters from the data. The method that Hubbert
recommended was to combine equations 1 and 2 to give:

= 1

(3)

Equation 5.3 can then be rearranged to give:

(4)

Equation 4 then says that if I plot qt/Qt versus Qt then the intercept on the y axis is the parameter
b and the intercept on the x axis is the ultimate recoverable oil, Qmax. This plot can be done at
any time, even before the peak rate is reached. The timing of the peak can be calculated by
taking the derivative of equation 2 and setting it equal to zero. This leads to:
1

= ln()

(5)

But to use equation 5 we need to know the parameter a, which was not determined from the plot
of equation 4. The easiest way to determine the parameter, a, is to rearrange equation 1 into the
form:

1 =

(6)

Equation 6 says that if I plot the (Qmax/Qt 1) versus e-bt then the slope of the plot will be equal
to a. To do this second plot we assume we have already determined b and Qmax from the plot of
equation 5.4. Deffeyes showed his plot of equation 4 using the world production data up until
2005, which is reproduced here as fig. 5. His extrapolation to the x axis shows an intercept of 2
trillion barrels, which is his estimate of the ultimate recoverable oil, Qmax. Note that prior to
Brian Towler 2014

Property of Reed Elsevier. Not for resale or redistribution.

Peak Oil Theory Brian Towler

p8

1983 the data was increasing and deceasing and had not settled down to form a straight line. But
from 1983 to 2005 the data does lie on the straight line that Hubberts theory predicts. Deffeyes
was also able to deduce his estimate for the time of the peak oil rate directly from his plot,
because if the ultimate recovery is projected to be 2 trillion barrels then the peak oil rate will
occur when the cumulative production is 1 trillion barrels. This occurred in 2005 and led
Deffeyes to predict that oil production would peak in that year.

Fig. 5 Deffeyes Plot of Equation 5.4 for World Oil Production (Deffeyes, Beyond Oil)4
But world oil production did not peak in 2000 or in 2005. Fig 6 shows annual world oil
production from 1965 to 2010 and at that time the production was still increasing. Fig 7 shows
the world oil production on a monthly basis from the beginning of 1994 to early 2011 and though
there are occasional declines the overall trend on both plots is upwards and there is no evidence
that a peak has occurred or will occur. The occasional dips in production that have occurred in
the past 45 years are due to decreases in demand rather than decreases in supply. However this
does not stop the pundits from declaring that world oil production has peaked every time the
Brian Towler 2014

Property of Reed Elsevier. Not for resale or redistribution.

Peak Oil Theory Brian Towler

p9

production decreases from one year to the next or even from one month to the next. Figs 6 and 7
use data from two different sources. The data for fig 6 come from the BP Annual Statistical
Review, while the data for fig. 7 come from the US Energy Information Agency (EIA). So any
discrepancies that are perceived between the two plots are due to the different data sources. What
is important is that both plots show a consistent upward trend in world oil production.
Production did show a secondary peak in 1979 and from 1979 to 1983 production did decrease.
This was due to a steep increase in the world oil price in the 1970s, which resulted in decreased
demand in the early 1980s as people reduced their use of transportation fuels. But from 1983 to
the present day there has been a steady increase in oil demand, which has been matched by
supply. The world economic crisis that was precipitated in the middle of 2008, tempered
demand, causing a decrease in production in late 2008. But from January 2009 to January 2011
there was a persistent increase in production. The uprising in Libya and other countries in the
Middle East in early 2011, which is being called the Arab Spring, has once again caused a new
round of price increases and a resulting decrease in demand for oil but this too is expected to be
temporary.

World Oil Production (Million barrels per day)

90
80

Annual World Oil Production

70
60
50
40
30
20
10
0
1965

1970

1975

1980

1985

1990

1995

2000

2005

2010

Fig 6 Annual World Oil Production Since 1965 (Data Source: BP Annual Review)

Brian Towler 2014

Property of Reed Elsevier. Not for resale or redistribution.

Peak Oil Theory Brian Towler

p10

World Oil Production (million barrels per day)

90

Monthly World Oil Production


85

80

75

70

65

60
1994

1996

1998

2000

2002

2004

2006

2008

2010

Fig 7 Monthly World Oil Production Since 1994 (Data Source: EIA)
So what is wrong with the Hubbert model and the analysis of his supporters that has caused their
prognostications about the timing of peak oil to be off? I believe that the Hubbert model is
essentially correct under a constant price and constant technology scenario. However when the
oil price increases, the value of Qmax also increases, as more oil becomes economic to produce.
Technology also has an impact. Technology breakthroughs bring more oil reserves into
production even under a constant price scenario. Additionally, when the price of oil increases,
there is an incentive to develop new technologies, which also increases the oil supply. Price
increases and technology breakthroughs seem to unlock large volumes of oil that were
previously not economic to produce. In the past twenty years, large reserves in the Canadian oil
sands have come on stream. New fracture stimulation and horizontal drilling technologies have
also unlocked large reserves of tight oil, tight gas and shale gas. The Canadian oil sands in
Alberta have currently booked reserves of 170 billion barrels and the possible reserves reach as
high as 1 trillion barrels. Compare that to the slightly more than one trillion barrels of oil that
have been produced in the world up until the present time and the one trillion barrels of
conventional oil that Deffeyes and Hubbert say are left to be produced. Hundreds of billions of
barrels of oil in the Bakken formation in North Dakota, Montana, Manitoba and Saskatchewan
are also being unlocked with horizontal wells and multi-zone fracture stimulations. The success
in the Bakken is also opening up more formations to successful production, such as the Eagle
Ford in Texas, the Granite Wash in Oklahoma and the Texas Panhandle, the Niobrara in
Brian Towler 2014

Property of Reed Elsevier. Not for resale or redistribution.

Peak Oil Theory Brian Towler

p11

Colorado and Wyoming, the Monterey in California and the Utica formation in Eastern Ohio.
Vast quantities of oil have also been discovered in the deep waters of the Gulf of Mexico and in
the Santos offshore basin in Brazil. As these technologies are developed they will be applied to
many other areas around the world.
$140

Average World Price of Crude Oil ($/barrel)

$120

$100

$80

$60

$40

$20

$0
1989

1991

1993

1995

1997

1999

2001

2003

2005

2007

2009

2011

Fig. 8 Average World Price of Crude Oil (Data Source: EIA)


Fig 8 shows the average price of crude oil in the world since 1989 (as determined by the US
Energy Information Administration (EIA)). The price increases of 2007-2008 and 2011 have
accelerated the deployment of these new technologies as well as the economic development of
other marginal reserves. From 1986 to 2005 the price of oil remained relatively constant at
around $20/barrel but the warnings from the peak oil theorists in the twenty-first century may
have caused the market to start anticipating supply shortages and this, and the political upheavals
in the Middle East in 2011, have driven up the price of oil. At the same time they have driven up
the value of the worlds ultimate oil reserves, Qmax, and pushed out the timing of the peak
production, tpeak. These developments not only affect Qmax and tpeak but will also affect the
decline in production on the back side of the Hubbert curve. I will show that we will not be
sliding down the other side of the curve in the manner that the Hubbert model forecasts or that
the theorists expect. To illustrate this point it is necessary to examine the USA natural gas
Brian Towler 2014

Property of Reed Elsevier. Not for resale or redistribution.

Peak Oil Theory Brian Towler

p12

production curves, which we will look at in the next section of this paper. The history of the US
natural gas production has considerable relevance to the trends in world oil supply.
At this point you might also ask why did the Hubbert model work so well in the prediction of the
USA oil supply but does not seem to be working, and will not continue to work, for predicting
the world oil supply. The answer is simple. The oil market is a world market and the USA oil
production peaked and declined amidst a relatively constant world oil price. Even though the
USA supply was decreasing, the world supply of oil was stable and the price remained relatively
constant from 1986 to 2005. The Hubbert model works as long as the price remains stable. But
the world price is now ramping upwards and this will profoundly change the dynamics of the
Hubbert model.
For example, if the production data shown in fig. 6 are plotted according to equation 4 we get
fig. 9. Extrapolating this to the x-axis gives a value for Qmax of 2.54 trillion barrels, compared
with the value of 2 trillion barrels that Deffeyes got using this same data up until 2005. But
between 2004 and 2010 the price of oil increased from $20/barrel to $100/barrel and the tight oil
in the Bakken and Eagle Ford formations, and the heavy oil sands in Canada and the deepwater
oil in the Gulf of Mexico and the Santos Basin became economic to find and produce. In fact
another half trillion barrels of oil became economic to produce. If the monthly data published by
the EIA, and shown plotted in fig. 7, is used to do the same plot, an even more startling
revelation emerges. This plot is shown in fig 10. This is the monthly data from January 1994 to
March 2011 and comes from a very reliable source (EIA). When this data is extrapolated to the
x-axis the Qmax is 3.055 trillion barrels. Of this 3 trillion barrels 1.3 trillion barrels has already
been produced, leaving about 1.7 trillion barrels still to be found and produced. The current
listed world oil proved reserves according to EIA is 1.3 trillion barrels, meaning that there are
only 400 billion barrels still to be found. But remember that these numbers are a function of oil
price and are likely to be conservative. But since this data is probably the most reliable available
data, this estimate is probably the most reliable estimate using current economics. It would seem
that more oil is appearing all the time. This is due to economics. If and when the price of oil
goes up again, and stays up, these numbers will increase again.
The value for the exponential coefficient parameter, a, is obtained using a plot of equation 6.
Using this plot and the monthly data from EIA, I obtained a value for a:
a = 162.66
The intercept on the y-axis in fig.10 gave me the value for b:
b = 0.00011733 days-1
Using these values for a and b, I can insert these numbers into equation 5 to calculate the date for
the timing of the world peak oil rate.

Brian Towler 2014

1
1
ln() =
ln(162.66) = 43,396

0.00011733

Property of Reed Elsevier. Not for resale or redistribution.

Peak Oil Theory Brian Towler

p13

The 43,396 days is measured from an arbitrary time zero, used in the plots, which was 1/1/1900.
This equation gives me a peak oil date of October 23, 2018. Note that I am not saying that the
world oil production will peak in October 2018. I am saying that using the Hubbert model and
the latest and most accurate monthly world oil production data the current projection for the
peak oil rate is October 23, 2018. If the price of oil remained constant for the next seven years
and there were no big technological breakthroughs during this time this may prove to be an
approximately accurate forecast. But I dont expect that this will be the case and so this date
will probably move again.

0.0002

qt/Qt (1/days)

0.00015

0.0001

0.00005

0
0

0.5

1.5

2.5

Cumulative World Oil Production, Qt (Trillion Barrels)

Fig. 9 Plot of Equation 4 for World Oil Production Data Shown in Fig. 6 (Data Source: BP Annual
Review)

Brian Towler 2014

Property of Reed Elsevier. Not for resale or redistribution.

Peak Oil Theory Brian Towler

p14

0.00014

0.00012

qt/Qt (1/days)

0.0001

0.00008

0.00006

0.00004

0.00002

0
0

0.5

1.5

2.5

3.5

Cumulative World Oil Production, Qt (Trillion Barrels)

Fig. 10 Plot of Equation 4 for World Oil Production Data Shown in Fig. 7 (Data Source: EIA)
The USA Gas Supply Analogy to the World Oil Supply
The US gas supply trends have a lot of relevance to the world oil supply behavior. In his 1956
paper1 Hubbert made a forecast of the USA natural gas production, which is reproduced in fig.
11 (his fig 22). This showed the nations gas production also peaking in the early 1970s
(around1972) at about 14 trillion cubic feet per year (38 billion cubic feet per day), with an
ultimate cumulative production (Qmax) of 850 trillion cubic feet. His figure also showed a line
for the projected gas consumption rate which continues to increase after the nations gas
production peaks and starts to decline. This was a projection using data supplied by Wallace
Pratt. Fig. 12 shows the actual USA dry gas production. The units of production rate on this plot
are BCF/day. The data shows that the USA peaked in 1973 (almost exactly when Hubbert
forecast it) at just below 60 BCF/day. His forecast of the peak year was quite accurate even
though his forecast of peak rate was low. The consumption of gas continued to increase as his
plot showed and the shortfall that occurred after 1973 was met by imports, mostly by pipeline
from Canada.

Brian Towler 2014

Property of Reed Elsevier. Not for resale or redistribution.

Peak Oil Theory Brian Towler

p15

Fig. 11 Hubberts 1956 Forecast for USA Natural Gas Production (Hubbert, 1956)1
70

USA Dry Gas Production (BCF/day)

Dry Gas Production (BCF/day)

60
50
40
30
20
10
0

Brian Towler 2014

Property of Reed Elsevier. Not for resale or redistribution.

2010

2006

2002

1998

1994

1990

1986

1982

1978

1974

1970

1966

1962

1958

1954

1950

1946

1942

1938

1934

1930

Fig. 12 Actual USA Dry Gas Production (Data Source: EIA)

Peak Oil Theory Brian Towler

p16

In Fig. 12 the production is shown on an annual basis up until 1997 and on a monthly basis from
1997 until the present time (2011). However the decline in production after the peak in 1973 did
not happen according to Hubberts forecast. The rate began to decline for two years then
remained constant for five years. The decline then resumes, finally bottoming out at 44 BCF/day
in 1986. Since then there has been a steady increase in production. The production started to
increase more sharply in 2006 and today we are making about 63 BCF/day of dry gas. This is
more gas than the US was making at the peak in 1973. If the production had declined in a mirror
image of the front side of the peak, in 2010 we would expect to see a gas production rate the
same as in 1936, when the production was only 6 BCF/day. Instead we are making more than
ten times that amount. The Hubbert method has failed miserably to forecast what has happened
on the back side of the US gas production curve. The reason for this is economics. Once the
nations gas supply peaked and a gas shortage developed, the price of gas began to increase. The
increased price shook loose gas that was previously uneconomic to produce and the industry
began to develop technologies to find and produce coal-bed methane, tight gas and shale gas.
This is unconventional gas and it accounts for the majority of the current US gas supply. The US
surpassed Hubberts estimate of the total ultimate recovery of 850 trillion cubic feet of gas in
1997, and so far have produced more than 1,120 trillion cubic feet without reaching any new
peak. Fig 13 shows the gas production repeated with the average annual gas price, which
illustrates the effect that price has on the supply. The steep run up in the gas price after the peak
has created new supplies of gas, causing the Hubbert model to fail on the back side.
The same thing did not happen to the USA oil supply curve because the oil market is a global
market. The price for US oil could not be pushed up in the same way that the gas price was
pushed up because the US has always imported a significant portion of its oil and so the US oil
producers were constrained to the world price of oil. The world price of oil remained relatively
low until recently. However, apart from Canadian supplies and a small and expensive liquefied
natural gas (LNG) market, the US gas market is relatively insular.
This analogy illustrates that economics affects the supply of commodities such as oil and gas. In
the case of the world oil supply the price of oil has recently been pushed up before the peak of
the oil production has been reached. This in turn has pushed out the timing of the peak and
indeed the total cumulative production. When the world production of oil does eventually peak
(as it must) the back side of the curve will not be a mirror image of the front side of the curve as
Hubbert has forecast. It probably will not look like the back side of the US gas supply curve
either. It will be controlled by economics and technology, which at this stage are a little difficult
to predict.
In his 2010 book When Oil Peaked, Ken Deffeyes presents several proofs and analogies to
show that the production curves must be symmetrical, that the back side of the curve must be a
mirror image of the front side. All of these proofs depend on a constant oil price, which clearly
will not happen. If and when oil production does peak the shortage of supply will push the price
of oil up and the back side of the curve will not be a mirror image of the front side. The fact that
the USA gas production curve is not symmetrical is an indication of the fallacy of Hubberts
assumption and the subsequent proofs by Deffeyes. I can envisage one scenario where the back
side of the world oil production curve might be a mirror image of the front side. At $100/barrel
Brian Towler 2014

Property of Reed Elsevier. Not for resale or redistribution.

Peak Oil Theory Brian Towler

p17

gas to liquids and coal to liquids technology is economic. If the world began to shift rapidly to
these technologies and they are able to maintain their supply at a high enough rate to keep the
price of oil constant then the back side of the oil production curve might then be a mirror image
of the front side

$7

USA Dry Gas Production and Wellhead Price

60

$6

50

$5

40

$4

30

$3

20

$2

10

$1

$0
2010

2006

2002

1998

1994

1990

1986

1982

1978

1974

1970

1966

1962

1958

1954

1950

1946

1942

1938

1934

1930

Fig. 12 USA Dry Gas Production With Average Annual Wellhead Price (Data Source: EIA)

Brian Towler 2014

Property of Reed Elsevier. Not for resale or redistribution.

Average Annual Wellhead Gas Price ($/MMBTU)

Dry Gas Production (BCF/day)

70

Peak Oil Theory Brian Towler

p18

World Oil Reserves


The top twenty countries in the world in terms of proved oil reserves are shown in table 1
Table 1 Crude Oil Proved Reserves (Billion Barrels) (Data Source: EIA)
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20

Saudi Arabia
Venezuela
Canada
Iran
Iraq
Kuwait
United Arab Emirates
Russia
Libya
Nigeria
Kazakhstan
Qatar
United States
China
Brazil
Algeria
Mexico
Angola
Azerbaijan
Ecuador

262.6
211.2
175.2
137.0
115.0
104.0
97.8
60.0
46.4
37.2
30.0
25.4
20.7
20.4
12.9
12.2
10.4
9.5
7.0
6.5

The number 2 and 3 countries on this list, Venezuela and Canada, owe the majority of their
reserves to their heavy oil sands. The total reported proved reserves of crude oil for the entire
world is 1.3 trillion barrels, although certain peak oil theorists do not believe that these reserves
are correct because they believe that some OPEC members inflate their reserves so that they can
get a higher production allocation. I have no reason to believe that these numbers are not
approximately accurate and reasonable.
Table 2 Crude Oil Production Rates in 2010 (Thousands of Barrels/day) (Data Source: EIA)
1
2
3
4
5
6
7
8

Russia
Saudi Arabia
United States
Iran
China
Canada
Mexico
Nigeria

9674
8900
5474
4080
4076
2734
2621
2455

Brian Towler 2014

Property of Reed Elsevier. Not for resale or redistribution.

Peak Oil Theory Brian Towler

9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30

United Arab Emirates


Iraq
Kuwait
Venezuela
Brazil
Angola
Norway
Algeria
Libya
Kazakhstan
United Kingdom
Qatar
Azerbaijan
Indonesia
Oman
Colombia
India
Argentina
Malaysia
Egypt
Sudan
Ecuador

p19

2415
2399
2300
2146
2055
1939
1869
1729
1650
1525
1233
1127
1035
953
865
786
751
642
554
523
511
486

The worlds top thirty producing countries are listed in table 2. Production rates should have an
approximate correlation to reserves, the higher the reserves the higher should be the production
rate. In this respect USA does very well. It is producing 5.47 Million b/d from only 20.7 billion
barrels of reserves. Countries such as Canada and Venezuela clearly have the capacity to
increase their production, although most of their reserves are tied up in very heavy oil, which
limits their production rates, because the viscosity of the oil is so low. If Saudi Arabia really has
263 billion barrels of reserves, and I believe that they do, then they could also increase their rates
substantially and they have done this at times. But Saudi Arabia has elected to operate as the
worlds swing producer, increasing their production when the world demand increases and
decreasing production when demand decreases. The Saudis would be happy to increase
production if the world demanded it but they are aware that when the price gets too high demand
decreases, and the world starts looking for alternatives. USA is producing about the same
amount of oil as Saudi Arabia with less than one tenth of their reserves.
There are other countries that also have the capacity to increase their production, and one way to
gauge this is to calculate their reserve life, the number of years it would take to produce their
reserves if they keep producing at the current rates. Table 3 shows the reserve life of the top
thirty countries in this category. Note that the top two countries on this list are once again
Venezuela and Canada because of their heavy oil reserves. Any country that has over thirty
years of reserve life probably has the potential to increase their production. The USA does not
appear in the top thirty on this list because the USA reserve life is only 10.35 years. USA
Brian Towler 2014

Property of Reed Elsevier. Not for resale or redistribution.

Peak Oil Theory Brian Towler

p20

cannot keep producing oil at its current high rates relative to its reserves unless they are
continually drilling new wells and finding more oil. As soon as USA stops drilling its
production rate plummets.
Conclusions
The peak in world oil production is dependent on economics and is not likely to occur before
2018. This date will be further extended by rising oil prices and technology developments.
When oil rate does eventually peak the back side of the curve will not be a mirror image of the
front side of the curve in the manner that Hubbert has predicted. There is still plenty of oil in the
world and production will continue to meet demand for some time yet.
References
1. M.K. Hubbert, Nuclear Energy and the Fossil Fuels, American Petroleum Institute,
Drilling and Production Practices, Proc. Spring Meet., 1956
2. M.K. Hubbert, Energy Resources, in National Research Council Committee on
Resources and Man, W.H. Freeman, San Francisco, 1969
3. K. S. Deffeyes, Hubberts Peak, The Impending World Oil Shortage, Princeton
University Press, Princeton NJ, 2001
4. K. S. Deffeyes, Beyond Oil, The View from Hubberts Peak, Hill and Wang, New
York NY, 2005
5. K. S. Deffeyes, When Oil Peaked, Hill and Wang, New York NY, 2010.

Brian Towler 2014

Property of Reed Elsevier. Not for resale or redistribution.

Peak Oil Theory Brian Towler

p21

Table 3 Reserve Life (Years) of Oil Producing Countries


1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30

Venezuela
Canada
Iraq
Kuwait
United Arab Emirates
Iran
Saudi Arabia
Libya
Qatar
Kazakhstan
Netherlands
Nigeria
Ecuador
Chad
Yemen
Bolivia
Sudan
Gabon
Egypt
Brunei
Australia
India
Poland
Trinidad and Tobago
Peru
Malaysia
Algeria
Syria
Romania
Azerbaijan

269.62
175.61
131.32
123.86
110.97
91.99
80.84
77.08
61.71
53.89
42.47
41.51
36.69
32.57
31.93
29.69
26.79
24.01
23.05
22.13
20.88
20.72
20.45
20.31
20.08
19.78
19.34
18.66
18.65
18.54

More information: The material for this blog was taken from Dr Towlers new book, The
Future of Energy, to be published by Elsevier in June 2014.

Brian Towler 2014

Property of Reed Elsevier. Not for resale or redistribution.

You might also like