VNX - Su Avensis Ewd 2005 PDF

FOREWORD
This wiring diagram manual has been prepared to provide

information on the electrical system of the AVENSIS.
Applicable models: AZT250 Series

ZZT250, 251 Series
CDT250 Series
For service specifications and repair procedures of the above

models other than those listed in this manual, refer to the
following manuals;
Manual Name
D AVENSIS Chassis and Body Repair
Volume 1
Volume 2
D 1AZFSE Engine Repair Manual
D AVENSIS New Car Features
Pub. No.
RM1018E1
RM1018E2
RM1019E
NCF240E
All information in this manual is based on the latest product

information at the time of publication. However, specifications
and procedures are subject to change without notice.
NOTICE
When handling supplemental restraint system components (removal,
installation or inspection, etc.), always follow the direction given in the repair
manuals listed above to prevent accidents and supplemental restraint
system malfunction.
http://vnx.su
A INTRODUCTION
This manual consists of the following 13 sections:
Section
No.
Description
INDEX
Index of the contents of this manual.
INTRODUCTION
Brief explanation of each section.
HOW TO USE THIS

MANUAL
Instructions on how to use this manual.
TROUBLE
SHOOTING
Describes the basic inspection procedures for electrical circuits.
ABBREVIATIONS
Defines the abbreviations used in this manual.
GLOSSARY OF
TERMS AND
SYMBOLS
Defines the symbols and functions of major parts.
RELAY LOCATIONS
Shows position of the Electronic Control Unit, Relays, Relay Block, etc.
This section is closely related to the system circuit.
ELECTRICAL
WIRING ROUTING
Describes position of Parts Connectors, Splice points, Ground points, etc.

INDEX
Index of the system circuits.
SYSTEM CIRCUITS
Electrical circuits of each system are shown from the power supply through ground
points. Wiring connections and their positions are shown and classified by code
according to the connection method. (Refer to the section, How to use this manual).
The System Outline and Service Hints useful for troubleshooting are also contained
in this section.
GROUND POINT
Shows ground positions of all parts described in this manual.
POWER SOURCE
(Current Flow Chart)
Describes power distribution from the power supply to various electrical loads.
CONNECTOR LIST
Describes the form of the connectors for the parts appeared in this book.
PART NUMBER OF
CONNECTORS
Indicates the part number of the connectors used in this manual.
OVERALL
ELECTRICAL
WIRING DIAGRAM
Provides circuit diagrams showing the circuit connections.
2
AVENSIS (EWD526E)
http://vnx.su
HOW TO USE THIS MANUAL B

This manual provides information on the electrical circuits installed on vehicles by
dividing them into a circuit for each system.
The actual wiring of each system circuit is shown from the point where the power
source is received from the battery as far as each ground point. (All circuit
diagrams are shown with the switches in the OFF position.)
When troubleshooting any problem, first understand the operation of the circuit
where the problem was detected (see System Circuit section), the power source
supplying power to that circuit (see Power Source section), and the ground points
(see Ground Point section). See the System Outline to understand the circuit
operation.
When the circuit operation is understood, begin troubleshooting of the problem
circuit to isolate the cause. Use Relay Location and Electrical Wiring Routing
sections to find each part, junction block and wiring harness connectors, wiring
harness and wiring harness connectors, splice points, and ground points of each
system circuit. Internal wiring for each junction block is also provided for better
understanding of connection within a junction block.
Wiring related to each system is indicated in each system circuit by arrows
(from__, to__). When overall connections are required, see the Overall Electrical
Wiring Diagram at the end of this manual.
3
AVENSIS (EWD526E)
http://vnx.su
B HOW TO USE THIS MANUAL

The system shown here is an EXAMPLE ONLY. It is different to the actual
circuit shown in the SYSTEM CIRCUITS SECTION.
[A]
Stop Light
From Power Source System (See Page 66)
15A
STOP
7.5A
GAUGE
4
IB
[B]
R L
3 IB
1 IB
[C]
2 IB
R L
L (S/D)
R (W/G)
W R
[G]
[E]
14 IE1
[D]
Rear
Lights
S6
Stop Light SW
1
I5
[F]
Y G
G W
L (S/D)
G W
13
G W
ABS ECU
C7
Combination
Meter
H17
High Mounted
Stop Light
[K]
1
W B
B18
W B
1
W B
BV1
BO
50
[L]
BL
[M]
AVENSIS (EWD526E)
http://vnx.su
W B
W B
[J]
(Shielded)
R6
Rear Combination Light LH
Stop
W B
[I]
B18
G R
R7
Rear Combination Light RH
G R
1
G R
BV1
Stop
11
G B
[H]
G R
L4
Light Failure Sensor
B
[A] : System Title
[H] : Indicates the wiring color.

Wire colors are indicated by an alphabetical code.
[B] : Indicates a Relay Block. No shading is used and

only the Relay Block No. is shown to distinguish it
from the J/B
Example:
Indicates Relay Block No.1
= Black
W = White
BR = Brown
= Blue
SB = Sky Blue
= Violet
R = Red
G = Green
LG = Light Green
[C] : (
) is used to indicate different wiring and
connector, etc. when the vehicle model, engine
type, or specification is different.
GR = Gray
[D] : Indicates related system.
The first letter indicates the basic wire color and the
second letter indicates the color of the stripe.
= Pink
= Yellow
O = Orange
[E] : Indicates the wiring harness and wiring harness

connector. The wiring harness with male terminal is
).
shown with arrows (
Outside numerals are pin numbers.
Example:
LY
L
(Blue)
[I]
Female
Male (
Y
(Yellow)
: Indicates a wiring Splice Point (Codes are E for the

Engine Room, I for the Instrument Panel, and B
for the Body).
The first letter of the code for each wiring harness

and wiring harness connector(s) indicates the
components location, e.g, E for the Engine
Compartment, I for the Instrument Panel and
Surrounding area, and B for the Body and
Surrounding area.
When more than one code has the first and second
letters in common, followed by numbers (e.g, IH1,
IH2), this indicates the same type of wiring harness
and wiring harness connector.
[F] : Represents a part (all parts are shown in sky blue).
The code is the same as the code used in parts
position.
[G] : Junction Block (The number in the circle is the J/B
No. and the connector code is shown beside it).
Junction Blocks are shaded to clearly separate
them from other parts.
Example:
3C indicates that
it is inside
Junction Block
No.3
The Location of splice Point I 5 is indicated by the

shaded section.
[J] : Indicates a shielded cable.
[K] : Indicates the pin number of the connector.

The numbering system is different for female and
male connectors.
Example: Numbered in order
from upper left to
lower right
Female
Numbered in order
from upper right to
lower left
Male
[L] : Indicates a ground point.

The first letter of the code for each ground point(s)
indicates the components location, e.g, E for the
Engine Compartment, I for the Instrument Panel
and Surrounding area, and B for the Body and
Surrounding area.
[M] : Page No.
5
AVENSIS (EWD526E)
http://vnx.su

[N]
System Outline
Current is applied at all times through the STOP fuse to TERMINAL 2 of the stop light SW.
When the ignition SW is turned on, current flows from the GAUGE fuse to TERMINAL 8 of the light failure sensor, and also flows
through the rear lights warning light to TERMINAL 4 of the light failure sensor.
Stop Light Disconnection Warning
When the ignition SW is turned on and the brake pedal is pressed (Stop light SW on), if the stop light circuit is open, the current
flowing from TERMINAL 7 of the light failure sensor to TERMINALS 1, 2 changes, so the light failure sensor detects the
disconnection and the warning circuit of the light failure sensor is activated.
As a result, the current flows from TERMINAL 4 of the light failure sensor to TERMINAL 11 to GROUND and turns the rear lights
warning light on. By pressing the brake pedal, the current flowing to TERMINAL 8 of the light failure sensor keeps the warning
circuit on and holds the warning light on until the ignition SW is turned off.
[O]
Service Hints
S6 Stop Light SW
21 : Closed with the brake pedal depressed
L4 Light Failure Sensor
1, 2, 7Ground : Approx. 12 volts with the stop light SW on
4, 8Ground : Approx. 12 volts with the ignition SW at ON position
11Ground : Always continuity
[P]
: Parts Location
Code
See Page
Code
See Page
Code
See Page
C7
34
L4
36
R7
37
H17
36
R6
37
S6
35
[Q]
: Relay Blocks
Code
1
[R]
See Page
18
Relay Blocks (Relay Block Location)

R/B No.1 (Instrument Panel Brace LH)
: Junction Block and Wire Harness Connector

Code
See Page
Junction Block and Wire Harness (Connector Location)
IB
20
Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)
3C
22
Instrument Panel Wire and J/B No.3 (Instrument Panel Brace LH)
[S]
: Connector Joining Wire Harness and Wire Harness

Code
See Page
Joining Wire Harness and Wire Harness (Connector Location)
IE1
42
Floor Wire and Instrument Panel Wire (Left Kick Panel)
BV1
50
Luggage Room Wire and Floor Wire (Luggage Room Left)
[T]
: Ground Points
Code
See Page
Ground Points Location
BL
50
Under the Left Center Pillar
BO
50
Back Panel Center
[U]
: Splice Points
Code
I5
See Page
44
Wire Harness with Splice Points

Cowl Wire
Code
B18
See Page
50
6
AVENSIS (EWD526E)
http://vnx.su

Luggage Room Wire
B
[N] : Explains the system outline.
[O] : Indicates values or explains the function for reference during troubleshooting.
[P] : Indicates the reference page showing the position on the vehicle of the parts in the system circuit.
Example : Part L4 (Light Failure Sensor) is on page 36 of the manual.
The letter in the code is from the first letter of the part, and the number indicates its order in parts
starting with that letter.
Example : L 4
Parts is 4th in order

Light Failure Sensor
[Q] : Indicates the reference page showing the position on the vehicle of Relay Block Connectors in the system circuit.
Example : Connector 1 is described on page 18 of this manual and is installed on the left side of the instrument
panel.
[R] : Indicates the reference page showing the position on the vehicle of J/B and Wire Harness in the system circuit.
Example : Connector 3C connects the Instrument Panel Wire and J/B No.3. It is described on page 22 of this
manual, and is installed on the instrument panel left side.
[S] : Indicates the reference page describing the wiring harness and wiring harness connector (the female wiring
harness is shown first, followed by the male wiring harness).
Example : Connector IE1 connects the floor wire (female) and Instrument panel wire (male). It is described on
page 42 of this manual, and is installed on the left side kick panel.
[T] : Indicates the reference page showing the position of the ground points on the vehicle.
Example : Ground point BO is described on page 50 of this manual and is installed on the back panel center.
[U] : Indicates the reference page showing the position of the splice points on the vehicle.
Example : Splice point I5 is on the Cowl Wire Harness and is described on page 44 of this manual.
7
AVENSIS (EWD526E)
http://vnx.su

The ground points circuit diagram shows the connections from all major parts to the respective ground points. When
troubleshooting a faulty ground point, checking the system circuits which use a common ground may help you identify
the problem ground quickly. The relationship between ground points ( EA , IB and IC shown below) can also be
checked this way.
I GROUND POINT
WB
WB
FAN MAIN Relay
FAN MAIN Relay
A/C Control Assembly

WB
WB
A/C Relay No.3
WB
O/D Main SW
E3
WB
A WB
Clock
E3
Blower Motor
I6
WB
A/C Relay No.2
WB
Cigarette Lighter
WB
Blower SW
I6
WB
WB
Parking Brake SW
E3
J1
Junction
Connector
WB
Radiator Fan Motor
E3
7
3B
WB
Headlight Cleaner Relay
E2
WB
Combination Meter
WB
WB
Headlight LH
E4
E5
WB
WB
WB
E5
WB
Front Turn Signal Light LH
WB
E4
WB
WB
Front Fog Light LH
3
3F
13
3G
WB
WB
Brake Fluid Level SW
E6
WB
Door Lock Control SW
WB
B4
2
IA1
Cruise Control ECU
Remote Control Mirror SW
Turn Signal Flasher
5
3E
WB
Front Clearance Light LH

WB
I2
1
3D
WB
Front Clearance Light RH
WB
WB
Front Fog Light RH
WB
E4
E4
WB
Front Turn Signal Light RH
Combination SW
7
3C
WB
Headlight RH
WB
6
3E
WB
I4
WB
Defogger SW
I2
WB
I2
Combination SW
B4
WB
WB
Door Lock Motor RH
I5
WB
B4
WB
15 WB
WB
ID1
B5
WB
WB
WB
Unlock Warning SW
I5
10 EA2
Door Lock Control Relay
WB
WB
WB
WB
Door Courtesy SW RH
I5
WB
B5
EA
WB
I4
8 WB
IB1
I8
WB
WB
A/C Amplifier
Door Courtesy SW LH
B5
WB
B5
WB
WB
WB
IdleUp SW
Power Window Control

Relay
WB
WB
WB
Blower Resistor
Power Window Master SW
Door Lock Motor LH

WB (4AGZE)
4
BR
WB
Radio and Player
Fuel Control SW
I5
3
IC3
WB
I5
WB
Woofer Speaker Amplifier
WB
HEATER Relay
Combination Meter
4
BR
BR
4
I3
BR
Combination Meter
I3
BR
Fuel Sender
WB
BR
5
BA1
WB
BR
Auto Antenna Motor
BR
IB
IC
The system shown here is an EXAMPLE ONLY. It is different to the actual circuit shown in the SYSTEM CIRCUITS SECTION.
8
AVENSIS (EWD526E)
http://vnx.su
B
The Current Flow Chart section, describes which parts each power source (fuses, fusible links, and circuit breakers)
transmits current to. In the Power Source circuit diagram, the conditions when battery power is supplied to each system
are explained. Since all System Circuit diagrams start from the power source, the power source system must be fully
understood.
J POWER SOURCE (Current Flow Chart)

The chart below shows the route by which current flows from the battery to each electrical source
(Fusible Link, Circuit Breaker, Fuse, etc.) and other parts.
10A ECUB
Short Pin
2
7.5A DOME
15A EFI
30A AM2
Battery
Fusible Link Block
10A HAZARD
2
20A RADIO NO.1
S2
Starter
10A HORN
6
100A ALT
60A ABS
Engine Room R/B (See Page 20)
20A
10A
Page
System
Fuse
STOP
ABS
ABS and Traction Control
Cruise Control
Electronically Controlled Transmission
Multiplex Communication System
194
187
180
166
210
DOME
Cigarette Lighter
Combination Meter
Headlight
Interior Light
Key Reminder and Seat Belt Warning
Light Auto Turn Off
Theft Deterrent and Door Lock Control
214
230
112
122
Power Source
40A DOOR LOCK CB
1.25B FL MAIN
W
2
7
EB1
W
I2
W
1
I2
W
1
15A HAZRADIO
2
W
4
AM1
E7
6
EB1
WR
WR
AM2
7.5A AM2
1
TAIL
Relay
E7
B
2
B
STARTER Relay
1
3
I8
Ignition SW
BW
2
3
1
WB
2
BW
15A TAIL
G
1
20A DEFOG
BY
WR
1
WB
2
GW
INJECTION Relay
3
1
IG1
ACC
BO
IG2
E7
R
1
WL
1
7.5A DOME
W
I2
50A MAIN
E7
Battery
3 EA2 1 EA1
E6
15A RAD CIG
BY
1
PL
1
The system shown here is an EXAMPLE ONLY. It is different to the actual circuit shown in the SYSTEM CIRCUITS SECTION.
9
AVENSIS (EWD526E)
http://vnx.su

K CONNECTOR LIST
I14
I15
Dark Gray
Gray
[A]
I16
J1
J2
Black
A
A
1 2
A
A
A B B
D D
A A B CC CD D
6 7 8
[B]
J3
J4
K1
K2
L1
1 2
1 2
Dark Gray
A
A A
A A A A A
A B B
DD
A A B CC CDD
L2
L3
L4
Gray
M1
M2
1 2 3
4 5
6 7 8 9 101112
1
2
3 45 6 78
M3
1 2
3 4
M4
[D]
N1
Gray
1 2 3
[C]
Black
1
2
1
7
2 3 4
8 9 10
N2
O1
O2
Gray
Black
Dark Gray
[A] : Indicates connector to be connected to a part. (The numeral indicates the pin No.)
[B] : Junction Connector
Indicates a connector which is connected to a short terminal.
Junction Connector
Junction connector in this manual include a short terminal which is

connected to a number of wire harnesses. Always perform
inspection with the short terminal installed. (When installing the
wire harnesses, the harnesses can be connected to any position
within the short terminal grouping. Accordingly, in other vehicles,
the same position in the short terminal may be connected to a wire
harness from a different part.)
Wire harness sharing the same short terminal grouping have the
same color.
Same Color
Short Terminal
[C] : Parts Code

The first letter of the code is taken from the first letter of part, and the numbers indicates its order in parts which
start with the same letter.
[D] : Connector Color
Connectors not indicated are milky white in color.
10
AVENSIS (EWD526E)
http://vnx.su
B
L PART NUMBER OF CONNECTORS
Part Name
Code
Part Number
Code
A1
A/C Ambient Temp. Sensor
9098011070
D4
A2
A/C Condenser Fan Motor
9098011237
A3
A/C Condenser Fan Relay
9098010940
A4
A/C Condenser Fan Resistor
A5
A/C Magnetic Clutch
A6
A/T Oil Temp. Sensor
A7
[A]
A8
Part Name
Part Number
Diode (Courtesy)
9098011608
D5
Diode (Interior Light)
9098010962
D6
Diode (Moon Roof)
9098011608
9098010928
D7
Door Lock Control Relay
9098010848
9098011271
D8
Door Lock Control SW LH
9098011413
D9
Door Lock Control SW RH
ABS Actuator
[B]
9098011151
[C]
D10
Door Courtesy SW LH
ABS Actuator
9098011009
D11
Door Courtesy SW RH
9098011148
9098011097
A9
ABS Speed Sensor Front LH
9098010941
D12
Door Courtesy SW Front LH
A10
ABS Speed Sensor Front RH
9098011002
D13
Door Courtesy SW Front RH
A11
Airbag Sensor Front LH
D14
Door Courtesy SW Rear LH
A12
Airbag Sensor Front RH
A13
Airbag Squib
9098011156
9098011856
D15
Door Courtesy SW Rear RH
9098011194
D16
Door Key Lock and Unlock SW LH
9098011070
D17
Door Key Lock and Unlock SW RH
9098011170
[A] : Part Code

[B] : Part Name
[C] : Part Number
Toyota Part Number are indicated.
Not all of the above part numbers of the connector are established for the supply.
11
AVENSIS (EWD526E)
http://vnx.su
C TROUBLESHOOTING
To Ignition SW
IG Terminal
(a) Establish conditions in which voltage is present at the check

point.
Example:
[A] Ignition SW on
[B] Ignition SW and SW 1 on
[C] Ignition SW, SW 1 and Relay on (SW 2 off)
Fuse
[A]
SW 1
VOLTAGE CHECK
Voltmeter
[B]
(b) Using a voltmeter, connect the negative lead to a good ground

point or negative battery terminal, and the positive lead to the
connector or component terminal.
This check can be done with a test light instead of a voltmeter.
Relay
[C]
Solenoid
SW 2
CONTINUITY AND RESISTANCE CHECK

(a) Disconnect the battery terminal or wire so there is no voltage
between the check points.
Ohmmeter
(b) Contact the two leads of an ohmmeter to each of the check

points.
SW
If the circuit has diodes, reverse the two leads and check
again.
When contacting the negative lead to the diode positive side
and the positive lead to the negative side, there should be
continuity.
When contacting the two leads in reverse, there should be no
continuity.
Ohmmeter
Diode
Digital Type
Analog Type
(c) Use a volt/ohmmeter with high impedance (10 k/V

minimum) for troubleshooting of the electrical circuit.
12
AVENSIS (EWD526E)
http://vnx.su
C
FINDING A SHORT CIRCUIT
To Ignition SW
IG Terminal
(a) Remove the blown fuse and disconnect all loads of the fuse.
(b) Connect a test light in place of the fuse.
(c) Establish conditions in which the test light comes on.
Test Light
Fuse Case
Example:
[A] Ignition SW on
[B] Ignition SW and SW 1 on
[C] Ignition SW, SW 1 and Relay on (Connect the
Relay) and SW 2 off (or Disconnect SW 2)
Short [A]
SW 1
(d) Disconnect and reconnect the connectors while watching the

test light.
The short lies between the connector where the test light
stays lit and the connector where the light goes out.
Short [B]
Disconnect
Disconnect
Light
(e) Find the exact location of the short by lightly shaking the
problem wire along the body.
Relay
CAUTION:
Short [C]
Disconnect
SW 2
Solenoid
(a) Do not open the cover or the case of the ECU unless
absolutely necessary. (If the IC terminals are touched,
the IC may be destroyed by static electricity.)
(b) When replacing the internal mechanism (ECU part) of
the digital meter, be careful that no part of your body or
clothing comes in contact with the terminals of leads
from the IC, etc. of the replacement part (spare part).
DISCONNECTION OF MALE AND FEMALE

CONNECTORS
To pull apart the connectors, pull on the connector itself, not
the wire harness.
HINT : Check to see what kind of connector you are
disconnecting before pulling apart.
Pull Up
Pull Up
Press Down
Press Down
13
AVENSIS (EWD526E)
http://vnx.su
C TROUBLESHOOTING
HOW TO REPLACE TERMINAL
(with terminal retainer or secondary locking device)
Reference:
1. PREPARE THE SPECIAL TOOL
10
3
1
Example:
(Case 1)
HINT : To remove the terminal from the connector, please

construct and use the special tool or like object shown on
the left.
2. DISCONNECT CONNECTOR
0.2
(mm)
Up
Tool
3. DISENGAGE THE SECONDARY LOCKING DEVICE OR

TERMINAL RETAINER.
(a) Locking device must be disengaged before the terminal
locking clip can be released and the terminal removed from
the connector.
(b) Use a special tool or the terminal pick to unlock the secondary
locking device or terminal retainer.
NOTICE:
Do not remove the terminal retainer from connector body.
Terminal Retainer
[A]
Terminal Retainer
For NonWaterproof Type Connector

HINT : The needle insertion position varies according to the
connectors shape (number of terminals etc.), so
check the position before inserting it.
Case 1
[Retainer at Full Lock Position]
Raise the terminal retainer up to the temporary lock

position.
Stopper
Terminal
Retainer
[Retainer at Temporary Lock Position]
Example:
(Case 2)
Secondary
Locking Device
Case 2
Open the secondary locking device.
14
AVENSIS (EWD526E)
http://vnx.su
C
Tool
Tab
Tab
Example:
(Case 1)
[B]
Terminal
Retainer
Tool
[Male]
Access Hole
(
Mark)
Tool
For Waterproof Type Connector

HINT : Terminal retainer color is different
according to connector body.
Example:
Terminal Retainer
Black or White
Black or White
Gray or White
: Connector Body
: Gray
: Dark Gray
: Black
[Female]
Case 1
Type where terminal retainer is pulled
up to the temporary lock position (Pull
Type).
Insert the special tool into the terminal
retainer access hole (YMark) and pull
the terminal retainer up to the
temporary lock position.
Retainer
at Full Lock Position
HINT : The needle insertion position varies

according to the connectors shape
(Number of terminals etc.), so check
the position before inserting it.
Retainer
at Temporary Lock Position
[Male]
Example:
(Case 2)
[Female]
Case 2
Type which cannot be pulled as far as
Power Lock insert the tool straight into
the access hole of terminal retainer as
shown.
Terminal Retainer
Tool
Tool
[Male]
Press Down
Press Down
[Female]
15
AVENSIS (EWD526E)
http://vnx.su
C TROUBLESHOOTING
Push the terminal retainer down to the temporary lock position.
Retainer at
Full Lock Position
Retainer at
Temporary Lock Position
[Male]
[Female]
(c) Release the locking lug from terminal and pull the terminal out
from rear.
Locking Lug
Tool
4. INSTALL TERMINAL TO CONNECTOR

(a) Insert the terminal.
HINT:
1. Make sure the terminal is positioned correctly.
2. Insert the terminal until the locking lug locks firmly.
3. Insert the terminal with terminal retainer in the temporary lock
position.
(b) Push the secondary locking device or terminal retainer in to

the full lock position.
5. CONNECT CONNECTOR
16
AVENSIS (EWD526E)
http://vnx.su
ABBREVIATIONS D
ABBREVIATIONS
The following abbreviations are used in this manual.
A/C
A/T
ABS
CIS
DLC3
EC
ECT
ECU
EFI
EGR
EPS
ESA
EVAP
HID
INT
ISC
J/B
L/B
LH
LHD
M/T
PTC
R/B
RH
RHD
S/D
SRS
SW
TEMP.
TRC
VRV
VSC
VSV
VVT
VVTi
W/G
w/
w/o
=
=
=
=
=
=
=
=
=
=
=
=
=
=
=
=
=
=
=
=
=
=
=
=
=
=
=
=
=
=
=
=
=
=
=
=
=
=
Air Conditioner
Automatic Transaxle
AntiLock Brake System
Commonwealth of Independent States
Data Link Connector 3
Electrochromic
Electronic Control Transmission
Electronic Control Unit
Electronic Fuel Injection
Exhaust Gas Recirculation
Electric Power Steering
Electronic Spark Advance
Evaporative Emission
High Intensity Discharge
Intermittent
Idle Speed Control
Junction Block
Liftback Type
LeftHand
LeftHand Drive
Manual Transaxle
Positive Temperature Coefficient
Relay Block
RightHand
RightHand Drive
Sedan Type
Supplemental Restraint System
Switch
Temperature
Traction Control
Vacuum Regulating Valve
Vehicle Stability Control
Vacuum Switching Valve
Variable Valve Timing
Variable Valve Timingintelligent
Wagon Type
With
Without
The titles given inside the components are the names of the terminals (terminal codes) and are not treated as being
abbreviations.
17
AVENSIS (EWD526E)
http://vnx.su
E GLOSSARY OF TERMS AND SYMBOLS

GROUND
The point at which wiring attaches to
the Body, thereby providing a return
path for an electrical circuit; without a
ground, current cannot flow.
BATTERY
Stores chemical energy and
converts it into electrical energy.
Provides DC current for the autos
various electrical circuits.
CAPACITOR (Condenser)
A small holding unit for temporary
storage of electrical voltage.
CIGARETTE LIGHTER
An electric resistance heating
element.
HEADLIGHTS
Current flow causes a headlight
1. SINGLE
FILAMENT filament to heat up and emit light. A
headlight may have either a single
(1) filament or a double (2) filament
2. DOUBLE
FILAMENT
CIRCUIT BREAKER
Basically a reusable fuse, a circuit
breaker will heat and open if too
much current flows through it.
Some units automatically reset when
cool, others must be manually reset.
HORN
An electric device which sounds a
loud audible signal.
DIODE
A semiconductor which allows
current flow in only one direction.
IGNITION COIL
Converts lowvoltage DC current
into highvoltage ignition current for
firing the spark plugs.
DIODE, ZENER
LIGHT
Current flow through a filament
causes the filament to heat up and
emit light.
A diode which allows current flow in one

direction but blocks reverse flow only up
to a specific voltage. Above that potential,
it passes the excess voltage. This acts as
a simple voltage regulator.
PHOTODIODE
The photodiode is a semiconductor
which controls the current flow
according to the amount of light.
LED (LIGHT EMITTING DIODE)

Upon current flow, these diodes emit
light without producing the heat of a
comparable light.
DISTRIBUTOR, IIA
Channels highvoltage current from
the ignition coil to the individual
spark plugs.
METER, ANALOG
Current flow activates a magnetic
coil which causes a needle to move,
thereby providing a relative display
against a background calibration.
FUSE
METER, DIGITAL
Current flow activates one or many
LEDs, LCDs, or fluorescent
displays, which provide a relative or
digital display.
A thin metal strip which burns through

when too much current flows through it,
thereby stopping current flow and
protecting a circuit from damage.
FUEL
FUSIBLE LINK
(for Medium Current Fuse)
(for High Current Fuse or

Fusible Link)
A heavygauge wire placed in high

amperage circuits which burns through on
overloads, thereby protecting the circuit.
The numbers indicate the crosssection
surface area of the wires.
18
AVENSIS (EWD526E)
http://vnx.su
MOTOR
A power unit which converts
electrical energy into mechanical
energy, especially rotary motion.
E
SPEAKER
An electromechanical device which
creates sound waves from current
flow.
RELAY
Basically, an electrically operated
1. NORMALLYswitch which may be normally
CLOSED closed (1) or open (2).
Current flow through a small coil
creates a magnetic field which either
opens or closes an attached switch.
2. NORMALLY
OPEN
SWITCH, MANUAL
Opens and closes
circuits, thereby
1. NORMALLY
stopping (1) or
OPEN
allowing (2) current
flow.
RELAY, DOUBLE THROW

A relay which passes current
through one set of contacts or the
other.
2. NORMALLY
CLOSED
RESISTOR
An electrical component with a fixed
resistance, placed in a circuit to
reduce voltage to a specific value.
SWITCH, DOUBLE THROW

A switch which continuously passes
current through one set of contacts
or the other.
RESISTOR, TAPPED
A resistor which supplies two or
more different non adjustable
resistance values.
SWITCH, IGNITION
A key operated switch with several
positions which allows various
circuits, particularly the primary
ignition circuit, to become
operational.
RESISTOR, VARIABLE or RHEOSTAT

A controllable resistor with a variable
rate of resistance.
Also called a potentiometer or
rheostat.
(Reed Switch Type)
SENSOR (Thermistor)
A resistor which varies its resistance
with temperature.
SWITCH, WIPER PARK

Automatically returns wipers to the
stop position when the wiper switch
is turned off.
SENSOR, SPEED
Uses magnetic impulses to open
and close a switch to create a signal
for activation of other components.
TRANSISTOR
A solidstate device typically used as
an electronic relay; stops or passes
current depending on the voltage
applied at base.
SHORT PIN
Used to provide an unbroken
connection within a junction block.
SOLENOID
An electromagnetic coil which forms
a magnetic field when current flows,
to move a plunger, etc.
WIRES
Wires are always drawn as
(1) NOT
straight lines on wiring
CONNECTED diagrams.
Crossed wires (1) without a
black dot at the junction are
not joined;
crossed wires (2) with a
black dot or octagonal ( )
(2) SPLICED
mark at the junction are
spliced (joined)
connections.
19
AVENSIS (EWD526E)
http://vnx.su
F RELAY LOCATIONS
[Engine Compartment]
(Gasoline)
Electronic Driver Unit
Engine Room R/B No.4

Engine Room J/B No.4
Skid Control
ECU with
Actuator
(w/o VSC)
Skid Control
ECU with
Actuator
(w/ VSC)
Engine Room
R/B No.1
Engine Room
J/B No.1
Headlight
Control
ECU RH
Headlight Control
ECU LH
Headlight Cleaner
Control Relay
Engine Room
R/B No.2
(1CDFTV)
Glow Plug Relay
Engine Room
R/B No.3
Electronic
Driver Unit
Power Heater
Assembly
Skid Control
ECU with
Actuator
(w/o VSC)
Skid Control
ECU with
Actuator
(w/ VSC)
Engine Room
R/B No.1
Engine Room
J/B No.1
Headlight
Control
ECU RH
Headlight Control
ECU LH
Headlight Cleaner
Control Relay
20
AVENSIS (EWD526E)
http://vnx.su
F
[Instrument Panel]
(LHD)
Transponder Key EPS ECU
Amplifier
Transponder Key
Computer
Antenna
Amplifier
Center J/B
Wiper Relay
Door Control
Receiver
Turn Signal
Flasher Relay
Headlight Beam
Level Control
ECU
Driver Side
R/B
Rear Window
Defogger Relay
Engine and ECT

ECU (A/T)
Engine ECU (M/T)
Rear Fog
Light Relay
A/C Control
Assembly
Circuit Opening
Relay
Option Connector
(Navigation ECU)
Integration
Relay
Driver Side J/B
Fuse Block Navigation ECU

J/B No.6
Airbag Sensor
Assembly
Shift Lock
Control ECU
(RHD)
Rear Window
Defogger Relay
Door Control
Receiver
Driver Side
R/B
Antenna
Amplifier
Transponder
EPS ECU
Key Computer
Rear Fog
Light Relay
Turn Signal
Flasher Relay
Driver Side
J/B
Center J/B
Theft Deterrent
ECU
Circuit Opening
Relay
Headlight Beam
Level Control ECU
Integration Relay
Wiper Relay
Engine and ECT
ECU (A/T)
Engine ECU
(M/T)
Fuse Block
J/B No.6
Transponder
Key Amplifier
Navigation ECU
Shift Lock
Control ECU
Airbag Sensor
Assembly
Option Connector
(Navigation ECU)
A/C Control
Assembly
21
AVENSIS (EWD526E)
http://vnx.su
F RELAY LOCATIONS
[Body]
(S/D)
Telephone Microphone
Amplifier
Moon Roof Control

Relay and Motor
Amplifier
Moon Roof Control

Relay and Motor
(L/B)
Rear Wiper
Motor and Relay
22
AVENSIS (EWD526E)
http://vnx.su
F
(W/G)
Amplifier
Moon Roof Control

Relay and Motor
Rear Wiper
Motor and Relay
23
AVENSIS (EWD526E)
http://vnx.su
F RELAY LOCATIONS
1
: Engine Room R/B No.1

Engine Compartment Left (See Page 20)
: Engine Room J/B No.1
(Gasoline)
* 1:1AZ-FSE, 1AZ-FE
* 2:1ZZ-FE, 3ZZ-FE
3
5
FAN NO.1 Relay

1
30A CDS
(for High Current)
30A RDI
(for High Current) (*1)
40A RDI
40A HTR
(for High Current)
3
5
1 4 2
FAN NO.2 Relay
3
5
1
FAN NO.3 Relay

2
30A RR DEF
(for High Current)
1B
1A
1
(from Engine Room Main Wire)
40A MAIN
(for High Current)
2 30A 1
AM2
2 30A 1
DCC
2 20A 1
EFI
2 15A 1
IG2
2 7.5A 1
ALT-S
2 10A 1
HAZARD
2 15A 1
HORN
2 10A 1
THROTTLE
2 20A 1
A/F
50A EMPS
(for High Current)
5
2
1
3
24
AVENSIS (EWD526E)
http://vnx.su
EMPS Relay
F
1

(1CDFTV)
* 1:VSC (w/ VSC)
ABS (w/o VSC)
50A AM1 NO.1
(for High Current)
30A H/CLN
(for High Current)
3
5
1
40A HTR
(for High Current)
3
5
1
30A CDS
(for High Current)
EFI MAIN Relay

2
EDU Relay
2
40A RDI
(for High Current)
1C
1

Gray
1B
50A VSC
(for High Current) (w/ VSC)
40A ABS
(for High Current) (w/o VSC)
(from Engine Wire)

1
*1
1 25A 2
2 7.5A 1
ALT-S
2 30A 1
DCC
2 30A 1
AM2
2 10A 1
HAZARD
2 25A 1
F-HTR
2 15A 1
HORN
2 20A 1
EFI
2 25A 1
PWR HTR
2
30A RR DEF
(for High Current)
40A MAIN
(for High Current)
1A
FAN NO.3 Relay
5 3
(from Engine Wire)

1
FAN NO.1 Relay
5
2
25
AVENSIS (EWD526E)
http://vnx.su
F RELAY LOCATIONS
2
: Engine Room R/B No.2 Near the Radiator Fan (See Page 20)
HORN Relay
H-LP HI LH
1 10A 2
H-LP Relay
DIM Relay
FAN NO.2 Relay
2
3 5
H-LP HI RH
1 10A 2
1
1
H-LP LH
1 15A 2
H-LP RH
1 15A 2
3 5
1
1
3
3
5
1 4 2
3
2
F-HTR Relay
Left Side of the Suspension Tower (See Page 20)
(1CDFTV)
50A HTR2
(for High Current)
50A HTR1
(for High Current)
2
1
80A GLOW
(for High Current)
3
2
HTR2 Relay
HTR1 Relay
140A ALT
(for High Current)
26
AVENSIS (EWD526E)
http://vnx.su
F
4

(Gasoline)
* 1:VSC (w/ VSC)

ABS (w/o VSC)
* 2:1AZ-FSE, 1AZ-FE
* 3:1ZZ-FE, 3ZZ-FE
INJ Relay
1
5
3
*1
1 25A 2
7.5A
EFI NO.2
4A
10A
EFI NO.1
4C
1
4D
4B

120A ALT
100A ALT

4E
1
1
(from Engine Wire)
5 3
EFI Relay
IG2 Relay
5 3
2
50A VSC
(for High Current)
(w/ VSC)
40A ABS
(for High Current)
(w/o VSC)
50A AM1 NO.1
(for High Current)
A/F Relay
5 3
2
30A H-LP CLN

(for High Current)
27
AVENSIS (EWD526E)
http://vnx.su
F RELAY LOCATIONS
5
: Driver Side R/B
LHD : Left Side of the Instrument Panel (See Page 21)

RHD : Instrument Panel Reinforcement LH (See Page 21)
(LHD)
P/POINT Relay
1
5
3
ST Relay
1
5
3
5
3
FR DEICER Relay
1
5
3
FR FOG Relay
(RHD)
ST Relay
1
5 3
FR DEICER Relay
P/POINT Relay
5 3
FR FOG Relay
1
5 3
5 3
2
28
AVENSIS (EWD526E)
http://vnx.su
F
6
: Fuse Block
: J/B No.6
Lower Finish Panel (See Page 21)
30A PWR SEAT

(for High Current)
P-RR P/W
1 20A 2
P-FR P/W
1 20A 2
DEF I/UP
1 7.5A 2
D-RR P/W
1 20A 2
ST
7.5A
D-FR P/W
1 20A 2
MIR HTR
2 10A 1
ECU-B 1
1 7.5A 2
RAD NO.2
2 15A 1
FUEL OPN
10A 2
FR DIC
1 20A 2
ECU-B 2
2 7.5A 1
DOME
7.5A 1
6A
(from Instrument Panel Wire)
29
AVENSIS (EWD526E)
http://vnx.su
F RELAY LOCATIONS
: Driver Side J/B
Left Side of the Instrument Panel (See Page 21)
Black
Gray
DB
DC
1 2 3 4 5 6 7 8 9 10
11 1213141516171819 20
DF
17 34
16 33
15 32
14 31
13 30
12 29
11 28
27
26
25
24
6
5
4
3
2
1
23
22
21
20
19
18
34 17
33 16
32 15
31 14
30 13
29 12
28 11
DA
10 9 8 7 6 5 4 3 2 1
20 19181716 1514 1312 11
23
22
21
20
19
18
6
5
4
3
2
1
7 6 5
DD
IGN
10A
2
1
6 5 4 3
2 1
4 3
2 1
10 9 8
DG
3
2 1
9 876 5 4
5
2
S/ROOF
20A
RR FOG
7.5A
TAIL
10A
FR FOG
15A
OBD2
7.5A
1
3
PANEL
7.5A
P/POINT
15A
RR WIP
20A
DOOR
25A
GAUGE2
7.5A
WIP
25A
CIG
15A
ECU-IG
7.5A
HTR
10A
S-HTR
20A
IG1 Relay
SEAT HTR Relay
1 2
3 4
1 2
5 6 7
3 4
8 9 10

30A PWR SEAT
(for High Current)
AM1
25A
DJ
HTR Relay
2 1
7 6 5
Yellow
4 3
(from Instrument
Panel Wire)
1 2
3
4 5 6 7 8 9
4 3
10 9 8
27 10
26 9
25 8
24 7
(from Instrument
Panel Wire)
3 4
8 9 10

Black
10
9
8
7
1 2
5 6 7
2
3 5
3 5
1
GAUGE1
10A
RAD NO.1
7.5A
STOP
15A
Blue
DH
TAIL Relay
1
2
3 4 5 6
30
AVENSIS (EWD526E)
http://vnx.su
1 2 3 4 5 6 7 8 9
10 11 121314151617 18
DL
1 2
3 4
5 6 7 8 9 1011
DK
DP
4 3
2 1
1110 9 8 7 6 5
(from Roof Wire)
1
9 8 7 6 5 4 3 2 1
18 17161514131211 10
5 4 3 2 1
1 2 3 4 5
6 7
8 9
DM
9 8
7 6
1716151413121110
3 2 1
DN
1011121314151617
(from Floor Wire)

1 2 3 4 5 6 7 8 9 10111213141516171819202122 2324 25
Integration Relay
31
AVENSIS (EWD526E)
http://vnx.su
F RELAY LOCATIONS
[Driver Side J/B Inner Circuit]
2 DC
1 DH
25A AM1
4 DC
4 DM
3 DB
8 DM
1 DN
3 DC
10A TAIL
9 DL
TAIL Relay
3
5
7.5A PANEL
19 DB
23 DA
15 DL
8 DD
8 DL
20A S-HTR
SEAT HTR Relay
3
5
5 DM
12 DB
17 DB
33 DA
5 DB
6 DC
9 DA
16 DA
IG1 Relay
3
16 DM
10A HTR
3 DP
21 DA
3 DD
6 DH
5 DH
4 DD
6 DK
10 DK
30A PWR SEAT
7.5A RR FOG
9 DB
10 DD
3 DA
25 DA
14 DL
3 DJ
10 DA
1 DL
30 DA
31 DA
2 DM
2 DJ
3 DK
15 DA
20A S/ROOF
15A STOP
15A P/POINT
15A FR FOG
7.5A OBD2
25A DOOR
1 DG
22 DA
19 DA
24 DA
7 DA
10 DC
32 DA
2 DL
5 DC
1 DB
7 DB
10A GAUGE1
2 DA
1 DM
11 DK
7.5A GAUGE2
5 DK
27 DA
25A WIP
17 DL
18 DL
4 DA
26 DA
18 DA
9 DM
10A IGN
5 DD
16 DL
2 DH
(Cont. Next Page)
32
AVENSIS (EWD526E)
http://vnx.su
(Cont'd)
7.5A ECU-IG
18 DB
3 DL
7 DC
4 DL
10 DL
17 DM
11 DL
6 DB
20A RR WIP
7 DD
5 DL
1 DP
6 DL
4 DF
11 DM
2 DF
15 DB
3 DF
34 DA
2 DP
14 DB
2 DD
HTR Relay
12 DA
8 DC
6 DD
4 DH
11 DA
15A CIG
11 DB
9 DD
7.5A RAD NO.1
3 DH
4 DB
17 DA
1 DC
25
9 DJ
6 DJ
22
IG
E
15 INTB (w/o Double Locking)
ACTR (w/ Double Locking)
14 TOUT (w/o Double Locking)
ACTS (w/ Double Locking)
1
B
3 DM
9 DC
PCTY
B
6
4
2 DB
16 DB
1 DA
7 DK
21 12 13
ACC T TRLY
23
13 DL
12 DL
LP
8 DK
LACT
12 DM
9 DK
13 DM
10 DM
20 DA
14 DM
Integration Relay
15 DM
1 DK
2 DK
LSWP
H
16
RCTY
DCTY
7
18
17
6 DM
KSW
3
P/W
ACT-
1 DJ
L1
7 DM
20 DB
28 DA
13 DB
8 DA
4 DJ
10 DB
8 DB
UL1
2
SNOW
ACT+
19
20
11
10
8
6 DA
5 DA
29 DA
13 DA
14 DA
33
AVENSIS (EWD526E)
http://vnx.su
F RELAY LOCATIONS
: Center J/B
1 2
3 4 5
6 7 8 9 10 1112 13
Instrument Panel Reinforcement RH (See Page 21)
CF
5 4 3
2 1
13121110 9 8 7 6
5 4 3 2 1
10 9 8 7 6
1 2 3 4 5 6
7 8 9 10 1112
CB
CD
1 2 3 4 5
6 7 8 9 10
6 5 4 3 2 1
12 1110 9 8 7
5 4
3 2 1
13121110 9 8 7 6
CA
1 2 3
4 5
6 7 8 9 10111213
1 2
3
4 5 6 7 8 9
CC
3
2 1
9 8765 4
4 3
2 1
1110 9 8 7 6 5
CE
1 2
3 4
5 6 7 8 9 1011
34
AVENSIS (EWD526E)
http://vnx.su
5 4
3 2 1
1312 1110 9 8 7 6
CK
1 2 3
4 5
6 7 8 9 10111213
1 2 3 4 5 6
7 8 9 10 1112
CJ
6 5 4 3 2 1
12 1110 9 8 7
3
2 1
9 8765 4
CG

CH
1 2 3 4 5
6 7 8 9 10
1 2
3
4 5 6 7 8 9
5 4 3 2 1
10 9 8 7 6
4 3
2 1
1110 9 8 7 6 5
CI
1 2
3 4
5 6 7 8 9 10 11
35
AVENSIS (EWD526E)
http://vnx.su
(Cont'd)
8 CA
2 CA
6 CC
1 CE
1 CD
5 CH
9 CE
12 CJ
5 CK
3 CK
5 CA
10 CC
11 CA
3 CD
12 CA
7 CF
4 CD
8 CF
1 CF
9 CF
8 CG
7 CI
1 CH
4 CA
2 CH
7 CC
7 CH
7 CJ
3 CI
4 CC
4 CI
5 CC
8 CI
10 CK
1 CJ
2 CB
2 CJ
8 CC
3 CJ
11 CK
8 CJ
6 CB
8 CK
12 CB
9 CK
2 CK
10 CA
1 CC
5 CB
2 CC
2 CD
13 CK
6 CF
1 CI
37
AVENSIS (EWD526E)
http://vnx.su
G ELECTRICAL WIRING ROUTING

Position of Parts in Engine Compartment
[LHD : 1AZFSE]
H9
H10
C2
F16
H7
C1
H8
B3
B2
F13
F12
*1:w/ HID
*2:w/o HID
F5
E5
F6
E4
A5
A6
C6
A4
A10
(M/T)
H2
(A/T)
H6
F10
H1
(*1)
H5
(*2)
(*1)
(*2)
F2
H4
A 1
A 2
A 3
A 4
A 5
A 6
A 9
A 10
A 11
A 12
C5
E2
F11
F9
B1
F4
H3

A/C Pressure Sensor
Air Flow Meter
Alternator
Alternator
B 1 BackUp Light SW
B 2 Brake Booster Pressure Sensor
B 3 Brake Fluid Level Warning SW
C
C
C
C
C
1
2
3
5
6
Camshaft Position Sensor

Camshaft Timing Oil Control Valve
Compressor Assembly
Counter Gear Speed Sensor
Crankshaft Position Sensor
E
E
E
E
1
2
4
5
ECT Solenoid
EFI Water Temp. Sensor
F 1 Front Clearance Light LH

F 2 Front Clearance Light RH
F 3 Front Fog Light LH
A11
C3
A3
A12
H12
A1
F
F
F
F
4
5
6
7
H11
A2
E1
A9
F3
F1
F 11
F 12
F 13
F 16
Front Fog Light RH

Front Side Turn Signal Light LH
Front Side Turn Signal Light RH
Headlight Control ECU LH
Headlight LH (Low)
Headlight Control ECU RH
Headlight RH (Low)
Front Washer Motor
Front Window Deicer
Front Wiper Motor
Fuel Pressure Sensor
H 1
H 2
H 3
H 4
H 5
H 6
H 7
H 8
H 9
H10
H 11
H12
Headlight Beam Level Control Actuator LH

Headlight Beam Level Control Actuator RH
Headlight Cleaner Control Relay
Headlight Cleaner Motor
Headlight LH (High)
Headlight RH (High)
Heated Oxygen Sensor (Bank 1 Sensor 1)
Horn LH
Horn RH
F 8
F 9
F 10
38
AVENSIS (EWD526E)
http://vnx.su
F7
F8
G
[LHD : 1AZFSE]
V1
I5
I6
I7
I8
S3
T1
V5
N2
V6
J2
P2
J1
O1
O2
S1
S5
R3
S4
I1
I
I
I
I
I
I
I
I
1
2
3
4
5
6
7
8
Ignition Coil and Igniter No.1

Injector No.1
Injector No.2
Injector No.3
Injector No.4
J 1 Junction Connector
I2
I3
K1
I4
R1
N1
T4
P 2 Power Steering Oil Pressure SW

R 1 Radiator Fan Motor
R 3 Rear Washer Motor
S
S
S
S
1
3
4
5
Skid Control ECU with Actuator

Spill Valve
Starter
Starter
T 1 Throttle Control Motor and Position Sensor

T 4 Turbine Speed Sensor
K 1 Knock Sensor
N 1 Neutral Start SW
N 2 Noise Filter (Ignition)
V 1 Vacuum Sensor
V 5 VSV (EVAP)
V 6 VSV (Intake Air Control Valve)
O 1 Oil Pressure Sensor

O 2 Oil Pressure SW
39
AVENSIS (EWD526E)
http://vnx.su

[LHD : 1AZFE]
C2
A8
H10
A7
C1
H8
B3
F13
F12
*1:w/ HID
*2:w/o HID
F6
F5
A5
A6
C6
A4
A10
(M/T)
H2
(A/T)
H6
F10
H1
(*1)
H5
(*2)
(*1)
(*2)
F2
H4
A 1
A 2
A 3
A 4
A 5
A 6
A 7
A 8
A 9
A 10
A 11
A 12
F4
H3
1
2
3
5
6
A11

A/C Pressure Sensor
Air Flow Meter
Air Fuel Ratio Sensor (Bank 1 Sensor 1)
Alternator
Alternator
B 1 BackUp Light SW
C
C
C
C
C
C5
E2
F11
F9
B1

Compressor Assembly
E 1 ECT Solenoid
E 2 EFI Water Temp. Sensor
C3
A3
A12
H12
A1
F
F
F
F
F
3
4
5
6
7
H11
A2
E1
A9
F3
F1
F 11
F 12
F 13
Front Fog Light LH

Front Fog Light RH
Headlight LH (Low)
Headlight RH (Low)
Front Washer Motor
Front Window Deicer
Front Wiper Motor
H 1
H 2
H 3
H 4
H 5
H 6
H 8
H10
H 11
H12

Headlight LH (High)
Headlight RH (High)
Horn LH
Horn RH
F 8
F 9
F 10
40
AVENSIS (EWD526E)
http://vnx.su
F7
F8
G
[LHD : 1AZFE]
I5
I6
I7
I8
I10
T2
V3
V5
N2
J2
P2
J1
S2
O2
R3
S5
S4
I1
I 1
I 2
I 3
I 4
I 5
I 6
I 7
I 8
I 10

Injector No.1
Injector No.2
Injector No.3
Injector No.4
ISC Valve
I2
I3
K1
I4
R1
N1
T4
O 2 Oil Pressure SW
S 2 Skid Control ECU with Actuator
S 4 Starter
S 5 Starter
T 2 Throttle Position Sensor
K 1 Knock Sensor
V 3 Variable Resistor
V 5 VSV (EVAP)
41
AVENSIS (EWD526E)
http://vnx.su

[LHD : 1ZZFE, 3ZZFE]

C2
C6
A11
C1
H7
B3
F13
F12
*1:w/ HID
*2:w/o HID
F6
F5
A5
A6
A12
A4
A10
E2
H2
B1
H6
H1
F11
F9
F10
H5
(*1)
(*1)
(*2)
(*2)
F2
H4
A 1
A 3
A 4
A 5
A 6
A 9
A 10
A 11
A 12
F4

A/C Pressure Sensor
Air Flow Meter
Alternator
Alternator
H3
C3
A3
H12
A1
H11
F
F
F
F
4
5
6
7
C
C
C
C
1
2
3
6

Compressor Assembly
E 1 ECT Solenoid
A9
F3
F1
F 11
F 12
F 13
Front Fog Light RH

Headlight LH (Low)
Headlight RH (Low)
Front Washer Motor
Front Window Deicer
Front Wiper Motor
H 1
H 2
H 3
H 4
H 5
H 6
H 7
H 11
H12

Headlight LH (High)
Headlight RH (High)
Horn LH
Horn RH
F 8
F 9
F 10
B 1 BackUp Light SW
E1
42
AVENSIS (EWD526E)
http://vnx.su
F7
F8
G

I1
I2
I3
I4
N2
V5
J2
S2
J1
R3
T2
T4
I10
I5
I 1
I 2
I 3
I 4
I 5
I 6
I 7
I 8
I 10

Injector No.1
Injector No.2
Injector No.3
Injector No.4
ISC Valve
K1
I6
O2
I7
I8
S4
R1
S5
N1
R2
O 2 Oil Pressure SW
R 2 Radiator Fan Resistor
S 4 Starter
S 5 Starter

K 1 Knock Sensor
V 5 VSV (EVAP)
43
AVENSIS (EWD526E)
http://vnx.su

[LHD : 1CDFTV]
C1
A12
G1
A11
F18
F16
E2
E3
F17
F15
B3
F13
F12
*1:w/ HID
*2:w/o HID
*3:Power Heater
(Hot Gas Type)
*4:Power Heater
(Electrical Type)
F6
E5
A5
F5
E4
G2
C6
A4
E7
A6
A10
F14
H2
B1
H6
H1
F11
F9
F10
H5
(*1)
(*1)
(*2)
(*2)
F2
H4
A 1
A 2
A 3
A 4
A 5
A 6
A 9
A 10
A 11
A 12
F4
H3

A/C Pressure Sensor
Air Flow Meter
Alternator
Alternator
B 1 BackUp Light SW
C
C
C
C
1
3
4
6

Compressor Assembly
Condenser Assembly
D 1 Diesel Throttle Control Motor

E
E
E
E
E
2
3
4
5
7

EGR Valve Control Motor
Engine Oil Level Sensor
F
F
F
F
1
2
3
4

Front Fog Light LH
Front Fog Light RH
C4
A3
A3
(*3)
(*4)
C3
H12
A1
H11
A2
D1
A9
F3
F1
F 5 Front Side Turn Signal Light LH

F 6 Front Side Turn Signal Light RH
F 7 Front Turn Signal Light LH
F 8 Front Turn Signal Light LH
Headlight LH (Low)
F 9 Front Turn Signal Light RH
Headlight RH (Low)
F 11 Front Washer Motor
F 12 Front Window Deicer
F 13 Front Wiper Motor
F 14 Fuel Filter Warning SW
F 15 Fuel Heater
F 16 Fuel Pressure Sensor
F 17 Fuel Pump
F 18 Fuel Temp. Sensor
G 1 Glow Plug
G 2 Glow Plug Relay
H 1
H 2
H 3
H 4
H 5
H 6
H 11
H12

Headlight LH (High)
Headlight RH (High)
Horn LH
Horn RH
44
AVENSIS (EWD526E)
http://vnx.su
F7
F8
G
[LHD : 1CDFTV]
I5
I6
I7
I8
V4
V2
* 5:w/ VSC
* 6:w/o VSC
S2
(*6)
P1
O1
S1
J2
(*5)
J1
W1
T5
R3
I9
S6
I
I
I
I
I
5
6
7
8
9
Injector No.1
Injector No.2
Injector No.3
Injector No.4
Intake Air Temp. Sensor
S4
O2
S5
P3
R1
S
S
S
S
S
1
2
4
5
6
T3

Starter
Starter
Suction Control Valve
T 3 Throttle Position SW
T 5 Turbo Pressure Sensor

O 2 Oil Pressure SW
V 2 Vacuum SW
V 4 VRV (EGR)
P 1 Power Heater Assembly

P 3 Pressure Discharge Valve
W 1 Water Temp. SW (Radiator Fan)

45
AVENSIS (EWD526E)
http://vnx.su

Position of Parts in Instrument Panel
[LHD]
(*2)
C10
A18
C11
A23
A17 A21
A25
A19
* 1:Except Automatic A/C
* 2:Automatic A/C
C14
A31
A30
(*1)
C12
(*2)
A20
B5
A29
C9
B4
C8
C13
A 13
A 14
A 15
A 16
A 17
A 18
A 19
A 20
A 21
A 22
A 23
A 24
A 25
A 26
A 27
A 28
A 29
A 30
A 31
B6
A14
A15
A13
A16
(*1)
(*2)
(*1)
(*2)

A/C Room Temp. Sensor
A/C Solar Sensor
A/C Thermistor
Accel Position Sensor
Air Inlet Control Servo Motor
Air Mix Control Servo Motor
Air Mix Control Servo Motor (Driver Side)
Air Mix Control Servo Motor (Front Passenger Side)
Air Vent Mode Control Servo Motor
Airbag Sensor Assembly
Airbag Squib (Front Passenger Airbag Assembly)
Airbag Squib (Steering Wheel Pad)
Antenna Amplifier
A26
C7
A27
A28
A22
A24
(*1)
(*2)
B 4 Blower Motor
B 5 Blower Motor Controller
B 6 Blower Resistor
C 7 Cigarette Lighter
Cigarette Lighter Illumination
C 8 Circuit Opening Relay
C 9 Clutch Start SW
C10 Combination Meter
C 11 Combination Meter
C12 Combination SW
C13 Combination SW
C14 Combination SW
46
AVENSIS (EWD526E)
http://vnx.su
G
[LHD]
E15
E14
F19
H13
D2
D6
G3
E9
D3
E10
(*5)
D4
H16
E11
H14
H15
E12
I14
E13
F20
D5
* 3:w/ Engine Immobiliser System

* 4:w/o Engine Immobiliser System
* 5:1AZ-FSE
I13
D
D
D
D
D
2
3
4
5
6
Diode
Diode
Diode (Fan)
DLC3
Door Control Receiver
E8
I11
I12
(*4)
(*3)
H18
H17
F 19 Front Passengers Seat Belt Warning Light

Rear Window Defogger SW
Security Indicator Light
F 20 Front Wiper Deicer SW
G 3 Glove Box Light
E 8 ECT Pattern Select SW

E 9 Engine and ECT ECU (A/T)
Engine ECU (M/T)
Engine ECU (M/T)
Engine ECU (M/T)
Engine ECU (M/T)
Engine ECU (M/T)
E 14 EPS ECU
E 15 EPS ECU
H13
H14
H15
H16
H17
H18
Hazard SW
Headlight Beam Level Control ECU
Headlight Beam Level Control SW
Headlight Cleaner SW
Height Control Sensor (Front)
I 11 Ignition Key Cylinder Light

Transponder Key Amplifier
I 13 Ignition SW
I 14 Integration Relay
47
AVENSIS (EWD526E)
http://vnx.su

[LHD]
(*7)
J10
J11
J8
J6
J5
M3
(*6)
M2
M1
M3
J14
J18
J3
J12
J4
J13
J15
* 6:w/ Navigation System (Map Type)

* 7:w/ Multi-Display
w/o Navigation System (Map Type)
J9
J 3
J 4
J 5
J 6
J 7
J 8
J 9
J 10
J 11
J 12
J 13
J 14
J 15
J 16
J 17
J 18
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
K2
J7
K3
J16
J17
K 2 Kick Down SW
K 3 Knee Airbag Squib
M 1 MultiDisplay
M 2 MultiDisplay
M 3 MultiDisplay
48
AVENSIS (EWD526E)
http://vnx.su
G
[LHD]
V7
R4
T8
R5
R6
R7
P7
P5
S11
T10
N6
S10
W2
R9
T7
R8
S8
R10
S7
T9
S13
S12
N3
N4
N
N
N
N
3
4
5
6
Navigation ECU
Navigation ECU
Navigation ECU
Noise Filter (Rear Window Defogger No.1)
P
P
P
P
4
5
6
7
Parking Brake SW
Power Heater SW
Power Outlet
PTC Heater
R 4
R 5
R 6
R 7
R 8
R 9
R10
R 11
Radio and Player

Radio and Player
Radio and Player
Radio and Player
Rear Fog Light Relay
Rear Window Defogger Relay
Remote Controller (Navigation)
N5
U1
Z1
Z2
Y1
S9
P4
R11
P6
S 7
S 8
S 9
S 10
S 11
S 12
S 13
Seat Heater SW
Seat Heater SW
Shift Lock Control ECU
Short Connector
Short Connector
Steering Sensor
Stop Light SW
T 7
T 8
T 9
T 10
Transmission Control SW
Transponder Key Computer
TRC Off SW
Turn Signal Flasher Relay
U 1 Unlock Warning SW
V 7 VSC Warning Buzzer
W 2 Wiper Relay
Y 1 Yaw Rate Sensor
Z 1 Option Connector (Navigation ECU)
49
AVENSIS (EWD526E)
http://vnx.su

Position of Parts in Body
[LHD : S/D]
I15
C17
F22
I16
D15
C18
D17
D13
F24
D20
F21
H20
D7
D12
D9
A33
D18
H19
C15
A32
A 32 ABS Speed Sensor Rear LH

A 33 ABS Speed Sensor Rear RH
Curtain Shield Airbag Sensor LH
Curtain Shield Airbag Sensor RH
Curtain Shield Airbag Squib LH
Curtain Shield Airbag Squib RH
D 7
D 8
D 9
D10
D 11
D12
D13
Door Courtesy Light LH

Door Courtesy Light RH
Door Key Lock and Unlock SW (Drivers Side)
Door Lock Control Motor (Drivers Side)
Door Unlock Detection SW (Drivers Side)
Door Lock Control Motor (Front Passengers Side)
Door Lock Motor Rear LH
Door Lock Motor Rear RH
D18
D20
D8
F25
F 21
F 22
F 23
F 24
F 25
C15
C16
C17
C18
D15
D17
D11
F23
D10
C16
Front Door Speaker LH

Front Door Speaker RH
Fuel Lid Opener Motor
Fuel Lid Opener SW
Fuel Pump
Fuel Sender
H19 Height Control Sensor (Rear)

H20 High Mounted Stop Light
I 15 Inner Mirror
I 16 Interior Light
50
AVENSIS (EWD526E)
http://vnx.su
G
[LHD : S/D]
V8
R12
P8
M7
M6
T11
V9
T17
M5
P13
P9
S15
T19
R19
T16
P11
M4
P15
P12
L5
T18
R14
P10
L2
S14
L1
P16
L3
R15
P14
J32
L 1 License Plate Light LH
L 2 License Plate Light RH
L 3 Luggage Compartment Door Lock Motor
Luggage Compartment Light SW
L 4 Luggage Compartment Door Opener SW
L 5 Luggage Compartment Light
M 4 Mirror Heater LH
Remote Control Mirror LH
M 5 Mirror Heater RH
Remote Control Mirror RH
M 6 Moon Roof Control Relay and Motor
M 7 Moon Roof Control SW
P 8
P 9
P 10
P 11
P 12
P 13
R18
P17
J30
J31
R13
R16
L4
P 14
P 15
P 16
P 17
Power Window Motor Rear LH

Power Window Motor Rear RH
Pretensioner LH
Pretensioner RH
R12
R13
R14
R15
R16
R18
R19
Rain Sensor
Rear Door Speaker LH
Rear Door Speaker RH
Rear Window Defogger
S 14 Side Airbag Sensor LH

S 15 Side Airbag Sensor RH
Personal Light
Power Window Control SW (Front Passenger Side)
Power Window Control SW Rear LH
Power Window Control SW Rear RH
Power Window Motor Front LH
Power Window Motor Front RH
T 11
T 16
T 17
T 18
T 19
Telephone Microphone Amplifier

Tweeter Front LH
Tweeter Front RH
Tweeter Rear LH
Tweeter Rear RH
V 8 Vanity Light LH
V 9 Vanity Light RH
51
AVENSIS (EWD526E)
http://vnx.su

[LHD : L/B]
I15
C17
F22
I16
D8
D15
C18
D13
D17
D20
F24
D12
F21
A33
D7
H20
D9
H19
D18
B7
B8
C15
A32

D11
F25
D10
F23
C16
D15 Door Lock Control Motor (Front Passengers Side)

D17 Door Lock Control SW
D18 Door Lock Motor Rear LH
D20 Door Lock Motor Rear RH
B 7 Back Door Courtesy SW

Back Door Lock Motor
B 8 Back Door Opener SW
F 21
F 22
F 23
F 24
F 25
C15
C16
C17
C18

D 7
D 8
D 9
D10
D 11
D12
D13


Fuel Lid Opener SW
Fuel Pump
Fuel Sender

I 15 Inner Mirror
I 16 Interior Light
52
AVENSIS (EWD526E)
http://vnx.su
G
[LHD : L/B]
V8
R12
P8
M6
M7
T11
V9
T17
M5
P9
P13
T19
T16
P11
M4
S15
P12
P15
T18
R19
P10
R14
S14
R20
P16
L2
L1
R15
J 30
J 31
J 32
J 33
J 34
P14
R17
P17
J32
J30
N7
N8
R16
R13
R18
J33
J34
P 15 Power Window Motor Rear RH

P 16 Pretensioner LH
P 17 Pretensioner RH
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
R12
R13
R14
R15
R16
R17
R18
R19
R20

Rain Sensor
Rear Interior Light
Rear Wiper Motor and Relay

N 7 Noise Filter (Rear Window Defogger No.2)

N 8 Noise Filter (Stop Light)
P 8
P 9
P 10
P 11
P 12
P 13
P 14
J31
Personal Light
T 11
T 16
T 17
T 18
T 19

Tweeter Front LH
Tweeter Front RH
Tweeter Rear LH
Tweeter Rear RH
V 8 Vanity Light LH
V 9 Vanity Light RH
53
AVENSIS (EWD526E)
http://vnx.su

[LHD : W/G]
I15
C17
F22
D8
I16
D15
C18
D13
D17
F24
H20
F21
D20
D7
D12
D9
H19
D18
C15
A32

D11
F25
D10
F23
C16
A33
B8
B7


F 21
F 22
F 23
F 24
F 25
C15
C16
C17
C18

D 7
D 8
D 9
D10
D 11
D12
D13


Fuel Lid Opener SW
Fuel Pump
Fuel Sender

I 15 Inner Mirror
I 16 Interior Light
54
AVENSIS (EWD526E)
http://vnx.su
G
[LHD : W/G]
V8
R12
P8
M7
M6
T11
V9
M5
T17
P9
S15
P17
T19
P11
R16
T16
P15
M4
R20
P12
R19
T18
R14
P10
J34
S14
J33
P16
L2
L1
R15
J 30
J 31
J 32
J 33
J 34
P14
P13
J30
J31
J32
N8
R17
R13
R18

Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
R12
R13
R14
R15
R16
R17
R18
R19
R20

Rain Sensor
Rear Interior Light


P 8
P 9
P 10
P 11
P 12
P 13
P 14
N7
Personal Light
T 11
T 16
T 17
T 18
T 19

Tweeter Front LH
Tweeter Front RH
Tweeter Rear LH
Tweeter Rear RH
V 8 Vanity Light LH
V 9 Vanity Light RH
55
AVENSIS (EWD526E)
http://vnx.su

Position of Parts in Seat
[LHD]
(*2)
S17
J37
J38
* 1:w/ Power Seat

* 2:w/o Power Seat
P23
B10
(*1)
P22
S18
(*2)
P24
J35
S16
S19
P19
(*2)
J36
B9
S18
(*1)
P18
L7
P20
S16
P21
L6
P25
(*1)
B 9 Buckle SW (Drivers Side)

B 10 Buckle SW (Front Passengers Side)
Occupant Detection Sensor
J 35
J 36
J 37
J 38
Junction Connector
Junction Connector
Junction Connector
Junction Connector
L 6 Lumbar Support Control Motor

L 7 Lumbar Support Control SW
S17
S19
(*1)
(*2)
P 18
P 19
P 20
P 21
P 22
P 23
P 24
Power Seat Control SW (Drivers Seat)

Power Seat Control SW (Front Passengers Seat)
Power Seat Motor (Drivers Seat Front Vertical Control)
Power Seat Motor (Drivers Seat Lifter Control)
Power Seat Motor (Drivers Seat Reclining Control)
Power Seat Motor (Drivers Seat Slide Control)
Power Seat Motor
(Front Passengers Seat Reclining Control)
P 25 Power Seat Motor
(Front Passengers Seat Slide Control)
S 16
S 17
S 18
S 19
Seat Heater LH
Seat Heater RH
Side Airbag Squib LH
Side Airbag Squib RH
56
AVENSIS (EWD526E)
http://vnx.su

[RHD : 1AZFSE]
B3
F13
B2
C2
H9
F16
H10
C1
H7
H8
*1:w/ HID
*2:w/o HID
F5
F6
E5
A5
E4
C6
A6
A11
A4
A10
(M/T)
H2
(A/T)
H6
F10
H1
(*1)
H5
(*2)
(*1)
(*2)
F2
H4
A 1
A 2
A 3
A 4
A 5
A 6
A 9
A 10
A 11
A 12
C5
E2
F11
F9
B1
F4
H3

A/C Pressure Sensor
Air Flow Meter
Alternator
Alternator
C3
A12
H12
E6
A1
H11
F
F
F
F
F
3
4
5
6
7
C
C
C
C
C
1
2
3
5
6

Compressor Assembly
E
E
E
E
E
1
2
4
5
6
ECT Solenoid
Engine Hood Courtesy SW

A3
E1
A9
F3
F1
F 11
F 13
F 16
Front Fog Light LH

Front Fog Light RH
Headlight LH (Low)
Headlight RH (Low)
Front Washer Motor
Front Wiper Motor
H 1
H 2
H 3
H 4
H 5
H 6
H 7
H 8
H 9
H10
H 11
H12

Headlight LH (High)
Headlight RH (High)
Horn LH
Horn RH
F 8
F 9
F 10
B 1 BackUp Light SW
B 2 Brake Booster Pressure Sensor
A2
58
AVENSIS (EWD526E)
http://vnx.su
F7
F8
G
[RHD : 1AZFSE]
V1
I5
I6
I7
I8
S3
T1
V5
N2
V6
J2
P2
J1
O1
O2
S1
S5
R3
S4
I1
I
I
I
I
I
I
I
I
1
2
3
4
5
6
7
8

Injector No.1
Injector No.2
Injector No.3
Injector No.4
I2
I3
K1
I4
R1
N1
T4

S
S
S
S
1
3
4
5

Spill Valve
Starter
Starter
T 1 Throttle Control Motor and Position Sensor

K 1 Knock Sensor
V 1 Vacuum Sensor
V 5 VSV (EVAP)
V 6 VSV (Intake Air Control Valve)

O 2 Oil Pressure SW
59
AVENSIS (EWD526E)
http://vnx.su

[RHD : 1AZFE]
F13
B3
A12
C1
F6
F5
A5
A6
C6
A4
A11
C5
A10
E2
H6
H5
F11
F8
F10
F1
F2
C3
A 1
A 2
A 3
A 4
A 5
A 6
A 9
A 10
A 11
A 12

A/C Pressure Sensor
Air Flow Meter
Alternator
Alternator

C
C
C
C
1
3
5
6

Compressor Assembly
H12
A1
E1
H11
A2
A3
A9
E 1 ECT Solenoid
F
F
F
F
F
1
2
5
6
8

Headlight LH (Low)
Headlight RH (Low)
H 5
H 6
H 11
H12
Headlight LH (High)
Headlight RH (High)
Horn LH
Horn RH
60
AVENSIS (EWD526E)
http://vnx.su
G
[RHD : 1AZFE]
I5
I6
I7
I8
I10
V3
T2
V5
N2
J2
P2
J1
S2
O2
S5
S4
I1
I 1
I 2
I 3
I 4
I 5
I 6
I 7
I 8
I 10

Injector No.1
Injector No.2
Injector No.3
Injector No.4
ISC Valve
I2
I3
K1
I4
R1
N1
T4
O 2 Oil Pressure SW
S 4 Starter
S 5 Starter

K 1 Knock Sensor
V 3 Variable Resistor
V 5 VSV (EVAP)
61
AVENSIS (EWD526E)
http://vnx.su

[RHD : 1ZZFE, 3ZZFE]

F13
B3
C2
C6
A11
C1
H7
E2
*1:w/ HID
*2:w/o HID
F6
A5
F5
A12
A4
A10
A6
H2
B1
H6
H1
F11
F9
F10
H5
(*1)
(*1)
(*2)
(*2)
F2
H4
A 1
A 3
A 4
A 5
A 6
A 9
A 10
A 11
A 12
F4

A/C Pressure Sensor
Air Flow Meter
Alternator
Alternator
B 1 BackUp Light SW
C
C
C
C
1
2
3
6

Compressor Assembly
E 1 ECT Solenoid
E 6 Engine Hood Courtesy SW
H3
C3
H12
E6
A1
H11
F
F
F
F
F
3
4
5
6
7
A3
E1
A9
F3
F1
F 11
F 13
Front Fog Light LH

Front Fog Light RH
Headlight LH (Low)
Headlight RH (Low)
Front Washer Motor
Front Wiper Motor
H 1
H 2
H 3
H 4
H 5
H 6
H 7
H 11
H12

Headlight LH (High)
Headlight RH (High)
Horn LH
Horn RH
F 8
F 9
F 10
62
AVENSIS (EWD526E)
http://vnx.su
F7
F8
G

I1
I2
I3
I4
N2
V5
J2
S2
J1
R3
T4
T2
I10
I5
I 1
I 2
I 3
I 4
I 5
I 6
I 7
I 8
I 10

Injector No.1
Injector No.2
Injector No.3
Injector No.4
ISC Valve
K1
I6
O2
I7
I8
S4
R1
S5
N1
R2
O 2 Oil Pressure SW
R 2 Radiator Fan Resistor
S 4 Starter
S 5 Starter

K 1 Knock Sensor
V 5 VSV (EVAP)
63
AVENSIS (EWD526E)
http://vnx.su

[RHD : 1CDFTV]
C1
F13
B3
G1
A11
F18
F16
E2
E3
F15
*1:w/ HID
*2:w/o HID
*3:Power Heater
(Hot Gas Type)
*4:Power Heater
(Electrical Type)
F6
A12
E5
F5
A5
G2
E4
A4
C6
A6
E7
F14
H2
B1
H6
H1
F11
F9
F10
H5
(*1)
(*1)
(*2)
(*2)
F2
A10
F4
H3
C4
A3
C3
H12
A1
E6
H11
A2
(*3)

A/C Pressure Sensor
Air Flow Meter
Alternator
Alternator
1
3
4
6

Compressor Assembly
Condenser Assembly
D 1 Diesel Throttle Control Motor

E
E
E
E
E
E
2
3
4
5
6
7


A3
D1
F3
A9
(*4)
F
F
F
F
F
3
4
5
6
7
F 8
F 9
F 10
B 1 BackUp Light SW
C
C
C
C
F8
F1
H4
A 1
A 2
A 3
A 4
A 5
A 6
A 9
A 10
A 11
A 12
F7
F 11
F 13
F 14
F 15
F 16
F 18
Front Fog Light LH

Front Fog Light RH
Headlight LH (Low)
Headlight RH (Low)
Front Washer Motor
Front Wiper Motor
Fuel Filter Warning SW
Fuel Heater
Fuel Temp. Sensor
G 1 Glow Plug
G 2 Glow Plug Relay
H 1
H 2
H 3
H 4
H 5
H 6
H 11
H12

Headlight LH (High)
Headlight RH (High)
Horn LH
Horn RH
64
AVENSIS (EWD526E)
http://vnx.su
G
[RHD : 1CDFTV]
I5
I6
I7
I8
V2
V4
*5:w/ VSC
*6:w/o VSC
S2
(*6)
O1
S1
J2
(*5)
J1
W1
T5
R3
I9
S6
I
I
I
I
I
5
6
7
8
9
Injector No.1
Injector No.2
Injector No.3
Injector No.4
S4
O2
S5
P3
S
S
S
S
S
1
2
4
5
6
R1
T3

Starter
Starter
T 3 Throttle Position SW
T 5 Turbo Pressure Sensor

O 2 Oil Pressure SW
V 2 Vacuum SW
V 4 VRV (EGR)

65
AVENSIS (EWD526E)
http://vnx.su

[RHD]
A21
A19
A31
(*1)
(*2)
A22
A23
A17
A25
A18
C10
C11
A29
A24
C9
C8
C12
B4
B6
B5
A14
A15
C14
(*1)
C13
(*2)
A20
(*1)
(*2)

* 2:Automatic A/C
A26
A 13
A 14
A 15
A 16
A 17
A 18
A 19
A 20
A 21
A 22
A 23
A 24
A 25
A 26
A 27
A 28
A 29
A 30
A 31
C7

A/C Solar Sensor
A/C Thermistor
Antenna Amplifier
A27
A28
A13
A16
(*1)
(*2)
A30
B 4 Blower Motor
B 5 Blower Motor Controller
B 6 Blower Resistor
C 7 Cigarette Lighter
C 8 Circuit Opening Relay
C 9 Clutch Start SW
C 11 Combination Meter
C12 Combination SW
C13 Combination SW
C14 Combination SW
66
AVENSIS (EWD526E)
http://vnx.su
G
[RHD]
D4
G3
D2
D3
H13
F19
I13
E15
E14
D6
E9
(*3)
E10
(*4)
E11
H15
H16
(*7)
H14
E12
D5
I14
E13
* 3:w/ Headlight Beam Level Control w/o HID

* 4:w/ Headlight Cleaner
* 7:1AZ-FSE
H18
D
D
D
D
D
2
3
4
5
6
Diode
Diode
Diode (Fan)
DLC3
E 8 ECT Pattern Select SW

Engine ECU (M/T)
Engine ECU (M/T)
Engine ECU (M/T)
Engine ECU (M/T)
Engine ECU (M/T)
E 14 EPS ECU
E 15 EPS ECU
H17
E8
I12
I11
(*5)
(*6)
F 19 Front Passengers Seat Belt Warning Light

G 3 Glove Box Light
H13
H14
H15
H16
H17
H18
Hazard SW

I 13 Ignition SW
I 14 Integration Relay
67
AVENSIS (EWD526E)
http://vnx.su

[RHD]
J26
(*9)
(*8)
M3
M3
M2
M1
J29
J19
J23
J21
J3
J4
J15
J28
J24
J27
J25
J13
K3
J12
J17
J 3
J 4
J 12
J 13
J 15
J 16
J 17
J 19
J 20
J 21
J 22
J 23
J 24
J 25
J 26
J 27
J 28
J 29
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
J16
J22
J20
K 3 Knee Airbag Squib

M 1 MultiDisplay
M 2 MultiDisplay
M 3 MultiDisplay
68
AVENSIS (EWD526E)
http://vnx.su

G
[RHD]
R9
N6
R4
R5
R6
R7
T8
V7
T10
T9
R8
P5
P7
R10
N3
T6
N4
W2
N5
S13
P6
S12
Y1
R11
N
N
N
N
3
4
5
6
Navigation ECU
Navigation ECU
Navigation ECU
P
P
P
P
4
5
6
7
Parking Brake SW
Power Heater SW
Power Outlet
PTC Heater
R 4
R 5
R 6
R 7
R 8
R 9
R10
R 11
Radio and Player

Radio and Player
Radio and Player
Radio and Player
P4
S9
T7
Z2
T 6
T 7
T 8
T 9
T 10
Z1
U1
Theft Deterrent ECU

TRC Off SW
U 1 Unlock Warning SW
V 7 VSC Warning Buzzer
W 2 Wiper Relay
Y 1 Yaw Rate Sensor
S 9 Shift Lock Control ECU

S 12 Steering Sensor
S 13 Stop Light SW
69
AVENSIS (EWD526E)
http://vnx.su

[RHD : S/D]
I15
C17
F22
D17
I16
F24
(*1)
(*2)
D14
D13
C18
* 1:w/ Double Locking
* 2:w/o Double Locking
D16
D15
(*1)
(*2)
(*1)
(*2)
F21
D7
D18
D12
(*1)
A33
(*2)
H19
C15
A32
D11

C15
C16
C17
C18
D 7
D 8
D 9
D10
D 11
D12
D13
D20
H20
D9
D19
D21


D14 Door Key Lock and Unlock SW (Drivers Side)
Double Lock Motor (Drivers Side)
Double Lock Position SW (Drivers Side)
Door Unlock Detection SW (Front Passengers Side)
Double Lock Motor (Front Passengers Side)
Double Lock Position SW (Front Passengers Side)
D8
F25
F23
D10
C16

Door Unlock Detection SW Rear LH
Double Lock Motor Rear LH
Double Lock Position SW Rear LH
Door Unlock Detection SW Rear RH
Double Lock Motor Rear RH
Double Lock Position SW Rear RH
F 21
F 22
F 23
F 24
F 25

Fuel Lid Opener SW
Fuel Pump
Fuel Sender

I 15 Inner Mirror
I 16 Interior Light
70
AVENSIS (EWD526E)
http://vnx.su
G
[RHD : S/D]
V8
R12
P8
T12
M7
M6
T11
V9
T17
M5
P13
S15
T19
T16
R19
M4
P11
P9
P15
P12
T15
T18
L5
P10
R14
S14
L2
P16
L3
R15
L1
P14
J32
R18
P17
J30
J31
R13
R16
L4


L 3 Luggage Compartment Door Lock Motor
L 4 Luggage Compartment Door Opener SW
L 5 Luggage Compartment Light
R12
R13
R14
R15
R16
R18
R19
P 8
P 9
P 10
P 11
P 12
P 13
P 14
Rain Sensor

Personal Light
T 11
T 12
T 15
T 16
T 17
T 18
T 19

Theft Warning Ultrasonic Sensor
Theft Warning Siren
Tweeter Front LH
Tweeter Front RH
Tweeter Rear LH
Tweeter Rear RH
V 8 Vanity Light LH
V 9 Vanity Light RH
71
AVENSIS (EWD526E)
http://vnx.su

[RHD : L/B]
I15
C17
F22
D8
D17
I16
F24
D14
C18
D21
D16
D12
F21
A33
D7
H20
D9
H19
D19
B7
B8
C15
A32
D11
F25

D 7
D 8
D 9
D10
D 11
D12
D14
F23
C16


C15
C16
C17
C18
D10


F 21
F 22
F 23
F 24
F 25

Fuel Lid Opener SW
Fuel Pump
Fuel Sender

I 15 Inner Mirror
I 16 Interior Light
72
AVENSIS (EWD526E)
http://vnx.su
G
[RHD : L/B]
V8
R12
P8
T12
M6
M7
T11
V9
T17
M5
P13
T19
T16
P11
M4
S15
P9
P15
P12
T15
T18
R19
P10
R14
S14
R20
P16
L2
L1
R15
J 30
J 31
J 32
J 33
J 34
P14
R17
P17
J32
J30
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
N7
N8
R16
R13
R18
J33
J34
R12
R13
R14
R15
R16
R17
R18
R19
R20

Rain Sensor
Rear Interior Light


P 8
P 9
P 10
P 11
P 12
P 13
P 14
P 15
J31
Personal Light
T 11
T 12
T 15
T 16
T 17
T 18
T 19

Theft Warning Siren
Tweeter Front LH
Tweeter Front RH
Tweeter Rear LH
Tweeter Rear RH
V 8 Vanity Light LH
V 9 Vanity Light RH
73
AVENSIS (EWD526E)
http://vnx.su

[RHD : W/G]
I15
C17
F22
D17
F24
I16
D14
C18
D16
H20
F21
D21
D7
D12
D9
H19
D19
C15
A32
D11
D8
F25

D 7
D 8
D 9
D10
D 11
D12
D14
F23
C16
A33
B8
B7


C15
C16
C17
C18
D10


F 21
F 22
F 23
F 24
F 25

Fuel Lid Opener SW
Fuel Pump
Fuel Sender

I 15 Inner Mirror
I 16 Interior Light
74
AVENSIS (EWD526E)
http://vnx.su
G
[RHD : W/G]
V8
R12
P8
M7
M6
T11
V9
M5
T17
T13
S15
P17
T19
T14
P11
T12
R16
T16
P15
M4
T15
P9
R19
P12
R14
T18
J34
S14
J33
P10
R20
P16
L2
L1
R15
J 30
J 31
J 32
J 33
J 34
P14
P13
J30
J31
J32
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
N8
R17
R12
R13
R14
R15
R16
R17
R18
R19
R20

R13
R18
Rain Sensor
Rear Interior Light


P 8
P 9
P 10
P 11
P 12
P 13
P 14
P 15
P 16
P 17
N7
Personal Light
Pretensioner LH
Pretensioner RH
T 11
T 12
T 13
T 14
T 15
T 16
T 17
T 18
T 19

Theft Warning Ultrasonic Sensor Rear LH
Theft Warning Ultrasonic Sensor Rear RH
Theft Warning Siren
Tweeter Front LH
Tweeter Front RH
Tweeter Rear LH
Tweeter Rear RH
V 8 Vanity Light LH
V 9 Vanity Light RH
75
AVENSIS (EWD526E)
http://vnx.su

Position of Parts in Seat
[RHD]
(*2)
S19
J37
J38
L6
* 1:w/ Power Seat

* 2:w/o Power Seat
P25
P24
S18
(*2)
P22
J35
L7
J36
B10
S18
(*1)
P19
P23
P21
B9
S19
P20
P18
(*1)
B 9 Buckle SW (Drivers Side)

B 10 Buckle SW (Front Passengers Side)
J 35
J 36
J 37
J 38
Junction Connector
Junction Connector
Junction Connector
Junction Connector
L 6 Lumbar Support Control Motor

L 7 Lumbar Support Control SW
P 18
P 19
P 20
P 21
P 22
P 23
P 24

Power Seat Control SW (Front Passengers Seat)
Power Seat Motor (Drivers Seat Front Vertical Control)
Power Seat Motor (Drivers Seat Lifter Control)
Power Seat Motor (Drivers Seat Reclining Control)
Power Seat Motor (Drivers Seat Slide Control)
Power Seat Motor
(Front Passengers Seat Reclining Control)
P 25 Power Seat Motor
(Front Passengers Seat Slide Control)
S 18 Side Airbag Squib LH
S 19 Side Airbag Squib RH
76
AVENSIS (EWD526E)
http://vnx.su

: Location of Connector Joining Wire Harness and Wire Harness
: Location of Ground Points
[LHD : 1AZFSE]
Engine Wire
Engine Room
Main Wire
EE
EA1
EB
ED
EA
EC
EF
Engine No.2 Wire
: Location of Splice Points

E3
E4
E5
;;;;;;;;;
;;;;;;;;;
;;;;;;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;;;;;;;;
;;;;
;;;;
;;;;;;;
;;;;
;;;;;;;;;;;
;;;;
;;;;
;;;;;;;;
;;;;;;;;
;;;;;;;;
;;;;;;;;
;;;;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
E1
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
E2
E8
E7
E6
78
AVENSIS (EWD526E)
http://vnx.su
G
Connector Joining Wire Harness and Wire Harness
EA1
1 2 3
4 5
6 7 8 9 10 11 12 13
5 4
3 2 1
13 12 11 10 9 8 7 6
Code
EA1
Engine Wire and Engine Room Main Wire (Left Side of the Suspension Tower)
79
AVENSIS (EWD526E)
http://vnx.su

[LHD : 1AZFE]
Engine Wire
Engine Room
Main Wire
EE
EA1
EB
ED
EA
EC
EF
Engine No.2 Wire

E3
E4
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
E1
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
E2
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
80
AVENSIS (EWD526E)
http://vnx.su
G
EA1
1 2 3
4 5
6 7 8 9 10 11 12 13
5 4
3 2 1
13 12 11 10 9 8 7 6
Code
EA1
81
AVENSIS (EWD526E)
http://vnx.su

Engine Wire
Engine Room
Main Wire
EH
ED
EB
EA1
EA
EC
EG
EB1
Engine No.4 Wire

E3
;;;
;;;
;;;
;;;
;;;
;;;
;;;
;;;
E1
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
E2
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
E4
82
AVENSIS (EWD526E)
http://vnx.su
G
EA1
1 2 3
4 5
6 7 8 9 10 11 12 13
EB1
5 4
3 2 1
13 12 11 10 9 8 7 6
Code
EA1
EB1
Engine Wire and Engine No.4 Wire (Near the Alternator)
Gray
2 1
83
AVENSIS (EWD526E)
http://vnx.su

[LHD : 1CDFTV]
Engine Wire
Engine Room
Main Wire
Engine No.4
Wire
EC1
ED
EB
ED1
EE1
EA
EC
Engine No.6 Wire
EB1
EA1
EI
Engine No.5 Wire

E4
;;;;;;;;
;;;;;;;;
;;;;;;;;
;;;;;;;;
;;;;;;;;
;;;;;;;;
;;;;;;;;
E3
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;;;;;;;
;;;;;;;;;;;;
;;;;;;;;;;;;
;;;;;;;;;;;;
;;;;;;;;;;;;
;;;;;;;;;;;;
;;;;;;;;;;;;
;;;;;;;;;;;;
;;;;;;;;;;;;
;;;;;;;;;;;;
;;;;;;;;;;;;
;;;;;;;;;;;;
;;;;;;;;;;;;
;;;;;;;;;;;;
;;;;;;;;;;;;
;;;;;;;;;;;;
;;;;;;;;;;;;
;;;;;;;;;;;;
;;;;;;;;;;;;
E1
84
AVENSIS (EWD526E)
http://vnx.su
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
E2
G
EA1
ED1
EB1
Gray
Gray
EE1
Black
3 2 1
6 5 4
1 2 3
4 5 6
EC1
Black
1 2 3 4 5
6 7 8 9 10
5 4 3 2 1
10 9 8 7 6
Code
EA1
Engine Wire and Engine No.5 Wire (Near the Starter)
EB1
EC1
ED1
EE1
Engine Wire and Engine Room Main Wire (Engine Compartment Left)
85
AVENSIS (EWD526E)
http://vnx.su

[LHD]
Engine Room
Main Wire
IE7
IE1
IE2
IE8
IE6
A/C Sub
Instrument
Wire No.1 Panel Wire
A/C Sub
Wire No.2
Roof Wire
Engine Wire
ID1
Front Door
RH Wire
IB1
IC1
Floor No.3 Wire
IC2
Floor No.2 Wire
Front Door
LH Wire
Floor No.2 Wire

Instrument Panel
No.3 Wire
IC3
Floor Wire
IA2
IA1
IE3
IE4
IE5
Floor Wire
Switch Wire

IK
IM
IN
IO
IL
IP
IJ
86
AVENSIS (EWD526E)
http://vnx.su
G
IA1
1
6
4
8
IA2
2
7
1
6
IB1
1 2
1 2 3 4 5 6 7 8 9 10 11
11 10 9 8 7 6 5 4 3 2 1
12 13 14 15 16 17 18 19 20 21 22
22 21 20 19 18 17 16 15 14 13 12
5 6
3 4
7
4 3
9 10
10 9
2 1
8
6 5
17 16 15 14 13 12 11 10
10 11 12 13 14 15 16 17
IC1
IC2
1 2 3 4 5 6 7 8 9
9 8 7 6 5 4 3 2 1
10 11 12 13 14 15 16 17 18
18 17 16 15 14 13 12 11 10
10 11 12 13 14 15 16 17 18
3 4 5 6 7
ID1
IC3
7 6 5 4 3
1 2
5 6
3 4
7
4 3
9 10
18 17 16 15 14 13 12 11 10
10 9
IE1
2 1
8
6 5
IE2
1 2 3 4 5 6 7 8 9 10
10 9 8 7 6 5 4 3 2 1
1 2 3 4 5 6 7 8 9 10 11
11 10 9 8 7 6 5 4 3 2 1
1 2 3 4 5 6 7 8 9
9 8 7 6 5 4 3 2 1
11 12 13 14 15 16 17 18 19 20
20 19 18 17 16 15 14 13 12 11
12 13 14 15 16 17 18 19 20 21 22
22 21 20 19 18 17 16 15 14 13 12
10 11 12 13 14 15 16 17 18
18 17 16 15 14 13 12 11 10
IE3
1
3
8
2
4 5 6 7
9 10 11 12
IE7
IE4
2
7
1
6
12 11 10 9
4 3
2 1
4 3
IE6
1 2 3
4 5
6 7 8 9 10 11 12 13
5 4
3 2 1
13 12 11 10 9 8 7 6
IE8
Yellow
2 1
1 2
IE5
1 2 3 4 5 6 7
7 6 5 4 3 2 1
8 9 10 11 12 13 14
14 13 12 11 10 9 8
3 4
Code
IA1
IA2
IB1

Front Door LH Wire and Instrument Panel Wire (Left Kick Panel)
Engine Room Main Wire and Floor Wire (Near the Driver Side J/B)
IC1
IC2
Instrument Panel Wire and Floor Wire (Left Kick Panel)
IC3
ID1
Instrument Panel Wire and Roof Wire (Left Side of the Instrument Panel)
IE1
IE2
IE3
IE4
IE5
Engine Room Main Wire and Instrument Panel Wire (Behind the Combination Meter)
IE6
IE7
IE8
87
AVENSIS (EWD526E)
http://vnx.su

[LHD]
* 1:1AZ-FE, 1ZZ-FE
* 2:1AZ-FSE, 1CD-FTV
* 4:Automatic A/C
A/C Sub
Wire No.1
IF1
IK1
IK2
Instrument
Panel Wire
IJ1
(*3)
IJ2
(*4)
A/C Sub
Wire No.2
Engine Wire
IM1
Roof Wire
Front Door
RH Wire
IL1
IM2
Engine Room
Main Wire
IL2
IN1
Front Door
LH Wire
Floor No.2 Wire

Floor No.2 Wire
Floor Wire
II1
Switch
Wire
(*2)
(*1)
Floor No.3 Floor
IG1
IG2
Wire
Wire
IH2
IH1
Instrument Panel
No.3 Wire
I3
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;;;;;;
;;;;;;
;;;;;;;;;;
;;;;;;
;;;;;;;;;;
;;;;;;
;;;;;;;;;;
;;;;;;
;;;;;;;;;;
;;;;;;
;;;;;;;;;;
;;;;
;;;;;;
;;;;;;;;;;
;;;;;;
;;;;
;;;;;;
I2
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
I5
;;;;
;;;;
;;;;
;;;;
I1
I4
;;;;;;;;;;;;;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;;;;
I7
I6
88
AVENSIS (EWD526E)
http://vnx.su
G
IF1
IG1
Black
2 1
4 3
1 2
3 4
IH2
IG2
Black
1 2
2 1
II1
Gray
IJ1
IH1
Black
1 2 3 4 5
IJ2
Black
5 4 3 2 1
IK1
Black
1 2
2 1
4 3
1 2
3 4
2 1
1 2 3 4 5 6 7 8 9 10 11
11 10 9 8 7 6 5 4 3 2 1
22 21 20 19 18 17 16 15 14 13 12
1
6
4
8
IM1
1 2 3 4 5 6 7 8 9
9 8 7 6 5 4 3 2 1
18 17 16 15 14 13 12 11 10
10 11 12 13 14 15 16 17 18
IH1
IH2
II1
IJ1
IJ2
IK1
IK2
IL1
IL2
IM1
IM2
IN1
5 6
3 4 5 6 7
3 4
7
9 10
4 3
2 1
8
1 2 3 4 5 6 7 8 9 10 11
11 10 9 8 7 6 5 4 3 2 1
12 13 14 15 16 17 18 19 20 21 22
22 21 20 19 18 17 16 15 14 13 12
6 5
17 16 15 14 13 12 11 10
IM2
10 11 12 13 14 15 16 17 18
IG2
IL2
10 11 12 13 14 15 16 17
IG1
IL1
12 13 14 15 16 17 18 19 20 21 22
IF1
10 9
IK2
Code
IN1
7 6 5 4 3
Yellow
2 1
1
18 17 16 15 14 13 12 11 10

Instrument Panel Wire and A/C Sub Wire No.1 (Left Side of the Combination Meter)
Instrument Panel Wire and Switch Wire (Instrument Panel Brace LH)
Floor No.3 Wire and Instrument Panel Wire (Instrument Panel Brace RH)
Instrument Panel Wire and Instrument Panel No.3 Wire (Under the Console Box)
Instrument Panel Wire and A/C Sub Wire No.2 (Left Side of the A/C Unit)
Engine Wire and Instrument Panel Wire (Behind the Glove Box)
Front Door RH Wire and Instrument Panel Wire (Right Kick Panel)
Instrument Panel Wire and Floor No.2 Wire (Right Kick Panel)
Floor No.2 Wire and Instrument Panel Wire (Right Kick Panel)
89
AVENSIS (EWD526E)
http://vnx.su

[LHD : S/D] Instrument
Roof Wire
BB1
Panel Wire
Roof No.2
Wire
Front Door
RH Wire
BU
BW
Rear Window
No.2 Wire
Front Door
LH Wire
BQ
Rear Door
No.1 Wire
BA1
Floor Wire
BR
Rear Door
No.2 Wire
BC1
Floor No.2 Wire
BV
BS
BT

B5
B6
;;;;;;;;;;;
;;;;;;;;;;;
;;;;;;;;;;;
;;;;;;;;;;;
;;;;;;;;;;;
B7
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
B1
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
B9
;;;;;
;;;;;
;;;;;;;
;;;;;
;;;;;;;
;;;;;
;;;;;;;
;;;;;
;;;;;;;
;;;;;;;
;;;;;;;
;;;;;;;
;;;;
;;;;
;;;;
;;;;;;
;;;;
;;;;;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
B8
B2
B3
B4
90
AVENSIS (EWD526E)
http://vnx.su
G
BA1
3 4
BB1
17
16 15141312 11
20 1918
10
9 8
8 9
10
4 3
11 12131415 16
1819 20
17
1 2
2 1
3 4
4 3
5 6
6 5
BC1
3 4
10
11 12131415 16
1819 20
4 3
16 15141312 11
20 1918
10
9 8
8 9
17
17
Code
BA1
Rear Door No.2 Wire and Floor Wire (Under the Left Center Pillar)
BB1
Roof Wire and Roof No.2 Wire (Near the Personal Light)
BC1
Rear Door No.1 Wire and Floor No.2 Wire (Under the Right Center Pillar)
91
AVENSIS (EWD526E)
http://vnx.su

[LHD : L/B]
Roof Wire
BB1
Roof No.2 Back Door

Wire
No.1 Wire
BE2
Front Door
RH Wire
BE1
Instrument
Panel Wire
BU
Front Door
LH Wire
Rear Door
No.1 Wire
BQ
BX
BA1
Floor Wire
Back Door
No.2 Wire
BR
Rear Door
No.2 Wire
Floor No.2 Wire
BD1
BD2
BC1
BV
BS
BT

B5
B6
;;;;;;;;;
;;;;;;;;;
;;;;;;;;;
;;;;;;;;;
B1
B7
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
B9
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;;
;;;;;
;;;;;
;;;;;;;;
;;;;;
;;;;;;;;
;;;;;
;;;;;;;;
;;;;;;;;
;;;;;;;;
;;;;;;;;
;;;;;;;;
;;;;;
;;;;;
;;;;;
;;;;;;
;;;;;
;;;;;;
;;;;;
;;;;;;
;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
B8
B2
B3
B4
92
AVENSIS (EWD526E)
http://vnx.su
G
BA1
3 4
BB1
11 12131415 16
1819 20
17
17
16 15141312 11
20 1918
10
2 1
3 4
4 3
BC1
3 4
BD1
11 12131415 16
1819 20
17
17
BD2
12
3
456 7 8
4 3
1 2
3 4
2
16 15141312 11
20 1918
10
BE1
3
21
87 654
1 2
3 4
BE2
2 1
4 3
12
3
456 78
Code
BA1
BB1
BC1
BD1
BD2
BE1
BE2
2 1
4 3
9 8
8 9
10
6 5
5 6
9 8
8 9
10
4 3
1 2
3
21
87 654
Back Door No.1 Wire and Floor Wire (Under the Left Quarter Pillar)
Back Door No.2 Wire and Back Door No.1 Wire (Back Door Upper Left)
93
AVENSIS (EWD526E)
http://vnx.su

[LHD : W/G]
Roof Wire
BB1
Front Door
RH Wire
Roof No.2
Wire
BU
BC1
Instrument
Panel Wire
Back Door
No.1 Wire
Front Door
LH Wire
Rear Door
No.1 Wire
Back Door
No.2 Wire
BQ
BA1
BX
Floor Wire
BT
BR
Rear Door
No.2 Wire
BV
Floor No.2 Wire
BF1
BF2
BG2
BG1
BS

B5
B6
B7
;;;;;;;;;;
;;;;;;;;;;
;;;;;;;;;;
;;;;;;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
B1
B9
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;;
;;;;;
;;;;;
;;;;;;;
;;;;;
;;;;;;;
;;;;;
;;;;;;;
;;;;;;;
;;;;;;;
;;;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;
B8
B2
B3
B4
94
AVENSIS (EWD526E)
http://vnx.su
G
BA1
3 4
BB1
11 12131415 16
1819 20
17
17
16 15141312 11
20 1918
10
2 1
3 4
4 3
6 5
5 6
9 8
8 9
10
4 3
1 2
BC1
BF1
1 2
3 4
1
3 4
16 15141312 11
20 1918
10
17
17
BF2
3 4 5 6
BG1
3 4
2 1
4 3
BA1
BB1
BC1
BG1
BG2
6 5
3 4 5 6
2
1
6 5 43
6 5
Code
BF2
4 3
BG2
1 2
2
1
6 5 43
5 6
BF1
5 6
9 8
11 12131415 16
1819 20
4 3
8 9
10
2 1
Back Door No.1 Wire and Back Door No.2 Wire (Back Door Left)
95
AVENSIS (EWD526E)
http://vnx.su

[LHD]
Floor No.2 Wire
Floor Wire
Front Seat LH Wire
Front Seat RH Wire
96
AVENSIS (EWD526E)
http://vnx.su

[RHD : 1AZFSE]
Engine Room
Main Wire
EE
Engine Wire
EA1
EB
ED
EA
EC
EF
Engine No.2 Wire

E7
E6
E4
E5
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;;;;;
;;;;;;;; ;;;;
;;;;
;;;;;;;;
;;;;;;;;
;;;;;;;;;;;
;;;;;;;;;;;;;;;; ;;;;
;;;;
;;;;;;;;;;;
;;;;;;;;;;;
;;;;;;;;;;;
;;;;;;;;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
E1
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
E2
E8
98
AVENSIS (EWD526E)
http://vnx.su
G
EA1
1 2 3
4 5
6 7 8 9 10 11 12 13
5 4
3 2 1
13 12 11 10 9 8 7 6
Code
EA1
99
AVENSIS (EWD526E)
http://vnx.su

[RHD : 1AZFE]
Engine Room
Main Wire
EE
Engine Wire
EA1
EB
ED
EC
EA
EF
Engine No.2 Wire

E4
;;;;
;;;;
;;;;
;;;;
;;;;
E1
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
E2
100
AVENSIS (EWD526E)
http://vnx.su
G
EA1
1 2 3
4 5
6 7 8 9 10 11 12 13
5 4
3 2 1
13 12 11 10 9 8 7 6
Code
EA1
101
AVENSIS (EWD526E)
http://vnx.su

Engine Room
Main Wire
EH
Engine Wire
ED
EB
EA1
EA
EC
EG
EB1
Engine No.4 Wire

E3
;;;
;;;
;;;
;;;
;;;
;;;
;;;
;;;
E1
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
E2
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
E4
102
AVENSIS (EWD526E)
http://vnx.su
G
EA1
1 2 3
4 5
6 7 8 9 10 11 12 13
EB1
5 4
3 2 1
13 12 11 10 9 8 7 6
Code
EA1
EB1
Gray
2 1
103
AVENSIS (EWD526E)
http://vnx.su

[RHD : 1CDFTV]
Engine Wire
Engine Room
Main Wire
Engine No.4
Wire
ED1
ED
EB
EE1
EA
EC
Engine No.6 Wire
EB1
EA1
EI
EC1
Engine No.5 Wire
E3
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;;;;;;;;;
;;;;;;;;;;;;;;
;;;;;;;;;;;;;;
;;;;;;;;;;;;;;
;;;;;;;;;;;;;;
;;;;;;;;;;;;;;
;;;;;;;;;;;;;;
;;;;;;;;;;;;;;
;;;;;;;;;;;;;;
;;;;;;;;;;;;;;
;;;;;;;;;;;;;;
;;;;;;;;;;;;;;
;;;;;;;;;;;;;;
;;;;;;;;;;;;;;
;;;;;;;;;;;;;;
;;;;;;;;;;;;;;
;;;;;;;;;;;;;;
;;;;;;;;;;;;;;
;;;;;;;;;;;;;;
;;;;;;;;;;;;;;
E1
104
AVENSIS (EWD526E)
http://vnx.su
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
E2
G
EA1
ED1
EB1
Gray
Gray
EE1
Black
3 2 1
6 5 4
1 2 3
4 5 6
EC1
Black
1 2 3 4 5
6 7 8 9 10
5 4 3 2 1
10 9 8 7 6
Code
EA1
EB1
EC1
ED1
EE1
105
AVENSIS (EWD526E)
http://vnx.su

[RHD]
Roof Wire
ID1
Engine Room
Main Wire
Engine Wire A/C Sub

Wire No.2
A/C Sub
Wire No.1
IB1
IE1
IF1
IE2
Instrument
Panel Wire
Front Door
LH Wire
A/C Sub
Wire No.3
IC1
Cowl Wire
IA1
Floor No.3 Wire
IC2
IA2
Front Door
RH Wire
IC3
Floor No.2 Wire

Floor Wire
Instrument Panel
No.3 Wire
Floor No.2
Floor Wire Wire
IH2
IH1

IN
IM
IK
IJ
IP
IL
106
AVENSIS (EWD526E)
http://vnx.su
G
IA1
4
8
IA2
2
7
1
6
IB1
1 2
1 2 3 4 5 6 7 8 9 10 11
11 10 9 8 7 6 5 4 3 2 1
12 13 14 15 16 17 18 19 20 21 22
22 21 20 19 18 17 16 15 14 13 12
5 6
3 4
7
4 3
9 10
10 9
2 1
8
6 5
17 16 15 14 13 12 11 10
10 11 12 13 14 15 16 17
IC1
IC2
1 2 3 4 5 6 7 8 9
9 8 7 6 5 4 3 2 1
10 11 12 13 14 15 16 17 18
18 17 16 15 14 13 12 11 10
10 11 12 13 14 15 16 17 18
3 4 5 6 7
IC3
7 6 5 4 3
18 17 16 15 14 13 12 11 10
ID1
1 2
5 6
3 4
7
9 10
4 3
10 9
IE1
2 1
8
6 5
IE2
1 2 3 4 5 6 7 8 9 10
10 9 8 7 6 5 4 3 2 1
1 2 3 4 5 6 7 8 9 10 11
11 10 9 8 7 6 5 4 3 2 1
1 2 3 4 5 6 7 8 9
9 8 7 6 5 4 3 2 1
11 12 13 14 15 16 17 18 19 20
20 19 18 17 16 15 14 13 12 11
12 13 14 15 16 17 18 19 20 21 22
22 21 20 19 18 17 16 15 14 13 12
10 11 12 13 14 15 16 17 18
18 17 16 15 14 13 12 11 10
IF1
2 1
4 3
1 2
3 4
Code
IA1
IA2
IB1
IH1
Black
1 2 3 4 5
IH2
5 4 3 2 1
1 2
3 4
Gray
2 1
4 3

IC1
IC2
IC3
ID1
IE1
IE2
IF1
IH1
IH2
Engine Room Main Wire and Instrument Panel Wire (Behind the Glove Box)
Instrument Panel Wire and A/C Sub Wire No.1 (Right Side of the Combination Meter)
107
AVENSIS (EWD526E)
http://vnx.su

[RHD]
*1:Except Automatic A/C
*2:Automatic A/C
Engine Room
Main Wire
A/C Sub A/C Sub

IJ1
IJ2
Wire No.2 Wire No.3
(*1)
(*2)
A/C Sub
Wire No.1
Instrument
Panel Wire
Roof Wire
IO1
Cowl Wire
IO3
IR1
IL1
IO2
IM1
IP1
IM2
Front Door
LH Wire
IL2
Engine Wire
Front Door
RH Wire
Floor Wire
Floor Wire
IN1
Instrument Panel
No.3 Wire
II1
IK1
Floor No.2
Wire
IK2
IQ1

I2
I3
;;;
;;;
;;;
;;;
;;;
;;;
;;;
;;;;;;;
;;;;
;;;
;;;
;;;;;;;
;;;;
;;;
;;;;
;;;;;;
;;;;;;
;;;;;
;;;;;;
;;;;;
;;;;;;
;;;;;
;;;;;;
;;;;;
;;;;;;
;;;;;;
;;;;;;
I5
I4
;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;
I7
I6
108
AVENSIS (EWD526E)
http://vnx.su
Floor No.3 Floor No.2

Wire
Wire
G
II1
IJ1
IJ2
Black
IK1
Black
1 2
1
2 1
3 4
7
5 6
4 3
9 10
10 9
IK2
2 1
8
IL1
1 2 3 4 5 6 7 8 9 10 11
11 10 9 8 7 6 5 4 3 2 1
12 13 14 15 16 17 18 19 20 21 22
22 21 20 19 18 17 16 15 14 13 12
IL2
1 2 3 4 5 6 7 8 9 10 11
11 10 9 8 7 6 5 4 3 2 1
12 13 14 15 16 17 18 19 20 21 22
22 21 20 19 18 17 16 15 14 13 12
17 16 15 14 13 12 11 10
10 11 12 13 14 15 16 17
IM1
IM2
1 2 3 4 5 6 7 8 9
9 8 7 6 5 4 3 2 1
10 11 12 13 14 15 16 17 18
18 17 16 15 14 13 12 11 10
10 11 12 13 14 15 16 17 18
IO2
3 4 5 6 7
IO3
6 5
IN1
7 6 5 4 3
2 1
1
3
8
18 17 16 15 14 13 12 11 10
IP1
Yellow
IO1
Yellow
IQ1
2
4 5 6 7
9 10 11 12
2
7
1
4
12 11 10 9
IR1
Black
2 1
1 2 3
4 5
5 4
6 7 8 9 10 11 12 13
Code
II1
IJ1
IJ2
IK1
IK2
IL1
IL2
IM1
IM2
IN1
3 2 1
13 12 11 10 9 8 7 6
4 3
1 2
3 4
3 4
6 5
4 3
2
5 6
1 2 3 4 5
5 4 3 2 1
2 1
4 3
6 5

Instrument Panel Wire and A/C Sub Wire No.2 (Right Side of the A/C Unit)
IO1
IO2
Engine Room Main Wire and Instrument Panel Wire (Left Side of the Instrument Panel)
IO3
IP1
Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Reinforcement LH)
IQ1
Instrument Panel Wire and A/C Sub Wire No.3 (Behind the Glove Box)
IR1
Instrument Panel Wire and Cowl Wire (Right Side of the Instrument Panel)
109
AVENSIS (EWD526E)
http://vnx.su

[RHD : S/D]Instrument
Roof Wire
BB1
Panel Wire
Roof No.2
Wire
Front Door
RH Wire
BU
BW
Rear Window
No.2 Wire
Front Door
LH Wire
BQ
Rear Door
No.1 Wire
BA1
Floor Wire
BR
Rear Door
No.2 Wire
BV
BC1
Floor No.2 Wire
BS
BT

B5
B7
;;;;;;;;;
;;;;;;;;;
;;;;;;;;;
;;;;;;;;;
;;;;;;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
B10
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
B1
B9
;;;;;
;;;;;;;
;;;;;
;;;;;;;
;;;;;
;;;;;;;
;;;;;
;;;;;;;
;;;;;
;;;;;;;
;;;;;;;
;;;;;;;
;;;;;;;
;;;;
;;;;
;;;;;;
;;;;
;;;;;;
;;;;
;;;;;;
;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
B8
B2
B3
B4
110
AVENSIS (EWD526E)
http://vnx.su
G
BA1
3 4
BB1
17
16 15141312 11
20 1918
10
9 8
8 9
10
4 3
11 12131415 16
1819 20
17
1 2
2 1
3 4
4 3
5 6
6 5
BC1
3 4
10
11 12131415 16
1819 20
4 3
16 15141312 11
20 1918
10
9 8
8 9
17
17
Code
BA1
BB1
BC1
111
AVENSIS (EWD526E)
http://vnx.su

[RHD : L/B]
Roof Wire
BB1
Roof No.2 Back Door

Wire
No.1 Wire
BE2
BE1
Front Door
RH Wire
Instrument
Panel Wire
BU
Front Door
LH Wire
Rear Door
No.1 Wire
BQ
BX
BA1
Floor Wire
Back Door
No.2 Wire
BR
Rear Door
No.2 Wire
Floor No.2 Wire
BD1
BD2
BC1
BV
BS
BT

B5
B7
;;;;;;;;;
;;;;;;;;;
;;;;;;;;;
;;;;;;;;;
B10
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
B9
;;;;;
;;;;;
;;;;;
;;;;;;;;
;;;;;
;;;;;;;;
;;;;;
;;;;;;;;
;;;;;;;;
;;;;;;;;
;;;;;;;;
;;;;;;;;
;;;;;
;;;;;
;;;;;
;;;;;;
;;;;;
;;;;;;
;;;;;
;;;;;;
;;;;;
;;;;;;
;;;;;;
;;;;;;
;;;;;;
B1
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
B8
B2
B3
B4
112
AVENSIS (EWD526E)
http://vnx.su
G
BA1
3 4
BB1
11 12131415 16
1819 20
17
17
16 15141312 11
20 1918
10
2 1
3 4
4 3
BC1
3 4
BD1
11 12131415 16
1819 20
17
17
BD2
12
3
456 7 8
4 3
1 2
3 4
2
16 15141312 11
20 1918
10
BE1
3
21
87 654
1 2
3 4
BE2
2 1
4 3
12
3
456 78
Code
BA1
BB1
BC1
BD1
BD2
BE1
BE2
2 1
4 3
9 8
8 9
10
6 5
5 6
9 8
8 9
10
4 3
1 2
3
21
87 654
113
AVENSIS (EWD526E)
http://vnx.su

[RHD : W/G]
Roof Wire
BB1
Front Door
RH Wire
Roof No.2
Wire
BU
BC1
Instrument
Panel Wire
Back Door
No.1 Wire
Front Door
LH Wire
Rear Door
No.1 Wire
Back Door
No.2 Wire
BQ
BA1
BX
Floor Wire
BT
BR
Rear Door
No.2 Wire
BV
Floor No.2 Wire
BF1
BF2
BG2
BG1
BS

B5
B7
;;;;;;;;;;
;;;;;;;;;;
;;;;;;;;;;
;;;;;;;;;;
B10
B1
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
;;;;
B9
;;;;;
;;;;;
;;;;;
;;;;;;;
;;;;;
;;;;;;;
;;;;;
;;;;;;;
;;;;;;;
;;;;;;;
;;;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;
;;;;;;;;;;;;;;;;;;;;;;;;;
B8
B2
B3
B4
114
AVENSIS (EWD526E)
http://vnx.su
G
BA1
3 4
BB1
11 12131415 16
1819 20
17
17
16 15141312 11
20 1918
10
2 1
3 4
4 3
6 5
5 6
9 8
8 9
10
4 3
1 2
BC1
BF1
1 2
3 4
1
3 4
16 15141312 11
20 1918
10
17
17
BF2
3 4 5 6
BG1
3 4
2 1
4 3
BA1
BB1
BC1
BG1
BG2
6 5
3 4 5 6
2
1
6 5 43
6 5
Code
BF2
4 3
BG2
1 2
2
1
6 5 43
5 6
BF1
5 6
9 8
11 12131415 16
1819 20
4 3
8 9
10
2 1
115
AVENSIS (EWD526E)
http://vnx.su

[RHD]
Floor No.2 Wire
Floor Wire
Front Seat LH Wire
Front Seat RH Wire
116
AVENSIS (EWD526E)
http://vnx.su
Power Source
20A FR DIC
1
2
IE5 IP1
(LHD)(RHD)
W
(2)
1
6A
RW
30A PWR SEAT

50A AM1 NO. 1
1
1
2
LO
(1)
10A FUEL OPN
1
30A HLP CLN

1
7. 5A ECUB 1
(1)
50A VSC (w/ VSC)

40A ABS (w/o VSC)
1
120A ALT (5)

100A ALT (6)
LR
WR
(LHD)
20A DFR P/W

1
(1)
25A VSC (w/ VSC)

25A ABS (w/o VSC)
LB
LY
(RHD)
20A DRR P/W
(1)
LW
20A PFR P/W

BG
1
4C
BG
(1)
20A PRR P/W
(1)
LB
1 4D
BG(1)
(1)
BG
(1)
BG
1 4B
1
4A
B
(2)
40A HTR
W
(2)
1
1B
1 (2)
L
(2)
1 (2)
FL MAIN
3. 0W
140A ALT
1
80A GLOW
(2) 1
2
(2)
WR
(6)
WR
(2) 1
2
B
(2)
L
(2)
BR
R
(2)
W(2)
30A RR DEF
1
25A VSC (w/ VSC)

25A ABS (w/o VSC)
50A HTR1
1
50A HTR2
Battery
50A VSC (w/ VSC)

40A ABS (w/o VSC)
3
(2)
L(2, 5)
2
30A CDS
30A H/CLN
W(2)
B(2)
(1)
BG
30A RDI (5)

40A RDI (2, 6)
50A AM1 NO. 1
(2)
W
(1)
(2)
W(2)
1
ED1
BL(2)
BL(2)
BG
(1)
120
AVENSIS (EWD526E)
http://vnx.su
RW
RW
25A PWR HTR
(2) 1
RW
2
10A MIR HTR
FR DEICER Relay
5
3
(2)
30A AM2
1
: Gasoline
: 1CDFTV
: w/ Daytime Running Light
: w/o Daytime Running Light
: 1AZFSE, 1AZFE
: 1ZZFE, 3ZZFE
BR
15A HLP LH
2
WL
WR
20A A/F
(1) 1
1
2
3
4
5
6
BY
BR
40A MAIN
1
15A HLP RH
2
BR
RB
(1)
RL
(1) 1
WL
10A THROTTLE
GR
10A HLP HI LH
WR
(1)
2
(4)
RY
15A HORN
1
1A
(3)
RY
BG(1)
WR(4)
RB
(3)
RL
(3)
B
(2)
WR
15A IG2
(1) 1
BY
(1)
GR
(1)
25A FHTR
2
BW
(1)
(1)
1
4
5
IE4 IP1
(LHD)(RHD)
(2)
(1)
WR
BW
WR
15A RAD NO. 2

2
BW
LY
R9
Rear Window
Defogger Relay
RW 1
2 GW
50A EMPS
2
(6)
(1)
W
BL(2)
BW
(2)
30A DCC
(6) 1
7. 5A DOME
2
(1)
7. 5A ECUB 2
BR
WB
30A RR DEF
(2) 1
7. 5A EFI NO. 2
EFI Relay
2
(2) 1
(1)
20A EFI
1
10A EFI NO. 1
(3)
RL
DIM Relay
2
WR
7. 5A ALTS
(3)
10A HAZARD
1
10A HLP HI RH
RB
WR
HLP Relay
(1)
7
IB1
(1)
W
(1)
(1)
B
(1)
7. 5A DEF I/UP
7
IC3
B
(1)
GW
(1)
BL(2)
BG
BG
(1)
(1)
121
AVENSIS (EWD526E)
http://vnx.su
Power Source
BR
BR
1
1
IE4 IP1
(LHD)(RHD)
ACC 2
GR
3 AM1
IG1 1
GY
BR
4 AM2
IG2 6
BR
ST2 5
BY
3
DH
15A CIG
7. 5A RAD NO. 1
2
DH
10A IGN
7. 5A ST
I13
Ignition SW
10A GAUGE1
IG1 Relay
GY
5
DH
7. 5A GAUGE2
25A WIP
20A RR WIP
10A HTR
7. 5A ECUIG
1
DH
25A AM1
(1)
BG
(2)
BL
1
DN
TAIL Relay
5
7. 5A PANEL
10A TAIL
SEAT HTR Relay

5
3
GR
20A SHTR
2
30A PWR SEAT
1
7. 5A RR FOG
20A S/ROOF
15A STOP
15A P/POINT
15A FR FOG
7. 5A OBD2
BL(2)
25A DOOR
BG
(1)
122
AVENSIS (EWD526E)
http://vnx.su
1 : Gasoline
2 : 1CDFTV
BW
Service Hints
I13 Ignition SW
32 : Closed with the ignition key at ACC or ON position
31 : Closed with the ignition key at ON or ST position
46 : Closed with the ignition key at ON or ST position
45 : Closed with the ignition key at ST position
: Parts Location
Code
See Page
47 (LHD)
I13
67 (RHD)
Code
R9
See Page
Code
See Page
49 (LHD)
69 (RHD)
: Relay Blocks
Code
1
See Page
24 (*1)
25 (*2)

Engine Room R/B No.1 (Engine Compartment Left)
26
Engine Room R/B No.2 (Near the Radiator Fan)
26
Engine Room R/B No.3 (Left Side of the Suspension Tower)
27
28 (LHD)
Driver Side R/B (Left Side of the Instrument Panel)
28 (RHD)
Driver Side R/B (Instrument Panel Reinforcement LH)
29
Fuse Block (Lower Finish Panel)
5
6

Code
1A
1B
See Page
24 (*1)
Engine Room Main Wire and Engine Room J/B No.1 (Engine Compartment Left)
25 (*2)
Engine Wire and Engine Room J/B No.1 (Engine Compartment Left)
24 (*1)
25 (*2)
27
Engine Room Main Wire and Engine Room J/B No.4 (Left Side of the Suspension Tower)
4A
4B
4C
4D
6A
29
Instrument Panel Wire and J/B No.6 (Lower Finish Panel)
DH
30
Instrument Panel Wire and Driver Side J/B (Left Side of the Instrument Panel)
DN
31
Engine Room Main Wire and Driver Side J/B (Left Side of the Instrument Panel)

Code
ED1
IB1
IC3
IE4
IE5
IP1
See Page
84 (*6)
104 (*10)
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)

86 (LHD)
108 (RHD)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 5 : LHD 1ZZFE, 3ZZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 9 : RHD 1ZZFE, 3ZZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
123
AVENSIS (EWD526E)
http://vnx.su
Starting
1 : Gasoline
2 : 1CDFTV
7. 5A
ST
J12(A), J13(B)
Junction
Connector
BR
BW
B B
1 IE4 (LHD)
1 IP1 (RHD)
BW
BY
(A/T)
BR
BR
B A
30A
AM2
BY
(M/T)
N1
Neutral Start SW
N
6
BY
ST Relay
(A/T)
1
1 1A
2
(1)
(2)
BG
A A
J12(A), J13(B)
Junction
Connector
1 4A
1 4B
C B
(1)
BG
(2)
7 IK1
WB
BY
2 DJ
1 A
FL MAIN
3. 0W
9 DA
BR
1
B
Battery
WB
S 4(A), S 5(B)
Starter
IJ
124
AVENSIS (EWD526E)
http://vnx.su
Service Hints
S4 (A), S5 (B) Starter
Point closed with the neutral start SW at P or N position and the ignition SW at ST position (A/T)
Point closed with the ignition SW at ST position (M/T)
N1 Neutral Start SW
96 : Closed with the shift lever in P or N position
ST Relay
53 : Closed with the neutral start SW at P or N position and the ignition SW at ST position (A/T)
Closed with the ignition SW at ST position (M/T)
: Parts Location
Code
J12
See Page
48 (LHD)
J13
Code
N1
Code
See Page
63 (*9)
39 (*3)
68 (RHD)
39 (*3)
41 (*4)
48 (LHD)
41 (*4)
43 (*5)
68 (RHD)
43 (*5)
39 (*3)
45 (*6)
S4
41 (*4)
N1
See Page
S5
45 (*6)
59 (*7)
59 (*7)
61 (*8)
43 (*5)
61 (*8)
63 (*9)
59 (*7)
63 (*9)
65 (*10)
61 (*8)
65 (*10)
: Relay Blocks
Code
1
3
5
6
See Page
24 (*1)
25 (*2)

26
28 (LHD)
28 (RHD)
29

Code
1A
4A
4B
DA
DJ
See Page
24 (*1)
25 (*2)
27
30

Code
IE4
IK1
IP1
See Page
86 (LHD)
88 (LHD)
108 (RHD)
108 (RHD)

: Ground Points
Code
IJ
See Page
86 (LHD)
106 (RHD)

Left Kick Panel
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
125
AVENSIS (EWD526E)
http://vnx.su
Charging
B(2)
BG(1)
B
10A
GAUGE1
7. 5A
DOME
10 IC1
11
MPX2
22
(LHD)
1 4E
2
120A
ALT(11)
100A
ALT(7)
1 4B
1 4A
1 1A
CPU
(1)
B
5 B
C10(A), C11(B)
Combination Meter
WB
(1)
BG
(2)
13 A
BEAN
I/F
BG
(2)
14 A
7. 5A
ALTS
21 B
140A
ALT
20 B
Charge
WR
PB
1 IC1
(1)
BG
PB
6 CD
H B
(2)
MPX1
F A (LHD)
F C
F C (RHD)
RW
J10(A), J11(B), J26(C)

Junction
Connector
7 CA
I14
Integration Relay
WR
RW
7 DB
(RHD)
WR
6 CK
FL MAIN
3. 0W
WB
6 CA
Battery
IP
126
AVENSIS (EWD526E)
http://vnx.su
B(2)
From Power Source
System (See Page 120)
BG(1)
B
P
7. 5A
ECUIG
(8)
(1AZFE)
(7)
(2)
8 E
1 IK2
RW
(2)
BL
4 A
3 A
1 A
A11(A), A12(B)
Alternator
B(2)
BG(1)
I3
(5)
RW
5 EA1 (1)
5 EE1 (2)
E4
(3)
BW
(2)
BL
13 IK2
G A (LHD)
C B (RHD)
(3)
Y
Y
26 A
G A (LHD)
C B (RHD)
9 IK1
(5)
MPX
ALT
(EFII)
BL
C
B
A
D
(6)
21
28
27
9
MPX+
RW
ALT
29 A (9)
20 B (10)
9 A
10 B
J10(A), J20(B)
Junction
Connector
RL
3 EE1
PB
MPX2
A13(A), A15(B)
PB
P
MPX1
(6)
29 B (8)
29 A (6)
21 A (2)
18 B
23 A
20 A
(4)
E 9(A), E10(B), E11(C), E12(D), E13(E)

Engine and ECT ECU (A/T)
Engine ECU (M/T)
ALT+L
(4)
P1
Power Heater Assembly
18 DB
1 B
B+(1)
B (2)
2 A
IG
1 : Gasoline
2 : 1CDFTV
3 : Power Heater (Electrical Type)
4 : Power Heater (Combustion Type)
5 : 1AZFSE, 1CDFTV
6 : 1AZFE, 1ZZFE, 3ZZFE
7 : 1ZZFE, 3ZZFE
8 : 1AZFSE
9 : Except Automatic A/C
10 : Automatic A/C
11 : 1AZFSE, 1AZFE
127
AVENSIS (EWD526E)
http://vnx.su
Charging
Service Hints
A11 (A) Alternator
(A) 1Ground : 13.214.0 volts with the engine running at 6000 rpm and 135C (275F) (Gasoline)
13.214.0 volts with the engine running at 5000 rpm and 115C (239F) (1CDFTV, taxi package w/ A/C)
13.213.7 volts with the engine running at 5000 rpm and 115C (239F) (Taxi package w/o A/C)
: Parts Location
Code
See Page
38 (*3)
40 (*4)
42 (*5)
A11
44 (*6)
58 (*7)
60 (*8)
62 (*9)
64 (*10)
38 (*3)
40 (*4)
A12
42 (*5)
44 (*6)
58 (*7)
60 (*8)
Code
A12
A13
A15
See Page
B
A
B
C10
C11
E9
E10
A
B
62 (*9)
64 (*10)
46 (LHD)
66 (RHD)
46 (LHD)
66 (RHD)
Code
See Page
E11
E12
E13
46 (LHD)
47 (LHD)
67 (RHD)
47 (LHD)
67 (RHD)
47 (LHD)
67 (RHD)
47 (LHD)
I14
66 (RHD)
67 (RHD)
46 (LHD)
J10
48 (LHD)
66 (RHD)
J11
48 (LHD)
47 (LHD)
J20
68 (RHD)
67 (RHD)
J26
68 (RHD)
47 (LHD)
P1
45 (*6)
67 (RHD)
: Relay Blocks
Code
1
See Page
24 (*1)
25 (*2)

26
29

Code
1A
4A
4B
4E
CA
CD
See Page
24 (*1)
25 (*2)
27
27
Engine Wire and Engine Room J/B No.4 (Left Side of the Suspension Tower)
34
CK
35
DB
30
Instrument Panel Wire and Center J/B (Instrument Panel Reinforcement RH)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
128
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV

Code
See Page
78 (*3)
80 (*4)
EA1
82 (*5)
98 (*7)
100 (*8)
102 (*9)
EE1
IC1
IK1
IK2
84 (*6)
104 (*10)
86 (LHD)
106 (RHD)
88 (LHD)
108 (RHD)
88 (LHD)
108 (RHD)
: Ground Points
Code
IP
See Page
86 (LHD)
106 (RHD)

Right Kick Panel
: Splice Points
Code
See Page
E4
84 (*6)
I3
88 (LHD)

Engine Wire
Code
I3
See Page
108 (RHD)

Engine Wire
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
129
AVENSIS (EWD526E)
http://vnx.su
Ignition
15A
IG2
10A
IGN
1
2
3
4
: 1AZFSE, 1AZFE
: 1ZZFE, 3ZZFE
: 1AZFSE
: 1AZFE
2
1
16 DL
BR
E 4 : 1
E 3 : 2
RB
E 4 : 1
E 3 : 2
E 4 : 1
E 3 : 2
1
RB
IG2 Relay
RB
BR
BR
N2
Noise Filter
(Ignition)
RB
RB
RB
RB
8 EA1
RB
I1
Ignition Coil and
Igniter No. 1
IGT
IGF
GND
IGT
IGF
GND
IGT
IGF
GND
IGT
IGF
GND
WR
WB
LGB
WR
WB
LY
WR
WB
+B
WB
+B
I4
Ignition Coil and
Igniter No. 4
WR
+B
I3
Ignition Coil and
Igniter No. 3
RW
10
IGT3
24 (3)
13 (4)
23 (2)
IGF1(1)
IGF(2)
WB
WR
E 5 : 3
E 4 : 4
I 3 : 2
11
IGT4
(2)
9
IGT2
WR
E 5 : 3
E 4 : 4
I 3 : 2
E4
WB
8
IGT1
WB
E4
(1)
WB
E4
WR
WB
+B
I2
Ignition Coil and
Igniter No. 2
EC
(1)
WB
WB
E13
Engine ECU (M/T)
EF
130
AVENSIS (EWD526E)
http://vnx.su
EH
Service Hints
I1, I2, I3, I4 Ignition Coil and Igniter No.1, No.2, No.3, No.4
1Ground : Approx. 12 volts with the ignition SW at ON position
: Parts Location
Code
See Page
Code
47 (LHD)
E13
67 (RHD)
I1
Code
I2
61 (*8)
See Page
43 (*5)
I4
59 (*7)
39 (*3)
63 (*9)
41 (*4)
39 (*3)
63 (*9)
43 (*5)
41 (*4)
39 (*3)
59 (*7)
43 (*5)
41 (*4)
61 (*8)
I2
See Page
59 (*7)
I3
59 (*7)
N2
61 (*8)
43 (*5)
63 (*9)
61 (*8)
39 (*3)
63 (*9)
61 (*8)
41 (*4)
39 (*3)
63 (*9)
43 (*5)
I4
59 (*7)
41 (*4)
: Relay Blocks
Code
See Page
24 (*1)
27

Code
DL
See Page
31


Code
See Page
78 (*3)
80 (*4)
EA1
82 (*5)
98 (*7)
100 (*8)
102 (*9)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
131
AVENSIS (EWD526E)
http://vnx.su
Ignition
: Ground Points
Code
See Page
78 (*3)
80 (*4)
82 (*5)
EC
84 (*6)
98 (*7)
Engine Compartment Left
100 (*8)
102 (*9)
104 (*10)
78 (*3)
EF
80 (*4)
98 (*7)
100 (*8)
EH
Left Side of the Cylinder Head
82 (*5)
102 (*9)
: Splice Points
Code
E3
See Page
80 (*4)
82 (*5)
98 (*7)
Code
E4
102 (*9)
78 (*3)
E4
82 (*5)
Engine Wire
E5
I3
See Page
100 (*8)
102 (*9)
78 (*3)
98 (*7)
Engine Wire
88 (LHD)
108 (RHD)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
132
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
Memo
133
AVENSIS (EWD526E)
http://vnx.su
Engine Control (1AZFSE)

BW
10A IGN
BY
BW
4
B
GR
BY
BY
10 IB1
BW
WB
BW
7 EA1
BW
20A EFI
4 IE2
6 IC3
LB
2
BG
BW
1 1A
WB
10A EFI NO. 1
3
1
GY
EFI
Relay
7. 5A EFI NO. 2
15A IG2
1
4
GY
C8
Circuit
Opening Relay
IG2
Relay
INJ Relay
BY
4
BR
BW
18 DA
BW
16 DL
BR
GR
1 4A
BG
WB
F25
Fuel Pump
1 4B
BR
BW
4
M
5
E2
13 EA1
GY
BW
FL MAIN
3. 0W
WB
BR
BW
Battery
WB
EC
134
AVENSIS (EWD526E)
http://vnx.su
BR
1 : LHD M/T
2 : RHD M/T
GRR
BW
BW
BY
BY
GR
GR
RW(1)
RW(2)

P
1
LW
10 IC1
10A
GAUGE1
11
MPX1
RW
6
MPX2
I14
Integration Relay
7 DB
RW(2)
BW
RW(1)
7. 5A
DOME
22
BW
LW
LW
PB
21 B
3 B
14 A
19 B
22 B
BEAN
I/F
Check
Engine
Temp.
Tachometer
PB
16 IE1
GRR
WR
Speedometer
20 B
1 IC1
RW
6 CD
WR
H B
8 CE
(RHD)
F A (LHD)
F C
F C (RHD)
(LHD)
J10(A), J11(B), J26(C)

Junction
Connector
WR
7 CA
VW
C10(A), C11(B)
Combination Meter
13 A
9 B
18 B
5 B
WB
CPU
6 CK
6 CA
VW
3 CB
GY
BR
BR
BW
BW
WB
GY
WB
WB
(RHD)
(RHD)
IP
135
AVENSIS (EWD526E)
http://vnx.su

GRR
GRR
BW
BW(LHD)
BY
BW(RHD)
GR
LW
9
IE2
RW(1)
5
IR1
RW(2)
RW(1)
RW(2)
P
LW
BW
BATT
C B (LHD)
E D (RHD)
BW
(RHD)
BW
E D
(LHD)
BW
BW
C A (LHD)
A C (RHD)
BW
BW
3 A
C A
A C
(RHD)
BY
BY
8 A
MREL
MPX2
GR
(2)
10 B
LGB
LGB
29 B
7 IE3 (LHD)
7 IO1 (RHD)
2 IE1
(1)
PB
C A
(LHD)
J19
Junction
Connector
J14(A)
Junction
Connector
C A
(2)
GR
6 IR1
LGB
C A
15 IE2
10
J 8(A), J 9(B), J26(C), J27(D)

Junction Connector
(1)
LGB
(2)
(1)
MPX+
LGB
LGB
MPX
A15
20
C9
Clutch
Start SW
9 A
IGSW
E 9(A), E10(B), E11(C), E12(D), E13(E)

Engine ECU (M/T)
W
11 A
SPD
MPX1
18 B
17 B
FC
10 A
IREL
+B
35 B
1 A
+B2
2 A
E03
7 C
E01
7 E
E02
6 E
ME01
4 C
GY
D A (LHD)
D B (RHD)
WB
WB
WB
WB
WB
BR
H A (LHD)
H C (RHD)
2 IE4 (LHD)
3 IP1 (RHD)
BR
VW
D A (LHD)
D B (RHD)
VW
J10(A), J20(C)
Junction Connector
WB
(RHD)
D A
D B
H A (LHD)
H C (RHD)
BR
BR
J14(A), J28(B)
Junction Connector
GY
VW
BW
V
BR
BW
B
BR
WB
(RHD)
EE
136
AVENSIS (EWD526E)
http://vnx.su
EF
GRR
GRR
BW(LHD)
BW(LHD)
BW(RHD)
BW(RHD)
1 : LHD M/T
2 : RHD M/T
1
3 : Shielded
LW
S1
35
7. 5A
ST
SP1
ENG+
ENG
NEO
32
TRC+
TRC
18
19
5 IE8
13 IE1
6 IE8
13 IE2
13 IE8 (LHD)
3 IE2 (RHD)
(M/T)
BY
YB
(RHD)
(LHD)
BW
(A/T)
BY
GR
A A
EFIO
B A
EFII
A A
6
BY
YB
14 IE8
14 IE2
J12(A), J13(B)
Junction Connector
B B
(A/T)
7 IE8
15 IE2
T8
BW
N1
Neutral
Start SW
26 B
24 A
27 B
IMO
ENG+
IMI
30 A
ENG
17 A
NEO
25 A
TRC+
31 A
17 E
TRC
STA
E 9(A), E10(B), E11(C), E12(D), E13(E)

Engine ECU (M/T)
E1
1 C
BW
I5
Injector No. 1
WB
I8
Injector No. 4
1
(RHD)
BR
(3)
(3)
WB
BR
W
E6
BR
BR
E 5 : LHD
E 4 : RHD
7 A
8 A
4 A
5 A
3 A
E8
VB
INJ# 1
COM1
INJ# 4
BR
BR
GND
E 4(A), E 5(B)
BR
BR
BR
BW
E 3 : LHD
I 3 : RHD
WB
(RHD)
137
AVENSIS (EWD526E)
http://vnx.su

GRR
GRR
BW(LHD)
3 : Shielded
BW(RHD)
15A
STOP
(RHD)
GW
GW
GW
(LHD)
1 IR1
2 DA
(RHD)
GW
(LHD)
(LHD)
RW
RW
(RHD)
RW
6 IE3
11 IE3
(LHD)
RW
(RHD)
(LHD)
BW
BW
BW
2 IR1
20 IE1
(RHD)
3 IR1
(LHD)
BW
(RHD)
(LHD)
GW
GW
GW
14 IE2
(RHD)
GW
(RHD)
GW
(LHD)
4 IR1
(LHD)
GW
(RHD)
22 DA
10 DC
S13
Stop Light SW
GW
19 B
12 B
ST1
STP
E 9(A), E10(B), E11(C), E12(D), E13(E)

Engine ECU (M/T)
I6
Injector No. 2
#2
#3
#4
2 E
3 E
4 E
IJF1
25 E
PSW
10 C
I7
Injector No. 3
1
BW
GW
WR
RW
WL
RB
E7
1 A
6 A
2 A
4 B
1 B
2 B
3 B
5 B
INJ# 2
COM2
INJ# 3
IJT# 1
IJT# 2
IJT# 3
IJT# 4
P2
Power Steering Oil Pressure SW
#1
1 E
BR
IJF
E 4(A), E 5(B)
BR
BW
BW
WB
WB
(RHD)
(RHD)
138
AVENSIS (EWD526E)
http://vnx.su
GRR
GRR
10A
THROTTLE
10A
TAIL
A27
4 DM
A11
Alternator
3 IC2
23
FAN NO. 1 Relay

FAN NO. 2 Relay
Diode (Fan)
C A (LHD)
C C (RHD)
11 DA
14 A
4 A
21 C
LGB
C B (LHD)
C D (RHD)
GY
9 DD
J10(A), J11(B), J26(C), J27(D)

Junction Connector
5 IE2
LGB
GR
J30
Junction
Connector
GSW2
12 A
6 B
ELS
+BM
F/PS
FAN
RL
E 9(A), E10(B), E11(C), E12(D), E13(E)

Engine ECU (M/T)
IGT1
IGT3
IGT2
9 E
IGT4
10 E
11 E
IGF1
24 E
E A
WR
WR
LY
WR
E5
WR
WR
E5
WR
E5
WR
R
(3)
C6
Crankshaft
Position Sensor
BR
C1
Camshaft
Position Sensor
(3)
I5
LGB
8 E
EOM
15 A
RW
NE+
25 C
BR
NE
24 C
G2+
27 C
IGT
IGF
IGT
IGF
IGT
IGF
IGT
IGF
E A
I1
Ignition Coil
and Igniter No. 1
E A
I2
Ignition Coil
and Igniter No. 2
I3
Ignition Coil
and Igniter No. 3
I4
Ignition Coil
and Igniter No. 4
J12(A), J13(B)
Junction
Connector
D B
D B
BR
BR
BW
BW
WB
WB
(RHD)
(RHD)
139
AVENSIS (EWD526E)
http://vnx.su

GRR
GRR
3 : Shielded
A20
(RHD)
7 IG2
E2
VC
RW
2 IG2
(LHD)
(RHD)
3 IG2
(RHD)
(LHD)
(RHD)
5 IG2
PIM
VCP2
4 (LHD)
6 (RHD)
2
2
BR
6 IG2
VPA2
1
3
(RHD)
(LHD)
EP2
6
4
1 IG2
(RHD)
(LHD)
VCP1
5
5
(LHD)
VPA1
3
1
(LHD)
EP1
B2
Brake Booster Pressure Sensor
11 EA1
10 EA1
9 EA1
28 A
23 A
EPA2
BR
(LHD)
29 A
VCPA
(LHD)
26 A
VPA
(LHD)
22 A
EPA
(LHD)
(LHD)
(LHD)
RW
26 E
27 A
VPA2
PB
VCP2
E 9(A), E10(B), E11(C), E12(D), E13(E)

Engine ECU (M/T)
OX
HT
1
E1
+B
H8
Heated Oxygen Sensor
(Bank 1 Sensor 2)
26 C
BW
2
1
O1B
21 D
S3
Spill Valve
K1
Knock Sensor
C2
Camshaft Timing
Oil Control Valve
(3)
25 D
OX1B
HT1B
15 C
YB
OC1
16 C
WG
OC1+
3 D
FP
6 D
FP+
(3)
EKNK
2 D
(3)
KNK1
1 D
E5
BW
(3)
BR
BR
BW
I3
BR
BW
BR
WB
WB
(RHD)
(RHD)
140
AVENSIS (EWD526E)
http://vnx.su
GRR
GRR
BR
E 3 : LHD
I 3 : RHD
E 3 : LHD
I 3 : RHD
E 3 : LHD
I 3 : RHD
BR
BR
E 3 : LHD
I 3 : RHD
BR
E 3 : LHD
I 3 : RHD
VCC
GND
VOUT
BR
RW
F16
BR
RW
BR
V1
Vacuum Sensor
RW
T1
Throttle Control Motor
and Position Sensor
RW
BR
E 3 : LHD
I 3 : RHD
E2
BR
RW
VCC
GND
VOUT
VC
VTA1
2 C
M+
17 C
YG
3 C
GW
21 E
VTA2
31 E
THW
(3)
19 E
18 E
E2
LW
RW
28 E
BR
BR
E 3 : LHD
I 3 : RHD
BR
BW
RW
33 E
23 E
GE01
PIM
PR
E 9(A), E10(B), E11(C), E12(D), E13(E)

Engine ECU (M/T)
BW
E5
OX
E1
BW
E5
HT
+B
H9
(Bank 2 Sensor 1)
4 D
BW
BW
BW
+B
HT2A
23 D
BR
E1
HT
(3)
OX
OX2A
H7
(Bank 1 Sensor 1)
+B
BW
HT
1
E2
BR
OX
HT1A
5 D
(3)
OX1A
22 D
H10
(Bank 2 Sensor 2)
(3)
LB
O2B
31 C
OX2B
29 D
HT2B
33 D
E5
I 3 : LHD
I 4 : RHD
BR
I3
BR
BR
BW
(3)
D A
D A
D A
E 3 : LHD
I 3 : RHD
J12(A), J13(B)
Junction Connector
BR
BW
BR
E B
WB
BR
(RHD)
WB
(RHD)
141
AVENSIS (EWD526E)
http://vnx.su

GRR
7. 5A OBD2
BR
D5
DLC3
7 DA
WL
J20(C), J21(D)
Junction Connector
WG
16
9 DB
17 DB
30 DA
3 DC
WL
18 A
20 A
WFSE
SIL
TC
14 IK2
GR
LY
THA
VG
E2G
+B
1
BR
BR
E5
J16
Junction
Connector
E2
E 3 : LHD
I 3 : RHD
BW
BR
BW
A6
Air Flow Meter
E5
EVG
29 E
BW
V6
VSV (Intake Air Control Valve)
WG
VG
30 E
BW
V5
VSV (EVAP)
THA
20 E
WB
SCV
5 E
LB
EVP1
34 E
BR
E 9(A), E10(B), E11(C), E12(D), E13(E)

Engine ECU (M/T)
(LHD)
19 A
TACH
WG
GRR
A B (LHD)
B D (RHD)
5 A
BW
(RHD)
WL
B C
WL
G A
B A (LHD)
G C (RHD)
(LHD)
D D
(RHD)
WL
J 8(A), J26(C)
Junction
Connector
GRR
J 8(A), J 9(B), J26(C), J27(D)

Junction
Connector
GRR
G A
B A (LHD)
G C (RHD)
E A (LHD)
D C (RHD)
E A
D C
(LHD)
WG
13
BAT
BR
WB
(RHD)
EF
142
AVENSIS (EWD526E)
http://vnx.su
IO
CG
WB
15
SG
(LHD)
TC
WB
SIL
(RHD)
WFSE
BR
TAC
System Outline
The engine control system utilizes a microcomputer and maintains overall control of the engine, transaxle etc. An outline of
the engine control is given here.
1. Input Signals
(1) Engine coolant temp. signal circuit
The EFI water temp. sensor detects the engine coolant temp. and has a builtin thermistor with a resistance, which
varies according to the engine coolant temp.. The engine coolant temp. which is input into TERMINAL THW of the
engine and ECT ECU (A/T) or engine ECU (M/T) as a control signal.
(2) Intake air temp. signal circuit
The intake air temp. sensor is installed in the air flow meter and detects the intake air temp. which is input as a control
signal to TERMINAL THA of the engine and ECT ECU (A/T) or engine ECU (M/T).
(3) Oxygen density signal circuit
The oxygen density in the exhaust emission is detected by the heated oxygen sensor and input as a control signal to
TERMINALS OX1A, OX2A, OX1B and OX2B of the engine and ECT ECU (A/T) or engine ECU (M/T).
(4) RPM signal circuit
Camshaft position and crankshaft position are detected by the camshaft position sensor and crankshaft position sensor.
Camshaft position is input as a control signal to TERMINAL G2+ of the engine and ECT ECU (A/T) or engine ECU
(M/T), and engine RPM is input into TERMINAL NE+.
(5) Throttle position signal circuit
The accelerator pedal position sensor detects the accelerator pedal opening angle, which is input as a control signal to
TERMINALS VPA and VPA2 of the engine and ECT ECU (A/T) or engine ECU (M/T).
(6) Vehicle speed circuit
The speed sensor detects the vehicle speed and inputs a control signal to TERMINAL SPD of the engine and ECT ECU
(A/T) or engine ECU (M/T).
(7) Battery signal circuit
Voltage is constantly applied to TERMINAL BATT of the engine and ECT ECU (A/T) or engine ECU (M/T). With the
ignition SW turned on, the voltage for engine and ECT ECU (A/T) or engine ECU (M/T) startup power supply is applied
to TERMINALS +B and +B2 of the engine and ECT ECU (A/T) or engine ECU (M/T) via the EFI relay.
(8) Stop light SW signal circuit
The stop light SW is used to detect whether the vehicle is braking or not and the signal is input into TERMINAL STP of
the engine and ECT ECU (A/T) or engine ECU (M/T) as a control signal.
(9) Starter signal circuit
To confirm whether the engine is cranking, the voltage is applied to the starter motor during cranking is detected and the
signal is input into TERMINAL STA of the engine and ECT ECU (A/T) or engine ECU (M/T) as a control signal.
(10) Engine knock signal circuit
Engine knocking is detected by knock sensor and the signal is input into TERMINAL KNK1 as a control signal.
143
AVENSIS (EWD526E)
http://vnx.su

2. Control System
ESA system
The ESA system monitors the engine condition through the signals input to the engine and ECT ECU (A/T) or engine
ECU (M/T) from each sensor. The best ignition timing is decided according to this data and the memorized data in the
engine and ECT ECU (A/T) or engine ECU (M/T) and the control signal is output to TERMINALS IGT1, IGT2, IGT3,
IGT4. This signal controls the igniter to provide the best ignition timing for the driving conditions.
Heated oxygen sensor heater control system
The heated oxygen sensor heater control system turns the heater on when the intake air volume is low (Temp. of
exhaust emissions is low), and warms up the heated oxygen sensor to improve detection performance of the sensor.
The engine and ECT ECU (A/T) or engine ECU (M/T) evaluates the signals from each sensor, and outputs current to
TERMINALS HT1A, HT2A, HT1B and HT2B to control the heater.
Fuel pump control system
The engine and ECT ECU (A/T) or engine ECU (M/T) operation outputs to TERMINAL FC and controls the circuit
opening relay. Thus controls the fuel pump drive speed in response to conditions.
VVTi system
The system controls the position of the spool valve of the oil control valve according to the signals from the engine and
ECT ECU (A/T) or engine ECU (M/T). In this manner, the hydraulic pressure to the advance side vane chamber and the
retard side vane chamber of the VVT is controlled to vary the intake camshaft phase continuously.
3. Diagnosis System
With the diagnosis system, when there is a malfunction in the engine and ECT ECU (A/T) or engine ECU (M/T) signal
system, the malfunctioning system is recorded in the memory. The malfunctioning system can be found by reading the code
displayed by the malfunction indicator lamp.
4. FailSafe System
When a malfunction has occurred in any system, if there is a possibility of engine trouble being caused by continued control
based on the signals from that system, the failsafe system either controls the system by using data (Standard values)
recorded in the engine and ECT ECU (A/T) or engine ECU (M/T) memory or else stops the engine.
Service Hints
E9 (A), E10 (B), E11 (C), E12 (D), E13 (E) Engine and ECT ECU (A/T) or Engine ECU (M/T)
BATTE1 : Always 9.014.0 volts
VCE2 : 4.55.5 volts (Ignition SW at ON position)
VTA1E2 : 0.31.0 volts (Ignition SW on and throttle valve fully closed)
3.24.9 volts (Ignition SW on and throttle valve fully open)
VGEVG : 1.11.5 volts (Engine idling and A/C SW off)
THAE2 : 0.53.4 volts (Engine idling and intake air temp. 20C, 68F)
THWE2 : 0.21.0 volts (Engine idling and coolant temp. 80C, 176F)
IGF1E1 : 4.55.5 volts (Ignition SW at ON position)
Pulse generation (Engine idling)
SILE1 : Pulse generation (During transmission)
TACHE1 : Pulse generation (Engine idling)
STAE1 : 6.0 volts or more (Engine cranking)
FCE01 : 9.014.0 volts (Ignition SW at ON position)
SPDE1 : Pulse generation (Ignition SW on and rotate driving wheel slowly)
WE01 : Below 3.0 volts (Ignition SW at ON position)
EVP1E01 : 9.014.0 volts (Ignition SW at ON position)
STPE1 : 7.514.0 volts (Ignition SW on and brake pedal depressed)
Below 1.5 volts (Ignition SW on and brake pedal released)
KNK1E1 : Pulse generation (Engine idling)
PSWE1 : 9.014.0 volts (Ignition SW at ON position)
IGSWE1 : 9.014.0 volts (Ignition SW at ON position)
MRELE1 : 9.014.0 volts (Ignition SW at ON position)
G2+, NE+ NE : Pulse generation (Engine idling)
OC1+ OC1 : Pulse generation (Ignition SW at ON position)
IGT1, IGT2, IGT3, IGT4E1 : Pulse generation (Engine idling)
#1, #2, #3, #4E01 : 9.014.0 volts (Ignition SW at ON position)
VPAEPA : 0.61.0 volts (Ignition SW on accelerator pedal fully closed)
VPA2EPA2 : 1.41.8 volts (Ignition SW on accelerator pedal fully closed)
144
AVENSIS (EWD526E)
http://vnx.su
: Parts Location
Code
See Page
38 (*3)
A6
58 (*7)
38 (*3)
A11
E9
E10
E11
E12
48 (LHD)
J16
68 (RHD)
J19
68 (RHD)
68 (RHD)
74 (RHD W/G)
J26
68 (RHD)
58 (*7)
38 (*3)
J27
68 (RHD)
58 (*7)
J28
68 (RHD)
H7
H8
59 (*7)
39 (*3)
59 (*7)
39 (*3)
59 (*7)
39 (*3)
I6
38 (*3)
58 (*7)
59 (*7)
39 (*3)
I7
38 (*3)
58 (*7)
59 (*7)
39 (*3)
I8
47 (LHD)
67 (RHD)
59 (*7)
47 (LHD)
I14
47 (LHD)
75 (RHD W/G)
39 (*3)
I5
71 (RHD S/D)
73 (RHD L/B)
59 (*7)
I4
55 (LHD W/G)
58 (*7)
39 (*3)
I3
J30
38 (*3)
59 (*7)
I2
58 (*7)
53 (LHD L/B)
39 (*3)
I1
38 (*3)
51 (LHD S/D)
58 (*7)
58 (*7)
H10
67 (RHD)
38 (*3)
38 (*3)
H9
47 (LHD)
48 (LHD)
38 (*3)
66 (RHD)
68 (RHD)
68 (RHD)
46 (LHD)
66 (RHD)
J14
48 (LHD)
J21
46 (LHD)
72 (RHD L/B)
66 (RHD)
J13
68 (RHD)
66 (RHD)
46 (LHD)
E2
66 (RHD)
D5
J12
J20
46 (LHD)
See Page
48 (LHD)
70 (RHD S/D)
58 (*7)
Code
54 (LHD W/G)
F25
38 (*3)
C9
E5
52 (LHD L/B)
58 (*7)
C8
58 (*7)
46 (LHD)
38 (*3)
C6
67 (RHD)
50 (LHD S/D)
58 (*7)
C2
47 (LHD)
66 (RHD)
38 (*3)
C1
67 (RHD)
38 (*3)
F16
46 (LHD)
B2
E4
66 (RHD)
A27
C11
E13
46 (LHD)
A20
See Page
D
58 (*7)
A15
C10
Code
E12
67 (RHD)
67 (RHD)
J8
48 (LHD)
47 (LHD)
J9
48 (LHD)
67 (RHD)
J10
48 (LHD)
47 (LHD)
J11
48 (LHD)
K1
N1
P2
S1
S3
S13
T1
T8
V1
V5
V6
39 (*3)
59 (*7)
39 (*3)
59 (*7)
39 (*3)
59 (*7)
39 (*3)
59 (*7)
39 (*3)
59 (*7)
49 (LHD)
69 (RHD)
39 (*3)
59 (*7)
49 (LHD)
69 (RHD)
39 (*3)
59 (*7)
39 (*3)
59 (*7)
39 (*3)
59 (*7)
: Relay Blocks
Code
See Page
24 (*1)
27
29
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
145
AVENSIS (EWD526E)
http://vnx.su

Code
1A
4A
4B
See Page
24 (*1)
27
CA
CB
CD
34
CE
CK
35
DA
DB
30
DL
31
DM
31
Floor Wire and Driver Side J/B (Left Side of the Instrument Panel)
DC
DD

Code
EA1
IB1
IC1
IC2
IC3
IE1
IE2
See Page
78 (*3)
98 (*7)
86 (LHD)
106 (RHD)

86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
88 (LHD)
IE3
IE4
IE8
IG2
IK2
88 (LHD)
108 (RHD)
IO1
108 (RHD)
IP1
108 (RHD)
IR1
108 (RHD)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
146
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
: Ground Points
Code
EC
EE
EF
IO
IP
See Page
78 (*3)
98 (*7)
78 (*3)
98 (*7)
78 (*3)
98 (*7)
86 (LHD)
86 (LHD)
106 (RHD)

Intake Side of Cylinder Block
Instrument Panel Reinforcement RH
Right Kick Panel
90 (LHD S/D)
92 (LHD L/B)
BR
94 (LHD W/G)
110 (RHD S/D)
112 (RHD L/B)

114 (RHD W/G)
: Splice Points
Code
E2
See Page
78 (*3)
98 (*7)
E3
78 (*3)
E4
98 (*7)
E5
E6
78 (*3)
98 (*7)
78 (*3)
98 (*7)

Engine Room Main Wire
Code
E7
E8
Engine Wire
I3
I4
I5
See Page
78 (*3)
98 (*7)
78 (*3)
98 (*7)
Engine Wire
108 (RHD)
88 (LHD)
108 (RHD)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
147
AVENSIS (EWD526E)
http://vnx.su
Engine Control (1AZFE)

BW
10A IGN
RB
BY
BW
1 : Unleaded Gasoline
BW
IG2 Relay
BW
BY
(1)
GR
BY
BR
BW
WB
(1)
1
C8
Circuit Opening
Relay
GR
BW
(1)
BR
10 IB1
4
BW
1
4
(1)
(1)
WB
WB
BW
1 1A
BG
6 IC3
10A EFI NO. 1
BR
13 EA1
12 EA1
2 EA1 1 EA1
GY
BR
WB
BW
E2
(1)
W
FL MAIN
3. 0W
(1)
BG
1 4B
F25
Fuel Pump
BW
1 4A
WB
7. 5A EFI NO. 2
3
1
GY
LB
A/F Relay
20A EFI
20A A/F
2
EFI Relay
2
15A IG2
GY
18 DA
RB
16 DL
BR
GR
BR
BW
WB
W(1)
W(1)
WB
Battery
EC
148
AVENSIS (EWD526E)
http://vnx.su
BR
GRR
BW
BW
RB
RB
BY
BY
GR
GR
RW(M/T)

P
1
BW
10 IC1
10A
GAUGE1
11
7 DB
MPX1
RW
(M/T)
RW
6
MPX2
I14
Integration Relay
7. 5A
DOME
22
PB
GRR
PB
BW
21 B
3 B
14 A
22 B
Tachometer
Speedometer
20 B
1 IC1
BEAN
I/F
Check
Engine
Temp.
WR
6 CD
RW
WR
H B
8 CE
(RHD)
F A (LHD)
F C
F C (RHD)
(LHD)
J10(A), J11(B), J26(C)

Junction
Connector
WR
7 CA
C10(A), C11(B)
Combination Meter
13 A
9 B
18 B
LW
5 B
VW
19 B
WB
16 IE1
LW
CPU
6 CK
23
SP1
S2
Skid Control ECU
with Actuator
P
6 CA
3 CB
VW
GY
BR
BR
BW
BW
W(1)
W(1)
W(1)
W(1)
WB
GY
WB
WB
(RHD)
(RHD)
IP
149
AVENSIS (EWD526E)
http://vnx.su

GRR
GRR
BW
RB
BY
GR
RW(M/T)
RW
(M/T)
RB
BW
BW
(RHD)
BW
(LHD)
E D
C A (LHD)
A C (RHD)
C A
A C
J 8(A), J26(C),
J27(D)
Junction
Connector
I8
Injector No. 4
RB
I7
Injector No. 3
RB
I6
Injector No. 2
RB
I5
Injector No. 1
BY
BATT
C A
GR
3 A
MREL
E4
BR
PB
8 A
MPX2
RB
29 A
E4
BW
BW
RB
7 IE3 (LHD)
7 IO1 (RHD)
2 IE1
RB
RB
BY
MPX+
E4
GR
MPX
A13
29
8 EA1
1 D
2 D
3 D
4 D
#1
#2
#3
#4
9 A
IGSW
E 9(A), E10(B), E12(C), E13(D)

Engine ECU (M/T)
H A (LHD)
H C (RHD)
1
DUTY
E 3 : LHD
I 3 : RHD
GY
BR
BR
VW
+B
WB
BR
VW
GND
BR
RSD
10 C
BR
I10
ISC Valve
1
8 IK1
BR
J10(A), J20(C)
Junction Connector
H A (LHD)
H C (RHD)
E1
7 C
GR
23 D
P2
Power Steering
Oil Pressure SW
GY
PSW
+B
1 A
10 A
VW
FC
17 B
BR
SPD
MPX1
23 A
W
11 A
E 3 : LHD
I 3 : RHD
BR
BW
BW
W(1)
W(1)
W(1)
W(1)
WB
WB(RHD)
(RHD)
BR
EF
150
AVENSIS (EWD526E)
http://vnx.su
GRR
GRR
3 : Leaded Gasoline
7. 5A
ST
10A
TAIL
RW
(M/T)
2
4 DM
BW
G
15 IE2
J30
Junction
Connector
3 IC2
(M/T)
B A
C A (LHD)
C C (RHD)
BY
BW
C B (LHD)
C D (RHD)
10 B
BY
N1
Neutral
Start SW
(M/T)
LGB
A A
(M/T)
J10(A), J11(B),
J26(C), J27(D)
Junction Connector
J14
Junction
Connector
RW
(M/T)
9 IE2
A A
BY
(A/T)
LGB
J12(A), J13(B)
Junction Connector
B B
(A/T)
C9
Clutch Start SW
RW
(M/T)
(M/T)
LGB
12 A
9 C
ELS
CLSW
STA
E 9(A), E10(B), E12(C), E13(D)

Engine ECU (M/T)
PRG
VG
24 C
EVG
32 C
THA
E2
THW
20 D
19 D
28 D
VTA1
VC
21 D
E2
5
W(1)
BR
(1)
E 3 : LHD
I 3 : RHD
(3)
(3)
3 EA1
(3)
9 EA1
VCC
VAF
E2
T2
Throttle Position
Sensor
BR
BR
BR
BR
BW
E 3 : LHD
I 3 : RHD
BW
VC
E2
2
BR
VTA
(3)
RW
RW
LW
RW
V3
Variable Resistor
+B
E4
BR
THA
E3
32 D
(3)
E2G
E2
VG
A6
Air Flow Meter
V5
VSV (EVAP)
1
BR
BW
GR
LY
WG
BW
VAF
18 D
RW
12 D
10 EA1
BR
(3)
BW(1)
W(1)
W(1)
WB(RHD)
W(1)
BR
WB(RHD)
BR
151
AVENSIS (EWD526E)
http://vnx.su

GRR
GRR
2 : Shielded
4 : w/ Engine Immobiliser System
15A
STOP
A27
(RHD)
LGB
9 DD
10 DC
11 DA
S13
Stop Light SW
2 DA
FAN NO. 1 Relay

FAN NO. 2 Relay
Diode (Fan)
GW
GW
GW
23
1 IR1
(LHD)
A11
Alternator
GSW2
(RHD)
GW
(LHD)
(LHD)
RW
RW
RW
6 IE3
11 IE3
(RHD)
2 IR1
(LHD)
RW
(RHD)
22 DA
9 IK1
GW
LGB
19 B
14 A
7 A
28 B
STP
F/PS
RL
FAN
E 9(A), E10(B), E12(C), E13(D)

Engine ECU (M/T)
HA1A
6 C
A1A+
23 C
A1A
HA2A
31 C
5 C
A2A+
22 C
A2A
HT1B
30 C
OX1B
21 C
4 B
O1B
OX2B
32 D
29 C
O2B
HT2B
31 D
3 B
HT
1
BR
(1)
+B
2
BW(1)
D A
(1)
10 IK1
+B
(1)
E1
LR
OX
LR
(1)
(1)
(2)
(2)
HT
(1)
E1
H10
(Bank 2 Sensor 2)
BW
+B
2
I4
(1)
OX
L
HT
1
(1)
4 IK1
(1)
(2)
AF
BW
+B
2
AF+
HT
1
(1)
AF
A8
Air Fuel Ratio Sensor
(Bank 2 Sensor 1)
AF+
(2)
H8
BR (Bank 1 Sensor 2)
(1)
(1)
(1)
(1)
(1)
(1)
(1)
A7
(Bank 1 Sensor 1)
(1)
(1)
I4
E3
D A
J12(A), J13(B)
Junction Connector
BW(1)
W(1)
W(1)
WB(RHD)
WB(RHD)
BR
BR
152
AVENSIS (EWD526E)
http://vnx.su
GRR
GRR
IGT
IGF
IGT
IGF
IGT
WR
WR
E4
WR
GR
WR
E4
(4)
(4)
(1)
YB
(1)
WG
E4
RW
IGF
2
IGT
3
WR
EFIO
IGF
2
LGB
EFII
7
I1
Ignition Coil and
Igniter No. 1
WR
C2
Camshaft Timing
Oil Control Valve
I2
Ignition Coil and
Igniter No. 2
LY
T8
I3
Ignition Coil and
Igniter No. 3
WR
I4
Ignition Coil and
Igniter No. 4
15 D
14 D
OC1+
26 B
OC1
13 D
27 B
IMO
IMI
11 D
IGF1
10 D
IGT4
9 D
IGT3
8 D
IGT2
IGT1
E 9(A), E10(B), E12(C), E13(D)

Engine ECU (M/T)
G2+
NE
NE+
34 D
EOM
27 D
15 A
26 D
BR
EKNK
2 C
KNK1
1 C
(2)
(2)
(2)
I5
2
1
C6
Crankshaft
Position Sensor
K1
Knock Sensor
C1
Camshaft
Position Sensor
J12(A), J13(B)
Junction Connector
(2)
D A
(2)
(2)
E A
E A
BR
E A
BR
WB
(RHD)
E B
E B
D B
D B
BR
BR
BR
WB(RHD)
BR
153
AVENSIS (EWD526E)
http://vnx.su

GRR
7. 5A OBD2
D5
DLC3
TAC
WFSE
SIL
15
WL
BAT
16
WL
WG
WB
(LHD)
WB
(RHD)
BR
WL
(RHD)
(LHD)
E A (LHD)
D C (RHD)
J 8(A), J 9(B),
J26(C), J27(D)
Junction
Connector
CG
4
(LHD)
WG
J 8(A), J26(C)
Junction
Connector
G A
B A (LHD)
G C (RHD)
E A
D C
SG
5
G A
B A (LHD)
G C (RHD)
GRR
GRR
TC
13
9 DB
17 DB
30 DA
3 DC
19 A
TACH
WFSE
WL
5 A
WG
GRR
A B (LHD)
B D (RHD)
18 A
20 A
SIL
TC
E 9(A), E10(B), E12(C), E13(D)

Engine ECU (M/T)
E04
4 C
E01
7 D
E02
6 D
E05
3 C
J16
Junction
Connector
(1)
WB
WB
WB
(1)
WB
BR
WB
EE
(LHD)
WB
(RHD)
IO
154
AVENSIS (EWD526E)
http://vnx.su
7 DA
System Outline
The engine control system utilizes a microcomputer and maintains overall control of the engine, transaxle etc. An outline of
the engine control is given here.
1. Input Signals
(1) Engine coolant temp. signal circuit
The EFI water temp. sensor detects the engine coolant temp. and has a builtin thermistor with a resistance, which
varies according to the engine coolant temp.. The engine coolant temp. which is input into TERMINAL THW of the
engine and ECT ECU (A/T) or engine ECU (M/T) as a control signal.
The intake air temp. sensor is installed in the air flow meter and detects the intake air temp. which is input as a control
signal to TERMINAL THA of the engine and ECT ECU (A/T) or engine ECU (M/T).
(3) Oxygen density signal circuit (Unleaded gasoline)
The oxygen density in the exhaust emission is detected by the heated oxygen sensor and input as a control signal to
TERMINALS OX1B and OX2B of the engine and ECT ECU (A/T) or engine ECU (M/T).
Camshaft position is input as a control signal to TERMINAL G2+ of the engine and ECT ECU (A/T) or engine ECU
(M/T), and engine RPM is input into TERMINAL NE+.
(5) Throttle position signal circuit
The throttle position sensor detects the throttle valve opening angle as a control signal, which is input into TERMINAL
VTA1 of the engine and ECT ECU (A/T) or engine ECU (M/T).
(6) Vehicle speed circuit
The speed sensor detects the vehicle speed and inputs a control signal to TERMINAL SPD of the engine and ECT ECU
Voltage is constantly applied to TERMINAL BATT of the engine and ECT ECU (A/T) or engine ECU (M/T). With the
ignition SW turned on, the voltage for engine and ECT ECU (A/T) or engine ECU (M/T) startup power supply is applied
to TERMINAL +B of the engine and ECT ECU (A/T) or engine ECU (M/T) via the EFI relay.
the engine and ECT ECU (A/T) or engine ECU (M/T) as a control signal.
(9) Starter signal circuit
To confirm whether the engine is cranking, the voltage is applied to the starter motor during cranking is detected and the
Engine knocking is detected by knock sensor and the signal is input into TERMINAL KNK1 as a control signal.
(11) Air fuel ratio signal system (Unleaded gasoline)
The air fuel ratio is detected and input as a control signal into TERMINALS A1A+ and A2A+ of the engine and ECT ECU
155
AVENSIS (EWD526E)
http://vnx.su

2. Control System
EFI system
The EFI system monitors the engine condition through the signals input from each sensor to the engine and ECT ECU
(A/T) or engine ECU (M/T). And the control signal is output to TERMINALS #1, #2, #3, #4 of the engine and ECT ECU
(A/T) or engine ECU (M/T) to operate the injector (Inject the fuel). The EFI system controls the fuel injection operation by
the engine and ECT ECU (A/T) or engine ECU (M/T) in response to the driving conditions.
ESA system
The ESA system monitors the engine condition through the signals input to the engine and ECT ECU (A/T) or engine
ECU (M/T) from each sensor. The best ignition timing is decided according to this data and the memorized data in the
engine and ECT ECU (A/T) or engine ECU (M/T) and the control signal is output to TERMINALS IGT1, IGT2, IGT3,
IGT4. This signal controls the igniter to provide the best ignition timing for the driving conditions.
Heated oxygen sensor heater control system (Unleaded gasoline)
exhaust emissions is low), and warms up the heated oxygen sensor to improve detection performance of the sensor.
TERMINALS HT1B and HT2B to control the heater.
ISC system
The ISC system (Rotary solenoid type) increases the RPM and provides idling stability for fast idleup when the engine
is cold and when the idle speed has dropped due to electrical load, etc. The engine and ECT ECU (A/T) or engine ECU
(M/T) evaluates the signals from each sensor, outputs current to TERMINAL RSD, and controls the ISC valve.
VVTi system
3. Diagnosis System
With the diagnosis system, when there is a malfunction in the engine and ECT ECU (A/T) or engine ECU (M/T) signal
system, the malfunctioning system is recorded in the memory. The malfunctioning system can be found by reading the code
displayed by the malfunction indicator lamp.
4. FailSafe System
When a malfunction has occurred in any system, if there is a possibility of engine trouble being caused by continued control
based on the signals from that system, the failsafe system either controls the system by using data (Standard values)
recorded in the engine and ECT ECU (A/T) or engine ECU (M/T) memory or else stops the engine.
156
AVENSIS (EWD526E)
http://vnx.su
Service Hints
E9 (A), E10 (B), E12 (C), E13 (D) Engine and ECT ECU (A/T) or Engine ECU (M/T)
VCE2 : 4.55.5 volts (Ignition SW at ON position)
VTA1E2 : 0.31.0 volts (Ignition SW on and throttle valve fully closed)
3.24.9 volts (Ignition SW on and throttle valve fully open)
VGEVG : 1.11.5 volts (Engine idling and A/C SW off)
THAE2 : 0.53.4 volts (Engine idling and intake air temp. 20C, 68F)
THWE2 : 0.21.0 volts (Engine idling and coolant temp. 80C, 176F)
IGF1E1 : 4.55.5 volts (Ignition SW at ON position)
SILE1 : Pulse generation (During transmission)
FCE01 : 9.014.0 volts (Ignition SW at ON position)
SPDE1 : Pulse generation (Ignition SW on and rotate driving wheel slowly)
PRGE01 : 9.014.0 volts (Ignition SW at ON position)
Below 1.5 volts (Ignition SW on and brake pedal released)
KNK1E1 : Pulse generation (Engine idling)
PSWE1 : 9.014.0 volts (Ignition SW at ON position)
HA1AE04 : Below 3.0 volts (Engine idling)
IGSWE1 : 9.014.0 volts (Ignition SW at ON position)
G2+, NE+ NE : Pulse generation (Engine idling)
OC1+ OC1 : Pulse generation (Ignition SW at ON position)
HT1BE1 : 9.014.0 volts (Engine idling)
Below 3.0 volts (Ignition SW at ON position)
A1A+ E1 : 3.3 volts (Ignition SW at ON position)
A1A E1 : 3.0 volts (Ignition SW at ON position)
OX1BE1 : Pulse generation (Maintain engine speed at 2500 rpm for 90 sec. after warming up)
IGT1, IGT2, IGT3, IGT4E1 : Pulse generation (Engine idling)
#1, #2, #3, #4E01 : 9.014.0 volts (Ignition SW at ON position)
157
AVENSIS (EWD526E)
http://vnx.su

: Parts Location
Code
See Page
40 (*4)
A6
60 (*8)
A7
40 (*4)
A8
40 (*4)
J20
68 (RHD)
J26
68 (RHD)
61 (*8)
J27
68 (RHD)
I1
61 (*8)
41 (*4)
61 (*8)
41 (*4)
I6
46 (LHD)
66 (RHD)
61 (*8)
41 (*4)
I7
46 (LHD)
66 (RHD)
61 (*8)
41 (*4)
I8
61 (*8)
41 (*4)
I10
60 (*8)
41 (*4)
I5
40 (*4)
E12
61 (*8)
61 (*8)
47 (LHD)
I14
47 (LHD)
67 (RHD)
67 (RHD)
J8
48 (LHD)
47 (LHD)
J9
48 (LHD)
67 (RHD)
J10
48 (LHD)
47 (LHD)
J11
48 (LHD)
68 (RHD)
51 (LHD S/D)
J30
41 (*4)
I4
67 (RHD)
61 (*8)
I3
47 (LHD)
E10
41 (*4)
I2
66 (RHD)
48 (LHD)
J16
41 (*4)
46 (LHD)
E2
48 (LHD)
40 (*4)
66 (RHD)
D5
68 (RHD)
H10
46 (LHD)
J14
48 (LHD)
66 (RHD)
60 (*8)
40 (*4)
40 (*4)
C9
J13
68 (RHD)
H8
40 (*4)
C8
48 (LHD)
46 (LHD)
60 (*8)
C6
67 (RHD)
See Page
J12
70 (RHD S/D)
40 (*4)
C2
47 (LHD)
Code
54 (LHD W/G)
F25
66 (RHD)
C1
67 (RHD)
50 (LHD S/D)
46 (LHD)
A27
E9
E13
60 (*8)
A13
C11
See Page
C
40 (*4)
A11
C10
Code
E12
55 (LHD W/G)
71 (RHD S/D)
K1
N1
P2
S2
S13
T2
T8
V3
V5
41 (*4)
61 (*8)
41 (*4)
61 (*8)
41 (*4)
61 (*8)
41 (*4)
61 (*8)
49 (LHD)
69 (RHD)
41 (*4)
61 (*8)
49 (LHD)
69 (RHD)
41 (*4)
61 (*8)
41 (*4)
61 (*8)
: Relay Blocks
Code
See Page
24 (*1)
27
29
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
158
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV

Code
1A
4A
4B
See Page
24 (*1)
27
CA
CB
CD
34
CE
CK
35
DA
DB
30
DL
31
DM
31
DC
DD

Code
EA1
IB1
IC1
IC2
IC3
See Page
80 (*4)
100 (*8)
86 (LHD)
106 (RHD)

86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
IE2
106 (RHD)
IE3
86 (LHD)
IE1
IK1
88 (LHD)
108 (RHD)
IO1
108 (RHD)
IR1
108 (RHD)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
159
AVENSIS (EWD526E)
http://vnx.su

: Ground Points
Code
EC
EE
EF
IO
IP
See Page
80 (*4)
100 (*8)
80 (*4)
100 (*8)
80 (*4)
100 (*8)
86 (LHD)
86 (LHD)
106 (RHD)

Right Kick Panel
90 (LHD S/D)
BR
94 (LHD W/G)
110 (RHD S/D)
: Splice Points
Code
E2
E3
E4
See Page
80 (*4)
100 (*8)

80 (*4)
100 (*8)
80 (*4)
Engine Wire
Code
See Page
E4
100 (*8)
I3
108 (RHD)
I4
88 (LHD)
I5
Engine Wire
88 (LHD)
108 (RHD)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
160
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
Memo
161
AVENSIS (EWD526E)
http://vnx.su
Engine Control (1ZZFE, 3ZZFE)

BW
10A IGN
RB
BY
18 DA
BW
RB
16 DL
BR
GR
BW
3
IG2
Relay
BW
BW
C8
Circuit
Opening Relay
GR
BY
WB
10 IB1
BW
BY
4
BW
GY
20A EFI
6 IC3
BG
BW
1 1A
WB
LB
10A EFI NO. 1
3
1
7. 5A EFI NO. 2
15A IG2
4
EFI
Relay
GY
BR
12 EA1
BR
1 4B
BG
WB
E2
F25
Fuel Pump
BW
13 EA1
BW
1 4A
M
5
GY
FL MAIN
3. 0W
WB
BR
BW
WB
Battery
EC
162
AVENSIS (EWD526E)
http://vnx.su
BR
GRR
BW
BW
RB
RB
BY
BY
GR
GR
BW
10 IC1
10A
GAUGE1
11
7 DB
MPX1
RW
6
MPX2
I14
Integration Relay
7. 5A
DOME
22
PB
WR
(RHD)
6 CD
F A (LHD)
F C
F C (RHD)
Tachometer
PB
BW
21 B
GRR
20 B
Speedometer
H B
3 B
14 A
22 B
BEAN
I/F
Check
Engine
Temp.
WR
RW
1 IC1
(LHD)
J10(A), J11(B), J26(C)

Junction
Connector
WR
7 CA
13 A
9 B
C10(A), C11(B)
Combination Meter
18 B
LW
LW
16 IE1
5 B
VW
19 B
WB
CPU
6 CK
23
SP1
S2
Skid Control ECU
with Actuator
6 CA
VW
3 CB
GY
BR
BR
BW
BW
WB
GY
WB
WB
(RHD)
(RHD)
IP
163
AVENSIS (EWD526E)
http://vnx.su

GRR
GRR
BW
RB
BY
RB
GR
1 D
2 D
3 D
4 D
# 20
# 30
J 8(A), J26(C), J27(D)

Junction Connector
BW
BW
(RHD)
BW
RB
B
BY
C A (LHD)
A C (RHD)
C A
A C
E D
(LHD)
RB
I8
Injector No. 4
RB
I5
Injector No. 1
# 10
BATT
C A
GR
3 A
MREL
E3
BR
PB
8 A
MPX2
RB
29 A
E3
2
7 IE3 (LHD)
7 IO1 (RHD)
2 IE1
RB
RB
MPX+
9 A (2)
10 B (3)
BY
E3
I7
Injector No. 3
MPX
I6
Injector No. 2
29 A (2)
20 B (3)
BW
RB
8 EA1
GR
A13(A), A15(B)
BW
9 A
# 40
IGSW
SPD
1 A
J10(A), J20(C)
Junction Connector
BR
GND
VISC
I10
ISC Valve
H A (LHD)
H C (RHD)
BR
DUTY
VW
8 IK1
WB
H A (LHD)
H C (RHD)
RSO
5 D
GR
+B
10 A
GY
23 A
BR
FC
17 B
MPX1
11 A
VW
E 9(A), E10(B), E12(C), E13(D)

Engine ECU (M/T)
VW
GY
BR
BR
I3
BR
I3
BR
BW
BW
WB
WB(RHD)
(RHD)
WB
164
AVENSIS (EWD526E)
http://vnx.su
GRR
GRR
1 : Shielded
3 : Automatic A/C
10A
TAIL
7. 5A
ST
2
4 DM
26 B
OCV
IMO
BW
G
G
(M/T)
BY
C B (LHD)
C D (RHD)
(A/T)
C A (LHD)
C C (RHD)
27 B
A A
P
BY
YB
14 D
OCV+
A A
BY
WG
15 D
B A
BW
(A/T)
3 IC2
N1
Neutral
Start SW
EFIO
EFII
J12(A), J13(B)
Junction Connector
B B
J10(A), J11(B), J26(C), J27(D)

Junction Connector
T8
GR
J30
Junction Connector
C2
13 A
IMI
9 C
STA
ELS2
E 9(A), E10(B), E12(C), E13(D)

Engine ECU (M/T)
THW
VTA
VC
HT1A
OX1A
18 D
21 D
4 C
23 C
E2
28 D
I3
+B
2
T2
Throttle
Position Sensor
E1
BR
I3
BR
I3
BR
BW
OX
BR
BR
A6
Air Flow Meter
E2
5
BR
+B
1
BR
V5
VSV (EVAP)
BW
HT
BR
I3
(1)
THA
H7
(Bank 1 Sensor 1)
BW
E2G
BR
GR
VG
BW
LY
E2
WG
19 D
THA
20 D
LW
EVG
32 C
RW
VG
24 C
BR
EVP1
12 D
BW
BW
I3
I3
BR
BW
(1)
WB(RHD)
WB
WB(RHD)
WB
165
AVENSIS (EWD526E)
http://vnx.su

GRR
GRR
1 : Shielded
15A
STOP
A27
GW
(RHD)
GW
(LHD)
RW
(LHD)
RW
(RHD)
22 DA
GSW2
23
6 IE3
11 IE3
1 IR1
2 DA
9 DD
10 DC
11 DA
FAN NO. 2 Relay

Diode (Fan)
GW
(RHD)
GW
(LHD)
RW
(LHD)
RW
(RHD)
LGB
2 IR1
S13
Stop
Light SW
GW
LGB
19 B
14 A
7 A
STP
F/PS
FAN
E 9(A), E10(B), E12(C), E13(D)

Engine ECU (M/T)
IGT1
IGT3
IGT2
9 D
IGT4
10 D
11 D
IGF
23 D
HT1B
4 B
OX1B
21 C
WR
IGF
IGT
IGF
IGT
IGF
IGT
IGF
HT
I1
Ignition Coil
and Igniter No. 1
BR
BW
I2
Ignition Coil
and Igniter No. 2
18
IK2
BR
10
IK1
BW
I3
Ignition Coil
and Igniter No. 3
3
IH2
BR
1
IH2
BW
I4
Ignition Coil
and Igniter No. 4
E1
4
OX
+B
(1)
4 IH2
H17
(Bank 1 Sensor 2)
IGT
2 IH2
WR
WR
I3
WR
I3
(1)
7 IK2
WR
WR
WR
I3
LY
LGB
RW
8 D
2
(1)
(1)
(1)
(1)
WB(RHD)
WB(RHD)
WB
WB
166
AVENSIS (EWD526E)
http://vnx.su
GRR
GRR
(1)
C6
Crankshaft
Position Sensor
A11
Alternator
E15
EPS ECU
IDUP
TACH
12
GR
GRR
C1
Camshaft
Position Sensor
(1)
9 IK1
6 IK2
(1)
(1)
GR
26 D
27 A
29 C
G2
RL
I5
27 D
34 D
NE+
NE
GRR
EMPS
E 9(A), E10(B), E12(C), E13(D)

Engine ECU (M/T)
FKN
2 C
FKN+
1 C
(1)
(1)
(1)
(1)
BR
(1)
(1)
B
2 EB1
(1)
W
1 EB1
(1)
D A
D A
D A
E A
E A
E A
J12(A), J13(B)
Junction
Connector
E B
D B
D B
BR
BR
(1)
K1
Knock Sensor
1
WB
(1)
(RHD)
(1)
WB
(1)
BR
WB(RHD)
WB
167
AVENSIS (EWD526E)
http://vnx.su

GRR
1 : Shielded
7. 5A OBD2
(1)
(1)
D5
DLC3
7 DA
TC
19 A
TACH
WFSE
WL
WL
(LHD)
17 DB
30 DA
3 DC
18 A
20 A
SIL
B
WB
(LHD)
WB
(RHD)
BR
14 IK2
7 D
6 D
WB
WB
E02
7 C
BR
E01
5 C
WB
E1
BAT
16
TC
E 9(A), E10(B), E12(C), E13(D)

Engine ECU (M/T)
E03
CG
4
BR
5 A
9 DB
WL
GRR
GRR
B C
WG
A B (LHD)
B D (RHD)
G A
B A (LHD)
G C (RHD)
WG
A B
B D
E A (LHD)
D C (RHD)
D D
J20(C), J21(D)
Junction Connector
WL
WL
J 8(A), J26(C)
Junction
Connector
GRR
J 8(A), J 9(B), J26(C), J27(D)

Junction
Connector
GRR
E A
D C
G A
B A (LHD)
G C (RHD)
SG
5
(RHD)
13
(RHD)
SIL
7
(LHD)
WFSE
15
WG
TAC
9
(1)
(1)
J16
Junction
Connector
A
WB
BR
WB
(LHD)
WB
(RHD)
BR
EH
EG
168
AVENSIS (EWD526E)
http://vnx.su
IO
System Outline
This system utilizes an engine and ECT ECU (A/T) or engine ECU (M/T) and maintains overall control of the engine,
transaxle and so on. An outline of the engine control is explained here.
1. Input Signals
(1) Water temp. signal circuit
The EFI water temp. sensor detects the engine coolant temp. and has a builtin thermistor with a resistance which
varies according to the engine coolant temp. Thus the engine coolant temp. is input in the form of a control signal into
TERMINAL THW of the engine and ECT ECU (A/T) or engine ECU (M/T).
The intake air temp. sensor is installed in the air flow meter and detects the intake air temp., which is input as a control
signal into TERMINAL THA of the engine and ECT ECU (A/T) or engine ECU (M/T).
(3) Oxygen sensor signal circuit
The oxygen density in the exhaust emission is detected by the heated oxygen sensors and input as a control signal to
TERMINALS OX1A and OX1B of the engine and ECT ECU (A/T) or engine ECU (M/T).
Camshaft position and crankshaft position air detected by the camshaft position sensor and crankshaft position sensor.
Camshaft position is input as a control signal to TERMINAL G2 of the engine and ECT ECU (A/T) or engine ECU (M/T),
and engine RPM is input into TERMINAL NE+.
(5) Throttle signal circuit
The throttle position sensor detects the throttle valve opening angle, which is input as a control signal into TERMINAL
VTA of the engine and ECT ECU (A/T) or engine ECU (M/T).
(6) Vehicle speed signal circuit
The speed sensor, detects the vehicle speed and inputs a control signal to TERMINAL SPD of the engine and ECT ECU
Voltage is constantly applied to TERMINAL BATT of the engine and ECT ECU (A/T) or engine ECU (M/T). When the
ignition SW is turned on, the voltage for engine and ECT ECU (A/T) or engine ECU (M/T) startup power supply is
applied to TERMINAL +B of engine and ECT ECU (A/T) or engine ECU (M/T) via EFI relay.
(8) Started signal circuit
To confirm whether the engine is cranking, the voltage applied to the starter motor during cranking is detected and the
Engine knocking is detected by knock sensor and the signal is input into TERMINAL FKN+ as a control signal.
169
AVENSIS (EWD526E)
http://vnx.su

2. Control System
EFI system
The EFI system monitors the engine condition through the signals, which are input from each sensor to the engine and
ECT ECU (A/T) or engine ECU (M/T). The best fuel injection volume is decided based on this data and the program
memorized by the engine and ECT ECU (A/T) or engine ECU (M/T), and the control signal is output to TERMINALS #10,
#20, #30 and #40 of the engine and ECT ECU (A/T) or engine ECU (M/T) to operate the injector. (Inject the fuel). The
EFI system produces control of fuel injection operation by the engine and ECT ECU (A/T) or engine ECU (M/T) in
response to the driving conditions.
ESA system
The ESA system monitors the engine condition through the signals, which are input to the engine and ECT ECU (A/T) or
engine ECU (M/T) from each sensor the best ignition timing is detected according to this data and the memorized data
in the engine and ECT ECU (A/T) or engine ECU (M/T), and the control signal is output to TERMINALS IGT1, IGT2,
IGT3 and IGT4. This signal controls the igniter to provide the best ignition timing for the driving conditions.
ISC system
The ISC system (Rotary solenoid type) increases the RPM and provides idling stability for fast idleup when the engine
is cold and when the idle speed has dropped due to electrical load, etc. The engine and ECT ECU (A/T) or engine ECU
(M/T) evaluates the signals from each sensor, outputs current to TERMINAL RSO, and controls the ISC valve.
Heated oxygen sensor heater control system
exhaust emissions is low), and warms up the heated oxygen sensors to improve detection performance of the sensors.
TERMINALS HT1A and HT1B to control the heater
VVTi system
3. Diagnosis System
With the diagnosis system, when there is a malfunctioning in the engine and ECT ECU (A/T) or engine ECU (M/T) signal
system, the malfunction system is recorded in the memory. The malfunctioning system can then be found by reading the
display (Code) of the malfunction indicator lamp.
4. FailSafe System
When a malfunction occurs in any system, if there is a possibility of engine trouble being caused by continued control based
on the signals from that system, the failsafe system either controls the system by using data (Standard values) recorded in
the engine and ECT ECU (A/T) or engine ECU (M/T) memory or else stops the engine.
Service Hints
E9 (A), E12 (C), E13 (D) Engine and ECT ECU (A/T) or Engine ECU (M/T)
BATTE1 : Always approx. 8.014.0 volts
+BE1 : 8.014.0 volts (Ignition SW at ON position)
VCE2 : Always 4.855.15 volts (Ignition SW at ON position)
VTAE2 : 0.31.0 volts (Ignition SW on and accelerator pedal fully closed)
3.04.9 volts (Ignition SW on and accelerator pedal fully open)
THWE2 : 0.21.0 volts (Engine idling and EFI water temp. 80C)
THAE2 : 0.53.4 volts (Engine idling and intake air temp. 20C)
G2NE : Pulse generation (Engine idling)
NE+ NE : Pulse generation (Engine idling)
#10, #20, #30, #40E01 : 914 volts (Ignition SW at ON position)
IGT1, IGT2, IGT3, IGT4E1 : Pulse generation (Engine cranking or idling)
170
AVENSIS (EWD526E)
http://vnx.su
: Parts Location
Code
See Page
A6
A15
A27
C10
C11
E9
E10
68 (RHD)
62 (*9)
J21
68 (RHD)
47 (LHD)
J26
68 (RHD)
67 (RHD)
J27
68 (RHD)
H7
H17
I1
46 (LHD)
47 (LHD)
47 (LHD)
47 (LHD)
43 (*5)
63 (*9)
43 (*5)
63 (*9)
43 (*5)
63 (*9)
47 (LHD)
I14
67 (RHD)
75 (RHD W/G)
63 (*9)
I10
67 (RHD)
71 (RHD S/D)
73 (RHD L/B)
43 (*5)
I8
67 (RHD)
55 (LHD W/G)
63 (*9)
63 (*9)
I7
J30
43 (*5)
43 (*5)
I6
62 (*9)
53 (LHD L/B)
63 (*9)
I5
66 (RHD)
51 (LHD S/D)
43 (*5)
I4
66 (RHD)
68 (RHD)
63 (*9)
63 (*9)
I3
48 (LHD)
J16
43 (*5)
43 (*5)
I2
42 (*5)
E13
68 (RHD)
67 (RHD)
48 (LHD)
J20
47 (LHD)
E12
68 (RHD)
42 (*5)
46 (LHD)
J13
70 (RHD S/D)
48 (LHD)
74 (RHD W/G)
66 (RHD)
46 (LHD)
46 (LHD)
E2
J12
66 (RHD)
62 (*9)
D5
48 (LHD)
72 (RHD L/B)
42 (*5)
46 (LHD)
62 (*9)
J11
54 (LHD W/G)
42 (*5)
C8
67 (RHD)
46 (LHD)
62 (*9)
C6
48 (LHD)
52 (LHD L/B)
42 (*5)
C2
62 (*9)
66 (RHD)
C1
See Page
J10
50 (LHD S/D)
F25
Code
47 (LHD)
42 (*5)
66 (RHD)
See Page
E15
62 (*9)
A11
A13
Code
42 (*5)
67 (RHD)
47 (LHD)
J8
48 (LHD)
67 (RHD)
J9
48 (LHD)
K1
N1
S2
S13
T2
T8
V5
43 (*5)
63 (*9)
43 (*5)
63 (*9)
43 (*5)
63 (*9)
49 (LHD)
69 (RHD)
43 (*5)
63 (*9)
49 (LHD)
69 (RHD)
43 (*5)
63 (*9)
: Relay Blocks
Code
See Page
24 (*1)
27
29
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
171
AVENSIS (EWD526E)
http://vnx.su

Code
1A
4A
4B
See Page
24 (*1)
27
CA
CB
34
CD
CK
35
DA
DB
30
DL
31
DM
31
DC
DD

Code
EA1
EB1
IB1
IC1
IC2
IC3
IE1
IE3
IH2
IK1
IK2
See Page
82 (*5)
102 (*9)
82 (*5)
102 (*9)
86 (LHD)
106 (RHD)

86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
88 (LHD)
106 (RHD)
88 (LHD)
108 (RHD)
88 (LHD)
108 (RHD)
IO1
108 (RHD)
IR1
108 (RHD)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
172
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
: Ground Points
Code
EC
EG
EH
IO
IP
See Page
82 (*5)
102 (*9)

82 (*5)
102 (*9)
82 (*5)
102 (*9)
86 (LHD)
86 (LHD)
106 (RHD)

Right Kick Panel
90 (LHD S/D)
92 (LHD L/B)
BR
94 (LHD W/G)
110 (RHD S/D)
112 (RHD L/B)

114 (RHD W/G)
: Splice Points
Code
E2
E3
See Page
82 (*5)
102 (*9)
82 (*5)
102 (*9)
Code
I3
Engine Wire
I5
See Page
88 (LHD)
108 (RHD)
88 (LHD)
Engine Wire
108 (RHD)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
173
AVENSIS (EWD526E)
http://vnx.su
Engine Control (1CDFTV)

BY
BY
GR
GR
R
From Power Source System
(See Page 120)
1
2 IE1
7 IE3 (LHD)
7 IO1 (RHD)
80A
GLOW
GR
BY
EDU Relay
G2
Glow Plug Relay
EFI MAIN
Relay
BY
BW
1
1
RB
BW
BR
WB
BW
BW
20A EFI
1 1A
10 EE1
7 EE1
G1
Glow Plug
BW
4 IE2
FL MAIN
3. 0W
Y
BW
Battery
G
BR
EC
174
AVENSIS (EWD526E)
http://vnx.su
GRR
BY
BY
GR
GR
RW(LHD)
RW(RHD)
P
P
LW(4)
1
R
11
7 DB
6
RW
MPX1
MPX2
PB
PB
BW
3 B
14 A
22 B
Glow
Temp.
BEAN
I/F
6 CK
18 B
13 A
9 B
WB
LW
19 B
5 B
VW
CPU
Check Engine
GRR
21 B
Tachometer
Speedometer
20 B
1 IC1
RW
WR
22
6 CD
C10(A), C11(B)
Combination Meter
4 : w/ VSC
5 : w/o VSC
WR
H B
8 CE
(RHD)
F A (LHD)
F C
F C (RHD)
(LHD)
J10(A), J11(B), J26(C)

Junction
Connector
WR
7 CA
I14
Integration Relay
BW
10 IC1
RW(RHD)
RW(LHD)
10A
GAUGE1
7. 5A
DOME
16 IE1
6 CA
(5)
LW
LW
3 CB
WB
(RHD)
SP1
WB
(4)
23
P
S2
Skid Control ECU
with Actuator
VW
WB(RHD)
BW
BW
BR
BR
IP
175
AVENSIS (EWD526E)
http://vnx.su

GRR
GRR
BY
LW(4)
(See Page 120)
GR
BW(LHD)
9
IE2
RW(LHD)
BW(RHD)
RW
RW
10A
IGN
(LHD)
RW(RHD)
(RHD)
5
IR1
LW(4)
R
18 DA
2 B
9 A
MREL
BATT
BW
C B (LHD)
E D (RHD)
(RHD)
E D
BW
C A (LHD)
A C (RHD)
BW
BW
8 A
(LHD)
BY
10 B
PTC1
C A
A C
(LHD)
BW
J 8(A), J 9(B),
J26(C), J27(D)
Junction Connector
(RHD)
LGB
LGB
11 B
MPX2
LGB
RW
21 A
GREL
6 IR1
(LHD)
PB
14 A
(1)
15 IE2
GR
10 IK1
C A
(RHD)
9 A
10 B (3)
RPTC1
(SIG1)
28 A (2)
LGB
MPX+
(RHD)
MPX
BW
C9
Clutch
Start SW
29 A (2)
20 B (3)
(LHD)
A13(A), A15(B)
BW
IGSW
E 9(A), E10(B), E12(C), E13(D)

Engine ECU (M/T)
B2
W
B1
5
BW
+B
1 A
D1
Diesel Throttle Control Motor
J10(A), J20(C)
Junction Connector
H A (LHD)
H C (RHD)
S2
12 D
S4
LUB
13 D
S1
LU+B
14 D
S3
LUA
15 D
H A (LHD)
H C (RHD)
LU+A
E3
EGB
3 C
GB
EG+B
4 C
RL
EGA
5 C
YG
EG+A
6 C
IREL
10 A
SP1
17 B
VW
MPX1
20 A
W
12 A
8 IK1
BW
BW
BW
BW
VW
BW
WB(RHD)
Y
BW
I3
BW
I3
BW
I3
BW
I3
BW
I3
BW
BR
BR
WB
(RHD)
176
AVENSIS (EWD526E)
http://vnx.su
GRR
GRR
LW(4)
BW(LHD)
BW(LHD)
BW(RHD)
BW(RHD)
1
2
3
4
: Power Heater (Electrical Type)

: Except Automatic A/C
: Automatic A/C
: w/ VSC
S1
35
SP1
7. 5A
ST
ENG+
ENG
NEO
32
TRC+
TRC
18
19
BW
(4)
(4)
(4)
YB
(4)
(4)
T8
5 IE8
13 IE1
13 IE8 (LHD)
3 IE2 (RHD)
6 IE8
13 IE2
EFII
EFIO
C B
J12(A), J13(B)
Junction
Connector
B B
14 IE8
14 IE2
7 IE8
15 IE2
GR
30 B
A A
BY
BY
29 B
(4)
(4)
(4)
YB
(4)
(4)
B A
24 A
30 A
ENG+
ENG
17 A
25 A
NEO
31 A
TRC+
IMO
TRC
7 A
IMI
STA
E 9(A), E10(B), E12(C), E13(D)

Engine ECU (M/T)
THIA
E2
1
PIM
28 C
WR
RW
GR
1
RW
E2
+B
3
THA
18 D
3
VC
E2
2
PIM
T5
Turbo Pressure Sensor
E2G
A6
Air Flow Meter
V4
VRV (EGR)
VG
29 D
I3
2 EC1
VC
THF
20 D
F18
Fuel Temp. Sensor
GR
E2
28 D
LY
THW
19 D
I9
31 D
THA
32 C
EVG
24 C
BW
VG
VN
10 D
BR
RW
BR
BR
1 EC1
BR
BR
BR
BW
BW
BW
I3
I3
RW
BR
I3
BR
I3
BR
I3
BR
I3
BR
BR
BR
WB
WB
(RHD)
(RHD)
177
AVENSIS (EWD526E)
http://vnx.su

GRR
GRR
BW(LHD)
BW(RHD)
15A
STOP
GW
(RHD)
(LHD)
GW
2 DA
FAN NO. 1 Relay

FAN NO. 2 Relay
1 IR1
(RHD)
GW
GW
RW
(LHD)
6 IE3
(LHD)
RW
(LHD)
(RHD)
RW
RW
11 IE3
(RHD)
BW
(LHD)
2 IR1
20 IE1
BW
BW
(RHD)
3 IR1
(LHD)
BW
(RHD)
(LHD)
GW
GW
GW
14 IE2
(RHD)
GW
(RHD)
GW
(LHD)
4 IR1
(LHD)
GW
(RHD)
22 DA
10 DC
S13
Stop Light SW
12 B
GW
19 B
3 A
ST1
STP
FAN
E 9(A), E10(B), E12(C), E13(D)

Engine ECU (M/T)
PB
PB
2 EB1
BR
5 EB1
BR
RW
3 EB1
RW
1 EB1
VCS
E2S
VC
E2
PR
INJF
25 D
PRD
32 D
#1
#2
#3
#4
24 D
23 D
22 D
21 D
E3
BR
PCR2
33 D
PR2
I8
Injector No. 4
PCR1
26 D
BR
E2S
1 C
I5
Injector No. 1
VCS
2 C
WR
RW
WL
BR
4 EB1
GW
6 EB1
F16
Fuel Pressure
Sensor
RL
BR
RW
RB
7 B
4 B
6 B
3 B
2 B
5 B
5 A
4 A
3 A
IJF
PRD
IJT# 1
IJT# 2
IJT# 3
IJT# 4
COM1
INJ# 1
INJ# 4
BATTERY
8 A
E 4(A), E 5(B)
RW
(Shielded)
(Shielded)
BR
WB
G
(RHD)
BR
BR
WB
(RHD)
178
AVENSIS (EWD526E)
http://vnx.su
GRR
GRR
A20
LGR
LG
9 C
2 D
1 D
RL
PCV+
28 A
22 A
VCP2
EPA2
(RHD)
(RHD)
(LHD)
7 IG2
23 A
(LHD)
W
W
2 IG2
(LHD)
4 (LHD)
6 (RHD)
(LHD)
Y
29 A
VCPA
(RHD)
3 IG2
26 A
VPA
VPA2
2
2
(LHD)
(RHD)
5 IG2
EP2
1
3
(LHD)
(RHD)
6 IG2
EPA
PCV
(LHD)
(RHD)
Y
BL
8 D
ALT
(LHD)
1 IG2
(LHD)
L
4
(LHD)
M
3
S6
A11
Alternator
VCP1
6
4
(LHD)
VPA1
5
5
(LHD)
EP1
3
1
27 A
VPA2
VCP2
E 9(A), E10(B), E12(C), E13(D)

Engine ECU (M/T)
E02
6 D
7 A
1 B
BR
I3
WB
BR
I3
GND
BR
E 4(A), E 5(B)
BR
WB
COM3
BR
PL
WB
8 B
PRV
T3
Throttle Position SW
WB
B
V
INJ# 3
(Shielded)
1 A
2 EA1
1 EA1
1
2 A
INJ# 2
E1
7 C
(Shielded)
WB
P3
Pressure
Discharge Valve
L
2
I7
Injector No. 3
I6
Injector No. 2
6 A
COM2
THOP
11 D
(Shielded)
E3
E01
7 D
(Shielded)
WB
WB
(RHD)
(RHD)
BR
EI
179
AVENSIS (EWD526E)
http://vnx.su

GRR
(Shielded)
(Shielded)
31 C
23 C
G1
NE
J20(C), J21(D)
Junction Connector
(RHD)
WL
WL
WL
(LHD)
B C
WG
G A
B A (LHD)
G C (RHD)
9 DB
17 DB
30 DA
3 DC
A B (LHD)
B D (RHD)
5 A
TACH
19 A
WFSE
WL
34 D
NE+
D D
WG
27 D
G A
B A (LHD)
G C (RHD)
(RHD)
WG
J 8(A), J26(C)
Junction
Connector
GRR
E A (LHD)
D C (RHD)
GRR
E A
D C
TC
13
WL
SIL
7
(LHD)
WFSE
15
(Shielded)
(Shielded)
J 8(A), J 9(B), J26(C), J27(D)

Junction
Connector
GRR
TAC
9
C1
Camshaft
Position Sensor
C6
D5
DLC3
18 A
11 A
SIL
TC
E 9(A), E10(B), E12(C), E13(D)

Engine ECU (M/T)
EOM
15 A
(Shielded)
E3
(Shielded)
(Shielded)
(Shielded)
E 3 : LHD
I 4 : RHD
BR
BR
(Shielded)
(Shielded)
D A
D A
E A
E A
E A
BR
BR
BR
J12(A), J13(B)
Junction
Connector
BR
E B
E B
D B
D B
BR
BR
BR
WB
WB
(RHD)
(RHD)
180
AVENSIS (EWD526E)
http://vnx.su
7. 5A OBD2
(Shielded)
(Shielded)
D5
DLC3
7 DA
SG
CG
BAT
WB
(LHD)
WB
(RHD)
BR
16
J16
Junction
Connector
A
(Shielded)
WB
(LHD)
(Shielded)
BR
WB
(RHD)
IL
181
AVENSIS (EWD526E)
http://vnx.su

System Outline
This system utilizes an engine ECU and maintains overall control of the engine, transaxle and so on. An outline of the
engine control is explained here.
1. Input Signals
(1) Water temp. signal circuit
The EFI water temp. sensor detects the engine coolant temp. and has a builtin thermistor with a resistance varies
according to the engine coolant temp. Thus the engine coolant temp. is input in the form of a control signal to
TERMINAL THW of the engine ECU.
The intake air temp. sensor is installed in the air flow meter and detects the intake air temp., which is input as a control
signal to TERMINAL THIA of the engine ECU.
Camshaft position is input as a control signal to TERMINAL G1 of the engine ECU, and engine RPM is input into
TERMINAL NE+.
(4) Throttle signal circuit
The accelerator pedal position sensor detects the accelerator pedal opening angle, which is input as a control signal to
TERMINALS VPA, VPA2 of the engine ECU.
(5) Vehicle speed signal circuit
The speed sensor detects the vehicle speed and inputs a control signal to TERMINAL SP1 of the engine ECU.
Voltage is constantly applied to TERMINAL BATT of the engine ECU. When the ignition SW is turned to on, voltage for
engine ECU operation is applied via the EFI MAIN relay to TERMINAL +B of the engine ECU.
(7) Started signal circuit
To confirm that the engine is cranking, the voltage applied to the starter motor during cranking is detected and is input as
a control signal to TERMINAL STA of the engine ECU.
(8) Fuel temp. signal circuit
The fuel temp. sensor is detects the fuel temp., which is input as a control signal to TERMINAL THF of the engine ECU.
(9) Intake air vacuum pressure signal system
Intake air vacuum pressure is detected by the turbo pressure sensor and is input as a control signal to TERMINAL PIM
of the engine ECU.
the engine ECU as a control signal.
182
AVENSIS (EWD526E)
http://vnx.su
2. Control System
EGR control system
The EGR control system detects the signals from each sensors, then the current is output to the TERMINAL VN to control
the VRV (EGR).
Common rail pressure control
The rail pressure is controlled by calculating the target rail pressure based on the engine status (Engine opening, engine
speed), as well as the amount of fuel to be pressurefed from the supply pump and the relief rate of the pressure reducing
valve so that the detection value of the rail pressure sensor will meet the target value, and sending a signal to the suction
volume regulating and pressure reducing valves.
Fuel injection timing control
The fuel injection timing is controlled by calculating the basic fuel injection timing based on the engine status (Engine
opening, engine speed), making corrections according to the water temperature, suction air temperature, suction air
pressure, etc., then sending a signal to the solenoid control valve of the ejector via the electronic driver unit.
Fuel injection rate control
The fuel injection rate is controlled by calculating the basic fuel injection rate based on the engine status (Engine opening,
engine speed), making corrections according to the water temperature, suction air temperature, suction air pressure, etc.,
then sending a signal to the solenoid control valve of the ejector via the electronic driver unit.
Pilot injection control
The fuel injection timing and rate are controlled by calculating the pilot injection rate and timing based on the engine status
(Engine opening, engine speed), making corrections according to the water temperature, suction air temperature, suction
air pressure, etc., then sending a signal to the solenoid control valve of the ejector via the electronic driver unit.
3. Diagnosis System
With the diagnosis system, when there is a malfunctioning in the ECU signal system, the malfunction system is recorded in
the memory. The malfunctioning system cab be found by reading the display (Code) of the check engine warning light.
4. Failsafe System
When a malfunction occurs in any system, if there is a possibility of engine trouble being caused by continued control based
on the signals from that system, the failsafe system either controls the system by using data (Standard values) recorded in
the ECU memory or else stops the engine.
183
AVENSIS (EWD526E)
http://vnx.su

Service Hints
EDU Relay
53 : Closed with the ignition SW at ON or ST position
E9 (A), E10 (B), E12 (C), E13 (D) Engine ECU (M/T)
+BE1 : 9.014.0 volts (Ignition SW at ON position)
VC, VCPA, VCP2, VCSE1 : 4.55.5 volts (Ignition SW at ON position)
01.5 volts (More than two seconds passed away after the ignition SW was turned to OFF)
IRELE1 : 01.5 volts (Engine idling)
9.014.0 volts (Ignition SW at OFF position)
GRELE1 : 9.014.0 volts (Engine cranking)
01.5 volts (Engine idling (More than 600 seconds passed away after the engine started to run) )
NE+ NE : Pulse generation (Engine idling)
G1G : Pulse generation (Engine idling)
VPAEPA : 0.51.1 volts (Ignition SW on and accelerator pedal fully closed)
3.04.6 volts (Ignition SW on and accelerator pedal fully opened)
VPA2EPA2 : 0.92.3 volts (Ignition SW on and accelerator pedal fully closed)
3.45.0 volts (Ignition SW on and accelerator pedal fully opened)
01.5 volts (Ignition SW on and brake pedal released)
ST1 E1 : 01.5 volts (Ignition SW on and brake pedal depressed)
7.514.0 volts (Ignition SW on and brake pedal released)
PIME2 : 0.20.8 volts (When a negative pressure of 40 kPA (300 mmhg) is applied)
1.31.9 volts (During air release)
3.23.8 volts (When a pressure of 69 kPA (0.7 kg/cm3) is applied)
THWE2 : 0.21.0 volts (During warmup and coolant temp. 60C, 140F120C, 248F)
THAE2 : 0.53.4 volts (During warmup and intake temp. 0C, 32F80C, 176F)
THIAE2 : 0.53.4 volts (During warmup and intake air temp. 0C, 32F80C, 176F)
THFE2 : 0.53.4 volts (During cooling with the ignition SW kept at the ON position)
VGE2 : 0.53.4 volts (Engine idling)
PCR1E2 : 1.82.1 volts (Engine idling)
PCR2E2 : 1.21.5 volts (Engine idling)
ALTE1 : Pulse generation (Engine idling)
RLE1 : 9.014.0 volts (Engine idling)
PCV+ PCV : Pulse generation (Engine idling)
#1, #2, #3, #4E1 : Pulse generation (Engine idling)
PRDE1 : 4.06.5 volts (Ignition SW off)
INJFE1 : Pulse generation (Engine idling)
EG+AE1 : Pulse generation (During idling after warmup)
EGAE1 : Pulse generation (During idling after warmup)
EG+BE1 : Pulse generation (During idling after warmup)
EGBE1 : Pulse generation (During idling after warmup)
LU+AE1 : Pulse generation (During racing after warmup)
LUAE1 : Pulse generation (During racing after warmup)
LU+BE1 : Pulse generation (During racing after warmup)
LUBE1 : Pulse generation (During racing after warmup)
THOPE1 : 9.014.0 volts (During idling after warmup)
03.0 volts (Only once within five seconds after the ignition SW was turned to ON)
VNE1 : Pulse generation (Ignition SW at ON position)
MPX1E1 : Pulse generation (During idling after warmup)
MPX2E1 : Pulse generation (During idling after warmup)
WE1 : 03.0 volts (Check engine warning light lights up and ignition SW at ON position)
9.014.0 volts (Engine idling and except check engine warning light lights up)
TCE1 : 9.014.0 volts (Ignition SW at ON position)
03.0 volts (The DLC3 is shorted between the TERMINALS TC and CG)
DE1 : 7.514.0 volts (Ignition SW on and clutch pedal depressed)
01.5 volts (Ignition SW on and clutch pedal released)
184
AVENSIS (EWD526E)
http://vnx.su
: Parts Location
Code
See Page
44 (*6)
A6
64 (*10)
44 (*6)
A11
A13
64 (*10)
46 (LHD)
A15
66 (RHD)
46 (LHD)
66 (RHD)
46 (LHD)
A20
E10
F18
66 (RHD)
66 (RHD)
66 (RHD)
64 (*10)
D5
67 (RHD)
64 (*10)
E3
64 (*10)
E4
E5
48 (LHD)
J12
J13
47 (LHD)
67 (RHD)
47 (LHD)
67 (RHD)
48 (LHD)
68 (RHD)
48 (LHD)
68 (RHD)
48 (LHD)
J16
47 (LHD)
68 (RHD)
67 (RHD)
J20
68 (RHD)
44 (*6)
J21
68 (RHD)
64 (*10)
J26
68 (RHD)
44 (*6)
J27
68 (RHD)
45 (*6)
65 (*10)
45 (*6)
65 (*10)
45 (*6)
65 (*10)
45 (*6)
65 (*10)
47 (LHD)
I14
44 (*6)
65 (*10)
I9
44 (*6)
J11
67 (RHD)
45 (*6)
I8
44 (*6)
E2
47 (LHD)
64 (*10)
I7
47 (LHD)
48 (LHD)
44 (*6)
I6
44 (*6)
64 (*10)
I5
46 (LHD)
See Page
J10
44 (*6)
G2
46 (LHD)
Code
64 (*10)
64 (*10)
G1
46 (LHD)
D1
D
F16
64 (*10)
E13
44 (*6)
E12
64 (*10)
C9
C11
E9
44 (*6)
C6
See Page
B
66 (RHD)
C1
C10
Code
E5
67 (RHD)
64 (*10)
J8
48 (LHD)
44 (*6)
J9
48 (LHD)
P3
S1
S2
S6
S13
T3
T5
T8
V4
45 (*6)
65 (*10)
45 (*6)
65 (*10)
45 (*6)
65 (*10)
45 (*6)
65 (*10)
49 (LHD)
69 (RHD)
45 (*6)
65 (*10)
45 (*6)
65 (*10)
49 (LHD)
69 (RHD)
45 (*6)
65 (*10)
: Relay Blocks
Code
See Page
25 (*2)
26
29

Code
1A
See Page
25 (*2)

CA
CB
CD
34
CE
CK
35
DA
DB
30
DC
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
185
AVENSIS (EWD526E)
http://vnx.su

Code
EA1
EB1
EC1
EE1
IC1
IE1
IE2
IE3
IE8
IG2
IK1
See Page
84 (*6)
104 (*10)
84 (*6)
104 (*10)
84 (*6)
104 (*10)
84 (*6)
104 (*10)
86 (LHD)
106 (RHD)

86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
88 (LHD)
88 (LHD)
108 (RHD)
IO1
108 (RHD)
IR1
108 (RHD)
: Ground Points
Code
EC
EI
IL
IP
See Page
84 (*6)
104 (*10)
84 (*6)
104 (*10)
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)

Near the Starter
Behind the Combination Meter
Right Kick Panel
: Splice Points
Code
E3
I3
See Page
84 (*6)
104 (*10)
Code
I3
Engine Wire
I4
See Page
108 (RHD)

Engine Wire
88 (LHD)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
186
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
Memo
187
AVENSIS (EWD526E)
http://vnx.su
Engine Immobiliser System

1 : Gasoline
2 : 1CDFTV
D5
DLC3
10A
IGN
7. 5A
ECUB 1
SIL
I12
WG
J 8(A), J26(B)
Junction
Connector
4 DA
G A (LHD)
G B (RHD)
G A (LHD)
G B (RHD)
CODE
VC5
YG
YB
WG
LR
GRR
WR
TXCT
BW
GND
13
12
11
IG
+B
AGND
TXCT
CODE
VC5
T8
D A
D B
B A
(RHD)
(LHD)
EFIO
EFII
7
GR
8 DA
CTY
4
F B
J22(A), J23(B)
Junction
Connector
Y
WB
(RHD)
WB
(LHD)
6 DA
(RHD)
10
J10(A), J11(B)
Junction
Connector
KSW
GND
14
(LHD)
IND
3
26
29
27 (1)
30 (2)
4 CK
1 CA
1 (LHD)
8 (RHD)
(RHD)
(LHD)
(RHD)
(LHD)
13 CF
1
WB
WB
6 CA
9 IM1
(RHD)
(RHD)
A
A
WB
(LHD)
J16
Junction
Connector
A
WB
WB
(LHD)
(RHD)
WB
IP
IL : LHD 2, RHD
IO : LHD 1
188
AVENSIS (EWD526E)
http://vnx.su
D10
Door Courtesy SW
Front RH
9 CH
14 IC2
(LHD)
8 (LHD)
1 (RHD)
D9
Door Courtesy SW
Front LH
5 CI
IMB
IMI
E10
Engine ECU (M/T)
U1
Unlock Warning
SW
F19
IMO
Service Hints
T8 Transponder Key Computer
1Ground : Always approx. 12 volts
U1 Unlock Warning SW
21 : Closed with the ignition key in cylinder
: Parts Location
Code
See Page
Code
47 (LHD)
D5
E10
67 (RHD)
52 (LHD L/B)
I12
54 (LHD W/G)
D10
E10
J16
68 (RHD)
J22
68 (RHD)
67 (RHD)
J23
68 (RHD)
47 (LHD)
J26
68 (RHD)
67 (RHD)
J8
48 (LHD)
72 (RHD L/B)
J10
48 (LHD)
74 (RHD W/G)
J11
48 (LHD)
J16
See Page
47 (LHD)
70 (RHD S/D)
47 (LHD)
Code
67 (RHD)
F19
50 (LHD S/D)
D9
See Page
T8
U1
49 (LHD)
69 (RHD)
49 (LHD)
69 (RHD)
48 (LHD)
: Relay Blocks
Code
6
See Page
29


Code
CA
CF
See Page
34
CH
CI
35
CK
DA
30

Code
See Page
IC2
86 (LHD)
IM1
108 (RHD)
: Ground Points
Code
IL
IO
IP
See Page
86 (LHD)
106 (RHD)
86 (LHD)
86 (LHD)
106 (RHD)

Right Kick Panel
189
AVENSIS (EWD526E)
http://vnx.su
Multiplex Communication System (Communication Bus)
MPX1
MPX2
(5)
14
BEAN
(BODY)
MPX+
9 A (3)
10 B (4)
13
29 B (1AZFSE)
29 A (1)
21 A (2)
MPX2
MPX1
18 B (1AZFSE)
23 A (1)
20 A (2)
BEAN
(EFI)
E 9(A), E10(B)
Engine ECU (M/T)
PB
C10
Combination Meter
15
MPX
PB
1 IC1
BEAN
(SECURITY)
29 A (3)
20 B (4)
PB
22
31
PL
11
A13(A), A15(B)
MPX
I14
Integration Relay
T6
Theft Deterrent ECU
10 IC1
190
AVENSIS (EWD526E)
http://vnx.su
1
2
3
4
5
: 1AZFE, 1ZZFE, 3ZZFE

: 1CDFTV
: Automatic A/C
: w/ Theft Deterrent
System Outline
The multiplex communication system communicates among the integration relay, A/C control assembly, engine and ECT
ECU (A/T), engine ECU (M/T), combination meter, theft deterrent ECU and controls the following systems according to the
signals from respective sensors or switches.
Multiplex Communication System Includes Following Systems
Door Lock Control
Double Locking
Headlight (w/ Daytime Running Light)
Interior Light
Key Reminder
Light Reminder
Seat Belt Warning
Theft Deterrent
Wireless Door Lock Control
: Parts Location
Code
A13
A15
C10
See Page
A
B
Code
46 (LHD)
66 (RHD)
46 (LHD)
66 (RHD)
46 (LHD)
See Page
C10
E9
E10
66 (RHD)
A
B
47 (LHD)
67 (RHD)
Code
I14
T6
See Page
47 (LHD)
67 (RHD)
69 (RHD)
47 (LHD)
67 (RHD)

Code
IC1
See Page
86 (LHD)
106 (RHD)

* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
191
AVENSIS (EWD526E)
http://vnx.su
Multiplex Communication System (LHD)

I14(A)
Integration Relay
7. 5A
ECUB 2
25A
DOOR
B
1
INTB
TOUT
23
14
15
16 DB
6 DJ
9 DJ
PRG
TRLY
16 A
13
RDA
7 A
(4)
LW
(4)
GY
16 IC2
7 IC2
GY
LW
(3)
GW
(3)
WR
WR
(4)
(4)
2
RDA
+B
GROUND
(4)
WR
WB
3
WR
3
PRG
D6
3 CD
TAIL Relay
(4)
WR
9 CF
(4)
10 CC
7. 5A PANEL
Illuminations
19 DB
(2)
BL
1 DN
1 4D
2
140A ALT
(1)
BG
1 4B
(2)
120A ALT (1AZFSE, 1AZFE)

100A ALT (1ZZFE, 3ZZFE)
(1)
(2)
: Gasoline
: 1CDFTV
: w/ Wireless Door Lock
: w/ Headlight Cleaner
: 3 w/ HID
1
2
3
4
5
6
BG
1 ED1
FL MAIN
3. 0W
WB
(4)
Battery
192
AVENSIS (EWD526E)
http://vnx.su
I14(A)
Integration Relay
HRLY
BKL
9 A
LR
FRLY
15 A
LG
OBD2
21 A
WG
P/W
20
2 A
(3)
RY
H14
Headlight Beam
Level Control ECU
(w/ Moon Roof)
1 IC3
6 IC2
12 IC2
15 IC2
HDLP
D A
C A
C A
RY
(6)
RY
(3)
RY
LR
J10(A), J11(B)
Junction Connector
LG
J 8(A), J 9(B)
Junction Connector
G A
B B
C A
14 DB
J 6(A), J 7(B)
Junction Connector
C B
2 DD
PWS
PW
SIL
EHW
GSW1
DBEW
T10
Turn Signal
Flasher Relay
A27
Airbag Sensor
Assembly
M6
Moon Roof Control
Relay and Motor
D17
Power Window
Master SW
D5
DLC3
(3)
LR
LG
3 IA1
5 BB1
WG
RY
6 ID1
WG
G B
E B
(w/ Moon Roof)
J 8(A), J 9(B)
Junction Connector
A A
(w/o Moon Roof)
10
A A
H16
Headlight
Cleaner SW
(3 5)
5 DA
RY
(3)
WB
WB
(4)
(4)
193
AVENSIS (EWD526E)
http://vnx.su

I14(A)
Integration Relay
DIM
14 A
(See Page 120)
RB
(3)
RL
(3)
2
40A
MAIN
6 IB1
15A
HLP LH
(3)
WR
(3)
RB
(3)
RL
(3)
WL
15A
HLP RH
WL
2
2
(3)
RY
RB
(7)
RB
(6)
(6)
WB
WB
(7)
(3)
WB
(3)
WR
(3)
WR
(3)
E1
A
D B
(8)
D B
WR
E A
RY
J 3(A), J 4(B)
Junction Connector
RY
F9
F10
Headlight RH (Low)
(7)
WB
F7
DIM Relay
(6)
(6)
F8
Headlight LH (Low)
HLP Relay
(7)
J2
Junction
Connector
(3)
WB
(3)
WB
(3)
RY
(8)
WB
WB
(4)
(4)
1
2
3
4
6
7
8
: Gasoline
: 1CDFTV
: 3 w/ HID
: 3 w/o HID
: 2 3 Except Automatic A/C
WB
WB
(3)
(3)
WB
(3)
EC
194
AVENSIS (EWD526E)
http://vnx.su
I14(A)
Integration Relay
T
RB
HU
6 A
12
18
12 DB
28 DA
HF
13 A
(3)
(3)
RY
(3)
RW
3 IC3
E A
E A
3
E B
A B
H3
Headlight Cleaner
Control Relay
RY
D A
RY
(3)
(6)
J 3(A), J 4(B)
Junction Connector
D A
2
(3)
J 6(A), J 7(B)
Junction Connector
(6)
RY
(6)
RY
3
HDLO
H6
Headlight RH (High)
(3)
(3)
(3)
RL
RL
RY
9 IC3
H5
Headlight LH (High)
(7)
RY
10 IE1
RW
(6)
10A
HLP
HI RH
RY
10A
HLP
HI LH
RY
(6)
(3)
RY
RW
(3)
RW
(3)
WB
(3)
WB
(7)
(3)
RY
R
(3)
(3)
Dimmer SW
Light
Control SW
14
13
OFF
C12
Combination SW
Tail
Head
Flash
Low
High
16
RW
(3)
RY
(8)
(8)
WB
WB
(4)
(4)
WB
WB
(3)
(3)
RY
WB
WB
(3)
(3)
EB
IL : 2
IO : 1
195
AVENSIS (EWD526E)
http://vnx.su

I14(A)
Integration Relay
7. 5A
RAD
NO. 1
7 DB
RW
F A
7 CA
J 8(A), J 9(B)
Junction
Connector
4 DB
GR
10A
GAUGE1
MPX2
MPX1
22 A
11 A
IG
22
PB
ACC
21
RW
RW(16)
(16)
WR
LR(16)
7 CD
1 IC1
10 IC1
H B
E 9(A), E10(B)
Engine ECU (M/T)
(15)
High Beam
(15)
13 A
C10(A), C11(B)
Combination Meter
PBLT
HRLY
30 A (12)
(8)
MPX+
9 A
10 B (13)
24 A (12)
3 C (13)
29 B (1AZFSE)
29 A (11)
21 A (2)
MPX2
MPX1
18 B (1AZFSE)
23 A (11)
20 A (2)
WB
5 B
(3)
WB
6 A
(3)
RW
12 B
CPU
MPX
PB
Door
BEAN
I/F
Buzzer
Seat Belt
(15)
29 A
20 B
RY
20 B
14 A
A13(A), A15(B), A16(C)

21 B
WR
RW
2 A
PB
GR
6 CD
6 CK
RW
(3)
8 CD
6 CA
9 CH
11 CF
RY
(8)
WB
WB
(4)
WB
WB
(14)
(14)
(16)
WB
WB
(16)
A
WB
WB
WB
(3)
J16
Junction
Connector
IP
196
AVENSIS (EWD526E)
http://vnx.su
I14(A)
Integration Relay
SNOW
LP

(See Page 120)
I11(A), I12(B)
Ignition Key Cylinder Light
WG
7. 5A
DOME
2
6
RW(16)
WR
WR
WR
ILL+
2 A (10)
2 B (9)
WR
RW
ILL
H B
H B
F A
F A
IG
WR
BPBEW
F19
Front Passenger' s Seat
Belt Warning Light
WR
4 ID1
1
E
PBEW
B5
WR
WR
WR
WG
GY
(16)
WB
WR
(16)
(14)
WB
6 A (10)
6 B (9)
H B
WR
E8
ECT Pattern Select SW
(16)
LR
(16)
(14)
WR
LR(16)
7 DK
WG
1 DA
J10(A), J11(B)
Junction Connector
14 DA
WB
P8
Personal Light
V9
Vanity Light RH
V8
Vanity Light LH
2
B5
WB
WB
WB
B10
Buckle SW (Front Passenger' s Side)
GY
(16)
14 IM1
WB
B5
WB
WB
WB
WB
(16)
(14)
(16)
WB
BV
2 : 1CDFTV
3 : w/ Daytime Running Light
4 : w/ Wireless Door Lock
8 : 2 3 Except Automatic A/C
10 : w/o Engine Immobiliser System
13 : Automatic A/C
14 : A/T Except 1AZFE
15 : Except 1AZFE, Latin America, Argentina, CIS
16 : Except 1AZFE
197
AVENSIS (EWD526E)
http://vnx.su

I14(A)
Integration Relay
LGCY
6 DK
2 DK
A
RY
(S/D)
WG
J32
Junction Connector
9 DA
WB
2 DB
WB
25
(S/D)
RY
1 A
A
11
IL1
11 IA1
I16
Interior Light
WR
WB
WR
D7
R
2
WR
WR
(S/D)
D8
R
2
WR
L5
Luggage Compartment Light
RY
(S/D)
WR
(17)
10
IL1
10 IA1
11 ID1
WR
WR
F A
F A
H B
H B
WR
WR
WR
F A
WR
5 IC2
RY
WB
(17)
J 6(A), J 7(B)
Junction Connector
WB
D3
Diode
R17
Rear Interior Light
WB
B5
WB
WB
WB
RY
(17)
RY
(S/D)
WB
WB
IJ
198
AVENSIS (EWD526E)
http://vnx.su
I14(A)
Integration Relay
PCTY
RCTY
16
13 DB
9 DC
12 DM
L1
KSW
19
13 DM
8 DA
UL1
11
10
29 DA
13 DA
WG
DCTY
17
4 IC2
BRW
GW
3 IA2
BRW
GW
WG
D17
Unlock
Lock
U1
Unlock Warning SW
WG
1
D12
D11
4 IA2
18 IM1
D10
9 IM1
14 IC2
D9
D B
B A
B A
J10(A), J11(B)
Junction Connector
WG
WB
WB
17 : L/B, W/G
WB
WB
B1
9 IA1
WB
RY
RY
(17)
(17)
RY
RY
(S/D)
(S/D)
WB
199
AVENSIS (EWD526E)
http://vnx.su

I14(A)
Integration Relay
8 CC
LG
LR
LB
LR
LB
2 IA2
1 IA2
18 IA2
7 IA1
2 IA1
2 BA1
11 BA1
LG
LR
LB
LR
LB
LR
10
D13
Door Key Lock and Unlock SW
(Driver' s Side)
Door Lock Control Motor
(Driver' s Side)
Door Unlock Detection SW
(Driver' s Side)
D18
Door Lock Motor
Rear LH
IL1
7 CC
11 CK
LB
7 CJ
16 IC1
17 IM2
1 IM2
LB
2 CB
2 BC1
11 BC1
LB
4 CA
LR
7 IC1
10 DB
LR
20 DB
LR
6 DM
LR
7 DM
LB
4 DJ
LB
1 DJ
LB
LR
LR(17)
ACT
LR
LY(S/D)
ACT+
17 IC1
WB
LSWD
3 A
LR
UL2
5 A
LG
L2
4 A
IL1
D15
(Front Passenger' s Side)
D20
Door Lock Motor
Rear RH
17 : L/B, W/G
RY
RY
(17)
(17)
RY
RY
(S/D)
(S/D)
200
AVENSIS (EWD526E)
http://vnx.su
WB
(17)
3 BG1
BX
AVENSIS (EWD526E)
http://vnx.su
B A
B A
C B
J30(A), J31(B)
Junction Connector
(S/D)
WB
WB
LB
LB
3 BG2
L4
Luggage Compartment Door Opener SW
(S/D)
LB
(S/D)
(S/D)
RY
(W/G)
L3
Luggage Compartment Door Lock Motor
(S/D)
WB
(17)
WB
A B
(S/D)
B8
Back Door Opener
SW
(L/B)
A B
(L/B)
6 BE2
WB
RY
WB
A A
J33(A), J34(B)
Junction Connector
WB
(17)
4 BG2
(W/G)
A B
(W/G)
(L/B)
(W/G)
7 BD2 (L/B)
6 BF2 (W/G)
WB
L
(L/B)
(17)
LB
(17)
RY
(17)
(17)
(W/G)
7 BE2
WB
B7
Back Door Courtesy SW
5 BG2
(L/B)
J32
Junction
Connector
(17)
LACT
(W/G)
WB
2
RY
8 BD2 (L/B)
2 BF2 (W/G)
WB
8 BE2
(W/G)
RY
RY
(17)
(W/G)
RY
(L/B)
BDCY
(17)
RY
(L/B)
12 A
(17)
WB
(17)
RY
(17)
I14(A)
Integration Relay
10 A
BDSU
(S/D)
LB
3 DM
(S/D)
6 BD2 (L/B)
5 BF2 (W/G)
2 BD1 (L/B)
4 BF1 (W/G)
WB
(L/B)
RY
2 BE1
(S/D)
BS
201

Service Hints
Integration Relay
22Ground : Approx. 12 volts with ignition SW at ON position
1, 23Ground : Always approx. 12 volts
: Parts Location
Code
See Page
A13
46 (LHD)
A15
46 (LHD)
A16
46 (LHD)
A27
B7
Code
See Page
D17
54 (LHD W/G)
43 (*5)
45 (*6)
52 (LHD L/B)
J3
48 (LHD)
46 (LHD)
54 (LHD W/G)
J4
48 (LHD)
52 (LHD L/B)
50 (LHD S/D)
J6
48 (LHD)
52 (LHD L/B)
J7
48 (LHD)
54 (LHD W/G)
J8
48 (LHD)
47 (LHD)
J9
48 (LHD)
D18
D20
52 (LHD L/B)
54 (LHD W/G)
B10
See Page
J2
50 (LHD S/D)
54 (LHD W/G)
B8
Code
E8
56 (LHD)
E9
47 (LHD)
J10
48 (LHD)
C10
46 (LHD)
E10
47 (LHD)
J11
48 (LHD)
C11
46 (LHD)
C12
46 (LHD)
D3
38 (*3)
J16
48 (LHD)
42 (*5)
J30
51 (LHD S/D)
47 (LHD)
44 (*6)
J31
51 (LHD S/D)
D5
47 (LHD)
38 (*3)
D6
47 (LHD)
F7
50 (LHD S/D)
D7
52 (LHD L/B)
38 (*3)
42 (*5)
F9
50 (LHD S/D)
44 (*6)
52 (LHD L/B)
38 (*3)
54 (LHD W/G)
F10
50 (LHD S/D)
D9
D10
52 (LHD L/B)
F19
D12
D15
42 (*5)
44 (*6)
54 (LHD W/G)
38 (*3)
42 (*5)
H16
51 (LHD S/D)
P8
53 (LHD L/B)
55 (LHD W/G)
R17
53 (LHD L/B)
55 (LHD W/G)
49 (LHD)
49 (LHD)
47 (LHD)
54 (LHD W/G)
I12
47 (LHD)
50 (LHD S/D)
I14
47 (LHD)
52 (LHD L/B)
55 (LHD W/G)
U1
47 (LHD)
50 (LHD S/D)
50 (LHD S/D)
53 (LHD L/B)
47 (LHD)
A
I16
M6
T10
I11
52 (LHD L/B)
51 (LHD S/D)
44 (*6)
52 (LHD L/B)
54 (LHD W/G)
D17
51 (LHD S/D)
52 (LHD L/B)
50 (LHD S/D)
D13
51 (LHD S/D)
38 (*3)
H14
55 (LHD W/G)
L5
44 (*6)
54 (LHD W/G)
53 (LHD L/B)
47 (LHD)
54 (LHD W/G)
52 (LHD L/B)
55 (LHD W/G)
51 (LHD S/D)
52 (LHD L/B)
H6
J34
53 (LHD L/B)
L4
42 (*5)
50 (LHD S/D)
44 (*6)
50 (LHD S/D)
H5
J33
L3
38 (*3)
H3
55 (LHD W/G)
42 (*5)
54 (LHD W/G)
50 (LHD S/D)
D11
53 (LHD L/B)
J32
44 (*6)
54 (LHD W/G)
D8
51 (LHD S/D)
42 (*5)
F8
51 (LHD S/D)
V8
53 (LHD L/B)
55 (LHD W/G)
51 (LHD S/D)
V9
52 (LHD L/B)
53 (LHD L/B)
55 (LHD W/G)
54 (LHD W/G)
J2
39 (*3)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
202
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
: Relay Blocks
Code
1
See Page
24 (*1)
25 (*2)

26
26
29

Code
4B
4D
See Page
27

CA
CB
CC
34
CD
CF
CH
CJ
35
CK
DA
DB
DC
30
DK
31
Roof Wire and Driver Side J/B (Left Side of the Instrument Panel)
DM
31
DN
31
DD
DJ
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
203
AVENSIS (EWD526E)
http://vnx.su

Code
ED1
See Page
84 (*6)
86 (LHD)
86 (LHD)
86 (LHD)
ID1
86 (LHD)
IE1
86 (LHD)
IL1
88 (LHD)
88 (LHD)
IA1
IA2
IB1
IC1
IC2
IC3
IM1
IM2
90 (LHD S/D)
BA1
92 (LHD L/B)
94 (LHD W/G)
90 (LHD S/D)
BB1
92 (LHD L/B)
94 (LHD W/G)
90 (LHD S/D)
BC1
92 (LHD L/B)
94 (LHD W/G)
BD1
BD2
BE1
BE2
BF1
BF2
BG1
BG2
92 (LHD L/B)
92 (LHD L/B)
94 (LHD W/G)
94 (LHD W/G)
: Ground Points
Code
See Page
78 (*3)
EB
82 (*5)
Engine Compartment Right
84 (*6)
78 (*3)
EC
82 (*5)
84 (*6)
IJ
86 (LHD)
Left Kick Panel
IL
86 (LHD)
IO
86 (LHD)
IP
86 (LHD)
Right Kick Panel
90 (LHD S/D)
BS
92 (LHD L/B)
Lower Back Panel Left
94 (LHD W/G)
90 (LHD S/D)
BV
92 (LHD L/B)
Under the Right Center Pillar
94 (LHD W/G)
BX
92 (LHD L/B)
94 (LHD W/G)
Right Side of the Back Door
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
204
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
: Splice Points
Code
See Page
78 (*3)
E1
82 (*5)
B1
90 (LHD S/D)
92 (LHD L/B)
B5
Front Door LH Wire
See Page
94 (LHD W/G)

Front Door LH Wire
90 (LHD S/D)
84 (*6)
B1
Code
92 (LHD L/B)
Roof Wire
94 (LHD W/G)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
205
AVENSIS (EWD526E)
http://vnx.su
Multiplex Communication System (RHD)

I14(A)
Integration Relay
25A
DOOR
B
1
PRG
23
16 A
16 DB
GY
7. 5A
ECUB 2
RDA
TRLY
7 A
13
(3)
+B
GROUND
BL
2
RDA
D6
1 4D
120A ALT
(1AZFSE, 1AZFE)
100A ALT
(1ZZFE, 3ZZFE)
: Gasoline
: 1CDFTV
BG
1 4B
(2)
(1)
1
2
3
4
2
140A ALT
(1)
(2)
BG
1 ED1
(3)
WB
(3)
(3)
WR
9 CF
WR
(4)
WR
1 DN
PRG
5
7 CI
(3)
3 CD
7 IC2
LW
WR
10 CC
(3)
WR
GY
16 IC2
3
TAIL Relay
WR
(2)
LW
(3)
FL MAIN
3. 0W
(3)
WB
Battery
WR
(4)
J15
Junction
Connector
IK
206
AVENSIS (EWD526E)
http://vnx.su
I14(A)
Integration Relay
P/W
OBD2
FRLY
21 A
20
BKL
15 A
9 A
LG
LR
D B
F A
J24(A), J25(B)
Junction Connector
LG
J26(A), J27(B)
Junction Connector
(w/ Moon Roof)
G A
LR
WG
12 IC2
WG
6 IC2
14 DB
2 DD
LR
LG
IL1
5 BB1
WG
1 IC3
G B
A B
6 ID1
(w/o Moon Roof)
B
E A
J26(A), J27(B)
Junction Connector
E A
(w/ Moon Roof)
5 DA
PWS
PW
SIL
EHW
GSW1
DBEW
T10
Turn Signal
Flasher Relay
A27
Airbag Sensor
Assembly
M6
Moon Roof Control
Relay and Motor
D17
Power Window
Master SW
D5
DLC3
WR
WR
(4)
(4)
207
AVENSIS (EWD526E)
http://vnx.su

I14(A)
Integration Relay
SNOW
8
ACC
IG
21
MPX2
22 A
22
(See Page 120)
PB
10A GAUGE1
7. 5A
RAD NO. 1
WR
RW(4)
PL(4)
14 DA
4 DB
RW
7 DB
1 CK
(8)
RW
7 CA
RW
RW
F A
(4)
GR
J20(A), J21(B)
Junction
Connector
(8)
(8)
1 IC1
7 CD
2
4
5
6
7
8
: 1CDFTV
: Automatic A/C
: Except 1AZFE
H B
WR
15 A
PB
21 B
(4)
2 A
PL
RW
GR
E8
6 CD
14 A
20 B
(10)
Door
Buzzer
(8)
WB
(10)
(10)
(10)
Seat Belt
BEAN
I/F
CPU
5 B
13 A
WB
C10(A), C11(B)
Combination Meter
8 CH
6 CK
P
WB
6 CA
9 CG
13 CF
WB
WB
WB(4)
WB(4)
WR
WR
(4)
(4)
IP
208
AVENSIS (EWD526E)
http://vnx.su
IL
AVENSIS (EWD526E)
http://vnx.su
B A
C B
J30(A), J31(B)
Junction
Connector
SEC
D A
2
2
(8)
F B
D A
J22(A), J23(B)
Junction Connector
(4)
(8)
MPX1
U1
Unlock Warning SW
J32
Junction
Connector
(1AZFE)
(4)
(8)
RW
11 A
WB
(8)
8 IC3
WB
(8)
PBEW
F19
Front Passenger' s Seat Belt
Warning Light
MPX
WB
29 B (1AZFSE)
29 A (7)
21 A (2)
B10
29 A (5)
20 B (6)
WB
MPX2
E
(8)
GY
IG
(8)
GY
BPBEW
(8)
WB
(8)
(8)
J16
Junction
Connector
MPX1
18 B (1AZFSE)
23 A (7)
20 A (2)
PBLT
24 A (5)
3 C (6)
LR
MPX+
(8)
9 A
10 B
LR
PB
A13(A), A15(B), A16(C)

10 IC1
(8)
WB
E 9(A), E10(B)
Engine ECU (M/T)
I14(A)
Integration Relay
19
KSW
8 DA
WR
WR
Y(4)
RW(4)
RW(4)
PL(4)
PL(4)
RW
V(4)
(8)
WB(4)
WB
WB(4)
WR
WR
(4)
(4)
BS
209

I14(A)
Integration Relay
WR
WR
Y(4)
WR
(4)
RW(4)
PL(4)
29
25
E
31
MPX
IND
10
12
IG
(4)
WR
(4)
WB(4)
(4)
RW
V(4)
2
+B1
KSW
T6
Theft Deterrent ECU
IOUT
HORN
26
J26(A), J27(B)
Junction Connector
(4)
LB
(4)
LW
(4)
LGB
(4)
(4)
S+B
24
(4)
SSW1
13
LR
DSWH
34
LR
CTLS
27
S+B
IOUT
(4)
D B
(4)
LB
(4)
LW
(4)
LGB
(4)
SOU+
GND
(4 W/G)
(Shielded)
1
MIN
2
MIN+
(4)
SOU
WB
SIN
SIN+
(4 W/G)
3
SOFF
(4 W/G)
19 ID1
T12
(4)
WR
GND
9 ID1
+B
1
8 ID1
E6
CONT
T15
Theft Warning Siren
(4)
LR
5 IO1
LR
B A
11 IM1
G
(4)
(4)
WB
(4)
WB
12 IM1
WR
T14
Theft Warning
Ultrasonic
Sensor Rear RH
(4)
1
MOU
2
MOU+
T13
Theft Warning
Ultrasonic
Sensor Rear LH
WB
(4)
BV
EC
210
AVENSIS (EWD526E)
http://vnx.su
I14(A)
Integration Relay
LP
6
H B
F A
F A
7 DK
WG
I11(A), I12(B)
6 A (10)
6 B (9)
ILL
ILL+
2 A (10)
2 B (9)
WR
WR
WR
(4)
F A
WR
F A
WR
H B
1 DA
WG
J26(A), J27(B)
Junction
Connector
(4)
(4)
WR
15A HORN
WR
WR
1
7. 5A DOME
1
WR
W
(4)
2
2
4 ID1
5
WR
3
B5
WR
WR
WR
(4)
GW
(4)
WR
HORN
Relay
H12
Horn
RH
P8
Personal Light
20 IE1
(4)
H11
Horn
LH
V8
Vanity Light LH
V9
Vanity Light RH
GW
WB
WB
4 : w/ Theft Deterrent
WB
(4)
WB
B5
WB
WB
(4)
WB
B5
WB
(4)
211
AVENSIS (EWD526E)
http://vnx.su
WR
WR
9 CI
11 CI
10 CI
3 CE
6 CH
WR
5 IC2
10 IA1
1
1
10
IL1
WB
212
AVENSIS (EWD526E)
http://vnx.su
WG
PCTY
RCTY
9
16
13 DB
9 DC
9 IM1
14 IC2
1
1
1
D12
IL1
WG
DCTY
17
12 DM
WG
1 CA
D11
11
WG
7 CG
D9
11 IA1
J32
Junction
Connector
D8
2 DB
LGCY
D7
RY
(S/D)
1 A
D10
(S/D)
L5
WR
RY
(S/D)
WR
(S/D)
WR
WR
WR
WR
(11)
RY
R17
Rear Interior Light
D3
Diode
WR
(11)
RY

I14(A)
Integration Relay
13 DM
5 CE
A
4 IC2
18 IM1
WR
WB
(11)
RY
(S/D)
RY
I14(A)
Integration Relay
E
BDCY
(11)
RY
2 DK
3 DM
A
J32
Junction
Connector
WG
L
(S/D)
RY
(11)
RY
(11)
WB
WB
6 DK
8 BD2 (L/B)
2 BF2 (W/G)
(11)
9 DA
LACT
12 A
25
7 BD2 (L/B)
6 BF2 (W/G)
11 ID1
WB
(W/G)
WB
(11)
(11)
WB
4
M
WR
4 BG2
(W/G)
(L/B)
RY
(W/G)
L
L
(L/B)
7 BE2
B7
5 BG2
RY
RY
WB
WR
(L/B)
I16
Interior Light
8 BE2
(W/G)
RY
(L/B)
WR
WB
(11)
WB
B5
WB
WB
(11)
RY
WB
(11)
RY
RY
(S/D)
(S/D)
11 : L/B, W/G
213
AVENSIS (EWD526E)
http://vnx.su
RY
BX
WB
1
A A
C B
A B
8
5
2 BE1
BS
214
AVENSIS (EWD526E)
http://vnx.su
LG
4 A
L2
2
IL2
2 BD1 (L/B)
4 BF1 (W/G)
WB
(L/B)
WB
(S/D)
IP
IL2
8 A (13)
8 B
LG
IL2
LG
IL2
LR
13 DA
LR
29 DA
D17
GW
BRW
UL1
5 A
UL2
17 IC1
7 IC1
16 IC1
18
(12)
GW
Unlock
6 BD2 (L/B)
5 BF2 (W/G)
BRW
LB
10
3 BG2
Lock
(S/D)
11
LY
LB
(S/D)
(S/D)
WB
L
(S/D)
L1
D13(A)
Door Key Lock and Unlock SW (Driver' s Side)
Door Lock Control Motor (Driver' s Side)
Door Unlock Detection SW (Driver' s Side)
D14(B)
Double Lock Motor (Driver' s Side)
Double Lock Position SW (Driver' s Side)
L4
Luggage Compartment
Door Opener SW
RY
(S/D)
L
(W/G)
LB
(11)
BDSU
WB
WB
B A
J30(A), J31(B)
Junction Connector
LB
(W/G)
L
(L/B)
10 A
WB
B A
(S/D)
WB
(S/D)
WB
(S/D)
WB
(11)
WB
LB
(L/B)
L3
B8
Back Door Opener
SW
WB
3 BG1
(L/B)
WB
WB
(W/G)
(11)
A B
WB
(11)
A B
WB
WB
1
(W/G)
(11)
(11)
WB
WB
6 BE2
WB
(11)
(11)
J33(A), J34(B)
Junction
Connector

I14(A)
Integration Relay
3 A
LSWD
IL2
6 A
6 B
5 A
5 B
7 A (13)
7 B (12)
10 B (12)
B7
IL1
WB
I14(A)
Integration Relay
LSWP
DLPD
(12)
20 DB
B
(12)
G
A
2 CB
7 CJ
8 CC
4 CA
B
(12)
(12)
G
A
B
(12)
G
B
B
(12)
LB
G
A
LB
G
B
LR
B
(12)
B
(12)
LR
(12)
3 IC1
8 DB
10 DB
(12)
6 A
6 CF
5 CH
1 CI
1 CE
11 : L/B, W/G
12 : w/ Double Locking
13 : w/o Double Locking
(12)
(12)
W
W
16 BC1
(12)
(12)
(12)
L
L
2 B
(12)
LGB
(12)
(12)
LGB
9 B
1 B (12)
10 B (12)
6 B
B8
WB
D20(A)
D21(B)
Door Unlock Detection
SW Rear RH
Double Lock Motor
Rear RH
Double Lock
Position SW Rear RH
5 B
WB
1 A (13)
3 B
6 BC1
11 IM2
(12)
4 A
4 B
2 IM2
(12)
1 A (13)
1 B (12)
WB
4 A
2 B
9 BC1
(12)
4 BC1
11 BC1
(12)
2 BC1
16 IM1
LGB
(12)
LB
(12)
LR
LB
IL1
LR
2
17 IM1
(12)
D13(A)
D14(B)
IL1
1 IM2
LB
B
9 B
4 B
17 IM2
LR
IL2
(12)
17
11 CK
LB
(12)
(12)
L
L
IL1
7 CC
LR
3 B
(12)
W
W
IL1
(12)
(12)
J20(A), J21(B)
Junction
Connector
10 BC1
WB
WB
(12)
WB
BU
215
AVENSIS (EWD526E)
http://vnx.su
9 DJ
20 DA
1 DJ
4 DJ
LR
LB
10 DM
6 DM
(12)
(12)
(12)
7 DM
LB
6 DJ
LR
(12)
ACT
LGB
ACT+
(12)
ACTR
15
LGB
ACTS
14
LGB
I14(A)
Integration Relay
(12)
6 B (12)
WB
(12)
(12)
B2
9 IA1
10 BA1
IJ
WB
(12)
WB
(12)
WB
BQ
216
AVENSIS (EWD526E)
http://vnx.su
LB
11 BA1
LB
LR
2 BA1
LR
(12)
LGB
5 B
WB
WB
9 BA1
(12)
(12)
9 B
10 B
D18(A)
D19(B)
B1
WB
(12)
L
L
4 B
3 B
4 BA1
(12)
1 A (13)
3 B (12)
6 BA1
12 IC1
(12)
4 A
4 B
4 IC3
(12)
(12)
W
W
LB
16 BA1
(12)
LR
2 IA1
LB
(12)
7 B (12)
WB
5 B
(12)
8 B
WB
6 B
7 IA1
LR
(12)
LGB
18 IA2
LGB
(12)
B
B
(12)
(12)
W
W
1 B
17 IA2
(12)
2 B
8 IA1
(12)
L
L
4 IA1
(12)
D15(A)
Door Lock Control Motor (Front Passenger' s Side)
D16(B)
Door Unlock Detection SW (Front Passenger' s Side)
Double Lock Motor (Front Passenger' s Side)
Double Lock Position SW (Front Passenger' s Side)
(12)
10 IC3
3 CK
(12)
5 CB
2 CA
(12)
2 CD
(12)
(12)
L
10 CA 12 CJ
(12)
(12)
4 A
2 B
1 A (13)
1 B (12)
Service Hints
Integration Relay
: Parts Location
Code
See Page
A13
66 (RHD)
A15
66 (RHD)
A16
66 (RHD)
A27
Code
See Page
72 (RHD L/B)
D17
D18
B7
B8
D19
76 (RHD)
70 (RHD S/D)
D20
70 (RHD S/D)
D21
72 (RHD L/B)
66 (RHD)
74 (RHD W/G)
C11
66 (RHD)
58 (*7)
D5
67 (RHD)
D6
67 (RHD)
D7
E6
E8
D14
D15
D16
A
B
D17
62 (*9)
64 (*10)
70 (RHD S/D)
58 (*7)
62 (*9)
H12
71 (RHD S/D)
M6
73 (RHD L/B)
75 (RHD W/G)
71 (RHD S/D)
P8
73 (RHD L/B)
75 (RHD W/G)
R17
73 (RHD L/B)
75 (RHD W/G)
69 (RHD)
69 (RHD)
67 (RHD)
72 (RHD L/B)
I12
67 (RHD)
74 (RHD W/G)
I14
67 (RHD)
71 (RHD S/D)
T12
70 (RHD S/D)
73 (RHD L/B)
75 (RHD W/G)
72 (RHD L/B)
T13
75 (RHD W/G)
74 (RHD W/G)
T14
75 (RHD W/G)
70 (RHD S/D)
J15
68 (RHD)
72 (RHD L/B)
J16
68 (RHD)
74 (RHD W/G)
J20
68 (RHD)
70 (RHD S/D)
J21
68 (RHD)
70 (RHD S/D)
J22
68 (RHD)
72 (RHD L/B)
J23
68 (RHD)
74 (RHD W/G)
J24
68 (RHD)
70 (RHD S/D)
J25
68 (RHD)
70 (RHD S/D)
J26
68 (RHD)
72 (RHD L/B)
J27
68 (RHD)
75 (RHD W/G)
T10
J30
73 (RHD L/B)
T6
I11
I16
75 (RHD W/G)
64 (*10)
70 (RHD S/D)
70 (RHD S/D)
73 (RHD L/B)
71 (RHD S/D)
74 (RHD W/G)
74 (RHD W/G)
J34
67 (RHD)
74 (RHD W/G)
58 (*7)
72 (RHD L/B)
D13
J33
71 (RHD S/D)
67 (RHD)
70 (RHD S/D)
D12
75 (RHD W/G)
L5
H11
73 (RHD L/B)
67 (RHD)
E10
74 (RHD W/G)
D11
71 (RHD S/D)
J32
71 (RHD S/D)
72 (RHD L/B)
72 (RHD L/B)
D10
75 (RHD W/G)
L4
67 (RHD)
F19
73 (RHD L/B)
64 (*10)
A
72 (RHD L/B)
D9
71 (RHD S/D)
L3
E9
70 (RHD S/D)
75 (RHD W/G)
62 (*9)
70 (RHD S/D)
74 (RHD W/G)
D8
70 (RHD S/D)
67 (RHD)
J31
72 (RHD L/B)
C10
D3
74 (RHD W/G)
74 (RHD W/G)
B10
J30
70 (RHD S/D)
74 (RHD W/G)
72 (RHD L/B)
See Page
74 (RHD W/G)
66 (RHD)
72 (RHD L/B)
Code
71 (RHD S/D)
T15
73 (RHD L/B)
75 (RHD W/G)
U1
69 (RHD)
71 (RHD S/D)
V8
73 (RHD L/B)
75 (RHD W/G)
71 (RHD S/D)
V9
73 (RHD L/B)
75 (RHD W/G)
71 (RHD S/D)
73 (RHD L/B)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
217
AVENSIS (EWD526E)
http://vnx.su

: Relay Blocks
Code
1
See Page
24 (*1)
25 (*2)

26
26
29

Code
4B
4D
See Page
27

CA
CB
CC
CD
34
CE
CF
CG
CH
CI
35
CJ
CK
DA
DB
DC
30
DK
31
DM
31
DN
31
DD
DJ
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
218
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV

Code
ED1
See Page
104 (*10)
106 (RHD)
106 (RHD)
ID1
106 (RHD)
IE1
106 (RHD)
108 (RHD)
108 (RHD)
108 (RHD)
IA1
IA2
IC1
IC2
IC3
IL1
IL2
IM1
IM2
IO1
110 (RHD S/D)

BA1
112 (RHD L/B)
114 (RHD W/G)

110 (RHD S/D)
BB1
112 (RHD L/B)
114 (RHD W/G)

110 (RHD S/D)
BC1
112 (RHD L/B)
114 (RHD W/G)

BD1
BD2
BE1
BE2
BF1
BF2
BG1
BG2
112 (RHD L/B)
112 (RHD L/B)
114 (RHD W/G)
114 (RHD W/G)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
219
AVENSIS (EWD526E)
http://vnx.su

: Ground Points
Code
See Page
98 (*7)
EC
102 (*9)
104 (*10)
IJ
IK
IL
IP
106 (RHD)
Left Kick Panel
106 (RHD)
106 (RHD)
Right Kick Panel
110 (RHD S/D)

BQ
112 (RHD L/B)
114 (RHD W/G)

110 (RHD S/D)
BS
112 (RHD L/B)
114 (RHD W/G)

110 (RHD S/D)
BU
112 (RHD L/B)

114 (RHD W/G)
110 (RHD S/D)
BV
112 (RHD L/B)

114 (RHD W/G)
BX
112 (RHD L/B)

114 (RHD W/G)
: Splice Points
Code
See Page
110 (RHD S/D)

B1
112 (RHD L/B)
Code
See Page
B5
114 (RHD W/G)
B7
110 (RHD S/D)

112 (RHD L/B)
B5
112 (RHD L/B)
112 (RHD L/B)
Front Door RH Wire
114 (RHD W/G)

110 (RHD S/D)
Rear Door No.2 Wire
114 (RHD W/G)

110 (RHD S/D)
Roof Wire
110 (RHD S/D)
Front Door LH Wire
114 (RHD W/G)

B2
B8
Roof Wire
112 (RHD L/B)
Rear Door No.1 Wire
114 (RHD W/G)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
220
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
Memo
221
AVENSIS (EWD526E)
http://vnx.su
1
2
3
4
: Gasoline
: 1CDFTV
: 1AZFSE, 1AZFE
: 1ZZFE, 3ZZFE
25A
DOOR
7. 5A
ECUB 2
WR
19 DB
I14(A)
Integration Relay
7. 5A PANEL
10 CC
B
3 CD
15
16 DB
9 DJ
TRLY
13
9 DA
RY
WB
GW
HRLY
2 A
25
WR
TAIL Relay
INTB
23
15 IC2
RY
(2)
BL
1 DN
C A
C B
1 4D
2
RY
140A ALT
120A ALT (3)

100A ALT (4)
(2)
(1)
1 4B
BG
J 6(A), J 7(B)
Junction
Connector
(1)
(2)
BG
1 ED1
FL MAIN
3. 0W
RY
WB
Battery
IJ
222
AVENSIS (EWD526E)
http://vnx.su
1
5
2
2
WR
1
WR
F8
Headlight LH (Low)
D B
WB
AVENSIS (EWD526E)
http://vnx.su
2
F7
F10
Headlight RH (Low)
F9
(w/ HID)
RB
(w/o HID)
RB
(w/ HID)
WB
2
15A
HLP LH
(w/ HID)
3
2
WB
RB
(w/o HID)
WB
3
RL
WL
1
(w/ HID)
1
2
(w/o HID)
WB
WL
(w/o HID)
DIM Relay
HLP Relay
WB
RY
WR
RY
RL
WB
J 3(A), J 4(B)
Junction
Connector
I14(A)
Integration Relay
14 A
DIM

(See Page 120)
RB
WR
2
40A
MAIN
6 IB1
15A
HLP RH
2
2
E A
E1
J2
Junction
Connector
WB
WB
EC
223
I14(A)
Integration Relay
H
HU
RB
HF
6 A
18
13 A
28 DA
J 6(A), J 7(B)
Junction Connector
2
E A
RY
RL
RL
3
E B
RY
RY
(w/ HID)
D A
J 3(A), J 4(B)
Junction Connector
D A
2
RW
13
Dimmer SW
Light
Control SW
H6
Headlight RH (High)
A B
WB
WB
H5
Headlight LH (High)
3 IC3
RY
RY
RW
RY
10A
HLP
HI RH
(w/o HID)
10A
HLP
HI LH
9 IC3
1
(w/ HID)
RW
OFF
C12
Combination SW
Tail
Head
Flash
Low
High
16
WB
WB
RW
WB
EB
IL : 2
IO : 1
224
AVENSIS (EWD526E)
http://vnx.su
WB
WB
10A
GAUGE1
1
7. 5A
RAD
NO. 1
7. 5A
DOME
21
22
ACC
7 DB
4 DB
IG
I14(A)
Integration Relay
F A
H B
11 A
GR
RW
F A
7 CA
1 IC1
10 IC1
H B
6 CD
WR
2 A
21 B
20 B
RW
14 A
GR
PB
J 8(A), J 9(B)
Junction
Connector
22 A
MPX1
PB
MPX2
J10(A), J11(B)
Junction
Connector
WR
A13(A), A15(B)
BEAN
I/F
MPX+
9 A (7)
10 B (8)
WB
13 A
6 CK
29 B (1AZFSE)
29 A (5)
21 A (2)
MPX2
RL
MPX1
21
28
27
9
18 B
23 A (5)
20 A (2)
1
2
4
5
6
7
8
: Gasoline
: 1CDFTV
: 1ZZFE, 3ZZFE
: 1AZFSE, 1CDFTV
: Automatic A/C
WB
Y
(5)
9 IK1
J16
Junction
Connector
(1AZFSE)
(1AZFE)
(4)
(2)
(5)
WB
6 CA
C
B
A
D
(6)
WB
C10(A), C11(B)
Combination Meter
E 9(A), E10(B),
E11(C), E12(D)
Engine ECU (M/T)
5 B
6 A
RW
High Beam
12 B
RW
MPX
PB
CPU
29 A (7)
20 B (8)
4
L
A11
Alternator
IP
225
AVENSIS (EWD526E)
http://vnx.su

System Outline
When the ignition SW is ON and a signal is input from the alternator, if the light control SW is OFF, the daytime running light
system operates.
When any of the following conditions are met, the daytime running light is canceled.
Ignition SW is turned OFF from ON.
Light control SW is turned to TAIL or HEAD position
Service Hints
I14 (A) Integration Relay
18Ground : Continuity with the light control SW at HEAD position
(A) 2Ground : Always approx. 12 volts
C12 Combination SW
1316 : Closed with the light control SW at HEAD position
716 : Closed with the dimmer SW at HIGH or FLASH position
816 : Closed with the dimmer SW at FLASH position
: Parts Location
Code
See Page
Code
38 (*3)
42 (*5)
A11
38 (*3)
46 (LHD)
A15
46 (LHD)
C10
C11
I14
See Page
A
47 (LHD)
39 (*3)
43 (*5)
J2
45 (*6)
42 (*5)
J3
48 (LHD)
46 (LHD)
44 (*6)
J4
48 (LHD)
46 (LHD)
38 (*3)
J6
48 (LHD)
42 (*5)
J7
48 (LHD)
44 (*6)
J8
48 (LHD)
38 (*3)
J9
48 (LHD)
42 (*5)
J10
48 (LHD)
J11
48 (LHD)
46 (LHD)
F9
F10
47 (LHD)
E10
47 (LHD)
E11
47 (LHD)
E12
47 (LHD)
44 (*6)
38 (*3)
38 (*3)
42 (*5)
F7
Code
42 (*5)
44 (*6)
E9
38 (*3)
F8
44 (*6)
A13
C12
See Page
H5
H6
44 (*6)
J16
48 (LHD)
42 (*5)
44 (*6)
: Relay Blocks
Code
1
See Page
24 (*1)
25 (*2)

26
26
29
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
226
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV

Code
4B
4D
See Page
27

CA
CC
34
CD
CK
35
DA
DB
30
31
DJ
DN

Code
See Page
ED1
84 (*6)
IB1
86 (LHD)
86 (LHD)
88 (LHD)
IC1
IC2
IC3
IK1
: Ground Points
Code
See Page
78 (*3)
EB
82 (*5)
84 (*6)
78 (*3)
EC
82 (*5)
84 (*6)
IJ
86 (LHD)
Left Kick Panel
IL
86 (LHD)
IO
86 (LHD)
IP
86 (LHD)
Right Kick Panel
: Splice Points
Code
E1
See Page
78 (*3)
82 (*5)

Code
E1
See Page
84 (*6)

* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
227
AVENSIS (EWD526E)
http://vnx.su
Headlight (w/o Daytime Running Light)

WL
WR
40A
MAIN
WL
WR
HLP Relay
WL
RY
WR
WR
E A
J 3(A), J 4(B)
Junction
Connector
D B
D B
RY
(2, 3)
J 7(A), J29(B)
Junction
Connector
(1)
RY
RY
C A (2)
E B (3)
C A (2)
E B (3)
RY
C12
Combination SW
13
(2, 3)
Light
Control
SW
OFF
Tail
Dimmer SW
Head
Flash
Low
High
7
WB
16
WB
RW
IL : 4
IO : 5
228
AVENSIS (EWD526E)
http://vnx.su
RW
WB
EC
ED
1
WB
EB
RW
1
2
3
4
5
E1
A
RL
(w/o HID)
B A
B B
1
3
3
J2
Junction
Connector
RW
AVENSIS (EWD526E)
http://vnx.su
D
A
D
A
6 A
(w/o HID)
(w/o HID)
(w/ HID)
RW
RL
C10(A), C11(B)
Combination Meter
2
RL
(w/ HID)
High Beam
10A
HLP HI RH
10A
HLP HI LH
15A
HLP RH
H6
Headlight RH
(High)
RL
RY
(w/ HID)
RW
RB
(w/ HID)
15A
HLP LH
H5
Headlight LH
(High)
RL
(w/o HID)
RW
F10
Headlight RH (Low)
WB
(w/o HID)
(w/o HID)
F9
R
(w/o HID)
WB
F8
Headlight LH (Low)
R
(w/ HID)
(w/ HID)
(w/o HID)
WB
(w/ HID)
WB
WB
F7
WR
WR
J 3(A), J 4(B)
Junction
Connector
D
A
E
B
12 B
B A
J 3(A), J 4(B)
Junction
Connector
B B
(w/ HID)
RW
(w/o HID)
R
: LHD General, RHD w/o HID

: LHD Except General
: RHD w/ HID
: LHD 1CDFTV, RHD
: LHD Gasoline
WB
EA
229
Headlight (w/o Daytime Running Light)

Service Hints
C12 Combination SW
1316 : Closed with the light control SW at HEAD position
816 : Closed with the dimmer SW at FLASH position
716 : Closed with the dimmer SW at HIGH or FLASH position
: Parts Location
Code
C10
See Page
A
C11
F7
See Page
40 (*4)
38 (*3)
42 (*5)
40 (*4)
46 (LHD)
44 (*6)
42 (*5)
F9
58 (*7)
44 (*6)
H6
46 (LHD)
62 (*9)
66 (RHD)
64 (*10)
60 (*8)
38 (*3)
38 (*3)
62 (*9)
40 (*4)
40 (*4)
64 (*10)
42 (*5)
42 (*5)
39 (*3)
44 (*6)
44 (*6)
41 (*4)
58 (*7)
43 (*5)
F10
58 (*7)
62 (*9)
60 (*8)
64 (*10)
62 (*9)
38 (*3)
64 (*10)
61 (*8)
40 (*4)
38 (*3)
63 (*9)
42 (*5)
40 (*4)
65 (*10)
44 (*6)
42 (*5)
58 (*7)
44 (*6)
60 (*8)
F9
Code
66 (RHD)
58 (*7)
F8
See Page
46 (LHD)
66 (RHD)
C12
Code
H5
58 (*7)
45 (*6)
J2
59 (*7)
J3
J4
48 (LHD)
68 (RHD)
48 (LHD)
62 (*9)
60 (*8)
64 (*10)
62 (*9)
J7
68 (RHD)
48 (LHD)
38 (*3)
64 (*10)
J29
68 (RHD)
: Relay Blocks
Code
1
2
See Page
24 (*1)
25 (*2)
26

* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
230
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
: Ground Points
Code
See Page
78 (*3)
80 (*4)
82 (*5)
EA
84 (*6)
98 (*7)
100 (*8)
102 (*9)
104 (*10)
78 (*3)
80 (*4)
82 (*5)
EB
84 (*6)
98 (*7)
100 (*8)
102 (*9)
104 (*10)
78 (*3)
80 (*4)
82 (*5)
EC
84 (*6)
98 (*7)
100 (*8)
102 (*9)
104 (*10)
78 (*3)
80 (*4)
82 (*5)
ED
84 (*6)
98 (*7)
Left Side of the Suspension Tower
100 (*8)
102 (*9)
104 (*10)
IL
IO
86 (LHD)
106 (RHD)
86 (LHD)

: Splice Points
Code
See Page
Code
78 (*3)
E1
80 (*4)
82 (*5)
84 (*6)
See Page
98 (*7)
E1
100 (*8)
102 (*9)
104 (*10)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
231
AVENSIS (EWD526E)
http://vnx.su
Front Fog Light
G
: Gasoline
: 1CDFTV
: w/ Rear Fog Light
: LHD Gasoline
: 1AZFSE, 1AZFE
: 1ZZFE, 3ZZFE
: LHD 1CDFTV, RHD
J30
Junction
Connector
A
3 IC2
A
1
2
3
4
5
6
7
8
9
GY
C A (LHD)
C C (RHD)
J10(A), J11(B),
J26(C), J27(D)
Junction
Connector
C B (LHD)
C D (RHD)
4 DM
24 DA
1
15A
FR FOG
5
10A
TAIL
GY
TAIL
Relay
3
13
1 DN
TRLY
(2)
FR FOG
Relay
12
1
RY
(8)
5 B
WB
(RHD)
6 CG
6 CK
WB
WB
(LHD)
9 DA
IL : 9
IO : 4
IJ
232
AVENSIS (EWD526E)
http://vnx.su
6 CA
WB
Battery
IP
EC
EB
J 3(A), J 4(B)
Junction
Connector
WB
16 DA
2
WB
10
WB
16
(LHD)
C12
Combination SW
F4
Front Fog
Light RH
Front
A A
OFF
A A
WB
Head
F3
Front Fog
Light LH
Tail
Front Fog
OFF
Rear (3)
FL MAIN
3. 0W
7 A
C10(A), C11(B)
Combination Meter
(2)
(1)
1 4B
BG
Light
Control SW
11
C B
14
Fog Light
SW
140A ALT
120A ALT(5)
100A ALT(6)
1 4D
3
5
12 DB
RY
(1)
(2)
BG
23 DA
(7)
1 ED1
BL
Integration
Relay
Service Hints
FR FOG Relay
53 : Closed with the light control SW at TAIL or HEAD position and
the fog light SW at FRONT or REAR (w/ rear fog light) position
: Parts Location
Code
C10
See Page
A
C11
Code
46 (LHD)
F3
64 (*10)
Code
J10
See Page
A
48 (LHD)
66 (RHD)
38 (*3)
J11
48 (LHD)
46 (LHD)
40 (*4)
J26
68 (RHD)
66 (RHD)
42 (*5)
J27
68 (RHD)
46 (LHD)
C12
See Page
F3
44 (*6)
51 (LHD S/D)
66 (RHD)
58 (*7)
53 (LHD L/B)
38 (*3)
62 (*9)
40 (*4)
64 (*10)
42 (*5)
48 (LHD)
73 (RHD L/B)
68 (RHD)
75 (RHD W/G)
44 (*6)
58 (*7)
62 (*9)
F4
J3
J4
A
B
J30
55 (LHD W/G)
71 (RHD S/D)
48 (LHD)
68 (RHD)
: Relay Blocks
Code
3
5
See Page
26
28 (LHD)
28 (RHD)

Code
4B
4D
CA
CG
CK
DA
See Page
27

34
35
30
DM
31
DN
31
DB

Code
ED1
IC2
See Page
84 (*6)
104 (*10)
86 (LHD)
106 (RHD)

* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
233
AVENSIS (EWD526E)
http://vnx.su
Front Fog Light

: Ground Points
Code
See Page
78 (*3)
80 (*4)
82 (*5)
EB
84 (*6)
98 (*7)
102 (*9)
104 (*10)
78 (*3)
80 (*4)
82 (*5)
EC
84 (*6)
98 (*7)
102 (*9)
104 (*10)
IJ
IL
IO
IP
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
86 (LHD)
106 (RHD)
Left Kick Panel

Right Kick Panel
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
234
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
Memo
235
AVENSIS (EWD526E)
http://vnx.su
Rear Fog Light

RY
: Gasoline
: 1CDFTV
: w/ Front Fog Light
: w/o Front Fog Light
: 1AZFSE, 1AZFE
: 1ZZFE, 3ZZFE
: LHD 1CDFTV, RHD
: LHD Gasoline
J30
Junction
Connector
A
A
10 DA
4 DM
7. 5A
RR FOG
R8
Rear Fog
Light Relay
10A
TAIL
TAIL
Relay
2
RY
RY
1
2
3
4
5
6
7
8
11 IC2
13
1 DN
TRLY
WR
(2)
RW
12
23 DA
12 DB
13 IC2
5 IC3
WR
BL
Integration
Relay
8 A
OFF
(RHD)
RW
Fog
Fog
R14(A), (B), (C)

Rear Combination
Light RH
RW
(LHD)
2 A (S/D)
5 B (L/B)
4 C (W/G)
3 A (S/D)
7 B (L/B)
5 C (W/G)
6 A (S/D)
3 B (L/B)
3 C (W/G)
Tail
WB
(RHD)
WB
Rear (4)
WB
Head
OFF
Fog Light
SW
5 A (S/D)
1 B (L/B)
2 C (W/G)
(LHD)
Light
Control SW
(1)
BG
1 4B
(2)
5 B
12
14
R13(A), (B), (C)

Rear Combination
Light LH
Rear Fog
RW
C10(A), C11(B)
Combination Meter
140A ALT
(w/ Daytime Running Light)
2
120A ALT(5)
100A ALT(6)
1 4D
(w/o Daytime Running Light)
(1)
(2)
BG
1 ED1
Rear (3)
6 CG
6 CK
WB
16 DA
WB
10
WB
16
(RHD)
C12
Combination SW
(LHD)
FL MAIN
3. 0W
Battery
9 DA
6 CA
IL : 7
IO : 8
IJ
WB
WB
(LHD)
WB
IP
236
AVENSIS (EWD526E)
http://vnx.su
BS
BT
Service Hints
R8 Rear Fog Light Relay
53 : Closed with the light control SW at TAIL or HEAD position and the fog light SW at REAR position
: Parts Location
Code
C10
See Page
A
C11
Code
46 (LHD)
66 (RHD)
C12
J30
Code
51 (LHD S/D)
53 (LHD L/B)
55 (LHD W/G)
66 (RHD)
73 (RHD L/B)
71 (RHD S/D)
46 (LHD)
75 (RHD W/G)
73 (RHD L/B)
66 (RHD)
49 (LHD)
75 (RHD W/G)
51 (LHD S/D)
55 (LHD W/G)
See Page
A
71 (RHD S/D)
46 (LHD)
See Page
53 (LHD L/B)
J30
R8
R13
R14
69 (RHD)
: Relay Blocks
Code
3
See Page
26


Code
4B
4D
CA
CG
CK
DA
See Page
27

34
35
30
DM
31
DN
31
DB

Code
ED1
IC2
IC3
See Page
84 (*6)
104 (*10)

86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
237
AVENSIS (EWD526E)
http://vnx.su
Rear Fog Light

: Ground Points
Code
IJ
IL
IO
IP
See Page
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
86 (LHD)
106 (RHD)

Left Kick Panel
Right Kick Panel
90 (LHD S/D)
92 (LHD L/B)
BS
94 (LHD W/G)
110 (RHD S/D)
112 (RHD L/B)

114 (RHD W/G)
90 (LHD S/D)
92 (LHD L/B)
BT
94 (LHD W/G)
110 (RHD S/D)
112 (RHD L/B)
114 (RHD W/G)
Lower Back Panel Center

Lower Back Panel Right
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
238
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
Memo
239
AVENSIS (EWD526E)
http://vnx.su
Taillight
G
BG
(3)
BL
(4)
4 DM
1 DN
5
TAIL
Relay
(4)
BL
13
1 ED1
TRLY
10A
TAIL
(4)
(3)
12
23 DA
1 4D
12 DB
9 DL
8 DL
140A ALT
1
(2)
120A ALT (8)

100A ALT (9)
(1)
BG
Integration
Relay
1 4B
J1
Junction
Connector
3
A
OFF
Head
C12
Combination SW
WB
WB

: Gasoline
: 1CDFTV
: LHD 1CDFTV, RHD
: LHD Gasoline
: L/B, W/G
: 1AZFSE, 1AZFE
: 1ZZFE, 3ZZFE
WB
Battery
1
2
3
4
5
6
7
8
9
F2
F1
16
FL MAIN
3. 0L
Tail
Light
Control SW
(4)
(3)
BG
14
WB
WB
(LHD)
(LHD)
IL : 5
IO : 6
240
AVENSIS (EWD526E)
http://vnx.su
EC
EB
A A
J30(A), J31(B)
Junction Connector
A A
3 IC2
A B
A B
A B
A B
(7)
A B
(W/G)
(L/B)
(S/D)
C A (LHD)
C B (RHD)
(S/D)
J10(A), J26(B)
Junction Connector
3 BD2 (L/B)
1 BF2 (W/G)
C A (LHD)
C B (RHD)
J33(A), J34(B)
Junction Connector
L2
License Plate
Light RH
G
2
(7)
WB
(7)
J31(B)
Junction
Connector
WB
C B
J16
Junction
Connector
A
C B
WB
WB
WB
(RHD)
WB
(LHD)
(7)
C B
L1
License Plate
Light LH
C B
(7)
6 A (S/D)
3 B (L/B)
3 C (W/G)
C B
(W/G)
G
B A
Tail
R14(A), (B), (C)

WB
WB
4 A (S/D)
2 B (L/B)
2 C (W/G)
(S/D)
L2
License Plate Light RH
(S/D)
2 A (S/D)
5 B (L/B)
4 C (W/G)
L1
License Plate Light LH
C10(A), C11(B)
Combination Meter
Tail
17 A
Tail
R13(A), (B), (C)

G
14 B
4 A (S/D)
6 B (L/B)
5 C (W/G)
6 BG2
(L/B)
3 BE2
J17
Junction
Connector
A B
A B
J15
Junction
Connector
(LHD)
IK
(7)
WB
WB
A
WB
J34(B)
Junction
Connector
(S/D)
WB
(RHD)
A B
WB
BS
BT
BX
241
AVENSIS (EWD526E)
http://vnx.su
Taillight
Service Hints
C12 Combination SW
1416 : Closed with the light control SW at TAIL or HEAD position
: Parts Location
Code
C10
See Page
A
C11
Code
See Page
46 (LHD)
61 (*8)
66 (RHD)
J1
46 (LHD)
66 (RHD)
C12
63 (*9)
51 (LHD S/D)
65 (*10)
53 (LHD L/B)
48 (LHD)
55 (LHD W/G)
L1
J15
68 (RHD)
J16
48 (LHD)
73 (RHD L/B)
38 (*3)
J17
68 (RHD)
75 (RHD W/G)
68 (RHD)
51 (LHD S/D)
42 (*5)
51 (LHD S/D)
53 (LHD L/B)
44 (*6)
53 (LHD L/B)
58 (*7)
55 (LHD W/G)
J26
J30
71 (RHD S/D)
55 (LHD W/G)
L2
71 (RHD S/D)
71 (RHD S/D)
73 (RHD L/B)
62 (*9)
73 (RHD L/B)
75 (RHD W/G)
64 (*10)
75 (RHD W/G)
38 (*3)
51 (LHD S/D)
40 (*4)
53 (LHD L/B)
42 (*5)
55 (LHD W/G)
44 (*6)
J31
73 (RHD L/B)
60 (*8)
75 (RHD W/G)
62 (*9)
53 (LHD L/B)
39 (*3)
J33
55 (LHD W/G)
73 (RHD L/B)
41 (*4)
75 (RHD W/G)
43 (*5)
53 (LHD L/B)
45 (*6)
59 (*7)
J34
A
R13
71 (RHD S/D)
58 (*7)
64 (*10)
J1
75 (RHD W/G)
66 (RHD)
60 (*8)
F2
See Page
B
46 (LHD)
40 (*4)
F1
J10
Code
J34
B
C
A
R14
B
C
51 (LHD S/D)
71 (RHD S/D)
53 (LHD L/B)
73 (RHD L/B)
55 (LHD W/G)
75 (RHD W/G)
51 (LHD S/D)
71 (RHD S/D)
53 (LHD L/B)
73 (RHD L/B)
55 (LHD W/G)
75 (RHD W/G)
55 (LHD W/G)
73 (RHD L/B)
: Relay Blocks
Code
3
See Page
26


Code
4B
See Page
27
30
DL
31
DM
31
DN
31
4D
DA
DB
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
242
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV

Code
ED1
IC2
BD2
BE2
BF2
BG2
See Page
84 (*6)
104 (*10)
86 (LHD)
106 (RHD)
92 (LHD L/B)
112 (RHD L/B)
92 (LHD L/B)
112 (RHD L/B)
94 (LHD W/G)
114 (RHD W/G)
94 (LHD W/G)
114 (RHD W/G)

: Ground Points
Code
See Page
78 (*3)
80 (*4)
82 (*5)
EB
84 (*6)
98 (*7)
100 (*8)
102 (*9)
104 (*10)
78 (*3)
80 (*4)
82 (*5)
EC
84 (*6)
98 (*7)
100 (*8)
102 (*9)
104 (*10)
IK
IL
IO
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
90 (LHD S/D)
92 (LHD L/B)
BS
94 (LHD W/G)
110 (RHD S/D)
112 (RHD L/B)

114 (RHD W/G)
90 (LHD S/D)
92 (LHD L/B)
BT
94 (LHD W/G)
110 (RHD S/D)
112 (RHD L/B)
114 (RHD W/G)

92 (LHD L/B)
BX
94 (LHD W/G)
112 (RHD L/B)
114 (RHD W/G)

* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
243
AVENSIS (EWD526E)
http://vnx.su
Turn Signal and Hazard Warning Light

2
27 DA
+B
IG
LL
LR
RW
GY
(LHD)
GY
(RHD)
GW
(RHD)
GW
2 IE3 (LHD)
2 IO1 (RHD)
(LHD)
8 CA
T10
RW
7. 5A
GAUGE2
10A HAZARD
GY
GY
(LHD)
GY
E B
(RHD)
J22(A), J23(B)
Junction
Connector
(RHD)
GW
(LHD)
6 DB
GW
D B
(LHD)
GW
GY
J5
Junction
Connector
D
E A
(RHD)
E A
(LHD)
GY
F A
(RHD)
GW
F A
(RHD)
GW
J5
Junction
Connector
(RHD)
6 CC
15 DB
5 DL
4 DL
F5
Front Side Turn
Signal Light LH
WB
GY
Turn RH
C10(A), C11(B)
Combination Meter
17 A
3 A (w/ HID)
3 B (w/o HID)
4 A (w/ HID)
4 B (w/o HID)
WB
WB
WB
(RHD)
4 A (w/ HID)
4 B (w/o HID)
WB
2 A (S/D)
5 B (L/B)
4 C (W/G)
F 7(A), F 8(B)
Front Turn Signal
Light LH
13 B
Turn LH
GW
3 A (w/ HID)
3 B (w/o HID)
GW
GW
3 A (S/D)
3 B (L/B)
3 C (W/G)
Turn
R13(A), (B), (C)

Rear Combination
Light LH
1 B
F 9(A), F10(B)
Front Turn Signal
Light RH
3 DL
(LHD)
17 DM
J17
Junction
Connector
E2
E1
WB
WB
WB
WB
(RHD)
WB
WB
WB
BS
J15
Junction
Connector
EC
IK
244
AVENSIS (EWD526E)
http://vnx.su
EB
(LHD)
WB
T10
GND
EHW
LG
(LHD)
LG
WB
(RHD)
Off
B B (LHD)
D D (RHD)
H13
Hazard SW
LH
Turn SW
C12
Combination SW
D A (LHD)
F C (RHD)
J10(A), J11(B),
J24(C), J25(D)
Junction
Connector
D A
F C
LG
WB
LG
GY
ER
6
GW
EL
5
RH
2
LG
WB
(RHD)
WB
(LHD)
(RHD)
WB
WB
(LHD)
6 IC2
15
11 DM
3 CH
11 CF
6 CA
FRLY
I14
Integration Relay
WB
WB
(RHD)
GY
GY
6 DL
9 CD
5 A (S/D)
5 B (L/B)
4 C (W/G)
WB
(RHD)
WB
WB
(LHD)
Turn
6 A (S/D)
3 B (L/B)
3 C (W/G)
(LHD)
R14(A), (B), (C)

Rear Combination
Light RH
F6
Front Side Turn
Signal Light RH
WB
WB
IL : 1CDFTV
IO : 1
(LHD)
WB
BT
J16
Junction
Connector
1 : Gasoline
IP
WB
(LHD)
WB
J16
Junction
Connector
(RHD)
(LHD)
WB
WB
WB
WB
IL
245
AVENSIS (EWD526E)
http://vnx.su

Service Hints
T10 Turn Signal Flasher Relay
: Parts Location
Code
C10
See Page
46 (LHD)
C11
66 (RHD)
B
C12
62 (*9)
See Page
47 (LHD)
I14
64 (*10)
67 (RHD)
66 (RHD)
40 (*4)
J10
48 (LHD)
46 (LHD)
42 (*5)
J11
48 (LHD)
66 (RHD)
44 (*6)
F8
J5
48 (LHD)
J15
58 (*7)
68 (RHD)
48 (LHD)
J16
40 (*4)
60 (*8)
42 (*5)
62 (*9)
44 (*6)
64 (*10)
J22
68 (RHD)
58 (*7)
38 (*3)
J23
68 (RHD)
60 (*8)
40 (*4)
J24
68 (RHD)
62 (*9)
42 (*5)
J25
68 (RHD)
F9
58 (*7)
40 (*4)
62 (*9)
42 (*5)
64 (*10)
44 (*6)
38 (*3)
58 (*7)
40 (*4)
60 (*8)
42 (*5)
62 (*9)
44 (*6)
F10
58 (*7)
38 (*3)
60 (*8)
40 (*4)
62 (*9)
42 (*5)
64 (*10)
44 (*6)
58 (*7)
H13
47 (LHD)
67 (RHD)
68 (RHD)
J17
44 (*6)
38 (*3)
64 (*10)
F7
Code
38 (*3)
64 (*10)
F6
F7
See Page
46 (LHD)
38 (*3)
F5
Code
68 (RHD)
A
R13
B
C
A
R14
B
C
T10
51 (LHD S/D)
71 (RHD S/D)
53 (LHD L/B)
73 (RHD L/B)
55 (LHD W/G)
75 (RHD W/G)
51 (LHD S/D)
71 (RHD S/D)
53 (LHD L/B)
73 (RHD L/B)
55 (LHD W/G)
75 (RHD W/G)
49 (LHD)
69 (RHD)
: Relay Blocks
Code
1
See Page
24 (*1)
25 (*2)


Code
See Page
CA
CC
CD
34
CF
CH
DA
35
30
DL
31
DM
31
DB
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
246
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV

Code
IC2
See Page
86 (LHD)
106 (RHD)

IE3
86 (LHD)
IO1
108 (RHD)
: Ground Points
Code
See Page
78 (*3)
80 (*4)
82 (*5)
EB
84 (*6)
98 (*7)
100 (*8)
102 (*9)
104 (*10)
78 (*3)
80 (*4)
82 (*5)
EC
84 (*6)
98 (*7)
100 (*8)
102 (*9)
104 (*10)
IK
IL
IO
IP
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
86 (LHD)
106 (RHD)

Right Kick Panel
90 (LHD S/D)
92 (LHD L/B)
BS
94 (LHD W/G)
110 (RHD S/D)
112 (RHD L/B)

114 (RHD W/G)
90 (LHD S/D)
92 (LHD L/B)
BT
94 (LHD W/G)
110 (RHD S/D)
112 (RHD L/B)
114 (RHD W/G)

* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
247
AVENSIS (EWD526E)
http://vnx.su

: Splice Points
Code
E1
See Page
Code
See Page
78 (*3)
78 (*3)
80 (*4)
80 (*4)
82 (*5)
82 (*5)
84 (*6)
98 (*7)
E2
84 (*6)
98 (*7)
100 (*8)
100 (*8)
102 (*9)
102 (*9)
104 (*10)
104 (*10)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
248
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
Memo
249
AVENSIS (EWD526E)
http://vnx.su
Stop Light
15A
STOP
22 DA
GW
B4
GW
(LHD)
C A
(L/B)
WB
WB
A A
J33(A), J34(B)
Junction
Connector
BS
BT
250
AVENSIS (EWD526E)
http://vnx.su
WB
(L/B, W/G)
WB
WB
WB
4 BG1
(W/G)
A B
(S/D)
C B
WB
(L/B)
GW
6 A (S/D)
3 B (L/B)
3 C (W/G)
R14(A), (B), (C)

Rear Combination
Light RH
2 A (S/D)
5 B (L/B)
4 C (W/G)
7 A (S/D)
4 B (L/B)
1 C (W/G)
Stop
1 A (S/D)
4 B (L/B)
6 C (W/G)
B A
J30(A), J31(B)
Junction
Connector
L
(W/G)
Stop
(S/D)
R13(A), (B), (C)

Rear Combination
Light LH
J32
Junction
Connector
H20
High Mounted
Stop Light
GW
(S/D)
B B
GW
B B
WB
1 BE1
J30(A), J31(B)
Junction
Connector
WB
C A
GW
C A
(W/G)
(S/D)
H20
High Mounted
Stop Light
GW
GW
GW
(L/B, W/G)
1 DM
(L/B)
1 BD1 (L/B)
3 BF1 (W/G)
2 DA
BX
N8
Noise Filter
(Stop Light)
GW
(L/B, W/G)
GW
6 IE3
(RHD)
GW
1 IR1
(L/B, W/G)
GW
2 IR1
(RHD)
11 IE3
GW
(LHD)
(L/B, W/G)
RW
S13
Stop Light SW
(LHD)
RW
(RHD)
RW
(RHD)
RW
(LHD)
Service Hints
S13 Stop Light SW
21 : Closed with the brake pedal depressed
: Parts Location
Code
See Page
50 (LHD S/D)
H20
Code
J31
51 (LHD S/D)
54 (LHD W/G)
53 (LHD L/B)
70 (RHD S/D)
55 (LHD W/G)
J32
73 (RHD L/B)
51 (LHD S/D)
75 (RHD W/G)
53 (LHD L/B)
53 (LHD L/B)
55 (LHD W/G)
55 (LHD W/G)
75 (RHD W/G)
53 (LHD L/B)
J34
71 (RHD S/D)
53 (LHD L/B)
73 (RHD L/B)
N8
R13
B
C
A
R14
B
C
73 (RHD L/B)
75 (RHD W/G)
75 (RHD W/G)
A
55 (LHD W/G)
55 (LHD W/G)
See Page
73 (RHD L/B)
N8
73 (RHD L/B)
75 (RHD W/G)
53 (LHD L/B)
B
J33
73 (RHD L/B)
51 (LHD S/D)
J31
71 (RHD S/D)
74 (RHD W/G)
71 (RHD S/D)
Code
75 (RHD W/G)
52 (LHD L/B)
72 (RHD L/B)
J30
See Page
B
S13
51 (LHD S/D)
71 (RHD S/D)
53 (LHD L/B)
73 (RHD L/B)
55 (LHD W/G)
75 (RHD W/G)
51 (LHD S/D)
71 (RHD S/D)
53 (LHD L/B)
73 (RHD L/B)
55 (LHD W/G)
75 (RHD W/G)
49 (LHD)
69 (RHD)
55 (LHD W/G)

Code
See Page
DA
30
DM
31

Code
See Page
IE3
86 (LHD)
IR1
108 (RHD)
BD1
BE1
BF1
BG1
92 (LHD L/B)
112 (RHD L/B)
92 (LHD L/B)
112 (RHD L/B)
94 (LHD W/G)
114 (RHD W/G)
94 (LHD W/G)
114 (RHD W/G)
251
AVENSIS (EWD526E)
http://vnx.su
Stop Light
: Ground Points
Code
See Page
90 (LHD S/D)
92 (LHD L/B)
BS
94 (LHD W/G)
110 (RHD S/D)
112 (RHD L/B)

114 (RHD W/G)
90 (LHD S/D)
92 (LHD L/B)
BT
94 (LHD W/G)
110 (RHD S/D)
112 (RHD L/B)
114 (RHD W/G)

92 (LHD L/B)
BX
94 (LHD W/G)
112 (RHD L/B)
114 (RHD W/G)
: Splice Points
Code
B4
See Page
92 (LHD L/B)
94 (LHD W/G)

Floor Wire
Code
B4
See Page
112 (RHD L/B)
114 (RHD W/G)
252
AVENSIS (EWD526E)
http://vnx.su

Floor Wire
Memo
253
AVENSIS (EWD526E)
http://vnx.su
BackUp Light
7. 5A
GAUGE2
27 DA
RY
(2)
RY
J5
Junction
Connector
(2)
RW
RY
(LHD S/D 5 1)
C
5 IK1
1 CD
(2)
RY
RY
(RHD)
(7)
RB
RY(6)
8 CA
RY
RB
(3)
RB
(LHD 4, LHD L/B, LHD W/G)
RB
J32
Junction
Connector
RB
1 IK1
(RHD 4, RHD L/B, RHD W/G)
(RHD)
RY
C B
(3)
A A
3 A (A/T)
2 B (M/T)
8 IC2
J22(A), J23(B)
Junction
Connector
2 A (A/T)
1 B (M/T)
RW
N 1(A)
Neutral Start SW
B 1(B)
BackUp Light SW
RW
(RHD)
RB
(3)
BackUp
BackUp
2 A (S/D)
5 B (L/B)
4 C (W/G)
6 A (S/D)
3 B (L/B)
3 C (W/G)
WB
: LHD Except S/D 5 1

: S/D w/o Rear Fog Light
: S/D w/ Rear Fog Light
: 1ZZFE M/T, 3ZZFE
: 1AZFSE A/T, 1AZFE A/T, 1ZZFE, 3ZZFE, 1CDFTV
: 1AZFSE M/T, 1AZFE M/T
R14(A), (B), (C)

Rear Combination
Light RH
2
3
4
5
6
7
WB
R13(A), (B), (C)

Rear Combination
Light LH
2 A (S/D)
6 A (S/D)
6 B (L/B)
2 B (L/B)
6 C (W/G)
1 w/o
C (W/G)
1 : w/o Winter Package, w/o Moon Roof, w/o Rear Power Window, w/o Headlight Cleaner,
Front Fog Light, w/o Daytime Running Light or w/o MultiDisplay
WB
BS
254
AVENSIS (EWD526E)
http://vnx.su
BT
Service Hints
B1 (B) BackUp Light SW (M/T)
(B) 2(B) 1 : Closed with the shift lever in R position
N1 (A) Neutral Start SW (A/T)
(A) 3(A) 2 : Closed with the shift lever in R position
: Parts Location
Code
See Page
38 (*3)
Code
J23
40 (*4)
B
J5
J22
71 (RHD S/D)
44 (*6)
39 (*3)
58 (*7)
41 (*4)
62 (*9)
43 (*5)
64 (*10)
N1
Code
68 (RHD)
51 (LHD S/D)
J32
42 (*5)
B1
See Page
B
59 (*7)
48 (LHD)
61 (*8)
68 (RHD)
63 (*9)
See Page
A
R13
71 (RHD S/D)
73 (RHD L/B)
75 (RHD W/G)
A
R14
51 (LHD S/D)
51 (LHD S/D)
71 (RHD S/D)
53 (LHD L/B)
55 (LHD W/G)

Code
CA
CD
DA
See Page
34
30

Code
IC2
IK1
See Page
86 (LHD)
106 (RHD)
88 (LHD)
108 (RHD)

: Ground Points
Code
See Page
90 (LHD S/D)
92 (LHD L/B)
BS
94 (LHD W/G)
110 (RHD S/D)
112 (RHD L/B)

114 (RHD W/G)
90 (LHD S/D)
92 (LHD L/B)
BT
94 (LHD W/G)
110 (RHD S/D)
112 (RHD L/B)
114 (RHD W/G)

* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
255
AVENSIS (EWD526E)
http://vnx.su
Illumination
1
2
3
4
5
6
7
8
: Gasoline
: 1CDFTV
: LHD 1CDFTV, RHD
: LHD Gasoline
: 1CDFTV Power Heater (Hot Gas Type)
5 CA
8 CI
G
A A
(3)
(4)
A A
(8)
J30(A)
Junction
Connector
3 IC2
GW
(3)
6 DJ
4 DM
P5
Power Heater SW
TAIL Relay
2
9 DJ
7. 5A PANEL
(2)
BL
19 DB
10A TAIL
1 DN
1 ED1
WB
(LHD)
OFF
Tail
Head
C12
Combination SW
16
WB
Battery
(8)
(4)
WB
23 DA
14
Light
Control SW
(1)
BG
FL MAIN
3. 0W
12
12 DB
1 4B
(2)
Integration Relay
(3)
TOUT
140A ALT
14
INTB
1 4D

15
TRLY
(1)
(2)
BG
13
A
WB
IL : 5
IO : 6
256
AVENSIS (EWD526E)
http://vnx.su
J16
Junction
Connector
1 CJ
11 CA
G
10A
GAUGE1
7. 5A
DOME
2
G
C A (LHD)
C C (RHD)
F A
F C
C A
C C
H B
J10(A), J11(B), J26(C)

Junction
Connector
1
21 A (7)
23 B (Automatic A/C)
WB
(RHD)
WB
(LHD)
WB
Tail
Illumination
C10(A), C11(B)
Combination Meter
(RHD)
CPU
A13(A), A16(B)
A/C Control
Assembly
GND
40 A (7)
WB
14 B
ILL+
(LHD)
20 B
G3
Glove Box Light
WR
RW
21 B
(LHD)
(RHD)
WR
WR
RW
F C
7 CA
6 CD
7 DB
17 A
5 B
WB
(LHD)
WB
(RHD)
WB
(RHD)
WB
(RHD)
WB
6 CK
9 CD
3 CG
J17
Junction
Connector
6 CA
WB
WB
(RHD)
J15
Junction
Connector
IK
IP
257
AVENSIS (EWD526E)
http://vnx.su
Illumination
H13
Hazard SW
T9
TRC Off SW
3 CI
(w/ VSC)
(w/ Front Window Deicer)
F20
Front Wiper Deicer SW
WB
(RHD)
WB
(LHD)
WB
(17)
WB
(LHD w/ VSC)
WB
(w/ Front Window Deicer)
WB
WB
ILL
3 CJ
(11)
WB
(w/ Headlight Cleaner)
(9)
WB
(10)
(11)
GND
TAIL
(10)
13
ILL+
M1
MultiDisplay
8 CJ
10
3
M1
MultiDisplay
1 CH
(w/ Headlight Cleaner)
H16
H15
Headlight Beam Level
Control SW
2 CJ
(9)
8 CK
WB
(RHD)
WB
(17)
11 CE
5 CI
2 CI (LHD)
5 CD (RHD)
10 CH
4 CG
5 CJ
9 : w/ Headlight Beam Level Control w/o HID

10 : w/ Navigation System (Map Type)
11 : w/ MultiDisplay w/o Navigation System (Map Type)
13 : w/ Steering SW
15 : w/ Seat Heater
16 : w/ MultiDisplay
17 : RHD w/ VSC
258
AVENSIS (EWD526E)
http://vnx.su
11 CJ
8 CH
2 CH
G
E
(12)
J 8(A), J 9(B)
Junction Connector
H A
J19
Junction
Connector
(LHD)
G
G
F B
F B
5 (LHD)
4 (RHD)
H A
F B
F B
E8
ECT Pattern
Select SW
3
10
WB
WB
(15)
(15)
J32
Junction
Connector
EAU
C14
Combination SW
(16)
(14)
WB
WB
WB
(RHD)
WB
(LHD)
S7
Seat Heater SW
P8
Personal Light
(16)
(RHD)
8 IC1
6
ILL+
7 ID1
(LHD 13)
(LHD 14)
E
8 (LHD)
1 (RHD)
(RHD 13)
ILL+
(15)
(LHD)
G
(RHD)
(RHD 14)
F19
(RHD)
4 CD
WB
WB
(13)
WB
(13)
WB
(17)
J30(A), J31(B)
Junction
Connector
WB
WB
(RHD)
WB
(RHD)
WB
(RHD)
WB
(17)
6 DK
B A
9 DA
A
C B
IL
WB
WB
IJ
(15)
J16
Junction
Connector
WB
12 CF (LHD)
9 CH (RHD)
(RHD)
9 CH
(15)
(RHD)
BS
259
AVENSIS (EWD526E)
http://vnx.su
4 CI
7 CH
Illumination
1 CF
12 CA

13 : w/ Steering SW
10 A
ILL+
GND
6 D
GND
7 A
R 4(A), R 7(D)
Radio and Player
GND
ILL
T7
C7
Cigarette Lighter
Illumination
WB
(RHD)
R11
Remote Controller
(Navigation)
P5
Power Heater SW
(12)
(12)
WB
WB
(13)
(13)
J17
Junction
Connector
WB
WB
(LHD)
J15
Junction
Connector
(RHD)
IK
IP
260
AVENSIS (EWD526E)
http://vnx.su
IN
WB
BR
(LHD)
WB
WB
WB
(LHD)
WB
(12)
(RHD)
WB
(RHD)
Service Hints
C12 Combination SW
1416 : Closed with the light control SW at TAIL or HEAD position
: Parts Location
Code
A13
See Page
A
A16
C7
C11
48 (LHD)
46 (LHD)
J9
48 (LHD)
66 (RHD)
J10
48 (LHD)
46 (LHD)
J11
48 (LHD)
J15
66 (RHD)
C12
66 (RHD)
66 (RHD)
47 (LHD)
E8
F19
F20
J26
H15
68 (RHD)
75 (RHD W/G)
68 (RHD)
55 (LHD W/G)
71 (RHD S/D)
47 (LHD)
73 (RHD L/B)
67 (RHD)
75 (RHD W/G)
51 (LHD S/D)
J31
47 (LHD)
71 (RHD S/D)
73 (RHD L/B)
67 (RHD)
67 (RHD)
55 (LHD W/G)
P8
48 (LHD)
53 (LHD L/B)
47 (LHD)
H13
53 (LHD L/B)
47 (LHD)
A
69 (RHD)
51 (LHD S/D)
51 (LHD S/D)
J30
49 (LHD)
P5
68 (RHD)
68 (RHD)
C
68 (RHD)
48 (LHD)
67 (RHD)
47 (LHD)
G3
J19
48 (LHD)
M1
68 (RHD)
J17
46 (LHD)
C14
55 (LHD W/G)
48 (LHD)
J16
46 (LHD)
53 (LHD L/B)
J32
67 (RHD)
A
46 (LHD)
See Page
51 (LHD S/D)
47 (LHD)
J8
66 (RHD)
Code
67 (RHD)
H16
46 (LHD)
66 (RHD)
See Page
H15
66 (RHD)
C10
Code
46 (LHD)
53 (LHD L/B)
55 (LHD W/G)
R4
R7
D
R11
S7
T7
T9
49 (LHD)
69 (RHD)
49 (LHD)
69 (RHD)
49 (LHD)
69 (RHD)
49 (LHD)
49 (LHD)
69 (RHD)
49 (LHD)
69 (RHD)
: Relay Blocks
Code
See Page
26
29
261
AVENSIS (EWD526E)
http://vnx.su
Illumination
Code
4B
4D
See Page
27

CA
CD
CE
34
CF
CG
CH
CI
35
CJ
CK
DA
DB
30
DJ
DK
31
DM
31
DN
31

Code
ED1
IC1
IC2
ID1
See Page
84 (*6)
104 (*10)

86 (LHD)
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
: Ground Points
Code
IJ
IK
IL
IN
IO
IP
See Page
86 (LHD)
106 (RHD)

Left Kick Panel
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
86 (LHD)
106 (RHD)
Instrument Panel Reinforcement Center

Right Kick Panel
90 (LHD S/D)
BS
92 (LHD L/B)
94 (LHD W/G)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
262
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
Memo
263
AVENSIS (EWD526E)
http://vnx.su
Interior Light (LHD)

25A DOOR
7. 5A ECUB 2
I14(A)
Integration Relay
B
1
B
23
ACC
IG
21

(See Page 120)
22
MPX2
MPX1
22 A
11 A
10A
GAUGE1
4 DB
7. 5A
RAD
NO. 1
PB
WR
WR
16 DB
1 IC1
10 IC1
7 DB
WR
P
14 A
Door
BEAN
I/F
E 9(A), E10(B)
Engine ECU (M/T)
CPU
C10(A), C11(B)
Combination Meter
13 A
1
2
3
4
5
6

: 1CDFTV
: Automatic A/C
: w/ Engine Immobiliser System
: w/o Engine Immobiliser System
WB
5 B
6 CK
WB
6 CA
IP
264
AVENSIS (EWD526E)
http://vnx.su
20 B
29 A (3)
20 B (4)
MPX
MPX+
9 A (3)
10 B (4)
PB
21 B
29 B (1AZFSE)
29 A (1)
21 A (2)
MPX2
MPX1
18 B (1AZFSE)
23 A (1)
20 A (2)
2 A
A13(A), A15(B)
6 CD
PB
RW
H B
RW
7 CA
GR
WR
F A
J 8(A), J 9(B)
Junction
Connector
3 CD
GR
10 CC
I14(A)
Integration Relay
LP
6
1 DA
7 DK
WG
WG

(See Page 120)
7. 5A
DOME
2
6
WR
WR
H B
H B
J10(A), J11(B)
Junction Connector
6 A (6)
6 B (5)
ILL
ILL+
2 A (6)
2 B (5)
WR
WR
F A
WR
4 ID1
WR
WR
B5
WR
WR
WR
B5
B5
WB
D3
Diode
WB
WB
P8
Personal Light
V8
Vanity Light LH
V9
Vanity Light RH
WB
F A
I11(A), I12(B)
WR
H B
WR
WR
WR
B5
B
WG
WB
265
AVENSIS (EWD526E)
http://vnx.su
WB
B A
C B
WB
BS
WR
5 IC2
1
10
1
IL1
F A
F A
H B
H B
9 DA
6 DK
2 DK
WB
WB
WG
2 DB
I16
Interior Light
LGCY
3
1
10 IA1
J 6(A), J 7(B)
Junction
Connector
WB
B5
IJ
266
AVENSIS (EWD526E)
http://vnx.su
4
3
WB
D7
IL1
J32
Junction Connector
RY
(S/D)
1 A
WR
D8
11
WR
L5
(S/D)
WR
RY
(S/D)
WB
WR
(S/D)
L3
WR
WR
F A
WR
WR
R17
Rear Interior Light
J30(A), J31(B)
Junction Connector
WB
(S/D)
(7)
RY
WB
(S/D)
RY
WB
(S/D)

I14(A)
Integration Relay
25
E
A
11 IA1
2
WR
(7)
11 ID1
R
WB
RY
(7)
1
1
(7)
AVENSIS (EWD526E)
http://vnx.su
8 BE2
RY
(W/G)
(7)
RY
RY
RY
(L/B)
(W/G)
18 IM1
B7
Back Door
Courtesy SW
RY
9 IM1
(L/B)
4 IC2
(7)
RY
(7)
12 DM
RY
9 DC
D12
WG
13 DB
WG
16
WG
RCTY
D11
WG
PCTY
(7)
WB
D10
DCTY
17
(7)
WB
R
14 IC2
D B
B A
D9
B A
J10(A), J11(B)
Junction Connector
I14(A)
Integration Relay
12 A
BDCY
13 DM
J32
Junction
Connector
8 BD2 (L/B)
2 BF2 (W/G)
5 BG2
7 : L/B, W/G
J34
Junction
Connector
RY
BX
267

System Outline
Illuminated Entry System
1. Light on Condition
The light comes on when either of the following conditions is met:
When any of the doors is open (Except the luggage compartment door (S/D) or back door (L/B, W/G) ).
When all doors are closed and the ignition SW is set to OFF.
2. Light off Condition
The light gradually goes off when any of the following conditions is met (The dome light must be turned on):
When the ignition SW is kept in the ON position for more than approximately 12 to 18 seconds after all doors are closed.
When all doors are closed and the drivers and front passengers side doors are locked.
When all doors are closed and the ignition SW is set to ACC or ON.
Service Hints
D9, D10, D11, D12 Door Courtesy SW Front LH, RH, Rear LH, RH
1Ground : Continuity with the door open
Integration Relay
: Parts Location
Code
See Page
A13
46 (LHD)
A15
46 (LHD)
Code
See Page
52 (LHD L/B)
D11
50 (LHD S/D)
54 (LHD W/G)
J31
53 (LHD L/B)
55 (LHD W/G)
C10
46 (LHD)
C11
46 (LHD)
E9
47 (LHD)
47 (LHD)
E10
47 (LHD)
L3
51 (LHD S/D)
50 (LHD S/D)
I11
47 (LHD)
L5
51 (LHD S/D)
52 (LHD L/B)
I12
47 (LHD)
54 (LHD W/G)
I14
47 (LHD)
D3
D7
54 (LHD W/G)
51 (LHD S/D)
51 (LHD S/D)
J32
52 (LHD L/B)
D12
See Page
B
54 (LHD W/G)
52 (LHD L/B)
B7
Code
50 (LHD S/D)
52 (LHD L/B)
I16
54 (LHD W/G)
D9
D10
D11
54 (LHD W/G)
53 (LHD L/B)
55 (LHD W/G)
R17
53 (LHD L/B)
55 (LHD W/G)
J6
48 (LHD)
52 (LHD L/B)
J7
48 (LHD)
54 (LHD W/G)
J8
48 (LHD)
55 (LHD W/G)
50 (LHD S/D)
J9
48 (LHD)
51 (LHD S/D)
52 (LHD L/B)
J10
48 (LHD)
54 (LHD W/G)
J11
48 (LHD)
50 (LHD S/D)
J30
51 (LHD S/D)
See Page
29
55 (LHD W/G)
50 (LHD S/D)
: Relay Blocks
Code
53 (LHD L/B)
51 (LHD S/D)
P8
50 (LHD S/D)
52 (LHD L/B)
D8
J34

268
AVENSIS (EWD526E)
http://vnx.su
51 (LHD S/D)
V8
V9
53 (LHD L/B)
53 (LHD L/B)
55 (LHD W/G)

Code
See Page
CA
CC
34
CD
CK
35
DA
DB
30
DK
31
DM
31
DC

Code
IA1
See Page
86 (LHD)
86 (LHD)
ID1
86 (LHD)
IL1
88 (LHD)
IM1
88 (LHD)
BD2
92 (LHD L/B)
BE2
92 (LHD L/B)
BF2
94 (LHD W/G)
BG2
94 (LHD W/G)
IC1
IC2
: Ground Points
Code
See Page
IJ
86 (LHD)
Left Kick Panel
IP
86 (LHD)
Right Kick Panel
BS
90 (LHD S/D)
BX
92 (LHD L/B)
94 (LHD W/G)
: Splice Points
Code
B5
See Page
90 (LHD S/D)
92 (LHD L/B)

Roof Wire
Code
B5
See Page
94 (LHD W/G)

Roof Wire
269
AVENSIS (EWD526E)
http://vnx.su
Interior Light (RHD)

1
7. 5A
ECUB 2
I14(A)
Integration Relay
25A
DOOR
B
1
B
23
ACC
MPX2
IG
21
From Power Source

22 A
22
PB
16 DB
WR
WR
6
7. 5A
RAD
NO. 1
10A
GAUGE1
1 IC1
2 A
21 B
WR
15 A
PB
6 CD
MPX
31
PL
RW
H B
RW
GR
7 CA
GR
WR
F A
J20(A), J21(B)
Junction Connector
3 CD
7 DB
(7)
4 DB
T6
Theft Deterrent ECU
10 CC
14 A
20 B
Door
BEAN
I/F
CPU
C10(A), C11(B)
Combination Meter
13 A
WB
5 B
6 CK
P
WB
6 CA
IP
270
AVENSIS (EWD526E)
http://vnx.su
I14(A)
Integration Relay
LP
MPX1
11 A

(See Page 120)
WR
7. 5A
DOME
10 IC1
WG
H B
6
J26(A), J27(B)
Junction
Connector
I11(A), I12(B)
F A
WR
F A
WR
WR
F A
WR
F A
6 A (3)
6 B (4)
ILL
ILL+
2 A (3)
2 B (4)
WR
WR
29 A (5)
20 B (6)
MPX
4 ID1
MPX+
9 A (5)
10 B (6)
WR
PB
WR
A13(A), A15(B)
7 DK
WG
1 DA
WR
WR
WR
B5
WR
29 B (1AZFSE)
29 A (1)
21 A (2)
P8
Personal Light
MPX1
18 B (1AZFSE)
23 A (1)
20 A (2)
V9
Vanity Light RH
MPX2
V8
Vanity Light LH
E 9(A), E10(B)
Engine ECU (M/T)
B5
WB
WB
WB
B5
1
2
3
4
5
6
7
WB
B5
WB
WB

: 1CDFTV
: w/o Engine Immobiliser System
: Automatic A/C
271
AVENSIS (EWD526E)
http://vnx.su
WR
WR
C B
9 CI
11 CI
10 CI
3 CE
6 CH
WR
(8)
WR
WR
5 IC2
10 IA1
7 CG
11
1
1
10
IL1
WB
BU
272
AVENSIS (EWD526E)
http://vnx.su
1 CA
DCTY
PCTY
17
9
13 DB
9 DC
9 IM1
D9
11 IA1
J32
Junction
Connector
D8
2 DB
LGCY
D7
RY
(S/D)
1 A
D10
(S/D)
L5
WR
RY
(S/D)
L3
WR
(S/D)
WB
(S/D)
WR
WB
(S/D)
B A
J30(A), J31(B)
Junction
Connector
RY
R17
Rear Interior Light
(8)
D3
Diode
WR
WR
RY

I14(A)
Integration Relay
5 CE
2
IL1
14 IC2
8 : L/B, W/G
WR
WB
RY
(8)
WB
WB
B5
IJ
AVENSIS (EWD526E)
http://vnx.su
BX
(1AZFE)
5 BG2
4 IC2
D
J22
Junction Connector
(Except 1AZFE)
8 BD2 (L/B)
2 BF2 (W/G)
(Except 1AZFE)
RY
9 DA
8 BE2
(W/G)
(8)
RY
BDCY
U1
Unlock
Warning SW
RY
(W/G)
WB
11 ID1
B7
Back Door
Courtesy SW
(8)
RY
12 A
WB
J34
Junction Connector
RY
(L/B)
25
(L/B)
6 DK
(8)
RY
2 DK
WB
WB
WG
13 DM
RY
WB
WG
RCTY
(8)
WB
WR
18 IM1
I16
Interior Light
WG
16
(8)
WB
D12
WG
12 DM
WB
WB
WR
D11
WG
I14(A)
Integration Relay
19
KSW
J32
Junction
Connector
8 DA
13 CF
6 CA
WR
WB
RY
(8)
IP
273

System Outline
Illuminated Entry System
1. Light on Condition
The light comes on when either of the following conditions is met:
When any of the doors is open (Except the luggage compartment door (S/D) or back door (L/B, W/G) ).
When all doors are closed and the ignition SW is set to OFF.
2. Light off Condition
The light gradually goes off when any of the following conditions is met (The dome light must be turned on):
When the ignition SW is kept in the ON position for more than approximately 12 to 18 seconds after all doors are closed.
When all doors are closed and the drivers and front passengers side doors are locked.
When all doors are closed and the ignition SW is set to ACC or ON.
Service Hints
D9, D10, D11, D12 Door Courtesy SW Front LH, RH, Rear LH, RH
1Ground : Continuity with the door open
Integration Relay
: Parts Location
Code
See Page
A13
66 (RHD)
A15
66 (RHD)
Code
See Page
72 (RHD L/B)
D11
74 (RHD W/G)
72 (RHD L/B)
B7
Code
71 (RHD S/D)
J32
70 (RHD S/D)
74 (RHD W/G)
72 (RHD L/B)
D12
73 (RHD L/B)
75 (RHD W/G)
J34
73 (RHD L/B)
C10
66 (RHD)
C11
66 (RHD)
E9
67 (RHD)
L3
71 (RHD S/D)
67 (RHD)
E10
67 (RHD)
L5
71 (RHD S/D)
70 (RHD S/D)
I11
67 (RHD)
72 (RHD L/B)
I12
67 (RHD)
74 (RHD W/G)
I14
67 (RHD)
D3
D7
74 (RHD W/G)
See Page
70 (RHD S/D)
70 (RHD S/D)
72 (RHD L/B)
D8
72 (RHD L/B)
I16
74 (RHD W/G)
D9
D10
D11
75 (RHD W/G)
R17
73 (RHD L/B)
75 (RHD W/G)
69 (RHD)
69 (RHD)
68 (RHD)
72 (RHD L/B)
J21
68 (RHD)
68 (RHD)
70 (RHD S/D)
J26
68 (RHD)
72 (RHD L/B)
J27
68 (RHD)
74 (RHD W/G)
J30
71 (RHD S/D)
70 (RHD S/D)
J31
71 (RHD S/D)
See Page
29
73 (RHD L/B)
U1
: Relay Blocks
Code
P8
T6
J20
J22
71 (RHD S/D)
74 (RHD W/G)
70 (RHD S/D)
74 (RHD W/G)
75 (RHD W/G)

274
AVENSIS (EWD526E)
http://vnx.su
71 (RHD S/D)
V8
73 (RHD L/B)
75 (RHD W/G)
71 (RHD S/D)
V9
73 (RHD L/B)
75 (RHD W/G)

Code
See Page
CA
CC
CD
34
CE
CF
CG
CH
CI
35
CK
DA
DB
30
DK
31
DM
31
DC

Code
IA1
See Page
106 (RHD)
106 (RHD)
ID1
106 (RHD)
IL1
108 (RHD)
IC1
IC2
IM1
108 (RHD)
BD2
112 (RHD L/B)
BE2
112 (RHD L/B)
BF2
114 (RHD W/G)
BG2
114 (RHD W/G)
: Ground Points
Code
See Page
IJ
106 (RHD)
Left Kick Panel
IP
106 (RHD)
Right Kick Panel
110 (RHD S/D)

BU
112 (RHD L/B)
114 (RHD W/G)

BX
112 (RHD L/B)

114 (RHD W/G)
: Splice Points
Code
B5
See Page
110 (RHD S/D)
112 (RHD L/B)

Roof Wire
Code
See Page
B5
114 (RHD W/G)

Roof Wire
275
AVENSIS (EWD526E)
http://vnx.su
Headlight Beam Level Control (w/ HID)

40A MAIN
7. 5A
GAUGE2
H1
Control Actuator LH
H2
Control Actuator RH
1 IE6
1 IO2
6 IE6
6 IO2
8 IE6
8 IO2
PL
GY
LW
7 IE6
7 IO2
5 CK
GY
LW
PL
12 IE1
J29
Junction Connector
2 IE6 (LHD)
2 IO2 (RHD)
RY
E
RY
RY
C A
(LHD)
RY
WR
14
23
13
22
(RHD)
C B
2
(RHD)
RY
J 6(A), J 7(B)
Junction Connector
(LHD)
3
HLP
Relay
8 CA
BW
D B
BW
RW
E A
RW
J 3(A), J 4(B)
Junction
Connector
WL
WL
27 DA
RY
10
HDLP
LH2
IG
LH1
RH2
LH3
RH1
RH3
BW
GW
5 IH1
8 IM1
7 IM1
SGR
GND
WNG
24
10 CE
2 CI
6 CA
6 CK
SPDR
11
12
VW
20
LG
WB
4 IH1
SGF
(RHD)
21
3 IH1
SHF
WB
SHR
WR
SBF
(LHD)
SBR
15
WG
H14
6 IM1
BW
GW
SHB
SHFR
SHG
SHB
WB
WR
WB
WG
VW
LG
WB
H18
SHRR
SHG
H19
Height Control Sensor (Rear)
IP
276
AVENSIS (EWD526E)
http://vnx.su
7. 5A
DOME
10A
GAUGE1
10A
IGN
7 DB
BW
F A (LHD)
F C
F C (RHD)
6 CD
C A (LHD)
A C (RHD)
C A (LHD)
A C (RHD)
BW
RW
H B
J 8(A), J26(C)
Junction
Connector
7 CA
J10(A), J11(B), J26(C)

Junction Connector
18 DA
RW
WR
(RHD)
WR
WR
C10(A), C11(B)
Combination Meter
22 B
21 B
Speedometer
20 B
Beam Level
(LHD)
CPU
LG
LW
10 B
16 IE1
35 A (w/ VSC)
23 B (w/o VSC)
SP1
VW
F B (LHD)
F D (RHD)
19 B
LW
H A (LHD)
H C (RHD)
5 B
WB
J10(A), J11(B), J20(C), J21(D)

Junction
Connector
VW
18 B
VW
S 1(A), S 2(B)
Skid Control ECU
with Actuator
LG
WB
277
AVENSIS (EWD526E)
http://vnx.su
Headlight Beam Level Control (w/ HID)

System Outline
This system automatically adjusts the optic axis of the headlights according to the posture of the car at rest to prevent glare
to oncoming cars, and ensures the maximum irradiation range of the headlights.
Service Hints
H14 Headlight Beam Level Control ECU
IGGround : Approx. 12 volts with the ignition SW at ON position
GNDGround : Always continuity
: Parts Location
Code
C10
See Page
A
C11
Code
46 (LHD)
48 (LHD)
47 (LHD)
J10
48 (LHD)
67 (RHD)
J11
48 (LHD)
47 (LHD)
J20
68 (RHD)
67 (RHD)
J21
68 (RHD)
40 (*4)
50 (LHD S/D)
J26
68 (RHD)
42 (*5)
52 (LHD L/B)
44 (*6)
54 (LHD W/G)
H14
66 (RHD)
H18
38 (*3)
H19
58 (*7)
70 (RHD S/D)
J29
68 (RHD)
39 (*3)
S1
45 (*6)
62 (*9)
72 (RHD L/B)
64 (*10)
74 (RHD W/G)
65 (*10)
38 (*3)
48 (LHD)
41 (*4)
40 (*4)
42 (*5)
H2
See Page
J8
46 (LHD)
H1
Code
64 (*10)
66 (RHD)
See Page
H2
J3
68 (RHD)
48 (LHD)
59 (*7)
43 (*5)
S2
45 (*6)
J4
68 (RHD)
63 (*9)
58 (*7)
J6
48 (LHD)
65 (*10)
62 (*9)
J7
48 (LHD)
44 (*6)
: Relay Blocks
Code
1
See Page
24 (*1)
25 (*2)

26
29

Code
See Page
CA
CD
34
CE
CI
CK
DA
DB
35
30
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
278
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV

Code
IE1
IE6
IH1
IM1
IO2
See Page
86 (LHD)
106 (RHD)
86 (LHD)
88 (LHD)
106 (RHD)
88 (LHD)
108 (RHD)
108 (RHD)
: Ground Points
Code
IP
See Page
86 (LHD)
106 (RHD)

Right Kick Panel
279
AVENSIS (EWD526E)
http://vnx.su
Headlight Beam Level Control (w/o HID)

1
5
10A
TAIL
TAIL
Relay
2
13
1 DN
8 DL
4 DM
TRLY
Integration
Relay
T
(2)
BL
12
12 DB
23 DA
J30
Junction
Connector
1 ED1
(5)
(6)
(1)
(2)
BG
3 IC2
1 4D
H2
Control Actuator RH
GY
GY(7)
140A ALT
1 4B
(1)
(2)
BG
Light
Control SW
14
A
A
120A ALT(3)
100A ALT(4)
J1
Junction
Connector
H1
Control Actuator LH
OFF
Tail
Head
C12
Combination SW
16
GR(8)
PL
WB
12 IE1
PL
FL MAIN
3. 0W
Battery
WB
WB
C A
A B
C A
J 3(A), J 4(B)
Junction
Connector
GY
IL : 9
IO : 10
EC
280
AVENSIS (EWD526E)
http://vnx.su
1 : Gasoline
2 : 1CDFTV
3 : 1AZFSE, 1AZFE
4 : 1ZZFE, 3ZZFE
6 : w/o Daytime Running Light
7 : Except RHD 1CDFTV
8 : RHD 1CDFTV
9 : LHD 1CDFTV, RHD
10 : LHD Gasoline
C A (LHD)
C B (RHD)
WB
C A (LHD)
C B (RHD)
PL
GY
11 CE (LHD)
5 CI (RHD)
6 CA
WB
PL
WB
H15
Control SW
J10(A), J26(B)
Junction
Connector
GY
IP
281
AVENSIS (EWD526E)
http://vnx.su
Headlight Beam Level Control (w/o HID)

Service Hints
H1, H2 Headlight Beam Level Control Actuator LH, RH
3Ground : Approx. 12 volts with the light control SW at TAIL or HEAD position
H15 Headlight Beam Level Control SW
1Ground : Approx. 12 volts with the light control SW at TAIL or HEAD position
: Parts Location
Code
See Page
Code
See Page
46 (LHD)
C12
58 (*7)
66 (RHD)
J3
J4
68 (RHD)
48 (LHD)
64 (*10)
40 (*4)
47 (LHD)
J10
48 (LHD)
67 (RHD)
J26
68 (RHD)
H15
68 (RHD)
44 (*6)
39 (*3)
51 (LHD S/D)
58 (*7)
41 (*4)
53 (LHD L/B)
62 (*9)
43 (*5)
64 (*10)
H2
See Page
38 (*3)
42 (*5)
H1
62 (*9)
H2
Code
45 (*6)
J1
55 (LHD W/G)
J30
71 (RHD S/D)
38 (*3)
59 (*7)
73 (RHD L/B)
40 (*4)
63 (*9)
75 (RHD W/G)
42 (*5)
65 (*10)
44 (*6)
J3
48 (LHD)
: Relay Blocks
Code
3
See Page
26


Code
4B
4D
CA
CE
CI
DA
DB
See Page
27

34
35
30
DL
31
DM
31
DN
31

Code
ED1
IC2
IE1
See Page
84 (*6)
104 (*10)
86 (LHD)
106 (RHD)

86 (LHD)
106 (RHD)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
282
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
: Ground Points
Code
See Page
78 (*3)
80 (*4)
82 (*5)
EC
84 (*6)
98 (*7)
102 (*9)
104 (*10)
IL
IO
IP
86 (LHD)
106 (RHD)
86 (LHD)
86 (LHD)
106 (RHD)

Right Kick Panel
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
283
AVENSIS (EWD526E)
http://vnx.su
Headlight Cleaner (w/ HID)

WL
WL
10 CC
3
3 CD
HLP
Relay
2
WR
H4
Headlight Cleaner
Motor
10 IE1
2
RY
RY
WL
BW
J2
Junction
Connector
WR
(1)
LR
F11
Front Washer
Motor
16 DB
23
IG
WR
WL
(1)
RY
LR
10A
GAUGE1
2
1
(4)
J1
Junction
Connector
C
40A MAIN
(3)
LR
17 DL
30A H/CLN
25A WIP
7. 5A ECUB 2
1
30A HLP CLN
FRWA
PB
22
B
IG
I14(A)
Integration Relay
HDLO
H3
RY
HRLY
2 A
18
9 DA
(1)
RY
(1)
RY
(1)
RY
28 DA
WB
E
25
WB
(2)
H
E
J 6(A), J 7(B)
Junction Connector
13
EB
RY
Head
16
IL : 5
IO : 6
C A
1
2
3
4
5
6
C A

: Gasoline
: 1CDFTV
: LHD 1CDFTV, RHD
: LHD Gasoline
284
AVENSIS (EWD526E)
http://vnx.su
WB
Tail
(LHD)
C12
Combination SW
WB
WB
Light
Control SW
(LHD)
RY
C B
(1)
RY
RY
(LHD)
RY
RY
(RHD)
OFF
15 IC2
J 6(A), J 7(B)
Junction Connector
RY
E A
A B
(RHD)
J29
Junction
Connector
E
E
D B
(2)
D B
H16
Headlight Cleaner
SW
RY
E A
(1)
E A
E A
J 3(A), J 4(B)
Junction Connector
1 IE1
IJ
Service Hints
H3 Headlight Cleaner Control Relay
: Parts Location
Code
See Page
C12
Code
See Page
66 (RHD)
40 (*4)
38 (*3)
42 (*5)
39 (*3)
44 (*6)
41 (*4)
H4
63 (*9)
J1
65 (*10)
42 (*5)
58 (*7)
44 (*6)
62 (*9)
58 (*7)
64 (*10)
59 (*7)
47 (LHD)
63 (*9)
67 (RHD)
65 (*10)
62 (*9)
H16
64 (*10)
38 (*3)
I14
47 (LHD)
43 (*5)
45 (*6)
J2
48 (LHD)
J3
J4
43 (*5)
J6
48 (LHD)
62 (*9)
45 (*6)
J7
48 (LHD)
64 (*10)
59 (*7)
40 (*4)
H3
Code
38 (*3)
40 (*4)
F11
See Page
46 (LHD)
67 (RHD)
42 (*5)
39 (*3)
44 (*6)
41 (*4)
58 (*7)
J1
68 (RHD)
48 (LHD)
68 (RHD)
J29
68 (RHD)
: Relay Blocks
Code
1
See Page
24 (*1)
25 (*2)

26
27
29

Code
CC
CD
DA
DB
DL
See Page
34
30
31

Code
IC2
IE1
See Page
86 (LHD)
86 (LHD)
106 (RHD)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
285
AVENSIS (EWD526E)
http://vnx.su
Headlight Cleaner (w/ HID)

: Ground Points
Code
See Page
78 (*3)
80 (*4)
82 (*5)
EB
84 (*6)
98 (*7)
102 (*9)
104 (*10)
IJ
IL
IO
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
Left Kick Panel

* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
286
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
Memo
287
AVENSIS (EWD526E)
http://vnx.su
Headlight Cleaner (w/o HID)

WR
WL
(4)
J1
Junction
Connector
10A
GAUGE1
2
1
(3)
40A MAIN
2
4
LR
17 DL
30A H/CLN
25A WIP
7. 5A ECUB 2
1
30A HLP CLN
WL
C
2
LR
10 CC
3
3 CD
HLP
Relay
5
2
WR
16 DB
23
22
B
IG
I14(A)
Integration Relay
HRLY
2 A
18
D B
D B
E A
A B
(1)
RY
(1)
RY
WB
E A
15 IC2
C12
Combination SW
Tail
EB
C A
1
2
3
4
5
6

: Gasoline
: 1CDFTV
: LHD 1CDFTV
: LHD Gasoline
288
AVENSIS (EWD526E)
http://vnx.su
WB
16
IL : 5
IO : 6
C A
RY
Head
WB
WB
Light
Control SW
RY
13
OFF
(1)
RY
C B
J 6(A), J 7(B)
Junction Connector
E1
RY
(1)
RY
(2)
RY
WB
H16
Headlight Cleaner
SW
9 DA
J 6(A), J 7(B)
Junction Connector
J 3(A), J 4(B)
Junction Connector
H4
BW
28 DA
1 IE1
E
25
WB
RY
H3
WR
IJ
Service Hints
H3 Headlight Cleaner Control Relay
: Parts Location
Code
See Page
C12
Code
46 (LHD)
40 (*4)
H16
42 (*5)
I14
44 (*6)
38 (*3)
H4
Code
42 (*5)
H4
38 (*3)
H3
See Page
J1
40 (*4)
See Page
J1
45 (*6)
44 (*6)
J3
48 (LHD
47 (LHD)
J4
48 (LHD)
47 (LHD)
J6
48 (LHD)
39 (*3)
J7
48 (LHD)
41 (*4)
43 (*5)
: Relay Blocks
Code
1
See Page
24 (*1)
25 (*2)

26
27
29

Code
CC
CD
DA
DB
DL
See Page
34
30
31

Code
See Page
IC2
86 (LHD)
IE1
86 (LHD)
: Ground Points
Code
See Page
78 (*3)
EB
80 (*4)
82 (*5)
84 (*6)
IJ
86 (LHD)
Left Kick Panel
IL
86 (LHD)
IO
86 (LHD)
: Splice Points
Code
E1
See Page
78 (*3)
80 (*4)

Code
E1
See Page
82 (*5)
84 (*6)

* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
289
AVENSIS (EWD526E)
http://vnx.su
Key Reminder and Light Reminder

25A DOOR
7. 5A ECUB 2
I14(A)
Integration Relay
B
1
INTB
DCTY
23
17
15
16 DB
13 DB
9 DJ
TRLY
T
12
13
2
12 DB
(3)
1 DN
23 DA
BL
(2)
1 ED1
1 4D
120A ALT (12)

100A ALT (13)
2
140A ALT
OFF
Tail
Head
C12
Combination
SW
16
WB
(1)
BG
1 4B
(2)
14
Light
Control SW
W
3
(1)
BG
(9)
(2)
D10
10A TAIL
7. 5A PANEL
4 DM
TAIL Relay
9 IM1
D9
R
1
(LHD)
14 IC2
19 DB
1 CA
(LHD)
WR
B A
10 CC
(RHD)
B A
5 CE
(RHD)
J10(A)
Junction Connector
3 CD
(3)
(3)
GW
(RHD)
(LHD)
WR
WR
FL MAIN
3. 0W
Battery
WB
IL : 4
IO : 5
290
AVENSIS (EWD526E)
http://vnx.su
(LHD)
I14(A)
Integration Relay
MPX2
IG
KSW
MPX1
22 A
22
19
11 A
8 DA
J30
Junction
Connector
(11)
WR
(RHD)
WR
RW
(LHD)
G
3 IC2
14 B
20 B
14 A
29 A (7)
20 B (8)
MPX
MPX+
9 A (7)
10 B (8)
PB
U1
Unlock
Warning SW
21 B
A13(A), A15(B)
WR
F C
RW
C A (LHD)
C C (RHD)
H B
PB
6 CD
1 IC1
F C
WR
J10(A), J26(C)
Junction Connector
(11)
C A (LHD)
C C (RHD)
F A
(RHD)
7 CA
J26(C)
Junction Connector
10 IC1
(LHD)
J22
Junction Connector
7 DB
J10(A), J11(B)
Junction Connector
(10)
10A
GAUGE1
PB
7. 5A DOME
CPU
13 CF
MPX1
18 B (1AZFSE)
23 A (6)
20 A (2)
WB
J16
Junction
Connector
MPX2
6 CK
6 CA
A
13 A
C10(A), C11(B)
Combination Meter
WB
WB
(RHD)
WB
(LHD)
5 B
29 B (1AZFSE)
29 A (6)
21 A (2)
BEAN
I/F
E 9(A), E10(B)
Engine ECU (M/T)
Buzzer
WB
(LHD)
IP
1 : Gasoline
2 : 1CDFTV
4 : LHD 1CDFTV, RHD
5 : LHD Gasoline
8 : Automatic A/C
9 : w/o Daytime Running Light
10 : LHD, RHD 1AZFE
11 : RHD Except 1AZFE
12 : 1AZFSE, 1AZFE
13 : 1ZZFE, 3ZZFE
291
AVENSIS (EWD526E)
http://vnx.su
Key Reminder and Light Reminder

System Outline
1. Key Reminder Buzzer System
If you open the door of the drivers side when the ignition key is inserted in ignition SW being off, the buzzer comes on.
2. Light Reminder Buzzer System
If you open the door of the drivers side when either headlight or taillight is on with ignition SW being off, the buzzer comes
on.
Service Hints
Integration Relay
17Ground : Continuity with the drivers door open
: Parts Location
Code
See Page
A13
A15
C10
See Page
D9
J22
46 (LHD)
47 (LHD)
51 (LHD S/D)
67 (RHD)
53 (LHD L/B)
66 (RHD)
46 (LHD)
E9
E10
A
B
47 (LHD)
67 (RHD)
J30
68 (RHD)
55 (LHD W/G)
71 (RHD S/D)
47 (LHD)
73 (RHD L/B)
67 (RHD)
75 (RHD W/G)
I14
50 (LHD S/D)
J10
48 (LHD)
52 (LHD L/B)
J11
48 (LHD)
66 (RHD)
J26
68 (RHD)
74 (RHD W/G)
46 (LHD)
D9
68 (RHD)
66 (RHD)
66 (RHD)
C12
72 (RHD L/B)
D10
See Page
48 (LHD)
J16
70 (RHD S/D)
46 (LHD)
Code
54 (LHD W/G)
66 (RHD)
C11
Code
46 (LHD)
U1
49 (LHD)
69 (RHD)
: Relay Blocks
Code
See Page
26
29

Code
4B
4D
See Page
27

CA
CC
CD
34
CE
CF
CK
35
DA
DB
30
DM
31
DN
31
DJ
292
AVENSIS (EWD526E)
http://vnx.su

Code
ED1
IC1
See Page
84 (*6)
104 (*10)

86 (LHD)
106 (RHD)
IC2
86 (LHD)
IM1
108 (RHD)

: Ground Points
Code
IL
IO
IP
See Page
86 (LHD)
106 (RHD)
86 (LHD)
86 (LHD)
106 (RHD)

Right Kick Panel
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
293
AVENSIS (EWD526E)
http://vnx.su
Seat Belt Warning

RW
(5)
7. 5A DOME
10A
GAUGE1
1
2
3
4
5
6
7
8

: 1CDFTV
: Automatic A/C
: w/ Front Passenger' s Seat Belt Warning
: LHD 5
: RHD 5
: 1AZFE, Latin America, Argentina, CIS
LR
LR
7 CD
PB
7 CA
22
MPX2
BKL
H B
1 IC1
I14
Integration Relay
PB
(5)
RW
F A (LHD)
F C
F C (RHD)
RW
WR
J10(A), J11(B), J26(C)

Junction
Connector
(RHD)
7 DB
WR
MPX1
11
20 B
21 B
C10(A), C11(B)
Combination Meter
PB
RW
WR
(LHD)
6 CD
14 A
10 IC1
(8)
Buzzer
BEAN
I/F
A13(A), A15(B), A16(C)

Speedometer
Seat Belt
(8)
CPU
29 A (3)
20 B (4)
MPX
MPX+
9 A
10 B
PBLT
24 A (3)
3 C (4)
P
16 IE1
LW
6 CK
35 A (w/ VSC)
23 B (w/o VSC)
6 CA
E 9(A), E10(B)
Engine ECU (M/T)
(5)
13 A
5 B
WB
LW
19 B
LR
PB
(8)
29 B (1AZFSE)
29 A (1)
21 A (2)
MPX2
MPX1
18 B (1AZFSE)
23 A (1)
20 A (2)
9 CH
LR
SP1
(6)
WB
WB
(5)
WB
S 1(A), S 2(B)
Skid Control ECU
with Actuator
(6)
IP
294
AVENSIS (EWD526E)
http://vnx.su
RW
(5)
4 (LHD)
5 (RHD)
10A IGN
LR
(5)
RW
IG
F19
Front Passenger' s
Seat Belt
Warning Light
5 DD
LR
12 IC2
BW
14 DB
BPBEW
PBEW
7 (LHD)
2 (RHD)
6
3
8
1
(7)
GY
(6)
(5)
LR
(7)
WB
GY
8 IC3
GY
LBE+(LHD)
RBE+(RHD)
19 A (LHD)
14 C (RHD)
E1
27 B
E2
28 B
B10
LSP+
RSP+
4 A
1 C
(7)
LSP
RSP
3 A
2 C
14 IM1
IG2
(6)
PBEW
LBE
RBE
2 A
3 C
A26(A), A27(B), A28(C)

5 B
GY
4 B
(6)
LR
WB
2 DD
4 DD
3 DD
WB
B A
(6)
WB
(7)
J32
Junction
Connector
J30(A), J31(B)
Junction
Connector
WB
WB
WB
B9
1
Buckle SW (Driver' s Side)
J16
Junction
Connector
Buckle SW
Seat Position
Airbag Sensor
9 DA
(7)
WB
(7)
GY
WB
LB
WB
GRB
WB
C B
LR
(7)
WB
(5)
WB
(6)
IJ
IL
BV
BS
295
AVENSIS (EWD526E)
http://vnx.su
Seat Belt Warning

System Outline
1. Seat Belt Warning for the Drivers Seat
If the driver does not wear the seat belt when the ignition SW is set to on, the seat belt warning light for the drivers seat
comes on, and the buzzer sounds (But 1AZFE, Latin America, Argentina and CIS specification vehicles do not sound the
buzzer, indicate the warning with the light only). When the driving speed exceeds 15 km/h with the buzzer activated, the
interval of buzzer sounding becomes shorter.
2. Seat Belt Warning for the Front Passengers Seat (Except 1AZFE)
A sensor (Occupant detection sensor) detects whether there is an occupant in the front passengers seat when the ignition
SW is set to on. If an occupant is detected and he/she does not wear the front passengers seat belt, the front passengers
seat belt warning light flickers, and the buzzer sounds (But Latin America, Argentina and CIS specification vehicles do not
the buzzer, indicate the warning with the light only). When the driving speed exceeds 15 km/h with the buzzer activated, the
interval of buzzer sounding becomes shorter.
Service Hints
B9 Buckle SW (Driver Side)
31 : Closed with drivers seat belt in use
B10 Buckle SW (Front Passengers Side) and Occupant Detection Sensor
31 : Closed with passenger sit on the front passengers seat and front passengers seat belt not use
: Parts Location
Code
See Page
A13
A15
A16
46 (LHD)
66 (RHD)
46 (LHD)
66 (RHD)
46 (LHD)
A26
66 (RHD)
A28
E9
E10
B
F19
46 (LHD)
See Page
66 (RHD)
71 (RHD S/D)
J31
47 (LHD)
73 (RHD L/B)
75 (RHD W/G)
67 (RHD)
71 (RHD S/D)
47 (LHD)
73 (RHD L/B)
J32
67 (RHD)
75 (RHD W/G)
47 (LHD)
39 (*3)
47 (LHD)
S1
45 (*6)
59 (*7)
67 (RHD)
65 (*10)
46 (LHD)
J10
48 (LHD)
41 (*4)
66 (RHD)
J11
48 (LHD)
43 (*5)
56 (LHD)
56 (LHD)
48 (LHD)
J16
76 (RHD)
J26
68 (RHD)
C
76 (RHD)
46 (LHD)
Code
46 (LHD)
67 (RHD)
I14
66 (RHD)
B10
C10
66 (RHD)
B9
See Page
C11
46 (LHD)
A27
Code
J30
66 (RHD)
S2
45 (*6)
61 (*8)
68 (RHD)
63 (*9)
71 (RHD S/D)
65 (*10)
73 (RHD L/B)
75 (RHD W/G)
: Relay Blocks
Code
6
See Page
29

* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
296
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV

Code
CA
CD
CH
CK
See Page
34
35
DA
DB
30
DD

Code
IC1
IC2
IC3
IE1
IM1
See Page
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
106 (RHD)
86 (LHD)
106 (RHD)
88 (LHD)
: Ground Points
Code
IJ
IL
IP
See Page
86 (LHD)
106 (RHD)
106 (RHD)
86 (LHD)
106 (RHD)

Left Kick Panel
Right Kick Panel
110 (RHD S/D)

BS
112 (RHD L/B)
114 (RHD W/G)

90 (LHD S/D)
BV
92 (LHD L/B)
94 (LHD W/G)
297
AVENSIS (EWD526E)
http://vnx.su
ECT and A/T Indicator (1AZFSE)

BY
GR
P
From Power Source
7. 5A
ECUB 2
10A
GAUGE1
10 IC1
I14(A)
Integration Relay
6
11 A
22
MPX1
7 DB
WR
IG
E
B
23
25
MPX2
SNOW
RW
22 A
16 DB
9 DA
14 DA
WR
WB
10 CC
4
4
1
10A EFI NO. 1
20A EFI
EFI
Relay
3
PB
WB
5
2
1 IC1
PB
BW
BY
E8
GR
BY
3 CD
2
1
4
BR
BW
BG
WB
4
1 1A
PB
1 4A
BG
1 4B
FL MAIN
3. 0W
WB
WB
WB
BR
Battery
IJ
EC
298
AVENSIS (EWD526E)
http://vnx.su
BY
BY
GR
GR
7. 5A
DOME
RW
6
RW
7 CA
1 CG
(RHD)
F A (LHD)
F C
F C (RHD)
6 CD
RW
J10(A), J11(B), J26(C)

Junction
Connector
WR
WR
RW
RW
20 B
H B
21 B
WR
A/T SHIFT
CLOCK
ECT SNOW
Speedometer
(LHD)
BEAN
I/F
19 B
18 B
13 A
PB
C10(A), C11(B)
Combination Meter
VW
PB
5 B
WB
14 A
LW
CPU
WB
16 IE1
6 CK
WB
WB
6 CJ
(LHD)
WB
6 CA
WB
LW
11 CF (LHD)
8 CH (RHD)
(LHD)
P
35
VW
SP1
S1
Skid Control ECU
with Actuator
WB(LHD)
BR
BR
WB
(LHD)
IP
299
AVENSIS (EWD526E)
http://vnx.su

BY
GR
P
MPX+
10
PB
GR
BY
22 B
21 B
20 B
29 B
8 A
3 A
SFTU
SFTD
MPX2
SPT1
MREL
LG
7 IE3 (LHD)
7 IO1 (RHD)
LGB
2 IE1
WB
SFTD
SFTU
BO
C5
MPX
T4
Turbine Speed Sensor
20
BY
3
IG
GR
T7
A15
RW
27 D
35 D
34 D
26 D
BATT
NT+
NT
NC
NC+
E 9(A), E10(B), E11(C), E12(D), E13(E)

E03
7 C
E01
7 E
E02
6 E
E1
1 C
D A
D B
BR
WB
WB
WB
D B
BR
E A
BR
W
2
VW
J14(A), J28(B)
Junction Connector
H A (LHD)
H C (RHD)
D A (LHD)
D B (RHD)
D A (LHD)
D B (RHD)
K2
Kick Down SW
WB
(LHD)
(LHD)
H A (LHD)
H C (RHD)
ME01
4 C
WB
A
8 IG2
EOM
15 A
BR
BR
2 A
J12(A), J13(B)
Junction Connector
+B2
+B
1 A
BR
VW
KD
30 B
(LHD)
SPD
17 B
J10(A), J20(C)
Junction Connector
WB
(RHD)
WB
VW
(LHD)
J17
Junction
Connector
MPX1
18 B
E 3 : LHD
I 3 : RHD
2 IE4 (LHD)
3 IP1 (RHD)
4 IG2
BR
WB(LHD)
BR
BR
J15
Junction
Connector
EE
IK
300
AVENSIS (EWD526E)
http://vnx.su
EF

1 : Shielded
10A
THROTTLE
10A
IGN
15A
STOP
11 IE3
6 IE3
GW
(RHD)
GW
(LHD)
RW
RW
2 IR1
1 IR1
BW
GR
5 IE2
(LHD)
22 DA
18 DA
(RHD)
GW
(RHD)
GW
(LHD)
RW
(LHD)
RW
C A (LHD)
A C (RHD)
(RHD)
C A
2 DA
GW
BW
9 A
19 B
IGSW
STP
E 9(A), E10(B), E11(C), E12(D), E13(E)

GE01
17 C
(1)
M
2 C
M+
3 C
LW
VTA1
21 E
BR
VTA2
31 E
RW
E2
BW
VC
18 E
BR
E2
28 E
T1
Throttle Control Motor and
Position Sensor
BR
THW
19 E
BR
+BM
(RHD)
J 8(A), J26(C),
J27(D)
Junction
Connector
BW
6 B
(LHD)
GY
E D
10 DC
S13
Stop Light SW
BR
BR
E 3 : LHD
I 3 : RHD
301
AVENSIS (EWD526E)
http://vnx.su

N1
Neutral Start SW
7. 5A
GAUGE2
7. 5A ST
RW
3
RB
P
6
27 DA
NL
RL
PL
LGB
RY
WL
10 IK2
9 IK2
5 IK1
20 IK2
8 CA
1 CD
RY
RW
B A
J12(A), J13(B)
Junction Connector
B B
DL
6
RW
BW
J5
Junction Connector
RW
RY
(LHD)
RY
17 E
10 B
7 A
11 B
6 A
STA
LGB
WL
(LHD)
C B
J22(A), J23(B)
Junction Connector
C A (LHD)
D B (RHD)
1 IK1
BY
A A
A A
RY
A A
C A (LHD)
D B (RHD)
(RHD)
J12(A)
Junction
Connector
J14(A), J19(B)
Junction
Connector
BW
BY
LGB
(RHD)
E 9(A), E10(B), E11(C), E12(D), E13(E)

10
THO
SLT+
SLT
DSL
SL2+
SL2
SL1+
SL1
S4
6
E2
YB
S4
10 D
BR
SL1
18 D
RB
SL1+
19 D
SL2
16 D
LB
SL2+
17 D
DSL
11 D
SLT
12 D
BR
SLT+
13 D
PL
THO
32 D
BR
E1
ECT Solenoid
302
AVENSIS (EWD526E)
http://vnx.su
System Outline
Previous automatic transaxle have selected each gear shift using mechanically controlled throttle hydraulic pressure,
governor hydraulic pressure and lockup hydraulic pressure. The ECT, however, electrically controls the line pressure,
throttle pressure, lockup pressure and accumulator pressure etc. through the solenoid valve. The ECT is a system which
precisely controls gear shift timing and lockup timing in response to the vehicles driving conditions and the engine
condition detected by various sensors. It makes smooth driving possible by shift selection for each gear which is the most
appropriate to the driving conditions at that time, and by preventing downing, squat and gear shift shock when starting off.
1. Gear Shift Operation
When driving, the engine warm up condition is input as a signal to TERMINAL THW of the engine and ECT ECU from the
EFI water temp. sensor and the vehicle speed signal is input to TERMINAL SPD of the engine and ECT ECU. At the same
time, the throttle valve opening signal from the throttle position sensor is input to TERMINAL VTA1 of the engine and ECT
ECU as throttle angle signal.
Based on these signals, the engine and ECT ECU selects the best shift position for the driving conditions and sends current
to the ECT solenoid.
2. LockUp Operation
When each signal makes engine and ECT ECU recognize that LOCKUP condition is satisfied, the current flows from
engine and ECT ECU TERMINAL DSL to ECT solenoid TERMINAL DSL. At the same time, the current flows engine and
ECT ECU TERMINAL SL1+ to ECT solenoid TERMINAL SL1+ and from TERMINAL SL1 to engine and ECT ECU
TERMINAL SL1. This works LOCKUP solenoid to perform LOCKUP operation.
3. Stop Light SW Circuit
If the brake pedal is depressed (Stop light SW on) when driving in lockup condition, a signal is input to TERMINAL STP of
the engine and ECT ECU. The engine and ECT ECU operates and cuts the current to the solenoid to release lockup.
4. Sequential Shift Operation
With the sequential shift function, the manual shift lever becomes available by setting the shift lever to the S position, and the
S and range display indicators appear in the combination meter. Any desired range can be selected by shifting up or down
the shift lever.
Service Hints
E10 (B), E11 (C), E12 (D), E13 (E) Engine and ECT ECU (A/T)
RE1 : 10.014.0 volts (Ignition SW on and shift lever at R position)
DE1 : 10.014.0 volts (Ignition SW on and shift lever at D position)
THOE2 : Below 1.0 volts (Ignition SW on and AFT temperature 110 C (230 F)
SLT+ SLT: 10.014.0 volts (Ignition SW on)
N1 Neutral Start SW
31 : Closed with shift lever in P position
32 : Closed with shift lever in R position
35 : Closed with shift lever in N position
37 : Closed with shift lever in D position
303
AVENSIS (EWD526E)
http://vnx.su

: Parts Location
Code
See Page
46 (LHD)
A15
66 (RHD)
38 (*3)
C5
C10
58 (*7)
46 (LHD)
C11
66 (RHD)
E1
E11
E13
I14
J5
47 (LHD)
J23
68 (RHD)
J26
68 (RHD)
67 (RHD)
J27
68 (RHD)
47 (LHD)
J28
68 (RHD)
67 (RHD)
48 (LHD)
48 (LHD)
48 (LHD)
58 (*7)
J11
48 (LHD)
47 (LHD)
J12
J13
J14
67 (RHD)
J15
47 (LHD)
48 (LHD)
68 (RHD)
48 (LHD)
68 (RHD)
48 (LHD)
68 (RHD)
48 (LHD)
J17
67 (RHD)
68 (RHD)
J8
67 (RHD)
67 (RHD)
See Page
A
J10
47 (LHD)
Code
J22
38 (*3)
58 (*7)
E8
See Page
47 (LHD)
66 (RHD)
38 (*3)
E2
E10
E12
46 (LHD)
E9
Code
68 (RHD)
47 (LHD)
J19
68 (RHD)
67 (RHD)
J20
68 (RHD)
K2
48 (LHD)
39 (*3)
N1
59 (*7)
39 (*3)
S1
59 (*7)
49 (LHD)
S13
69 (RHD)
39 (*3)
T1
59 (*7)
39 (*3)
T4
59 (*7)
49 (LHD)
T7
69 (RHD)
: Relay Blocks
Code
See Page
24 (*1)
27
29

Code
1A
4A
4B
See Page
24 (*1)
27
CA
CC
CD
34
CF
CG
CH
CJ
35
CK
DA
DB
30
DC
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
304
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV

Code
IC1
IE1
IE2
IE3
IE4
IG2
IK1
IK2
See Page
86 (LHD)
106 (RHD)

86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
88 (LHD)
88 (LHD)
108 (RHD)
88 (LHD)
108 (RHD)
IO1
108 (RHD)
IP1
108 (RHD)
IR1
108 (RHD)
: Ground Points
Code
EC
EE
EF
IJ
IK
IP
See Page
78 (*3)
98 (*7)
78 (*3)
98 (*7)
78 (*3)
98 (*7)
86 (LHD)
106 (RHD)
106 (RHD)
86 (LHD)
106 (RHD)

Left Kick Panel
Right Kick Panel
: Splice Points
Code
E3
See Page
78 (*3)

Engine Wire
Code
I3
See Page
108 (RHD)

Engine Wire
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
305
AVENSIS (EWD526E)
http://vnx.su
ECT and A/T Indicator (1AZFE)

BY
GR
P
1
10 IC1
10A
GAUGE1
7. 5A
DOME
WR
11
MPX1
F A (LHD)
F C
F C (RHD)
RW
WR
(RHD)
RW
I14
Integration
Relay
MPX2
22
7 CA
PB
J10(A), J11(B), J26(C)

Junction
Connector
RW
7 DB
1 CG
H B
GR
6 CD
(LHD)
RW
BW
BY
20 B
4
PB
BY
1 IC1
WR
21 B
14 A
1
10A EFI NO. 1
20A EFI
EFI
Relay
3
Speedometer
5
2
A/T SHIFT
CLOCK
BEAN
I/F
2
1
4
CPU
19 B
18 B
13 A
WB
LW
VW
6 CK
16 IE1
5 B
C10(A), C11(B)
Combination Meter
12 EA1
WB
BG
1 4B
LW
BR
1 4A
BR
BG
BW
1 1A
WB
6 CA
(LHD)
6 CJ
(1)
FL MAIN
3. 0W
WB
WB
P
VW
WB(1)
WB
BR
LW
Battery
WB
(LHD)
EC
IP
306
AVENSIS (EWD526E)
http://vnx.su

BY
10A IGN
GR
P
1
2
3
4
: Europe
: Unleaded Gasoline
: Automatic A/C
18 DA
2 IE1
7 IE3 (LHD)
7 IO1 (RHD)
PB
GR
BY
WB
22 A
21 A
20 B
29 A
8 A
3 A
SFTU
SFTD
SPT1
MREL
MPX2
1
E D
9 A
BATT
T4
BW
BW
SFTD
SFTU
(LHD)
2
C A (LHD)
A C (RHD)
BO
MPX+
9 A (3)
10 B (4)
C A
BW
MPX
(RHD)
IG
J 8(A), J26(C), J27(D)

Junction Connector
29 A (3)
20 B (4)
BY
GR
T7
Transmission
Control SW
A13(A), A15(B)
RW
27 C
35 C
NT+
IGSW
NT
E 9(A), E10(B), E12(C), E13(D)

E02
E1
6 D
7 C
BR
E01
7 D
WB
E04
4 C
WB
E05
3 C
EOM
15 A
BR
(2)
WB
WB
2 IG1
(2)
VW
+B
1 A
BR
KD
27 A
17 B
(1)
SPD
MPX1
23 A
D B
1
E A
VW
1 IG1
(1)
WB
WB
(RHD)
(LHD)
VW
WB
J12(A), J13(B)
Junction Connector
K2
Kick Down SW
H A (LHD)
H C (RHD)
BR
(1)
J10(A), J20(C)
Junction Connector
J17
Junction
Connector
8 IK1
H A (LHD)
H C (RHD)
LW
BR
BR
WB
WB
(2)
WB
BR
(2)
WB
WB(1)
LW
A
J15
Junction
Connector
IK
EE
EF
307
AVENSIS (EWD526E)
http://vnx.su

15A
STOP
2 IR1
GW
6 IE3
(RHD)
GW
11 IE3
(LHD)
RW
(LHD)
RW
(RHD)
22 DA
1 IR1
GW
(RHD)
GW
(LHD)
RW
(LHD)
RW
2
(RHD)
2 DA
C5
Counter Gear
Speed Sensor
10 DC
S13
Stop
Light SW
LG
LGB
GW
26 C
34 C
NC
19 B
NC
STP
E 9(A), E10(B), E12(C), E13(D)

BR
10
E2
THO
SLT+
SLT
DSL
SL2+
SL2
SL1+
SL1
S4
YB
S4
13 C
SL1
18 C
RB
SL1+
19 C
BR
SL2
16 C
LB
SL2+
17 C
DSL
11 C
PL
SLT
16 D
BR
SLT+
17 D
E2
30 D
LW
BW
THO
VTA1
21 D
BR
VC
18 D
RW
E2
28 D
BR
THW
19 D
T2
Throttle
Position
Sensor
BR
E 3 : LHD
I 3 : RHD
E1
ECT Solenoid
LW
LW
308
AVENSIS (EWD526E)
http://vnx.su
7. 5A
GAUGE2
7. 5A
ST
BW
RW
N1
Neutral Start SW
9
P
27 DA
RL
PL
8 CA
WL
NL
RY
DL
BY
J12(A), J13(B)
Junction Connector
10 IK2
9 IK2
5 IK1
20 IK2
1 CD
RY
RW
B A
LGB
BW
B B
3
RB
RW
J22(A), J23(B)
Junction
Connector
LGB
(RHD)
RY
(LHD)
10 B
11 B
STA
RW
C
RY
9 C
WL
(RHD)
RY
1 IK1
(LHD)
J14
Junction
Connector
LGB
(LHD)
A A
C B
LGB
BY
A A
(LHD)
A A
J12(A)
Junction Connector
BY
BW
(RHD)
J5
Junction
Connector
D A (LHD)
D B (RHD)
A A
A B
E 9(A), E10(B), E12(C), E13(D)

WL
A A
A B
22 B
D A
D B
D2
Diode
21 B
D A (LHD)
D B (RHD)
A A
A B
WL
WL
J18(A), J29(B)
Junction Connector
LW
LW
1 IE2
23
21
SP1
PN
S2
Skid Control ECU
with Actuator
309
AVENSIS (EWD526E)
http://vnx.su

System Outline
Previous automatic transaxle have selected each gear shift using mechanically controlled throttle hydraulic pressure,
governor hydraulic pressure and lockup hydraulic pressure. The ECT, however, electrically controls the line pressure,
throttle pressure, lockup pressure and accumulator pressure etc. through the solenoid valve. The ECT is a system which
precisely controls gear shift timing and lockup timing in response to the vehicles driving conditions and the engine
condition detected by various sensors. It makes smooth driving possible by shift selection for each gear which is the most
appropriate to the driving conditions at that time, and by preventing downing, squat and gear shift shock when starting off.
time, the throttle valve opening signal from the throttle position sensor is input to TERMINAL VTA1 of the engine and ECT
2. LockUp Operation
When each signal makes engine and ECT ECU recognize that LOCKUP condition is satisfied, the current flows from
engine and ECT ECU TERMINAL DSL to ECT solenoid TERMINAL DSL. At the same time, the current flows engine and
ECT ECU TERMINAL SL1+ to ECT solenoid TERMINAL SL1+ and from TERMINAL SL1 to engine and ECT ECU
TERMINAL SL1. This works LOCKUP solenoid to perform LOCKUP operation.
the shift lever.
Service Hints
E10 (B), E12 (C), E13 (D) Engine and ECT ECU (A/T)
THOE2 : Below 1.0 volts (Ignition SW on and AFT temperature 110 C (230 F)
SLT+ SLT: 10.014.0 volts (Ignition SW on)
N1 Neutral Start SW
310
AVENSIS (EWD526E)
http://vnx.su
: Parts Location
Code
A13
See Page
46 (LHD)
A15
66 (RHD)
46 (LHD)
66 (RHD)
E9
E10
J23
68 (RHD)
J26
68 (RHD)
67 (RHD)
J27
68 (RHD)
47 (LHD)
J29
68 (RHD)
48 (LHD)
A
48 (LHD)
48 (LHD)
66 (RHD)
J11
48 (LHD)
J12
J13
48 (LHD)
68 (RHD)
48 (LHD)
68 (RHD)
40 (*4)
J14
48 (LHD)
60 (*8)
J15
68 (RHD)
47 (LHD)
48 (LHD)
J17
67 (RHD)
47 (LHD)
J8
60 (*8)
68 (RHD)
J10
40 (*4)
E2
67 (RHD)
See Page
A
46 (LHD)
67 (RHD)
E1
J22
67 (RHD)
J5
Code
47 (LHD)
66 (RHD)
47 (LHD)
D2
D
I14
46 (LHD)
See Page
C
E13
60 (*8)
A
C11
E12
40 (*4)
C5
C10
Code
68 (RHD)
47 (LHD)
J18
48 (LHD)
67 (RHD)
J20
68 (RHD)
K2
48 (LHD)
41 (*4)
N1
61 (*8)
41 (*4)
S2
61 (*8)
49 (LHD)
S13
69 (RHD)
41 (*4)
T2
61 (*8)
41 (*4)
T4
61 (*8)
49 (LHD)
T7
69 (RHD)
: Relay Blocks
Code
See Page
24 (*1)
27
29

Code
1A
4A
4B
CA
CD
See Page
27
34
CG
CJ
24 (*1)
35
CK
DA
DB
30
DC
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
311
AVENSIS (EWD526E)
http://vnx.su

Code
EA1
IC1
IE1
IE2
See Page
80 (*4)
100 (*8)
86 (LHD)
106 (RHD)

86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
IE3
86 (LHD)
IG1
88 (LHD)
IK1
IK2
88 (LHD)
108 (RHD)
88 (LHD)
108 (RHD)
IO1
108 (RHD)
IR1
108 (RHD)
: Ground Points
Code
EC
EE
EF
IK
IP
See Page
80 (*4)
100 (*8)
80 (*4)
100 (*8)
80 (*4)
100 (*8)
106 (RHD)
86 (LHD)
106 (RHD)

Right Kick Panel
: Splice Points
Code
E3
See Page
80 (*4)

Engine Wire
Code
I3
See Page
108 (RHD)

Engine Wire
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
312
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
Memo
313
AVENSIS (EWD526E)
http://vnx.su
ECT and A/T Indicator (1ZZFE)

BY
GR
P
From Power Source
7. 5A
ECUB 2
10A
GAUGE1
10 IC1
6
11 A
I14(A)
Integration Relay
22
MPX1
7 DB
WR
IG
E
B
23
25
MPX2
SNOW
RW
22 A
16 DB
9 DA
14 DA
WR
WB
10 CC
4
4
1
10A EFI NO. 1
20A EFI
EFI
Relay
3
PB
WB
5
2
1 IC1
PB
BW
BY
E8
GR
BY
3 CD
2
1
4
BR
BW
BG
WB
4
1 1A
PB
12 EA1
BR
1 4A
BG
1 4B
FL MAIN
3. 0W
WB
WB
WB
BR
Battery
IJ
EC
314
AVENSIS (EWD526E)
http://vnx.su
BY
BY
GR
GR
7. 5A
DOME
RW
6
RW
7 CA
1 CG
(RHD)
F A (LHD)
F C
F C (RHD)
6 CD
RW
J10(A), J11(B), J26(C)

Junction
Connector
WR
WR
RW
RW
H B
20 B
21 B
WR
Speedometer
(LHD)
A/T SHIFT
CLOCK
BEAN
I/F
19 B
18 B
13 A
PB
C10(A), C11(B)
Combination Meter
VW
PB
5 B
WB
14 A
LW
CPU
WB
6 CK
(LHD)
16 IE1
LW
WB
WB
6 CJ
(LHD)
WB
VW
6 CA
WB
11 CF (LHD)
8 CH (RHD)
WB(LHD)
BR
BR
LW
WB
(LHD)
IP
315
AVENSIS (EWD526E)
http://vnx.su

BY
GR
2 : Automatic A/C
2 IE1
PB
GR
BY
7 IE3 (LHD)
7 IO1 (RHD)
WB
SFTD
23 B
30 B
8 B
29 A
8 A
3 A
SFTU
SFTD
SPT
MREL
MPX2
BATT
SFTU
MPX+
9 A (1)
10 B (2)
BO
MPX
T4
IG
29 A (1)
20 B (2)
BY
GR
T7
A13(A), A15(B)
RW
27 C
35 C
NT+
NT
E 9(A), E10(B), E12(C), E13(D)

E1
7 C
BR
E03
5 C
WB
E02
6 D
WB
E01
7 D
WB
VW
+B
1 A
BR
KD
12 B
17 B
(LHD)
SPD
MPX1
23 A
2 IG1
VW
W
1
WB
(RHD)
WB
VW
BR
(LHD)
K2
Kick Down SW
H A (LHD)
H C (RHD)
WB
(LHD)
J10(A), J20(C)
Junction Connector
J17
Junction
Connector
H A (LHD)
H C (RHD)
(LHD)
8 IK1
A
1 IG1
WB(LHD)
BR
LW
LW
A
J15
Junction
Connector
IK
EG
316
AVENSIS (EWD526E)
http://vnx.su
EH
10A
IGN
15A
STOP
GW
6 IE3
(RHD)
GW
(LHD)
RW
11 IE3
1 IR1
BW
2 IR1
(LHD)
RW
(RHD)
22 DA
18 DA
GW
(RHD)
GW
(LHD)
RW
(LHD)
RW
C A (LHD)
A C (RHD)
C A
(RHD)
2 DA
10 DC
J 8(A), J26(C),
J27(D)
Junction
Connector
S13
Stop
Light SW
GW
BW
(RHD)
BW
(LHD)
E D
9 A
19 B
IGSW
STP
E 9(A), E10(B), E12(C), E13(D)

10
OT
SLT+
SLT
S1
S2
SL
SB
ST
LG
RB
6
E2
ST
12 C
SB
19 C
SL
13 C
PL
S2
14 C
GR
S1
15 C
PL
SLT
16 D
T2
Throttle
Position
Sensor
BR
BR
LW
SLT+
17 D
RW
THO
30 D
BR
21 D
BR
VTA
18 D
E2
BW
VC
E2
28 D
THW
19 D
I3
BR
I3
E1
ECT Solenoid
LW
LW
317
AVENSIS (EWD526E)
http://vnx.su

N1
Neutral Start SW
7. 5A
GAUGE2
7. 5A ST
RW
3
RB
P
6
27 DA
NL
RL
PL
LGB
RY
WL
10 IK2
9 IK2
5 IK1
20 IK2
1 CD
RW
WL
RY
1 IK1
RW
C B
RY
(RHD)
RY
(RHD)
LGB
BY
A A
J12(A)
Junction Connector
A A
J22(A), J23(B)
Junction
Connector
A A
(LHD)
(RHD)
BY
BW
8 CA
RY
B A
J12(A), J13(B)
Junction Connector
B B
DL
6
RW
BW
RY
(LHD)
J5
Junction
Connector
10 B
11 B
STA
E 9(A), E10(B), E12(C), E13(D)

D A (LHD)
D B (RHD)
A A
A B
A A
A B
WL
D A
D B
LW
1 IE2
LW
D A (LHD)
D B (RHD)
A A
A B
D2
Diode
N
22 B
WL
P
21 B
WL
J18(A), J29(B)
Junction Connector
9 C
23
21
SP1
S2
Skid Control ECU
with Actuator
318
AVENSIS (EWD526E)
http://vnx.su
PN
System Outline
Engine and ECT ECU controls of the solenoid valve based on the input signals from each sensor which makes smooth
driving possible by shift selection for each gear which is most appropriate to the driving conditions at that time.
time, the throttle valve opening signal from the throttle position sensor is input to TERMINAL VTA of the engine and ECT
the shift lever.
Service Hints
E10 (B), E12 (C) Engine and ECT ECU (A/T)
N1 Neutral Start SW
: Parts Location
Code
A13
See Page
A
A15
C10
C11
B
D2
E1
46 (LHD)
66 (RHD)
46 (LHD)
66 (RHD)
46 (LHD)
66 (RHD)
46 (LHD)
E12
E13
I14
J5
68 (RHD)
47 (LHD)
J22
68 (RHD)
67 (RHD)
J23
68 (RHD)
47 (LHD)
J26
68 (RHD)
67 (RHD)
J27
68 (RHD)
47 (LHD)
J29
68 (RHD)
67 (RHD)
48 (LHD)
48 (LHD)
67 (RHD)
J10
48 (LHD)
42 (*5)
J11
48 (LHD)
J12
B
J15
47 (LHD)
J18
48 (LHD)
68 (RHD)
48 (LHD)
68 (RHD)
68 (RHD)
48 (LHD)
J17
67 (RHD)
47 (LHD)
J13
67 (RHD)
E10
47 (LHD)
68 (RHD)
A
See Page
J20
J8
62 (*9)
E9
Code
67 (RHD)
47 (LHD)
42 (*5)
E8
See Page
B
66 (RHD)
62 (*9)
E2
Code
E10
48 (LHD)
K2
N1
S2
S13
T2
T4
T7
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
48 (LHD)
43 (*5)
63 (*9)
43 (*5)
63 (*9)
49 (LHD)
69 (RHD)
43 (*5)
63 (*9)
43 (*5)
63 (*9)
49 (LHD)
69 (RHD)
* 6 : LHD 1CDFTV
319
AVENSIS (EWD526E)
http://vnx.su

: Relay Blocks
Code
See Page
24 (*1)
27
29

Code
1A
4A
4B
See Page
24 (*1)
27
CA
CC
CD
34
CF
CG
CH
CJ
35
CK
DA
DB
30
DC

Code
EA1
IC1
See Page
82 (*5)
102 (*9)
86 (LHD)
106 (RHD)

86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
IE3
86 (LHD)
IG1
88 (LHD)
IE1
IE2
IK1
IK2
88 (LHD)
108 (RHD)
88 (LHD)
108 (RHD)
IO1
108 (RHD)
IR1
108 (RHD)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
320
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
: Ground Points
Code
EC
EG
EH
IJ
IK
IP
See Page
82 (*5)
102 (*9)

82 (*5)
102 (*9)
82 (*5)
102 (*9)
86 (LHD)
106 (RHD)
106 (RHD)
86 (LHD)
106 (RHD)
Left Kick Panel

Right Kick Panel
: Splice Points
Code
I3
See Page
88 (LHD)

Engine Wire
Code
I3
See Page
108 (RHD)

Engine Wire
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
321
AVENSIS (EWD526E)
http://vnx.su
Cruise Control (1AZFSE)

LW
BY
GR
RW(1)
RW(2)
1
P
P
7. 5A
DOME
10A
GAUGE1
10 IC1
11
MPX1
MPX2
F A (LHD)
F C
F C (RHD)
7 CA
H B
6 CD
I14
Integration Relay
RW
WR
(RHD)
WR
J10(A), J11(B), J26(C)

Junction
Connector
GR
BY
RW(2)
7 DB
6
RW(1)
22
PB
8 CE
1 IC1
(LHD)
4
PB
WR
RW
BY
21 B
14 A
4
20 B
1
EFI
Relay
BW
CRUISE
BEAN
I/F
WB
Speedometer
20A EFI
CPU
18 B
WB
VW
16 IE1
6 CK
BG
19 B
4
1 4A
C10(A), C11(B)
Combination Meter
13 A
5 B
LW
1 1A
BG
1 4B
LW
10A EFI NO. 1
2
6 CA
VW
BR
FL MAIN
3. 0W
WB
Battery
WB
BR
EC
IP
322
AVENSIS (EWD526E)
http://vnx.su
LW
LW
BW(LHD)
BY
BW(RHD)
9
IE2
RW(1)
RW(2)
5
IR1
10A IGN
GR
RW(1)
RW(2)
BW
18 DA
1
C9
Clutch
Start SW
BY
3 A
MREL
BW
BY
8 A
BW
(RHD)
BW
C B (LHD)
E D (RHD)
(RHD)
BW
GR
(2)
10 B
MPX2
7 IE3 (LHD)
7 IO1 (RHD)
E D
LGB
LGB
29 B
2 IE1
(1)
PB
C A
(LHD)
C A
(2)
GR
LGB
J14(A)
Junction
Connector
10
(LHD)
BW
J 8(A), J 9(B), J26(C), J27(D)

Junction Connector
(2)
LGB
(1)
LGB
6 IR1
J19
Junction
Connector
MPX+
C A (LHD)
A C (RHD)
C A
15 IE2
(1)
MPX
LGB
20
A15
9 A
BATT
IGSW
E 9(A), E10(B), E11(C), E12(D), E13(E)

Engine ECU (M/T)
+B
J10(A), J20(C)
Junction Connector
E03
7 C
E01
7 E
E1
E02
1 C
6 E
D A (LHD)
D B (RHD)
D B
D B
J12(A), J13(B)
Junction Connector
BR
WB
WB
WB
WB
BR
VW
2 IE4 (LHD)
3 IP1 (RHD)
E A
BR
BR
VW
EOM
15 A
D A (LHD)
D B (RHD)
H A (LHD)
H C (RHD)
ME01
4 C
BR
D A
D B
H A (LHD)
H C (RHD)
+B2
2 A
BR
BR
VW
1 A
J14(A), J28(B)
Junction Connector
SPD
17 B
BR
MPX1
18 B
BR
1 : LHD M/T
2 : RHD M/T
BR
EF
EE
E 3 : LHD
I 3 : RHD
323
AVENSIS (EWD526E)
http://vnx.su

LW
LW
BW(LHD)
BW(RHD)
15A
STOP
GW
(RHD)
(LHD)
GW
1 IR1
GW
GW
RW
(LHD)
6 IE3
2 DA
(RHD)
11 IE3
(LHD)
RW
(LHD)
(RHD)
RW
RW
2 IR1
(RHD)
BW
(LHD)
BW
BW
20 IE1
(RHD)
3 IR1
(LHD)
BW
(RHD)
(LHD)
GW
GW
GW
14 IE2
(RHD)
GW
(RHD)
GW
(LHD)
4 IR1
(LHD)
GW
(RHD)
22 DA
10 DC
S13
Stop Light SW
GW
12 B
19 B
ST1
STP
E 9(A), E10(B), E11(C), E12(D), E13(E)

Engine ECU (M/T)
M
2 C
M+
3 C
BR
E B
Cruise Control SW
C14
Combination SW
E B
J13(B)
Junction Connector
CCS
CRUISE
(Shielded)
21 E
LW
VTA1
31 E
BR
VTA2
18 E
RW
VC
28 E
BR
E2
CCS
24 B
RES/ACC
SET/COAST
T1
and Position Sensor
CANCEL
ECC
BR
324
AVENSIS (EWD526E)
http://vnx.su
GE01
17 C
LW
10A
THROTTLE
7. 5A
ST
10A
TAIL
S1
35
4 DM
BW
SP1
ENG
NEO
TRC+
TRC
18
19
GR
32
J30
Junction
Connector
ENG+
YB
J12(A), J13(B)
Junction Connector
B B
3 IC2
31 A
TRC+
N1
Neutral
Start SW
12 A
6 B
TRC
GY
25 A
NEO
BY
BW
N
17 E
STA
ELS
+BM
6
BY
YB
(M/T)
C B (LHD)
C D (RHD)
17 A
ENG
A A
E 9(A), E10(B), E11(C), E12(D), E13(E)

Engine ECU (M/T)
EP1
EP2
(LHD)
(RHD)
(LHD)
(RHD)
7 IG2
W
W
(LHD)
(RHD)
2 IG2
4 (LHD)
6 (RHD)
2
2
1
3
VCP1
VCP2
27 A
(LHD)
(LHD)
Y
Y
6
4
VPA1
VPA2
23 A
3 IG2
(RHD)
(LHD)
(RHD)
5 IG2
5
5
3
1
EPA2
29 A
(LHD)
G
G
(LHD)
(RHD)
6 IG2
(LHD)
1 IG2
(LHD)
(LHD)
VCPA
26 A
(LHD)
VPA
22 A
EPA
28 A
(LHD)
(RHD)
30 A
ENG+
A A
BY
C A (LHD)
C C (RHD)
5 IE2
24 A
B A
(A/T)
13 IE8 (LHD)
3 IE2 (RHD)
6 IE8
13 IE2
(A/T)
5 IE8
13 IE1
14 IE8
14 IE2
J10(A), J11(B), J26(C), J27(D)

Junction Connector
7 IE8
15 IE2
VPA2
VCP2
A20
325
AVENSIS (EWD526E)
http://vnx.su

System Outline
The cruise control system is a fixed speed driving control function that, when you want to drive your car on a highway at a
fixed speed, automatically adjusts the opening of the throttle valve simply by manually operating the cruise control SW
without stamping on the accelerator pedal.
1. Set Operation
When the cruise control main SW is turned on, the system starts preparations necessary for the cruiser control and turns on
the CRUISE indicator light in the combination meter.
2. Set Speed Control
When the SET/COAST SW is operated with the cruise control main SW turned on during travelling, the constant vehicle
speed is controlled.
3. Coast Control
When the SET/COAST SW is kept on during cruise control driving, this system reduces the requested cruise control opening
to 0 to decelerate the car (However, the throttle valve is not fully closed by the ISC, etc.), and stores the car speed at the
time the SW is turned off, and provides fixed speed control.
4. Accel Control
When the RESUME/ACCEL SW is kept on during cruise control driving, this system performs fixed acceleration control by
running the electronic throttle motor in the opening direction of the throttle valve, and stores the car speed at the time the SW
is turned off, and provides fixed speed control.
5. Resume Control
If the driving speed is still above the lower speed limit after cruise control by signals is canceled with the stop light SW on,
the clutch SW off, the CANCEL SW of the cruise control SW on, and the VSC activated, fixed acceleration control is
performed by setting the RESUME/ACCEL SW from off to on to reset the car speed to the speed stored at the time of
cancellation.
6. TapUp Control Function
This function increases the stored car speed by approximately 1.5 km/h each time the RESUME/ACCEL SW is
instantaneously (For approximately 0.5 seconds) turned on.
However, if the difference between the stored and actual car speeds is 5 km/h or more, the stored car speed cannot be
changed by this operation.
7. TapDown Control Function
This function reduces the stored car speed by approximately 1.5 km/h each time the SET/COAST SW is instantaneously
(For approximately 0.5 seconds) turned on.
However, if the difference between the stored and actual car speeds is 5 km/h or more, the car speed at the time the switch
is turned off is stored for fixed speed control by tapdown operation.
8. Manual Cancel Mechanism
If any of the following signals is input during cruise control travelling, the cruise control is cancelled.
The stop light SW is turned on.
The clutch SW is turned off.
The CANCEL SW is turned on.
The cruise control main SW is turned off.
The VSC is activated.
9. Auto Cancel Function
A) If either of the following problems occurs, the stored speed will be cleared, and control will be canceled.
In this case, the CRUISE indicator will remain flickering until the main SW is turned off, and control will stay disabled until
the main SW is turned on.
The stop light SW is disconnected or shorted.
The vehicle speed signal is faulty.
The electronically controlled throttle malfunctions.
B) If any of the following problems occurs, the stored speed will be cleared, and control will be canceled.
the ignition SW is turned off.
The stop light SW input circuit is malfunctioning.
The cancel circuit is malfunctioning.
C) If any of the following conditions occurs during cruise control operation, the set speed is erased and the cruise control is
released.
When the vehicle speed falls below the minimum speed limit (Approx. 40 km/h 25 mph).
The driving speed is more than 16 km/h below the stored car speed.
326
AVENSIS (EWD526E)
http://vnx.su
Service Hints
E9 (A), E10 (B), E11 (C), E13 (E) Engine and ECT ECU (A/T) or Engine ECU (M/T)
(A) 9Ground : Approx. 12 volts with the ignition SW at ON position
(A) 1, (A) 2, (A) 3, (B) 6Ground : Always approx. 12 volts
(A)15, (C) 1, (C) 4, (C) 7, (E) 6, (E) 7Ground : Always continuity
(B) 19Ground : Approx. 12 volts with the stop light SW at on
(B) 24Ground : Continuity with the cruise control main SW at on
Approx. 1540 with the CANCEL SW on in cruise control SW
Approx. 240 with the RES/ACC SW on in cruise control SW
Approx. 630 with the SET/COAST SW on in cruise control SW
C14 Combination SW
23 : Approx. 1540 with the CANCEL SW on
Approx. 240 with the RES/ACC SW on
Approx. 630 with the SET/COAST SW on
: Parts Location
Code
See Page
46 (LHD)
A15
66 (RHD)
46 (LHD)
A20
66 (RHD)
C11
E11
67 (RHD)
J28
68 (RHD)
47 (LHD)
51 (LHD S/D)
67 (RHD)
53 (LHD L/B)
67 (RHD)
J30
55 (LHD W/G)
71 (RHD S/D)
48 (LHD)
73 (RHD L/B)
66 (RHD)
J9
48 (LHD)
75 (RHD W/G)
46 (LHD)
J10
48 (LHD)
66 (RHD)
J11
48 (LHD)
67 (RHD)
47 (LHD)
J12
J13
J14
67 (RHD)
68 (RHD)
47 (LHD)
47 (LHD)
I14
See Page
J27
J8
66 (RHD)
A
E10
E13
Code
47 (LHD)
46 (LHD)
46 (LHD)
C14
E9
66 (RHD)
A
See Page
E12
46 (LHD)
C9
C10
Code
J19
48 (LHD)
68 (RHD)
48 (LHD)
68 (RHD)
48 (LHD)
68 (RHD)
47 (LHD)
J20
68 (RHD)
67 (RHD)
J26
68 (RHD)
N1
S1
S13
T1
39 (*3)
59 (*7)
39 (*3)
59 (*7)
49 (LHD)
69 (RHD)
39 (*3)
59 (*7)
: Relay Blocks
Code
See Page
24 (*1)
27
29
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
327
AVENSIS (EWD526E)
http://vnx.su

Code
1A
4A
4B
See Page
24 (*1)
27
CA
CD
34
CE
CK
35
DA
DB
30
31
DC
DM

Code
IC1
IC2
See Page
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
IG2
88 (LHD)
IO1
108 (RHD)
IP1
108 (RHD)
IR1
108 (RHD)
IE1
IE2
IE3
IE4
IE8
: Ground Points
Code
See Page
78 (*3)
EC
98 (*7)
104 (*10)
EE
EF
IP
78 (*3)
98 (*7)
78 (*3)
98 (*7)
86 (LHD)
106 (RHD)

Right Kick Panel
: Splice Points
Code
E3
See Page
78 (*3)

Engine Wire
Code
I3
See Page
108 (RHD)

Engine Wire
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
328
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
Memo
329
AVENSIS (EWD526E)
http://vnx.su
Cruise Control (1CDFTV)

BY
BY
GR
GR
RW(LHD)
1
RW(RHD)
10A
GAUGE1
2
7 DB
11
8 CE
F A (LHD)
F C
F C (RHD)
MPX1
MPX2
I14
Integration Relay
RW
(RHD)
WR
22
PB
6 CD
RW
J10(A), J11(B), J26(C)

Junction
Connector
GR
BY
10 IC1
7 CA
2 IE1
WR
7 IE3 (LHD)
7 IO1 (RHD)
RW(RHD)
RW(LHD)
7. 5A
DOME
H B
WR
PB
BY
1 IC1
5
EFI MAIN
Relay
(LHD)
20 B
3
14 A
21 B
C10(A), C11(B)
Combination Meter
1
1
CRUISE
BEAN
I/F
WB
BW
20A EFI
Speedometer
CPU
LW
13 A
16 IE1
BW
6 CK
18 B
LW
WB
10 EE1
19 B
6 CA
(w/o VSC)
5 B
VW
1 1A
VW
23
SP1
WB
FL MAIN
3. 0W
S2
Skid Control ECU
with Actuator
BW
Battery
LW
(w/ VSC)
EC
IP
330
AVENSIS (EWD526E)
http://vnx.su
BY
GR
5
IR1
RW
RW
(LHD)
BW(LHD)
(RHD)
RW(RHD)
10A
IGN
9
IE2
RW(LHD)
18 DA
BW(RHD)
BW
C9
Clutch
Start SW
J 8(A), J 9(B), J26(C), J27(D)

Junction Connector
C B (LHD)
E D (RHD)
9 A
BATT
BW
BW
2 B
(RHD)
BY
8 A
MREL
(LHD)
GR
10 B
MPX2
LGB
LGB
21 A
(RHD)
PB
(LHD)
E D
BW
6 IR1
(RHD)
LGB
15 IE2
(RHD)
LGB
MPX+
9 A (1)
10 B (2)
BW
C A (LHD)
A C (RHD)
C A
(LHD)
MPX
(LHD)
A13(A), A15(B)
2
29 A (1)
20 B (2)
IGSW
E 9(A), E10(B), E12(C), E13(D)

Engine ECU (M/T)
I3
BW
I3
BW
I3
BW
8 IK1
BW
BW

2 : Automatic A/C
BW
B1
5
BW
BW
B2
VW
+B
1 A
D1
BW
J10(A), J20(C)
Junction Connector
H A (LHD)
H C (RHD)
S2
S4
LUB
12 D
BW
S1
LU+B
13 D
S3
LUA
14 D
H A (LHD)
H C (RHD)
LU+A
15 D
EGB
3 C
E3
EG+B
4 C
GB
EGA
5 C
RL
EG+A
6 C
YG
VW
17 B
SP1
MPX1
20 A
I3
LW
LW
(w/ VSC)
(w/ VSC)
331
AVENSIS (EWD526E)
http://vnx.su

15A
STOP
BW(LHD)
22 DA
GW
(RHD)
(LHD)
GW
2 DA
(RHD)
GW
GW
1 IR1
(LHD)
RW
(LHD)
6 IE3
11 IE3
RW
RW
(RHD)
2 IR1
(LHD)
RW
(RHD)
(LHD)
BW
BW
20 IE1
(LHD)
(RHD)
BW
BW
3 IR1
(RHD)
(LHD)
GW
GW
GW
14 IE2
(RHD)
GW
(RHD)
GW
(LHD)
4 IR1
(LHD)
GW
(RHD)
BW(RHD)
10 DC
S13
Stop Light SW
GW
12 B
19 B
ST1
STP
E 9(A), E10(B), E12(C), E13(D)

Engine ECU (M/T)
E2
PR2
ENG+
ENG
NEO
35
LW
332
AVENSIS (EWD526E)
http://vnx.su
19
TRC+
TRC
S1
(w/ VSC)
(w/ VSC)
18
SP1
F16
(w/ VSC)
YB
(w/ VSC)
32
PR
13 IE8 (LHD)
3 IE2 (RHD)
(w/ VSC)
6 IE8
13 IE2
E2S
TRC
31 A
(w/ VSC)
VCS
5 IE8
13 IE1
YB
VC
14 IE8
14 IE2
TRC+
25 A
(w/ VSC)
BR
7 IE8
15 IE2
PB
2 EB1
NEO
17 A
PB
P
5 EB1
ENG
30 A
BR
3 EB1
BR
RW
1 EB1
RW
RW
6 EB1
RW
BR
4 EB1
ENG+
24 A
(w/ VSC)
PCR2
33 D
(w/ VSC)
PCR1
26 D
(w/ VSC)
E2S
1 C
(w/ VSC)
VCS
2 C
VC
18 D
E2
28 D
A20
7. 5A
ST
EP1
VPA1
5
5
EP2
VPA2
1
3
6
4
VCP2
4 (LHD)
6 (RHD)
2
2
C B
B A
A A
BY
BY
(LHD)
B B
J12(A), J13(B)
Junction
Connector
(RHD)
(LHD)
(RHD)
W
W
7 IG2
(LHD)
(LHD)
(RHD)
2 IG2
(LHD)
3 IG2
(LHD)
5 IG2
(LHD)
(RHD)
(LHD)
(RHD)
(LHD)
G
G
6 IG2
(LHD)
1 IG2
(LHD)
(RHD)
(LHD)
BW
3
1
VCP1
28 A
22 A
EPA
26 A
VPA
29 A
VCPA
23 A
EPA2
27 A
VPA2
7 A
VCP2
STA
E 9(A), E10(B), E12(C), E13(D)

Engine ECU (M/T)
THOP
E1
7 C
CCS
EOM
15 A
24 B
CCS
CRUISE
D B
D B
C14
Combination SW
BR
BR
WB
I3
E B
E B
J12(A), J13(B)
Junction
Connector
Cruise Control SW
T3
WB
RES/ACC
SET/COAST
CANCEL
E A
ECC
BR
BR
BR
WB
WB
PL
11 D
E01
7 D
BR
E02
6 D
EI
333
AVENSIS (EWD526E)
http://vnx.su

System Outline
The cruise control system is a fixed speed driving control function that, when you want to drive your car on a highway at a
fixed speed, controls the fuel injection simply by manually operating the cruise control SW without stamping on the
accelerator pedal.
1. Set Operation
When the cruise control main SW is turned on, the system starts preparations necessary for the cruiser control and turns on
the CRUISE indicator light in the combination meter.
2. Set Speed Control
When the SET/COAST SW is operated with the cruise control main SW turned on during travelling, the constant vehicle
speed is controlled.
3. Coast Control
When the SET/COAST SW is kept on during cruise control driving, this system reduces the requested cruise control opening
to 0 to decelerate the car (However, the throttle valve is not fully closed by the ISC, etc.), and stores the car speed at the
time the SW is turned off, and provides fixed speed control.
4. Accel Control
When the RESUME/ACCEL SW is kept on during cruise control driving, this system performs fixed acceleration control in
the direction the fuel injection increases, and stores the car speed at the time the SW is turned off, and provides fixed speed
control.
5. Resume Control
If the driving speed is still above the lower speed limit after cruise control by signals is canceled with the stop light SW on,
the clutch SW off, the CANCEL SW of the cruise control SW on, and the VSC activated (w/ VSC), fixed acceleration control
is performed by setting the RESUME/ACCEL SW from off to on to reset the car speed to the speed stored at the time of
cancellation.
6. TapUp Control Function
This function increases the stored car speed by approximately 1.5 km/h each time the RESUME/ACCEL SW is
instantaneously (For approximately 0.5 seconds) turned on.
However, if the difference between the stored and actual car speeds is 5 km/h or more, the stored car speed cannot be
changed by this operation.
7. TapDown Control Function
This function reduces the stored car speed by approximately 1.5 km/h each time the SET/COAST SW is instantaneously
(For approximately 0.5 seconds) turned on.
However, if the difference between the stored and actual car speeds is 5 km/h or more, the car speed at the time the SW is
turned off is stored for fixed speed control by tapdown operation.
8. Manual Cancel Mechanism
If any of the following signals is input during cruise control travelling, the cruise control is cancelled.
The stop light SW is turned on.
The clutch SW is turned off.
The CANCEL SW is turned on.
The cruise control main SW is turned off.
The VSC is activated (w/ VSC).
9. Auto Cancel Function
A) If either of the following problems occurs, the stored speed will be cleared, and control will be canceled.
the main SW is turned on.
The stop light SW is disconnected or shorted.
The vehicle speed signal is faulty.
The fuel injection unit is malfunctioning.
B) If any of the following problems occurs, the stored speed will be cleared, and control will be canceled.
the ignition SW is turned off.
The stop light SW input circuit is malfunctioning.
The cancel circuit is malfunctioning.
C) If any of the following conditions occurs during cruise control operation, the set speed is erased and the cruise control is
released.
When the vehicle speed falls below the minimum speed limit (Approx. 40 km/h 25 mph).
The driving speed is more than 16 km/h below the stored car speed.
334
AVENSIS (EWD526E)
http://vnx.su
Service Hints
E9 (A), E10 (B), E12 (C), E13 (D) Engine ECU (M/T)
(A) 1, (B) 2Ground : Always approx. 12 volts
(A) 15, (C) 7, (D) 6, (D) 7Ground : Always continuity
(B) 19Ground : Approx. 12 volts with the stop light SW at on
(B) 24Ground : Continuity with the cruise control main SW at on
Approx. 1540 with the CANCEL SW on in cruise control SW
Approx. 240 with the RES/ACC SW on in cruise control SW
Approx. 630 with the SET/COAST SW on in cruise control SW
C14 Combination SW
23 : Approx. 1540 with the CANCEL SW on
Approx. 240 with the RES/ACC SW on
Approx. 630 with the SET/COAST SW on
: Parts Location
Code
A13
See Page
A
A15
66 (RHD)
46 (LHD)
66 (RHD)
46 (LHD)
A20
66 (RHD)
46 (LHD)
C9
C10
66 (RHD)
46 (LHD)
C11
Code
46 (LHD)
E9
See Page
48 (LHD)
J13
67 (RHD)
J20
68 (RHD)
47 (LHD)
J26
68 (RHD)
67 (RHD)
J27
68 (RHD)
67 (RHD)
47 (LHD)
47 (LHD)
67 (RHD)
64 (*10)
47 (LHD)
I14
Code
J12
47 (LHD)
44 (*6)
F16
46 (LHD)
E3
E13
66 (RHD)
D1
E12
46 (LHD)
C14
64 (*10)
A
E10
66 (RHD)
See Page
E3
67 (RHD)
66 (RHD)
J8
48 (LHD)
44 (*6)
J9
48 (LHD)
64 (*10)
J10
48 (LHD)
44 (*6)
J11
48 (LHD)
S1
S2
S13
T3
68 (RHD)
48 (LHD)
68 (RHD)
45 (*6)
65 (*10)
45 (*6)
65 (*10)
49 (LHD)
69 (RHD)
45 (*6)
65 (*10)
: Relay Blocks
Code
See Page
25 (*2)
26
29

Code
1A
See Page
25 (*2)

CA
CD
34
CE
CK
35
DA
DB
30
DC
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
335
AVENSIS (EWD526E)
http://vnx.su

Code
EB1
EE1
IC1
IE1
IE2
IE3
IE8
IG2
IK1
See Page
84 (*6)
104 (*10)
84 (*6)
104 (*10)
86 (LHD)
106 (RHD)

86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
88 (LHD)
88 (LHD)
108 (RHD)
IO1
108 (RHD)
IR1
108 (RHD)
: Ground Points
Code
EC
EI
IP
See Page
84 (*6)
104 (*10)
84 (*6)
104 (*10)
86 (LHD)
106 (RHD)

Near the Starter
Right Kick Panel
: Splice Points
Code
I3
See Page
88 (LHD)

Engine Wire
Code
I3
See Page
108 (RHD)

Engine Wire
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
336
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
Memo
337
AVENSIS (EWD526E)
http://vnx.su
VSC
50A
VSC
50A
VSC
2
4
25A
VSC
25A
VSC
2
1
7. 5A
ECUIG
2
4
18 DB
J10(A), J11(B),
J20(C), J21(D)
Junction
Connector
G A (LHD)
C C (RHD)
RW
BY
(2)
(1)
(2)
(1)
G A
C C
Buzzer
V7
VSC Warning Buzzer
RW
RW
RW
3 IE1
22 IE1
G B (LHD)
C D (RHD)
FL
41
24
FR+
FR
21
22
IG1
RL+
RL
23
40
2 IB1
1 IB1
RL
LY
WB
FL+
GND1
14
BZ
WB
GND2
10
15
+BS
+BM
RW
S1
BY
RW
E1
WB
A4
A5
WB
EA
EB
338
AVENSIS (EWD526E)
http://vnx.su
A32
ABS Speed Sensor Rear LH
1
2
3
4
: 1AZFSE
: 1CDFTV
: RHD 1AZFSE
: Except RHD 1AZFSE
15A
STOP
ENG
30
NEO
7 IE8
15 IE2
GW
GW
(LHD)
2 DA
S13
Stop Light SW
5 IE8 (LHD)
13 IE1 (RHD)
14 IE8
14 IE2
(RHD)
GW
RW
(RHD)
RW
(LHD)
YB
Y(4)
W(3)
2 IR1
2
13 IE8
3 IE2
6 IE3
1 IR1
17
11 IE3
6 IE8
13 IE2
(LHD)
GW
RW
ENG+
24
(RHD)
TRC
31
(LHD)
TRC+
25
RW
22 DA
(RHD)
E9
Engine ECU (M/T)
2 DL
1
GW
GW
YB
(LHD)
GW
(RHD)
18
19
TRC+
TRC
ENG+
ENG
STP
VCM
S1
PKB
12
31
2 IE2
GY
14 IE1
GY
BW
V
11 IE2
1 IM1
10 IM1
E2
11
BW
P
10 IE2
PMC
27
YR
CSW
42
GR
RR
39
37
NEO
YG
RR+
38
32
T9
TRC Off SW
3 DB
WB
(RHD)
(LHD)
WB
2 DC
1
O1
Oil Pressure Sensor
J16
Junction
Connector
IP
WB
(RHD)
(LHD)
WB
6 CA
P4
Parking Brake SW
10 CJ
BW
A33
ABS Speed Sensor Rear RH
IL
339
AVENSIS (EWD526E)
http://vnx.su
VSC
S1
J15
Junction
Connector
E B
IK
340
AVENSIS (EWD526E)
http://vnx.su
CAN
HIGH
CAN
LOW
S12
Steering Sensor
WL
(LHD)
WG
(LHD)
12V
D B
(Shielded)
B B
W
A A
(LHD)
B
B A
(LHD)
D A
(Shielded)
(Shielded)
(LHD)
A A
(LHD)
CANH
5
GND
CANL
(LHD)
4
UBAT
Y1
Yaw Rate Sensor
2
9 IE8
J 6(A), J 7(B)
Junction Connector
(LHD)
WB
B B
(LHD)
(Shielded)
B A
GND
D A
WL
(LHD)
WG
(LHD)
WL
(LHD)
3 IE8
WG
WL
WG
W
(LHD)
(Shielded)
(LHD)
2 IE8
J18
Junction Connector
B
10 IE8
1 IE8
YIGA
30
(LHD)
YGND
16
(LHD)
SS1
13
(LHD)
SS2
29
D5
DLC3
(RHD)
D C
J 8(A)
Junction
Connector
J20(C), J21(D)
Junction
Connector
D A
B D
WG
(RHD)
B C
WL
D A
G A (LHD)
G C (RHD)
B A
(LHD)
WG
G A (LHD)
G C (RHD)
J20(C), J21(D)
Junction
Connector
(RHD)
D D
J 8(A)
Junction
Connector
(LHD)
12
J 8(A), J26(C)
Junction
Connector
WL
(RHD)
WL
(LHD)
B A
WL
TS
SIL
7
(LHD)
TC
13
9 DB
17 DB
12 IE2
1 DL
WL
WG
15 DL
17
26
28
TC
D/G
YGND
B A
11 IO1
B A
12 IO1
CAN
HIGH
S12
Steering Sensor
WL
(RHD)
(RHD)
WG
CAN
LOW
(Shielded)
(RHD)
(RHD)
12V
(RHD)
CANH
(RHD)
CANL
5
GND
4
UBAT
Y1
Yaw Rate Sensor
WL
(RHD)
WG
(RHD)
2
GND
(Shielded)
WB
(RHD)
A B
C A
J22(A), J23(B)
Junction
Connector
WG
(RHD)
(RHD)
(Shielded)
C A
(RHD)
WG
(RHD)
B B
11 IO2
J22(A), J23(B)
Junction
Connector
WL
(RHD)
WL
WG
30
(RHD)
12 IO2
(RHD)
(Shielded)
13 IO2
TS
YIGA
16
(RHD)
SS1
13
(RHD)
SS2
29
S1
J19
Junction Connector
IK
WB
WB
(RHD)
(RHD)
J15
Junction
Connector
341
AVENSIS (EWD526E)
http://vnx.su
VSC
7. 5A
DOME
10A
GAUGE1
RW
2
6
6 CD
WR
(RHD)
RW
7 DB
WR
20 B
21 B
F C (RHD)
WR
F A (LHD)
F C
C10(A), C11(B)
Combination Meter
(LHD)
H B
Speedometer
J10(A), J11(B), J26(C)

Junction Connector
7 CA
CPU
S1
19 B
6 CK
LW
SP1
35
16 IE1
WB
6 CA
LW
34
WB
VSCW
LW
IND
WR
WA
LG
WT
36
LGB
EBDW
20
RY
5 B
WR
LG
LGB
RY
WB
WB
(RHD)
(RHD)
IP
342
AVENSIS (EWD526E)
http://vnx.su
1 : 1AZFSE
2 : 1CDFTV
J 8(A), J26(C)
Junction
Connector
10A
IGN
WB
C A (LHD)
A C (RHD)
(LHD)
WB
BW
17 A
J17
Junction
Connector
WB
WR
LG
LGB
RY
RW
6 IE1
8 IE1
7 IE1
17 IE1
18 IE1
19 IE1
WB
2 B
(LHD)
4 B
WB
9 A
(LHD)
17 B
WB
15 B
(RHD)
16 B
(LHD)
WB
ABS
Brake
22 B
TRC OFF
Slip
VSC
C10(A), C11(B)
Combination Meter
(RHD)
J16
Junction
Connector
18 DA
(RHD)
BW
C A (LHD)
A C (RHD)
RW
(1)
RW
RY
LGB
LG
WR
(2)
(2)
(2)
RW
LG
B3
Brake Fluid Level
Warning SW
WR
J2
Junction
Connector
C
RW
RY
V2
Vacuum SW
WB
LGB
WB
(RHD)
EC
IL : 2
IO : 1
343
AVENSIS (EWD526E)
http://vnx.su
VSC
System Outline
1. ABS Operation
If the brake pedal is depressed suddenly, the ABS controls the hydraulic pressure of the wheel cylinders for all the four
wheels to automatically avoid wheel locking and ensure the directional and steering stability of the vehicle. If the brake pedal
is depressed suddenly, the skid control ECU with actuator controls the solenoids in the actuators using the signals from the
sensors to move the brake fluid to the reservoir in order to release the braking pressure applied to the wheel cylinder. If the
skid control ECU with actuator detects that the fluid pressure in the wheel cylinder is insufficient, the ECU controls the
solenoids in the actuators to increase the braking pressure.
2. Traction Control Operation
The traction control system controls the engine torque, the hydraulic pressure of the driving wheel cylinders, slipping of the
wheels which may occur at start or acceleration of the vehicle, to ensure an optimal driving power and vehicle stability
corresponding to the road conditions.
3. VSC Operation
Unexpected road conditions, vehicle speed, emergency situation, and any other external factors may cause large under or
oversteering of the vehicle. If this occurs, the VSC system automatically controls the engine power and wheel brakes to
reduce the under or oversteering.
To reduce large oversteering :
If the VSC system determines that the oversteering is large, it activates the brakes for the outer turning wheels depending
on the degree of the oversteering to produce the moment toward the outside of the vehicle and reduce the oversteering.
To reduce large understeering :
If the VSC system determines that the understeering is large, it controls the engine power and activates the rear wheel
brakes to reduce the understeering.
TRC off SW
The TRC off SW is used to stop the TRC function. After the engine is started, the TRC system is stopped (Turned off) and
the TRC OFF indicator light lights up. When the TRC off SW is pressed again, the TRC system enters the standby mode. If
the engine is stopped and restarted, the TRC system enters the standby mode regardless of the TRC off SW.
VSC indicator light
If an error occurs in the VSC system, the VSC indicator lights up to warn the driver.
4. Mutual System Control
To efficiently operate the VSC system at its optimal level, the VSC system and other control systems are mutually controlled
while the VSC system is being operated.
Engine fuel injecting control
The engine power does not interfere with the VSC brake control by controlling the opening of the fuel injecting and reducing
the engine output.
Engine control and electronically controlled transmission control
The strong engine braking force does not interfere with the braking force control of the VSC system by turning off the accel.
and reducing changes in the driving torque at shiftdown.
VSC system operation indication
The slip indicator light flashes and the buzzer sounds intermittently to warn the driver that the current road is slippery, while
the VSC system is being operated.
5. Fail Safe Function
If an error occurs in the skid control ECU with actuator, sensor signals, and/or actuators, the skid control ECU with actuator
inhibits the brake actuator control and inputs the error signal to the engine and ECT ECU (A/T) or engine ECU (M/T).
According to the error signal, the brake actuator turns off the solenoid and the engine and ECT ECU (A/T) or engine ECU
(M/T) rejects any electronically controlled fuel injection request from the VSC system. As a result, the vehicle functions
without the ABS, TRC, and VSC systems.
Service Hints
S1 Skid Control ECU with Actuator
37Ground : Approx. 12 volts with stop light SW on
6, 10Ground : Always continuity
A4, A5 ABS Speed Sensor Front LH, RH
21 : Approx. 1.21.6 k (20C, 68F)
A32, A33 ABS Speed Sensor Rear LH, RH
12 : Approx. 1.01.4 k (20C, 68F)
344
AVENSIS (EWD526E)
http://vnx.su
: Parts Location
Code
See Page
38 (*3)
44 (*6)
A4
58 (*7)
Code
A
C11
64 (*10)
44 (*6)
64 (*10)
A32
C10
48 (LHD)
54 (LHD W/G)
J7
48 (LHD)
70 (RHD S/D)
J8
48 (LHD)
72 (RHD L/B)
J10
48 (LHD)
74 (RHD W/G)
J11
48 (LHD)
48 (LHD)
J15
68 (RHD)
48 (LHD)
J16
70 (RHD S/D)
65 (*10)
68 (RHD)
72 (RHD L/B)
J17
68 (RHD)
74 (RHD W/G)
J18
48 (LHD)
38 (*3)
J19
68 (RHD)
44 (*6)
J20
68 (RHD)
58 (*7)
J21
68 (RHD)
64 (*10)
J22
68 (RHD)
46 (LHD)
J23
68 (RHD)
68 (RHD)
39 (*3)
O1
45 (*6)
59 (*7)
65 (*10)
P4
45 (*6)
A
54 (LHD W/G)
B3
67 (RHD)
J6
52 (LHD L/B)
A33
66 (RHD)
52 (LHD L/B)
50 (LHD S/D)
See Page
C
46 (LHD)
47 (LHD)
J2
50 (LHD S/D)
Code
J26
67 (RHD)
E9
58 (*7)
66 (RHD)
47 (LHD)
D5
38 (*3)
A5
See Page
C10
49 (LHD)
69 (RHD)
39 (*3)
S1
45 (*6)
59 (*7)
65 (*10)
S12
S13
T9
V2
V7
Y1
49 (LHD)
69 (RHD)
49 (LHD)
69 (RHD)
49 (LHD)
69 (RHD)
45 (*6)
65 (*10)
49 (LHD)
69 (RHD)
49 (LHD)
69 (RHD)
: Relay Blocks
Code
1
See Page
24 (*1)
25 (*2)

27
29

Code
CA
CD
CJ
CK
See Page
34
35
DA
DB
30
31
DC
DL
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
345
AVENSIS (EWD526E)
http://vnx.su
VSC
Code
IB1
IE1
IE2
IE3
IE8
IM1
IO1
IO2
IR1
See Page
86 (LHD)
106 (RHD)

86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
88 (LHD)
108 (RHD)
108 (RHD)
108 (RHD)
: Ground Points
Code
See Page
78 (*3)
EA
84 (*6)
98 (*7)
104 (*10)
78 (*3)
EB
84 (*6)
98 (*7)
104 (*10)
78 (*3)
EC
84 (*6)
98 (*7)
104 (*10)
IK
IL
IO
IP
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
86 (LHD)
106 (RHD)

Right Kick Panel
: Splice Points
Code
E1
See Page
78 (*3)
84 (*6)

Code
E1
See Page
98 (*7)
104 (*10)

* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
346
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
Memo
347
AVENSIS (EWD526E)
http://vnx.su
ABS
40A
ABS
25A
ABS
7. 5A
ECUIG
7. 5A
GAUGE2
18 DB
27 DA
RW
25A
ABS
8 CA
J10(A), J20(C)
Junction Connector
G A (LHD)
C C (RHD)
1 CD
RW
RW
22 IE1
1 IK1
RW
RW
(2)
(1)
(2)
(1)
G A (LHD)
C C (RHD)
(A/T)
40A
ABS
(A/T)
RW
(A/T)
RW
+BM
+BS
(A/T)
18
IG1
FL
6
10
FR+
FR
9
FL+
5
LY
WB
GND1
WB
GND2
RL
S2
E1
WB
A4
WB
EA
EB
348
AVENSIS (EWD526E)
http://vnx.su
A5
RW
(A/T)
3
GW
(LHD)
GW
RW
GW
(LHD)
GW
(RHD)
2 DA
2
(A/T)
2 IR1
6 IE3
(RHD)
RW
D2
Diode
D A (LHD)
D B (RHD)
1 IR1
A A
A B
RW
11 IE3
(RHD)
RW
WL
(A/T)
R
WL
(A/T)
S13
Stop
Light SW
2 DL
WL
(A/T)
GW
GW
1 IE2
(A/T)
(LHD)
(A/T)
GW
(RHD)
21
20
PN
STP
S2
RL+
RL
RR+
RR
PKB
BW
1 IB1
10 IE2
11 IE2
2 IE2
1 IM1
10 IM1
BW
2 IB1
3 DB
14
19
17
2 DC
2
A32
A33
1 : Gasoline
2 : 1CDFTV
BW
P4
Parking Brake SW
(A/T)
J18(A), J29(B)
Junction Connector
D A (LHD)
D B (RHD)
A A
A B
(A/T)
20 IK2
(LHD)
WL
9 IK2
22 DA
(LHD)
(A/T)
PL
NL
(RHD)
15A
STOP
(A/T)
N1
Neutral Start SW
RB
349
AVENSIS (EWD526E)
http://vnx.su
ABS
12
6
WR
(RHD 1AZFE)
(LHD)
25
11
13
D/G
WR
F A (LHD)
F C
F C (RHD)
H B
WR
(LHD)
TS
23
LW
SP1
22
RY
WA
12
EBDW
WR
(LHD)
12 IE2
1 DL
WG
15 DL
WL
9 DB
(RHD)
(RHD)
B D
17 DB
TC
S2
WR
J 8(A), J 9(B), J20(C), J21(D)

Junction Connector
WG
G A (LHD)
G C (RHD)
(RHD 1AZFE)
D A (LHD)
(RHD)
D A
D C
WG
D B (LHD)
D D (RHD)
G A (LHD)
G C (RHD)
J 8(A), J26(C)
Junction Connector
WL
B A (LHD)
B C (RHD)
(Except RHD 1AZFE)
WL
J 8(A), J 9(B), J20(C), J21(D)

Junction Connector
(3)
WL
B A
B C
(LHD)
(RHD 1AZFE)
7. 5A
DOME
(Except RHD 1AZFE)
WL
TS
D5
DLC3
J10(A), J11(B), J26(C)

Junction Connector
SIL
7
(3)
TC
13
LW
RY
350
AVENSIS (EWD526E)
http://vnx.su
10A
GAUGE1
10A
IGN
J 8(A), J26(C)
Junction Connector
7 CA
6 CD
BW
RW
C A (LHD)
A C (RHD)
C A (LHD)
A C (RHD)
7 DB
WR
1 : Gasoline
2 : 1CDFTV
3 : RHD Except 1AZFE
18 DA
(LHD)
21 B
C10(A), C11(B)
Combination Meter
22 B
ABS
Speedometer
20 B
Brake
WR
BW
RW
(RHD)
18 IE1
RW
17 IE1
WB
6 CK
(RHD)
16 IE1
2 B
(LHD)
17 A
4 B
RY
9 A
WB
5 B
LW
19 IE1
LW
RW
(1)
RW
J17
Junction
Connector
J16
Junction
Connector
WB
6 CA
LW
RY
(2)
J2
Junction Connector
19 B
WB
CPU
RW
(2)
J15
Junction
Connector
IP
IO : 1
IL : 2
WB
RY
IK
(2)
RW
1
V2
Vacuum SW
WB
(RHD)
(LHD)
WB
B3
Brake Fluid
Level Warning SW
EC
351
AVENSIS (EWD526E)
http://vnx.su
ABS
System Outline
ABS system
This system controls the respective brake fluid pressures acting on the disc brake cylinders of the right front wheel, left front
wheel and rear wheels when the brakes are applied in a panic stop so that the wheels do not lock. This results in improved
directional stability and steerability during panic braking.
Front and rear braking force distribution system
Using the hydraulic controlling device, this system distributes the braking force to the front and rear wheel in appropriately
according to the running condition of the vehicle.
1. Input Signals
(1) Speed sensor signal
The speed of the wheels is detected and input to TERMINALS FL+, FR+, RL+ and RR+ of the skid control ECU with
actuator.
(2) Stop light SW signal
A signal is input to TERMINAL STP of the skid control ECU with actuator when the brake pedal is depressed.
2. System Operation
During sudden braking the skid control ECU with actuator has signals input from each sensor, which controls the current to
the solenoid inside the actuator and lets the hydraulic pressure acting on each wheel cylinder escape to the reservoir. The
pump inside the actuator is also operating at this time and it returns the brake fluid from the reservoir to the master cylinder,
thus preventing locking of the vehicle wheels.
If the skid control ECU with actuator judges that the hydraulic pressure acting on the wheel cylinder is insufficient, the current
on the solenoid is controlled and the hydraulic pressure is increased. Holding of the hydraulic pressure is also controlled by
the skid control ECU with actuator, by the same method as above. Pressure reduction, holding and increase are repeated to
maintain vehicle stability and to improve steerability during sudden braking.
Service Hints
A4, A5 ABS Speed Sensor Front LH, RH
21 : 1.4 1.8 k (20C, 68F)
A32, A33 ABS Speed Sensor Rear LH, RH
12 : 1.0 1.4 k (20C, 68F)
S2 Skid Control ECU with Actuator
20Ground : Approx. 12 volts with the brake pedal depressed
1, 4Ground : Always continuity
352
AVENSIS (EWD526E)
http://vnx.su
: Parts Location
Code
See Page
Code
40 (*4)
A4
68 (RHD)
40 (*4)
J18
48 (LHD)
42 (*5)
J20
68 (RHD)
60 (*8)
44 (*6)
J21
68 (RHD)
60 (*8)
J26
68 (RHD)
64 (*10)
62 (*9)
J29
68 (RHD)
40 (*4)
64 (*10)
44 (*6)
60 (*8)
62 (*9)
B3
C10
C11
64 (*10)
52 (LHD L/B)
D5
54 (LHD W/G)
70 (RHD S/D)
66 (RHD)
41 (*4)
N1
46 (LHD)
66 (RHD)
43 (*5)
61 (*8)
63 (*9)
P4
49 (LHD)
69 (RHD)
67 (RHD)
41 (*4)
47 (LHD)
43 (*5)
67 (RHD)
45 (*6)
J2
72 (RHD L/B)
46 (LHD)
47 (LHD)
D2
50 (LHD S/D)
A33
See Page
J17
44 (*6)
42 (*5)
A32
Code
74 (RHD W/G)
42 (*5)
62 (*9)
A5
See Page
A33
S2
45 (*6)
61 (*8)
65 (*10)
63 (*9)
65 (*10)
74 (RHD W/G)
J8
48 (LHD)
50 (LHD S/D)
J9
48 (LHD)
52 (LHD L/B)
J10
48 (LHD)
54 (LHD W/G)
J11
48 (LHD)
70 (RHD S/D)
J15
68 (RHD)
72 (RHD L/B)
J16
48 (LHD)
S13
V2
49 (LHD)
69 (RHD)
45 (*6)
65 (*10)
: Relay Blocks
Code
1
See Page
24 (*1)
25 (*2)

27
29

Code
CA
CD
CK
See Page
34

35
DA
DB
30
31
DC
DL
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
353
AVENSIS (EWD526E)
http://vnx.su
ABS
Code
IB1
IE1
IE2
IE3
IK1
IK2
IM1
IR1
See Page
86 (LHD)
106 (RHD)

86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
88 (LHD)
108 (RHD)
88 (LHD)
108 (RHD)
88 (LHD)
108 (RHD)
108 (RHD)
: Ground Points
Code
See Page
80 (*4)
82 (*5)
EA
84 (*6)
100 (*8)
102 (*9)
104 (*10)
80 (*4)
82 (*5)
EB
84 (*6)
100 (*8)
102 (*9)
104 (*10)
80 (*4)
82 (*5)
EC
84 (*6)
100 (*8)
102 (*9)
104 (*10)
IK
106 (RHD)
IL
86 (LHD)
IO
86 (LHD)
IP
86 (LHD)
106 (RHD)

Right Kick Panel
: Splice Points
Code
See Page
Code
80 (*4)
E1
82 (*5)
84 (*6)
See Page
100 (*8)
E1
102 (*9)
104 (*10)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
354
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
SRS
NOTICE: When inspecting or repairing the SRS, perform the operation in accordance with the following precautionary
instructions and the procedure and precautions in the Repair Manual for the applicable model year.
D Malfunction symptoms of the SRS are difficult to confirm, so the DTCs become the most important source of information
when troubleshooting. When troubleshooting the SRS, always inspect the DTCs before disconnecting the battery.
D Work must be started after 90 seconds from when the ignition switch is turned to the LOCK position and the
negative () terminal cable is disconnected from the battery.
(The SRS is equipped with a backup power source so that if work is started within 90 seconds from
disconnecting the negative () terminal cable of the battery, the SRS may be deployed.)
D When the negative () terminal cable is disconnected from the battery, the memory of the clock and audio system will be
canceled. So before starting work, make a record of the contents memorized in the audio memory system. When work is
finished, reset the audio systems as they were before and adjust the clock. To avoid erasing the memory in each
memory system, never use a backup power supply from outside the vehicle.
D Before repairs, remove the airbag sensor if shocks are likely to be applied to the sensor during repairs.
D Do not expose the steering wheel pad, front passenger airbag assembly, seat belt pretensioner, airbag sensor
assembly, front airbag sensor assembly, knee airbag assembly, curtain shield airbag assembly, curtain shield airbag
sensor assembly, side airbag assembly or side airbag sensor assembly directly to hot air or flames.
D Even in cases of a minor collision where the SRS does not deploy, the steering wheel pad, front passenger airbag
assembly, seat belt pretensioner, airbag sensor assembly, front airbag sensor assembly, knee airbag assembly, curtain
shield airbag assembly, curtain shield airbag sensor assembly, side airbag assembly and side airbag sensor assembly
should be inspected.
D Never use SRS parts from another vehicle. When replacing parts, replace them with new parts.
D Never disassemble and repair the steering wheel pad, front passenger airbag assembly, seat belt pretensioner, airbag
sensor assembly, front airbag sensor assembly, knee airbag assembly, curtain shield airbag assembly, curtain shield
airbag sensor assembly, side airbag assembly or side airbag sensor assembly in order to reuse it.
D If the steering wheel pad, front passenger airbag assembly, seat belt pretensioner, airbag sensor assembly, front airbag
sensor assembly, knee airbag assembly, curtain shield airbag assembly, curtain shield airbag sensor assembly, side
airbag assembly or side airbag sensor assembly has been dropped, or if there are cracks, dents or other defects in the
case, bracket or connector, replace them with new ones.
D Use a volt/ohmmeter with high impedance (10 k/V minimum) for troubleshooting the systems electrical circuits.
D Information labels are attached to the periphery of the SRS components. Follow the instructions on the notices.
D After work on the SRS is completed, perform the SRS warning light check.
D If the vehicle is equipped with a mobile communication system, refer to the precaution in the IN section of the Repair
Manual.
355
AVENSIS (EWD526E)
http://vnx.su
SRS
System Outline
The SRS is a driver and passenger protection device which has a supplemental role to the seat belts.
When the ignition SW is turned to ON, the current from the IGN fuse flows to TERMINAL (B) 5 of the airbag sensor
assembly.
If an accident occurs while driving, when the frontal impact exceeds a set level, the current from the IGN fuse flows to
TERMINALS (B) 14, (B) 16, (B) 10, (B) 8, (C) 12, (A) 8 and (C) 9 of the airbag sensor assembly to the airbag squibs and the
pretensioners to TERMINALS (B) 13, (B) 17, (B) 11, (B) 7, (C) 11, (A) 7 and (C) 10 of the airbag sensor assembly to
TERMINAL (B) 27, (B) 28 or BODY GROUND to GROUND, so that current flows to the airbag squibs and the pretensioners
and causes them to operate.
When the side impact also exceeds a set level, the current from the IGN fuse flows to TERMINALS (A) 12, (C) 5, (A) 9 and
(C) 8 of the airbag sensor assembly to the side airbag squibs and the curtain shield airbag squibs TERMINALS (A) 10, (C) 7,
(A) 11 and (C) 6 of the airbag sensor assembly to TERMINAL (B) 27, (B) 28 or BODY GROUND to GROUND, causing side
airbag squibs and curtain shield airbag squibs to operate.
The airbag stored inside the steering wheel pad is instantaneously expanded to soften the shock to the driver.
The airbag stored inside the passengers instrument panel is instantaneously expanded to soften the shock to the front
passenger.
Side airbags are instantaneously expanded to soften the shock of side to the driver and front passenger.
The curtain shield airbag can ease an impact on the head of the front and rear passengers and reduce risks of injury.
In a headon crash, the driver moves forward and may strike his/her lower limbs against the instrument panel, the key
cylinder, etc. The knee airbag is equipped to protect the lower limbs of the driver in headon crashes.
The pretensioners make sure of the seat belt restrainability.
360
AVENSIS (EWD526E)
http://vnx.su
: Parts Location
Code
See Page
Code
38 (*3)
C15
40 (*4)
A9
A13
A15
A26
A27
A28
73 (RHD L/B)
58 (*7)
54 (LHD W/G)
75 (RHD W/G)
70 (RHD S/D)
51 (LHD S/D)
62 (*9)
72 (RHD L/B)
53 (LHD L/B)
64 (*10)
74 (RHD W/G)
38 (*3)
50 (LHD S/D)
40 (*4)
52 (LHD L/B)
73 (RHD L/B)
42 (*5)
54 (LHD W/G)
75 (RHD W/G)
70 (RHD S/D)
51 (LHD S/D)
58 (*7)
72 (RHD L/B)
53 (LHD L/B)
60 (*8)
74 (RHD W/G)
62 (*9)
50 (LHD S/D)
64 (*10)
52 (LHD L/B)
46 (LHD)
54 (LHD W/G)
C16
C11
C18
66 (RHD)
74 (RHD W/G)
46 (LHD)
47 (LHD)
46 (LHD)
66 (RHD)
D5
E9
E10
46 (LHD)
55 (LHD W/G)
P17
71 (RHD S/D)
55 (LHD W/G)
71 (RHD S/D)
73 (RHD L/B)
75 (RHD W/G)
S14
51 (LHD S/D)
53 (LHD L/B)
B
55 (LHD W/G)
71 (RHD S/D)
67 (RHD)
73 (RHD L/B)
47 (LHD)
75 (RHD W/G)
67 (RHD)
51 (LHD S/D)
47 (LHD)
53 (LHD L/B)
67 (RHD)
67 (RHD)
46 (LHD)
J8
48 (LHD)
66 (RHD)
J10
48 (LHD)
56 (LHD)
J11
48 (LHD)
55 (LHD W/G)
71 (RHD S/D)
73 (RHD L/B)
75 (RHD W/G)
S15
51 (LHD S/D)
53 (LHD L/B)
76 (RHD)
J15
68 (RHD)
46 (LHD)
J16
48 (LHD)
66 (RHD)
J17
68 (RHD)
73 (RHD L/B)
75 (RHD W/G)
46 (LHD)
J20
68 (RHD)
66 (RHD)
J21
68 (RHD)
50 (LHD S/D)
J26
68 (RHD)
52 (LHD L/B)
C15
71 (RHD S/D)
P16
47 (LHD)
I14
66 (RHD)
70 (RHD S/D)
72 (RHD L/B)
66 (RHD)
B9
C10
C17
46 (LHD)
46 (LHD)
A30
55 (LHD W/G)
52 (LHD L/B)
66 (RHD)
A29
74 (RHD W/G)
44 (*6)
66 (RHD)
See Page
53 (LHD L/B)
50 (LHD S/D)
44 (*6)
Code
42 (*5)
60 (*8)
A10
See Page
72 (RHD L/B)
54 (LHD W/G)
70 (RHD S/D)
K3
P16
48 (LHD)
68 (RHD)
S18
S19
55 (LHD W/G)
71 (RHD S/D)
56 (LHD)
76 (RHD)
56 (LHD)
76 (RHD)
51 (LHD S/D)
: Relay Blocks
Code
6
See Page
29

* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
361
AVENSIS (EWD526E)
http://vnx.su
SRS
Code
CA
CD
CK
See Page
34

35
DA
DB
30
DD

Code
IC1
IC2
IE7
IN1
IO3
See Page
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
88 (LHD)
108 (RHD)
108 (RHD)
: Ground Points
Code
IJ
See Page
86 (LHD)
106 (RHD)
IK
106 (RHD)
IL
86 (LHD)
IO
86 (LHD)
IP
86 (LHD)
106 (RHD)

Left Kick Panel
Right Kick Panel
362
AVENSIS (EWD526E)
http://vnx.su
Memo
363
AVENSIS (EWD526E)
http://vnx.su
SRS
7. 5A DOME
10A GAUGE1
1
2
3
4
5
6
7
8
9
: Gasoline
: LHD Gasoline
: LHD 1CDFTV
: Except LHD 1CDFTV
: w/ Knee Airbag
: 1AZFSE
: Automatic A/C
BW
BY
7 DB
(RHD)
H B
PB
LR
F A (LHD)
F C
F C (RHD)
I14
Integration Relay
7 CA
LGB
PB
RW
J10(A), J11(B), J26(C)

Junction
Connector
WR
WR
LR
22
MPX2
BKL
(1)
MPX1
11
20 B
22 B
8 B
PB
BY
21 B
BW
WR
RW
(LHD)
1 IC1
6 CD
14 A
MPX
MPX+
9 A (8)
10 B (9)
PB
SRS
29 A (8)
20 B (9)
WB
IP
J15
Junction
Connector
IK
29 B
29 A
21 A (1CDFTV)
MPX2
MPX1
18 B (7)
23 A (6)
20 A (1CDFTV)
WB
(LHD)
WB
E 9(A), E10(B)
Engine ECU (M/T)
J16
Junction
Connector
(RHD)
WB
J17
Junction
Connector
6 CK
(LHD)
WB
6 CA
13 A
17 A
C10(A), C11(B)
Combination Meter
(RHD)
WB
5 B
(1)
BEAN
I/F
LGB
A13(A), A15(B)
10 IC1
IL : 3
IO : 2
356
AVENSIS (EWD526E)
http://vnx.su
14 A (7)
14 A (6)
F/PS
10A IGN
BW
BY
18 DA
5 DD
LR
LGB
BW
BW
(1)
J 8(A), J26(C)
Junction
Connector
K3
Knee Airbag Squib
LR
C A (LHD)
A C (RHD)
C A (LHD)
A C (RHD)
IG2
(5)
(5)
YR
11 C
DK
A26(A), A27(B), A28(C)

SL
SR+
YG
YB
A29
Airbag Squib
(Front Passenger Airbag Assembly)
9 B
SR
20 B
2 IE7 (LHD)
2 IO3 (RHD)
YR
1 IE7
1 IO3
YR
4 IE7
4 IO3
YG
3 IE7
3 IO3
26 B
SL+
15 B
P2
7 B
P2+
8 B
YB
P
11 B
P+
10 B
SL+
SL
SR+
SR
A9
Airbag Sensor
Front LH
BR(4)
D2
17 B
A30
Airbag Squib
(Steering Wheel Pad)
DK+
BR
D2+
16 B
12 C
5 B
LA
YR(3)
D+
14 B
YB
3 B
GSW1
DBEW
WR
D
13 B
4 B
WR
GSW
BY
23 B
2 IN1
6 DD
LR
2 DD
(1)
LGB
9 DD
(5)
(5)
1 IN1
YR
YB
BY
12 DA
BW
LR
11 DA
14 DB
(1)
LGB
12 IC2
A10
Airbag Sensor
Front RH
357
AVENSIS (EWD526E)
http://vnx.su
SRS
D5
DLC3
TC
B A
SIL
G A
B A
G A
WG
G C
G C
J26(C)
Junction Connector
B A
(RHD)
WG
(LHD)
(LHD)
J 8(A)
Junction Connector
(12)
D B
WL
WL
J20(A), J21(B)
Junction Connector
WL
(13)
13
C16
Curtain Shield Airbag
Sensor RH
S15(A), (B)
Side Airbag Sensor RH
WG
(RHD)
WG
(LHD)
WL
(LHD)
WL
(13)
BCR+
1
1 A
BCR
2 A
BBR+
BCR+
4 A
2 B
BBR(10)
BCR(11)
3 A (10)
1 B (11)
L
(10)
17 DB
LG
9 DB
PL
SIL
P
15 C
BBR+
BBL+
9 C
10 C
YB
PR
7 A
PR+
8 A
YB
PL+
A26(A), A27(B), A28(C)

16 A
BBR
BBL
18 A
LGB
12 B
GRL
WG
19 B
TC
17 C
10 DD
WL
8 DD
GR
(10)
4 A
2 B
3 A (10)
1 B (11)
LB
(10)
GRR
(10)
1 A
BCL+
P16
Pretensioner LH
P17
Pretensioner RH
2 A
C15
358
AVENSIS (EWD526E)
http://vnx.su
BCL
S14(A), (B)
Side Airbag Sensor LH
BBL+
BCL+
BBL(10)
BCL(11)
10
11
12
13
C18
Curtain Shield
Airbag Squib RH
YR
(10)
YV
(10)
11 A
GRB
27 B
28 B
4 DD
3 DD
LBE(LHD)
RBE(RHD)
2 A (LHD)
3 C (RHD)
B9
Buckle SW
(Driver' s Side)
Buckle SW
LB
E2
Seat Position
Airbag Sensor
GY
E1
LSP(LHD)
RSP(RHD)
GY
12 A
LSP+
RSP+
WB
SFL
LBE+
RBE+
LB
10 A
SFL+
3 A (LHD)
2 C (RHD)
GRB
ICL
4 A
1 C
WB
ICL+
SFR+
SFR
A26(A), A27(B), A28(C)
19 A
14 C
WB
ICR
6 C
WB
ICR+
9 A
YG
5 C
YG
YR
(10)
7 C
YR
8 C
YR
S19
(10)
YV
: w/ Curtain Shield Airbag

: w/o Curtain Shield Airbag
: RHD 1AZFE
: RHD Except 1AZFE
9 DA
2
WB
C17
Curtain Shield
Airbag Squib LH
S18
IJ
359
AVENSIS (EWD526E)
http://vnx.su
EPS
7. 5A
ECUIG
50A
EMPS
E 9(A), E12(C)
Engine ECU (M/T)
D5
DLC3
2
SIL
1
EMPS
29 C
12
5 A
J 8(A), J 9(B), J20(C)

Junction Connector
D B (LHD)
D D (RHD)
TS
WR
11 B
TC
4 B
WL
2 B
(RHD)
B B
(LHD)
WL
(LHD)
WL
G B (LHD)
G D (RHD)
(RHD)
3 B
GRR
1 A
GR
5 IE1
RW
G B (LHD)
C D (RHD)
(RHD)
WG
A B (LHD)
B D (RHD)
D A (LHD)
D C
D C (RHD)
B A (LHD)
B C (RHD)
WL
WR
G A (LHD)
G C (RHD)
(LHD)
6 IK2
A B (LHD)
B D (RHD)
J 8(A), J 9(B), J20(C), J21(D)

Junction Connector
J 9(B), J27(D)
Junction Connector
J 8(A), J 9(B), J26(C), J27(D)

Junction Connector
GRR
GR
1
EMPS
Relay
J10(A), J11(B), J20(C)J21(D)

Junction Connector
TS
13
G A (LHD)
C C (RHD)
TC
R
1
RW
TACH
WG
18 DB
6 B
IG
PIG
8 B
RLY
IDUP
12 B
TACH
SIL
E14(A), E15(B)
EPS ECU
TRQ2
Torque Sensor
TRQG
PGND
WL
SPD
2 A
9 B
5 B
VW
TRQ1
BW
TRQV
WB
M2
EPS Motor
M1
VW
BW
IM
364
AVENSIS (EWD526E)
http://vnx.su
7. 5A
DOME
10A
IGN
10A
GAUGE1
F A (LHD)
F C
F C (RHD)
7 CA
6 CD
BW
RW
WR
18 DA
J 8(A), J26(C)
Junction
Connector
J10(A), J11(B), J26(C)

Junction
Connector
(RHD)
7 DB
WR
C A (LHD)
A C (RHD)
C A (LHD)
A C (RHD)
RW
BW
21 B
22 B
19 B
5 B
6 B
LW
WB
BW
(LHD)
WR
H B
C10(A), C11(B)
Combination Meter
P/S
Speedometer
20 B
CPU
H A (LHD)
H C (RHD)
23
6 CK
WB
J16
Junction
Connector
(RHD)
WB
H A (LHD)
H C (RHD)
(LHD)
16 IE1
J17
Junction
Connector
SP1
VW
J10(A), J20(C)
Junction Connector
VW
17 A
LW
VW
18 B
6 CA
S2
Skid Control ECU
with Actuator
WB
(RHD)
WB
(LHD)
WB
BW
IP
IO
J15
Junction
Connector
IK
365
AVENSIS (EWD526E)
http://vnx.su
EPS
System Outline
To reduce the drivers steering effort, assist current computed according to the torque sensor signal and vehicle speed signal
is output to the motor. In case the system fails, to prohibit further assistance, the current to the EMPS relay and motor relay
(Built in the EPS ECU) is shut off, and the warning light in the combination meter comes on.
Service Hints
E14 (A), E15 (B) EPS ECU
(B) 6Ground : Approx. 12 volts with the ignition SW at ON position
(A) 2Ground : Always continuity
: Parts Location
Code
C10
See Page
46 (LHD)
C11
E12
66 (RHD)
E14
46 (LHD)
66 (RHD)
E9
E12
See Page
C
A
Code
See Page
67 (RHD)
J15
68 (RHD)
47 (LHD)
J16
48 (LHD)
67 (RHD)
J17
68 (RHD)
47 (LHD)
J20
68 (RHD)
67 (RHD)
J21
68 (RHD)
E15
67 (RHD)
J8
48 (LHD)
J26
68 (RHD)
47 (LHD)
J9
48 (LHD)
J27
68 (RHD)
67 (RHD)
J10
48 (LHD)
47 (LHD)
J11
48 (LHD)
47 (LHD)
D5
Code
43 (*5)
S2
63 (*9)
: Relay Blocks
Code
See Page
24 (*1)
29

Code
CA
CD
CK
DA
DB
See Page
34

35
30

Code
IE1
IK2
See Page
86 (LHD)
106 (RHD)
88 (LHD)
108 (RHD)
: Ground Points
Code
IK
IM
IO
IP
See Page
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
86 (LHD)
106 (RHD)

Right Kick Panel
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
366
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
Memo
367
AVENSIS (EWD526E)
http://vnx.su
Door Lock Control (LHD)

25A DOOR
7. 5A ECUB 2
I14(A)
Integration Relay
B
1
B
23
25
DCTY
PCTY
RCTY
17
16
13 DB
9 DC
12 DM
KSW
19
16 DB
9 DA
WR
WB
2
8 DA
13 DM
WG
U1
Unlock Warning SW
WG
1
D12
D11
R
1
18 IM1
D10
9 IM1
D9
14 IC2
4 IC2
WR
B A
WG
B A
3 CD
J10(A)
Junction Connector
10 CC
WG
WR
WB
J16
Junction
Connector
WB
WB
IJ
368
AVENSIS (EWD526E)
http://vnx.su
IL : 1
IO : Gasoline
I14(A)
Integration Relay
8 CC
LR
LB
LR
LB
2 IA2
1 IA2
18 IA2
7 IA1
2 IA1
2 BA1
11 BA1
LR
LB
LR
LB
LR
10
IL1
7 CC
11 CK
LB
7 CJ
LG
16 IC1
LG
7 IC1
17 IM2
1 IM2
LB
2 CB
2 BC1
11 BC1
LB
4 CA
17 IC1
10 DB
LR
20 DB
LR
6 DM
LR
7 DM
LB
4 DJ
LB
1 DJ
LB
LR
LR(L/B, W/G)
ACT
ACT+
LR
GW
LSWD
3 A
LR
UL2
5 A
LR
BRW
GW
3 IA2
Unlock
4 IA2
LY(S/D)
13 DA
BRW
29 DA
Lock
L2
4 A
LG
UL1
10
D17
L1
11
IL1
WB
WB
D18
Door Lock Motor
Rear LH
D15
D20
Door Lock Motor
Rear RH
WB
B1
D13
(Driver' s Side)
(Driver' s Side)
(Driver' s Side)
9 IA1
WB
1 : 1CDFTV
IJ
369
AVENSIS (EWD526E)
http://vnx.su
WB
A B
A A
A B
BX
370
AVENSIS (EWD526E)
http://vnx.su
L
1
2
C B
BS
B A
B A
J30(A), J31(B)
Junction Connector
LB
3 BG2
L4
(S/D)
J32
Junction
Connector
L3
6 BD2 (L/B)
5 BF2 (W/G)
(S/D)
(S/D)
RY
3 DM
RY
(S/D)
L
(W/G)
LB
(L/B, W/G)
BDSU
WB
LB
(W/G)
L
(L/B)
10 A
(S/D)
WB
(S/D)
B8
Back Door Opener
SW
6 BE2
WB
A B
LB
4 BG2
(L/B)
7 BD2 (L/B)
6 BF2 (W/G)
(S/D)
(W/G)
L
(L/B, W/G)
J33(A), J34(B)
Junction Connector
L
(L/B)
J32
Junction
Connector
(W/G)
7 BE2
WB
L
(L/B)
RY
RY
(L/B, W/G)
LACT
(L/B, W/G)
1
5 BG2
B7
2
(W/G)
8 BD2 (L/B)
2 BF2 (W/G)
WB
8 BE2
RY
RY
(L/B, W/G)
(W/G)
RY
(L/B)
BDCY
(L/B, W/G)
RY
(L/B)
12 A
(L/B, W/G)
WB
(L/B, W/G)

I14(A)
Integration Relay
1 A
LGCY
(S/D)
LB
(S/D)
I14(A)
Integration Relay
MPX2
11 A
PB
MPX1
22 A
LR
BKL
9 A
1 IC1
10 IC1
1
2
3
4
5
: 1CDFTV
: Automatic A/C
: w/ Front Passenger' s Seat Belt Warning
C10
Combination Meter
14 DB
2 DD
14
BEAN
(BODY)
BEAN
(EFI)
A13(A), A15(B), A16(C)

PB
LR
12 IC2
LR
MPX
MPX+
9 A
10 B
PBLT
24 A (3)
3 C (4)
F19
Warning Light
(5)
GY
14 IM1
B10
MPX1
18 B (1AZFSE)
23 A (2)
20 A (1)
PBEW
(5)
MPX2
6
BPBEW
GY
B9
Buckle SW (Driver' s Side)
29 B (1AZFSE)
29 A (2)
21 A (1)
GY
E 9(A), E10(B)
Engine ECU (M/T)
LBE+
19 A
Buckle SW
(5)
(5)
WB
LBE
2 A
PB
GSWI
DBEW
LR
4 B
WB
A26(A), A27(B)
13
29 A (3)
20 B (4)
BV
371
AVENSIS (EWD526E)
http://vnx.su

System Outline
Manual Lock Operation
All the doors are locked when the door lock control SW or the drivers side door key linked SW is operated to lock.
Manual Unlock Operation
All the doors are unlocked when the door lock control SW or the drivers side door key linked SW is operated to unlock.
Ignition Key Reminder Operation
The doors can not be locked unless the key is removed from the ignition key cylinder.
Service Hints
Integration Relay
: Parts Location
Code
See Page
Code
See Page
Code
46 (LHD)
A15
46 (LHD)
A16
46 (LHD)
A26
46 (LHD)
A27
46 (LHD)
54 (LHD W/G)
I14
47 (LHD)
52 (LHD L/B)
50 (LHD S/D)
J10
48 (LHD)
54 (LHD W/G)
52 (LHD L/B)
B7
B8
D11
D12
D13
52 (LHD L/B)
See Page
A13
E9
47 (LHD)
50 (LHD S/D)
E10
47 (LHD)
52 (LHD L/B)
J30
51 (LHD S/D)
J31
51 (LHD S/D)
C10
46 (LHD)
50 (LHD S/D)
50 (LHD S/D)
D15
D17
52 (LHD L/B)
52 (LHD L/B)
52 (LHD L/B)
54 (LHD W/G)
54 (LHD W/G)
50 (LHD S/D)
50 (LHD S/D)
D18
52 (LHD L/B)
51 (LHD S/D)
53 (LHD L/B)
J32
55 (LHD W/G)
J33
J34
53 (LHD L/B)
55 (LHD W/G)
53 (LHD L/B)
55 (LHD W/G)
52 (LHD L/B)
54 (LHD W/G)
L3
51 (LHD S/D)
54 (LHD W/G)
50 (LHD S/D)
L4
51 (LHD S/D)
52 (LHD L/B)
U1
49 (LHD)
50 (LHD S/D)
D20
: Relay Blocks
See Page
29
48 (LHD)
50 (LHD S/D)
54 (LHD W/G)
J16
54 (LHD W/G)
56 (LHD)
Code
47 (LHD)
54 (LHD W/G)
B10
D11
F19
52 (LHD L/B)
56 (LHD)
D10
54 (LHD W/G)
54 (LHD W/G)
B9
D9
D20

372
AVENSIS (EWD526E)
http://vnx.su

Code
See Page
CA
CB
CC
34
CD
CJ
CK
35
DA
DB
DC
30
31
DD
DJ
DM

Code
IA1
IA2
IC1
IC2
IL1
IM1
IM2
See Page
86 (LHD)
86 (LHD)
88 (LHD)
88 (LHD)
90 (LHD S/D)
BA1
92 (LHD L/B)
94 (LHD W/G)
90 (LHD S/D)
BC1
92 (LHD L/B)
94 (LHD W/G)
BD2
92 (LHD L/B)
BE2
92 (LHD L/B)
BF2
94 (LHD W/G)
BG2
94 (LHD W/G)
: Ground Points
Code
See Page
IJ
86 (LHD)
Left Kick Panel
IL
86 (LHD)
IO
86 (LHD)
BS
90 (LHD S/D)
90 (LHD S/D)
BV
92 (LHD L/B)
94 (LHD W/G)
BX
92 (LHD L/B)
94 (LHD W/G)
: Splice Points
Code
B1
See Page
90 (LHD S/D)
92 (LHD L/B)

Front Door LH Wire
Code
B1
See Page
94 (LHD W/G)

Front Door LH Wire
373
AVENSIS (EWD526E)
http://vnx.su
Door Lock Control (RHD) and Theft Deterrent

I14(A)
Integration Relay
25A
DOOR
7. 5A
ECUB 2
B
1
23
PRG
16 A
RDA
7 A
(3)
LW
(3)
16 DB
GY
+B
GROUND
WB
(3)
1
2
3
4
5
6
7
(3)
(3)
WR
WR
(3)
WR
(4)
9 CF
D6
2
RDA
5
7 CI
(3)
LW
3
PRG
WB
3 CD
7 IC2
(3)
WR
10 CC
16 IC2
GY
WR
WR
: 1AZFSE
: 1CDFTV
: Automatic A/C
WR
(4)
J15
Junction
Connector
IK
374
AVENSIS (EWD526E)
http://vnx.su
I14(A)
Integration Relay
P/W
OBD2
FRLY
21 A
20
MPX1
15 A
11 A
WG
LG
1 IC3
6 IC2
10 IC1
MPX
A13(A), A15(B)
MPX+
9 A (5)
10 B (6)
IL1
3
IG
PW
SIL
EHW
D17
Power Window
Master SW
D5
DLC3
T10
Turn Signal
Flasher Relay
29 B (1)
29 A (7)
21 A (2)
MPX2
E 9(A), E10(B)
Engine ECU (M/T)
MPX1
18 B (1)
23 A (7)
20 A (2)
M6
Moon Roof Control
Relay and Motor
PB
LG
WG
5 BB1
LG
29 A (5)
20 B (6)
F A
(w/ Moon Roof)
6 ID1
G A
D B
J24(A), J25(B)
Junction Connector
A B
G B
J26(A), J27(B)
Junction Connector
E A
J26(A), J27(B)
Junction Connector
E A
(w/o Moon Roof)
WG
(w/ Moon Roof)
5 DA
WR
WR
(4)
(4)
375
AVENSIS (EWD526E)
http://vnx.su

I14(A)
Integration Relay
ACC
IG
21
KSW
19
22
8 DA
WR
Y(4)
RW(4)
PL(4)
J22(A), J23(B)
Junction Connector
F B
D A
D A
15 A
(8)
21 B
WR
2 A
(4)
PL
RW
14 A
GR
PB
6 CD
(1AZFE)
H B
20 B
Door
U1
Unlock Warning SW
1 CK
(4)
7 CA
RW
F A
(4)
RW
7 DB
GR
1 IC1
J20(A), J21(B)
Junction
Connector
4 DB
(1AZFE)
7. 5A
RAD NO. 1
10A GAUGE1
PB

(See Page 120)
(8)
MPX2
22 A
1
WB
(4)
WB
BEAN I/F
CPU
5 B
C10(A), C11(B)
Combination Meter
WB
13 A
6 CK
6 CA
9 CG
13 CF
WB
WB
WB(4)
WR
WR
(4)
(4)
IP
376
AVENSIS (EWD526E)
http://vnx.su
I14(A)
Integration Relay
8 : Except 1AZFE
WR
WR
Y(4)
WR
(4)
31
12
(4)
KSW
IG
WR
10
MPX
(4)
RW
PL(4)
PL(4)
(4)
RW(4)
+B1
T6
Theft Deterrent ECU
SEC
E
IOUT
J26(A), J27(B)
Junction Connector
S+B
(4)
(4)
LB
3
SOFF
T12
SIN+
SIN
SOU
SOU+
GND
(4)
WB
(4 W/G)
(4 W/G)
1
MIN
(Shielded)
2
MIN+
(4)
(4 W/G)
(4)
F19
WB
E6
GND
T15
Theft Warning Siren
(4)
D B
(4)
LB
(4)
LW
LW
(4)
LGB
B A
(4)
19 ID1
(4)
9 ID1
LGB
8 ID1
CONT
WR
HORN
5 IO1
(4)
IOUT
26
11 IM1
WB
+B
S+B
24
(4)
SSW1
13
(4)
(4)
LR
IND
25
LR
(4)
LR
DSWH
34
(4)
(4)
WB
CTLS
27
LR
E
29
12 IM1
J16
Junction
Connector
(4)
WB
(4)
WB
1
MOU
2
MOU+
T14
Theft Warning
Ultrasonic
Sensor Rear RH
(4)
BV
EC
T13
Theft Warning
Ultrasonic
Sensor Rear LH
G
(4)
(4)
WB
WR
IL
WB
(4)
377
AVENSIS (EWD526E)
http://vnx.su

I14(A)
Integration Relay
LP
6
(4)
H B
F A
F A
7 DK
WG
WG
WR
H B
1 DA
I11(A), I12(B)
6 A (10)
6 B (9)
ILL
ILL+
2 A (10)
2 B (9)
WR
WR
(4)
F A
WR
F A
WR
J26(A), J27(B)
Junction
Connector
WR
WR
WR
15A HORN
WR
(4)
1
7. 5A DOME
4 ID1
W
WR
WR
(4)
2
P8
Personal Light
V9
Vanity Light RH
2
H12
Horn
RH
(4)
B5
WB
WB
(4)
G
(4)
WB
H11
Horn
LH
2
1
WB
(4)
WB
V8
Vanity Light LH
(4)
GW
GW
20 IE1
1
2
(4)
WR
HORN
Relay
WR
B5
WR
WB
(4)
378
AVENSIS (EWD526E)
http://vnx.su
B5
WB
WB
I14(A)
Integration Relay
13 DB
9 DC
12 DM
E
25
13 DM
2 DK
6 DK
9 DA
WB
16
WB
RCTY
WG
PCTY
WG
DCTY
17
5 CE
1 CA
4 IC2
WR
WB
I16
Interior Light
4
11 ID1
WR
D12
WG
R
1
D11
WR
18 IM1
D9
WR
14 IC2
D10
9 IM1
WG
WG
D3
Diode
6 CH
WB
3 CE
WB
B5
WB
WB
379
AVENSIS (EWD526E)
http://vnx.su

I14(A)
Integration Relay
BDCY
LACT
12 A
LGCY
BDSU
1 A
10 A
RY
3 DM
A
J32
Junction
Connector
(S/D)
RY
(11)
LB
(S/D)
L
(S/D)
(W/G)
WB
L4
Luggage Compartment
Door Opener SW
B A
C B
WB
WB
LB
WB
J30(A), J31(B)
Junction Connector
(11)
A B
(11)
WB
A B
(11)
A B
(S/D)
(S/D)
(S/D)
B8
Back Door Opener
SW
B A
J33(A), J34(B)
Junction
Connector
A A
WB
(S/D)
WB
(11)
WB
(11)
(S/D)
RY
L3
LB
(W/G)
L
LB
(L/B)
3 BG2
(11)
(L/B)
(W/G)
L
L
6 BE2
4
M
WB
4 BG2
(W/G)
(L/B)
RY
(W/G)
L
L
(L/B)
7 BE2
B7
5 BG2
RY
RY
(L/B)
8 BE2
6 BD2 (L/B)
5 BF2 (W/G)
7 BD2 (L/B)
6 BF2 (W/G)
(W/G)
RY
(L/B)
8 BD2 (L/B)
2 BF2 (W/G)
J32
Junction
Connector
(S/D)
LB
(11)
(11)
RY
(11)
11 : L/B, W/G
WB
WB
BX
380
AVENSIS (EWD526E)
http://vnx.su
BS
9
7
IL1
2
IL1
6 A
6 B
5 A
5 B
7 A
7 B
4 A
2 B
1 A (13)
1 B (12)
IL1
IP
AVENSIS (EWD526E)
http://vnx.su
17 IM2
1 IM2
16 IM1
(12)
LGB
7 CC
2 BC1
11 BC1
9 BC1
(12)
LGB
10 DB
4 A
4 B
1 A (13)
3 B
9 B (12)
(12)
IL2
8 CC
LB
LSWD
LGB
18
7 CJ
LB
3 A
(12)
IL2
2 CB
LB
1
4 CA
LR
20 DB
LR
LB
16 IC1
LB
7 IC1
LR
17 IC1
LR
LG
UL2
LR
IL2
LG
5 A
D20(A)
D21(B)
LB
LR
LG
8
L
IL2
3
L2
WB
WB
IL2
4 A
(12)
WB
UL1
WB
WB
13 DA
LR
29 DA
LR
GW
10
LY
GW
L1
D17
Unlock
BRW
11
D13(A), D14(B)
WB
BRW
Lock
I14(A)
Integration Relay
LSWP
7
8 DB
11 CK
8 A (13)
8 B (12)
10 B (12)
B1
10 BC1
WB
WB
BU
381

I14(A)
Integration Relay
5 B
LB
LB
LR
2 BA1
11 BA1
LB
LGB
1 A (13)
3 B (12)
6 DM
LR
(12)
LB
4 A
4 B
7 DM
LR
LGB
9 BA1
(12)
2 IA1
LB
7 IA1
LR
(12)
10 DM
LGB
4 DJ
LB
1 DJ
LR
(12)
(12)
8 B
LR
LGB
LGB
(12)
LGB
18 IA2
ACT
4 A
2 B
1 A (13)
1 B (12)
WB
6 B (12)
WB
7 B (12)
(12)
D18(A)
D19(B)
(12)
D15(A)
D16(B)
Door Unlock Detection SW (Front Passenger' s Side)
20 DA
ACT+
IJ
WB
10 BA1
(12)
WB
WB
(12)
9 IA1
BQ
382
AVENSIS (EWD526E)
http://vnx.su
System Outline
Manual Lock Operation
All the doors are locked when the door lock control SW or the drivers side door key linked SW is operated to lock.
Manual Unlock Operation
All the doors are unlocked when the door lock control SW or the drivers side door key linked SW is operated to unlock.
Ignition Key Reminder Operation
The doors can not be locked unless the key is removed from the ignition key cylinder.
Service Hints
Integration Relay
383
AVENSIS (EWD526E)
http://vnx.su

: Parts Location
Code
See Page
A13
66 (RHD)
A15
66 (RHD)
74 (RHD W/G)
74 (RHD W/G)
A
66 (RHD)
66 (RHD)
D20
D21
67 (RHD)
D6
67 (RHD)
E9
70 (RHD S/D)
E10
D16
A
B
D17
D18
73 (RHD L/B)
J32
72 (RHD L/B)
75 (RHD W/G)
J33
J34
73 (RHD L/B)
75 (RHD W/G)
73 (RHD L/B)
75 (RHD W/G)
71 (RHD S/D)
L4
71 (RHD S/D)
67 (RHD)
67 (RHD)
73 (RHD L/B)
75 (RHD W/G)
62 (*9)
71 (RHD S/D)
64 (*10)
74 (RHD W/G)
58 (*7)
H12
71 (RHD S/D)
M6
58 (*7)
72 (RHD L/B)
P8
73 (RHD L/B)
75 (RHD W/G)
62 (*9)
T6
69 (RHD)
64 (*10)
T10
69 (RHD)
74 (RHD W/G)
I11
67 (RHD)
70 (RHD S/D)
I12
67 (RHD)
72 (RHD L/B)
I14
67 (RHD)
71 (RHD S/D)
T12
73 (RHD L/B)
75 (RHD W/G)
74 (RHD W/G)
70 (RHD S/D)
T13
75 (RHD W/G)
70 (RHD S/D)
72 (RHD L/B)
T14
75 (RHD W/G)
I16
70 (RHD S/D)
D15
71 (RHD S/D)
70 (RHD S/D)
67 (RHD)
72 (RHD L/B)
71 (RHD S/D)
H11
70 (RHD S/D)
D14
L3
F19
70 (RHD S/D)
J31
64 (*10)
74 (RHD W/G)
D13
72 (RHD L/B)
62 (*9)
E6
72 (RHD L/B)
D12
71 (RHD S/D)
58 (*7)
D5
D11
74 (RHD W/G)
67 (RHD)
D10
See Page
J30
70 (RHD S/D)
D3
D9
Code
70 (RHD S/D)
74 (RHD W/G)
72 (RHD L/B)
B8
C11
D19
See Page
72 (RHD L/B)
B7
C10
Code
74 (RHD W/G)
72 (RHD L/B)
J15
68 (RHD)
74 (RHD W/G)
J16
68 (RHD)
71 (RHD S/D)
T15
73 (RHD L/B)
75 (RHD W/G)
70 (RHD S/D)
J20
68 (RHD)
U1
70 (RHD S/D)
J21
68 (RHD)
69 (RHD)
72 (RHD L/B)
J22
68 (RHD)
74 (RHD W/G)
J23
68 (RHD)
75 (RHD W/G)
70 (RHD S/D)
J24
68 (RHD)
71 (RHD S/D)
72 (RHD L/B)
J25
68 (RHD)
74 (RHD W/G)
J26
68 (RHD)
70 (RHD S/D)
J27
68 (RHD)
71 (RHD S/D)
V8
V9
73 (RHD L/B)
73 (RHD L/B)
75 (RHD W/G)
: Relay Blocks
Code
1
See Page
24 (*1)
25 (*2)

26
29
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
384
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV

Code
See Page
CA
CB
CC
CD
34
CE
CF
CG
CH
CI
35
CJ
CK
DA
DB
30
DK
31
DM
31
DC
DJ

Code
IA1
See Page
106 (RHD)
106 (RHD)
ID1
106 (RHD)
IE1
106 (RHD)
108 (RHD)
108 (RHD)
108 (RHD)
IA2
IC1
IC2
IC3
IL1
IL2
IM1
IM2
IO1
110 (RHD S/D)

BA1
112 (RHD L/B)
114 (RHD W/G)

110 (RHD S/D)
BB1
112 (RHD L/B)
114 (RHD W/G)

110 (RHD S/D)
BC1
112 (RHD L/B)
114 (RHD W/G)

BD2
112 (RHD L/B)
BE2
112 (RHD L/B)
BF2
114 (RHD W/G)
BG2
114 (RHD W/G)
385
AVENSIS (EWD526E)
http://vnx.su

: Ground Points
Code
See Page
98 (*7)
EC
102 (*9)
104 (*10)
IJ
IK
IL
IP
106 (RHD)
Left Kick Panel
106 (RHD)
106 (RHD)
Right Kick Panel
110 (RHD S/D)

BQ
112 (RHD L/B)
114 (RHD W/G)

BS
110 (RHD S/D)
110 (RHD S/D)

BU
112 (RHD L/B)

114 (RHD W/G)
110 (RHD S/D)
BV
112 (RHD L/B)

114 (RHD W/G)
BX
112 (RHD L/B)

114 (RHD W/G)
: Splice Points
Code
See Page
Code
110 (RHD S/D)

B1
112 (RHD L/B)

114 (RHD W/G)
See Page
110 (RHD S/D)

Front Door LH Wire
B5
112 (RHD L/B)
Roof Wire
114 (RHD W/G)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
386
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
Memo
387
AVENSIS (EWD526E)
http://vnx.su
Wireless Door Lock Control (LHD)

I14(A)
Integration Relay
7. 5A
ECUB 2
25A
DOOR
B
1
B
23
PRG
16 A
RDA
7 A
25
GY
LW
16 IC2
7 IC2
LW
9 DA
WR
PRG
RDA
+B
GROUND
1
WB
WR
D6
3 CD
WB
9 CF
WR
10 CC
WB
WR
WR
16 DB
GY
8 CD
WB
WB
6 CA
IP
388
AVENSIS (EWD526E)
http://vnx.su
IJ
WB
I14(A)
Integration Relay
PCTY
RCTY
16
13 DB
9 DC
12 DM
KSW
13 DM
10
29 DA
13 DA
WG
8 DA
UL1
11
J10(A)
Junction
Connector
B A
B A
L1
19
DCTY
17
BRW
GW
3 IA2
BRW
GW
Lock
Unlock
D17
U1
Unlock Warning SW
WG
1
D12
D11
R
1
4 IA2
18 IM1
D10
9 IM1
D9
14 IC2
WG
WG
4 IC2
WB
J16
Junction
Connector
WB
WB
WB
B1
9 IA1
WB
WB
WB
IL : 1CDFTV
IO : Gasoline
389
AVENSIS (EWD526E)
http://vnx.su

I14(A)
Integration Relay
8 CC
LG
LR
LB
LR
LB
2 IA2
1 IA2
18 IA2
7 IA1
2 IA1
2 BA1
11 BA1
LG
LR
LB
LR
LB
LR
10
D13
(Driver' s Side)
(Driver' s Side)
(Driver' s Side)
D18
Door Lock Motor
Rear LH
IL1
AVENSIS (EWD526E)
http://vnx.su
11 CK
17 IM2
1 IM2
2 BC1
11 BC1
IL1
D15
390
7 CC
LB
7 CJ
16 IC1
LB
2 CB
LB
4 CA
LR
7 IC1
10 DB
LR
20 DB
LR
6 DM
LR
7 DM
LB
4 DJ
LB
1 DJ
LB
LR
LR
(L/B, W/G)
ACT
LR
LY
(S/D)
ACT+
17 IC1
WB
LSWD
3 A
LR
UL2
5 A
LG
L2
4 A
D20
Door Lock Motor
Rear RH
A B
A A
A B
WB
BX
AVENSIS (EWD526E)
http://vnx.su
M
B A
C B
L4
Luggage Compartment
Door Opener SW
(S/D)
LB
(S/D)
L3
WB
RY
J32
Junction
Connector
6 BD2 (L/B)
5 BF2 (W/G)
(S/D)
(S/D)
2
(W/G)
LB
(L/B, W/G)
(S/D)
RY
3 DM
(S/D)
L
(L/B)
BDSU
WB
4
LB
6 BE2
(W/G)
4 BG2
B8
Back Door Opener
SW
LB
7 BD2 (L/B)
6 BF2 (W/G)
(L/B)
10 A
(S/D)
A B
(W/G)
L
(L/B, W/G)
J33(A), J34(B)
Junction Connector
WB
7 BE2
(W/G)
L
(L/B)
RY
(L/B, W/G)
LACT
(L/B, W/G)
L
(L/B)
RY
J32
Junction
Connector
WB
1
5 BG2
B7
2
(W/G)
8 BD2 (L/B)
2 BF2 (W/G)
WB
8 BE2
RY
RY
(L/B, W/G)
(W/G)
RY
(L/B)
BDCY
(L/B, W/G)
RY
(L/B)
12 A
(L/B, W/G)
WB
(L/B, W/G)
I14(A)
Integration Relay
1 A
LGCY
(S/D)
LB
(S/D)
3 BG2
B A
J30(A), J31(B)
Junction Connector
BS
391

System Outline
The current is always sent from DOOR fuse to TERMINAL 1 of the integration relay. At the same time, the current is always
sent from ECUB 2 fuse to TERMINAL 5 of the door control receiver.
1. Wireless Door Lock or Unlock Normal Operation
Lock operation
When the LOCK SW of the transmitter is pushed, all the doors are locked.
Unlock operation
When the UNLOCK SW of the transmitter is pushed, all the doors are unlocked.
Luggage door unlock operation (S/D)
When the luggage door unlock SW is pushed, the luggage door is unlocked.
Back door unlock operation (L/B, W/G)
When the back door unlock SW is pushed, the back door is unlocked.
2. Automatic Lock Operation
If the door is not actually opened within approx. 30 sec. after the door has been unlocked by pushing the UNLOCK SW of
the transmitter, unless each of the doors is opened or the ignition key is inserted, all the doors are locked again.
3. Visual Confirmation of Lock or Unlock Function
When doors are locked by using the transmitter, the hazard warning lights blink once. When doors are unlocked by using the
transmitter, the hazard warning lights blink twice.
4. Wireless Control Stop Function
If the following situations occur, wireless door lock function does not operate.
Lock operation
When each of the doors opens. (Door courtesy SW is on)
When ignition key is inserted to ignition SW. (Unlock warning SW is on)
When ignition SW is on.
Unlock operation
5. Repeat Function
If the doors are not locked after the lock signal is out put from transmitter by pushing LOCK SW, the lock signal is sent again
to lock the doors.
Service Hints
Integration Relay
D6 Door Control Receiver
392
AVENSIS (EWD526E)
http://vnx.su
: Parts Location
Code
See Page
52 (LHD L/B)
B7
Code
D12
54 (LHD W/G)
52 (LHD L/B)
B8
D6
D13
48 (LHD)
J16
48 (LHD)
A
51 (LHD S/D)
47 (LHD)
50 (LHD S/D)
J31
51 (LHD S/D)
50 (LHD S/D)
D15
52 (LHD L/B)
51 (LHD S/D)
54 (LHD W/G)
53 (LHD L/B)
J32
50 (LHD S/D)
D17
52 (LHD L/B)
52 (LHD L/B)
54 (LHD W/G)
54 (LHD W/G)
50 (LHD S/D)
50 (LHD S/D)
D18
52 (LHD L/B)
55 (LHD W/G)
J33
J34
53 (LHD L/B)
55 (LHD W/G)
53 (LHD L/B)
55 (LHD W/G)
52 (LHD L/B)
54 (LHD W/G)
L3
51 (LHD S/D)
54 (LHD W/G)
50 (LHD S/D)
L4
51 (LHD S/D)
52 (LHD L/B)
U1
49 (LHD)
50 (LHD S/D)
D12
J10
52 (LHD L/B)
47 (LHD)
J30
54 (LHD W/G)
D11
50 (LHD S/D)
See Page
A
54 (LHD W/G)
52 (LHD L/B)
D10
Code
I14
54 (LHD W/G)
50 (LHD S/D)
D9
See Page
54 (LHD W/G)
D20
52 (LHD L/B)
54 (LHD W/G)
: Relay Blocks
Code
6
See Page
29


Code
See Page
CA
CB
CC
34
CD
CF
CJ
CK
35
DA
DB
DC
30
31
DJ
DM
393
AVENSIS (EWD526E)
http://vnx.su

Code
IA1
IA2
IC1
IC2
IL1
IM1
IM2
See Page
86 (LHD)
86 (LHD)
88 (LHD)
88 (LHD)
90 (LHD S/D)
BA1
92 (LHD L/B)
94 (LHD W/G)
90 (LHD S/D)
BC1
92 (LHD L/B)
94 (LHD W/G)
BD2
92 (LHD L/B)
BE2
92 (LHD L/B)
BF2
94 (LHD W/G)
BG2
94 (LHD W/G)
: Ground Points
Code
See Page
IJ
86 (LHD)
Left Kick Panel
IL
86 (LHD)
IO
86 (LHD)
IP
86 (LHD)
Right Kick Panel
BS
90 (LHD S/D)
BX
92 (LHD L/B)
94 (LHD W/G)
: Splice Points
Code
B1
See Page
90 (LHD S/D)
92 (LHD L/B)

Front Door LH Wire
Code
B1
See Page
94 (LHD W/G)
394
AVENSIS (EWD526E)
http://vnx.su

Front Door LH Wire
Memo
395
AVENSIS (EWD526E)
http://vnx.su
Wireless Door Lock Control (RHD)

I14(A)
Integration Relay
PRG
RDA
FRLY
16 A
7 A
15 A
16 DB
LG
B
23
LW
B
1
GY
25A DOOR
7. 5A ECUB 2
16 IC2
7 IC2
6 IC2
E
25
DCTY
PCTY
17
13 DB
9 DC
2
9 DA
R
WB
WR
WR
5 CE
PRG
RDA
+B
GROUND
R
1
WB
14 IC2
D9
9 IM1
8
EHW
D10
F A
J24(A), J25(B)
Junction Connector
1 CA
T10
D B
LG
D6
LG
LW
WR
WB
3 CD
WR
WR
9 CF
GY
10 CC
J15
Junction
Connector
IK
396
AVENSIS (EWD526E)
http://vnx.su
WB
WB
A
IJ
WB
A A
A B
A B
BX
AVENSIS (EWD526E)
http://vnx.su
WB
(S/D)
2
1
C B
WB
B A
LB
18 IM1
L4
(S/D)
J32
Junction
Connector
L3
6 BD2 (L/B)
5 BF2 (W/G)
(S/D)
RY
RY
(S/D)
(S/D)
L
(W/G)
LB
(L/B, W/G)
BDSU
WB
L
(S/D)
L
(L/B)
10 A
(S/D)
LB
(W/G)
6 BE2
WB
B8
Back Door Opener
SW
J33(A), J34(B)
Junction Connector
LB
4 BG2
(L/B)
7 BD2 (L/B)
6 BF2 (W/G)
(S/D)
A B
(W/G)
L
(L/B, W/G)
(L/B, W/G)
WB
L
(L/B)
LACT
(L/B, W/G)
(W/G)
7 BE2
WB
5 BG2
(L/B)
J32
Junction
Connector
(L/B, W/G)
RY
8 BD2 (L/B)
2 BF2 (W/G)
B7
2
(W/G)
RY
(L/B, W/G)
BDCY
WB
8 BE2
RY
RY
(L/B, W/G)
(W/G)
RY
(L/B)
12 A
(L/B, W/G)
RY
13 DM
(L/B)
WG
RCTY
(L/B, W/G)
WB
WB
D12
WG
12 DM
WG
16
(L/B, W/G)
D11
WG
I14(A)
Integration Relay
1 A
LGCY
(S/D)
LB
3 DM
4 IC2
3 BG2
B A
J30(A), J31(B)
Junction
Connector
WB
BS
397

I14(A)
Integration Relay
KSW
11 A
MPX1
22 A
PB
MPX2
19
L1
UL1
L2
UL2
4 A
11
10
29 DA
13 DA
LSWD
5 A
3 A

(See Page 120)
8 DA
LG
1 IC1
LR
7. 5A
DOME
17 IC1
7 IC1
16 IC1
10 IC1
MPX
13 A
MPX2
MPX1
18 B (3)
23 A (4)
20 A (5)
L
IL2
18
IL2
LG
IL2
LY
GW
IL2
BRW
29 B (3)
29 A (4)
21 A (5)
7
8
WB
6 CK
13 CF
C10(A), C11(B)
Combination Meter
WB
WB
5 B
E 9(A), E10(B)
Engine ECU (M/T)
CPU
IL2
D17
PB
U1
Unlock Warning SW
BEAN
I/F
LR
MPX+
9 A (1)
10 B (2)
4
GW
BRW
MPX
Unlock
PB
14 A
29 A (1)
20 B (2)
WB
15 A
A13(A), A15(B)
20 B
(7)
PL
WR
LG
31
Lock
T6
Theft Deterrent ECU
J26
Junction Connector
J22
Junction Connector
WR
WB
B1
WB
WB
6 CA
D14
Door Key Lock and
Unlock SW
(Driver' s Side)
Door Lock Control
Motor
(Driver' s Side)
Door Unlock
Detection SW
(Driver' s Side)
WB
IL1
WB
WB
WB
IP
398
AVENSIS (EWD526E)
http://vnx.su
I14(A)
Integration Relay
LSWP
7
LR
LB
LGB
18 IA2
7 IA1
2 IA1
2 BA1
11 BA1
9 BA1
LR
LB
LGB
10 DM
LB
6 DM
LB
D16
WB
WB
WB
10 BC1
9 IA1
10 BA1
WB
WB
WB
10
D19

: Automatic A/C
: 1AZFSE
: 1ZZFE, 3ZZFE
: 1CDFTV
7 DM
LR
1
2
3
4
5
4 DJ
LR
D21
9 BC1
LGB
11 BC1
LB
2 BC1
1 DJ
LGB
16 IM1
D14
(Driver' s Side)
(Driver' s Side)
(Driver' s Side)
LGB
1 IM2
LR
IL1
LGB
LB
2
17 IM2
LB
IL1
20 DA
ACT
11 CK
LR
7 CC
LGB
8 CC
LB
7 CJ
LB
2 CB
LR
LB
4 CA
8 DB
LR
LR
10 DB
LR
20 DB
ACT+
WB
IJ
BQ
399
AVENSIS (EWD526E)
http://vnx.su

System Outline
The current is always sent from DOOR fuse to TERMINAL 1 of the integration relay. At the same time, the current is always
sent from ECUB 2 fuse to TERMINAL 5 of the door control receiver.
1. Wireless Door Lock or Unlock Normal Operation
Lock operation
When the LOCK SW of the transmitter is pushed, all the doors are locked.
Unlock operation
When the UNLOCK SW of the transmitter is pushed, all the doors are unlocked.
Luggage door unlock operation (S/D)
When the luggage door unlock SW is pushed, the luggage door is unlocked.
Back door unlock operation (L/B, W/G)
When the back door unlock SW is pushed, the back door is unlocked.
2. Automatic Lock Operation
If the door is not actually opened within approx. 30 sec. after the door has been unlocked by pushing the UNLOCK SW of
the transmitter, unless each of the doors is opened or the ignition key is inserted, all the doors are locked again.
3. Visual Confirmation of Lock or Unlock Function
When doors are locked by using the transmitter, the hazard warning lights blink once. When doors are unlocked by using the
transmitter, the hazard warning lights blink twice.
4. Wireless Control Stop Function
If the following situations occur, wireless door lock function does not operate.
Lock operation
When each of the doors opens. (Door courtesy SW is on)
Unlock operation
5. Repeat Function
If the doors are not locked after the lock signal is out put from transmitter by pushing LOCK SW, the lock signal is sent again
to lock the doors.
Service Hints
Integration Relay
D6 Door Control Receiver
400
AVENSIS (EWD526E)
http://vnx.su
: Parts Location
Code
See Page
A13
66 (RHD)
A15
66 (RHD)
B8
C11
J24
68 (RHD)
72 (RHD L/B)
J25
68 (RHD)
70 (RHD S/D)
J30
71 (RHD S/D)
72 (RHD L/B)
J31
71 (RHD S/D)
66 (RHD)
D16
J26
68 (RHD)
74 (RHD W/G)
71 (RHD S/D)
70 (RHD S/D)
67 (RHD)
73 (RHD L/B)
J32
72 (RHD L/B)
D17
70 (RHD S/D)
74 (RHD W/G)
72 (RHD L/B)
70 (RHD S/D)
74 (RHD W/G)
72 (RHD L/B)
D19
75 (RHD W/G)
J33
J34
73 (RHD L/B)
75 (RHD W/G)
73 (RHD L/B)
70 (RHD S/D)
74 (RHD W/G)
72 (RHD L/B)
70 (RHD S/D)
L3
71 (RHD S/D)
72 (RHD L/B)
L4
71 (RHD S/D)
74 (RHD W/G)
D21
70 (RHD S/D)
D12
70 (RHD S/D)
72 (RHD L/B)
D11
68 (RHD)
74 (RHD W/G)
66 (RHD)
D10
See Page
J22
74 (RHD W/G)
D9
Code
74 (RHD W/G)
D14
74 (RHD W/G)
D6
See Page
D12
72 (RHD L/B)
B7
C10
Code
75 (RHD W/G)
74 (RHD W/G)
T6
69 (RHD)
72 (RHD L/B)
E9
67 (RHD)
T10
69 (RHD)
74 (RHD W/G)
E10
67 (RHD)
U1
69 (RHD)
70 (RHD S/D)
I14
67 (RHD)
72 (RHD L/B)
J15
68 (RHD)
: Relay Blocks
Code
6
See Page
29


Code
See Page
CA
CB
CC
CD
34
CE
CF
CJ
CK
35
DA
DB
DC
30
31
DJ
DM
401
AVENSIS (EWD526E)
http://vnx.su

Code
IA1
IA2
IC1
IC2
IL1
IL2
IM1
IM2
See Page
106 (RHD)
106 (RHD)
108 (RHD)
108 (RHD)
110 (RHD S/D)

BA1
112 (RHD L/B)
114 (RHD W/G)

110 (RHD S/D)
BC1
112 (RHD L/B)
114 (RHD W/G)

BD2
112 (RHD L/B)
BE2
112 (RHD L/B)
BF2
114 (RHD W/G)
BG2
114 (RHD W/G)
: Ground Points
Code
See Page
IJ
106 (RHD)
Left Kick Panel
IK
106 (RHD)
IP
106 (RHD)
Right Kick Panel
110 (RHD S/D)

BQ
112 (RHD L/B)
114 (RHD W/G)

BS
BX
110 (RHD S/D)

112 (RHD L/B)
114 (RHD W/G)

: Splice Points
Code
B1
See Page
110 (RHD S/D)
112 (RHD L/B)

Front Door LH Wire
Code
See Page
B1
114 (RHD W/G)
402
AVENSIS (EWD526E)
http://vnx.su

Front Door LH Wire
Memo
403
AVENSIS (EWD526E)
http://vnx.su
Double Locking
I14(A)
Integration Relay
25A
DOOR
7. 5A
ECUB 2
B
1
B
23
PRG
16 A
RDA
FRLY
7 A
15 A
GY
LW
LG
16 IC2
7 IC2
6 IC2
LW
16 DB
GY
WR
WR
F A
WB
EHW
J15
Junction
Connector
IK
404
AVENSIS (EWD526E)
http://vnx.su
J24(A), J25(B)
Junction Connector
GROUND
T10
+B
D B
LG
2
RDA
D6
WR
3
PRG
WB
3 CD
WR
WR
9 CF
LG
10 CC
WB
C B
1
1
RY
5 CE
8 BE2
BS
AVENSIS (EWD526E)
http://vnx.su
RY
(W/G)
13 DM
RY
RY
9 DC
(L/B, W/G)
13 DB
(W/G)
RY
12 A
(L/B)
WG
16
(L/B)
B7
14 IC2
D12
WG
WG
RCTY
RY
(L/B, W/G)
12 DM
WG
D11
9 IM1
D9
1 CA
RY
(S/D)
PCTY
J34
Junction
Connector
WB
D10
J32
Junction
Connector
A
DCTY
17
(L/B, W/G)
L3
RY
(S/D)
LGCY
(L/B, W/G)
B A
J30(A), J31(B)
Junction
Connector
WB
(S/D)
1 A
WB
(S/D)
I14(A)
Integration Relay
BDCY
J32
Junction
Connector
8 BD2 (L/B)
2 BF2 (W/G)
4 IC2
18 IM1
5 BG2
BX
405
Double Locking
I14(A)
Integration Relay
KSW
MPX2
19
MPX1
22 A
11 A
PB
1
8 DA
1 IC1
10 IC1
7. 5A
DOME
T6
Theft Deterrent ECU
J26
Junction
Connector
WR
J22
Junction
Connector
MPX
31
15 A
PB
14 A
A13(A), A15(B)
20 B
(3)
PL
WR
U1
Unlock Warning
SW
MPX+
9 A (1)
10 B (2)
BEAN I/F
CPU
13 A
29 B (1AZFSE)
29 A (1ZZFE, 3ZZFE)
21 A (1CDFTV)
MPX2
MPX1
18 B (1AZFSE)
23 A (1ZZFE, 3ZZFE)
20 A (1CDFTV)
6 CK
13 CF
C10(A), C11(B)
Combination Meter
WB
WB
5 B
E 9(A), E10(B)
Engine ECU (M/T)
MPX
PB
29 A (1)
20 B (2)
WB
6 CA
WB
WB
IP
406
AVENSIS (EWD526E)
http://vnx.su
I14(A)
Integration Relay
UL1
DLPD
6 A
10
29 DA
13 DA
L1
11
G
A
G
B
G
A
G
A
G
B
3 IC1
6 CF
5 CH
1 CI
1 CE
4 BC1
6 BC1
16 BC1
Unlock
IL2
17
IL1
IL1
11 IM2
IL2
2 IM2
GW
17 IM1
BRW
IL2
Lock
D17
GW
BRW
J20(A), J21(B)
Junction Connector
7
6
WB
D21
Double Lock Position SW
Rear RH
WB
10
WB
D14
Double Lock Motor
(Driver' s Side)
(Driver' s Side)
WB
B1
WB
IL1
10 BC1
2 : Automatic A/C
WB
BU
407
AVENSIS (EWD526E)
http://vnx.su
Double Locking
I14(A)
Integration Relay
ACTS
ACTR
14
15
6 DJ
9 DJ
E
25
9 DA
WB
10 CA
12 CJ
17 IA2
16 BA1
6 BA1
4 BA1
D19
Rear LH
10
9 IA1
10 BA1
WB
WB
WB
WB
D16
Double Lock Motor
8 IA1
4 IA1
12 IC1
4 IC3
10 IC3
W
3 CK
5 CB
2 CA
2 CD
WB
IJ
408
AVENSIS (EWD526E)
http://vnx.su
BQ
Service Hints
Integration Relay
: Parts Location
Code
See Page
A13
66 (RHD)
A15
66 (RHD)
B7
Code
See Page
D14
Code
70 (RHD S/D)
J20
72 (RHD L/B)
J21
See Page
A
68 (RHD)
68 (RHD)
72 (RHD L/B)
74 (RHD W/G)
J22
74 (RHD W/G)
70 (RHD S/D)
J24
68 (RHD)
68 (RHD)
72 (RHD L/B)
J25
68 (RHD)
C10
66 (RHD)
C11
66 (RHD)
74 (RHD W/G)
67 (RHD)
70 (RHD S/D)
J30
71 (RHD S/D)
72 (RHD L/B)
J31
71 (RHD S/D)
D6
D16
70 (RHD S/D)
D9
D17
72 (RHD L/B)
74 (RHD W/G)
74 (RHD W/G)
70 (RHD S/D)
70 (RHD S/D)
D10
72 (RHD L/B)
74 (RHD W/G)
74 (RHD W/G)
70 (RHD S/D)
D21
72 (RHD L/B)
D11
D12
68 (RHD)
71 (RHD S/D)
J32
72 (RHD L/B)
D19
70 (RHD S/D)
J26
73 (RHD L/B)
75 (RHD W/G)
J34
73 (RHD L/B)
75 (RHD W/G)
72 (RHD L/B)
L3
71 (RHD S/D)
74 (RHD W/G)
T6
69 (RHD)
74 (RHD W/G)
E9
67 (RHD)
T10
69 (RHD)
70 (RHD S/D)
E10
67 (RHD)
U1
69 (RHD)
72 (RHD L/B)
I14
67 (RHD)
74 (RHD W/G)
J15
68 (RHD)
: Relay Blocks
Code
6
See Page
29


Code
See Page
CA
CB
CC
CD
34
CE
CF
CH
CI
CJ
35
CK
DA
DB
DC
30
31
DJ
DM
409
AVENSIS (EWD526E)
http://vnx.su
Double Locking
Code
IA1
IA2
See Page
106 (RHD)
106 (RHD)
108 (RHD)
108 (RHD)
IC1
IC2
IC3
IL1
IL2
IM1
IM2
110 (RHD S/D)

BA1
112 (RHD L/B)
114 (RHD W/G)

110 (RHD S/D)
BC1
112 (RHD L/B)
114 (RHD W/G)

BD2
112 (RHD L/B)
BE2
112 (RHD L/B)
BF2
114 (RHD W/G)
BG2
114 (RHD W/G)
: Ground Points
Code
See Page
IJ
106 (RHD)
Left Kick Panel
IK
106 (RHD)
IP
106 (RHD)
Right Kick Panel
110 (RHD S/D)

BQ
112 (RHD L/B)
114 (RHD W/G)

BS
110 (RHD S/D)
110 (RHD S/D)

BU
112 (RHD L/B)
114 (RHD W/G)

BX
112 (RHD L/B)

114 (RHD W/G)
: Splice Points
Code
B1
See Page
110 (RHD S/D)
112 (RHD L/B)

Front Door LH Wire
Code
See Page
B1
114 (RHD W/G)
410
AVENSIS (EWD526E)
http://vnx.su

Front Door LH Wire
Memo
411
AVENSIS (EWD526E)
http://vnx.su
Power Window (LHD)

7. 5A
ECUB 2
25A
DOOR
10A
GAUGE1
20A
DFR P/W
7. 5A
RAD NO. 1
DCTY
PCTY
17
16 DB
13 DB
9 DC
9 DA
P/W
20
5 DA
WR
8 DA
E
25
B A
10 CC
LR
KSW
19
ACC
WB
B
23
21
B
WR
IG
J10(A)
Junction
Connector
(4)
22
Integration Relay
6
(3)
(3)
A A
B A
J 8(A), J 9(B)
Junction
Connector
3 CD
E B
B
(4)
B
(4)
LR
R
1
D10
9 IM1
D9
U1
Unlock Warning SW
14 IC2
WB
WB
J16
Junction
Connector
WB
IL : 1CDFTV
IO : 5
WB
IJ
412
AVENSIS (EWD526E)
http://vnx.su
D17
Window
Lock SW
20A
PFR P/W
2
(1)
(1)
6
(2)
(2)
WL
23
PW
FLD
FLU
FLA
14
GW
GY
LB
11 IA2
3 IA1
(2)
LR
B
(3)
LR
(1)
B
(3)
(1)
(4)
LR
WB
LR
LR
(2)
B
(4)
LR
LR
LR
GW
GY
LB
5 IA1
WB
WB
P12
WB
B1
9 IA1
1
2
3
4
5
: w/ Rear Power Window

: w/o Rear Power Window
: w/o Moon Roof
: w/ Moon Roof
: Gasoline
WB
413
AVENSIS (EWD526E)
http://vnx.su
Power Window (LHD)
RLD
17
15
WL
WG
9 IA2
8 IA2
10 IA2
LR
RLU
16
(1)
RLA
11
(1)
FRA
10
RY
FRU
(1)
FRD
WR
D17
(1)
LR
21 IA2
19 IA2
20 IA2
(1)
J10(A), J11(B)
Junction Connector
E
A
LR
B
A
(1)
(1)
LR
(1)
(1)
(1)
(1)
LR
E
B
RY
A
A
(1)
LR
(1)
LR
L
5 IC1
13 IC1
14 IC1
4 IC1
IL1
3 BA1
8 BA1
(1)
LR
B3
B6
L (1)
P13
WL
AUTO
UP
DOWN
(1)
(1)
RY
WR
WL
3
AUTO
(1)
WG
1
UP
WL
6
DOWN
WR
8
WL
R (1)
RY(1)
B3
B3
WG
B6
LR
12 BA1
B6
IL1
(1)
B2
WB
WB
(1)
WB
WB
B7
P9
Power Window Control SW
(Front Passenger Side)
WB
WB
10 BA1
IP
(1)
WB
(1)
(1)
RY
(1)
(1)
LR
18 BA1
(1)
IL2
(1)
10
RY
IL2
WG
WL
8
(1)
IL2
WG
WL
IL2
WR
11
(1)
LR
(2)
WR
LR
BQ
414
AVENSIS (EWD526E)
http://vnx.su
P10
SW Rear LH
WB
(1)
D17
20A
DRR P/W
20A
PRR P/W
7 IA2
5 IA2
(1)
(1)
LB
(1)
(1)
19
GY
RRD
18
(1)
RRU
22
LW
RRA
LW
6 IA2
LB
(1)
(1)
8 BC1
1 BC1
(1)
12 BC1
(1)
3 BC1
R (1)
8 IM2
(1)
GY
(1)
3 IM1
(1)
GY
4 IM1
GY
(1)
LW
(1)
18 BC1
2 IM1
(1)
1 BA1
5 IM1
LR
(1)
LW
2 IC3
LW
(1)
(1)
LW
LR
LR
(1)
B9
RY(1)
L (1)
B9
AUTO
UP
DOWN
P14
(1)
LB
(1)
(1)
GR
(1)
LW
8
WL
(1)
(1)
GY
(1)
LW
(1)
LW
(1)
(1)
RY
(1)
B9
P15
(1)
WB
P11
SW Rear RH
WB
WB
(1)
(1)
WB
B8
1 : w/ Rear Power Window

2 : w/o Rear Power Window
(1)
10 BC1
WB
(1)
BU
415
AVENSIS (EWD526E)
http://vnx.su
Power Window (LHD)

System Outline
1. Manual Down or Up Operation
When the power window master SW is pushed one step, the motor rotates to open the window.
When the power window master SW is pulled up one step, the motor rotates in the opposite direction, to close the window.
All the other windows can be opened/closed as well, by the operation of the power window master SW or respective power
window SW.
When the window lock SW is pushed to the lock side, the ground circuit to the passengers window becomes open. As a
result, even if Open/Close operation of the passengers window is attempted, the current from TERMINAL E of the power
window master SW is not grounded and the motor does not rotate, so the passengers window can not be operated and
window lock occurs.
2. Auto Down or Up Operation
When the power window master SW or respective power window SW is pushed two steps, the motor rotates to open the
window automatically.
When the power window master SW or respective power window SW is pulled up two steps, the motor rotates to close the
3. Jam Protection Function
When any foreign object gets caught during power window AUTO UP operation, the motor rotates in the opposite direction to
open the window.
4. Key Off Power Window Operation
Within approximately 43 sec. after the ignition SW is turned from on to off, the power window can be operated. However, if
the driver or front passenger door is opened during this period of time, the power window operation is stopped even through
43 sec. have not elapsed.
Service Hints
D17 Power Window Master SW
Integration Relay
: Parts Location
Code
See Page
50 (LHD S/D)
52 (LHD L/B)
D9
Code
J11
See Page
A
J16
54 (LHD W/G)
50 (LHD S/D)
D10
D17
48 (LHD)
48 (LHD)
51 (LHD S/D)
P9
53 (LHD L/B)
51 (LHD S/D)
P13
53 (LHD L/B)
55 (LHD W/G)
54 (LHD W/G)
51 (LHD S/D)
51 (LHD S/D)
50 (LHD S/D)
53 (LHD L/B)
P10
52 (LHD L/B)
55 (LHD W/G)
54 (LHD W/G)
51 (LHD S/D)
48 (LHD)
J9
48 (LHD)
J10
48 (LHD)
P11
53 (LHD L/B)
See Page
P14
P12
51 (LHD S/D)

416
AVENSIS (EWD526E)
http://vnx.su
53 (LHD L/B)
55 (LHD W/G)
51 (LHD S/D)
P15
55 (LHD W/G)
: Relay Blocks
29
55 (LHD W/G)
55 (LHD W/G)
P12
See Page
53 (LHD L/B)
52 (LHD L/B)
J8
Code
Code
53 (LHD L/B)
55 (LHD W/G)
U1
49 (LHD)

Code
CC
CD
See Page
34
30
DA
DB
DC

Code
IA1
IA2
See Page
86 (LHD)
86 (LHD)
88 (LHD)
88 (LHD)
IC1
IC2
IC3
IL1
IL2
IM1
IM2
90 (LHD S/D)
BA1
92 (LHD L/B)
94 (LHD W/G)
90 (LHD S/D)
BC1
92 (LHD L/B)
94 (LHD W/G)
: Ground Points
Code
See Page
IJ
86 (LHD)
Left Kick Panel
IL
86 (LHD)
IO
86 (LHD)
IP
86 (LHD)
Right Kick Panel
90 (LHD S/D)
BQ
92 (LHD L/B)
94 (LHD W/G)
90 (LHD S/D)
BU
92 (LHD L/B)
94 (LHD W/G)
: Splice Points
Code
See Page
90 (LHD S/D)
B1
92 (LHD L/B)
Code
B6
90 (LHD S/D)
Front Door LH Wire
94 (LHD W/G)
B7
90 (LHD S/D)
B2
90 (LHD S/D)
B3
Rear Door No.2 Wire
92 (LHD L/B)
Front Door RH Wire
92 (LHD L/B)
94 (LHD W/G)
90 (LHD S/D)
94 (LHD W/G)
B6
92 (LHD L/B)
90 (LHD S/D)
B8
92 (LHD L/B)
90 (LHD S/D)
94 (LHD W/G)
92 (LHD L/B)
94 (LHD W/G)
See Page
94 (LHD W/G)
B9
Front Door RH Wire
Rear Door No.1 Wire
92 (LHD L/B)
94 (LHD W/G)
417
AVENSIS (EWD526E)
http://vnx.su
Power Window (RHD)

10A
GAUGE1
7. 5A
ECUB 2
25A
DOOR
7. 5A
RAD NO. 1
20A
PFR P/W
2
Integration
Relay
22
21
DCTY
17
16 DB
9 DC
13 DB
ACC
KSW
P/W
PCTY
23
IG
19
25
8 DA
20
5 DA
(2)
(1)
(3)
WB
9 DA
WR
WR
J22
Junction Connector
10 CC
5 CE
3 CD
E A
B
(4)
J26(A), J27(B)
Junction
Connector
A B
D
1 CA
(3)
(3)
(2)
B
(4)
U1
Unlock
Warning SW
14 IC2
9 IM1
WB
R
1
D10
D9
13 CF
6 CA
WB
WB
WB
WB
IP
418
AVENSIS (EWD526E)
http://vnx.su
IJ
D17
Window
Lock SW
20A
DFR P/W
2
(5)
(5)
6
(6)
IL2
(6)
LR
11
FRA
14
FRU
2
WL
FRD
4
WR
LR
PW
3
23
IL1
LR
(5)
B
(4)
LR
(5)
(4)
(3)
WL
WB
LY
(6)
LY
LR
(6)
B
(3)
WR
WL
IL1
WB
WB
B7
WB
WB
P13
IL1
WB
1
2
3
4
5
6
: 1AZFE
: Except 1AZFE
: w/ Moon Roof
: w/o Moon Roof
: w/o Rear Power Window
WB
WB
WB
419
AVENSIS (EWD526E)
http://vnx.su
Power Window (RHD)
RLA
RLU
RLD
11
16
17
15
21
LR
18 BA1
GY
LB
P12
(5)
WL
AUTO
UP
DOWN
(5)
LY
(5)
GW
P9
9 IA1
10 BA1
(5)
WB
WB
(5)
WB
B2
WB
WB
(5)
WB
WB
L (5)
RY
GY
3
AUTO
LB
1
UP
GY
6
DOWN
LR
8
WL
R (5)
RY(5)
B3
B3
LB
GW
B10
B1
8 BA1
B3
B10
12 BA1
GW
LR
B10
3 BA1
4 IC1
LR
5 IA1
14 IC1
(5)
LY
10 IA2
13 IC1
LB
8 IA2
(5)
GY
9 IA2
GW
11 IA2
GW
(5)
LR
(6)
(5)
5 IC1
LR
(5)
10
CB
(5)
(5)
4
CE
RY
LR
(5)
(5)
LY
LR
(5)
(5)
IL2
8
CB
RY
LR
20
(5)
(5)
IL2
RY
(5)
19
9
CB
LR
(5)
LR
IL2
IL2
10
(5)
IL2
(5)
LB
GY
8
(5)
IL2
(5)
(5)
FLA
10
RY
FLU
GW
FLD
(5)
D17
BQ
420
AVENSIS (EWD526E)
http://vnx.su
P10
Rear LH
WB
(5)
D17
20A
DRR P/W
20A
PRR P/W
GY
(5)
LB
(5)
LB
8 BC1
1 BC1
(5)
12 BC1
(5)
3 BC1
R (5)
8 IM2
(5)
3 IM1
(5)
4 IM1
(5)
IL2
(5)
GY
(5)
(5)
(5)
LW
(5)
18 BC1
2 IM1
IL2
GY
LW
1 BA1
5 IM1
LR
(5)
LW
2 IC3
LW
(5)
(5)
LR
IL2
(5)
(5)
19
(5)
RRD
18
GY
RRU
22
LW
RRA
LW
LR
(5)
B9
RY(5)
L (5)
B9
AUTO
UP
DOWN
P14
(5)
LB
(5)
(5)
GR
(5)
LW
8
WL
(5)
(5)
GY
(5)
LW
(5)
LW
(5)
(5)
RY
(5)
B9
P15
(5)
WB
P11
Rear RH
WB
WB
(5)
(5)
WB
B8

(5)
10 BC1
WB
(5)
BU
421
AVENSIS (EWD526E)
http://vnx.su
Power Window (RHD)

System Outline
1. Manual Down or Up Operation
When the power window master SW is pushed one step, the motor rotates to open the window.
When the power window master SW is pulled up one step, the motor rotates in the opposite direction, to close the window.
All the other windows can be opened/closed as well, by the operation of the power window master SW or respective power
window SW.
When the window lock SW is pushed to the lock side, the ground circuit to the passengers window becomes open. As a
result, even if Open/Close operation of the passengers window is attempted, the current from TERMINAL E of the power
window master SW is not grounded and the motor does not rotate, so the passengers window can not be operated and
window lock occurs.
2. Auto Down or Up Operation
When the power window master SW or respective power window SW is pushed two steps, the motor rotates to open the
When the power window master SW or respective power window SW is pulled up two steps, the motor rotates to close the
3. Jam Protection Function
When any foreign object gets caught during power window AUTO UP operation, the motor rotates in the opposite direction to
open the window.
4. Key Off Power Window Operation
Within approximately 43 sec. after the ignition SW is turned from on to off, the power window can be operated. However, if
the driver or front passenger door is opened during this period of time, the power window operation is stopped even through
43 sec. have not elapsed.
Service Hints
D17 Power Window Master SW
Integration Relay
: Parts Location
Code
See Page
Code
70 (RHD S/D)
72 (RHD L/B)
D9
J22
73 (RHD L/B)
75 (RHD W/G)
70 (RHD S/D)
71 (RHD S/D)
P10
73 (RHD L/B)
73 (RHD L/B)
75 (RHD W/G)
71 (RHD S/D)
P14
73 (RHD L/B)
75 (RHD W/G)
71 (RHD S/D)
71 (RHD S/D)
P11
73 (RHD L/B)
74 (RHD W/G)
75 (RHD W/G)
68 (RHD)
71 (RHD S/D)
68 (RHD)
J27
68 (RHD)
P12
73 (RHD L/B)
75 (RHD W/G)
: Relay Blocks
See Page
29
P13
70 (RHD S/D)
See Page
71 (RHD S/D)
75 (RHD W/G)
J26
Code
Code
74 (RHD W/G)
72 (RHD L/B)
D17
P9
74 (RHD W/G)
72 (RHD L/B)
D10
See Page
71 (RHD S/D)

422
AVENSIS (EWD526E)
http://vnx.su
P15
73 (RHD L/B)
75 (RHD W/G)
U1
69 (RHD)

Code
See Page
CA
CB
CC
CD
34
30
CE
CF
DA
DB
DC

Code
IA1
IA2
See Page
106 (RHD)
106 (RHD)
108 (RHD)
108 (RHD)
IC1
IC2
IC3
IL1
IL2
IM1
IM2
110 (RHD S/D)

BA1
112 (RHD L/B)
114 (RHD W/G)

110 (RHD S/D)
BC1
112 (RHD L/B)
114 (RHD W/G)
: Ground Points
Code
See Page
IJ
106 (RHD)
Left Kick Panel
IP
106 (RHD)
Right Kick Panel
110 (RHD S/D)

BQ
112 (RHD L/B)
114 (RHD W/G)

110 (RHD S/D)
BU
112 (RHD L/B)
114 (RHD W/G)
: Splice Points
Code
See Page
110 (RHD S/D)

B1
112 (RHD L/B)
B8
110 (RHD S/D)

Rear Door No.2 Wire
B9
Rear Door No.1 Wire
112 (RHD L/B)

114 (RHD W/G)
112 (RHD L/B)
110 (RHD S/D)
114 (RHD W/G)

112 (RHD L/B)
Front Door RH Wire
112 (RHD L/B)

114 (RHD W/G)
110 (RHD S/D)
110 (RHD S/D)
112 (RHD L/B)

110 (RHD S/D)
B7
114 (RHD W/G)
110 (RHD S/D)

114 (RHD W/G)
B3
See Page
B7
Front Door LH Wire
114 (RHD W/G)

B2
Code
B10
Front Door RH Wire
112 (RHD L/B)
Front Door LH Wire
114 (RHD W/G)
423
AVENSIS (EWD526E)
http://vnx.su
Front Wiper and Washer (w/ Auto Wiper System)

1
2
3
4
: w/ Headlight Cleaner w/ HID

: Except 1
: LHD 1CDFTV, RHD
: LHD Gasoline
LR
F11
Front Washer Motor
LR
2
M
1
C B
LR
LR
(RHD)
(RHD)
A A
LR
J24(A), J25(B)
Junction
Connector
A A
(LHD)
LR
LR
26 DA
(RHD)
18 DL
J1
Junction
Connector
17 DL
LR
25A WIP
(LHD)
RW
(RHD)
LR
LR
(RHD)
(RHD)
WL
C A
C A
J24(A), J25(B)
Junction
Connector
(2)
WL
J2
Junction
Connector
RW
(RHD)
A B
(1)
RW
(RHD)
B
WL
RW
RW
RW
(RHD)
(RHD)
(RHD)
(1)
WL
1 IE3 (LHD)
1 IO1 (RHD)
LR
WL
424
AVENSIS (EWD526E)
http://vnx.su
C13
Combination SW
OFF
Front
Wiper
SW
Front Wiper SW
MIST
AUTO
Off
On
LO
+2
+S
AUTO
VR1
VR2
WF
EW
17
16
13
15
12
14
11
GRR
LGB
WL
16
11
20
24
RW
WB
(LHD)
RW
(LHD)
J14
Junction
Connector
LR
(LHD)
BR
LR
RW
LR
LR
(RHD)
(RHD)
+B
(LHD)
+1
LY
HI
B
RW
(RHD)
J14
Junction
Connector
LR
LR
(LHD)
(RHD)
(LHD)
RW
RW
+B
+2
WF
3 (LHD)
1 (RHD)
SG
WB
22
12 ID1
13 ID1
3 ID1
RSSIGNAL
VCC RS
23
WL
SP
19
PB
+2
10 IE3 (LHD)
10 IO1 (RHD)
RSI
2
LG
RW
+1
12
BR
4
3
WF
17
(RHD)
1
5
VR2
PB
+S
3 IE3
3 IO1
VR1
F2
W2
Wiper Relay
RW
8 IE3
8 IO1
F1
+1
LG
RW
BR
(LHD)
(LHD)
(RHD)
2
GND
F13
Front Wiper Motor
5 (LHD)
4 (RHD)
WB
J2
Junction
Connector
ED
J15
Junction
Connector
WL
WB
LR
WB
EC
WB
2
2
WB
R12
Rain Sensor
IK
IL : 3
IO : 4
425
AVENSIS (EWD526E)
http://vnx.su
Front Wiper and Washer (w/ Auto Wiper System)

System Outline
By turning the ignition SW to on, the wiper is controlled according to the position of the front wiper and washer SW.
Auto Wiper Operation
When the front wiper and washer SW is set to AUTO, the wiper relay is deactivated, operates at low speed, or operates at
high speed based on the input signal from the rain sensor.
When the wiper signal is off and the washer SW is set to on, the wiper relay operates at low speed, irrespective of the signal
output from the rain sensor.
Service Hints
C13 Combination SW
7Ground : Approx. 12 volts with the ignition SW on and the wiper and washer SW at LO position
16Ground : Approx. 12 volts with the ignition SW on and unless the front wiper motor at STOP position
8Ground : Approx. 12 volts with the ignition SW on and the front wiper and washer SW at HI position
F13 Front Wiper Motor
BS : Closed unless the front wiper motor at STOP position
: Parts Location
Code
See Page
46 (LHD)
C13
F11
F13
See Page
Code
64 (*10)
See Page
J14
48 (LHD)
66 (RHD)
39 (*3)
38 (*3)
41 (*4)
40 (*4)
43 (*5)
J24
68 (RHD)
42 (*5)
45 (*6)
J25
68 (RHD)
J1
48 (LHD)
J15
68 (RHD)
44 (*6)
59 (*7)
51 (LHD S/D)
58 (*7)
63 (*9)
53 (LHD L/B)
62 (*9)
65 (*10)
64 (*10)
39 (*3)
38 (*3)
41 (*4)
73 (RHD L/B)
40 (*4)
43 (*5)
75 (RHD W/G)
42 (*5)
F13
Code
J2
45 (*6)
44 (*6)
59 (*7)
58 (*7)
63 (*9)
62 (*9)
65 (*10)
55 (LHD W/G)
R12
71 (RHD S/D)
49 (LHD)
W2
69 (RHD)

Code
See Page
DA
30
DL
31

Code
ID1
See Page
86 (LHD)
106 (RHD)

IE3
86 (LHD)
IO1
108 (RHD)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
426
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
: Ground Points
Code
See Page
78 (*3)
80 (*4)
82 (*5)
EC
84 (*6)
98 (*7)
102 (*9)
104 (*10)
78 (*3)
80 (*4)
82 (*5)
ED
84 (*6)
98 (*7)
102 (*9)
104 (*10)
IK
IL
IO
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
427
AVENSIS (EWD526E)
http://vnx.su
Front Wiper and Washer (w/o Auto Wiper System)

C13
Combination SW
OFF
INT
LO
Front Wiper SW
MIST
Off
16
BR
RW
LY(LHD)
8 IE3
8 IO1
3 IE3
3 IO1
11
WL
WB
G(RHD)
17
LR
(1)
Wiper Relay
On
Front
Washer
SW
HI
WL
10 IE3 (LHD)
10 IO1 (RHD)
LR
BR
RW
5
4
1
5
4
3
3
1
2 (LHD)
2 (RHD)
+1
+2
LR
WB
J2
Junction
Connector
LR
WB
F13
Front Wiper Motor
ED
WB
WB
EC
IL : 4
IO : 5
428
AVENSIS (EWD526E)
http://vnx.su
18 DL
J1
Junction
Connector
26 DA
LR
LR
17 DL
LR
25A
WIP
LR
F11
Front
Washer Motor
2
M
1
WL
(3)
WL
J2
Junction
Connector
(2)
B
WL
(2)
1 IE3 (LHD)
1 IO1 (RHD)
WL
LR
LR
1
2
3
4
5
: Intermittent Volume SW
: Except 2
: LHD 1CDFTV, RHD
: LHD Except 1CDFTV
429
AVENSIS (EWD526E)
http://vnx.su
Front Wiper and Washer (w/o Auto Wiper System)

System Outline
With the ignition SW turned on, the current flows to TERMINAL 17 of the front wiper and washer SW, TERMINAL B of the
front wiper motor and TERMINAL 2 of the front washer motor through the WIP fuse.
1. Low Speed Position
With the wiper SW turned to LO position, the current flows from TERMINAL 17 of the front wiper and washer SW to
TERMINAL 7 to TERMINAL +1 of the front wiper motor to TERMINAL E to GROUND and causes to the wiper motor to run at
low speed.
2. High Speed Position
With the wiper SW turned to HI position, the current flows from TERMINAL 17 of the front wiper and washer SW to
TERMINAL 8 to TERMINAL +2 of the front wiper motor to TERMINAL E to GROUND and causes to the wiper motor to run at
high speed.
3. INT Position
With the wiper SW turned to INT position, the relay operates and the current which is connected by relay function flows from
TERMINAL 17 of the front wiper and washer SW to TERMINAL 2 to GROUND. This flow of current operates the intermittent
circuit and the current flows from TERMINAL 17 of the front wiper and washer SW to TERMINAL 7 to TERMINAL +1 of the
front wiper motor to TERMINAL E to GROUND and the functions.
The intermittent operation is controlled by the charge/discharge function of the condenser installed in the relay, and the
intermittent time is controlled by a time control SW to change the charging time of the condenser.
4. Mist Position
With the wiper SW turned to MIST position, the current flows from TERMINAL 17 of the front wiper and washer SW to
TERMINAL 7 to TERMINAL +1 of the front wiper motor to TERMINAL E to GROUND and causes to the front wiper motor to
run at low speed.
5. Washer Continuous Operation
With the washer SW pulled to on, the current flows from the WIP fuse to TERMINAL 2 of the front washer motor to
TERMINAL 1 to TERMINAL 11 of the front wiper and washer SW to TERMINAL 2 to GROUND and causes to the washer
motor to run, and the window washer jet operates. This causes the current to flow to washer continuous operation circuit in
TERMINAL 17 of the front wiper and washer SW to TERMINAL 7 to TERMINAL +1 of the front wiper motor to TERMINAL E
to GROUND and the washer operates continuously.
Service Hints
C13 Combination SW
7Ground : Approx. 12 volts with front wiper and washer SW at LO position
: Approx. 12 volts with front wiper and washer SW at MIST position
16Ground : Approx. 12 volts with ignition SW on unless front wiper motor at STOP position
8Ground : Approx. 12 volts with ignition SW on and front wiper and washer SW at HI position
F13 Front Wiper Motor
BS : Closed unless front wiper motor at STOP position
: Parts Location
Code
C13
See Page
66 (RHD)
44 (*6)
Code
J1
See Page
63 (*9)
65 (*10)
60 (*8)
41 (*4)
42 (*5)
62 (*9)
43 (*5)
44 (*6)
64 (*10)
60 (*8)
41 (*4)
62 (*9)
43 (*5)
63 (*9)
45 (*6)
65 (*10)
64 (*10)
F13
See Page
42 (*5)
40 (*4)
F11
Code
46 (LHD)
40 (*4)
F13
J1
J2
45 (*6)
61 (*8)
61 (*8)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
430
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV

Code
See Page
DA
30
DL
31

Code
See Page
IE3
86 (LHD)
IO1
108 (RHD)
: Ground Points
Code
See Page
80 (*4)
82 (*5)
EC
84 (*6)
100 (*8)
102 (*9)
104 (*10)
80 (*4)
82 (*5)
ED
84 (*6)
100 (*8)
102 (*9)
104 (*10)
IL
IO
86 (LHD)
106 (RHD)
86 (LHD)

* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
431
AVENSIS (EWD526E)
http://vnx.su
Rear Wiper and Washer

1 : w/ Auto Wiper System

2 : LHD 1CDFTV, RHD
3 : LHD Except 1CDFTV
20A
RR WIP
R3
Rear Washer Motor
R
2
1
M
LR
7 DD
4 IE3 (LHD)
4 IO1 (RHD)
LR
9 IE3
9 IO1
3
Washer
Rear Wiper and

Washer SW
A A (LHD)
A B (RHD)
11 IC1
2 IC1
+B
LS
5 BE2
(W/G)
(L/B)
5 BD2 (L/B)
4 BF2 (W/G)
2 BG1
(L/B)
(W/G)
L
LB
1 BG1
(W/G)
(L/B)
4 BE2
LB
LR
4 BD2 (L/B)
3 BF2 (W/G)
(L/B)
(W/G)
6 BG1
LB
LR
LB
WB
2 IC2
(W/G)
(L/B)
L
LR
LR
10
3 BD1 (L/B)
5 BF1 (W/G)
(L/B)
ON
Washer
+ON (1)
A A (LHD)
A B (RHD)
3 BE1
INT
A A
A B
C13
Combination SW
OFF
(W/G)
J 5(A), J28(B)
Junction Connector
LR
2
C1
+B
+1
WB
R20
Wiper Relay
IL : 2
IO : 3
432
AVENSIS (EWD526E)
http://vnx.su
System Outline
When the ignition SW is turned on, the current flows to TERMINAL 2 of the rear washer motor and TERMINAL 1 of the rear
wiper motor and relay through the RR WIP fuse.
1. Rear Wiper Normal Operation
With the ignition SW turned on and rear wiper and washer SW turned on, current to TERMINAL 1 of the rear wiper motor and
relay flows to TERMINAL 3 of the rear wiper motor and relay to TERMINAL 10 of the rear wiper and washer SW to
TERMINAL 2 to GROUND. Thus, the relay coil is activated and current to the rear wiper motor to motor to GROUND,
causing the motor to operate the wiper.
2. Rear Wiper Intermittent Operation
When the ignition SW is turned on and the rear wiper and washer SW is turned to INT position, current to TERMINAL 1 of
the rear wiper motor and relay flows to TERMINAL 2 of the rear wiper motor and relay to TERMINAL 4 of the rear wiper and
washer SW to TERMINAL 2 to GROUND.
This causes the motor to operate (The point changes) and the intermittent circuit of the relay operates. Intermittent operation
of the circuit is controlled by the charging and discharging of the condenser installed inside the relay.
3. Washer Operation
With the ignition SW turned on and the rear wiper and washer SW turned to ON position, when the wiper SW is turned
further, current to TERMINAL 2 of the rear washer motor flows to TERMINAL 1 to TERMINAL 3 of the rear wiper and washer
SW to TERMINAL 2 to GROUND so that the rear washer motor rotates and the window washer emits a water, only while the
SW is fully turned.
When the wiper SW is off and then turned washer on (Wiper off side), the wiper SW is on and then turned to washer on
(Wiper on side), only the washer operates.
Service Hints
R20 Rear Wiper Motor and Relay
2Ground : Continuity with the rear wiper and washer SW at INT position
3Ground : Continuity with the rear wiper and washer SW at ON position
: Parts Location
Code
See Page
C13
Code
See Page
46 (LHD)
41 (*4)
66 (RHD)
43 (*5)
J5
48 (LHD)
J28
68 (RHD)
59 (*7)
39 (*3)
63 (*9)
R3
R3
45 (*6)
Code
R3
See Page
65 (*10)
53 (LHD L/B)
R20
55 (LHD W/G)
73 (RHD L/B)
75 (RHD W/G)

Code
DD
See Page
30

* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
433
AVENSIS (EWD526E)
http://vnx.su
Rear Wiper and Washer

Code
IC1
IC2
See Page
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
IE3
86 (LHD)
IO1
108 (RHD)
BD1
BD2
BE1
BE2
BF1
BF2
BG1
92 (LHD L/B)
112 (RHD L/B)
92 (LHD L/B)
112 (RHD L/B)

92 (LHD L/B)
112 (RHD L/B)
92 (LHD L/B)
112 (RHD L/B)

94 (LHD W/G)
114 (RHD W/G)
94 (LHD W/G)
114 (RHD W/G)

94 (LHD W/G)
114 (RHD W/G)
: Ground Points
Code
IL
IO
See Page
86 (LHD)
106 (RHD)
86 (LHD)

434
AVENSIS (EWD526E)
http://vnx.su
Memo
435
AVENSIS (EWD526E)
http://vnx.su
Moon Roof
25A
DOOR
7. 5A
RAD NO. 1
10A
GAUGE1
7 DB
RW
21
9 DC
(2)
(1)
P/W
20
25
8 DA
(RHD)
(LHD)
KSW
19
5 CE
9 DA
6 DK
WB
13 DB
(RHD)
IG
5 DA
J 8(A), J26(C)
Junction
Connector
B A
PCTY
22
ACC
A A (LHD)
E C (RHD)
J22
Junction
Connector
B A
DCTY
17
J10(A)
Junction
Connector
(LHD)
WB
Integration Relay
A A (LHD)
E C (RHD)
Y
R
(RHD)
(LHD)
14 IC2
(2)
1 CA
U1
Unlock Warning
SW
9 IM1
(RHD)
WB
WB
13 CF
(LHD)
(RHD)
R
1
D10
Door Courtesy SW
Front RH
D9
Door Courtesy SW
Front LH
6 CA
A
6 CK
B
J16
Junction
Connector
WB
WB
WB
WB
WB
(LHD)
WB
IL : 3
IO : 4
IP
436
AVENSIS (EWD526E)
http://vnx.su
IJ
20A
S/ROOF
7. 5A
DOME
2
1 DG
LW
WR
RW
RW
F A (LHD)
F C (RHD)
J10(A), J11(B),
J26(C)
Junction
Connector
F C
WR
(RHD)
7 CA
1 ID1
LW
H B
LW
WR
RW
6 BB1
M6
Moon Roof Control Relay and Motor
10
21
(LHD)
6 CD
C11
Combination
Meter
20
Speedometer
+B
CPU
OPN
CLS
6 ID1
M7
Moon Roof
Control SW
VW
B5
VW
LW
SP1
Close
WB
35 A (w/ VSC)
23 B (w/o VSC)
S 1(A), S 2(B)
Skid Control ECU
with Actuator
2 ID1
Open
F B (LHD)
F D (RHD)
LW
4 BB1
16 IE1
VW
3 BB1
VW
1 BB1
WB
2 BB1
5 BB1
19
H A (LHD)
H C (RHD)
J10(A), J11(B),
J20(C), J21(D)
Junction Connector
VW
SPD
SC
SO
WB
GND
PWS
WB
18
CPU
1
2
3
4
: LHD, RHD 1AZFE

: RHD Except 1AZFE
: 1CDFTV
: Gasoline
WB
WB
437
AVENSIS (EWD526E)
http://vnx.su
Moon Roof
System Outline
Key Off Moon Roof Operation
Within approximately 43 sec. after the ignition SW is turned from on to off, the moon roof can be operated. However, if the
driver or front passenger door is opened during this period of time, the moon roof operation is stopped even through 43 sec.
have not elapsed.
Service Hints
M6 Moon Roof Control Relay and Motor
: Parts Location
Code
See Page
C11
Code
46 (LHD)
J10
48 (LHD)
66 (RHD)
J11
48 (LHD)
50 (LHD S/D)
D9
See Page
55 (LHD W/G)
71 (RHD S/D)
M7
48 (LHD)
73 (RHD L/B)
J20
68 (RHD)
75 (RHD W/G)
54 (LHD W/G)
J21
68 (RHD)
39 (*3)
J22
J26
68 (RHD)
C
68 (RHD)
S1
45 (*6)
59 (*7)
74 (RHD W/G)
51 (LHD S/D)
65 (*10)
50 (LHD S/D)
53 (LHD L/B)
41 (*4)
52 (LHD L/B)
54 (LHD W/G)
Code
52 (LHD L/B)
72 (RHD L/B)
J8
J16
70 (RHD S/D)
D10
See Page
M6
55 (LHD W/G)
71 (RHD S/D)
43 (*5)
S2
45 (*6)
70 (RHD S/D)
73 (RHD L/B)
63 (*9)
72 (RHD L/B)
75 (RHD W/G)
65 (*10)
74 (RHD W/G)
51 (LHD S/D)
48 (LHD)
M7
53 (LHD L/B)
U1
49 (LHD)
69 (RHD)
: Relay Blocks
Code
6
See Page
29


Code
See Page
CA
CD
CE
34
CF
CK
35
DA
DB
DC
30
31
DG
DK
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
438
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV

Code
IC2
ID1
IE1
IM1
See Page
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)

86 (LHD)
106 (RHD)
88 (LHD)
108 (RHD)
90 (LHD S/D)
92 (LHD L/B)
BB1
94 (LHD W/G)
110 (RHD S/D)
112 (RHD L/B)

114 (RHD W/G)
: Ground Points
Code
IJ
See Page
86 (LHD)
106 (RHD)

Left Kick Panel
IL
86 (LHD)
IO
86 (LHD)
IP
86 (LHD)
106 (RHD)
Right Kick Panel
: Splice Points
Code
See Page
Code
90 (LHD S/D)
B5
92 (LHD L/B)
94 (LHD W/G)
See Page
110 (RHD S/D)

Roof Wire
B5
112 (RHD L/B)
Roof Wire
114 (RHD W/G)
439
AVENSIS (EWD526E)
http://vnx.su
Shift Lock
RW
RW
RW
(LHD)
2 IR1
(RHD)
11 IE3
RW
22 DA
(LHD)
7 DB
(RHD)
15A
STOP
RW
10A
GAUGE1
2
7 CA
S13
Stop Light SW
4 CF
GW
2 DA
GW
1 DB
IG
STP
SLS+
SLS
WB
Shift Lock
Solenoid
S9
A
J17
Junction
Connector
WB
(RHD)
WB
(LHD)
IP
(RHD)
1 IR1
GW
GW
(LHD)
RW
6 IE3
J15
Junction Connector
IK
440
AVENSIS (EWD526E)
http://vnx.su
(RHD)
GW
(LHD)
System Outline
Shift Lock Mechanism
If the brake pedal is depressed with the ignition SW set at ON (The stop light SW is on), the shift lock control ECU is
activated, allowing the driver to change the shift lever to a position other than the P position.
Service Hints
S9 Shift Lock Control ECU
: Parts Location
Code
See Page
J15
68 (RHD)
S9
48 (LHD)
J17
Code
68 (RHD)
S13
See Page
49 (LHD)
Code
S13
See Page
69 (RHD)
69 (RHD)
49 (LHD)

Code
CA
CF
DA
DB
See Page
34
30

Code
See Page
IE3
86 (LHD)
IR1
108 (RHD)
: Ground Points
Code
See Page
IK
106 (RHD)
IP
86 (LHD)
Right Kick Panel
441
AVENSIS (EWD526E)
http://vnx.su
Horn
15A
HORN
2
5
HORN
Relay
GW
GW
(RHD)
B A
D B
(LHD)
J26(A), J27(B)
Junction
Connector
(RHD)
13 IE1 (LHD)
20 IE1 (RHD)
Horn SW
C14
Combination SW
GW
1
H11
Horn LH
442
AVENSIS (EWD526E)
http://vnx.su
H12
Horn RH
Service Hints
HORN Relay
53 : Closed with the horn SW at on
: Parts Location
Code
See Page
Code
46 (LHD)
C14
66 (RHD)
H11
64 (*10)
40 (*4)
38 (*3)
44 (*6)
58 (*7)
Code
See Page
H12
58 (*7)
62 (*9)
38 (*3)
42 (*5)
H11
See Page
60 (*8)
60 (*8)
H12
62 (*9)
64 (*10)
40 (*4)
J26
68 (RHD)
42 (*5)
J27
68 (RHD)
44 (*6)
: Relay Blocks
Code
1
2
See Page
24 (*1)
25 (*2)
26


Code
IE1
See Page
86 (LHD)
106 (RHD)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
443
AVENSIS (EWD526E)
http://vnx.su
Fuel Lid Opener

10A
FUEL OPN
LB
LB
13 IA2 (LHD)
13 IL2 (RHD)
F24
Fuel Lid
Opener SW
LR
LR
12 IA2 (LHD)
12 IL2 (RHD)
2
LR
F23
Fuel Lid Opener
Motor
WB
18 IC2
LR
J32
Junction
Connector
WB
B A
WB
C B
BS
444
AVENSIS (EWD526E)
http://vnx.su
J30(A), J31(B)
Junction
Connector
Service Hints
F24 Fuel Lid Opener SW
32 : Closed with fuel lid opener SW on
: Parts Location
Code
See Page
Code
50 (LHD S/D)
F24
52 (LHD L/B)
F23
Code
See Page
74 (RHD W/G)
55 (LHD W/G)
J31
71 (RHD S/D)
54 (LHD W/G)
51 (LHD S/D)
70 (RHD S/D)
53 (LHD L/B)
75 (RHD W/G)
55 (LHD W/G)
51 (LHD S/D)
71 (RHD S/D)
53 (LHD L/B)
72 (RHD L/B)
74 (RHD W/G)
F24
See Page
72 (RHD L/B)
J30
73 (RHD L/B)
50 (LHD S/D)
73 (RHD L/B)
52 (LHD L/B)
75 (RHD W/G)
54 (LHD W/G)
51 (LHD S/D)
73 (RHD L/B)
53 (LHD L/B)
75 (RHD W/G)
70 (RHD S/D)
J31
J32
55 (LHD W/G)
71 (RHD S/D)
: Relay Blocks
Code
6
See Page
29


Code
IA2
IC2
IL2
See Page
86 (LHD)
86 (LHD)
106 (RHD)
108 (RHD)

: Ground Points
Code
See Page
90 (LHD S/D)
92 (LHD L/B)
BS
94 (LHD W/G)
110 (RHD S/D)
112 (RHD L/B)

114 (RHD W/G)
445
AVENSIS (EWD526E)
http://vnx.su
Fuel Heater
25A
FHTR
7. 5A
ECUIG
2
1
RL
10 DL
5
FHTR
Relay
3
WB
LR
LR
1 EE1
F15
Fuel Heater
EC
WB
WB
EI
446
AVENSIS (EWD526E)
http://vnx.su
Service Hints
FHTR Relay
53 : Closed with the ignition SW at ON position
: Parts Location
Code
See Page
F15
44 (*6)
Code
F15
See Page
Code
See Page
64 (*10)
: Relay Blocks
Code
See Page
25 (*2)
26

Code
DL
See Page
31


Code
EE1
See Page
84 (*6)
104 (*10)

: Ground Points
Code
EC
EI
See Page
84 (*6)
104 (*10)
84 (*6)
104 (*10)

Near the Starter
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
447
AVENSIS (EWD526E)
http://vnx.su
Automatic GlareResistant EC Mirror

10A
GAUGE1
RW
11 DK
I15
Inner Mirror
WB
6 DK
WB
9 DA
IJ
448
AVENSIS (EWD526E)
http://vnx.su
Service Hints
I15 Inner Mirror
: Parts Location
Code
See Page
50 (LHD S/D)
I15
Code
I15
52 (LHD L/B)
See Page
54 (LHD W/G)
70 (RHD S/D)
Code
I15
See Page
72 (RHD L/B)
74 (RHD W/G)

Code
See Page
DA
30
DK
31
: Ground Points
Code
IJ
See Page
86 (LHD)
106 (RHD)

Left Kick Panel
449
AVENSIS (EWD526E)
http://vnx.su
Cigarette Lighter
15A
CIG
11 DB
C7
Cigarette
Lighter
WB
(RHD)
WB
(LHD)
J17
Junction
Connector
WB
IP
450
AVENSIS (EWD526E)
http://vnx.su
IL
(RHD)
WB
(LHD)
J16
Junction
Connector
Service Hints
C7 Cigarette Lighter
1Ground : Approx. 12 volts with the ignition SW at ACC or ON position
: Parts Location
Code
See Page
C7
Code
See Page
46 (LHD)
J16
68 (RHD)
66 (RHD)
J17
48 (LHD)
Code
See Page

Code
DB
See Page
30

: Ground Points
Code
See Page
IL
106 (RHD)
IP
86 (LHD)
Right Kick Panel
451
AVENSIS (EWD526E)
http://vnx.su
Power Outlet
15A
P/POINT
7. 5A
RAD NO. 1
4 DB
GR
WL
19 DA
GR
WL
F A (LHD)
F C (RHD)
J 8(A), J 9(B),
J20(C), J21(D)
Junction
Connector
H B (LHD)
H D (RHD)
1
P/POINT
Relay
2
5
WR
II1
WB
WR
P6
Power
Outlet
21 DA
WB
9 DA
II1
WB
J17
Junction
Connector
IP
WB
WB
(RHD)
WB
(LHD)
J15
Junction
Connector
IK
IJ
452
AVENSIS (EWD526E)
http://vnx.su
Service Hints
P6 Power Outlet
: Parts Location
Code
See Page
J8
48 (LHD)
J9
48 (LHD)
J15
Code
See Page
48 (LHD)
J17
68 (RHD)
J20
68 (RHD)
C
68 (RHD)
Code
J21
See Page
D
P6
68 (RHD)
49 (LHD)
69 (RHD)
: Relay Blocks
Code
5
See Page
28 (LHD)
28 (RHD)

Code
DA
DB
See Page
30


Code
II1
See Page
88 (LHD)
108 (RHD)

: Ground Points
Code
IJ
See Page
86 (LHD)
106 (RHD)

Left Kick Panel
IK
106 (RHD)
IP
86 (LHD)
Right Kick Panel
453
AVENSIS (EWD526E)
http://vnx.su
Front Window Deicer

10A
GAUGE1
20A
FR DIC
2
6
RW
7 DB
7 CA
RW
4 CH
RW
5 CF
RW
FR DEICER
Relay
2
3
5
6
12 IE3
IG
F20
Free
WB
Full
Travel
4 CJ
WB
E 3
WB
F12
Front Window Deicer
J2
Junction
Connector
6 CA
IP
454
AVENSIS (EWD526E)
http://vnx.su
WB
WB
ED
Service Hints
F20 Front Wiper Deicer SW
2, 6Ground : Approx. 12 volts with the ignition SW at ON position
: Parts Location
Code
See Page
F12
Code
See Page
38 (*3)
F12
44 (*6)
40 (*4)
F20
47 (LHD)
42 (*5)
J2
Code
See Page
41 (*4)
43 (*5)
J2
39 (*3)
45 (*6)
: Relay Blocks
Code
See Page
28 (LHD)
29

Code
CA
CF
CH
CJ
DB
See Page
34
35
30

Code
IE3
See Page
86 (LHD)

: Ground Points
Code
See Page
78 (*3)
ED
80 (*4)
82 (*5)
84 (*6)
IP
86 (LHD)
Right Kick Panel
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
455
AVENSIS (EWD526E)
http://vnx.su
WB
WB
29 B (9)
29 A (6)
21 A (2)
IK
MPX1
18 B (9)
23 A (6)
20 A (2)
BW
456
AVENSIS (EWD526E)
http://vnx.su
Rear Window
Defogger
(L/B)
4 BD1
4 BE1
(W/G)
(W/G)
(L/B)
B4
(W/G)
B
(L/B)
4 A (7)
4 C (8)
(L/B)
Noise Filter
10 IC1
(L/B)
B
(S/D)
B
(1)
R18(A), R19(B)
(S/D)
(L/B)
(1)
GW
7. 5A
DEF I/UP
R18(A), R19(B)
MPX2
WB
GND
40 A (7)
13 B (8)
(LHD)
A13(A), A15(B), A16(C)

(1)
(W/G)
WB
I14
Integration Relay
MPX+
(L/B)
13
RDEFIN
WB
BEAN
(EFI)
(S/D)
BEAN
(BODY)
14
(RHD)
1 IC1
9 A
10 B
MPX
(S/D)
BEAN
(SECURITY)
MPX2
PB
22
29 A
20 B
(RHD)
J17
Junction
Connector
15
PB
T6
Theft Deterrent ECU
MPX
MPX1
E 9(A), E10(B)
Engine ECU (M/T)
PB
(5)
PL
31
11
C10
Combination Meter
1
7 IC3
6
B
6 BF1
5 BG1
1 A
1 A
1 B
(L/B)
1 B
J15
Junction
Connector
(LHD)
WB
BX
1
2
3
4
5
6
7
8
9
: Gasoline
: 1CDFTV
: LHD w/o FR DEICER Relay, RHD
: LHD w/ FR DEICER Relay
: Automatic A/C
: 1AZFSE
10A
GAUGE1
30A
RR DEF
RW
18 IC1
7 CA
B4
RW
I2
B
7 DB
5 DC
7 IB1
7 CD
RW
4 (LHD)
5 (RHD)
(3)
(4)
GW
IG
F19
Rear Window
Defogger SW
J6
Junction
Connector
9 IC1
GW
N6
Noise Filter (Rear Window Defogger No. 1)
N7
B
1
(L/B, W/G)
GW
RW
R9
Rear Window
Defogger Relay
DEF
3
6
(4)
GW
E
8 (LHD)
1 (RHD)
WB
(RHD)
WB
WB
GW(4)
(LHD)
GW(3)
9 CH
1 DP
J16
Junction
Connector
4 DF
A
WB
(RHD)
WB
WB
(LHD)
WB
WB
6 CA
(LHD)
3 CG
(LHD)
IP
IJ
IL
457
AVENSIS (EWD526E)
http://vnx.su

Service Hints
R9 Rear Window Defogger Relay
53 : Closed with the ignition SW at ON position and rear window defogger SW at ON position
: Parts Location
Code
A13
See Page
46 (LHD)
A15
66 (RHD)
A16
E9
E10
51 (LHD S/D)
53 (LHD L/B)
66 (RHD)
J15
68 (RHD)
47 (LHD)
J16
J17
N6
48 (LHD)
75 (RHD W/G)
51 (LHD S/D)
69 (RHD)
53 (LHD L/B)
R19
73 (RHD L/B)
49 (LHD)
55 (LHD W/G)
71 (RHD S/D)
73 (RHD L/B)
75 (RHD W/G)
R9
71 (RHD S/D)
49 (LHD)
55 (LHD W/G)
67 (RHD)
55 (LHD W/G)
73 (RHD L/B)
47 (LHD)
47 (LHD)
68 (RHD)
53 (LHD L/B)
N7
R18
68 (RHD)
67 (RHD)
67 (RHD)
F19
69 (RHD)
48 (LHD)
66 (RHD)
See Page
R9
67 (RHD)
46 (LHD)
Code
J6
66 (RHD)
C10
I14
See Page
47 (LHD)
46 (LHD)
46 (LHD)
Code
75 (RHD W/G)
T6
69 (RHD)
: Relay Blocks
Code
1
6
See Page
24 (*1)
25 (*2)
29


Code
CA
CD
CG
CH
See Page
34
35
DB
DC
30
31
DF
DP
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
458
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV

Code
IB1
IC1
IC3
BD1
BE1
BF1
BG1
See Page
86 (LHD)
106 (RHD)

86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
92 (LHD L/B)
112 (RHD L/B)
92 (LHD L/B)
112 (RHD L/B)
94 (LHD W/G)
114 (RHD W/G)
94 (LHD W/G)
114 (RHD W/G)
: Ground Points
Code
IJ
See Page
86 (LHD)
106 (RHD)
IK
106 (RHD)
IL
86 (LHD)
IP
106 (RHD)
BW
90 (LHD S/D)
110 (RHD S/D)

Left Kick Panel
Right Kick Panel
Right Quarter Panel
92 (LHD L/B)
BX
94 (LHD W/G)
112 (RHD L/B)
114 (RHD W/G)
: Splice Points
Code
I2
B4
See Page
88 (LHD)
108 (RHD)
90 (LHD S/D)
92 (LHD L/B)
Code

B4
Floor Wire
See Page
94 (LHD W/G)
110 (RHD S/D)
112 (RHD L/B)
Floor Wire
114 (RHD W/G)
459
AVENSIS (EWD526E)
http://vnx.su
Mirror Heater
10A
GAUGE1
1 : LHD w/ FR DEICER Relay

w/o Front Window Deicer
2 : w/ Front Window Deicer
3 : RHD w/ FR DEICER Relay
20A
FR DIC
2
6
10A
MIR HTR
RW
7 DB
2
7 CA
BY
RW
RW
4 CH
E A (LHD)
B B (RHD)
J18(A), J29(B)
Junction Connector
5
E A (LHD)
B B (RHD)
FR DEICER
Relay
3
5
BY
BY
E A (LHD)
B B (RHD)
L
(1)
BY
5 B
DEF
6
D
9 IA1
WB
WB
GW
(1)
(1)
3 (LHD)
6 (RHD)
F20
6 B
M5
Mirror Heater
RH
F19
Rear Window
Defogger SW
5 A
S10(A), S11(B)
Short Connector
M4
Mirror Heater
LH
(1)
GW
6 A
IL1
BY
L
(3)
GW
J6
Junction
Connector
12
(2)
12 IA1
IL1
GW
IJ
460
AVENSIS (EWD526E)
http://vnx.su
WB
WB
(1)
IP
Service Hints
M4, M5 Mirror Heater LH, RH
4Ground : Approx. 12 volts with the front deicer SW (w/ front deicer) or
rear window defogger SW (w/o front deicer) on
: Parts Location
Code
See Page
F19
Code
See Page
47 (LHD)
53 (LHD L/B)
67 (RHD)
55 (LHD W/G)
F20
47 (LHD)
J6
48 (LHD)
73 (RHD L/B)
M4
Code
See Page
55 (LHD W/G)
71 (RHD S/D)
M5
71 (RHD S/D)
73 (RHD L/B)
75 (RHD W/G)
J18
48 (LHD)
75 (RHD W/G)
S10
49 (LHD)
J29
68 (RHD)
51 (LHD S/D)
S11
49 (LHD)
M4
M5
51 (LHD S/D)
53 (LHD L/B)
: Relay Blocks
Code
5
6
See Page
28 (LHD)
28 (RHD)
29

Code
See Page
CA
34
CH
35
DB
30


Code
IA1
IL1
See Page
86 (LHD)
106 (RHD)
88 (LHD)
108 (RHD)

: Ground Points
Code
IJ
IP
See Page
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)

Left Kick Panel
Right Kick Panel
461
AVENSIS (EWD526E)
http://vnx.su
Remote Control Mirror

1 : w/ Retractor
F A (LHD)
F C (RHD)
J 8(A), J 9(B),
J20(C), J21(D)
Junction
Connector
H B (LHD)
H D (RHD)
7. 5A
RAD NO. 1
GR
4 DB
GR
R10
Retractor SW
M+
MF
10
13 CK
2 CK
1 CC
6 CB
WB
MR
9
VR
3
6 CI (LHD)
8 CD (RHD)
10 CK
MV
MR
13 IA1
16
IL1
6 CA
(1)
YG
(1)
(1)
YG
IL1
4 CC
16 IA1
MH
14
5 CC
MR
IL1
(1)
MV
13
12 CB
YG
MH
LB
LB
(1)
14 IA1
(1)
IL1
YG
15
(1)
IL1
LB
LB
LB
BW
17
GW
15 IA1
LGB
17 IA1
(1)
LB
LGB
BW
2 CC
WB
Return
GW
Retraction
Right/
Down
(1)
Right
VL
LB
HR
LGB
HL
Left
YG
Right
Left/
Up
Down
LB
Left
Up
(1)
Right
Select SW
Left
Operation SW
LB
M+
MF
(1)
YG
YG
(1)
WB
MF
2
M5
Remote Control
Mirror RH
M+
7
M4
Remote Control
Mirror LH
(1)
IP
462
AVENSIS (EWD526E)
http://vnx.su
Service Hints
R10 Remote Control Mirror SW
8Ground : Approx. 12 volts with ignition SW at ACC or ON position
86 : Continuity with the operation SW at RIGHT or DOWN position
67 : Continuity with the operation SW at LEFT or UP position
89, 107 : Continuity with the retractor SW at RETRACTION position
810, 97 : Continuity with the retractor SW at RETURN position
: Parts Location
Code
See Page
Code
See Page
J8
48 (LHD)
55 (LHD W/G)
J9
48 (LHD)
71 (RHD S/D)
J20
68 (RHD)
J21
68 (RHD)
75 (RHD W/G)
51 (LHD S/D)
51 (LHD S/D)
M4
M4
M5
53 (LHD L/B)
73 (RHD L/B)
53 (LHD L/B)
Code
See Page
55 (LHD W/G)
M5
71 (RHD S/D)
73 (RHD L/B)
75 (RHD W/G)
R10
49 (LHD)
69 (RHD)

Code
See Page
CA
CB
CC
34
CD
CI
CK
DB
35
30

Code
IA1
IL1
See Page
86 (LHD)
106 (RHD)
88 (LHD)
108 (RHD)

: Ground Points
Code
IP
See Page
86 (LHD)
106 (RHD)

Right Kick Panel
463
AVENSIS (EWD526E)
http://vnx.su
Power Seat
30A
PWR SEAT
2 DM
LO
(LHD)
LO
(RHD)
LO
LO
(RHD)
(RHD)
A A (LHD)
A C (RHD)
J35(A), J36(B),
J37(C), J38(D)
Junction
Connector
E B (LHD)
E D (RHD)
1 (LHD)
1 (RHD)
YR
(LHD)
RL
RL
(RHD)
(RHD)
P18
Power Seat Control SW (Driver' s Seat)
Rear
Front
Reclining
Down
Rear
Lifter
Down
Front Vertical
Front
Slide
Up
YR
(LHD)
Up
RL
(RHD)
YR
E B
E D
(LHD)
LO
(RHD)
SLDF
SLDR
FUP
FDWN
LUP
LDWN
RCLF
RCLR
9
9
6
6
10
5
5
10
7
8
8
7
3
3
2
2
E
4 (LHD)
4 (RHD)
WB
WB
YB
YR
H A (LHD)
H C (RHD)
2
M
1
BR
464
AVENSIS (EWD526E)
http://vnx.su
WB
1 (LHD)
2 (RHD)
J35(A), J36(B),
J37(C), J38(D)
Junction
Connector
WB
2 (LHD)
1 (RHD)
F B (LHD)
F D (RHD)
F B
F D
(LHD)
2 (LHD)
1 (RHD)
2 (LHD)
1 (RHD)
P22
Power Seat Motor
(Driver' s Seat Reclining Control)
1 (LHD)
2 (RHD)
P21
Power Seat Motor
(Driver' s Seat Lifter Control)
1 (LHD)
2 (RHD)
P20
Power Seat Motor
(Driver' s Seat Front Vertical Control)
P23
Power Seat Motor
(Driver' s Seat Slide Control)
F B
F D
(RHD)
YG
LR
LY
LB
WB
BV
30A
PWR SEAT
LO
(RHD)
(RHD)
LO
LO
(RHD)
(RHD)
LO
LO
(LHD)
10 IM2
LO
A A (RHD)
A C (LHD)
J35(A), J36(B),
J37(C), J38(D)
Junction
Connector
E B (RHD)
E D (LHD)
YR
YR
Reclining
E2
SLDF
SLDR
RCLF
RCLR
LB
YR
YB
Rear
E1
RB
Rear
Front
Slide
Front
1
B
P19
Power Seat Control SW
(Front Passenger' s Seat)
RG
L7
Lumbar Support Control SW
3
B
(RHD)
RL
RL
(RHD)
(LHD)
(LHD)
1 (LHD)
2 (RHD)
M
1
WB
BV
WB
(RHD)
1 (LHD)
2 (RHD)
WB
2 (LHD)
1 (RHD)
F B (RHD)
F D (LHD)
J35(A), J36(B),
J37(C), J38(D)
Junction
Connector
H A (RHD)
H C (LHD)
(LHD)
2 (LHD)
1 (RHD)
P24
Power Seat Motor
(Front Passenger' s Seat
Reclining Control)
L6
Lumbar Support Control Motor
WB
P25
Power Seat Motor
(Front Passenger' s
Seat Slide Control)
WB
BR
465
AVENSIS (EWD526E)
http://vnx.su
Power Seat
Service Hints
P18 Power Seat Control SW (Drivers Seat)
P19 Power Seat Control SW (Front Passengers Seat)
: Parts Location
Code
J35
See Page
56 (LHD)
J36
56 (LHD)
76 (RHD)
56 (LHD)
J38
L7
76 (RHD)
J37
Code
76 (RHD)
56 (LHD)
76 (RHD)
56 (LHD)
L6
76 (RHD)
P18
P19
P20
P21
See Page
56 (LHD)
76 (RHD)
56 (LHD)
76 (RHD)
56 (LHD)
76 (RHD)
56 (LHD)
76 (RHD)
56 (LHD)
76 (RHD)
: Relay Blocks
Code
6
See Page
29


Code
DM
See Page
31


Code
IM2
See Page
88 (LHD)
108 (RHD)

: Ground Points
Code
See Page
90 (LHD S/D)
92 (LHD L/B)
BR
94 (LHD W/G)
110 (RHD S/D)
112 (RHD L/B)

114 (RHD W/G)
90 (LHD S/D)
92 (LHD L/B)
BV
94 (LHD W/G)
110 (RHD S/D)
112 (RHD L/B)

114 (RHD W/G)
466
AVENSIS (EWD526E)
http://vnx.su
Code
P22
P23
P24
P25
See Page
56 (LHD)
76 (RHD)
56 (LHD)
76 (RHD)
56 (LHD)
76 (RHD)
56 (LHD)
76 (RHD)
Memo
467
AVENSIS (EWD526E)
http://vnx.su
Seat Heater
10A
HTR
RL
RL
16
DM
S 7(A), S 8(B)
Seat Heater SW
2 A
E
5 A
RVL
SWL
3 A
4 A
1 ED1
LG
LGB
(2)
(2)
WB
20A SHTR
(4)
BL
1 DN
SEAT HTR Relay
IG
LGB(2)
LG(2)
LB
E A
H B
G B
A B
J35(A), J36(B)
Junction
Connector
G A
(2)
(1)
LB
F A
LG
(1)
Seat Heater Controller
B A
WB
Battery
WB
Seat
Heater
Squab
6
Seat Heater
Cushion
S16
Seat Heater LH
WB
(1)
F
B
H
A
J35(A), J36(B)
Junction Connector
IP
BS
468
AVENSIS (EWD526E)
http://vnx.su
C B
J17
Junction
Connector
FL MAIN
3. 0W
(3)
BG
J30(A), J31(B)
Junction
Connector
(4)
WB
1 4B
5
3
(1)
RG
(1)
J32
Junction
Connector
WB
140A ALT
1
LB
I1
2
120A ALT(5)
100A ALT(6)
LGB
LG
1 4D
(1)
LB
LB
(1)
5 DM
(3)
(4)
BG
33 DA
LB
17 IC2
WB
(1)
1
2
3
4
5
6
: w/ Power Seat
: w/o Power Seat
: Gasoline
: 1CDFTV
: 1AZFSE, 1AZFE
: 1ZZFE, 3ZZFE
S 7(A), S 8(B)
Seat Heater SW
SWR
RVR
1 B
2 B
LGB(2)
LG(2)
BO
(2)
(2)
LB
LB
11 IM2
LB
(2)
LB
(2)
BO
(2)
(1)
(2)
G B
(1)
H B
RB
A B
LB
G A
LB
(1)
BO
(1)
LG
(1)
(1)
J37(A), J38(B)
Junction Connector
LB
(2)
LGB
F A
LG
E A
(2)
(2)
LB
(2)
(1)
(1)
S17
Seat Heater RH
F
B
H
A
Seat Heater
Cushion
WB
(2)
S17
Seat Heater RH
WB
Seat
Heater
Squab
Seat Heater
Cushion
WB
WB
(2)
S16
Seat Heater LH
Seat
Heater
Squab
Seat Heater
Cushion
WB
Seat
Heater
Squab
(1)
J37(A), J38(B)
Junction Connector
BR
BV
469
AVENSIS (EWD526E)
http://vnx.su
Seat Heater
Service Hints
S7 Seat Heater SW
: Parts Location
Code
See Page
J17
48 (LHD)
Code
J31
See Page
B
51 (LHD S/D)
J30
53 (LHD L/B)
J32
55 (LHD W/G)
J31
Code
See Page
55 (LHD W/G)
J37
56 (LHD)
51 (LHD S/D)
J38
56 (LHD)
53 (LHD L/B)
S7
49 (LHD)
55 (LHD W/G)
S8
49 (LHD)
51 (LHD S/D)
J35
56 (LHD)
S16
56 (LHD)
53 (LHD L/B)
J36
56 (LHD)
S17
56 (LHD)
: Relay Blocks
Code
3
See Page
26


Code
4B
4D
See Page
27
DA
30
DM
31
DN
31

Code
See Page
ED1
84 (*6)
IC2
86 (LHD)
IM2
88 (LHD)
: Ground Points
Code
IP
See Page
86 (LHD)

Right Kick Panel
90 (LHD S/D)
BR
92 (LHD L/B)
94 (LHD W/G)
90 (LHD S/D)
BS
92 (LHD L/B)
94 (LHD W/G)
90 (LHD S/D)
BV
92 (LHD L/B)
94 (LHD W/G)
: Splice Points
Code
I1
See Page
88 (LHD)
Code
See Page
Floor Wire
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
470
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
Memo
471
AVENSIS (EWD526E)
http://vnx.su
Navigation System (Map Type)

7. 5A ST
10A
GAUGE1
7. 5A
RAD NO. 1
M 1(A), M 2(B), M 3(C)

MultiDisplay
15A RAD NO. 2
ST1
7 DB
GR
+B1
IG1
3 A
ACC
1 A
14 A
BW
RW
4 DB
15 A
RW
GR
(RHD)
GR
(LHD)
LY
(LHD)
LY
3 CF
RW
LY
(LHD)
LY
(RHD)
6 CD
(RHD)
7 CA
RW
4 CE
LY
(LHD)
LY
(LHD)
GR
9 CB
GR
(LHD)
GR
LY
E B
10 CB
(LHD)
E B
J24(A), J25(B)
Junction
Connector
E A
GR
F A
F C
F A
F C
F A (LHD)
F C (RHD)
(LHD)
GR
GR
H B (LHD)
H D (RHD)
(RHD)
H B
H D
GR
(RHD)
(RHD)
GR
J 8(A), J 9(B), J20(C), J21(D)

Junction Connector
LY
(RHD)
LY
GR
(LHD)
LY
(LHD)
LY
(RHD)
GR
472
AVENSIS (EWD526E)
http://vnx.su
M 1(A), M 2(B), M 3(C)

MultiDisplay
SGD1
22 A
TX3+
RE1
TX3
12 A
10 A
SPD
24 A
4 A
7. 5A DOME
VW
RW
GR
ACC
GND
2 A
21 B
20 B
GR
4 A
AVCLAN
I/F
WB
GR
(RHD)
(LHD)
3 A
VW
TX
5 B
18 B
VW
C10(A), C11(B)
Combination Meter
LW
19 B
WB
CPU
J10(A), J11(B), J20(C), J21(D)

Junction Connector
WR
(LHD)
Speedometer
R11
Remote Controller
(Navigation)
WR
H B
SGND
GR
F A (LHD)
F C
F C (RHD)
(RHD)
RW
GY
WR
J10(A), J11(B), J26(C)

Junction
Connector
(Shielded)
H A
H C
F B (LHD)
F D (RHD)
H A (LHD)
H C (RHD)
VW
GR
LW
16 IE1
(LHD)
LY
LY
(LHD)
(LHD)
LY
LY
(RHD)
(RHD)
GR
GR
35 A (w/ VSC)
23 B (w/o VSC)
SP1
WB
WB
S 1(A), S 2(B)
Skid Control ECU
with Actuator
473
AVENSIS (EWD526E)
http://vnx.su

M 1(A), M 2(B), M 3(C)
MultiDisplay
PKB
GTX+
(RHD)
LG
10 C
R 4(A), R 6(C), R 7(D)

Radio and Player
TX
10
11
AU1
EAU
AU2
D5
DLC3
FL+
FR+
1 A
2 A
FL
FR
5 A
6 A
MODE
SEEK
VOICE
or DISP
(RHD)
LG
(LHD)
(RHD)
C14
Combination SW
SEEK+
WR
LG
12
2 DC
TC
SW2
8 D
8 DM
P4
Parking Brake SW
13
GND
6 D
(LHD)
BW
SW1
7 D
BW
WL
9 C
TX+
(RHD)
D D
18 A
9 IC2
J21(D)
Junction Connector
D D
(LHD)
B A
WL
WL
J 8(A), J 9(B)
Junction Connector
WL
(LHD)
D B
GTX
5 A
BW
17 A
TC
16 A
VOL+
VOL
1 A
10 A
AUI+
AUI
N 3(A), N 4(B), N 5(C)

Navigation ECU
(+)OUT
()OUT
(RHD)
LG
L
6
IL1
(+)IN
()IN
(+)OUT
()OUT
T17
Tweeter Front RH
2
()IN
IL1
4
(+)IN
LG
6 IA1
(RHD)
(LHD)
1 IA1
(LHD)
GR
(RHD)
AUO
11 A
T16
Tweeter Front LH
LY
AUO+
2 A
LY
(LHD)
LY
LY
VW
ACC
18 A
+B
9 A
(LHD)
SPD
5 A
GR
LG
(RHD)
WB
WB
F21
F22
WB
WB
474
AVENSIS (EWD526E)
http://vnx.su
7. 5A
GAUGE2
M 1(A), M 2(B), M 3(C)

MultiDisplay
VG
SYNC
6 B
8 B
3 B
7 B
2 B
CTX
VR
1 B
CTX+
10 B
GND1
5 B
25 A
GND2
1 C
RW
WB
WB
27 DA
8 CA
RW
LG
(Shielded)
(Shielded)
1 CD
B 1(B)
BackUp Light SW
N 1(A)
Neutral Start SW
RW
1 IK1
8 B
VG
SYNC
3 B
7 B
2 B
1 B
10 B
5 B
TX
VR
TX+
GND
5 IK1
N 3(A), N 4(B), N 5(C)

Navigation ECU
SGND
10 CH
5 CG
J 5(A), J22(B)
Junction Connector
7 CK
C A (LHD)
A B (RHD)
WB
(RHD)
RY
13 CF
WB
RY
17 A
WB
C A (LHD)
A B (RHD)
14 ID1
WB
T11
J15
Junction
Connector
WB A
(RHD)
WB
WB
(LHD)
WB
J17
Junction
Connector
WB
2
MIC
(Shielded)
4
MIC+
6 CA
6 CK
WB
5
MACC
RY
W
16 ID1
SNSE
7 C
WB
B
18 ID1
(Shielded)
I7
17 ID1
REV
14 A
WB
6 C
(LHD)
MIC
5 C
BR
MIC+
3 C
BR
MACC
4 C
2 A (A/T)
1 B (M/T)
RY
6 B
3 A (A/T)
2 B (M/T)
IP
IK
475
AVENSIS (EWD526E)
http://vnx.su

System Outline
The navigation system precisely measures the current vehicle position, displays the map obtained from the map database
on the screen, and informs the route to the destination shown on the map using voice guidance.
The navigation system is also capable of recognizing voice and enables you to operate itself or the audio system by briefly
pressing the voice operation switch and giving a voice command.
Service Hints
N3 (A) Navigation ECU
(A) 18Ground : Approx. 12 volts with the ignition SW at ACC or ON position
R11 Remote Controller (Navigation)
M1 (A), M3 (C) MultiDisplay
(A) 25, (C) 1Ground : Always continuity
476
AVENSIS (EWD526E)
http://vnx.su
: Parts Location
Code
See Page
Code
38 (*3)
J15
40 (*4)
42 (*5)
B1
C10
C11
68 (RHD)
49 (LHD)
69 (RHD)
49 (LHD)
R11
68 (RHD)
62 (*9)
J21
68 (RHD)
64 (*10)
J22
68 (RHD)
46 (LHD)
J24
68 (RHD)
66 (RHD)
J25
68 (RHD)
65 (*10)
46 (LHD)
J26
68 (RHD)
41 (*4)
47 (LHD)
67 (RHD)
50 (LHD S/D)
M1
M2
M3
69 (RHD)
39 (*3)
S1
48 (LHD)
68 (RHD)
45 (*6)
59 (*7)
43 (*5)
S2
45 (*6)
48 (LHD)
63 (*9)
68 (RHD)
65 (*10)
48 (LHD)
51 (LHD S/D)
68 (RHD)
53 (LHD L/B)
52 (LHD L/B)
39 (*3)
54 (LHD W/G)
41 (*4)
70 (RHD S/D)
T11
55 (LHD W/G)
71 (RHD S/D)
43 (*5)
73 (RHD L/B)
72 (RHD L/B)
59 (*7)
75 (RHD W/G)
74 (RHD W/G)
63 (*9)
51 (LHD S/D)
50 (LHD S/D)
49 (LHD)
53 (LHD L/B)
52 (LHD L/B)
54 (LHD W/G)
F22
R7
69 (RHD)
66 (RHD)
F21
See Page
C
J20
46 (LHD)
D5
48 (LHD)
Code
R6
58 (*7)
66 (RHD)
C14
68 (RHD)
J17
44 (*6)
See Page
48 (LHD)
70 (RHD S/D)
72 (RHD L/B)
74 (RHD W/G)
J5
48 (LHD)
J8
48 (LHD)
J9
48 (LHD)
J10
48 (LHD)
J11
48 (LHD)
N1
N3
N4
N5
C
P4
69 (RHD)
49 (LHD)
R6
55 (LHD W/G)
71 (RHD S/D)
69 (RHD)
73 (RHD L/B)
49 (LHD)
75 (RHD W/G)
69 (RHD)
51 (LHD S/D)
49 (LHD)
53 (LHD L/B)
69 (RHD)
R4
T16
49 (LHD)
T17
55 (LHD W/G)
71 (RHD S/D)
69 (RHD)
73 (RHD L/B)
49 (LHD)
75 (RHD W/G)
: Relay Blocks
Code
6
See Page
29


Code
See Page
CA
CB
CD
34
CE
CF
CG
CH
35
CK
DA
DB
30
31
DC
DM
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
477
AVENSIS (EWD526E)
http://vnx.su

Code
IA1
IC2
ID1
IE1
IK1
IL1
See Page
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)

86 (LHD)
106 (RHD)
88 (LHD)
108 (RHD)
88 (LHD)
108 (RHD)
: Ground Points
Code
IK
IP
See Page
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)

Right Kick Panel
: Splice Points
Code
I7
See Page
88 (LHD)

Instrument Panel Wire
Code
I7
See Page
108 (RHD)
478
AVENSIS (EWD526E)
http://vnx.su

Memo
479
AVENSIS (EWD526E)
http://vnx.su
MultiDisplay (w/o Navigation System Map Type)

15A
RAD NO. 2
7. 5A
RAD NO. 1
10A
GAUGE1
2
4 DB
7 DB
6 CD
G
GY
3 CF
H B (LHD)
H D (RHD)
(LHD)
GR
M 1(A), M 2(B), M 3(C)

MultiDisplay
ACC
SG
BRQ
TX3+
TX3
ST1
LG
15 A
6 A
GY
1 B
4 B
4 A
15
13
16
14
TX1
GND
7 A
1 C
WB
DTX
5 B
IG
WR
DTX+
2 A
1 A
+B
2 B
13 A
(LHD)
TX1+
GND
8 A
WB
9 A
GY
GR
LY
GR
RW
9 CB
H B
LY
RW
7 CA
GR
4 CE
(RHD)
RW
F A (LHD)
F C
F C (RHD)
(RHD)
E B
J 8(A), J 9(B), J20(C), J21(D)

Junction
Connector
GR
E A
(LHD)
LY
J24(A), J25(B)
Junction
Connector
LY
(RHD)
RW
Z1
Option Connector (Navigation ECU)
10 CH
GND
SW1
R7
Radio and Player
11
AU1
EAU
AU2
DISP
SEEK+
MODE
SEEK
VOICE
or DISP
VOL+
VOL
480
AVENSIS (EWD526E)
http://vnx.su
6 CK
WB
8
SW2
10
C14
Combination SW
LG
WR
6 CA
12
WB
J15
Junction
Connector
IK
IP
7. 5A DOME
WR
GR
G
GY
F A (LHD)
F C
F C (RHD)
WR
RW
GR
GY
H B
(RHD)
J10(A), J11(B), J26(C)

Junction
Connector
RW
WR
(LHD)
4 A
2 A
20 B
Fuel
AVCLAN
I/F
21 B
Speedometer
3 A
CPU
6 IC1
19 B
LW
GW
15 IC1
GW
10 A
BRW
5 A
BRW
5 B
WB
C10(A), C11(B)
Combination Meter
16 IE1
LW
F25
Fuel Sender
35 A (w/ VSC)
23 B (w/o VSC)
WB
SP1
S 1(A), S 2(B)
Skid Control ECU
with Actuator
481
AVENSIS (EWD526E)
http://vnx.su
MultiDisplay (w/o Navigation System Map Type)

Service Hints
M1 (A), M3 (C) MultiDisplay
(A) 8, (C) 1Ground : Always continuity
: Parts Location
Code
C10
See Page
A
C11
Code
J10
48 (LHD)
66 (RHD)
J11
48 (LHD)
46 (LHD)
F25
Code
M3
See Page
C
68 (RHD)
49 (LHD)
R7
48 (LHD)
J15
66 (RHD)
C14
See Page
46 (LHD)
69 (RHD)
68 (RHD)
39 (*3)
46 (LHD)
J20
68 (RHD)
66 (RHD)
J21
68 (RHD)
50 (LHD S/D)
J24
68 (RHD)
65 (*10)
52 (LHD L/B)
J25
68 (RHD)
41 (*4)
54 (LHD W/G)
J26
68 (RHD)
70 (RHD S/D)
72 (RHD L/B)
74 (RHD W/G)
J8
48 (LHD)
J9
48 (LHD)
M1
M2
M3
48 (LHD)
S1
45 (*6)
59 (*7)
43 (*5)
S2
45 (*6)
68 (RHD)
63 (*9)
48 (LHD)
65 (*10)
68 (RHD)
48 (LHD)
49 (LHD)
Z1
69 (RHD)
: Relay Blocks
Code
6
See Page
29


Code
See Page
CA
CB
CD
34
CE
CF
CH
CK
DB
35
30

Code
IC1
IE1
See Page
86 (LHD)
106 (RHD)

86 (LHD)
106 (RHD)
: Ground Points
Code
IK
IP
See Page
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)

Right Kick Panel
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
482
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
Memo
483
AVENSIS (EWD526E)
http://vnx.su
Radio and Player

()IN
(+)IN
LY
(11)
7 BC1
7 BA1
17 BA1
9 IM2
18 IM2
1 IC2
10 IC2
LY
ACC
ANT+
8 A
+B
SW1
SW2
6 D
1 B
3 B
2 B
6 B
RR+
GND
7 D
R 4(A), R 5(B), R 6(C), R 7(D)

Radio and Player
4 A
3 A
GR
LY
()IN
1
()OUT
8 CB
(+)IN
3
(+)OUT
17 BC1
J24
Junction
Connector
(11)
F A (LHD)
F B (RHD)
1
()OUT
E
LY
4 CE
(10)
LY
F A (LHD)
F B (RHD)
(LHD)
J 8(A), J20(B)
Junction Connector
(LHD)
GR
4 DB
3
(+)OUT
T18
Tweeter Rear LH
15A
RAD NO. 2
T19
Tweeter Rear RH
7. 5A
RAD NO. 1
R15
1
2
R16
1
2
RR
FR+
8 D
RL+
RL
FR
1 A
5 A
LG
R
(6)
10
EAU
AU2
AUO
11
LG
SEEK+
MODE
(6)
A31
Antenna
Amplifier
AU1
AUO+
(5)
11
AUI
10
(5)
LG
12
N3
Navigation ECU
(6)
(8)
(8)
WR
LG
(8)
R
(7)
AUI+
(6)
(7)
2
()IN
(+)OUT
()OUT
4
(+)IN
Z 1(A), Z 2(B)
Option Connector
(Navigation ECU)
LG
11 A
2 A
9 A
18 A
11 B
2 B
9 B
18 B
R
1
(7)
W
F22
Front Door
Speaker RH
484
AVENSIS (EWD526E)
http://vnx.su
(7)
(7)
(7)
(7)
LG
LG
IL1
(7)
IL1
VOL
T17
Tweeter Front RH
VOL+
C14
Combination SW
SEEK
1 : LHD 3
2 : LHD 9
4 : RHD, LHD w/o MultiDisplay
5 : LHD, RHD w/o MultiDisplay
6 : RHD 3
7 : RHD 9
8 : w/ Steering SW
10 : RHD 1CDFTV w/o MultiDisplay
11 : RHD Except 1CDFTV w/o MultiDisplay
M1
MultiDisplay
LG
(3)
18
GTX
(3)
GTX+
9 C
R 4(A), R 5(B), R 6(C), R 7(D)

Radio and Player
10 C
TX+
TX
FL+
GND
FL
2 A
6 A
7 A
LG
(1)
LG
(1)
(2)
R
(2)
10
11
V
1
LG
11 A
2 A
9 A
18 A
11 B
2 B
9 B
18 B
WB
(RHD)
(2)
(2)
BR
()OUT
Z 1(A), Z 2(B)
Option Connector
(Navigation ECU)
(+)OUT
2
()IN
4
(+)IN
(2)
6 IA1
(2)
1 IA1
(LHD)
(1)
(1)
AUO
AUO+
(4)
AUI
LG
T16
Tweeter Front LH
(4)
N3
Navigation ECU
1
AUI+
R
1
(2)
W
F21
Front Door
Speaker LH
(2)
IN
485
AVENSIS (EWD526E)
http://vnx.su
Radio and Player

Service Hints
R4 (A) Radio and Player
: Parts Location
Code
See Page
46 (LHD)
A31
66 (RHD)
46 (LHD)
C14
66 (RHD)
50 (LHD S/D)
52 (LHD L/B)
R5
R6
Code
69 (RHD)
See Page
T16
75 (RHD W/G)
49 (LHD)
51 (LHD S/D)
69 (RHD)
53 (LHD L/B)
49 (LHD)
55 (LHD W/G)
T17
69 (RHD)
71 (RHD S/D)
73 (RHD L/B)
69 (RHD)
75 (RHD W/G)
70 (RHD S/D)
51 (LHD S/D)
51 (LHD S/D)
72 (RHD L/B)
53 (LHD L/B)
53 (LHD L/B)
74 (RHD W/G)
55 (LHD W/G)
50 (LHD S/D)
F22
R4
See Page
49 (LHD)
54 (LHD W/G)
F21
Code
R7
R15
55 (LHD W/G)
T18
71 (RHD S/D)
71 (RHD S/D)
52 (LHD L/B)
73 (RHD L/B)
73 (RHD L/B)
54 (LHD W/G)
75 (RHD W/G)
75 (RHD W/G)
70 (RHD S/D)
51 (LHD S/D)
51 (LHD S/D)
72 (RHD L/B)
53 (LHD L/B)
53 (LHD L/B)
74 (RHD W/G)
55 (LHD W/G)
R16
55 (LHD W/G)
T19
J8
48 (LHD)
J20
68 (RHD)
73 (RHD L/B)
73 (RHD L/B)
68 (RHD)
75 (RHD W/G)
75 (RHD W/G)
48 (LHD)
51 (LHD S/D)
68 (RHD)
53 (LHD L/B)
J24
M1
49 (LHD)
N3
R4
T16
71 (RHD S/D)
55 (LHD W/G)
69 (RHD)
71 (RHD S/D)
49 (LHD)
73 (RHD L/B)
Z1
Z2
: Relay Blocks
Code
6
See Page
29


Code
CB
CE
DB
See Page
34
30
486
AVENSIS (EWD526E)
http://vnx.su
71 (RHD S/D)
49 (LHD)
69 (RHD)
49 (LHD)
69 (RHD)

Code
IA1
IC2
IL1
IM2
See Page
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
88 (LHD)
108 (RHD)
88 (LHD)
108 (RHD)

90 (LHD S/D)
92 (LHD L/B)
BA1
94 (LHD W/G)
110 (RHD S/D)
112 (RHD L/B)

114 (RHD W/G)
90 (LHD S/D)
92 (LHD L/B)
BC1
94 (LHD W/G)
110 (RHD S/D)
112 (RHD L/B)

114 (RHD W/G)
: Ground Points
Code
IN
See Page
86 (LHD)
106 (RHD)

487
AVENSIS (EWD526E)
http://vnx.su
Combination Meter
VW
(7)
7. 5A
RAD NO. 1
7. 5A
DOME
10A
GAUGE1
2
4 DB
7 DB
: 1AZFSE
: 1CDFTV
: w/ VSC
: Gasoline
: w/ MultiDisplay w/o Navigation System (Map Type)
7 CA
6 : w/ Moon Roof
9 : Automatic A/C
6 CD
RW
WR
(LHD)
H B
1
2
3
4
5
RW
F C
WR
F A (LHD)
F C (RHD)
F A (LHD)
F C (RHD)
(RHD)
J10(A), J11(B),
J26(C)
Junction
Connector
20 B
21 B
OUTSIDE
TEMP.
ODO/TRIP
Temp.
Fuel
Tachometer
Door
GR
H B (LHD)
H D (RHD)
Speedometer
J 8(A), J 9(B), J20(C), J21(D)

Junction Connector
GR
WR
VW
CPU
A/T SHIFT (A/T)

CLOCK
2 A
18 B
C10(A), C11(B)
Combination Meter
GR
VW
VW
H A
H C
H A
H C
F B
F D
F B
F D
F B (LHD)
F D (RHD)
12
(6)
VW
(6)
VW
VW
(w/ HID)
2 ID1
4 BB1
SPDR
488
AVENSIS (EWD526E)
http://vnx.su
SPD
VW
(6)
E15
EPS ECU
(7)
VW
SPD
H14
Control ECU
12
(5)
VW
J10(A), J11(B),
J20(C), J21(D)
Junction
Connector
SPD
Z1
Option Connector
(Navigation ECU)
(7)
VW
N3
Navigation ECU
H A (LHD)
H C (RHD)
H A
H C
M6
Moon Roof Control
Relay and Motor
VW
(w/ EPS)
VW
P
(7)
VW
4 A
15 A
14 A
Buzzer
13 A
A B (LHD)
B D (RHD)
E A (LHD)
D C (RHD)
29 A (8)
20 B (9)
MPX
MPX+
9 A (8)
10 B (9)
PB
18 B
23 A
20 A
A13(A), A15(B)
MPX2
29 B (1)
29 A (11)
21 A (2)
PB
PL
TACH
MPX1
1 IC1
(10)
(w/ MultiDisplay)
GY
(w/ MultiDisplay)
3 A
5 A
SPD(4)
SP1(2)
GRR
22
17 B
J 8(A), J 9(B), J26(C), J27(D)

Junction Connector
GRR
31
MPX2
PB
12 A
4 B
MPX
MPX1
PB
TX3 (7)
TX1 (5)
24 A (7)
13 B (5)
TX3+
TX1+
E 9(A), E10(B)
Engine and ECT
ECU (A/T)
Engine ECU (M/T)
VW
11
I14
Integration Relay
SPD
T6
Theft Deterrent
ECU
M 1(A), (B)
MultiDisplay
4 A
10 IC1
C10(A), C11(B)
Combination Meter
3 B
BEAN
I/F
AVCLAN
I/F
CPU
4 IE1
4 IK1
YG
(2)
15 IE1
YR
YG
6 IC1
(2)
15 IC1
1 A
WR
16 A
WR
12 A
GW
11 A
GW
10 A
BRW
WB
5 A
BRW
19 B
LW
5 B
15 IK2
(2)
YR
(2)
F14
35 A (3)
23 B (w/o VSC)
F25
Fuel Sender
6 CA
E7
Engine Oil
Level Sensor
LW
6 CK
A1
A/C Ambient
Temp. Sensor
16 IE1
S 1(A), S 2(B)
Skid Control
ECU with Actuator
BR
(2)
(2)
WB
BR
SP1
I3
BR
(2)
EI
IP
489
AVENSIS (EWD526E)
http://vnx.su
Combination Meter
10A
TAIL
3 IC2
GW
GY
C10(A), C11(B)
Combination Meter
G
C A (LHD)
C C (RHD)
14 B
1 B
13 B
Tail
Illumination
Turn RH
C A (LHD)
C C (RHD)
Turn LH
J10(A), J26(C)
Junction
Connector
J30
Junction
Connector
4 DM
CPU
WB
J17
Junction
Connector
J16
Junction
Connector
WB
A
(12)
WB
(LHD)
(RHD)
WB
(LHD)
(RHD)
WB
17 A
J15
Junction
Connector
IK
490
AVENSIS (EWD526E)
http://vnx.su
IL : 2
IO : 4
2 : 1CDFTV
4 : Gasoline
10A
IGN
J 8(A), J26(C)
Junction
Connector
BW
18 DA
C A (LHD)
A C (RHD)
BW
C A (LHD)
A C (RHD)
WB
(12)
(w/ HID)
LG

Control ECU
10 B
Beam Level
Check Engine
9 B

Engine ECU (M/T)
Filter
CRUISE
Glow
22 B
Seat Belt
ECT SNOW
Charge
A/T OIL TEMP
Fuel
Oil Level
C10(A), C11(B)
Combination Meter
WB
(12)
491
AVENSIS (EWD526E)
http://vnx.su
Combination Meter
BY
2 : 1CDFTV
3 : w/ VSC
4 : Gasoline
13 : w/o Daytime Running Light w/o HID
14 : w/o Daytime Running Light w/ HID
15 : w/ Daytime Running Light, w/ HID
16 : w/ Front Fog Light
17 : w/ Rear Fog Light
C10(A), C11(B)
Combination Meter
(3)
TRC OFF
LGB
(3)
Slip
17 B
LG
15 B
(3)
VSC
16 B
WR
2 B
RW
4 B
SRS
Brake
ABS
9 A
RY
P/S
BW
(w/ EPS)
6 B
8 B
19 IE1
J2
Junction
Connector
(2)
C
Skid Control ECU

with Actuator
RW
RW
(2)
(2)
(4)
RW
B3
Brake Fluid Level
Warning SW
Skid Control ECU

with Actuator
EPS ECU
RW
V2
Vacuum SW
WB
WB
WB
(12)
(12)
EC
492
AVENSIS (EWD526E)
http://vnx.su
1
10A
HLP
HI RH
15A
HLP RH
RL
(15)
RL
(w/o HID)
J 3(A), J 4(B)
Junction
Connector
FR FOG Relay
D A
(w/o HID)
RW
(15)
RW
(17)
12 B
High Beam
8 A
Rear Fog
G
7 A
Front Fog
Oil Pressure
C10(A), C11(B)
Combination Meter
(16)
E B
6 A
(14)
RW
(13)
(12)
WB
YB
11 B
YB
Combination SW
19 IK2
O2
Oil Pressure
SW
WB
(12)
493
AVENSIS (EWD526E)
http://vnx.su
Combination Meter
Service Hints
C10 (A), C11 (B) Combination Meter
(B) 20Ground : Always approx. 12 volts
(B) 21Ground : Approx. 12 volts with the ignition SW at ON position
(A) 6Ground : Always continuity (w/ daytime running light)
(B) 5Ground : Always continuity
: Parts Location
Code
See Page
Code
38 (*3)
50 (LHD S/D)
40 (*4)
52 (LHD L/B)
42 (*5)
54 (LHD W/G)
F25
44 (*6)
A1
A15
53 (LHD L/B)
62 (*9)
47 (LHD)
40 (*4)
42 (*5)
C11
H14
E10
J3
F14
75 (RHD W/G)
49 (LHD)
N3
45 (*6)
69 (RHD)
65 (*10)
39 (*3)
48 (LHD)
41 (*4)
68 (RHD)
43 (*5)
48 (LHD)
45 (*6)
J8
48 (LHD)
61 (*8)
60 (*8)
J9
48 (LHD)
63 (*9)
62 (*9)
J10
48 (LHD)
65 (*10)
64 (*10)
J11
48 (LHD)
O2
39 (*3)
68 (RHD)
59 (*7)
46 (LHD)
J15
68 (RHD)
66 (RHD)
J16
48 (LHD)
46 (LHD)
J17
68 (RHD)
65 (*10)
S1
45 (*6)
59 (*7)
66 (RHD)
J20
68 (RHD)
41 (*4)
44 (*6)
J21
68 (RHD)
43 (*5)
64 (*10)
J26
68 (RHD)
47 (LHD)
J27
68 (RHD)
67 (RHD)
51 (LHD S/D)
47 (LHD)
53 (LHD L/B)
67 (RHD)
55 (LHD W/G)
J30
47 (LHD)
E15
73 (RHD L/B)
47 (LHD)
67 (RHD)
J2
71 (RHD S/D)
67 (RHD)
58 (*7)
E7
E9
I14
55 (LHD W/G)
M6
J4
44 (*6)
68 (RHD)
74 (RHD W/G)
66 (RHD)
48 (LHD)
60 (*8)
38 (*3)
C10
68 (RHD)
51 (LHD S/D)
46 (LHD)
B3
A
M1
72 (RHD L/B)
66 (RHD)
See Page
58 (*7)
46 (LHD)
Code
70 (RHD S/D)
64 (*10)
A13
See Page
71 (RHD S/D)
67 (RHD)
73 (RHD L/B)
44 (*6)
75 (RHD W/G)
64 (*10)
M1
48 (LHD)
S2
45 (*6)
61 (*8)
63 (*9)
65 (*10)
T6
V2
Z1
69 (RHD)
45 (*6)
65 (*10)
49 (LHD)
69 (RHD)
: Relay Blocks
Code
See Page
26
29
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
494
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV

Code
CA
CD
CK
DA
DB
DM
See Page
34

35
30
31

Code
IC1
IC2
ID1
IE1
IK1
IK2
See Page
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
88 (LHD)
108 (RHD)
88 (LHD)
108 (RHD)
90 (LHD S/D)
92 (LHD L/B)
BB1
94 (LHD W/G)
110 (RHD S/D)
112 (RHD L/B)

114 (RHD W/G)
: Ground Points
Code
See Page
78 (*3)
80 (*4)
82 (*5)
EC
84 (*6)
98 (*7)
100 (*8)
102 (*9)
104 (*10)
EI
IK
84 (*6)
104 (*10)
86 (LHD)
106 (RHD)
IL
86 (LHD)
IO
86 (LHD)
IP
Near the Starter
86 (LHD)
106 (RHD)

Right Kick Panel
: Splice Points
Code
I3
See Page
88 (LHD)

Engine Wire
Code
I3
See Page
108 (RHD)

Engine Wire
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
495
AVENSIS (EWD526E)
http://vnx.su
Radiator Fan and Condenser Fan (1AZFE, 1AZFSE)

30A
CDS
30A
RDI
7. 5A
ECUIG
11 DL
10 DL
RL
RL
WR
RL
WR
WR
RL
1
FAN
NO. 1
Relay
FAN
NO. 3
Relay
D4
Diode (Fan)
3
4
FAN
NO. 2
Relay
2
2
WR
B
W
WR
J1
Junction
Connector
16 IE2
6 IE2
WR
4 (1AZFSE)
7 (1AZFE)
23 A (1)
FAN
CFAN
A13(A), A15(B)
E9
Engine ECU (M/T)
B
E2
M
1
A2
A/C Condenser Fan
Motor
WB
R1
Radiator Fan Motor
1
E2
WB
WR
WB
EC
496
AVENSIS (EWD526E)
http://vnx.su
WB
System Outline
The system controls the radiator fan motor in two steps HIGH or LOW, according to the engine coolant temperature and A/C
operation condition.
: Parts Location
Code
See Page
38 (*3)
40 (*4)
A2
58 (*7)
60 (*8)
A13
A15
46 (LHD)
Code
A15
D4
E9
66 (RHD)
See Page
B
J1
46 (LHD)
Code
66 (RHD)
See Page
59 (*7)
J1
47 (LHD)
61 (*8)
67 (RHD)
39 (*3)
47 (LHD)
41 (*4)
R1
67 (RHD)
59 (*7)
39 (*3)
61 (*8)
41 (*4)
: Relay Blocks
Code
1
See Page
24 (*1)


Code
DL
See Page
31


Code
IE2
See Page
86 (LHD)
106 (RHD)
: Ground Points
Code
See Page
78 (*3)
EC
80 (*4)
98 (*7)
100 (*8)
: Splice Points
Code
E2
See Page
78 (*3)
80 (*4)

Code
E2
See Page
98 (*7)
100 (*8)

* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
497
AVENSIS (EWD526E)
http://vnx.su
Radiator Fan (1ZZFE, 3ZZFE)

40A
RDI
7. 5A
ECUIG
10 DL
11 DL
RL
WR
RL
3
4
FAN
NO. 2
Relay
FAN
NO. 3
Relay
3
WR
WB
WR
WR
D4
Diode (Fan)
WR
R1
Radiator Fan
Motor
J1
Junction
Connector
1
6 IE2
23 A (1)
CFAN
7
FAN
E2
E9
Engine ECU (M/T)
WB
A13(A), A15(B)
EC
498
AVENSIS (EWD526E)
http://vnx.su
WB
WB
WR
WR
16 IE2
R2
Radiator Fan Resistor
System Outline
The FAN NO.2 relay is turned ON/OFF according to the engine coolant temperature and A/C refrigerant pressure operation
condition. This allows the current to flow to the radiator fan resister when the fan speed is LOW, and to the radiator fan motor
when HIGH.
: Parts Location
Code
A13
See Page
46 (LHD)
A15
66 (RHD)
46 (LHD)
Code
D4
E9
66 (RHD)
D4
J1
47 (LHD)
See Page
Code
67 (RHD)
See Page
43 (*5)
R1
47 (LHD)
67 (RHD)
63 (*9)
43 (*5)
R2
43 (*5)
63 (*9)
63 (*9)
: Relay Blocks
Code
1
See Page
24 (*1)


Code
DL
See Page
31


Code
IE2
See Page
86 (LHD)
106 (RHD)
: Ground Points
Code
EC
See Page
82 (*5)
102 (*9)

: Splice Points
Code
E2
See Page
82 (*5)

Code
E2
See Page
102 (*9)

* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
499
AVENSIS (EWD526E)
http://vnx.su
Radiator Fan and Condenser Fan (1CDFTV)

30A
CDS
40A
RDI
7. 5A
ECUIG
10 DL
RL
11 DL
WR
1 1C
RL
WR
RL
FAN
NO. 1
Relay
3
3
4
FAN
NO. 2
Relay
FAN
NO. 3
Relay
3
E2
W
3
WR
1
B
WR
WR
D4
Diode (Fan)
16 IE2
2
EB
500
AVENSIS (EWD526E)
http://vnx.su
E2
WB
WB
WB
EC
FAN
WB
A13(A), A15(B)
WB
CFAN
E9
Engine ECU (M/T)
23 A (1)
W1
Water Temp. SW
(Radiator Fan)
WB
WR
R1
Radiator Fan
Motor
6 IE2
A2
A/C Condenser Fan
Motor
J1
Junction
Connector
WB
WR
WR
System Outline
: Parts Location
Code
See Page
44 (*6)
A2
A13
A15
64 (*10)
46 (LHD)
66 (RHD)
Code
D4
E9
46 (LHD)
J1
66 (RHD)
See Page
Code
47 (LHD)
See Page
45 (*6)
R1
67 (RHD)
47 (LHD)
65 (*10)
45 (*6)
W1
67 (RHD)
65 (*10)
45 (*6)
65 (*10)
: Relay Blocks
Code
See Page
25 (*2)
26

Code
See Page
1C
25 (*2)
DL
31

Code
IE2
See Page
86 (LHD)
106 (RHD)
: Ground Points
Code
EB
EC
See Page
84 (*6)
104 (*10)
84 (*6)
104 (*10)

: Splice Points
Code
E2
See Page
84 (*6)

Code
E2
See Page
104 (*10)

* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
501
AVENSIS (EWD526E)
http://vnx.su
Air Conditioner (Automatic A/C) and

10A
HTR
40A
HTR
2
RW
RW
5 DB
RW
9 CJ
(LHD)
12 CK
RW
RW
RW
1 CB
F D
(LHD 1)
(RHD 1)
RW
HTR
Relay
(RHD 1)
H C
J26(C), J27(D)
Junction
Connector
F D
(RHD)
H C
RW
H C
RW
(RHD)
(LHD)
RW
(RHD 1)
RW
H C
(RHD)
6 DC
(LHD 1)
RW
(LHD)
RW
L
2 DP
(RHD)
RW
(RHD)
(RHD)
RW
11 IE1
(RHD)
2 IK2
RW
C3
Compressor Assembly
IN
(1)
RB
GND
SI
(1)
GY
(1)
3 IK2
+B
(1)
RY
WB
18 IE2
IJ2
J16
Junction
Connector
B5
Blower Motor
Controller
LB
2
IJ2
VM
WB
(1)
BW
IG
M
2
P5
Power Heater SW
C4
Condenser Assembly
I6
B4
Blower Motor
LB
RW
34 DA
GRR
2 DF
LB
4 DF
A
GY
(1)
A
RY
3
IJ2
A
A
IK
WB
J15
Junction
Connector
IJ
GRR
(1)
IJ2
WB
LB
WB
(1)
WB
WB
(RHD)
(RHD)
IL
502
AVENSIS (EWD526E)
http://vnx.su
Power Heater (Hot Gas Type Automatic A/C)

1 : 1CDFTV w/ Power Heater (Hot Gas Type)

7. 5A
ECUB 2
7. 5A
DEF I/UP
2
RW
RW
WR
RW
(LHD)
RW
(RHD)
(RHD)
(RHD)
10 CC
A21
Air Inlet Control
Servo Motor
7 CF
REC
FRS
GW
PB
12 B
RY
RW
(RHD)
(LHD)
RW
2 CE
5 A
6 A
IG
REC
WR
6 CE
(Gasoline)
RW
(LHD)
4 B
24 B
RDEFIN
FRS
+B
TE
TR
19 A
17 A
16 A
10 B
22 B
6 B
WR
WG
GR
PBKIG
CFAN
RY
(1)
A19
A/C Thermistor
(1)
P4
Parking Brake SW
BW
2 DC
GY
SG5
A17
A/C Room Temp.
Sensor
4 DC
SG4
FAN NO. 3 Relay
BLW
5 B
(1)
RY
HR
17 B
GRR
MGV
7 A
(1)
11 B
GY
HOTGASIN
SOL+
8 A
BW
A15(A), A16(B)
GRR
WB
WB
(RHD)
(RHD)
503
AVENSIS (EWD526E)
http://vnx.su
A23
(Driver Side)
A25
GND
VZ
3
GND
VZ
PT
MAX
COOL
MAX
HOT
LGB
LB
YR
YB
GR
PL
GRR
FACE
BRW
DEF
GW
PT
15 A
14 B
19 B
3 A
4 A
14 A
2 B
8 B
11 A
12 A
SG3
S53
TPM
AOD
AOF
SG2
S52
TPD
AMDC
AMDH
A15(A), A16(B)
IF1
IF1
GND
13 B
WB
(LHD)
LW
17 IE2
S54
15 B
WB
GW
8 IE2
9 B
BW
7 IE2
TSD
21 B
(RHD)
TSP
PRE
7 B
LG
SG
18 B
S5
16 B
IF1
LW
LG
6 CA
6 CK
WB
GW
WB
BW
3 CG
J17
Junction
Connector
A18
A/C Solar Sensor
WB
A3
A/C Pressure Sensor
(RHD)
WB
WB
(RHD)
IP
504
AVENSIS (EWD526E)
http://vnx.su

1
10A
GAUGE1
7. 5A
DOME
2
7 DB
A24
RW
SG1
1 B
TPP
1 A
2 A
AMPC
AMPH
WR
J10(A), J11(B), J26(C)

Junction Connector
(RHD)
WR
5 IQ1
(LHD)
4 IQ1
H B
(RHD)
Y
Y
20 B
S51
(LHD)
V
V
3 IQ1
(RHD)
(LHD)
R
R
(LHD)
(RHD)
P
13 A
1 IQ1
(RHD)
(LHD)
2 IQ1
F A (LHD)
F C
F C (RHD)
4 (LHD)
5 (RHD)
5
4
(LHD)
3
3
(RHD)
2
1
(RHD)
1
2
6 CD
MAX
HOT
(RHD)
MAX
COOL
(RHD)
PT
VZ
(RHD)
GND
(RHD)
WR
7 CA
M
A15(A), A16(B)
RW
MPX+
MPX
20 A
10 A
12 A
19 B
4 IE1
15 IE1
LW
5 B
WR
14 A
11 A
CPU
13 A
PB
Temp.
MPX1
18 B (1AZFSE)
23 A (2)
20 A (1CDFTV)
Tachometer
MPX2
OUT SIDE
TEMP.
ODO/TRIP
Speedometer
BEAN
I/F
WB
MPX2
22
29 B (1AZFSE)
29 A (2)
21 A (1CDFTV)
PB
MPX1
E 9(A), E10(B)
Engine ECU (M/T)
I14
Integration Relay
10 IC1
11
21 B
20 B
PB
C10(A), C11(B)
Combination Meter
1 IC1
WB
1
A1
A/C Ambient
Temp. Sensor
LW
WR
PB
16 IE1
35 A (w/ VSC)
23 B (w/o VSC)
SP1
S 1(A), S 2(B)
Skid Control ECU
with Actuator
505
AVENSIS (EWD526E)
http://vnx.su

System Outline
1. Heater Blower Operation
(Manual operation)
When the blower speed is set to a certain level using the blower control SW, the A/C control assembly sends the signals to
the blower control to control the blower motor speed.
(Auto operation)
When the auto SW is turned on, the A/C control assembly sends the signals from various sensors and temperature SW to
the blower control to automatically control the blower motor speed.
2. Air inlet Control Servo Motor Control
When the FRESH/RECIRC select SW is set to RECIRC, the motor in the air inlet control servo motor starts rotating to move
the damper toward the RECIRC side. The motor is continuously rotates until the damper reaches its stop position. When the
FRESH/RECIRC select SW is set to FRESH, the motor in the air inlet control servo motor starts rotating to move the damper
toward the FRESH side. The motor is continuously rotated until the damper reaches its stop position. However, when the
mode SW is at DEF position, forcibly the air intake is set to FRESH mode.
3. Air Vent Mode Control Servo Motor Control
(Manual operation)
If the mode select SW is operated, the A/C control assembly is controlled to operate the air vent mode control servo motor
and the positions of outlets change among FACE, BILEVEL, FOOT, FOOT/DEF and DEF.
(Auto operation)
When the AUTO SW is turned on, the A/C control assembly selects the best position of the outlet according to the signals
from various sensors and operates the air vent mode control servo motor to change the outlet position among FACE,
BILEVEL, FOOT and FOOT/DEF.
4. Air Mix Control Servo Motor Control
According to the signals from various sensors, the A/C control assembly operates the air mix control servo motor and sets
the blowoff temperature to the most appropriate degree in order to adjust the temperature to the desired degree set by the
temperature control SW.
(When the DUAL switch is turned ON)
The system can provide independent air temperature control on the right and left sides. The temperature control switch for
each of the drivers and passengers sides independently controls air at the set temperature.
(When the DUAL switch is turned OFF)
The system controls air at the temperature set by the temperature control switch for the drivers side.
5. Air Conditioning Operation
The A/C control assembly receives various signals, I.E., the engine RPM from the engine and ECT ECU (A/T) or engine
ECU (M/T), out side air temperature signal from the A/C ambient temp. sensor and coolant temperature from the engine and
ECT ECU (A/T) or engine ECU (M/T), etc.
When the engine is started and the A/C SW (A/C control assembly) is on, a signal is input to the A/C control assembly.
6. Hot Gas Operation (1CDFTV)
This function uses air conditioner parts to radiate heat through an evaporator during air compression by the compressor.
Hot gas operation takes place when any of the following conditions is met:
The power heater SW is turned on.
The FRESH/RECIRC select SW is set to FRESH.
The blower SW is turned on.
The outside temperature is 0 C or below.
The water temperature is 70 C or below
MAX HOT
Service Hints
A16 (B) A/C Control Assembly
+BGround : Always approx. 12 volts
IGGround : Approx. 12 volts with ignition SW at ON position
GNDGround : Always continuity
506
AVENSIS (EWD526E)
http://vnx.su

: Parts Location
Code
See Page
Code
38 (*3)
A23
40 (*4)
42 (*5)
58 (*7)
64 (*10)
38 (*3)
40 (*4)
A3
A16
48 (LHD)
48 (LHD)
J15
66 (RHD)
68 (RHD)
48 (LHD)
J16
46 (LHD)
66 (RHD)
68 (RHD)
48 (LHD)
J17
J26
68 (RHD)
62 (*9)
42 (*5)
J27
68 (RHD)
44 (*6)
C3
46 (LHD)
58 (*7)
66 (RHD)
62 (*9)
46 (LHD)
64 (*10)
66 (RHD)
44 (*6)
66 (RHD)
46 (LHD)
66 (RHD)
46 (LHD)
A21
40 (*4)
46 (LHD)
A19
J11
58 (*7)
66 (RHD)
A18
48 (LHD)
46 (LHD)
38 (*3)
C4
46 (LHD)
A17
67 (RHD)
A
44 (*6)
64 (*10)
A15
47 (LHD)
J10
46 (LHD)
B5
42 (*5)
67 (RHD)
66 (RHD)
66 (RHD)
B4
See Page
B
I14
46 (LHD)
A25
62 (*9)
Code
E10
66 (RHD)
A24
44 (*6)
A1
See Page
46 (LHD)
66 (RHD)
C10
C11
64 (*10)
A
B
E9
E10
46 (LHD)
68 (RHD)
49 (LHD)
P4
69 (RHD)
49 (LHD)
P5
69 (RHD)
39 (*3)
S1
45 (*6)
59 (*7)
66 (RHD)
65 (*10)
46 (LHD)
41 (*4)
66 (RHD)
43 (*5)
47 (LHD)
S2
45 (*6)
67 (RHD)
63 (*9)
47 (LHD)
65 (*10)
: Relay Blocks
Code
1
6
See Page
24 (*1)
25 (*2)
29


Code
See Page
CA
CB
CC
CD
34
CE
CF
CG
CJ
35
CK
DA
DB
DC
30
31
DF
DP
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
507
AVENSIS (EWD526E)
http://vnx.su

Code
IC1
IE1
IE2
IF1
IJ2
IK2
IQ1
See Page
86 (LHD)
106 (RHD)

86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
88 (LHD)
Instrument Panel Wire and A/C Sub Wire No.1 (Left Side of the Combination Meter)
106 (RHD)
Instrument Panel Wire and A/C Sub Wire No.1 (Right Side of the Combination Meter)
88 (LHD)
108 (RHD)
88 (LHD)
108 (RHD)
108 (RHD)
Instrument Panel Wire and A/C Sub Wire No.3 (Behind the Glove Box)
: Ground Points
Code
IJ
IK
IL
IP
See Page
86 (LHD)
106 (RHD)

Left Kick Panel
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
Right Kick Panel
: Splice Points
Code
I6
See Page
88 (LHD)

Code
I6
See Page
108 (RHD)
508
AVENSIS (EWD526E)
http://vnx.su

Memo
509
AVENSIS (EWD526E)
http://vnx.su
Air Conditioner (Manual A/C) and

1
40A HTR
10A HTR
RW
(LHD)
RW(RHD)
WB(3)
RW
(RHD)
RW
4 DF
2 DF 34 DA
GRR
(LHD)
2 B
3 B
C1
C2
35 A
HRIN
A/C Amplifier
Blower SW
4 B
HI
1 B
WB
(3)
WB
(RHD)
GND
GRR
1 CA
7 CG
(LHD)
GRR
GRR
(RHD)
GRR
(RHD)
GRR
(RHD)
GRR
1
HTR Relay
(RHD)
4 CK
(LHD)
GRR
5 CE
(LHD)
(LHD)
GRR
J28
Junction
Connector
5 DB
GRR
6 DC
(1)
RW
2 DP
RW
(LHD)
(1)
M2
M1
5 B
6 B
A13(A), A14(B)
WB
J16
Junction
Connector
IJ1
IJ1
IJ1
WB
(LHD)
4
IJ1
WB
LB
HI
M2
M1
LO
WB
(3)
WB
B4
Blower
Motor
BW
WB
(RHD)
LB
I6
LB
WB
(LHD)
J15
Junction
Connector
B6
Blower Resistor
IJ
IL
WB
WB
(RHD)
(RHD)
IK
510
AVENSIS (EWD526E)
http://vnx.su
Power Heater (Hot Gas Type Manual A/C)

RW(RHD)
RW
RW
(LHD)
(LHD)
RW
(RHD)
RW(RHD)
RW
(1)
WB(3)
RW
(RHD)
RW
(RHD)
RW
(RHD)
(2)
RW
(1)
RW
RW
(RHD)
(LHD)
(1)
RW
RW
RW
2 IK2
(2)
11 IE1
H C
IG
C3
Compressor Assembly
H C
RW
H C
(3)
C4
Condenser Assembly
RW
H C
IN
P5
Power Heater SW
(RHD)
RW
J26(C), J27(D)
Junction
Connector
(3)
RB
F D
(2)
RW
F D
3 IK2
(3)
GY
(3)
(3)
RY
WB
18 IE2
A13(A), A14(B)
14 A
22 A
MGV
17 A
HOTGASIN
SOL+
A/C Amplifier
SG4
39 A
WG
TE
31 A
GND
40 A
PBKIG
25 A
WB
BW
WB
(RHD)
(LHD)
J17
Junction
Connector
A
A
(RHD)
4 DC
1
3 CG
6 CA
6 CK
WB
1 : LHD 1CDFTV Power Heater (Hot Gas Type)

2 : RHD 1CDFTV Power Heater (Hot Gas Type)
3 : 1CDFTV Power Heater (Hot Gas Type)
WB
WB
9 CG
P4
Parking Brake SW
2 DC
BW
WB
(LHD)
(LHD)
WB
(RHD)
WB
A19
A/C Thermistor
WB
WB
(RHD)
IP
511
AVENSIS (EWD526E)
http://vnx.su

RW(RHD)
1 : LHD 1CDFTV Power Heater (Hot Gas Type)
RW
(LHD)
RW
(RHD)
RW
RW
10 A
8 IE2
17 IE2
7 A
38 A
32 A
FAN NO. 3 Relay
7 IE2
WR
11 A
RW
LW
LW
FRS
PB
REC
RY
RW
(LHD)
GW
RW
RW
GW
6 CE
BW
2 CE
BW
1 CB
A21
Air Inlet Control
Servo Motor
12 CK
(RHD)
A3
A/C Pressure Sensor
(LHD)
9 CJ
(1)
RW
RW
(LHD)
(LHD)
(1)
(RHD)
1 A
IG
REC
S5
FRS
SG
A13(A), A14(B)
23 A
PRE
CFAN
A/C Amplifier
AMH
15 A
PL
AMC
16 A
TP
34 A
GR
SG2
36 A
YR
S52
5 A
YB
AOF
13 A
LB
AOD
12 A
LGB
TPM
33 A
GRR
GW
S53
6 A
BRW
SG3
37 A
GND
VZ
PT
DEF
FACE
VZ
GND
PT
MAX
COOL
MAX
HOT
A25
A22
WB
WB
512
AVENSIS (EWD526E)
http://vnx.su

7. 5A
ECUB 2
7. 5A
DEF I/UP
7. 5A
DOME
2
6
10A
GAUGE1
2
7 DB
WR
RW
WR
(RHD)
WR
7 CA
F A (LHD)
F C
F C (RHD)
MPX2
WR
C10(A), C11(B)
Combination Meter
20 B
21 B
PB
WR
13 A
RW
H B
J10(A), J11(B), J26(C)

Junction Connector
MPX1
29 (5)
21 (1CDFTV)
MPX+
BEAN
I/F
A/C Amplifier
PTC2
(PTCL)
HRLY
MPX
30 A
29 A
CPU
(4)
(4)
RW
(4)
19 A
RY
PTC1
(PTC)
20 A
(4)
BW
26 A
(4)
28 A
ALT
(EFII)
WL
RPTC1
(SIG1)
Temp.
9 A
Tachometer
4 A
RDEFIN
+B
Speedometer
A13(A), A14(B)
2 A
RW
6 CD
23 (5)
20 (1CDFTV)
(LHD)
GW
(Gasoline)
7 CF
E9
Engine ECU (M/T)
10 CC
OUT SIDE
TEMP.
ODO/TRIP
LW
WB
19 B
WR
PB
11 A
4 IE1
15 IE1
16 IE1
22
WR
11
12 A
5 B
14 A
PB
MPX1
PB
1 IC1
LW
MPX2
A1
A/C Ambient
Temp. Sensor
I14
Integration Relay
HLP Relay
HTR2 Relay
HTR1 Relay
Alternator
Engine ECU (M/T)
10 IC1
35 A (w/ VSC)
23 B (w/o VSC)
SP1
S 1(A), S 2(B)
Skid Control ECU
with Actuator
WB
513
AVENSIS (EWD526E)
http://vnx.su

System Outline
1. Heater Blower Motor Operation
Current is applied at all times through the HTR (40A) fuse to TERMINAL 5 of the HTR relay.
When the ignition SW is turned on, current flows through the HTR (10A) fuse to TERMINAL 1 of the HTR relay to TERMINAL
2 to TERMINAL (B) 2 or (B) 3 of the A/C control assembly.
Low speed operation
When the blower SW is moved to LO position, the current to TERMINAL (B) 2 of the A/C control assembly flows to
TERMINAL (B) 1 to GROUND, causing the HTR relay is turned on. This causes the current to flow from the HTR (40A)
fuse to TERMINAL 5 of the HTR relay to TERMINAL 3 to TERMINAL 1 of the blower motor to TERMINAL 2 to
TERMINAL 1 of the blower resistor to TERMINAL 4 to GROUND, causing the blower motor to rotate at low speed.
Medium speed operation (Operation at M1, M2)
When the blower SW is moved to M1 position, the current to TERMINAL (B) 2 of the A/C control assembly flows to
TERMINAL (B) 1 to GROUND, turns the HTR relay on. This causes the current to flow from the HTR (40A) fuse to
TERMINAL 5 of the HTR relay to TERMINAL 3 to TERMINAL 1 of the blower motor to TERMINAL 2 to TERMINAL 1 of
the blower resistor to TERMINAL 2 to TERMINAL (B) 6 of the A/C control assembly to TERMINAL (B) 1 to GROUND. At
this time, the blower resistance of the blower resistor is less than at low speed, so the blower motor rotates at medium
low speed.
When the blower SW is moved to M2 position, the current to TERMINAL (B) 3 of the A/C control assembly flows to
TERMINAL (B) 1 to GROUND, turns the HTR relay on. This causes the current to flow from the HTR (40A) fuse to
TERMINAL 5 of the HTR relay to TERMINAL 3 to TERMINAL 1 of the blower motor to TERMINAL 2 to TERMINAL 1 of
the blower resistor to TERMINAL 3 to TERMINAL (B) 5 of the A/C control assembly to TERMINAL (B) 1 to GROUND. At
this time, resistance of the blower resistor is less than at M1 position, so the blower motor rotates at medium high speed.
High speed operation
When the blower SW is moved to HI position, the current flows to TERMINAL (B) 3 of the A/C control assembly to
TERMINAL (B) 1 to GROUND and turns the HTR relay on.
This causes the current to flow from the HTR (40A) fuse to TERMINAL 5 of the HTR relay to TERMINAL 3 to TERMINAL
1 of the blower motor to TERMINAL 2 to TERMINAL (B) 4 of the A/C control assembly to TERMINAL (B) 1 to GROUND,
causing the blower motor to rotate at high speed.
2. Air Inlet Control Servo Motor Control
When the FRESH/RECIRC select SW is set to RECIRC, the motor in the air inlet control servo motor starts rotating to move
the damper toward the RECIRC side. The motor is continuously rotates until the damper reaches its stop position. When the
FRESH/RECIRC select SW is set to FRESH, the motor in the air inlet control servo motor starts rotating to move the damper
toward the FRESH side. The motor is continuously rotated until the damper reaches its stop position. However, when the
mode SW is at DEF position, forcibly the air intake is set to FRESH mode.
3. Air Vent Mode Control Servo Motor Control
If the mode select SW is operated, the A/C control assembly is controlled to operate the air vent mode control servo motor
and the positions of outlets change among FACE, BILEVEL, FOOT, FOOT/DEF and DEF.
4. Air Mix Control Servo Motor Control
According to the signals from various sensors, the A/C control assembly operates the air mix control servo motor and sets
the blowoff temperature to the most appropriate degree in order to adjust the temperature to the desired degree set by the
temperature control SW.
5. Air Conditioning Operation
If the A/C control SW is turned on when the blower SW is set to on, A/C operation starts.
6. Hot Gas Operation (1CDFTV)
This function uses air conditioner parts to radiate heat through an evaporator during air compression by the compressor.
Hot gas operation takes place when any of the following conditions is met:
The power heater SW is turned on.
The FRESH/RECIRC select SW is set to FRESH.
The blower SW is turned on.
The outside temperature is 0 C or below.
The water temperature is 70 C or below
MAX HOT
514
AVENSIS (EWD526E)
http://vnx.su

Service Hints
A13 (A), A14 (B) A/C Control Assembly
(A) 1, (A) 35, (B) 2, (B) 3Ground : Approx. 12 volts with the ignition SW at ON position
: Parts Location
Code
See Page
Code
40 (*4)
A25
42 (*5)
60 (*8)
A13
A14
48 (LHD)
J17
68 (RHD)
42 (*5)
44 (*6)
J27
68 (RHD)
C3
60 (*8)
60 (*8)
62 (*9)
62 (*9)
64 (*10)
64 (*10)
44 (*6)
C4
C10
66 (RHD)
68 (RHD)
49 (LHD)
P4
69 (RHD)
49 (LHD)
P5
S1
69 (RHD)
A
45 (*6)
65 (*10)
46 (LHD)
41 (*4)
66 (RHD)
43 (*5)
67 (RHD)
I14
46 (LHD)
66 (RHD)
47 (LHD)
E9
46 (LHD)
46 (LHD)
68 (RHD)
J28
64 (*10)
A
C11
66 (RHD)
A25
68 (RHD)
46 (LHD)
A23
66 (RHD)
J26
66 (RHD)
A22
48 (LHD)
J16
46 (LHD)
42 (*5)
46 (LHD)
A19
68 (RHD)
40 (*4)
66 (RHD)
66 (RHD)
40 (*4)
46 (LHD)
48 (LHD)
64 (*10)
44 (*6)
A3
See Page
J15
46 (LHD)
B6
62 (*9)
Code
66 (RHD)
B4
44 (*6)
A1
See Page
S2
45 (*6)
61 (*8)
47 (LHD)
63 (*9)
67 (RHD)
65 (*10)
66 (RHD)
J10
48 (LHD)
46 (LHD)
J11
48 (LHD)
: Relay Blocks
Code
1
6
See Page
24 (*1)
25 (*2)
29

* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
515
AVENSIS (EWD526E)
http://vnx.su

Code
See Page
CA
CB
CC
CD
34
CE
CF
CG
CJ
35
CK
DA
DB
DC
30
31
DF
DP

Code
IC1
IE1
IE2
IJ1
IK2
See Page
86 (LHD)
106 (RHD)

86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
88 (LHD)
108 (RHD)
88 (LHD)
108 (RHD)
: Ground Points
Code
IJ
IK
IL
IP
See Page
86 (LHD)
106 (RHD)

Left Kick Panel
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
Right Kick Panel
: Splice Points
Code
I6
See Page
88 (LHD)

Code
I6
See Page
108 (RHD)
516
AVENSIS (EWD526E)
http://vnx.su

Memo
517
AVENSIS (EWD526E)
http://vnx.su
Heater
10A HTR
40A HTR
RW
(LHD)
RW
GRR
(LHD)
RW
(RHD)
(RHD)
J28
Junction
Connector
(LHD)
RW
5 CE
C
4 CK
(LHD)
GRR
(LHD)
GRR
(LHD)
GRR
GRR
(RHD)
GRR
(RHD)
GRR
(RHD)
GRR
2 DF 34 DA
GRR
(LHD)
3 B
C1
C2
4 B
35 A
HRIN
Heater Amplifier
HI
1 B
WB
(RHD)
GRR
2 B
Blower SW
GND
M2
M1
5 B
6 B
A13(A), A14(B)
WB
I6
LB
WB
1 CA
HTR Relay
5
4
4 DF
7 CG
6 DC
(RHD)
2 DP
(LHD)
LB
WB
(RHD)
B4
Blower
Motor
IJ1
IJ1
IJ1
IJ1
J15
Junction
Connector
IJ
WB
LB
HI
M2
M1
LO
B6
Blower Resistor
WB
BW
WB
(RHD)
IK
518
AVENSIS (EWD526E)
http://vnx.su
1
7. 5A ECUB 2
7. 5A DEF I/UP
RW
(LHD)
IG
2 A
FRS
4 A
+B
23 A
28 A
RDEFIN
CFAN
Alternator
(1)
10 A
REC
BW
11 A
(1)
WR
FRS
RW
A21
Air Inlet Control
Servo Motor
REC
PB
1 A
RY
RW
(LHD)
RW
(RHD)
FAN NO. 3 Relay
7 CF
Engine ECU (M/T)
WR
6 CE
RW
2 CE
WR
10 CC
GW
J26
Junction
Connector
1 CB
(Gasoline)
(LHD)
RW
(RHD)
(RHD)
(RHD)
RW
RW
(LHD)
6
RW
26 A
RPTC1
(SIG1)
ALT
(EFII)
Heater Amplifier
GND
SG3
37 A
40 A
A13(A), A14(B)
S53
6 A
TPM
33 A
AOD
12 A
AOF
13 A
WB
LB
LGB
GRR
BRW
GW
WB
(LHD)
WB
(LHD)
WB
9 CG
J17
Junction
Connector
WB
GND
VZ
PT
DEF
FACE
(RHD)
WB
(RHD)
A
A
(LHD)
(RHD)
6 CA
3 CG
A25
WB
WB
(RHD)
IP
519
AVENSIS (EWD526E)
http://vnx.su
Heater
PTC1
(PTC)
MPX2
PB
9 A
HRLY
MPX+
36 A
TP
34 A
AMC
16 A
MPX
AMH
15 A
29 A
BEAN
(BODY)
14
5 A
SG2
13
BEAN
(EFI)
Heater Amplifier
S52
E9
Engine ECU (M/T)
A13(A), A14(B)
30 A
PTC2
(PTCL)
MPX1
29 (2)
21 (1CDFTV)
(1)
RY
HLP Relay
HTR2 Relay
(1)
19 A
23 (2)
20 (1CDFTV)
GND
PT
MAX
COOL
MAX
HOT
M
PB
11
MPX1
MPX2
22
PB
1
VZ
I14
Integration Relay
PL
GR
YR
YB
10 IC1
PB
1 IC1
A22
520
AVENSIS (EWD526E)
http://vnx.su
C10
Combination Meter
20 A
RW
(1)
WL
HTR1 Relay

Service Hints
A13 (A), A14 (B) A/C Control Assembly
(A)40, (B) 1Ground : Always continuity
(A) 1, (A) 35, (B) 2, (B) 3Ground : Approx. 12 volts with the ignition SW at ON position
: Parts Location
Code
A13
See Page
46 (LHD)
A14
66 (RHD)
46 (LHD)
66 (RHD)
46 (LHD)
A21
66 (RHD)
46 (LHD)
A22
66 (RHD)
A25
46 (LHD)
Code
A25
B4
B6
C10
E9
See Page
Code
66 (RHD)
46 (LHD)
66 (RHD)
46 (LHD)
66 (RHD)
46 (LHD)
I14
J15
J17
See Page
47 (LHD)
67 (RHD)
48 (LHD)
68 (RHD)
48 (LHD)
68 (RHD)
66 (RHD)
J26
68 (RHD)
47 (LHD)
J28
68 (RHD)
67 (RHD)
: Relay Blocks
Code
1
6
See Page
24 (*1)
25 (*2)
29


Code
See Page
CA
CB
CC
34
CE
CF
CG
CK
35
DA
DC
30
31
DF
DP

Code
IC1
IJ1
See Page
86 (LHD)
106 (RHD)

88 (LHD)
108 (RHD)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
521
AVENSIS (EWD526E)
http://vnx.su
Heater
: Ground Points
Code
IJ
IK
IP
See Page
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)

Left Kick Panel
Right Kick Panel
: Splice Points
Code
I6
See Page
88 (LHD)

Code
I6
See Page
108 (RHD)
522
AVENSIS (EWD526E)
http://vnx.su

Memo
523
AVENSIS (EWD526E)
http://vnx.su
Power Heater (Electrical Type)

50A
HTR2
2
3
RW
(LHD)
2 DP
GRR
RW
5 IK2
16 IK2
(LHD)
GRR
5 CE
(RHD)
GRR
J28
Junction
Connector
(RHD)
GRR
(RHD)
35
S52
SG2
36
34
16
15
PL
HRIN
TP
AMC
AMH
ALT
(EFII)
26
BW
PTC1
(PTC)
GR
BR
PTC2
(PTCL)
A13
YR
20
1 CA
BR
19
LB
WB
WL
HTR2 Relay
2 DF 34 DA
YB
HTR1 Relay
RW
BR
WL
RW
C
4 DF
GRR
WL
(LHD)
HTR Relay
6 DC
GRR
BR
RW
(RHD)
BR
I3
PTC1
PTC2
VZ
GND
PT
MAX
COOL
MAX
HOT
M
BL
13 IK2
3
M
P7
PTC Heater
(LHD)
10A HTR
50A
HTR1
40A HTR
BR
A22
EI
524
AVENSIS (EWD526E)
http://vnx.su
A11
Alternator
7. 5A
ECUB 2
40A
MAIN
RW
RW
WL
(LHD)
WL
(RHD)
10 CC
P
20 A
MPX1
7 CF
WR
2 CE
RY
H
PTC1
11 B
MPX2
21 A
RW
J 3(A), J 4(B)
Junction
Connector
(LHD)
RW
(RHD)
E A
30
28
HRLY
RPTC1
(SIG1)
PB
GND
A13
40
MPX+
13
BEAN
(EFI)
MPX
BEAN
(BODY)
29
14
PB
+B
RW
IG
RY
WR
D B
C10
Combination
Meter
3 CG
J17
Junction
Connector
I14
Integration Relay
WB
(LHD)
WB
(RHD)
10 IC1
11
MPX1
MPX2
22
1 IC1
PB
WB
(LHD)
WB
PB
6 CA
(RHD)
J26
Junction
Connector
3
HLP Relay
E 9(A), E10(B)
Engine ECU (M/T)
1 CB
WR
RW
(LHD)
J15
Junction
Connector
IK
IP
525
AVENSIS (EWD526E)
http://vnx.su
Power Heater (Electrical Type)

Service Hints
HTR1 Relay
HTR2 Relay
: Parts Location
Code
See Page
44 (*6)
A11
E9
64 (*10)
46 (LHD)
A13
Code
46 (LHD)
A22
B
I14
66 (RHD)
46 (LHD)
C10
E10
66 (RHD)
See Page
J3
66 (RHD)
47 (LHD)
67 (RHD)
Code
J4
See Page
B
48 (LHD)
68 (RHD)
47 (LHD)
J15
68 (RHD)
67 (RHD)
J17
68 (RHD)
47 (LHD)
J26
68 (RHD)
67 (RHD)
J28
68 (RHD)
48 (LHD)
68 (RHD)
P7
49 (LHD)
69 (RHD)
: Relay Blocks
Code
See Page
25 (*2)
26
26
29

Code
See Page
CA
CB
CC
34
CE
CF
CG
35
DA
DC
30
31
DF
DP

Code
IC1
IK2
See Page
86 (LHD)
106 (RHD)
88 (LHD)
108 (RHD)

: Ground Points
Code
EI
See Page
84 (*6)
104 (*10)

Near the Starter
IK
106 (RHD)
IP
86 (LHD)
Right Kick Panel
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
526
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
: Splice Points
Code
I3
See Page
88 (LHD)

Engine Wire
Code
I3
See Page
108 (RHD)

Engine Wire
527
AVENSIS (EWD526E)
http://vnx.su
Power Heater (Combustion Type)

10A
HTR
25A
PWR HTR
2
1
RW
6 DC
P1
1 CB
5
+
RW
12 CK
WB
F/P
GY
3 EE1
WB
GY
4
L
WB
A11
Alternator
J15
Junction
Connector
IK
EC
528
AVENSIS (EWD526E)
http://vnx.su
WB
F17
Fuel Pump
12 IE6
J2
Junction
Connector
ALT+L
IN
GY
SW
WB
P5
Power Heater SW
IG
Service Hints
P1 Power Heater Assembly
3Ground : Approx. 12 volts with the ignition SW at ON position and power heater SW on
: Parts Location
Code
See Page
Code
See Page
Code
See Page
A11
44 (*6)
J2
45 (*6)
P1
45 (*6)
F17
44 (*6)
J15
48 (LHD)
P5
49 (LHD)
: Relay Blocks
Code
1
See Page
25 (*2)


Code
See Page
CB
34
CK
35
DC
30


Code
See Page
EE1
84 (*6)
IE6
86 (LHD)
: Ground Points
Code
See Page
EC
84 (*6)
IK
86 (LHD)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
* 6 : LHD 1CDFTV
529
AVENSIS (EWD526E)
http://vnx.su
I GROUND POINT
WB
E4
WB
E4
BR
E4
(E01)
(E03)
BR
BR
(E01)
Engine and
ECT ECU (A/T)
Engine ECU (M/T)
(E04)
(E05)
E
B
E
B
WB
BR
Combination SW
J12(A), J13(B)
Junction Connector
(1AZFSE)
BR
WB
BR
WB
WB
E
A
D
B
(Unleaded Gasoline)
E
B
WB
(Unleaded Gasoline)
BR
D
B
(1AZFE)
E
B
BR
(SG)
DLC3
J12(A), J13(B)
Junction Connector
BR
BR
ISC Valve
BR
D
B
WB
EE
(E1)
D
B
WB
(E02)
E
A
E 3 : LHD
I 3 : RHD
WB
EE
(EOM)
Ignition Coil and

Igniter No. 4
BR
(E02)
WB
WB
Ignition Coil and

Igniter No. 1
WB
Ignition Coil and

Igniter No. 2
WB
Ignition Coil and

Igniter No. 3
WB
Ignition Coil and

Igniter No. 4
WB
WB
(1AZFE)
EF
E4
WB
(E1)
Ignition Coil and

Igniter No. 3
BR
BR
Engine and
ECT ECU (A/T)
Engine ECU (M/T)
WB
WB
BR
(EOM)
Ignition Coil and

Igniter No. 2
(1AZFSE)
EF
(ME01)
WB
BR
(SG)
Ignition Coil and

Igniter No. 1
WB
DLC3
BR
WB
E 5 : LHD
E 4 : RHD
14
IK2
WB
WB
Electronic
Driver Unit
E4
530
AVENSIS (EWD526E)
http://vnx.su
BR
WB
(E03)
Engine and
ECT ECU (A/T)
Engine ECU
(M/T)
E4
WB
WB
(E02)
Ignition Coil and

Igniter No. 1
WB
Ignition Coil and

Igniter No. 2
WB
Ignition Coil and

Igniter No. 3
WB
Ignition Coil and

Igniter No. 4
WB
(E1)
WB
EH
E4
(1ZZFE, 3ZZFE)
WB
(E01)
14
IK2
BR
BR
(SG)
WB
EG
ISC Valve
(1ZZFE, 3ZZFE)
BR
HTR2 Relay
(E1)
BR
I3
I3
Throttle
Position SW
WB
Electronic
Driver Unit
WB
BR
Engine Oil Level

Sensor
BR
Fuel Filter
Warning SW
WB
Fuel Heater
WB
(1CDFTV)
EI
E
A
WB
(E01)
WB
I3
BR
BR
WB
BR
I3
WB
(E02)
BR
BR
HTR1 Relay
D
B
I3
BR
(EOM)
Engine ECU
(M/T)
(SG)
DLC3
D
B
E
B
BR
Glow Plug Relay
Engine ECU
(M/T)
DLC3
E
B
BR
E
B
BR
Combination SW
J12(A), J13(B)
Junction Connector
531
AVENSIS (EWD526E)
http://vnx.su
I GROUND POINT
WB
Headlight Cleaner
Control Relay
WB
E1
WB
Water Temp. SW
(Radiator Fan)
WB
WB
E1
(w/o HID)
WB
WB
Headlight Cleaner
Control Motor
WB
(w/ HID)
WB
EB
EA
WB
(w/o HID)
E1
(w/o HID)
Front Side Turn

Signal Light RH
WB
Front Clearance
Light RH
WB
E2
E1
E2
E2
E2
E2
WB
(1)
E2
WB
J2
Junction
Connector
WB
E2
(w/ HID)
WB
WB
WB
(w/o HID)
Radiator Fan
Resistor
Brake Fluid Level

Warning SW
EFI Relay
WB
IG2 Relay
WB
Headlight LH (High)
(1)
WB
A/F Relay
WB
Front Clearance
Light LH
E2
WB
Front Fog Light LH
E2
WB
(1AZFSE, 1AZFE)
WB
WB
EC
WB
FHTR Relay
EFI MAIN Relay
WB
WB
WB
WB
WB
WB
Radiator Fan Motor
WB
WB
WB
E2
FAN NO. 2 Relay
Engine Hood
Courtesy SW
WB
WB
A
Power Heater
Assembly
WB
WB
WB
E2
Headlight LH (Low)
Front Turn Signal

Light LH
WB
Headlight Control
ECU LH
WB
WB
WB
D
Front Wiper Motor
Front Side Turn

Signal Light LH
WB
E1
E2
Front Window Deicer
WB
WB
Headlight RH (High)

Control Actuator LH
WB
E1
WB
Front Fog Light RH
(GND2)
Skid Control
ECU with
Actuator
WB
WB
WB
Front Turn Signal

Light RH
(GND1)
E1
WB
Headlight RH (Low)
WB
WB
WB
Headlight Control
ECU RH
WB
E1
ED
E2
WB
E2
WB
Fuel Pump
WB
(1ZZFE, 3ZZFE)
WB
IM
532
AVENSIS (EWD526E)
http://vnx.su
EPS ECU
I
WB
Luggage Compartment
Door Lock Motor
Luggage Compartment
Light SW
WB
(S/D)
4
BG1
WB
WB
Luggage Compartment
Door Opener SW
(W/G)
C
WB
A
B
B A
J30(A), J31(B)
Junction
Connector
WB
C B
C B
C B
WB
2 BD1 (L/B)
4 BF1 (W/G)
WB
A
B
WB
WB
WB
BT
BS
(L/B)
WB
BW
2 BE1
(w/o Power Seat)

WB
(Gasoline)

(Front Passenger' s
Seat)
WB
WB
(LHD)
(E1)
Lumbar Support
Control SW
(E2)
WB
(RHD)
WB
(RHD)
WB
(w/ Power Seat)
10
BA1
F
B
F
B
Power Seat Control

SW (Driver' s Seat)
F
B
WB(LHD)
F
B
WB(LHD)
WB
(w/ Power Seat)
J35(A), J36(B)
Junction
Connector
BR
F
B
WB(LHD)
WB
WB
B2
B2
H
A
J37(A), J38(B)
Junction Connector
WB
WB
10 BC1
(w/ Power Seat)

BV
Door Unlock
Detection SW
Rear LH
Double Lock
Position SW
Rear LH
Power Window Motor

Rear LH
B8
WB
BU
Door Unlock
Detection SW
Rear RH
Double Lock
Position SW
Rear RH
WB

SW Rear RH
WB
Power Window Motor

Rear RH
WB
WB
Seat Heater LH
WB
WB
(LHD)
WB
(E2)
Power Window
Control SW Rear LH
WB
WB
Lumbar Support
Control SW
WB
BQ
B8
Seat Heater RH
WB
(E1)
WB
(RHD)
F
B
F
B
H
A
WB

(Driver' s Seat)
F
B
WB
WB

(Front Passenger' s
Seat)
WB
Fuel Pump
WB(RHD)
BX
WB
Seat Heater LH
Back Door
Courtesy SW
Back Door
(ACT) Lock Motor
(L/B)
Rear Combination
Light RH
WB
WB
(W/G)
3 BG1
Rear Combination
Light LH
(E)
J33(A), J34(B)
Junction
Connector
WB
WB
WB
(W/G)
(S/D)
WB
License Plate
Light LH
A
B
(L/B, W/G)
(S/D)
WB
A
B
WB
License Plate
Light RH
(L/B, W/G)
WB
(S/D)
B A
J32
Junction
Connector
Theft Warning Siren
High Mounted
Stop Light
(L/B, W/G)
WB
B A
WB
Seat Heater SW
A
A
(S/D)
A
B
(L/B, W/G)
WB
A
A
WB
WB
WB
High Mounted
Stop Light
Buckle SW (Front
Passenger' s Side)
Occupant Detection
Sensor
L
(W/G)
(S/D)
Buckle SW (Front
Passenger' s Side)
Occupant Detection
Sensor
Seat Heater RH
Back Door Opener SW
WB(L/B)
533
AVENSIS (EWD526E)
http://vnx.su
I GROUND POINT
Combination Meter
(E)
Front Wiper
Deicer SW
(ILL)
Remote Control
Mirror SW
(E)

Transponder Key
Computer
(E)
6
CK
WB
4
CJ
WB
5
CJ
11
CF
WB
WB
6
CI
12
CF
WB
WB
8
CD
9
CG
WB
5
CI
2
CI
WB
WB
10
CJ
11
CE
WB
WB
11
CJ
3
CH
WB
WB
4
CG
8
CH
WB
5
CG
9
CD
WB
10
CE
WB
13
CF
WB
TRC Off SW
(ILL)
6
CJ
1
4
IG1 IG2
(3) (2)
WB
WB
WB
(E)
ECT Pattern
Select SW
(ILL)
4
IJ1
WB
Kick Down SW
WB
Blower Resistor
Control SW
(TL)
Hazard SW
(ILL)
(6)
MultiDisplay
WB
(GND1)
(6)
Front Passenger' s
Seat Belt Warning
Light
SW
Security Indicator
Light
9
CH
WB
(GND)
MultiDisplay
(GND)
10
CH
WB
(6)
WB
(4)
A/C Control
Assembly
WB
A/C Control
Assembly
WB
(5)
(GND)
(Except 5)
(SNSE)
J15
Junction Connector
A
WB
WB
Wiper Relay
(TL)
Power Heater SW
WB
(ILL)
(7)
Shift Lock
Control ECU
WB
Remote Controller
(Navigation)
WB
Cigarette Lighter
Cigarette Lighter
Illumination
WB
WB
33
DA
2
II1
WB
WB
4
IJ2
WB
(5)
WB
(5)
WB
WB
WB
(LHD)
IP
534
AVENSIS (EWD526E)
http://vnx.su
9
IL1
WB
B7
Blower Motor
Controller
(GND) A/C Control
Assembly
(Except 5)
MultiDisplay
WB
IK
WB
WB
J17
Junction
Connector
Navigation
ECU

: 1AZFSE
: Except 1AZFSE
: w/ MultiDisplay w/o Navigation System (Map Type)
: Automatic A/C
: w/ Navigation System (Map Type)
: Power Heater (Combustion Type)
WB
(ILL)
SEAT HTR Relay

Control ECU
(7)
Transmission
Control SW
Power Outlet
Glove Box Light
6 CA
WB
(E)
1
2
3
4
5
6
7
8
3
CG
WB
Navigation ECU
(ILL)
Mirror Heater RH
WB
Power Window Motor

Front RH
WB

SW (Front
Passenger Side)
I
WB
Interior Light
WB
B5
WB
Personal Light
WB
B5
WB
Vanity Light RH
WB
B5
WB
Vanity Light LH
WB
WB
B5
6
DK
WB
Moon Roof Control SW
WB
Inner Mirror
2
BB1
WB
Moon Roof Control

Relay and Motor
B5
WB
1
DP
WB
Noise Filter (Rear

Window Defogger No. 1)
HTR Relay
P/POINT Relay
21
DA
WB
4 DF
Integration Relay
WB
IG1 Relay
ST Relay
WB
16
DA
WB
2
DJ
B1
WB
(EF)
WB
WB
(E2)
3
DD
Door Key Lock and

Unlock SW
(Driver' s Side)
SW (Driver' s Side)
WB
Power Window Motor

Front LH
WB
Door Lock
Control SW
Power Window
Master SW
WB
B1
Airbag Sensor
Assembly
Combination
SW
4
DD
WB
(E1)
WB
WB
9 IA1
B1
WB
Mirror Heater LH
9 DA
Unlock Warning SW
Turn Signal Flasher
Relay
Combination SW
(TB)
Combination Meter
DLC3
WB
WB
WB
WB
WB
WB
(LHD)
IJ
J16
Junction
Connector
WB
Combination Meter
WB
WB
(EL)
Combination SW
Combination SW
WB
(1)
(CG)
(E)
WB
WB
IL : LHD 1CDFTV
IO : LHD Gasoline
(LHD)
(8)
Power Heater SW
(ILL)
WB
BR
(8)
(LHD)
Radio and Player
IN
535
AVENSIS (EWD526E)
http://vnx.su
I GROUND POINT
Combination
SW
(EF)
Combination Meter
Remote Control
Mirror SW
(E)
Theft Deterrent ECU
Unlock Warning SW
Navigation
ECU
(SNSE)
(ILL)
WB
6
CG
WB
6
CK
8
CH
WB
WB
8
CD
9
CH
WB
WB
9
CG
3
CB
WB
WB
13
CF
5
CI
WB

Control SW
WB
7
CK
9
CD
WB
Turn Signal Flasher

Relay
WB
4
CG
2
CI
WB

Control ECU
5
CG
11
CF
WB
10
CH
5
CD
WB
(6)
MultiDisplay
(GND1)
Navigation
ECU
(GND)
MultiDisplay
(GND)
WB
(6)
WB
(6)
6 CA
(4)
WB
(10)
WB
WB
WB
WB
WB
WB
WB
B7
(10)
WB
B7
(RHD)
(9)
WB
IP
Hazard SW
(ILL)
WB
B7
(E)
J16
Junction Connector
WB
WB
Transponder Key
Computer
WB
Power Heater SW
(ILL)
Cigarette Lighter
Cigarette Lighter
Illumination
(E)
WB
WB
WB
WB
WB
WB
TRC Off SW
(ILL)
(ILL)
(CG)
DLC3
(TB) Combination SW
Door Key Lock and

Unlock SW
(Driver' s Side)
Door Unlock
Detection SW
(Driver' s Side)
Double Lock
Position SW
(Driver' s Side)
WB
WB
WB
WB
(TL)
ECT Pattern
Select SW
WB
9
IL1
Front Passenger' s
Seat Belt
Warning Light
SW
Security Indicator
Light
(E)
WB
IL
(RHD)

5 : Automatic A/C
536
AVENSIS (EWD526E)
http://vnx.su
IN
(RHD)
Door Key Lock and

Unlock SW
(Driver' s Side)
Door Unlock
Detection SW
(Driver' s Side)
Power Window Motor

Front RH
Mirror Heater RH
Door Lock
Control SW
Power Window
Master SW
(EL) Combination SW
Combination SW
Radio and Player
I
WB
WB
B5
Interior Light
WB
Vanity Light LH
WB
WB
B5
Personal Light
WB
WB
WB
B5
Vanity Light RH
WB
Inner Mirror
WB
Theft Warning
Ultrasonic Sensor
B5
J15
Junction
Connector
2 BB1
WB
Moon Roof Control

Relay and Motor
6 DK
P/POINT Relay
(E1)
Airbag Sensor
Assembly
21
DA
WB
4
DD
WB
WB
WB
(5)
4
IJ2
(GND)
WB
(5)
A/C Control
Assembly
Blower Motor
Controller
(RHD)
IK
9
DA
1
DP
WB
Noise Filter (Rear

Window Defogger No. 1)
IG1 Relay
WB
HTR Relay
4 DF
WB
(E)
Transmission
Control SW
(ILL)
WB
WB
WB
WB
Glove Box Light
WB
9 IA1
IJ
Shift Lock Control

ECU
WB
Remote Controller
(Navigation)
WB
J17
Junction Connector
WB
Combination Meter
WB
4
IJ1
WB
WB
(RHD)
B1
WB
Power Window Motor

Front LH
WB

SW (Front Passenger
Side)
WB
A
WB
(Except 5)
WB
WB
(GND)
WB
(5)
WB
B1
WB
2
II1
Door Unlock
Detection SW
(Front Passenger' s
Side)
Double Lock
Position SW
(Front Passenger' s
Side)
WB
B1
WB
A/C Control
Assembly
Blower Resistor
MultiDisplay
WB
Integration Relay
A/C Control
Assembly
Wiper Relay
(Except 5)
2
DJ
WB
3
DD
WB
(E2)
ST Relay
WB
WB
WB
WB
WB
Mirror Heater LH
Power Outlet
537
AVENSIS (EWD526E)
http://vnx.su
I GROUND POINT
: Parts Location
Code
See Page
J12
J13
41 (*4)
53 (LHD L/B)
43 (*5)
55 (LHD W/G)
J15
J16
See Page
53 (LHD L/B)
J33
55 (LHD W/G)
73 (RHD L/B)
75 (RHD W/G)
59 (*7)
73 (RHD L/B)
53 (LHD L/B)
61 (*8)
75 (RHD W/G)
63 (*9)
51 (LHD S/D)
65 (*10)
53 (LHD L/B)
48 (LHD)
55 (LHD W/G)
J31
71 (RHD S/D)
48 (LHD)
73 (RHD L/B)
68 (RHD)
75 (RHD W/G)
48 (LHD)
51 (LHD S/D)
68 (RHD)
53 (LHD L/B)
48 (LHD)
55 (LHD W/G)
68 (RHD)
J17
J30
Code
71 (RHD S/D)
68 (RHD)
See Page
51 (LHD S/D)
45 (*6)
J2
Code
39 (*3)
J32
71 (RHD S/D)
48 (LHD)
73 (RHD L/B)
68 (RHD)
75 (RHD W/G)
J34
55 (LHD W/G)
73 (RHD L/B)
75 (RHD W/G)
J35
J36
J37
J38
56 (LHD)
76 (RHD)
56 (LHD)
76 (RHD)
56 (LHD)
76 (RHD)
56 (LHD)
76 (RHD)
: Relay Blocks
Code
1
See Page
24 (*1)
25 (*2)

26
26
27
28 (LHD)
28 (RHD)

Code
See Page
CA
CB
CD
34
CE
CF
CG
CH
CI
35
CJ
CK
DA
DD
30
DK
31
DP
31
DF
DJ
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
538
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
I
Code
IA1
IG1
IG2
II1
IJ1
IJ2
IK2
IL1
See Page
86 (LHD)
106 (RHD)
88 (LHD)
88 (LHD)
108 (RHD)

88 (LHD)
108 (RHD)
88 (LHD)
108 (RHD)
88 (LHD)
108 (RHD)
88 (LHD)
108 (RHD)
90 (LHD S/D)
92 (LHD L/B)
BA1
94 (LHD W/G)
110 (RHD S/D)
112 (RHD L/B)

114 (RHD W/G)
90 (LHD S/D)
92 (LHD L/B)
BB1
94 (LHD W/G)
110 (RHD S/D)
112 (RHD L/B)

114 (RHD W/G)
90 (LHD S/D)
92 (LHD L/B)
BC1
94 (LHD W/G)
110 (RHD S/D)
112 (RHD L/B)

114 (RHD W/G)
BD1
BE1
BF1
BG1
92 (LHD L/B)
112 (RHD L/B)
92 (LHD L/B)
112 (RHD L/B)
94 (LHD W/G)
114 (RHD W/G)
94 (LHD W/G)
114 (RHD W/G)
539
AVENSIS (EWD526E)
http://vnx.su
I GROUND POINT
: Ground Points
Code
See Page
78 (*3)
80 (*4)
82 (*5)
EA
84 (*6)
98 (*7)
100 (*8)
102 (*9)
104 (*10)
78 (*3)
80 (*4)
82 (*5)
EB
84 (*6)
98 (*7)
100 (*8)
102 (*9)
104 (*10)
78 (*3)
80 (*4)
82 (*5)
EC
84 (*6)
98 (*7)
100 (*8)
102 (*9)
104 (*10)
78 (*3)
80 (*4)
82 (*5)
ED
84 (*6)
98 (*7)
100 (*8)
102 (*9)
104 (*10)
78 (*3)
EE
80 (*4)
98 (*7)
100 (*8)
78 (*3)
EF
80 (*4)
98 (*7)
100 (*8)
EG
EH
EI
IJ
IK
82 (*5)
102 (*9)
82 (*5)
102 (*9)
84 (*6)
104 (*10)
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
Near the Starter

Left Kick Panel
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
540
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
I
: Ground Points
Code
IL
IM
IN
IO
IP
See Page
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
106 (RHD)
86 (LHD)
86 (LHD)
106 (RHD)

Right Kick Panel
90 (LHD S/D)
92 (LHD L/B)
BQ
94 (LHD W/G)
110 (RHD S/D)
112 (RHD L/B)
114 (RHD W/G)
90 (LHD S/D)
92 (LHD L/B)
BR
94 (LHD W/G)
110 (RHD S/D)
112 (RHD L/B)
114 (RHD W/G)
90 (LHD S/D)
92 (LHD L/B)
BS
94 (LHD W/G)
110 (RHD S/D)
112 (RHD L/B)

114 (RHD W/G)
90 (LHD S/D)
92 (LHD L/B)
BT
94 (LHD W/G)
110 (RHD S/D)
112 (RHD L/B)
114 (RHD W/G)

90 (LHD S/D)
92 (LHD L/B)
BU
94 (LHD W/G)
110 (RHD S/D)
112 (RHD L/B)
114 (RHD W/G)
90 (LHD S/D)
92 (LHD L/B)
BV
94 (LHD W/G)
110 (RHD S/D)
112 (RHD L/B)
114 (RHD W/G)
BW
90 (LHD S/D)
110 (RHD S/D)
Right Quarter Panel
92 (LHD L/B)
BX
94 (LHD W/G)
112 (RHD L/B)
114 (RHD W/G)
541
AVENSIS (EWD526E)
http://vnx.su
I GROUND POINT
: Splice Points
Code
See Page
Code
78 (*3)
80 (*4)
B1
82 (*5)
E1
114 (RHD W/G)

90 (LHD S/D)
100 (*8)
92 (LHD L/B)
78 (*3)
B2
90 (LHD S/D)
84 (*6)
92 (LHD L/B)
98 (*7)
B5
B1
94 (LHD W/G)
110 (RHD S/D)
102 (*9)
112 (RHD L/B)
104 (*10)
114 (RHD W/G)
78 (*3)
90 (LHD S/D)
78 (*3)
92 (LHD L/B)
B7
82 (*5)
98 (*7)
94 (LHD W/G)
110 (RHD S/D)
90 (LHD S/D)
92 (LHD L/B)
B8
108 (RHD)
92 (LHD L/B)
Front Door LH Wire
Rear Door No.2 Wire
Roof Wire
Front Door RH Wire
114 (RHD W/G)
78 (*3)
88 (LHD)
Front Door LH Wire
112 (RHD L/B)
Engine Wire
102 (*9)
90 (LHD S/D)
112 (RHD L/B)

114 (RHD W/G)
100 (*8)
I3
110 (RHD S/D)
82 (*5)
80 (*4)
E5
94 (LHD W/G)
80 (*4)
100 (*8)
E4
112 (RHD L/B)
98 (*7)
104 (*10)
E3
110 (RHD S/D)
84 (*6)
102 (*9)
E2
See Page
94 (LHD W/G)
94 (LHD W/G)
110 (RHD S/D)
Rear Door No.1 Wire
112 (RHD L/B)

114 (RHD W/G)
* 1 : Gasoline
* 2 : 1CDFTV
* 3 : LHD 1AZFSE
* 4 : LHD 1AZFE
* 7 : RHD 1AZFSE
* 8 : RHD 1AZFE
* 10 : RHD 1CDFTV
542
AVENSIS (EWD526E)
http://vnx.su
* 6 : LHD 1CDFTV
Memo
543
AVENSIS (EWD526E)
http://vnx.su
K CONNECTOR LIST
A1
A2
A3
Gray
Black
Black
1 2
A4
1 2 3
1
A5
A6
A7
A8
A9
A10
Black
Gray
Gray
Yellow
Yellow
1 2
3 4
1 2 3 4 5
A11
A12
A12
Black
(Except 1CDFTV)
(1CDFTV)
1
1
A13
A14
1
4
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40
A16
A17
A18
Black
Black
12
1 2 3
2
5
A15
3
6
1 2 3 4 5 6 7 8 9 10
11 12 13 14 15 16 17 18 19 20
A19
A20
Black
12
1 2 3 4 5 6 7 8 9 10 11 12
1
4
2
5
3
6
13 14 15 16 17 18 19 20 21 22 23 24
A21
A22
A23
A24
A25
Black
Black
Black
Black
Black
1 2 3 4 5
1 2 3 4 5
1 2 3 4 5
1 2 3 4 5
1 2 3
556
AVENSIS (EWD526E)
http://vnx.su
K
*1 : 1AZFSE, 1AZFE
A26
A27
A28
A29
Yellow
Yellow
Yellow
Yellow
A B
1 2
3 4
A B
1 2 3
4 5 6
A B
1 2
1 2 3 4
3 4
5 6 7 8 9 101112
7 8 9 1011121314151617
5 6 7 8 9 101112
13 1415 16 171819 20
1819 2021 22 23 2425 26 27 28
13 1415 16 171819 20
A30
A31
A32
A33
Yellow
2 1
1 2 3 4
B3
B4
Black
B1
B2
Gray
Black
2 1
1 2 3
B5
B6
B7
B7
Black
Black
(L/B)
(W/G) Blue
1 2
3 4
1 2
3 4
1 2
B8
B9
B10
Gray
2 1
C3
C4
Gray
1
1
1 2
3 4
1 2
3 4
C1
C2
Black
Black
1 2
1 2
C5
C6
C6
Black
(*1) Gray
(1CDFTV) Black
C6
C7
(1ZZFE, 3ZZFE) Black
Black
1 2
1 2
3 4
1 2
C8
C9
C10
Blue
3
5
1 2
1 X 2
1 2 3 4 5 6 7 8 9
10 11 12 13 14 15 16 17 18
557
AVENSIS (EWD526E)
http://vnx.su
K CONNECTOR LIST
C11
C12
C13
Black
1 2 3 4 5 6 7 8 9 10 11
1 2 3 4 5 6 7 8 9
12 13 14 15 16 17 18 19 20 21 22
9 10 1112131415 16 17
10 11 12 131415 16 17 18
C14
4 5 6 7
C15
C16
C17
C18
Yellow
Yellow
Black
Black
1 2
1 2
1 2
1 2
1 2 3 4 5 6
7 8 9 10 11 12
D1
D2
Black
1 2 3
1
4
2
5
D3
D4
D4
Black
(Except 1CDFTV)
(1CDFTV)
1 2
1 2
1 2 3
3
6
D5
D6
D7
D8
D9
1 2 3 4 5
16 15 14 13 12 11 10 9
8 7 6 5 4 3 2 1
D10
D11
D12
D13
D14
5 6 7 8 9 10
D16
5 6 7 8 9 10
558
AVENSIS (EWD526E)
http://vnx.su
D19
5 6 7 8 9 10
13 14 15 16 17 18 19 20 21 22 23 24
5 6 7 8 9 10
D18
1
1 2 3 4 5 6 7 8 9 10 11 12
5 6 7 8 9 10
D17
D15
5 6 7 8 9 10
K
D20
D21
E1
E2
E2
(Except 1AZFE) Gray (1AZFE) Gray
Gray
1 2
1
5 6 7 8 9 10
5 6 7 8 9 10
9 10
1 2
E3
E4
E5
E5
Black
Black
(1AZFSE) Black
(1CDFTV) Dark Gray
1
4
2
5
1 2 3 4 5
3
6
E6
E7
E8
Black
Gray
Black
1 2
3
1 2 3 4
5 6 7 8
1 2
E9
1 2 3 4
8 9 10 11 12 13 14 15 16 17
E10
18 19 20 21 22 23
24 25
26 27
30 31
28 29
E11
E12
7 8 9 10 11 12 13 14 15 16
8 9 10 11 12 13 14 15 16 17
8 9 10 11 12 13 14 15 16 17 18 19
17 18 19 20 21 22 23 24 25 26 27
18 19 20 21 22 23 24 25 26 27
20 21 22 23
24 25
26 27
28 29 30
28 29
28 29 30 31
32 33
34 35
31 32 33 34 35
E13
E14
30
31 32
E15
Gray
8 9 10 11 12 13 14 15 16 17
18 19 20 21 22 23 24 25 26 27
28 29 30 31 32
1 2 3 4 5 6
F1
F2
Black
Black
7 8 9 10 11 12
2
33 34
559
AVENSIS (EWD526E)
http://vnx.su
K CONNECTOR LIST
F3
F4
F5
F6
Brown
Brown
Gray
Gray
1 2
1 2
F9
F10
F7
F8
1 2
3 4
1 2
3 4
F11
F12
F13
Black
Black
Gray
2 1
1 2
3 4
1 2
3 4
1 2 3
1 2
4 5
F14
F15
F16
F16
F17
Gray
Gray
(1AZFSE) Gray
(1CDFTV) Black
Black
1
1
F18
1 2
3
F19
Gray
1 2
F24
1 2
F21
F22
F23
Black
Black
Black
Black
1
2
1
2
3 4 5 6
F25
F20
1
1 2 3 4 5 6 7 8
G1
Gray
G2
G3
Gray
Black
1
1 2 3 4
2
4
3
5
H1
H2
H3
H4
Gray
Gray
Black
Black
H5
1
2
3
2
3
1 2
560
AVENSIS (EWD526E)
http://vnx.su
K
H6
H7
H7
H8
H9
H10
(1AZFSE) Gray
(1ZZFE, 3ZZFE) Gray
Black
Gray
Black
1 2
3 4
1
2
1 2
3 4
H11
H12
H13
Black
Black
Black
H14
H15
1
1 2
3 4
1 2 3 4 5
5 6 7 8 9 10
1 2 3 4 5 6 7 8 9 10 11 12
13 14 15 16 17 18 19 20 21 22 23 24
H16
H17
H18
H19
H20
H20
Black
Gray
Black
Black
(L/B)
(S/D) Gray
1234
12
1
3
2
4
2 1
H20
I1
I2
I3
I4
(W/G) Black
Black
Gray
Black
Gray
1 2 3 4
1 2 3 4
1 2 3 4
1 2 3 4
I5
I5
I6
I6
I7
(Except 1AZFSE) Black
(1AZFSE) Black
(Except 1AZFSE) Gray
(1AZFSE) Gray
(Except 1AZFSE) Black
1 2
1 2
1
1 2
I7
I8
I8
I9
I10
(1AZFSE) Black
(1AZFSE) Gray
Gray
Black
1 2
1
I11
I12
Black
Black
2 3 4 5 6
2 3 4 5 6
1 2 3
I13
1
4
2
5
3
6
561
AVENSIS (EWD526E)
http://vnx.su
K CONNECTOR LIST
I14
I15
I16
J1
Gray
Black
1 2 3 4 5 6 7 8 9 10 11
A A B
CC
A A B B B CC
1 2 3 4
1 2 3 4 5 6 7
12 13 14 15 16 17 18 19 20 21 22
J2
J3
J4
J5
A A B B C C
A A B B C C
A B B
C C
A A B D D D C C
D D D E E E
D D D E E E
Black
A A A
B B
CCCDD DB
J6
J7
J8
Black
A A B B C C C D D E E
F F F F G G G H H H H
J9
J10
J11
Black
Gray
Gray
J12
J13
J14
A A B B C C
A A B B C C
A B B
C C
A A B DD D C C
D D D E E E
D D D E E E
J15
A
A
J16
J17
J18
A A A
A A
A A A A A A A A
A A A
A A
A A A A A A A A
A A A B B B B C C C C
A
A
D D D E E E E F F F F
J19
J20
J21
562
AVENSIS (EWD526E)
http://vnx.su
K
J22
J23
J24
J25
A A B B C C
A A B B C C
A A B B C C
A A B B C C
D D E E F F
D D E E F F
D D E E F F
D D E E F F
J26
J27
J28
A B B
C C
A A B D D D C C
J29
J30
J31
J32
A A A B B B C C C C C
A A A A A A
A A A A A A
A B B
C C
A A B DD D C C
D D D D E E E E E E E
B B B C C C
B B B C C C
J33
J34
J35
J36
A A A A A A
A A A A A A
A A B C D E
A B C D E E
B B B C C C
B B B C C C
F G H H H H
F F F F G H
J37
J38
K1
K2
K3
Black
Black
Yellow
1 2
A A B C D E
A B C D E E
F G H H H H
F F F F G H
1
1
L1
L2
L3
Black
Black
Black
1 2
1 2
L4
L5
1
1 2 3
L6
2
1 2
2 1
563
AVENSIS (EWD526E)
http://vnx.su
K CONNECTOR LIST
*2 : w/ Navigation System (Map Type)
*3 : w/o Navigation System (Map Type)
L7
1 2 3 4 5
M1
M1
M2
(*2)
(*3)
(*2)
1 2 3 4 5 6 7 8 9 101112 13
1 2 3 4 5 6 7 8 9
1 2 3 4 5
10 11 12 13 14 15 16 17 18
6 7 8 9 10
14 15 16171819
M2
*4 : Power Heater (Combustion Type)

*5 : Power Heater (Hot Gas Type)
2021222324 25
M3
M4
M5
M6
Gray
(*3)
1 2 3
2 1
2 1
3 7 6
4 5 6
3 7 6
5 4
1 2 3 4 5
5 4
6 7 8 9 10
M7
1 2
3 4
N1
N2
Gray
Gray
N3
1 2 3 4 5 6 7 8 9
1 2
1
3
7
N4
4
8
10 11 12 13 14 15 16 17 18
5
9
N5
N6
N7
N8
O1
Black
1 2 3 4 5
1 2
1 2 3 4
5 6 7 8
6 7 8 9 10
1 2
1 2
O2
P1
P2
P3
P4
P5
Gray
Black
Black
Gray
Black
(*4) Gray
12
1 2 3 4
3 4 5 6
5 6 7 8
P5
P6
(*5)
Black
3 4 5 6
P7
P8
P9
P10
1 2 3 4
1 2 3 4
5 6 7 8
5 6 7 8
1
2
1 2 3 4
1
564
AVENSIS (EWD526E)
http://vnx.su
K
P11
1 2 3 4
P12
P13
P14
P15
Gray
Gray
Gray
Gray
1 2 3
4 5 6
1 2 3
4 5 6
1 2 3
4 5 6
1 2 3
4 5 6
5 6 7 8
P16
P17
P18
P19
Yellow
Yellow
Black
Black
P21
1 2
3 4
1 2
5 6 7 8 9 10
P22
P23
Black
1 2
P24
1 2
3 4
5 6 7 8 9 10
Blue
1 2
P20
1 2
1 2
P25
R1
Blue
Gray
1 2
1
R2
R3
Black
Red
R4
1 2
R5
3 4
5 6 7 8 9 10
1 2
1
R6
3 4 5 6
1 2 3 4 5 6
7 8 9 10 11 12
R7
R8
1 2 3 4 5 6 7 8 9 10
11 12 13 14 15 16 17 18 19 20
R11
1 2 3 4 5
R9
3
5
3
5
1 X 2
1 X 2
R10
1 2 3 4 5 6 7 8 9 10
R12
R13
R13
Black
(Except W/G) Black
(W/G)
1 2 3 4 5 6
3 2 1
1 2 3 4 5 6 7
565
AVENSIS (EWD526E)
http://vnx.su
K CONNECTOR LIST
*1 : 1AZFSE, 1AZFE
*6 : 1AZFE, 1ZZFE, 3ZZFE
R14
R14
R15
R16
(Except W/G) Black
(W/G)
Black
Black
1 2 3 4 5 6
1
2
1
2
R17
1 2 3 4 5 6 7
R18
R19
R19
R19
R20
(S/D, W/G)
(L/B)
(S/D)
(W/G)
Black
1 2 3
R18
(L/B)
1
1
S1
Black
1 2 3 4
10
11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26
27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42
S2
S3
S4
Black
Gray
Black
5 6 7 8 9 10 11 12 13 14 15
16 17 18 19 20 21 22 23 24 25 26
S5
S5
S5
S6
S7
S8
(*1)
(1CDFTV)
(1ZZFE, 3ZZFE)
Gray
Black
Black
12
12
1 2 3 4 5
S9
1
1 2 3 4 5 6
S10
S11
S12
S13
Black
Black
Black
(*6) Black
3 4 5 6
2
1
6 5 43
7 8 9 10 11 12
566
AVENSIS (EWD526E)
http://vnx.su
1 2 3 4
5 6 7
1
3
2
4
K
*7 : 1AZFSE, 1CDFTV
*8 : w/ Curtain Shield Airbag
*9 : w/o Curtain Shield Airbag
S13
S14
S14
S15
(*7)
(*8) Yellow
(*9) Yellow
(*8) Yellow
1 2 3 4
1 2
1 2 3 4
S15
S16
S16
S17
S17
(*9) Yellow
(w/ Power Seat) Gray
(w/o Power Seat)
(w/o Power Seat)
1 2
1 2 3 4
3 4 5 6
1 2 3 4
3 4 5 6
S18
S19
T1
T2
T3
Yellow
Yellow
Black
Black
Gray
1 2
1 2
1 2 3 4 5 6
T4
T5
Black
Black
1 2 3
T8
T7
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40
1 2 3 4
5 6 7 8
T9
T10
Black
3 4
T6
Black
1 2
1 2 3 4 5 6 7
1 2 3
T11
T12
1 2 3 4 5
1 2 3 4
5 6 7 8
12
3
456 7 8
5 6 7 8 9 10
8 9 10 11 12 13 14
T13
12
T14
T15
Black
Black
12
T18
1 2 3 4
T19
T16
T17
1 2 3 4
1 2 3 4
U1
V1
V2
Black
Black
Black
1 2
1 2 3
1 2 3 4
567
AVENSIS (EWD526E)
http://vnx.su
K CONNECTOR LIST
V3
V4
V5
V6
V7
Black
Black
Blue
Brown
Black
V8
12
1 2
1 2
12
1 2
V9
W1
12
W2
Y1
Black
Black
1 2
2
1
9 10 11 12 13 14 15 16
17 18 19 20 21 22 23 24
Z1
Z2
9 8 7 6 5 4 3 2 1
1 2 3 4 5 6 7 8 9
18 17 16 15 14 13 12 11 10
10 11 12 13 14 15 16 17 18
568
AVENSIS (EWD526E)
http://vnx.su
4
3
Memo
569
AVENSIS (EWD526E)
http://vnx.su

Code
Part Name
Part Number
A1
9098011030
A2
9098010928
A3
A/C Pressure Sensor
9098010845
A4

9098011003
Code
Part Name
Part Number
Buckle SW (Front Passengers Side)

B10
9098010795
C1
9098010947
C2
9098011162
C3
Compressor Assembly
9098011156
A5
A6
Air Flow Meter
9098011317
C4
Condenser Assembly
9098011003
A7
9098011178
C5
9098011156
A8
9098010869
Crankshaft Position Sensor (1AZFSE,

1AZFE)
9098010947
A9
A10
Crankshaft Position Sensor (1CDFTV)
9098012028
Crankshaft Position Sensor (1ZZFE,

3ZZFE)
9098010947
A11
9098011856
Alternator
9098011964
Alternator (Except 1CDFTV)
9098009212
Alternator (1CDFTV)
9098009213
A13
9098012169
A14
9098011778
A15
9098012259
A16
9098012200
A17
9098011918
A18
A/C Solar Sensor
9098011987
A19
A/C Thermistor
9098011918
A20
9098011144
A21
9098011987
A22
A23
A24
Air Mix Control Servo Motor (Front

Passenger Side)
A25
A26
A12
9098011909
8282450160
A27
9098011872
A28
8282450150
A29
Airbag Squib (Front Passenger Airbag

Assembly)
A30
A31
Antenna Amplifier
A32
A33
B1
BackUp Light SW
B2
B3
9098012160
9098010870
C6
Cigarette Lighter
C7
C8
Circuit Opening Relay
8266005020
C9
Clutch Start SW
9098010825
C10
Combination Meter
9098011913
C11
Combination Meter
9098011915
C12
Combination SW
9098011672
C13
Combination SW
9098011594
C14
Combination SW
9098012183
C15
C16
C17
C18
D1
9098011144
D2
Diode
9098011071
D3
Diode
9098010962
Diode (Fan) (Except 1CDFTV)
9098011608
D4
9098011071
DLC3
9098011665
D6
9098011909
D7
D8

9098010576
D11
9098010845
D12
Brake Fluid Level Warning SW
9008098001
B4
Blower Motor
9098010214
B5
Blower Motor Controller
9098011676
B6
Blower Resistor
9098011136
D13

9098010795
B8
Back Door Opener SW
9098011967
B9
Buckle SW (Drivers Side)
9098010942
9098011148
9098010871
Door Key Lock and Unlock SW (Drivers

Side)

9098012219
Diode (Fan) (1CDFTV)
D9
B7
9098012352
D5
D10
9098011060
9098010795
Note: Not all of the above part numbers of the connector are established for the supply.
570
AVENSIS (EWD526E)
http://vnx.su
9098012226
L
Code
Part Name
Part Number
Door Key Lock and Unlock SW (Drivers

Side)
D14

D15
Door Lock Control Motor (Front

Passengers Side)
9098012226
Door Lock Control Motor (Front

Passengers Side)
9098012300
E15
EPS ECU
9098012290
F1
F2
F3
Front Fog Light LH
F4
Front Fog Light RH
F5
F6
D19
F9
F10
Headlight LH (Low)
9098010942
Headlight RH (Low)
F11
Front Washer Motor
F12
Front Window Deicer
9098011155
F13
Front Wiper Motor
9098011599
F14
9098011002
F15
Fuel Heater
9098010928
Fuel Pressure Sensor (1AZFSE)
9098011451
9098012226
F16
9008098117
Fuel Pressure Sensor (1CDFTV)
9098011194
F17
Fuel Pump
9008098001
F18
Fuel Temp. Sensor
9098010737

E1
9098011162

9098012200

D21
9098011660

D20
9098011149

F8
Double Lock Motor (Front Passengers

Side)
D18
Part Number
EPS ECU
Double Lock Position SW (Front

Passengers Side)
D17
Part Name
E14
F7
Door Unlock Detection SW (Front

Passengers Side)
D16
Code
Front Passengers Seat Belt Warning Light
ECT Solenoid
9098011658
EFI Water Temp. Sensor (Except 1AZFE)
9098010737
EFI Water Temp. Sensor (1AZFE)
9098010735
F20
E3
9098011144
F21
E4
9098011592
F22
Electronic Driver Unit (1AZFSE)
9098011024
F23
9008098313
F24
Fuel Lid Opener SW
9098011013
E2
E5
Electronic Driver Unit (1CDFTV)
9098011593
E6
9098010554
E7
9098011235
E8
9098011013

E9
Engine ECU (M/T)
9098012142

E10
Engine ECU (M/T)
9098012146

E11
Engine ECU (M/T)
9098012143

E12
Engine ECU (M/T)
9098012145
F19
9098011989

9098010797
9008098157
Fuel Pump
F25
Fuel Sender
9098011077
G1
Glow Plug
9914113006
G2
Glow Plug Relay
9098011569
G3
Glove Box Light
9098011098
H1
H2
H3
9098010939
H4
9008098116
H5
Headlight LH (High)
H6
Headlight RH (High)
9098011016
9098011314

E13
Engine ECU (M/T)
9098012144
571
AVENSIS (EWD526E)
http://vnx.su

Code
Part Name
Part Number

(1AZFSE)
9098011028

(1ZZFE, 3ZZFE)
9098010869
H8
9098011028
H9
9098010869
H7
H10
H11
Horn LH
H12
Horn RH
9098011028
9098010619
H13
Hazard SW
9098010801
H14
9098012200
H15
9098010789
H16
9098010601
H17
9098011930
H18
H19

High Mounted Stop Light (L/B)
H20
90980WB002
High Mounted Stop Light (W/G)
9098011148
I2
I3
I6
I7
I8
I9
9098011875
Injector No.1 (1AZFSE)
9098012117
Injector No.2 (Except 1AZFSE)
9098011875
9098012117
9098011875
9098012117
9098011875
9098012117
9098011025
I10
ISC Valve
I11

I12
9098011885

I5
9098010320
High Mounted Stop Light (S/D)
I1
I4
9098011860
9098011145
9098012092
I13
Ignition SW
9098011778
I14
Integration Relay
9098011915
I15
Inner Mirror
9098011794
I16
Interior Light
9098011950
J1
Junction Connector
J2
J3
J4
Junction Connector
Junction Connector
Junction Connector
J5
Junction Connector
J6
Junction Connector
J7
9098010803
Junction Connector
Code
Part Number
Junction Connector
J9
Junction Connector
J10
Junction Connector
J11
Junction Connector
J12
Junction Connector
J13
Junction Connector
J14
Junction Connector
9098011542
J15
Junction Connector
9098010976
J16
Junction Connector
J17
Junction Connector
J18
Junction Connector
J19
Junction Connector
J20
Junction Connector
J21
Junction Connector
J22
Junction Connector
J23
Junction Connector
J24
Junction Connector
J25
Junction Connector
J26
Junction Connector
J27
Junction Connector
J28
Junction Connector
9098011542
J29
Junction Connector
9098011915
J30
Junction Connector
J31
Junction Connector
J32
Junction Connector
J33
Junction Connector
J34
Junction Connector
J35
Junction Connector
J36
Junction Connector
J37
Junction Connector
J38
Junction Connector
K1
Knock Sensor
K2
Kick Down SW
9098011156
K3
Knee Airbag Squib
9098012253
L1
L2
9098011915
9098011661
9098011542
9098011915
9098011661
9098011915
9098011661
9098011542
9098011661
9098011875
9008098001

L3
9098010908
L4
9098011967
L5
9098011148
L6
Lumbar Support Control Motor
9098010825
L7
Lumbar Support Control SW
9098010789
MultiDisplay (w/ Navigation System (Map

Type))
9098011877
MultiDisplay (w/o Navigation System (Map

Type))
9098011973
9098011661
9098011542
Part Name
J8
M1
9098011915
572
AVENSIS (EWD526E)
http://vnx.su
L
Code
M2
M3
Part Name
Part Number
Code
9098011923
P23
MultiDisplay (w/o Navigation System (Map

Type))
9098012209
P24
Power Seat Motor (Front Passengers Seat

Reclining Control)
MultiDisplay
9098010871
P25
Power Seat Motor (Front Passengers Seat

Slide Control)
R1
Radiator Fan Motor
R2
R3
Rear Washer Motor
9008098117
R4
Radio and Player
9098010997
R5
Radio and Player
9098010996
R6
Radio and Player
9098012183
R7
Radio and Player
9098012259
R8
8266005010
R9
8266005020
R10
9098011657
R11
9098011909
R12
Rain Sensor
9008098309
Rear Combination Light LH (Except W/G)
9008098175
Rear Combination Light LH (W/G)
9098010964
Rear Combination Light RH (Except W/G)
9008098175
Rear Combination Light RH (W/G)
9098010964

9098012059
Mirror Heater RH
M5
M6
8282405030
M7
9098010795
N1
Neutral Start SW
9098011784
N2
Noise Filter (Ignition)
9098010843
N3
Navigation ECU
9098011973
N4
Navigation ECU
9098011923
N5
Navigation ECU
9098012221
N6
N7
N8
Noise Filter (Stop Light)
9098010825
R13
O1
Oil Pressure Sensor
9008098200
O2
Oil Pressure SW
9098011363
P1
9098010897
P2
9098011428
P3
Pressure Discharge Valve
9098011285
P4
Parking Brake SW
9098010871
P5
Power Heater SW
9098010996
P6
Power Outlet
9008098182
P7
PTC Heater
9098011685
P8
Personal Light
9098011950
P9
Part Number
Power Seat Motor (Drivers Seat Slide

Control)
Mirror Heater LH
M4
Part Name
MultiDisplay (w/ Navigation System (Map

Type))
Power Window Control SW (Front

Passenger Side)
9098012113
R14
9098010825
9098010928
R15
R16
R17
Rear Interior Light
9098011148
Rear Window Defogger (L/B)
9098011258
Rear Window Defogger (S/D, W/G)
9098011259
9098011258
Rear Window Defogger (S/D)
9098010786
Rear Window Defogger (W/G)
9098011259
R20
9098010908
R18
R19
9008098157
P10
S1
9008098278
P11
S2
90980WB001
P12
S3
Spill Valve
9098012117
P13
S4
Starter
9098011400
P14
Starter (1AZFSE, 1AZFE)
9098009506
P15
Starter (1CDFTV)
9098009507
P16
Pretensioner LH
Starter (1ZZFE, 3ZZFE)
9098009463
S6
9098011285
S7
Seat Heater SW
9098011909
S8
Seat Heater SW
9098011918
9008098276
S5
9098012253
P17
Pretensioner RH
P18
P19
Power Seat Control SW (Front Passengers

Seat)
P20
Power Seat Motor (Drivers Seat Front

Vertical Control)
P21
Power Seat Motor (Drivers Seat Lifter

Control)
P22
Power Seat Motor (Drivers Seat Reclining

Control)
9098010997
9098010825
S9
9098012183
S10
Short Connector
9098010797
S11
Short Connector
9098010796
S12
Steering Sensor
9008098241
S13
Stop Light SW
9098011118
573
AVENSIS (EWD526E)
http://vnx.su

Code
S14
S15
S16
S17
Part Name
Part Number
Side Airbag Sensor LH (w/ Curtain Shield

Airbag)
9098012225
Side Airbag Sensor LH (w/o Curtain Shield

Airbag)
9098012352
Side Airbag Sensor RH (w/ Curtain Shield

Airbag)
9098012225
Side Airbag Sensor RH (w/o Curtain Shield

Airbag)
9098012352
Seat Heater LH (w/ Power Seat)
9098010797
Seat Heater LH (w/o Power Seat)
9098011090
Seat Heater RH (w/ Power Seat)
9098010797
Seat Heater RH (w/o Power Seat)
9098011090
S18
S19
T1
Throttle Control Motor and Position Sensor
9098011858
T2
Throttle Position Sensor
9098011261
T3
9098011038
T4
9098011156
T5
Turbo Pressure Sensor
9098010845
T6
Theft Deterrent ECU
9098012169
T7
9098012221
T8
9098011911
T9
TRC Off SW
9098010801
T10
9098010799
T11
9098011909
T12
9098012221
T13
T14
T15
Theft Warning Siren
T16
Tweeter Front LH
T17
Tweeter Front RH
T18
Tweeter Rear LH
T19
Tweeter Rear RH
U1
Unlock Warning SW
9098010860
V1
Vacuum Sensor
9098010845
V2
Vacuum SW
9098011252
V3
Variable Resistor
9098010902
V4
VRV (EGR)
9098011162
V5
VSV (EVAP)
9098010572
V6
VSV (Intake Air Control Valve)
9098011149
V7
VSC Warning Buzzer
9098010906
V8
Vanity Light LH
V9
Vanity Light RH
W1
Water Temp. SW (Radiator Fan)
9098011235
W2
Wiper Relay
9008098318
Y1
Yaw Rate Sensor
9008098249
Z1
8282430240
Z2
9098011973
Code
Part Name
9098011864
9098011918
9098011349
9098012304
9098011918
574
AVENSIS (EWD526E)
http://vnx.su
Part Number
L
Code
Part Name
Part Number
Code
Part Name
Part Number
575
AVENSIS (EWD526E)
http://vnx.su
W-R
R
2 B
B-L
(2L-T)
2 A
(2L-T)
(2L-T)
W-B
B-W
576
AVENSIS (EWD526E)
http://vnx.su
EA
Emission ECU <9-8>
S38 (A), S39 (B)
(22R-E)
B-W
40A AM1
100A ALT
Injector No.4
Injector No.2
Injector No.3
B-W
R-G
W-R
I10
W-R
30A AM2
Fender Apron LH
W-R
I12
W-R
B-R
W-R
W-R
BR
Left Kick Panel
R-G
BR
Data Link
Connector 1
D1
17
EA3
E1
3
FP
VF
T1
+B
OX1
GR-B
6
9
BR
Y-R
G-Y
L-Y
Y-R
G-R
BR-W
Y-R
(22R-E)
B-W
Y-R
GR
EC
Y-R
Intake
Manifold RH
W-R
W-R
GR-B
G-Y
L-Y
G-R
BR-W
Y-R
Y-R
GR
BR
R-Y
B-L
[L]
[J]
21 EA3
BR
W-B
W-B
ID
R-G
BR 2
4 EA3
R-W
Air Flow Meter
A5
B
BR
Y-R
EA
W-B
Circuit Opening
Relay
C19
Heated
Oxygen
Sensor
H11
Knock Sensor
1
K2
Y-R
Fender Apron LH
B-R
16 BS1
5
BO2
Y-R
F37
[K]
B-R
1
B-R
W-B
Starter
B-R
R-G
1 A
R-G
1
B
B-R
[D]
15 3C
EFI MAIN
Relay
[E]
R-Y
R-G
(2L-T)
B-W
[G]
[F]
Y-R
6 EA4
S40 (A), S41 (B)
B-W
Starter Relay
7 3C
[H]
15A
EFI
Engine Control
* The system shown here is an EXAMPLE ONLY. It is different to the

actual circuit shown in the wiring diagram section.
(Shielded)
Battery
[C]
B-W
B-W
1 B
B-L
12 EA1
B-W
1 A
B-W(22R-E)
[I]
7. 5A
IGN
B-R
(2L-T)
B-W
Y-R
B-W
7 EA3
(22R-E)
(22R-E)
(2L-T)
7. 5A
ST
B-R
R-Y
Y-R
W-R
B-L
B-R
B-W
ST2
2
A
B-W
Starting
W-R
[B]
5 8
AM2
A B
1 4
B A
7
IG2
B
ST1
ACC I 6 (A),(B)
Ignition SW
IG1
[A]
B-R
W-R
1 4
AM1
A B
Power Source
HOW TO READ THIS SECTION
M OVERALL ELECTRICAL WIRING DIAGRAM
BR
Fuel Pump
W-B
I11
W-R
W-R
I9
Injector No.1
= Yellow
GR = Gray
LG = Light Green
SB = Sky Blue
BR = Brown
L
(Blue)
LY
Y
(Yellow)
AVENSIS (EWD526E)
http://vnx.su
Male
Numbered in order
from upper right to
lower left
Example :
Indicates Relay Block No.1
[E] : Indicates a Relay Block. No shading is used and

only the Relay Block No. is shown to distinguish
it from the J/B.
The numbering system for the overall wiring diagram is

the same as above
Female
Example : Numbered in order

from upper left to
lower right
[D] : Indicates the pin number of the connector.

The numbering system is different for female
and male connectors.
[C] : The position of the parts is the same as shown in

the wiring diagram and wire routing.
Example:
The first letter indicates the basic wire color and the
second letter indicates the color of the stripe.
O = Orange
= Pink
= Violet
W = White
G = Green
= Blue
R = Red
= Black
Wire colors are indicated by an alphabetical code.
[B] : Indicates the wiring color.
[A] : System Title
3C indicates that
it is inside
Junction Block
No.3
Male (
: ( ) is used to indicate different wiring and

connector, etc. when the vehicle model, engine type,
or specification is different.
[L] : The same code occuring on the next page indicates

that the wire harness is continuous.
[K] : Indicates and located on ground point.
[J] : Indicates a shielded cable.
[I]
Female
[H] : Indicates the wiring harness and wiring harness

connector. The wiring harness with male
terminal is shown with arrows ( ).
Outside numerals are pin numbers.
[G] : Indicates related system.
Example:
[F] : Junction Block (The number in the circle is the J/B No.
and the connector code is shown beside it).
Junction Blocks are shaded to clearly separate them
from other parts.
577
1 AVENSIS
580
BL
(2)
W
(2)
AVENSIS (EWD526E)
http://vnx.su
140A ALT
B
(2)
B
(2)
Battery
FL MAIN
3. 0W
BG
(1)
1 4B
IL
IJ
WB
25A AM1

BG
(1)
7. 5A ECUB 2
30A DCC
40A MAIN
Behind the
Combination Meter
WB
(2)
WB
(1)
IO
19 DB
Left Kick Panel
Instrument Panel
Reinforcement RH
WB
BG
(1)
1 4A
9 DJ
TRLY
13
WB
1 1A
INTB
15
22
IG
: Gasoline
: 1CDFTV
7 DB
1
2
3
4
4 DB
BL(2)
GR
6 DK
TAIL Relay
9 DA
16 DB
ACC
21
25A DOOR
RW
3 CD
10 CC
I14(A)
Integration Relay
25
WR
WB
GR
RW
WL(3)
WR(4)
10A GAUGE1
7. 5A DOME
3 DH
9 CF
23
7. 5A RAD NO. 1
WL
(3)
BW
BW
1 4D
BG
(1)
GY
5 DH 1 DN
BG(1)
IG1
Relay
IG1 1
4 IE4
1 DH
GR
Ignition SW
I13
3 AM1
ACC 2
WR
WR
(4)
7. 5A PANEL
WR
M u ltip le x C o m m u n ic a tio n S y s te m (L H D )
WR
WR
GW
(3)
1 ED1
P o w e r S o u rc e
(Cont. next page)
G
WB
(4)
WR
WR
E
WB
WB
D
GR
C
RW
RY
(3)
J 6(A), J 7(B)
Junction
Connector
15 IC2
RY
(3)
I14(A)
Integration Relay
2 A
RY
(3)
RY
(3)
C B
E A
RY
(6)
C A

Control ECU< 243>
C A
RY
(3 5)
C A
Headlight Cleaner
SW< 284> < 304>
RY
(8)
A/C Control
Assembly
< 488> < 498>
J 3(A), J 4(B)
Junction
Connector
D B
RY
(3)
D B
WR
(3)
WL
(3)
HLP Relay

5 : w/ Headlight Cleaner
HRLY
GR
2
1
WR
(3)
WL
(3)
GROUND
+B
WB
(4)
RDA
GY
(4)
7 IC2
16 IC2
7 A
GY
(4)
LW
(4)
WR
(4)
12 IC2
LG
1 IC3
(A/T)

< 2211>
WG
DLC3
< 519> < 615> < 714> < 815>
ECT and A/T Indicator System

< 102> < 122>
AVENSIS (EWD526E)
http://vnx.su
Illumination System
< 193>
WL(3)
(3)
Taillight System
< 141>
(3)
WR(4)
Moon Roof System

< 322>
Power Window System
< 333>
5 DA
14 DA
LR

< 153>
WG
12 DB
BKL
LR
6 DJ
15 A
FRLY
OBD2
21 A
8
SNOW
P/W
20
T
12
TOUT
14
1 AVENSIS (Cont' d)
9 A
PRG
LW
(4)
16 A
RDA
D6
Door Control
Receiver
PRG
WR
(3)
6 IB1
2
2
RL
(3)
RL
(3)
14 A
DIM
RB
(3)
RW
B
WR
(3)
A
RB
(3)
WR
(3)
DIM
Relay
6 : 3 w/ HID
8 : 3 Power Heater (Electrical Type)
(Cont. next page)
581
582
AVENSIS (EWD526E)
http://vnx.su
GR
WR
(3)
ED
WB
WB
(3)
WB
(3)
WB
(3)
EB
EA
Engine
Compartment
Right
Behind the
Combination Meter
Dimmer SW
F7
WB
(6)
WB
(3)
WB
High
Low
Flash
16
IL
WB
(2 3)
H5
Headlight LH (High)
WB
(3)
H6
Headlight RH (High)
EC
WB
(3)
Tail
Head
13
H
HL
HU
HF
IO
Instrument Panel
Reinforcement RH
C12
Combination SW
WB
(1 3)
Engine
Compartment
Left
WB
(4)
WR
WB
3 IC3
9 IC3
F A
H B
GR
RW(3)
RW
WB
(4)
WR
WB
J 8(A), J 9(B)
Junction Connector
GR
WB
(7)
RW
R
(7)
WB
(7)
F8
Headlight LH (Low)
J2
R
(6)
Light
Control SW
Junction
Connector
RB
(7)
OFF
EL
Headlight Cleaner
Relay< 284>
RB
(6)
RY
(3)
J 3(A), J 4(B)
Junction Connector
RW
(3)
E B
RY
(7)
RL
(3)
RL
(3)
RY
(6)
A B
E A
J 6(A), J 7(B)
Junction Connector
RL
(3)
D A
RY
(6)
E A
RY
(6)
D A
10A
HLP
HI RH
RY
(6)
HF
13 A
RW
(3)
10A
HLP
HI LH
10 IE1
HU
6 A
RY
(3)
15A
HLP RH
28 DA
18
12

6 : 3 w/ HID
7 : 3 w/o HID
(Cont. next page)
GR
WR
(3)
15A
HLP LH
I14(A)
Integration Relay
11
1 : Gasoline
2 : 1CDFTV
RW
(3)
RB
(3)
10
RY
(3)
RB
(3)
1 AVENSIS (Cont' d)
F9
WB
(6)
F10
Headlight RH (Low)
WB
(3)
AVENSIS (EWD526E)
http://vnx.su
BU
LR
(14)
B10
GY
(14)
Under the Right

Center Pillar
Buzzer
Right Kick Panel
E 9(A), E10(B)
Engine ECU (M/T)
WB
WB
(14)
IP
WB
WR
WB
2 : 1CDFTV
13 : Automatic A/C
14 : Except 1AZFE
15 : Except 1AZFE, Latin America, Argentina, CIS
WR
BV
6 CA
23 A (11)
20 A (2)
WB
Under the Right

Center Pillar
WB
Seat Belt
WB
(4)
9 CH
WB
6 CK
13 A
WR
WB
(4)
8 CD
5 B
MPX1
18 B (1AZFSE)
4 ID1
V8
Vanity Light LH
WB
(14)
MPX2
F A
WB
V9
Vanity Light RH
GY
(14)
21 A (2)
29 A (11)
29 B (1AZFSE)
F A
H B
WR
High Beam
6 A
(15)
LR
(14)
CPU
10 B (13)
MPX+
9 A (12)
PB
3 C
24 A
PBLT
MPX
20 B (13)
29 A (12)
H B
WR
14 IM1
BPBEW
RW
(3)
PBEW
GR
(15)
WR
WR
1 DA
2 B (9)
ILL+
2 A (10)
ILL
6 B (9)
6 A (10)
LP
7 DK
WR
WB
(3)
WB
P8
Personal Light
WR
WB
RW
(14)
RW
WR
WR
20 B
H B
16
I11(A), I12(B)
Ignition Key
Cylinder Light
BEAN
I/F
PB
14 A
21 B
10 IC1
2 A
1 IC1
WR
12 B
C10(A), C11(B)
Combination Meter
7 CA
WR
IG
6 CD
7 CD
MPX1
11 A
WR
F19
Warning Light
RW
RW
(14)
22 A
MPX2
I14(A)
Integration Relay
15
(Cont. next page)
WG
GR
RW(3)
RW
14
PB
13
1 AVENSIS (Cont' d)
WG
WG
WB
J10(A), J11(B)
Junction Connector
WB
A13(A), A15(B), A16(C)

Door
P
(15)
WB
(14)
WB
(3)
583
584
J 6(A), J 7(B)
Junction
Connector
WR
11 ID1
WG
D11
Door Courtesy SW
Rear LH
AVENSIS (EWD526E)
http://vnx.su
Behind the
Combination Meter
D12
Door Courtesy SW
Rear RH
WR
WB
(3)
WR
(16)
WR
H B
WB
(2)
IL
WB
(3)
Instrument Panel
Reinforcement RH
A
A
WB
L5
Luggage
Compartment Light
WR
(S/D)
WR
F A
18 IM1
U1
Unlock Warning SW
WB
WR
F A
4 IC2
6 DA
8 DA
13 DM
WB
(1)
IO
J16
Junction
Connector
RY(S/D)
RY(16)

< 94>
D8
Door Courtesy
Light RH
WR
H B
WR
R
(9)
F A
10 IA1
9 IM1
14 IC2
10 IL1
D B
B A
5 IC2
D B
B A
KSW
19
RY
(S/D)
11 IA1
12 DM
9 DC
11 IL1
RCTY
16
WG
WG
J32
Junction
Connector
13 DB
PCTY
20
WG
2 DK
17
DCTY
I14(A)
Integration Relay
19
WR
2 DB
18
(Cont. next page)

1 : Gasoline
2 : 1CDFTV
16 : L/B, W/G
Y
(9)
LGCY
1 A
RY
(S/D)
RY
(S/D)
17
1 AVENSIS (Cont' d)
WG
D10
Door Courtesy SW
Front RH
D9
Door Courtesy SW
Front LH
J10(A), J11(B)
Junction
Connector

< 94>
I16
Interior Light
WG
WB
WR
D7
Door Courtesy
Light LH
WR
R17
Rear Interior Light
RY
(16)
D3
Diode
LG
LY(S/D)
LR(16)
LB
LR
LR
GW
BRW
BRW
AVENSIS (EWD526E)
http://vnx.su
WB
(16)
WB
D17
Lock
A B
WB
(16)
A B
WB
(16)
A B
B7
LB
(W/G)
Right Side of
the Back Door
2 BD1 (L/B)
4 BF1 (W/G)
WB
3 BG1
WB
(W/G)
WB
(16)
Left Kick Panel
D20
Door Lock Motor
Rear RH
A A
B8
J33(A), J34(B)
Junction Connector
Back Door Opener SW
WB
(16)
WB
(W/G)
BX
2 BE1
WB
(16)
Lower Back
Panel Left
1
M
C B
B A
BS
WB
(S/D)
WB
IJ
D15
Door Lock
Control Motor
RY
(W/G)
WB
(16)
RY
(S/D)
WB
(L/B)
RY(S/D)
D18
Door Lock Motor
Rear LH
6 BE2
3 BG2
6 BD2 (L/B)
5 BF2 (W/G)
LB
(S/D)
WB
(S/D)
9 IA1
D13
(Driver' s Side)
(Driver' s Side)
(Driver' s Side)
LR
LB
2 BC1
LR
2 IL1
7 BE2
4 BG2
7 BD2 (L/B)
6 BF2 (W/G)
L
(S/D)
BDSU
10 A
24
16 : L/B, W/G
B A
J30(A), J31(B)
Junction
Connector
L3
RY(16)
WB
GW
LR
LG
LR
LB
10
LR
LB
11 BC1
LB
7 IL1
5 BG2
3 DM
L
(W/G)
11 BA1
LR
2 BA1
LG
LR
2 IA1
LR
LB
7 IA1
LB
RY
(L/B)
18 IA2
LR
L
(L/B)
1 IA2
RY
(L/B)
8 BE2
RY
(W/G)
LB
(L/B)
2 IA2
J32
Junction
Connector
L
(L/B)
1 IM2
7 CC
8 BD2 (L/B)
2 BF2 (W/G)
LACT
L
(W/G)
17 IM2
11 CK
LB
8 CC
2 CB
BDCY
12 A
L
(L/B)
3 IA2
7 CJ
4 CA
10 DB
20 DB
LR
16 IC1
6 DM
LB
7 DM
LB
RY
(16)
7 IC1
4 DJ
ACT
L
(16)
17 IC1
1 DJ
ACT+
L
(W/G)
L4
WB
(S/D)
LSWD
3 A
LB
(16)
UL2
5 A
23
L
(S/D)
4 IA2
13 DA
L2
4 A
I14(A)
Integration Relay
RY
(16)
29 DA
UL1
10
22
LB
(S/D)
L1
11
21
1 AVENSIS (Cont' d)
WB
(L/B)
RY
(16)
Unlock
585
586
BL
(2)
W
(2)
140A ALT
AVENSIS (EWD526E)
http://vnx.su
B
(2)
B
(2)
Battery
FL MAIN
3. 0W
BG
(1)
7. 5A DOME
1 4A
1 4B
WB
TRLY
13
25A AM1

BG
(1)
30A DCC
IJ
WB
Left Kick Panel
WB
1 1A
22
IG
WB
WR
WB
WR(4)
GR
RW
WR
(3)
25
: Gasoline
: 1CDFTV
7 DB
1
2
3
4
4 DB
16 DB
ACC
21
(Cont. next page)
WB
BL(2)
GR
6 DK
3 DH
I14(A)
Integration Relay
TAIL Relay
9 DA
5 DH 1 DN
23
25A DOOR
RW
7. 5A ECUB 2
BW
7. 5A RAD NO. 1
BW
BG
(1)
WR
(4)
IG1
Relay
IG1 1
ACC 2
GY
1 4D
1 DH
GR
Ignition SW
I13
3 AM1
BG(1)
9 CF
3 CD
WR
(3)
7 CI
10 CC
5 IP1
M u ltip le x C o m m u n ic a tio n S y s te m (R H D )
WR
2
WR
WR
WR
1 ED1
WR
BG
(1)
2 AVENSIS
10A GAUGE1
Moon Roof System

< 322>
Power Window System
< 343>
AVENSIS (EWD526E)
http://vnx.su
WB
WB
WB
IK
WB
T13
Theft Warning
Ultrasonic
Sensor Rear LH
MOU
MOU+
GND
+B
WB
(4)
BV
Under the Right

Center Pillar
T15
Theft Warning
Siren
CONT
5 IO1
WB
(4)
EC
SSW1
13
KSW
12
HORN
5
IND
IG
10
MPX
31
25
+B1
29
E6
Engine Hood
Courtesy SW
Behind the
Combination Meter
J15
Junction
Connector
WB
(4)
WB
MIN
MIN+
11 IM1
WR
(4)
WR
(3)
L
(4 W/G)
DSWH
34
CTLS
S+B
24
27
12 IM1
WR
(4)
LR
(4)
T14
Theft Warning
Ultrasonic
Sensor Rear RH
W
(4 W/G)
SOU+
4
P
(4 W/G)
SOU
SIN
(4 W/G)
SIN+
(Shielded)
GND
IOUT
26
LR
(4)
LR
(4)
WB
GROUND
WB
(3)
+B
RDA
S+B
LR
(4)
WR
LR
PRG
IOUT
LGB
(4)
SOFF
LW
(4)
WB
(4)
WG
LB
(4)
Security Indicator
Light< 92>
WR(4)
GY
(3)
19 ID1
LB
(4)
T12
Theft Warning
Ultrasonic Sensor
8 ID1
9 ID1
LW
(4)
V
(4)
LG
7 IC2
GY
(3)
LW
(3)
16 IC2
LW
(3)
LGB
(4)
HORN Relay
< 262>
RDA
7 A
WR
(4)
G
(4)
GR
WG
12 IC2
PRG
16 A
PL
(4)
Y
(4)
RW
BKL
9 A
LR
1 IC3
FRLY
15 A

RW
(4)
H
I
WB
(4)
Y
(4)
WR
WB
GR
RW
PL
(4)
WR
(4)
(Cont. next page)
RW
(4)
WR
(3)
14 DA
OBD2
21 A
I14(A)
Integration Relay
LW
(4)
T6
Theft Deterrent ECU
5 DA
SNOW
LGB
(4)
P/W
20
2 AVENSIS (Cont' d)
D6

< 2211>

< 153>
DLC3
< 519> < 615> < 714> < 815>

< 102> < 122>
587
588
RW
(4)
AVENSIS (EWD526E)
http://vnx.su
Y
(4)
WB
(4)
Seat Belt
WB
WB
WR
Right Kick Panel
Lower Back
Panel Left
C B
WB
(8)
J20(A), J21(B)
Junction Connector
GR
RW
BS
BPBEW
PBEW
8 IC3
Behind the
Combination Meter
IL
WB
(8)
WB
IP
20 A (2)
B A
C
23 A (7)
WB
(8)
MPX1
18 B (1AZFSE)
MPX2
WB
(8)
6 CA
13 A
A13(A), A15(B), A16(C)

21 A (2)
29 A (7)
29 B (1AZFSE)
3 C (6)
PBLT
24 A (5)
LR
(8)
C10(A), C11(B)
Combination Meter
10 B
9 A
MPX+
MPX
20 B (6)
J32
Junction
Connector
6 CK
Buzzer
CPU
(8)
BEAN
I/F
20 B
29 A (5)
IG
12
Y
(4)
WR
WB
J16
Junction
Connector
WR
WR
(4)
6 : Automatic A/C
8 : Except 1AZFE
(Cont. next page)
F19
Warning Light
2 : 1CDFTV
LR
(8)
9 CG
5 B
(8)
14 A
10 IC1
PB
GY
(8)
GR
RW
(8)
GY
(8)
GR
WB
(8)
RW
GR
F A
RW
15 A
PL
(4)
21 B
PB
2 A
WR
H B
MPX1
11 A
7 CA
RW
6 CD
1 IC1
PB
7 CD
MPX2
22 A
I14(A)
Integration Relay
11
PL
(4)
10
RW
(8)
1 CK
WR
(4)
2 AVENSIS (Cont' d)
B10
WB
(8)
J30(A), J31(B)
Junction
Connector
E 9(A), E10(B)
Engine ECU (M/T)
Door
P
AVENSIS (EWD526E)
http://vnx.su
WG
WR
V8
Vanity Light LH
WR
Y
(4)
10 CI
11 ID1
14 IC2
9 IM1
4 IC2
13 DM
12 DM
WG
RY
(S/D)
RY
B
(L/B, W/G)
Y(4)
18 IM1
D12
WB
6 CH
3 CE
11 CI
WR
V9
Vanity Light RH
WB
WR
WR
WB
WR
(L/B, W/G)
WR
9 CI
WR
WR
WR
WR
L5
Luggage Compartment
Light
WR
(S/D)
D7
Door Courtesy
Light LH
WR
WR
I11(A), I12(B)
4
R
(9)
D8
Door Courtesy
Light RH
WR
10 IL1
4 CK
RCTY
16
9 DC
WR
10 IA1
1 CA
5 CE
5 IC2
7 CG
11 IL1
R
2 B (9)
RY
(S/D)
2 A (10)
ILL+
11 IA1
13 DB
PCTY
WG
4 ID1
F A
J32
Junction
Connector
2 DK
WR
(4)
F A
A
R
ILL
2 DB
F A
WR
6 B (9)
6 A (10)
WG
H B
RY
(S/D)
RY
(S/D)
H B
7 DK
DCTY
17
16
F A
J26(A), J27(B)
Junction
Connector
1 DA
1 A
LGCY
I14(A)
Integration Relay
15
WG
WB
WR
WR
(4)
LP
6
14
(Cont. next page)
WG
13
2 AVENSIS (Cont' d)
WG
D11
D9
D10

< 94>
I16
Interior Light
WG
WB
R17
Rear Interior Light
RY
(L/B, W/G)
D3
Diode
WG
R
P8
Personal Light
WR
WR
WB
WB
WR
WR
WB
589
590
Y
(8)
Y
(8)
WB
Y
(9)
Y
(4)
AVENSIS (EWD526E)
http://vnx.su
RY
(W/G)
WB
(L/B, W/G)
WB
(L/B, W/G)
A B
LB
(W/G)
J33(A), J34(B)
Junction
Connector
Right Side of
the Back Door
WB
(W/G)
WB
IP
WB
(L/B, W/G)
WB
(L/B, W/G)
WB
(L/B)
Lower Back
Panel Left
WB
(S/D)
BS
J30(A), J31(B)
Junction
Connector
Right Kick Panel
9 IL1
WB
WB
(W/G)
BX
2 BE1
WB
(L/B)
J22(A), J23(B)
Junction Connector

< 94>
Right Kick Panel
A B
B7
A B
B8
Back Door Opener SW
C B
B A
WB
(S/D)
3 BG1
WB
(S/D)
B A
L4
Luggage Compartment
Door Opener SW
A A
2 BD1 (L/B)
4 BF1 (W/G)
WB
IP
WB
D17
RY
(S/D)
U1
Unlock Warning SW
WB
Lock
BRW
Unlock
L
(W/G)
3 IL2
5 B
6 B
WB
(12)
WB
8 B
8 A (11)
5 A
6 A
10 B (12)
7 B
7 A (11)
4 B (12)
B
(12)
L(12)
W(12)
D13(A)
(Driver' s Side)
(Driver' s Side)
(Driver' s Side)
D14(B)
(Driver' s Side)
(Driver' s Side)
(Driver' s Side)
Double Lock Motor
(Driver' s Side)
(Driver' s Side)
3 B
4 IL1
8 IL1
18 IL2
1 IL2
2 IL2
LY
RY
(L/B)
GW
4 IL2
3 IC1
L
(L/B)
16 IC1
7 IC1
17 IC1
DLPD
6 A
LG
Y(4)
RY
(L/B)
W
(12)
6 CA
RY
(W/G)
LSWD
3 A
B
(12)
L
(12)
13 CF
L
(W/G)
LB
(L/B)
L
(W/G)
1
LB
(S/D)
RY
(S/D)
3 BG2
UL2
5 A
W
(12)
L
(L/B)
6 BE2
L
(S/D)
4 BG2
BRW
L
(L/B)
7 BE2
6 BD2 (L/B)
5 BF2 (W/G)
13 DA
GW
29 DA
L2
4 A
LR
5 BG2
L
(S/D)
UL1
10
20
L
(12)
RY
(L/B, W/G)
Y
(1AZFE)
RY
(L/B, W/G)
7 BD2 (L/B)
6 BF2 (W/G)
L
(L/B, W/G)
8 BE2
3 DM
LB
(L/B, W/G)
L
F B
J32
Junction
Connector
LB
(S/D)
L1
11
LR
LG
F B
RY
(L/B, W/G)
BDSU
10 A
8 BD2 (L/B)
2 BF2 (W/G)
LACT
I14(A)
Integration Relay
19
LG
D A
8 DA
BDCY
12 A
18
(Cont. next page)

8 : Except 1AZFE
B
(12)
D A
KSW
19
17
2 AVENSIS (Cont' d)
L3
WB
(L/B, W/G)
RY
(L/B, W/G)
LB
LR
B
(12)
LB
LR
B
(12)
AVENSIS (EWD526E)
http://vnx.su
L
(12)
LGB
(12)
B
(12)
LB
LR

W
(12)
D20(A)
6 B
10 B (12)
WB
(12)
WB
(12)
BV
Left Kick Panel
WB
(12)
WB
(12)
WB
(12)
IJ
10 B
9 B
6 B (12)
5 B
10 BA1
Under the Right

Center Left
WB
(12)
Under the Right

Center Pillar
9 IA1
Door Lock Motor

Rear LH
SW Rear LH
Double Lock Motor
Rear LH
Double Lock Position
SW Rear LH
D19(B)
D18(A)
7 B (12)
5 B
4 B
Door Lock Motor

Rear LH
3 B
8 B (12)
6 B
WB
(12)
WB
(12)
BQ
WB
(12)
BU
WB
D16(B)

Double Lock Motor
3 B
1 A (11)
WB
(12)
WB
(12)
10 BC1
D15(A)
4 B
4 A
WB
(12)
Under the Right

Center Pillar
Door Lock Motor

Rear RH
Door Unlock
Detection SW Rear RH
Double Lock Motor
Rear RH
SW Rear RH
D21(B)
Door Lock Motor

Rear RH
1 B
1 A (11)
1 B (12)
4 A
2 B
L
(12)
2 B
8 IA1
W
(12)
1 B (12)
7 IA1
LR
2 B
2 IA1
LB
9 B
17 IA2
B
(12)
5 B
18 IA2
LGB
(12)
3 B
16 BA1
W
(12)
1 A (11)
6 BA1
L
(12)
4 B
4 BA1
B
(12)
4 A
11 BA1
2 BA1
9 BA1
LGB
(12)
4 IA1
6 DM
7 DM
LR

LR
1 B (12)
LB
1 A (11)
B
(12)
2 B
LGB
(12)
4 A
L
(12)
LB
D14(B)
LR
W
(12)
9 B
L
(12)
16 BC1
W
(12)
6 BC1
W
(12)
9 BC1
B
(12)
4 BC1
LGB
(12)
11 BC1
10 DM
LGB
(12)
2 BC1
12 IC1
4 IC3
10 IC3
W
(12)
2 IL1
B
(12)
L
(12)
7 IL1
LGB
(12)
B
(12)
17 IL2
L
(12)
11 IM2
LR
3 CK
LGB
(12)
2 IM2
LR
5 CB
W
(12)
1 IM2
1 CE
W
(12)
1 CI
LB
2 CA
LB
2 CD
L
(12)
16 IM1
12 CJ
20 DA
B
(12)
17 IM1
10 CA
4 DJ
LGB
(12)
17 IM2
11 CK
LB
7 CC
5 CH
1 DJ
ACT
24
LR
8 CC
6 CF
9 DJ
6 DJ
ACT+
23

LB
D13(A)
7 CJ
2 CB
LR
4 CA
L
(12)
Junction
Connector
B
(12)
W
(12)
J20(A), J21(B)
G
A
G
B
B
(12)
ACTR
15
L
(12)
G
A
G
A
G
B
8 DB
14
ACTS
I14(A)
Integration Relay
L
(12)
B
(12)
L(12)
W(12)
10 DB
LB
20 DB
LSWP
22
W
(12)
B(12)
21
2 AVENSIS (Cont' d)
591

IJ
Left Kick Panel
9 DA
WB
BY
(2)
C B
BY
B B
A11(A), A12(B)
Alternator
6
2
BY
GY
1
2
3
4
5
6
7
8
9
BW
S ta rtin g
B A
N
BW
(A/T)
BY
(M/T)
1 A
1 B
Engine ECU (M/T)

< 87>
N1
Neutral
Start SW
BL
(3)
: Gasoline
: 1CDFTV
: 1AZFSE, 1CDFTV
: 1ZZFE, 3ZZFE
: 1AZFSE
: 1AZFSE, 1AZFE
C B
A A
BY
(A/T)
BW
(3)
13 IK2
A A
A/C Control
Assembly< 488>
< 498>
BY
(1)
BL
(2)
BL
(2)
Engine ECU (M/T)

< 88>
3 A
5 EA1 (1)
5 EE1 (2)

< 511> < 611> < 77>
Engine ECU (M/T)
< 511> < 611> < 77>
BY
(M/T)
B+(1)
B (2)
B(2)
J12(A), J13(B)
Junction
Connector
IG
Y
(4)
Power Heater
Assembly< 433>
BG(1)
Y
(5)
4 A
9 IK1
Y
(6)
Y
(5)
E 9(A), E10(B),
E11(C), E12(D)
Engine and ECT
ECU (A/T)
Engine ECU (M/T)
2 A
RW
1 IK2
C B (RHD)
G A (LHD)
Y
(6)
27 A (7)
21 C (8)
28 B (1AZFE)
RL
21 A (2)
MPX2
MPX1
29 A (6)
20 A
29 B (8)
18 B
23 A
GR
BG(1)
BL(2)
C h a rg in g
RW
J10(A), J20(B)
Junction Connector
25A AM1
Multiplex Communication
System< 115> < 211>
C B (RHD)
G A (LHD)
RW
18 DB
1 DH
7. 5A ECUIG
9 D (2)
2
3
WB
2 DJ
1 DN 5 DH
IG1 Relay
GY
1 A
BR
AVENSIS (EWD526E)
http://vnx.su
Battery
FL MAIN
3. 0W
B
(2)
B
(2)
BG
(1)
3
1
W
(2)
BG
(1)
1 1A
1 4B
120A ALT (9)

100A ALT (7)
1 4A
2
1 4E
1 4D
B
(2)
1 ED1
1
B
1
1
BG
(1)
BG
(1)
3 AVENSIS
7 IK1
5
5
(RHD)
B
140A ALT
592
B
(2)
7. 5A ALTS
BL
(2)
S 4(A), S 5(B)
Starter
5
2
30A AM2
BR
1 IP1
1 IE4
(LHD)
BR
BR
WB
BR
I13
Ignition SW
ST2 5
IG2
4 AM2
ST Relay
BY
BR
IG1 1
ACC
3 AM1
GR
7. 5A ST
BG
IGF
2
GND
IGF
GND
WR
I2
Ignition Coil and
Igniter No. 2
WB
IGT
+B
IGF
WB
AVENSIS (EWD526E)
http://vnx.su
BG
WR
Left Side of the

Cylinder Head
GND
I3
Ignition Coil and
Igniter No. 3
IGT
+B
WR
LGB
WB
WR
P
Left Side of the

Cylinder Head
WB
WB
(1)
GND
WB
(1)
WB
EH
WB
(2)
EF
IGF
I4
Ignition Coil and
Igniter No. 4
WR
Engine and ECT ECU (A/T)< 59> < 611> < 78>
Engine ECU (M/T)< 59> < 611> < 78>
IGT
+B
WB
(2)
EC
IGT
3
I1
Ignition Coil and
Igniter No. 1
WB
Battery
RB
+B
RB
BR
1 : 1AZFSE, 1AZFE
2 : 1ZZFE, 3ZZFE
N2
Noise Filter
(Ignition)
FL MAIN
3. 0W
IG2
Relay
RB
RB
1 4B
8 EA1
BR
10A
IGN
RB
16 DL
2 DH
RB
1 4A
15A
IG2
BR
RB
IG2 6
ST2
Ig n itio n
RB
1 1A
30A
AM2
(RHD)
(LHD)
I13
Ignition SW
4 AM2
BR
BR
1 IP1
1 IE4
BR
4 AVENSIS
WR
LY
WB
WR
RW
RB
RB
593
5 AVENSIS
594
BG
AVENSIS (EWD526E)
http://vnx.su
120A ALT
BG
4
B
25A AM1
Left Kick Panel
BY
10A GAUGE1
WB
WB
WB
IG2 Relay
15A IG2
30A AM2
20A EFI
30A DCC
EC
WB
IJ
WB
WB
Battery
10A IGN
BW
WB
BY
13 EA1
BW
BW
FL MAIN
3. 0W
10A THROTTLE
BG
9 DA
7 DB
BY
7 EA1
4 IE2
1 1A
16 DL
BR
1 4A
7 DA
BR
1 4B
GR
BW
(RHD)
(LHD)
BW
BY
BR
BW
B
BR
1 IP1
BW
1 IE4
5 DH 1 DN
GY
(RHD)
1 DH
GR
7. 5A DOME
(LHD)
GR
18 DA
BG
5 IP1
2 DH
BR
IG2 6
ST2
GY
IG1 1
I13
Ignition SW
4 AM2
3 AM1
BY
GR
ACC
RW
V
1 4D
WR
4 IE4
BW
BR
BY
GR
RW
BW
BW
WR
GR
(Cont. next page)
INJ Relay
10A EFI NO. 1

BR
7. 5A EFI NO. 2
BR
BW
EFI Relay
7. 5A OBD2
IG1 Relay
WR
(RHD)
AVENSIS (EWD526E)
http://vnx.su
J10(A), J11(B), J26(C)

Junction Connector
WB
BW
WB
IP
CRUISE
Right Kick Panel
LB
WB
BR
GY
GY
BQ
Under the Left

Center Pillar
(RHD)
Intake Side of
Cylinder Block
EE
BR
WB
Left side of
the Cylinder
Head
EF
WB
Under the Left

Center Pillar
WB
2 IE4
3 IP1
D B (RHD)
D A (LHD)
(LHD)
D B (RHD)
D A (LHD)
D B
WB
BR
(3)
BR
(3)
10 B
E1
1 C
BR
BR
C8
Circuit Opening
Relay
J14(A), J28(B)
Junction
Connector
V
BR
6 CA
F25
Fuel
Pump
BW
BR
D A
ME01
4 C
E02
6 E
E01
7 E
BR
6 IC3
+B
1 A
WB
IREL
35 B
WB
6 CK
Check Engine
9 B
W
11 A
ST1
WB
Multiplex
Communication System
< 115> < 211>
RW
5 B
BW
FC
BW
10 A
BW
BR
WR
(LHD)
12 B
Stop Light
System< 172>
WB
E 9(A), E10(B), E11(C), E12(D), E13(E)

Engine ECU (M/T)
+B2
E03
2 A
7 C
GW
(LHD)
4 IR1
RW
(1)
14 A
RW
(2)
IGSW
9 A
14 IE2
6 IR1
J19
Junction
Connector
13 A
BW
MREL
BY
8 A
GR
BATT
BW
(LHD)
3 A
J 8(A), J 9(B), J26(C), J27(D)

Junction Connector
GW
(RHD)
CPU
BW
C A (LHD)
15 IE2
J14
Junction
Connector
22 B
A C (RHD)
GW
(LHD)
LGB
(1)
21 B
C A
A C
BW
(RHD)
C A
5 IE2
BW
BR
+BM
6 B
GY
20 B
GR
2 IE1
GW
(RHD)
(RHD)
(LHD)
S13
Stop Light SW
7 IO1
5 IR1
LGB
(1)
10 IB1
BY
7 IE3
9 IE2
C9
Clutch
Start SW
LGB
(2)
6 CD
RW
(1)
8 CE
BW
(RHD)
H B (LHD)
7 CA
E D (RHD)
LGB
(1)
E D
LGB
(2)
F C (RHD)
C B (LHD)
BW(RHD)
3 IR1
1 : LHD M/T
2 : RHD M/T
3 : Shielded
(Cont. next page)
GR
BEAN I/F
F C
F A (LHD)
20 IE1
BW
(LHD)
RW
BW
(LHD)
BY
RW
(1)
GR
RW
BW
BW
WR
GR
E n g in e C o n tro l (1 A Z F S E )
RW
(2)
5 AVENSIS (Cont' d)
LGB
(2)
BR
RW
(2)
BR
BR
GY
BW
C10(A), C11(B)
Combination Meter
W
595
596
AVENSIS (EWD526E)
http://vnx.su
BR
INJ# 2
COM2
INJ# 3
IJT# 2
IJT# 1
IJT# 3
2 B
IJT# 4
3 B
IJF
5 B
STA
17 E
BR
E A
D B
E A
(3)
E 4(A), E 5(B)
INJ# 4
1 B
4 B
F/PS
14 A
G2+
27 C
FAN
4 A
C1
Camshaft
Position Sensor
BR
STP
19 B
D B
E A
NE+
25 C
MPX2
29 B
BR
J12(A), J13(B)
Junction
Connector
NE
24 C
SPD
17 B
(3)
BR
COM1
RL
21 C
3 : Shielded
EOM
15 A
MPX1
18 B
BW
BR
BR
BW
BR
L
INJ# 1
BW
2 A
I7
Injector No. 3
2
GW
6 A
1
WR
VB
1 A
3 A
I6
Injector No. 2
1
IMI
27 B
IJF1
25 E
IMO
26 B
E 9(A), E10(B), E11(C), E12(D), E13(E)

Engine ECU (M/T)
#1
#2
#3
#4
1 E
2 E
3 E
4 E
ELS
12 A
RW
5 A
NEO
17 A
WL
4 A
I8
Injector No. 4
2
ENG
30 A
8 A
ENG+
24 A
BR
RW
C6
Crankshaft
Position Sensor
GND
LGB
7 A
LY
RB
WR
I5
Injector No. 1
1
TRC
Y(LHD)
W(RHD)
31 A
TRC+
YB
25 A
IGF1
TAIL Fuse
< 142>
W
24 E
GR
IGT4
Charging System
< 34>
11 E
LGB
IGT3
Skid Control ECU

with Actuator< 207>
BY
10 E

< 228>
W
IGT2
Neutral Start SW (A/T)

< 33>
ST Fuse (M/T)
< 33>
GW
9 E
Diode (Fan)< 444>

FAN NO. 1 Relay< 444>
VW
IGT1
Transponder Key
Computer< 94>
12
(Cont. next page)
System< 115> < 211>
8 E
Ignition Coil and Igniter

No. 1, No. 2, No. 3 or No. 4
< 43> < 44>
11
Stop Light SW
< 172>
10
Combination Meter
< 423>
5 AVENSIS (Cont' d)
(3)
G
(3)
R
BR
G
(RHD)
Y
(RHD)
B
(LHD)
G
(LHD)
Y
(LHD)
P2
AVENSIS (EWD526E)
http://vnx.su
+B
2
LB
LB
BR
BW
E B
E B
BW
J12(A), J13(B)
Junction
Connector
BR
BW
(3)
D A
H10
(Bank 2 Sensor 2)
BW
E1
4
+B
HT
BW
BR
E1
OX
OX2A
23 D
BR
D A
+B
2
OX
HT1A
5 D
PIM
33 E
H7
(Bank 1 Sensor 1)
D A
H8
(Bank 1 Sensor 2)
BR
BW
HT
1
E1
OX1A
22 D
GE01
17 C
VOUT
GND
BR
+B
HT
HT2A
4 D
PR
23 E
BW
(3)
BR
YB
BR
HT
(3)
OX
(3)
E1
2 C
OX
O2B
31 C
OX2B
29 D
M+
3 C
HT1B
25 D
OC1
15 C
VTA1
21 E
VOUT
1
VCC
OC1+
16 C
VTA2
31 E
E 9(A), E10(B), E11(C), E12(D), E13(E)

Engine ECU (M/T)
OX1B
O1B
HT2B
21 D
26 C
33 D
THW
19 E
1
GND
BR
BR
BW
H9
(Bank 2 Sensor 1)
BW
FP
3 D
S3
Spill Valve
FP+
6 D
VC
18 E
3
VCC
BR
B
(RHD)
Y
(LHD)
E2
RW
V1
Vacuum Sensor
Y
(RHD)
W
(LHD)
EKNK
2 D
W
(RHD)
B
(LHD)
KNK1
1 D
B
(RHD)
PSW
10 C
28 E
BR
PB
BR
26 E
RW
VCP2
RW
27 A
E2
BW
VPA2
BR
23 A
RW
EPA2
LW
29 A
VCPA
T1
and Position Sensor
26 A
BR
VPA
BR
RW
RW
BR
BR
3 : Shielded
F16
Fuel Pressure
Sensor
Y
(LHD)
(3)
22 A
B
(LHD)
GW
EPA
Y
(LHD)
YG
28 A
W
(LHD)
7 IG2
9 EA1
BR
BR
2 IG2
BR
10 EA1
1
RW
11 EA1
VC
RW
3 IG2
4 (LHD)
6 (RHD)
VCP2
B
(LHD)
2
2
VPA2
E2
BR
5 IG2
1
3
EP2
PIM
B2
16
RW
6 IG2
6
4
VCP1
A20
15
BR
1 IG2
5
5
VPA1
G
(LHD)
3
1
EP1
14
(Cont. next page)
BR
13
5 AVENSIS (Cont' d)
BW
BR
BW
BR
BR
BR
BW
C2
Camshaft Timing Oil
Control Valve
WG
(3)
(3)
K1
Knock Sensor
597
598
AVENSIS (EWD526E)
http://vnx.su
V6
VSV (Intake Air
Control Valve)
V5
VSV (EVAP)
BR
BR
BR
A6
Air Flow Meter
WG
E2
ECC
CANCEL
SET/COAST
RES/ACC
G D (RHD)
G B (LHD)
WG
BR
LB
+B
CCS
CRUISE
Skid Control ECU

with Actuator
< 2011>
W
(RHD)
Left Side of the

Cylinder Head
14 IK2
BR
GR
E2G
G C
12 IE2
B D (RHD)
D C (RHD)
D A (LHD)
SG
5
BR
EF
CG
4
WB
(LHD)
BW
LY
VG
THA
G C (RHD)
G A
WG
G C
WG
WG
G A
J 8(A), J 9(B), J20(C), J21(D)

Junction Connector
G A (LHD)
BW
GRR
CCS
Skid Control ECU

with Actuator
< 2011>
W
(LHD)
24 B
Airbag Sensor
Assembly
< 228>
D D (RHD)
D A
TS
12
WB
(LHD)
IO
Instrument
Panel
Reinforcement
RH
J16
Junction
Connector
20
6 CA
3 CB
WB
(RHD)
TC
WG
20 A
WL
SIL
WL
18 A
WG
WFSE
WL
19 A
Transponder Key
Computer< 94>
E 9(A), E10(B), E11(C), E12(D), E13(E)

Engine ECU (M/T)
SCV
THA
VG
EVG
5 E
20 E
30 E
29 E
J 8(A), J 9(B), J26(C), J27(D)

Junction Connector
WL
(4)
TACH
G
WL
(RHD)
D D
D B (LHD)
J 8(A), J20(C), J21(D)

Junction Connector
5 A
1 DL
C14
Combination SW
WG
15 DL
B A (LHD)
B C (RHD)
B A
WL
10 DD
9 DB
WL
(LHD)
8 DD
17 DB
TC
13
WL
(RHD)
A B (LHD)
30 DA
SIL
7
W
(LHD)
B D (RHD)
3 DC
WG
D C (RHD)
WFSE
15
D5
DLC3
19
WB
(RHD)
EVP1
34 E
GRR
E A (LHD)
GRR
E A
TAC
BAT
16
WL
D C
18
C ru is e C o n tro l (1 A Z F S E )
BW
BR
Combination
Meter< 424>
BR
17
5 AVENSIS (Cont' d)
WB
(RHD)
IP
Right
Kick
Panel
MultiDisplay
< 396>
J 8(A), J 9(B), J26(C), J27(D)

Junction Connector
Integration Relay
< 15> < 25>
BR
Cruise Control SW
BR
BW
BW
BW
6 AVENSIS
600
BG
AVENSIS (EWD526E)
http://vnx.su
120A ALT
BG
25A AM1
Left Kick Panel
10A GAUGE1
7. 5A OBD2
WB
WB
WB
WB
IG2 Relay
10A IGN
15A IG2
30A AM2
20A A/F
EC
W
(1)
IJ
WB
1 EA1
A/F Relay
W
(1)
2 EA1
BW
12 EA1
13 EA1
BW
Battery
4
B
WB
(1)
EFI
Relay
W
(1)
BR
FL MAIN
3. 0W
20A EFI
BG
W
(1)
BW
1 1A
BW
1 4A
BY
9 DA
7. 5A EFI NO. 2
BR
1 4B
BR
(1)
BR
BR
RB
WB
BW
(LHD)
RB
BR
GR
(1)
8 EA1
7 DB
BY
16 DL
7 DA
BR
(1)
(RHD)
GR
(LHD)
GY
5 DH 1 DN
BG
1 DH
7 CA
8 CE
RW
(M/T)
BY
1 IP1
BW
(RHD)
18 DA
1 IE4
2 DH
BR
IG2 6
ST2
GY
IG1 1
ACC
RW
(M/T)
I13
Ignition SW
4 AM2
3 AM1
GR
(1)
GR
BW
1 4D
W(1)
W(1)
BW
BR
BW
GR
BY
RW
(M/T)
RB
BW(LHD)
BW
(RHD)
(Cont. next page)
10A EFI NO. 1
GR
WB
IG1 Relay
AVENSIS (EWD526E)
http://vnx.su
BQ
BR
Under the Left

Center Pillar
WB
EF
BR
I10
ISC Valve
Left Side of the
Cylinder Head
D A
BR
(1)
WB
Under the Left

Center Pillar
WG
BR
GY
WB
V5
VSV (EVAP)
BW
(1)
+B
HT
(2)
W(1)
AF
AF+
O1B
32 D
4
E1
+B
2
3
OX
HT
1
4 IK1
J12(A), J13(B)
Junction Connector
BW
(1)
THA
20 D
D A
BR
(1)
LB
+B
HT
OX1B
21 C
L
(1)
H8
(Bank 1 Sensor 2)
L
(1)
GY
HT1B
4 B
B
(1)
BW
(1)
W(1)
GY
BR
BR
AF
A2A
30 C
EVG
32 C
BR
(1)
BR
GR
AF+
A2A+
22 C
G
(1)
B
(1)
HA2A
5 C
L
(1)
GND
W
(1)
A1A
31 C
VG
24 C
W
(1)
+B
A1A+
23 C
11 A
THA
OX2B
29 C
BW
(1)
H10
(Bank 2 Sensor 2)
+B
OX
O2B
31 D
THW
19 D
R
(1)
DUTY
HA1A
6 C
IGSW
E2G
HT
E1
E2
28 D
BR
G
(1)
BW
BW
3 B
HT2B
BR
10 IK1
(2)
GR
F25
Fuel
Pump
BY
LGB
(M/T)
12 D
PRG
J14
Junction
Connector
E1
BR
7 C
8 IK1
C9
Clutch Start SW
RSD
I6
Injector No. 2
10 C
LR
(1)
+B
I7
Injector No. 3
1 A
I8
Injector No. 4
E 9(A), E10(B), E12(C), E13(D)

Engine ECU (M/T)
J26(A), J27(B)
Junction Connector
6 IC3
FC
RB
9 A
C11
Combination Meter
10 A
RB
#4
BW
(RHD)
4 D
BW
(LHD)
#3
RB
3 D
Check Engine
I5
Injector No. 1
#2
2 D
A6
Air Flow Meter
#1
VG
3
1 D
J 8(A)
Junction
Connector
LY
CLSW
RB
10 B
E B
C A
GR
BATT
E2
3 A
C A
E2
BW
MREL
C A
+B
BR
8 A
A A
BR
BR
(RHD)
A A
22
BR
BW
GR
10 IB1
BY
7 IO1
RW
(M/T)
2 IE1
(LHD)
BW
(RHD)
7 IE3
LGB
(M/T)
BW
(RHD)
RB
BW
(LHD)
BW
RB
BW
(LHD)
15 IE2
LGB
(M/T)
9 IE2
RB
BR
GR
RW
(M/T)
(Cont. next page)

2 : Shielded
BR
BR
BW
(LHD)
BY
RW
(M/T)
RB
BW(LHD)
BW
(RHD)
E n g in e C o n tro l (1 A Z F E )
BW
(RHD)
6 AVENSIS (Cont' d)
LR
(1)
(2)
W
(1)
A8
(Bank 2 Sensor 1)
Y
(1)
(2)
W
(1)
A7
(Bank 1 Sensor 1)
L
(1)
BW
BR
C8
BR
601
602
BR
BR
LW
AVENSIS (EWD526E)
http://vnx.su
BR
K1
Knock Sensor
BR
(2)
(2)
(2)
E B
BR
Left Side of the

Cylinder Head
P2
Power Steering
Oil Pressure SW
EF
PSW
23 D
IGT1
8 D
IGT2
9 D
IGT3
10 D
11 D
IGT4
FAN
7 A

No. 1, No. 2, No. 3 or No. 4
< 43> < 44>
13 D
IGF1
SPD
17 B
26 B
IMO
STA
9 C
27 B
IMI
STP
19 B
E02
E04
E05
WB
(1)
WB
WB
WB
WB
Intake Side of
Cylinder Block
WB
(1)
EE
3 C
6 D
MPX1
23 A
12
BR
(Cont. next page)

: Unleaded Gasoline
: Shielded
: Leaded Gasoline
4 C
7 D
E01
MPX2
29 A
1
2
3
4
WB
(1)
D B
E A
BR
EOM
15 A
ELS
12 A
WB
(1)
D B
E A
(2)
E A
E B
C6
Crankshaft
Position Sensor
D A
NE+
27 D
(2)
NE
34 D
F/PS
14 A
J12(A), J13(B)
Junction Connector
G2+
RL
LGB
RW
LY
RW
P
(3)
26 D
RW
(3)
YB
(1)
EKNK
C2
Camshaft Timing Oil
Control Valve
2 C
WG
(1)
KNK1
E 9(A), E10(B), E12(C), E13(D)

Engine ECU (M/T)
Charging System
< 34>
28 B
LGB
OC1+
Airbag Sensor
Assembly< 228>
15 D
OC1
TAIL Fuse
< 142>
14 D
VAF
Diode (Fan)< 444>

32 D
VW
VC
BY
18 D
V3
Variable Resistor
RW
(3)
Combination Meter
< 423>
3 EA1

< 33>
ST Fuse (M/T)
< 33>
9 EA1
(2)
P
(3)
VAF
GW
VTA1
VCC
11
Stop Light SW
< 172>
21 D
VC
E2
10
System< 115> < 211>
1 C
T2
Throttle Position
Sensor
VTA
10 EA1
BR
(3)
E2
BR
(3)
6 AVENSIS (Cont' d)
GR
(4)
W
(4)
< 94>
WR
RW
BR
C1
Camshaft
Position Sensor
Combination
Meter< 424>
GRR
E A
B D (RHD)
WG
J 8(A), J 9(B), J26(C), J27(D)

Junction Connector
GRR
E 9(A), E10(B), E12(C), E13(D)

Engine ECU (M/T)
WL
SIL
TC
WG
WFSE
G D (RHD)
G B (LHD)
G C (RHD)
G C
D B
B A
B A
D A
D A
12 IE2
W
(LHD)
WG
WL
Skid Control ECU

with Actuator
< 216>
15 DL
WL
10 DD
G C
G A (LHD)
G A
TS
12
TC
13
J 8(A)
Junction Connector
Airbag Sensor
Assembly
< 228>
1 DL
WG
8 DD
WG
G A
WG
TACH
9 DB
WG
(4)
20 A
WL
(LHD)
17 DB
WG
30 DA
WG
WL
(RHD)
WL
(LHD)
18 A
3 DC
WL
SIL
D5
DLC3
15
WL
(LHD)
19 A
BAT
16
SG
BR
Instrument Panel
Reinforcement RH
CG
16

WB
(LHD)
WB
(LHD)
J 8(A), J 9(B)
Junction Connector
WL
(5)
MultiDisplay
< 396>
WG
(4)
Transponder Key
Computer< 94>
WG
Integration Relay
< 15> < 25>
AVENSIS (EWD526E)
http://vnx.su
WB
(RHD)
WB
(LHD)
IP
WB
(RHD)
IO
J16
Junction
Connector
6 CA
3 CB
WB
(RHD)
5 A
15
WFSE
TAC
14
WL
(RHD)
A B (LHD)
D C (RHD)
E A (LHD)
GRR
D C
13
GRR
WL
(LHD)
BR
B
W
(LHD)
6 AVENSIS (Cont' d)
Right
Kick
Panel
W
(RHD)
Skid Control ECU

with Actuator
< 216>
J 8(A), J 9(B), J26(C), J27(D)

Junction Connector
603
7 AVENSIS
604
BG
7. 5A OBD2
100A ALT
AVENSIS (EWD526E)
http://vnx.su
BG
BQ
BR
BW
WB
20A EFI
15A IG2
30A AM2
BR
Under the Left

Center Pillar
WB
BR
WB
EC
BW
12 EA1
7. 5A EFI NO. 2
BR
13 EA1
Under the Left

Center Pillar
F25
Fuel Pump
6 IC3
7 IO1
7 IE3
10 A
FC
BATT
MREL
BR
(RHD)
(LHD)
18 DA
2 DH
16 DL
1 A
+B
8 IK1
BR
E 9(A), E10(B), E12(C), E13(D)

Engine ECU (M/T)
3 A
8 A
GY
Battery
2
4
WB
BW
BG
EFI
Relay
WB
1 1A
LB
FL MAIN
3. 0W
1 4A
BW
2 IE1
BR
1 4B
BR
BY
GR
BY
BW
GY
BY
BW
10 IB1
GR
1 4D
BR
WB
1
BW
BY
1 DN
4
GR
(RHD)
IG2
Relay
RB
BY
1 IP1
BR
BR
(LHD)
IG2 6
ST2
BR
1 IE4
I13
Ignition SW
4 AM2
E n g in e C o n tro l (1 Z Z F E , 3 Z Z F E )
BR
7 DA
BW
BR
BW
RB
(Cont. next page)
10A IGN
BW
BR
BW
C8
10A EFI NO. 1
E1
BW
10
IK1
BW
BR
+B
BW
HT
BR
BR
RW
BW
T2
Throttle
Position
Sensor
LW
BR
BR
E2
1
THW
BR
BW
BR
A6
Air Flow Meter
BW
BR
2
BR
WB
BR
I10
ISC Valve
Left Side of the

Cylinder Head
DUTY
GR
GND
VISC
V5
VSV (EVAP)
BW
WG
BW
E2
+B
BR
THA
E2G
2
3
BR
VG
LY
20 D
THA
EVP1
12 D
2 D
# 20
RSO
I5
Injector No. 1
5 D
BR
GR
# 10
2
RB
RB
1 D
I6
Injector No. 2
RB
8 EA1
RB
E 9(A), E10(B), E12(C), E13(D)

Engine ECU (M/T)
VG
EVG
24 C
32 C
14 D
RB
I7
Injector No. 3
# 40
RB
4 D
I8
Injector No. 4
# 30
RB
3 D
15 D
WG
OCV+
YB
OCV
C2
Camshaft Timing Oil
Control Valve
RB
EG
EH
BR
Left Side of the

Cylinder Head
6 D
E02
E01
7 D
7 C
E1
E03
IGSW
9 A
E D (RHD)
5 C
A C (RHD)
C A (LHD)
WB
WB
BR
AVENSIS (EWD526E)
http://vnx.su
BW
BW
(LHD)
BW
BW
(RHD)
RB
B
BW
(LHD)
C A
BW
J 8(A), J26(C), J27(D)

Junction Connector
WB
C A
BW
A C
BW
Check
Engine
22
11 A
C11
Combination Meter
7 AVENSIS (Cont' d)
BR
18
IK2
BR
BR
OX
23 C
OX1A
HT1A
4 C
21 D
VTA
VC
E2
18 D
23 D
IGF
IGT4
IGT3
ELS2
IMI
13 A
26 B

< 94>
27 B
GR
H7
Heated Oxygen
Sensor
(Bank 1 Sensor 1)
IMO
TAIL Fuse
< 142>
28 D
BY
19 D
Neutral Start SW(A/T)

< 33>
ST Fuse (M/T)
< 33>
10 D
11 D
RW
8 D
9 D
(1)
IGT2
LGB
9 C
Ignition Coil and

Igniter No. 1, No. 2, No. 3
or No. 4< 43> < 44>
IGT1
LY
STA
WR
(1)
BW
1
IH2
B
BR
FAN
7 A
GW
F/PS
Stop Light SW
< 172>
14 A
LGB
19 B

< 228>
STP
3
IH2
A
B
Diode (Fan)
< 453>
FAN NO. 2 Relay
< 453>
1 : Shielded
(Cont. next page)
605
606
AVENSIS (EWD526E)
http://vnx.su
+B
(1)
D A
D A
(1)
E1
E B
D A
(1)
OX
D B
E A
D B
E A
EMPS
29 C
(1)
BR
RL
27 A
(1)
HT
(1)
4 IH2
2 EB1
W
B
1 EB1
2 IH2
FKN+
1 C
MPX1
23 A
E A
GRR
BW
7 IK2
(1)
(1)
FKN
2 C
MPX2
29 A
A B (LHD)
B D (RHD)
A B
B D
Left Side of
the Cylinder Head
J12(A), J13(B)
Junction
Connector
J 8(A), J 9(B), J26(C), J27(D)

Junction Connector
OX1B
E 9(A), E10(B), E12(C), E13(D)

Engine ECU (M/T)
(1)
TACH
5 A
EH
BR
SPD
System< 115> < 211>
21 C
VW
17 B
Charging System
< 34>
HT1B
R
GR
G2
EPS ECU
< 234>
4 B
26 D
Combination Meter
< 423>
GRR
NE
D C (RHD)
D C
WFSE
19 A
34 D
C6
Crankshaft
Position Sensor
E A (LHD)
WFSE
15
SIL
18 A
WG
NE+
GR
6 IK2
GRR
E A
TAC
BAT
16
TC
20 A
D5
DLC3
12
1 : Shielded
(1)
(1)
WL
WG
(1)
(1)
(Cont. next page)
WL
27 D
Combination
Meter< 424>
11
GRR
BR
10
7 AVENSIS (Cont' d)
(1)
BR
BR
K1
Knock Sensor
C1
Camshaft
Position Sensor
R
(1)
BW
H17
Heated Oxygen
Sensor
(Bank 1 Sensor 2)
BR
WL
WG
WL
G D
G B
G C
G D (RHD)
G B (LHD)
G C (RHD)
G A (LHD)
D D
D B
B C
B A
B A (LHD)
D D (RHD)
D B (LHD)
B C (RHD)
J 8(A), J 9(B), J20(C), J21(D)

Junction Connector
W
(LHD)
WL
(RHD)
W
Skid Control ECU

with Actuator
< 216>
B D (RHD)
B B (LHD)
D C (RHD)
W
(RHD)
D A (LHD)
SG
W
(RHD)
EPS ECU
< 234>
Left Side of the

Cylinder Head
14 IK2
BR
12 IE2
D A
D C
TS
12
WB
(LHD)
BR
J 8(A), J 9(B), J20(C), J21(D)

Junction Connector
J 8(A), J 9(B), J26(C), J27(D)

Junction Connector
WL
(2)
MultiDisplay
< 396>
WG
EPS ECU
< 234>
WG
Integration
Relay< 15> < 25>
WG
Transponder Key
Computer< 94>
AVENSIS (EWD526E)
http://vnx.su
WB
(LHD)
WB
(LHD)
BR
IO
Instrument Panel
Reinforcement RH
J16
Junction
Connector
6 CA
3 CB
IP
WB
(RHD)
EG
CG
4
16
WB
(RHD)
(1)
1 DL
WG
15 DL
G A
WG
G C
WG
G A
WL
10 DD
9 DB
TC
13
15
1 : Shielded
2 : Navigation System (Map Type)
WB
(RHD)
WG
17 DB
WL
30 DA
D5
DLC3
WL
(LHD)
8 DD
3 DC
SIL
7
14
W
(LHD)
(1)
WL
WG
(1)
13
(1)
7 AVENSIS (Cont' d)
Right Kick
Panel
W
(LHD)
W
(RHD)
WL
(RHD)
WL
(LHD)
EPS ECU
< 234>
Skid Control ECU

with Actuator
< 216>
Airbag Sensor
Assembly
< 228>
607
608
AVENSIS (EWD526E)
http://vnx.su
1
BR
80A GLOW
EI
BW
WB
140A ALT
EC
7 EE1
RB
BW
Near the
Starter
BW
EFI MAIN Relay
4 IE2
10 EE1
EDU Relay
WB
IJ
10A GAUGE1
G1
Glow Plug
G2
Glow
Plug
Relay
14 A
Multiplex
Communication
System
< 115> < 211>
13 A
BEAN I/F
CPU
6 CD
21 B
5 B
6 CA
6 CK
WB
BR
10A IGN
BW
Left Kick Panel
9 DA
1 1A
18 DA
BW
20 B
H B
7 CA
WB
IP
Glow
Right Kick Panel
9 B
22 B
C10(A), C11(B)
Combination Meter
8 CE
RW(RHD)
RW(LHD)
GR
BY
BW
BW
(Cont. next page)
BW
FL MAIN
3. 0W
BW
7 DB
BY
BY
7 DA
F C (RHD)
F A (LHD)
CRUISE
BR
GY
BL
5 DH 1 DN
BR
2 DH
2 IE1
F C
RW
E n g in e C o n tro l (1 C D F T V )
WR
(RHD)
GR
1 DH
RW
(RHD)
GY
BY
1 IP1
I13
Ignition SW
ST2
IG2 6
IG1 1
GR
(RHD)
(LHD)
4 AM2
BR
1 IE4
3 AM1
GR
ACC
GR
BW
5 IP1
(LHD)
WR
G lo w P lu g
J10(A), J11(B), J26(C)

Junction Connector
WR
(LHD)
Check Engine
BL
RW
7. 5A DOME
4 IE4
WR
1 ED1
8 AVENSIS
BW
7. 5A OBD2
IG1 Relay
25A AM1
30A AM2
20A EFI
30A DCC
Battery
AVENSIS (EWD526E)
http://vnx.su
BW
BW
BW
BW
BW
BW
BW
1 EC1
BR
BR
BR
THF
29 D
THIA
20 D
RL
9 C
IMO
29 B
BR
E2
VC
VC
18 D
IMI
30 B
PIM
PIM
28 C
PCV+
2 D
PCV
1 D
RW
BR
T5
Turbo Pressure
Sensor
D1
Diesel Throttle
Control Motor
BW
THA
E2G
E2
E3
EGR Valve
Control Motor
+B
VG
BW
B1
YG
B2
BW
8 IK1
S2
LY
J 8(A), J 9(B), J26(C), J27(D)

Junction Connector
S4
RL
S1
S3
BW
2 EC1
E2
28 D
ALT
8 D
GR
THW
19 D
STP
19 B
I9
3
6
GB
VG
EVG
THA
24 C 32 C 31 D
V4
VRV (EGR)
GR
VN
10 D
GREL
14 A
RW
+B
1 A
PTC1
WR
BW
(LHD)
LU+B LUB
13 D 12 D
GR
LU+A LUA
15 D 14 D
BY
EG+A EGA EG+B EGB

6 C
5 C
4 C
3 C
BY
STA
R
RW
BW
BW
(RHD)
IREL
10 A
ST Fuse
< 33>
11 B
RW
(1)
7 A
GW
BATT
BL
2 B
Charging System
< 34>
MREL
8 A
10 IK1

< 94>
W
12 A
LGB
(RHD)
E 9(A), E10(B), E12(C), E13(D)

Engine ECU (M/T)
6
IR1
GR
10 B
LGB
(RHD)
LGB
(LHD)

< 488> < 498>
(RHD)
LGR
ST1
12 B
15
IE2
C9
Clutch
Start SW
(LHD)
LG
IGSW
LGB
(LHD)
7 IO1
7 IE3
S6
Suction Control
Valve
9 A
GW
(RHD)
GW
(LHD)
RW
(RHD)
4
IR1
14
IE2
Stop Light
System< 172>
RW
(RHD)
RW
(LHD)
(Cont. next page)
LG
GW
(RHD)
GW
(LHD)
BW
(RHD)
BW
(LHD)
5
IR1
9
IE2
Stop Light SW
< 172>
A C (RHD)
C A (LHD)
3
IR1
20
IE1
RW
(LHD)
Alternator
< 33>
A C
C A
E D (RHD)
BW
(RHD)
BW
(LHD)
S13
Stop
Light SW
C A
E D
C B (LHD)
RW(RHD)
RW(LHD)
GR
BY
BY
8 AVENSIS (Cont' d)
BR
RW
F18
Fuel Temp. Sensor
BR
BR
BR
E2
EFI Water Temp.
Sensor
BR
A6
Air Flow Meter
BR
BW
BW
BW
BW
BW
BW
BW
BW
609
610
B
(LHD)
Y
(LHD)
G
(RHD)
G
(LHD)
B
(RHD)
B
(LHD)
RW
AVENSIS (EWD526E)
http://vnx.su
G
RW
6 EB1
(Shielded)
BR
COM1
COM2
INJ# 4
INJ# 1
E 4(A), E 5(B)
6 A
3 A
4 A
5 A
I5
Injector No. 1
IJT# 4
5 B
IJT# 3
2 B
I8
Injector No. 4
IJT# 2
3 B
IJT# 1
6 B
INJ# 2
2 A
PRD
4 B
I6
Injector No. 2
IJF
7 B
NEO
17 A
INJ# 3
1 A
BR
4 EB1
B
(RHD)
8 A
ENG
30 A
I7
Injector No. 3
BATTERY
BR
ENG+
24 A
PRV
8 B
COM3
7 A
2 EA1
1 EA1
SP1
17 B
12
BR
F16
Fuel Pressure
Sensor
TRC
31 A
VC
TRC+
25 A
E2
PR2
RW
PR
BR
E2S
RB
VCS
RL
#1
24 D
GW
#4
21 D
#3
22 D
#2
23 D
WR
PRD
32 D
21 A
MPX1
MPX2
E 9(A), E10(B), E12(C), E13(D)
Engine ECU (M/T)
20 A
RW
INJF
25 D
FAN
3 A
WL
2 EB1
BR
5 EB1
PB
3 EB1
PB
1 EB1
PCR2
33 D
B
(LHD)
PCR1
26 D
W
(RHD)
E2S
1 C
W
(LHD)
EPA2
Y
(RHD)
VCS
2 C
Y
(LHD)
29 A
VPA2

23 A
System< 115> < 211>
VCP2
G
(w/ VSC)
27 A
L
(w/ VSC)
EPA
Y
(w/ VSC)
28 A
Skid Control ECU

with Actuator< 207>
VPA
3 IG2
G
(LHD)
2 IG2
1 (LHD)
3 (RHD)
EP2
B
(w/ VSC)
22 A
2
2
VPA2
YB
(w/ VSC)
VCPA
Y
(LHD)
7 IG2
B
(LHD)
1 IG2
4
6
VCP2
W
(LHD)
6 IG2
3
1
EP1
11
VW
26 A
5
5
VPA1
Y
(LHD)
5 IG2
A20
10
Combination
Meter< 423>
B
6
4
VCP1
(Shielded)
GND
1 B
WB
(Shielded)
(Cont. next page)
RW
BR
P3
Pressure Discharge Valve
8 AVENSIS (Cont' d)
(Shielded)
Y
(RHD)
RW
PL
AVENSIS (EWD526E)
http://vnx.su
WB
BR
EI
ECC
E B
E B
D A
BR
CANCEL
BR
D A
E B
E A
D B
E A
D B
BR
RES/ACC
CRUISE
G D (RHD)
G B (LHD)
E A
(Shielded)
(Shielded)
12 IE2
Skid Control ECU

with Actuator
< 2011> < 216>
B D (RHD)
BR
Behind the
Combination Meter
Junction
Connector
J16
W
(RHD)
SET/COAST
W
(2)
Skid Control ECU

with Actuator
< 2011> < 216>
Integration
Relay
< 15> < 25>
CCS
(Shielded)
(Shielded)
Airbag Sensor
Assembly
< 228>
J 8(A), J 9(B), J26(C), J27(D)

Junction Connector
T3
WB
Near the Starter
CCS
24 B
TC
J 8(A), J 9(B), J20(C), J21(D)

Junction Connector
EOM
15 A
11 A
SIL
D D (RHD)
D D
D B (LHD)
D C (RHD)
D A (LHD)
SG
5
CG
4
WB
(LHD)
(Shielded)
C1
Camshaft Position
Sensor
W
WB
(Shielded)
WG
(Shielded)
18 A
G C (RHD)
G C
W
(LHD)
E02
6 D
J 8(A), J 9(B), J26(C), J27(D)

Junction Connector
E 9(A), E10(B), E12(C), E13(D)

Engine ECU (M/T)
E01
E1
THOP
7 D
7 C
11 D
GRR
WFSE
19 A
WB
(LHD)
IL
6 CA
3 CB
WB
(RHD)
C6
Crankshaft
Position Sensor
WL
(3)
TACH
WG
5 A
WL
G1
WL
23 C
WG
WL
31 C
G A (LHD)
G A
D A
TS
12
16
WB
(LHD)
WL
(RHD)
NE
WG
34 D
G C
G A
WG
B D (RHD)
WG
1 DL
Transponder
Key Computer
< 94>
WG
15 DL
B A (LHD)
B C (RHD)
B A
WL
10 DD
9 DB
WL
(LHD)
8 DD
17 DB
J 8(A), J20(C), J21(D)

Junction Connector
NE+
GRR
30 DA
TC
13
W
(LHD)
A B (LHD)
3 DC
SIL
7
WL
(RHD)
D C (RHD)
D5
DLC3
15
2 : w/ Cruise Control
WB
(RHD)
27 D
Combination
Meter< 424>
E A (LHD)
GRR
E A
WFSE
15
14
C ru is e C o n tro l (1 C D F T V )
D C
TAC
BAT
16
13
WG
WL
8 AVENSIS (Cont' d)
WB
(RHD)
IP
Right Kick
Panel
MultiDisplay
< 396>
BR
BR
BR
BR
(2)
J12(A), J13(B)
Junction
Connector
C14
Combination SW
Cruise Control SW
BR
BR
WB
(Shielded)
WB
611
9 AVENSIS
612
W
(2)
W
(2)
B
(2)
50A AM1 NO. 1
AVENSIS (EWD526E)
http://vnx.su
7. 5A ECUB 1
140A ALT
F19
30A AM2
BG
(1)
B
(2)
Right Kick Panel
WB
(LHD)
IP
A
A
WB
(RHD)
WB
(RHD)
WB
(LHD)
6 CA
WB
(RHD)
Theft Deterrent ECU

< 28>
120A ALT (3)

100A ALT (4)
IL
Behind the
Combination Meter
J16
Junction
Connector
Unlock Warning SW
< 120> < 217>
Battery
V
(5)
FL MAIN
3. 0W
9 CH
WB
(LHD)
5 CI
8 (LHD)
1 (RHD)
IMB
SEC
KSW
10
CTY
1 4B
1 (LHD)
8 (RHD)
14
GND
VC5
CODE
TXCT
T8
11
12
9
D
EFII
7
50A AM1 NO. 1
IND
10A IGN
BG
(1)
1 4A
BW
VC5
1
AGND
CODE
13
TXCT
+B
GND
WR
IG
I12
GRR
4 DA
2 DH
LR
BR
YG
W
(1)
I13
Ignition SW
IG2 6
ST2
YB
1 1A
(RHD)
(LHD)
4 AM2
WG
1 1B
1 IP1
1 IE4
BR
E n g in e Im m o b ilis e r S y s te m
DLC3< 519> < 615>

< 713> < 815>
1 6A
BR
W
(1)
(RHD)
(LHD)
WR
BR
2 IP1
1 IE5
1
2
3
4
5
EFIO
: Gasoline
: 1CDFTV
: 1AZFSE, 1AZFE
: 1ZZFE, 3ZZFE
GR
< 511> < 611> < 77>
Engine ECU (M/T)
< 511> < 611> < 77> < 88>

< 119>
< 216>
614
BG
AVENSIS (EWD526E)
http://vnx.su
1
E
SNOW
25
120A ALT
BG
23
B
Left Kick Panel
WB
IJ
14 DA
9 DA
Battery
BG
1 1A
IG1 Relay
FL MAIN
3. 0W
GR
I14(A)
Integration
Relay
16 DB
11 A
MPX1
IG
22
Multiplex
Communication
System
< 115> < 211>
22 A
MPX2
7 DB
10A GAUGE1
1 4B
7. 5A DOME
30A DCC
BW
7. 5A ECUB 2
BR
27 DA
WR
BW
5 DH 1 DN
BY
GR
1 DH
WB
EC
GR
BY
GY
(RHD)
BG
1 IP1
RW
5 IP1
(LHD)
(RHD)
(LHD)
10A EFI NO. 1

BW
EFI Relay
3 IP1
2 IE4
BR
BR
1 IE4
8 CA
RW
3 CD
7 CA
6 CD
1 CG
21 B
RW
4 IE4
I13
BR
Ignition SW
BR
1 CD
F A (LHD)
F C (RHD)
H B
20 B
5 B
F C
A/T SHIFT
CLOCK
RW
WB
Combination Meter
BR
GR
BY
BR
GR
RW
13 A
BEAN I/F
14 A
C10(A), C11(B)
CPU
J10(A), J11(B),
J26(C)
Junction Connector
WR
(LHD)
IG2 6
WR
10 CC
RW
ST2
4 AM2
BR
GY
RW
IG1 1
3 AM1
(Cont. next page)
Multiplex
Communication
System
< 115> < 211>
1 4D
WR
GR
1 IK1
E C T a n d A /T In d ic a to r (1 A Z F S E )
RW
WR
ACC
RW
WR
1 4A
10 AVENSIS
WB
WR
(RHD)
ECT SNOW
BW
BY
7. 5A GAUGE2
25A AM1
20A EFI
30A AM2
10A THROTTLE
AVENSIS (EWD526E)
http://vnx.su
WB
(LHD)
WB
Right Kick Panel
WB
EE
WB
Intake Side of
Cylinder Block
WB
EF
BR
BR
WB
WB
(RHD)
IP
J8
Junction
Connector
Left Side of the
Cylinder Head
1
THO
J17
Junction
Connector
WB
(LHD)
Behind the
Combination Meter
6
E2
THO
32 D
SLT+
SLT+
13 D
SLT
SLT
12 D
DSL
11 D
DSL
STA
17 E
SL2+
ECT Solenoid
E1
SL2+
16 D
SL2
VTA2
31 E
SL2
VTA1
21 E
17 D
VC
18 E
IK
E2
28 E
PL
J15
Junction
Connector
E A
D B
ME01
4 C
EOM
15 A
MPX1
18 B
LB
E1
1 C
MPX2
29 B
6 CA
E02
6 E
+BM
6 B
RB
6 CK
E01
7 E
IGSW
9 A
SL1+
2 C
SL1+
19 D
M+
3 C
SL1
10
18 D
SL1
THW
19 E
Engine Control System

< 511> < 512> < 514> < 515>
8 IG2
W
(LHD)
4 IG2
E03
7 C
BATT
3 A
5 IE2
YB
WB
11 CF (LHD)
8 CH (RHD)
6 CJ
KD
30 B
MREL
8 A
10A
IGN
S4
STP
19 B
S4
10 D
SPD
17 B
RW
(Cont. next page)
WB
R
WB
(LHD)
J14(A), J28(B)
Junction
Connector
W
(LHD)
+B
1 A
E B
A A
BW
(RHD)
BR
+B2
(RHD)
(LHD)
J26(A), J27(B)
Junction
Connector
E 9(A), E10(B), E11(C), E12(D), E13(E)

BR
2 A
BR
SPT1
GR
20 B
7 IO1
7 IE3
BY
SFTD
2 IE1
BW
(LHD)
21 B
D B (RHD)
D A (LHD)
18 DA
2 DH
BR
BW
(LHD)
SFTU
D B
D A
D B (RHD)
BW
(RHD)
GY
22 B
IG
D A (LHD)
BR
SFTD
GR
SFTU
T7
Transmission
Control SW
System< 115> < 211>
BY
RW
BR
GR
BY
BR
GR
RW
GR
10 AVENSIS (Cont' d)
BR
J12(A), J13(B)
Junction Connector
BR
BR
WB
K2
Kick Down SW
E8
WB
615
616
RW
BO
C5
Counter Gear Speed
Sensor
LG
LGB
T4
D
10 B
E 9(A), E10(B), E11(C), E12(D), E13(E)

NT
35 D
J14(A), J19(B)
Junction
Connector
NT+
LGB
27 D
N
7 A
NC+
C B
11 B
RY
(LHD)
26 D
D B (RHD)
C A (LHD)
A A
RY
(RHD)
D B (RHD)
RY
(LHD)
NC
LGB
C A (LHD)
5 IK1
RL
J5
Junction
Connector
N1
Neutral Start SW
20 IK2
PL
6 A
WL
34 D
LGB
9 IK2
NL
3
RB
10
RY
10 IK2
DL
RW
11
WL
12
J22(A), J23(B)
Junction
Connector
RY
(RHD)
AVENSIS (EWD526E)
http://vnx.su
618
BG
120A ALT
AVENSIS (EWD526E)
http://vnx.su
BG
Battery
30A DCC
BG
1 1A
BW
FL MAIN
3. 0W
7. 5A DOME
BR
1 4B
BW
9 DA
WB
IJ
IG1 Relay
Left Kick Panel
7 DB
BY
BR
27 DA
WB
EC
GR
GY
5 DH 1 DN
10A EFI NO. 1

BW
EFI Relay
BR
GR
1 DH
5 B
21 B
F C
F A (LHD)
H B
20 B
BEAN I/F
14 A
RW
BR
GR
BY
BR
RW
13 A
WB
Combination Meter
C10(A), C11(B)
A/T SHIFT
CLOCK
CPU
F C (RHD)
J10(A), J11(B),
J26(C)
Junction Connector
BY
BG
(RHD)
RW
1 IP1
RW
5 IP1
(LHD)
RW
1 IE4
BR
12 EA1
6 CD
1 CG
7 CA
WR
(LHD)
4 IE4
8 CA
1 CD
RW
I13
Ignition SW
BR
(Cont. next page)
Multiplex
Communication
System
< 115> < 211>
1 4D
IG2 6
4 AM2
BR
GY
RW
ST2
IG1 1
3 AM1
GR
1 IK1
E C T a n d A /T In d ic a to r (1 A Z F E )
RW
WR
ACC
RW
WR
1 4A
11 AVENSIS
WR
(RHD)
WB
BW
BY
10A GAUGE1
7. 5A GAUGE2
25A AM1
20A EFI
30A AM2
WB
AVENSIS (EWD526E)
http://vnx.su
V
BR
W
(1)
WB
(1)
WB
(1)
Right Kick Panel
PL
WB
WB
(LHD)
WB
(RHD)
IP
Behind the
Combination Meter
3
DSL
SL2+
SL2+
17 C
E1
ECT Solenoid
IK
7
SLT
DSL
11 C
LB
2
SLT+
SLT
16 D
6 CA
1
THO
SLT+
17 D
NC
34 C
16 C
SL2
MPX2
29 A
SL2
E 9(A), E10(B), E12(C), E13(D)

NC+
26 C
RB
J15
Junction
Connector
WB
6 CK
6
E2
THO
30 D
NT
35 C
SL1+
19 C
SL1+
MPX1
23 A
2 IG1
W
(1)
1 IG1
E2
28 D
NT+
27 C
SL1
SL1
10
18 C
STA
9 C
YB
6 CJ
KD
27 A
IGSW
9 A
S4
13 C
S4
STP
19 B
BATT
J 8(A)
Junction
Connector
J17
Junction
Connector
3 A
T4
BR
MREL
BY
8 A
BW
(LHD)
+B
BO
1 A
J26(A), J27(B)
Junction Connector
BW
BW
(RHD)
(RHD)
E B
A A
SPT1
C A
C A
LG
20 B
(RHD)
C5
LGB
SFTD
7 IO1
(LHD)
System< 115> < 211>
21 A
7 IE3
10A
IGN

< 611>
SFTU
SFTD
2 IE1
GR
8 IK1
18 DA
2 DH
BR
SPD
17 B
VC
18 D
1 : Europe
VTA1
21 D
THW
19 D
RW
(Cont. next page)

< 68> < 69>
22 A
SFTU
IG
BR
BW
(LHD)
T7
Transmission
Control SW
GR
WB
RW
BR
GR
BY
BR
RW
BY
BR
K2
Kick Down SW
619
620
RW
LGB
(LHD)
LGB
(RHD)
7 D
E01
15 A
EOM
BR
AVENSIS (EWD526E)
http://vnx.su
E A
D B
WB
WB
WB
(2)
WB
(2)
Left Side of the

Cylinder Head
J12(A), J13(B)
Junction Connector
BR
EF
21 B
WL
Intake Side of
Cylinder Block
7 C
E1
22 B
A B
A A
A B
A A
D B
D A
RY
(RHD)
J5
Junction
Connector
RY
(LHD)
5 IK1
RL
N1
Neutral Start SW
A B
A A
C B
A A
PL
20 IK2
J22(A), J23(B)
Junction Connector
EE
6 D
E02
E 9(A), E10(B), E12(C), E13(D)

RY
(LHD)
RB
D B (RHD)
D A (LHD)
Junction
Connector
J18(A), J29(B)
D B (RHD)
D A (LHD)
WL
4 C
E04
RY
(LHD)
11 B
LGB
(LHD)
J14
Junction
Connector
LGB
RY
(RHD)
10 B
LGB
(RHD)
9 IK2
NL
10 IK2
DL
RW
11
RY
RY
(RHD)
LGB
(LHD)
10
WL
3 C
E05
12
WL
Diode
< 215>
WL
BR
622
BG
AVENSIS (EWD526E)
http://vnx.su
1 1A
1
E
SNOW
25
100A ALT
BG
23
B
Left Kick Panel
WB
IJ
14 DA
9 DA
Battery
BG
IG1 Relay
FL MAIN
3. 0W
1 4A
30A DCC
BW
I14(A)
Integration
Relay
MPX2
11 A
MPX1
IG
22
Multiplex
Communication
System
< 115> < 211>
22 A
10A GAUGE1
1 4B
7. 5A ECUB 2
BR
7 DB
WB
EC
10A EFI NO. 1

BW
EFI Relay
21 B
F C
5 B
WR
(RHD)
BW
27 DA
WR
16 DB
BY
BR
5 DH 1 DN
GR
GR
1 DH
BR
BY
GY
(RHD)
BG
1 IP1
RW
5 IP1
(LHD)
BR
12 EA1
6 CD
1 CG
RW
1 IE4
8 CA
RW
3 CD
7 CA
F A (LHD)
20 B
H B
RW
C10(A), C11(B)
WB
Combination Meter
BR
GR
BY
BR
RW
13 A
BEAN I/F
14 A
A/T SHIFT
CLOCK
CPU
F C (RHD)
J10(A), J11(B),
J26(C)
Junction Connector
WR
(LHD)
4 IE4
I13
Ignition SW
WR
1 CD
RW
10 CC
(Cont. next page)
Multiplex
Communication
System
< 115> < 211>
1 4D
BR
RW
ST2
IG2 6
4 AM2
BR
GY
1 IK1
RW
IG1 1
3 AM1
GR
ACC
E C T a n d A /T In d ic a to r (1 Z Z F E )
WR
WR
WR
RW
12 AVENSIS
WB
ECT SNOW
BW
BY
7. 5A GAUGE2
25A AM1
20A EFI
30A AM2
7. 5A DOME
AVENSIS (EWD526E)
http://vnx.su
WB
Right Kick Panel
WB
EH
BR
Left Side of the

Cylinder Head
EG
WB
WB
(RHD)
WB
WB
(LHD)
IP
Left Side of the

Cylinder Head
WB
Behind the
Combination Meter
WB
(LHD)
OT
30 D
THO
SPD
17 B
S1
3
SLT+
8
SLT
S1
15 C
SLT
16 D
SLT+
17 D
THW
19 D
VTA
21 D
VC
18 D
S2
10
14 C
S2
10 B
ECT Solenoid
E1
IK
WB
(LHD)
E2
28 D
E2
STP
19 B
BR
E02
6 D
STA
9 C
6 CA
E01
7 D
MPX1
23 A
PL
J15
Junction
Connector
6 CK
E1
7 C
MPX2
29 A
WB
11 CF (LHD)
8 CH (RHD)
2 IG1
W
(LHD)
1 IG1
W
(LHD)
6 CJ
E03
5 C
NT
35 C
PL
KD
12 B
NT+
27 C
J17
Junction
Connector
E 9(A), E10(B), E12(C), E13(D)

IGSW
9 A
SL
13 C
SL
11 B
B
BW
(RHD)
SB
19 C
SB
22 B
WB
BATT
J26(A), J27(B)
Junction
Connector
ST
12 C
LGB
WL
RY(LHD)
21 B
ST
RW
RY
(RHD)
RB
BR
3 A
BY
MREL
BO
8 A
+B
System< 115> < 211>
1 A
LGB
SPT
RY(LHD)
8 B

< 77> < 78> < 710>
RY(RHD)
SFTD
J 8(A)
Junction Connector
BW
(LHD)
C A
C B
A A
J22(A), J23(B)
Junction Connector
RY(RHD)
30 B
E B
C A
10A
IGN
SFTU
A A
18 DA
2 DH
BR
(Cont. next page)
WL
23 B
(RHD)
(LHD)
BW
(RHD)
7 IO1
7 IE3
BW
(LHD)
2 IE1
GR
8 IK1
BR
SFTD
IG
3
GR
SFTU
BY
T7
RW
BR
GR
BY
BR
RW
RY
(RHD)
LG
GR
T4
K2
Kick Down SW
E8
WB
623
624
WL
LGB
WL
RB
A B
A B
A A
A A
A B
A A
RY(LHD)
RY
(RHD)
D B
D A
J5
Junction
Connector
D B (RHD)
D A (LHD)
J18(A), J29(B)
Junction Connector
D B (RHD)
D A (LHD)
20 IK2
PL
5 IK1
RL
N1
Neutral Start SW
10
RY
(LHD)
RY(LHD)
NL
9 IK2
LGB
R
10 IK2
DL
RW
R
WL
RY
LGB
RY
(RHD)
RW
WL
11
12
WL
Diode
< 215>
AVENSIS (EWD526E)
http://vnx.su
: Gasoline
: 1CDFTV
: LHD 1CDFTV, RHD
: RHD w/ HID
: LHD Except 1CDFTV
1
2
3
4
5
6
7
8
9
Engine
Compartment
Right
B B
B A
B B
B A
3
3
RW
RW
RY
(w/ HID)
RY
(w/ HID)
EA
12 B
2
RL
(w/o HID)
2
2
J 3(A), J 4(B)
Junction
Connector
RL
D
A
E
B
RW
H5
Headlight
LH (High)
WR
RW(w/ HID)
R (w/o HID)
H6
Headlight RH (High)
1
2
10A
HLP HI LH
Engine
Compartment
Left
WB
ED
E
E
RY
(8)
RW
Behind the
Combination Meter
HF
HU
HL
H
Instrument Panel
Reinforcement RH
16
Dimmer SW
AVENSIS (EWD526E)
http://vnx.su
1 4B
BG
(1)
B
(2)
1 4A
BG
(1)
1 1A
40A MAIN
WB
(9)
High
Low
Flash
Tail
Light
Control
SW
Head
OFF
RY
(3)

< 488> < 498>
WL
IL
RY(8)
RY(6)
RY
(3)
13 AVENSIS
WB
(4)
13
D B
RY
D B
(7 w/ HID)
RY
(5)
D B
E A
RY
E A
Headlight Cleaner
Relay< 284>
C12
Combination SW
EL
2
5
2
2
WL
HLP Relay
RY
RY(6)
RY(8)
J 3(A), J 4(B)
Junction
Connector
WL
WR
WR
J29
Junction
Connector
IO
C A
E
WB
RY
(8)
RY
(8)
B
(2)
Battery

Control ECU< 243>
RY
(6)
FL MAIN
3. 0W
RY
(8)
C B
< 284>
C B
RY
(LHD w/ HID)
C A

Control ECU< 243>
J 6(A), J 7(B)
Junction
Connector
RY
(6)
EC
WB
Engine
Compartment
Left
WB
(w/ HID)
R
(w/ HID)
RY
(LHD 7)
Engine
Compartment
Right
WB
WB
(w/o HID)
F7
< 284> < 304>
EB
WB
J2
Junction
Connector
WR
R
(w/o HID)
WB
WB
(w/ HID)
F8
Headlight LH (Low)
R
(w/o HID)
15A
HLP LH
RB
(w/ HID)
WB
(w/o HID)
F9
15A
HLP RH
RL
(w/o HID)
RL
(w/o HID)
F10
Headlight RH (Low)
H e a d lig h t (w /o D a y tim e R u n n in g L ig h t)
High Beam
RL
RL
(w/ HID)
RL
(w/o HID)
D
A
J 3(A), J 4(B)
Junction
Connector
D
10A
HLP HI RH
6 A
C10(A), C11(B)
Combination Meter
RW(w/ HID)
R (w/o HID)
625
626
BG
(3)
120A ALT (5)

100A ALT (6)
B
(4)
BG
(3)
AVENSIS (EWD526E)
http://vnx.su
Behind the
Combination
Meter
Light Control
SW
G
WB
(LHD 4, RHD)
C12
Combination SW
WB
(LHD 3)
140A ALT
WB
WB
EB
F2
Engine
Compartment
Right
IK
Behind the
Combination
Meter
BS
WB
Engine
Compartment
Left
J15
Junction
Connector
Lower Back
Panel Left
WB
J31(B)
Lower Back
Panel Center
Junction
Connector
2 C (W/G)
2 B (L/B)
3 C (W/G)
3 B (L/B)
6 A (S/D)
BT
WB
EC
F1
WB
(RHD)
WB
(S/D)
C B
L2
C B
C B
R14(A), (B), (C)

J30(A), J31(B)
Junction
Connector
3 BE2
C B
B A
6 BG2
3 BD2 (L/B)
1 BF2 (W/G)
C B
J33(A), J34(B)
A B
A B
BX
Right Side of
the Back Door
A B
Junction
Connector
J34(B)
Junction
Connector
WB
(7)
IL
WB
(LHD)
R13(A), (B), (C)

J17
Junction
Connector
WB
(S/D)
IO
WB
(RHD)
WB
(S/D)
C10(A), C11(B)
Combination Meter
J16
Junction
Connector
4 C (W/G)
4 A (S/D)
A B
G
(7)
L1
License Plate
Light LH
WB
(7)
WB
(LHD 4)
WB
(LHD 3)
5 B (L/B)
2 A (S/D)
Tail
Tail
17 A
5 C (W/G)
6 B (L/B)
Tail
G
(7)
Instrument Panel
Reinforcement RH
16
14 B
J10(A), J11(B),
J26(C), J27(D)
Junction
Connector
Head
J1
Junction
Connector
G
(L/B)
Tail
EL
4 A (S/D)
4
: Gasoline
: 1CDFTV
: 1AZFSE, 1AZFE
: 1ZZFE, 3ZZFE
: L/B, W/G
G
(W/G)
L2
License Plate
Light RH
WB
(7)
Battery
OFF
C C (RHD)
C A (LHD)
A B
R
(2)
C C
C A
G
(S/D)
9 DL
8 DL
A B
L1
G
(S/D)
A B
A A
1
2
3
4
5
6
7
G
(L/B)
14
12 DB
R
(1)
23 DA
C D (RHD)
C B (LHD)
A B
A A
G
(W/G)
FL MAIN
3. 0W
12
10A
TAIL
G
(3)
1 4B
TRLY
Integration
Relay
13

< 510> < 611> < 77>
Engine ECU (M/T)
< 510> < 611> < 77>
3 IC2
G
(7)
W
(4)
TAIL
Relay
4 DM
1 DN
T a illig h t
1 4D
BL
(4)
BG
(3)
1 ED1
14 AVENSIS
BL
(2)
W
(2)
BG
(1)
B
(2)
10A HAZARD
B
(2)
BG
(1)
AVENSIS (EWD526E)
http://vnx.su
Turn
120A ALT (3)

100A ALT (4)
BG
(1)
F 7(A), F 8(B)
F5
Front Side Turn
Signal Light LH
7. 5A GAUGE2
Engine
Compartment
Left
Engine
Compartment
Right
WB
EB
R14(A), (B), (C)

Rear Combination
Light RH
F6
Front Side Turn
Signal Light RH
WB
(RHD)
WB
Battery
Lower Back Panel

Center (S/D, L/B)
Lower Back Panel
Right (W/G)
WB
BT
WB
WB
WB
IO
J16
Junction
Connector
Instrument
Panel
Reinforcement
RH
WB
(LHD 1)
6 CA
IP
WB
IK
WB
EC
GY
(LHD)
J15
Junction
Connector
WB
WB
Lower Back
Panel Left
WB
WB
(LHD 2)
WB
(LHD)
11 CF
9 CD 3 CH
IL
WB
(RHD)
BS
GW
3 C (W/G)
WB
WB
F 9(A), F10(B)
Front Turn Signal
Light RH
WB
(LHD)
6 A (S/D)
3 B (L/B)
TR
GND
WB
(LHD)
J17
4 B (6)
GY
Junction
Connector
WB
(RHD)
Turn
4 C (W/G)
TB
WB
(LHD)
4 B (6)
4 A (5)
4 C (W/G)
5 B (L/B)
5 A (S/D)
TL
ER
6
WB
(RHD)
5 B (L/B)
17 A
11 DM
RH
EL
5
F C (RHD)
D A (LHD)
J16
Junction
Connector
IJ
25A AM1
Turn RH
2 A (S/D)
IG1 Relay
3 B (6)
3 A (5)
6 DL
LH
Off
8
EHW
J10(A), J11(B), J24(C), J25(D)

Junction
Connector
WB
(RHD)
Left Kick Panel
GW
FL MAIN
3. 0W
GW
4 A (5)
5 DL
15 DB
C12
Combination SW
3 B (6)
GW
(LHD)
3 A (5)
13 B
GY
3 C (W/G)
E B
J5
Junction
Connector
D
Integration Relay
< 16> < 25>
F C
D A
B B (LHD)
D D (RHD)
H13
Hazard SW
1 4B
GR
1 B
GW
(RHD)
3 B (L/B)
4 DL
Junction
Connector
J22(A), J23(B)
E A
E A
GY
(RHD)
3 A (S/D)
3 DL
GW
(LHD)
GY
BG
(1)
17 DM
GW
(LHD)
D B
F A
GY
(RHD)
GW
(RHD)
F A
GW
(RHD)
GY
(RHD)
6 DB
LR
2
T10
6 IC2
Turn SW
9 DA
J5
Junction
Connector
(RHD)
(LHD)
: Gasoline
: 1CDFTV
: 1AZFSE, 1AZFE
: 1ZZFE, 3ZZFE
: w/ HID
: w/o HID
: Right Kick Panel
: Behind the Combination Meter
GY
(LHD)
GY
(LHD)
1 4D
27 DA
+B
2 IO1
2 IE3
1
2
3
4
5
6
7
8
LG
GW
1 4A
GR
WB
(LHD)
LL
IG
6 CC
8 CA
T u rn S ig n a l a n d H a z a rd W a rn in g L ig h t
WB
(RHD)
BL
(2)
GY
WB
(LHD)
GY
1 DN 5 DH
RW
1 DH
GY
RW
IG1 1
Ignition SW
I13
3 AM1
ACC
2
RW
LG
LG
1 ED1
LG
1 1A
15 AVENSIS
Turn LH
C10(A), C11(B)
Combination Meter
WB
R13(A), (B), (C)

Rear Combination
Light LH
140A ALT
627
16 AVENSIS
628
BL
(2)
W
(2)
AVENSIS (EWD526E)
http://vnx.su
Engine
Compartment
Left
G
(4)
140A ALT
BG
(1)
B
(2)
F4
Front Fog
Light RH
Engine
Compartment
Right
Front Fog
Right Kick
Panel
C10(A), C11(B)
Combination Meter
Rear Fog
WB
(4)
WB
(4)
120A ALT (7)

100A ALT (8)
IJ
WB
IP
9 DA
Left Kick
Panel
16 DA
WB
(LHD)
6 CA
6 CG
WB
(LHD)
EB
WB
6 CK
WB
(RHD)
10
Lower Back
Panel Left
BT
R14(A), (B), (C)

Rear Combination
Light RH
Lower Back Panel

Center (S/D, H/B)
Lower Back Panel
Right (W/G)
3 C (W/G)
4 C (W/G)
BS
3 B (L/B)
5 B (L/B)
WB
6 A (S/D)
2 A (S/D)
WB
(LHD 5)
EC
5 B
C12
Combination SW
Rear (3)
5 C (W/G)
WB
(RHD 5)
Battery
G
(4)
G
(4)
G
(4)
RW
(5)
A A
Fog Light
SW
FL MAIN
3. 0W
A A
G
(4)
1 4B
7 B (L/B)
2 C (W/G)
R13(A), (B), (C)

Rear Combination
Light LH
3 A (S/D)
1 B (L/B)
Fog
Rear (6)
RR
R8
Rear Fog
Light Relay
5 A (S/D)
RW
(5)
Fog
G(4)
Front (4)
EF
12
11
FR
5 IC3
13 IC2
WR
(5)
RY
(4)
8 A
FR FOG
Relay
WR
(5)
7 A
G(4)
OFF
RW
(5)
J 3(A), J 4(B)
Junction
Connector
C D (RHD)
C B (LHD)
C C (RHD)
C A (LHD)
G
(5)
1 : Gasoline
2 : 1CDFTV
and Rear Fog Light
w/o Front Fog Light
7 : 1AZFSE, 1AZFE
8 : 1ZZFE, 3ZZFE
RW
(LHD 5)
C B
3 IC2
G
(5)
R e a r F o g L ig h t
RW
(RHD 5)
BG
(1)
10A
TAIL
J10(A), J11(B), J26(C), J27(D)

Junction Connector
TAIL
Relay
G
(4)
1 4D
15A
FR FOG
4 DM
J30
Junction
Connector
A
A
G
(4)
1 DN
7. 5A
RR FOG
Taillight System
< 141>
GY
(4)
RY
(5)
24 DA
GY
(4)
10 DA
RY
(5)
F ro n t F o g L ig h t
RY
(5)
1 ED1
11 IC2
F3
Front Fog
Light LH
17 AVENSIS
BG
(1)
AVENSIS (EWD526E)
http://vnx.su
Lower Back
Panel Left
GW
< 324>
GW

< 206> < 215>
140A ALT
120A ALT (3)

100A ALT (4)
B
(2)
WB
BT
WB
(W/G)
Lower Back Panel

Center (S/D, L/B)
Lower Back Panel
Right (W/G)
3 BG1
2 BE1
2 BD1 (L/B)
4 BF1 (W/G)
WB
(L/B)
WB
BS
WB
WB
(L/B, W/G)
3 C (W/G)
3 B (L/B)
6 A (S/D)
WB
(L/B)
BX
1 BE1
A B
A A
WB
(L/B, W/G)
Right Side of
the Back Door
WB
(W/G)
L
(W/G)
J33(A), J34(B)
Junction
Connector
1 BD1 (L/B)
3 BF1 (W/G)
WB
(L/B)
Battery
4 C (W/G)
5 B (L/B)
R14(A), (B), (C)

Rear Combination
Light RH
: Gasoline
: 1CDFTV
: 1AZFSE, 1AZFE
: 1ZZFE, 3ZZFE
H20
High Mounted
Stop Light
FL MAIN
3. 0W
C B
Stop
2 A (S/D)
1 C (W/G)
4 B (L/B)
7 A (S/D)
J30(A), J31(B)
Junction
Connector
Stop
BG(1)
W
(2)
WB
(S/D)
J30(A), J31(B)
Junction
Connector
R13(A), (B), (C)

Rear Combination
Light LH
B B
C A
GW
(L/B, W/G)
1
2
3
4
GW
(L/B)
H20
High Mounted
Stop Light
B A
6 C (W/G)
1 A (S/D)
4 B (L/B)
J32
Junction
Connector
B B
C A
GW
C A
GW
10 DC
1 DB
1 DM
GW
(S/D)
GW
4 BG1
GW
(W/G)
1 4B
BL
(2)
GW
2 DL
2 DA
WB
(S/D)
1 ED1
GW
(LHD)
1 IR1
GW
(RHD)
L
(L/B)
RW
(LHD)
1 DN
RW
(RHD)
15A
STOP
6 IE3
GW
(RHD)
22 DA
GW
(LHD)
S13
Stop Light SW
GW
(L/B, W/G)
RW
(LHD)
2 IR1
RW
(RHD)
11 IE3
S to p L ig h t
GW
(L/B, W/G)
1 4D
N8
Noise Filter
(Stop Light)
WB
(W/G)
WB
(L/B, W/G)
WB
(S/D)

< 512> < 611> < 78>
Engine ECU (M/T)
< 512> < 611> < 78> < 88>
629
18 AVENSIS
630
BL
(2)
W
(2)
AVENSIS (EWD526E)
http://vnx.su
140A ALT
Left Kick Panel
WB
IJ
RW
BG
(1)
B
(2)
Lower Back
Panel Left
BT
R14(A), (B), (C)

Rear Combination
Light RH
Lower Back Panel

Center (S/D, L/B)
Lower Back Panel
Right (W/G)
4 C (W/G)
WB
BS
3 C (W/G)
5 B (L/B)
WB
6 A (S/D)
3 B (L/B)
2 A (S/D)
BackUp
WB
Battery
R13(A), (B), (C)

Rear Combination
Light LH
6 C (W/G)
BackUp
FL MAIN
3. 0W
1 4B
8 CA
27 DA
BL
(2)
RW
9 DA
6 B (L/B)
1 C (W/G)
RB
(6)
2 A (S/D)
2 B (L/B)
(RHD 7, RHD L/B, RHD W/G)
6 A (S/D)
RB
(6)
(LHD 7, LHD L/B, LHD W/G)
RW
1 CD
RB
7. 5A
GAUGE2
8 IC2
4
1 : Gasoline
2 : 1CDFTV
3 : 1AZFSE, 1AZFE
4 : 1ZZFE, 3ZZFE
5 : w/ MultiDisplay
6 : S/D w/o Rear Fog
7 : S/D w/ Rear Fog
8 : w/o Winter Package
w/o Moon Roof,
w/o Rear Power Window,
w/o Headlight Cleaner,
w/o Front Fog Light,
w/o Daytime Running Light or
w/o MultiDisplay
9 : LHD Except 4 LHD S/D M/T 8
10 : Except 3 M/T
RB
BG
(1)
C B
A A
J32
Junction
Connector
1 IK1
RW
2 B (M/T)
3 A (A/T)
A A
RY
(RHD)
RB
(6)
N 1(A)
Neutral Start SW
B 1(B)
BackUp Light SW
IG1
Relay
RY(10)
RB(3 M/T)
1 B (M/T)
RY
(RHD)
2 A (A/T)
RY
(RHD 5)
25A
AM1
BG
(1)
1 DN
C
RY
(LHD 5)
GR
1 DH
J5
Junction Connector
RY
(9)
1 4D
GY
5 DH
5 IK1
RY
(4 LHD S/D M/T 8)
RY
(4 LHD S/D M/T 8)
I13
Ignition SW
IG1 1
ACC
RY
(9)
3 AM1
GR
B a c k U p L ig h t
RY
(9)
1 ED1
Navigation ECU
< 396>
Option Connector
(Navigation ECU)< 503>
J22(A), J23(B)
Junction Connector
RY
(RHD)
120A ALT (3)

100A ALT (4)
632
BL
(2)
1 ED1
BG
(1)
W
(2)
30A DCC
BW
BG
(1)
B
(2)
140A ALT
AVENSIS (EWD526E)
http://vnx.su
25A AM1
Left Kick Panel
TRLY
Integration Relay
INTB
15
TOUT
14
10A TAIL

BG
(1)
B
(2)
Behind the
Combination
Meter
Illumination
(3)
WB
(LHD 1)
IO
Instrument
Panel
Reinforcement
RH
CPU
C C
C A
IK
WB
(RHD)
WB
(LHD 2, RHD)
WB
IL
WB
(LHD)
J16
Junction
Connector
WB
(4)
C10(A), C11(B)
Combination Meter
12 DB
12
17 A
20 B
WB
(RHD)
IJ
13
H B
F C
F A
WB
(RHD)
Battery
25
21 B
F C
14 B
J17
Junction
Connector
WB
WB(RHD)
WB(RHD)
Behind the
Combination Meter
Junction
Connector
J15
5 B
C C (RHD)
C A (LHD)
J10(A), J11(B), J26(C)

Junction Connector
FL MAIN
3. 0W
1 4B
GR
9 DA
TAIL Relay
GR
GY
6 CD
7 CA
WR
: Gasoline
: 1CDFTV
Tail
BG
(1)
BL
(2)
GY
4 DM
RW
1
2
3
4
WR
(RHD)
1 4D
RW
1 4A
6 DJ
G
(3)
G
(3)
9 DJ
J30
Junction
Connector
19 DB
7 DB
5 DH 1 DN
G
(4)
1 DH
GW
(3)
3 IC2
8 CI
RW
1 1A
IG1 1
5 CA
WR
(LHD)
(RHD)
BW
(LHD)
I13
Ignition SW
3 AM1
ACC
Illu m in a tio n
(Cont. next page)
7. 5A DOME
5 IP1
WR
4 IE4
19 AVENSIS
P5
Power Heater SW
Taillight System
< 141>
7. 5A PANEL
10A GAUGE1
IG1 Relay
Right Kick Panel
H15
WB
(7)
AVENSIS (EWD526E)
http://vnx.su
H16
WB
(9)
2 CI (LHD)
5 CD (RHD)
4 CG (5)
10 CH (6)
F20
5 CJ
11 CJ
H13
Hazard SW
8 CH
WB
(LHD)
WB
(LHD)
5 CI
11 CE
2 CH
8 (LHD)
1 (RHD)
ILL+
5 (LHD)
4 (RHD)
9 CH
WB
(LHD)
WB
IP
G
WB
(LHD)
3 CG
WB
(6)
9 CD
3 CI
WB
(RHD w/ VSC)
B
WB
(RHD)
WB
(RHD)
11 : Automatic A/C
WB
(RHD)
6 CA
6 CK
ILL
GND
M1
MultiDisplay
WB
(5)
WB
WB
(8)
TAIL
T9
TRC Off SW
WB
(LHD w/ VSC)
WB(RHD)
13 B (11)
GND
40 A (10)
ILL+
ILL+
13
3 CJ
8 CJ

: w/o Navigation System (Map Type)
: w/ Headlight Beam Level Control w/o HID
: w/ Front Window Deicer
WB(RHD)
G
(7)
10
G
(6)
23 B (11)
1 CH
G
(5)
8 CK
5
6
7
8
G
(8)
21 A (10)
2 CJ
G
(9)
11 CA
G
(w/ VSC)
1 CJ
Illu m in a tio n
(Cont. next page)
F19
WB
(RHD)
WB
(RHD w/ VSC)
M1
MultiDisplay
A13(A), A16(B)
WB
(RHD)
G3
Glove Box Light
WB
(RHD)
633
634
E8
ECT Pattern
Select SW
WB
(14)
AVENSIS (EWD526E)
http://vnx.su
Left Kick
Panel
WB
(RHD)
WB
(RHD)
WB
(RHD w/ VSC)
Lower Back
Panel Left
IK
WB
(LHD)
WB
(15)
WB
WB
(RHD)
Behind the
Combination Meter
IP
WB
(LHD)
BS
J15
Junction
Connector
WB
(12)
WB
(RHD)
J17
Right Kick Panel
Junction
Connector
A
T7
IJ
J30(A), J31(B)
Junction
Connector
GND
ILL
1 CF
12
13
14
15
IN
GND
ILL+
10
12 CA
12

: w/ Steering SW
: A/T Except 1AZFE
: w/ Seat Heater
Instrument Panel
Reinforcement Center
BR(LHD)
WB(RHD)
IL
WB
(RHD)
C B
J32
Junction
Connector
R11
J16
Junction
Connector
9 DA
WB
(15)
B A
S7
Seat Heater SW
WB
C14
Combination SW
P8
Personal Light
WB
(RHD)
WB
6 DK
Behind the
Combination Meter
12 CF (LHD)
9 CH (RHD)
EAU
10
7 CH
G
(RHD 14)
WB
(15)
WB
(RHD w/ VSC)
G
(LHD 14)
G
(LHD 13)
ILL+
8 IC1
7 ID1
F B
F B
F B
G
(LHD)
G
(15)
G
(RHD)
C7
Cigarette Lighter
Illumination
F B
H A
G
(15)
WB
(RHD)
J 8(A), J 9(B)
Junction Connector
G
(12)
G
(RHD 13)
H A
4 CI
11
WB
(RHD)
G
(RHD)
J19
G
(LHD)
Junction
Connector
4 CD
10
Illu m in a tio n
R4
Radio and Player
WB
P5
Power Heater SW
Radio and Player

System< 412>
20 AVENSIS
636
R
(2)
W
(2)
25A VSC
140A ALT
AVENSIS (EWD526E)
http://vnx.su
B
(2)
120A ALT
BG
(1)
1
1 1A
25A AM1
Left Kick Panel
9 DA
FL+
41
24
FL
21
FR+
S1
BZ
15
FR
22
RL
RL
LY
LY
WB
50A VSC
B
(2)
B
(2)
A5
ABS Speed Sensor
Front RH
A4
ABS Speed Sensor
Front LH
WB
EA
GND1
GND2
10
WB
10A GAUGE1
7 DB
IG1
14
C D (RHD)
RW
BR
1 : 1AZFSE
2 : 1CDFTV
WB
IJ
18 DB
5
+BS
9
+BM
C C (RHD)
G A (LHD)
G B (LHD)
C C
G A
RW
Battery
FL MAIN
3. 0W
1 4A
50A VSC
BG
(1)
1 4B
25A VSC
W
(2)
BL
(2)
BR
GR
GY
BG
(1)
5 DH 1 DN
RW
BL
(2)
RW
1 DH
7 CA
3 IE1
J10(A), J11(B), J20(C), J21(D)

Junction Connector
I13
Ignition SW
L
(1)
(RHD)
R
(1)
1 IP1
(LHD)
RW
1 IE4
V7
VSC Warning
Buzzer
R
(1)
1 ED1
L
(1)
BY
1 1B
BG
(1)
1 4D
L
(2)
6 CD
R
(2)
BR
IG2 6
BY
ST2
RW
4 AM2
BR
22 IE1
2
Buzzer
GY
IG1 1
ACC
RW
L
(2)
3 AM1
RW
GR
RW
VSC
RW
(Cont. next page)
7. 5A ECUIG
IG1 Relay
30A AM2
B
(2)
P4
Parking Brake SW
AVENSIS (EWD526E)
http://vnx.su
BW
GY
WB
(LHD)
R
WB
(LHD)
IL
WB
(RHD)
IP
Behind the
Combination Meter
IK
J15
Behind the
Combination Meter
B B
J 6(A), J 7(B)
Junction Connector
A A
(Shielded)
Junction
Connector
B A
B B
D A
D B
E B
A A
B A
(Shielded)
(Shielded)
Right Kick Panel
WB
(LHD)
D A
B
(LHD)
J16
Junction
Connector
B
(LHD)
6 CA
E2
12
CAN
LOW
CAN
HIGH
7
12V
6
GND
W
(LHD)
10 CJ
T9
TRC Off
SW
W
(LHD)
CANH
CANL
4
UBAT
GND
PMC
VCM
WL
(LHD)
3 IE8
WG
(LHD)
10 IE8
11
27
WG
(LHD)
B
(LHD)
A33
ABS Speed Sensor
Rear RH
30
WL
(LHD)
16
YIGA
NEO
YGND
32
7
ENG
Y1
Yaw Rate
Sensor
WB
(RHD)
9 IE8
W
(LHD)
2 IE8
8
ENG+
WG
(LHD)
1 IE8
13
SS2
29
SS1
TRC
TRC+
S1
19
18
WL
(LHD)
10 IM1
14 IE1
42
STP
(RHD)
(LHD)
O1
Oil Pressure Sensor
WG
(LHD)
1 IM1
BW
GY
11 IE2
BW
(Shielded)
10 IE2

< 475> < 488> < 497>
CSW
BW
B
(LHD)
WL
(LHD)
RR
LW
39
Combination Meter
< 424>
SP1
G
W
(LHD)
Junction
Connector
J18
BR
BW
S12
Steering
Sensor
A32
ABS Speed Sensor
Rear LH
RR+
GW
37
Stop Light SW
< 171>
35
5 IE8
13 IE1
14 IE2
14 IE8
3 IE2
L
13 IE2
7 IE8
15 IE2
Y
PKB
13 IE8
W(3)
Y(4)
B
31
6 IE8
B
YB
38
4 DC
YB
1 IB1
RL
MultiDisplay
< 396>
2 IE2
8 DM
BW
(5)
3 DB
YG
40
2 DC
(Cont. next page)

3 : RHD 1AZFSE
4 : Except RHD 1AZFSE
GR
23
Engine and ECT ECU

(A/T)< 510>
Engine ECU (M/T)
< 510> < 811>
RL+
BW
BR
VSC
YR
2 IB1
(Shielded)
637
638
RW
BR
10A IGN
BW
(Shielded)
W
(RHD)
B
(RHD)
AVENSIS (EWD526E)
http://vnx.su
4 B
WG
(RHD)
WL
(RHD)
W
(RHD)
B
(RHD)
WG
(RHD)
Y1
Yaw Rate
Sensor
F
B
(RHD)
B
(RHD)
CAN
HIGH
1
CAN
LOW
12V
W
(RHD)
5
GND
B B
B A
WL
(RHD)
B A
S12
Steering
Sensor
CANH
W
(RHD)
CANL
4
UBAT
WL
(RHD)
GND
WL
(RHD)
WG
(RHD)
J22(A), J23(B)
Junction
Connector
A B
C A
EBDW
20
Combination Meter
System< 4211>
WL
(RHD)
C A
WA
36
S1
WT
18 IE1
17 IE1
2 B
WB
(RHD)
Behind the
Combination
Meter
DLC3
< 518> < 815>
TC
17
WL
WG
WG
(RHD)
(Shielded)
IK
26
D/G
11
TS
28
Behind the
Combination
Meter
IL
J17
Junction
Connector
A
J16
Junction
Connector
12
1 : 1AZFSE
2 : 1CDFTV
IO
WB
(LHD 1)
J19
Junction Connector
12 IO1
WG
(RHD)
11 IO1
IND
9 A
17 A
J22(A), J23(B)
Junction
Connector
YIGA
30
WL
(RHD)
16
YGND
VSCW
WR
34
LG
WB
(RHD)
WR
LGB
WB
(LHD 2)
LG
RY
7 IE1
LGB
8 IE1
17 B
22 B
WB(RHD)
WB(LHD)
WB
(RHD)
11 IO2
J 8(A), J26(B)
Junction Connector
RY
6 IE1
21 B
VSC
WB
(LHD)
12 IO2
15 B
Slip
13 IO2
SS1
VSC
16 B
RW
10
BW
ABS
P
13
C10(A), C11(B)
Combination Meter
TRC OFF
P
29
SS2
A B (RHD)
C A (LHD)
A B (RHD)
C A (LHD)
BW
18 DA
2 DH
Instrument Panel
Reinforcement RH
DLC3
< 519> < 816>
J15
Junction
Connector
(Shielded)
Brake
(Shielded)
WG
(RHD)
21 AVENSIS
640
L
(2)
W
(2)
40A ABS
W
(2)
140A ALT
AVENSIS (EWD526E)
http://vnx.su
B
(2)
40A ABS
120A ALT (3)

100A ALT (4)
25A AM1
Left Kick Panel
BG
(1)
25A ABS
B
(2)
B
(2)
WB
(RHD)
WB
(RHD)
IK
WB
(LHD 2)
IL
Behind the
Combination
Meter
J16
Junction
Connector
WB
(LHD 1)
IO
C10(A), C11(B)
Combination Meter
P
Instrument Panel
Reinforcement RH
4 B
S2
2
+BM
17 IE1
18 IE1
22
WA
WB
EA
GND2
Engine
Compartment
Right
GND1
+BS
: Gasoline
: 1CDFTV
: 1AZFE
: 1ZZFE, 3ZZFE
WB
BR
WB
30A AM2
B
(2)
BG
(1)
Behind the
Combination
Meter
J15
Junction
Connector
WB
(LHD)
IJ
7. 5A ECUIG
RY
J17
Junction
Connector
9 A
12
EBDW
IG1
18
22 IE1
17 A
22 B
1
2
3
4
WB
Battery
9 DA
2 B
RY
FL MAIN
3. 0W
1 4A
25A ABS
BG
(1)
1 4B
1 1A
BL
(2)
ABS
BR
10A IGN
GR
GY
RW
18 DB
A B (RHD)
C A (LHD)
RW
BG
(1)
5 DH 1 DN
Combination Meter
System< 4211>
1 DH
J 8(A), J26(B)
Junction
Connector
R
(1)
I13
Ignition SW
BW
(RHD)
(LHD)
C B (RHD)
G A (LHD)
RW
L
(1)
1 IP1
1 IE4
2 DH
A B (RHD)
C A (LHD)
J10(A), J20(B)
Junction
Connector
1 4D
BR
IG2 6
ST2
C B (RHD)
G A (LHD)
R
(2)
L
(1)
R
(1)
4 AM2
BR
GY
IG1 1
18 DA
BW
L
(2)
BL
(2)
1 ED1
BG
(1)
1 1B
3 AM1
GR
ACC
BW
R
(2)
ABS
RW
(Cont. next page)
RY
Brake
IG1 Relay
FR
13
D2
Diode
10 IM1
1 IM1
11 IE2
10 IE2
1 IB1
2 IB1
19
17
7
A33
ABS Speed Sensor
Rear RH
A32
ABS Speed Sensor
Rear LH
FR+
10
A5
ABS Speed Sensor
Front RH
FL
RL
FL+
LY
LW
23
Combination Meter
< 424>
SP1
Stop Light SW
< 171>
GW
STP
A4
ABS Speed Sensor
Front LH
20
PN
G
(A/T)
21
G
(A/T)
1 IE2
Neutral Start SW
< 1111> < 1210>
R
(A/T)
WL
(A/T)
14
25
W
DLC3
< 615> < 715> < 816>
TS
WL
TC
DLC3
< 614> < 713> < 815>
S2
RL+
RL
D/G
11
WG
PKB
RR+
BW
2 IE2
BW
3 DB
4 DC
BW

< 475> < 488> < 497>
RR
P4
BW
2 DC
BW
(5)
8 DM
MultiDisplay
< 396>
Parking
Brake SW
ABS
AVENSIS (EWD526E)
http://vnx.su
641
22 AVENSIS
642
BL
(2)
BG
(1)
B
(2)
W
(2)
120A ALT
(1AZFSE, 1AZFE)
100A ALT
(1ZZFE, 3ZZFE)
140A ALT
AVENSIS (EWD526E)
http://vnx.su
25A AM1
Left Kick Panel
9 DA
Right Kick Panel
5 B
WB
30A AM2
BG
(1)
B
(2)
6 CA
6 CK
A
WB
(RHD)
WB
WB
GR
Battery
Behind the
Combination
Meter
J15
Junction
Connector
17 A
22 B
IL
WB
(LHD 2)
IK
J17
Junction
Connector
14 A
Behind the
Combination
Meter
Junction
Connector
J16
SRS
8 B
IO
BY
BW
BR
Instrument Panel
Reinforcement RH
1 : Gasoline
2 : 1CDFTV
WB
(LHD 1)
IP
C10(A), C11(B)
Combination Meter
CPU
BEAN
I/F
13 A
WB
(RHD)
IJ
20 B
H B
F C (RHD)
F A (LHD)
WB
(LHD)
FL MAIN
3. 0W
1 4B
21 B
J10(A), J11(B), J26(C)

Junction Connector
WR
(LHD)
BG
(1)
GR
GY
BL
(2)
GY
RW
6 CD
WR
(RHD)
1 4A
BG
(1)
7 DB
BR
5 DH 1 DN
RW
1 DH
RW
7 CA
F C
System< 115> < 211>
1 4D
I13
Ignition SW
ST2
IG2 6
IG1 1
WR
1 1A
4 AM2
3 AM1
ACC
7. 5A DOME
BW
(RHD)
(LHD)
BW
1 IE4
1 IP1
30A DCC
BR
5 IP1
SRS
BY
BW
4 IE4
BR
BW
1 ED1
(Cont. next page)
10A GAUGE1
IG1 Relay
BY
BW
BR
BY
AVENSIS (EWD526E)
http://vnx.su
WB
4 IO3
SL
A9
Airbag Sensor
Front LH
WR
SL+
YR(4)
BR (5)
1
SR
A10
Airbag Sensor
Front RH
SR+
2 IO3
1 IO3
Left Kick Panel
3 IO3
YG
WB
IJ
WB
2 IE7
SL+
15 B
WR
1 IE7
SL
26 B
BR
4 IE7
SR+
9 B
3 IE7
SR
20 B
A29
Airbag Squib
P2
7 B
YB
P2+
8 B
(RHD)
(LHD)
P16
Pretensioner
LH
P17
Pretensioner
RH
PR
10 C
PR+
9 C
PL
7 A
SIL
TC
PL+
8 A
12 B
19 B
YB
A30
Airbag Squib
YB
YG
P
11 B
GSW2
23 B
9 DA
D2+
16 B
DK
11 C
YB
3 DD
P+
10 B
D2
17 B
YR
D+
14 B
BW
YR
D
13 B
10A IGN
4 DD
E2
28 B
DK+
12 C
YB
(3)
IG2
A26(A), A27(B), A28(C)
LGB
(1)
9 DD
WL
E1
27 B
BW
5 B
2 IN1
YR
(3)
1 IN1
11 DA
: Gasoline
: w/ Knee Airbag
: LHD 1CDFTV
: Except LHD 1CDFTV
WG
LA
A B (RHD)
C A (LHD)
YB
(3)
J 8(A), J26(B)
Junction Connector
1
3
4
5
LGB
(1)
A B (RHD)
YR
(3)
K3
Knee Airbag Squib
(Cont. next page)
DLC3
< 518> < 614>
< 713> < 814>
3 B
BW
C A (LHD)
5 DD
SRS

< 511> < 611> < 78>
Engine ECU (M/T)
< 511> < 611> < 78>
6 DD
12 DA
18 DA
2 DH
BR
643
644
C16
GR
AVENSIS (EWD526E)
http://vnx.su
1 B (7)
BBL (6)
BCL (7)
C17
Curtain Shield
Airbag Squib
LH
S18
Side Airbag
Squib LH
GSW1
DBEW
4 B
14 DB
2 DD
3 C (RHD)
LBE(LHD)
RBE(RHD)
2 A (LHD)
LSP(LHD)
RSP(RHD)
2 C (RHD)
LSP+
RSP+
1 C
14 C
LBE+
RBE+
3 A (LHD)
4 A
19 A
LR
S14(A), (B)
Side Airbag
Sensor LH
BBL+
BCL+
2 B
GRL
LGB
3 A (6)
YV
(6)
4 A
SFL
11 A
SFL+
12 A
ICL
10 A
SFR
SFR+
YR
(6)
ICL+
9 A
ICR
YR
BBL
18 A
ICR+
YG
BBL+
16 A
A26(A), A27(B), A28(C)

BBR
6 C
LR
BCL
2 A
BBR+
YV
(6)
5 C
YR
7 C
YG
8 C
GY
15 C
YR
(6)
LB
17 C
1 B (7)
BBR (6)
BCR (7)
3 A (6)
B9
Buckle SW
(Driver' s Side)
Seat Position
Airbag Sensor
BCL+
1 A
2 B
BBR+
BCR+
4 A
S19
Side Airbag
Squib RH
GRB
GRR
(6)
BCR
2 A
C18
Curtain Shield
Airbag Squib RH
11
GRB
12
6 : w/ Curtain Shield Airbag

7 : w/o Curtain Shield Airbag
Buckle SW
LB
(6)
LG
(6)
L
(6)
BCR+
1 A
S15(A), (B)
Side Airbag
Sensor RH
10
SRS
GY
C15

Sensor RH
WB
LB
WB
Integration Relay
< 16> < 25>
AVENSIS (EWD526E)
http://vnx.su
BG
50A EMPS
BG
Left Kick Panel
WB
IJ
IO
WB
(LHD)
Behind the
Combination
Meter
J15
Junction
Connector
Instrument Panel
Reinforcement RH
J16
Junction
Connector
6 B
M1
M2
TACH
12 B
TRQ2 TRQG
Torque Sensor
TRQV TRQ1
E14(A), E15(B)
EPS ECU
IDUP
8 B
5 B
SPD
SIL
2 B
Behind the
Combination
Meter
TS
TC
2 A
PGND
11 B
4 B
IM
WB
IK
WB
(RHD)
Battery
WB
(RHD)
J17
Junction
Connector
WB
(LHD)
P/S
FL MAIN
3. 0W
17 A
WL
9 B
RLY
VW
1 4B
BG
BW
1 4A
RW
1 1A
9 DA
WR
3 B
GR
PIG
GRR
1 A
5 IE1
WG
IG
DLC3
< 714>
6 B
WL
22 B
DLC3
< 714>
1 4D
J10(A), J11(B),
J20(C), J21(D)
Junction
Connector
G B (LHD)
C D (RHD)
C C (RHD)
G A (LHD)
EMPS
Relay
Engine and ECT

ECU (A/T)< 711>
Engine ECU (M/T)
< 711>
J 8(A), J26(B)
Junction
Connector
C A (LHD)
A B (RHD)
A B (RHD)
C A (LHD)
BR
1 DN
BW
1 DH
EPS
DLC3
< 715>
BR
18 DB
18 DA
2 DH
10A IGN
WR
GY
5 DH
RW
(RHD)
(LHD)
BR
GY
BR
RW
1 IP1
I13
Ignition SW
IG2 6
4 AM2
ST2
IG1 1
3 AM1
ACC
GR
1 IE4
BG
23 AVENSIS
Combination Meter
< 424>
EPS Motor
BW
C10(A), C11(B)
Combination Meter
25A AM1
7. 5A ECUIG
IG1 Relay
GR
100A ALT
30A AM2
645
646
BL
(2)
BG
(1)
B
(2)
W
(2)
AVENSIS (EWD526E)
http://vnx.su
140A ALT
BG
(1)
B
(2)
Left Kick Panel
WB
30A AM2
120A ALT (3)

100A ALT (4)
IP
WB
IJ
10
Beam Level
Battery
J 8(A), J26(B)
Junction
Connector
H18
Right Kick Panel
Height Control Sensor

(Front)
SHG
WG
WR
SHFR
H19
(Rear)
2
SHRR
1
SHB
SHG
6 IM1
BW
SGR
20
7 IM1
SHR
RH3
22
8 IM1
SBR
RH1
13
SHB
5 IH1
3
RH2
(RHD)
(LHD)
12 IE1
GW
FL MAIN
3. 0W
6 CA
SGF
21
4 IH1
WG
3 IH1
SHF
WR
22
WB
(RHD)
2 CI
SBF
15
LH3
23
1 4B
WB
(LHD)
10 CE
LH1
14
BW
A B (RHD)
C A (LHD)
A B (RHD)
E1
24
LH2
BG
(1)
WB
GW
IG1 Relay
BW
11
WNG
SPDR
HDLP
2 IO2
2 IE6
8 IO2
8 IE6
6 IO2
6 IE6
1 IO2
1 IE6
7 IO2
7 IE6
H14
12
10
RW
IG
RY
C A (LHD)
HLP Relay
< 17> < 132>
VW
1 4A
Combination Meter
< 423>
10A
IGN
5 CK
8 CA
H2
: Gasoline
: 1CDFTV
: 1AZFSE, 1AZFE
: 1ZZFE, 3ZZFE

Control Actuator RH
1
2
3
4
BW
18 DA
2 DH
9 DA
7. 5A
GAUGE2
GY
BL
(2)
27 DA
BR
RW
5 DH
BW
1 4D
BG
(1)
1 DN
GY
25A
AM1
GR
1 DH
H1
Control Actuator LH
LW
1 1A
I13
Ignition SW
RW
PL
BR
(RHD)
(LHD)
BR
GY
GY
1 IP1
1 IE4
IG2 6
4 AM2
BR
ST2
IG1 1
ACC
3 AM1
GR
H e a d lig h t B e a m L e v e l C o n tro l (w / H ID )
LW
1 ED1
PL
24 AVENSIS
LG
C11
Combination Meter
BW
25 AVENSIS
BL
(2)
W
(2)
AVENSIS (EWD526E)
http://vnx.su
B
(2)
G
GY
WB
120A ALT (3)

100A ALT (4)
B
(2)
GY
C A (LHD)
C B (RHD)
C A (LHD)
C B (RHD)
6 CA
11 CE (LHD)
5 CI (RHD)
Right Kick Panel
H15
Control SW
GY
WB
H1
Control Actuator LH
IP
WB
EC
H2
Control Actuator RH
PL
J10(A), J26(B)
Junction
Connector
J 3(A), J 4(B)
Junction Connector
PL
12 IE1
3
IC2
A B
GY(5)
GR(6)
C A
C A
J30
Junction
Connector
WB
Battery
FL MAIN
3. 0W
1 4B
140A ALT
BG
(1)
BG
(1)
4 DM
8 DL
J1
Junction
Connector
10A
TAIL
1 4D
TAIL
Relay
Taillight System
< 141>
1 DN
BG
(1)
BL
(2)
H e a d lig h t B e a m L e v e l C o n tro l (w /o H ID )
1 ED1
1
2
3
4
5
6
: Gasoline
: 1CDFTV
: 1AZFSE, 1AZFE
: 1ZZFE, 3ZZFE
: Except RHD 1CDFTV
: RHD 1CDFTV
WB
GY
PL
647
26 AVENSIS
648
BL
(2)
W
(2)
50A AM1 NO. 1
AVENSIS (EWD526E)
http://vnx.su
140A ALT
B A
G
(RHD)
G
(RHD)
H11
Horn LH
WB
IJ
25A AM1
Engine Compartment
Left
EC
WB
G
(LHD)
G
(5)
BG
(1)
EI
LR
Left Kick Panel
H12
Horn RH
1 EE1
12 IL2
12 IA2
F15
Fuel Heater
Near the Starter
18 IC2
LR
GW
13 IL2
13 IA2
WB
J32
Junction
Connector
F23
Fuel Lid
Opener
Motor
(RHD)
(LHD)
F24
Fuel Lid
Opener SW
(RHD)
(LHD)
10A
FUEL OPN
4
1
2
3
4
5
C B
B A
WB
GW
C14
Combination SW
Horn SW
Theft Deterrent ECU

< 28>
15A HORN
25A FHTR
BG
(1)
BG
(1)
BS
Lower Back
Panel Left
J30(A), J31(B)
Junction
Connector
: Gasoline
: 1CDFTV
: 1AZFSE, 1AZFE
: 1ZZFE, 3ZZFE
F u e l L id O p e n e r
WB
Battery
B A
J26(A), J27(B)
Junction
D B
Connector
(RHD)
(LHD)
9 DA
WB
20 IE1
LR
FL MAIN
3. 0W
1 1A
13 IE1
LR
B
(2)
B
(2)
120A ALT (3)

100A ALT (4)
1 4A
1 DN
FHTR
Relay
1 4B
HORN
Relay
1 DH
LR
50A AM1 NO. 1
W
(2)
10 DL
1 6A
LB
L
(2)
W
(1)
5 DH
RL
1 1B
GY
1 ED1
IG1 1
GY
I13
Ignition SW
3 AM1
RL
LB
GR
ACC
GR
(RHD)
F u e l H e a te r
BL
W
(2)
2 IP1
(LHD)
H o rn
1 IE5
WB
7. 5A ECUIG
IG1 Relay
27 AVENSIS
W
(2)
BG
(1)
120A ALT (3)

100A ALT (4)
25A WIP
BG
(1)
AVENSIS (EWD526E)
http://vnx.su
IG1 Relay
LR
WB
140A ALT
LR
WB
F13
Front Wiper Motor
IK
J15
Junction
Connector
EW
WB(5)
IL
WB(6)
J2
Junction
Connector
WB
WB
WB
25A AM1
ED
GND
12
WF
WL
R12
Rain Sensor
VCC RS
WB
Left Side of the

Suspension Tower
5 (LHD)
4 (RHD)
2
2
RSSIGNAL
WF
WF
11
WB(5)
22
VR2
24
14
VR2
WL
(7)
2
M
(RHD)
1 IO1
10
(LHD)
1 IE3
IO
WL
WL
(7)
WB(6)
IJ
BR
+2
RW
+1
12 ID1
LG
3 (LHD)
1 (RHD)
3 ID1
13 ID1
PB
4
3
(LHD)
(RHD)
23
SG
VR1
20
12
VR1
1
5
10 IO1
G
3 IO1
10 IE3
RW
(LHD)
3 IE3
LG
8 IO1
PB
Left Kick Panel
BR
8 IE3
19
SP
F2
11
1 : Gasoline
2 : 1CDFTV
3 : 1AZFSE, 1AZFE
4 : 1ZZFE, 3ZZFE
5 : LHD 1CDFTV, RHD
6 : LHD Except 1CDFTV
7 : w/ Headlight Cleaner w/ HID
8 : Except 7
9 : Behind the Combination Meter
10 : Instrument Panel Reinforcement RH
B
(2)
FL MAIN
3. 0W
BR
F1
15
EW
WL
(8)
18 DL
W2
Wiper Relay
RSI
+1
16
AUTO
WF
J2
Junction
Connector
17
+B
13
On
Off
F11
Front Washer Motor
9 DA
J14
Junction
Connector
RW
(RHD)
+S
RW
(RHD)
LR(RHD)
+2
B RW(LHD)
+S
LY
16
C A
+B
17
+2
8
GR
C A
A B
RW
(RHD)
RW
(RHD)
AUTO
GRR
1 4B
BG
(1)
LR
(LHD)
26 DA
LR
(RHD)
LR
17 DL
+1
HI
LO
+S
LGB
GY
1 DN 5 DH
OFF
AUTO
+2
LR(RHD)
LR
(LHD)
+1
WL
BL
(2)
1 DH
LR
(RHD)
LR
(LHD)
A A
RW
(LHD)
C B
A A
+B
C13
Combination SW
BL
(2)
J14
Junction
Connector
A
J24(A), J25(B)
Junction
Connector
LR
(LHD)
LR
(RHD)
MIST
LR
1 4D
GY
J1
Junction
Connector
Front Wiper SW
1 ED1
IG1 1
ACC
LR
F ro n t W ip e r a n d W a s h e r (w / A u to W ip e r S y s te m )
Front
Washer SW
Ignition SW
I13
3 AM1
J24(A), J25(B)
Junction
Connector
Battery
649
650
L
(2)
BL
(2)
30A H/CLN
W
(2)
W
(2)
25A AM1
Left Kick Panel
1
2
3
4
5
6
7
8
9
AVENSIS (EWD526E)
http://vnx.su
+1
+2
GR
BG
(1)
OFF
INT
MIST
Wiper Relay
LR
IL : 5
IO : 6
WB
+1
3
1
2 (LHD)
2 (RHD)
Combination SW
< 112> < 131>
Engine
Compartment
Right
J2
Junction Connector
WB
WB
On
+B
WB
EB
WB
+2
1
5
WB
ED
4
3
RW
5
4
3
3
IE3 IO1
(LHD) (RHD)
LR
: Gasoline
: 1CDFTV
: 1AZFSE, 1AZFE
: 1ZZFE, 3ZZFE
: Behind the Combination Meter (LHD 1CDFTV, RHD)
: Instrument Panel Reinforcement RH (LHD Except 1CDFTV)
: Except 7
: Left Side of the Suspension Tower
C13
Combination SW
17
RW
BR
1 IE1
PB
RY
IJ
+S
8
IO1
8
IE3
HDLO
IG
H16
Headlight
Cleaner SW
Battery
WB
10
IO1
6
FRWA
FL MAIN
3. 0W
LR
B
(2)
INT1
10
IE3
WL
(7)
RY
BR
LY(LHD)
G (RHD)
J2
Junction
Connector
L
(1)
16
LR
H3
1 4B
120A
ALT (3)
100A
ALT (4)
B1
WL
(7)
Junction
Connector
J1
30A HLP CLN
140A
ALT
BG
(1)
IG1 Relay
26 DA
25A WIP
9 DA
INT2
1 4D
EW
WF
GY
WL
(8)
1
1
IE3 IO1
(LHD) (RHD)
WL
(7)
1 1B
WL
F11
Front
Washer Motor
11
WL
LR
18 DL
LR
LR
LR
17 DL
Front Wiper SW
LO
1 DN 5 DH
Front
Washer
SW
LR
LR
BW
1 ED1
1 DH
IG1 1
H e a d lig h t C le a n e r
(w / H ID )
H4
Headlight Cleaner
Motor
L
(1)
BG(1)
BL(2)
I13
Ignition SW
3 AM1
ACC
HI
Off
F ro n t W ip e r a n d W a s h e r (w /o A u to W ip e r S y s te m )
L
(2)
28 AVENSIS
Integration Relay
< 17>
Combination SW
< 132>
F13
Front Wiper Motor
WB
BG
(1)
W
(2)
AVENSIS (EWD526E)
http://vnx.su
BG
(1)
Left Kick
Panel
LR
(W/G)
Wiper Relay
+B
+1
LS
LB
(W/G)
+B
R20
Rear Wiper and

Washer SW
5 BE2
C1
L
(L/B)
L
(W/G)
1 BG1
L
(L/B)
L
(L/B)
4 BE2
2 BG1
L
(W/G)
Behind the
Combination
Meter
WB
(6)
IL
WB
(7)
IO
IP
Right Kick
Panel
IL
J17
Junction
Connector
A
C7
Cigarette
Lighter
15A
CIG
WB
(LHD)
WB
IJ
L
(W/G)
6 BG1
11 DB
WB
(LHD)
WB
(RHD)
Battery
L
(L/B)
3 BE1
5 BD2 (L/B)
4 BF2 (W/G)
4 BD2 (L/B)
3 BF2 (W/G)
WB
(7)
C13
Combination SW
3 DH
WB
(RHD)
FL MAIN
3. 0W
120A ALT (3)

100A ALT (4)
B
(2)
1 4B
LB
LR
3 BD1 (L/B)
5 BF1 (W/G)
: Gasoline
: 1CDFTV
: 1AZFSE, 1AZFE
: 1ZZFE, 3ZZFE
: w/ Auto Wiper System
: LHD 1CDFTV, RHD
: LHD Except 1CDFTV
: Instrument Panel Reinforcement RH
C1R
1
2
3
4
5
6
7
8
2 IC1
WR
11 IC1
10
+1R
C ig a re tte L ig h te r
7 DD 9 DA
2 IC2
J 5(A), J28(B)
Junction
Connector
A B (RHD)
Washer +
ON (5)
ON
INT
OFF
Washer
4
4
IE3 IO1
(LHD) (RHD)
WB
(6)
BL
(2)
LR
A B (RHD)
A A (LHD)
A B
A A (LHD)
(RHD)
(LHD)
LB
1 4D
LR
A A
9 IO1
LR
9 IE3
R3
Rear Washer
Motor
L
1 ED1
IG1
Relay
5 DH
LR
1 DN
25A
AM1
GY
R e a r W ip e r a n d W a s h e r
1 DH
IG1 1
ACC 2
I13
Ignition SW
3 AM1
29 AVENSIS
J16
Behind the
Combination
Meter
Junction
Connector
L
(W/G)
LB
(L/B)
LR
(L/B)
LR
20A RR WIP
140A ALT
651
30 AVENSIS
652
L
(2)
W
(2)
W
(2)
30A H/CLN
AVENSIS (EWD526E)
http://vnx.su
120A ALT (3)

100A ALT (4)
30A HLP CLN
140A ALT
BG
(1)
B
(2)
Left Kick Panel
BL
(2)
WB
IP
Right Kick Panel
25A WIP
WB
(LHD)
WB
(RHD)
WB
Behind the
Combination Meter
P6
Power Outlet
H3
WB
EB
WB
IK
WB
WB
IJ
J15
Junction
Connector
WR
WR
II1
LR
WB
1 IE1
BW
Battery
WB
II1
J1
Junction
Connector
H16
Headlight
Cleaner SW
J17
Junction
Connector
J 8(A), J 9(B),
J20(C), J21(D)
Junction Connector
H B (LHD)
H D (RHD)
F C (RHD)
F A (LHD)
1
2
3
4
: Gasoline
: 1CDFTV
: 1AZFSE, 1AZFE
: 1ZZFE, 3ZZFE
Headlight
Cleaner Motor
H4
L
(2)
FL MAIN
3. 0W
IG1 Relay
1 4B
21 DA
WB
9 DA
15A
P/POINT
GR
2
WL
BL
(2)
L
(1)
GR
BG
(1)
1 4D
4 DB
GR
17 DL
7. 5A
RAD NO. 1
WL
19 DA
L
(1)
25A
AM1
BG
(1)
1 DN
LR
1 ED1
GR
1 DH
3 DH
Integration Relay
< 17>
Combination SW
< 132>
GY
5 DH
H e a d lig h t C le a n e r (w /o H ID )
RY
1 1B
IG1 1
ACC 2
LR
I13
Ignition SW
3 AM1
P o w e r O u tle t
WB
P/POINT
Relay
WB
GR
1 DN
1 DH
BG
(2)
LB
BW
AVENSIS (EWD526E)
http://vnx.su
LB
BW
B
(3)
BG
(2)
MF
MF
2
M+
7
LGB
YG(1)
YG(1)
Right Kick Panel
YG
(1)
13 IA1
YG[
(1)
M+
16 IA1
16 IL1
14 IL1
4 CC
5 CC
12 CB
MR
MV
LGB
MH
LB
(1)
M+
10 CK
6 CB
2 CK
Retractor
SW
Operation
SW
YG
(1)
MR
13 IL1
LB
(1)
14 IA1
1 CC
2 CC
Return
MF
10
MR
9
13 CK
Retraction
Right/
Down
YG
(1)
MV
VR
15 IL1
Select
SW
Left/
Up
MH
LB
(1)
VL
LGB
GW
17 IL1
4
LB
HR
Right
Down
GW
15 IA1
Left
Up
6 CA
6 CI (LHD)
8 CD (RHD)
: w/ Retractor
: Gasoline
: 1CDFTV
: 1AZFSE, 1AZFE
: 1ZZFE, 3ZZFE
Battery
HL
Right
Right
LB
(1)
17 IA1
Left
Left
R10
1
2
3
4
5
WB
FL MAIN
3. 0W
GR
J 8(A), J 9(B),
J20(C), J21(D)
Junction
Connector
H B (LHD)
H D (RHD)
F C (RHD)
F A (LHD)
7. 5A
RAD NO. 1
WB
1 4B
140A
ALT
4 DB
3 DH
GR
LB
(1)
W
(3)
LB
(1)
120A ALT
(4)
100A ALT
(5)
1 ED1
IG1
ACC 2
R e m o te C o n tro l M irro r
YG
(1)
BL
(3)
I13
Ignition SW
3 AM1
GR
Y
1 4D
25A
AM1
31 AVENSIS
WB
IP
M5
Remote Control
Mirror RH
YG
(1)
M4
Remote Control
Mirror LH
653
654
B
(2)
BG
(1)
W
(2)
B
WB
AVENSIS (EWD526E)
http://vnx.su
140A ALT
2 ID1
120A ALT (3)

100A ALT (4)
BG
(1)
Open
OPN
Close
M7
CLS
B
VW
6 ID1
VW
E B (RHD)
A A (LHD)
3 BB1
1 BB1
2 BB1
SC
4 BB1
SO
WB
5 BB1
E B (RHD)
8
VW
A A (LHD)
GND
WB
Left Kick Panel
5 DA
SPD
WB
WB
WB
IJ
8 DA
PWS
CPU
1
2
3
4
WB
(LHD)
IP
Right Kick
Panel
: Gasoline
: 1CDFTV
: 1AZFSE, 1AZFE
: 1ZZFE, 3ZZFE
IG
4 CF
7 CA
WB
Battery
9 DC
13 DB
20
P/W
M6
FL MAIN
3. 0W
6 DK
WB
9 DA
17
19
KSW
PCTY
Integration Relay
DCTY
21
+B
10
6 BB1
1 4B
25A AM1
1 4D
25
IG1 Relay
1
ACC
10A GAUGE1
IG
22
7. 5A RAD NO. 1
20A S/ROOF
WB
1 DN
7 DB
1 ID1
LW
LW
RW
GR
3 DH
RW
LW
WB
(RHD)
25A DOOR
IK
Shift Lock
Solenoid
STP
Shift Lock Control

ECU
S9
SLS+
Behind the
Combination
Meter
J15
Junction
Connector
J17
Junction
Connector
S h ift L o c k
GW
BL
(2)
GY
5 DH
IG1 1
ACC 2
M oon R oof
Stop Light SW
< 172>
1
ED1
I13
Ignition SW
3 AM1
LW
1 DH
RW
1 DG
32 AVENSIS
SLS
WB
Combination
Meter< 423>
J 8(A), J26(B)
Junction Connector

< 119> < 120> < 216> < 217>
656
BL
(3)
50A AM1 NO. 1
W
(3)
AVENSIS (EWD526E)
http://vnx.su
1 4B
120A ALT
(1AZFSE, 1AZFE)
100A ALT
(1ZZFE, 3ZZFE)
BG
(2)
50A AM1 NO. 1
140A ALT
Battery
WB
FL MAIN
3. 0W
WB
IJ
25A DOOR
Left Kick Panel
WB
E B
A A
J 8(A), J 9(B)
Junction Connector
B
(3)
B
(4)
5 DA
8 DA
9 DC
13 DB
7. 5A RAD NO. 1
9 DA
B
(5)
B
(4)
9 IA1
WB
1 1B
BL
(3)
P/W
20
KSW
ACC
21
3 IA1
WB
W
(3)
W
(3)
W
(2)
25A AM1
BG
(2)
19
PCTY
DCTY
17
Integration Relay
IG
22
10A GAUGE1
1 4D
IG1 Relay
LW
(1)
25
1
20A DRR P/W
LB
(1)
1 6A
PW
3
14
FLA
5 IA1
FLU
LW(1)
LB(1)
FLD
D17
(Cont. next page)

: Gasoline
: 1CDFTV
: w/ Moon Roof
: w/o Moon Roof
LB
3 DH
1
2
3
4
5
GW
1 DN
GY
5 DH
LR
1 ED1
IG1 1
1 DH
GR
Ignition SW
I13
3 AM1
ACC 2
P o w e r W in d o w (L H D )
GY
1 IE5
33 AVENSIS
LR
WB
P12
WB
B
(4)
B
(5)
20A DFR P/W

LR
20A PRR P/W
20A PFR P/W

< 119> < 120>
LR
(6)
WR
WL
WL
LR
(1)
LR
AVENSIS (EWD526E)
http://vnx.su
WL
WB
Right Kick
Panel
WR
4
4
E
WB
(1)
WB
Under the Left

Center Pillar
BR
Under the Left

Center Pillar
WB
(1)
P14
WL
WB
BU
WB
(1)
BQ
10 BC1
WB
(1)
WB
(1)
10 BA1
WB
P10
Rear LH
WB
(1)
IP
WG
P13
WB
(1)
9 IL1
WG
L
(1)
RY
(1)
R
(1)
LW
(1)
DOWN
1
UP
L
(1)
RY
(1)
LR
(1)
P9
L
(1)
R
(1)
AUTO
RY
(1)
12 BC1
8 BC1
Under the Right

Center Pillar
WB
BV

Rear RH
WB
(1)
P11
Under the Right

Center Pillar
1
UP
3
AUTO
DOWN
GY
(1)
LR
(1)
R
(1)
LW
(1)
WL
LW
(1)
G
(1)
3 BC1
GY
(1)
AUTO
18 BC1
G
(1)
1 BA1
3 IM1
4 IM1
2 IM1
5 IM1
LW
(1)
DOWN
2 IC3
LB
(1)
8 IM2
1 BC1
P15
GR
(1)
LW
(1)

G
(1)
UP
WR
LR
(1)
8 BA1
5 IC1
LR
(1)
12 BA1
13 IC1
L
(1)
3 BA1
14 IC1
RY
(1)
18 BA1
4 IC1
R
(1)
LB
(1)
WL
LR
(1)
LW
(1)
5 IL1
J10(B), J11(A)
Junction
Connector
LR
(1)
6 IA2
5 IA2
7 IA2
LR
(1)
WL
E
B
E
B
L
(1)
LW
(1)
LW(1)
WR
A
A
A
A
RY
(1)
LR
(1)
LR
(1)
19 IA2
LR
(1)
GY
(1)
WG
10 IL2
20 IA2
R
(1)
21 IA2
RRD
19
RRU
18
RRA
22
LW
(1)
G
(1)
WL
GY
(1)
LB
(1)
LB(1)
WR
G
(1)
11 IL2
WG
9 IL2
LR
8 IL2
LR
(6)
L
(1)
11 IA2
RLD
15
RLU
17
RY
(1)
16
RLA
R
(1)
10 IA2
WL
23
LW
(1)
9 IA2
FRA
11
D17
GY
(1)
8 IA2
FRD
G
(1)
FRU
10
WB
WG
657
658
BL
(3)
50A AM1 NO. 1
W
(3)
AVENSIS (EWD526E)
http://vnx.su
1 4B
120A ALT
(1AZFSE, 1AZFE)
100A ALT
(1ZZFE, 3ZZFE)
BG
(2)
50A AM1 NO. 1
140A ALT
Battery
WB
FL MAIN
3. 0W
WB
IJ
Left Kick Panel
A B
E A
B
(4)
Junction Connector
J26(A), J27(B)
B
(5)
LY
B
(3)
B
(4)
5 DA
8 DA
9 DC
13 DB
7. 5A RAD NO. 1
9 DA
9 IL1
WB
1 1B
BL
(3)
P/W
20
KSW
ACC
21
3 IL1
WB
W
(3)
W
(3)
W
(2)
25A AM1
BG
(2)
19
PCTY
DCTY
17
Integration Relay
IG
22
10A GAUGE1
1 4D
IG1 Relay
LW
(1)
25
1
20A DRR P/W
LB
(1)
1 6A
PW
3
WB
IP
4
D17
WB
P13
FRU
5 IL1
Right Kick Panel
14
FRA
LY
LW(1)
LB(1)
FRD
(Cont. next page)

: Gasoline
: 1CDFTV
: w/ Moon Roof
: w/o Moon Roof
3 DH
1
2
3
4
5
WR
1 DN
GY
5 DH
1 ED1
IG1 1
1 DH
GR
Ignition SW
I13
3 AM1
ACC 2
P o w e r W in d o w (R H D )
WL
2 IP1
34 AVENSIS
B
(4)
B
(5)
20A PFR P/W

L
20A PRR P/W
20A DFR P/W

< 216> < 217>
25A DOOR
GY
LR
(6)
GW
GY
GY
LR
(1)
LR
AVENSIS (EWD526E)
http://vnx.su
LB
WB
Left Kick
Panel
GY
E
WB
(1)
P10
WB
BR
Under the Left

Center Pillar
WB
(1)
P14
WL
WB
Under the Left

Center Pillar
BU
WB
(1)
BQ
10 BC1
WB
(1)
WB
(1)
10 BA1
WB

SW Rear LH
WB
(1)
IJ
LB
LY
WB
(1)
9 IA1
GW
L
(1)
RY
(1)
R
(1)
P12
LR
(1)
1
UP
LW
(1)
DOWN
RY
(1)
L
(1)
R
(1)
AUTO
LR
(1)
P9
L
(1)
12 BC1
8 BC1
Under the Right

Center Pillar
WB
BV

Rear RH
WB
(1)
P11
Under the Right

Center Pillar
1
UP
3
AUTO
DOWN
GY
(1)
LR
(1)
RY
(1)
LW
(1)
WL
LW
(1)
G
(1)
3 BC1
GY
(1)
AUTO
18 BC1
G
(1)
1 BA1
3 IM1
4 IM1
2 IM1
5 IM1
LW
(1)
DOWN
2 IC3
6 IL2
5 IL2
7 IL2
LB
(1)
8 IM2
1 BC1
P15
GR
(1)
LW
(1)
RRD
19
RRU
18
RRA
22

G
(1)
UP
GW
R
(1)
5 IA1
LY
8 BA1
5 IC1
LR
(1)
12 BA1
13 IC1
L
(1)
3 BA1
14 IC1
RY
(1)
18 BA1
4 IC1
R
(1)
LB
(1)
WL
4 CE
10 CB
L
(1)
LW
(1)
LY
GW
8 CB
19 IL2
RY
(1)
LR
(1)
LW(1)
LB
9 CB
20 IL2
R
(1)
21 IL2
LR
(1)
LW
(1)
GY
LW
(1)
GY
(1)
GW
GY
(1)
G
(1)
11 IA2
LB
LR
(1)
10 IA2
LR
(1)
9 IA2
LR
(1)
8 IA2
LR
(6)
LR
11 IL2
L
(1)
10 IL2
RLD
15
RLU
17
RY
(1)
16
RLA
R
(1)
9 IL2
WL
23
LW
(1)
8 IL2
FLA
11
D17
GY
(1)
G
(1)
LB
(1)
LB(1)
FLD
G
(1)
FLU
10
WB
LB
659
35 AVENSIS
660
BL
(2)
W
(2)
W
(2)
50A AM1 NO. 1
120A ALT
(1AZFSE, 1AZFE)
100A ALT
(1ZZFE, 3ZZFE)
50A AM1 NO. 1
W
(2)
140A ALT
AVENSIS (EWD526E)
http://vnx.su
BG
(1)
B
(2)
25A AM1
Left Kick Panel
WB
IJ
10A GAUGE1
Right Kick Panel
WB
F12
Front Window Deicer
J2
Junction
Connector
S10(A), S11(B)
Short Connector
Left Side of the
Suspension Tower
WB
WB
WB
(4)
ED
Left
Kick
Panel
Right
Kick
Panel
IJ
IP
WB
IP
WB
9 IL1
M4
Mirror Heater LH
WB
9 IA1
12 IL1
12 IA1
WB
B B (RHD)
E A (LHD)
J18(A), J29(B)
Junction
Connector
M5
Mirror Heater RH
Battery
WB
(4)
6 CA
2
B
FL MAIN
3. 0W
GW
(5)
4 CJ
6 A
B B
E A
B B (RHD)
BY
1 4B
5 A
6 B
12 IE3
E A (LHD)
BY
GR
5 B
GW
(5)
L(5)
B
(4)
B
(3)
BY
9 DA
F20
1 : Gasoline
2 : 1CDFTV
3 : w/ Mirror Heater
4 : w/ Front Window Deicer
5 : LHD w/ FR DEICER Relay
w/o Front Window Deicer
6 : RHD w/ FR DEICER Relay
BY
W
(1)
BG
(1)
IG
RW
(4)
1 4D
RW
(4)
L
(4)
(RHD)
4 CH
FR DEICER
Relay
20A FR DIC
(LHD)
BL
(2)
2 IP1
GY
1 IE5
GW
(6)
Rear Window
Defogger SW
< 364>
RW
7 DB
GW
(6)
BY
1 1B
BG
(1)
5 DH 1 DN
Rear Window
Defogger Relay
< 364>
GR
1 DH
5 CF
7 CA
M irro r H e a te r
10A MIR HTR
1 ED1
W
(2)
IG1 1
ACC
RW
RW
1 6A
I13
Ignition SW
3 AM1
F ro n t W in d o w D e ic e r
RW
RW
B

< 363>
IG1 Relay
Behind the
Combination
Meter
A
IL
J16
Junction
Connector
IP
6 CA
WB
(LHD)
G
G
GW
(4)
J6
Junction
Connector
GW
(4)
WB
(LHD)
Right Kick Panel
3
6
9 IC1
WB
(RHD)
F19
7 IB1
R9
Rear Window
Defogger Relay
GW
(6)
R e a r W in d o w D e fo g g e r
GW
(3)
DEF
8 (LHD)
1 (RHD)
GW
(5)
GW
RW
18 IC1
RW
WB
(RHD)
GW
(5)
GW
(5)
9 CH
FR DEICER Relay
< 353>
IG
RW
7 CD
7 CA
RW
4 (LHD)
5 (RHD)
Short Connector
< 353>
7. 5A DEF I/UP
GW
(1)

< 476> < 488> < 497>
Right Side of
the Back Door
B
(1)
7 IC3
B
(1)
N7
R18(A), R19(B)
BW
Right Quarter Panel
IJ
Left Kick Panel
5 DH 1 DN
25A AM1
1 4B
3
1 4D
BG
(1)
BG
(1)
B
(2)
BG
(1)
1 4C
GR
120A ALT
(1AZFSE, 1AZFE)
100A ALT
(1ZZFE, 3ZZFE)
Battery
1 DH
GR
FL MAIN
3. 0W
I13
Ignition SW
3 AM1
IG1 1
GY
IG1 Relay
BG
(1)
ACC
WB
(L/B)
7 DB
BL
(2)
WB
B
(S/D)
10A GAUGE1
RW
WB
1 B
Rear Window
Defogger
(L/B)
5 DC
RW
(S/D)
4 DF
1 DP
N6
Noise Filter
(Rear Window Defogger No. 1)
WB
(L/B)
B
(S/D)
9 DA
B
(S/D)
(L/B)
B
(L/B)
1 A
4 BD1
4 BE1
B
(L/B)
(L/B)
Noise Filter
B
(L/B)
(S/D)
WB
(W/G)
BX
1 B
1 A
B
(W/G)
5 BG1
B
(W/G)
6 BF1
B
(W/G)
R18(A), R19(B)
: Gasoline
: 1CDFTV
: w/o FR DEICER Relay
: RHD w/ FR DEICER Relay
: 4 w/o Front Window Deicer
(L/B, W/G)
1
2
3
4
5
6
AVENSIS (EWD526E)
http://vnx.su
W
(2)
W
(2)
1 1B
1
1 ED1
2
BL
(2)
140A ALT
36 AVENSIS
30A RR DEF
W
661
662
BL
(4)
W
(4)
AVENSIS (EWD526E)
http://vnx.su
120A ALT (5)

100A ALT (6)
Left
Kick
Panel
140A ALT
B
B
B
J35(A), J36(B)
Junction Connector
R
Y
WB
WB
B
(4)
Lower Back
Panel Left
WB
J17
Junction
Connector
WB
WB
WB
Under the Left

Center Pillar
WB
(1)
6
WB
(2)
BR
WB
(1)
J37(A), J38(B)
Junction Connector
WB
(1)
Under the Right
Center Pillar
S17
H
A
Seat Heater RH
F
B
S17
Seat Heater
Cushion
Seat Heater RH
J35(A), J36(B)
Junction Connector
S16
Seat Heater LH
H
A
BS
Seat
Heater
Squab
WB
(1)
F
B
Seat Heater
Cushion
S16
Seat Heater LH
Seat
Heater
Squab
BV
WB
(2)
IP
Seat Heater
Cushion
Seat
Heater
Squab
Seat Heater
Cushion
J37(A), J38(B)
Junction Connector
Seat
Heater
Squab
Right Kick
Panel
WB
IJ
J32
Junction Connector
: w/ Power Seat
: w/o Power Seat
: Gasoline
: 1CDFTV
: 1AZFSE, 1AZFE
: 1ZZFE, 3ZZFE
Battery
G B
G A
BO
(2)
1
2
3
4
5
6
C B
LG
(2)
LB
(2)
LGB
(2)
B A
R
(1)
RG
(1)
LG
(1)
RVR
RB
(1)
H B
F A
B
(2)
2 B
LB
(2)
1 4B
SWR
A B
E A
LB
(2)
LB
(1)
FL MAIN
3. 0W
BG
(3)
A B
E A
11 IM2
LB
1 B
B
(2)
BG
(3)
WB
WB
G B
LG
(1)
H B
G A
LB
LB
(2)
LGB
(2)
17 IC2
SWL
BO
(2)
I15
Inner
Mirror
LG
(1)
F A
LG
(2)
4 A
LGB
(1)
RVL
LB
(1)
LB
3 A
LB
(1)
RW
1 4D
5 DM
IG
S 7(A), S 8(B)
Seat Heater SW
B
(1)
IG1 Relay
33 DA
5 A
2 A
S e a t H e a te r
BO
(1)
10A GAUGE1
WB
11 DK
SEAT HTR Relay
6 DK
LB
9 DA
16 DM
10A HTR
1 ED1
GY
1 DN
25A
AM1
5 DH
RL
1 DH
GR
Ignition SW
IG1 1
A u to m a tic G la re
R e s is ta n t E C M irro r
RL
I13
3 AM1
ACC
37 AVENSIS
J30(A), J31(B)
Junction Connector
20A SHTR
BG
(1)
AVENSIS (EWD526E)
http://vnx.su
WB
WB
RG
50A AM1 NO. 1
B
(2)
BG
(1)
Battery
WB
J35(A), J36(B),
J37(C), J38(D)
Junction
Connector
Under the Right

Center Pillar
P23
Power Seat Motor
(Driver' s Seat
Slide Control)
Under the Left

Center Pillar
LDWN
2 (LHD)
1 (RHD)
1 (LHD)
2 (RHD)
8
7
3
3
RCLR
2 (LHD)
2 (RHD)
YB
Under the Left

Center Pillar
RCLF
WB
(RHD)
WB
(LHD)
WB
(RHD)
BR
BV
SLDR
2 (LHD)
1 (RHD)
1 (LHD)
2 (RHD)
RCLF
Reclining
P19
Slide
SLDF
Under the Right

Center Pillar
H C (LHD)
H A (RHD)
F D (LHD)
F B (RHD)
WB
(LHD)
BR
1 (LHD)
2 (RHD)
LUP
E D (LHD)
E B (RHD)
A C (LHD)
A A (RHD)
P25
Power Seat Motor
Slide Control)
BV
H C (RHD)
1 (LHD)
2 (RHD)
7
8
YR
H A (LHD)
FDWN
LO
(LHD)
1 (LHD)
2 (RHD)
LB
F D (RHD)
LY
2 (LHD)
1 (RHD)
5
10
LR
F D
FUP
WB
FL MAIN
3. 0W
50A AM1 NO. 1

YG
2 (LHD)
1 (RHD)
Up
10
5
Down
F D
Rear
SLDR
Up
F B (LHD)
6
6
Down
LB
F B
SLDF
Front
YR
F B
Front
9
9
Rear
RCLR
YB
Reclining
J35(A), J36(B),
J37(C), J38(D)
Junction
Connector
2 (LHD)
1 (RHD)
4
4
Lifter
30A
PWR SEAT
Front
E1
Front
Vertical
P18
LO
(RHD)
10 IM2
1 6A
: Gasoline
: 1CDFTV
: 1AZFSE, 1AZFE
: 1ZZFE, 3ZZFE
Rear
1 4B
E2
1 (LHD)
1 (RHD)
Slide
E D (RHD)
E B (LHD)
1
2
3
4
Front
YR(LHD)
RL(RHD)
E D
E B
A C (RHD)
A A (LHD)
Rear
LO
(RHD)
W
(2)
30A
PWR SEAT
RL(LHD)
YR(RHD)
W
(2)
2 DM
1 DN
LO
(LHD)
1 ED1
BL
(2)
J35(A), J36(B).
J37(C), J38(D)
Junction
Connector
W
(1)
YR(LHD)
RL(RHD)
W
(2)
LO
1 1B
(RHD)
(LHD)
BG
(1)
Pow er Seat
LO
(RHD)
1 4D
2 IP1
1 IE5
38 AVENSIS
P24
Power Seat Motor
Reclining Control)
J35(A), J36(B),
J37(C), J38(D)
Junction
Connector
P22
Power Seat Motor
(Driver' s Seat
Reclining Control)
P21
Power Seat Motor
(Driver' s Seat
Lifter Control)
P20
Power Seat Motor
(Driver' s Seat
Front Vertical Control)
L6
Lumbar Support
Control Motor
RB
L7
Lumbar Support
Control SW
140A ALT
120A ALT (3)

100A ALT (4)
663
664
1 ED1
W
(2)
BG
(1)
30A AM2
30A DCC
W
(2)
B
(2)
AVENSIS (EWD526E)
http://vnx.su
1
2
3
4
: Gasoline
: 1CDFTV
: 1AZFSE, 1AZFE
: 1ZZFE, 3ZZFE
B
(2)
WB
120A ALT (3)

100A ALT (4)
IJ
10A GAUGE1
Left Kick Panel
9 DA
WB
Battery
7 DB
RW
FL MAIN
3. 0W
1 4B
140A ALT
BG
(1)
E B
E A
E B
LY
(RHD)
F C
F A
LY
(RHD)
F C
F A
J24(A), J25(B)
Junction
Connector
RW
BL(2)
IG1
Relay
4 DB
7 CA
3 CF
GR
3 DH
F C (RHD)
F A (LHD)
H D (RHD)
+B1
1 A
IG
3 A
RW
9 CB
10 CB
GR
(RHD)
GR
(RHD)
4 CE
H B (LHD)
GR
(LHD)
25A
AM1
5 DH 1 DN
BY
BW
15A RAD NO. 2
BG
(1)
1 4D
GR
1 4A
G
GY
GY
1 DH
I13
Ignition SW
IG2
4 AM2
BR
ST2 5
IG1 1
ACC 2
3 AM1
GR
BG(1)
(RHD)
1 IP1
LY
(LHD)
(LHD)
1 IE4
BR
RW
1 1A
BR
BL
(2)
BW
(RHD)
(LHD)
15 A
ACC
14 A
ST1
M 1(A), M 2(B), M 3(C)
MultiDisplay
D
GR
C
LY
(RHD)
LY
(LHD)
GR
(LHD)
GR
(RHD)
N a v ig a tio n S y s te m (M a p T y p e )
LY
(LHD)
5 IP1
4 IE4
(Cont. next page)
BW
BW
39 AVENSIS
GR
(RHD)
GR
(LHD)
LY
(RHD)
LY
(LHD)
GR
(LHD)
GR
GR
LY
(RHD)
J 8(A), J 9(B), J20(C), J21(D)

Junction Connector
7. 5A RAD NO. 1
7. 5A ST
BW
AUO+
2 A
SGND
6 C
(Shielded)
BR
W
B
B
R
R
GR
WB
AVENSIS (EWD526E)
http://vnx.su
R
WB
(LHD)
MACC
MIC+
MIC
Tweeter LH (LHD)
< 414>
Tweeter RH (RHD)
< 413>
T11
Amplifier
(Shielded)
14 ID1
BR
16 ID1
P (LHD)
LG(RHD)
18 ID1
AUI+
1 A
R(LHD)
W(RHD)
17 ID1
AUO
11 A
AUI
10 A
2 B
Right Kick Panel
6 CA
WB
IP
WB
(LHD)
Behind the
Combination Meter
WB
(RHD)
5 CG
IK
GND2
1 C
GND1
25 A
10 CH
7 CK
13 CF
TX+
5 B
GND
17 A
TX
10 B
SNSE
7 C
VR
1 B
WB
(LHD)
Right Kick
Panel
MIC
5 C
7 B
WB
IP
MIC+
3 C
3 B
CTX+
5 B
CTX
10 B
WB
(RHD)
GR
LY
(RHD)
VW
WB
(RHD)
MACC
4 C
SYNC
VR
1 B
WB
WB
LY
(LHD)
R11
Remote Controller
(Navigation)
REV
14 A
Radio and Player

< 414>
SPD
5 A
Parking Brake SW
< 206> < 216>
RY
ACC
18 A
8 B
VG
R
2 B
(Shielded)
(Shielded)
J17
Junction
Connector
+B
9 A
Combination Meter
< 425>
N 3(A), N 4(B), N 5(C)

Navigation ECU
(Shielded)
6 B
G
7 B
B
3 B
GR
(LHD)
GND
SYNC
8 B
(Shielded)
Combination Meter
< 423>
P
DLC3
< 519> < 615>
< 714> < 815>
ACC
LG
BW
TX
BW
VG
6 B
LG
SPD
4 A
VW
PKB
17 A
SGND
TC
16 A
WL
9 IC2
TX3
24 A
TX3+
12 A
GY
GTX
18 A
M 1(A), M 2(B), M 3(C)

MultiDisplay
GTX+
5 A
WB
RE1
10 A
WB
GR
(RHD)
SGD1
22 A
J15
Junction
Connector
LG(LHD)
R (RHD)
Radio and Player
< 413> < 414>
V(LHD)
L(RHD)
Neutral Start SW
(A/T)< 183>
BackUp Light SW
(M/T)< 183>
Combination Meter
< 423>
LY
(RHD)
LY
(LHD)
GR
(LHD)
665
666
W
(2)
W
(2)
B
(2)
Left Kick Panel
AVENSIS (EWD526E)
http://vnx.su
BG
(1)
B
(2)
Combination Meter
< 425>
WB
WB
WB
DTX+
2 B
GY
IK
J15
Junction
Connector
TX1+
4 A
DTX
5 B
SG
4 B
BRQ
1 B
Option Connector
(Navigation ECU)
< 502>
6 A
TX3+
E B
E A
TX3
15 A
9 CB
4 CE
GND
8 A
6 CA
10 CH
Right Kick Panel
Radio and Player

System< 412>
10
EAU
DISP
7 A
ST1
+B
9 A
IP
WB
IJ
TX1
13 A
M 1(A), M 2(B), M 3(C)

MultiDisplay
Battery
WB
7 CA
GND
1 C
FL MAIN
3. 0W
RW
3 CF
ACC
1 A
F C (RHD)
: Gasoline
: 1CDFTV
: 1AZFSE, 1AZFE
: 1ZZFE, 3ZZFE
WR
1 4B
IG
2 A
H B
F C
1
2
3
4
WB
120A ALT
(3)
100A ALT
(4)
RW
140A
ALT
BG
(1)
7 DB
10A
GAUGE1
7. 5A
RAD
NO. 1
J 8(A), J 9(B), J20(C)

Junction Connector
9 DA
IG1
Relay
4 DB
15A RAD NO. 2
1 4D
3 DH
F A (LHD)
LY
(LHD)
J24(A), J25(B)
Junction Connector
LY
(RHD)
BG
(1)
1 4A
GR
BL(2)
GR
(LHD)
BG(1)
5 DH 1 DN
GR
LY
(LHD)
25A
AM1
I13
Ignition SW
G
GY
GR
(RHD)
1 DH
IG1 1
ACC 2
LY
(RHD)
1 1A
30A
DCC
3 AM1
M u lti D is p la y (w /o N a v ig a tio n S y s te m M a p T y p e )
LY
(LHD)
BW
BL
(2)
1 ED1
(RHD)
(LHD)
BW
5 IP1
4 IE4
BW
40 AVENSIS
C14
Combination SW
LG
GY
RW
BL
(2)
W
(2)
AVENSIS (EWD526E)
http://vnx.su
BG
(1)
1 4A
30A DCC
1 1A
120A ALT
(1AZFSE, 1AZFE)
100A ALT
(1ZZFE, 3ZZFE)
1 4B
LY
(11)
140A ALT
BG
(1)
FL
TX
10 C
F21
Front Door
Speaker LH
T16
Tweeter
Front LH
F22
()OUT
3
(+)OUT
2
()IN
(+)IN
6 IA1
1 IA1
6 A
LG
Front Door
Speaker RH
()OUT
3
(+)OUT
TX+
9 C
2 A
FL+
RL
6 B
V
(6)
P
(6)
R
(6)
LG
(6)
Navigation ECU< 397>
Option Connector
Instrument Panel
GND
7 A
BR(LHD)
WB(RHD)
Battery
J24
Junction Connector
2
LG
()IN

Option Connector
(+)IN
10 IC2
MultiDisplay
< 396>
6 IL1
L
1 IL1
L
(7)
LG
(7)
W(3)
R(9)
(7)
R (3)
LG(9)
(7)
17 BA1
()IN
FL MAIN
3. 0W
A31
Antenna
Amplifier
EAU
10
12
AU2
11
LG
(8)
AU1
P
(8)
B
(2)
BW
LG
(5)
25A AM1
FR
5 A
L
(5)
1 A
FR+
RL+
2 B
R 4(A), R 5(B), R 6(C), R 7(D)

Radio and Player
RR
3 B
1
()OUT
P
(4)
BG
(1)
1 4D
GND
6 D
SW2
8 D
RR+
1 B
4
1 : Gasoline
2 : 1CDFTV
6 : LHD w/ MultiDisplay
7 : RHD w/ MultiDisplay
8 : w/ Steering SW
9 : w/ MultiDisplay
V
(4)
BW
WR
(8)
7 D
SW1
LY
(LHD)
ANT+
LY
(11)
8 A
GR
+B
4 A
LY
(10)
ACC
9 IM2
3 A
18 IM2
(RHD)
F B (RHD)
1 IC2
5 IP1
15A
RAD NO. 2
(LHD)
GR
F A (LHD)
7 BA1
R
Y
4 IE4
1 DN
7. 5A RAD NO. 1
F A (LHD)
T18
Tweeter Rear LH
(+)IN
7 BC1
3
(+)OUT
R15
LY
(LHD)
17 BC1
()IN
T19
Tweeter Rear RH
(+)IN
R
W
F B (RHD)
1
()OUT
(+)OUT
W
B
8 CB
4 CE
B
P
(3)
LY
(10)
4 DB
3 DH
LY
(11)
I13
Ignition SW
LY
(LHD)
IG1
ACC 2
1 DH
3 AM1
R16
GR
R a d io a n d P la y e r
R
Y
LG
(3)
1 ED1
41 AVENSIS
BR(LHD)
WB(RHD)
IN
T17
Tweeter
Front RH
C14
Combination SW
J 8(A), J20(B)
Junction Connector
B
(2)
667
F B
H A
H C
Door
H D (RHD)
H B (LHD)
F C (RHD)
F A (LHD)
4 DB
3 DH
GR
IL
Behind the
Combination
Meter
IP
Right
Kick
Panel
IK
Behind the
Combination
Meter
VW
(7)
MultiDisplay
< 396>
VW
(5)
Navigation ECU
< 396>
Option Connector
GR
VW
J 8(A), J 9(B), J20(C), J21(D)

Junction Connector
WB
(RHD)
Moon Roof Control

Relay and Motor
< 323>
WR
(RHD)
7. 5A RAD NO. 1
J15
Junction
Connector
WB
(LHD)
A
F B
F D (RHD)
H C
H A
H A
VW
(6)

Control ECU< 243>
VW
2 A
GR
20 B
H B
H C
18 B
J10(A), J11(B), J26(C)

Junction
Connector
F C (RHD)
F A (LHD)
VW
(w/ HID)
F C
WR
Speedometer
C o m b in a tio n M e te r
VW
F D
F B (LHD)
J10(A), J11(B), J20(C), J21(D)

Junction Connector
F D
H A (LHD)
H C (RHD)
A/T SHIFT (A/T)

CLOCK
C10(A), C11(B)
Combination Meter
: Gasoline
: 1CDFTV
: 1AZFSE, 1AZFE
: 1ZZFE, 3ZZFE
EPS ECU
< 234>
Fuel
Tachometer
WR
(LHD)
WB
6 CA
6 CK
5 B
WB
VW
(8)
1
2
3
4
Skid Control ECU

with Actuator
< 206> < 215>
LW
16 IE1
19 B
LW
CPU
Temp.

< 517> < 613> < 711>
Engine ECU (M/T)
< 517> < 613> < 711> < 813>
GRR
3 B
21 B
6 CD
7 CA
OUTSIDE
TEMP.
ODO/TRIP
A
BR
RW
: w/ MultiDisplay
: w/ Moon Roof
: w/ EPS
RW
5
6
7
8
(Cont. next page)

< 512> < 611> < 710>
Engine ECU (M/T)
< 512> < 611> < 710> < 812>
BL
(2)
Left Kick Panel
1 DH
4 AM2
I13
Ignition SW
25A AM1
GR
W
(2)
1 4B
1 4A
1 1A
B
(2)
BG
(1)
1 ED1
30A AM2
BR
BG
(1)
(RHD)
1 IP1
1 IE4
BR
(LHD)
BG
(1)
1 4D
B
(2)
30A DCC
(RHD)
5 IP1
AVENSIS (EWD526E)
http://vnx.su
(LHD)
140A ALT
BL
(2)
BW
4 IE4
6
1
WR
7. 5A DOME
42 AVENSIS
BW
Battery
120A ALT (3)

100A ALT (4)
FL MAIN
3. 0W
BR
GR
BW
668
IJ
9 DA
WB
ST2
GY
IG2 6
IG1 1
3 AM1
ACC 2
GY
IG1 Relay
5 DH 1 DN
BG
(1)
BR
7 DB
10A GAUGE1
RW
GY
(5)
10 A
GW
BRW
AVENSIS (EWD526E)
http://vnx.su
EI
WR
Behind the
Combination Meter
WB
(LHD 2)
GW
BRW
IL
Tail
Instrument Panel
Reinforcement RH
IO
WB
(LHD 1)
A1
A/C Ambient
Temp. Sensor
IK
BR
(2)
Behind the
Combination Meter
J15
Junction
Connector
J17
Junction
Connector
A/T OIL TEMP
Near the Starter
E7
Engine Oil
Level Sensor
BR
(2)
J16
Junction
Connector
WB
(RHD)
BR
(2)
YG
(2)
WR
YR
(2)
WB
(LHD)
Turn RH
17 A
13 B
WB
(RHD)
1 B
Fuel
4 IE1
YG
(2)
15 IE1
YR
(2)
15 IK2
Illumination
14 B
Turn LH
4 IK1
1 A
C10(A), C11(B)
Combination Meter
Turn Signal and

Hazard Warning
Light System
< 152> < 153>
Oil Level
6 IC1
16 A
14 A
1
2
5
9
: Gasoline
: 1CDFTV
: w/ MultiDisplay
Glow
15 IC1
12 A
CPU
BEAN
I/F
13 A
BR
(Cont. next page)
(2)
11 A
Buzzer
(9)
15 A
Multiplex
Communication
System< 115>
< 210> < 211>
AVCLAN
I/F
4 A
MultiDisplay
< 396> < 403>
G
(5)
3 A
Taillight System
< 142>
Illumination
System< 194>
5 A
BR
CRUISE
(2)
(2)
Seat Belt
ECT SNOW
Charge
F14
BR
(2)
F25
Fuel Sender
669
High Beam
System< 114>
Headlight System
< 134>
Front Fog
19 IK2
O2
Oil Pressure SW
V2
Vacuum
SW
C
RW
(2)
C
RW
(2)
B3
Brake Fluid Level
Warning SW
4 B
10
9 A
C10(A), C11(B)
Combination Meter
VSC System< 2010>

ABS System< 213>
ABS
P/S
670
22 B
10A
IGN
A B (RHD)
C A (LHD)
A B (RHD)
2 DH
18 DA
Filter
BR
BW
J 8(A), J26(B)
Junction
Connector
C A (LHD)
Check Engine
(w/ HID)
9 B
Beam Level
10 B
6 B
EPS System< 232>
AVENSIS (EWD526E)
http://vnx.su
Headlight Beam Level Control

System< 243>

< 55> < 67>
< 75> < 84>
EC
WB
RW
(1)
19 IE1
RW
Brake
BW
RW
(2)
SRS
2 B
8 B
SRS System
< 224>
16 B
11
VSC
(w/ VSC)
J2
Junction
Connector
(w/ VSC)
Slip
YB
(w/ VSC)
VSC System
< 2010>
TRC OFF
YB
11 B
Oil Pressure
17 B
8 A
Front Fog
Light System
< 162>
Rear Fog
15 B
Rear Fog
Light System
< 162>
7 A
12
12 B
System< 114>
Headlight System
< 134>
6 A
1 : Gasoline
2 : 1CDFTV
AVENSIS (EWD526E)
http://vnx.su
140A ALT
Left Kick Panel
GY
EC
WB
IG1 Relay
P5
Power Heater SW
GY
WB
WB
BR
Near the Starter
2
PTC2
P7
PTC Heater
PTC1
HTR2 Relay
IK
WB
J15
Junction
Connector
EI
BR
IJ
RW
Battery
IN
IG
RW
1
WB
GY
12 IE6
F/P
2
12 CK
3 EE1
SW
ALT+L
1 CB
10A
HTR
BR
FL MAIN
3. 0W
9 DA 6 DC
16 IK2
5 IK2
BR
1 1A
BR
BL
GR
GY
WL
BL
5 DH 1 DN
P1
+
P o w e r H e a te r
(E le c tric a l T y p e )

< 488> < 498>
HTR1 Relay
RW
1 ED1
25A
AM1
I13
Ignition SW
IG1 1
WL
1 DH
3 AM1
ACC
P o w e r H e a te r (C o m b u s tio n T y p e )
BR
RW
43 AVENSIS
J2
Junction
Connector
WB
F17
Fuel Pump
Alternator
< 33>
50A HTR1
50A HTR2
25A PWR HTR
671
672
30A CDS
BG
30A RDI
AVENSIS (EWD526E)
http://vnx.su
1 4B
120A ALT
BG
Battery
WB
IJ
IG1 Relay
Left Kick Panel

< 475> < 488> < 497>
WR
A2
A/C Condenser
Fan Motor
2
M
R1
Radiator
Fan Motor
6 IE2
D4
Diode
(Fan)
WB
FAN
NO. 1
Relay
J1
FAN
NO. 2
Relay
Junction
Connector

< 512> < 611>
Engine ECU (M/T)
< 512> < 611>
FL MAIN
3. 0W
WR
9 DA
7. 5A ECUIG
BG
1
DN
1
4D
16 IE2
RL
Engine Compartment
Left
WB
25A AM1
EC
WR
WB
1 4C
11 DL
1 1B
10 DL
FAN
NO. 3
Relay
WR
WR
GR
5 DH
GY
1 DH
RL
RL
1
WR
B
WR
RL
IG1 1
I13
Ignition SW
3 AM1
ACC
R a d ia to r F a n a n d C o n d e n s e r F a n (1 A Z F S E , 1 A Z F E )
WR
RL
44 AVENSIS
WR
BG
AVENSIS (EWD526E)
http://vnx.su
IG1 Relay
Left Kick Panel
6 IE2
D4
Diode
(Fan)
J1
Junction
Connector
Engine and ECT ECU

(A/T)< 78>
Engine ECU (M/T)
< 78>
WB
100A ALT
BG
IJ
WR
FAN
NO. 2
Relay
2
R2
WB
WR
WB
EC
WB
Battery
R1
Radiator
Fan Motor
FAN
NO. 3
Relay
FL MAIN
3. 0W

< 475> < 488> < 497>
1 4B
40A RDI
9 DA
7. 5A ECUIG
WR
16 IE2
L
W
1
DN
11 DL
WR
BG
RL
10 DL
RL
1
4D
GY
5 DH
RL
WB
1 4C
GR
1 DH
IG1 1
R a d ia to r F a n (1 Z Z F E , 3 Z Z F E )
1 1B
I13
Ignition SW
3 AM1
ACC
WR
RL
45 AVENSIS
WR
25A AM1
673
674
WR
40A RDI
30A CDS
AVENSIS (EWD526E)
http://vnx.su
IG1 Relay
Left Kick Panel
WB
WR
D4
Diode (Fan)
< 475> < 488> < 497>
WB
WB
140A ALT
EB
WB
IJ
R1
Radiator
Fan Motor
WR
9 DA
7. 5A ECUIG
Battery
1
DN
W
B
6 IE2
FL MAIN
3. 0W
BL
FAN
NO. 3
Relay
1
ED1
16 IE2
Engine ECU (M/T)

< 810>
WB
J1
Junction
Connector
FAN
NO. 2
Relay
WB
EC
1
M
WR
WB
11 DL
FAN
NO. 1
Relay
RL
10 DL
GY
RL
5 DH
WR
1 1B
GR
1 DH
RL
WR
1 1C
IG1 1
ACC
RL
I13
Ignition SW
3 AM1
R a d ia to r F a n a n d C o n d e n s e r F a n (1 C D F T V )
RL
WR
46 AVENSIS
A2
A/C Condenser
Fan Motor
W1
Water Temp. SW
(Radiator Fan)
WB
25A AM1
47 AVENSIS
676
BW
BL
(2)
BG
(1)
W
(2)
B
(2)
W
(2)
30A DCC
AVENSIS (EWD526E)
http://vnx.su
120A ALT (3)

100A ALT (4)
140A ALT
BG
(1)
B
(2)
25A AM1
Left Kick Panel
WB
IJ
WB
WB
WB
IK
4 IJ2
GND
VM
J15
3
IJ2
C4
Condenser
Assembly
WB
(2)
LB
GR
IL
Behind the
Combination Meter
IN
2
RW
(RHD)
RW
(LHD)
P5
Power Heater SW
Behind the
Combination Meter
Junction
Connector
SI
+B
B5
Blower Motor
Controller
Battery
BW
FL MAIN
3. 0W
18 IE2
RB
(2)
IG
WB
(2)
1 4B
B4
Blower Motor
2 IJ2
LB
1 IJ2
11 IE1
12 CK
GY
(2)
BG
(1)
HTR
Relay
J26(A), J27(B)
Junction
Connector
3 IK2
2 IK2
8 A
SOL+
IG
12 B
2 CE
6 CE
9 CJ
1 CB
C3
Compressor Assembly
R
2 DF
LB
LB
34 DA
GRR
40A HTR
1 4D
10A HTR
1 4C
BW
BG
(1)
1 4A
7. 5A ECUB 2
RW
IG1 Relay
4 DF
RW
(2)
9 DA
BL
(2)
RW
(LHD)
5 DB
RW
(RHD 2)
GY
RW
(RHD)
2 DP 6 DC
RW
(LHD 2)
RW
(LHD 2)
BG
(1)
5 DH 1 DN
H A
7 CF
10 CC
+B
24 B
11 B
HOTGASIN
7 A
MGV
17 B
5 B
BLW
RW(LHD)
RW(RHD)
HR
A15(A), A16(B)
RW
(RHD)
1 1B
1 DH
RW
(RHD 2)
RW
(LHD)
RW
(RHD 2)
WR
1 1A
F B
F B
H A
RW
(RHD)
RW
(LHD)
I13
Ignition SW
IG1 1
H A
RW
(LHD)
3 AM1
H A
RW
(RHD)
WR
1 ED1
BW
(RHD)
WR
5 IP1
(LHD)
ACC
RW
(RHD)
A ir C o n d itio n e r (A u to m a tic A /C ) a n d
P o w e r H e a te r (H o t G a s T y p e A u to m a tic A /C )
RW
(RHD)
4 IE4
(Cont. next page)

1 : Gasoline
2 : 1CDFTV w/ Power
Heater (Hot Gas Type)
3 : 1AZFSE, 1AZFE
4 : 1ZZFE, 3ZZFE

R
GRR
RY
(2)
GY
(2)
R
J16
Junction
Connector
RY
(2)
WB
Right
Kick
Panel
A17
A/C Room Temp.
Sensor
GR
BW
Parking Brake SW
< 206> < 216>
WB
(RHD)
WB
(LHD)
AVENSIS (EWD526E)
http://vnx.su
WB
(RHD)
WB
(LHD)
WB
(RHD)
IK
FAN NO. 3 Relay

< 443> < 452> < 463>
IP
WR
J15
Behind the
Combination Meter
GW
(1)
S5
16 B
SG1
13 A
2
1
VZ
18 B
SG
S51
1 B
1 IQ1
PRE
7 B
A3
A/C Pressure Sensor
17 IE2
8 IE2
7 IE2
BW
10 B
TE
AMDH
12 A
2 IQ1
BW
GW
Junction
Connector
SG4
16 A
AMDC
11 A
1
2
GND
GW
LW
4 B
TPD
8 B
LW
J17
RDEFIN
PBLT
3 B
S52
2 B
3
3
PT
TPP
20 B
3 IQ1
AMPC
1 A
TSP
21 B
5
4
4 IQ1
TSD
9 B
15 B
S54
AMPH
2 A
A18
A/C Solar Sensor
3 IF1
2 IF1
1 IF1
5 IQ1
4 (LHD)
5 (RHD)
MAX
HOT
1 : Gasoline
Junction
Connector
MPX
20 A
SG2
14 A
PT
LG
MPX+
10 A
A15(A), A16(B)
AOF
VZ
MAX
COOL
LG
6 CA
RY
P
(RHD)
3 CG
PB
17 A
CFAN
A21
Air Inlet Control
Servo Motor
PBKIG
GW
V
(RHD)
19 A
BRW
R
(RHD)
GND
GRR
Y
(RHD)
13 B
LGB
4 A
LB
AOD
YR
3 A
GND
YB
TPM
FACE
GR
19 B
S53
DEF
PL
14 B
P
(LHD)
SG3
PT
P
(RHD)
15 A
R
(LHD)
FRS
VZ
R
(RHD)
6 A
V
(LHD)
REC
GND
V
(RHD)
5 A
MAX
HOT
Y
(LHD)
TR
FRS
MAX
COOL
A24
Y
(RHD)
22 B
A23
(Driver Side)
W
(LHD)
SG5
REC
A25
A ir C o n d itio n e r (A u to m a tic A /C ) a n d P o w e r H e a te r (H o t G a s T y p e A u to m a tic A /C )
W
(RHD)
6 B
RW(LHD)
RW(RHD)
W
(RHD)
A19
A/C Thermistor
WG
DEF I/UP Fuse

< 363>
System< 115> < 211>
677
678
BL
(2)
7. 5A ECUB 2
BW
BG
(1)
BG
(1)
W
(2)
30A DCC
B
(2)
W
(2)
AVENSIS (EWD526E)
http://vnx.su
120A ALT
(1AZFE)
100A ALT
(1ZZFE, 3ZZFE)
140A ALT
BG
(1)
B
(2)
25A AM1
Left Kick Panel
WB
IJ
Behind the
Combination Meter
WB
WB
IK
WB
(3)
GR
J15
Junction
Connector
3
M2
M1
LO
4 IJ1
2 IJ1
3 IJ1
BW
HI
18 IE2
A/C Amplifier
MGV
14 A
B6
Blower
Resistor
A13(A), A14(B)
LB
IL
6 B
M1
1 IJ1
J16
LB
Junction
Connector
5 B
M2
HRIN
35 A
WB
(RHD)
WB
Battery
WB
(3)
Blower SW
C2
C1
FL MAIN
3. 0W
B4
4 B
HI
Blower
Motor
GRR
(LHD)
1 B
GND
3 B
2 B
1 CA
11 IE1
RW
(LHD 3)
WB
(LHD)
4 DF
WB
34 DA
2 DF
LB
1 4B
9 DA
GRR
(RHD)
40A HTR
GRR
(LHD)
BG
(1)
10A HTR
7 CG
GRR
(LHD)
4 CK
5 CE
GRR
(LHD)
1 4D
GRR
(RHD)
1 4C
BL
(2)
5 DB
J28
Junction Connector
: Gasoline
: 1CDFTV
GRR
(RHD)
1 4A
GY
2 DP 6 DC
L
GRR
(RHD)
RY
(3)
BG
(1)
5 DH 1 DN
RW
(LHD)
GRR
(RHD)
GR
1 DH
RW
(LHD 3)
1 1B
C4
Condenser Assembly
RB
(3)
I13
Ignition SW
IG1 1
ACC
1
2
3
4
GRR
(LHD)
1 1A
3 AM1
WB(LHD)
WB(RHD)
D
RW
(RHD 3)
WB
(3)
RW(RHD)
RW(LHD)
WR
(Cont. next page)
RW
(3)
BW
(RHD)
(LHD)
A ir C o n d itio n e r (M a n u a l A /C ) a n d P o w e r H e a te r (H o t G a s T y p e M a n u a l A /C )
RW
(RHD)
1 ED1
BW
5 IP1
WR
4 IE4
48 AVENSIS
HTR Relay
WB
IG1 Relay
RW
(RHD)
RW
(RHD 3)
AVENSIS (EWD526E)
http://vnx.su
WB
(LHD)
A25
5 A
PT
34 A
MAX
HOT
15 A
AMH
28 A
RPTC1
(SIG1)
26 A
ALT
(EFII)
20 A
PTC1
(PTC)
MPX
29 A
19 A
PTC2
(PTCL)
PBLT
24 A
HRLY
30 A
Engine ECU (M/T)

< 87>
MAX
COOL
16 A
AMC
MPX+
RW
(5)
GR
YR
A22
2
GND
YB
VZ
36 A
TP
9 A
4 A
RDEFIN
Alternator
< 33>
LGB
GRR
BRW
WB
(RHD)
WB
(LHD)
FACE
13 A
SG2
PBKIG
25 A
BW
(5)
DEF
12 A
S52
CFAN
23 A
HTR1 Relay
< 434>
Behind the
Combination Meter
PT
33 A
AOF
PRE
32 A
WL
(5)
IK
J15
Junction
Connector
2
VZ
GW
GND
6 A
AOD
SG
38 A
HTR2 Relay
< 434>
P5
Power Heater SW
J17
Junction
Connector
37 A
TPM
S5
7 A
RW
(5)
IP
WB
(RHD)
39 A
S53
+B
2 A
HLP Relay
< 18> < 131>
Right Kick Panel
31 A
SG3
A/C Amplifier
FRS
RY
(5)
6 CA
WB
(LHD)
3 CG
WB
(3)
9 CG
GY
(3)
40 A
SG4
RW
(LHD)
TE
PB
10 A
WR
REC
BW
GND
RY
11 A
GW
IG
WR
1 A
FAN NO. 3 Relay

< 443> < 452> < 463>
SOL+
BW
17 A
17 IE2
8 IE2
LW
7 IE2
Parking Brake SW
< 206> < 216>
22 A
RW
(RHD)
FRS
GW
(1)
HOTGASIN
C3
Compressor Assembly
R
1
RW
(RHD)
REC
RW
(LHD)
7 CF
DEF I/UP Fuse

< 363>
A13(A), A14(B)
6 CE
A3
A/C Pressure Sensor
BW
3 IK2
2 CE
10 CC
GW
IN
1 CB
LW
12 CK
: Gasoline
: Except 1AZFE
7
1
3
5
6
System< 115> < 211>
WB(LHD)
RW
(RHD 3)
IG
9 CJ
(6)
RW
(RHD)
J26(A), J27(B)
Junction
Connector
RW
(RHD)
F B
H A
RW
F B
RW
(RHD)
H A
RW
(LHD 3)
H A
2 IK2
RW
(LHD)
RW
(LHD 3)
H A
RW
(LHD 3)
RW
(RHD)
RW
(LHD)
WB(RHD)
RW
(RHD 3)
A ir C o n d itio n e r (M a n u a l A /C ) a n d P o w e r H e a te r (H o t G a s T y p e M a n u a l A /C )
WR
WB
(3)
RW(RHD)
RW(LHD)
WR
PL
A21
Air Inlet Control
Servo Motor
LB
WG
A19
A/C Thermistor
WB
(RHD)
679
49 AVENSIS
680
BL
(2)
BW
W
(2)
7. 5A ECUB 2
BG
(1)
BG
(1)
B
(2)
W
(2)
30A DCC
AVENSIS (EWD526E)
http://vnx.su
25A AM1
Left Kick Panel
120A ALT
(1AZFE)
100A ALT
(1ZZFE, 3ZZFE)
140A ALT
BG
(1)
B
(2)
WB
3
M2
M1
LO
4 IJ1
2 IJ1
BW
HI
Heater Amplifier
B6
Blower
Resistor
A13(A), A14(B)
LB
WB
IK
J15
Junction
Connector
6 B
M1
3 IJ1
1 IJ1
LB
WB
IJ
5 B
M2
HRIN
35 A
WB
(RHD)
WB
Battery
Blower SW
C2
C1
B4
4 B
HI
Blower
Motor
GRR
(LHD)
1 B
GND
3 B
2 B
1 CA
WB
(LHD)
FL MAIN
3. 0W
4 DF
WB
2 DF
LB
1 4B
34 DA
GRR
(RHD)
9 DA
GRR
(LHD)
40A HTR
7 CG
4 CK
5 CE
GRR
(LHD)
BG
(1)
10A HTR
RW
(RHD)
1 4D
GRR
(RHD)
1 4C
J28
Junction Connector
GRR
(RHD)
1 4A
2 DP 6 DC
1 : Gasoline
2 : 1CDFTV
GRR
(LHD)
GY
5 DH 1 DN
BG
(1)
GRR
(RHD)
GR
1 DH
BL
(2)
1 1B
1
L
GRR
(RHD)
I13
Ignition SW
IG1 1
ACC
RW
(LHD)
1 1A
3 AM1
H e a te r
GRR
(LHD)
BW
(RHD)
1 ED1
BW
5 IP1
(LHD)
WR
4 IE4
WB(LHD)
WB(RHD)
RW(RHD)
RW(LHD)
WR
(Cont. next page)
HTR Relay
WB
IG1 Relay
GR
J26
Junction
Connector
AVENSIS (EWD526E)
http://vnx.su
WB
(LHD)
WB
(LHD)
LGB
GR
YR
YB
LB
GRR
BRW
WB
(RHD)
WB
(LHD)
A22
4
MAX
COOL
5
MAX
HOT
28 A
RPTC1
(SIG1)
26 A
ALT
(EFII)
20 A
PTC1
(PTC)
19 A
PTC2
(PTCL)
HRLY
30 A
Engine ECU (M/T)

< 87>
PT
15 A
AMH
RW
(3)
A25
GND
16 A
AMC
Alternator
< 33>
VZ
34 A
TP
PBLT
24 A
BW
(3)
5
FACE
36 A
SG2
MPX
29 A
HTR1 Relay
< 434>
Behind the
Combination Meter
4
DEF
5 A
S52
MPX+
WL
(3)
IK
J15
Junction
Connector
3
PT
13 A
AOF
9 A
4 A
RDEFIN
HTR2 Relay
< 434>
2
VZ
GW
GND
12 A
AOD
PBKIG
25 A
RW
(3)
IP
RW
(RHD)
J17
Junction
Connector
33 A
TPM
Heater Amplifier
CFAN
23 A
HLP Relay
< 18> < 131>
Right Kick Panel
WB
(RHD)
6 A
S53
+B
2 A
1 : Gasoline
4 : Except 1AZFE
RY
(3)
6 CA
37 A
SG3
A21
Air Inlet Control
Servo Motor
3 CG
RW
(LHD)
FRS
WR
9 CG
PB
10 A
WR
REC
FAN NO. 3 Relay

< 443> < 452> < 463>
WB(LHD)
RY
11 A
FRS
BW
IG
RW
(RHD)
REC
RW
(LHD)
7 CF
10 CC
Parking Brake SW
< 206> < 216>
1 A
6 CE
1 CB
GW
(1)
WB(RHD)
2 CE
RW
(RHD)
DEF I/UP Fuse

< 363>
40 A
RW
(RHD)
System< 115> < 211>
GND
H e a te r
(4)
RW
(LHD)
A13(A), A14(B)
RW(RHD)
RW(LHD)
WR
WR
PL
WB
(RHD)
681
682
BW
BW
BG
(1)
BG
(1)
B
(2)
L
AVENSIS (EWD526E)
http://vnx.su
BG
(1)
B
(2)
Battery
3 A
RY
FL MAIN
3. 0W
14 A
12 A
VW
1 4B
MultiDisplay
< 403> < 404>
5 A
E B
E A
17 A
6 CA
10 CF
WB
IP
10 CB
4 CE
Right Kick Panel
1 A
18 A
18 B
9 A
9 B
2 A
2 B
P (LHD)
LG(RHD)
16 A
Z 1(A), Z 2(B)
WB
120A ALT
(3)
100A ALT
(4)
GR
13 A
10 A
LY
(RHD)
140A
ALT
15 A
F B (RHD)
Junction
Connector
F A (LHD)
J 8(A), J20(B)
F B (RHD)
F A (LHD)
LY
(LHD)
J24(A), J25(B)
Junction
Connector
6 A
7. 5A
RAD
NO. 1
GR
1 4D
4 DB
3 DH
15A RAD NO. 2
1 4A
LY
(LHD)
W
(2)
BL
(2)
1 ED1
IG1
ACC 2
GR
1 1A
1 DN
25A
AM1
Ignition SW
I13
3 AM1
LY
(RHD)
30A
DCC
1 DH
GR
O p tio n C o n n e c to r (N a v ig a tio n S y s te m T u rn b y T u rn T y p e )
BW
(RHD)
LY
(LHD)
5 IP1
4 IE4
(LHD)
50 AVENSIS
1
2
3
4
: Gasoline
: 1CDFTV
: 1AZFSE, 1AZFE
: 1ZZFE, 3ZZFE
11 A
11 B
V(LHD)
L(RHD)
Tweeter LH (LHD)
< 414>
Tweeter RH (RHD)
< 413>
LG
Radio and Player
< 413> < 414>
Combination Meter
< 423>
Neutral Start SW
(A/T)< 183>
BackUp Light SW
(M/T)< 183>
LG
GY
D RELAY LOCATIONS
[Engine Compartment]
(Gasoline)

Engine Room J/B No.4
Skid Control
ECU with
Actuator
(w/o VSC)
Skid Control
ECU with
Actuator
(w/ VSC)
Engine Room
R/B No.1
Engine Room
J/B No.1
Headlight
Control
ECU RH
Headlight Control
ECU LH
Radiator
Fan Relay
Engine Room
R/B No.2
Headlight Cleaner
Control Relay
(Diesel)
Glow Plug Relay
Engine Room
R/B No.3
* 1:2AD-FHV, 2AD-FTV
Electronic
Driver Unit
(*1)
Electronic
Driver Unit
(1CD-FTV)
Engine Room
R/B No.1
Engine Room
J/B No.1
Skid Control
ECU with
Actuator
(w/o VSC)
Skid Control
ECU with
Actuator
(w/ VSC)
Headlight Control
ECU LH
Headlight
Control
ECU RH
Headlight Cleaner
Control Relay
8
AVENSIS (EWD625E)
http://vnx.su
D
[Instrument Panel]
(LHD)
Transponder Key EPS ECU
Amplifier
Transponder Key
Computer
Center J/B
Tire Pressure
Monitor ECU
Wiper Relay
Door Control
Receiver
Turn Signal
Flasher Relay
Headlight Beam
Level Control
ECU
Driver Side
R/B
Rear Window
Defogger Relay
Engine and ECT

ECU (A/T)
Engine ECU (M/T)
Rear Fog
Light Relay
Air Fuel Ratio

Sensor Relay
Circuit Opening
Relay
A/C Control
Assembly
Integration
Relay
Option Connector
(Navigation ECU)
Driver Side J/B
Fuse Block Navigation ECU

J/B No.6
Airbag Sensor
Assembly
Shift Lock
Control ECU
(RHD)
Rear Window
Defogger Relay
Door Control Driver Side Engine and ECT

Transponder
EPS ECU
R/B
Receiver
ECU (A/T)
Key Computer
Engine ECU (M/T)
Rear Fog
Light Relay
Turn Signal
Flasher Relay
Driver Side
J/B
Center J/B
Theft Deterrent
ECU
Circuit Opening
Relay
Headlight Beam
Level Control ECU
Integration Relay
Wiper Relay
Tire Pressuer
Monitor ECU
Fuse Block
J/B No.6
Navigation ECU
Transponder
Key Amplifier
Air Fuel Ratio

Sensor Relay
Shift Lock
Control ECU
Airbag Sensor
Assembly
Option Connector
(Navigation ECU)
A/C Control
Assembly
9
AVENSIS (EWD625E)
http://vnx.su
D RELAY LOCATIONS
[Body]
(S/D)
Moon Roof Control
Relay and Motor
(L/B)
Moon Roof Control
Relay and Motor
Rear Wiper
Motor and Relay
10
AVENSIS (EWD625E)
http://vnx.su
D
(W/G)
Moon Roof Control

Relay and Motor
Rear Wiper
Motor and Relay
11
AVENSIS (EWD625E)
http://vnx.su
D RELAY LOCATIONS
1

(Gasoline)
* 1:2AZ-FSE, 1AZ-FSE, 1AZ-FE
* 2:1ZZ-FE, 3ZZ-FE
3
5
FAN NO.1 Relay

1
30A CDS
(for High Current)
30A RDI
40A RDI
40A HTR
(for High Current)
3
5
1 4 2
FAN NO.2 Relay
3
5
1
FAN NO.3 Relay

2
30A RR DEF
(for High Current)
1B
1A
1
40A MAIN
(for High Current)
2 30A 1
AM2
2 30A 1
DCC
2 20A 1
EFI
2 15A 1
IG2
2 7.5A 1
ALT-S
2 10A 1
HAZARD
2 15A 1
HORN
2 10A 1
ETCS
2 20A 1
A/F
50A EMPS
(for High Current)
5
2
1
3
12
AVENSIS (EWD625E)
http://vnx.su
EMPS Relay
D
1

(Diesel)
* 1:VSC (w/ VSC)
ABS (w/o VSC)
50A AM1 NO.1
(for High Current)
30A H/CLN
(for High Current)
3
5
1
40A HTR
(for High Current)
3
5
1
30A CDS
(for High Current)
EFI MAIN Relay

2
EDU Relay
2
40A RDI
(for High Current)
1C
1

Gray
1B
50A VSC
(for High Current) (w/ VSC)
40A ABS
(for High Current) (w/o VSC)
(from Engine Wire)

1
*1
1 25A 2
2 7.5A 1
ALT-S
2 30A 1
DCC
2 30A 1
AM2
2 10A 1
HAZARD
2 25A 1
F-HTR
2 15A 1
HORN
2 20A 1
EFI
2 25A 1
PWR HTR
2
30A RR DEF
(for High Current)
40A MAIN
(for High Current)
1A
FAN NO.3 Relay
5 3
(from Engine Wire)

1
FAN NO.1 Relay
5
2
13
AVENSIS (EWD625E)
http://vnx.su
D RELAY LOCATIONS
2
: Engine Room R/B No.2 Near the Radiator Fan (See Page 8)
HORN Relay
H-LP HI LH
1 10A 2
H-LP Relay
DIM Relay
FAN NO.2 Relay
2
3 5
H-LP HI RH
1 10A 2
1
1
H-LP LH
1 15A 2
H-LP RH
1 15A 2
3 5
1
1
3
3
5
1 4 2
3
2
F-HTR Relay
(Diesel)
50A HTR2
(for High Current)
50A HTR1
(for High Current)
2
1
80A GLOW
(for High Current)
3
2
HTR2 Relay
HTR1 Relay
140A ALT
(for High Current)
14
AVENSIS (EWD625E)
http://vnx.su
D
4

(Gasoline)
* 1:VSC (w/ VSC)

ABS (w/o VSC)
* 2:2AZ-FSE, 1AZ-FSE, 1AZ-FE
* 3:1ZZ-FE, 3ZZ-FE
INJ Relay
1
5
3
*1
1 25A 2
7.5A
EFI NO.2
4A
10A
EFI NO.1
4C
1
4D
4B

120A ALT
100A ALT

4E
1
1
(from Engine Wire)
5 3
EFI Relay
IG2 Relay
5 3
2
50A VSC
(for High Current)
(w/ VSC)
40A ABS
(for High Current)
(w/o VSC)
50A AM1 NO.1
(for High Current)
A/F Relay
5 3
2
30A H-LP CLN

(for High Current)
15
AVENSIS (EWD625E)
http://vnx.su
D RELAY LOCATIONS
5
: Driver Side R/B
LHD : Left Side of the Instrument Panel (See Page 9)

RHD : Instrument Panel Reinforcement LH (See Page 9)
(LHD)
P/POINT Relay
1
5
3
ST Relay
1
5
3
5
3
FR DEICER Relay
1
5
3
FR FOG Relay
(RHD)
ST Relay
1
5 3
FR DEICER Relay
P/POINT Relay
5 3
FR FOG Relay
1
5 3
5 3
2
16
AVENSIS (EWD625E)
http://vnx.su
D
6
: Fuse Block
: J/B No.6
Lower Finish Panel (See Page 9)

* 1:P-RR P/W (LHD)
D-RR P/W (RHD)
* 2:P-FR P/W (LHD)
D-FR P/W (RHD)
* 3:D-RR P/W (LHD)
P-RR P/W (RHD)
* 4:D-FR P/W (LHD)
P-FR P/W (RHD)
30A PWR SEAT

(for High Current)
A/F
15A
*1
20A
*2
20A
*3
20A
*4
20A
DEF I/UP
1 7.5A 2
ST
7.5A
MIR HTR
2 10A 1
ECU-B 1
1 7.5A 2
RAD NO.2
2 15A 1
FUEL OPN
10A 2
FR DIC
1 20A 2
ECU-B 2
2 7.5A 1
DOME
7.5A 1
6A
17
AVENSIS (EWD625E)
http://vnx.su
D RELAY LOCATIONS
: Driver Side J/B
Left Side of the Instrument Panel (See Page 9)
Black
Gray
DB
DC
1 2 3 4 5 6 7 8 9 10
11 1213141516171819 20
DF
17 34
16 33
15 32
14 31
13 30
12 29
11 28
27
26
25
24
6
5
4
3
2
1
23
22
21
20
19
18
34 17
33 16
32 15
31 14
30 13
29 12
28 11
DA
10 9 8 7 6 5 4 3 2 1
20 19181716 1514 1312 11
23
22
21
20
19
18
6
5
4
3
2
1
7 6 5
DD
IGN
10A
2
1
6 5 4 3
2 1
4 3
2 1
10 9 8
DG
3
2 1
9 876 5 4
5
2
S/ROOF
20A
RR FOG
7.5A
TAIL
10A
FR FOG
15A
OBD2
7.5A
1
3
PANEL
7.5A
P/POINT
15A
RR WIP
20A
DOOR
25A
GAUGE2
7.5A
WIP
25A
CIG
15A
ECU-IG
7.5A
HTR
10A
S-HTR
20A
IG1 Relay
SEAT HTR Relay
1 2
3 4
1 2
5 6 7
3 4
8 9 10

30A PWR SEAT
(for High Current)
AM1
25A
DJ
HTR Relay
2 1
7 6 5
Yellow
4 3
(from Instrument
Panel Wire)
1 2
3
4 5 6 7 8 9
4 3
10 9 8
27 10
26 9
25 8
24 7
(from Instrument
Panel Wire)
3 4
8 9 10

Black
10
9
8
7
1 2
5 6 7
2
3 5
3 5
1
GAUGE1
10A
RAD NO.1
7.5A
STOP
15A
Blue
DH
TAIL Relay
1
2
3 4 5 6
18
AVENSIS (EWD625E)
http://vnx.su
1 2 3 4 5 6 7 8 9
10 11 121314151617 18
DL
1 2
3 4
5 6 7 8 9 1011
DK
DP
4 3
2 1
1110 9 8 7 6 5
(from Roof Wire)
1
9 8 7 6 5 4 3 2 1
18 17161514131211 10
5 4 3 2 1
1 2 3 4 5
6 7
8 9
DM
9 8
7 6
1716151413121110
3 2 1
DN
1011121314151617
(from Floor Wire)

1 2 3 4 5 6 7 8 9 10111213141516171819202122 2324 25
Integration Relay
19
AVENSIS (EWD625E)
http://vnx.su
D RELAY LOCATIONS
[Driver Side J/B Inner Circuit]
2 DC
1 DH
25A AM1
4 DC
4 DM
3 DB
8 DM
1 DN
3 DC
10A TAIL
9 DL
TAIL Relay
3
5
7.5A PANEL
19 DB
23 DA
15 DL
8 DD
8 DL
20A S-HTR
SEAT HTR Relay
3
5
5 DM
12 DB
17 DB
33 DA
5 DB
6 DC
9 DA
16 DA
IG1 Relay
3
16 DM
10A HTR
3 DP
21 DA
3 DD
6 DH
5 DH
4 DD
6 DK
10 DK
30A PWR SEAT
7.5A RR FOG
9 DB
10 DD
3 DA
25 DA
14 DL
3 DJ
10 DA
1 DL
30 DA
31 DA
2 DM
2 DJ
3 DK
15 DA
20A S/ROOF
15A STOP
15A P/POINT
15A FR FOG
7.5A OBD2
25A DOOR
1 DG
22 DA
19 DA
24 DA
7 DA
10 DC
32 DA
2 DL
5 DC
1 DB
7 DB
10A GAUGE1
2 DA
1 DM
11 DK
7.5A GAUGE2
5 DK
27 DA
25A WIP
17 DL
18 DL
4 DA
26 DA
18 DA
9 DM
10A IGN
5 DD
16 DL
2 DH
(Cont. Next Page)
20
AVENSIS (EWD625E)
http://vnx.su
(Cont'd)
7.5A ECU-IG
18 DB
3 DL
7 DC
4 DL
10 DL
17 DM
11 DL
6 DB
20A RR WIP
7 DD
5 DL
1 DP
6 DL
4 DF
11 DM
2 DF
15 DB
3 DF
34 DA
2 DP
14 DB
2 DD
HTR Relay
12 DA
8 DC
6 DD
4 DH
11 DA
15A CIG
11 DB
9 DD
7.5A RAD NO.1
3 DH
4 DB
17 DA
1 DC
25
9 DJ
6 DJ
22
IG
E
15 INTB (w/o Double Locking)
ACTR (w/ Double Locking)
14 TOUT (w/o Double Locking)
ACTS (w/ Double Locking)
1
B
3 DM
9 DC
PCTY
B
6
4
2 DB
16 DB
1 DA
7 DK
21 12 13
ACC T TRLY
23
13 DL
12 DL
LP
8 DK
LACT
12 DM
9 DK
13 DM
10 DM
20 DA
14 DM
Integration Relay
15 DM
1 DK
2 DK
LSWP
H
16
RCTY
DCTY
7
18
17
6 DM
KSW
3
P/W
ACT-
1 DJ
L1
7 DM
20 DB
28 DA
13 DB
8 DA
4 DJ
10 DB
8 DB
UL1
2
SNOW
ACT+
19
20
11
10
8
6 DA
5 DA
29 DA
13 DA
14 DA
21
AVENSIS (EWD625E)
http://vnx.su
D RELAY LOCATIONS
: Center J/B
1 2
3 4 5
6 7 8 9 10 1112 13
Instrument Panel Reinforcement RH (See Page 9)
CF
5 4 3
2 1
13121110 9 8 7 6
5 4 3 2 1
10 9 8 7 6
1 2 3 4 5 6
7 8 9 10 1112
CB
CD
1 2 3 4 5
6 7 8 9 10
6 5 4 3 2 1
12 1110 9 8 7
5 4
3 2 1
13121110 9 8 7 6
CA
1 2 3
4 5
6 7 8 9 10111213
1 2
3
4 5 6 7 8 9
CC
3
2 1
9 8765 4
4 3
2 1
1110 9 8 7 6 5
CE
1 2
3 4
5 6 7 8 9 1011
22
AVENSIS (EWD625E)
http://vnx.su
5 4
3 2 1
1312 1110 9 8 7 6
CK
1 2 3
4 5
6 7 8 9 10111213
1 2 3 4 5 6
7 8 9 10 1112
CJ
6 5 4 3 2 1
12 1110 9 8 7
3
2 1
9 8765 4
CG

CH
1 2 3 4 5
6 7 8 9 10
1 2
3
4 5 6 7 8 9
5 4 3 2 1
10 9 8 7 6
4 3
2 1
1110 9 8 7 6 5
CI
1 2
3 4
5 6 7 8 9 10 11
23
AVENSIS (EWD625E)
http://vnx.su
D RELAY LOCATIONS
[Center J/B Inner Circuit]
7 CA
6 CA
6 CD
3 CB
7 CD
5 CD
8 CE
8 CD
2 CF
9 CD
3 CF
10 CE
4 CF
11 CE
5 CF
10 CF
1 CG
11 CF
2 CG
12 CF
4 CH
13 CF
1 CK
3 CG
8 CB
4 CG
9 CB
5 CG
10 CB
6 CG
4 CE
9 CG
13 CA
3 CH
3 CE
8 CH
6 CH
9 CH
9 CI
10 CH
10 CI
2 CI
11 CI
5 CI
1 CA
6 CI
5 CE
4 CJ
7 CG
5 CJ
4 CK
6 CJ
1 CB
10 CJ
2 CE
11 CJ
6 CE
6 CK
9 CJ
7 CK
12 CK
(Cont. Next Page)
24
AVENSIS (EWD625E)
http://vnx.su
(Cont'd)
8 CA
2 CA
6 CC
1 CE
1 CD
5 CH
9 CE
12 CJ
5 CK
3 CK
5 CA
10 CC
11 CA
3 CD
12 CA
7 CF
4 CD
8 CF
1 CF
9 CF
8 CG
7 CI
1 CH
4 CA
2 CH
7 CC
7 CH
7 CJ
3 CI
4 CC
4 CI
5 CC
8 CI
10 CK
1 CJ
2 CB
2 CJ
8 CC
3 CJ
11 CK
8 CJ
6 CB
8 CK
12 CB
9 CK
2 CK
10 CA
1 CC
5 CB
2 CC
2 CD
13 CK
6 CF
1 CI
25
AVENSIS (EWD625E)
http://vnx.su
http://vnx.su
H3
A11
C3
A3
A12
H12
C1
A1
H8
H11
B3
A2
F13
E1
F12
A9
F3
F1
* 1:w/ HID
* 2:w/o HID
F2
F10
F9
F11
H6
(*2)
-1-
(*2)
(*1)
(A/T)
F4
A7
H2
H4
A8
(M/T)
(*1)
H10
A10
C6
A5
F6
C2
Position of Parts in Engine Compartment <LHD 1AZ-FE>
F8
F7
H5
H1
E2
C5
B1
A4
A6
F5
A
A
A
A
A
A
A
A
A
A
A
A
A
1
2
3
4
5
6
7
8
9
10
11
12
12

A/C Pressure Sensor
Air Flow Meter
Alternator
Alternator (1CD-FTV)
Alternator (Except 1CD-FTV)
B
B
1 Back-Up Light SW
3 Brake Fluid Level Warning SW
C
C
C
C
C
C
C
C
1
2
3
3
5
6
6
6

Compressor Assembly (2AD-FHV, 2AD-FTV)
Compressor Assembly (Except 2AD-FHV, 2AD-FTV)
Crankshaft Position Sensor (2AD-FHV, 2AD-FTV)
Crankshaft Position Sensor (2AZ-FSE, 1AZ-FSE, 1AZ-FE, 1ZZ-FE, 3ZZ-FE)
Crankshaft Position Sensor (1CD-FTV)
E
E
E
E
E
E
1
1
2
2
2
2
ECT Solenoid (2AZ-FSE)

ECT Solenoid (Except 2AZ-FSE)
EFI Water Temp. Sensor (2AD-FHV, 2AD-FTV)
EFI Water Temp. Sensor (1CD-FTV)
EFI Water Temp. Sensor (2AZ-FSE, 1AZ-FSE, 1ZZ-FE, 3ZZ-FE)
EFI Water Temp. Sensor (1AZ-FE)
F
F
F
F
F
F
F
F
F
F
F
F
F
1
2
3
4
5
6
7
8
9
10
11
12
13

Front Fog Light LH
Front Fog Light RH
Front Turn Signal Light LH , Headlight Control ECU LH
Front Turn Signal Light LH , Headlight LH (Low)
Front Turn Signal Light RH , Headlight Control ECU RH
Front Turn Signal Light RH , Headlight RH (Low)
Front Washer Motor
Front Window Deicer
Front Wiper Motor
H 1 Headlight Beam Level Control Actuator LH

H 2 Headlight Beam Level Control Actuator RH
H 3 Headlight Cleaner Control Relay
H 4 Headlight Cleaner Motor
H 5 Headlight LH (High)
H 6 Headlight RH (High)
H 8 Heated Oxygen Sensor (Bank 1 Sensor 2)
H 11 Horn LH
H 12 Horn RH
-2-
http://vnx.su
A 1
A 2
A 3
Gray
Black
Black
1 2
1
1
A 4
A 5
A 6
A 7
A 8
A 9
A 10
Black
Gray
Gray
Yellow
Yellow
3 4
A 11
A 12
A 12
B 1
B 3
Black
(1CD-FTV)
(Except 1CD-FTV)
Gray
Black
1
1
1
1
C 1
C 2
C 3
C 3
C 5
Black
Black
Black (2AD-FHV, 2AD-FTV)
Gray (Except 2AD-FHV, 2AD-FTV)
Black
1 2
2
1
C 6
C 6
Gray (2AD-FHV, 2AD-FTV)
C 6
Gray (2AZ-FSE, 1AZ-FSE, 1AZ-FE, 1ZZ-FE, 3ZZ-FE)
Black (1CD-FTV)
1 2
E 1
E 1
E 2
E 2
Gray (2AZ-FSE)
Gray (Except 2AZ-FSE)
Gray (1CD-FTV)
1 2
1
7
2
8
3
4 5 6
9 10 11 12 13
E 2
Gray (2AZ-FSE, 1AZ-FSE, 1ZZ-FE, 3ZZ-FE)
1 2
10
1
2
E 2
F 1
F 2
F 3
Gray (1AZ-FE)
Black
Black
Brown
1 2
1
1
-3-
http://vnx.su
F 4
F 5
F 6
Brown
Gray
Gray
F 10
F 8
2
4
1
3
1
3
F 9
2
4
1
3
F 11
F 12
F 13
H 1
Black
Black
Gray
Gray
2
2
4
1
3
F 7
1
1
2
4
H 2
H 3
H 4
Gray
Black
Black
2
3
H 5
H 6
1
1
2
3
H 8
H 10
H 11
H 12
Black
Black
Black
Black
-4-
http://vnx.su
1
3
2
4
http://vnx.su
R3
S2
P2
I1
I2
I5
I3
I6
K1
I7
-1-
I4
I8
R1
I10
N1
T2
T4
V3
S4
S5
O2
J1
J2
N2
V5
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
1
2
3
4
5
5
5
5
6
6
6
6
7
7
7
7
8
8
8
8
10

Injector No.1 (2AD-FTV)
Injector No.1 (2AD-FHV)
Injector No.1 (1AZ-FE, 1ZZ-FE, 3ZZ-FE, 1CD-FTV)
Injector No.1 (2AZ-FSE, 1AZ-FSE)
ISC Valve
J
J
1 Junction Connector
1 Knock Sensor (Bank 1)
N
N
1 Neutral Start SW
2 Noise Filter (Ignition)
2 Oil Pressure SW
2 Power Steering Oil Pressure SW
R
R
1 Radiator Fan Motor

3 Rear Washer Motor
S
S
S
S
S
S
2
4
5
5
5
5
T
T
2 Throttle Position Sensor

4 Turbine Speed Sensor
V
V
3 Variable Resistor
5 VSV (EVAP)

Starter
Starter (2AD-FHV, 2AD-FTV)
Starter (2AZ-FSE, 1AZ-FSE, 1AZ-FE)
Starter (1ZZ-FE, 3ZZ-FE)
Starter (1CD-FTV)
-2-
http://vnx.su
I 1
I 2
I 3
I 4
I 5
Black
Gray
Black
Gray
Black (2AD-FTV)
I 5
I 5
Black (2AD-FHV)
Black (1AZ-FE, 1ZZ-FE, 3ZZ-FE, 1CD-FTV)
1
1
I 6
Gray (2AD-FTV)
I 6
Gray (1AZ-FE, 1ZZ-FE, 3ZZ-FE, 1CD-FTV)
1
1
I 6
I 7
Black (2AD-FTV)
I 7
I 8
Black (2AZ-FSE, 1AZ-FSE)
Gray (2AD-FTV)
1
1
I 8
I 8
Gray (2AD-FHV)
1
1
I 8
I 10
Gray (2AZ-FSE, 1AZ-FSE)
Black
2
1
J 1
J 2
K 1
N 1
Black
Black
Gray
1 2 3
4 5
6 7 8 9 10 11 12
1 2 3
4 5
6 7 8 9 10 11 12
1
6
3
7
N 2
O 2
P 2
R 1
R 3
Gray
Gray
Black
Gray
Red
1
2
Gray
I 7
1
1
I 7
Black (2AD-FHV)
I 5
I 6
Gray (2AD-FHV)
1
1
-3-
http://vnx.su
S 2
S 4
S 5
Black
Black
(2AD-FHV, 2AD-FTV)
1
1
6 7 8 9 10 11 12 13 14 15
16 17 18 19 20 21 22 23 24 25 26
S 5
(2AZ-FSE, 1AZ-FSE, 1AZ-FE)
S 5
S 5
T 2
T 4
(1ZZ-FE, 3ZZ-FE)
(1CD-FTV)
Black
Black
1
1 2 3
1
V 3
V 5
Black
Blue
2
3
-4-
http://vnx.su
http://vnx.su
EA
EB
EF
Engine Wire
EE
-1-
Engine No.2 Wire
Engine Room
Main Wire
Wire and Wire , Ground Points in Engine Compartment <LHD 1AZ-FE>
EC
ED
EA1
Wire and Wire , Ground Points in Engine Compartment <LHD 1AZ-FE>
EA1
Gray
-2-
http://vnx.su
http://vnx.su
F2
F10
F11
H6
A10
A11
C6
A5
F6
C3
H12
F13
A1
B3
-1-
E1
A12
H11
C1
A2
A3
Position of Parts in Engine Compartment <RHD 1AZ-FE>
A9
F1
F8
H5
E2
C5
A4
A6
F5
A
A
A
A
A
A
A
A
A
A
A
1
2
3
4
5
6
9
10
11
12
12

A/C Pressure Sensor
Air Flow Meter
Alternator
C
C
C
C
C
C
C
1
3
3
5
6
6
6

E
E
E
E
E
E
1
1
2
2
2
2


F 8 Front Turn Signal Light LH , Headlight LH (Low)
F 10 Front Turn Signal Light RH , Headlight RH (Low)
H 11 Horn LH
H 12 Horn RH
-2-
http://vnx.su
A 1
A 2
A 3
Gray
Black
Black
1 2
1
1
A 4
A 5
A 6
A 9
A 10
A 11
A 12
Black
Yellow
Yellow
Black
(1CD-FTV)
1
1
A 12
B 3
C 1
C 3
C 3
(Except 1CD-FTV)
Black
Black
1
1
1 2
C 5
C 6
Black
C 6
C 6
Black (1CD-FTV)
1 2
E 1
E 1
E 2
E 2
Gray (2AZ-FSE)
Gray (1CD-FTV)
1 2
1
7
2
8
3
4 5 6
9 10 11 12 13
E 2
1 2
10
1
2
E 2
F 1
F 2
F 5
Gray (1AZ-FE)
Black
Black
Gray
1 2
1
1
-3-
http://vnx.su
F 6
F 8
F 10
Gray
F 11
F 13
Black
Gray
H 5
1
1
H 6
1
2
2
4
1
3
1
3
H 11
H 12
Black
Black
2
4
2
4
-4-
http://vnx.su
3
5
http://vnx.su
S2
P2
I1
I2
I5
I3
I6
K1
I7
-1-
I4
I8
R1
I10
N1
V3
T4
T2
S4
S5
O2
J1
J2
N2
V5
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
1
2
3
4
5
5
5
5
6
6
6
6
7
7
7
7
8
8
8
8
10

ISC Valve
J
J
N
N
1 Neutral Start SW
2 Oil Pressure SW
S
S
S
S
S
S
2
4
5
5
5
5
T
T
2 Throttle Position Sensor

V
V
3 Variable Resistor
5 VSV (EVAP)

Starter
Starter (1CD-FTV)
-2-
http://vnx.su
I 1
I 2
I 3
I 4
I 5
Black
Gray
Black
Gray
Black (2AD-FTV)
I 5
I 5
Black (2AD-FHV)
1
1
I 6
Gray (2AD-FTV)
I 6
1
1
I 6
I 7
Black (2AD-FTV)
I 7
I 8
Gray (2AD-FTV)
1
1
I 8
I 8
Gray (2AD-FHV)
1
1
I 8
I 10
Black
2
1
J 1
J 2
K 1
N 1
Black
Black
Gray
1 2 3
4 5
6 7 8 9 10 11 12
1 2 3
4 5
6 7 8 9 10 11 12
1
6
N 2
O 2
P 2
R 1
Gray
Gray
Black
Gray
1
2
Gray
I 7
1
1
I 7
Black (2AD-FHV)
I 5
I 6
Gray (2AD-FHV)
1
1
-3-
http://vnx.su
3
7
4
8
5
9
S 2
S 4
S 5
Black
Black
(2AD-FHV, 2AD-FTV)
1
1
6 7 8 9 10 11 12 13 14 15
16 17 18 19 20 21 22 23 24 25 26
S 5
S 5
S 5
T 2
T 4
(1ZZ-FE, 3ZZ-FE)
(1CD-FTV)
Black
Black
1
1 2 3
1
V 3
V 5
Black
Blue
2
3
-4-
http://vnx.su
http://vnx.su
EA
EB
EF
Engine Room
Main Wire
Engine Wire
-1-
Engine No.2 Wire
EE
Wire and Wire , Ground Points in Engine Compartment <RHD 1AZ-FE>
EC
ED
EA1
Wire and Wire , Ground Points in Engine Compartment <RHD 1AZ-FE>
EA1
Gray
-2-
http://vnx.su
http://vnx.su
F4
A11
E7
C3
A12
A3
H7
H12
C1
A1
H8
H11
B3
A2
B2
E1
F13
F26
F12
F3
A9
F1
* 1:w/ HID
* 2:w/o HID
F2
F10
F9
F11
H6
(*2)
-1-
(*2)
(*1)
(A/T)
H3
F16
H2
H4
C2
(M/T)
(*1)
H9
A10
C6
A5
F6
H10
Position of Parts in Engine Compartment <LHD 2AZ-FSE, 1AZ-FSE>
F8
F7
H5
H1
E2
C5
B1
A4
A6
E4
E5
F5
A
A
A
A
A
A
A
A
A
A
A
1
2
3
4
5
6
9
10
11
12
12

A/C Pressure Sensor
Air Flow Meter
Alternator
B
B
B
1 Back-Up Light SW
2 Brake Booster Pressure Sensor
C
C
C
C
C
C
C
C
1
2
3
3
5
6
6
6

E
E
E
E
E
E
E
E
E
2
2
2
2
4
5
5
7
7

Electronic Driver Unit (1CD-FTV, 2AD-FTV)
Electronic Driver Unit (2AZ-FSE, 1AZ-FSE)
Engine Oil Level Sensor (2AZ-FSE)
Engine Oil Level Sensor (1CD-FTV, 2AD-FHV, 2AD-FTV)
F
F
F
F
F
F
F
F
F
F
F
F
F
F
F
F
1
2
3
4
5
6
7
8
9
10
11
12
13
16
16
26
H
H
H
H
H
H
H
1
2
3
4
5
6
7

Front Fog Light LH
Front Fog Light RH
Front Washer Motor
Front Window Deicer
Front Wiper Motor
Fuel Pressure Sensor (1CD-FTV, 2AD-FHV)
Fuel Pressure Sensor (2AZ-FSE, 1AZ-FSE)
Fuel Pump Resistor
Headlight LH (High)
Headlight RH (High)
Heated Oxygen Sensor (Bank 1 Sensor 1) (1ZZ-FE, 3ZZ-FE)
-2-
http://vnx.su
H 7 Heated Oxygen Sensor (Bank 1 Sensor 1) (2AZ-FSE, 1AZ-FSE)

H 11 Horn LH
H 12 Horn RH
-3-
http://vnx.su
A 1
A 2
A 3
Gray
Black
Black
1 2
1
1
A 4
A 5
A 6
A 9
A 10
A 11
A 12
Black
Yellow
Yellow
Black
(1CD-FTV)
1
1
A 12
B 1
B 2
B 3
C 1
(Except 1CD-FTV)
Gray
Black
Black
Black
1
1
1
1 2
C 2
C 3
C 3
C 5
Black
Black
2
1
C 6
C 6
C 6
E 2
Black (1CD-FTV)
1 2
E 2
E 2
Gray (1CD-FTV)
1 2
E 2
E 4
Black
1 2
E 5
E 5
E 7
Gray (2AZ-FSE)
1
3
1 2
Dark Gray (1CD-FTV, 2AD-FTV)
Gray (1AZ-FE)
1 2
-4-
http://vnx.su
E 7
Gray (1CD-FTV, 2AD-FHV, 2AD-FTV)
F 1
F 2
F 3
F 4
F 5
Black
Black
Brown
Brown
Gray
F 6
F 7
F 8
F 9
F 10
F 11
Gray
Black
1
3
2
4
1
3
2
4
1
3
2
4
1
3
2
4
F 12
F 13
F 16
F 16
F 26
Black
Gray
Black (1CD-FTV, 2AD-FHV)
Dark Gray
1
1
2
4
3
5
1 2
1 2
3
H 1
H 2
H 3
H 4
Gray
Gray
Black
Black
H 5
1
1
2
3
H 6
H 7
H 7
H 8
H 9
Gray (1ZZ-FE, 3ZZ-FE)
Black
Gray
1
2
3 4
3 4
H 10
H 11
H 12
Black
Black
Black
-5-
http://vnx.su
http://vnx.su
R3
S1
O1
P2
V6
I1
V1
I2
I5
I3
I6
K1
I7
-1-
I4
I8
R1
S3
N1
T1
T4
V5
R21
S4
S5
O2
J1
J2
N2
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
1
2
3
4
5
5
5
5
6
6
6
6
7
7
7
7
8
8
8
8

J
J
N
N
1 Neutral Start SW
O
O
1 Oil Pressure Sensor

2 Oil Pressure SW

R 21 Radiator Fan Relay
S
S
S
S
S
S
S
1
3
4
5
5
5
5

Spill Valve
Starter
Starter (1CD-FTV)
T
T
1 Throttle Control Motor and Position Sensor

V
V
V
1 Vacuum Sensor
5 VSV (EVAP)
6 VSV (Intake Air Control Valve)
-2-
http://vnx.su
I 1
I 2
I 3
I 4
I 5
Black
Gray
Black
Gray
Black (2AD-FTV)
I 5
I 5
Black (2AD-FHV)
1
1
I 6
Gray (2AD-FTV)
I 6
1
1
I 6
I 7
Black (2AD-FTV)
I 7
I 7
I 8
Gray (2AD-FTV)
1
1
I 8
I 8
Gray (2AD-FHV)
1
1
I 8
J 1
Gray
1 2 3
4 5
6 7 8 9 10 11 12
2
1
J 2
K 1
N 1
N 2
Black
Black
Gray
Gray
1 2 3
4 5
6 7 8 9 10 11 12
2
1
1
6
3
7
4
8
5
9
O 1
O 2
P 2
R 1
R 3
Black
Gray
Black
Gray
Red
2
1
I 7
Black (2AD-FHV)
I 5
I 6
Gray (2AD-FHV)
1
1
-3-
http://vnx.su
R 21
S 1
S 3
Black
Black
Gray
10
11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26
27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42
S 4
S 5
Black
(2AD-FHV, 2AD-FTV)
S 5
S 5
S 5
(1ZZ-FE, 3ZZ-FE)
(1CD-FTV)
T 1
T 4
V 1
V 5
V 6
Black
Black
Black
Blue
Brown
-4-
http://vnx.su
http://vnx.su
EA
EB
EF
Engine Wire
EE
-1-
Engine No.2 Wire
Engine Room
Main Wire
Wire and Wire , Ground Points in Engine Compartment <LHD 2AZ-FSE, 1AZ-FSE>
EC
ED
EA1
Wire and Wire , Ground Points in Engine Compartment <LHD 2AZ-FSE, 1AZ-FSE>
EA1
Gray
-2-
http://vnx.su
http://vnx.su
H3
E7
C3
A12
H12
H10
E6
F16
A1
H9
H11
C1
A2
H7
A3
H8
E1
F26
F3
A9
F1
* 1:w/ HID
* 2:w/o HID
F2
F10
F9
F11
H6
(*2)
-1-
(*2)
(*1)
(A/T)
F4
C2
H2
H4
B2
(M/T)
(*1)
F13
A10
A11
C6
A5
F6
B3
Position of Parts in Engine Compartment <RHD 2AZ-FSE, 1AZ-FSE>
F8
F7
H5
H1
E2
C5
B1
A4
A6
E4
E5
F5
A
A
A
A
A
A
A
A
A
A
A
1
2
3
4
5
6
9
10
11
12
12

A/C Pressure Sensor
Air Flow Meter
Alternator
B
B
B
1 Back-Up Light SW
2 Brake Booster Pressure Sensor
C
C
C
C
C
C
C
C
1
2
3
3
5
6
6
6

E
E
E
E
E
E
E
E
E
E
E
E
1
1
2
2
2
2
4
5
5
6
7
7

F
F
F
F
F
F
F
F
F
F
F
F
F
F
F
1
2
3
4
5
6
7
8
9
10
11
13
16
16
26
H
H
H
H
H
1
2
3
4
5

Front Fog Light LH
Front Fog Light RH
Front Washer Motor
Front Wiper Motor
Fuel Pump Resistor
Headlight LH (High)
-2-
http://vnx.su
H 7 Heated Oxygen Sensor (Bank 1 Sensor 1) (1ZZ-FE, 3ZZ-FE)
H 11 Horn LH
H 12 Horn RH
-3-
http://vnx.su
A 1
A 2
A 3
Gray
Black
Black
1 2
1
1
A 4
A 5
A 6
A 9
A 10
A 11
A 12
Black
Yellow
Yellow
Black
(1CD-FTV)
1
1
A 12
B 1
B 2
B 3
C 1
(Except 1CD-FTV)
Gray
Black
Black
Black
1
1
1
1 2
C 2
C 3
C 3
C 5
Black
Black
2
1
C 6
C 6
C 6
Black (1CD-FTV)
1 2
E 1
E 1
E 2
E 2
Gray (2AZ-FSE)
Gray (1CD-FTV)
1 2
1
7
2
8
3
4 5 6
9 10 11 12 13
E 2
1 2
10
1
2
E 2
E 4
Gray (1AZ-FE)
Black
1 2
1
-4-
http://vnx.su
E 5
E 5
E 6
E 7
Black
Gray (2AZ-FSE)
1
1
E 7
1
2
3
1 2
F 1
F 2
F 3
F 4
Black
Black
Brown
Brown
2
1
F 5
F 6
Gray
Gray
F 7
1
3
F 8
2
4
1
3
F 9
2
4
1
3
F 10
2
4
1
3
F 11
F 13
F 16
F 16
F 26
Black
Gray
Dark Gray
2
4
3
5
1 2
1 2
3
H 1
H 2
H 3
H 4
Gray
Gray
Black
Black
H 5
1
1
2
3
H 6
H 7
H 7
H 8
H 9
Black
Gray
1
2
3 4
3 4
H 10
H 11
H 12
Black
Black
Black
-5-
http://vnx.su
2
4
http://vnx.su
R3
S1
O1
P2
V6
I1
V1
I2
I5
I3
I6
K1
I7
-1-
I4
I8
R1
S3
N1
T1
T4
V5
R21
S4
S5
O2
J1
J2
N2
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
1
2
3
4
5
5
5
5
6
6
6
6
7
7
7
7
8
8
8
8

J
J
N
N
1 Neutral Start SW
O
O

2 Oil Pressure SW

R 21 Radiator Fan Relay
S
S
S
S
S
S
S
1
3
4
5
5
5
5

Spill Valve
Starter
Starter (1CD-FTV)
T
T

V
V
V
1 Vacuum Sensor
5 VSV (EVAP)
6 VSV (Intake Air Control Valve)
-2-
http://vnx.su
I 1
I 2
I 3
I 4
I 5
Black
Gray
Black
Gray
Black (2AD-FTV)
I 5
I 5
Black (2AD-FHV)
1
1
I 6
Gray (2AD-FTV)
I 6
1
1
I 6
I 7
Black (2AD-FTV)
I 7
I 7
I 8
Gray (2AD-FTV)
1
1
I 8
I 8
Gray (2AD-FHV)
1
1
I 8
J 1
Gray
1 2 3
4 5
6 7 8 9 10 11 12
2
1
J 2
K 1
N 1
N 2
Black
Black
Gray
Gray
1 2 3
4 5
6 7 8 9 10 11 12
2
1
1
6
3
7
4
8
5
9
O 1
O 2
P 2
R 1
R 3
Black
Gray
Black
Gray
Red
2
1
I 7
Black (2AD-FHV)
I 5
I 6
Gray (2AD-FHV)
1
1
-3-
http://vnx.su
R 21
S 1
S 3
Black
Black
Gray
10
11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26
27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42
S 4
S 5
Black
(2AD-FHV, 2AD-FTV)
S 5
S 5
S 5
(1ZZ-FE, 3ZZ-FE)
(1CD-FTV)
T 1
T 4
V 1
V 5
V 6
Black
Black
Black
Blue
Brown
-4-
http://vnx.su
http://vnx.su
EA
EB
EF
Engine Room
Main Wire
Engine Wire
-1-
Engine No.2 Wire
EE
Wire and Wire , Ground Points in Engine Compartment <RHD 2AZ-FSE, 1AZ-FSE>
EC
ED
EA1
Wire and Wire , Ground Points in Engine Compartment <RHD 2AZ-FSE, 1AZ-FSE>
EA1
Gray
-2-
http://vnx.su
http://vnx.su
F4
H3
C3
C4
F16
H12
E2
A1
E3
A1
F17
H11
B3
A2
F14
D1
F13
A9
F12
F2
F10
F9
(*2)
A3
(*4)
A3
F3
F1
(*3)
-1-
(*3)
(*4)
F8
F7
H5
H1
B1
A4
A6
G2
F15
F5
* 1:w/ HID
* 2:w/o HID
* 3:Power Heater
(Hot Gas Type)
* 4:Power Heater
(Combustion Type)
(*2)
A11
F11
H4
G1
(*1)
(*1)
A12
H6
H2
A10
E7
C6
F18
E4
A5
E5
F6
C1
Position of Parts in Engine Compartment <LHD 1CD-FTV>
A
A
A
A
A
A
A
A
A
A
A
1
2
3
4
5
6
9
10
11
12
12

A/C Pressure Sensor
Air Flow Meter
Alternator
B
B
1 Back-Up Light SW
C
C
C
C
C
C
C
1
3
3
4
6
6
6

Condenser Assembly
E
E
E
E
E
E
E
E
E
E
2
2
2
2
3
4
5
5
7
7

F
F
F
F
F
F
F
F
F
F
F
F
F
F
F
F
F
F
F
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
16
17
18

Front Fog Light LH
Front Fog Light RH
Front Washer Motor
Front Window Deicer
Front Wiper Motor
Fuel Heater
Fuel Pump
Fuel Temp. Sensor
G
G
1 Glow Plug
2 Glow Plug Relay
H
H
1 Headlight Beam Level Control Actuator LH

2 Headlight Beam Level Control Actuator RH
-2-
http://vnx.su

H 11 Horn LH
H 12 Horn RH
-3-
http://vnx.su
A 1
A 2
A 3
Gray
Black
Black
1 2
1
1
A 4
A 5
A 6
A 9
A 10
A 11
A 12
Black
Yellow
Yellow
Black
(1CD-FTV)
1
1
A 12
B 1
B 3
C 1
C 3
(Except 1CD-FTV)
Gray
Black
Black
1
1
1
C 3
C 4
C 6
C 6
1
1
1 2
1 2
2
3
C 6
E 2
E 2
Black (1CD-FTV)
Gray (1CD-FTV)
E 2
1 2
1 2
1
1
E 2
E 3
E 4
E 5
Gray (1AZ-FE)
Black
Black
1 2
1
E 5
E 7
Gray (2AZ-FSE)
1 2
E 7
F 1
Black
2
1
-4-
http://vnx.su
F 2
F 3
F 4
F 5
F 6
Black
Brown
Brown
Gray
Gray
F 9
F 10
F 11
F 12
F 13
Black
Black
Gray
2
2
4
1
3
2
4
1
3
2
4
1
1
F 14
F 15
F 16
F 16
F 17
Gray
Black
1
1
F 18
G 1
Gray
2
4
Gray
2
4
1
3
F 8
1
3
F 7
3
5
1 2
3
G 2
H 1
H 2
Gray
Gray
Gray
1 2
1
3
H 3
H 4
Black
Black
H 5
H 6
1
1
1
3
-5-
http://vnx.su
2
3
H 11
H 12
Black
Black
http://vnx.su
R3
W1
S1
O1
S2
(*5)
(*6)
S6
S4
O2
I5
S5
I6
-1-
P3
I7
R1
I8
T3
V2
V4
* 5:w/ VSC
* 6:w/o VSC
I9
T5
J1
J2
P1
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
5
5
5
5
6
6
6
6
7
7
7
7
8
8
8
8
9

J
J
O
O

2 Oil Pressure SW
P
P
1 Power Heater Assembly

3 Pressure Discharge Valve
R
R

3 Rear Washer Motor
S
S
S
S
S
S
S
S
1
2
4
5
5
5
5
6
5 Turbo Pressure Sensor
V
V
V
2 Vacuum SW
4 VRV (EGR) (2AD-FHV, 2AD-FTV)
4 VRV (EGR) (1CD-FTV)

Starter
Starter (1CD-FTV)
-2-
http://vnx.su
I 5
I 5
Black (2AD-FTV)
Black (2AD-FHV)
I 5
1
1
I 6
I 6
Gray (2AD-FHV)
I 6
2
1
I 7
I 7
Black (2AD-FTV)
Black (2AD-FHV)
I 7
2
1
I 8
I 8
Gray (2AD-FTV)
Gray (2AD-FHV)
I 8
I 8
2
1
I 7
2
1
I 6
1
1
2
1
Gray (2AD-FTV)
I 5
2
1
I 9
J 1
J 2
O 1
O 2
Gray
Gray
Black
Black
Gray
1 2 3
4 5
6 7 8 9 10 11 12
1 2 3
4 5
6 7 8 9 10 11 12
2
1
P 1
P 3
R 1
R 3
Black
Gray
Gray
Red
1 2
1
1
-3-
http://vnx.su
S 1
Black
10
11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26
27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42
S 2
S 4
S 5
Black
Black
(2AD-FHV, 2AD-FTV)
1
1
6 7 8 9 10 11 12 13 14 15
16 17 18 19 20 21 22 23 24 25 26
S 5
S 5
S 5
S 6
T 5
(1ZZ-FE, 3ZZ-FE)
(1CD-FTV)
Gray
Black
1 2
1
V 2
V 4
V 4
Black
Black (1CD-FTV)
W 1
-4-
http://vnx.su
http://vnx.su
EA
EB
Engine Wire
Engine No.6 Wire
EB1
-1-
EA1
Engine Room
Main Wire
EI
Engine No.4
Wire
EC1
Engine No.5 Wire
Wire and Wire , Ground Points in Engine Compartment <LHD 1CD-FTV>
EC
EE1
ED1
ED
Wire and Wire , Ground Points in Engine Compartment <LHD 1CD-FTV>
EA1
EB1
EC1
Gray
Gray
Gray
2
1
1
1
ED1
EE1
Black
1
1
9 10
10 9
-2-
http://vnx.su
http://vnx.su
F4
H3
C4
A3
C3
A11
H12
F18
E6
F16
A1
E2
H11
E3
A2
F15
D1
F14
F2
F10
F9
F3
A9
* 1:w/ HID
* 2:w/o HID
(*2)
-1-
(*2)
A10
G1
F11
H4
B3
(*1)
(*1)
F13
H6
H2
E7
C6
E4
A5
E5
A12
F6
C1
Position of Parts in Engine Compartment <RHD 1CD-FTV>
F1
F8
F7
H5
H1
B1
A4
A6
G2
F5
A
A
A
A
A
A
A
A
A
A
A
1
2
3
4
5
6
9
10
11
12
12

A/C Pressure Sensor
Air Flow Meter
Alternator
B
B
1 Back-Up Light SW
C
C
C
C
C
1
4
6
6
6
1 Diesel Throttle Control Motor
E
E
E
E
E
E
E
E
E
E
E
2
2
2
2
3
4
5
5
6
7
7
F
F
F
F
F
F
F
F
F
F
F
F
F
F
F
F
F
1
2
3
4
5
6
7
8
9
10
11
13
14
15
16
16
18

Condenser Assembly

Front Fog Light LH
Front Fog Light RH
Front Washer Motor
Front Wiper Motor
Fuel Heater
Fuel Temp. Sensor
G
G
1 Glow Plug
2 Glow Plug Relay
H
H
H

3 Headlight Cleaner Control Relay
-2-
http://vnx.su

H 11 Horn LH
H 12 Horn RH
-3-
http://vnx.su
A 1
A 2
A 3
Gray
Black
Black
1 2
1
1
A 4
A 5
A 6
A 9
A 10
A 11
A 12
Black
Yellow
Yellow
Black
(1CD-FTV)
1
1
A 12
B 1
B 3
C 1
(Except 1CD-FTV)
Gray
Black
Black
C 4
1
1
1
1 2
C 6
C 6
C 6
D 1
Black (1CD-FTV)
Black
1 2
E 2
E 2
Gray (1CD-FTV)
E 2
1 2
E 2
E 3
Gray (1AZ-FE)
Black
1 2
1 2
1
2
E 7
Gray (2AZ-FSE)
1 2
E 4
E 5
E 5
E 6
Black
Black
1
1
E 7
1
2
3
F 1
F 2
F 3
Black
Black
Brown
2
1
-4-
http://vnx.su
F 4
F 5
F 6
Brown
Gray
Gray
F 10
2
4
1
3
F 7
1
3
F 8
2
4
1
3
F 13
F 14
F 15
Gray
Gray
Gray
1
1
F 16
F 16
F 18
Gray
G 1
G 2
Gray
1 2
3
1
3
F 11
2
4
Black
F 9
1 2
3
H 1
H 2
H 3
H 4
Gray
Gray
Black
Black
H 5
1
1
H 6
1
2
H 11
H 12
Black
Black
-5-
http://vnx.su
2
4
http://vnx.su
R3
W1
S1
O1
S2
(*3)
(*4)
S6
S4
O2
I5
-1-
S5
I6
P3
I7
R1
V2
T3
I8
V4
* 3:w/ VSC
* 4:w/o VSC
I9
T5
J1
J2
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
5
5
5
5
6
6
6
6
7
7
7
7
8
8
8
8
9

J
J
O
O

2 Oil Pressure SW
3 Pressure Discharge Valve
R
R

3 Rear Washer Motor
S
S
S
S
S
S
S
S
1
2
4
5
5
5
5
6
T
T
3 Throttle Position SW
V
V
V
2 Vacuum SW

Starter
Starter (1CD-FTV)
-2-
http://vnx.su
I 5
I 5
Black (2AD-FTV)
Black (2AD-FHV)
I 5
1
1
I 6
I 6
Gray (2AD-FHV)
I 6
2
1
I 7
I 7
Black (2AD-FTV)
Black (2AD-FHV)
I 7
2
1
I 8
I 8
Gray (2AD-FTV)
Gray (2AD-FHV)
I 8
I 8
2
1
I 7
2
1
I 6
1
1
2
1
Gray (2AD-FTV)
I 5
2
1
I 9
J 1
J 2
O 1
O 2
Gray
Gray
Black
Black
Gray
1 2 3
4 5
6 7 8 9 10 11 12
1 2 3
4 5
6 7 8 9 10 11 12
2
1
P 3
R 1
R 3
Gray
Gray
Red
1 2
1
1
-3-
http://vnx.su
S 1
Black
10
11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26
27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42
S 2
S 4
S 5
Black
Black
(2AD-FHV, 2AD-FTV)
1
1
6 7 8 9 10 11 12 13 14 15
16 17 18 19 20 21 22 23 24 25 26
S 5
S 5
S 5
S 6
T 3
(1ZZ-FE, 3ZZ-FE)
(1CD-FTV)
Gray
Gray
1 2
1
T 5
V 2
V 4
V 4
Black
Black
Black (1CD-FTV)
-4-
http://vnx.su
W 1
http://vnx.su
EA
EB
Engine Wire
Engine No.6 Wire
EB1
EA1
-1-
Engine Room
Main Wire
EI
EC1
Engine No.4
Wire
Wire and Wire , Ground Points in Engine Compartment <RHD 1CD-FTV>
Engine No.5 Wire
ED1
EC
EE1
ED
Wire and Wire , Ground Points in Engine Compartment <RHD 1CD-FTV>
EA1
EB1
EC1
Gray
Gray
Gray
2
1
1
1
ED1
EE1
Black
1
1
9 10
10 9
-2-
http://vnx.su
http://vnx.su
H3
A10
D22
A3
E2
H12
E16
A1
F18
E7
B3
C3
F17
H11
F13
A2
F12
E18
B1
F3
A9
* 1:w/ HID
* 2:w/o HID
H6
F11
F10
(*2)
F9
(*1)
-1-
(*2)
F4
E20
H2
F2
E19
(*1)
H4
C1
F16
G1
A12
A11
E23
A5
E22
E21
F6
C6
Position of Parts in Engine Compartment <LHD 2AD-FHV>
F1
B12
F8
F7
H5
H1
B11
A4
A6
G2
F14
F5
A
A
A
A
A
A
A
A
A
A
A
1
2
3
4
5
6
9
10
11
12
12

A/C Pressure Sensor
Air Flow Meter
Alternator
B 1 Back-Up Light SW
B 11 Battery Current Sensor
B 12 Battery Thermometer Sensor
C
C
C
C
C
C
1
3
3
6
6
6

D 22 Differential Pressure Sensor

E
E
E
E
E
E
E
E
E
E
E
E
E
2
2
2
2
7
7
16
18
19
20
21
22
23

Exhaust Fuel Addition Injector Assembly
EGR Valve Position Sensor
Exhaust Gas Temperature Sensor (Front)
Exhaust Gas Temperature Sensor (Rear)
Electronic Driver Unit (2AD-FHV)
F
F
F
F
F
F
F
F
F
F
F
F
F
F
F
F
F
F
1
2
3
4
5
6
7
8
9
10
11
12
13
14
16
16
17
18

Front Fog Light LH
Front Fog Light RH
Front Washer Motor
Front Window Deicer
Front Wiper Motor
Fuel Pump
Fuel Temp. Sensor
-2-
http://vnx.su
G
G
1 Glow Plug
2 Glow Plug Relay

H 11 Horn LH
H 12 Horn RH
-3-
http://vnx.su
A 1
A 2
A 3
Gray
Black
Black
1 2
1
1
A 4
A 5
A 6
A 9
A 10
A 11
A 12
Black
Yellow
Yellow
Black
(1CD-FTV)
1
1
A 12
B 1
B 3
B 11
B 12
(Except 1CD-FTV)
Gray
Black
Black
Black
1
1
1
C 1
C 3
C 3
C 6
Black
1 2
2
3
C 6
C 6
D 22
E 2
Black (1CD-FTV)
Black
1 2
1
E 2
1 2
3
2
E 2
Gray (1CD-FTV)
E 2
E 7
Gray (1AZ-FE)
Gray (2AZ-FSE)
1 2
1 2
1 2
E 7
E 16
E 18
E 19
E 20
Black
Black
Gray
Dark Gray
1 2
1 2
-4-
http://vnx.su
E 21
E 22
E 23
F 1
F 2
Gray (2AD-FHV)
Black (2AD-FHV)
Black (2AD-FHV)
Black
Black
1 2 3 4 5 6
7 8 9 10 11 12
F 3
F 4
F 5
F 6
Brown
Brown
Gray
Gray
F 9
F 10
2
4
1
3
1
3
F 13
F 14
Gray
1
1
F 18
Gray
1 2
3
5
G 1
1 2
3
G 2
H 1
H 2
H 3
H 4
Gray
Gray
Gray
Black
Black
H 6
1
3
H 5
2
4
F 17
2
4
Gray
Black
1
3
F 12
F 16
2
4
Black
F 8
F 11
F 16
Black
F 7
2
2
4
1
3
2
3
H 11
H 12
Black
Black
-5-
http://vnx.su
http://vnx.su
R3
S1
O1
P26
T5
I5
I17
I18
V10
O2
V4
I9
I6
-1-
S4
I7
S5
I8
R1
S6
P3
P1
J1
J2
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
5
5
5
5
6
6
6
6
7
7
7
7
8
8
8
8
9
17
18

Intake Shutter Assembly
J
J
O
O

2 Oil Pressure SW

P 26 Power Steering Oil Pressure Sensor
R
R

3 Rear Washer Motor
S
S
S
S
S
S
S
1
4
5
5
5
5
6

Starter
Starter (1CD-FTV)
V 4 VRV (EGR) (2AD-FHV, 2AD-FTV)

V 4 VRV (EGR) (1CD-FTV)
V 10 VSV (EGR)
-2-
http://vnx.su
I 5
I 5
Black (2AD-FTV)
Black (2AD-FHV)
I 5
1
1
I 6
Gray (2AD-FHV)
I 6
1
1
2
1
I 7
I 7
Black (2AD-FTV)
Black (2AD-FHV)
I 7
2
1
I 8
I 8
Gray (2AD-FTV)
Gray (2AD-FHV)
I 8
I 8
2
1
I 7
2
1
I 6
2
1
I 6
Gray (2AD-FTV)
I 5
2
1
I 9
I 17
I 18
J 1
J 2
Gray
Black
Black
Gray
Black
1 2 3
1 2 3
4 5
6 7 8 9 10 11 12
1 2 3
4 5
6 7 8 9 10 11 12
O 1
O 2
P 1
P 3
P 26
Black
Gray
Black
Gray
Black
1 2
2
1
-3-
http://vnx.su
R 1
R 3
S 1
Gray
Red
Black
1
1
2
1
10
11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26
27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42
S 4
S 5
Black
(2AD-FHV, 2AD-FTV)
S 5
S 5
S 5
(1ZZ-FE, 3ZZ-FE)
(1CD-FTV)
S 6
T 5
V 4
V 4
V 10
Gray
Black
Black (1CD-FTV)
Black
1 2
1
2
1
-4-
http://vnx.su
http://vnx.su
EA
EB
Engine Wire
EZ
EY
-1-
Engine Room
Main Wire
Wire and Wire , Ground Points in Engine Compartment <LHD 2AD-FHV>
Engine No.2 Wire
EC
EE1
ED1
ED
Wire and Wire , Ground Points in Engine Compartment <LHD 2AD-FHV>
ED1
EE1
Black
1
1
9 10
10 9
-2-
http://vnx.su
http://vnx.su
H3
A10
C3
H12
E20
E6
E19
A1
C1
E7
E2
H11
E16
A3
F18
A2
E18
B1
F3
A9
* 1:w/ HID
* 2:w/o HID
H6
F10
(*2)
F9
(*1)
-1-
(*2)
F4
D22
F11
H4
B3
(*1)
F2
F13
H2
F16
G1
A12
A11
E23
A5
E22
E21
F6
C6
Position of Parts in Engine Compartment <RHD 2AD-FHV>
F1
F8
F7
H5
H1
B12
B11
A4
A6
G2
F14
F5
A
A
A
A
A
A
A
A
A
A
A
1
2
3
4
5
6
9
10
11
12
12

A/C Pressure Sensor
Air Flow Meter
Alternator
C
C
C
C
C
C
1
3
3
6
6
6


E
E
E
E
E
E
E
E
E
E
E
E
E
E
2
2
2
2
6
7
7
16
18
19
20
21
22
23

Exhaust Fuel Addition Injector Assembly
Exhaust Gas Temperature Sensor (Front)
Exhaust Gas Temperature Sensor (Rear)
F
F
F
F
F
F
F
F
F
F
F
F
F
F
F
F
1
2
3
4
5
6
7
8
9
10
11
13
14
16
16
18

Front Fog Light LH
Front Fog Light RH
Front Washer Motor
Front Wiper Motor
Fuel Temp. Sensor
1 Glow Plug
-2-
http://vnx.su
2 Glow Plug Relay

H 11 Horn LH
H 12 Horn RH
-3-
http://vnx.su
A 1
A 2
A 3
Gray
Black
Black
1 2
1
1
A 4
A 5
A 6
A 9
A 10
A 11
A 12
Black
Yellow
Yellow
Black
(1CD-FTV)
1
1
A 12
B 1
B 3
B 11
B 12
(Except 1CD-FTV)
Gray
Black
Black
Black
1
1
1
C 1
C 3
C 3
C 6
Black
1 2
2
3
C 6
C 6
D 22
E 2
Black (1CD-FTV)
Black
1 2
1
E 2
1 2
3
2
E 2
Gray (1CD-FTV)
E 2
E 6
E 7
Gray (1AZ-FE)
Black
Gray (2AZ-FSE)
1 2
1
2
3
1 2
1 2
E 7
E 16
E 18
E 19
E 20
Black
Black
Gray
Dark Gray
1 2
1 2
-4-
http://vnx.su
E 21
E 22
E 23
F 1
F 2
Gray (2AD-FHV)
Black (2AD-FHV)
Black (2AD-FHV)
Black
Black
1 2 3 4 5 6
7 8 9 10 11 12
F 3
F 4
F 5
F 6
Brown
Brown
Gray
Gray
F 9
F 10
2
4
1
3
1
3
2
4
F 7
1
3
F 14
Gray
2
4
F 16
F 18
Gray
G 1
G 2
Gray
1 2
4
1
3
F 13
2
4
Gray
1 2
3
H 1
H 2
H 3
H 4
Gray
Gray
Black
Black
H 5
1
1
H 6
1
2
H 11
H 12
Black
Black
-5-
http://vnx.su
F 8
F 11
F 16
Black
2
4
http://vnx.su
R3
S1
O1
T5
I5
P26
I17
I18
V10
O2
V4
I9
I6
-1-
S4
I7
S5
I8
R1
S6
P3
J1
J2
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
5
5
5
5
6
6
6
6
7
7
7
7
8
8
8
8
9
17
18

J
J
O
O

2 Oil Pressure SW

R
R

3 Rear Washer Motor
S
S
S
S
S
S
S
1
4
5
5
5
5
6

Starter
Starter (1CD-FTV)
V 4 VRV (EGR) (2AD-FHV, 2AD-FTV)

V 4 VRV (EGR) (1CD-FTV)
V 10 VSV (EGR)
-2-
http://vnx.su
I 5
I 5
Black (2AD-FTV)
Black (2AD-FHV)
I 5
1
1
I 6
Gray (2AD-FHV)
I 6
1
1
2
1
I 7
I 7
Black (2AD-FTV)
Black (2AD-FHV)
I 7
2
1
I 8
I 8
Gray (2AD-FTV)
Gray (2AD-FHV)
I 8
I 8
2
1
I 7
2
1
I 6
2
1
I 6
Gray (2AD-FTV)
I 5
2
1
I 9
I 17
I 18
J 1
J 2
Gray
Black
Black
Gray
Black
1 2 3
1 2 3
4 5
6 7 8 9 10 11 12
1 2 3
4 5
6 7 8 9 10 11 12
O 1
O 2
P 3
P 26
R 1
Black
Gray
Gray
Black
Gray
1 2
2
1
3
1
R 3
S 1
S 4
Red
Black
Black
2
1
10
11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26
27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42
-3-
http://vnx.su
S 5
S 5
(2AD-FHV, 2AD-FTV)
S 5
S 5
S 6
(1ZZ-FE, 3ZZ-FE)
(1CD-FTV)
Gray
T 5
V 4
V 4
V 10
Black
Black (1CD-FTV)
Black
2
1
-4-
http://vnx.su
1 2
http://vnx.su
EA
EB
Engine Wire
EZ
EY
-1-
Engine Room
Main Wire
Wire and Wire , Ground Points in Engine Compartment <RHD 2AD-FHV>
Engine No.2 Wire
EC
EE1
ED
ED1
Wire and Wire , Ground Points in Engine Compartment <RHD 2AD-FHV>
ED1
EE1
Black
1
1
9 10
10 9
-2-
http://vnx.su
http://vnx.su
H3
A10
A3
H12
A1
F18
E7
B3
C3
F17
H11
F13
A2
F12
E18
B1
F3
A9
* 1:w/ HID
* 2:w/o HID
H6
F11
F10
(*2)
F9
(*1)
-1-
(*2)
F4
E2
H2
F2
D22
(*1)
H4
C6
F28
G1
A12
A11
A5
E4
E5
F6
C1
Position of Parts in Engine Compartment <LHD 2AD-FTV>
F1
B12
F8
F7
H5
H1
B11
A4
A6
G2
F14
F5
A
A
A
A
A
A
A
A
A
A
A
1
2
3
4
5
6
9
10
11
12
12

A/C Pressure Sensor
Air Flow Meter
Alternator
C
C
C
C
C
C
1
3
3
6
6
6


E 2
E 2
E 2
E 2
E 4
E 5
E 5
E 7
E 7
E 18

F
F
F
F
F
F
F
F
F
F
F
F
F
F
F
F
F

Front Fog Light LH
Front Fog Light RH
Front Washer Motor
Front Window Deicer
Front Wiper Motor
Fuel Pump
Fuel Temp. Sensor
1
2
3
4
5
6
7
8
9
10
11
12
13
14
17
18
28
G
G
1 Glow Plug
2 Glow Plug Relay

-2-
http://vnx.su

H 11 Horn LH
H 12 Horn RH
-3-
http://vnx.su
A 1
A 2
A 3
Gray
Black
Black
1 2
1
1
A 4
A 5
A 6
A 9
A 10
A 11
A 12
Black
Yellow
Yellow
Black
(1CD-FTV)
1
1
A 12
B 1
B 3
B 11
B 12
(Except 1CD-FTV)
Gray
Black
Black
Black
1
1
1
C 1
C 3
C 3
C 6
Black
1 2
2
3
C 6
C 6
D 22
E 2
Black (1CD-FTV)
Black
1 2
1
E 2
1 2
3
2
E 2
Gray (1CD-FTV)
E 2
E 4
Gray (1AZ-FE)
Black
1 2
1 2
1
E 5
E 5
E 7
Gray (2AZ-FSE)
1
1
1 2
-4-
http://vnx.su
E 7
E 18
F 1
F 2
F 3
F 4
Black
Black
Black
Brown
Brown
F 5
F 6
Gray
Gray
F 7
F 8
2
4
1
3
1
3
F 9
2
4
1
3
F 10
2
4
1
3
F 11
F 12
F 13
F 14
F 17
F 18
Black
Black
Gray
Gray
Black
Gray
1 2
2
1
1
1
2
4
F 28
2
4
G 1
Black
G 2
H 1
H 2
Gray
Gray
Gray
1
1
H 3
H 4
Black
Black
H 5
H 6
1
1
1
3
-5-
http://vnx.su
2
3
H 11
H 12
Black
Black
http://vnx.su
R3
S1
O1
T5
I5
P26
I17
I18
O2
I9
V4
S4
I6
-1-
S5
I7
R1
I8
S6
P1
J1
J2
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
5
5
5
5
6
6
6
6
7
7
7
7
8
8
8
8
9
17
18

J
J
O
O

2 Oil Pressure SW

R
R

3 Rear Washer Motor
S
S
S
S
S
S
S
1
4
5
5
5
5
6
V
V


Starter
Starter (1CD-FTV)
-2-
http://vnx.su
I 5
I 5
Black (2AD-FTV)
Black (2AD-FHV)
I 5
1
1
I 6
Gray (2AD-FHV)
I 6
1
1
2
1
I 7
I 7
Black (2AD-FTV)
Black (2AD-FHV)
I 7
2
1
I 8
I 8
Gray (2AD-FTV)
Gray (2AD-FHV)
I 8
I 8
2
1
I 7
2
1
I 6
2
1
I 6
Gray (2AD-FTV)
I 5
2
1
I 9
I 17
I 18
J 1
J 2
Gray
Black
Black
Gray
Black
1 2 3
1 2 3
4 5
6 7 8 9 10 11 12
1 2 3
4 5
6 7 8 9 10 11 12
O 1
O 2
P 1
P 26
R 1
Black
Gray
Black
Black
Gray
2
1
-3-
http://vnx.su
3
1
R 3
S 1
S 4
Red
Black
Black
2
1
10
11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26
27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42
S 5
S 5
(2AD-FHV, 2AD-FTV)
S 5
S 5
S 6
(1ZZ-FE, 3ZZ-FE)
(1CD-FTV)
Gray
T 5
V 4
V 4
Black
Black (1CD-FTV)
-4-
http://vnx.su
1 2
http://vnx.su
EA
EB
Engine Wire
EZ
EY
-1-
Engine Room
Main Wire
Wire and Wire , Ground Points in Engine Compartment <LHD 2AD-FTV>
Engine No.2 Wire
EC
EE1
ED1
ED
Wire and Wire , Ground Points in Engine Compartment <LHD 2AD-FTV>
ED1
EE1
Black
1
1
9 10
10 9
-2-
http://vnx.su
http://vnx.su
H3
A10
C3
H12
C6
A1
E2
E6
F18
E7
H11
A3
A2
E18
F3
B1
A9
* 1:w/ HID
* 2:w/o HID
H6
F10
(*2)
F9
(*1)
-1-
(*2)
F4
C1
F11
F2
D22
(*1)
H4
B3
H2
F28
G1
A12
A11
A5
E4
E5
F6
F13
Position of Parts in Engine Compartment <RHD 2AD-FTV>
F1
F8
F7
H5
H1
B12
B11
A4
A6
G2
F14
F5
A
A
A
A
A
A
A
A
A
A
A
1
2
3
4
5
6
9
10
11
12
12

A/C Pressure Sensor
Air Flow Meter
Alternator
C
C
C
C
C
C
1
3
3
6
6
6


E 2
E 2
E 2
E 2
E 4
E 5
E 5
E 6
E 7
E 7
E 18

F
F
F
F
F
F
F
F
F
F
F
F
F
F
F

Front Fog Light LH
Front Fog Light RH
Front Washer Motor
Front Wiper Motor
Fuel Temp. Sensor
1
2
3
4
5
6
7
8
9
10
11
13
14
18
28
G
G
1 Glow Plug
2 Glow Plug Relay
H
H

-2-
http://vnx.su

H 11 Horn LH
H 12 Horn RH
-3-
http://vnx.su
A 1
A 2
A 3
Gray
Black
Black
1 2
1
1
A 4
A 5
A 6
A 9
A 10
A 11
A 12
Black
Yellow
Yellow
Black
(1CD-FTV)
1
1
A 12
B 1
B 3
B 11
B 12
(Except 1CD-FTV)
Gray
Black
Black
Black
1
1
1
C 1
C 3
C 3
C 6
Black
1 2
2
3
C 6
C 6
D 22
E 2
Black (1CD-FTV)
Black
1 2
1
E 2
1 2
3
2
E 2
Gray (1CD-FTV)
E 2
E 4
Gray (1AZ-FE)
Black
1 2
1 2
1
E 5
E 5
E 6
E 7
Black
Gray (2AZ-FSE)
1
1
1
2
3
1 2
-4-
http://vnx.su
E 7
E 18
F 1
F 2
Black
Black
Black
F 3
F 4
F 5
F 6
Brown
Brown
Gray
Gray
F 9
1
3
F 10
2
4
1
3
F 28
2
4
F 7
1
3
F 8
2
4
1
3
2
4
F 11
F 13
F 14
F 18
Black
Gray
Gray
Gray
2
4
G 1
Black
1 2
G 2
H 1
H 2
Gray
Gray
Gray
1
1
H 3
H 4
Black
Black
H 5
H 6
1
1
1
3
-5-
http://vnx.su
2
3
H 11
H 12
Black
Black
http://vnx.su
R3
S1
O1
T5
I5
P26
I17
I18
O2
I9
V4
S4
I6
-1-
S5
I7
R1
I8
S6
J1
J2
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
5
5
5
5
6
6
6
6
7
7
7
7
8
8
8
8
9
17
18

J
J
O
O

2 Oil Pressure SW

R
R

3 Rear Washer Motor
S
S
S
S
S
S
S
1
4
5
5
5
5
6
V
V


Starter
Starter (1CD-FTV)
-2-
http://vnx.su
I 5
I 5
Black (2AD-FTV)
Black (2AD-FHV)
I 5
1
1
I 6
Gray (2AD-FHV)
I 6
1
1
2
1
I 7
I 7
Black (2AD-FTV)
Black (2AD-FHV)
I 7
2
1
I 8
I 8
Gray (2AD-FTV)
Gray (2AD-FHV)
I 8
I 8
2
1
I 7
2
1
I 6
2
1
I 6
Gray (2AD-FTV)
I 5
2
1
I 9
I 17
I 18
J 1
J 2
Gray
Black
Black
Gray
Black
1 2 3
1 2 3
4 5
6 7 8 9 10 11 12
1 2 3
4 5
6 7 8 9 10 11 12
O 1
O 2
P 26
R 1
R 3
Black
Gray
Black
Gray
Red
2
1
1
1
S 1
S 4
S 5
Black
Black
(2AD-FHV, 2AD-FTV)
1
1
1
10
11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26
27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42
-3-
http://vnx.su
S 5
S 5
S 5
S 6
T 5
(1ZZ-FE, 3ZZ-FE)
(1CD-FTV)
Gray
Black
1 2
1
V 4
V 4
Black (1CD-FTV)
-4-
http://vnx.su
http://vnx.su
EA
EB
Engine Wire
EZ
EY
-1-
Engine Room
Main Wire
Wire and Wire , Ground Points in Engine Compartment <RHD 2AD-FTV>
Engine No.2 Wire
EC
EE1
ED
ED1
Wire and Wire , Ground Points in Engine Compartment <RHD 2AD-FTV>
ED1
EE1
Black
1
1
9 10
10 9
-2-
http://vnx.su
http://vnx.su
F2
F10
F9
F11
H6
H2
A10
A12
A5
F6
(*2)
(*1)
H4
F4
H3
C3
C2
A3
C6
H12
A11
-1-
A1
C1
H11
H7
E1
B3
A9
F13
F3
F12
Position of Parts in Engine Compartment <LHD 1ZZ-FE, 3ZZ-FE>
F1
* 1:w/ HID
* 2:w/o HID
(*2)
(*1)
F8
F7
H5
H1
B1
E2
A4
A6
F5
A
A
A
A
A
A
A
A
A
A
1
3
4
5
6
9
10
11
12
12

A/C Pressure Sensor
Air Flow Meter
Alternator
B
B
1 Back-Up Light SW
C
C
C
C
C
C
C
1
2
3
3
6
6
6

E
E
E
E
E
E
1
1
2
2
2
2

F
F
F
F
F
F
F
F
F
F
F
F
F
1
2
3
4
5
6
7
8
9
10
11
12
13

Front Fog Light LH
Front Fog Light RH
Front Washer Motor
Front Window Deicer
Front Wiper Motor

H 11 Horn LH
H 12 Horn RH
-2-
http://vnx.su
A 1
A 3
Gray
Black
1 2
A 4
A 5
A 6
Black
A 9
A 10
A 11
A 12
A 12
Yellow
Yellow
Black
(1CD-FTV)
(Except 1CD-FTV)
1
2
B 1
B 3
C 1
C 2
C 3
Gray
Black
Black
Black
1
1
1 2
2
1
C 3
C 6
C 6
1 2
2
3
C 6
E 1
E 1
E 2
Black (1CD-FTV)
Gray (2AZ-FSE)
2
8
1
7
E 2
3
4 5 6
9 10 11 12 13
E 2
Gray (1CD-FTV)
1 2
2
7
3
8
4
9
5
2
10
E 2
F 1
F 2
Gray (1AZ-FE)
Black
Black
1 2
1 2
1
F 3
F 4
F 5
F 6
Brown
Brown
Gray
Gray
-3-
http://vnx.su
F 7
1
3
2
4
F 8
1
3
2
4
F 9
F 10
F 11
F 12
F 13
H 1
Black
Black
Gray
Gray
2
2
4
1
3
1
3
2
4
1
1
2
4
H 2
H 3
H 4
Gray
Black
Black
H 5
H 6
1
1
2
3
H 7
H 7
H 11
H 12
Black
Black
3 4
-4-
http://vnx.su
1
3
2
3
http://vnx.su
R3
S1
O1
S2
(*3)
(*3)
(*4)
I5
K1
I6
I1
O2
I2
I7
I3
-1-
I8
I4
S4
N2
R1
S5
N1
R2
* 3:w/ VSC
* 4:w/o VSC
T4
T1
J1
J2
V5
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
1
2
3
4
5
5
5
5
6
6
6
6
7
7
7
7
8
8
8
8

J
J
N
N
1 Neutral Start SW
O
O

2 Oil Pressure SW
R
R
R

2 Radiator Fan Resistor
3 Rear Washer Motor
S
S
S
S
S
S
S
1
2
4
5
5
5
5
T
T

5 VSV (EVAP)

Starter
Starter (1CD-FTV)
-2-
http://vnx.su
I 1
I 2
I 3
I 4
I 5
Black
Gray
Black
Gray
Black (2AD-FTV)
I 5
I 5
Black (2AD-FHV)
1
1
I 6
Gray (2AD-FTV)
I 6
1
1
I 6
I 7
Black (2AD-FTV)
I 7
1
1
I 7
I 8
Gray (2AD-FTV)
1
1
I 8
I 8
Gray (2AD-FHV)
1
1
I 7
Black (2AD-FHV)
I 5
I 6
Gray (2AD-FHV)
I 8
J 1
Gray
1 2 3
4 5
6 7 8 9 10 11 12
2
1
J 2
K 1
N 1
N 2
Black
Black
Gray
Gray
1 2 3
4 5
6 7 8 9 10 11 12
2
1
1
3
7
4
8
5
9
O 1
O 2
R 1
R 2
R 3
Black
Gray
Gray
Black
Red
2
1
1
1
-3-
http://vnx.su
S 1
Black
10
11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26
27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42
S 2
S 4
S 5
Black
Black
(2AD-FHV, 2AD-FTV)
1
1
6 7 8 9 10 11 12 13 14 15
16 17 18 19 20 21 22 23 24 25 26
S 5
S 5
S 5
T 1
(1ZZ-FE, 3ZZ-FE)
(1CD-FTV)
Black
1
1
T 4
V 5
Black
Blue
-4-
http://vnx.su
http://vnx.su
EA
EB
EB1
Engine Room
Main Wire
-1-
Engine No.4 Wire
Engine Wire
EH
EG
Wire and Wire , Ground Points in Engine Compartment <LHD 1ZZ-FE, 3ZZ-FE>
EC
EA1
ED
Wire and Wire , Ground Points in Engine Compartment <LHD 1ZZ-FE, 3ZZ-FE>
EA1
EB1
Gray
Gray
2
1
-2-
http://vnx.su
http://vnx.su
F2
F10
F11
H6
H2
A10
A12
A5
F6
F13
F4
B3
C3
C2
H12
C6
E6
A11
-1-
A1
C1
H11
H7
A3
E2
E1
A9
Position of Parts in Engine Compartment <RHD 1ZZ-FE, 3ZZ-FE>
F3
F1
F8
H5
H1
B1
A6
A4
F5
A
A
A
A
A
A
A
A
A
A
1
3
4
5
6
9
10
11
12
12

A/C Pressure Sensor
Air Flow Meter
Alternator
B
B
1 Back-Up Light SW
C
C
C
C
C
C
C
1
2
3
3
6
6
6

E
E
E
E
E
E
E
1
1
2
2
2
2
6


F 4 Front Fog Light RH
F 8 Front Turn Signal Light LH , Headlight LH (Low)
F 10 Front Turn Signal Light RH , Headlight RH (Low)
H 11 Horn LH
H 12 Horn RH
-2-
http://vnx.su
A 1
A 3
Gray
Black
1 2
A 4
A 5
A 6
Black
A 9
A 10
A 11
A 12
A 12
Yellow
Yellow
Black
(1CD-FTV)
(Except 1CD-FTV)
1
2
B 1
B 3
C 1
C 2
C 3
Gray
Black
Black
Black
1
1
1 2
2
1
C 3
C 6
C 6
1 2
2
3
C 6
E 1
E 1
E 2
Black (1CD-FTV)
Gray (2AZ-FSE)
2
8
1
7
E 2
3
4 5 6
9 10 11 12 13
E 2
Gray (1CD-FTV)
1 2
4
9
5
2
10
E 2
E 6
F 1
Gray (1AZ-FE)
Black
Black
1 2
1
2
3
1 2
F 2
F 3
F 4
F 5
F 6
Black
Brown
Brown
Gray
Gray
-3-
http://vnx.su
F 8
1
3
2
4
F 10
2
4
1
3
F 13
H 1
H 2
Gray
Gray
Gray
2
4
H 5
H 6
1
2
F 11
Black
H 7
H 7
H 11
H 12
Black
Black
1
3
2
3
3 4
-4-
http://vnx.su
http://vnx.su
R3
S1
O1
S2
(*1)
(*1)
(*2)
I5
K1
I6
I1
O2
I2
I7
I3
-1-
I8
I4
S4
N2
R1
S5
N1
R2
* 1:w/ VSC
* 2:w/o VSC
T1
T4
J1
J2
V5
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
1
2
3
4
5
5
5
5
6
6
6
6
7
7
7
7
8
8
8
8

J
J
N
N
1 Neutral Start SW
O
O

2 Oil Pressure SW
R
R
R

2 Radiator Fan Resistor
3 Rear Washer Motor
S
S
S
S
S
S
S
1
2
4
5
5
5
5
T
T

5 VSV (EVAP)

Starter
Starter (1CD-FTV)
-2-
http://vnx.su
I 1
I 2
I 3
I 4
I 5
Black
Gray
Black
Gray
Black (2AD-FTV)
I 5
I 5
Black (2AD-FHV)
1
1
I 6
Gray (2AD-FTV)
I 6
1
1
I 6
I 7
Black (2AD-FTV)
I 7
1
1
I 7
I 8
Gray (2AD-FTV)
1
1
I 8
I 8
Gray (2AD-FHV)
1
1
I 7
Black (2AD-FHV)
I 5
I 6
Gray (2AD-FHV)
I 8
J 1
Gray
1 2 3
4 5
6 7 8 9 10 11 12
2
1
J 2
K 1
N 1
N 2
Black
Black
Gray
Gray
1 2 3
4 5
6 7 8 9 10 11 12
2
1
1
3
7
4
8
5
9
O 1
O 2
R 1
R 2
R 3
Black
Gray
Gray
Black
Red
2
1
1
1
-3-
http://vnx.su
S 1
Black
10
11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26
27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42
S 2
S 4
S 5
Black
Black
(2AD-FHV, 2AD-FTV)
1
1
6 7 8 9 10 11 12 13 14 15
16 17 18 19 20 21 22 23 24 25 26
S 5
S 5
S 5
T 1
(1ZZ-FE, 3ZZ-FE)
(1CD-FTV)
Black
1
1
T 4
V 5
Black
Blue
-4-
http://vnx.su
http://vnx.su
EA
EB
EB1
EH
-1-
Engine No.4 Wire
Engine Room
Main Wire
EG
Engine Wire
Wire and Wire , Ground Points in Engine Compartment <RHD 1ZZ-FE, 3ZZ-FE>
EC
EA1
ED
Wire and Wire , Ground Points in Engine Compartment <RHD 1ZZ-FE, 3ZZ-FE>
EA1
EB1
Gray
Gray
2
1
-2-
http://vnx.su
http://vnx.su
D18
D9
D7
F21
F24
D17
D13
C15
A32
D11
I15
F25
C17
-1-
D10
F22
F23
I16
C16
D8
Position of Parts in Body <LHD L/B>
D15
C18
B8
B7
H19
H20
A33
D12
D20

B
B
B
7 Back Door Courtesy SW , Back Door Lock Motor (W/G)

7 Back Door Courtesy SW , Back Door Lock Motor (L/B)
8 Back Door Opener SW
C
C
C
C
15
16
17
18

D
D
D
D
D
D
D
D
D
D
D
7
8
9
10
11
12
13
15
17
18
20

Door Key Lock and Unlock SW (Driver's Side) , Door Lock Control Motor (Driver's Side) , Door Unlock Detection SW (Driver's Side)
Door Lock Control Motor (Front Passenger's Side)
Door Lock Control SW , Power Window Master SW
F
F
F
F
F
21
22
23
24
25

Fuel Lid Opener SW
Fuel Pump , Fuel Sender
H
H
H
H
19
20
20
20

I
I
15 Inner Mirror
16 Interior Light
-2-
http://vnx.su
A 32
A 33
2 1
B 7
B 7
Blue (W/G)
(L/B)
1 2
1 2
3 4
3 4
2 1
C 16
C 17
C 18
Yellow
Black
Black
1 2
D 10
D 11
D 12
9 10 11 12
13 14 15 16 17 18 19 20 21 22 23 24
F 23
9 10
2
6
9 10
H 20
H 20
I 15
(L/B)
Black
4
9 10
3
8
4
9 10
F 21
F 22
Black
Black
H 19
H 20
Black
Black (W/G)
I 16
F 25
12
Gray (S/D)
Gray
1
2
D 20
F 24
D 9
D 15
Black
D 8
D 18
1
3
2 1
D 13
D 17
1 2
C 15
Yellow
D 7
B 8
1 2 3 4
-3-
http://vnx.su
http://vnx.su
P16
S14
P10
T18
P12
M4
T16
R15
P14
R17
V8
P17
R12
J32
P8
J30
T22
(*2)
J31
M6
(*1)
-1-
N7
M7
N8
T11
R16
V9
R13
T17
R18
M5
J33
P9
J34
* 1: w/ Moon Roof
* 2: w/ Tire Pressure
Warning System
L1
L2
R20
R14
R19
P15
S15
P11
T19
P13
J
J
J
J
J
30
31
32
33
34
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
L
L
1 License Plate Light LH

2 License Plate Light RH
M
M
M
M
4
5
6
7
N
N
7 Noise Filter (Rear Window Defogger No.2)

8 Noise Filter (Stop Light)
Mirror Heater LH , Remote Control Mirror LH

Mirror Heater RH , Remote Control Mirror RH
P
P
P
P
P
P
P
P
P
P
8
9
10
11
12
13
14
15
16
17
Personal Light
Pretensioner LH
Pretensioner RH
R
R
R
R
R
R
R
R
R
R
R
R
R
R
12
13
13
14
14
15
16
17
18
18
19
19
19
20
Rain Sensor
Rear Interior Light (Except S/D)
S
S
S
S
14
14
15
15
Side Airbag Sensor LH (w/o Curtain Shield Airbag)

Side Airbag Sensor LH (w/ Curtain Shield Airbag)
Side Airbag Sensor RH (w/o Curtain Shield Airbag)
Side Airbag Sensor RH (w/ Curtain Shield Airbag)
T
T
T
T
T
T
11
16
17
18
19
22

Tweeter Front LH
Tweeter Front RH
Tweeter Rear LH
Tweeter Rear RH
Tire Pressure Monitor Receiver
V
V
8 Vanity Light LH
9 Vanity Light RH
-2-
http://vnx.su
J 30
J 31
J 32
J 33
1 2 3
1
9 10 11 12
9 10 11 12
J 34
9 10 11 12
4 5
6 7 8 9 10 11 12 13
L 1
L 2
Black
Black
9 10 11 12
M 4
6
3
M 6
M 7
N 7
N 8
1 2
M 5
1
7
2
6
1
7
P 8
P 9
Gray
1 2 3 4
1
9 10
3 4
P 10
P 11
P 13
P 14
Gray
1
4
2
5
3
6
1
4
2
5
3
6
1
4
P 16
P 17
R 12
R 13
Yellow
Black
(W/G)
Gray
Yellow
3
6
P 12
P 15
2
5
Gray
Gray
1
4
2
5
3
6
1 2 3 4 5 6
R 13
R 14
R 14
R 15
R 16
Black (Except W/G)
(W/G)
Black (Except W/G)
Black
Black
1 2 3 4 5 6
1
R 17
R 18
R 18
R 19
R 19
R 19
R 20
(Except S/D)
(S/D, W/G)
(L/B)
(W/G)
(S/D)
(L/B)
Black
1
1
1
1
-3-
http://vnx.su
S 14
S 14
S 15
S 15
Yellow (w/o Curtain Shield Airbag)
Yellow (w/ Curtain Shield Airbag)
1 2
1 2 3 4
T 11
T 16
1 2 3
1
T 17
1 2 3
T 22
1 2
V 8
V 9
1 2
1 2
-4-
http://vnx.su
1 2 3 4
T 18
1 2 3
T 19
1 2 3
http://vnx.su
* 1:w/ Moon Roof

* 2:w/ Tire Pressure
Warning System
BR
Floor Wire
BA1
BQ
Front Door
LH Wire
Instrument
Panel Wire
(*2)
BB2
Rear Door
No.2 Wire
Roof Wire
-1-
BD1
BD2
Roof No.2 Back Door

Wire
No.1 Wire
Floor No.2 Wire
(*1)
BB1
BC1
BE2
Wire and Wire , Ground Points in Body <LHD L/B>
BV
BS
Front Door
RH Wire
BT
BE1
Back Door
No.2 Wire
BX
Rear Door
No.1 Wire
BU
Wire and Wire , Ground Points in Body <LHD L/B>
BA1
3 4
BB1
8 9
11 12 13 14 15 16
10
18 19
4 3
16 15 14 13 12 11
10
20
17
3 4
8 9
11 12 13 14 15 16
18 19
BD1
20
17
BD2
2 1
4 3
1 2
3
4 5 6 7 8
16 15 14 13 12 11
10
BE1
3
2 1
8 7 6 5 4
1 2
3 4
BE2
1 2
3
4 5 6 7 8
4 3
9 8
17
20
3 4
BC1
10
1 2
19 18
BB2
9 8
17
20
3
2 1
8 7 6 5 4
-2-
http://vnx.su
2 1
4 3
19 18
http://vnx.su
D19
D9
D7
F21
D16
C15
I15
A32
C17
D11
F22
F25
D8
-1-
D10
D17
F23
I16
C16
F24
Position of Parts in Body <RHD L/B>
D14
C18
B8
B7
H19
H20
A33
D12
D21

B
B
B

C
C
C
C
15
16
17
18

D
D
D
D
D
D
D
7
8
9
10
11
12
14
D 17
D 19
D 21

Door Key Lock and Unlock SW (Driver's Side) , Door Lock Control Motor (Driver's Side) , Door Unlock Detection SW (Driver's Side) ,
Double Lock Motor (Driver's Side) , Double Lock Position SW (Driver's Side)
Door Lock Control Motor (Front Passenger's Side) , Door Unlock Detection SW (Front Passenger's Side) , Double Lock Motor (Front
Passenger's Side) , Double Lock Position SW (Front Passenger's Side)
Door Lock Motor Rear LH , Door Unlock Detection SW Rear LH , Double Lock Motor Rear LH , Double Lock Position SW Rear LH
Door Lock Motor Rear RH , Door Unlock Detection SW Rear RH , Double Lock Motor Rear RH , Double Lock Position SW Rear RH
F
F
F
F
F
21
22
23
24
25

Fuel Lid Opener SW
H
H
H
H
19
20
20
20

I
I
15 Inner Mirror
16 Interior Light
D 16
-2-
http://vnx.su
A 32
A 33
2 1
B 7
B 7
Blue (W/G)
(L/B)
1 2
1 2
3 4
3 4
2 1
C 16
C 17
C 18
Yellow
Black
Black
1 2
D 10
D 11
D 12
9 10 11 12
13 14 15 16 17 18 19 20 21 22 23 24
F 23
9 10
2
6
9 10
H 20
H 20
I 15
(L/B)
Black
4
9 10
3
8
4
9 10
F 21
F 22
Black
Black
H 19
H 20
Black
Black (W/G)
I 16
F 25
12
Gray (S/D)
Gray
1
2
D 21
F 24
D 9
D 16
Black
D 8
D 19
1
3
2 1
D 14
D 17
1 2
C 15
Yellow
D 7
B 8
1 2 3 4
-3-
http://vnx.su
http://vnx.su
P16
S14
P10
T18
P12
P9
M4
T16
R15
P14
V8
R17
R12
P17
P8
J32
T12
J30
T22
(*2)
J31
M6
(*1)
-1-
N7
M7
N8
T11
R16
V9
R13
T17
R18
M5
J33
J34
L1
L2
R20
R14
R19
T15
P15
P11
S15
T19
P13
* 1: w/ Moon Roof
* 2: w/ Tire Pressure Warning System
J
J
J
J
J
30
31
32
33
34
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
L
L

M
M
M
M
4
5
6
7
N
N


P
P
P
P
P
P
P
P
P
P
8
9
10
11
12
13
14
15
16
17
Personal Light
Pretensioner LH
Pretensioner RH
R
R
R
R
R
R
R
R
R
R
R
R
R
R
12
13
13
14
14
15
16
17
18
18
19
19
19
20
Rain Sensor
S
S
S
S
14
14
15
15

T
T
T
T
T
T
T
T
11
12
15
16
17
18
19
22

Theft Warning Siren
Tweeter Front LH
Tweeter Front RH
Tweeter Rear LH
Tweeter Rear RH
V
V
8 Vanity Light LH
9 Vanity Light RH
-2-
http://vnx.su
J 30
J 31
J 32
J 33
1 2 3
1
9 10 11 12
9 10 11 12
J 34
9 10 11 12
4 5
6 7 8 9 10 11 12 13
L 1
L 2
Black
Black
9 10 11 12
M 4
6
3
M 6
M 7
N 7
N 8
1 2
M 5
1
7
2
6
1
7
P 8
P 9
Gray
1 2 3 4
1
9 10
3 4
P 10
P 11
P 13
P 14
Gray
1
4
2
5
3
6
1
4
2
5
3
6
1
4
P 16
P 17
R 12
R 13
Yellow
Black
(W/G)
Gray
Yellow
3
6
P 12
P 15
2
5
Gray
Gray
1
4
2
5
3
6
1 2 3 4 5 6
R 13
R 14
R 14
R 15
R 16
Black (Except W/G)
(W/G)
Black (Except W/G)
Black
Black
1 2 3 4 5 6
1
R 17
R 18
R 18
R 19
R 19
R 19
R 20
(Except S/D)
(S/D, W/G)
(L/B)
(W/G)
(S/D)
(L/B)
Black
1
1
1
1
-3-
http://vnx.su
S 14
S 14
S 15
S 15
1 2
1 2 3 4
T 11
1 2
T 12
T 15
1 2 3 4
T 16
T 17
Black
1 2 3
1
T 18
1 2 3
1
1
T 19
1 2 3
1 2 3
T 22
4
1
-4-
http://vnx.su
V 8
V 9
1 2
1 2
http://vnx.su
* 1:w/ Moon Roof

Warning System
BR
Floor Wire
BA1
BQ
Front Door
LH Wire
Instrument
Panel Wire
Floor No.2 Wire
-1-
BD1
BD2
Roof No.2 Back Door

BB2
BB1
Wire
No.1 Wire
(*2)
(*1)
Rear Door
No.2 Wire
Roof Wire
BC1
BE2
Wire and Wire , Ground Points in Body <RHD W/G>
BV
BE1
BS
BT
Front Door
RH Wire
Back Door
No.2 Wire
BX
Rear Door
No.1 Wire
BU
Wire and Wire , Ground Points in Body <RHD W/G>
BA1
3 4
BB1
8 9
11 12 13 14 15 16
10
18 19
4 3
16 15 14 13 12 11
10
20
17
3 4
8 9
11 12 13 14 15 16
18 19
BD1
20
17
BD2
2 1
4 3
1 2
3
4 5 6 7 8
16 15 14 13 12 11
10
BE1
3
2 1
8 7 6 5 4
1 2
3 4
BE2
1 2
3
4 5 6 7 8
4 3
9 8
17
20
3 4
BC1
10
1 2
19 18
BB2
9 8
17
20
3
2 1
8 7 6 5 4
-2-
http://vnx.su
2 1
4 3
19 18
http://vnx.su
D18
D9
D7
F21
F24
D13
D17
C15
A32
I15
D11
C17
-1-
D8
F22
F25
I16
F23
D15
Position of Parts in Body <LHD S/D>
D10
C18
C16
H19
A33
D12
H20
D20

C
C
C
C
15
16
17
18

D
D
D
D
D
D
D
D
D
D
D
7
8
9
10
11
12
13
15
17
18
20

F
F
F
F
F
21
22
23
24
25

Fuel Lid Opener SW
H
H
H
H
19
20
20
20

I
I
15 Inner Mirror
16 Interior Light
-2-
http://vnx.su
A 32
A 33
2 1
2 1
D 7
D 8
C 15
C 16
C 17
C 18
Yellow
Yellow
Black
Black
1 2
1 2
D 9
D 10
D 11
D 12
D 13
1
5
D 15
1
5
2
6
3
8
D 17
D 18
1
1
9 10
9 10 11 12
13 14 15 16 17 18 19 20 21 22 23 24
F 21
F 22
F 23
Black
Black
Black
3
8
9 10
H 20
H 20
I 15
Gray (S/D)
(L/B)
Black
12
2
-3-
http://vnx.su
9 10
2
6
3
8
4
9 10
H 19
3
5
I 16
Black
F 25
H 20
Gray
1
1
D 20
F 24
Black (W/G)
1 2 3 4
http://vnx.su
P14
R15
P16
S14
P10
T18
P12
M4
T16
V8
R12
P8
M7
M6
(*1)
J32
T22
(*2)
R18
T11
-1-
P17
V9
J30
T17
J31
M5
R13
P13
R16
P9
T19
L3
L1
L2
R14
L5
P15
P11
R19
L4
* 1: w/ Moon Roof
S15
L
L
L
L
L
1
2
3
4
5

Luggage Compartment Door Lock Motor , Luggage Compartment Light SW
M
M
M
M
4
5
6
7

P
P
P
P
P
P
P
P
P
P
8
9
10
11
12
13
14
15
16
17
Personal Light
Pretensioner LH
Pretensioner RH
R
R
R
R
R
R
R
R
R
R
R
R
12
13
13
14
14
15
16
18
18
19
19
19
Rain Sensor
S
S
S
S
14
14
15
15

T
T
T
T
T
T
11
16
17
18
19
22

Tweeter Front LH
Tweeter Front RH
Tweeter Rear LH
Tweeter Rear RH
V
V
8 Vanity Light LH
9 Vanity Light RH
-2-
http://vnx.su
J 30
J 31
J 32
1 2 3
1
9 10 11 12
9 10 11 12
L 3
4 5
L 1
L 2
Black
Black
6 7 8 9 10 11 12 13
L 4
L 5
M 4
M 5
Black
1
1
3
3
2 1
M 6
M 7
P 8
1
7
2
6
P 9
1
7
P 10
P 11
Gray
1 2 3 4
1
9 10
1
4
1 2
3 4
P 12
P 13
P 14
P 15
P 16
Gray
Gray
Gray
Gray
Yellow
2
5
3
6
1
4
2
5
3
6
1
4
2
5
3
6
1
4
2
5
3
6
P 17
R 12
R 13
R 13
Yellow
Black
(W/G)
Black (Except W/G)
1 2 3 4 5 6
R 14
R 14
R 15
R 16
R 18
R 18
(W/G)
Black (Except W/G)
Black
Black
(S/D, W/G)
(L/B)
1 2 3 4 5 6
1
-3-
http://vnx.su
R 19
R 19
R 19
S 14
S 14
(W/G)
(S/D)
(L/B)
1
1 2
S 15
S 15
1 2 3 4
T 11
T 16
1 2 3
1 2
T 17
1 2 3
1 2 3 4
T 18
1 2 3
T 19
1 2 3
T 22
V 8
4
1
V 9
1 2
-4-
http://vnx.su
1 2
http://vnx.su
BR
* 1:w/ Moon Roof

Warning System
Floor Wire
BA1
BQ
Front Door
LH Wire
Rear Door
No.2 Wire
Instrument Roof Wire

Panel Wire
(*1)
BB1
-1-
Floor No.2 Wire
(*2)
BB2
BC1
Roof No.2
Wire
Wire and Wire , Ground Points in Body <LHD S/D>
BV
BS
Front Door
RH Wire
BU
BT
BW
Rear Door
No.1 Wire
Rear Window
No.2 Wire
Wire and Wire , Ground Points in Body <LHD S/D>
BA1
3 4
8 9
10
11 12 13 14 15 16
18 19
BB1
4 3
16 15 14 13 12 11
10
9 8
17
20
17
20
19 18
BC1
3 4
8 9
10
11 12 13 14 15 16
18 19
20
4 3
16 15 14 13 12 11
10
9 8
17
17
20
19 18
-2-
http://vnx.su
http://vnx.su
D18
D19
D9
D7
F21
D15
D16
(*2)
(*1)
(*2)
(*1)
I15
C15
C17
A32
F22
D11
D17
-1-
D8
I16
F25
F24
F23
D14
(*1)
Position of Parts in Body <RHD S/D>
D10
D13
(*2)
C16
C18
* 1:w/ Double Locking
* 2:w/o Double Locking
(*2)
(*1)
H19
A33
D12
H20
D20
D21

C
C
C
C
15
16
17
18

D
D
D
D
D
D
D
D
7
8
9
10
11
12
13
14
D
D
D
D
D
17
18
19
20
21

F
F
F
F
F
21
22
23
24
25

Fuel Lid Opener SW
H
H
H
H
19
20
20
20

I
I
15 Inner Mirror
16 Interior Light
D 15
D 16
-2-
http://vnx.su
A 32
A 33
2 1
2 1
D 7
D 8
C 15
C 16
C 17
C 18
Yellow
Yellow
Black
Black
1 2
1 2
D 9
D 10
D 11
D 12
D 13
1
5
D 14
1
5
2
6
D 15
9 10
2
6
D 18
D 16
9 10
D 19
D 17
4
1
9 10
9 10 11 12
13 14 15 16 17 18 19 20 21 22 23 24
D 20
D 21
F 21
Black
1
5
2
6
3
8
9 10
F 22
F 23
Black
Black
2
6
3
8
9 10
3
8
9 10
F 24
2
1
H 20
H 20
H 20
I 15
Black (W/G)
Gray (S/D)
(L/B)
Black
12
2
H 19
Black
I 16
-3-
http://vnx.su
9 10
F 25
Gray
1 2 3 4
4
9 10
http://vnx.su
P14
R15
P16
S14
P10
T18
P12
P9
M4
T16
R12
T12
P8
* 3: w/ Moon Roof
V8
M7
J32
T22
(*4)
R18
M6
(*3)
-1-
P17
T11
J30
V9
J31
T17
R13
M5
R16
P13
L4
S15
T19
L1
L3
L2
R14
L5
T15
P15
P11
R19
L
L
L
L
L
1
2
3
4
5

Luggage Compartment Door Lock Motor , Luggage Compartment Light SW
M
M
M
M
4
5
6
7

P
P
P
P
P
P
P
P
P
P
8
9
10
11
12
13
14
15
16
17
Personal Light
Pretensioner LH
Pretensioner RH
R
R
R
R
R
R
R
R
R
R
R
R
12
13
13
14
14
15
16
18
18
19
19
19
Rain Sensor
S
S
S
S
14
14
15
15

T
T
T
T
T
T
T
T
11
12
15
16
17
18
19
22

Theft Warning Siren
Tweeter Front LH
Tweeter Front RH
Tweeter Rear LH
Tweeter Rear RH
V
V
8 Vanity Light LH
9 Vanity Light RH
-2-
http://vnx.su
J 30
J 31
J 32
1 2 3
1
9 10 11 12
9 10 11 12
L 3
4 5
L 1
L 2
Black
Black
6 7 8 9 10 11 12 13
L 4
L 5
M 4
M 5
Black
1
1
3
3
2 1
M 6
M 7
P 8
1
7
2
6
P 9
1
7
P 10
P 11
Gray
1 2 3 4
1
9 10
1
4
1 2
3 4
P 12
P 13
P 14
P 15
P 16
Gray
Gray
Gray
Gray
Yellow
2
5
3
6
1
4
2
5
3
6
1
4
2
5
3
6
1
4
2
5
3
6
P 17
R 12
R 13
R 13
Yellow
Black
(W/G)
Black (Except W/G)
1 2 3 4 5 6
R 14
R 14
R 15
R 16
R 18
R 18
(W/G)
Black (Except W/G)
Black
Black
(S/D, W/G)
(L/B)
1 2 3 4 5 6
1
-3-
http://vnx.su
R 19
R 19
R 19
S 14
S 14
(W/G)
(S/D)
(L/B)
1
1 2
S 15
S 15
1 2
T 11
1 2 3 4
T 15
1 2 3 4
T 16
T 12
T 17
T 18
Black
1 2 3
1
T 19
1 2 3
1 2 3
1 2 3
T 22
4
1
V 8
V 9
1 2
1 2
-4-
http://vnx.su
http://vnx.su
BR
Floor Wire
BA1
BQ
Front Door
LH Wire
Rear Door
No.2 Wire
-1-
Floor No.2 Wire
Instrument Roof Wire BB2

Roof No.2
BB1
Panel Wire
Wire
(*2)
(*1)
BC1
BV
Front Door
RH Wire
Wire and Wire , Ground Points in Body <RHD S/D>
BU
BS
BT
BW
Rear Door
No.1 Wire
Rear Window
No.2 Wire
* 1:w/ Moon Roof

Warning System
Wire and Wire , Ground Points in Body <RHD S/D>
BA1
3 4
BB1
8 9
11 12 13 14 15 16
10
18 19
4 3
16 15 14 13 12 11
10
20
17
19 18
BB2
9 8
17
20
BC1
3 4
8 9
10
11 12 13 14 15 16
18 19
4 3
16 15 14 13 12 11
10
9 8
17
20
17
20
-2-
http://vnx.su
19 18
http://vnx.su
D18
D9
D7
F21
F24
D17
D13
C15
A32
I15
D11
C17
F25
F22
-1-
D10
D8
F23
I16
C16
D15
Position of Parts in Body <LHD W/G>
A33
C18
B8
B7
H19
D12
D20
H20

B
B
B

C
C
C
C
15
16
17
18

D
D
D
D
D
D
D
D
D
D
D
7
8
9
10
11
12
13
15
17
18
20

F
F
F
F
F
21
22
23
24
25

Fuel Lid Opener SW
H
H
H
H
19
20
20
20

I
I
15 Inner Mirror
16 Interior Light
-2-
http://vnx.su
A 32
A 33
2 1
B 7
B 7
Blue (W/G)
(L/B)
1 2
1 2
3 4
3 4
2 1
C 16
C 17
C 18
Yellow
Black
Black
1 2
D 10
D 11
D 12
9 10 11 12
13 14 15 16 17 18 19 20 21 22 23 24
F 23
9 10
2
6
9 10
H 20
H 20
I 15
(L/B)
Black
4
9 10
3
8
4
9 10
F 21
F 22
Black
Black
H 19
H 20
Black
Black (W/G)
I 16
F 25
12
Gray (S/D)
Gray
1
2
D 20
F 24
D 9
D 15
Black
D 8
D 18
1
3
2 1
D 13
D 17
1 2
C 15
Yellow
D 7
B 8
1 2 3 4
-3-
http://vnx.su
http://vnx.su
P16
S14
P10
T18
P12
M4
T16
V8
R15
R12
P14
P8
P13
M7
J30
T22
(*2)
J31
M6
(*1)
J32
T11
N8
V9
-1-
N7
M5
R17
T17
R13
P9
R18
S15
P17
T19
* 1: w/ Moon Roof
Warning System
L1
L2
J33
J34
R14
R19
R20
P15
R16
P11
J
J
J
J
J
30
31
32
33
34
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
L
L

M
M
M
M
4
5
6
7
N
N


P
P
P
P
P
P
P
P
P
P
8
9
10
11
12
13
14
15
16
17
Personal Light
Pretensioner LH
Pretensioner RH
R
R
R
R
R
R
R
R
R
R
R
R
R
R
12
13
13
14
14
15
16
17
18
18
19
19
19
20
Rain Sensor
S
S
S
S
14
14
15
15

T
T
T
T
T
T
11
16
17
18
19
22

Tweeter Front LH
Tweeter Front RH
Tweeter Rear LH
Tweeter Rear RH
V
V
8 Vanity Light LH
9 Vanity Light RH
-2-
http://vnx.su
J 30
J 31
J 32
J 33
1 2 3
1
9 10 11 12
9 10 11 12
J 34
9 10 11 12
4 5
6 7 8 9 10 11 12 13
L 1
L 2
Black
Black
9 10 11 12
M 4
6
3
M 6
M 7
N 7
N 8
1 2
M 5
1
7
2
6
1
7
P 8
P 9
Gray
1 2 3 4
1
9 10
3 4
P 10
P 11
P 13
P 14
Gray
1
4
2
5
3
6
1
4
2
5
3
6
1
4
P 16
P 17
R 12
R 13
Yellow
Black
(W/G)
Gray
Yellow
3
6
P 12
P 15
2
5
Gray
Gray
1
4
2
5
3
6
1 2 3 4 5 6
R 13
R 14
R 14
R 15
R 16
Black (Except W/G)
(W/G)
Black (Except W/G)
Black
Black
1 2 3 4 5 6
1
R 17
R 18
R 18
R 19
R 19
R 19
R 20
(Except S/D)
(S/D, W/G)
(L/B)
(W/G)
(S/D)
(L/B)
Black
1
1
1
1
-3-
http://vnx.su
S 14
S 14
S 15
S 15
1 2
1 2 3 4
T 11
T 16
1 2 3
1
T 17
1 2 3
T 22
1 2
V 8
V 9
1 2
1 2
-4-
http://vnx.su
1 2 3 4
T 18
1 2 3
T 19
1 2 3
http://vnx.su
BV
-1-
BF1
BF2
BG2
BG1
BC1
BS
Back Door
No.2 Wire
Rear Door
No.1 Wire
Back Door
No.1 Wire
* 1:w/ Moon Roof

Warning System
BR
BT
BU
Floor Wire
Floor No.2 Wire
Front Door
RH Wire
BX
Rear Door
No.2 Wire
BB2
BB1 Roof No.2
Wire
(*2)
(*1)
BA1
BQ
Front Door
LH Wire
Instrument
Panel Wire
Roof Wire
Wire and Wire , Ground Points in Body <LHD W/G>
Wire and Wire , Ground Points in Body <LHD W/G>
BA1
3 4
BB1
8 9
11 12 13 14 15 16
10
18 19
4 3
16 15 14 13 12 11
10
20
17
3 4
8 9
11 12 13 14 15 16
18 19
BF1
20
17
BF2
2
4
6
1
3
16 15 14 13 12 11
10
2
4
19 18
BG1
2
1
6 5 4 3
BG2
4 3
9 8
17
20
BC1
10
19 18
BB2
9 8
17
20
2
1
6 5 4 3
-2-
http://vnx.su
http://vnx.su
D19
D9
D7
F21
D16
C15
A32
I15
D11
C17
D8
F22
F25
D17
-1-
D10
F24
F23
I16
C16
D14
Position of Parts in Body <RHD W/G>
A33
C18
B8
B7
H19
D12
D21
H20

B
B
B

C
C
C
C
15
16
17
18

D
D
D
D
D
D
D
7
8
9
10
11
12
14
D 17
D 19
D 21

F
F
F
F
F
21
22
23
24
25

Fuel Lid Opener SW
H
H
H
H
19
20
20
20

I
I
15 Inner Mirror
16 Interior Light
D 16
-2-
http://vnx.su
A 32
A 33
2 1
B 7
B 7
Blue (W/G)
(L/B)
1 2
1 2
3 4
3 4
2 1
C 16
C 17
C 18
Yellow
Black
Black
1 2
D 10
D 11
D 12
9 10 11 12
13 14 15 16 17 18 19 20 21 22 23 24
F 23
9 10
2
6
9 10
H 20
H 20
I 15
(L/B)
Black
4
9 10
3
8
4
9 10
F 21
F 22
Black
Black
H 19
H 20
Black
Black (W/G)
I 16
F 25
12
Gray (S/D)
Gray
1
2
D 21
F 24
D 9
D 16
Black
D 8
D 19
1
3
2 1
D 14
D 17
1 2
C 15
Yellow
D 7
B 8
1 2 3 4
-3-
http://vnx.su
http://vnx.su
P16
P10
S14
T18
P12
P9
M4
T16
T12
V8
R15
R12
P14
P8
P13
M7
J30
T22
(*2)
J31
M6
(*1)
J32
T11
N8
V9
-1-
N7
M5
R17
T17
R13
T13
R18
S15
P17
T19
* 1: w/ Moon Roof
Warning System
T14
L1
L2
R20
J33
J34
R14
R19
T15
P15
R16
P11
J
J
J
J
J
30
31
32
33
34
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
L
L

M
M
M
M
4
5
6
7
N
N


P
P
P
P
P
P
P
P
P
P
8
9
10
11
12
13
14
15
16
17
Personal Light
Pretensioner LH
Pretensioner RH
R
R
R
R
R
R
R
R
R
R
R
R
R
R
12
13
13
14
14
15
16
17
18
18
19
19
19
20
Rain Sensor
S
S
S
S
14
14
15
15

T
T
T
T
T
T
T
T
T
T
11
12
13
14
15
16
17
18
19
22

Theft Warning Siren
Tweeter Front LH
Tweeter Front RH
Tweeter Rear LH
Tweeter Rear RH
-2-
http://vnx.su
V
V
8 Vanity Light LH
9 Vanity Light RH
-3-
http://vnx.su
J 30
J 31
J 32
J 33
1 2 3
1
9 10 11 12
9 10 11 12
J 34
9 10 11 12
4 5
6 7 8 9 10 11 12 13
L 1
L 2
Black
Black
9 10 11 12
M 4
6
3
M 6
M 7
N 7
N 8
1 2
M 5
1
7
2
6
1
7
P 8
P 9
Gray
1 2 3 4
1
9 10
3 4
P 10
P 11
P 13
P 14
Gray
1
4
2
5
3
6
1
4
2
5
3
6
1
4
P 16
P 17
R 12
R 13
Yellow
Black
(W/G)
Gray
Yellow
3
6
P 12
P 15
2
5
Gray
Gray
1
4
2
5
3
6
1 2 3 4 5 6
R 13
R 14
R 14
R 15
R 16
Black (Except W/G)
(W/G)
Black (Except W/G)
Black
Black
1 2 3 4 5 6
1
R 17
R 18
R 18
R 19
R 19
R 19
R 20
(Except S/D)
(S/D, W/G)
(L/B)
(W/G)
(S/D)
(L/B)
Black
1
1
1
1
-4-
http://vnx.su
S 14
S 14
S 15
S 15
1 2
1 2 3 4
T 11
T 12
T 17
1 2 3
1 2
T 13
1 2
1
T 18
1 2 3
1 2 3 4
T 14
T 15
Black
Black
T 16
1 2 3
1 2
T 19
1 2 3
T 22
V 8
4
1
V 9
1 2
-5-
http://vnx.su
1 2
http://vnx.su
-1-
BF2
BU
BG2
BG1
BC1
BS
Back Door
No.2 Wire
Rear Door
No.1 Wire
Back Door
No.1 Wire
* 1:w/ Moon Roof

Warning System
BR
BT
BF1
Front Door
RH Wire
Floor Wire
BV
Roof No.2
Wire
Floor No.2 Wire
(*1)
BB1
BX
Rear Door
No.2 Wire
(*2)
BB2
BA1
BQ
Front Door
LH Wire
Instrument
Panel Wire
Roof Wire
Wire and Wire , Ground Points in Body <RHD L/B>
Wire and Wire , Ground Points in Body <RHD L/B>
BA1
3 4
BB1
8 9
11 12 13 14 15 16
10
18 19
4 3
16 15 14 13 12 11
10
20
17
3 4
8 9
11 12 13 14 15 16
18 19
BF1
20
17
BF2
2
4
6
1
3
16 15 14 13 12 11
10
2
4
19 18
BG1
2
1
6 5 4 3
BG2
4 3
9 8
17
20
BC1
10
19 18
BB2
9 8
17
20
2
1
6 5 4 3
-2-
http://vnx.su
http://vnx.su
IJ
IL
IK
IM
-1-
IN
Ground Points in Instrument Panel <LHD>
IP
http://vnx.su
A16
A37
A34
A17 A21
A26
A25
C7
A19
C8
C9
A20
A15
(*2)
A14
A27
A28
(*1)
(*3)
(*1)
(*2)
(*3)
(*5)
-1-
A22
(*1)
A34
A24
(*4)
(*6)
A35
B4
A29
B5
B6
A31
* 1:Manual A/C
* 2:Automatic A/C
(Except 2AD-FHV,
2AD-FTV)
* 3:Automatic A/C
(2AD-FHV, 2AD-FTV)
* 4:2AD-FHV w/o HID
* 5:2AD-FHV w/ HID
* 6:Automatic A/C
(*2)
A13
A23
C12
A36
C11
(*1)
C13
A18
A30
C14
C10
(*2)
Position of Parts in Instrument Panel <LHD>
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
B
B
B
C
C
C
C
C
C
C
C
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
34
35
36
37

A/C Solar Sensor
A/C Thermistor
Antenna Amplifier
Air Fuel Ratio Sensor Relay
4 Blower Motor
5 Blower Motor Controller
6 Blower Resistor
7
8
9
10
11
12
13
14
Cigarette Lighter , Cigarette Lighter Illumination

Clutch Start SW
Combination Meter
Combination Meter
Combination SW
Combination SW
Combination SW
-2-
http://vnx.su
A 13
A 14
A 15
9 10 11 12 13 14 15 16 17 18 19 20
21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40
A 16
A 17
A 18
Black
Black
1 2
1
9 10
11 12 13 14 15 16 17 18 19 20
A 19
A 20
Black
1 2
9 10 11 12
13 14 15 16 17 18 19 20 21 22 23 24
A 21
A 22
A 23
A 24
A 25
Black
Black
Black
Black
Black
A 27
A 28
A 29
Yellow
Yellow
Yellow
1 2 3
3 4
4 5 6
1 2
3 4
7 8 9 10 11 12 13 14 15 16 17
5 6 7 8 9 10 11 12
13 14 15 16 17 18 19 20
18 19 20 21 22 23 24 25 26 27 28
13 14 15 16 17 18 19 20
A 30
A 31
A 34
Yellow
A 35
A 36
Gray
1
2
A 26
5 6 7 8 9 10 11 12
Yellow
1 2
A 37
1 X 2
B 4
B 5
B 6
Black
Black
1
1
9 10 11 12 13 14 15 16 17 18 19 20
21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40
-3-
http://vnx.su
4
1
C 7
C 8
C 9
C 10
Black
C 11
Blue
3
1 2
3 4
C 12
C 13
C 14
Black
10 11 12 13 14 15 16 17
4 5 6
4 5 6
10 11 12 13 14 15 16 17 18
-4-
http://vnx.su
9 10 11
12 13 14 15 16 17 18 19 20 21 22
10 11 12 13 14 15 16 17 18
1 X 2
9 10 11 12
http://vnx.su
D5
F20
I14
H15
H16
D4
D3
I13
E8
E15
I12
(*7)
(*8)
F19
I11
E14
-1-
H18
H13
H17
(*9) (*10)
H17
D2

* 9:1ZZ-FE, 3ZZ-FE w/ HID
* 10:1ZZ-FE, 3ZZ-FE w/o HID
E13
E12
H14
E11
E10
E9
G3
D6
D
D
D
D
D
D
2
3
4
4
5
6
E
E
E
E
E
E
E
E
8
9
10
11
12
13
14
15
Diode
Diode
Diode (Fan) (Except 1CD-FTV)
Diode (Fan) (1CD-FTV)
DLC3
Engine and ECT ECU (A/T) , Engine ECU (M/T)
EPS ECU
EPS ECU
F 19 Front Passenger's Seat Belt Warning Light , Rear Window Defogger SW , Security Indicator Light
F 20 Front Wiper Deicer SW
G
3 Glove Box Light
H
H
H
H
H
H
H
13
14
15
16
17
17
18
Hazard SW
Heated Oxygen Sensor (Bank 1 Sensor 2) (w/o HID)
Heated Oxygen Sensor (Bank 1 Sensor 2) (w/ HID)
I
I
I
I
11
12
13
14

Ignition Key Cylinder Light , Transponder Key Amplifier
Ignition SW
Integration Relay
-2-
http://vnx.su
D 2
D 3
D 4
D 4
Black
(Except 1CD-FTV)
(1CD-FTV)
D 5
16 15 14 13 12 11 10 9
8
D 6
E 8
E 9
E 10
Black
1
8
9 10 11 12 13 14 15 16 17
9 10 11 12 13 14 15 16
18 19 20 21 22 23
24 25
17 18 19 20 21 22 23 24 25 26 27
26 27
30 31
28 29 30
E 11
28 29
E 12
31 32 33 34 35
E 13
E 14
Gray
1
8
9 10 11 12 13 14 15 16 17
9 10 11 12 13 14 15 16 17 18 19
18 19 20 21 22 23 24 25 26 27
20 21 22 23
24 25
26 27
18 19 20 21 22 23 24 25 26 27
28 29
28 29 30 31
32 33
34 35
28 29 30 31 32
30
31 32
E 15
F 19
9 10 11 12
H 14
33 34
F 20
G 3
H 13
Black
Black
Black
1
1
9 10 11 12 13 14 15 16 17
H 15
3
7
H 16
H 17
H 17
Black
Gray (w/o HID)
Gray (w/ HID)
1 2 3 4
1 2 3 4 5
1
2 1
4 3
9 10 11 12
13 14 15 16 17 18 19 20 21 22 23 24
-3-
http://vnx.su
9 10
H 18
I 11
I 12
Black
Black
Black
I 14
9 10 11
12 13 14 15 16 17 18 19 20 21 22
-4-
http://vnx.su
I 13
http://vnx.su
J15
J4
J3
J10
J9
J11
K2
J8
J7
J6
K3
J5
-1-
J16
M3
(*12)
J17
M2
M1
M3
(*11)
J14
J12
J13

J18
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
K
K
2 Kick Down SW
3 Knee Airbag Squib
M
M
M
M
M
1
1
2
2
3
Multi-Display (w/o Navigation System (Map Type))

Multi-Display (w/ Navigation System (Map Type))
Multi-Display
-2-
http://vnx.su
J 3
J 4
J 5
J 6
1 2 3
1
9 10 11 12
9 10 11 12
9 10 11
12 13 14 15 16 17 18 19 20 21 22
9 10 11
6 7 8 9 10 11 12 13
9 10 11
9 10 11
9 10 11
9 10 11 12
9 10 11 12
J 16
1 2 3
6 7 8 9 10 11 12 13
4 5
1 2 3
4 5
6 7 8 9 10 11 12 13
K 2
K 3
M 1
Black
Yellow
(w/o Navigation System (Map Type))
1
1
J 17
10 11 12 13 14 15 16 17 18
M 2
M 2
(w/ Navigation System (Map Type))
20 21 22 23 24 25
9 10 11
J 13
14 15 16 17 18 19
J 12
M 1
3 4 5 6 7 8 9 10 11 12 13
9 10 11
12 13 14 15 16 17 18 19 20 21 22
12 13 14 15 16 17 18 19 20 21 22
12 13 14 15 16 17 18 19 20 21 22
J 18
J 15
4 5
J 11
1 2 3
Gray
J 14
J 9
Black
J 10
J 8
Gray
Black
12 13 14 15 16 17 18 19 20 21 22
12 13 14 15 16 17 18 19 20 21 22
12 13 14 15 16 17 18 19 20 21 22
J 7
4 5
6 7 8 9 10 11 12 13
M 3
9 10
-3-
http://vnx.su
http://vnx.su
T9
R10
R8
R9
S10
N6
T10
S11
P5
S13
S12
N3
V7
N4
R4
N5
T8
U1
R5
-1-
Z1
R6
Z2
R7
Y1
P7
S9
T20
P4
S21
R11
S20
P6
S7
S8
T7
T21
W2
N
N
N
N
3
4
5
6
Navigation ECU
Navigation ECU
Navigation ECU
P
P
P
P
P
4
5
5
6
7
Parking Brake SW
Power Heater SW (Power Heater (Combustion Type))
Power Heater SW (Power Heater (Hot Gas Type))
Power Outlet
PTC Heater
R 4 Radio and Player

R 8 Rear Fog Light Relay
R 9 Rear Window Defogger Relay
R 10 Remote Control Mirror SW
R 11 Remote Controller (Navigation)
S
S
S
S
S
S
S
S
S
S
7
8
9
10
11
12
13
13
20
21
Seat Heater SW
Seat Heater SW
Short Connector
Short Connector
Steering Sensor
Stop Light SW (LHD 1AZ-FE)
Stop Light SW (Except LHD 1AZ-FE)
Short Connector
Short Connector
T 7 Transmission Control SW
T 8 Transponder Key Computer
T 9 TRC Off SW
T 10 Turn Signal Flasher Relay
T 20 Tire Pressure Monitor ECU
T 21 Tire Pressure Warning SW
U
1 Unlock Warning SW
7 VSC Warning Buzzer
W 2 Wiper Relay
Y
1 Yaw Rate Sensor
Z
Z
1 Option Connector (Navigation ECU)

-2-
http://vnx.su
N 3
N 4
N 5
N 6
P 4
Black
10 11 12 13 14 15 16 17 18
9 10
P 5
P 5
P 6
Gray (Power Heater (Combustion Type))
(Power Heater (Hot Gas Type))
Black
1
3
R 5
R 4
R 6
1
3
P 7
2
4
R 7
3
7
R 8
1 X 2
1 X 2
9 10 11 12
9 10
11 12 13 14 15 16 17 18 19 20
R 11
S 7
S 8
Black
Black
S 9
1 2
9 10 11 12
S 10
S 11
S 12
S 13
S 13
Black
Black
Black
Black (LHD 1AZ-FE)
(Except LHD 1AZ-FE)
1
5
2
1
6 5 4 3
2
5
S 20
9 10
R 9
1 2 3 4 5 6 7 8 9 10
R 10
3
6
4
3
S 21
9 10 11 12 13 14 15 16
1
4
T 7
16 15 14 13 12 11 10 9
T 8
-3-
http://vnx.su
9 10 11 12 13 14
2
4
T 9
T 10
Black
Black
3
7
T 20
T 21
1 2
3
4 5 6 7 8
9 10
9 10 11 12 13 14 15 16
V 7
W 2
Y 1
Black
Black
Black
1
1
2
1
10 11 12 13 14 15
16
17
18 19 20 21 22 23
24
Z 1
Z 2
18 17 16 15 14 13 12 11 10
U 1
Black
10 11 12 13 14 15 16 17 18
-4-
http://vnx.su
4
3
http://vnx.su
IE4
IE8
IE5
IE6
Floor Wire
Switch Wire
A/C Sub
Instrument
Wire No.1 Panel Wire
Floor No.3 Wire
Front Door
RH Wire
Engine Wire
A/C Sub
Wire No.2
Floor Wire
IC3
-1-
Instrument Panel
No.3 Wire
Floor No.2 Wire
IE3
IE2
Front Door
LH Wire
IA1
IE1
Floor No.2 Wire
IA2
IE7
IC2
IC1
IB1
ID1
Roof Wire
Engine Room
Main Wire
Wire and Wire in Instrument Panel <LHD>
IA1
IA2
2
6
3
7
4
4 3
9 10
2 1
8
10 11 12 13 14 15 16 17 18
6 5
18 17 16 15 14 13 12 11 10
2 3 4 5 6 7 8 9 10
11 12 13 14 15 16 17 18 19 20
10 9 8 7 6 5 4 3 2
20 19 18 17 16 15 14 13 12 11
IE1
9 10 11
12 13 14 15 16 17 18 19 20 21 22
11 10 9
3
7
9 10
4 3
10 9
ID1
IC3
10 11 12 13 14 15 16 17 18
18 17 16 15 14 13 12 11 10
IC2
IC1
10 9
22 21 20 19 18 17 16 15 14 13 12
-2-
http://vnx.su
22 21 20 19 18 17 16 15 14 13 12
12 13 14 15 16 17 18 19 20 21 22
IB1
17 16 15 14 13 12 11 10
10 11 12 13 14 15 16 17
11 10 9
9 10 11
2 1
8
6 5
IE2
IE3
IE4
1
3
8
18 17 16 15 14 13 12 11 10
10 11 12 13 14 15 16 17 18
2
4 5 6 7
9 10 11 12
2
7
IE5
IE6
IE7
Yellow
4 5
6 7 8 9 10 11 12 13
1 2 3
5 4
3 2 1
1 2
13 12 11 10 9 8 7 6
3 4
IE8
9 10 11 12 13 14
14 13 12 11 10 9
-3-
http://vnx.su
1
6
12 11 10 9
http://vnx.su
Floor Wire
Front Door
LH Wire
Engine Room
Main Wire
Roof Wire
* 1:1AZ-FE
* 2:Except 1AZ-FE
* 3:Manual A/C
* 4:Automatic A/C
Switch
Wire
IF1
IK2
IK1
-1-
IH2
Instrument
Panel Wire
(*1)
(*2)
Floor No.3 Floor
IG1
IG2
Wire
Wire
A/C Sub
Wire No.1
IH1
IJ2
(*4)
IN1
IL2
IM2
IL1
Front Door
RH Wire
IM1
A/C Sub
Wire No.2
Engine Wire
II1
Floor No.2 Wire
Floor No.2 Wire
Instrument Panel
No.3 Wire
IJ1
(*3)
IF1
IG1
IG2
Black
Black
Black
2 1
4 3
1 2
3 4
IH1
IH2
II1
Gray
3 4
IJ1
IJ2
Black
Black
2 1
4 3
1 2
IK1
3
7
IK2
4
4 3
9 10
2 1
8
10 9
6 5
22 21 20 19 18 17 16 15 14 13 12
12 13 14 15 16 17 18 19 20 21 22
IL2
10 11 12 13 14 15 16 17
11 10 9
9 10 11
IL1
2 1
9 10 11
12 13 14 15 16 17 18 19 20 21 22
17 16 15 14 13 12 11 10
-2-
http://vnx.su
11 10 9
22 21 20 19 18 17 16 15 14 13 12
IM1
10 11 12 13 14 15 16 17 18
IM2
18 17 16 15 14 13 12 11 10
10 11 12 13 14 15 16 17 18
IN1
Yellow
2 1
1
-3-
http://vnx.su
18 17 16 15 14 13 12 11 10
http://vnx.su
IJ
-1-
IN
IL
Ground Points in Instrument Panel <RHD>
IM
IP
IK
http://vnx.su
A36
A15
A14
A35
B5
B6
B4
C8
A24
A29
* 1:Manual A/C
* 2:Automatic A/C
(Except 2AD-FHV, 2AD-FTV)
* 3:Automatic A/C (2AD-FHV, 2AD-FTV)
* 4:2AD-FHV w/o HID
* 5:2AD-FHV w/ HID
* 6:Automatic A/C
(*3)
(*2)
(*1)
(*2)
(*1)
A26
A21
C7
A19
A27
A31
-1-
A28
A22
(*1)
A13
(*1)
(*4)
A17
A34
A23
(*6)
(*3)
A37
A25
Position of Parts in Instrument Panel <RHD>
(*2)
A16
A18
(*5)
A34
C10
A30
C11
A20
C13
C14
C12
C9
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
B
B
B
C
C
C
C
C
C
C
C
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
34
35
36

A/C Solar Sensor
A/C Thermistor
Antenna Amplifier
Air Fuel Ratio Sensor Relay
4 Blower Motor
5 Blower Motor Controller
6 Blower Resistor
7
8
9
10
11
12
13
14
Cigarette Lighter , Cigarette Lighter Illumination

Clutch Start SW
Combination Meter
Combination Meter
Combination SW
Combination SW
Combination SW
-2-
http://vnx.su
A 13
A 14
A 15
9 10 11 12 13 14 15 16 17 18 19 20
21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40
A 16
A 17
A 18
Black
Black
1 2
1
9 10
11 12 13 14 15 16 17 18 19 20
A 19
A 20
Black
1 2
9 10 11 12
13 14 15 16 17 18 19 20 21 22 23 24
A 21
A 22
A 23
A 24
A 25
Black
Black
Black
Black
Black
A 28
A 29
Yellow
Yellow
1 2 3
3 4
4 5 6
1 2
3 4
13 14 15 16 17 18 19 20
18 19 20 21 22 23 24 25 26 27 28
13 14 15 16 17 18 19 20
A 30
A 31
A 34
Yellow
A 35
A 36
B 4
1 X 2
B 5
B 6
C 7
Black
Black
Black
Gray
A 27
5 6 7 8 9 10 11 12
Yellow
7 8 9 10 11 12 13 14 15 16 17
A 26
5 6 7 8 9 10 11 12
Yellow
1 2
C 8
C 9
4
1
1 2
3 4
1 X 2
-3-
http://vnx.su
C 10
C 11
C 12
Blue
9 10 11
12 13 14 15 16 17 18 19 20 21 22
10 11 12 13 14 15 16 17 18
C 13
C 14
Black
4 5 6
10 11 12 13 14 15 16 17 18
9 10 11 12
-4-
http://vnx.su
10 11 12 13 14 15 16 17
4 5 6
http://vnx.su
H17
H13
E8
F19
I12
I13
I11
E15
E14
E13
I14
E12
E11
(*12)
(*11)
-1-
(*7)
(*8)
D5
H14
H16
H15

* 9:w/ Headlight Beam
Level Control w/o HID
* 10:w/ Headlight Cleaner
* 11:1ZZ-FE, 3ZZ-FE w/ HID
* 12:1ZZ-FE, 3ZZ-FE w/o HID
(*10)
H18
D3
E10
H17
D2
(*9)
G3
E9
D6
D4
D
D
D
D
D
D
2
3
4
4
5
6
E
E
E
E
E
E
E
E
8
9
10
11
12
13
14
15
Diode
Diode
Diode (Fan) (Except 1CD-FTV)
Diode (Fan) (1CD-FTV)
DLC3
EPS ECU
EPS ECU
F 19 Front Passenger's Seat Belt Warning Light , Rear Window Defogger SW , Security Indicator Light
G
3 Glove Box Light
H
H
H
H
H
H
H
13
14
15
16
17
17
18
Hazard SW
Heated Oxygen Sensor (Bank 1 Sensor 2) (w/o HID)
Heated Oxygen Sensor (Bank 1 Sensor 2) (w/ HID)
I
I
I
I
11
12
13
14

Ignition Key Cylinder Light , Transponder Key Amplifier
Ignition SW
Integration Relay
-2-
http://vnx.su
D 2
D 3
D 4
D 4
Black
(Except 1CD-FTV)
(1CD-FTV)
D 5
16 15 14 13 12 11 10 9
8
D 6
E 8
E 9
E 10
Black
1
8
9 10 11 12 13 14 15 16 17
9 10 11 12 13 14 15 16
18 19 20 21 22 23
24 25
17 18 19 20 21 22 23 24 25 26 27
26 27
30 31
28 29 30
E 11
28 29
E 12
31 32 33 34 35
E 13
E 14
Gray
1
8
9 10 11 12 13 14 15 16 17
9 10 11 12 13 14 15 16 17 18 19
18 19 20 21 22 23 24 25 26 27
20 21 22 23
24 25
26 27
18 19 20 21 22 23 24 25 26 27
28 29
28 29 30 31
32 33
34 35
28 29 30 31 32
30
31 32
E 15
F 19
9 10 11 12
H 14
G 3
H 13
Black
H 15
3
7
33 34
Black
1
1
9 10 11 12 13 14 15 16 17
9 10
H 16
H 17
H 17
Black
Gray (w/o HID)
Gray (w/ HID)
1 2 3 4
1 2 3 4 5
1
2 1
4 3
9 10 11 12
13 14 15 16 17 18 19 20 21 22 23 24
-3-
http://vnx.su
H 18
I 11
I 12
Black
Black
Black
I 14
9 10 11
12 13 14 15 16 17 18 19 20 21 22
-4-
http://vnx.su
I 13
http://vnx.su
J12
J13
J27
J28
J4
J3
J26
M3
M3
(*14) (*13)
-1-
J17
M2
J16
M1
J22
J19
J29
J20
J21

J23
K3
J25
J24
J15
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
3
4
12
13
15
16
17
19
20
21
22
23
24
25
26
27
28
29
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
Junction Connector
3 Knee Airbag Squib
M
M
M
M
M
1
1
2
2
3

Multi-Display
-2-
http://vnx.su
J 3
J 4
9 10 11 12
9 10 11 12
9 10 11 12
9 10 11 12
J 16
1
3
J 13
J 15
J 12
J 17
1 2 3
6 7 8 9 10 11 12 13
4 5
J 19
1 2 3
4 5
1
6 7 8 9 10 11 12 13
9 10 11
12 13 14 15 16 17 18 19 20 21 22
J 20
J 21
9 10 11
12 13 14 15 16 17 18 19 20 21 22
J 24
J 22
9 10 11
12 13 14 15 16 17 18 19 20 21 22
9 10 11 12
9 10 11 12
J 25
9 10 11 12
9 10 11 12
4 5
2
9 10 11
9 10 11
M 1
10 11 12 13 14 15 16 17 18
M 2
M 2
20 21 22 23 24 25
14 15 16 17 18 19
K 3
M 1
3 4 5 6 7 8 9 10 11 12 13
Yellow
9 10 11
12 13 14 15 16 17 18 19 20 21 22
12 13 14 15 16 17 18 19 20 21 22
J 27
J 29
12 13 14 15 16 17 18 19 20 21 22
J 28
1 2 3
J 26
6 7 8 9 10 11 12 13
J 23
M 3
9 10
-3-
http://vnx.su
http://vnx.su
P6
N5
N4
N3
P7
T21
S21
S20
R8
R9
Y1
N6
R11
T20
P4
R4
S9
R5
-1-
T7
R6
Z2
R7
Z1
T8
U1
V7
S12
S13
W2
T6
R10
P5
T9
T10
N
N
N
N
3
4
5
6
Navigation ECU
Navigation ECU
Navigation ECU
P
P
P
P
P
4
5
5
6
7
Parking Brake SW
Power Heater SW (Power Heater (Combustion Type))
Power Heater SW (Power Heater (Hot Gas Type))
Power Outlet
PTC Heater

R 8 Rear Fog Light Relay
R 9 Rear Window Defogger Relay
R 10 Remote Control Mirror SW
R 11 Remote Controller (Navigation)
S
S
S
S
S
S
9
12
13
13
20
21

Steering Sensor
Stop Light SW (LHD 1AZ-FE)
Stop Light SW (Except LHD 1AZ-FE)
Short Connector
Short Connector
T 6 Theft Deterrent ECU

T 7 Transmission Control SW
T 8 Transponder Key Computer
T 9 TRC Off SW
T 10 Turn Signal Flasher Relay
T 20 Tire Pressure Monitor ECU
T 21 Tire Pressure Warning SW
U
1 Unlock Warning SW
7 VSC Warning Buzzer
W 2 Wiper Relay
Y
1 Yaw Rate Sensor
Z
Z

-2-
http://vnx.su
N 3
N 4
N 5
N 6
P 4
Black
10 11 12 13 14 15 16 17 18
9 10
P 5
P 5
P 6
Gray (Power Heater (Combustion Type))
(Power Heater (Hot Gas Type))
Black
1
3
R 5
1
3
P 7
R 4
2
4
R 6
R 7
R 8
9 10
1 X 2
1 X 2
9 10 11 12
9 10
11 12 13 14 15 16 17 18 19 20
R 11
S 9
S 12
5
1
S 13
S 13
Black (LHD 1AZ-FE)
(Except LHD 1AZ-FE)
1
4
S 20
1
4
2
5
9 10 11 12
3
6
4
7
S 21
16 15 14 13 12 11 10 9
9 10 11 12 13 14 15 16
T 6
1 2 3 4 5 6 7 8 9 10
R 9
Black
R 10
T 7
T 8
9 10 11 12 13 14 15 16 17 18 19 20
21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40
-3-
http://vnx.su
9 10 11 12 13 14
T 9
T 10
Black
Black
3
7
T 20
T 21
1 2
3
4 5 6 7 8
9 10
9 10 11 12 13 14 15 16
V 7
W 2
Y 1
Black
Black
Black
1
1
2
1
10 11 12 13 14 15
16
17
18 19 20 21 22 23
24
Z 1
Z 2
18 17 16 15 14 13 12 11 10
U 1
Black
10 11 12 13 14 15 16 17 18
-4-
http://vnx.su
4
3
http://vnx.su
Floor Wire
IC3
IA2
IC2
IA1
IC1
Front Door
LH Wire
IH1
-1-
Floor No.2 Wire
Front Door
RH Wire
Floor No.3 Wire
Cowl Wire
A/C Sub
Wire No.3
Instrument
Panel Wire
A/C Sub
Wire No.1
IE2
IH2
Engine Wire A/C Sub

Wire No.2
Floor No.2
Floor Wire Wire
Engine Room
Main Wire
IF1
Instrument Panel
No.3 Wire
ID1
IE1
IB1
Roof Wire
Wire and Wire in Instrument Panel <RHD>
IA1
IA2
2
6
3
7
4
4 3
9 10
2 1
8
10 11 12 13 14 15 16 17 18
6 5
18 17 16 15 14 13 12 11 10
2 3 4 5 6 7 8 9 10
11 12 13 14 15 16 17 18 19 20
10 9 8 7 6 5 4 3 2
20 19 18 17 16 15 14 13 12 11
IE1
9 10 11
12 13 14 15 16 17 18 19 20 21 22
11 10 9
3
7
9 10
4 3
10 9
ID1
IC3
10 11 12 13 14 15 16 17 18
18 17 16 15 14 13 12 11 10
IC2
IC1
10 9
22 21 20 19 18 17 16 15 14 13 12
-2-
http://vnx.su
22 21 20 19 18 17 16 15 14 13 12
12 13 14 15 16 17 18 19 20 21 22
IB1
17 16 15 14 13 12 11 10
10 11 12 13 14 15 16 17
11 10 9
9 10 11
2 1
8
6 5
IE2
IF1
Black
10 11 12 13 14 15 16 17 18
1 2
18 17 16 15 14 13 12 11 10
3 4
IH1
IH2
Gray
1 2
3 4
2 1
4 3
-3-
http://vnx.su
2 1
4 3
http://vnx.su
Floor Wire
Floor Wire
Engine Wire
Front Door
LH Wire
IP1
IO2
IO3
IO1
Roof Wire
Instrument Panel
No.3 Wire
* 1:Manual A/C
* 2:Automatic A/C
II1
IK1
Engine Room
Main Wire
-1-
Floor No.2
Wire
IK2
IQ1
Floor No.3 Floor No.2

Wire
Wire
A/C Sub A/C Sub

IJ1
IJ2
Wire No.2 Wire No.3
(*1)
(*2)
IN1
Front Door
RH Wire
IL2
IM2
IM1
IL1
IR1
Cowl Wire
A/C Sub
Wire No.1
Instrument
Panel Wire
II1
2 1
IJ1
IJ2
Black
Black
IK1
3
7
4 3
2 1
8
10 9
11 10 9
9 10 11
11 10 9
9 10 11
IM2
18 17 16 15 14 13 12 11 10
IN1
IO1
2 1
1
3
8
2
4 5 6 7
9 10 11 12
10 11 12 13 14 15 16 17 18
Yellow
17 16 15 14 13 12 11 10
10 11 12 13 14 15 16 17 18
22 21 20 19 18 17 16 15 14 13 12
12 13 14 15 16 17 18 19 20 21 22
IM1
IL2
10 11 12 13 14 15 16 17
22 21 20 19 18 17 16 15 14 13 12
12 13 14 15 16 17 18 19 20 21 22
6 5
IL1
IK2
9 10
2
7
1
6
12 11 10 9
-2-
http://vnx.su
18 17 16 15 14 13 12 11 10
IO2
IO3
Yellow
1 2 3
4 5
6 7 8 9 10 11 12 13
5 4
3 2 1
1 2
13 12 11 10 9 8 7 6
3 4
IP1
IQ1
IR1
Black
3 4
5 6
2
6 5
4 3
-3-
http://vnx.su
http://vnx.su
P18
S18
B9
J36
S16
J35
S18
P22
P23
(*1)
(*2)
(*2)
* 1:w/ Power Seat

* 2:w/o Power Seat
L7
P20
(*1)
S16
P21
-1-
L6
P25
S19
(*2)
(*1)
J37
S17
S17
(*2)
Position of Parts in Seat <LHD>
J38
(*1)
P19
P24
S19
B10
B 9 Buckle SW (Driver's Side)

B 10 Buckle SW (Front Passenger's Side) , Occupant Detection Sensor
J
J
J
J
L
L
35
36
37
38
Junction Connector
Junction Connector
Junction Connector
Junction Connector
6 Lumbar Support Control Motor

7 Lumbar Support Control SW
P
P
P
P
P
P
P
19
20
21
22
23
24
25
Power Seat Control SW (Front Passenger's Seat)

Power Seat Motor (Driver's Seat Front Vertical Control)
Power Seat Motor (Driver's Seat Lifter Control)
Power Seat Motor (Driver's Seat Reclining Control)
Power Seat Motor (Driver's Seat Slide Control)
Power Seat Motor (Front Passenger's Seat Reclining Control)
Power Seat Motor (Front Passenger's Seat Slide Control)
S
S
S
S
S
S
16
16
17
17
18
19
Seat Heater LH (w/ Power Seat)

Seat Heater LH (w/o Power Seat)
Seat Heater RH (w/ Power Seat)
Seat Heater RH (w/o Power Seat)
-2-
http://vnx.su
B 9
B 10
J 35
J 36
J 37
Gray
2
4
1
3
1 2
3 4
9 10 11 12
9 10 11 12
9 10 11 12
J 38
L 6
L 7
P 19
P 20
Black
9 10 11 12
P 21
1 2 3 4 5
P 22
P 23
Black
P 24
Blue
3
7
9 10
P 25
S 16
Blue
Gray (w/ Power Seat)
S 16
S 17
S 17
S 18
S 19
Gray (w/ Power Seat)
(w/o Power Seat)
Yellow
Yellow
1
3
-3-
http://vnx.su
(w/o Power Seat)
http://vnx.su
Floor Wire
-1-
Front Seat LH Wire
Floor No.2 Wire
Wire and Wire in Seat <LHD>
Front Seat RH Wire
http://vnx.su
P19
S18
B10
J36
J35
S18
P24
P25
(*1)
(*2)
* 1:w/ Power Seat

* 2:w/o Power Seat
-1-
P23
P21
S19
(*2)
B9
J37
Position of Parts in Seat <RHD>
(*1)
S19
J38
P20
L6
P18
L7
P22
B 9 Buckle SW (Driver's Side)

B 10 Buckle SW (Front Passenger's Side) , Occupant Detection Sensor
J
J
J
J
L
L
P
P
P
P
P
P
P
35
36
37
38
Junction Connector
Junction Connector
Junction Connector
Junction Connector
6 Lumbar Support Control Motor

7 Lumbar Support Control SW
18
19
20
21
22
23
24
Power Seat Control SW (Driver's Seat)

Power Seat Control SW (Front Passenger's Seat)
Power Seat Motor (Driver's Seat Front Vertical Control)
Power Seat Motor (Driver's Seat Lifter Control)
Power Seat Motor (Driver's Seat Reclining Control)
Power Seat Motor (Driver's Seat Slide Control)
Power Seat Motor (Front Passenger's Seat Reclining Control)
S 18 Side Airbag Squib LH

S 19 Side Airbag Squib RH
-2-
http://vnx.su
B 9
B 10
J 35
J 36
J 37
Gray
2
4
1
3
1 2
3 4
9 10 11 12
9 10 11 12
9 10 11 12
J 38
9 10 11 12
P 20
L 6
P 21
L 7
1 2 3 4 5
P 22
Black
P 23
-3-
http://vnx.su
P 18
P 19
Black
Black
3
7
P 24
Blue
9 10
3
7
9 10
S 18
S 19
Yellow
Yellow
http://vnx.su
Floor Wire
-1-
Front Seat LH Wire
Floor No.2 Wire
Wire and Wire in Seat <RHD>
Front Seat RH Wire
F CONNECTOR LIST
A1
A2
A3
Gray
Black
Black
1 2
A4
1 2 3
1
A5
A6
A7
A8
A9
A10
Black
Gray
Gray
Yellow
Yellow
1 2
3 4
1 2 3 4 5
A11
A12
A12
Black
(1CDFTV)
(Except 1CDFTV)
1
A13
A14
1
4
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40
A16
A17
A18
Black
Black
12
1 2 3
2
5
A15
3
6
1 2 3 4 5 6 7 8 9 10
11 12 13 14 15 16 17 18 19 20
A19
A20
Black
12
1 2 3 4 5 6 7 8 9 10 11 12
1
4
2
5
3
6
13 14 15 16 17 18 19 20 21 22 23 24
A21
A22
A23
A24
A25
Black
Black
Black
Black
Black
1 2 3 4 5
1 2 3 4 5
1 2 3 4 5
1 2 3 4 5
1 2 3
98
AVENSIS (EWD625E)
http://vnx.su
F
*1 : 2ADFHV, 2ADFTV
*2 : Except 2ADFHV, 2ADFTV
A26
A27
A28
A29
Yellow
Yellow
Yellow
Yellow
A B
1 2
3 4
A B
1 2 3
4 5 6
A B
1 2
1 2 3 4
3 4
5 6 7 8 9 101112
7 8 9 1011121314151617
5 6 7 8 9 101112
13 1415 16 171819 20
1819 2021 22 23 2425 26 27 28
13 1415 16 171819 20
A30
A31
A32
A33
A34
Yellow
A35
Gray
2 1
1 2 3 4
A36
2 1
1
3
A37
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40
1 2 3 4
5 6 7 8
B3
B4
Black
3
5
2
4
1 X 2
B1
B2
Gray
Black
1 2 3
B5
B6
B7
B7
Black
Black
(L/B)
(W/G) Blue
1 2
3 4
1 2
3 4
1 2
B8
B9
B10
Gray
1 2
3 4
1 2
3 4
2 1
B11
B12
Black
Black
1 2 3
C1
C2
C3
C3
Black
Black
(*1) Black
(*2) Gray
1 2
1 2
C4
1
1
99
AVENSIS (EWD625E)
http://vnx.su
F CONNECTOR LIST
*1 : 2ADFHV, 2ADFTV
*3 : 2AZFSE, 1AZFSE, 1AZFE, 1ZZFE, 3ZZFE
C5
C6
C6
C6
C7
Black
(1CDFTV) Black
(*1) Gray
(*3) Gray
Black
1 2
1 2
3 4
C8
2
3
C9
C10
C11
Blue
3
5
1 2
1 X 2
C12
1 2 3 4 5 6 7 8 9
1 2 3 4 5 6 7 8 9 10 11
10 11 12 13 14 15 16 17 18
12 13 14 15 16 17 18 19 20 21 22
C13
C14
C15
Yellow
Black
4 5 6 7
1 2
1 2 3 4 5 6 7 8 9
1 2 3 4 5 6
9 10 1112131415 16 17
10 11 12 131415 16 17 18
7 8 9 10 11 12
C16
C17
C18
D1
Yellow
Black
Black
Black
1 2
1 2
D4
D4
(Except 1CDFTV)
1 2 3
1 2
2
5
D3
Black
1 2 3
1
4
1 2
(1CDFTV)
D2
1 2
3
6
D5
D6
D7
1
1 2 3 4 5
16 15 14 13 12 11 10 9
8 7 6 5 4 3 2 1
100
AVENSIS (EWD625E)
http://vnx.su
F
*1 : 2ADFHV, 2ADFTV
*6 : 2AZFSE, 1AZFSE
*4 : 2AZFSE, 1AZFSE, 1ZZFE, 3ZZFE *7 : 1CDFTV, 2ADFHV, 2ADFTV

*5 : 1CDFTV, 2ADFTV
D8
D9
D10
D11
D12
D13
5 6 7 8 9 10
D14
D15
5 6 7 8 9 10
D16
5 6 7 8 9 10
D17
4
1 2 3 4 5 6 7 8 9 10 11 12
5 6 7 8 9 10
13 14 15 16 17 18 19 20 21 22 23 24
D18
D19
5 6 7 8 9 10
D20
5 6 7 8 9 10
D21
5 6 7 8 9 10
5 6 7 8 9 10
D22
E1
E1
E2
Black
(2AZFSE) Gray
(1AZFE) Gray
1 2
1 2 3
1 2 3
4 5 6
7 8 9 10 11 12 13
9 10
E2
E2
E2
E3
E4
(1CDFTV) Gray
(*1) Gray
(*4) Gray
Black
Black
1 2
1 2
1
4
1
2
2
5
3
6
5 6 7 8
E5
E5
E6
E7
E7
(*5) Dark Gray
(*6) Black
Black
(*7) Gray
(2AZFSE) Gray
1 2
1 2
1 2
3
1 2 3 4 5
1 2 3 4
101
AVENSIS (EWD625E)
http://vnx.su
F CONNECTOR LIST
E8
E9
E10
Black
1 2 3 4
8 9 10 11 12 13 14 15 16 17
7 8 9 10 11 12 13 14 15 16
18 19 20 21 22 23
24 25
17 18 19 20 21 22 23 24 25 26 27
26 27
30 31
28 29 30
28 29
E11
31 32 33 34 35
E12
E13
E14
Gray
8 9 10 11 12 13 14 15 16 17
8 9 10 11 12 13 14 15 16 17 18 19
8 9 10 11 12 13 14 15 16 17
18 19 20 21 22 23 24 25 26 27
20 21 22 23
24 25
26 27
18 19 20 21 22 23 24 25 26 27
28 29
28 29 30 31
32 33
34 35
28 29 30 31 32
30
31 32
E15
33 34
E16
E18
E19
E20
Black
Black
Gray
Dark Gray
1 2 3 4 5
1 2
1 2
1 2 3 4 5 6
7 8 9 10 11 12
E21
E22
E23
F1
F2
Gray
Black
Black
Black
Black
1
4
2
5
1 2 3 4 5 6
7 8 9 101112
3
6
F3
F4
F5
F6
Brown
Brown
Gray
Gray
1 2
1 2
F9
F10
F7
F8
1 2
3 4
1 2
3 4
F11
F12
F13
Black
Black
Gray
2 1
1 2
3 4
1 2
3 4
1 2
1 2 3
4 5
102
AVENSIS (EWD625E)
http://vnx.su
F
*6 : 2AZFSE, 1AZFSE
*8 : 1CDFTV, 2ADFHV
F14
F15
F16
F16
F17
Gray
Gray
(*8) Black
(*6) Gray
Black
1
1
F18
F19
Gray
1 2
F20
F21
F22
F23
Black
Black
Black
Black
1
2
1
2
1
1 2 3 4 5 6 7 8
F24
1 2
1 2
3
3 4 5 6
F25
F26
F28
Gray
Dark Gray
Black
G1
1
1
1 2 3 4
2
4
1 2
1 2 3
G2
G3
H1
H2
H3
Gray
Black
Gray
Gray
Black
H4
H5
H6
Black
1
2
1 2
H7
H7
H8
(1ZZFE, 3ZZFE) Gray
(*6) Gray
Black
1
3
1 2
3 4
H9
H10
H11
H12
H13
Gray
Black
Black
Black
Black
1
1 2
3 4
1 2
5 6 7 8 9 10
3 4
103
AVENSIS (EWD625E)
http://vnx.su
F CONNECTOR LIST
*6 : 2AZFSE, 1AZFSE
*9 : 1AZFE, 1ZZFE, 3ZZFE, 1CDFTV
H14
H15
H16
H17
H17
Black
(w/ HID) Gray
(w/o HID) Gray
1234
1 2 3 4 5
1
3
1 2 3 4 5 6 7 8 9 10 11 12
2 1
4 3
2
4
13 14 15 16 17 18 19 20 21 22 23 24
H18
H19
H20
H20
H20
I1
Black
Black
(L/B)
(S/D) Gray
(W/G) Black
Black
12
1
1 2 3 4
2 1
I2
I3
I4
I5
I5
Gray
Black
Gray
(*9) Black
(2ADFHV) Black
1 2 3 4
1 2 3 4
1 2 3 4
1 2
1
I5
I5
I6
I6
I6
(2ADFTV) Black
(*6) Black
(*9) Gray
(2ADFHV) Gray
(2ADFTV) Gray
1 2
1 2
1
1 2
1
I6
I7
I7
I7
I7
(*6) Gray
(*9) Black
(2ADFHV) Black
(2ADFTV) Black
(*6) Black
1 2
1
1 2
I8
I8
I8
I8
I9
(*9) Gray
(2ADFHV) Gray
(2ADFTV) Gray
(*6) Gray
Gray
1 2
1 2
1
104
AVENSIS (EWD625E)
http://vnx.su
F
I10
I11
I12
Black
Black
Black
I13
1 2 3
1
2 3 4 5 6
I14
I15
2 3 4 5 6
1
4
I16
3
6
I17
Black
Black
1 2 3 4 5 6 7
1 2 3 4 5 6 7 8 9 10 11
2
5
1 2 3 4
1 2 3
12 13 14 15 16 17 18 19 20 21 22
I18
J1
J2
Black
Gray
Black
A A B
CC
A A B B B CC
A A A
B B
CCCDD DB
1 2 3
J3
J4
A A B B C C
A A B B C C
D D D E E E
D D D E E E
J5
J6
J7
A B B
C C
A A B D D D C C
J8
J9
J10
Black
Black
Gray
J11
J12
J13
J14
A A B B C C
A A B B C C
A B B
C C
A A B DD D C C
D D D E E E
D D D E E E
Gray
105
AVENSIS (EWD625E)
http://vnx.su
F CONNECTOR LIST
J15
A
A
A
A
J16
J17
J18
A A A
A A
A A A A A A A A
A A A
A A
A A A A A A A A
J19
J20
J21
J22
J23
J24
J25
A A B B C C
A A B B C C
A A B B C C
A A B B C C
D D E E F F
D D E E F F
D D E E F F
D D E E F F
J26
J27
J28
A B B
C C
A A B D D D C C
J29
J30
J31
J32
A A A B B B C C C C C
A A A A A A
A A A A A A
A B B
C C
A A B DD D C C
D D D D E E E E E E E
B B B C C C
B B B C C C
J33
J34
J35
J36
A A A A A A
A A A A A A
A A B C D E
A B C D E E
B B B C C C
B B B C C C
F G H H H H
F F F F G H
106
AVENSIS (EWD625E)
http://vnx.su
F
*10 : w/ Navigation System (Map Type)
*11 : w/o Navigation System (Map Type)
J37
J38
K1
K2
K3
Black
Black
Yellow
1 2
A A B C D E
A B C D E E
F G H H H H
F F F F G H
1
1
L1
L2
L3
Black
Black
Black
1 2
1 2
L4
L5
L6
1 2 3
1 2
2 1
L7
1 2 3 4 5
M1
M1
M2
(*10)
(*11)
(*10)
1 2 3 4 5 6 7 8 9 101112 13
1 2 3 4 5 6 7 8 9
1 2 3 4 5
10 11 12 13 14 15 16 17 18
6 7 8 9 10
14 15 16171819
M2
M3
2021222324 25
M4
M5
M6
Gray
(*11)
1 2 3
4 5 6
2 1
2 1
3 7 6
3 7 6
5 4
1 2 3 4 5
5 4
6 7 8 9 10
M7
1 2
3 4
N1
N2
Gray
Gray
1 2
1
6
3
7
4
8
N3
1 2 3 4 5 6 7 8 9
10 11 12 13 14 15 16 17 18
107
AVENSIS (EWD625E)
http://vnx.su
F CONNECTOR LIST
*12 : Power Heater (Combustion Type)
*13 : Power Heater (Hot Gas Type)
N4
N5
N6
N7
N8
O1
Black
1 2 3 4 5
1 2
1 2 3 4
5 6 7 8
6 7 8 9 10
1 2
1 2
O2
P1
P2
P3
P4
P5
Gray
Black
Black
Gray
Black
(*12) Gray
12
3 4 5 6
1 2 3 4
5 6 7 8
P5
P6
(*13)
Black
P7
P8
P9
P10
1 2 3 4
1 2 3 4
5 6 7 8
5 6 7 8
1
2
1 2 3 4
3 4 5 6
P11
1 2 3 4
P12
P13
P14
P15
Gray
Gray
Gray
Gray
1 2 3
4 5 6
1 2 3
4 5 6
1 2 3
4 5 6
1 2 3
4 5 6
5 6 7 8
P16
P17
P18
P19
Yellow
Yellow
Black
Black
P21
P22
Black
1 2
1 2
3 4
5 6 7 8 9 10
P23
P24
Blue
1 2
1 2
1 2
1 2
P20
3 4
5 6 7 8 9 10
1 2
P25
P26
Blue
Black
1 2
1 2 3
108
AVENSIS (EWD625E)
http://vnx.su
F
R1
R2
R3
Gray
Black
Red
R4
1 2
2
R6
1 2 3 4 5 6 7 8 9 10
7 8 9 10 11 12
11 12 13 14 15 16 17 18 19 20
R11
R9
3
5
3
5
1 X 2
1 X 2
R12
R13
Black
(Except W/G) Black
3 2 1
1 2 3 4 5
1 2 3 4 5 6 7
1 2 3 4 5 6 7 8 9 10
R13
R14
R14
R15
R16
(W/G)
(Except W/G) Black
(W/G)
Black
Black
1 2 3 4 5 6
1
2
1
2
1 2 3 4 5 6
1 2 3 4 5 6 7
R17
R18
R18
R19
R19
R19
R20
(L/B)
(S/D, W/G)
(L/B)
(S/D)
(W/G)
Black
1 2 3
1
1
R21
S1
Black
Black
1
3
3 4 5 6
R8
1 2 3 4 5 6
R7
R10
3 4
5 6 7 8 9 10
1 2
1
R5
2
4
1 2 3 4
10
11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26
27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42
109
AVENSIS (EWD625E)
http://vnx.su
F CONNECTOR LIST
*1 : 2ADFHV, 2ADFTV
*14 : 2AZFSE, 1AZFSE, 1AZFE
*15 : Except LHD 1AZFE
S2
S3
S4
Black
Gray
Black
*16 : w/ Curtain Shield Airbag

*17 : w/o Curtain Shield Airbag
5 6 7 8 9 10 11 12 13 14 15
16 17 18 19 20 21 22 23 24 25 26
S5
S5
S5
S5
S6
(1CDFTV)
(1ZZFE, 3ZZFE)
(*1)
(*14)
Gray
S7
S8
Black
Black
S9
S10
S11
Black
Black
12
1 2 3 4 5
2
1
6 5 43
3 4 5 6
1 2 3 4 5 6
12
7 8 9 10 11 12
S12
S13
S13
S14
Black
(*15)
(LHD 1AZFE) Black
(*16) Yellow
1 2 3 4
5 6 7
1
3
2
4
1 2 3 4
S14
S15
S15
S16
S16
(*17) Yellow
(*16) Yellow
(*17) Yellow
(w/o Power Seat)
1 2
1 2 3 4
1 2
110
AVENSIS (EWD625E)
http://vnx.su
3 4 5 6
1 2 3 4
F
S17
S17
S18
S19
(w/o Power Seat)
Yellow
Yellow
1 2 3 4
1 2
1 2
3 4 5 6
S20
1 2 3 4 5 6 7 8
9 10 11 12 13 14 15 16
S21
T1
T2
T3
Black
Black
Gray
1 2 3
1 2 3 4 5 6
8 7 6 5 4 3 2 1
16 15 14 13 12 11 10 9
T4
T5
Black
Black
1 2 3
T8
T7
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40
1 2 3 4
5 6 7 8
T9
T10
Black
Black
1 2
1 2 3 4 5 6 7
T6
3 4
T11
T12
1 2 3 4 5
1 2 3 4
5 6 7 8
12
3
456 7 8
5 6 7 8 9 10
8 9 10 11 12 13 14
T13
12
T14
T15
Black
Black
12
T18
T19
1 2 3 4
1 2 3 4
T16
T17
1 2 3 4
1 2 3 4
T20
1 2 3 4 5 6 7 8
T21
T22
1 2
1 2 3 4 5
9 10 11 12 13 14 15 16
111
AVENSIS (EWD625E)
http://vnx.su
F CONNECTOR LIST
*1 : 2ADFHV, 2ADFTV
U1
V1
V2
V3
V4
V4
Black
Black
Black
Black
(1CDFTV) Black
(*1) Black
1 2
1 2 3
1 2
1 2
3
V5
V6
V7
Blue
Brown
Black
V10
1 2
V8
V9
12
12
W1
W2
Black
Black
1 2
1 2
9 10 11 12 13 14 15 16
17 18 19 20 21 22 23 24
Y1
Z1
Z2
9 8 7 6 5 4 3 2 1
1 2 3 4 5 6 7 8 9
18 17 16 15 14 13 12 11 10
10 11 12 13 14 15 16 17 18
Black
1
2
4
3
112
AVENSIS (EWD625E)
http://vnx.su
1 2
Memo
113
AVENSIS (EWD625E)
http://vnx.su
F CONNECTOR LIST
EA1
(Gasoline)
(Diesel)
1 2 3
4 5
6 7 8 9 10 11 12 13
(1ZZFE, 3ZZFE)
EB1
ED1
5 4
3 2 1
13 12 11 10 9 8 7 6
Gray
(1CDFTV)
2 1
1 2 3
4 5 6
EB1
EA1
Gray
EC1
Black
3 2 1
6 5 4
1 2 3 4 5
6 7 8 9 10
1 2 3 4 5 6 7 8 9 10 11
11 10 9 8 7 6 5 4 3 2 1
12 13 14 15 16 17 18 19 20 21 22
22 21 20 19 18 17 16 15 14 13 12
1716151413121110
5 6
IC1
3 4
8
9 10
5 4 3 2 1
10 9 8 7 6
IB1
IA2
1011121314151617
1 2
Gray
EE1
Black
IA1
4 3
10 9
2 1
8
6 5
1 2 3 4 5 6 7 8 9
9 8 7 6 5 4 3 2 1
10 11 12 13 14 15 16 17 18
18 17 16 15 14 13 12 11 10
114
AVENSIS (EWD625E)
http://vnx.su
F
IC2
IC3
1 2 3 4 5 6 7 8 9
9 8 7 6 5 4 3 2 1
10 11 12 13 14 15 16 17 18
18 17 16 15 14 13 12 11 10
1 2
5 6
3 4
7
4 3
9 10
2 1
8
10 9
6 5
ID1
1 2 3 4 5 6 7 8 9 10
11 1213141516171819 20
10 9 8 7 6 5 4 3 2 1
20 1918171615141312 11
IE1
1 2 3 4 5 6 7 8 9 10 11
11 10 9 8 7 6 5 4 3 2 1
12 13 14 15 16 17 18 19 20 21 22
22 21 20 19 18 17 16 15 14 13 12
IE2
IE3
1 2 3 4 5 6 7 8 9
9 8 7 6 5 4 3 2 1
10 11 12 13 14 15 16 17 18
18 17 16 15 14 13 12 11 10
IE4
1
3
2
4
1
2
3 4 5 6 7
8 9 10 11 12
7 6 5 4 3
12 11 10 9 8
IE5
2 1
4 3
115
AVENSIS (EWD625E)
http://vnx.su
F CONNECTOR LIST
IE6
IE7
Yellow
2 1
1 2 3
4 5
6 7 8 9 10 11 12 13
5 4
3 2 1
13 12 11 10 9 8 7 6
3 4
IE8
IF1
1 2 3 4 5 6 7
7 6 5 4 3 2 1
8 9 10 11 12 13 14
14 13 12 11 10 9 8
IG2
IG1
Black
2 1
4 3
1 2
3 4
5 6 7 8
1 2 3 4 5
II1
IJ1
2 1
5 4 3 2 1
IJ2
5 6
9 10
Black
IK2
3 4
7
Gray
2 1
4 3
1 2
3 4
IK1
1 2
2 1
IH2
Black
Black
1 2
IH1
Black
1 2 3 4
1 2
4 3
1 2
4 3
10 9
2 1
8
6 5
1 2 3 4 5 6 7 8 9 10 11
11 10 9 8 7 6 5 4 3 2 1
12 13 14 15 16 17 18 19 20 21 22
22 21 20 19 18 17 16 15 14 13 12
116
AVENSIS (EWD625E)
http://vnx.su
F
IL1
1
6
4
8
IL2
4
8
2
7
1
6
1 2 3 4 5 6 7 8 9 10 11
11 10 9 8 7 6 5 4 3 2 1
12 13 14 15 16 17 18 19 20 21 22
22 21 20 19 18 17 16 15 14 13 12
1716151413121110
1011121314151617
IM1
IM2
1 2 3 4 5 6 7 8 9
9 8 7 6 5 4 3 2 1
1 2 3 4 5 6 7 8 9
9 8 7 6 5 4 3 2 1
10 11 12 13 14 15 16 17 18
18 17 16 15 14 13 12 11 10
10 11 12 13 14 15 16 17 18
18 17 16 15 14 13 12 11 10
IN1
IO1
Yellow
2 1
1 2
1
2
3 4 5 6 7
8 9 10 11 12
7 6 5 4 3
12 11 10 9 8
IO2
IO3
Yellow
2 1
1 2 3
4 5
6 7 8 9 10 11 12 13
5 4
3 2 1
13 12 11 10 9 8 7 6
IP1
3 4
5 6
1 2
3 4
IQ1
65
43
1 2 3 4 5
4 3
IR1
Black
5 4 3 2 1
1 2
2 1
3 4
4 3
5 6
6 5
117
AVENSIS (EWD625E)
http://vnx.su
F CONNECTOR LIST
BA1
3 4
BB1
4 3
10
11 12131415 16
1819 20
17
17
16 15141312 11
20 1918
10
BB2
2 1
3 4
4 3
6 5
5 6
3 4
4 3
6 5
11 12131415 16
1819 20
10
BD1
17
17
BD2
2 1
4 3
12
3
456 7 8
BE2
3
21
87 654
16 15141312 11
20 1918
10
2 1
4 3
1 2
3 4
BF2
1 2
3 4
5 6
4 3
BE1
BF1
3
21
87 654
9 8
8 9
12
3
456 7 8
3 4
BC1
1 2
1 2
3 4
2 1
5 6
9 8
8 9
1 2
2 1
4 3
3 4 5 6
6 5
118
AVENSIS (EWD625E)
http://vnx.su
2
1
65 43
F
BG1
BG2
1 2
3 4
5 6
2 1
4 3
3 4 5 6
2
1
6 5 43
6 5
119
AVENSIS (EWD625E)
http://vnx.su
1 AVENSIS
128
BL
(2)
W
(2)
AVENSIS (EWD625E)
http://vnx.su
140A ALT
B
(2)
B
(2)
Battery
FL MAIN
3. 0W
BG
(1)
1 4B
IL
9 DJ
7 DB
1 : Gasoline
2 : Diesel
11 : 1ZZFE, 3ZZFE
19 DB
TRLY
13
4 DB
Left Kick Panel
INTB
15
6 DK
IJ
WB
25A AM1
120A ALT
(2AZFSE, 1AZFSE, 1AZFE)
100A ALT (11)
BG
(1)
40A MAIN
Behind the
Combination Meter
WB
9 DA
WB
BG
(1)
30A DCC
1 4A
BL(2)
WB
1 1A
16 DB
ACC
21
I14(A)
Integration Relay
TAIL Relay
GR
7. 5A DOME
3 CD
10 CC
25A DOOR
RW
WL
(3)
3 DH
9 CF
23
7. 5A RAD NO. 1
BW
BW
BG
(1)
1 4D
7. 5A ECUB 2
GY
5 DH 1 DN
BG(1)
IG1
Relay
IG1 1
4 IE4
GR
1 DH
I13
Ignition SW
3 AM1
ACC 2
WR
WR
(4)
7. 5A PANEL
WR
M u ltip le x C o m m u n ic a tio n S y s te m (B E A N L H D )
WR
WR
GW
(3)
1 ED1
22
IG
25
WR
WB
GR
RW
WL(3)
WR(4)
(Cont. next page)
H OVERALL ELECTRICAL WIRING DIAGRAM
10A GAUGE1
G
WB
(4)
WR
WR
E
WB
WB
D
GR
C
RW
GR
2
1
2
2
6 IB1
C A
15 IC2
RY
(3)
Integration Relay
2 A
RY
(3)
RY
(3)
RY
(3)
J 6(A), J 7(B)
Junction
Connector
RY
(6)
C B
E A
Control ECU< 243>
C A
RY
(3 5)
C A
Headlight Cleaner
SW< 284> < 304>
RY
(8)
A/C Control
Assembly
< 488> < 536>
J 3(A), J 4(B)
Junction
Connector
D B
RY
(3)
D B
WR
(3)
WL
(3)
HLP Relay
HRLY
WR
(3)
WR
(3)
WL
(3)
GROUND
+B
WB
(4)
RDA
2
3
GY
(4)
PRG
7 IC2
GY
(4)
LW
(4)
16 IC2
7 A
LW
(4)
WR
(4)
12 IC2
LG
1 IC3
WG
14 DA
LR

< 2211>

< 153>
(A/T)
WG
DLC3
< 518> < 615> < 714>
< 814> < 5019> < 5115>

< 102> < 122>
Moon Roof System

< 322>
Power Window System
< 333>
5 DA
BKL
FRLY
15 A
21 A
OBD2
SNOW
8
20
LR
AVENSIS (EWD625E)
http://vnx.su
Illumination System
< 193>
WL(3)
(3)
Taillight System
< 141>
WR(4)
(3)
12 DB
6 DJ
TOUT
14
12
P/W
9 A
PRG
RDA
D6
Door Control
Receiver
16 A
I14(A)
RW
B
WR
(3)
A
RB
(3)
14 A
DIM
RL
(3)
RL
(3)

1 AVENSIS (Cont' d)
WR
(3)
DIM
Relay
RB
(3)
6 : 3 w/ HID
8 : 3 w/ Power Heater (Electrical Type)
(Cont. next page)
129
130
AVENSIS (EWD625E)
http://vnx.su
GR
WR
(3)
ED
WB
EB
WB
(3)
H5
Headlight LH (High)
F9
WB
(6)
F7
WB
(3)
WB
(3)
WB
(3)
WB
(3)
WB
H6
Headlight RH (High)
EC
WB
(6)
WB
(3)
EA
Engine
Compartment
Right
Tail
High
Low
Flash
Head
16
IL
WB
(3)
Engine
Compartment
Left
WB
(4)
WR
WB
WB
(7)
RW
R
(7)
WB
(7)
F8
Headlight LH (Low)
J2
R
(6)
Light
Control SW
Junction
Connector
RB
(7)
EL
13
H
HL
HU
Behind the
Combination Meter
HF
3 IC3
9 IC3
C12
Combination SW
Headlight Cleaner
Control Relay
< 284>
RB
(6)
RY
(3)
RL
(3)
OFF
RY
(7)
J 3(A), J 4(B)
Junction Connector
RW
(3)
E B
RY
(6)
RL
(3)
D A
A B
E A
J 6(A), J 7(B)
Junction Connector
2
RL
(3)
D A
RY
(6)
E A
RY
(6)
10A
HLP
HI RH
RY
(6)
HF
13 A
RW
(3)
10A
HLP
HI LH
10 IE1
HU
6 A
RY
(3)
15A
HLP RH
28 DA
18
3
4
6
7
J 8(A), J 9(B)
Junction Connector
GR
F A
H B
12

: 3 w/ HID
: 3 w/o HID
GR
WR
(3)
15A
HLP LH
I14(A)
Integration Relay
11
RW
(3)
RB
(3)
10
RY
(3)
RB
(3)
1 AVENSIS (Cont' d)
WB
(4)
WR
WB
GR
RW(3)
RW
(Cont. next page)
Dimmer SW
F10
Headlight RH (Low)
WB
(3)
AVENSIS (EWD625E)
http://vnx.su
LR
(14)
Under the Right

Center Pillar
Buzzer
Right Kick Panel
WB
WB
: Automatic A/C (Except 2ADFHV, 2ADFTV)

: Except 1AZFE
: Except 1AZFE, Latin America, Argentina, CIS
: 2AZFSE, 1AZFSE
: Automatic A/C (2ADFHV, 2ADFTV)
: 1CDFTV
: 2ADFHV, 2ADFTV
WR
Door
P
WB
WB
(14)
IP
13
14
15
17
18
19
20
WB
BV
A13(A), A15(C), A16(D), A37(F)


11 : 1ZZFE, 3ZZFE
12 : Manual A/C
WB
WB
Under the Right

Center Pillar
B10
Buckle SW
GY
(14)
6 CA
WR
J10(A), J11(B)
Junction Connector
BU
WB
Seat Belt
WB
(4)
9 CH
WR
WB
(4)
8 CD
E 9(A), E10(B)
Engine ECU (M/T)
P
31 B (20)
20 A (19)
23 A (1AZFE)
MPX1
18 B (11, 17)
MPX2
32 B (20)
4 ID1
V8
Vanity Light LH
WB
(14)
21 A (19)
29 A (1AZFE)
29 B (11, 17)
F A
V9
Vanity Light RH
GY
(14)
WB
6 CK
13 A
LR
(14)
5 B
35 F (18)
F A
H B
WR
High Beam
6 A
12 F
10 C (13)
MPX+
9 A (12)
PB
CPU
(15)
BEAN
I/F
3 D
24 A
PBLT
MPX
15 F (18)
20 C (13)
H B
WR
14 IM1
RW
(3)
GR
BPBEW
RW
(15)
PBEW
20 B
WR
WR
PB
14 A
H B
WR
WR
1 DA
16
I11(A), I12(B)
Ignition Key
Cylinder Light
6 A (10)
2 B (9)
ILL+
2 A (10)
ILL
6 B (9)
LP
7 DK
WR
WB
(3)
WB
P8
Personal Light
WR
WB
RW
(14)
29 A (12)
21 B
10 IC1
2 A
1 IC1
WR
12 B
C10(A), C11(B)
Combination Meter
7 CA
WR
IG
6 CD
7 CD
MPX1
11 A
WR
F19
Warning Light
RW
RW
(14)
22 A
MPX2
I14(A)
Integration Relay
15
(Cont. next page)
WG
GR
RW(3)
RW
14
PB
13
1 AVENSIS (Cont' d)
WG
WG
WB
(15)
WB
(14)
WB
(3)
131
132
WR
H B
11 ID1
WR
WR
AVENSIS (EWD625E)
http://vnx.su
WR
(16)
J 6(A), J 7(B)
Junction
Connector
WB
(3)
Behind the
Combination Meter
A
A
WB
WB
(3)
L5
Luggage
Compartment Light
WR
(S/D)
WR
F A
U1
Unlock Warning SW
WB
WR
F A
18 IM1
WB
IL
J16
Junction
Connector
RY(S/D)
RY(16)

< 94>
D8
Door Courtesy
Light RH
WR
H B
WR
R
(9)
F A
10 IA1
9 IM1
14 IC2
10 IL1
D B
B A
5 IC2
D B
B A
4 IC2
6 DA
8 DA
13 DM
12 DM
9 DC
RY
(S/D)
11 IA1
KSW
19
11 IL1
RCTY
16
WG
WG
J32
Junction
Connector
13 DB
PCTY
20
WG
2 DK
17
DCTY
I14(A)
Integration Relay
19

16 : L/B, W/G
WR
2 DB
18
(Cont. next page)
Y
(9)
LGCY
1 A
RY
(S/D)
RY
(S/D)
17
1 AVENSIS (Cont' d)
WG
D12
Door Courtesy SW
Rear RH
WG
D11
Door Courtesy SW
Rear LH
D10
Door Courtesy SW
Front RH
D9
Door Courtesy SW
Front LH
J10(A), J11(B)
Junction
Connector

< 94>
I16
Interior Light
WG
WB
WR
D7
Door Courtesy
Light LH
WR
R17
Rear Interior Light
RY
(16)
D3
Diode
LG
LY(S/D)
LR(16)
LB
LR
LR
GW
BRW
BRW
AVENSIS (EWD625E)
http://vnx.su
Lock
A B
LB
(W/G)
J33(A), J34(B)
Junction Connector
Right Side of
the Back Door
2 BD1 (L/B)
4 BF1 (W/G)
WB
3 BG1
WB
(W/G)
WB
(16)
WB
(16)
Left Kick Panel
A B
WB
(16)
A B
B7
WB
(W/G)
BX
2 BE1
WB
(16)
WB
(L/B)
Lower Back
Panel Left
1
M
C B
B A
BS
WB
(S/D)
WB
IJ
D20
WB
(L/B)
RY(16)
D17
Door Lock Motor
Rear RH
WB
(16)
D15
A A
WB
(16)
Door Lock
Control Motor
B8
Back Door
Opener SW
D18
RY
(W/G)
WB
(16)
RY
(S/D)
Door Lock Motor

Rear LH
6 BE2
3 BG2
6 BD2 (L/B)
5 BF2 (W/G)
LB
(S/D)
WB
(S/D)
9 IA1
D13
(Driver' s Side)
(Driver' s Side)
(Driver' s Side)
LR
LB
2 BC1
LR
2 IL1
7 BE2
4 BG2
7 BD2 (L/B)
6 BF2 (W/G)
L
(S/D)
BDSU
10 A
B A
J30(A), J31(B)
Junction
Connector
L3
RY(S/D)
WB
GW
LR
LG
LR
LB
10
LR
LB
11 BC1
LB
7 IL1
3 DM
L
(W/G)
11 BA1
LG
LR
2 BA1
LR
LB
2 IA1
LR
RY
(L/B)
7 IA1
LB
L
(L/B)
18 IA2
LR
LB
(L/B)
1 IA2
RY
(L/B)
8 BE2
RY
(W/G)
5 BG2
8 BD2 (L/B)
2 BF2 (W/G)
J32
Junction
Connector
L
(L/B)
1 IM2
7 CC
L
(W/G)
17 IM2
11 CK
LB
8 CC
2 CB
LACT
L
(L/B)
2 IA2
7 CJ
4 CA
10 DB
20 DB
BDCY
12 A
L
(W/G)
3 IA2
16 IC1
6 DM
LB
7 DM
LR
7 IC1
4 DJ
ACT
LB
RY
(16)
17 IC1
1 DJ
ACT+
24
16 : L/B, W/G
L
(S/D)
L4
WB
(S/D)
LSWD
3 A
L
(16)
UL2
5 A
23
LB
(S/D)
4 IA2
13 DA
L2
4 A
I14(A)
Integration Relay
RY
(16)
29 DA
UL1
10
22
LB
(16)
L1
11
21
1 AVENSIS (Cont' d)
RY
(16)
Unlock
WB
133
134
BL
(2)
W
(2)
140A ALT
AVENSIS (EWD625E)
http://vnx.su
B
(2)
B
(2)
1
2
3
4
7
1 4B
: Gasoline
: Diesel
: 1ZZFE, 3ZZFE
BG
(1)
Battery
FL MAIN
3. 0W
BG
(1)
7. 5A DOME
1 4A
WB
TRLY
13
25A AM1
120A ALT
100A ALT (7)
30A DCC
IJ
WB
Left Kick Panel
7 DB
4 DB
6 DK
16 DB
ACC
21
WB
1 1A
BL(2)
WB
9 DA
3 DH
I14(A)
Integration Relay
TAIL Relay
GR
5 DH 1 DN
23
25A DOOR
RW
7. 5A ECUB 2
BW
7. 5A RAD NO. 1
BW
BG
(1)
WR
(4)
IG1
Relay
IG1 1
ACC 2
GY
1 4D
1 DH
GR
Ignition SW
I13
3 AM1
BG(1)
9 CF
3 CD
WR
(3)
7 CI
10 CC
5 IP1
M u ltip le x C o m m u n ic a tio n S y s te m (B E A N R H D )
WR
2
WR
WR
WR
1 ED1
WR
BG
(1)
2 AVENSIS
22
IG
25
WB
WR
WB
WR(4)
GR
RW
WR
(3)
(Cont. next page)
10A GAUGE1
AVENSIS (EWD625E)
http://vnx.su
WB
Moon Roof System

< 322>
Power Window System
< 343>
IK
WB
(3)
WB
WB
T13
Theft Warning
Ultrasonic
Sensor Rear LH
MOU+
GND
+B
WB
(4)
BV
Under the Right

Center Pillar
T15
Theft Warning
Siren
CONT
5 IO1
WB
(4)
EC
SSW1
13
KSW
12
HORN
5
IND
IG
10
MPX
31
25
+B1
29
E6
Engine Hood
Courtesy SW
Behind the
Combination Meter
J15
Junction
Connector
WB
(4)
WR
(3)
MOU
WR
(4)
WB
MIN
MIN+
L
(4 W/G)
11 IM1
LR
(4)
12 IM1
WR
(4)
DSWH
34
CTLS
27
S+B
24
LR
(4)
LR
(4)
T14
Theft Warning
Ultrasonic
Sensor Rear RH
W
(4 W/G)
SOU+
4
P
(4 W/G)
SOU
SIN
(4 W/G)
SIN+
(Shielded)
GND
IOUT
26
LR
(4)
WB
GROUND
WB
(3)
+B
RDA
S+B
WB
(4)
WR
LR
PRG
IOUT
LGB
(4)
SOFF
LW
(4)
Security Indicator
Light< 92>
WG
LB
(4)
V
(4)
WR(4)
GY
(3)
19 ID1
LB
(4)
T12
9 ID1
LW
(4)
Theft Warning
Ultrasonic Sensor
8 ID1
LGB
(4)
HORN Relay
< 262>
LG
7 IC2
GY
(3)
LW
(3)
16 IC2
WR
(4)
G
(4)
RDA
7 A
PL
(4)
Y
(4)
GR
WG
12 IC2
PRG
16 A

H
I
WB
(4)
Y
(4)
WR
WB
GR
RW
B
RW
(4)
PL
(4)
WR
(4)
(Cont. next page)
RW
(4)
RW
BKL
9 A
LR
1 IC3
FRLY
15 A
LW
(3)
T6
Theft Deterrent ECU
14 DA
OBD2
21 A
I14(A)
Integration Relay
LW
(4)
WR
(3)
5 DA
SNOW
LGB
(4)
P/W
20
2 AVENSIS (Cont' d)
D6

< 2211>

< 153>
DLC3
< 518> < 615> < 714>
< 814> < 5019> < 5115>

< 102> < 122>
135
136
RW
(4)
AVENSIS (EWD625E)
http://vnx.su
Y
(4)
WB
(4)
Seat Belt
WR
WB
: Automatic A/C (Except 2ADFHV, 2ADFTV)
: 1ZZFE, 3ZZFE
E 9(A), E10(B)
Engine ECU (M/T)
Door
P
8 : Except 1AZFE
13 : Automatic A/C (2ADFHV, 2ADFTV)
14 : 1CDFTV
15 : 2AZFSE, 1AZFSE
16 : 2ADFHV, 2ADFTV
Lower Back
Panel Left
C B
B A
WB
J20(A), J21(B)
Junction Connector
GR
RW
BS
WB
(8)
Right Kick Panel
4
5
6
7
BPBEW
PBEW
8 IC3
Behind the
Combination Meter
IL
WB
(8)
IP
31 B (16)
20 A (14)
23 A (1AZFE)
MPX1
18 B (7, 15)
MPX2
32 B (16)
WB
(8)
6 CA
29 A (1AZFE)
WB
(8)
9 CG
A13(A), A15(C), A16(D), A37(F)

21 A (14)
J32
Junction
Connector
WB
13 A
PB
29 B (7, 15)
12 F (13)
3 D (6)
PBLT
24 A (5)
LR
(8)
C10(A), C11(B)
Combination Meter
35 F
10 C
9 A
MPX+
MPX
15 F (13)
20 C (6)
LR
(8)
6 CK
Buzzer
CPU
(8)
BEAN
I/F
20 B
29 A (5)
IG
F19
Warning Light
12
WR
WR
(4)
WB
Y
(4)
WR
(Cont. next page)
J16
Junction
Connector
5 B
(8)
14 A
10 IC1
GY
(8)
RW
(8)
GY
(8)
GR
GR
WB
(8)
RW
GR
F A
RW
15 A
PL
(4)
21 B
PB
2 A
WR
H B
MPX1
11 A
7 CA
RW
6 CD
1 IC1
PB
7 CD
MPX2
22 A
I14(A)
Integration Relay
11
PL
(4)
10
RW
(8)
1 CK
WR
(4)
2 AVENSIS (Cont' d)
B10
Buckle SW
WB
(8)
J30(A), J31(B)
Junction
Connector
AVENSIS (EWD625E)
http://vnx.su
WG
WR
V8
Vanity Light LH
WR
Y
(4)
10 CI
11 ID1
14 IC2
9 IM1
4 IC2
13 DM
12 DM
B
C
RY
(S/D)
WG
RY
(L/B, W/G)
Y(4)
18 IM1
D12
WB
6 CH
3 CE
11 CI
WR
V9
Vanity Light RH
WB
WR
WR
WB
WR
(L/B, W/G)
WR
9 CI
WR
WR
WR
WR
L5
Luggage Compartment
Light
WR
(S/D)
D7
Door Courtesy
Light LH
WR
WR
I11(A), I12(B)
4
R
(9)
D8
Door Courtesy
Light RH
WR
10 IL1
4 CK
1 CA
5 CE
RCTY
16
9 DC
WR
10 IA1
7 CG
5 IC2
11 IL1
R
2 B (9)
RY
(S/D)
2 A (10)
ILL+
11 IA1
13 DB
PCTY
WG
4 ID1
F A
J32
Junction
Connector
2 DK
WR
(4)
F A
A
R
ILL
2 DB
F A
WR
6 B (9)
6 A (10)
WG
H B
RY
(S/D)
RY
(S/D)
H B
7 DK
DCTY
17
16
F A
J26(A), J27(B)
Junction
Connector
1 DA
1 A
LGCY
I14(A)
Integration Relay
15
WG
WB
WR
WR
(4)
LP
6
14
(Cont. next page)
WG
13
2 AVENSIS (Cont' d)
WG
D11
D9
D10

< 94>
I16
Interior Light
WG
WB
R17
Rear Interior Light
RY
(L/B, W/G)
D3
Diode
WG
R
P8
Personal Light
WR
WR
WB
WB
WR
WR
WB
137
138
Y
(8)
Y
(8)
Y
(9)
Y
(4)
AVENSIS (EWD625E)
http://vnx.su
WB
LB
(W/G)
J33(A), J34(B)
Junction
Connector
RY
(W/G)
WB
(L/B, W/G)
WB
(L/B, W/G)
Right Side of
the Back Door
WB
(W/G)
WB
IP
WB
(L/B, W/G)
WB
(L/B, W/G)
WB
(L/B)
Lower Back
Panel Left
WB
(S/D)
BS
Lock
J30(A), J31(B)
Junction
Connector
Right Kick Panel
9 IL1
WB
WB
(W/G)
BX
2 BE1
WB
(L/B)
A B
7
WB
J22(A), J23(B)
Junction Connector

< 94>
Right Kick Panel
A B
B7
A B
B8
Back Door Opener SW
C B
B A
WB
IP
WB
Unlock
3 BG1
B A
L4
Luggage Compartment
Door Opener SW
A A
2 BD1 (L/B)
4 BF1 (W/G)
WB
(S/D)
D17
RY
(S/D)
U1
Unlock Warning SW
WB
(S/D)
L
(W/G)
BRW
3 IL2
5 B
6 B
WB
(12)
WB
8 B
8 A (11)
5 A
6 A
10 B (12)
7 B
7 A (11)
D13(A)

(Driver' s Side)
(Driver' s Side)
(Driver' s Side)
Double Lock Motor
(Driver' s Side)
(Driver' s Side)
D14(B)
B
(12)
L(12)
W(12)
4 B (12)

(Driver' s Side)
(Driver' s Side)
(Driver' s Side)
3 B
4 IL1
8 IL1
18 IL2
1 IL2
2 IL2
LY
RY
(L/B)
GW
4 IL2
3 IC1
L
(L/B)
16 IC1
7 IC1
17 IC1
DLPD
6 A
LG
Y(4)
RY
(L/B)
W
(12)
6 CA
RY
(W/G)
LSWD
3 A
B
(12)
L
(12)
13 CF
L
(W/G)
LB
(L/B)
L
(W/G)
1
LB
(S/D)
RY
(S/D)
3 BG2
UL2
5 A
W
(12)
L
(L/B)
6 BE2
L
(S/D)
4 BG2
BRW
L
(L/B)
7 BE2
6 BD2 (L/B)
5 BF2 (W/G)
13 DA
GW
29 DA
L2
4 A
LR
5 BG2
L
(S/D)
UL1
10
20
L
(12)
RY
(L/B, W/G)
Y
(1AZFE)
RY
(L/B, W/G)
7 BD2 (L/B)
6 BF2 (W/G)
L
(L/B, W/G)
8 BE2
3 DM
LB
(L/B, W/G)
L
F B
J32
Junction
Connector
LB
(S/D)
L1
11
LR
LG
F B
RY
(L/B, W/G)
BDSU
10 A
8 BD2 (L/B)
2 BF2 (W/G)
LACT
I14(A)
Integration Relay
19
LG
D A
8 DA
BDCY
12 A
18
(Cont. next page)

8 : Except 1AZFE
B
(12)
D A
KSW
19
17
2 AVENSIS (Cont' d)
L3
WB
(L/B, W/G)
RY
(L/B, W/G)
LR
LB
LR
B
(12)
LB
LR
B
(12)
AVENSIS (EWD625E)
http://vnx.su
W
(12)
L
(12)
LGB
(12)
B
(12)
LB
LR
D20(A)
6 B
10 B (12)
WB
(12)
WB
(12)
BV
Left Kick Panel
9 IA1
WB
(12)
WB
(12)
WB
(12)
IJ
10 B
9 B
6 B (12)
5 B
10 BA1
Under the Right

Center Left
WB
(12)
Under the Right

Center Pillar
D18(A)
D19(B)
Door Lock Motor
Rear LH
SW Rear LH
Double Lock Motor
Rear LH
SW Rear LH
7 B (12)
5 B
4 B
Door Lock Motor

Rear LH
3 B
8 B (12)
6 B
WB
(12)
WB
(12)
BQ
WB
(12)
BU
WB
3 B
1 A (11)
WB
(12)
WB
(12)
10 BC1
D16(B)
Double Lock Motor
D15(A)
4 A
4 B
WB
(12)
Under the Right

Center Pillar
D21(B)
Door Lock Motor
Rear RH
Door Unlock
Detection SW Rear RH
Double Lock Motor
Rear RH
SW Rear RH
Door Lock Motor

Rear RH
1 B
1 A (11)
1 B (12)
4 A
2 B
L
(12)
2 B
8 IA1
W
(12)
1 B (12)
7 IA1
LR
2 B
2 IA1
LB
9 B
17 IA2
B
(12)
5 B
18 IA2
LGB
(12)
3 B
16 BA1
W
(12)
1 A (11)
6 BA1
L
(12)
4 B
4 BA1
B
(12)
4 A
11 BA1
2 BA1
9 BA1
LGB
(12)
4 IA1
6 DM
7 DM
LR
D14(B)
LR
LB

LB
1 B (12)
B
(12)
1 A (11)
LGB
(12)
2 B
L
(12)
4 A
W
(12)
9 B
L
(12)
16 BC1
W
(12)
6 BC1
W
(12)
9 BC1
B
(12)
4 BC1
LGB
(12)
11 BC1
10 DM
LGB
(12)
2 BC1
12 IC1
4 IC3
10 IC3
W
(12)
2 IL1
B
(12)
L
(12)
7 IL1
LGB
(12)
B
(12)
17 IL2
L
(12)
11 IM2
LR
3 CK
LGB
(12)
2 IM2
LR
5 CB
W
(12)
1 IM2
1 CE
W
(12)
1 CI
LB
2 CA
LB
2 CD
L
(12)
16 IM1
12 CJ
20 DA
B
(12)
17 IM1
10 CA
4 DJ
LGB
(12)
17 IM2
11 CK
LB
7 CC
5 CH
1 DJ
ACT
24
LR
8 CC
6 CF
9 DJ
6 DJ
ACT+
23

LB
D13(A)
7 CJ
2 CB
LR
4 CA
L
(12)
Junction
Connector
B
(12)
W
(12)
J20(A), J21(B)
G
A
G
B
B
(12)
ACTR
15
L
(12)
G
A
G
A
G
B
8 DB
14
ACTS
I14(A)
Integration Relay
L
(12)
B
(12)
L(12)
W(12)
10 DB
LB
20 DB
LSWP
22
W
(12)
B(12)
21
2 AVENSIS (Cont' d)
139

IJ
Left Kick Panel
9 DA
WB
Y
(5, 7)
Y
(5, 7)
Y
(4)
Power Heater
Assembly< 433>
Engine ECU (M/T)

< 89> < 5011> < 519>
BW
A11(A), A12(B)
Alternator
1 B
1 A
S 4(A), S 5(B)
Starter
1
B
7 IK1
5
3
5
(RHD)
BR
FL MAIN
3. 0W
B
(2)
AVENSIS (EWD625E)
http://vnx.su
B
(2)
W
(2)
1 ED1
B
(2)
Battery
1 1A
1 4A
1 4B
1 4D
BG
(1)
1 4E
120A ALT (9)

100A ALT (7)
BG
(1)
B
(2)
BG
(1)
B
(1, 10)
BG
(1)
BL
(2)
1 A
5
5
30A AM2
BR
1 IP1
1 IE4
(LHD)
BR
WB
140A ALT
3 AVENSIS
6
2
I13
Ignition SW
IG2
4 AM2
ST2 5
BR
BR
IG1 1
ACC
3 AM1
GR
ST Relay
BY
7. 5A ALTS
140
3 A
BL
(3)
1 : Gasoline
2 : Diesel
5 : 2AZFSE, 1AZFSE, Diesel
6 : 1AZFE
7 : 1ZZFE, 3ZZFE
8 : 2AZFSE, 1AZFSE
9 : 2AZFSE, 1AZFSE, 1AZFE
10 : 1CDFTV
11 : 2ADFHV, 2ADFTV
C B
BW
(3)
BY
B A
BL
(2)
7. 5A ST
BR
B
(1, 10)
B B
B A
12 IK2
5 EA1 (1)
5 EE1 (10)
A A
A A
BY
(2)
C B
N1
BW
(7 A/T)
BY
GY
BY
(A/T)
BW
(A/T)

< 77>
A/C Control
Assembly
< 488> < 536>
GR
(11)
BL
(2)
Engine ECU (M/T)

< 89> < 5012> < 519>
Neutral
Start SW
BY
(1)
BY
(M/T)
S ta rtin g
B
(1, 10)
13 IK2

< 512> < 611> < 77>
Engine ECU (M/T)
< 512> < 611> < 77>
BY
(M/T)
GR
(11)
B+(1)
B (2)
B(2)
Engine ECU
< 5014> < 5112>
J12(A), J13(B)
Junction
Connector
9 IK1
Y
(6)
BG(1)
B
(1, 10)
IG
2 A
1 IK2
C B (RHD)
9 E (11)
27 D (7)
21 C (8)
28 B (6)
E 9(A), E10(B),
E11(C), E12(D), E13(E)
Engine and ECT
ECU (A/T)
Engine ECU (M/T)
RW
4 A
MPX2
RL
32 B (11)
21 A (10)
29 A (6)
29 B (7, 8)
Y
(6)
MPX1
31 B
20 A
23 A
18 B
G A (LHD)
1 DH
GR
BG(1)
C h a rg in g
RW
J10(A), J20(B)
Junction Connector
25A AM1
System (BEAN)< 115> < 211>
C B (RHD)
G A (LHD)
RW
18 DB
7. 5A ECUIG
9 D (10)
2
3
WB
2 DJ
1 DN 5 DH
IG1 Relay
GY
BG
IGF
2
GND
IGF
GND
WR
I2
Ignition Coil and
Igniter No. 2
WB
IGT
+B
IGF
WB
AVENSIS (EWD625E)
http://vnx.su
BG
WR
Left Side of the

Cylinder Head
GND
I3
Ignition Coil and
Igniter No. 3
IGT
+B
WR
LGB
WB
WR
P
Left Side of the

Cylinder Head
WB
WB
(1)
GND
WB
(1)
WB
EH
WB
(2)
EF
IGF
I4
Ignition Coil and
Igniter No. 4
WR
Engine and ECT ECU (A/T)< 510> < 611> < 78>
Engine ECU (M/T)< 510> < 611> < 78>
IGT
+B
WB
(2)
EC
IGT
3
I1
Ignition Coil and
Igniter No. 1
WB
Battery
RB
+B
RB
BR

2 : 1ZZFE, 3ZZFE
N2
Noise Filter
(Ignition)
FL MAIN
3. 0W
IG2
Relay
RB
RB
1 4B
8 EA1
BR
10A
IGN
RB
16 DL
2 DH
RB
1 4A
15A
IG2
BR
RB
IG2 6
ST2
Ig n itio n
RB
1 1A
30A
AM2
(RHD)
(LHD)
I13
Ignition SW
4 AM2
BR
BR
1 IP1
1 IE4
BR
4 AVENSIS
WR
LY
WB
WR
RW
RB
RB
141
5 AVENSIS
142
BG
AVENSIS (EWD625E)
http://vnx.su
120A ALT
BG
4
B
25A AM1
Left Kick Panel
BY
10A GAUGE1
WB
WB
WB
IG2 Relay
15A IG2
30A AM2
20A EFI
30A DCC
EC
WB
IJ
WB
WB
Battery
10A IGN
BW
WB
BY
13 EA1
BW
BW
FL MAIN
3. 0W
10A ETCS
BG
9 DA
7 DB
BY
7 EA1
4 IE2
1 1A
16 DL
BR
1 4A
7 DA
BR
1 4B
GR
BW
(RHD)
(LHD)
BW
BY
BR
BW
B
BR
1 IP1
BW
1 IE4
5 DH 1 DN
GY
(RHD)
1 DH
GR
7. 5A DOME
(LHD)
GR
18 DA
BG
5 IP1
2 DH
BR
IG2 6
ST2
GY
IG1 1
I13
Ignition SW
4 AM2
3 AM1
BY
GR
ACC
RW
V
1 4D
WR
4 IE4
BW
BR
BY
GR
RW
BW
BW
WR
GR
(Cont. next page)
INJ Relay
10A EFI NO. 1

BR
7. 5A EFI NO. 2
BR
BW
EFI Relay
7. 5A OBD2
IG1 Relay
C10(A), C11(B)
Combination Meter
AVENSIS (EWD625E)
http://vnx.su
J10(A), J11(B), J26(C)

Junction Connector
WB
WB
IP
CRUISE
Right Kick Panel
LG
(5)
BW
R21
Radiator Fan Relay
WB
BR
GY
Under the Left

Center Pillar
F26
Fuel Pump Resistor
WB
GY
BQ
LG
(5)
Under the Left

Center Pillar
3 IP1
(RHD)
(LHD)
D B (RHD)
D A (LHD)
2 IE4
J14(A), J28(B)
Junction
Connector
L
(5)
BR
BR
L
(5)
LB
(6)
Intake Side of
Cylinder Block
D B (RHD)
D A (LHD)
BR
D B
BW
6 CA
L
(5)
GY
6 IC3
BR
D A
EE
BR
ME01
4 C
E02
6 E
E01
7 E
E03
7 C
IGSW
9 A
14 IE2
WB
6 CK
Check Engine
9 B
C A (LHD)
WB
9 IB1
L
(5)
FC
10 A
A C (RHD)
A C
WB
6 EA1
BW
E 9(A), E10(B), E11(C), E12(D), E13(E)

Engine ECU (M/T)
FPR
+B
+B2
W
IREL
7 D 11 A 35 B
1 A
2 A
J 8(A), J 9(B),
J26(C), J27(D)
Junction Connector
WB
WB
Left Side of
the Cylinder
Head
WB
EF
WB
4 IR1
BR
(3)
ST1
12 B
BR
(3)
B
GR
BW
BR
RW(2)
RW(1)
E1
1 C
: LHD M/T
: RHD M/T
: Shielded
: 2AZFSE
: 1AZFSE
BR
RW
MREL
8 A
C A
C A
GW
(LHD)
Multiplex
Communication
System (BEAN)
< 115> < 211>
BW
LB
(5)
5 B
RW
(2)
BATT
2 IE1
BW
BR
WR
(LHD)
3 A
(RHD)
(LHD)
1
2
3
5
6
Stop Light
System< 172>
14 A
LB
(5)
LB
(5)
5 IB1
BY
LB
(5)
7 IO1
7 IE3
BW
13 A
WR
(RHD)
GR
CPU
C8
Circuit Opening
Relay
BY
BW
(LHD)
GR
LB
(5)
E D (RHD)
BW
(RHD)
22 B
3 IB1
LB
(5)
E D
C B (LHD)
BW(RHD)
3 IR1
GW
(LHD)
GW
(RHD)
21 B
8 CE
BW
20 IE1
GW
(RHD)
20 B
6 CD
7 CA
RW
(1)
H B (LHD)
F C (RHD)
10
IB1
(Cont. next page)
S13
Stop Light SW
BEAN I/F
F C
F A (LHD)
RW
BW
BW
(RHD)
BY
BW
(LHD)
GR
RW
BW
BW
WR
GR
E n g in e C o n tro l (2 A Z F S E , 1 A Z F S E )
BW
(LHD)
5 AVENSIS (Cont' d)
BR
BR
BR
F25
Fuel Pump
LG
(5)
143
144
AVENSIS (EWD625E)
http://vnx.su
J19
Junction
Connector
BR
RW
(2)
RW
(1)
BR
INJ# 3
IJT# 2
IJT# 1
IJT# 3
2 B
IJT# 4
3 B
IJF
5 B
RL
IMI
BR
E A
D B
E A
G2+
27 C
F/PS
14 A
(3)
E 4(A), E 5(B)
COM2
1 B
4 B
21 C
27 B
STA
17 E
C1
Camshaft
Position Sensor
BR
D B
E A
FAN
4 A
BR
MPX2
29 B
NE+
25 C
SPD
17 B
J12(A), J13(B)
Junction
Connector
NE
24 C
STP
19 B
(3)
LGB
(2)
INJ# 2
IMO
26 B
EOM
15 A
MPX1
18 B
1 : LHD M/T
2 : RHD M/T
3 : Shielded
BW
BR
BR
BW
BR
L
INJ# 4
BW
2 A
I7
Injector No. 3
2
GW
6 A
1
WR
COM1
1 A
3 A
I6
Injector No. 2
1
ELS
12 A
IJF1
25 E
NEO
17 A
#4
4 E
ENG
30 A
E 9(A), E10(B), E11(C), E12(D), E13(E)

Engine ECU (M/T)
#1
#2
#3
1 E
2 E
3 E
ENG+
24 A
BR
LGB
(1)
C6
Crankshaft
Position Sensor
J14
Junction
Connector
RW
INJ# 1
GY
WL
VB
RW
RB
5 A
TRC
31 A
TRC+
Y(LHD)
W(RHD)
4 A
25 A
IGF1
YB
I8
Injector No. 4
2
WR
24 E
IGT4
8 A
LY
11 E
GR
IGT3
Transponder Key
Computer< 94>
I5
Injector No. 1
1
LGB
10 E
Charging System
< 34>
IGT2
Skid Control ECU

with Actuator< 207>
9 E
LGB
IGT1
TAIL Fuse
< 142>
8 E
BY
+BM

< 228>
6 B
GW
10 B

< 33>
ST Fuse (M/T)
< 33>
Diode (Fan)< 444>

5 IE2
Stop Light SW
< 172>
GND
7 A
LGB
(1)
LGB
(2)
6 IR1

No. 1, No. 2, No. 3 or No. 4
< 43> < 44>
12
VW
LGB
(1)
15 IE2
C9
Clutch
Start SW
11
Combination Meter
< 423>
10
(Cont. next page)
System (BEAN)< 115> < 211>
RW
(1)
5 IR1
RW
(2)
9 IE2
LGB
(2)
RW(2)
RW(1)
GR
GR
5 AVENSIS (Cont' d)
(3)
G
(3)
R
BR
Y
(LHD)
G
(RHD)
Y
(RHD)
G
(LHD)
Y
(LHD)
AVENSIS (EWD625E)
http://vnx.su
+B
2
LB
LB
BR
BW
E B
E B
BW
J12(A), J13(B)
Junction
Connector
BR
BW
(3)
D A
H10
(Bank 2 Sensor 2)
BW
E1
4
+B
HT
BW
BR
E1
OX
OX2A
23 D
BR
D A
+B
2
OX
HT1A
5 D
PIM
33 E
H7
(Bank 1 Sensor 1)
D A
H8
(Bank 1 Sensor 2)
BR
BW
HT
1
E1
OX1A
22 D
GE01
17 C
VOUT
GND
BR
+B
HT
HT2A
4 D
PR
23 E
BW
(3)
BR
YB
BR
HT
(3)
OX
(3)
E1
2 C
OX
O2B
31 C
OX2B
29 D
M+
3 C
HT1B
25 D
OC1
15 C
VTA1
21 E
OC1+
16 C
VTA2
31 E
E 9(A), E10(B), E11(C), E12(D), E13(E)

Engine ECU (M/T)
HT2B
OX1B
O1B
21 D
26 C
33 D
THW
19 E
VOUT
1
VCC
BR
BR
BW
H9
(Bank 2 Sensor 1)
BW
FP
3 D
S3
Spill Valve
FP+
6 D
VC
18 E
1
GND
B
(LHD)
B
(RHD)
Y
(LHD)
E2
M
1
3
VCC
V1
Vacuum Sensor
Y
(RHD)
W
(LHD)
EKNK
2 D
W
(RHD)
B
(LHD)
KNK1
1 D
B
(RHD)
28 E
E2
PSW
10 C
PB
BR
26 E
BR
VCP2
RW
27 A
RW
VPA2
BW
23 A
BR
EPA2
BR
29 A
LW
VCPA
26 A
M+
2
VPA
VTA1
E2
(3)
22 A
VTA2
T1
and Position Sensor
RW
BR
B
BR
3 : Shielded
F16
Fuel Pressure
Sensor
G
(LHD)
GW
EPA
Y
(LHD)
YG
28 A
B
(LHD)
BR
RW
VC
RW
7 IG2
RW
BR
BR
2 IG2
9 EA1
BR
RW
3 IG2
BR
10 EA1
1
RW
11 EA1
VC
BR
5 IG2
4 (LHD)
6 (RHD)
VCP2
E2
16
RW
6 IG2
2
2
VPA2
W
(LHD)
1
3
EP2
PIM
B2
15
BR
1 IG2
6
4
VCP1
5
5
VPA1
A20
B
(LHD)
3
1
EP1
14
(Cont. next page)
BR
13
5 AVENSIS (Cont' d)
BW
BR
BW
BR
BR
BR
BW
C2
Camshaft Timing Oil
Control Valve
WG
(3)
(3)
K1
Knock Sensor
(Bank 1)
P2
145
Right
Kick
Panel
12 IE2
10 DD
WG
WL
G D (RHD)
G B (LHD)
WG
Tire Pressure
Monitor ECU
< 523>
WG
Integration Relay
< 15> < 25>
IL
EF
J 8(A), J 9(B), J26(C), J27(D)

Junction Connector
Skid Control ECU
with Actuator
< 2011>
ECC
CANCEL
SET/COAST
RES/ACC
CCS
CRUISE
2
BR
Cruise Control SW
BR
E2G
E2
+B
BW
BW
GR
VG
LY
BR
THA
V6
VSV (Intake Air
Control Valve)
BW
BW
LB
V5
VSV (EVAP)
AVENSIS (EWD625E)
http://vnx.su
BR
BR
E
BW
BW
WG
CCS
TC
24 B
E 9(A), E10(B), E11(C), E12(D), E13(E)

Engine ECU (M/T)
THA
VG
EVG
SCV
20 E
30 E
29 E
5 E
20 A
SIL
TACH
A6
Air Flow Meter
EVP1
34 E
BR
BR
J 8(A), J 9(B), J26(C), J27(D)

Junction Connector
GRR
5 A
A B (LHD)
D C
GRR
E A
Combination
Meter< 424>
B D (RHD)
D C (RHD)
GRR
E A (LHD)
15
TAC
BAT
17
16
WFSE
WG
WFSE
WL
18 A
Airbag Sensor
Assembly
< 228>
19 A
3 DC
30 DA
18
C14
Combination SW
WG
E n g in e C o n tro l
(2 A Z F S E , 1 A Z F S E )
G D
G A
1 DL
15 DL
WL
8 DD
9 DB
17 DB
WG
G B
SIL
WG
G C (RHD)
WG
Transponder Key
Computer< 94>
G A (LHD)
MultiDisplay
< 396>
G C
WL
(4)
G A
WL
(RHD)
G C
D D (RHD)
D B (LHD)
Tire Pressure
Monitor ECU
< 523>
WL
(LHD)
J 8(A), J 9(B), J20(C), J21(D)

Junction Connector
D5
DLC3
Skid Control ECU

with Actuator
< 2011>
WL
(RHD)
D D
D B
B A
WL
B C (RHD)
B A (LHD)
WL
(LHD)
B C
WL
(RHD)
TC
W
(RHD)
W
(LHD)
WL
(RHD)
13
Left Side of the

Cylinder Head
B D (RHD)
J 8(A), J20(C), J21(D)

Junction Connector
WL
5 AVENSIS (Cont' d)
IP
J16
Junction
Connector
A
14 IK2
D A (LHD)
BR
D A
W
(LHD)
WB
(LHD)
BR
D C (RHD)
CG
SG
12
TS
BR
WG
146
Behind the
Combination
Meter
6 CA
3 CB
WB
(RHD)
WB
(LHD)
19
C ru is e C o n tro l (2 A Z F S E , 1 A Z F S E )
WB
(RHD)
20
WB
(RHD)
6 AVENSIS
148
BG
AVENSIS (EWD625E)
http://vnx.su
120A ALT
BG
25A AM1
Left Kick Panel
10A GAUGE1
7. 5A OBD2
WB
WB
WB
WB
IG2 Relay
10A IGN
15A IG2
30A AM2
20A A/F
EC
W
(1)
IJ
WB
1 EA1
A/F Relay
W
(1)
2 EA1
BW
12 EA1
13 EA1
BW
Battery
4
B
WB
(1)
W
(1)
BR
FL MAIN
3. 0W
20A EFI
BG
W
(1)
EFI
Relay
BW
1 1A
BW
1 4A
BY
9 DA
7. 5A EFI NO. 2
BR
1 4B
BR
(1)
BR
BR
RB
WB
BW
(LHD)
RB
BR
GR
(1)
8 EA1
7 DB
BY
16 DL
7 DA
BR
(1)
(RHD)
GR
(LHD)
GY
5 DH 1 DN
BG
1 DH
7 CA
8 CE
RW
(M/T)
BY
1 IP1
BW
(RHD)
18 DA
1 IE4
2 DH
BR
IG2 6
ST2
GY
IG1 1
ACC
RW
(M/T)
I13
Ignition SW
4 AM2
3 AM1
GR
(1)
GR
BW
1 4D
W(1)
W(1)
BW
BR
BW
GR
BY
RW
(M/T)
RB
BW(LHD)
BW
(RHD)
(Cont. next page)
10A EFI NO. 1
GR
WB
IG1 Relay
AVENSIS (EWD625E)
http://vnx.su
BQ
BR
Under the Left

Center Pillar
WB
EF
BR
I10
ISC Valve
Left Side of the
Cylinder Head
+B
2
HT
1
D A
BR
(1)
WB
Under the Left

Center Pillar
WG
BR
GY
WB
V5
VSV (EVAP)
BW
(1)
AF
AF+
(2)
W(1)
HT1B
OX1B
O1B
32 E
E1
+B
2
OX
HT
1
4 IK1
4
21 D
4 B
J12(A), J13(B)
Junction Connector
BW
(1)
EVG
32 D
THA
20 E
D A
BR
(1)
LB
+B
HT
A2A
30 D
L
(1)
H8
(Bank 1 Sensor 2)
L
(1)
BR
AF
A2A+
22 D
B
(1)
BW
(1)
W(1)
GY
BR
GR
AF+
HA2A
5 D
VG
24 D
BR
(1)
BR
GY
B
(1)
W
(1)
A1A
31 D
G
(1)
GND
A1A+
23 D
L
(1)
+B
HA1A
6 D
11 A
W
(1)
DUTY
12 E
IGSW
THA
OX2B
29 D
BW
(1)
H10
(Bank 2 Sensor 2)
+B
OX
HT
E1
E2
28 E
BR
O2B
31 E
THW
19 E
R
(1)
GR
F25
Fuel
Pump
BY
LGB
(M/T)
E1
PRG
J14
Junction
Connector
7 D
BR
8 IK1
C9
Clutch Start SW
RSD
10 D
I6
Injector No. 2
G
(1)
+B
J26(A), J27(B)
Junction Connector
1 A
I7
Injector No. 3
E 9(A), E10(B), E12(D), E13(E)

Engine ECU (M/T)
I8
Injector No. 4
3 B
HT2B
BR
10 IK1
(2)
BW
BW
9 A
C11
Combination Meter
6 IC3
FC
#4
E2G
E2
E2
10 A
RB
4 E
#3
BW
(RHD)
RB
3 E
RB
I5
Injector No. 1
#2
BW
(LHD)
2 E
Check Engine
#1
1 E
A6
Air Flow Meter
CLSW
RB
10 B
VG
3
BATT
J 8(A)
Junction
Connector
LY
3 A
E B
C A
+B
GR
MREL
C A
BW
8 A
C A
BR
A A
BR
BR
BW
GR
(RHD)
A A
22
BR
LR
(1)
10 IB1
BY
7 IO1
RW
(M/T)
BW
(RHD)
2 IE1
(LHD)
BW
(RHD)
7 IE3
LGB
(M/T)
RB
BW
(LHD)
BW
RB
BW
(LHD)
15 IE2
LGB
(M/T)
9 IE2
RB
BR
RW
(M/T)
(Cont. next page)

2 : Shielded
BR
GR
BR
BW
(LHD)
BY
RW
(M/T)
RB
BW(LHD)
BW
(RHD)
BW
(RHD)
6 AVENSIS (Cont' d)
LR
(1)
(2)
W
(1)
A8
(Bank 2 Sensor 1)
Y
(1)
(2)
W
(1)
A7
(Bank 1 Sensor 1)
L
(1)
BW
BR
C8
BR
149
150
BR
BR
LW
AVENSIS (EWD625E)
http://vnx.su
BR
K1
Knock Sensor
(Bank 1)
BR
(2)
(2)
(2)
E B
BR
Left Side of the

Cylinder Head
P2
Power Steering
Oil Pressure SW
EF
PSW
23 E
IGT1
8 E
IGT2
9 E
IGT3
10 E
11 E
IGT4
FAN
7 A

No. 1, No. 2, No. 3 or No. 4
< 43> < 44>
13 E
IGF1
SPD
17 B
26 B
IMO
STA
9 D
27 B
IMI
STP
19 B
E02
E04
E05
WB
(1)
WB
WB
WB
WB
Intake Side of
Cylinder Block
WB
(1)
EE
3 D
6 E
MPX1
23 A
12
BR
(Cont. next page)

: Unleaded Gasoline
: Shielded
: Leaded Gasoline
4 D
7 E
E01
MPX2
29 A
1
2
3
4
WB
(1)
D B
E A
BR
EOM
15 A
ELS
12 A
WB
(1)
D B
E A
(2)
E A
E B
C6
Crankshaft
Position Sensor
D A
NE+
27 E
(2)
NE
34 E
F/PS
14 A
J12(A), J13(B)
Junction Connector
G2+
RL
LGB
RW
LY
RW
P
(3)
26 E
RW
(3)
YB
(1)
EKNK
C2
Camshaft Timing Oil
Control Valve
2 D
WG
(1)
KNK1
E 9(A), E10(B), E12(D), E13(E)

Engine ECU (M/T)
Charging System
< 34>
28 B
LGB
OC1+
Airbag Sensor
Assembly< 228>
15 E
OC1
TAIL Fuse
< 142>
14 E
VAF
Diode (Fan)< 444>

32 E
VW
VC
BY
18 E
V3
Variable Resistor
RW
(3)
Combination Meter
< 423>
3 EA1

< 33>
ST Fuse (M/T)
< 33>
9 EA1
(2)
P
(3)
VAF
GW
VTA1
VCC
11
Stop Light SW
< 172>
21 E
VC
E2
10
System (BEAN)< 115> < 211>
1 D
T2
Throttle Position
Sensor
VTA
10 EA1
BR
(3)
E2
BR
(3)
6 AVENSIS (Cont' d)
GR
(4)
W
(4)
< 94>
WR
RW
BR
C1
Camshaft
Position Sensor
Combination
Meter< 424>
GRR
E A
A B (LHD)
GRR
TC
SIL
WG
WFSE
WL
J 8(A), J 9(B), J26(C), J27(D)

Junction Connector
E 9(A), E10(B), E12(D), E13(E)

Engine ECU (M/T)
WG
G D (RHD)
G B (LHD)
G C (RHD)
G C
D B
B A
B A
D A
D A
12 IE2
W
(LHD)
WG
WL
Skid Control ECU

with Actuator
< 216>
15 DL
WL
10 DD
G C
G A (LHD)
G A
TS
12
TC
13
J 8(A)
Junction Connector
Airbag Sensor
Assembly
< 228>
1 DL
WG
8 DD
WG
G A
WG
20 A
9 DB
WG
(4)
18 A
WL
(LHD)
17 DB
WG
30 DA
WG
WL
(RHD)
WL
(LHD)
19 A
3 DC
WL
SIL
D5
DLC3
15
WL
(LHD)
TACH
WFSE
15
BAT
16
SG
BR
Behind the
Combination Meter
CG
16

WB
(LHD)
WB
(LHD)
J 8(A), J 9(B)
Junction Connector
WL
(5)
MultiDisplay
< 396>
WG
(4)
Transponder Key
Computer< 94>
WG
Integration Relay
< 15> < 25>
AVENSIS (EWD625E)
http://vnx.su
WB
(RHD)
WB
(LHD)
IP
WB
(RHD)
IL
J16
Junction
Connector
6 CA
3 CB
WB
(RHD)
5 A
TAC
14
WL
(RHD)
B D (RHD)
D C (RHD)
E A (LHD)
GRR
D C
13
GRR
WL
(LHD)
BR
B
W
(LHD)
6 AVENSIS (Cont' d)
Right
Kick
Panel
W
(RHD)
Skid Control ECU

with Actuator
< 216>
J 8(A), J 9(B), J26(C), J27(D)

Junction Connector
151
7 AVENSIS
152
BG
7. 5A OBD2
100A ALT
AVENSIS (EWD625E)
http://vnx.su
BG
BR
BW
BQ
10A EFI NO. 1
WB
20A EFI
15A IG2
30A AM2
10A ETCS
Under the Left

Center Pillar
WB
BR
WB
EC
BW
12 EA1
7. 5A EFI NO. 2
BR
13 EA1
Under the Left

Center Pillar
F25
Fuel Pump
6 IC3
16 B
FC
BR
1 A
+B
BATT
MREL
GY
Battery
WB
BW
BG
WB
1 1A
LB
FL MAIN
3. 0W
1 4A
3 A
4 B
(RHD)
(LHD)
8 IK1
BR
1 4B
GR
BR
BR
EFI
Relay
BW
GY
BY
GR
BY
BW
BY
BW
GR
7 IO1
7 IE3
BY
1 4D
BR
WB
2 IE1
5 IE2
16 DL
18 DA
2 DH
BR
E 9(A), E10(B), E12(D), E13(E)

Engine ECU (M/T)
+BM
6 B
GY
1 DN
BW
10 IB1
GR
(RHD)
4
BY
1 IP1
IG2
Relay
RB
BR
(LHD)
BR
GR
1 IE4
IG2 6
ST2
BR
I13
Ignition SW
4 AM2
BR
7 DA
BW
BR
BW
RB
(Cont. next page)
10A IGN
BW
BR
C8
BW
(1)
BW
B
BR
VC
BR
T1
and Position Sensor
BR
E2
5
4
M+
BR
BW
BR
BW
E1
+B
OX
BR
BW
BR
BW
BW
WG
BR
A6
Air Flow Meter
BW
E2
+B
BR
THA
4
2
3
E2G
LY
BR
VG
GR
BW
V5
VSV (EVAP)
OCV
OCV+
14 E
13 E
YB
WG
Left Side of the

Cylinder Head
WB
EG
WB
WB
Left Side of the

Cylinder Head
EH
BR
WB
AVENSIS (EWD625E)
http://vnx.su
ME01
E02
6 E
7 E
E01
E1
E03
9 A
BW
(LHD)
5 E
E D (RHD)
E D
C B (LHD)
J 8(A), J 9(B),
J26(C), J27(D)
Junction Connector
BW
(RHD)
3 D
ST1
12 B
4 IR1
GW
(LHD)
7 D
3 IR1
A C (RHD)
A C
C A (LHD)
20 IE1
BW
BR
BW
BW
(LHD)
GW
(RHD)
BW
(LHD)
C A
BW
RB
BW
(RHD)
14 IE2
GW
(RHD)
C A
BW
HT
BR
Stop Light
System< 172>
GW
(LHD)
BW
(RHD)
11 A
22
1
3
BW
(LHD)
VTA2
VTA1
18 E
VC
VTA2
31 E
21 E
VTA1
M
OX1A
22 D
6 D
HT1A
E2
THW
19 E
24 E
4 D
5 D
M+
GE01
18 D
IGT4
IGT3
10 E
IGF
28 E
C2
Camshaft Timing Oil
Control Valve
IGSW
W
Check
Engine
BR
H7
Heated Oxygen
Sensor
(Bank 1 Sensor 1)
C11
Combination Meter
S13
Stop Light SW
IGT2
THA
I5
Injector No. 1
E2
E 9(A), E10(B), E12(D), E13(E)

Engine ECU (M/T)
EVP1
VG
EVG
19 D
30 E
29 E
BR
RB
BW
IGT1
11 E
2
RB
8 EA1
RB
I6
Injector No. 2
(1)
STA
9 E
Y
RB
LW
(1)
# 30
2
RB
I7
Injector No. 3
3 E
RB
RB
8 E
27 B
26 B
I8
Injector No. 4
4 E
RB
# 20
2 E
GR
< 94>
12 E
12 A
TAIL Fuse
< 142>
NSW
BW
(A/T)
ST Fuse
< 32>
23 E
BY
# 10

< 33>
ST Fuse (M/T)
< 33>
ELS
RW
IMI
BR
IMO
LGB
1 E
Ignition Coil and

Igniter No. 1, No. 2, No. 3
or No. 4< 43> < 44>
RW
# 40
WR
LY
7 AVENSIS (Cont' d)
F/PS
GW
14 A
Stop Light SW
< 172>
STP
LGB
19 B

< 228>
20 E
9 D
FAN
A
B
Diode (Fan)
< 453>
FAN NO. 2 Relay
< 453>
1 : Shielded
(Cont. next page)
153
154
Y
(RHD)
G
(LHD)
Y
(LHD)
R
(2)
AVENSIS (EWD625E)
http://vnx.su
E1
P
(3)
BW
(3)
1 B (3)
3 B
OX H17(A), (B)
Heated Oxygen
Sensor
+B (Bank
1 Sensor 2)
2 A (2)
BR
(2)
1
IH2
P
(2)
BW
(2)
BW
(2)
B
(3)
B
(2)
4 A
(1)
HT
L
(4)
4 B (3)
Y(LHD)
W(RHD)
(4)
10
IK1
B
(2)
EKNK
2 D
KNK1
1 D
2 EB1
1 EB1
3 A (2)
B
(4)
Skid Control ECU

with Actuator
< 207>
NEO
17 A
(1)
2 B
ENG
30 A
C1
Camshaft
Position Sensor
B
1 A
ENG+
24 A
4 IH2
TRC
31 A
G2
26 E
2 IH2
TRC+
25 A
NE
34 E
(1)
3
IH2
OX1B
23 B
NE+
27 E
D A
EMPS
30 D
(1)
BR
(2)
HT1B
RL
27 D
E 9(A), E10(B), E12(D), E13(E)

Engine ECU (M/T)
SPD
17 B
E B
D A
(1)
BW
B
(LHD)
MPX1
18 B
GRR
(1)
G
(RHD)
A B (LHD)
B D (RHD)
A B
D B
E A
(1)
18
IK2
B
(RHD)
Y
(LHD)
MPX2
29 B
J 8(A), J 9(B), J26(C), J27(D)

Junction Connector
BR
Y
(RHD)
W
(LHD)
BR
(3)
W
(RHD)
B
(LHD)
VCP2
7 A
B
(RHD)
27 A
System (BEAN)< 115> < 211>
VPA2
VW
23 A
Charging System
< 34>
EPA2
D B
E A
E A
TACH
3 B
(1)
Y
(LHD)
R
29 A
VCPA
Combination Meter
< 423>
GR
26 A
EPS ECU
< 234>
VPA
GRR
22 A
C6
Crankshaft
Position Sensor
B D
WFSE
SIL
15 B
Left Side of
the Cylinder Head
J12(A), J13(B)
Junction
Connector
WFSE
19 A
15
EPA
GR
6 IK2
E A (LHD)
D C (RHD)
E A
D C
TAC
WG
1
2
3
4
TC
20 A
D5
DLC3
EH
BR
G
(LHD)
7 IG2
BAT
16
12
: Shielded
: w/ HID
: w/o HID
: w/ VSC
(1)
(1)
WL
WG
(1)
(1)
(Cont. next page)
WL
28 A
W
(LHD)
2 IG2
B
(LHD)
3 IG2
GRR
5 IG2
4 (LHD)
6 (RHD)
VCP2
11
Combination
Meter< 424>
6 IG2
2
2
VPA2
10
GRR
1 IG2
1
3
EP2
6
4
VCP1
A20
B
(LHD)
5
5
VPA1
Y
(LHD)
3
1
EP1
7 AVENSIS (Cont' d)
(1)
BR
BR
K1
Knock Sensor
(Bank 1)
(1)
YB
(4)
G
(4)
IP
WB
(RHD)
6 CA
WB
(RHD)
3 CB
WB
(RHD)
W
(RHD)
B B (LHD)
B D (RHD)
D C (RHD)
W
(LHD)
WL
(RHD)
D D (RHD)
D B (LHD)
D B
IL
WL
(RHD)
EPS ECU
< 234>
WL
(LHD)
WL
(LHD)
WL
(5)
D D
B C (RHD)
B A (LHD)
B A
WL
WL
(RHD)
B C
TC
WL
(LHD)
13
D5
DLC3
Tire Pressure
Monitor ECU
< 523>
WL
(LHD)
WL
(RHD)
Skid Control ECU

with Actuator
< 2011> < 216>
J 8(A), J 9(B), J20(C), J21(D)

Junction Connector
EG
W
(RHD)
12 IE2
D A
W
(LHD)
D C
W
(RHD)
D A (LHD)
TS
12
15
W
(LHD)
A
BR
BR
EPS ECU
< 234>
WB
(LHD)
Left Side of the

Cylinder Head
BR
WB
(LHD)
14 IK2
SG
WB
(LHD)
CG
J16
Junction
Connector
Behind the
Combination Meter
16
1 : Shielded
Right Kick
Panel
MultiDisplay
< 396>
G D (RHD)
G D
G B
G B
G D
G B (LHD)
G C (RHD)
G C
G A (LHD)
G A
G A
WG
G C
WG
SIL
14
J 8(A), J 9(B), J20(C), J21(D)

Junction Connector
WG
EPS ECU
< 234>
WG
Integration
Relay< 15> < 25>
WG
Tire Pressure
Monitor ECU
< 523>
J 8(A), J 9(B), J26(C), J27(D)

Junction Connector
8 DD
WL
Airbag Sensor
Assembly
< 228>
(1)
E
AVENSIS (EWD625E)
http://vnx.su
(1)
10 DD
WG
Skid Control ECU

with Actuator
< 2011> < 216>
1 DL
15 DL
WL
WL
WG
Transponder Key
Computer< 94>
WG
C
(1)
3 DC
30 DA
13
WG
(1)
7 AVENSIS (Cont' d)
WL
17 DB
9 DB
WG
155
156
140A ALT
AVENSIS (EWD625E)
http://vnx.su
80A GLOW
BR
EI
10 EE1
BW
Near the
Starter
G2
Glow
Plug
Relay
BW
BW
Engine
Compartment
Left
WB
EC
7 EE1
BW
RB
WB
IJ
BW
4 IE2
BR
10A IGN
BW
Left Kick Panel
G1
Glow Plug
2 IE1
EDU Relay
FL MAIN
3. 0W
9 DA
7 DB
1 1A
18 DA
7 DA
5 DH 1 DN
BR(LHD)
BY(RHD)
BR(LHD)
BY(RHD)
BR
BR
2 DH
GY
BW
GR
1 DH
BL
(RHD)
I13
Ignition SW
1 IP1
(LHD)
IG2 6
ST2
GY
RW
(RHD)
1 IE4
4 AM2
BR
IG1 1
BR(LHD)
BY(RHD)
5 IP1
(LHD)
3 AM1
GR
ACC
GR
BW
4 IE4
WR
GR
7. 5A DOME
1 ED1
BL
8 AVENSIS
BW
BW
G
BR(LHD), BY(RHD)
GR
RW
R
WR
(Cont. next page)
EFI MAIN Relay
10A GAUGE1
7. 5A OBD2
IG1 Relay
25A AM1
30A AM2
20A EFI
30A DCC
Battery
J10(A), J11(B), J26(C)

Junction Connector
WR
(LHD)
14 A
CRUISE
5 B
AVENSIS (EWD625E)
http://vnx.su
Glow
Right Kick Panel
4
2
WB
B2
BW
S2
S4
BW
BW
WR
(RHD)
BW
B1
5
D1
Diesel Throttle
Control Motor
BW
+B
1 A
6
IR1
15
IE2
8 IK1
BW
YG
S1
RL
S3
LU+B LUB
13 E 12 E
10 B
LGB
(RHD)
LGB
(LHD)
7 IO1
7 IE3
BATT
MREL
BW
BW
+B
VG
VG
EVG
THA
24 D 32 D 31 E
2 B
8 A
VN
10 E
LGB
(RHD)
LGB
(LHD)
E3
EGR Valve
Control Motor
BW
GW
(RHD)
GW
(LHD)
RW
(RHD)
RW
(LHD)
E2
2
THA
4
E2G
LY
WB
IP
BW
BW
G
4
IR1
14
IE2
Stop Light
System< 172>
E 9(A), E10(B), E12(D), E13(E)

Engine ECU (M/T)
EG+A EGA EG+B EGB
LU+A LUA
6 D
5 D
4 D
3 D
15 E 14 E
ST1
12 B
GW
(RHD)
GW
(LHD)
BW
(RHD)
GB
6 CA
22 B
W
12 A
IGSW
9 A
IREL
10 A
C A (LHD)
A C (RHD)
C A
3
IR1
BW
(LHD)
5
IR1
9
IE2
V4
VRV (EGR)
6 CK
Check Engine
9 B
A C
C A
BW
(LHD)
13 A
C10(A), C11(B)
Combination Meter
E D (RHD)
BW
(RHD)
BEAN I/F
RW
21 B
E D
C B (LHD)
BW
(RHD)
BW
(LHD)
S13
Stop
Light SW
CPU
6 CD
8 CE
RW(RHD)
RW(LHD)
C9
Clutch
Start SW
20 B
H B
7 CA
20
IE1
GR
GR
BW
BW
G
F C (RHD)
RW(RHD)
RW(LHD)
BY
WR
F A (LHD)
RW
F C
BR(LHD), BY(RHD)
GR
RW
E2
28 E
(RHD)
(LHD)
BR(LHD)
BY(RHD)
10 IK1
BR
GREL
14 A
R
WR
(Cont. next page)
8 AVENSIS (Cont' d)
BR
A6
Air Flow Meter
BR
BW
BW
BW
BW
BW
BW
BW
BW
J 8(A), J 9(B),
J26(C), J27(D)
Junction Connector
BW
Multiplex
Communication
System (BEAN)
< 115> < 211>
157
158
LG
S6
Suction Control
Valve
LGR
BR
RW
BW
AVENSIS (EWD625E)
http://vnx.su
BR
RW
RW
BR
RW
GR
L
BR
RW
T5
Turbo Pressure
Sensor
E2
BR
GW
8 A
WR
(1)
IJT# 3
5 A
INJ# 1
4 A
E 4(A), E 5(B)
IJT# 4 COM1
5 B
WL
BATTERY
RW
2 B
BR
IJT# 2
Y
(RHD)
3 B
IJT# 1
I5
Injector No. 1
6 B
6 A
INJ# 4 COM2
3 A
I8
Injector No. 4
PRD
RW
RL
4 B
IJF
24 A
30 A
INJ# 2
2 A
INJ# 3
1 A
TRC ENG+ ENG
31 A
I6
Injector No. 2
4 EB1
RB
7 B
TRC+
25 A
6 EB1
F16
Fuel Pressure
Sensor
PR2
PR
BR
E2
MPX2
21 A
BR
VC
E2S
MPX1
20 A
1
VCS
INJF PRD
#1
#2
#3
#4
25 E 32 E 24 E 23 E 22 E 21 E
FAN
3 A
E2
PIM
WR
VC
RW
2 EB1
5 EB1
3 EB1
BR
1 EB1
PCR2
33 E
PCR1
26 E
E2S
1 D
EPA2
I7
Injector No. 3
BR
LG
BR
BY
P
SP1
17 B
PRV
8 B
COM3
7 A
2 EA1
1 EA1
NEO
17 A
BR
ST Fuse
< 33>
RW
PB
1 EC1
GW
29 A
Stop Light SW
< 172>
27 A
23 A
VCP2
VPA2
E 9(A), E10(B), E12(D), E13(E)
Engine ECU (M/T)
BL
BR
Alternator
< 33>
P3
Pressure Discharge
Valve
Charging System
< 34>
P
2 EC1

< 94>
PB
VCS
2 D
GR
PIM
28 D
B
(RHD)
VC
18 E
G
(RHD)
THF
29 E
B
(LHD)
EPA
W
(RHD)
THIA
20 E
G
(LHD)
28 A
Y
(LHD)
VPA
Y
(RHD)
22 A
B
(LHD)
VCPA
B
(RHD)
26 A
W
(LHD)
IMI
Y
(LHD)
30 B
IMO

THW
19 E
29 B
System (BEAN)< 115> < 211>
RL
B
(LHD)
9 D
G
(w/ VSC)
ALT
L
(w/ VSC)
8 E
(w/ VSC)
STP
19 B
Skid Control ECU

with Actuator< 207>
STA
B
(w/ VSC)
7 A
G
(LHD)
3 IG2
YB
(w/ VSC)
PCV
Y
(LHD)
2 IG2
1 (LHD)
3 (RHD)
EP2
VW
1 E
B
(LHD)
7 IG2
2
2
VPA2
W
(LHD)
1 IG2
4
6
VCP2
Y
(LHD)
6 IG2
3
1
EP1
Combination
Meter< 423>
5 IG2
5
5
VPA1
12
NE+
27 E
1 : Shielded
PCV+
6
4
VCP1
A20
11
C6
2 E
10
GND
1 B
NE
34 E
(1)
WB
(1)
(1)
(Cont. next page)
8 AVENSIS (Cont' d)
(1)
(1)
BR
F18
Fuel Temp. Sensor
BR
I9
BR
E B
2
E B
D A
E B
SET/COAST
ECC
CCS
CRUISE
C14
Combination SW
CCS
24 B
BR
EOM
15 A
EI
T3
WB
AVENSIS (EWD625E)
http://vnx.su
(1)
WB
WB
(1)
WB
PL
E01
7 E
THOP
11 E
Near the
Starter
WB
WB
TC
23 D
G1
G
BR
E02
6 E
(1)
B
C1
31 D
BR
(2)
Cruise Control SW
BR
(1)
P
BR
BR
E1
7 D
11 A
SIL
WFSE
19 A
W
(2)
BR
13
J 8(A), J 9(B),
J26(C), J27(D)
Junction Connector
5 A
TACH
E 9(A), E10(B), E12(D), E13(E)
Engine ECU (M/T)
B D (RHD)
A B (LHD)
D C (RHD)
E A (LHD)
E A
GRR
D C
WFSE
15
9
TAC
BAT
16
18 A
Airbag Sensor
Assembly
< 228>
WG
GRR
(1)
(1)
BR
WL
GRR
BR
D A
WL
Skid Control ECU

with Actuator
< 2011> < 216>
RES/ACC
10 DD
WG
BR
1 DL
15 DL
WL
8 DD
9 DB
17 DB
3 DC
D5
DLC3
WG
30 DA
14
WL
WG
BR
Integration
Relay
< 15> < 25>
CANCEL
WG
J12(A), J13(B)
Junction
Connector
D B
Tire Pressure
Monitor ECU
< 523>
D B
WG
E A
(1)
G D (RHD)
G C (RHD)
G C
G B (LHD)
G B
G D
G A (LHD)
G A
G A
G C
WG
SIL
Transponder
Key Computer
< 94>
WG
J 8(A), J 9(B),
J26(C), J27(D)
Junction Connector
IL
MultiDisplay
< 396>
E A
WL
(3)
E A
WL
(RHD)
(1)
D B (LHD)
Tire Pressure
Monitor ECU
< 523>
WL
(LHD)
D D (RHD)
D B
WL
(RHD)
D D
B C (RHD)
B C
B A
Skid Control ECU

with Actuator
< 2011> < 216>
12 IE2
W
(LHD)
J 8(A), J 9(B), J20(C), J21(D)

Junction Connector
WG
8 AVENSIS (Cont' d)
W
(RHD)
D A
B A (LHD)
15
13
WL
(LHD)
WL
Combination
Meter< 424>
IP
6 CA
Behind the
Combination Meter
B D (RHD)
D C (RHD)
D A (LHD)
CG
3 CB
BR
WL
(RHD)
WB
(LHD)
SG
WB
J 8(A), J20(C), J21(D)

Junction Connector
TC
WB
(RHD)
J16
Junction
Connector
(LHD)
W
(LHD)
C ru is e C o n tro l (1 C D F T V )
WB
(RHD)
WB
(LHD)
12
TS
WB
(RHD)
16
1 : Shielded
Right Kick
Panel
159
ST2
AVENSIS (EWD625E)
http://vnx.su
1 4B
BG
(1)
1 4A
3
2
W
(2)
140A ALT
1 1B
50A AM1 NO. 1
W
(2)
1
(RHD)
(LHD)
1 IE5
W
(1)
2 IP1
2
W
1 6A
7. 5A ECUB 1
IP
Right Kick Panel
WB
(RHD)
WB
(LHD)
E
IMB
SEC
B
(2)
Battery
1
1 1A
1
2
BG
(1)
FL MAIN
3. 0W
(RHD)
(LHD)
30A AM2
BR
1 IP1
1 IE4
BR
W
(1)
I13
Ignition SW
4 AM2
2
1
120A ALT (3)

100A ALT (4)
50A AM1 NO. 1
B
(2)
WR
Theft Deterrent ECU

< 28>
IG2 6
BR
V
(5)
9 AVENSIS
160
WB
(LHD)
8 (LHD)
1 (RHD)
1 (LHD)
8 (RHD)
7
IND
IG
4 DA
2 DH
10A IGN
BW
WB
(RHD)
A
6 CA
5 CI
GND
WB
(LHD)
F19
BR
Behind the
Combination Meter
J16
Junction
Connector
A
WB
(RHD)
IL
Unlock Warning SW
< 120> < 217>
10
KSW
9 CH
WR

< 119>
< 216>
14
TXCT
AGND
+B
VC5
CODE
12
13
1
GRR
T8
CTY
9
8
11
VC5
CODE
LR
TXCT
GND
YG
I12
YB
E n g in e Im m o b ilis e r S y s te m
WG

< 511> < 611> < 77>
Engine ECU (M/T)
< 511> < 611> < 77>
< 810> < 5012> < 519> < 5110>
EFIO
EFII
DLC3< 519> < 615>

< 713> < 815>
< 5019> < 5115>
GR
1
2
3
4
5
: Gasoline
: Diesel
: 2AZFSE, 1AZFSE, 1AZFE
: 1ZZFE, 3ZZFE
162
BG
AVENSIS (EWD625E)
http://vnx.su
1
E
SNOW
25
120A ALT
BG
23
B
Left Kick Panel
WB
IJ
14 DA
9 DA
Battery
BG
1 1A
IG1 Relay
FL MAIN
3. 0W
GR
I14(A)
Integration
Relay
16 DB
11 A
MPX1
IG
22
Multiplex
Communication
System (BEAN)
< 115> < 211>
22 A
MPX2
7 DB
10A GAUGE1
1 4B
7. 5A DOME
30A DCC
BW
7. 5A ECUB 2
BR
27 DA
WR
BW
5 DH 1 DN
BY
GR
1 DH
WB
EC
GR
BY
GY
(RHD)
BG
1 IP1
RW
5 IP1
(LHD)
(RHD)
(LHD)
10A EFI NO. 1

BW
EFI Relay
3 IP1
2 IE4
BR
BR
1 IE4
8 CA
RW
3 CD
7 CA
6 CD
1 CG
21 B
RW
4 IE4
I13
BR
Ignition SW
BR
1 CD
F A (LHD)
F C (RHD)
H B
20 B
5 B
F C
A/T Shift
Clock
BEAN I/F
14 A
Combination Meter
C10(A), C11(B)
CPU
J10(A), J11(B),
J26(C)
Junction Connector
WR
(LHD)
IG2 6
WR
10 CC
RW
ST2
4 AM2
BR
GY
RW
IG1 1
3 AM1
RW
BR
GR
BY
BR
GR
RW
WB
13 A
(Cont. next page)
Multiplex
Communication
System (BEAN)
< 115> < 211>
1 4D
WR
GR
1 IK1
E C T a n d A /T In d ic a to r (2 A Z F S E , 1 A Z F S E )
RW
WR
ACC
RW
WR
1 4A
10 AVENSIS
WB
WR
(RHD)
ECT SNOW
BW
BY
7. 5A GAUGE2
25A AM1
20A EFI
30A AM2
10A ETCS
AVENSIS (EWD625E)
http://vnx.su
WB
(RHD)
J17
Junction
Connector
WB
(LHD)
WB
IP
Right Kick Panel
E01
7 E
WB
EE
E02
6 E
E1
WB
Intake Side of
Cylinder Block
1 C
EOM
15 A
E A
D B
4 C
ME01
IGSW
9 A
EF
WB
Behind the
Combination Meter
J15
Junction
Connector
6 CA
E03
7 C
BATT
3 A
10A
IGN
Left Side of the

Cylinder Head
J8
Junction
Connector
IK
WB
6 CK
4 IG2
WB
(LHD)
8 IG2
W
(LHD)
WB
11 CF (LHD)
8 CH (RHD)
6 CJ
KD
30 B
MREL
8 A
BR
WB
R
WB
(LHD)
J14(A), J28(B)
Junction
Connector
W
(LHD)
+B
1 A
E B
A A
BW
(RHD)
BR
+B2
(RHD)
(LHD)
J26(A), J27(B)
Junction
Connector
E 9(A), E10(B), E11(C), E12(D), E13(E)

BR
2 A
BR
SPT1
GR
20 B
7 IO1
7 IE3
BY
SFTD
2 IE1
BW
(LHD)
21 B
D B (RHD)
D A (LHD)
18 DA
2 DH
BR
BW
(LHD)
SFTU
D B
D A
D B (RHD)
BW
(RHD)
5 IE2
+BM
6 B
GY
22 B
IG
D A (LHD)
BR
SFTD
GR
SFTU
T7
Transmission
Control SW
MPX2
29 B
MPX1
18 B
System (BEAN)< 115> < 211>
BY
RW
BR
GR
BY
BR
GR
RW
GR
STA
17 E
VC
18 E
VTA1
21 E
VTA2
31 E
M+
3 C
2 C
THW
19 E

< 512> < 514> < 515>
SPD
17 B
STP
19 B
RW
(Cont. next page)
J12(A), J13(B)
Junction Connector
BR
BR
WB
K2
Kick Down SW
E8
WB
163
164
RW
LGB
PL
AVENSIS (EWD625E)
http://vnx.su
BR
THO
SLT+
E2
SLT
LB
DSL
3 B
10 A
T4
9 B
12 A
SL2
LG(1)
Y (2)
SB(1)
G (2)
GR(1)
G (2)
G(1)
O(2)
E 1(A), (B)
ECT Solenoid
SL2+
4 B
5 A
7 B
RB
8 A
SL1+
19 D
SL1+
5 B
6 A
2 B
SL2
16 D
SL1
18 D
SL1
10 B
13 A
YB
2 A
SL2+
17 D
S4
10 D
S4
8 B (2)
3 A
11 B
1 B
DSL
11 D
7 A
SR
9 D
SR
9 A
BRW
(1)
1 A
SLT
12 D
SLT+
13 D
15 D
SL3+
J5
Junction
Connector
SL3+
4 A
PL
20 IK2
LW
(1)
6 B
THO
32 D
LGB
(1)
14 D
SL3
6 A
SL3
11 A (1)
LR
(1)
7 A
LG
10 B
RY
(RHD)
E2
C5
Counter Gear Speed
Sensor
NT
C B
J22(A), J23(B)
Junction
Connector
28 E
BO
35 D
NT+
LGB
(2)
27 D
J14(A), J19(B)
Junction
Connector
NC+
26 D
D B (RHD)
C A (LHD)
RY
(LHD)
NC
LGB
(2)
A A
RY
(RHD)
D B (RHD)
RY
(LHD)
C A (LHD)
5 IK1
RL
N1
Neutral Start SW
WL
34 D
LGB
9 IK2
NL
3
RB
10
RY
10 IK2
DL
RW
E 9(A), E10(B), E11(C), E12(D), E13(E)

11
WL
12
1 : 2AZFSE
2 : 1AZFSE
Y(1)
R(2)
BR
166
BG
120A ALT
AVENSIS (EWD625E)
http://vnx.su
BG
Battery
30A DCC
BG
1 1A
BW
FL MAIN
3. 0W
7. 5A DOME
BR
1 4B
BW
9 DA
WB
IJ
IG1 Relay
Left Kick Panel
7 DB
BY
BR
27 DA
WB
EC
GR
GY
5 DH 1 DN
10A EFI NO. 1

BW
EFI Relay
BR
GR
1 DH
5 B
21 B
F C
F A (LHD)
H B
20 B
Combination Meter
C10(A), C11(B)
BEAN I/F
14 A
A/T Shift
Clock
CPU
F C (RHD)
J10(A), J11(B),
J26(C)
Junction Connector
BY
BG
(RHD)
RW
1 IP1
RW
5 IP1
(LHD)
RW
1 IE4
BR
12 EA1
6 CD
1 CG
7 CA
WR
(LHD)
4 IE4
8 CA
1 CD
RW
I13
Ignition SW
BR
RW
BR
GR
BY
BR
RW
WB
13 A
(Cont. next page)
Multiplex
Communication
System (BEAN)
< 115> < 211>
1 4D
IG2 6
4 AM2
BR
GY
RW
ST2
IG1 1
3 AM1
GR
1 IK1
RW
WR
ACC
RW
WR
1 4A
11 AVENSIS
WR
(RHD)
WB
BW
BY
10A GAUGE1
7. 5A GAUGE2
25A AM1
20A EFI
30A AM2
WB
AVENSIS (EWD625E)
http://vnx.su
V
BR
W
(1)
WB
(1)
WB
(1)
Right Kick Panel
PL
WB
WB
(LHD)
WB
(RHD)
IP
Behind the
Combination Meter
3
DSL
SL2+
SL2+
17 D
E1
ECT Solenoid
IK
7
SLT
DSL
11 D
LB
2
SLT+
SLT
16 E
6 CA
1
THO
SLT+
17 E
NC
34 D
16 D
SL2
MPX2
29 A
SL2
E 9(A), E10(B), E12(D), E13(E)

NC+
26 D
RB
J15
Junction
Connector
WB
6 CK
6
E2
THO
30 E
NT
35 D
SL1+
19 D
SL1+
MPX1
23 A
2 IG1
W
(1)
1 IG1
E2
28 E
NT+
27 D
SL1
SL1
10
18 D
STA
9 D
YB
6 CJ
KD
27 A
IGSW
9 A
S4
13 D
S4
STP
19 B
BATT
J 8(A)
Junction
Connector
J17
Junction
Connector
3 A
T4
BR
MREL
BY
8 A
BW
(LHD)
+B
BO
1 A
J26(A), J27(B)
Junction Connector
BW
BW
(RHD)
(RHD)
E B
A A
SPT1
C A
C A
LG
20 B
(RHD)
C5
LGB
SFTD
7 IO1
(LHD)
System (BEAN)< 115> < 211>
21 A
7 IE3
10A
IGN

< 611>
SFTU
SFTD
2 IE1
GR
8 IK1
18 DA
2 DH
BR
SPD
17 B
VC
18 E
1 : Europe
VTA1
21 E
THW
19 E
RW
(Cont. next page)

< 68> < 69>
22 A
SFTU
IG
BR
BW
(LHD)
T7
Transmission
Control SW
GR
WB
RW
BR
GR
BY
BR
RW
BY
BR
K2
Kick Down SW
167
168
RW
LGB
(LHD)
LGB
(RHD)
7 E
E01
15 A
EOM
AVENSIS (EWD625E)
http://vnx.su
BR
E A
D B
WB
WB
WB
(2)
WB
(2)
Left Side of the

Cylinder Head
J12(A), J13(B)
Junction Connector
BR
EF
21 B
WL
Intake Side of
Cylinder Block
7 D
E1
22 B
A B
A A
A B
A A
D B
D A
RY
(RHD)
J5
Junction
Connector
RY
(LHD)
5 IK1
RL
N1
Neutral Start SW
A B
A A
C B
A A
PL
20 IK2
J22(A), J23(B)
Junction Connector
EE
6 E
E02
E 9(A), E10(B), E12(D), E13(E)

RY
(LHD)
RB
D B (RHD)
D A (LHD)
Junction
Connector
J18(A), J29(B)
D B (RHD)
D A (LHD)
WL
4 D
E04
RY
(LHD)
11 B
LGB
(LHD)
J14
Junction
Connector
LGB
RY
(RHD)
10 B
LGB
(RHD)
9 IK2
NL
10 IK2
DL
RW
11
RY
RY
(RHD)
LGB
(LHD)
10
WL
3 D
E05
12
WL
Diode
< 215>
WL
BR
170
BG
AVENSIS (EWD625E)
http://vnx.su
1
E
SNOW
25
100A ALT
BG
23
B
Left Kick Panel
WB
IJ
14 DA
9 DA
Battery
10A ETCS
BG
1 1A
5
IG1 Relay
FL MAIN
3. 0W
GR
I14(A)
Integration
Relay
11 A
MPX1
IG
22
Multiplex
Communication
System (BEAN)
< 115> < 211>
22 A
MPX2
7 DB
10A GAUGE1
1 4B
7. 5A DOME
30A DCC
BW
7. 5A ECUB 2
BR
16 DB
BY
27 DA
WR
BW
5 DH 1 DN
WB
EC
GR
BR
7 CA
C10(A), C11(B)
Combination Meter
10A EFI NO. 1
BW
EFI Relay
12 EA1
BR
BY
GR
1 DH
GY
(RHD)
BG
1 IP1
RW
5 IP1
(LHD)
BR
1 IE4
8 CA
RW
3 CD
1 CD
6 CD
1 CG
21 B
RW
4 IE4
I13
10 CC
WR
Ignition SW
BR
RW
F A (LHD)
H B
BEAN I/F
14 A
A/T Shift
Clock
CPU
F C (RHD)
20 B
5 B
F C
J10(A), J11(B),
J26(C)
Junction Connector
WR
(LHD)
IG2 6
4 AM2
BR
GY
RW
ST2
IG1 1
3 AM1
GR
1 IK1
RW
BR
GR
BY
GR
BR
RW
WB
13 A
(Cont. next page)
Multiplex
Communication
System (BEAN)
< 115> < 211>
1 4D
WR
ACC
RW
WR
RW
WR
1 4A
12 AVENSIS
WB
WR
(RHD)
ECT SNOW
BW
BY
7. 5A GAUGE2
25A AM1
20A EFI
30A AM2
AVENSIS (EWD625E)
http://vnx.su
WB
(LHD)
WB
Right Kick Panel
WB
EH
BR
Left Side of the

Cylinder Head
EG
WB
WB
(RHD)
WB
WB
(LHD)
IP
Left Side of the

Cylinder Head
WB
Behind the
Combination Meter
STP
19 B
E2
28 E
E2
SPD
17 B
M+
OT
32 D
THO1
4 D
5 D
SLT+
13 D
SLT+
VTA1
21 E
SLT
12 D
S1
THW
19 E
S1
11 D
VC
18 E
SLT
VTA2
31 E
S2
10
10 D
S2
10 B
ECT Solenoid
E1
IK
WB
(LHD)
E02
6 E
STA
12 E
BR
6 CA
E01
7 E
MPX1
18 B
J15
Junction
Connector
6 CK
3 D
ME01
MPX2
29 B
PL
E1
5 E
NT
34 D
WB
11 CF (LHD)
8 CH (RHD)
8 IG2
W
(LHD)
4 IG2
W
(LHD)
6 CJ
E03
7 D
NT+
26 D
PL
KD
31 B
IGSW
9 A
J17
Junction
Connector
+BM
SL
15 D
SL
11 B
R
BW
(RHD)
SB
8 D
SB
20 B
WB
6 B
J26(A), J27(B)
Junction
Connector
E 9(A), E10(B), E12(D), E13(E)

BATT
T4
ST
20 D
ST
13 A
WL
RY(LHD)
LGB
RY
(RHD)
RW
RB
BR
3 A
BY
MREL
GY
4 B
BO
+B
1 A
System (BEAN)< 115> < 211>
LGB
8 B

< 77> < 78> < 710>
RY(LHD)
SFTD
J 8(A)
Junction Connector
BW
(LHD)
C A
C B
A A
RY(RHD)
1 B
E B
C A
10A
IGN
J22(A), J23(B)
Junction Connector
RY(RHD)
SFTU
A A
18 DA
2 DH
BR
(Cont. next page)
2 B
(RHD)
(LHD)
BW
(RHD)
7 IO1
7 IE3
5 IE2
BW
(LHD)
2 IE1
BR
GR
8 IK1
GR
SFTD
IG
BY
SFTU
GR
T7
RW
BR
GR
BY
GR
BR
RW
RY
(RHD)
LG
GR
WB
K2
Kick Down SW
E8
WB
171
172
WL
A B
WL
RY
(RHD)
RY(LHD)
J18(A), J29(B)
Junction Connector
A A
LGB
A B
A A
RB
J5
Junction
Connector
D B (RHD)
D A (LHD)
D B (RHD)
D A (LHD)
20 IK2
PL
5 IK1
RL
N1
Neutral Start SW
10
RY
(LHD)
RY(LHD)
NL
9 IK2
LGB
R
10 IK2
DL
RW
R
WL
RY
LGB
RY
(RHD)
RW
WL
11
12
AVENSIS (EWD625E)
http://vnx.su
1
2
3
4
5
6
7
J 3(A), J 4(B)
Junction
Connector
Engine
Compartment
Right
B B
EA
RW
RW
RY
(w/ HID)
RY
(w/ HID)
B A
H5
Headlight
LH (High)
B B
B A
RW
RL
(w/o HID)
2
2
1
WR
(w/ HID)
: Gasoline
: Diesel
: RHD w/ HID
12 B
D
A
RL
RL
(w/o HID)
RL
(w/ HID)
H6
Headlight RH (High)
RL
1
2
10A
HLP HI LH
Engine
Compartment
Left
A
ED
E
E
RY
(4)
RW
RY(6)
RY(6)
7
16
High
Low
Flash
Tail
Light
Control
SW
Head
OFF
RY
(3)

< 488> < 536>
Dimmer SW
AVENSIS (EWD625E)
http://vnx.su
1 4B
BG
(1)
B
(2)
1 4A
BG
(1)
1 1A
40A MAIN
WL
Behind the
Combination Meter
HF
HU
HL
WB
EL
D B
RY
(3)
13
RY
13 AVENSIS
RY(4)
RY(4)
RY
(5)
D B
E A
RY
(7 w/ HID)
E A
Headlight Cleaner
Relay< 284>
C12
Combination SW
D B
J 3(A), J 4(B)
2
5
2
RY
WL
HLP Relay
Junction
Connector
WL
WR
WR
(w/ HID)
J29
Junction
Connector
IL
C A
E
WB
RY
(4)
RY
(4)
B
(2)
Battery

Control ECU< 243>
RY
(6)
FL MAIN
3. 0W
RY
(4)
C B
< 284>
C B
RY
(LHD w/ HID)
C A

Control ECU< 243>
J 6(A), J 7(B)
Junction
Connector
RY
(6)
EC
WB
Engine
Compartment
Left
WB
WB
(w/ HID)
R
(w/ HID)
RY
(LHD 7)
Engine
Compartment
Right
WB
WB
(w/o HID)
F7
< 284> < 304>
EB
WB
J2
Junction
Connector
WR
R
(w/o HID)
WB
WB
(w/ HID)
F8
Headlight LH (Low)
R
(w/o HID)
15A
HLP LH
RB
(w/ HID)
WB
(w/o HID)
F9
15A
HLP RH
RL
(w/o HID)
RL
(w/o HID)
F10
Headlight RH (Low)
H e a d lig h t (w /o D a y tim e R u n n in g L ig h t)
High Beam
RW(w/ HID)
R (w/o HID)
E
B
D
A
J 3(A), J 4(B)
Junction
Connector
D
A
10A
HLP HI RH
6 A
C10(A), C11(B)
Combination Meter
RW(w/ HID)
R (w/o HID)
173
174
BG
(3)
120A ALT (5)

100A ALT (6)
B
(4)
BG
(3)
AVENSIS (EWD625E)
http://vnx.su
Behind the
Combination
Meter
WB
Light Control
SW
C12
Combination SW
140A ALT
F1
WB
F2
Engine
Compartment
Right
WB
(RHD)
WB
EB
IK
BS
WB
Behind the
Combination
Meter
J15
Junction
Connector
Lower Back
Panel Left
WB
J31(B)
Lower Back
Panel Center
Junction
Connector
3 C (W/G)
3 B (L/B)
6 A (S/D)
BT
WB
Engine
Compartment
Left
WB
(LHD)
C B
C B
L2
WB
(S/D)
WB
(S/D)
C B
R14(A), (B), (C)

C B
B A
C B
J33(A), J34(B)
A B
A B
BX
Right Side of
the Back Door
A B
Junction
Connector
J34(B)
Junction
Connector
WB
(7)
EC
WB
(RHD)
WB
(S/D)
C10(A), C11(B)
Combination Meter
J16
J17
R13(A), (B), (C)

Junction
Connector
2 C (W/G)
2 B (L/B)
L1
License Plate
Light LH
WB
(7)
Junction
Connector
3 BE2
6 BG2
3 BD2 (L/B)
1 BF2 (W/G)
G
(7)
4 C (W/G)
5 B (L/B)
2 A (S/D)
4 A (S/D)
A B
J30(A), J31(B)
Junction
Connector
G
(7)
IL
WB
(LHD)
Tail
17 A
Tail
5 C (W/G)
6 B (L/B)
4 A (S/D)
Tail
14 B
J10(A), J11(B),
J26(C), J27(D)
Junction
Connector
16
J1
Junction
Connector
Head
EL
G
(L/B)
Tail
4
: Gasoline
: Diesel
: 1ZZFE, 3ZZFE
: L/B, W/G
G
(W/G)
L2
License Plate
Light RH
WB
(7)
Battery
OFF
R
(2)
C C (RHD)
C A (LHD)
G
(S/D)
C C
C A
A B
9 DL
8 DL
A B
L1
G
(S/D)
A B
1
2
3
4
5
6
7
G
(L/B)
14
12 DB
R
(1)
23 DA
C D (RHD)
C B (LHD)
A B
A A
G
(W/G)
FL MAIN
3. 0W
10A
TAIL
G
1 4B
12
TRLY

< 511> < 611> < 77>
Engine ECU (M/T)
< 511> < 611> < 77>
< 5014> < 5112>
Integration
Relay
13
3 IC2
A A
G
(7)
W
(4)
TAIL
Relay
4 DM
1 DN
T a illig h t
1 4D
1 ED1
BL
(4)
BG
(3)
14 AVENSIS
BL
(2)
W
(2)
BG
(1)
B
(2)
10A HAZARD
B
(2)
BG
(1)
AVENSIS (EWD625E)
http://vnx.su
Turn
120A ALT (3)

100A ALT (4)
BG
(1)
F 7(A), F 8(B)
F5
Front Side Turn
Signal Light LH
7. 5A GAUGE2
Engine
Compartment
Left
Engine
Compartment
Right
WB
EB
R14(A), (B), (C)

Rear Combination
Light RH
F6
Front Side Turn
Signal Light RH
WB
(RHD)
WB
Battery
Lower Back Panel

Center (S/D, L/B)
Lower Back Panel
Right (W/G)
WB
BT
Right Kick Panel
J16
Junction
Connector
6 CA
IP
WB
WB
WB
WB
IK
WB
EC
WB
WB
Lower Back
Panel Left
WB
J15
Junction
Connector
GY
(LHD)
WB
(LHD)
11 CF
9 CD 3 CH
IL
WB
(RHD)
BS
GW
3 C (W/G)
WB
WB
F 9(A), F10(B)
Front Turn Signal
Light RH
WB
(LHD)
6 A (S/D)
3 B (L/B)
TR
GND
WB
(LHD)
J17
4 B (6)
4 A (5)
GY
Junction
Connector
WB
(RHD)
Turn
4 C (W/G)
TB
WB
(LHD)
4 B (6)
4 A (5)
4 C (W/G)
5 B (L/B)
5 A (S/D)
TL
ER
6
WB
(RHD)
5 B (L/B)
11 DM
RH
EL
5
F C (RHD)
D A (LHD)
J16
Junction
Connector
IJ
25A AM1
17 A
Turn RH
2 A (S/D)
IG1 Relay
3 B (6)
3 A (5)
6 DL
LH
Off
8
EHW
J10(A), J11(B), J24(C), J25(D)

Junction
Connector
WB
(RHD)
Left Kick Panel
GW
FL MAIN
3. 0W
GW
5 DL
15 DB
C12
Combination SW
3 B (6)
GW
(LHD)
3 A (5)
13 B
GY
3 C (W/G)
E B
J5
Junction
Connector
D
Integration Relay
< 16> < 25>
F C
D A
B B (LHD)
D D (RHD)
H13
Hazard SW
1 4B
GR
1 B
GW
(RHD)
3 B (L/B)
4 DL
J22(A), J23(B)
Junction
Connector
E A
E A
GY
(RHD)
3 A (S/D)
3 DL
GW
(LHD)
GY
BG
(1)
17 DM
GW
(LHD)
D B
F A
GY
(RHD)
GW
(RHD)
F A
GW
(RHD)
GY
(RHD)
6 DB
LR
2
T10
6 IC2
Turn SW
9 DA
J5
Junction
Connector
(RHD)
(LHD)
: Gasoline
: Diesel
: 1ZZFE, 3ZZFE
: w/ HID
: w/o HID
GY
(LHD)
GY
(LHD)
1 4D
27 DA
+B
2 IO1
2 IE3
1
2
3
4
5
6
7
LG
GW
1 4A
GR
WB
(LHD)
LL
IG
6 CC
8 CA
T u rn S ig n a l a n d H a z a rd W a rn in g L ig h t
WB
(RHD)
BL
(2)
GY
WB
(LHD)
GY
1 DN 5 DH
RW
1 DH
GY
RW
IG1 1
Ignition SW
I13
3 AM1
ACC
2
RW
LG
LG
1 ED1
LG
1 1A
15 AVENSIS
WB
(LHD)
C10(A), C11(B)
Combination Meter
Turn LH
WB
R13(A), (B), (C)

Rear Combination
Light LH
140A ALT
175
176
BL
(2)
W
(2)
AVENSIS (EWD625E)
http://vnx.su
Engine
Compartment
Left
G
(4)
140A ALT
BG
(1)
B
(2)
F4
Front Fog
Light RH
Engine
Compartment
Right
Front Fog
Right Kick
Panel
C10(A), C11(B)
Combination Meter
Rear Fog
WB
(4)
WB
(4)
120A ALT (7)

100A ALT (8)
IJ
WB
IP
9 DA
Left Kick
Panel
16 DA
WB
(LHD)
6 CA
6 CG
WB
(LHD)
EB
WB
6 CK
WB
(RHD)
10
Lower Back
Panel Left
BT
R14(A), (B), (C)

Rear Combination
Light RH
Lower Back Panel

Center (S/D, H/B)
Lower Back Panel
Right (W/G)
3 C (W/G)
4 C (W/G)
BS
3 B (L/B)
5 B (L/B)
WB
6 A (S/D)
2 A (S/D)
WB
(LHD 5)
EC
5 B
C12
Combination SW
Rear (3)
5 C (W/G)
WB
(RHD 5)
Battery
G
(4)
G
(4)
G
(4)
RW
(5)
A A
Fog Light
SW
FL MAIN
3. 0W
A A
G
(4)
Rear (6)
7 B (L/B)
2 C (W/G)
R13(A), (B), (C)

Rear Combination
Light LH
3 A (S/D)
1 B (L/B)
Fog
1 4B
G(4)
Front (4)
RR
R8
Rear Fog
Light Relay
5 A (S/D)
RW
(5)
Fog
J 3(A), J 4(B)
Junction
Connector
EF
12
11
FR
5 IC3
13 IC2
WR
(5)
RY
(4)
G(4)
OFF
FR FOG
Relay
WR
(5)
8 A
C D (RHD)
C B (LHD)
RW
(5)
7 A
C A (LHD)
C C (RHD)
G
(5)
1
2
3
4
5
6
: Gasoline
: Diesel
: w/ Front Fog Light and Rear Fog Light
: w/ Front Fog Light
: w/ Rear Fog Light
: w/ Rear Fog Light
w/o Front Fog Light
8 : 1ZZFE, 3ZZFE
RW
(LHD 5)
C B
3 IC2
G
(5)
R e a r F o g L ig h t
RW
(RHD 5)
BG
(1)
10A
TAIL
J10(A), J11(B), J26(C), J27(D)

Junction Connector
TAIL
Relay
G
(4)
1 4D
15A
FR FOG
4 DM
G
(4)
1 DN
7. 5A
RR FOG
Taillight System
< 141>
J30
Junction
Connector
A
A
GY
(4)
RY
(5)
24 DA
GY
(4)
10 DA
F ro n t F o g L ig h t
RY
(5)
1 ED1
11 IC2
RY
(5)
16 AVENSIS
F3
Front Fog
Light LH
17 AVENSIS
BG
(1)
AVENSIS (EWD625E)
http://vnx.su
Lower Back
Panel Left
4 C (W/G)
5 B (L/B)
2 A (S/D)
6 A (S/D)
120A ALT (3)

100A ALT (4)
GW
(5)
< 324>
GW

< 206> < 215>
140A ALT
B
(2)
Lower Back Panel

Center (S/D, L/B)
Lower Back Panel
Right (W/G)
3 BG1
2 BE1
2 BD1 (L/B)
4 BF1 (W/G)
WB
(W/G)
WB
BT
WB
(L/B, W/G)
3 C (W/G)
3 B (L/B)
R14(A), (B), (C)

Rear Combination
Light RH
WB
(L/B)
WB
BS
WB
1 C (W/G)
4 B (L/B)
7 A (S/D)
J30(A), J31(B)
Junction
Connector
WB
(L/B)
BX
1 BE1
A B
A A
WB
(L/B, W/G)
Right Side of
the Back Door
WB
(W/G)
J33(A), J34(B)
Junction
Connector
1 BD1 (L/B)
3 BF1 (W/G)
L
(W/G)
: Gasoline
: Diesel
: 1ZZFE, 3ZZFE
: w/ Shift Lock
WB
(L/B)
Battery
C B
J30(A), J31(B)
Junction
Connector
R13(A), (B), (C)

Rear Combination
Light LH
B B
C A
GW
(L/B, W/G)
1
2
3
4
5
H20
High Mounted
Stop Light
FL MAIN
3. 0W
H20
High Mounted
Stop Light
B A
6 C (W/G)
1 A (S/D)
4 B (L/B)
J32
Junction
Connector
B B
WB
(S/D)
Stop
BG(1)
W
(2)
Stop
C A
GW
10 DC
1 DB
1 DM
C A
GW
GW
(L/B)
BL
(2)
GW
2 DL
2 DA
GW
(S/D)
GW
L
(L/B)
1 IR1
GW
(RHD)
WB
(S/D)
1 ED1
GW
(LHD)
S13
Stop Light SW
4 BG1
GW
(W/G)
1 4B
RW
(LHD)
1 DN
RW
(RHD)
15A
STOP
6 IE3
GW
(LHD)
GW
(RHD)
22 DA
2 IR1
S to p L ig h t
GW
(L/B, W/G)
RW
(LHD)
11 IE3
RW
(RHD)
GW
(L/B, W/G)
1 4D
N8
Noise Filter
(Stop Light)
WB
(W/G)
WB
(L/B, W/G)
WB
(S/D)

< 512> < 611> < 78>
Engine ECU (M/T)
< 512> < 611> < 78>
< 89> < 5011> < 519>
177
18 AVENSIS
178
BL
(2)
W
(2)
AVENSIS (EWD625E)
http://vnx.su
Left Kick Panel
1
2
3
4
5
6
7
8
WB
IJ
RW
: Gasoline
: Diesel
: 1ZZFE, 3ZZFE
: w/ MultiDisplay
: w/o Rear Fog Light
: w/ Rear Fog Light
: w/o Winter Package
w/o Moon Roof,
w/o Rear Power Window,
w/o Headlight Cleaner,
w/o Front Fog Light,
w/o Daytime Running Light or w/o MultiDisplay
9 : LHD Except 4 LHD S/D M/T 8
10 : Except 11 M/T
11 : 1AZFSE, 1AZFE, 2ADFHV, 2ADFTV
R13(A), (B), (C)
6 C (W/G)
B
(2)
BT
R14(A), (B), (C)

Rear Combination
Light RH
Lower Back Panel

Center (S/D, L/B)
Lower Back Panel
Right (W/G)
4 C (W/G)
Lower Back
Panel Left
3 C (W/G)
5 B (L/B)
WB
BS
6 A (S/D)
3 B (L/B)
2 A (S/D)
WB
Rear Combination
Light LH
6 B (L/B)
1 C (W/G)
BackUp
WB
Battery
8 CA
27 DA
BL
(2)
RW
9 DA
2 A (S/D)
RB
(6)
2 B (L/B)
6 A (S/D)
RB
(6)
BackUp
FL MAIN
3. 0W
1 4B
140A ALT
BG
(1)
RW
1 CD
RB
(RHD 7)
7. 5A
GAUGE2
8 IC2
RB
(LHD 7)
BG
(1)
C B
A A
J32
Junction
Connector
N 1(A)
Neutral Start SW
B 1(B)
BackUp Light SW
1 IK1
RW
2 B (M/T)
3 A (A/T)
A A
RY
(RHD)
RB
(6)
IG1
Relay
RY(10)
RB(11 M/T)
1 B (M/T)
RY
(RHD 5)
25A
AM1
BG
(1)
1 DN
C
RY
(LHD 5)
GR
1 DH
RY
(RHD)
2 A (A/T)
J5
Junction Connector
RY
(9)
1 4D
GY
5 DH
5 IK1
RY
(4 LHD S/D M/T 8)
RY
(4 LHD S/D M/T 8)
I13
Ignition SW
IG1 1
ACC
RY
(9)
3 AM1
GR
B a c k U p L ig h t
RY
(9)
1 ED1
Navigation ECU
< 396>
Option Connector
J22(A), J23(B)
Junction Connector
RY
(RHD)
120A ALT (3)

100A ALT (4)
180
BL
(2)
1 ED1
BG
(1)
W
(2)
30A DCC
BW
BG
(1)
B
(2)
140A ALT
AVENSIS (EWD625E)
http://vnx.su
25A AM1
Left Kick Panel
INTB
Integration Relay
15
TRLY
7. 5A PANEL
13
TOUT
14
10A TAIL
120A ALT
BG
(1)
B
(2)
(3)
Behind the
Combination
Meter
CPU
C C
C A
IK
WB
(RHD)
WB
IL
WB
(LHD)
J16
Junction
Connector
WB
(4)
C10(A), C11(B)
Combination Meter
12 DB
12
17 A
20 B
WB
(RHD)
WB
IJ
H B
F C
F A
WB
(RHD)
Battery
25
21 B
F C
14 B
WB(RHD)
J17
Junction
Connector
WB
WB(RHD)
Behind the
Combination Meter
Junction
Connector
J15
5 B
C C (RHD)
C A (LHD)
J10(A), J11(B), J26(C)

Junction Connector
FL MAIN
3. 0W
1 4B
GR
9 DA
TAIL Relay
GR
GY
6 CD
7 CA
WR
: Gasoline
: Diesel
: Power Heater (Hot Gas Type)
Tail
BG
(1)
BL
(2)
GY
4 DM
RW
1
2
3
4
WR
(RHD)
1 4D
RW
1 4A
6 DJ
G
(3)
G
(3)
9 DJ
J30
Junction
Connector
19 DB
7 DB
5 DH 1 DN
G
(4)
1 DH
GW
(3)
3 IC2
8 CI
RW
1 1A
IG1 1
5 CA
WR
(LHD)
(RHD)
BW
(LHD)
7. 5A DOME
5 IP1
I13
Ignition SW
3 AM1
ACC
Illu m in a tio n
(Cont. next page)
4 IE4
WR
19 AVENSIS
Illumination
P5
Power Heater SW
Taillight System
< 141>
10A GAUGE1
IG1 Relay
M1
MultiDisplay
H16
WB
(9)
2 CI (LHD)
5 CD (RHD)
10 CH
4 CG
5 CJ
F20
WB
(7)
WB
(LHD)
WB
(RHD)
AVENSIS (EWD625E)
http://vnx.su
5 CI
11 CJ
8 CH
H13
Hazard SW
Right Kick Panel
H15
11 CE
WB
(LHD)
WB
IP
WB
(LHD)
3 CG
2 CH
10 : Manual A/C
11 : Automatic A/C (Except 2ADFHV, 2ADFTV)
16 : Automatic A/C (2ADFHV, 2ADFTV)
9 CH
WB
(RHD)
WB
(RHD)
WB
(RHD w/ VSC)
F19
Rear Window
Defogger SW
8 (LHD)
1 (RHD)
ILL+
5 (LHD)
4 (RHD)
WB
(LHD)
6 CA
9 CD
WB
(6)
6 CK
ILL
2
M1
MultiDisplay
WB
(5)
GND
WB
(8)
WB
T9
TRC Off SW
WB
(LHD w/ VSC)
A13(A), A16(D), A37(F)

21 F (16)
13 D (11)
TAIL
13
3 CI
WB(RHD)
G3
Glove Box Light
40 A (10)
GND
ILL+
ILL+
10
3 CJ
8 CJ

: w/o Navigation System (Map Type)
: w/ Headlight Beam Level Control w/o HID
(Cont. next page)
WB
(RHD)
WB(RHD)
G
(7)
39 F (16)
G
(6)
23 D (11)
1 CH
G
(5)
8 CK
5
6
7
8
G
(8)
21 A (10)
2 CJ
G
(9)
11 CA
G
(w/ VSC)
1 CJ
Illu m in a tio n
WB
(RHD)
WB
(RHD w/ VSC)
WB
(RHD)
181
182
G
(RHD 14)
E8
ECT Pattern
Select SW
WB
(14)
AVENSIS (EWD625E)
http://vnx.su
Left Kick
Panel
WB
(RHD)
WB
(RHD)
WB
(RHD w/ VSC)
Lower Back
Panel Left
WB
(15)
WB
WB
(RHD)
Behind the
Combination Meter
WB
(LHD)
IK
J15
Junction
Connector
IP
WB
(LHD)
BS
WB
(RHD)
GND
ILL
J17
Junction
Connector
A
Right Kick Panel
T7
IJ
J30(A), J31(B)
Junction
Connector
IN
GND
ILL+
10
12 CA
12

15 : w/ Seat Heater
Instrument Panel
BR(LHD)
WB(RHD)
IL
WB
(RHD)
C B
J32
Junction
Connector
WB
(12)
J16
Junction
Connector
9 DA
WB
(15)
B A
S7
Seat Heater SW
R11
C14
Combination SW
WB
WB
(RHD)
P8
Personal Light
6 DK
Behind the
Combination Meter
12 CF (LHD)
9 CH (RHD)
10
EAU
WB
(5)
G
(LHD 14)
WB
(15)
WB
(RHD w/ VSC)
G
(LHD 13)
ILL+
8 IC1
7 ID1
F B
F B
G
(LHD)
G
(15)
F B
G
(15)
G
(RHD)
C7
Cigarette Lighter
Illumination
F B
H A
G
(12)
WB
(RHD)
J 8(A), J 9(B)
Junction Connector
1 CF
7 CH
G
(5)
G
(RHD 13)
H A
4 CI
11

13 : w/ Steering SW
G
(A/T)
WB
(RHD)
G
(RHD)
J19
G
(LHD)
Junction
Connector
4 CD
10
Illu m in a tio n
R4
Radio and Player
WB
(A/T)
P5
Power Heater SW
Audio System
< 412>
20 AVENSIS
184
25A VSC
W
(2)
140A ALT
AVENSIS (EWD625E)
http://vnx.su
W
(2)
B
(2)
B
(2)
25A VSC
BG
(1)
1
1 1A
25A AM1
Left Kick Panel
9 DA
FL+
41
24
FL
21
FR+
S1
BZ
15
FR
22
RL
RL
LY
LY
WB
50A VSC
B
(2)
A5
ABS Speed Sensor
Front RH
A4
ABS Speed Sensor
Front LH
WB
EA
GND1
GND2
10
WB
10A GAUGE1
7 DB
IG1
14
C D (RHD)
WB
IJ
18 DB
5
+BS
9
+BM
C C (RHD)
G A (LHD)
G B (LHD)
C C
G A
RW
Battery
FL MAIN
3. 0W
1 4A
BG
(1)
1 4B
BL
(2)
50A VSC
120A ALT
(2AZFSE, 1AZFSE)
100A ALT
(1ZZFE, 3ZZFE)
BR
GR
GY
BG
(1)
5 DH 1 DN
RW
BL
(2)
RW
1 DH
7 CA
3 IE1
J10(A), J11(B), J20(C), J21(D)

Junction Connector
I13
Ignition SW
L
(1)
(RHD)
(LHD)
R
(1)
1 IP1
1 IE4
RW
ST2
V7
VSC Warning
Buzzer
R
(1)
1 ED1
L
(1)
BY
1 1B
BG
(1)
1 4D
L
(2)
6 CD
R
(2)
BR
IG2 6
RW
4 AM2
BR
22 IE1
2
Buzzer
BY
GY
RW
R
(2)
L
(2)
IG1 1
ACC
RW
3 AM1
1 : Gasoline
2 : Diesel
RW
GR
A B S (w / V S C ) a n d T R C a n d V S C
RW
RW
BR
(Cont. next page)
7. 5A ECUIG
IG1 Relay
30A AM2
B
(2)
BW
BR
RL+
P4
Parking Brake SW
AVENSIS (EWD625E)
http://vnx.su
GY
WB
(LHD)
R
WB
(RHD)
WB
(LHD)
IL
Behind the
Combination
Meter
IK
Behind the
Combination Meter
J15
Junction
Connector
B B
B A
J 6(A), J 7(B)
Junction Connector
A A
(Shielded)
IP
WB
(LHD)
D A
B B
D A
D B
B A
E B
A A
(Shielded)
(Shielded)
Right Kick Panel
J16
Junction
Connector
B
(LHD)
6 CA
CANH
CANL
CAN
LOW
CAN
HIGH
7
12V
6
GND
W
(LHD)
10 CJ
B
(LHD)
T9
TRC Off
SW
W
(LHD)
UBAT
GND
B
WL
(LHD)
B
C
C
WG
(LHD)
B
(LHD)
A33
ABS Speed Sensor
Rear RH
3 IE8
WG
(LHD)
10 IE8
E2
12
Y1
Yaw Rate
Sensor
WB
(RHD)
9 IE8
W
(LHD)
2 IE8
PMC
11
WG
(LHD)
1 IE8
VCM
27
WL
(LHD)
10 IM1
14 IE1
YIGA
30
YGND
WL
(LHD)
16
(RHD)
(LHD)
O1
Oil Pressure Sensor
WG
(LHD)
1 IM1
11 IE2
GY
10 IE2
SS1
NEO
13
SS2
32
7
ENG
8
ENG+
29
TRC
19
B
(LHD)
WL
(LHD)
CSW
S1
TRC+
W
(LHD)
BR
J18
Junction
Connector
BW
S12
Steering
Sensor
A32
ABS Speed Sensor
Rear LH
BW
42

< 475> < 488> < 535>
RR
MultiDisplay
< 396>
39
LW
(Shielded)
1 IB1
RR+
Combination Meter
< 424>
18
STP
3 IE2
L
SP1
15 IE2
Y
13 IE2
5 IE8
13 IE1
14 IE2
B
38
GW
37
Stop Light SW
< 171>
35
14 IE8
W(4)
Y(3)
7 IE8
B
YB
PKB
13 IE8
YB
31
Engine and
ECT ECU (A/T)
< 510> < 511>
< 710> < 711>
Engine ECU (M/T)
< 510> < 511>
< 710> < 711>
< 811> < 812>
< 5015> < 5111>
< 5112>
6 IE8
(Cont. next page)

3 : LHD, RHD 1CDFTV, RHD 2ADFHV, RHD 2ADFTV
4 : Except 3
YG
2 IB1
RL
BW
GR
40
3 DB
BW
2 IE2
4 DC
BW
8 DM
BW
(5)
2 DC
YR
23
(Shielded)
185
186
RW
BR
J 8(A), J26(B)
Junction Connector
10A IGN
BW
YIGA
(Shielded)
W
(RHD)
B
(RHD)
IND
AVENSIS (EWD625E)
http://vnx.su
WG
(RHD)
WL
(RHD)
W
(RHD)
B
(RHD)
WG
(RHD)
Y1
Yaw Rate
Sensor
F
B
(RHD)
B
(RHD)
CAN
HIGH
1
CAN
LOW
12V
W
(RHD)
5
GND
B B
B A
WL
(RHD)
B A
S12
Steering
Sensor
CANH
W
(RHD)
CANL
4
UBAT
WL
(RHD)
GND
WL
(RHD)
WG
(RHD)
J22(A), J23(B)
Junction
Connector
A B
C A
EBDW
20
WL
(RHD)
C A
WA
36
S1
WT
Combination Meter
System< 4211>
WB
(RHD)
D/G
TC
17
Behind the
Combination
Meter
DLC3
< 518> < 713> < 814>
< 5018> < 5114>
WG
(RHD)
(Shielded)
IK
26
WL
J19
Junction Connector
12 IO1
WG
(RHD)
11 IO1
30
WL
(RHD)
16
YGND
VSCW
WR
LG
34
18 IE1
17 IE1
2 B
17 A
J22(A), J23(B)
Junction
Connector
4 B
7 IE1
WR
8 IE1
LG
LGB
6 IE1
LGB
RY
WG
TS
28
Behind the
Combination
Meter
IL
J17
Junction
Connector
A
WB
(RHD)
9 A
RY
W
WB
(LHD)
17 B
22 B
11
WB
(RHD)
11 IO2
21 B
WB(RHD)
WB(LHD)
WB
(LHD)
12 IO2
15 B
Slip
13 IO2
SS1
VSC
16 B
RW
10
BW
ABS
P
13
C10(A), C11(B)
Combination Meter
TRC OFF
P
29
SS2
A B (RHD)
C A (LHD)
A B (RHD)
C A (LHD)
BW
18 DA
2 DH
J16
Junction
Connector
12
DLC3
< 519> < 715> < 816>
< 5020> < 5116>
J15
Junction
Connector
(Shielded)
Brake
(Shielded)
WG
(RHD)
21 AVENSIS
188
L
(2)
W
(2)
40A ABS
W
(2)
140A ALT
AVENSIS (EWD625E)
http://vnx.su
B
(2)
40A ABS
120A ALT (3)

100A ALT (4)
25A AM1
Left Kick Panel
BG
(1)
25A ABS
B
(2)
B
(2)
WB
(RHD)
WB
(RHD)
IK
WB
(LHD)
IL
J16
Behind the
Combination
Meter
Junction
Connector
4 B
P
2
+BM
17 IE1
18 IE1
22
WB
EA
Engine
Compartment
Right
S2
WA
GND2
GND1
+BS
: Gasoline
: 1CDFTV
: 1AZFE
: 3ZZFE
WB
BR
WB
30A AM2
B
(2)
BG
(1)
Behind the
Combination
Meter
J15
Junction
Connector
WB
(LHD)
IJ
7. 5A ECUIG
RY
J17
Junction
Connector
9 A
12
EBDW
IG1
18
22 IE1
17 A
22 B
1
2
3
4
WB
Battery
9 DA
2 B
RY
FL MAIN
3. 0W
1 4A
25A ABS
BG
(1)
1 4B
BL
(2)
1 1A
ABS
BR
10A IGN
GR
GY
RW
18 DB
A B (RHD)
C A (LHD)
C B (RHD)
G A (LHD)
RW
BG
(1)
5 DH 1 DN
Combination Meter
System< 4211>
1 DH
J 8(A), J26(B)
Junction
Connector
R
(1)
I13
Ignition SW
BW
(RHD)
(LHD)
J10(A), J20(B)
Junction
Connector
L
(1)
1 IP1
1 IE4
2 DH
A B (RHD)
C A (LHD)
RW
1 4D
ST2
BR
IG2 6
C B (RHD)
G A (LHD)
R
(2)
L
(1)
R
(1)
4 AM2
BR
GY
IG1 1
18 DA
BW
L
(2)
BL
(2)
1 ED1
BG
(1)
1 1B
3 AM1
GR
ACC
BW
R
(2)
A B S (w /o V S C )
RW
(Cont. next page)
RY
C10(A), C11(B)
Combination Meter
Brake
IG1 Relay
10 IM1
1 IM1
R
11 IE2
RR+
10 IE2
1 IB1
A33
ABS Speed Sensor
Rear RH
2 IB1
17
7
A32
ABS Speed Sensor
Rear LH
FR+
10
A5
ABS Speed Sensor
Front RH
RL
FL
PN
G
(A/T)
21
1 IE2
G
(A/T)
FL+
LY
LW
23
Combination Meter
< 424>
SP1
Stop Light SW
< 171>
GW
STP
A4
ABS Speed Sensor
Front LH
20
19
PKB
FR
13
D2
Diode
3
Neutral Start SW
< 1111>
R
(A/T)
WL
(A/T)
25
W
DLC3
< 615> < 715> < 816>
TS
WL
TC
DLC3
< 614> < 713> < 814>
S2
RL+
RL
14
11
WG
D/G
BW
2 IE2
BW
3 DB
4 DC
BW

< 475> < 488>
RR
BW
BW
(5)
2 DC
MultiDisplay
< 396>
8 DM
P4
Parking
Brake SW
A B S (w /o V S C )
AVENSIS (EWD625E)
http://vnx.su
189
22 AVENSIS
190
BL
(2)
BG
(1)
B
(2)
W
(2)
AVENSIS (EWD625E)
http://vnx.su
120A ALT
(3)
100A ALT
(1ZZFE, 3ZZFE)
140A ALT
25A AM1
Left Kick Panel
Right Kick Panel
5 B
WB
30A AM2
BG
(1)
B
(2)
6 CA
6 CK
A
WB
(RHD)
WB
WB
GR
Battery
IK
Behind the
Combination
Meter
J15
Junction
Connector
J17
Junction
Connector
14 A
17 A
22 B
IL
WB
(LHD)
IP
C10(A), C11(B)
Combination Meter
CPU
BEAN
I/F
13 A
WB
(RHD)
IJ
20 B
H B
F C (RHD)
F A (LHD)
WB
(LHD)
FL MAIN
3. 0W
1 4B
9 DA
21 B
J10(A), J11(B), J26(C)

Junction Connector
WR
(LHD)
BG
(1)
GR
GY
BL
(2)
GY
RW
6 CD
WR
(RHD)
1 4A
BG
(1)
7 DB
BR
5 DH 1 DN
RW
1 DH
RW
7 CA
F C
2
System (BEAN)< 115> < 211>
1 4D
I13
Ignition SW
ST2
IG2 6
IG1 1
WR
1 1A
4 AM2
3 AM1
ACC
7. 5A DOME
BW
(RHD)
(LHD)
BW
1 IE4
1 IP1
30A DCC
BR
5 IP1
SRS
Behind the
Combination
Meter
Junction
Connector
J16
SRS
8 B
1 : Gasoline
2 : Diesel
BY
BW
4 IE4
BR
BW
1 ED1
BY
BW
BR
(Cont. next page)
10A GAUGE1
IG1 Relay
BY
BW
BR
BY
AVENSIS (EWD625E)
http://vnx.su
WB
Left Kick Panel
4 IO3
SL
A9
Airbag Sensor
Front LH
WR
SL+
YR(4)
BR (5)
1
SR
A10
Airbag Sensor
Front RH
SR+
2 IO3
1 IO3
YG
A29
Airbag Squib
3 IO3
WB
IJ
WB
2 IE7
WR
1 IE7
SL
26 B
BR
4 IE7
SR+
9 B
3 IE7
SR
20 B
SL+
15 B
(RHD)
(LHD)
P16
Pretensioner
LH
P17
Pretensioner
RH
PR
10 C
PR+
9 C
PL
7 A
SIL
TC
PL+
8 A
12 B
19 B
YB
A30
Airbag Squib
YB
YG
P2
7 B
YB
P2+
8 B
GSW2
23 B
9 DA
P
11 B
DK
11 C
YB
3 DD
P+
10 B
D2
17 B
YR
D2+
16 B
BW
YR
D+
14 B
10A IGN
D
13 B
DK+
12 C
YB
(w/ Knee Airbag)
4 DD
E2
28 B
A26(A), A27(B), A28(C)

LGB
(1)
IG2
WL
E1
27 B
BW
5 B
9 DD
11 DA
WG
LA
A B (RHD)
C A (LHD)
2 IN1
YR
(w/ Knee Airbag)
1 IN1
(Cont. next page)
DLC3
< 518> < 614>
< 713> < 814>
< 5018> < 5114>
3 B
BW
J 8(A), J26(B)
Junction Connector
YB
(w/ Knee Airbag)
A B (RHD)
YR
(w/ Knee Airbag)
K3
Knee Airbag Squib
1 : Gasoline
4 : LHD Diesel
5 : Except LHD Diesel
LGB
(1)
C A (LHD)
5 DD
SRS

< 511> < 611> < 78>
Engine ECU (M/T)
< 511> < 611> < 78>
6 DD
12 DA
18 DA
2 DH
BR
191
192
C16
GR
AVENSIS (EWD625E)
http://vnx.su
C17
Curtain Shield
Airbag Squib
LH
S14(A), (B)
BBL
1 B (7)
S18
Side Airbag
Squib LH
GSW1
DBEW
4 B
14 DB
2 DD
3 C (RHD)
LBE(LHD)
RBE(RHD)
2 A (LHD)
LSP(LHD)
RSP(RHD)
2 C (RHD)
LSP+
RSP+
1 C
14 C
LBE+
RBE+
3 A (LHD)
4 A
19 A
LR
Side Airbag
Sensor LH
BBL+
2 B
GRL
LGB
3 A (6)
YV
(6)
4 A
SFL
11 A
SFL+
12 A
ICL
10 A
SFR
SFR+
YR
(6)
ICL+
9 A
ICR
YR
BBL
18 A
ICR+
YG
BBL+
16 A
A26(A), A27(B), A28(C)
BBR
6 C
LR
BCL
2 A
BBR+
YV
(6)
5 C
YR
7 C
YG
8 C
GY
15 C
YR
(6)
LB
17 C
1 B (7)
BBR
3 A (6)
Buckle SW
(Driver' s Side)
B9
Seat Position
Airbag Sensor
BCL+
1 A
2 B
BBR+
4 A
S19
Side Airbag
Squib RH
GRB
GRR
(6)
BCR
2 A
C18
Curtain Shield
Airbag Squib RH
11
GRB
12
6 : w/ Curtain Shield Airbag

7 : w/o Curtain Shield Airbag
Buckle SW
LB
(6)
LG
(6)
L
(6)
BCR+
1 A
S15(A), (B)
Side Airbag
Sensor RH
10
SRS
GY
C15

Sensor RH
WB
LB
WB
Integration Relay
< 16> < 25>
AVENSIS (EWD625E)
http://vnx.su
BG
50A EMPS
BG
Left Kick Panel
WB
IJ
WB
(LHD)
IL
Behind the
Combination Meter
J16
Junction
Connector
J10(A), J11(B),
J20(C), J21(D)
Junction
Connector
Behind the
Combination
Meter
J15
Junction
Connector
6 B
WL
9 B
M1
M2
TACH
12 B
Torque Sensor
TRQV TRQ1 TRQ2 TRQG
E14(A), E15(B)
EPS ECU
IDUP
8 B
5 B
SPD
SIL
2 B
Behind the
Combination
Meter
TS
TC
2 A
PGND
11 B
4 B
IM
WB
IK
WB
(RHD)
Battery
WB
(RHD)
J17
Junction
Connector
WB
(LHD)
17 A
P/S
FL MAIN
3. 0W
BG
VW
1 4B
J 8(A), J26(B)
Junction
Connector
BW
1 4A
RW
9 DA
RLY
3 B
WR
PIG
GR
1 A
GRR
IG
WG
6 B
5 IE1
DLC3
< 714>
22 B
WL
1 4D
C D (RHD)
Engine and ECT

ECU (A/T)< 711>
Engine ECU (M/T)
< 711>
G B (LHD)
C C (RHD)
G A (LHD)
EMPS
Relay
DLC3
< 714>
1 1A
BR
A B (RHD)
C A (LHD)
A B (RHD)
C A (LHD)
1 DN
BW
1 DH
EPS
DLC3
< 715>
BR
18 DB
18 DA
2 DH
10A IGN
WR
GY
5 DH
RW
(RHD)
BR
GY
BR
RW
1 IP1
(LHD)
I13
Ignition SW
IG2 6
4 AM2
ST2
IG1 1
3 AM1
ACC
GR
1 IE4
BG
23 AVENSIS
Combination Meter
< 424>
EPS Motor
BW
C10(A), C11(B)
Combination Meter
25A AM1
7. 5A ECUIG
IG1 Relay
GR
100A ALT
30A AM2
193
194
BL
(2)
BG
(1)
B
(2)
W
(2)
AVENSIS (EWD625E)
http://vnx.su
140A ALT
BG
(1)
B
(2)
1
2
3
4
30A AM2
: Gasoline
: Diesel
: 1ZZFE, 3ZZFE
Left Kick Panel
WB
120A ALT (3)

100A ALT (4)
IP
WB
IJ
10
Beam Level
Battery
J 8(A), J26(B)
Junction
Connector
Right Kick Panel
H18
(Front)
SHG
WG
WR
SHFR

(Rear)
H19
2
SHRR
1
SHB
SHG
6 IM1
BW
SGR
20
7 IM1
SHR
RH3
22
8 IM1
SBR
RH1
13
SHB
5 IH1
3
RH2
(RHD)
(LHD)
12 IE1
GW
FL MAIN
3. 0W
6 CA
SGF
21
4 IH1
WG
3 IH1
SHF
WR
22
WB
(RHD)
2 CI
SBF
15
LH3
23
1 4B
WB
(LHD)
10 CE
LH1
14
BW
A B (RHD)
C A (LHD)
A B (RHD)
E1
24
LH2
BG
(1)
WB
GW
IG1 Relay
BW
11
WNG
SPDR
HDLP
2 IO2
2 IE6
8 IO2
8 IE6
6 IO2
6 IE6
1 IO2
1 IE6
7 IO2
7 IE6
H14
12
10
RW
IG
RY
C A (LHD)
HLP Relay
< 17> < 132>
VW
Combination Meter
< 423>
10A
IGN
5 CK
8 CA
H2
Control Actuator RH
BW
18 DA
2 DH
9 DA
7. 5A
GAUGE2
GY
BL
(2)
27 DA
BR
RW
5 DH
BW
1 4A
BG
(1)
1 DN
GY
1 4D
25A
AM1
GR
1 DH
H1
Control Actuator LH
LW
1 1A
I13
Ignition SW
RW
PL
BR
(RHD)
(LHD)
BR
GY
GY
1 IP1
1 IE4
IG2 6
4 AM2
BR
ST2
IG1 1
ACC
3 AM1
GR
H e a d lig h t B e a m L e v e l C o n tro l (w / H ID )
LW
1 ED1
PL
24 AVENSIS
LG
C11
Combination Meter
BW
25 AVENSIS
BL
(2)
W
(2)
AVENSIS (EWD625E)
http://vnx.su
B
(2)
G
GY
WB
120A ALT (3)

100A ALT (4)
B
(2)
GY
C A (LHD)
C B (RHD)
C A (LHD)
C B (RHD)
6 CA
11 CE (LHD)
5 CI (RHD)
Right Kick Panel
H15
Control SW
GY
WB
H1
Control Actuator LH
IP
WB
EC
H2
Control Actuator RH
PL
J10(A), J26(B)
Junction
Connector
J 3(A), J 4(B)
Junction Connector
PL
12 IE1
3
IC2
A B
GY(5)
GR(6)
C A
C A
J30
Junction
Connector
WB
Battery
FL MAIN
3. 0W
1 4B
140A ALT
BG
(1)
BG
(1)
4 DM
8 DL
J1
Junction
Connector
10A
TAIL
1 4D
TAIL
Relay
Taillight System
< 141>
1 DN
BG
(1)
BL
(2)
H e a d lig h t B e a m L e v e l C o n tro l (w /o H ID )
1 ED1
1 : Gasoline
2 : Diesel
4 : 1ZZFE, 3ZZFE
5 : Except RHD Diesel
6 : RHD Diesel
WB
GY
PL
195
26 AVENSIS
196
BL
50A AM1 NO. 1
AVENSIS (EWD625E)
http://vnx.su
140A ALT
BG
(1)
B A
G
(RHD)
H11
Horn LH
WB
IJ
25A AM1
Engine Compartment
Left
EC
WB
G
(LHD)
G
(5)
EI
1 EE1
2
2
LR
Left Kick Panel
H12
Horn RH
12 IL2
12 IA2
WB
J32
Junction
Connector
F23
Fuel Lid
Opener
Motor
(RHD)
(LHD)
F24
Fuel Lid
Opener SW
(RHD)
(LHD)
C B
B A
WB
F15
Fuel Heater
GW
C14
Combination SW
Horn SW
Theft Deterrent ECU

< 28>
15A HORN
25A FHTR
B
(2)
BG
(1)
BS
Lower Back
Panel Left
J30(A), J31(B)
Junction
Connector
: Gasoline
: Diesel
: 1ZZFE, 3ZZFE
WB
Near the Starter
18 IC2
LR
GW
9 DA
13 IL2
13 IA2
1
2
3
4
5
10A
FUEL OPN
F u e l L id O p e n e r
WB
Battery
FL MAIN
3. 0W
B A
J26(A), J27(B)
Junction
D B
Connector
(RHD)
(LHD)
WB
G
(RHD)
LR
20 IE1
13 IE1
1 1A
LR
B
(2)
B
(2)
120A ALT (3)

100A ALT (4)
1 4A
1 DN
FHTR
Relay
1 4B
HORN
Relay
1 DH
LR
W
(2)
50A AM1 NO. 1
10 DL
1 6A
LB
W
(1)
5 DH
RL
1 1B
GY
1 ED1
IG1 1
GY
I13
Ignition SW
3 AM1
RL
LB
GR
ACC
GR
(RHD)
F u e l H e a te r
BL
W
(2)
2 IP1
(LHD)
H o rn
1 IE5
7. 5A ECUIG
IG1 Relay
27 AVENSIS
W
(2)
BG
(1)
120A ALT (3)

100A ALT (4)
25A WIP
BG
(1)
AVENSIS (EWD625E)
http://vnx.su
IG1 Relay
LR
WB
140A ALT
Behind the
Combination Meter
GND
IK
WB
J2
Junction
Connector
WB
WB
WB
25A AM1
ED
R12
Rain Sensor
VCC RS
WF
J15
Junction
Connector
12
WF
WF
11
WL
F13
Front Wiper Motor
Left Side of the

Suspension Tower
5 (LHD)
4 (RHD)
2
2
RSSIGNAL
WB
3 ID1
13 ID1
12 ID1
22
VR2
24
14
VR2
EW
IL
WB
IJ
LR
+2
+1
BR
3 (LHD)
1 (RHD)
RW
4
3
(LHD)
(RHD)
LG
1
5
10 IO1
Engine ECU
< 5015>
< 5112>
G
3 IO1
23
SG
VR1
20
12
VR1
WB
Left Kick Panel
RW
(8)
PB
: Gasoline
: Diesel
: 1ZZFE, 3ZZFE
: Except 5
: LHD 2ADFHV, LHD 2ADFTV
: RHD 2ADFHV, RHD 2ADFTV
BR
10 IE3
RW
(LHD)
3 IE3
LG
8 IO1
19
SP
F2
11
15
PB
1
2
3
4
5
6
7
8
J24(A), J25(B)
Junction
Connector
B
(2)
FL MAIN
3. 0W
BR
8 IE3
RW
(7)
F1
AUTO
EW
WL
WL
(5)
(LHD)
(RHD)
1 IE3
1 IO1
Behind the
Combination Meter
WL
(5)
WL
(6)
18 DL
W2
Wiper Relay
RSI
+1
16
13
WF
J2
Junction
Connector
17
+B
+S
On
Off
F11
Front Washer Motor
9 DA
J14
Junction
Connector
RW
(RHD)
+S
RW
(RHD)
LR(RHD)
+2
16
LY
B RW(LHD)
8
+B
17
GR
C A
+2
AUTO
GRR
1 4B
BG
(1)
C A
A B
LR
(RHD)
A B
RW
(RHD)
8
RW
(LHD)
LR
(LHD)
26 DA
RW
(RHD)
LR
(LHD)
LR
17 DL
+1
+S
LGB
GY
1 DN 5 DH
HI
LO
+2
LR
(LHD)
+1
WL
BL
(2)
LR
(RHD)
LR
(LHD)
A A
OFF
AUTO
+B
LR(RHD)
BL
(2)
J14
J24(A), J25(B)
Junction
Connector
Junction
Connector
A
A
C B
A A
Front Wiper SW
1 DH
LR
(RHD)
MIST
C13
Combination SW
J1
Junction
Connector
LR
1 4D
IG1 1
ACC
LR
F ro n t W ip e r a n d W a s h e r (w / A u to W ip e r S y s te m )
Front
Washer SW
1 ED1
I13
Ignition SW
3 AM1
Engine ECU
< 5015> < 5112>
Battery
197
198
L
(2)
BL
(2)
30A H/CLN
W
(2)
W
(2)
AVENSIS (EWD625E)
http://vnx.su
25A AM1
Left Kick Panel
Wiper Relay
WB
INT
MIST
+B
BG
(1)
WB
+1
BR
J2
Junction Connector
WB
RW
(9)
J24(A), J25(B)
Junction
Connector
WB
WB
+2
1
5
3
1
2 (LHD)
2 (RHD)
EB
WB
ED
4
3
5
4
WB
IL
A B
LR
Behind the
Combination Meter
LR
C A
H3
1 IE1
Engine
Compartment
Right
Integration Relay
< 111>
Combination SW
< 132>
IJ
+2
C A
RW
(9)
RY
Battery
OFF
C13
Combination SW
RW
(9)
3
3
IE3 IO1
(LHD) (RHD)
BR
PB
H16
Headlight
Cleaner SW
1 : Gasoline
2 : Diesel
4 : 1ZZFE, 3ZZFE
5 : w/ Headlight Cleaner w/ HID
6 : Except 5
7 : Left Side of the Suspension Tower
8 : LHD 2ADFHV, LHD 2ADFTV
9 : RHD 2ADFHV, RHD 2ADFTV
10 : Except 9
WB
RW(10)
8
IO1
8
IE3
HDLO
5
IG
1
6
FRWA
FL MAIN
3. 0W
+1
17
RW(10)
BR
10
IO1
10
IE3
WL
LR
H4
Headlight Cleaner
Motor
1 4B
RW
(8)
B
(2)
30A HLP CLN

+S
INT1
LY(LHD)
G (RHD)
J2
Junction
Connector
RY
BG
(1)
140A
ALT
120A
ALT (3)
100A
ALT (4)
16
J1
Junction
Connector
IG1 Relay
26 DA
25A WIP
LR
9 DA
B1
1 4D
Engine ECU
< 5015> < 5112>
GR
INT2
GY
EW
WL
(5)
WL
(6)
WL
(5)
1 1B
1
1
IE3 IO1
(LHD) (RHD)
F11
Front
Washer Motor
LR
18 DL
WL
WL
LR
17 DL
WF
1 DN 5 DH
11
LR
LR
LR
1 ED1
1 DH
Front Wiper SW
BW
L
(1)
Front
Washer
SW
LO
BG(1)
IG1 1
HI
Off
BL(2)
I13
Ignition SW
3 AM1
ACC
H e a d lig h t C le a n e r
(w / H ID )
L
(1)
F ro n t W ip e r a n d W a s h e r (w /o A u to W ip e r S y s te m )
L
(2)
28 AVENSIS
Combination SW
< 111> < 132>
F13
Front Wiper Motor
RW
Engine ECU
< 5015> < 5112>
On
GR
BG
(1)
120A ALT (3)

100A ALT (4)
AVENSIS (EWD625E)
http://vnx.su
Left Kick
Panel
LR
(W/G)
B
(2)
BG
(1)
Wiper Relay
+B
+1
LB
(W/G)
LS
5 BE2
C1
L
(L/B)
+B
Rear Wiper and

Washer SW
R20
L
(W/G)
1 BG1
L
(L/B)
L
(L/B)
4 BE2
2 BG1
L
(W/G)
IP
WB
Right Kick
Panel
WB
IL
J17
Junction
Connector
A
C7
Cigarette
Lighter
15A
CIG
WB
(LHD)
IJ
L
(W/G)
6 BG1
11 DB
WB
(LHD)
WB
(RHD)
Battery
L
(L/B)
3 BE1
C13
Combination SW
3 DH
WB
(RHD)
FL MAIN
3. 0W
5 BD2 (L/B)
4 BF2 (W/G)
4 BD2 (L/B)
3 BF2 (W/G)
LB
1 4B
3 BD1 (L/B)
5 BF1 (W/G)
: Gasoline
: Diesel
: 1ZZFE, 3ZZFE
: w/ Auto Wiper System
C1R
1
2
3
4
5
2 IC1
WR
11 IC1
10
+1R
WB
7 DD 9 DA
2 IC2
J 5(A), J28(B)
Junction
Connector
A B (RHD)
Washer +
ON (5)
ON
INT
OFF
Washer
4
4
IE3 IO1
(LHD) (RHD)
C ig a re tte L ig h te r
W
(2)
LR
BL
(2)
LR
A B (RHD)
A A (LHD)
A B
A A (LHD)
(RHD)
(LHD)
LB
1 4D
LR
9 IO1
LR
A A
9 IE3
LR
L
1 ED1
IG1
Relay
5 DH
R3
Rear Washer
Motor
1 DN
25A
AM1
GY
R e a r W ip e r a n d W a s h e r
1 DH
IG1 1
ACC 2
I13
Ignition SW
3 AM1
29 AVENSIS
Behind the
Combination
Meter
J16
Junction
Connector
L
(W/G)
LB
(L/B)
LR
(L/B)
LR
20A RR WIP
140A ALT
199
30 AVENSIS
200
L
(2)
W
(2)
W
(2)
30A H/CLN
AVENSIS (EWD625E)
http://vnx.su
120A ALT (3)

100A ALT (4)
30A HLP CLN
140A ALT
BG
(1)
B
(2)
Left Kick Panel
BL
(2)
WB
IP
Right Kick Panel
25A WIP
WB
(LHD)
WB
(RHD)
WB
Behind the
Combination Meter
P6
Power Outlet
H3
WB
Headlight Cleaner
Control Relay
1 IE1
EB
WB
IK
WB
WB
IJ
J15
Junction
Connector
WR
WR
II1
WB
J1
Junction
Connector
BW
Battery
WB
II1
LR
J17
Junction
Connector
H D (RHD)
J 8(A), J 9(B),
J20(C), J21(D)
Junction Connector
H B (LHD)
4
1 : Gasoline
2 : Diesel
3 : 2AZFSE, 1AZFSE,
1AZFE
4 : 1ZZFE, 3ZZFE
Headlight
Cleaner Motor
H4
L
(2)
FL MAIN
3. 0W
IG1 Relay
1 4B
21 DA
WB
9 DA
15A
P/POINT
GR
2
WL
L
(1)
BG
(1)
GR
BL
(2)
F C (RHD)
F A (LHD)
GR
1 4D
4 DB
7. 5A
RAD NO. 1
17 DL
LR
19 DA
L
(1)
25A
AM1
BG
(1)
1 DN
WL
1 ED1
GR
1 DH
3 DH
Integration Relay
< 17>
Combination SW
< 132>
1 1B
GY
5 DH
H e a d lig h t C le a n e r (w /o H ID )
RY
IG1 1
ACC 2
LR
I13
Ignition SW
3 AM1
P o w e r O u tle t
H16
Headlight
Cleaner SW
R
WB
P/POINT
Relay
WB
GR
1 DN
1 DH
BG
(2)
LB
BW
AVENSIS (EWD625E)
http://vnx.su
LB
BW
B
(3)
BG
(2)
MF
MF
2
M+
7
LGB
YG(1)
YG(1)
Right Kick Panel
YG
(1)
13 IA1
YG[
(1)
M+
16 IA1
16 IL1
14 IL1
4 CC
5 CC
12 CB
MR
MV
LGB
MH
LB
(1)
M+
10 CK
6 CB
2 CK
Retractor
SW
Operation
SW
YG
(1)
MR
13 IL1
LB
(1)
14 IA1
1 CC
2 CC
Return
MF
10
MR
9
13 CK
Retraction
Right/Down
YG
(1)
MV
VR
15 IL1
Select
SW
Left/Up
MH
LB
(1)
VL
LGB
GW
17 IL1
4
LB
HR
Right
Down
GW
15 IA1
Left
Up
6 CA
6 CI (LHD)
8 CD (RHD)
: w/ Retractor
: Gasoline
: Diesel
: 1ZZFE, 3ZZFE
Battery
HL
Right
Right
LB
(1)
17 IA1
Left
Left
R10
1
2
3
4
5
WB
FL MAIN
3. 0W
GR
J 8(A), J 9(B),
J20(C), J21(D)
Junction
Connector
H B (LHD)
H D (RHD)
F C (RHD)
F A (LHD)
7. 5A
RAD NO. 1
8
B
WB
1 4B
140A
ALT
4 DB
3 DH
GR
LB
(1)
W
(3)
LB
(1)
120A ALT
(4)
100A ALT
(5)
1 ED1
IG1
ACC 2
R e m o te C o n tro l M irro r
YG
(1)
BL
(3)
Ignition SW
I13
3 AM1
GR
Y
1 4D
25A
AM1
31 AVENSIS
WB
IP
M5
Remote Control
Mirror RH
YG
(1)
M4
Remote Control
Mirror LH
201
202
B
(2)
BG
(1)
W
(2)
B
WB
AVENSIS (EWD625E)
http://vnx.su
140A ALT
2 ID1
120A ALT (3)

100A ALT (4)
BG
(1)
Open
OPN
Close
M7
CLS
B
VW
6 ID1
VW
E B (RHD)
A A (LHD)
3 BB1
1 BB1
SC
2 BB1
SO
4 BB1
GND
WB
5 BB1
E B (RHD)
SPD
VW
A A (LHD)
PWS
WB
Left Kick Panel
5 DA
20
CPU
WB
WB
WB
IJ
8 DA
19
P/W
1
2
3
4
WB
(LHD)
IP
Right Kick
Panel
: Gasoline
: Diesel
: 1ZZFE, 3ZZFE
IG
4 CF
7 CA
WB
Battery
9 DC
13 DB
ACC
KSW
M6
FL MAIN
3. 0W
6 DK
WB
9 DA
17
B
PCTY
21
+B
10
6 BB1
1 4B
25A AM1
IG
DCTY
Integration Relay
10A GAUGE1
1 4D
25
IG1 Relay
22
7. 5A RAD NO. 1
20A S/ROOF
WB
1 DN
7 DB
1 ID1
LW
LW
RW
GR
3 DH
RW
LW
WB
(RHD)
25A DOOR
IK
Shift Lock
Solenoid
STP
S9
Shift Lock Control
ECU
SLS+
Behind the
Combination
Meter
J15
Junction
Connector
J17
Junction
Connector
S h ift L o c k
GW
BL
(2)
GY
5 DH
IG1 1
ACC 2
M oon R oof
Stop Light SW
< 172>
1
ED1
I13
Ignition SW
3 AM1
LW
1 DH
RW
1 DG
32 AVENSIS
SLS
WB
Combination
Meter< 423>
J 8(A), J26(B)
Junction Connector
System (BEAN)
< 119> < 120> < 216> < 217>
204
BL
(3)
50A AM1 NO. 1
W
(3)
AVENSIS (EWD625E)
http://vnx.su
1 4B
120A ALT
100A ALT
(1ZZFE, 3ZZFE)
BG
(2)
50A AM1 NO. 1
140A ALT
Battery
WB
FL MAIN
3. 0W
WB
IJ
25A DOOR
Left Kick Panel
WB
E B
A A
J 8(A), J 9(B)
Junction Connector
B
(3)
B
(4)
5 DA
8 DA
9 DC
13 DB
7. 5A RAD NO. 1
9 DA
B
(5)
B
(4)
9 IA1
WB
1 1B
BL
(3)
P/W
20
KSW
ACC
21
3 IA1
14
FLA
5 IA1
FLU
D17
WB
W
(3)
W
(3)
W
(2)
25A AM1
BG
(2)
19
PCTY
DCTY
17
Integration Relay
IG
22
10A GAUGE1
1 4D
IG1 Relay
LW
(1)
25
1
20A DRR P/W
LB
(1)
1 6A
PW
3
LW(1)
LB(1)
FLD
(Cont. next page)

: Gasoline
: Diesel
: w/ Moon Roof
: w/o Moon Roof
LB
3 DH
1
2
3
4
5
GW
GR
1 DN
GY
5 DH
LR
1 ED1
IG1 1
1 DH
I13
Ignition SW
3 AM1
ACC 2
GY
1 IE5
33 AVENSIS
LR
WB
P12
WB
B
(4)
B
(5)
20A DFR P/W

LR
20A PRR P/W
20A PFR P/W
System (BEAN)< 119> < 120>
LR
(6)
WR
WL
WL
LR
(1)
LR
AVENSIS (EWD625E)
http://vnx.su
WB
Right Kick
Panel
WL
E
WB
(1)
P10
WB
Under the Left

Center Pillar
BR
Under the Left

Center Pillar
WB
(1)
P14
Power Window Motor
Rear LH
WL
WB
BU
WB
(1)
BQ
10 BC1
WB
(1)
WB
(1)
10 BA1
WB

Rear LH
WB
(1)
IP
WG
P13
WB
(1)
9 IL1
WG
L
(1)
RY
(1)
R
(1)
Power Window Motor

Front RH
LW
(1)
DOWN
1
UP
L
(1)
RY
(1)
LR
(1)
P9
L
(1)
R
(1)
AUTO
RY
(1)
12 BC1
8 BC1
Under the Right

Center Pillar
WB
BV

Rear RH
WB
(1)
P11
Under the Right

Center Pillar
1
UP
3
AUTO
DOWN
GY
(1)
LR
(1)
R
(1)
LW
(1)
WL
LW
(1)
G
(1)
3 BC1
GY
(1)
AUTO
18 BC1
G
(1)
1 BA1
3 IM1
4 IM1
2 IM1
5 IM1
LW
(1)
DOWN
2 IC3
P15
LB
(1)
8 IM2
1 BC1
Power Window Motor

Rear RH
GR
(1)
LW
(1)

G
(1)
UP
WR
LR
(1)
8 BA1
5 IC1
LR
(1)
12 BA1
13 IC1
L
(1)
3 BA1
14 IC1
RY
(1)
18 BA1
4 IC1
R
(1)
LB
(1)
WL
LR
(1)
LW
(1)
5 IL1
J10(A), J11(B)
Junction
Connector
LR
(1)
6 IA2
5 IA2
7 IA2
LR
(1)
WL
LW
(1)
WR
E
B
E
B
L
(1)
A
A
A
A
RY
(1)
LR
(1)
LR
(1)
19 IA2
LR
(1)
GY
(1)
LW(1)
WG
10 IL2
20 IA2
R
(1)
21 IA2
RRD
19
RRU
18
RRA
22
LW
(1)
G
(1)
WL
GY
(1)
LB
(1)
LB(1)
WR
G
(1)
11 IL2
WG
9 IL2
LR
8 IL2
LR
(6)
L
(1)
11 IA2
RLD
15
RLU
17
RY
(1)
16
RLA
R
(1)
10 IA2
WL
23
LW
(1)
9 IA2
FRA
11
D17
GY
(1)
8 IA2
FRD
G
(1)
FRU
10
WB
WR
WG
205
206
BL
(3)
50A AM1 NO. 1
W
(3)
AVENSIS (EWD625E)
http://vnx.su
1 4B
120A ALT
100A ALT
(1ZZFE, 3ZZFE)
BG
(2)
50A AM1 NO. 1
140A ALT
Battery
WB
FL MAIN
3. 0W
WB
IJ
Left Kick Panel
A B
E A
B
(4)
Junction Connector
J26(A), J27(B)
B
(5)
LY
B
(3)
B
(4)
5 DA
8 DA
9 DC
13 DB
7. 5A RAD NO. 1
9 DA
9 IL1
WB
1 1B
BL
(3)
P/W
20
KSW
ACC
21
3 IL1
WB
IP
WB
P13
FRU
5 IL1
Right Kick Panel
14
FRA
D17
WB
W
(3)
W
(3)
W
(2)
25A AM1
BG
(2)
19
PCTY
DCTY
17
Integration Relay
IG
22
10A GAUGE1
1 4D
IG1 Relay
LW
(1)
25
1
20A PRR P/W
LB
(1)
1 6A
PW
3
LY
LW(1)
LB(1)
FRD
(Cont. next page)

: Gasoline
: Diesel
: w/ Moon Roof
: w/o Moon Roof
3 DH
1
2
3
4
5
WR
1 DN
GY
5 DH
1 ED1
IG1 1
1 DH
GR
Ignition SW
I13
3 AM1
ACC 2
WL
2 IP1
34 AVENSIS
B
(4)
B
(5)
20A DFR P/W

L
20A DRR P/W
20A PFR P/W
System (BEAN)< 216> < 217>
25A DOOR
GW
GY
LR
(6)
GW
GY
GY
LR
(1)
LR
AVENSIS (EWD625E)
http://vnx.su
LB
WB
Left Kick
Panel
GY
E
WB
(1)
P10
WB
BR
Under the Left

Center Pillar
WB
(1)
P14
Power Window Motor
Rear LH
WL
WB
Under the Left

Center Pillar
BU
WB
(1)
BQ
10 BC1
WB
(1)
WB
(1)
10 BA1
WB

SW Rear LH
WB
(1)
IJ
LY
WB
(1)
9 IA1
LB
P12
L
(1)
RY
(1)
R
(1)
Power Window Motor

Front LH
LR
(1)
LW
(1)
DOWN
1
UP
L
(1)
RY
(1)
LR
(1)
P9
L
(1)
R
(1)
AUTO
RY
(1)
8 BC1
Under the Right

Center Pillar
WB
BV

Rear RH
WB
(1)
P11
Under the Right

Center Pillar
1
UP
3
AUTO
DOWN
GY
(1)
LR
(1)
R
(1)
LW
(1)
WL
LW
(1)
G
(1)
12 BC1
GY
(1)
AUTO
3 BC1
G
(1)
18 BC1
LW
(1)
DOWN
1 BA1
3 IM1
4 IM1
2 IM1
5 IM1
LB
(1)
8 IM2
1 BC1
Power Window Motor

Rear RH
P15
GR
(1)
2 IC3
6 IL2
5 IL2
7 IL2
G
(1)
UP
GW
LW
(1)
RRD
19
RRU
18
RRA
22

LB
(1)
WL
8 BA1
5 IC1
LR
(1)
12 BA1
13 IC1
L
(1)
3 BA1
14 IC1
RY
(1)
18 BA1
4 IC1
R
(1)
5 IA1
LY
10 CB
L
(1)
LW
(1)
LW(1)
4 CE
8 CB
19 IL2
RY
(1)
LR
(1)
LB(1)
LB
9 CB
20 IL2
R
(1)
21 IL2
LR
(1)
LW
(1)
LY
GY
LW
(1)
GY
(1)
GW
GY
(1)
G
(1)
11 IA2
LB
LR
(1)
10 IA2
LR
(1)
9 IA2
LR
(1)
8 IA2
LR
(6)
LR
11 IL2
L
(1)
10 IL2
RLD
15
RLU
17
RY
(1)
16
RLA
R
(1)
9 IL2
WL
23
LW
(1)
8 IL2
FLA
11
D17
GY
(1)
G
(1)
LB
(1)
FLD
G
(1)
FLU
10
WB
GW
LB
207
35 AVENSIS
208
BL
(2)
W
(2)
W
(2)
50A AM1 NO. 1
AVENSIS (EWD625E)
http://vnx.su
120A ALT
100A ALT
(1ZZFE, 3ZZFE)
50A AM1 NO. 1
W
(2)
140A ALT
BG
(1)
B
(2)
25A AM1
Left Kick Panel
WB
IJ
10A GAUGE1
Right Kick Panel
WB
F12
Front Window Deicer
J2
Junction
Connector
S10(A), S11(B)
Short Connector
Left Side of the
Suspension Tower
WB
WB
WB
(4)
ED
Left
Kick
Panel
Right
Kick
Panel
IJ
IP
WB
IP
WB
9 IL1
M4
Mirror Heater LH
WB
9 IA1
12 IL1
12 IA1
M5
Mirror Heater RH
B B (RHD)
E A (LHD)
J18(A), J29(B)
Junction
Connector
WB
Battery
WB
(4)
6 CA
FL MAIN
3. 0W
GW
(5)
4 CJ
B B
E A
B B (RHD)
BY
1 4B
6 A
6 B
12 IE3
E A (LHD)
BY
GR
F20
5 A
5 B
GW
(5)
L(5)
B
(4)
B
(3)
4
: Gasoline
: Diesel
: w/ Mirror Heater
: LHD w/ FR DEICER Relay w/o Front Window Deicer
1
2
3
4
5
6
BY
9 DA
BY
W
(1)
BG
(1)
IG
RW
(4)
1 4D
RW
(4)
L
(4)
(RHD)
4 CH
FR DEICER
Relay
20A FR DIC
(LHD)
BL
(2)
2 IP1
GY
1 IE5
GW
(6)
Rear Window
Defogger SW
< 364>
RW
7 DB
GW
(6)
BY
1 1B
BG
(1)
5 DH 1 DN
Rear Window
Defogger Relay
< 364>
GR
1 DH
5 CF
7 CA
M irro r H e a te r
10A MIR HTR
1 ED1
W
(2)
IG1 1
ACC
RW
RW
1 6A
I13
Ignition SW
3 AM1
F ro n t W in d o w D e ic e r
RW
RW
B

< 363>
IG1 Relay
Behind the
Combination
Meter
Short Connector
< 353>
7 IC3
GW
(1)

< 476> < 488>
Right Side of
the Back Door
7. 5A DEF I/UP
B
(1)
N7
R18(A), R19(B)
IJ
Left Kick Panel
GR
W
(2)
AVENSIS (EWD625E)
http://vnx.su
B
(2)
Battery
140A ALT
1 ED1
BL
(2)
1 4B
W
(2)
30A RR DEF
W
(2)
BG
(1)
1 4D
1 1B
BG
(1)
1 1A
30A RR DEF
BG
(1)
1 4C
GR
120A ALT
100A ALT
(1ZZFE, 3ZZFE)
FL MAIN
3. 0W
1 DH
I13
Ignition SW
25A AM1
W
(1)
BW
WB
(L/B)
1 B
Right Quarter Panel
4 DF
2
5 DH 1 DN
IG1 1
GY
IG1 Relay
BG
(1)
3 AM1
WB
7 DB
BL
(2)
ACC
WB
B
(S/D)
10A GAUGE1
RW
(S/D)
9 DA
5 DC
RW
(L/B)
Rear Window
Defogger
(L/B)
(L/B)
1 DP
N6
Noise Filter
(Rear Window Defogger No. 1)
WB
(L/B)
B
(L/B)
1 A
4 BD1
B
(L/B)
4 BE1
1
2
3
4
5
6
Noise Filter
B
(L/B)
B
(S/D)
WB
(W/G)
BX
B
(W/G)
1 A
B
(W/G)
1 B
R18(A), R19(B)
B
(W/G)
6 BF1
(L/B, W/G)
5 BG1
: Gasoline
: Diesel
: w/o FR DEICER Relay
: 4 w/o Front Window Deicer
IL
G
G
GW
(6)
B
(1)
IP
Right Kick Panel
6 CA
9 CH
E
DEF
8 (LHD)
1 (RHD)
GW
(5)
GW
(4)
J6
Junction
Connector
GW
(4)
WB
(LHD)
F19
(S/D)
36 AVENSIS
WB
(LHD)
B
7 IB1
W
(1)
3
6
W
W
(2)
R e a r W in d o w D e fo g g e r
GW
(3)
1
5
RW
18 IC1
RW
GW
(5)
9 IC1
R9
Rear Window
Defogger Relay
GW
WB
(RHD)
J16
WB
(RHD)
GW
(5)
FR DEICER Relay
< 353>
Junction
Connector
IG
RW
7 CD
7 CA
RW
4 (LHD)
5 (RHD)
209
210
GR
BL
(4)
W
(4)
AVENSIS (EWD625E)
http://vnx.su
120A ALT (5)

100A ALT (6)
Left
Kick
Panel
140A ALT
B
B
B
R
Y
WB
B
(4)
WB
WB
J17
Junction
Connector
WB
WB
WB
Under the Left

Center Pillar
Lower Back
Panel Left
WB
(1)
1
WB
(2)
BR
WB
(1)
J37(A), J38(B)
Junction Connector
WB
(1)
Under the Right
Center Pillar
S17
H
A
Seat Heater RH
F
B
S17
Seat Heater
Cushion
Seat Heater RH
J35(A), J36(B)
Junction Connector
S16
Seat Heater LH
H
A
BS
J35(A), J36(B)
Junction Connector
Seat
Heater
Squab
WB
(1)
F
B
Seat Heater
Cushion
S16
Seat Heater LH
Seat
Heater
Squab
BV
WB
(2)
IP
Seat Heater
Cushion
Seat
Heater
Squab
Seat Heater
Cushion
J37(A), J38(B)
Junction Connector
Seat
Heater
Squab
Right Kick
Panel
WB
IJ
J32
Junction Connector
Battery
G B
G A
BO
(2)
C B
LG
(2)
LB
(2)
LGB
(2)
B A
R
(1)
RG
(1)
LG
(1)
RVR
RB
(1)
H B
F A
B
(2)
2 B
: w/ Power Seat
: w/o Power Seat
: Gasoline
: Diesel
: 1ZZFE, 3ZZFE
LB
(2)
1 4B
SWR
A B
E A
LB
(2)
LB
(1)
FL MAIN
3. 0W
BG
(3)
A B
E A
11 IM2
LB
1 B
1
2
3
4
5
6
B
(2)
BG
(3)
WB
WB
G B
LG
(1)
H B
G A
LB
LB
(2)
LGB
(2)
17 IC2
SWL
BO
(2)
I15
Inner
Mirror
LG
(1)
F A
LG
(2)
4 A
LGB
(1)
RVL
LB
(1)
LB
3 A
LB
(1)
5 DM
IG
B
(1)
RW
1 4D
IG1 Relay
33 DA
5 A
2 A
S 7(A), S 8(B)
Seat Heater SW
S e a t H e a te r
BO
(1)
10A GAUGE1
WB
11 DK
SEAT HTR Relay
6 DK
LB
9 DA
16 DM
10A HTR
1 ED1
GY
1 DN
25A
AM1
5 DH
RL
1 DH
IG1 1
ACC
A u to m a tic
G la re R e s is ta n t
E C M irro r
RL
I13
Ignition SW
3 AM1
37 AVENSIS
J30(A), J31(B)
Junction Connector
20A SHTR
BG
(1)
AVENSIS (EWD625E)
http://vnx.su
WB
WB
RG
50A AM1 NO. 1
B
(2)
BG
(1)
Battery
WB
J35(A), J36(B),
J37(C), J38(D)
Junction
Connector
Under the Right

Center Pillar
P23
Power Seat Motor
(Driver' s Seat
Slide Control)
Under the Left

Center Pillar
LDWN
2 (LHD)
1 (RHD)
1 (LHD)
2 (RHD)
8
7
3
3
RCLR
2 (LHD)
2 (RHD)
YB
Under the Left

Center Pillar
RCLF
WB
(RHD)
WB
(LHD)
WB
(RHD)
BR
BV
SLDR
2 (LHD)
1 (RHD)
1 (LHD)
2 (RHD)
RCLF
Reclining
P19
Slide
SLDF
Under the Right

Center Pillar
H C (LHD)
H A (RHD)
F D (LHD)
F B (RHD)
WB
(LHD)
BR
1 (LHD)
2 (RHD)
LUP
E B (RHD)
E D (LHD)
P25
Power Seat Motor
Slide Control)
BV
H A (LHD)
1 (LHD)
2 (RHD)
7
8
YR
H C (RHD)
FDWN
LO
(LHD)
1 (LHD)
2 (RHD)
LB
F D (RHD)
LY
2 (LHD)
1 (RHD)
5
10
LR
F D
FUP
WB
FL MAIN
3. 0W
50A AM1 NO. 1

YG
2 (LHD)
1 (RHD)
Up
10
5
Down
F D
Rear
SLDR
Up
F B (LHD)
6
6
Down
LB
F B
SLDF
Front
YR
F B
Front
9
9
Rear
RCLR
YB
Reclining
J35(A), J36(B),
J37(C), J38(D)
Junction
Connector
2 (LHD)
1 (RHD)
4
4
Lifter
A A (RHD)
A C (LHD)
Front
E1
Front
Vertical
P18
LO
(RHD)
30A
PWR SEAT
Rear
E2
1 (LHD)
1 (RHD)
Slide
E D (RHD)
E B (LHD)
10 IM2
1 6A
: Gasoline
: Diesel
: 1ZZFE, 3ZZFE
Front
YR(LHD)
RL(RHD)
E D
E B
A C (RHD)
A A (LHD)
1
2
3
4
Rear
1 4B
LO
(RHD)
W
(2)
30A
PWR SEAT
RL(LHD)
YR(RHD)
W
(2)
2 DM
1 DN
LO
(LHD)
1 ED1
BL
(2)
J35(A), J36(B),
J37(C), J38(D)
Junction
Connector
W
(1)
YR(LHD)
RL(RHD)
W
(2)
LO
1 1B
(RHD)
(LHD)
BG
(1)
Pow er Seat
LO
(RHD)
1 4D
2 IP1
1 IE5
38 AVENSIS
P24
Power Seat Motor
Reclining Control)
J35(A), J36(B),
J37(C), J38(D)
Junction
Connector
P22
Power Seat Motor
(Driver' s Seat
Reclining Control)
P21
Power Seat Motor
(Driver' s Seat
Lifter Control)
P20
Power Seat Motor
(Driver' s Seat
Front Vertical Control)
L6
Lumbar Support
Control Motor
RB
L7
Lumbar Support
Control SW
140A ALT
120A ALT (3)

100A ALT (4)
211
212
1 ED1
W
(2)
BG
(1)
30A AM2
30A DCC
W
(2)
B
(2)
AVENSIS (EWD625E)
http://vnx.su
1
2
3
4
: Gasoline
: Diesel
: 1ZZFE, 3ZZFE
B
(2)
WB
120A ALT (3)

100A ALT (4)
IJ
10A GAUGE1
Left Kick Panel
9 DA
WB
Battery
7 DB
RW
FL MAIN
3. 0W
1 4B
140A ALT
BG
(1)
E B
E A
E B
LY
(RHD)
F C
F A
LY
(RHD)
F C
F A
J24(A), J25(B)
Junction
Connector
RW
BL(2)
IG1
Relay
4 DB
7 CA
3 CF
GR
3 DH
F C (RHD)
F A (LHD)
H D (RHD)
+B1
1 A
IG
3 A
RW
9 CB
10 CB
GR
(RHD)
GR
(RHD)
4 CE
H B (LHD)
GR
(LHD)
25A
AM1
5 DH 1 DN
BY
BW
15A RAD NO. 2
BG
(1)
1 4D
GR
1 4A
G
GY
GY
1 DH
Ignition SW
I13
IG2
4 AM2
BR
ST2 5
IG1 1
GR
ACC 2
3 AM1
BG(1)
(RHD)
LY
(LHD)
(LHD)
1 IE4
1 IP1
BR
RW
1 1A
BR
BL
(2)
BW
(RHD)
(LHD)
15 A
ACC
14 A
ST1
M 1(A), M 2(B), M 3(C)
MultiDisplay
N a v ig a tio n S y s te m
(M a p T y p e )
LY
(LHD)
5 IP1
4 IE4
LY
(RHD)
GR
LY
(LHD)
GR
(LHD)
GR
(RHD)
(Cont. next page)
BW
BW
39 AVENSIS
GR
(RHD)
GR
(LHD)
LY
(RHD)
LY
(LHD)
GR
(LHD)
GR
GR
LY
(RHD)
J 8(A), J 9(B), J20(C), J21(D)

Junction Connector
7. 5A RAD NO. 1
7. 5A ST
BW
AUO+
2 A
SGND
6 C
(Shielded)
BR
W
B
B
R
R
Combination Meter
< 423>
GR
WB
AVENSIS (EWD625E)
http://vnx.su
R
WB
(LHD)
MACC
MIC+
MIC
Tweeter LH (LHD)
< 414>
Tweeter RH (RHD)
< 413>
T11
Amplifier
(Shielded)
14 ID1
BR
16 ID1
P (LHD)
LG(RHD)
18 ID1
AUI+
1 A
R(LHD)
W(RHD)
17 ID1
AUO
11 A
AUI
10 A
2 B
Right Kick Panel
6 CA
WB
IP
WB
(LHD)
Behind the
Combination Meter
WB
(RHD)
5 CG
IK
GND2
1 C
GND1
25 A
10 CH
7 CK
13 CF
TX+
5 B
GND
17 A
TX
10 B
SNSE
7 C
VR
1 B
WB
(LHD)
Right Kick
Panel
MIC
5 C
7 B
WB
IP
MIC+
3 C
3 B
CTX+
5 B
CTX
10 B
WB
(RHD)
GR
LY
(RHD)
MACC
4 C
SYNC
VR
1 B
WB
WB
LY
(LHD)
R11
Remote Controller
(Navigation)
VW
WB
(RHD)
Radio and Player

< 414>
REV
14 A
Parking Brake SW
< 206> < 216>
RY
SPD
5 A
DLC3
< 519> < 615>
< 714> < 815>
< 5019> < 5115>
ACC
18 A
8 B
VG
R
2 B
(Shielded)
(Shielded)
J17
Junction
Connector
+B
9 A
Combination Meter
< 425>
N 3(A), N 4(B), N 5(C)

Navigation ECU
(Shielded)
6 B
G
7 B
B
3 B
(Shielded)
GND
SYNC
8 B
GR
(LHD)
ACC
LG
BW
TX
BW
VG
6 B
LG
SPD
4 A
VW
PKB
17 A
SGND
TC
16 A
WL
9 IC2
TX3
24 A
TX3+
12 A
GY
GTX
18 A
M 1(A), M 2(B), M 3(C)

MultiDisplay
GTX+
5 A
WB
RE1
10 A
WB
GR
(RHD)
SGD1
22 A
J15
Junction
Connector
LG(LHD)
R (RHD)
Radio and Player
< 413> < 414>
V(LHD)
L(RHD)
Neutral Start SW
(A/T)< 183>
BackUp Light SW
(M/T)< 183>
Combination Meter
< 423>
LY
(RHD)
LY
(LHD)
GR
(LHD)
213
214
W
(2)
W
(2)
B
(2)
Left Kick Panel
AVENSIS (EWD625E)
http://vnx.su
BG
(1)
B
(2)
Combination Meter
< 425>
WB
WB
WB
IK
GY
J15
Junction
Connector
DTX+
2 B
DTX
5 B
SG
4 B
BRQ
1 B
Option Connector
(Navigation ECU)
< 492>
TX3+
6 A
TX3
15 A
9 CB
4 CE
GND
8 A
6 CA
10 CH
Right Kick Panel
Audio System
< 412>
10
EAU
DISP
7 A
ST1
+B
9 A
IP
WB
IJ
TX1
13 A
Battery
WB
7 CA
TX1+
4 A
FL MAIN
3. 0W
RW
3 CF
GND
1 C
M 1(A), M 2(B), M 3(C)

MultiDisplay
E B
E A
4
: Gasoline
: Diesel
: 1ZZFE, 3ZZFE
WR
1 4B
IG
2 A
ACC
1 A
1
2
3
4
WB
120A ALT
(3)
100A ALT
(4)
RW
140A
ALT
BG
(1)
7 DB
J 8(A), J 9(B), J20(C)

Junction Connector
9 DA
10A
GAUGE1
7. 5A
RAD
NO. 1
H B
1
15A RAD NO. 2
1 4D
IG1
Relay
4 DB
F C (RHD)
LY
(LHD)
J24(A), J25(B)
Junction Connector
LY
(RHD)
BG
(1)
1 4A
3 DH
F C
F A (LHD)
GR
(LHD)
GR
BL(2)
LY
(LHD)
25A
AM1
BG(1)
5 DH 1 DN
GR
1 DH
I13
G
GY
GR
(RHD)
Ignition SW
IG1 1
ACC 2
LY
(RHD)
1 1A
30A
DCC
3 AM1
M u lti D is p la y (w /o N a v ig a tio n S y s te m M a p T y p e )
LY
(LHD)
BW
BL
(2)
1 ED1
(RHD)
(LHD)
BW
5 IP1
4 IE4
BW
40 AVENSIS
C14
Combination SW
LG
GY
RW
BL
(2)
W
(2)
AVENSIS (EWD625E)
http://vnx.su
BG
(1)
1 4A
30A DCC
1 1A
120A ALT
(12)
100A ALT
(1ZZFE, 3ZZFE)
1 4B
LY
(11)
140A ALT
BG
(1)
FL
TX
10 C
F21
Front Door
Speaker LH
T16
Tweeter
Front LH
F22
()OUT
3
(+)OUT
2
()IN
(+)IN
6 IA1
1 IA1
6 A
LG
Front Door
Speaker RH
()OUT
3
(+)OUT
TX+
9 C
2 A
FL+
RL
6 B
V
(6)
P
(6)
R
(6)
LG
(6)
Option Connector
Instrument Panel
GND
7 A
BR(LHD)
WB(RHD)
Battery
J24
Junction Connector
2
LG
()IN

Option Connector
(+)IN
10 IC2
MultiDisplay
< 396>
6 IL1
L
1 IL1
L
(7)
LG
(7)
W(3)
R(9)
(7)
R (3)
LG(9)
(7)
17 BA1
()IN
FL MAIN
3. 0W
A31
Antenna
Amplifier
EAU
10
12
AU2
11
LG
(8)
AU1
P
(8)
B
(2)
BW
LG
(5)
25A AM1
FR
5 A
L
(5)
1 A
FR+
RL+
2 B
R 4(A), R 5(B), R 6(C), R 7(D)

Radio and Player
RR
3 B
1
()OUT
P
(4)
BG
(1)
1 4D
GND
6 D
SW2
8 D
RR+
1 B
4
1 : Gasoline
2 : Diesel
6 : LHD w/ MultiDisplay
7 : RHD w/ MultiDisplay
8 : w/ Steering SW
9 : w/o Navigation System (Map Type)
V
(4)
BW
WR
(8)
7 D
SW1
LY
(LHD)
ANT+
LY
(11)
8 A
GR
+B
4 A
LY
(10)
ACC
9 IM2
3 A
18 IM2
(RHD)
F B (RHD)
1 IC2
5 IP1
15A
RAD NO. 2
(LHD)
GR
F A (LHD)
7 BA1
R
Y
4 IE4
1 DN
7. 5A RAD NO. 1
F A (LHD)
T18
Tweeter Rear LH
(+)IN
7 BC1
3
(+)OUT
R15
LY
(LHD)
17 BC1
()IN
T19
Tweeter Rear RH
(+)IN
R
W
F B (RHD)
1
()OUT
(+)OUT
W
B
4 DB
8 CB
4 CE
B
P
(3)
LY
(10)
I13
3 DH
LY
(11)
Ignition SW
LY
(LHD)
IG1
ACC 2
1 DH
3 AM1
R16
GR
A u d io S y s te m
R
Y
LG
(3)
1 ED1
41 AVENSIS
BR(LHD)
WB(RHD)
IN
T17
Tweeter
Front RH
C14
Combination SW
J 8(A), J20(B)
Junction Connector
B
(2)
215
H D (RHD)
H B (LHD)
F C (RHD)
4 DB
3 DH
F A (LHD)
IL
Behind the
Combination
Meter
IP
Right
Kick
Panel
Moon Roof Control

Relay and Motor
< 323>
MultiDisplay
< 396>
Navigation ECU
< 396>
Option Connector
VW
(5)
GR
VW
J 8(A), J 9(B), J20(C), J21(D)

Junction Connector
IK
WR
(RHD)
GR

Control ECU< 243>
VW
(7)
J10(A), J11(B), J20(C), J21(D)
Junction Connector
F B
H A
Door
7. 5A RAD NO. 1
WB
(RHD)
WB
(LHD)
VW
(6)
Tire Pressure
Monitor ECU
< 523>
Behind the
Combination
Meter
F B (LHD)
F D (RHD)
F B
F D
F B
VW
(w/ HID)
F D
H C (RHD)
H A (LHD)
H A
VW
VW
H A
2 A
GR
20 B
H B
Speedometer
H C
18 B
J10(A), J11(B), J26(C)

Junction
Connector
F C (RHD)
F A (LHD)
VW
F C
WR
Tachometer
H C
Fuel
EPS ECU
< 234>
H C
A/T Shift (A/T)

Clock
C10(A), C11(B)
Combination Meter
VW
(8)
F D
Temp.
WR
(LHD)
WB
J15
Junction
Connector
6 CK
5 B
WB
6 CA
16 IE1
19 B
LW
CPU

< 517> < 613> < 712>
Engine ECU (M/T)
< 517> < 613> < 712>
< 813> < 5017> < 5113>
Skid Control ECU
LW
with Actuator
< 206> < 215>
GRR
3 B
Outside
Temp.
ODO/TRIP
21 B
6 CD
RW
RW
7 CA
BR
(Cont. next page)

< 512> < 611> < 710>
Engine ECU (M/T)
< 512> < 611> < 710>
< 812> < 5015> < 5112>
BL
(2)
Left Kick Panel
IJ
9 DA
5
1
WB
ST2
IG2 6
GY
GR
1 DH
25A AM1
I13
Ignition SW
4 AM2
IG1 1
3 AM1
ACC 2
GY
IG1 Relay
5 DH 1 DN
BG
(1)
BR
7 DB
10A GAUGE1
RW
W
(2)
1 4B
1 4A
1 1A
B
(2)
BG
(1)
1 ED1
30A AM2
BR
BG
(1)
(RHD)
1 IP1
1 IE4
BR
(LHD)
BG
(1)
1 4D
B
(2)
Battery
120A ALT (3)

100A ALT (4)
FL MAIN
3. 0W
BR
GR
216
1
2
3
4
5
6
7
8
(RHD)
5 IP1
AVENSIS (EWD625E)
http://vnx.su
(LHD)
140A ALT
BL
(2)
BW
4 IE4
42 AVENSIS
7. 5A DOME
WR
BW
: Gasoline
: Diesel
: 1ZZFE, 3ZZFE
: w/ MultiDisplay
: w/ Moon Roof
: w/ EPS
30A DCC
BW
GY
(5)
GW
BRW
AVENSIS (EWD625E)
http://vnx.su
WR
EI
GW
BRW
BR
(10)
BR
(2)
F25
Fuel Sender
EF
F14
BR
(2)
Left Side of the

Cylinder Head
Behind the
Combination Meter
Tail
BR
(11)
A1
A/C Ambient
Temp. Sensor
EY
IL
IK
WB
(LHD)
Near the Starter
E7
Engine Oil
RB(10) Level Sensor
YG(2)
BR
(2)
J16
Junction
Connector
WB
(RHD)
BR
(1CDFTV)
WB
(LHD)
Turn RH
YR
(2)
WB
(RHD)
15 IK2
17 A
13 B
Behind the
Combination Meter
J15
Junction
Connector
J17
Junction
Connector
Fuel
1 A
1 B
A/T OIL TEMP
Near the Starter
WR
4 IE1
4 IK1
YG
(2, 10)
15 IE1
16 A
YR
(2)
6 IC1
12 A
Illumination
14 B
Turn Signal and

Hazard Warning
Light System
< 152> < 153>
Oil Level
15 IC1
11 A
CPU
BEAN
I/F
C10(A), C11(B)
Combination Meter
Turn LH
10 A
Buzzer
14 A
Glow
MultiDisplay
< 396> < 403>
AVCLAN
I/F
13 A
BR
(Cont. next page)

2 : Diesel
5 : w/ MultiDisplay
10 : 2AZFSE
11 : 2ADFHV, 2ADFTV
(2)
G
(5)
15 A
(9)
4 A
Multiplex
Communication
System (BEAN)
< 115> < 210>
< 211>
3 A
Taillight System
< 142>
Illumination
System< 194>
5 A
BR
CRUISE
(2)
(2)
Driver' s
Seat Belt
ECT SNOW
Charge
217
8 A
Front Fog
Light System
< 162>
7 A
6 A
12 B
Rear Fog
Light System
< 162>
High Beam
System (BEAN)< 114>
Headlight System
< 134>
Rear Fog
12
1 : Gasoline
2 : Diesel
System (BEAN)< 114>
Headlight System
< 134>
Front Fog
19 IK2
V2
Vacuum
SW
B3
Brake Fluid Level
Warning SW
4 B
ABS
9 A
C10(A), C11(B)
Combination Meter
ABS (w/ VSC) and TRC and

VSC System< 2010>
ABS (w/o VSC) System< 213>
EPS System< 232>
6 B
10
P/S
Tire Pressure
218
22 B
9 B
10A
IGN
A B (RHD)
C A (LHD)
A B (RHD)
2 DH
18 DA
BW
Filter
BR
J 8(A), J26(B)
Junction
Connector
Check Engine
(w/ HID)
C A (LHD)
Beam Level
10 B
18 A
Tire Pressure
Warning System< 524>
AVENSIS (EWD625E)
http://vnx.su
Headlight Beam Level Control

System< 243>

< 55> < 67> < 76>
< 86> < 506> < 515>
EC
WB
RW
(1)
Brake
BW
J2
Junction
Connector
RW
(2)
RW
19 IE1
RW
(1CDFTV)
SRS
2 B
8 B
SRS System
< 224>
O2
Oil Pressure SW
(w/ VSC)
YB
RW
(2)
(w/ VSC)
11 B
17 B
(w/ VSC)
11
VSC
YB
ABS (w/ VSC) and TRC and

VSC System< 2010>
Slip
15 B
TRC OFF
16 B
Oil Pressure
BR
AVENSIS (EWD625E)
http://vnx.su
140A ALT
Left Kick Panel
GY
EC
WB
IG1 Relay
P5
Power Heater SW
GY
WB
WB
BR
Near the Starter
HTR2 Relay
IK
2
PTC2
1
PTC1
P7
PTC Heater
EY
BR
IJ
WB
J15
Junction
Connector
RW
Y
(2)
IN
Y
(1)
Battery
Y
(2)
IG
FL MAIN
3. 0W
RW
1
WB
GY
12 IE6
4 IK2
Y
(1)
3 EE1
12 CK
13 IE6
F/P
SW
ALT+L
16 IK2
5 IK2
BR
1 CB
10A
HTR

< 488> < 536>
BR
1 1A
9 DA 6 DC
Y
(2)
BL
GR
GY
WL
BL
5 DH 1 DN
P1
+
P o w e r H e a te r
(E le c tric a l T y p e )
1 : 1CDFTV
2 : 2ADFHV, 2ADFTV
HTR1 Relay
RW
1 ED1
25A
AM1
I13
Ignition SW
IG1 1
ACC
WL
1 DH
3 AM1
P o w e r H e a te r (C o m b u s tio n T y p e )
BR
RW
43 AVENSIS
J2
Junction
Connector
WB
F17
Fuel Pump
Alternator
< 33>
Alternator
< 33>
50A HTR1
50A HTR2
25A PWR HTR
219
220
WR
30A CDS
BG
30A RDI
AVENSIS (EWD625E)
http://vnx.su
1 4B
120A ALT
BG
Battery
WB
IJ
IG1 Relay
Left Kick Panel

< 475> < 488>
WR
A2
A/C Condenser
Fan Motor
2
M
R1
Radiator
Fan Motor
6 IE2
D4
Diode
(Fan)
WB
J1
FAN
NO. 2
Relay
Junction
Connector

< 512> < 611>
Engine ECU (M/T)
< 512> < 611>
FL MAIN
3. 0W
WR
9 DA
7. 5A ECUIG
BG
1
DN
FAN
NO. 1
Relay
1
4D
16 IE2
RL
Engine Compartment
Left
WB
25A AM1
EC
WR
WB
1 4C
11 DL
1 1B
10 DL
FAN
NO. 3
Relay
GR
WR
WR
B
GY
5 DH
RL
1 DH
RL
WR
RL
IG1 1
I13
Ignition SW
3 AM1
ACC
R a d ia to r F a n a n d C o n d e n s e r F a n (2 A Z F S E , 1 A Z F S E , 1 A Z F E )
WR
RL
44 AVENSIS
WR
BG
AVENSIS (EWD625E)
http://vnx.su
IG1 Relay
Left Kick Panel
4 EA1
D4
Diode
(Fan)
J1
Junction
Connector
Engine and ECT ECU

(A/T)< 78>
Engine ECU (M/T)
< 78>
WB
100A ALT
BG
IJ
WR
FAN
NO. 2
Relay
2
R2
WB
WR
WB
EC
WB
Battery
R1
Radiator
Fan Motor
FAN
NO. 3
Relay
FL MAIN
3. 0W

< 475> < 488>
1 4B
40A RDI
9 DA
7. 5A ECUIG
WR
16 IE2
L
W
1
DN
11 DL
WR
BG
RL
10 DL
RL
1
4D
GY
5 DH
RL
WB
1 4C
GR
1 DH
IG1 1
R a d ia to r F a n (1 Z Z F E , 3 Z Z F E )
1 1B
I13
Ignition SW
3 AM1
ACC
WR
RL
45 AVENSIS
WR
25A AM1
221
222
WR
30A CDS
AVENSIS (EWD625E)
http://vnx.su
IG1 Relay
Left Kick Panel
WB
WR
40A RDI
D4
Diode (Fan)
3
1
W
(1)
WB
140A ALT
IJ
7. 5A ECUIG
9 DA
D4
Diode (Fan)
WR
(1)
W
(1)
WR
(2)
W
(2)
6 IE2
J1
Junction
Connector
6 EE1
Engine ECU (M/T)

< 811> < 5014> < 5111>
W
(1)
WB
(1)
WB
(1)
25A AM1
EC
WB
WB
EB
FAN
NO. 2
Relay
W
(2)
Battery
1
DN
FAN
NO. 3
Relay
W
(1)
FL MAIN
3. 0W
BL
W
(2)
1
ED1
16 IE2
1
M
WR
WB
11 DL
FAN
NO. 1
Relay
RL
A2
A/C Condenser
Fan Motor
1 : 1CDFTV
2 : 2ADFHV, 2ADFTV
10 DL
GY
RL
5 DH
WR
1 1B
GR
1 DH
RL
(1)3
(2)5
(1)5
(2)3
WR
1 1C
IG1 1
ACC
RL
I13
Ignition SW
3 AM1
R a d ia to r F a n a n d C o n d e n s e r F a n (D ie s e l)
RL
WR
46 AVENSIS
W1
Water Temp. SW
(Radiator Fan)

< 475> < 488> < 535>
WB
R1
Radiator
Fan Motor
47 AVENSIS
224
BW
BL
(2)
BG
(1)
W
(2)
B
(2)
W
(2)
30A DCC
AVENSIS (EWD625E)
http://vnx.su
120A ALT (3)

100A ALT (4)
140A ALT
BG
(1)
B
(2)
25A AM1
Left Kick Panel
WB
IJ
WB
WB
Behind the
Combination Meter
P5
Power Heater SW
WB
(2)
LB
WB
GR
IL
Behind the
Combination Meter
3 IK2
1
2
3
4
8 A
SOL+
IG
12 B
7 CF
10 CC
11 B
HOTGASIN
7 A
MGV
17 B
HR
A15(A), A16(B)
+B
24 B
: Gasoline
: w/ Power Heater (Hot Gas Type)
: 1ZZFE, 3ZZFE
IK
J15
Junction
Connector
3
IJ2
IN
2
2 IK2
GY
(2)
SI
+B
B5
Blower Motor
Controller
4 IJ2
GND
VM
C4
Condenser
Assembly
RW
(RHD)
2 CE
6 CE
9 CJ
1 CB
RY
(2)
Battery
BW
FL MAIN
3. 0W
18 IE2
RB
(2)
IG
WB
(2)
1 4B
B4
Blower Motor
2 IJ2
LB
1 IJ2
11 IE1
GY
(2)
BG
(1)
HTR
Relay
12 CK
RW
(LHD)
J26(A), J27(B)
Junction
Connector
C3
Compressor Assembly
R
2 DF
LB
LB
34 DA
GRR
40A HTR
1 4D
10A HTR
1 4C
BW
BG
(1)
1 4A
7. 5A ECUB 2
RW
IG1 Relay
4 DF
RW
(2)
9 DA
BL
(2)
RW
(LHD)
5 DB
RW
(RHD 2)
GY
RW
(RHD)
2 DP 6 DC
RW
(LHD 2)
RW
(LHD 2)
BG
(1)
5 DH 1 DN
H A
RW
(RHD)
1 1B
1 DH
RW
(RHD 2)
RW
(LHD)
RW
(RHD 2)
WR
1 1A
F B
F B
H A
RW
(RHD)
RW
(LHD)
I13
Ignition SW
IG1 1
H A
RW
(LHD)
3 AM1
H A
RW
(RHD)
WR
1 ED1
BW
(RHD)
WR
5 IP1
(LHD)
ACC
RW
(RHD)
A u to m a tic A ir C o n d itio n e r (E x c e p t 2 A D F H V , 2 A D F T V ) a n d
P o w e r H e a te r (H o t G a s T y p e A u to m a tic A /C )
RW
(RHD)
4 IE4
5 B
BLW
RW(LHD)
RW(RHD)
(Cont. next page)

R
GRR
J16
Junction
Connector
RY
(2)
WB
Right
Kick
Panel
A17
A/C Room Temp.
Sensor
GR
BW
Parking Brake SW
< 206>
WB
(RHD)
WB
(LHD)
AVENSIS (EWD625E)
http://vnx.su
WB
(RHD)
WB
(LHD)
WB
(RHD)
IK
FAN NO. 3 Relay

< 443> < 452> < 463>
IP
WR
J15
Behind the
Combination Meter
GW
(1)
S5
16 B
SG1
13 A
2
1
VZ
18 B
SG
S51
1 B
1 IQ1
PRE
7 B
A3
A/C Pressure Sensor
17 IE2
8 IE2
7 IE2
BW
10 B
TE
AMDH
12 A
2 IQ1
BW
GW
Junction
Connector
AMDC
11 A
1
2
GND
GW
LW
16 A
SG4
TPD
8 B
LW
4 B
S52
2 B
3
3
PT
TPP
20 B
3 IQ1
AMPC
1 A
TSP
21 B
5
4
4 IQ1
TSD
9 B
15 B
S54
AMPH
2 A
A18
A/C Solar Sensor
3 IF1
2 IF1
1 IF1
5 IQ1
4 (LHD)
5 (RHD)
MAX
HOT
1 : Gasoline
J17
Junction
Connector
RDEFIN
PBLT
3 B
SG2
14 A
PT
LG
MPX
20 A
MPX+
10 A
A15(A), A16(B)
AOF
VZ
MAX
COOL
LG
6 CA
RY
P
(RHD)
3 CG
PB
17 A
CFAN
A21
Air Inlet Control
Servo Motor
PBKIG
GW
V
(RHD)
19 A
BRW
R
(RHD)
GND
GRR
Y
(RHD)
13 B
LGB
4 A
LB
AOD
YR
3 A
GND
YB
TPM
FACE
GR
19 B
S53
DEF
PL
14 B
P
(LHD)
SG3
PT
P
(RHD)
15 A
R
(LHD)
FRS
VZ
R
(RHD)
6 A
V
(LHD)
REC
GND
V
(RHD)
5 A
MAX
HOT
Y
(LHD)
TR
FRS
MAX
COOL
A24
Y
(RHD)
22 B
A23
(Driver Side)
W
(LHD)
SG5
REC
A25
A u to m a tic A ir C o n d itio n e r (E x c e p t 2 A D F H V , 2 A D F T V ) a n d P o w e r H e a te r (H o t G a s T y p e A u to m a tic A /C )
W
(RHD)
6 B
RW(LHD)
RW(RHD)
W
(RHD)
A19
A/C Thermistor
WG
DEF I/UP Fuse

< 363>
System (BEAN)< 115> < 211>
225
226
BL
(2)
7. 5A ECUB 2
BW
BG
(1)
BG
(1)
W
(2)
30A DCC
B
(2)
W
(2)
AVENSIS (EWD625E)
http://vnx.su
25A AM1
Left Kick Panel
120A ALT
(1AZFE)
100A ALT
(1ZZFE, 3ZZFE)
140A ALT
BG
(1)
B
(2)
WB
Behind the
Combination Meter
WB
WB
(3)
WB
GR
3
M2
M1
LO
4 IJ1
2 IJ1
3 IJ1
HI
18 IE2
A/C Amplifier
MGV
14 A
B6
Blower
Resistor
A13(A), A14(B)
BW
IK
6 B
M1
LB
IL
J15
Junction
Connector
L
R
1 IJ1
IJ
5 B
M2
LB
J16
Junction
Connector
Blower SW
HRIN
35 A
WB
(RHD)
WB
Battery
WB
(3)
4 B
HI
C2
C1
FL MAIN
3. 0W
B4
Blower
Motor
GRR
(LHD)
1 B
GND
3 B
2 B
1 CA
11 IE1
RW
(LHD 3)
WB
(LHD)
4 DF
WB
34 DA
2 DF
LB
1 4B
9 DA
GRR
(RHD)
40A HTR
GRR
(LHD)
BG
(1)
10A HTR
7 CG
GRR
(LHD)
4 CK
5 CE
GRR
(LHD)
1 4D
GRR
(RHD)
1 4C
BL
(2)
5 DB
J28
Junction Connector
: Gasoline
: Diesel
GRR
(RHD)
1 4A
GY
2 DP 6 DC
L
GRR
(RHD)
RY
(3)
BG
(1)
5 DH 1 DN
RW
(LHD)
GRR
(RHD)
GR
1 DH
RW
(LHD 3)
1 1B
C4
Condenser Assembly
RB
(3)
I13
Ignition SW
1
2
3
4
GRR
(LHD)
1 1A
IG1 1
ACC
WB(LHD)
WB(RHD)
D
RW
(RHD 3)
WB
(3)
RW(RHD)
RW(LHD)
WR
(Cont. next page)
RW
(3)
BW
(RHD)
(LHD)
3 AM1
M a n u a l A ir C o n d itio n e r a n d P o w e r H e a te r (H o t G a s T y p e M a n u a l A /C )
RW
(RHD)
1 ED1
BW
5 IP1
WR
4 IE4
48 AVENSIS
HTR Relay
WB
IG1 Relay
RW
(RHD)
RW
(RHD 3)
AVENSIS (EWD625E)
http://vnx.su
WB
(LHD)
AOD
5
FACE
S52
5 A
SG2
TP
AMC
MAX
COOL
16 A
AMH
MAX
HOT
15 A
RPTC1
(SIG1)
28 A
ALT
(EFII)
26 A
20 A
PTC1
(PTC)
MPX
29 A
19 A
PTC2
(PTCL)
PBLT
24 A
HRLY
30 A
Engine ECU (M/T)

< 5011> < 519>
GR
YR
LGB
GRR
BRW
WB
(RHD)
WB
(LHD)
PT
34 A
MPX+
RW
(5)
A22
2
GND
YB
VZ
36 A
9 A
4 A
RDEFIN
Alternator
< 33>
A25
AOF
13 A
PBKIG
25 A
BW
(5)
DEF
12 A
CFAN
23 A
HTR1 Relay
< 434>
Behind the
Combination Meter
PT
33 A
PRE
32 A
WL
(5)
IK
2
VZ
GW
GND
6 A
A/C Amplifier
SG
38 A
HTR2 Relay
< 434>
IP
J15
Junction
Connector
37 A
TPM
S5
7 A
RW
(5)
P5
Power Heater SW
39 A
S53
+B
2 A
HLP Relay
< 18> < 131>
Right Kick Panel
3 CG
J17
Junction
Connector
31 A
SG3
FRS
RY
(5)
6 CA
WB
(LHD)
9 CG
WB
(RHD)
WB
(3)
GY
(3)
40 A
SG4
RW
(LHD)
TE
PB
10 A
WR
REC
BW
GND
RY
11 A
GW
IG
WR
1 A
FAN NO. 3 Relay

< 443> < 452> < 463>
SOL+
BW
17 A
17 IE2
8 IE2
LW
7 IE2
Parking Brake SW
< 206> < 216>
22 A
RW
(RHD)
FRS
GW
(1)
HOTGASIN
C3
Compressor Assembly
R
1
RW
(RHD)
REC
RW
(LHD)
7 CF
DEF I/UP Fuse

< 363>
A13(A), A14(B)
6 CE
A3
A/C Pressure Sensor
BW
3 IK2
2 CE
10 CC
GW
IN
1 CB
LW
12 CK
: Gasoline
: Except 1AZFE
7
1
3
5
6
System (BEAN)< 115> < 211>
WB(LHD)
RW
(RHD 3)
IG
9 CJ
(6)
RW
(RHD)
J26(A), J27(B)
Junction
Connector
RW
(RHD)
F B
H A
RW
F B
RW
(RHD)
H A
RW
(LHD 3)
H A
2 IK2
RW
(LHD)
RW
(LHD 3)
H A
RW
(RHD 3)
RW
(RHD)
RW
(LHD)
WB(RHD)
RW
(RHD 3)
M a n u a l A ir C o n d itio n e r a n d P o w e r H e a te r (H o t G a s T y p e M a n u a l A /C )
WR
WB
(3)
RW(RHD)
RW(LHD)
WR
PL
A21
Air Inlet Control
Servo Motor
LB
WG
A19
A/C Thermistor
WB
(RHD)
227
228
BW
BW
BG
(1)
BG
(1)
B
(2)
L
AVENSIS (EWD625E)
http://vnx.su
BG
(1)
B
(2)
Battery
3 A
RY
FL MAIN
3. 0W
MultiDisplay
< 403> < 404>
14 A
12 A
VW
1 4B
5 A
E B
E A
17 A
6 CA
10 CF
WB
IP
10 CB
4 CE
Right Kick Panel
1 A
18 A
18 B
9 A
9 B
1
2
3
4
2 A
2 B
11 A
11 B
: Gasoline
: Diesel
: 1ZZFE, 3ZZFE
P (LHD)
LG(RHD)
16 A
Z 1(A), Z 2(B)
WB
120A ALT
(3)
100A ALT
(4)
GR
13 A
10 A
LY
(RHD)
140A
ALT
15 A
F B (RHD)
Junction
Connector
F A (LHD)
J 8(A), J20(B)
F B (RHD)
F A (LHD)
LY
(LHD)
J24(A), J25(B)
Junction
Connector
6 A
7. 5A
RAD
NO. 1
GR
1 4D
4 DB
3 DH
15A RAD NO. 2
1 4A
LY
(LHD)
W
(2)
BL
(2)
1 ED1
IG1
ACC 2
GR
1 1A
1 DN
25A
AM1
Ignition SW
I13
3 AM1
LY
(RHD)
30A
DCC
1 DH
GR
O p tio n C o n n e c to r (N a v ig a tio n S y s te m T u rn b y T u rn T y p e )
BW
(RHD)
LY
(LHD)
5 IP1
4 IE4
(LHD)
49 AVENSIS
V(LHD)
L(RHD)
Tweeter LH (LHD)
< 414>
Tweeter RH (RHD)
< 413>
LG
Radio and Player
< 413> < 414>
Combination Meter
< 423>
Neutral Start SW
(A/T)< 183>
BackUp Light SW
(M/T)< 183>
LG
GY
230
BW
AVENSIS (EWD625E)
http://vnx.su
B
B
80A GLOW
Near the
Starter
BR
EY
G2
10 EE1
Glow
Plug
Relay
BW
Engine
Compartment
Left
WB
EC
A35
Air Fuel Ratio
Sensor Relay
WB
IJ
BW
BR
10A IGN
BW
Left Kick Panel
7. 5A OBD2
1 : w/ HID
2 : w/o HID
10A GAUGE1
G1
Glow Plug
WB
WB
(RHD)
WB
(LHD)
25A AM1
30A AM2
20A EFI
RG
30A DCC
Battery
W
(1)
W
(2)
Behind the
Combination Meter
J15
Junction
Connector
BR
IK
1 6A
15A A/F
FL MAIN
3. 0W
9 DA
7 DB
1 1A
18 DA
7 DA
BR(LHD)
BY(RHD)
BR(LHD)
BY(RHD)
5 DH 1 DN
2 IE1
GR
BR
BR
2 DH
GY
GR
1 DH
BL
I13
Ignition SW
(RHD)
(LHD)
ST2
IG2 6
GY
RW
1 IP1
1 IE4
4 AM2
BR
IG1 1
BR(LHD)
BY(RHD)
(RHD)
(LHD)
3 AM1
GR
ACC
GR
50A AM1 NO. 1
140A ALT
5 IP1
BL
BW
1 ED1
4 IE4
WR
E n g in e C o n tro l (2 A D F H V )
GR
(RHD)
7. 5A DOME
1 1B
2 IP1
1 IE5
(LHD)
50 AVENSIS
WB
(LHD)
W(2)
W(1)
BW
BW
RG
RW
R
WR
GR
BR(LHD), BY(RHD)
(Cont. next page)
J17
Junction
Connector
EFI MAIN Relay
IG1 Relay
AVENSIS (EWD625E)
http://vnx.su
WB
Glow
Right Kick Panel
B
(2)
EDU Relay
RB
A34(A), (B)
Air Fuel
Ratio Sensor
BW
(1)
W
(2)
1 A (1)
2 B (2)
2 A
1 B
HT
4 B
AF
3 A
+B
3 B (2)
B
(1)
AF+
BR
(1)
4 A (1)
W
(2)
3 IH2
(3)
4 IH2
5 D
HAF2
CLSW
10 B
3 IK1
2 IH2
LR
(1)
WB
IP
1
IH2
Stop Light
System< 172>
LGB
(RHD)
LGB
(LHD)
15
IE2
6
IR1
BW
FIV
3 E
LGB
(RHD)
LGB
(LHD)
RW
(RHD)
RW
(LHD)
ECBV
15 E
BW
WB
(LHD)
W
(1)
GW
(RHD)
GW
(LHD)
E 9(A), E10(B), E12(D), E13(E)

Engine ECU (M/T)
AF2+
AF2
35 B
34 B
4
IR1
14
IE2
B
(1)
6 CA
22 B
IREL
10 A
ST1
14 B
GW
(RHD)
GW
(LHD)
W
(1)
6 CK
Check Engine
9 B
IGSW
9 A
W
12 A
C A (LHD)
A C (RHD)
C A
BW
(RHD)
5
IR1
9
IE2
+B
1 A
BW
8 IK1
1
VN
10 E
BW
1 (LHD)
2 (RHD)
C9
Clutch
Start SW
2 (LHD)
1 (RHD)
E16
Exhaust Fuel Addition
Injector Assembly
CRUISE
5 B
A C
C A
E D (RHD)
3
IR1
BW
(LHD)
LR
W(2)
W(1)
BW
BW
14 A
C10(A), C11(B)
Combination Meter
E D
C B (LHD)
BW
(RHD)
BW
(LHD)
RW(RHD)
RW(LHD)
GW
4 IE2
13 A
21 B
8 CE
20
IE1
V10
VSV (EGR)
LR
7 EE1
6 CD
7 CA
RW(RHD)
1 : w/ HID
2 : w/o HID
3 : Shielded
BW
RG
WR
(RHD)
BEAN I/F
CPU
20 B
H B
J10(A), J11(B), J26(C)

Junction Connector
WR
(LHD)
BW
(LHD)
F C (RHD)
RW
F C
F A (LHD)
RW(LHD)
GR
BW
(RHD)
RW
WR
S13
Stop
Light SW
RG
RW
GR
7 IO1
7 IE3
BATT
2 B
BY
R
WR
GR
BR(LHD), BY(RHD)
BR
BW
(RHD)
(LHD)
(Cont. next page)
BR(LHD)
BY(RHD)
V4
VRV (EGR)
BW
BW
BW
R
(1)
LR
(2)
BW
BW
J 8(A), J 9(B),
J26(C), J27(D)
Junction Connector
BW
Multiplex
Communication
System (BEAN)
< 115> < 211>
231
BR
BR
W
W
BR
BR
BR
E2
BW
C
E2
2
2
THG
BR
B12
Battery Thermometer
Sensor
1
2 EE1
BR
3 EE1
Stop Light SW
< 172>
GW
THG
22 D
THCI
THCO
30 D
BY
ALT
BL
8 E
Alternator
< 33>
BR
E20
Exhaust Gas Temperature
Sensor (Rear)
THB
26 D
9 E
Charging System
< 34>
IMI
30 B
29 B
IMO

< 94>
BR
RL
GR
BR
A
B
E19
Exhaust Gas Temperature
Sensor (Front)
12
(Cont. next page)
BR
1
BR
BR
E2
PIM
VC
RW
RW
BR
BW
BW
E2
BR
F16
Fuel Pressure
Sensor
BR
BR
PR2
PR
VCS
E2S
BW
E2
5
RL
2
GR
PB
PCR2
33 E
RW
PCR1
26 E
RW
BR
EGLS EGRS
VC
3
4
6
3 D
33 D
E2S
1 D
VC
18 E
EGLS EGRS
GB
+B
RW
VC
E18
EGR Valve
Position Sensor
VCS
2 D
10
RL
2 E
1 E
PCV+
PCV
E 9(A), E10(B), E12(D), E13(E)
Engine ECU (M/T)
RL
S6
Suction Control
Valve
E2
3
2
PIM
28 D
WR
RW
PTC1
BY
BR
T5
Turbo Pressure
Sensor
STA
ST Fuse
< 33>
7 A
RW
(4)
11

< 488> < 536>
20 B
RW
RW
IB
IB
27 D
VC5
STP
15 B
BR
B11
Battery Current
Sensor
BR
GR
BR
THF
29 E
THIA
20 E
F18
Fuel Temp. Sensor
I9
BR
E2
28 E
BR
BR
GR
BR
THW
19 E
BW
VG
EVG
THA
24 D 32 D 31 E
E2
EFI Water Temp.
Sensor
BR
BW
E2
BW
AVENSIS (EWD625E)
http://vnx.su
BW
+B
THA
E2G
VG
GREL
15 A
2
G
GR
LY
GR
MREL
8 A
10 IK1
A6
Air Flow Meter
R
232
BR
B
(RHD)
RW
WL
AVENSIS (EWD625E)
http://vnx.su
BR
D22
Differential
Pressure Sensor
BR
BR
BR
BR
(3)
IJt4
11 B
IJfR
1 B
WL
IJt3
IJen
2 B
WG
BW
LG
9 B
INJ+1
INJ1
INJ4
1 A
E21(A), E22(B), E23(C)
2 C
4 A
IJt2
BATTERY
WR
10 B
I5
Injector No. 1
IJt1
3 A
12 B
INJ+4
1 C
IJtR
I8
Injector No. 4
7 IK2
RL
7 B
INJ2
5 A
IJf
INJ+2
5 C
I6
Injector No. 2
17 IK2
RB
6 B
3 A
INJ3
6 A
2 A
INJ+3
4 C
1
L
2 B
EC
6 B
I7
Injector No. 3
GND
+B
DUTY
1 A
E2
VTA
3 B
E2
VC
1 B
SPD
17 B
BR
RW
VC
NEO
17 A
NE+
27 E
NE
34 E
INJR
6 C
INJ+R
3 C
9 EE1
G
(RHD)
BR
LR
ENG
30 A
LR
INJF PRD
#1
#2
#3
#4
RLFF IDLO
25 E 32 E 24 E 23 E 22 E 21 E 16 E 11 E
ENG+
24 A
GND
RW
PSP
RW
VC
B
(RHD)
LW
VP
BR
RW
9 IK1
LUSL
4 D
TRC
P3
Pressure
Discharge
Valve
W
B
(LHD)
31 A
(3)
G
(LHD)
4 EE1
Y
(RHD)
8 EE1
Y
(LHD)
RW
B
(LHD)
VLU
W
(RHD)
RW
W
(LHD)
6 D
25 A
7 B
RLO
ELS
INH
TRC+
E 9(A), E10(B), E12(D), E13(E)
Engine ECU (M/T)
BR
B
(LHD)
Y
(LHD)
29 D
Y
(RHD)
PSP
20 A
Diode (Fan)< 464>

8 B
GR
MPX2
Alternator
< 33>
PEX
System (BEAN)< 115> < 211>
32 B
MPX1
31 B
TAIL Fuse
< 142>
20 D
G
(LHD)
RW
FAN
13 E
EPA2
29 A
Skid Control ECU

with Actuator< 207>
VPA2
23 A
YB
VCP2
VW
27 A
WB
EPA
C6
28 A
RW
2 IK1
W
VPA
Y
(LHD)
3 IG2
22 A
1 (LHD)
3 (RHD)
EP2
G+
GND
2 A
23 D
31 D
VCPA
B
(LHD)
2 IG2
W
(LHD)
7 IG2
2
2
VPA2
Y
(LHD)
1 IG2
4
6
VCP2
Wiper Relay
(w/ Auto Wiper System)
< 272> < 273>
Combination SW
(w/o Auto Wiper System)
< 283>
6 IG2
3
1
EP1
16
3 : Shielded
C1
26 A
5
5
VPA1
Combination
Meter< 423>
5 IG2
A20
15
6
4
VCP1
14
WB
BR
WB
(3)
(3)
(3)
WB
(Cont. next page)
(3)
13
(3)
I17(A), I18(B)
WB
BW
BR
P26
Power Steering Oil
Pressure Sensor
BR
BR
BR
BR
233
WL
(RHD)
WL
(5)
Right Kick
Panel
MultiDisplay
< 396>
BR
BR
E B
D B
D B
BR
E B
ECC
D A
CANCEL
RES/ACC
CRUISE
C14
Combination SW
2
CCS
(3)
(3)
EOM
16 A
BR
Cruise Control SW
BR
BR
WB
EY
WB
Near the
Starter
E01
7 E
WB
E02
6 E
E1
7 D
BR
E05
BR
EZ
WB
AVENSIS (EWD625E)
http://vnx.su
WB
I
BR
H
WB
G
(3)
(3)
E
(3)
C
WB
B
WB
Near the
Starter
11 A
TC
SIL
18 A
19 A
GRR
4 A
TACH
E 9(A), E10(B), E12(D), E13(E)
Engine ECU (M/T)
17
J 8(A), J 9(B),
J26(C), J27(D)
Junction Connector
B D (RHD)
A B (LHD)
E A (LHD)
E A
GRR
D C
GRR
D C (RHD)
15
WFSE
Combination
Meter< 424>
TAC
16
BAT
WG
WFSE
WL
BR
Airbag Sensor
Assembly
< 228>
CCS
WL
Skid Control ECU

with Actuator
< 2011>
21 A
10 DD
WG
BR
4 E
1 DL
15 DL
WL
8 DD
9 DB
17 DB
30 DA
3 DC
DLC3
D5
18
WG
WG
D B
(3)
E A
Integration
Relay
< 15> < 25>
WG
E A
(3)
E A
J12(A), J13(B)
Junction
Connector
Tire Pressure
Monitor ECU
< 523>
WG
SET/COAST
G D (RHD)
G C (RHD)
G B (LHD)
G B
G D
G A (LHD)
G C
G A
G A
WG
G C
Transponder
Key Computer
< 94>
WG
SIL
J 8(A), J 9(B), J20(C), J21(D)

Junction Connector
WL
IL
D B (LHD)
Tire Pressure
Monitor ECU
< 523>
WL
(LHD)
D D (RHD)
D B
WL
(RHD)
D D
B C (RHD)
B C
B A
19
WL
Skid Control ECU

with Actuator
< 2011>
12 IE2
W
(LHD)
J 8(A), J 9(B),
J26(C), J27(D)
Junction Connector
WB
D A
B A (LHD)
WL
(LHD)
WG
234
IP
6 CA
14 IK2
BR
W
(RHD)
WL
(RHD)
13
WB
Behind the
Combination Meter
B D (RHD)
D C (RHD)
D A (LHD)
CG
3 CB
BR
SG
TS
BR
W
(LHD)
TC
WB
(RHD)
J16
Junction
Connector
WB
(LHD)
J 8(A), J20(C), J21(D)

Junction Connector
C ru is e C o n tro l (2 A D F H V )
WB
(RHD)
WB
(LHD)
12
20
3 : Shielded
WB
(RHD)
236
AVENSIS (EWD625E)
http://vnx.su
B
80A GLOW
Near the
Starter
BR
EY
BW
10 EE1
BW
Engine
Compartment
Left
WB
EC
7 EE1
RB
WB
IJ
G2
Glow
Plug
Relay
4 IE2
BR
10A IGN
BW
Left Kick Panel
2 IE1
EDU Relay
FL MAIN
3. 0W
G1
Glow Plug
1 1A
9 DA
7 DB
18 DA
7 DA
BR(LHD)
BY(RHD)
BR(LHD)
BY(RHD)
BR
GY
5 DH 1 DN
BL
BR
2 DH
BW
GR
1 DH
RW
I13
Ignition SW
BR(LHD)
BY(RHD)
(RHD)
(LHD)
IG2 6
ST2
GY
GR
1 IP1
1 IE4
4 AM2
BR
IG1 1
GR
(RHD)
(LHD)
3 AM1
GR
ACC
E n g in e C o n tro l (2 A D F T V )
RG
WR
140A ALT
5 IP1
BL
BW
4 IE4
7. 5A DOME
1 ED1
51 AVENSIS
BW
BW
R
WR
BR(LHD)
BY(RHD)
GR
RW
(Cont. next page)
EFI MAIN Relay
10A GAUGE1
7. 5A OBD2
IG1 Relay
25A AM1
30A AM2
20A EFI
RG
30A DCC
Battery
AVENSIS (EWD625E)
http://vnx.su
Glow
Right Kick Panel
BW
V4
VRV (EGR)
BW
+B
BW
E2
5
E2
EFI Water Temp.
Sensor
BR
BR
BR
I9
WB
IP
BW
GR
WB
BW
BW
THA
LY
THF
29 E
LGB
(RHD)
LGB
(LHD)
BR
PR
E2
VC
RW
E2
1
PIM
PIM
28 D
(RHD)
(LHD)
VC
BATT
VC
18 E
2 B
MREL
PCR1
26 E
7 IO1
7 IE3
8 A
E2G
THIA
20 E
6
IR1
VG
E2
28 E
CLSW
10 B
LGB
(RHD)
LGB
(LHD)
1 (LHD)
2 (RHD)
RW
GR
8 IK1
THW
19 E
E 9(A), E10(B), E12(D), E13(E)

Engine ECU (M/T)
VN
VG
EVG
THA
10 E
24 D 32 D 31 E
GW
(RHD)
GW
(LHD)
15
IE2
2 (LHD)
1 (RHD)
RW
6 CA
22 B
+B
1 A
ST1
14 B
4
IR1
14
IE2
A6
Air Flow Meter
BW
6 CK
9 B
Check Engine
10 IK1
RW
GREL
15 A
E2
VC5
IB
IB
27 D
RW
BW
BR
BR
B11
Battery Current
Sensor
CRUISE
5 B
W
12 A
IGSW
GW
(RHD)
GW
(LHD)
Stop Light
System< 172>
RW
BW
14 A
BW
(LHD)
9 A
IREL
10 A
C A (LHD)
A C (RHD)
C A
BW
(RHD)
13 A
A C
C A
BW
(RHD)
S13
Stop
Light SW
BEAN I/F
C10(A), C11(B)
Combination Meter
E D (RHD)
3
IR1
BW
(LHD)
RW
(RHD)
RW
(LHD)
GR
CPU
RW
21 B
E D
C B (LHD)
BW
(RHD)
BW
(LHD)
5
IR1
9
IE2
C9
Clutch
Start SW
20 B
6 CD
8 CE
20
IE1
RW(RHD)
RW(LHD)
BY
WR
J10(A), J11(B), J26(C)

Junction Connector
WR
(LHD)
H B
7 CA
RW(RHD)
RW(LHD)
RW
F C (RHD)
RW
F C
WR
F A (LHD)
BR(LHD)
BY(RHD)
R
V
R
WR
BR(LHD)
BY(RHD)
GR
RW
(Cont. next page)
T5
Turbo Pressure
Sensor
BR
BR
F28
Fuel Pressure
Sensor
BR
F18
Fuel Temp. Sensor
BR
BR
BR
BR
BR
BW
BW
BW
BW
BW
J 8(A), J 9(B),
J26(C), J27(D)
Junction Connector
BW
Multiplex
Communication
System (BEAN)
< 115> < 211>
WR
(RHD)
237
BR
BW
7 IK2
17 IK2
BR
1
3 D
+B
E2
VC
BR
3
5
EGRS
EGLS
EGLS
33 D
EGRS
RW
VCPA
BR
1
2 EE1
THB
26 D
3 EE1
BR
BR
BR
BR
BR
W
F
BW
E
E2
3
RW
AVENSIS (EWD625E)
http://vnx.su
BR
LR
VC
9 IK1
LR
PSP
P26
Power Steering Oil
Pressure Sensor
RW
26 A
15 B
20 B
7 A
BW
BR
RW
R
RL
1 E
RL
S6
Suction Control
Valve
BR
B12
Battery Thermometer
Sensor
PSP
20 A
BY
IMI
30 B
ST Fuse
< 33>
IMO
29 B
RW
(2)
RL
9 E

< 488> < 536>
GB
ALT
GW
8 E
Stop Light SW
< 172>
STP
BL
RW
PTC1
Alternator
< 33>
EZ
(1)
8 A
BATTERY
BR
BR
GND
3 A
BW
2 A
+B
E2
DUTY
1 A
WB
2 B
RW
VTA
LW
3 B
LUSL
4 D
GR
STA
PCV
B
(LHD)
I17(A), I18(B)
E18
EGR Valve
Position Sensor
PCV+
5 IG2
B
(LHD)
Near the
Starter
WB
GND
E 4(A), E 5(B)
1 B
1 A
INJ# 3
INJ# 2
2 A
6 A
3 A
INJ# 4 COM2
INJ# 1
4 A
5 A
COM1
IJt# 4
5 B
IJt# 2
2 B
3 B
7 B
RB
IJt# 1
6 B
WR
IJt# 3
2
2
2
LG
IJF
1
1
1
1
INJF
#1
#2
#3
#4
25 E 24 E 23 E 22 E 21 E
VPA
22 A
6 IG2
5
5
G
(LHD)
BR
(1)
EC
INH
WB
6 B
6 D
7 B
ELS
RLO
8 B
30 A
SPD
EPA2
29 A
B
(RHD)
6
4
VPA1
G
(LHD)
Charging System
< 34>
I5
Injector No. 1
VC
Y
(LHD)
1 B
Y
(LHD)
1 IG2
Y
(RHD)
I8
Injector No. 4
VLU
B
(LHD)
GR
13 E
31 B
7 IG2
B
(LHD)

< 94>
27 A
23 A
VCP2
VPA2
E 9(A), E10(B), E12(D), E13(E)
Engine ECU (M/T)
2 IG2
2
2
B
(RHD)
4
6
VCP2
EP1
W
(LHD)
I6
Injector No. 2
G
(RHD)
VCP1
A20
10
W
(LHD)
3
1
VPA2
W
(RHD)
EPA
Y
(LHD)
28 A
3 IG2
Y
(LHD)
I7
Injector No. 3
Y
(RHD)
1 (LHD)
3 (RHD)
EP2
2 E
11
System (BEAN)< 115> < 211>
Diode (Fan)< 464>
24 A
32 B
29 D
31 A
Skid Control ECU

with Actuator< 207>
25 A
17 A
17 B
VW
NEO
GR
Alternator
< 33>
Combination
Meter< 423>
WB
TRC ENG+ ENG
MPX1 MPX2 TRC+
RW
FAN
RW
2 IK1
12
Wiper Relay
(w/ Auto Wiper System)
< 272> < 273>
Combination SW
(w/o Auto Wiper System)
< 283>
TAIL Fuse
< 142>
YB
238
A
B
WB
WB
1 : Shielded
(Cont. next page)
14 IK2
(1)
C1
E B
E B
IP
ECC
3
CANCEL
RES/ACC
CRUISE
C14
Combination SW
2
CCS
(1)
CCS
21 A
BR
WB
WB
WB
WB
E1
7 D
BR
EY
BR
Near the
Starter
TC
SIL
EOM
16 A
11 A
18 A
BR
(3)
BR
E01
7 E
BR
Cruise Control SW
E02
6 E
(1)
WFSE
19 A
J 8(A), J 9(B),
J26(C), J27(D)
Junction Connector
4 A
A B (LHD)
B D (RHD)
D C (RHD)
E A (LHD)
E A
GRR
GRR
D C
WFSE
15
TAC
16
BAT
WG
W
(3)
TACH
WL
GRR
BR
Airbag Sensor
Assembly
< 228>
23 D
G+
E 9(A), E10(B), E12(D), E13(E)
Engine ECU (M/T)
WL
BR
10 DD
WG
Skid Control ECU

with Actuator
< 2011>
31 D
1 DL
15 DL
WL
8 DD
9 DB
17 DB
14
3 DC
30 DA
WG
DLC3
D5
WL
WG
D B
BR
D B
E A
Integration
Relay
< 15> < 25>
E A
WG
J12(A), J13(B)
Junction
Connector
E A
G D (RHD)
G C (RHD)
G C
G B (LHD)
G B
G D
G A (LHD)
G A
G A
WG
Tire Pressure
Monitor ECU
< 523>
(1)
G C
WG
SIL
15
Transponder
Key Computer
< 94>
WG
13
Right Kick
Panel
Behind the
Combination Meter
MultiDisplay
< 396>
D A
WL
(4)
SET/COAST
D D (RHD)
WL
(RHD)
J 8(A), J 9(B),
J26(C), J27(D)
Junction Connector
(1)
AVENSIS (EWD625E)
http://vnx.su
BR
(1)
34 E
NE
NE+
C6
27 E
NE
NE
3
WB
GND
BR
IL
A
Tire Pressure
Monitor ECU
< 523>
WL
(LHD)
J 8(A), J 9(B), J20(C), J21(D)

Junction Connector
WG
6 CA
WL
(RHD)
D D
D B (LHD)
B C (RHD)
D B
B A
WL
Combination
Meter< 424>
WB
Skid Control ECU

with Actuator
< 2011>
12 IE2
W
(LHD)
B C
B A (LHD)
TC
WL
(LHD)
13
BR
W
(RHD)
J 8(A), J20(C), J21(D)

Junction Connector
WB
D A
W
(LHD)
B D (RHD)
D C (RHD)
D A (LHD)
CG
3 CB
BR
SG
TS
BR
WB
(RHD)
J16
Junction
Connector
WB
(LHD)
WL
(RHD)
C ru is e C o n tro l (2 A D F T V )
WB
(RHD)
WB
(LHD)
12
16
1 : Shielded
WB
(RHD)
239
52 AVENSIS
240
BL
(2)
W
(2)
AVENSIS (EWD625E)
http://vnx.su
120A ALT (5)

100A ALT (6)
140A ALT
BG
(1)
B
(2)
Left Kick Panel
WB
Right Kick Panel
WB
(RHD)
WB
(LHD)
WB
Behind the
Combination Meter
J15
Junction
Connector
S20(A), S21(B)
Short Connector
IK
B
(4)
18 A
22 B
17 A
Behind the
Combination
Meter
IL
WB
(LHD)
IP
6 B
11 B
GW
(4)
6 A
11 A
WB
(4)
IND
6
A B (RHD)
C A (LHD)
A B (RHD)
C A (LHD)
J16
Junction
Connector
IJ
T21
Tire Pressure
Warning SW
J17
Junction
A
Connector
WB
(4)
Battery
GND
WB
(3)
T22
Tire Pressure
Monitor Receiver
+5V
RDA
WB
(3)
C D (RHD)
GR
GW
GND
11
2 DH
18 DA
B
(3)
G B (LHD)
C C (RHD)
4 BB2
10
CAL SW
T20
Tire Pressure Monitor ECU
: Gasoline
: Diesel
: w/ Tire Pressure Warning System
: w/o Tire Pressure Warning System
: 2AZFSE, 1AZFSE
: 1ZZFE, 3ZZFE
BW
WB
(LHD)
FL MAIN
3. 0W
WB
G A (LHD)
RW
1 BB2
GR
5 BB2
GW
1 4B
18 DB
5 ID1
16
GND2
SPD
20 ID1
GR
P
10 ID1
RF5V
GW
9 DA
7. 5A
ECUIG
RDA
TC
1
2
3
4
5
6
Tire Pressure
Warning Light
IG
2
SIL
BG
(1)
WG
IG1
Relay
DLC3
< 519> < 714> < 814>
< 5019> < 5115>
WL
12
DLC3
< 519> < 715> < 815>
< 5019> < 5115> < 5116>
VW
25A
AM1
1 DN
Combination Meter
< 424>
1 DH
J 8(A), J26(B)
Junction
Connector
1 4D
5 DH
GY
BW
BR
GR
I13
Ignition SW
IG2 6
AM2
BG(1)
ST2
IG1 1
3 AM1
ACC
T ire P re s s u re W a rn in g S y s te m
BW
1 ED1
GR
C10(A), C11(B)
Combination
Meter
WB
(RHD)
10A IGN
BR
RW
BL(2)
RW
J10(A), J11(B), J20(C), J21(D)

Junction Connector
53 AVENSIS
242
BW
BL
40A HTR
7. 5A ECUB 2
BW
30A DCC
AVENSIS (EWD625E)
http://vnx.su
140A ALT
25A AM1
Left Kick Panel
WB
IJ
WB
WB
WB
IK
4 IJ2
GND
VM
LB
GR
Behind the
Combination Meter
J15
Junction
Connector
SI
+B
BW
3
IJ2
B5
Blower Motor
Controller
Battery
2 IJ2
B4
Blower Motor
B
1 IJ2
LB
FL MAIN
3. 0W
LB
HTR
Relay
RW
(RHD)
3 IK2
2 IK2
16 B
SOL+
IG
20 B
2 CE
6 CE
9 CJ
1 CB
C3
Compressor Assembly
R
10A HTR
LB
34 DA
GRR
2 DF
RW
(LHD)
RW
4 DF
5
IG1 Relay
9 DA
2 DP 6 DC
RW
(LHD)
GY
5 DH 1 DN
F B
J26(A), J27(B)
Junction
Connector
7 CF
10 CC
+B
40 B
14 B
HRIN
8 B
BLW
A36(A), A37(B)
RW
(RHD)
1 1B
1 DH
BL
RW
(LHD)
WR
1 1A
RW
(RHD)
RW
(LHD)
I13
Ignition SW
IG1 1
H A
RW
(LHD)
3 AM1
H A
H A
RW
(RHD)
WR
1 ED1
BW
(RHD)
WR
5 IP1
(LHD)
ACC
RW
(RHD)
A u to m a tic A ir C o n d itio n e r (2 A D F H V , 2 A D F T V )
RW
(RHD)
4 IE4
RW(LHD)
RW(RHD)
(Cont. next page)
GRR
RW
(RHD)
WB
Right
Kick
Panel
A17
A/C Room Temp.
Sensor
GR
WB
(LHD)
AVENSIS (EWD625E)
http://vnx.su
HLP Relay
< 18> < 131>
WL
HTR1 Relay
< 434>
RW
HTR2 Relay
< 434>
BW
Alternator
< 33>
RW
Engine ECU
< 5011> < 5111>
WR
FAN NO. 3 Relay

< 463>
BW
Parking Brake SW
< 206>
WB
(RHD)
WB
(RHD)
WB
(LHD)
WB
(RHD)
IK
RY
Behind the
Combination Meter
Junction
Connector
PBLT
12 B
MPX
15 B
SG4
30 B
TE
5 B
S55
1 B
2
1
VZ
34 B
SG6
S51
7 B
1 IQ1
PRE
4 B
A3
A/C Pressure Sensor
17 IE2
8 IE2
7 IE2
BW
J17
Junction
Connector
MPX+
35 B
SG1
33 B
2 IQ1
BW
GW
IP
HRLY
38 B
AMHDr
AMCDr
1
2
GND
GW
LW
J15
PTC1
18 B
2 A
1 A
LW
PTC2
17 B
TPD
2 B
3
3
PT
TPP
22 B
3 IQ1
5 A
4 IQ1
TSD
23 B
AMCPa
TSP
24 B
5
4
6 A
26 B
S54
AMHPa
A18
A/C Solar Sensor
3 IF1
2 IF1
1 IF1
5 IQ1
4 (LHD)
5 (RHD)
MAX
HOT
ALT
10 B
S52
6 B
SG2
32 B
PT
LG
RPTC1
37 B
A36(A), A37(B)
AOF
VZ
MAX
COOL
LG
6 CA
RY
13 B
CFAN
A21
Air Inlet Control
Servo Motor
3 CG
PB
P
(RHD)
PBKIG
GW
V
(RHD)
19 B
BRW
R
(RHD)
GND
GRR
Y
(RHD)
21 B
LGB
3 A
LB
AOD
GND
YR
4 A
FACE
YB
TPM
GR
3 B
DEF
S53
PL
27 B
PT
P
(LHD)
SG3
P
(RHD)
31 B
VZ
R
(LHD)
FRS
R
(RHD)
7 A
GND
V
(LHD)
REC
MAX
HOT
V
(RHD)
8 A
FRS
MAX
COOL
A24
Y
(LHD)
TR
A23
(Driver Side)
Y
(RHD)
25 B
REC
A25
W
(LHD)
SG5
A u to m a tic A ir C o n d itio n e r (2 A D F H V , 2 A D F T V )
W
(RHD)
29 B
RW(LHD)
RW(RHD)
53 AVENSIS
W
(RHD)
A19
A/C Thermistor
WG
System (BEAN)< 115> < 211>
243

VNX - Su Avensis Ewd 2005 PDF

Uploaded by

Document Information

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

VNX - Su Avensis Ewd 2005 PDF

Uploaded by

Copyright:

Available Formats

FOREWORD

This wiring diagram manual has been prepared to provide

Applicable models: AZT250 Series

For service specifications and repair procedures of the above

All information in this manual is based on the latest product

Index of the contents of this manual.

Brief explanation of each section.

HOW TO USE THIS

Instructions on how to use this manual.

Describes the basic inspection procedures for electrical circuits.

Defines the abbreviations used in this manual.

Defines the symbols and functions of major parts.

Describes position of Parts Connectors, Splice points, Ground points, etc.

Index of the system circuits.

Shows ground positions of all parts described in this manual.

Indicates the part number of the connectors used in this manual.

Provides circuit diagrams showing the circuit connections.

HOW TO USE THIS MANUAL B

B HOW TO USE THIS MANUAL

[H] : Indicates the wiring color.

[B] : Indicates a Relay Block. No shading is used and

Indicates Relay Block No.1

[D] : Indicates related system.

[E] : Indicates the wiring harness and wiring harness

: Indicates a wiring Splice Point (Codes are E for the

The first letter of the code for each wiring harness

The Location of splice Point I 5 is indicated by the

[K] : Indicates the pin number of the connector.

[L] : Indicates a ground point.

B HOW TO USE THIS MANUAL

Relay Blocks (Relay Block Location)

: Junction Block and Wire Harness Connector

Junction Block and Wire Harness (Connector Location)

: Connector Joining Wire Harness and Wire Harness

Joining Wire Harness and Wire Harness (Connector Location)

Floor Wire and Instrument Panel Wire (Left Kick Panel)

Luggage Room Wire and Floor Wire (Luggage Room Left)

Ground Points Location

Under the Left Center Pillar

Back Panel Center

Wire Harness with Splice Points

Wire Harness with Splice Points

Parts is 4th in order

B HOW TO USE THIS MANUAL

FAN MAIN Relay

A/C Control Assembly

A/C Relay No.3

Front Fog Light LH

Door Lock Control SW

Cruise Control ECU

Remote Control Mirror SW

Turn Signal Flasher

Front Clearance Light LH

Front Clearance Light RH

Front Fog Light RH

Front Turn Signal Light RH

Door Lock Control Relay

Door Lock Control SW

Power Window Control

Power Window Master SW

Door Lock Motor LH

Radio and Player

J POWER SOURCE (Current Flow Chart)