Professional Documents
Culture Documents
GND
GND
VIDEO IN AUDIO
RX+
TX+
RX-
TX-
12
1
2
3
4
5
7
8
6
Make sure that the unit's firmware version (as listed on its box), is
compatible with your Latitude build. A firmware compatibility matrix, 3. If you connected any
RLY1
RLY2
RLY2
RLY1
+12V
GND
as well as instructions for updating VSIP unit firmware is available in the
GND
GND
VIDEO IN AUDIO
RX+
TX+
PTZ cameras to the units
RX-
TX-
IN1 IN2 IN3 IN4 IN5 IN6 IN7 IN8 IN OUT
Network
Support section of DVTel's website (http://www.dvtel.com).
11
10
12
serial port, change its set-
1
2
3
4
5
7
8
6
9
Jack
tings to match the cam-
3. If you are connecting any Pan-Tilt-Zoom (PTZ) cameras, you will need eras (in the case of multi-
B. Encoder Configuration to connect their serial ports to one of the encoders (either the RS-232 or
RS-422/485, depending on the cameras protocol. See below for RS-
ple PTZs, they must all
share the same protocol).
1. Launch the Latitude NVMS 3.5 Discovery Tool (also embedded into 422/485 4-wire and RS-485 2-wire connection diagrams). Note that multi-
AdminCenter, under the last tab of the Directory Configuration Pane). ple cameras may be connected to a single serial port only if they use the 4. Right click anywhere in
same protocol. the System View Pane
2. Run a VSIP port search (VSIP units default port is 5510. If your unit is and select Create>PTZ.
not brand new and you do not know its port number, use a low start value
RLY1
RLY1
RLY2
RLY2
RLY1
RLY2
RLY2
RLY1
+12V
+12V
GND
GND
GND
GND
GND
GND
RX+
RX+
TX+
TX+
RX-
RX-
TX-
TX-
and high stop value as your search parameters). 4-wire: In the Create PTZ
dialogue box, highlight your camera and select the encoder serial port
3. Your unit will appear as a connected to it as well as your PTZ protocol.
unit of type unknown for a Enter the PTZ number under the Properties tab of the PTZ
Tx+
new (or recently rebooted) Tx- Configuration Pane.
unit, and as a camera or Rx+
Rx- Switch to the Test tab to set up presets and patterns or to access the
analog monitor otherwise. cameras menu.
Right click it and choose
RLY1
RLY2
RLY2
RLY1
RLY1
+12V
RLY2
RLY2
RLY1
GND
GND
+12V
GND
GND
GND
GND
RX+
TX+
RX+
TX+
RX-
TX-
Change IP Address...
RX-
TX-
2-wire:
4. Enter an IP address in
the same IP scheme as your
server. You may also need -
Up to eight (8) encoders may be powered by a power brick via two 4-unit
wiring harnesses.