You are on page 1of 2

50 Series plug & play

world class water monitoring series 50 Instruments


Data Sheet

QUICK START GUIDE


1. Connect the two probes to the instrument using the two apposite
connectors

2. Switch on the instrument by connecting to the power supply

3. Once the run mode appears, press and hold on the ESC button
for 3-4 seconds: the display will show the Plug & Play mode:

PLUG & PLAY

PRESS ENTER

4. Press ENTER: the instrument will start searching for the probes

PLUG & PLAY

WAIT.

FOUND: NO PROBE
FOUND: NO PROBE

5. Once the digits DONE will appear on the display, press


ENTER to return to the RUN MODE

PLUG & PLAY

PRESS ENTER
DONE
7.4 pH
ENTER
FOUND: pH 1
FOUND: Rx 2 200 mV
20.5

WARNING: If the instrument is equipped with the optional PROFI BUS


communication, once the plug & play of the probes is done set again the PROFI
BUS YES command in the menu SETUP-> SETUP SYSTEM -> COMMUNICATION.

50Series Quick Start Guide Pagina 1


50 Series plug & play
world class water monitoring series 50 Instruments
Data Sheet

1. if you want to connect two sensors of the same type, e. g. 2 oxygen sensors,
before doing the plug & play procedure, do the following:

- Connect one of the two probes


- Run the plug & play procedure with one probe
- Enter the "setup" menu, and then in the "setup measure" menu
- Enter the change ID menu
- Confirm pressing Enter
- Connect the second probe and run the final plug & play

50Series Quick Start Guide Pagina 2

You might also like