Professional Documents
Culture Documents
ES 201
PART - I
om
(d) It does not link both the windings
(ii)The slip of 400V, 3-phase, 50 Hz, 4-pole induction motor when rotating at 1440 r.p.m. is -
(a) 2 % (c) 4 %
t.c
(b) 3 % (d) 5 %
(iv) For a wave connected d.c. machine, for no. of poles = 4, the no. of parallel paths is -
(a) 4 (c) 8
(b) 2 (d) none of these
m
(a) Iron loss = Copper loss (c) Copper loss > Iron loss
(b) Iron loss > Copper loss (d) None of these
GROUP B (Short Answer Type Questions)
4. Prove that the efficiency of a transformer is maximum when iron loss is equal to copper
loss.
om
Answer any two of the following
6. (a) Following test data were obtained on a 20 kVA, 50 Hz, 1 ph, 2000/200 V Transformer:
No load Test: 200 V, 1A, 120 W
yw
(b) A 120 V DC shunt motor having an armature circuit resistance of 0.2 and field fervent
resistance of 60 , draws a line current of 40 A at full load. The brush voltage drop is 3V and
rated full load speed is 1800 r.p.m. Calculate
(i) The speed at load.
(ii) The speed at 125 % of full load.
7. (a) Draw and explain the equivalent circuit of a 3 phase induction motor.
(a) Obtain the relation between the slip and the frequency of the rotor induced e.m.f.
PART - II
(a) CB configuration
(b) CC configuration
(c) CE configuration
om
(a) infinite AV (c) Zero R0
I) has a large gain bandwidth product II) has less input resistance
m
(vii)The output of a gate is low if and only if all its inputs are high. It is true for -
om
(b) Write the differences between JFET and MOSFET.
8. (a) Mention the advantages and disadvantages of a negative (-ve) feedback amplifier.
(b) An amplifier with negative (-ve) feedback provides an output voltage of 5V with an input
voltage of 0.2 V. On removal of feedback it needs only 0.1 V input voltage to give the same
output. Find out the
(i) Gain without feedback
(ii) Gain with feedback
(iii) Feedback ratio
9. (a) Sketch the cross-sectional view of a p-channel MOSFET with proper labels.
(b) Define
(i) Fitband voltage and
(ii) Capacitance of MOS devices
(c) Derive an expression for the threshold voltage of an ideal MOSFET.
10. (a) Why is FET called unipolar transistor?
(b) What do you mean by pich-off condition in JFET?
(c) As VGS is changed from -1 V to -1.5 V keeping VDS constant, ID of a FET drops from 7 to
5mA. What is the transconductance of the FET? If the a.c. drain resistance is 200 k, find
also the amplification factor of the FET.
om
t.c
bu
yw
m