Professional Documents
Culture Documents
by Danny T Wilder
2/5/09
Firstly, I’d like to state that I’ve been a car mechanic since 1978. I have studied
all fields of physics on my own since then as well. Plus, I have a degree in
computer engineering technology. Basically, I’m not some newbie to these
technologies.
Also, hydrogen burns about 100 times faster than octane (gasoline). Knowing
these two things can help you understand why HHO will increase your gas
mileage.
Before I go on, let’s acknowledge the debunkers. Many people will tell you that
the energy you put into separating the hydrogen and oxygen (electrolysis) offsets
the energy you gain when the elements are recombined in the combustion
chamber. In other words, they say that the amount of energy you get from
burning the HHO is less than what it takes to create the HHO. Well, they are
right. (Huh?) What they don’t consider is the mechanical energy gained by the
creation of the water.
It’s like we’re going back to the old steam engine, but instead of heating the
steam externally, we’re heating it within the combustion chamber. This is why
engines that burn pure hydrogen are about 40 to 45 percent efficient.
As a side note: I remember in the late ‘70s when turbo chargers were becoming
popular on sports cars. The biggest problem with these devices was that they
would overheat because they ran off of the exhaust fumes. Well, Renault came
up with a way to inject water in the combustion chamber when the turbo would
kick in. The result would be a cooler exhaust that wouldn’t burn up the turbo
charger. However, they discovered a side benefit of increased engine efficiency
because the water converted the heat to mechanical energy. (The article’s writer
played this down, as though it wasn’t significant.) This system never caught on,
because of the need to store in the vehicle pure water that could freeze up and
aid in corrosion. In fact, this is the major problem with HHO systems.
Another side note: An HHO add-on would probably not make a turbine engine
more efficient. Turbine engines can be as high as 60% efficient. With that said,
much of the research in creating hydrogen engines is being done with turbine
engines. Steam engines?
Finally, I’d like to say that adding too much HHO to your internal combustion
engine can actually decrease its efficiency, because too much water in the
combustion chamber can cool the burn too much. This varies depending on the
engine design.
Well, I hope this little lesson has helped you understand why HHO makes your
engine more efficient, and therefore saves on gasoline use.
On the next two pages, you will find a simple design for a pulse width modulator
to drive your HHO system.
Simple Pulse Width Modulator
by Danny T Wilder
2/5/09
This circuit is not the most stable in the world, but it’s probably the easiest to make. The
resistor and capacitor values here will give a frequency of about 900Hz, which will
provide good performance for an HHO cell.
The MOSFETS can be just about any size. I suggest the IRF540. Allied Electronics has
these for about 70 cents each. These are rated at 40 amps and by putting 2 in the circuit,
they can share the load. I definitely recommend heat sinks if you’re pushing more than 1
amp. You should put a fan on them if you’re going more than 5 amps.
The next page shows a circuit board layout (it’s not to scale) and a silk screen overlay for
this circuit. I added a power LED indicator to it. This design only requires a single sided
board.
God bless.