Professional Documents
Culture Documents
com
E-mail:http://www.LGEservice.com/techsup.html
COLOR MONITOR
SERVICE MANUAL
CHASSIS NO. : CL-32
FACTORY MODEL: LB500J
MENU
AUTO/SEL
ECT
CONTENTS
SPECIFICATIONS ................................................... 2 TROUBLESHOOTING GUIDE .............................. 13
PRECAUTIONS ....................................................... 3 PRINTED CIRCUIT BOARD................................... 17
TIMING CHART ....................................................... 4 EXPLODED VIEW...................................................19
OPERATING INSTRUCTIONS ................................ 5 REPLACEMENT PARTS LIST ...............................21
WIRING DIAGRAM ................................................. 6 PIN CONFIGURATION............................................24
BLOCK DIAGRAM ................................................... 8 SCHEMATIC DIAGRAM ......................................... 25
ADJUSTMENT ...................................................... 12
SPECIFICATIONS
1. LCD CHARACTERISTICS 4. POWER SUPPLY
Type : TFT XGA LCD Module
Size : 352.0(H) x 263.5(V) x 14.0(T) 4-1. Power
Pixel Pitch : 0.297mm x 0.297mm 100~240V, 50/60Hz 0.6A
Color Depth : 8Bits/ 16,194,277 colors
Active Video Area : 15.0inch 4-2. Power Consumption
(304.128 x 228.096)
MODE H/V SYNC VIDEO POWER CONSUMPTION LED COLOR
Surface Treatment : Anti-Glare, Hard Coating (3H)
Backlight Unit : Top/Bottom edge side 2CCFL POWER ON (MAX) ON/ON ACTIVE less than 30 W GREEN
Electrical Interface : LVDS interface POWER ON (NORMAL) ON/ON ACTIVE less than 28 W GREEN
2-2. Luminance : 150(min.), 180(typ.) at Center point 5-1. Operating Temperature: 10C~35C (50F~95F)
(Ambient)
2-3. Contrast Ratio :200(min.), 300(typ.)
5-2. Relative Humidity : 10%~80%
3. SIGNAL (Refer to the Timing Chart) (Non-condensing)
3-1. Sync Signal 5-3. MTBF : 50,000 Hours (Min.)
1) Type : Separate Sync. (Horizontal & Vertical) Lamp Life : 30,000 Hours (min.)
2) Input Voltage Level : Low=0~0.8V, High=2.1~5.5V
3) Sync Polarity : Positive or Negative 6. DIMENSIONS (with TILT/SWIVEL)
-2-
PRECAUTION
WARNING FOR THE SAFETY-RELATED COMPONENT. WARNING
There are some special components used in LCD BE CAREFUL ELECTRIC SHOCK !
monitor that are important for safety. These parts are
If you want to replace with the new backlight (CCFL) or
marked on the schematic diagram and the
inverter circuit, must disconnect the AC adapter
replacement parts list. It is essential that these critical
because high voltage appears at inverter circuit about
parts should be replaced with the manufacturers
650Vrms.
specified parts to prevent electric shock, fire or other
hazard.
Handle with care wires or connectors of the inverter
Do not modify original design without obtaining written circuit. If the wires are pressed cause short and may
permission from manufacturer or you will void the burn or take fire.
original parts and labor guarantee.
CAUTION
Please use only a plastic screwdriver to protect yourself
from shock hazard during service operation.
-3-
TIMING CHART
VIDEO
B A
E
C
F
D
SYNC
-4-
OPERATING INSTRUCTIONS
MENU
AUTO/SELECT
Power Connector
See front control panel D-Sub Signal Connector
2 3 4 1
amber.
2. Menu Button When adjusting your display settings, always
Use this button to enter or exit the On Screen press the AUTO/SELECT button before entering
Display. the On Screen Display(OSD). This will
automatically adjust your display image to the
3. Button ideal settings for the current screen resolution
size (display mode).
Use these buttons to choose or adjust items in the
On Screen Display. The best display mode is 1024x768.
100
Bring up Contrast and
100
Brightness adjustment.
-5-
WIRING DIAGRAM (LG Philips Module)
Connector Assy :
P/N: 6631T11012V
Connector Assy :
P/N: 6631T2008G
Connector Assy :
J705 J702 P/N: 6631T12002H
J707 J706
P902
CN3 J1
CN1
CN2
Connector Assy :
P/N: 6631T20015P
-6-
WIRING DIAGRAM (AUO Module)
Connector Assy :
P/N: 6631T11011H
Connector Assy :
P/N: 6631T20008G Connector Assy :
P/N: 6631T12002H
J702
J705
J707 J706
P902
CN3 J1
CN1
CN2
Connector Assy :
P/N: 6631T20015P
-7-
BLOCK DIAGRAM (LG Philips Module)
-8-
DESCRIPTION OF BLOCK DIAGRAM (LG Philips Module)
1. Scaler One chip IC(GMZAN-2, U201)
GMZAN-2 (U201) is one chip IC which it supports four internal function blocks of Video Amp, PLL,
A/D converter and Video processor.
Video signal (0.7Vp.p) clamped through C207, 208, 209 with matching ICs proper cut off voltage.
This signal is processed as a proper 8 bit digital signal by U201s amplifying, phase locking, A/D converting,
and scaling operations.
Also, U201 generates Clock, Horizontal and Vertical sync, Data Enable signals as LVDS ICs input signals.
1) Microprocessor (U501) distinguishes polarity and frequency by calculating horizontal and vertical sync input
from signal source.
2) Microprocessor (U501) carries out power control by sending power-down trigger signal to each IC.
3) Microprocessor (U501) communicates with EEPROM (U502), and GMZAN-2 (U201)
through IIC(2 lines) or 4 bit bus line. It makes all devices operated properly.
4) Microprocessor (U501) let User adjust screen by OSD function.
LVDS transmitter (U411) delivers digital signal to the receiver inside LCD module by method of abstraction.
The abstracted signals are pairs of RIN0+-, RIN1+-, RIN2+-, RIN3+-, and RCLKIN+- of which voltage swing
is 0.5V each.
When SHUTON pins input is High, transmitter goes to power down mode.
4. DC/DC block
This block is composed of regulators which supplies 2.5V, 3.3V, and 5V.
Each regulators source power is 5VS and 12V from power block.
U806 supplies 2.5VD and 2.5VA and U802 supplies 3.3VD, 3.3V_AD, and 3.3V_PL powers to GMZAN-2s
internal PLL, ADC, Pre-amp, and scaler by dropping down 5VS from power block.
U805 supplies MODPWR-3.3V for LCD modules operation by dropping down 5VS from power block.
U803 supplies 5VR for Microprocessor and Logic IC(U701)s operation by dropping down 12V from power block.
5. Power Block
This block supplies DC voltages of 5VS and 12V by converting AC input voltage of 100~240Vac.
Converting method is SMPS(Switching Mode Power Supply).
-9-
BLOCK DIAGRAM (AUO Module)
- 10 -
DESCRIPTION OF BLOCK DIAGRAM (AUO Module)
1. Scaler One chip IC(GMZAN-2, U201)
GMZAN-2 (U201) is one chip IC which it supports four internal function blocks of Video Amp, PLL,
A/D converter and Video processor.
Video signal (0.7Vp.p) clamped through C207, 208, 209 with matching ICs proper cut off voltage.
This signal is processed as a proper 8 bit digital signal by U201s amplifying, phase locking, A/D converting,
and scaling operations.
Also, U201 generates Clock, Horizontal and Vertical sync, Data Enable signals as Modules input signals.
1) Microprocessor (U501) distinguishes polarity and frequency by calculating horizontal and vertical sync input
from signal source.
2) Microprocessor (U501) carries out power control by sending power-down trigger signal to each IC.
3) Microprocessor (U501) communicates with EEPROM (U502), and GMZAN-2 (U201)
through IIC(2 lines) or 4 bit bus line. It makes all devices operated properly.
4) Microprocessor (U501) let User adjust screen by OSD function.
3. DC/DC block
This block is composed of regulators which supplies 2.5V, 3.3V, and 5V.
Each regulators source power is 5VS and 12V from power block.
U806 supplies 2.5VD and 2.5VA and U802 supplies 3.3VD, 3.3V_AD, and 3.3V_PL powers to GMZAN-2s
internal PLL, ADC, Pre-amp, and scaler by dropping down 5VS from power block.
U805 supplies MODPWR-3.3V for LCD modules operation by dropping down 5VS from power block.
U803 supplies 5VR for Microprocessor and Logic IC(U701)s operation by dropping down 12V from power block.
4. Power Block
This block supplies DC voltages of 5VS and 12V by converting AC input voltage of 100~240Vac.
Converting method is SMPS(Switching Mode Power Supply).
- 11 -
ADJUSTMENT
All adjustment are thoroughly checked and corrected 2. Adjustment for White Balance
when the monitor leaves the factory, but sometimes 1) Display color 0,0 pattern at Mode 13.
several minor adjustment may be required. 2) Set External Bright to MAX position and Contrast to
Adjustment should be following procedure and after MAX Position.
warming up for a minimum of 10 minutes. 3) Select PRESET START BIAS CAL command
Alignment appliances and tools. and Enter.
4) No attempt to manually adjust, BIAS data is auto-
- IBM Compatible PC
matically adjusted and saved to the EEPROM.
- Programmable Signal Generator.
5) Display color 15,0 pattern at Mode 13.
(eg. VG-819 made by Astrodesign Co.)
6) Select DRIVE CAL command and Enter.
- E(E)PROM with each mode data saved.
7) Color 1 (9300K) and Color 2 (6500K) are
- Alignment Adapter and Software.
automatically adjusted and saved to the EEPROM.
1. Adjustment for Factory Preset Mode 8) Select PRESET EXIT command and Enter.
1) Run alignment program for LB500J on the IBM
compatible PC.
2) Select EEPROM All Init. command and Enter.
3) Display cross hatch pattern at Mode 1.
4) Select COMMAND PRESET START command.
5) Select EDID WRITE command and Enter.
IBM 9 6
Video Signal 5 1
Compatible PC 15 11
Generator 10 6
5 1
C
PARALLEL PORT
d
13
se
1
tu
25
No
14
2
23
RS
OFF ON
5V
EL
Control Line
F
LL
C
RA
PA
VG ON
WE
S 5V
(110V/220V)
PO
E 74LS06
A
T
MO Power LED
CS
NI OFF 4.7K
YN
TO
V-S
R
74LS06
E ST Switch
B
B
F V-Sync On/Off Switch
(Switch must be ON.)
- 12 -
TROUBLESHOOTING GUIDE
1. NO POWER
NO POWER
(POWER INDICATOR OFF)
CHECK POWER
CHECK J707 BOARD, AND FIND
VOLTAGE NO
OUT A SHORT POINT
PIN1&PIN2(12V)
PIN4(5V)? AS OPENING
EACH POWER LINE
YES
CHECK
U501 PIN 8 NO
CHECK U803.
VOLTAGE
(5V) ?
YES
CHECK
NO CHECK 5VS LINE
U805 Voltage
(OPEN CHECK)
(5V) ?
NO PROBLEM
YES
IS U201 PIN12
VOLTAGE REPEATED NO
AS PULSE SHAPE ?
NO
- 13 -
2. NO RASTER (OSD IS NOT DISPLAYED) INVERTER
NO RASTER
(OSD IS NOT DISPLAYED)
J705 PIN1 NO
CHECK POWER BOARD
12V?
YES
YES
1. CONFIRM BRIGHTNESS
J705 PIN7 NO OSD CONTRL STATE.
5V? 2. CHECK MICOM DIM-ADJ
PORT
YES
CHECK
PULSE AS
CONTACTING SCOPE
PROBE TO CAUTION LABEL. NO REPLACE
(CONTACT PROBE TO
INVERTER ASSY
CAUTION LABEL.
CAN YOU SEE PULSE
AT YOUR
SCOPE?
YES
- 14 -
3. NO RASTER (OSD IS NOT DISPLAYED) gmZAN2
NO RASTER
(OSD IS NOT DISPLAYED)
U201 NO
POWER PINS CHECK U802, U806
3.3V?
YES
YES J402
(AUO Module) PIN63 IS 65MHz CLOCK?
PIN66 IS 48KHz H-SYNC? NO CHECK
PIN70 IS 60Hz V-SYNC? CONNECTION LINE
PIN69 IS 48KHz DEN? FROM U201 TO J402
IS PULSE APPEARED
AT SIGNAL PINS?
YES
(LG Philips Module YES
& Hydis Module)
NO CHECK
U401/U411 J402 PIN74, PIN1
3.3V? U805
PIN31 IS 65MHz CLOCK?
PIN27 IS 48KHz H-SYNC?
NO
PIN28 IS 60Hz V-SYNC? YES
PIN30 IS 48KHz DEN?
IS PULSE APPEARED TROUBLE IN CABLE
AT SIGNAL PINS? OR LCD MODULE
U401/U411 PIN1 NO
CHECK U805
3.3V?
YES
TROUBLE IN CABLE
OR LCD MODULE
- 15 -
4. NO RASTER (OSD IS DISPLAYED) gmZAN2
NO RASTER
(OSD IS DISPLAYED)
YES
U201
NO
POWER PIN CHECK U802, U806
3.3V?
YES
CHECK 1. CHECK PC
R,G,B INPUT? NO 2. CHECK SIGNAL CABLE
U201 PIN 87, 91, 95 & D-SUB CONNECTOR
LINE
YES
CHECK
NO CHECK H-SYNC LINE
H-SYNC INPUT
(D-SUBU701MICOM
U201 PIN 150?
U201 PIN150)
- 16 -
C715 R538 Q506
L708 C716 ZD501
R539
C717
X501 Q501
J705
Q505
C511
R535
C504 B
R532
C512 R536 C513 C501 Q502 20
R720 C514 D501
10
ZD502
C517
L707
C515
15 5 1
RA502
R540
RA501
Q503
C502
C503
R534
R537 25
C516
U501
35
U803
30
R533
U502
C830 R560 R513 R510 R528 40
R523
R518
R515
R517
R516
J707 C
L706
R511 R531
R581
R525
R2
R571
R570
C1
R3
R1
R580
R527
C835
R526
R805
R551
C509
R810
R811
C826
R541
C819
D801 L411
D1
U411 U1
U802 C411
C241
1. MAIN BOARD (Component Side)
R411
C818
C233
C243
C242
C237
C264
LG PANNEL
U805 C413
PRINTED CIRCUIT BOARD
C251
C825 C820
C263
C816
C
C813 C817
C267
C414
C227
C234
R807
C250
C415
C244
C246
C247
C245
L201
C253
C252
C262 R414
C228
C508
C507
C229
MODEL:LB500J-LGPL/HYDIS
R522
R521
R520
R519
R524
C412
BA201
B
A
C402
R509
R508
R507
R506
R505
R504
R503
R502
R501
C401
C403
BA202
C203
C256
C201
C255
C202
C254
R401
C265
C266
C207
C208
C209
BA203
R209
R210
R208
C249
C248
Hydis C701
R203 R204 R205
PANNEL
C236
C702
- 17 -
R706
R707
R701
R702
R703
R704
R207
C232
R404
C225
C230
C703
C404
C405
40 30 20 10 5
U201
C211
160
C704
C829 L401
C828
L804
C235
X201
150
C705
1
C212
C224
C220
J702
140
C223
C271
C215
C823
C822
R206
C708
130
C833
C709
C210 L703 L702
80
C270
U806 C831
C802 L805
C814
C815
R820
C812
C811
120
100
90
C214 C809
C257
LG Philips Module
C801
C269
C259
C258
R201 C832
R714
R202
R713
R710
C712
R711
R712
R715
L803
C821
C827 L802
C824
C711
L705
R705
R708
U701
L704
C713
1
ZD801
D703
R804
R709
C710
R802
C807
C808
L710
R733
D704
R803
C805
J706
C806
ZD702 C731 Q701 U801 C803
L709
C722
R734
C718
R806
C719
C723
J703 D705 R717
R722
R716
ZD701
R801
J704
- 18 -
C805
1
R802
C719
R803
40
C718
R804
L709
5
C722
C806 C723
35
R806
10
30
15
25
20
4. MAIN BOARD (Solder Side)
Q503
C517 R534 U502 C16 C9 C3 C265 C244 U1
R2 L710
C243 C241
C832
R533
R501 L702
R1
D501
B
R502
C264
C263
C252
C247
R540 R503 R3
ZD502
C25 C249
D1
R537
R504
C8
C6
C803
C24
C22
C19
C17
C14
C11
R505 80 2 C709
R529 L703
C516 R506 C708
C503
C514
J706
R528 R820
C1
C502
R531 R508 C227 C224 R801
Q505 R206
C815
C223
C814
C833
R509 C251
U801
C809
L804
Q506
Q502
R581 R709
R510
R580
L704
C829
C828
79 1
C210
C270
R511
R532
X201
C230
R512
C20
C2
C242
J402
L802
C211
C711
C23
C811
C21
C10
C7
C4
C266
C228
C245
C511
R513
R708
C212
C215
C235
Q501 R535 140
L805
150 130
C13
C15
R571
C234
C267
C253
C250
160 C812
ZD501
R570
U802
C501
ZD801
C229
120
R721
R560
P/N :6870T449A11
C18 C12 C5 C246 C237
C248
C513
R516 R524 C808
X501
R561
R716
R517 R733
5
C507 C205
R515 R722 ZD701
C508
BA8
R536
R518
C817
C807
R519 C713
C214
R523
10
R551 R520
R538
R539
R805 R521 BA24
C262
C512
Q701
C236
C819
BA7
R522
C818
R714
C261
R525 C206
R201
R713
C731
R734
C835
B
C232
R710
BA6
C504
U701
20
L201
R526
R202
ZD702
BA5
C712
U805
L202
R717
R715
100
R807
BA20
C715
C257
R712
C258
R711
R527
BA4
BA3
30
C506 BA22 BA23
C505 C259
C716 BA21
90
C509
BA19
A
C204
C269
C
U803 L203
C820
C225
R541
C515
L706
R720
C825
R207
RA501
40
L204
C826
C824
J705 C226
C816
C813
L707
RA502
D801
R705 D703 D704
C830
D705
C821
L708
80
R704 C801
C802
C203 C209
R205
D702
R703
U201
C254 R208
R810
A
C208 R702
C202
R811
C717 R701 MODEL:LB500J-AU
R204
D701
C255 R210
C831
C220
C271
C827
C201 C207 R707
DATE :2002.02.07
J707
C256 R209 R706
R203
D706
C823
U806
J703
C822
L803
3. MAIN BOARD (Component Side)
AUO Module
EXPLODED VIEW
9
8-1
8 12
10
7
6 10-1
- 19 -
5
4-B
2-1
2 4-A
11
1
EXPLODED VIEW PARTS LIST
8-1 3313TL5040B MAIN TOTAL ASSEMBLY, LB500J AUO BRAND CL-32 (LB500J-EU)
10 6631T11012V CONNECTOR ASSEMBLY, 20P H-H 140MM UL20276 UNIXTAR LB500J (LB500J-EL)
10-1 6631T11011H CONNECTOR ASSEMBLY, 80P H-H 133MM FPC F219-017 LB500J (LB500J-EU)
- 20 -
REPLACEMENT PARTS LIST
CAUTION: BEFORE REPLACING ANY OF THESE COMPONENTS,
READ CAREFULLY THE SAFETY PRECAUTIONS IN THIS MANUAL.
* NOTE : S SAFETY Mark
AL ALTERNATIVE PARTS
- 21 -
DATE: 2002. 2. 23. DATE: 2002. 2. 23.
*S *AL LOC. NO. PART NO. DESCRIPTION / SPECIFICATION *S *AL LOC. NO. PART NO. DESCRIPTION / SPECIFICATION
U803 0ISS780500H KA78M05-R 3P,D-PAK TP 5V 0.5A R509 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP
U805 0IRH033000A BA033SFP P/MOLD-5 TP REGULATOR R510 0RJ1000D677 100 OHM 1/10 W 5% 1608 R/TP
U806 0IPMGON007A NCP1117ST25T3 ON SEMI SOT223 R R511 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP
R512 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP
COILs & COREs
R513 0RJ1002D677 10K OHM 1/10 W 5% 1608 R/TP
R515 0RJ1000D677 100 OHM 1/10 W 5% 1608 R/TP
L201 6210TCE001P HB-1S2012-121JT CERATECH 2012M R516 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP
L202 6210TCE001P HB-1S2012-121JT CERATECH 2012M R517 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP
L203 6210TCE001P HB-1S2012-121JT CERATECH 2012M R518 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP
L204 6210TCE001P HB-1S2012-121JT CERATECH 2012M R519 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP
L401 6210TCE001G HH-1M3216-501 CERATEC 3216MM R R520 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP
L411 6210TCE001G HH-1M3216-501 CERATEC 3216MM R R521 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP
L701 6210TCE001S HU-1M2012-121 CERATECH 2012MM R522 0RJ1500D677 150 OHM 1/10 W 5% 1608 R/TP
L702 6210TCE001P HB-1S2012-121JT CERATECH 2012M R523 0RJ0332D677 33 OHM 1/10 W 5% 1608 R/TP
L703 6210TCE001P HB-1S2012-121JT CERATECH 2012M R524 0RJ0332D677 33 OHM 1/10 W 5% 1608 R/TP
L704 6210TCE001P HB-1S2012-121JT CERATECH 2012M R525 0RJ1000D677 100 OHM 1/10 W 5% 1608 R/TP
L705 6210TCE001P HB-1S2012-121JT CERATECH 2012M R526 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP
L706 6210TCE001P HB-1S2012-121JT CERATECH 2012M R527 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP
L707 6210TCE001P HB-1S2012-121JT CERATECH 2012M R528 0RJ1000D677 100 OHM 1/10 W 5% 1608 R/TP
L708 6210TCE001S HU-1M2012-121 CERATECH 2012MM R529 0RJ1000D677 100 OHM 1/10 W 5% 1608 R/TP
L710 6210TCE001G HH-1M3216-501 CERATEC 3216MM R R530 0RJ1000D677 100 OHM 1/10 W 5% 1608 R/TP
L803 6210TCE001G HH-1M3216-501 CERATEC 3216MM R R531 0RJ1000D677 100 OHM 1/10 W 5% 1608 R/TP
L804 6210TCE001G HH-1M3216-501 CERATEC 3216MM R R532 0RJ3301D677 3.3K OHM 1/10 W 5% 1608 R/TP
L805 6210TCE001G HH-1M3216-501 CERATEC 3216MM R R533 0RJ1500D677 150 OHM 1/10 W 5% 1608 R/TP
R534 0RJ1500D677 150 OHM 1/10 W 5% 1608 R/TP
TRANSISTOR
R535 0RJ3301D677 3.3K OHM 1/10 W 5% 1608 R/TP
R536 0RJ1004D677 1000000 OHM 1/10 W 5% 1608 R/T
Q501 0IKE704200J KIA7042AF SOT-89 TP 4.2V VOLTA R537 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP
Q502 0TR390409AE FAIRCHILD KST3904(LGEMTF) TP S R538 0RJ2202D677 22K OHM 1/10 W 5% 1608 R/TP
Q505 0TR162309CA KSC1623 TP SAMSUNG SOT23 NPN R539 0RJ1002D677 10K OHM 1/10 W 5% 1608 R/TP
Q506 0TR162309CA KSC1623 TP SAMSUNG SOT23 NPN R541 0RJ1000D677 100 OHM 1/10 W 5% 1608 R/TP
Q701 0TR390409AE FAIRCHILD KST3904(LGEMTF) TP S R551 0RJ0000D677 0 OHM 1/10 W 5% 1608 R/TP
R560 0RJ0000D677 0 OHM 1/10 W 5% 1608 R/TP
RESISTORs R561 0RJ0000D677 0 OHM 1/10 W 5% 1608 R/TP
R571 0RJ0000D677 0 OHM 1/10 W 5% 1608 R/TP
R1 0RJ1500D677 150 OHM 1/10 W 5% 1608 R/TP R581 0RJ0000D677 0 OHM 1/10 W 5% 1608 R/TP
R2 0RJ1500D677 150 OHM 1/10 W 5% 1608 R/TP R701 0RJ0752D677 75 OHM 1/10 W 5% 1608 R/TP
R3 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP R702 0RJ0000D677 0 OHM 1/10 W 5% 1608 R/TP
R201 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP R703 0RJ0752D677 75 OHM 1/10 W 5% 1608 R/TP
R202 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP R704 0RJ0000D677 0 OHM 1/10 W 5% 1608 R/TP
R203 0RJ1000D677 100 OHM 1/10 W 5% 1608 R/TP R705 0RJ4700D677 470 OHM 1/10 W 5% 1608 R/TP
R204 0RJ1000D677 100 OHM 1/10 W 5% 1608 R/TP R706 0RJ0752D677 75 OHM 1/10 W 5% 1608 R/TP
R205 0RJ1000D677 100 OHM 1/10 W 5% 1608 R/TP R707 0RJ0000D677 0 OHM 1/10 W 5% 1608 R/TP
R206 0RJ2701D677 2.7K OHM 1/10 W 5% 1608 R/TP R708 0RJ1000D677 100 OHM 1/10 W 5% 1608 R/TP
R207 0RJ0332D677 33 OHM 1/10 W 5% 1608 R/TP R709 0RJ1000D677 100 OHM 1/10 W 5% 1608 R/TP
R208 0RJ1000D677 100 OHM 1/10 W 5% 1608 R/TP R711 0RJ0000D677 0 OHM 1/10 W 5% 1608 R/TP
R209 0RJ1000D677 100 OHM 1/10 W 5% 1608 R/TP R712 0RJ1000D677 100 OHM 1/10 W 5% 1608 R/TP
R210 0RJ1000D677 100 OHM 1/10 W 5% 1608 R/TP R713 0RJ1000D677 100 OHM 1/10 W 5% 1608 R/TP
R401 0RJ1002D677 10K OHM 1/10 W 5% 1608 R/TP R714 0RJ1000D677 100 OHM 1/10 W 5% 1608 R/TP
R403 0RJ1001D677 1K OHM 1/10 W 5% 1608 R/TP R715 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP
R404 0RJ5601D477 5.6K OHM 1/10 W 1% 1608 R/TP R716 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP
R411 0RJ1002D677 10K OHM 1/10 W 5% 1608 R/TP R717 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP
R413 0RJ1001D677 1K OHM 1/10 W 5% 1608 R/TP R720 0RJ2202D677 22K OHM 1/10 W 5% 1608 R/TP
R414 0RJ5601D477 5.6K OHM 1/10 W 1% 1608 R/TP R721 0RJ0000D677 0 OHM 1/10 W 5% 1608 R/TP
R501 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP R722 0RJ1001D677 1K OHM 1/10 W 5% 1608 R/TP (LB500J-EL)
R502 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP R722 0RJ0000D677 0 OHM 1/10 W 5% 1608 R/TP (LB500J-EU)
R503 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP R733 0RJ1501D677 1.5K OHM 1/10 W 5% 1608 R/TP
R504 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP R734 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP
R505 0RJ1002D677 10K OHM 1/10 W 5% 1608 R/TP R805 0RJ1001D677 1K OHM 1/10 W 5% 1608 R/TP
R506 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP R807 0RJ1003D677 100K OHM 1/10 W 5% 1608 R/TP
R507 0RJ1002D677 10K OHM 1/10 W 5% 1608 R/TP R810 0RJ0221D677 2.2 OHM 1/10 W 5% 1608 R/TP
R508 0RJ1002D677 10K OHM 1/10 W 5% 1608 R/TP R811 0RJ0221D677 2.2 OHM 1/10 W 5% 1608 R/TP
- 22 -
DATE: 2002. 2. 23. DATE: 2002. 2. 23.
*S *AL LOC. NO. PART NO. DESCRIPTION / SPECIFICATION *S *AL LOC. NO. PART NO. DESCRIPTION / SPECIFICATION
RA501 0RHZTCZ001A 100 OHM 1/16 W 5% 3215 R/TP CH R5 0RJ3301D677 3.3K OHM 1/10 W 5% 1608 R/TP
RA502 0RHZTCZ001A 100 OHM 1/16 W 5% 3215 R/TP CH R6 0RJ3301D677 3.3K OHM 1/10 W 5% 1608 R/TP
R7 0RJ9101D677 9.1K OHM 1/10 W 5% 1608 R/TP
OTHERs SW1 140-058E SKHV10910B LGEC NON 12V 20A HO
SW2 140-058E SKHV10910B LGEC NON 12V 20A HO
X201 6202TST001A SX-1 SUNNY ,SMS, 14.31818MHZ , SW3 140-058E SKHV10910B LGEC NON 12V 20A HO
X501 6202TST003D HC-49/SM5H KONY CHIP 12 MHZ 30 SW4 140-058E SKHV10910B LGEC NON 12V 20A HO
SW5 140-058E SKHV10910B LGEC NON 12V 20A HO
POWER BOARD SW6 140-058E SKHV10910B LGEC NON 12V 20A HO
SW7 140-058E SKHV10910B LGEC NON 12V 20A HO
BD901 0DD260000BE D2SB60 SHINDENKEN ZD1 0DZ560009DA UDZ S 5.6B TP ROHM-K SOD323 20
C901 0CBZTBU002D 0.33UF D 275V K M/PP NI FM22.5 ZD2 0DZ560009DA UDZ S 5.6B TP ROHM-K SOD323 20
C902 0CKZTBU003D SC SAMWHA 250V 1000PF M BULK 7
C903 0CKZTBU003D SC SAMWHA 250V 1000PF M BULK 7
C905 0CZZTAB004B KMG SYE / SWE 400V 68UF 20% BU
C906 0CK10201515 1000P 1KV K B TS
C907 0CE105EK638 1UF KMG 50V M FM5 TP 5
C908 0CE476EH638 47UF KMG 25V M FM5 TP 5
C909 181-288B MKT 100V 104JTR PHS26104
C911 0CE108EF630 1000UF KMG 16V M FM5 BULK
C914 0CE335EK638 3.3UF KMG 50V M FM5 TP 5
C916 181-288L MKT 100V 823JTR PHS26823
C918 0CE108EF630 1000UF KMG 16V M FM5 BULK
C920 0CKZTBU003C SC E 472M 14.0BW7 250V BK7.5 S
C922 0CK10201515 1000P 1KV K B TS
C923 0CK10201515 1000P 1KV K B TS
D901 0DD400709CB UF4007 TP G.I DO204AL 1000V 1
D903 0DRGS00281A MBRF10H100CT GENERAL SEMICONDU
D906 0DR206000AA MBRF2060CT BK G.I ITO220 60V 2
D904 0DR400409AB UF4004 TP G.I DO204AL 400V 1A
D908 0DZ620009AG P6KE200 TP G.I D015 5W 200V 1M
F901 0FZZTTH001E TIME LAG HBC 2153.15MXE(LEAD),
IC901 0IPMGPF004A TOP246F POWER INTEGRATION TO26
IC904 0ISS431000A KA431AZ (LM431AZ)
LF901 6200TZZ001B - 0 BK L/FILTER, 9MH,LG56BP
P901 6620TKB002C BCP031S-A,BAE EUN AC UNIVERSAL
P902 6631T20008G 5P H-B 100MM UL1061 AWG 26 TWI
PC901 0ILI817000E LTV-817M B 4P BK PHOTO COUPLER
R901 0RD6803A609 680K OHM 1/2 W (7.0) 5% TA52
R902 0RD1004Q609 1M OHM 1/4 W (3.4) 5% TA52
R903 0RD1004Q609 1M OHM 1/4 W (3.4) 5% TA52
R904 0RD4704Q609 4.7M OHM 1/4 W (3.4) 5% TA52
R905 0RD4704Q609 4.7M OHM 1/4 W (3.4) 5% TA52
R906 0RX4702J609 47K OHM 1 W 5% TA52
R907 0RD0471Q609 4.70 1/4W(3 5% TA52
R908 0RD0681Q609 6.8 OHM 1/4 W (3.4) 5% TA52
R909 0RD1001Q609 1K 1/4W(3 5% TA52
R913 0RN1302F409 13K 1/6W 1% TA52
R917 0RD1201Q609 1.20K 1/4W(3 5% TA52
R918 0RD1000Q609 100 1/4W(3 5% TA52
R920 0RN1302F409 13K 1/6W 1% TA52
R921 0RN2701F409 2.70K 1/6W 1% TA52
R923 0RD1202Q609 12K 1/4W(3 5% TA52
T901 6170TMZ133A EER3016 1200 UH V-10PIN LG500J
TH901 6322A00002B SCK-102L THINKING 10OHM 20% 25
CONTROL BOARD
- 23 -
PIN CONFIGURATION
CAT24WC08J-TE13 8P
BLOCK DIAGRAM
DIP Package(p) SOIX Package(J)
EXTERNAL LOAD
A0 1 8 VCC A0 1 8 VCC
A1 2 7 WP A1 2 7 WP D OUT
SENSE AMPS
SHIFT REGISTERS
A2 3 6 SCL A2 3 6 SCL ACK
V SS 4 5 SDA V SS 4 5 SDA V CC
TSSOP Package(U)
SDA START/STOP
LOGIC
A0 1 8 VCC
A1 2 7 WP
A2 3 6 SCL E 2 PROM
XDEC
V SS 4 5 SDA
WP CONTROL
LOGIC
PIN CONFIGURATION
MC74HCT14ADR2 14P
BLOCK DIAGRAM 1 2
A1 Y1
A1 1 14 VCC
3 4
Y1 2 13 AS A2 Y2
A2 3 12 Y6 A3
5 6
Y3
Y2 4 11 A5
9 8
A4 Y4
A3 5 10 Y5
11 10
Y3 6 9 A4 A5 Y5
GND 7 8 Y4
13 12
A6 Y6
- 24 -
SCHEMATIC DIAGRAM (LG Philips Module)
1. GMZAN2
- 25 -
2. LVDS
- 26 -
3. MICOM
- 27 -
4. POWER
- 28 -
5. CONNECTOR & JACKS
- 29 -
6. KEY PART
- 30 -
SCHEMATIC DIAGRAM (AUO Module)
1. GMZAN2
- 31 -
2. LVDS
- 32 -
3. MICOM
MNT OBU
- 33 -
4. POWER
- 34 -
5. CONNECTOR & JACKS
- 35 -
6. KEY PART
- 36 -
Feb. 2002
P/NO : 3828TSL083A Printed in Korea