H2 CHOKES
‘The H2 choke is established as an economical
and dependable means of controlling moderate
Pressures in less severe service applications. This
‘choke is available in pressure ratings of 2000 to
10,000 psi. The nominal 2” H2 choke is available
with up toa 1” maximum orifice, and the nominal
3° H2 choke is available with up 'to a2" maximum
orifice.
* _ Interchangeability of parts to construct a
Positive, adjustable, or combination chake
® "Bonnet nut has rugged integrally forged lugs
for hammering nut loose
+ _ Fast installation ot bonnet nut by using
coarse threads
‘+ Coarse threads used tu allach bonnet to
choke, thus minimizing thread galling tendency
+ __Builtsin safety feature whioh releases residual
Pressure in the choke body before the nut Is fully
removed. The inside of the choke hady is vented
to atmosphere after the bonnet nut is only
partially removed.
+ Wide selection of choke body styles
+ __ Interchangeability of component parts in a
particular pressure range. For example, the same
blanking plugs and bonnet assemblies are used
in nominal 2" 2000 through 10,000 psi WP
* Long-lasting, dependable J packing on
adjustable choke needle
* _ Stainless steel adjustable choke needle and
seat
Ha CHOKE NEEDLE AND SEAT PART NUMBEHS
CHOKE SYSTEMS
a
CAMERON IRON WORKS, INC., HOUSTO!
I744mt
H2 CHOKE PARTS LST
@ |r| sunset Sunless Ga
2] SBS St ih Tae Pestotertat | eon
(fet ey eee Wee ei
| rm wisi —|~aser a
| Fa | assem a A
Ema ea
ae caress Soret ——| eta
i 0
w]e | $Saies sez Rew Toasty Saw To
{tte bs Sp an — aes
| & Sige Snes Sew "| Tae a oe a
Se ee Bice nT
| Gea Tawar }iear| rare ee
Set
ask
co
Biaeseen | Tira