Professional Documents
Culture Documents
page page
DIAGNOSIS AND TESTING (4) Push the fog lamp switch button. The test lamp
should illuminate, and the LED indicator on the
FOG LAMP SWITCH TEST front of the switch.
Refer to Group 8W, Wiring Diagrams for wiring or (5) If either the LED, or the test lamp fails to illu-
circuit information. minate, replace the switch.
FRONT
(1) Remove the fog lamp switch and disconnect the
connector at the center stack.
(2) Using two jumper wires connect Pin L7 to bat-
tery voltage, and connect Pin Z03 to ground (Fig. 1).
(3) Push the fog lamp switch button. The LED
indicator on the front of the switch should illuminate.
Check Pin L35 with a test lamp for battery voltage.
(4) If either the LED or the test lamp fails to illu-
minate, replace the switch.
INSTALLATION
For installation, reverse the above procedures.
INSTALLATION
For installation, reverse the above procedures.