Professional Documents
Culture Documents
Features
Vijay Energy
Energy saving: Auto Delta Star Delta
Delstar Converter Module Converter to automatically switch the
motor to Star when the input current falls
below the set value (55% FLC
approximately)
DELSTAR CONVERTER MODULE (DSCM) is an electronic system • Supply Voltage: 220V (Standard) or
to be interfaced with the existing Star Delta starter. When the 415V (Optional)
input power to the motor falls below 50%, it switches the
motor to operate in STAR to Save Energy. When the load
increases (beyond the pre set value - based on the capacity of
the motor), it automatically switches the motor to operate in Customised Solutions
DELTA.
Motors coupled to high inertia loads
Recommended Applications are: where motors are operating at
require higher capacity motors to meet
load conditions varying between high and low or permanently the starting current requirements and
low (frequency of load changes preferably not more than 120 are started in Delta. These motors
times/hour). work at low loads, once starting is
over. In these cases motors can be
Why DSCM? started in Delta and then run in Star to
• Substantial Saving in Energy save considerable amount of Energy.
Hence If motors are fitted with DOL
• Payback is less than one year in most of the cases starter, it will be worthwhile to fit our
• Reduction in KVA Leading to reduction in Maximum ENERGY SAVING STAR DELTA
Demand STARTER SYSTEM
• Improves power factor
• Extends life of the motor
Typical Applications
• Air Compressors, Air Handling Units
• Machine Tools, Conveyors
• Blenders, Textile Machinery
• Chemical Equipments, Ball Mills
• And Many More
ENERGY SAVING STAR DELTA
SAVE ENERGY WITH Vijay Energy STARTER
CASE STUDIES
Comparison of Models EQUIPMENT SAVINGS/YEAR
All models provided with LED Indications (RUPEES)
Fully sealed models for explosive areas and DIN RAIL & Blending M/c 22500/-
96 mm. square panel mounted models can also be 120T Press 56250/-
supplied. Two for One 16250/-
* *
Twister
MODEL NO.: SM 2 EM 1 EM 2
DESCRIPTION Blower 40000/-
ENERGY SAVING Brake Fatigue 8000/-
FEATURE Rig
NUMBER OF
C.Ts 3 1 1 Wire Drawing 40000/-
CURRENT BASED Machine
SINGLE PHASING TRIP _ _ Air 33750/-
Compressor
RUN OVERLOAD TRIP _
Lathe NH 26 20000/-
START OVERLOAD _ Vertical Turret 15550/-
TRIP OPTIONAL OPTIONAL
Lathe
CURRENT DSPLAY - _
LCD OPTIONAL OPTIONAL Injection 37500/-
HOUR COUNTER _ Molding M/C
(ENERGY SAVING HRS.) OPTIONAL OPTIONAL
• PLUS savings due to M.D. reduction
BYPASS FACILITY
and p.f improvement not considered.
SIZE IN MM (EXCLUDING • Calculations assume 5000 hours of
FIXING BRACKETS) 120*200*75 120*200*75 122*125*75
working @ Rs.5 per KWH.
Specifications/Design are subject to change without notice Our Other ENERGY SAVING
PRODUCTS