Professional Documents
Culture Documents
Home > Technical Library > Electrical and Electronics > Appendix 5.1: : Conductor Sag and Tension Calculations
From High Voltage Engineering and Testing, 2nd Edition Product Announcements
Typically, a 400 m span and a tension of 2500 kg with a conductor of mass 1.74
kg/m will have a sag of:
http://www.globalspec.com/reference/36205/203279/appendix-5-1-conductor-sag-and-tension-calculations 11/26/2012
Appendix 5.1: : Conductor Sag and Tension Calculations On GlobalSpec Page 2 of 3
The second term of the calculation is only 0.15% of the first term and, therefore, to a
first approximation it is usual to ignore it. Accordingly, the equation:
is used to calculate sags and tensions for level spans when the sag is less than
about 10% of the span. This equation describes the shape of a parabola.
For use in the case of supports on sloping ground, i.e. with supports at A and B in
the following diagram, the parabolic equation for sag and tension is adapted as
follows:
where, as shown in Figure 5.15. X is the distance from the lower support B.
It should be noted that the parabola follows the same curve from A to B as for a
parabola with level supports fixed at A and C. The above equation is sufficiently
accurate for determining sags and tensions of slack spans from the terminal...
Interested in this book and others like it? Try EngineeringPro from
Books24x7
Copyright The Institution of Electrical Engineers 2001 under license agreement with
Books24x7
http://www.globalspec.com/reference/36205/203279/appendix-5-1-conductor-sag-and-tension-calculations 11/26/2012
Appendix 5.1: : Conductor Sag and Tension Calculations On GlobalSpec Page 3 of 3
Product Announcements
Rail Cable Carrier RCC for long travel motion
U.S. Tsubaki Power Transmission, LLC
Rail Cable Carrier RCC from KabelSchlepp makes possible long travel motion up to
500 m travel length without sag. (read more)
Topics of Interest
Chapter 6: High Voltage Cables
M. Simmons 6.1 Introduction The first rule to understand when considering the design of high
voltage cables is that many of the design parameters are set by the system into which the cable
will...
Chapter 22: Sagging Line Conductors
Sagging operations begin as soon as the conductor stringing is completed, to establish the
proper conductor tension for the conditions at the time the work is performed. The correct
conductor tension...
Chapter 7: Weather Loads, Conductor Sags and Tensions
7.1 Scope The next two chapters look at conductors the workhorse of the overhead line.
Chapter 8 looks at the electrical choice for conductors and how to calculate what is required.
This chapter,...
Appendix
This appendix discusses shielding theory basics, as related in Figure 4.2. The material is taken
from [6] in Chapter 4, with slightly different wording and in a slightly different order than in the...
Tension in timing-belt drives
A urethane timing belt moves samples into position in this CAD simulation of an automated
blood sampling machine. Timing-belt drives transmit torque and motion from a driving to a
driven pulley or...
http://www.globalspec.com/reference/36205/203279/appendix-5-1-conductor-sag-and-tension-calculations 11/26/2012