You are on page 1of 14

CORE 5 Compilation

(1-3)

4. For all set A and B, A-B = AUBC. This is called


- Set Difference Law

5. For two set A and B, if refers to the set of all elements that is in B and not A
- Set Difference

6. This is a declarative statement that is either true of false


- Proposition

7. Two proposition is False, the answer is false, but if either 1 of the proposition is true the
answer is true.
- DISJUNCTION
8. Two proposition is TRUE, the answer is TRUE, but if either 1 of the proposition is False the
answer is False.
-CONJUCTION

9. The statement is false if and only the first proposition is true and the second proposition is
false.
-IMPLICATION

10. When the two propositions are both true and both false, the statement is true, otherwise false.
- Biconditional (XNOR Analogy)

11. A proposition that is always true


- Tautology

12. A proposition that is always false


- Contradiction

13. A proposition that can be true at least once.


Ans. Satisfaction

14. A proposition that is never true nor never false.


Ans. Contingency

15. p V true= true and p^ false= false


Ans. Domination Law

(16-18) ??

(19-21) ??

22. If the emitter resistor is open, the ac input voltage will


Ans. Increase

23. If the collector resistor is open, the ac input voltage will


Ans. Decrease

24. If the emitter bypass capacitor is shorted, the ac input voltage will
Ans. Decrease

(25-27) ??
31 For DC, the current in the coupling circuit is
- Zero

32 The current in the coupling circuit for high frequencies is


- Maximum

33 In a bypass capacitor, the top of the capacitor acts


- as a DC open and AC short

(34-36)
37. Reducing all dc sources to zero is the first step in obtaining the:
- ac equivalent circuit

38. In Ac Analysis, the capacitors are replaced by:


-Shorts

(39-42)

43. If the ac voltage is 1mV and the ac current 0.1mA, determine the ac resistance.
Ans. 10 ohms

44. A graph of emitter current and base-emitter voltage is applicable to ___.


Ans. Emitter diode

45. In CE amplifier, the output voltage is:


a. Amplified
b. Inverted
c. 180 out of phase
d. All of the above
Ans. d. All of the above
49- An ac emitter current times ac emitter resistance is
- Ac base voltage

50- An ac collector current equals ac base current times


-ac current gain

51- An emitter is an ac ground at


- CE stage

(55-57)??
(58-60)

61 in CE amp, effects of swamp amp becomes


Ans Unimportant

62 Swamp Amp
Ans reduces distortion

63 Swamp amp
Ans stabilize gain

64) the ac collector resistance of the first stage includes the?


- input impedance of second stage

65) if the emitter bypass capacitor opens, the ac output voltage will?
- decrease

66) If the collector resistor is shorted, the ac output voltage will?


- equal zero

(67-69) ??

70. If the bypass capacitor is open, the ac input voltage will


a. Decrease
b. Increase
c. Remain the same
d. Equals zero
ANSWER: B. Increase
71. The amount of heat required to raise the temperature of the unit mass of gas through one
degree at constant volume is:
a. specific heat at constant volume
b. specific heat at constant pressure
c. kilo joule
d. none of these
ANSWER: A. specific heat at constant volume

72. An adiabatic process in one in which:


a. No heat enter or leaves the gas
b. The temperature of gas changes
c. The change in internal energy is equal to mechanical work done
d. All of the above
ANSWER: All of the above

73. The processes occurring in open system which permit the transfer of mass to and from the
system, are known as:
-Flow Processes

74. Which of the following has the minimum atomic mass?


A. Oxygen
B. Sulphur
C. Nitrogen
D. Carbon
- ANSWER: D.CARBON

75. Work done in a free expansion process is


-Zero

76. Pressure exerted by the gas is equal to _____ of kinetic energy per unit volume of gas.
Ans. 2/3

77. Entropy ____


Ans. Increases

78. Atomic mass of oxygen


Ans. 32(sa flashing)

(79-81) ??
82. The distillation carried out in such a way that the liquid with the lowest boiling point is first
evaporated and recondensed, then the liquid with the next higher boiling point is then evaporated
and recondensed, and so on until all the available liquid fuels are separately recovered in the
sequence of their boiling points. Such a process is called
[A]. cracking
[B]. carbonisation
[C].fractional distillation
[D]. full distillation
Ans. C

83. Which of the following statement is incorrect?


A. The liquid fuels consist of hydrocarbons.
B. The liquid fuels have higher calorific value than solid fuels.
C. The solid fuels have higher calorific value than liquid fuels.
D. A good fuel should have low ignition point.
Ans. C

84. Value of universal gas constant (R) in SI units


Ans. 287 J/kgK

85.avogadro's law
-directly proportional

86.strain energy
-energy stored in a body when strained to elastic limit

87.vertical column, moment of inertia, direction


-minimum moment of inertia

88. a seller.....
-recovery something

89. unit of tension surface


-N/m

90. ung isa may axis keme tas sagot


-minimum
(91-93)

94. Regulating the Operation of Cable Antenna Television (CATV) systems in the Philippines,
and for other purposes.
Ans. EO 205

95. Rules and regulation requiring the services of duly registered electronics and communication
engineer in the planning, and designing installation or construction, operation and maintenance
of radio stations and in the manufacture and/or modification of radio communications
equipment.
Ans. DO 88

96. Policy to improve the provision of Local Exchange Carrier Service.


Ans. EO 109

97. Which law vested the jurisdiction, control and regulations over the Philippine communication
satellite corporation with the National Telecommunications Commission?
ans. E.O. 196

98. Which law provides for a national policy on the operation and use of international satellite
communications in the country?
ans. E.O. 467
99. What is otherwise known as "The Maritime Communications Law"?
ans. R.A. 3396

100. RA 6849 is otherwise known as


Answer: Municipal Telephone Act of 2000

101. Run-length encoding is used to:


a. encrypt data
b. compress data
c. correct data
d. none of the above
Answer: b. compress data

102. Public-key encryption:


a. allows the use of digital signatures
b. is used to convey symmetric keys
c. avoids the "password problem"
d. all of the above
Answer: d. all of the above

103. SDLC is
*Synchronous Data Link Control

104. HDLC is
a) a bit-oriented protocol
b) based on SLDC
c) is an ISO Standard
d) All of the above
Ans: D

105. The effect of too many collsions


* the network will slow down

106. MAU stands for


-Multistation Access Unit

107: The standard that describes Ethernet-type network is:


-IEEE 802.3

108: Ethernet was invented by


-Xerox

(109-111) ??
115. 100BaseT uses an
- RJ45 connector

116. UTP is also known as


- Unshielded Twisted Pair

117. CAT 5
- offers faster data rate

118. Switch
- sends incoming packets to specific ports.

119. Hub
- sends incoming packets to all ports connected to it.

120. Advantage of switch to hub.


-avoid collision

121. broadband LANs:


a. modulate data onto a carrier
b. coaxial cable
c. provided by cable tv companies for internet access
d. all of the above
ans. d

122. using one node in the network to hold all application softer is done in
a. peer-to-peer network
b. client - server network
c. both a and b
d. none of the above
ans. b
123. recording lock is used to
a. record securely in the server
b. prevents multiple users to access the same document
c. prevents one user to read a record another user is writing onto
d. none of these
ans. C

124. What software that runs the client-server network must be


Ans. MULTITASKING

125. "Thin" client


Ans. Pc without hard disk

126. MAN
Ans. Metropolitan Area Network

127. Packet Switching is based on


Ans: Store-and-Forward

128. SNA stands for


Ans: Systems Network Architecture

129. The number of layers in ISO OSI is


Ans: 7

130. The lowest-level layer in OSI ISO LAYER is called the:


a. Physical layer
b. Link layer
c. Cable layer
d. Transport layer
===ans. A===

131. Bad frames are usually detected by the:


a. Frame layer
b. Physical layer
c. Error-check layer
d. Link layer
===ans. D===

132. Virtual circuit is set up by the:


a. User
b. Link layer
c. Network
d. Frame
===ans. C===
133. ATM stands for
-Asynchronous Transfer Mode

134. Frame Relay:


A. is faster than X.25
B. does less error checking than X.25
C. allows for variable length packets
D. all of the above
-D. all of the above

(135-136)

(137-138) ??

139. IP is
Ans. Connectionless protocol

140. The lifetime of a packet


Ans. Depends on the number of hops

143
144

145. HTML allows


a. telnetting
b. high-speed file transfer
c. *web page layout*
d. all of the above

146. FTP stands for:


a. File Transfer Protocol

147. Transfer files between a server on the network and a user.


Ans. FTP

148. SMTP stands for:


Ans. Simple Mail Transport Protocol

149. ISP stands for


-Internet Service Provider

150. ?

You might also like