Professional Documents
Culture Documents
To design 220KV transmission tower for various wind zone Table 4.1: Parameters for the transmission line and its
in accordance with IS-802 for design calculation. components.
To perform finite element analysis of transmission tower in
staddpro. Transmission line voltage 220 kV.
To design for 765KV , 2000KV and 4000KV in various Suspension
wind zones. Tower type
type.
To compare CFS and HRS sections for X and K bracing.
To check yielding ,force deformation relationship in No. of circuits Single circuit.
maximum capacity in various wind forces.
Angle of Line deviation 00- 20
Terrain type considered Plain (II).
IV. LOADS ON TRANSMISSION LINE TOWER Basic wind speed 39 m/s.
V. PROBLEM STATEMENT
The present project presented the idea for using the advanced
structural tool STAAD.pro to solve complicated engineering
problems involving beam and in very less time. It has been
revealed that the load combinations involving wind-forces
were critical amongst all combinations. Hence the design
was carried out for those combinations. The wind force
normal to cables was found to the worst of all. The design
given by STAAD.pro has been found to be complying with
IS-800: 1984 and all the members were safe.
VIII. REFERENCES
1. Analysis and Design of 220kV transmission line tower
with hot rolled and cold formed section. International
Journal of Scientific & Engineering Research, Volume
6, Issue 12, December-2015 ISSN 2229-5518
2. Analysis of Transmission Towers with Different
Configurations. Jordan Journal of Civil Engineering,
Volume 7, No. 4, 2013