Professional Documents
Culture Documents
After installing the adapter, the adapter’s tray icon will appear in your system
tray. It appears at the bottom of the screen, and shows the signal strength using color
and the received signal strength indication (RSSI). If the icon is (green),
congratulations, there is excellent signal strength, and you may now use the wireless
network. If the icon is (gray), follow the steps below to launch the connection
manually.
1. Double-click the icon and the TWCU utility will run. You can also run the utility
by click the Start->Program->VigLAN->VigLAN Wireless Client Utility. On the
prompted configuration tab page, click the Profile Management tab.
2. Click the Scan button on the Profile Management page, the Available Network
window will appear.
3. Click the Refresh button to refresh the list at any time if you wish.
4. Highlight the network name and lick the Activate button to connect to an
available network. If no configuration profile exists for that network, the Profile
Management window will open to the General tab. Fill in the Profile name and
click OK to create the configuration profile for that network.
Note: If a well-balanced wireless network cannot be created, please refer to the
User Guide on the Resource CD or your dealer for help.
D. Software Installation for Windows XP
1. When “Found New Hardware Wizard” is prompted, click Cancel, and then insert
the Resource CD into your CD-ROM drive. Click the Start button and choose Run.
In the field that appears, enter F:\usb\Setup.exe (if “F” is the letter of your CD-
ROM drive; ‘USB’ represents the setup program path, which is labeled on the
Resource CD) to load the following page.
2. Follow the InstallShield Wizard steps, and click the OK button when done to
reboot the system.
Note: If Windows XP warns about Windows Logo testing, click Continue
Anyway to continue the installation.
E. Check Wireless Connection in Windows XP
a. Configure using VigLAN Utility
After installing the adapter, the adapter’s tray icon will appear in your system
tray. To use the VigLAN utility, double-click it. The steps for Windows XP and
Window 2000 are very similar. Please refer to check Wireless Connection in
Windows 2000.
b. Configure using Windows XP Wireless Zero Configuration
1. Windows XP will display a Wireless Network Connection message like this one.
To use Windows XP Wireless Zero Configuration, double-click here.
2. The screen that appears will show you many available wireless networks.
Highlight the network that you want, and then click Connect.
Note: The steps below are the instructions and screenshots for Windows, if you
have installed any Service Packs, it will not affect the setup. Windows menus are
almost the same, and as such the following steps can still be consulted.
3. The screen below will appear if the connection is finished.
Note: For more information about Windows XP Wireless Zero Configuration on
Windows XP computer, refer to Help and Support if the Operating System. If a
well-balanced wireless network cannot be created, please refer to the User Guide
on the Resource CD or your dealer for help.
CONTACT INFORMATION
For help with the Installation of the VigLAN USB Wireless Adapter, please contact us.
E-Mail: email@vigtools.co.kr
Website: www.vigtools.co.kr