Professional Documents
Culture Documents
Translation
Available
INTRODUCTION
Keep your Haas machines running at peak performance while avoiding unplanned downtime. A maintenance program allows
you to manage your schedule rather than getting caught with untimely surprises. This page shows the recommended
maintenance intervals. To change the control default Automatic Maintenance Reminders settings refer to: Classis Haas Control
(CHC) - Automatic Maintenance Reminders
Auxiliary Filter
Maintenance Item Hours - In Motion Hours - Power On Maintenance Setting
Service the Auxiliary Filter
Copyright 2018 by Haas Automation, Inc. No unauthorized reproduction | Last Published On April 24, 2017 1/4
Barfeeder
Maintenance Item Hours - In Motion Hours - Power On Maintenance Setting
Grease the bar feed push rod and bushing 50 - -
Grease the ballscrew, V-roller tracks, and rotation 200 - -
Check the lubrication on the rotation control shaft 2600 - -
Gearbox
Maintenance Item Hours - In Motion Hours - Power On Maintenance Setting
Inspect the oil level - 200 173
Replace the oil - 2400 170
HPC-300
Maintenance Item Hours - In Motion Hours - Power On Maintenance Setting
HPC-300 PSI - Daily Maintenance 10 - -
HPC-300 Pump-Filter - Maintenance 50 - -
Inspect the hoses for cracking - 1200 -
Verify the Auto Clean system is operating correctly 1200 - -
HPC-1000
Maintenance Item Hours - In Motion Hours - Power On Maintenance Setting
Inspect the oil level on the pump 50 - -
Service the Auxiliary Filter
Copyright 2018 by Haas Automation, Inc. No unauthorized reproduction | Last Published On April 24, 2017 2/4
Hydraulics
Maintenance Item Hours - In Motion Hours - Power On Maintenance Setting
Clean the coolant collector 50 - -
Inspect the oil level 50 - -
Clean chips from rotating union 50 - -
Replace the oil filter - Parker Hydraulic Unit - 1200 -
Replace the oil filter - Rexroth Hydraulic Unit - 1200 -
SL - Replace the oil filter - Haas Hydraulic Unit - 1200 -
ST - Replace the oil filter - Haas Hydraulic Unit - 1200 -
Inspect the hoses for cracking - 1200 -
Pneumatics
Maintenance Item Hours - In Motion Hours - Power On Maintenance Setting
Service the Air Supply
Copyright 2018 by Haas Automation, Inc. No unauthorized reproduction | Last Published On April 24, 2017 3/4
Tailstock
Maintenance Item Hours - In Motion Hours - Power On Maintenance Setting
Grease the tailstock 200 - -
Turret
Hours - In Hours - Power Maintenance
Maintenance Item
Motion On Setting
Run the coolant and inspect the coolant transfer seal for
- 1200 -
leaks.
Copyright 2018 by Haas Automation, Inc. No unauthorized reproduction | Last Published On April 24, 2017 4/4