(WEBRG) INSTRUCTION MANUAL
‘ Br
-DRONE MDRONEPRO XDRONEHD
Model No 6100099 ‘Model No.G140005 Model No. 615000
-DRONE MDRONEROWALS XDRONE DRONE
Model No, 6140006 Model No, 6150002, Model No, 6150003, Model No. 6150008BECOMING FAMILIAR WITH THE
CONTROLLER
Antenna
Indicate Light Forward/Bachward
Tim
u ilps)
(Power Selecta
Camera Buton
Ais tim
ow0rF
CLT Drone HD and XExone Sy eb, 24GH
Note: 1)L1 to select the engines power output: € XDrone, XOrone Pro and XOrone HO: L403, M 70% H 100% @ XOrone Nano, xDrone Royals and
XDrone Spy 1 beep=40%,2beeps=70%, 3 beeps=1009%
Indicator Lights: The controller indicator ight wilight up RED when the controllers tured on and working. f the controler indicator lights ashing, then the
controller needs new batteries,
BATTERY INSTALLATION
Your xDrone controller takes 4AA batteries (inched)
Remove the battery over on the controler and insert the bateres matching the +/-onthe batteries to the +/- indicated inside the controller,HOW TO CHARGE YOUR XDRONE
Pig charger inte a USB port then connect the charger plug to the bate. rDrone Nan, NOrone Spy and XOrone Royals only)
‘STEP1 Plug charger into the power jack, then connect the charger plug tothe battery. (XOrone, XDrone HD and XDrone Pro Only)
STEP 2 | Thecharging indicator ight (on charger willight up when the battery i fully charged, (XDrone Nano, XDrone Spy and XDrone Royals ony)
‘Unplug the charger plug from battery and disconnect charger Let the batteries rest for 15 minutes after,
STEP3 | done charging and after use (before recharging)
BATTERY INSTALATIONFLYING YOUR XDRONE
CONTROLLER
HoveRUP AND DowN | TURN COUNTER CLOCKWISE FORWARO/BACKWARD LeFT/RIGHT
[AND CLOCKWISE
ame \
\
a
FIRST FLIGHT INSTRUCTIONS |
STEP 1
Place the XDrone ona fat smooth surface An uneven surface wil alec the XDrones ability to Moff Turn on the KOrone by
plugging inthe battery
STEP 2
“Tum onthe controller immediatly (within 3 seconde) afer plugging n the battery to the Xdrone: Back away, atleast 6 fet with the
front ofthe xérone pointed away from you.
STEP 3
“Make sure the controlleris in sync withthe XDrone by pushing the left joystick up and down several mes until he propellers spin.
‘Once in syn, slowly push onthe left joystick for take-off
STEP 4
‘As s00n asthe XDrone leaves the grounds release the left joystick slighty. Worst case scenario the XDrone wl drop backto the or, but
{thisis better than having ierash into the cling Ifyou ae fying indoas or fing too high and losing contol fying outdoors.
STEPS
Ifthe XDrone starts to go down, push up on the Joystick gently. Ifthe KOrone rises to quickly, gently push down on the left joystick
STEP 6
Practice hovering, landing and fing patterns as described onthe coming pagesCHANGING PROPELLERS
1. Unplug LiPo Battery on
your XDrone,
2. Remove the small
screw holding
the blade in place
using a mini screwdriver.
3.Make note of the blade
color and letter (A2 or 82)
before removing the blade
from XDrone. (Markings are
located on the underside of
blades).
4. Replace the damaged
blade with a new blade with
matching color and letter,
Secure the blade with the
WARNING: Do not fly with broken or damaged propeller as it may cause damage or lead to injury.
MAINTENANCE
Over time propellers may wind up loose hair or carpet fibers from floors, reducing performance. Unplug Xdrone and remove
fibers from motors. (Remove blades, if necessary)
HOWTO TRIM YOUR XDRONE
To trim use the correct trim button and adjust it to your liking:
Qe siverbutton beneath the eft joytick (xs Trim Button trimsit counter dokwise and clockwise.) The silver button beneath the ight joystick
(Cefe/Right Trim Buton}itleftight. The silver button next the right joystick (Forward/Backward Trim Button trims it forward/backward,
ow you knowhow tori your NOrone. Go out there and pct Remember tha 9% ofthe time you Xone not balanced i's becouse you tok mare than 3 seconds toplce
‘on afat surface afte plugging in the battery. The rim ony for minor adutments Read our atl on how tol the Krone before yours fightPRACTICE MAKES PERFECT
Hovering Practice:
Practice hovering: Draw a circle onthe ground, Place the XDrone in the circle. AL
Stand next to the XDrone and slowly push up on the left joystick to raise the XDrone ‘
into te ar keeping twthin he ctt, lowly push down onthe lef joystick land v
Repeat this while standing infront of the XDrone. fat any time the XDrone shows
sigs of ping qulkly lower te lf joystick to land &
Mark a spot on the floor some distance off. Raise the XDrone into the air and try
landing on the spot that you have marked,
Practice Flight Patterns:
Once you have mastered hovering try fying patterns. Start by
fying our XDrone ina square. Nec ty fying ina cle then a
figure&.fatany time
the XDrone shows signs f tipping, quickly lower the let
Joystick to land. “ey
ay
For more practice tips and support visit: www.support.myfunkyplanet.comFLIPS & TRICKS
Back Flip
Step 1:Use Li to set power to 100%
‘Step 2: Bring the XDrone to a hover at an altitude of 10
‘Step 3: Press and hold R1, then push down on the right joystick.
Let go of RI and right joystick after a back flip has been complete.
Barrel Roll
Step 1: Use L1 to set power to 100%.
Step 2: Bring the XDrone to a hover at an altitude of 1oft.
Step 3: Press and hold R1, then push right on the joystick.
Let go of RI and right joystick after a barrel roll has been complete.
The XDrone s capable of performing lots of different fips, barre rolls and other tricks/stunts. Here you can find intructions on how to
perform some of the most basic ones. For information on more fun tricks/stunts visit us at ww.support.myfunkyplanet.comLarenaeaipilchne ‘TAKING PHOTOS AND RECORDING VIDEOS
(nbrone Fro XDrone HD and Drone Sy oni
nser the Miro Memory Crdint the xDrone
“Total pcture during ight push up the CAMERA BUTTON onthe REMOTE (gure 2)
“To take video push down the CAMERA BUTTON onthe REMOTE to start recording, Pash the CAMERA BUTTON
‘othe nial positon to stop recording figure 3)
DOWNLOANDING PHOTOS AND VIDEOS
ee ects cee ences
le
insert it back into the XDrone, ee
transfer. ‘pacty Mera Card Upto
Push down to video record {clickit once to start S268 Sod Separate)
recording) (Chekit again to sto recording) ae
oumayvogradeto longerTROUBLESHOOTING
PROBLEM
Rotor(s) not rotating (or slower than others)
The XDrone stops or drops
suddenly while flying,
‘The XDrone is not reacting to the
Controle’ commands.
The XDrone loses control.
The XDrone is not keeping a charge.
The XDrone will not lift off
The XDrone will only turnin one direction.
CAUSE
The batteries are low.
Controller and xDrone net synchroniced,
‘The powers too low,
Te XDrone may be out ofthe contol’ range.
The XOrone may not be ON,
‘The contler may be too fat aay fom the xDrone
tis windy ouside
The XOrone may be turned ON when
Yyouare charging it
‘The controller is low on battery power.
The XDrone may not be fly charged.
The XDrone has not been trimmed conectly
SOLUTION
Recharge the XDrone or confirm thatthe controller's
batteries are inserted matching the +/- sins
Reset controller and XDrone. Turn cntrller OFF,
unplug XDrone's battery and syne again
Recharge the XDrone and check the controller's
battery power.
Move the controller closer tothe XDrone
‘Turn the xDrone ON
Move the controller closer tothe XOrone.
‘Do not use the XDrone in strong wind as
can interfere withthe controle.
Turn the XDrone OFF when charging.
Replace the battriesin the control
(Charge the XDrone fully unt the green
Inleator light comes on,
Refer tothe trimming section inthe instructions
Not
‘normal functioning of the XDrone seems to be interrupted or disturbed, there could be strong electro-magnetic interference. To rest the
XDrone, turn it OFF completely, wait 10 seconds, then tur t back ON. Ifnormal operation do not resume, choose another place to operate your
Drone and try again. To ensure normal operation, check the batteries as low power will nt allow for normal operation.COMPANY / LEGAL
Cand RFF Regulation: 1) Ths produ comps wth at 1S he Fes pean subject othe flowing two can) This dele mayo ase asl ieee, an (2) eve st
cepa irre ese ncn inteerenc tat may cause desl operatn. This equipment hasbeen ese an four compy th the itso dass dtl devices pasuat top 1c the
rules. Theses desig a pride esol pceton gs hain wth alo cena Baas say ener, ue, canada a ee ney hte an be na
uaare tative wilt ou Its toy des casein witha reese ep ou can ch hs ting they of anon wilelserng the ite}, one or mare the
folowing measures may best-ever oat the eeing ata Inceae the dstane between the yan thera othe Cn the deer ran experienced sai technician hp.
NOTE: Change adstmens radiations a thst indo bt Tite telat of ayant component apt sence) cou esl na vlatin Cres udp 15
andr 35 and mes bees ape roy ays they oul ithe ssa tape the equipment Tis ass dtl apparatus meets te eqns the Crain
Inererence-