Professional Documents
Culture Documents
X79
"The repair procedures given by the manufacturer in this document are based on the All rights reserved by Renault.
technical specifications current when it was prepared.
Copying or translating, in part or in full, of this document or use of the service part reference
The procedures may be modified as a result of changes introduced by the manufacturer in numbering system is forbidden without the prior written authority of Renault.
the production of the various component units and accessories from which the vehicles are
constructed".
DUSTER - Chapitre 7
Contents
Pages
145783
(see ) (01D, Mechanical introduction)
71A-1
BODY INTERNAL TRIM
Interior body side trim assembly: Exploded view 71A
H79
71A-2
BODY INTERNAL TRIM
Roof trim assembly: Exploded view 71A
H79
145784
(see ) (01D, Mechanical introduction)
1 Grab handle
2 Courtesy light
3 Sun visor
6 Headlining clip
8 Headlining
71A-3
BODY INTERNAL TRIM
Floor trim assembly: Exploded view 71A
H79
145785-1
(see ) (01D, Mechanical introduction)
2 Lashing hook
4 Floor carpet
5 Floor soundproofing
71A-4
BODY INTERNAL TRIM
Floor carpet: Removal - Refitting 71A
REMOVAL
108525
108524
a Remove the rear bench seat base .
71A-5
BODY INTERNAL TRIM
Floor carpet: Removal - Refitting 71A
II - OPERATION FOR REMOVAL OF PART
CONCERNED
108503
118629
a Remove the retaining clips (5) .
108504
REFITTING
II - FINAL OPERATION
71A-6
BODY INTERNAL TRIM
Floor carpet: Removal - Refitting 71A
a Refit:
- the side door seals,
- the B-pillar linings (see 71A, Body internal trim,
B-pillar trim: Removal - Refitting, page 71A-9) ,
- the centre console (see Centre console: Removal
- Refitting) (MR 389, 57A, Interior equipment),
- the front seats (see Complete front seat: Remov-
al - Refitting) .
71A-7
BODY INTERNAL TRIM
Windscreen pillar trim: Removal - Refitting 71A
REMOVAL
107832
II - REMOVAL OPERATION
107833
REFITTING
a Proceed in the reverse order to removal.
71A-8
BODY INTERNAL TRIM
B-pillar trim: Removal - Refitting 71A
Tightening torquesm
REMOVAL
108515
a Remove:
- the cover,
- the bolt (2) .
108517
a Remove the bolt (1) .
71A-9
BODY INTERNAL TRIM
B-pillar trim: Removal - Refitting 71A
II - OPERATION FOR REMOVAL OF PART
CONCERNED
117826
a Remove the B-pillar upper trim.
108536
118108
108482
a Remove the B-pillar lower trim.
a Remove:
- the control (4) using a flat screwdriver,
REFITTING
- the door seals (partially).
71A-10
BODY INTERNAL TRIM
B-pillar trim: Removal - Refitting 71A
- the door seals,
- the seat belt adjustment control.
II - FINAL OPERATION
a Refit the upper and lower bolts for the seat belt.
a Tighten to torque the upper and lower bolts for the
seat belt (21 N.m).
a Refit the cover for the upper seat belt bolt.
71A-11
SIDE OPENING ELEMENT TRIM
Front side door trim: Removal - Refitting 72A
REMOVAL
125450
a Remove:
- the bolts (3) ,
- the speaker.
125449
a Remove: a Disconnect the speaker connector.
125451
a Unclip the trim (4) from the door trim bolt.
a Remove the cover from the interior handle (5) .
72A-1
SIDE OPENING ELEMENT TRIM
Front side door trim: Removal - Refitting 72A
REFITTING
Note:
To make it easier to fit the trim, moisten the box
section at the point where the seal is applied.
125453
a Unclip the front door trim using an unclipping tool.
72A-2
SIDE OPENING ELEMENT TRIM
Rear side door trim: Removal - Refitting 72A
Special tooling required
REMOVAL
II - REMOVAL OPERATION
144646
EQUIPMENT LEVEL E2
a Remove the speaker grille (3)
144764
144647
a Unclip the blanking cover of the rear side door trim
bolt (1) . a Remove:
a Remove the rear side door interior handle cover us- - the speaker bolts (4) ,
ing the tool (Car. 1363) by (2) . - the speaker.
a Disconnect the speaker connector.
72A-3
SIDE OPENING ELEMENT TRIM
Rear side door trim: Removal - Refitting 72A
REFITTING
Note:
To facilitate fitting the rear side door trim,
dampen the box section where the seal is to be
applied.
II - REFITTING OPERATION
145614 a Proceed in the reverse order to removal.
a Remove the rear side door armrest bolt (5) .
III - SPECIAL NOTES FOR REFITTING THE
EQUIPMENT LEVEL E2 MANUAL WINDOW WINDER
144645 109592
a Remove the rear side door interior handle bolts (6) . a Drill the trim at the centre of the mark (7) .
72A-4
SIDE OPENING ELEMENT TRIM
Rear side door trim: Removal - Refitting 72A
109593
109594
a Finish the operation using a conical milling cutter.
72A-5
NON-SIDE OPENING ELEMENTS TRIM
Rear opening element assembly on the passenger compartment side: Exploded view 73A
H79
146251
(see ) (01D, Mechanical introduction).
3 bulb
73A-1
FRONT SEAT FRAMES AND MECHANISMS
Front seat assembly: Exploded view 75A
DRIVER HEIGHT ADJUSTER
146024
(see )
75A-1
FRONT SEAT FRAMES AND MECHANISMS
Front seat assembly: Exploded view 75A
DRIVER HEIGHT ADJUSTER
10 Front seat chest-level side airbag (see Front (chest-level) side air-
bag: Removal - Refitting)
75A-2
FRONT SEAT FRAMES AND MECHANISMS
Front seat assembly: Exploded view 75A
DRIVER HEIGHT ADJUSTER
146025
(see )
75A-3
FRONT SEAT FRAMES AND MECHANISMS
Front seat assembly: Exploded view 75A
DRIVER HEIGHT ADJUSTER
11 Retaining clip
75A-4
FRONT SEAT FRAMES AND MECHANISMS
Front seat assembly: Exploded view 75A
FIXED SUBFRAME
146034
(see )
75A-5
FRONT SEAT FRAMES AND MECHANISMS
Front seat assembly: Exploded view 75A
FIXED SUBFRAME
10 Front seat chest-level side airbag (see Front (chest-level) side air-
bag: Removal - Refitting)
75A-6
FRONT SEAT FRAMES AND MECHANISMS
Front seat assembly: Exploded view 75A
FIXED SUBFRAME
146035
(see )
75A-7
FRONT SEAT FRAMES AND MECHANISMS
Front seat assembly: Exploded view 75A
FIXED SUBFRAME
11 Retaining clip
75A-8