Professional Documents
Culture Documents
Laboratory 9
1.4. Neck
Introduction to Mechanical Engineering [2014-2015]
1.5. Handle
Introduction to Mechanical Engineering [2014-2015]
1.6 Seal_neck
Introduction to Mechanical Engineering [2014-2015]
1.7. Seal_ball
Introduction to Mechanical Engineering [2014-2015]
2. Create a product, put all the parts in (Seal_ball - two times) and add from the Catalog Browser a M8
NUT GRADE A (ISO4032).
Use Coincident Constraint to align Body1, Body 2 and the two Seal_Ball.
Introduction to Mechanical Engineering [2014-2015]
Use Coincidence constraint to align the Neck, Handle, Seal_Neck and Nut:
Introduction to Mechanical Engineering [2014-2015]
Make a Coincidence constraint between the axis of the Neck and the axis of Body 1:
Introduction to Mechanical Engineering [2014-2015]
Make two Contact Constraints between the ball and the Neck (lateral surface & bottom surface):
Align the lateral surface of the handle with groove of the ball with an angle of 90deg. Align the hole of the Ball
with Body1 or 2.This signifies that the valve is OPEN (fluid can flow through the valve).
Introduction to Mechanical Engineering [2014-2015]