Professional Documents
Culture Documents
SUPPLIED FORMS
The main form supplied of this alloy is TripleGrip
Treadplate
• Sheet
• Extrusions
• Plate
• Treadplate/Patterened Sheet
[1 OF 2] CONTINUED
Property Value
Density 2.68 g/cm³
Melting Point 605 °C
Thermal Expansion 23.7 x10-6 /K
Modulus of Elasticity 70 GPa
Thermal Conductivity 138 W/m.K
Electrical Resistivity 0.0495 x10-6 Ω .m
MECHANICAL PROPERTIES
BS EN 485-2:2008
Sheet and Treadplate
0.2mm to 6.00mm
Property Value
Proof Stress 130 Min MPa
Tensile Strength 210 - 260 MPa CONTACT
Hardness Brinell 61 HB
Address: Please make contact directly with your local
The properties above are for material in the H32 condition service centre, which can be found via the
Locations page of our web site
Web: www.aalco.co.uk
WELDABILITY
Weldability – Gas: Good REVISION HISTORY
Weldability – Arc: Very Good
Weldability – Resistance: Very Good
Datasheet Updated 11 January 2016
Brazability: Acceptable
Solderability: Not recommended
DISCLAIMER
FABRICATION This Data is indicative only and as such is not to be relied upon in place of
the full specification. In particular, mechanical property requirements vary
Workability – Cold: Good widely with temper, product and product dimensions. All information is
Machinability: Acceptable based on our present knowledge and is given in good faith. No liability will
be accepted by the Company in respect of any action taken by any third
party in reliance thereon.
Please note that the 'Datasheet Update' date shown above is no guarantee
of accuracy or whether the datasheet is up to date.
The information provided in this datasheet has been drawn from various
recognised sources, including EN Standards, recognised industry references
(printed & online) and manufacturers’ data. No guarantee is given that the
information is from the latest issue of those sources or about the accuracy of
those sources.
Material supplied by the Company may vary significantly from this data, but
will conform to all relevant and applicable standards.
As the products detailed may be used for a wide variety of purposes and as
the Company has no control over their use; the Company specifically
excludes all conditions or warranties expressed or implied by statute or
otherwise as to dimensions, properties and/or fitness for any particular
purpose, whether expressed or implied.
Advice given by the Company to any third party is given for that party’s
assistance only and without liability on the part of the Company. All
transactions are subject to the Company’s current Conditions of Sale. The
extent of the Company’s liabilities to any customer is clearly set out in those
Conditions; a copy of which is available on request.
[2 OF 2]