Professional Documents
Culture Documents
// Set the load control parameter as loading from OMU and writing data into Flash.
In this way, the board loads host software from the OMU and writes the data into
Flash after being reset.
SET LODCTRL: LODCTRL=LFB;
// Initialize data
RST DATA:;
// Gb interface boards(IP)
ADD BRD: SRN=0, BRDCLASS=INT, BRDTYPE=FG2c, SN=16, RED=NO;
SET ETHPORT: SRN=0, SN=16, BRDTYPE=FG2c, PTYPE=FE, PN=0, AUTO=ENABLE, MTU=1500,
OAMFLOWBW=0, FLOWCTRLSWITCH=ON, FCINDEX=0, ERRDETECTSW=OFF, REMARK="GB over IP";
// Add an NSE
ADD NSE: NSEI=1, PT=GB_OVER_IP, OPNAME="46010", CNID=0;
//Unlock CM Control
ULK CMCTRL:;