This document provides instructions for 3D modeling a plate object in Autodesk using various commands:
1. The top view of the object is drawn, the UCS is changed to an isometric view, and the workspace is changed to 3D modeling.
2. The presspull command is used to add thickness and a fillet command adds semicircles on both sides of the object.
3. Circles are made within the semicircles and presspull creates holes on both sides, completing the 3D model of the plate.
This document provides instructions for 3D modeling a plate object in Autodesk using various commands:
1. The top view of the object is drawn, the UCS is changed to an isometric view, and the workspace is changed to 3D modeling.
2. The presspull command is used to add thickness and a fillet command adds semicircles on both sides of the object.
3. Circles are made within the semicircles and presspull creates holes on both sides, completing the 3D model of the plate.
This document provides instructions for 3D modeling a plate object in Autodesk using various commands:
1. The top view of the object is drawn, the UCS is changed to an isometric view, and the workspace is changed to 3D modeling.
2. The presspull command is used to add thickness and a fillet command adds semicircles on both sides of the object.
3. Circles are made within the semicircles and presspull creates holes on both sides, completing the 3D model of the plate.
UCS Icon the UCS to change After clicking the the view said part
Change the workspace from
Drafting and Annotation to 3D Modeling *Note: After changing the workspace the toolbar will eventually change to 3D Modeling
Use the presspull command to
make the thickness of the object. PRESSPULL icon
Left Click the highlighted
area then input the thickness of 16 Left Click the highlighted area then input the thickness of 64
Use the Fillet
command to make the Semicircle on the both side
Fillet then Radius then input the
radius 24 then click the highlighted area (enter/space once) then click the opposite side of the rectangle (enter/space) then do the same procedure on the other side
Make a circle with diameter 20 in the part of the semicircle
If the Circle has been
horizontally in orientation *Note use trial and make sure to change the error until the WCS orientation of the origin is like this After doing the said procedure make the circle at the both side using the center of the semicircle as the center of the circle
Then use the command
presspull to make a hole in the both side of the semicircle
Now change the MODEL
from 2D Wireframe to SHADED
In using the subtract command just
*NOTE If the presspull type SU then select the object the command does not make a whole object then (enter/space) hole on the object use the then click the object that you want subtract command (SU) to subtract then (enter/space)