You are on page 1of 3

1. When the transistor is saturated, V is approximately?

a. 0 V
b. ½ VCC
c. VCC
d. infinite
2. calculate the common-emitter amplification factor β of a transistor with a common-base
amplification factor α=0.99.
a. 10
b. 50
c. 100
d. 200
3. Three circles with radii 3.0, 5.0 and 9.0 cm are externally tangent. What is the area of the triangle
formed by joining their centers?
a. 32cm2
b. 36cm2
c. 48cm2
d. 46cm2
4. Find the radius of the circle circumscribing an isosceles right triangle having an area of 162 sq.
cm?
a. 11.23
b. 10.63
c. 12.73
d. 15.27
5. The time required for two examinees to solve the same problem differs by two minutes. Together,
they can solve 32 problems in one hour. How long will it take for the slower problem solver to
solve the problem?
a. 5 min
b. 6 min
c. 4 min
d. 3 min
6. The pattern appearing on an oscilloscope when harmonically related signals are applied to the
horizontal and vertical inputs.
a. Lossajous’ pattern
b. Shockley pattern
c. Braun’s pattern
d. Lee de Forest’s pattern
7. An earthquake is usually measured by the magnitude M on the Richter scale. The intensity I of an
earthquake and the magnitude M are related by the formula M=log I/Io,where Io is the intensity of
an arbitrary chosen earthquake. The earthquake that hit Kobe, Japan measured 5.7 on the Richter
scale. The earthquake that hit Baguio, Philippines measures 7.8. how many times stronger is the
earthquake that hit Baguio?
a. 148
b. 126
c. 137
d. 37
8. It refers to the average amount of time between the creation and recombination of a free electron
and a hole
a. Recombination time
b. Delay time
c. Conduction time
d. Life time
9. Find the coordinates of the midpoint of a segment whose end points are H (4,9) and K (-10,1).
a. (-3,5)
b. (-3,-5)
c. (3,5)
d. (5,-3)
10. Normally, diodes will not conduct when reversed-biased, but if the reverse voltage is increased
further, a point will be reached where the diode gives up and allowing the current to surge. This
voltage is one of the limiting parameter of diodes and is known as
a. Breakdown voltage
b. Peak reverse voltage
c. Peak inverse voltage
d. All are correct
11. The substrate used in a p-channel IGFET enhancement type
a. n-type material
b. p-type material
c. n’-type material
d. p’-type material
12. a network that employ diodes to remove away a portion of an input signal without distorting the
remaining part of the applied waveform?
a. Clamper
b. Rectifier
c. Regulator
d. Clipper
13. Carbon-composition resistors
a. Can handle gigantic levels of power
b. Have capacitance or inductance along with resistance
c. Have essentially no capacitance or inductance
d. Work better for ac than for dc
14. Compute the angle between the line 2y-9x-18=0 and the x-axis
a. 64.54
b. 77.47
c. 45
d. 87.65
15. Find the distance from the point (5,-3) to the line 7x-4y-28=0.
a. 2.62
b. 2.48
c. 2.36
d. 2.54
16. What is the effect in terms of bandwidth when the Q of a single-tune stage is doubled?
a. Doubled
b. The same
c. Halved
d. Four times
17. Resistivity of a wire depends on
a. Length
b. Material
c. Cross-sectional area
d. Both A and C
18. A circuit contains two unequal resistances in parallel
a. Current is same in both
b. Large current flows in larger resistor
c. Potential difference across each is same
d. Smaller resistance has smaller conductance
19. The power dissipated in across the resistance in an AC circuit
a. Imaginary power
b. Reactive power
c. Apparent power
d. True power
20. What is the efficiency of a series-fed class A amplifier?
a. 25
b. 78.5
c. 50
d. Above 90

You might also like