You are on page 1of 4

材料 Material 单位 单位Unit ¥价格 菲币Cost

混凝土 Ready Mix Concrete 立方米 cu.m ¥620.92 ₱4,750.00


混凝土泵 Pump Crete 台 ¥1,568.63 ₱12,000.00
标号33螺纹钢 Grade 33 kg ¥4.34 ₱33.20
标号40螺纹钢 Grade 40 kg ¥4.52 ₱34.60
标号33螺纹钢 Grade 60 kg ¥4.61 ₱35.26
绑扎铁丝 Tie Wire ga.16 捆 roll ¥209.15 ₱1,600.00
碎石-3/4英寸直径 Gravel 3/4 立方米 cu.m ¥209.15 ₱1,600.00
碎石-25.4mm直径 G-1 立方米 cu.m ¥196.08 ₱1,500.00
沙子 Sand 立方米 cu.m ¥91.50 ₱700.00
胶合板19.05mm Plywood 3/4" pc ¥126.80 ₱970.00
胶合板12.7mm Plywood 1/2" pc ¥71.90 ₱550.00
酚醛板19.05mm Phenolic 3/4" pc ¥156.86 ₱1,200.00
胶合板12.7mm Phenolic 1/2" pc ¥124.18 ₱950.00
铁钉 Nails kg ¥7.84 ₱60.00
原木 Rough Lumber 2x2x8 pc ¥15.69 ₱120.00
原木 Rough Lumber 2x3x8 pc ¥23.53 ₱180.00
原木 Rough Lumber 2x4x8 pc ¥31.37 ₱240.00
干木材 Clean dry Lumber 2x2x8 pc ¥32.42 ₱248.00
干木材 Clean dry Lumber 2x3x8 pc ¥48.63 ₱372.00
干木材 Clean dry Lumber 2x2x8 pc ¥66.80 ₱511.00
空心水泥砖 CHB 6" (400 psi) pc ¥2.61 ₱20.00
空心水泥砖 CHB 5" pc ¥1.83 ₱14.00
空心水泥砖 CHB 4" pc ¥1.57 ₱12.00
楼承板 Metal Deck pc ¥58.82 ₱450.00
脚手架 Scaffolding set ¥248.37 ₱1,900.00
防潮层 Moisture Barrier kg ¥23.53 ₱180.00
白蚁防治药 Termiticide 升 L ¥448.37 ₱3,430.00
铝箔保温层 Aluminum Insulation roll ¥1,960.78 ₱15,000.00
卷门 Roller Shutter Door sq.m ¥718.95 ₱5,500.00
钢推拉门 Steel Flush door pc ¥1,111.11 ₱8,500.00
地面瓷砖 Ceramic Floor Tiles pc ¥4.71 ₱36.00
墙面瓷砖 Ceramic Wall Tiles pc ¥4.71 ₱36.00
4.5mm菲林板 4.5mm Ficem Board pc ¥62.61 ₱479.00
100mm底板 100mm Baseboard 英寸 ft ¥4.58 ₱35.00
木推拉门 Wood Flush Door pc ¥209.15 ₱1,600.00
12mm石膏板 12mm Gypsum Board pc ¥75.82 ₱580.00
实木板门 Solid Wood Panel Door pc ¥627.45 ₱4,800.00
大门锁 Entrance Lock pc ¥101.96 ₱780.00
滚珠轴承铰链 Ball Bearing Hinges pc ¥26.14 ₱200.00
闭门器 Door Closer pc ¥130.72 ₱1,000.00
门框 Door Jamb pc ¥313.73 ₱2,400.00
0.5mm厚305不锈钢天沟 0.5mm Grade 305 stainless steel gutter pc ¥79.08 ₱605.00
0.5mm屋脊 0.5mm Ridge Roll pc ¥65.36 ₱500.00
红丹漆 Red Oxide pail ¥89.35 ₱683.55
速干墙漆 Quick Dry E (any color) pail ¥74.70 ₱571.45
底漆白 Primer White pail ¥100.20 ₱766.50
平面乳胶漆 Flat latex (color) pail ¥67.84 ₱519.00
环氧底漆 Epoxy primer pail ¥98.25 ₱751.65
环氧树脂漆 Epoxy Paint pail ¥124.11 ₱949.45
漆刷 Paint Brush pc ¥14.35 ₱109.75
油漆滚刷 Roller Paint brush pc ¥58.79 ₱449.75
PPR管50.8mm PPR Pipe 2" pc ¥262.88 ₱2,011.00
PPR管31.75mm PPR Pipe 1-1/4" pc ¥103.79 ₱794.00
PPR管25.4mm PPR Pipe 1" pc ¥60.00 ₱459.00
PPR管19.05mm PPR Pipe 3/4" pc ¥37.12 ₱284.00
PPR管12.7mm PPR Pipe 1/2" pc ¥24.71 ₱189.00
PPR转接头 PPR Adapter 2" m pc ¥145.10 ₱1,110.00
PPR转接头 PPR Adapter 1-1/4" m pc ¥65.36 ₱500.00
PPR转接头 PPR Adapter 1" m pc ¥51.50 ₱394.00
PPR转接头 PPR Adapter 3/4" m pc ¥21.57 ₱165.00
PPR转接头 PPR Adapter 1/2" m pc ¥16.08 ₱123.00
PPR转接头 PPR Elbow Adapter 1" f pc ¥46.14 ₱353.00
PPR弯管转接头 PPR Elbow Adapter 3/4" f pc ¥17.91 ₱137.00
PPR弯管转接头 PPR Elbow Adapter 1/2" f pc ¥11.50 ₱88.00
PPR弯管90° PPR Elbow 90 deg 2" pc ¥19.48 ₱149.00
PPR弯管90° PPR Elbow 90 deg 1-1/4" pc ¥5.75 ₱44.00
PPR弯管90° PPR Elbow 90 deg 1" pc ¥3.01 ₱23.00
PPR弯管90° PPR Elbow 90 deg 3/4" pc ¥1.96 ₱15.00
PPR弯管90° PPR Elbow 90 deg 1/2" pc ¥1.05 ₱8.00
PPR T型管 PPR Tee 2" pc ¥23.92 ₱183.00
PPR T型管 PPR Tee 1-1/4" pc ¥7.32 ₱56.00
PPR T型管 PPR Tee 1" pc ¥4.18 ₱32.00
PPR T型管 PPR Tee 3/4" pc ¥2.48 ₱19.00
PPR T型管 PPR Tee 1/2" pc ¥1.44 ₱11.00
减压器 Reducer 3/4" x 1/2" pc ¥1.05 ₱8.00
减压器 Reducer 1" x 3/4" pc ¥1.57 ₱12.00
减压器 Reducer 1-1/4" x 1" pc ¥2.61 ₱20.00
闸阀50.8mm Gate Valve 2" pc ¥180.52 ₱1,381.00
闸阀31.75mm Gate Valve 1-1/4" pc ¥85.49 ₱654.00
闸阀25.4mm Gate Valve 1" pc ¥63.79 ₱488.00
闸阀19.05mm Gate Valve 3/4" pc ¥47.58 ₱364.00
截止阀25.4 Check Valve 1" pc ¥10.57 ₱80.83
污水管50.4mm Sanitary Pipe 2" pc ¥32.68 ₱250.00
污水管100.8mm Sanitary Pipe 4" pc ¥93.33 ₱714.00
污水管151.2mm Sanitary Pipe 6" pc ¥200.00 ₱1,530.00
污水Y管151.2*100.8mm Sanitary Wye 6" x 4" pc ¥90.07 ₱689.00
污水Y管100.8*100.8mm Sanitary Wye 4" x 4" pc ¥17.12 ₱131.00
污水Y管100.8*50.4mm Sanitary Wye 4" x 2" pc ¥14.25 ₱109.00

经纬仪 Theodolite pc
水准仪 Level pc
塔尺 Tower ruler pc
50m卷尺 tape measure pc
铁锹 Shovel pc
推车 Cart
Remarks 备注 Supplier 供应商 Contact Number 电话
RCPJC corporation 09178002346
Minimum of 50 cu.m RCPJC corporation 09178002346
Steel Asia 2426638
Steel Asia 2426638
Steel Asia 2426638
25 kg/roll Jlex Hardware 6868818
Boss Mike 09235734830
Boss Mike 09235734830
Boss Mike 09235734830
Jlex Hardware 6868818
Jlex Hardware 6868818
Jlex Hardware 6868818
Jlex Hardware 6868818
Jlex Hardware 6868818
Jlex Hardware 6868818
Jlex Hardware 6868818
Jlex Hardware 6868818
Jlex Hardware 6868818
Jlex Hardware 6868818
Jlex Hardware 6868818
Boss Mike 09235734830
Boss Mike 09235734830
Boss Mike 09235734830
0.8mm x 1m Philmetal 09178220003
1.7 x 1.2 Sadelta 09178310719
5 x 60m RC New Chemical Resources 8510486
D.I.Y Pest Control Expert 09175006907
1m x 60m Insulation Technologies 6512485
Springfield Doors 41243116
With Door Jamb Springfield Doors 41243116
Wilcon 4547199
Wilcon 4547199
Wilcon 4547199
Benesco 4167321
Springfield Doors 41243116
Insulation Technologies 6512485
Springfield Doors 41243116
Lever Handle Springfield Doors 41243116
Springfield Doors 41243116
Springfield Doors 41243116
Springfield Doors 41243116
Multi-Line 4101155
Multi-Line 4101155
Wilcon 4547199
Ranging Prices based on color Wilcon 4547199
Wilcon 4547199
Ranging Prices based on color Wilcon 4547199
Wilcon 4547199
Ranging Prices based on color Wilcon 4547199
Wilcon 4547199
Wilcon 4547199
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408 31.75
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408 19.05
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408
Parklane Commercial Corp. 09951561408

50m long

You might also like