Professional Documents
Culture Documents
Date.
M ay 15, 2003
TAD AN O 1/ 3
TO: TADANO SOUTH CHINA CO.
Dear Mr.Koo,
Regarding to the subject, please adjust moment zero-span for TR-250M-5 as follows,
1) With no lifting and the boom retracted fully, force the boom against the boom rest (support
like the below figure.) w ith the accelerator fully depressed. Then, stop the engine.
(Stator key’ position is [OFF].)
2) Open the sm all w indow (for relay box) under the m ultiplex data transm itter.
(Location is the rear of the cab)
5) After m ake sure that the PTO sw itch is [OFF], start the engine.
6) Operate elevating operation lever so that the pressure of the boom elevating cylinder
is depressurized.
7) After the working completed, m ust be disconnect the connector for adjustment zero of
AML w ith the wiring ① like a above figure.
2/3
3) Press the picture selection key on the display section. The menu screen (the below figure.)
w ill appear.
※ Regarding to using Multi Display, please refer to the attached sheets (total 7 pages.)
4) Press the [5] key, the next menu screen (the below figure) w ill appear.
5) On the above menu picture, depress the key [・] three times successively, for the key number
inputting mode.
7) Depress the key [ 1 ] for adjust mode picture. (the below figure)
9) The follow ing m akes adjustment in accordance w ith attached m oment adjustment
procedure.
Boom angle
Boom length
Coarse adjustment