o OTHER A covariance indices based Cumulative method for fault detection IEEE 9 BUS approach and 1 and classification in a power covariance 2019 transmission system during index power swing
2 Effect of an additional large 765 kV
disturbance during power transmission 2018 swings on the impedance system of seen by the out-of-step Venezuelan blocking function national grid 3 An improved setting-free WSCC 9-Bus 2018 power swing blocking Test System scheme using local end information 4 Detecting symmetrical faults WSCC 9 Bus 2018 during power swing for system deblocking distance relays The proposed method is tested on a 5-machine 14-bus power Detection of Power Swing system, 2018 5 and Fault During Power simulated in Swing Using Lissajous Figure electromagnetic transient program (EMTP) for symmetrical, asymmetrical and non-ideal faults and found accurate. 6 Distance Protection during Kundur’s four- 2018 Asymmetrical Power Swings: machine system Challenges and Solutions is used for simulation studies and its data are given in Appendix 7 Modified concentric power three-machine 2018 power swing blocker applicable in system and IEEE UPFC compensated line 39-bus power system are considered 9 Modeling of distance This protection logic for out-of- experimental shows the step condition in power 2018 simulation system test for the theephase symmetrical fault. This test is simulated by the secondary injection to the protection distance numerical relay. The kit used with the experiment is the Freja 300. 10 Waveform asymmetry of WSCC 9-Bus instantaneous current signal Test System 2018 based symmetrical fault detection during power swing 11 A novel approach for SMIB test 2017 improvement of power swing system with blocking and deblocking parallel lines functions in distance relays and 68 bus and 68 bus New England Test New York Power System (NETS- NYPS) 12 A Novel Approach to Detect (SMIB) 2017 Faults Occurring During And (IEEE 39 Bus) Power Swings by Abrupt Change of Impedance Trajectory 13 A power and voltage-angle (WSCC) 9-bus, 3- 2017 machine based index for system with distinguishing symmetrical different fault fault from stable power scenarios swing 14 Assessment of power swings 2017 in hydropower plants through high-order modeling and eigenanalysis 15 Detection of fault during The 400kV, 2017 50Hz WSCC 9 power swing using bus system superimposed negative sequence apparent power based scheme 16 Detection of fault in 2017 transmission line during power swing using fuzzy c- means clustering transmission line protection 17 DWT based symmetrical fault 400KV double- 2017 detection method during circuit transmission power swing system without and with series compensation is considered 18 Fault detection during power 2-bus system 2017 And swing by phase difference 9-bus 3-machine technique WSCC power system model 19 Fault Detection During Power IEEE PSRC 2017 Swings Using the Properties standard test of Fundamental Frequency system. Phasors New England 39-Bus Multi- Machine System And Field data results 20 Modeling protection systems 2017 in time-domain simulations: a new method to detect mis- operating relays for unstable power swings 21 Power swing detection, 2017 blocking and unblocking logic in distance relay 22 Power Swing Detection in Two , UPFC-Compensated Line by simulations test scenarios Phase Angle of Current are prepared: the first uses a single machine to infinite bus (SMIB), whereas the second is based on the IEEE 39- Bus power system 23 Secured relay operations Two bus equivalent during power swing system , New England 39 bus system 24 Symmetrical fault detection WSCC 9-Bus system during power swings: An interpretable supervised learning approach 25 Variation of UPFC To analyse UPFC 2017 performance in controllable parameters different during power swing and their conditions, five impacts on distance relay different cases are provided. The Case 1 is the assessment of UPFC (phasor model) performance in steady-state condition. The Case 2 is simulation of UPFC (phasor model) performance during power swing (sinusoidal changes of δ1) and the Case 3 consists in the simulation of UPFC (phasor model) performance during power swing (sinusoidal changes of |V1|). Case 4 examines the performance of detailed model of UPFC during power swing and Case 5 simulates three-machine power system with detailed model of UPFC. 26 Supervising distance relay The proposed 2017 method is tested during power swing using for 230 kV, 60 Hz, synchrophasor two-area measurements fourmachine and ten-machine 39-bus systems simulated using PSCAD/ EMTDC software with detailed machine model and distributed transmission line model. 27 Secured zone-3 protection The 2017 during power swing and methodolog voltage instability: an online y is verified approach by a 400 kV 9-bus system with and without series compensati on. 28 Power swing and voltage 2017 stabilization by PV generator with active and reactive power controls 29 Solution to Fault Detection 400kV, 50Hz, 2017 During Power Swing Using 9-bus power system using Teager--Kaiser Energy PSCAD/EMTD Operator C 30 A direct method for assessing SMIB test 2017 distance-protection behavior system and during power swings IEEE nine- bus test system 31 Fast fault detection scheme IEEE PES 2017 for series-compensated lines power system during power swing relaying committee (PSRC) and large power system with series compensation WSCC 3- machine, the 9- bus case in is considered 32 Input-output properties of 2017 the swing dynamics for power transmission networks with hvdc modulation