Professional Documents
Culture Documents
1. Overview
The STT-433 is ideal for remote control applications where low cost and longer
range is required. The transmitter operates from a 1.5-12V supply, making it ideal
for battery-powered applications. The transmitter employs a SAW-stabilized
oscillator, ensuring accurate frequency control for best range performance. Output
power and harmonic emissions are easy to control, making FCC and ETSI
compliance easy. The manufacturing-friendly SIP style package and low-cost make
the STT-433 suitable for high volume applications.
2. Features 3. Applications
7. Mechanical Drawing
Description
STT-433
Pin Name
Description
ANT
50 ohm antenna output. The antenna port impedance affects output power and harmonic emissions. An
L-C low-pass filter may be needed to sufficiently filter harmonic emissions. Antenna can be single core
wire of approximately 17cm length or PCB trace antenna.
VCC
Operating voltage for the transmitter. VCC should be bypassed with a .01uF ceramic capacitor and
filtered with a 4.7uF tantalum capacitor. Noise on the power supply will degrade transmitter noise
performance.
DATA
Dimensions in Inches
0.55”
0.1”
OOK is the modulation method of choice for remote control applications where power consumption and cost
are the primary factors. Because OOK transmitters draw no power when they transmit a 0, they exhibit
significantly better power consumption than FSK transmitters.
OOK data rate is limited by the start-up time of the oscillator. High-Q oscillators which have very stable center
frequencies take longer to start-up than low-Q oscillators. The start-up time of the oscillator determines the
maximum data rate that the transmitter can send.
9. Typical
Application
10.
Disclaimer
© 2007 Sunrom Technologies http://www.sunrom.com
Copyright
© Sunrom Technologies , 200
7
Neither the whole nor any part of the information contained in, or the product described in this manual
,
which the failure of the product might reasonably be expected to result in personal injury. This document provides
preliminary information that may be subject to change without notice. Visit us at: http://www.sunrom.com/ X
may be adapted or reproduced in any material or electronic form without the prior written consent of the
copyright holder. This product and its documentation are supplied on an as-is basis and no warranty as to
their suitability
for any particular purpose is either made or implied.
Sunrom Technologies will not accept any claim for damages howsoever arising as a result of use or
failure of this product. Your statutory rights are not affected. This product or any variant of it is not
intended for use in any medical appliance, device or system in