Professional Documents
Culture Documents
Version 10/2002
SikaMelt-9670
The Assembly Specialist
Technical Product Data:
Chemical base Polyurethane reactive hotmelt
Colour White - beige, opaque
Solids content 100%
Reaction mechanism Moisture curing
1)
Density at 20°C (DIN 53217) 1,2 kg / l approx.
Viscosity at 130°C (Brookfield Thermosel) 22 000 mPas approx.
1)
Softening Temperature (DIN 52011: ring & ball) 65°C approx.
Application temperature range 100 - 160°C (short-term 170°C)
Open time (500 µm film at 100°C) (TS-SQP 559-0) 1 min approx.
Industry
SikaMelt-9670 1/ 2
Chemical resistance: Packaging information:
SikaMelt-9670 is resistant to Surface preparation. Bonding area Hobbock 20 kg
aqueous surfactant solutions, weak must be clean, dry and free from
acids and caustic solutions. It is grease, oil and dust. Adhesion can Bag 2,5 kg
temporarily resistant to fuels, be improved by suitable substrate Cartridge 0,33 kg
solvents and oils. As the chemical pre-treatment. Metals should be
resistance depends on type and heated to 40°C prior to use. Due to a
condition of the substrate, chemical variety of substrates and mechanical Important:
concentration, exposure duration load requirements, technical For information and advice on the
and temperature, a project adapted consultations with our Technical safe handling, storage and disposal
adhesive performance test is Service are in any case advisable. of chemical products, users should
strongly recommended. refer to the actual Safety Data Sheet
Cleaning up. SikaMelt-9670 in containing physical, ecological,
Method of application: uncured state may be removed from toxicological and other safety-related
SikaMelt-9670 can be applied by tools and equipment with SikaMelt- data.
heated piston-type cartridge gun, by 9900 (see also manual “Cleaning of
appropriate melting equipment out of SikaMelt reactive PUR hotmelt Note:
containers, and out of hobbocks or application tools”). The information, and, in particular, the
drums for film-, spot-, bond-line- or Once cured inside application recommendations relating to the
equipment, the material can be application and end-use of Sika products,
spray-application. are given in good faith based on Sika's
Split width 0,1-1 mm. swelled with SikaMelt-9901. After
current knowledge and experience of the
swelling there is a mechanical
products when properly stored, handled
Standstill periods for several hours cleaning necessary. and applied under normal conditions. In
or over night have to be avoided practice, the differences in materials,
especially at temperatures over Further information: substrates and actual site conditions are
Copies of the following publications such that no warranty in respect of
120°C. During longer periods of merchantability or of fitness for a
interruption the equipment are available on request:
particular purpose, nor any liability arising
temperature has to be lowered to - Safety Data Sheet out of any legal relationship whatsoever,
100°C. Clean the nozzles with a dry - Manual “Cleaning of SikaMelt can be inferred either from this
oil (available on request) in order to reactive PUR hotmelt application information, or from any written
avoid blockage. tools” recommendations, or from any other
advice offered. The proprietary rights of
third parties must be observed. All orders
are accepted subject to our current terms
of sale and delivery. Users should always
refer to the most recent issue of the
Technical Data Sheet for the product
concerned, copies of which will be
supplied on request.