2. Wait about 10 minutes. 3. Set three way cock (A) to blowing out 4. Open cock (E) and set reducing valve to * bar. 5. Open all spray nozzles (D) by turning the needles. 6. Open drain cock (B) to Pos. 1-3 and drain cock (C). 7. Set three way cock (A) to washing. 8. Water wash for 10 minutes. 9. Close cock (E). 10. Set three way cock (A) for a short period of time to blowing out, then to zero position. 11. Close all spray nozzles (D). 12. Close drain cock (B) (Pos. 2-1) and drain cock (C). 13. Run engine at same load for approx. 10 minutes. Then increase load slowly and check for undue vibrations that did not exist before or clean again. 14. Slight noise indicating contact of rotating parts is harmless due to running inlayer of cover ring. 15. Check spray nozzles from time to time.
Cleaning of BBC Turbocharger
! Turbine Side !
1. Reduce the rpm to 50% load.
2. Open the drain cock (A) (Pos. 1-3). 3. Close the drain cock (B). 4. Open valve (C). 5. Open the valve (D) slowly ! until the pressure gauge shows 2.5 bar. 6. When the water from the drain pipe 3 appears clean, the cleaning is completed (after about 10 minutes). 7. Close the valve (D). 8. Close the valve (C). 9. Open the drain cock (B). 10. Close the drain cock (A) (Pos. 2-1). 11. After completing the cleaning, operate at the same load for 5 minutes. 12. Listen to the turbocharger, to make sure that it runs smoothly (without vibrations) when increasing the rpm. If not, repeat the cleaning.