Professional Documents
Culture Documents
MOSFET Electronic Transistors How can I decide the W/L ratio of MOSFET?
Question 13 answers
Asked 4 years ago
Share Saumil Vora
In analog IC design we choose length of
opular Answers (1) MOSFET as per technology file, but what for
width? Means how I can decide the width of
MOSFET for particular application?
Abhishek Pandey 4 years ago
Birla Institute of Technology, Mesra
View
If you are using Cadence software then you can find in Model How can I ensure all transistors are working in
parameter (Cox, Cgs, Y..and many more parameter) in DC saturation on designing CMOS op-amp. using
operating point. cadence tool?
Question 7 answers
3 Recommendations
Asked 5 years ago
Sohiful Anuar Zainol Murad
ll Answers (7)
Can anyone give a simple solution?
In case you are asking for extracting the process parameters of Cox=(e0.er)/tox
MOSFET, there are number of tools available of Cadence,
Mentor or Synopsis etc for design objectives. You may use what would be the value of epsilon(r) for
Silvaco also for device siulation purposes. My first post in this HKMG
regard was for MOS parameters' study purpose only.
epsrox = 3.9, is same for all models in PTM,
1 Recommendation what does it signifies?
Vladimir Polischuk 3 years ago
NIK LLC View
How to calculate the gate capacitance (Cgd or
In the book of Jacob Baker "CMOS. Circuit Design, Layout, and Cgs) of a MOS from Output characteristics (Id
Simulation." See chapter about PSPICE parameter for 180 nm vs Vds) after DC simulation with different Vgs
Ad