You are on page 1of 1

Group 43 MID 130 Transmission Control Unit, Fault Codes

MID 130 PPID 50 Clutch, Pre-load


Type of FMI Description: Fault Condition: Possible Possible Cause:
fault: Symptoms:
FMI 0 • Data valid but above • The calculated • Yellow lamp is • N/A
normal operational stored energy is sent
range above 200 kJ • The clutch is
• The energy overheated
calculation is time • The clutch is
based for VTNA slowly engaged
and physical for
others
FMI 11 • Clutch protection • Clutch slip more • Yellow lamp is • N/A
active (unidentifiable than 8.0 s with sent
error) vehicle movement • There has been
less than 0.8 m unnecessary
(e.g. hill holding clutch slip
event)
• The clutch is
slowly engaged
FMI 14 • Special instructions • Attempt to start • White lamp is sent • N/A
in high range in • Not possible to
manual position start

MID 130 PPID 51 Clutch Disc, Pull Position


Type of FMI Description: Fault Condition: Possible Possible Cause:
fault: Symptoms:
FMI 13 • Calibration value out • The checksum • Yellow lamp is • N/A
of range in NVRAM is not sent
correct • It is not possible to
• The slip point drive the vehicle
has not been
calibrated

25

You might also like