Professional Documents
Culture Documents
Parts list
Important :
This book applies exclusively to FD dryers as from following serial numbers onwards and filled with
refrigerant R404a; see data plate:
FD260: AIQ-124 045
FD280: AIQ-703 623
FD300: AIQ-140 200
FD380: AIQ-129 800
FD450: AIQ-140 550
· Use only authorized parts. Any damage or malfunction caused by the use
of unauthorized parts is not covered by Warranty or Product Liability.
Replaces No. 2930 1255 01 for FD260, -300, -380 (W), FD450 (W) / 50 Hz
2002-04 www.atlascopco.com
Parts list
Contents Indice
Inhoud Innholdsfortegnelse
Innehåll Índice
Inhaltsverzeichnis Indholdsfortegnelse
Table des matières Sisällysluettelo
Indice
60717-10
Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks
2930 1335 00 3
Parts list
61538_10
4 2930 1335 00
Parts list
Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks
1030 1619 2766 00 2 Scraper bolt 4022 0686 6128 00 1 Plug
1040 0129 3115 00 12 Blind rivet 4030 0663 3143 00 2 O-ring
1070 0301 2321 00 4 Washer 4040 0147 1477 03 4 Hex.bolt
1150 1617 2971 00 1 Data plate EC 4050 0301 2378 00 4 Washer
1160 0129 3103 00 4 Blind rivet 4070 1202 7974 03 1 Thermometer
1170 1079 9901 09 1 Decal 4080 0348 0101 13 1 Cable tie
1180 0348 0111 06 1 Connector 4090 1617 1899 00 2 Seal air in/out
2010 1617 2716 00 1 Front panel 4100 1617 0315 00 2 Ring
2020 1617 2717 80 1 Rear panel assy 1603 1006 35 1 Drain connection
· 1 Rear panel 5010 0653 1062 00 · 1 Flat gasket
1088 1001 02 · 1 Warning mark 5020 0661 1020 00 · 1 Seal washer
1079 9915 98 · 1 Label 5030 0581 0000 35 · 2 Straight coupling
1079 9915 89 · 1 Label 5040 0070 6002 05 · AR Plastic tube
2030 1617 2718 00 1 Box 5050 0070 6002 05 · AR Plastic tube
2040 1617 2719 80 1 Side panel assy 5060 0581 0000 38 · 1 Straight coupling
· 1 Side panel 5070 0653 1046 00 · 1 Flat gasket
0690 1125 01 · 1 House mark 5080 0653 1092 00 · 1 Washer
1079 9920 83 · 1 Information label 5090 0581 0000 43 · 1 Bushing
2050 1617 2720 00 1 Roof 5100 1619 7336 00 · 1 Cock
3010 1617 2715 00 1 Frame 5110 1088 0801 21 · 1 Grommet
4010 1 Heat exchanger 1603 1900 54 1 Insulation heat exchanger
1617 2683 00 FD280 14.5 bar(e) 6010 1617 2691 00 · 1 Insulation Rear
1617 2752 00 FD280 20 bar(e) 6020 1617 2692 00 · 1 Insulation Bottom
4020 1 Water separator 6030 1617 2693 00 · 1 Insulation Top
1613 9369 80 FD280 14.5 bar(e) 6040 1617 2694 00 · 1 Insulation Front
1613 9369 81 FD280 20 bar(e) 6050 1617 2695 00 · 2 Insulation Side
0663 6147 00 · 1 O-ring 7200 1079 9921 14 1 Front decal
4021 0686 6132 00 2 Plug
2930 1335 00 5
Parts list
60714_15
6 2930 1335 00
Parts list
Heat exchangers and water separator - FD260, -300, -380 (W), FD450 (W) / 50 Hz 3
Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks
2930 1335 00 7
Parts list
4
4960 4930
4150 4150
4070 4020
4060 4010 6010
6020
6030
6040
2060
1020
1070
60718-17
2030 2070
2132
2133
2134
5020/5030
2081
2082
2083
60719-17
2040
60718_17 / 60719_17
8 2930 1335 00
Parts list
Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks
2930 1335 00 9
Parts list
5 4930
4110
4020
4010
2060
2070
1070
60720-17
2132
2133
2134
1040
5020
5030
1020
2081
2082
2083
60721-17
2030 2040
60720_17 / 60721_17
10 2930 1335 00
Parts list
Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks
1020 1614 7169 00 1 Condenser 2134 1 Ring
1040 1617 2002 03 1 Regulating valve 1617 0315 00 FD260 W, FD300 W/50Hz
1070 1619 5567 02 1 Sight glass 1617 0320 00 FD300 W/60Hz, FD380 W,
2030 1 Liquid receiver FD450 W/50Hz
1617 1751 00 SA 4010 1 Pressure switch
1617 1231 00 Others 1089 9214 08 T-IP54
2 Stop valve 1089 9214 32 Others
1617 0123 00 SA 4020 1617 0354 00 1 Plate (T-IP54)
2040 1617 0708 00 1 Liquid separator 4110 1617 1720 00 2 Capillary connection (T-IP54)
2060 1 Expansion valve R404a 4930 1617 0092 03 1 Ring Others
1619 6768 16 FD260 W, FD300 W/50Hz 5020 1 Refrigerant compressor
1619 6768 17 FD300 W/60Hz, FD380 W, 1619 7767 24 FD260 W 220V/50Hz
FD450 W/50Hz 1619 7767 18 FD260 W 380-415V/50Hz
2070 1617 1495 01 1 Filter drier 1619 7767 20 FD260 W 220-230V/60Hz
2081 1 Sleeve 1619 7767 21 FD260 W 440-460V/60Hz,
1617 0082 00 FD260 W, FD300 W/50Hz FD300 380-415V/50Hz
1617 0474 00 FD300 W/60Hz, FD380 W, 1619 7767 22 FD300 W 220V/50Hz
FD450 W/50Hz 1614 7168 15 FD300 W 220-230V/60Hz
2082 1 Nut 1614 7168 12 FD300 W 440-460V/60Hz,
1617 0058 00 FD260 W, FD300 W/50Hz FD380 W 380-415V/50Hz
1617 0314 00 FD300 W, FD380 W, 1614 7168 17 FD300 W 380V/60Hz
FD450 W/50Hz 1614 7168 11 FD380 W 220V/50Hz
2083 1 Ring 1614 7168 16 FD380 W 220-230V/60Hz
1617 0057 00 FD260 W, FD300 W/50Hz 1614 7168 13 FD380 W 440-460V/60Hz,
1617 0315 00 FD300 W/60Hz, FD380 W, FD450 W 380-415V/50Hz
FD450 W/50Hz 1614 7168 18 FD380 W 380V/60Hz
2132 1 Nut 1614 7168 14 FD450 W 220V/50Hz
1617 0314 00 FD260 W, FD300 W/50Hz 5030 1619 7689 01 1 Crankcase heater
1617 0476 00 FD300 W/60Hz, FD380 W,
FD450 W/50Hz
2133 1 Sleeve
1617 0386 00 FD260 W, FD300 W/50Hz
1617 0477 00 FD300 W/60Hz, FD380 W,
FD450 W/50Hz
2930 1335 00 11
Parts list
61541_17
12 2930 1335 00
Parts list
2930 1335 00 13
Parts list
61541_17
14 2930 1335 00
Parts list
2930 1335 00 15
Parts list
7 Control cubicle - FD260-300-380 (W) IEC 50-60Hz, FD450 (W) IEC 60Hz
60708_12
Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks
16 2930 1335 00
Parts list
60709_12
Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks
2930 1335 00 17