You are on page 1of 3

Environmental Modeling Course

Environmental Engineering Program


Faculty of Engineering
Mariana University
March 11th 2019
Mario Alberto Jurado Eraso
Razak Salifu

Fick’s Experiment Instructions

The students are going to do an experiment in classroom with water and salt. Thus, the professor
gives to group a tank and salt and then the students are going to fill it with water. The tank is divided
by two sides. You need to blended the water and salt in a side of tank and then measurement the salt
concentration with a conductivity meter. Call it C0,L where 0 it's initial salt concentration of L side
(L: right or left). Later, takes out tank division and lets salt flow between both sides of tank. Measure
the salt concentration on both sides of the tank all the time (Remember the theory about Fick's
experiment). Finally, calibrates the diffusion molecular flow (D') using insight Maker and show your
results.

Material

• Tank
• Division
• Salt
• Portable conductivity meter
• Rule
Environmental Modeling Course
Environmental Engineering Program
Faculty of Engineering
Mariana University
March 11th 2019
Mario Alberto Jurado Eraso
Razak Salifu

Bernoulli’s Experiment Instructions

Fill a Bernoulli’s tank with water but preventing water from spilling from the tank into the
surroundings. To do this, close the tube that leaves the tank until the experiment begins. Later on,
Let the contents of the tank flow to another tank located below. Thus, model and simulate the
emptying of the first tank and the filling of the second tank by means of a mass balance in both
tanks. Note that the flow in the first tank will depend on the area of the opening and the height of
water inside the tank. Then, compare the experimental results with the results obtained by the
model.

Material

• Bernoulli’s tank
• Water
• Tape-measure
• Bucket
Rubric of Evaluation

Item Description Score


5 4 3 1
Teamwork Most members of group they play an integral part in the
experiment development.
Showing The work team develops an exhibition in the English
language, which includes an explanation of the experimental
development, materials and methods.
Modeling and Explanation of the mathematical model and the simulation in
Computer Insight Maker
Simulation

You might also like