Professional Documents
Culture Documents
METHODOLOGY
Research Locale
The study will be conducted at Lala National High School. The area is
prone to debris because of the construction happening inside the area and it
produced particles from the material that is used for construction. It is also a
public school and it is expected that few are not fortunate enough when it comes
to financial issues.
Research Design
Materials Needed:
Metal sheets
12v DC motor
Plastic collar
Mesh fabric
Corrugated tube
Empty tube
Pipe
Deodorant bottle
The subject of the study will be the vacuum cleaner that will be used for
testing if it is effective and can remove the dust in a particular area. The
researcher’s would first fill out a survey on which it can determine how useful the
research study is for the people and how many people can relate to the study.
From the results, the researchers would try to focus mainly on the parts which
Research Method
Step 1:
The two liter plastic bottle will be mark around the circumference by using a
marker and make two halves with the help of a cutter and a scissor. Next, the
deodorant bottle will be cut off at the top and bottom to produce a nice flat sheet
of metal.
Step 2:
In order to make a fan, take the nice flat sheet the obtained from the deodorant
bottle. The open circumference of the plastic bottle will be mark with a marker,
fairly sketched and cut. Then cut the marked bit out of the metal sheet and make
a round metal disc. The obtained metal ruler will be drawn with two sheets of
perpendicular lines and divide the disc into eight equal segments of the center.
Cut along, not all the way to the center, left a little room away from the hole. The
produced eight wings connected by a small segment of the disc. The wings are
Step 3:
Now the fan and the motor are assembled. The either side of the crafted fan’s
center is glued with m-seal attached to the rotating rod on the 12v DC motor and
press hard to tighten it. Use m-seal because it provides an extra strength around
the joints. Then a circle is marked out around the base of the plastic bottle to fit
the DC motor. With the help of the soldering rod, drill around the bottle’s base
and make a series of small holes to allow the exhaust air to escape. Wire the
motor and then add a cap to cover the wiring which is glued inside the base of
the bottle and cut out the central circle made the DC motor to fit into the bottle.
Then connect the front assembly into the open section of the base with motor
and fan. Secure the seal with sticky plastic tape to form a nice airtight seal that
Step 4:
The bottle cap from the previous bottle will be taken and make a large hole in the
center big enough to accommodate the bendy plastic tube. The small bottle is
taken to make a similar hole in the base and glue it to the other end of the pipe