Professional Documents
Culture Documents
1. Use a warm iron over a towel to heat the vinyl and soften the adhesive.
Make sure to warm the entire tile, including the edges and middle.
2. Peel out the tile and then scrape out the old adhesive.
Use a notched trowel if you have one, or apply a thin, even coat using your scraper.
In the case of vinyl floor adhesive, less is more. Too much adhesive can cause the tile to ripple.
4. Place the replacement tile carefully into the hole and press on it with a block of wood
5. Remove the glue that squeezes out around the edges with soft white cloth.
Use a solvent like lacquer thinner or whatever the glue label suggests.
6. Lay a sheet of wax paper over the repair and then place a couple of books over the tile.
Leave the weight on it until the glue fully dries (usually 24 hours).
Keep traffic out of the area for a day until the seam sealer has had a chance to set up.
1) Heat the Vinyl Tile Floor
Cover the tile with aluminum foil. Then warm it with an iron on medium heat. This will make
the tile flexible and soften the adhesive.
Peel back more of the tile so you can apply sufficient adhesive. Gently lift the tile and spread a
thin layer of adhesive on the floor. Don't overdo it -- too much adhesive can cause the tile to
ripple.
3) Press the Tile Back Down
Press the tile back into place and using the rolling pin, roll towards the edge to force out any
excess adhesive. Wipe up any stray adhesive using a wet cloth.
4) Secure the Tile in Place
Cover the repair with wax paper and heavy books. The weight of the books will hold the tile
down until the adhesive dries. Leave the books on the tile for at least eight hours or until the glue
dries. After it's dry, take the seam sealer and run a thin bead along the seams. That will keep dirt
out for good.