Professional Documents
Culture Documents
Surface preparation
Using a concrete saw or right angle grinder create V-shaped groove with a minimum
surface width of 6mm and a depth of 6mm.
Clean the surface and remove any dust, unsound or contaminated material, plaster,
oil, paint, grease, corrosion deposits or algae.
The groove is then cleaned by airblasting or waterblasting and dried.
Mixing
Follow the mixing procedure as per product/technical data sheet.
Stir mechanically using a slow speed electric drill.
Application
Apply the mixed material by troweling tightly into the substrate to ensure positive
adhesion.
Any ridges left by the trowel will be brushed out or grinded while the material is still
wet.