Professional Documents
Culture Documents
®
wireless network is operational.
If your existing wireless network has security disabled, follow the instructions
2
in Step 1: Connecting the Range Expander and Step 2: Using the Auto
A Division of Cisco Systems, Inc.
Configuration Button. A Press the Range Expander’s
Auto configuration button and
If your existing wireless network has security enabled, follow the instructions hold it down for five seconds.
in Step 1: Connecting the Range Expander and Step 3: Using the Setup Then release the button.
Wizard.
The LEDs on the Range
Model No.
Model No. WRE54G (EU/UK/LA)
3 Using the Setup Wizard
After you have powered on the NOTE: If your wireless network E The site survey results will display J Review the new settings, and
Range Expander and placed it near fails to detect the Range all available access points and click Yes to save them.
your wireless router or access point, Expander, run the Setup Wiz- wireless routers. Select the one
run the Setup Wizard. ard again using the Ethernet
connection.
you want and click Yes. K Click Online Registration to
A Insert the Setup Wizard CD into F If security is disabled, then
register the Range Expander, or
click Exit to exit the Setup
your PC's CD-ROM drive. The proceed to step G. If security is
Setup Wizard should run enabled, the appropriate Wizard.
automatically, and the Security Settings screen will
Welcome screen should appear. Enter the WEP or WPA- E L Unplug the Range Expander
appear. If it does not, click the PSK settings. Then click Next. from the power outlet and
Start button and choose Run. In remove the Ethernet cable, if
the field that appears, enter WEP - Select the level of WEP necessary. J
D:\setup.exe (if “D” is the letter encryption, WEP (64-Bits) or WEP
of your CD-ROM drive). (128-Bits). Then enter the M Locate an optimum location
passphrase or the WEP key. for the Range Expander. The
B Click the Setup button. best placement is usually at
B WPA-PSK - Enter the passphrase the edge of your wireless
C Make sure your access point or or pre-shared key.
network.
wireless router is working
properly. Then click Next. If the G Now that the Setup Wizard has F
Range Expander is connected found an access point or N Fix the direction of the
through the Ethernet port, wireless router with which to antenna. Normally, the higher
continue to Step E. communicate, it will now search you place the Range
for the Range Expander. Select Expander’s antenna, the better
D When using a wireless the one you want and click Yes. the performance will be.
connection, the Setup Wizard Proper positioning of the
will run a search for your wireless H Enter the Range Expander’s antenna can enhance its
network’s settings. If found, you default password, admin, and receiving sensitivity.
will be asked to confirm the click Enter. (Some wireless
O
For additional information or troubleshooting help, refer to
settings. If the settings are networks may require additional Connect the power plate to a
G
the User Guide on the Setup CD-ROM. You can also email
correct, click Yes and proceed security settings, such as that power outlet, preferably a
for further support.
to step G. If you’d like to choose D1 shown in Step F, at this time.) surge protector.
a different wireless network, Website
Model No.