Professional Documents
Culture Documents
Sikorsky
A United Technologies Company
http://www.sikorsky.com
September 22, 2010
GENERAL INFORMATION
There are three types of S-76 service publications: the Alert Service Bulletin (ASB), the Customer Service Notice
(CSN), and the Special Service Instructions (SSI). The definition and content of each are provided as follows:
ALERT SERVICE BULLETIN (ASB). Commencing March 1982, the only type of Service Bulletin issued is the Alert Service
Bulletin (ASB). Previously issued Customer Service Bulletins (CSBs) in effect are still valid. Alert Service Bulle-
tins (ASBs) shall be issued on matters requiring the immediate attention of the operator and shall be limited gen-
erally to items affecting safety. Compliance with Alert Service Bulletins is considered essential. ASBs provide in-
structions for modifications, inspections, or other actions and establish required compliance times. One time
maintenance and inspection requirements will be carried in the text of the ASB. Revisions to repetitive mainte-
nance and inspection requirements, when safety related, will be issued concurrently with the ASB as temporary re-
visions to the Airworthiness Limitations and Inspection Requirements.
Matters of extreme urgency will be transmitted by facsimile (FAX). A FAX ASB will be followed with the issuance of
a printed 9hard copy9 to confirm the FAX message. The first page of Alert Service Bulletins hard copy will be
printed on red bordered paper to bring it to the immediate attention of the operator. Copies of Alert Service Bul-
letins should be routed to Chief of Operations, Chief of Maintenance, and Chief Pilot.
The primary numbering system used for Alert Service Bulletins and previously issued Customer Service Bulletins in-
corporates the ATA 100 designator and a chronological sequence number.
(Model - System - Consecutive No.) Sequence No. 11 (Chronologically, the eleventh CSB issued)
SEQUENCE NUMBERS. ASBs, previously issued CSBs and CSNs, have been assigned sequential numbers based on their
chronological release. Until ASBs and CSNs are issued with sequence numbers, it is suggested that operators write
these numbers on previously issued ASBs, CSBs, or CSN’s (these publications will not be reissued to add the se-
quence numbers) The sequence numbers are provided in this index.
EFFECTIVITY. Alert Service Bulletins, previously issued Customer Service Bulletins, and Customer Service Notices
normally specify the Sikorsky Serial No. of the helicopter, or part number of the unit, to which the directive is
applicable.
CUSTOMER SERVICE NOTICE (CSN). Customer Service Notices (CSNs) will be prepared and issued to furnish the operator
with information regarding product improvement modifications and parts changes.
i
SPECIAL SERVICE INSTRUCTIONS (SSI). Special Service Instructions (SSIs) are instructions data for installation of
Optional Modification Kits or parts such as an external cargo hook. Distribution of the SSI will be limited to
those individual operators that have purchased the optional equipment.
ii
S-76A
SPECIAL SERVICE INSTRUCTIONS
PAGE 1
S-76A
SPECIAL SERVICE INSTRUCTIONS
76-10A HYDRAULIC POWER - Tail Rotor Servo Sole- All S-76A and 02/06/87
noid Shutoff Valve - Incorporation of S-76B SS Nos
(Superseded by ASB No. 76-29-6) 76003 thru
76007, 760001
thru 760352
PAGE 2
S-76A
SPECIAL SERVICE INSTRUCTIONS
PAGE 3
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-3 4 ROTORS - Tail Rotor All S-76 helicop- None 06/13/79 65-21-01
Blades - Proper Installa- ters delivered as
tion Procedures for Tail of issue date of
Rotor Boots this CSN
76-5 6 HYDRAULIC LINES - Proper All S-76 helicop- None 06/19/79 29-10-04
Clearance ters delivered as
of issue date of
this CSN
PAGE 1
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-7 3 FUSELAGE - Sealing of En- All S-76 helicop- None 05/18/79 53-20-03
gine Compartment Decks ters delivered as
from Fluid Leaks of issue date of
this CSN
76-9 11 ROTORS - Swashplate As- All S-76 helicop- None 09/14/79 65-14-00
sembly — Replacement of ters delivered as
Bearing Shield with Main of issue date of
Rotor Head Installed this CSN
76-10 59 OIL - Engine Oil Cooler S-76 SS Nos 76005 None 10/01/81 79-10-02
Blower Drain Hole - In- thru 76007, 760001
corporation of thru 760282
PAGE 2
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-14 12 FUSELAGE - Main Gear Box All S-76 helicop- None 10/12/79 05–20–00
Fairing Support Structure ters delivered as
- Inspection Requirements of issue date of
(Refer to CSB No. 76- this CSN
53-7)
76–16B 13B HYDRAULIC SYSTEMS - Rec- All S-76 helicop- None 11/04/80 29-10-00
ommended Maintenance Pro- ters delivered as
cedures (Supersedes Revi- of issue date of
sion A) this CSN
PAGE 3
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-18 17 ROTORS - Main Rotor Blade All S-76 helicop- None 12/20/79 General
Limits — Rotor Stopped ters delivered as
of issue date of
this CSN
76-19 16 FUSELAGE - Engine Air In- All S-76 helicop- None 12/18/79 53-20-03
let Cowl Latches - Ad- ters delivered as
equate Clearance Inspec- of issue date of
tion this CSN
76-20 90 ELECTRICAL PANELS AND All S-76 helicop- None 05/19/82 20-31-00
COMPONENTS — Instrument ters with weather
Panel Harnesses — Instal- radar system deliv-
lation Inspection ered prior to date
of this CSN
76-22 44 POWERTRAIN - Main Gear S-76 Main gear box None 01/27/81 66-11-07
Box Oil Cooler Blower - oil cooler blower
Rework of (99D30-2, and -3)
PAGE 4
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-24A 20A POWERTRAIN - Main Gear S-76 Main gear None 05/08/80 66-10-00
Box — Corrosion Protec- boxes prior to and
tion of Main Rotor Shaft including S/N A081-
(Supersedes basic CSN) 00074
76-25 21 LANDING GEAR - Nose & S-76 Main landing None 03/20/80 32-30-05
Main Electrical Wiring gear electrical 32-30-06
Harness - Removal of wiring harness sen-
Clear Heat-Shrink Tubing; sor switches date-
Main Electrical Wiring - etched before 2:80
Moisture Protection of on elbow connector
Sensor Switches
PAGE 5
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-27 22 FUSELAGE - Engine Air In- All S-76 helicop- None 04/14/80 53-20-03
let Screen Assemblies - ters delivered as
Inspection and Replace- of issue date of
ment or Repair of this CSN
76-28 26 LANDING GEAR - Main - All S-76 helicop- None 07/22/80 32-10-02
Elimination of Interfer- ters delivered as
ence Between Strut and of issue date of
Airframe Upper Attachment this CSN
Fitting
76-30A 30A ELECTRICAL POWER - AC S-76 SS Nos. 76003, None 04/30/81 24–22–01
Generator Cooling Duct, 76005 thru 76007,
Addition of Drain Hole; SS Nos. 760001 thru
AC Generator Mounting 760090
Pad, Removal of Drain
Plug (Supersedes basic
CSN)
PAGE 6
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-32 80 LANDING GEAR - Main and S-76 SS Nos 76003, None 03/22/82 32-31-05
Nose Landing Gear Actua- 76005 thru 76007,
tors - Improved Shuttle SS Nos 760001 thru
Valve - Retrofit Program 760143
76-33 31 LIGHTS - Executive Inte- S-76 SS Nos 760009, None 09/25/80 33-20-00
rior — Replacement of 760016, 760019,
Wiring and Light Bulb 760028, 760032,
Connectors 760040, 760053 and
760063
76-35A 24A LANDING GEAR - Emergency S-76 SS Nos 76005 None 06/25/81 32-70-01
Flotation System - Main thru 76007, 760001 32-70-05
Landing Gear Door Link thru 760200
and Flotation Bottles - equipped with emer-
Inspection of Cartridge gency flotation sys-
Receptacles and Harness tem
Plugs (Supersedes basic
CSN)
PAGE 7
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-37 27 ELECTRICAL POWER - In- S-76 SS Nos 76003, None 08/01/80 39-30-02
spection of DC Junction 76005 thru 76007,
Box Assembly SS Nos 760001 thru
760061, 760063 thru
760071
76-38 51 FLIGHT CONTROLS - Longi- S-76 SS Nos 76005 None 03/19/81 67-00-00
tudinal and Lateral Sys- thru 76007, 760001
tems - Inspection for thru 760073
Minimal Clearance
76-40B 68B STARTING - No. 1 and No. S-76 SS Nos prior 76070-55024-011 02/16/84 80-10-00
2 Relay Panels, Overhead to 760206 with snow
Control Panel - Continu- protection system
ous Ignition - Installa- installed
tion of Relays (Super-
sedes Revision A)
(Compliance with this CSN
and CSN No. 84 cancels
CSN No. 76–52 and any re-
visions thereto)
PAGE 8
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-42 34 FLIGHT CONTROLS - Tail S-76 SS Nos 76005 None 10/23/80 67-21-00
Rotor Servo Actuator - and 76006, SS Nos
Inspection of Ground Link 760001 thru 760054,
and Input Lever Assem- 760056 thru 760071,
blies 760073, 760075,
760076, 760078 thru
760080, 760082 and
760084
76-43A 40A ELECTRICAL PANELS AND S-76 SS Nos 76003, None 02/02/81 39-10-01
COMPONENTS —Replacement 76005 thru 76007,
of Copilot’s VNE Placard 760001 thru 760107
(Supersedes basic CSN)
76-44 36 FLIGHT CONTROLS - Support S-76 SS Nos 76003, None 10/30/80 67-14-00
Assembly — Modification of 76005 thru 76007,
Shim 760001 thru 760099
PAGE 9
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-47 42 FLIGHT CONTROLS - Main S-76 Main rotor None 12/18/80 67-15-00
Rotor Servo Actuators - servo actuators se-
Inspection of Right Hand rial numbers 0176
Manifold thru 0443 (less ac-
tuators with mani-
fold serial numbers
listed in HRTextron
SB FMTC No. 256)
76-48B 37B ENGINE INDICATING - T5 S-76 SS Nos 76003, None 04/23/81 77-20-01
Indicating System - Im- 76005 thru 76007,
provement of Connector 760001 thru 760166;
Pin Isolation (Revises Note: Not appli-
Revision A) cable to helicop-
ters equipped with
environmental con-
trol unit (ECU)
PAGE 10
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-49 38 ROTORS - Main Rotor Blade All S-76 helicop- None 12/05/80 65-11-00
- Replacement of Root End ters delivered as
Seal Plate of issue date of
this CSN
76-50 73 ROTORS - Pitch Control S-76 SS Nos 76003, None 02/01/82 65-12-06
Rod Installation - Re- 76005 thru 76007,
placement of Aluminum SS Nos 760001 thru
Washers with Steel Wash- 760239
ers
76-51C 64C POWERTRAIN - Rotor Brake All helicopters de- None 10/06/82 66-50-02
- Modification and Reacti- livered as of issue
vation (Revises Revision date of this CSN
B)
76-52A 39A ICE AND RAIN PROTECTION — All S-76 helicop- None 07/12/82 General
Operation in Falling and ters equipped with
Blowing Snow (Supersedes snow protection
basic CSN) kits and delivered
as of issue date of
this CSN
76-53 41 ELECTRICAL POWER - No. 1 S-76 SS Nos 76003, None 12/12/80 24-31-02
and No. 2 DC Generator 76005 thru 76007,
Control Panel Assemblies 760001 thru 760054
- Replacement of
PAGE 11
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-55 45 FUSELAGE - Fuel Filler All S-76 helicop- None 01/27/81 28-10-03
Cap Receptacle Ring - Re- ters delivered as
moval of Paint of issue date of
this CSN
76-56 74 HYDRAULIC POWER - Lines All S-76 helicop- None 02/05/82 29-10-04
Installation - Improved ters delivered as 29-20-04
Clamping of issue date of
this CSN
76-57 84 FUSELAGE - Cockpit Door All S-76 helicop- None 04/22/82 53-40-01
Striker Fittings - Provi- ters with
sions for Inspection — 76209–10002–047
Incorporation of cockpit door
striker fitting as-
sembly installed
delivered as of is-
sue date of this
CSN
PAGE 12
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-58 57 LANDING GEAR - Emergency All S-76 helicop- None 08/27/81 32-70-03
Float Support Cables - ters delivered as
Installation of Protec- of issue date of
tive Sleeves this CSN
76-59A 72A ROTORS - Main Rotor Head S-76 SS Nos 76003, 76070-10013-011 12/16/82 65-12-09
- Damper Attachment Bolts 76005 thru 76007,
and Nuts — Replacement of SS Nos 760001 thru
(Supersedes basic CSN) 760231
76-61 53 ELECTRICAL POWER - Gen- All S-76 helicop- None 04/07/81 24-22-02
erator Control Unit - ters delivered as
Sealing of Printed Cir- of issue date of
cuit Boards this CSN
76-62 48 ROTORS - Main Rotor Blade All S-76 helicop- None 02/10/81 General
— Precautions During ters delivered as
Single Engine Landings of issue date of
this CSN
PAGE 13
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-66A 54A ELECTRICAL POWER - AC All S-76 helicop- None 11/13/81 24-22-01
Generator Harness - In- ters delivered as
spection for Proper In- of issue date of
stallation (Supersedes this CSN
basic CSN)
76-69A 56A OIL - Engine Oil Cooler - S-76 SS Nos 76003, 28E14-1 (Jani- 03/15/82 79-10-01
Addition of Thermostat 76005 thru 76007, trol Aero Divi-
Poppet End (Supersedes 760001 thru 760212 sion)
basic CSN)
PAGE 14
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-71 88 FUSELAGE - Transmission S-76 (Refer to CSN) Refer to CSN 05/11/82 51-01-00
and Engine Compartment
Structure and Electronics
Compartment Access Doors
- Sealing for Water In-
tegrity
PAGE 15
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-72A 81A POWERTRAIN - Main Gear S-76 SS Nos 76003, None 01/12/83 66-10-00
Box - Upper and Lower 76005 thru 76007,
Housings - AC Generator 760001 thru 760090
Mounting Flange - Inspec- (Refer to CSN for
tion for Corrosion; In- components)
corporation of Oil Cooler
Blower Pad Drain Hole;
Improved AC Generator
Mounting Procedure (Re-
vises basic CSN)
76-73 109 NAVIGATION - Horizontal SS Nos 76003, 76005 76070-55020-011 12/09/82 34–00–00
Situation Indicators - thru 76007, 760001
Incorporation of Separate thru 760114
Circuit Breakers
76-76 61 UTILITY HOIST - Replace- All utility hoist WB-5656 (Wadell) 10/28/81 25-53-01
ment of Cable Cutter cable cutter squibs
Squib Assembly delivered prior to
10/09/81
PAGE 16
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-77A 63A DOORS - Crew and Passen- S-76 SS Nos 76003, Refer to CSN 12/05/83 52-10-01
ger Doors — Modification 76005 thru 76007,
of Lock Mechanism (Super- 760001 thru 760145
sedes basic CSN)
76-78 65 DOORS - Right Sliding S-76 SS Nos 76004 76070-20015-011 11/19/81 52-10-03
Door — Incorporation of thru 760009, (SS Nos 760036
Door Open Supports and 760011, 760016 thru and subsequent)
Provisions for Improved 760018, 760020 thru 76070-20015–012
Operation 760026, 760033, (prior to and
760036 thru 760040, including SS No.
760042 thru 760044, 760033)
760046, 760049,
760051, 760052,
760056, 760057,
760059, 760064
76-79B 69B POWERTRAIN - Rotor Brake S-76 SS Nos 76003, 76070-30015-011 02/07/84 66-50-02
Access Door - Incorpora- 76005 thru 76007,
tion of (Revises Revision 760001 thru 760307
A)
76-80 83 HYDRAULIC POWER - First S-76 SS Nos 76003, 76070-65005-011 04/21/82 29-10-01
and Second Stage Hydrau- 76005 thru 76007,
lic Pumps — Replacement 760001 thru 760255
of
PAGE 17
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-81 86 NAVIGATION - Tailcone Pi- S-76 SS Nos 76003, 76070-45002-011 05/05/82 34-11-02
tot System — External 76005 thru 76007,
Drain Provisions — Incor- 760001 thru 760198
poration of
76-82A 67A OIL - Engine Oil Cooler S-76 SS Nos 76003, 76070-30016-011 08/02/83 79-10-01
and Reservoir Vent Lines 76005 thru 76007, and -012
- Replacement of (Super- 760001 thru 760210
sedes basic CSN)
76-83A 71A AUTO FLIGHT - Pitch Bias S-76 SS Nos prior 76070-55027-011 05/19/82 39-40-07
Actuator (PBA) Wiring - to and including (SS Nos prior to
Modification of (Super- 760231 760211) 76070-
sedes basic CSN) 55027-012 (SS
Nos 760211 thru
760231)
76-84A 99A ICE AND RAIN PROTECTION - S-76 SS Nos prior None 07/14/83 30-20-00
Engine Inlet Snow Protec- to 760206 with snow
tion System — Incorpora- protection system
tion of Shields (Super- installed
sedes basic CSN)
76-85A 82A LEVELING AND WEIGHING - S-76 (Refer to CSN) None 01/12/83 8-00-00
Level Plate — Inspection
for Proper Location (Su-
persedes basic CSN)
PAGE 18
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-86 101 POWERTRAIN - Main Gear S-76 SS Nos 76003, 76070-35005-013 09/08/82 66-11-07
Box Oil Cooler Blower Im- 76005 thru 76007,
peller — Replacement of 760001 thru 760227
76-87A 77A ENGINES - CAA In-Flight All S-76 helicop- None 08/18/82 General
Power Assurance (Super- ters (CAA certified)
sedes basic CSN)
76-88A 78A ENGINES - FAA In-Flight All S-76 helicop- None 08/18/82 General
Power Assurance (Super- ters (FAA certified)
sedes basic CSN)
76-90 94 FUEL - Fuel Tank Sump S-76 SS Nos 76003, None 06/08/82 28-10-04
Drain Valve Installation 76005, 76007, SS
- Improved Sealing of Nos 760001 thru
760200
PAGE 19
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-91 70 ELECTRICAL POWER — Wire All S-76 helicop- None 01/14/82 5-00-00
Harnesses - Inspection ters delivered
for Chafing prior to issue date
of this CSN
76-92 76 ROTORS - Main Rotor Head S-76 SS Nos 76003, None 02/24/82 65-12-08
- Anti-Flap Cam Assembly 76005 thru 76007,
- Replacement of 760001 thru 760245
76-93A 113A LANDING GEAR - Landing S-76 SS Nos 76003, 76070-55018-011 07/11/83 32-30-02
Gear Control Panel - 76005 thru 76007,
Modification of (Super- 760001 thru 760259
sedes CSN)
76-95A 91A LIGHTS - Instrument Panel S-76 SS Nos 76003, None 06/01/84 33-10-02
- Dimmer Control Unit - 76005 thru 76007,
Modification of (Super- 760001 thru 760261
sedes basic CSN)
76-96A 85A WINDOWS - Pilot’s Door - S-76 SS Nos 76003, 76070-20054-011 12/05/83 56-30-01
Openable Window - Doubler 76005 thru 76007,
and Washer Installation 760001 thru 760246
(Supersedes basic CSN)
PAGE 20
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-99 152 HYDRAULIC POWER - Tail S-76A SS Nos 76003 None 10/06/86 29-10-04
Rotor Servo Hydraulic thru 76007, 760001
Line Restrictor — Removal thru 760244
of
76-100 107 ROTORS - Main Rotor All S-76 helicop- None 11/10/82 65-11-00
Blades — Sealing of Root ters (with 76150-
End 09000-045 thru -050
and 76150-09100-041
thru -050 main ro-
tor blade assem-
blies prior to and
including Serial
No. A086-01053)
76-101 139 LIGHTS - Emergency Exit S-76 SS Nos. 76003, 76070-55042-011 06/05/84 33-50-00
Lighting — Modification of 76005 thru 76007,
Circuitry 760001 thru 760253
PAGE 21
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-102A 116A AUTO FLIGHT - Pitch Bias S-76 SS Nos 76003, 76070-55029-011 12/13/99 22-20-04
Actuator Servo Assembly - 76005 thru 76007,
Replacement of 760001 thru 760260
76-103 124 LANDING GEAR - Nose and S-76 SS Nos 76003, 76070-55041-011 07/06/83 32-30-05
Main Landing Gear - Prox- 76005 thru 76007,
imity Sensor Cable Assem- 760001 thru 760255
blies - Replacement of
76-104B 106B HYDRAULIC POWER - First & S-76 SS Nos 76003 76070-65006-011 08/12/87 29-10-04
Second Stage Hydraulic thru 76007, 760001 29-20-04
Lines - Replacement of thru 760241
(Supersedes Revision A)
76-105A 92A ROTORS - Main Rotor Head S-76 SS Nos 76003, 76070-10014- 11/17/83 65-12-06
and Rotor Pitch Control 76005 thru 76007, 011/-014
Rod Bearings — Replace- 760001 thru 760240
ment of (Supersedes basic
CSN)
76-106A 93A POWERPLANT - Engine Chip S-76 SS Nos 76003, 76070-20022-011 02/07/84 77-40-00
Detector Retention Plate 76005 thru 76007,
- Installation of (Re- 760001 thru 760307
vises basic CSN)
PAGE 22
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-109A 95A FUSELAGE - Aft Engine S-76 SS Nos 76003, 76070-30018-011 11/05/82 53-20-03
Cowl - Latch Modification 76005 thru 76007,
- Spring Assist Opening 760001 thru 760282
Installation (Revises ba-
sic CSN) Replacement of
76-110A 119A OIL - Engine Supplemen- S-76 SS Nos prior 76070-30019-011, 06/01/84 79-00-00
tary Oil Filtration - In- to 760327 without -014, -015
stallation of (Supersedes EAPS or EAPS provi-
basic CSN) sions (Mod. Kit
76070–30019–011)
76-111C 100C FUSELAGE - Engine Com- S-76A SS Nos 76003, 76070-20057-011 03/06/91 53-00-00
partment Center Firewall 76005 thru 76007,
- Modification of (Revises 760001 thru 760382
Revision B)
PAGE 23
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-112 105 FLIGHT CONTROLS - Tail All S-76 helicop- None 10/28/82 67-21-00
Rotor Servo Actuator - ters (with 76650-
Input Crank Assembly Ad- 05801 (30006840)
justers - Addition of series tail rotor
Lockwire servo actuator
prior to Serial No.
0441)
76-113 121 POWERTRAIN - Rotor Brake S-76 SS Nos 76003, 76070-55033-012 06/01/83 66-50-00
System — Circuit Breaker 76005 thru 76007,
and Diodes — Installation 760001 thru 760249
of
76-114A 102A AIR CONDITIONING - Envi- S-76A, S-76B 76070-20055-011 02/05/87 21-50-00
ronmental Control System
(ECS) - Modification of
(Revises basic CSN)
76-115 130 DOORS - Main Landing Gear S-76 SS Nos prior None 11/02/83 52-80-01
- Door to-Link Fitting to 760247
Assembly Attaching Hard-
ware - Replacement of
76-116 98 OIL - Oil Cooler S-76 SS Nos 76003, 76070-30013-011 07/07/82 79-10-03
Ducting/Forward Trans- 76005 thru 76007,
verse Wall - H Seal Re- 760001 thru 760299
tainers — Incorporation
of
PAGE 24
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-117 129 ROTORS - Tail Rotor S-76A, Component: None 10/31/83 65-21-01
Blades - Balance Brackets 76101-05101–041 and
- Installation of 76101-05001-044 and
-045 tail rotor as-
semblies prior to
SN A173-00501
76-118A 127A ROTORS - Tail Rotor Blade S-76A, Component: 76070-10012-011 11/10/83 65-21-00
- Reinforcement of Trail- 76101-05001–044,
ing Edge (Revises basic -045 and 76101-
CSN) 05101-041 tail ro-
tor blade assem-
blies prior to SN
A137-00560
76-119 128 ELECTRICAL PANELS AND S-76 SS Nos 76003, 76070-55039-011 10/10/83 39-40-06
COMPONENTS — No. 1 Relay 76005 thru 76007,
Panel- Addition of Stiff- 760001 thru 760011,
ener 760016 thru 760083
76-120A 96A FLIGHT CONTROLS - Tail All S-76 helicop- None 10/29/82 67-20-00
Rotor Control System — ters
Reassembly of Tail Rotor
Control Cable System (Su-
persedes basic CSN Msg
CST-SPT-82–288)
PAGE 25
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-121 125 POWERTRAIN - Main Gear S-76 SS Nos 76003, 76070-55038-011 07/14/83 66-10-00
Box Harness — Relocation 76005 thru 76007,
of Disconnect Points 760001 thru 760076
76-122 104 ROTORS - Main Rotor Hub Part I - S-76 SS 76070-10005-015 10/07/82 65–12–01
Subassembly and Rotating Nos 76003, 76005 (Part I);
Scissors Assembly — Modi- and 76006, 760001 76070–10005–016
fication of thru 760106, 760108 (Part II)
thru 760142, 760146
thru 760150, 760152
thru 760161, 760163
thru 760177, 760179
thru 760209, 760211
thru 760226; Part
II - S-76 SS Nos
76007, 760107,
760143 thru 760145,
760151, 760162,
760178 and 760210
76-123 111 FUSELAGE - Baggage Com- S-76 SS Nos 76005 76070-20056-011 12/16/82 53-10-00
partment Shroud Assem- thru 76007, 760001
blies - Modification of thru 760255
76-124 112 FLIGHT CONTROLS - Tail S-76 SS Nos 76003, None 01/11/83 67-20-00
Rotor Control System - 76005 thru 76007,
Station 215 Pulley In- 760001 thru 760238
stallation - Modification
of
PAGE 26
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-126 147 ICE AND RAIN PROTECTION - S-76A with engine 76070-30025-011 03/08/85 30-20-00
Snow Protection Shield inlet snow protec-
Support Clips & Bracket - tion kit, option
Replacement of 76K0063
76-127 135 AIR CONDITIONING - Cock- S-76 SS Nos prior 76070-20053-011 01/20/84 21-10-00
pit and Cabin Ventilation to 760230 with
- Improvement of utility hard panel
trim interior, Op-
tion 76K0099A; SS
Nos prior to 760197
with utility hard
panel trim inte-
rior, Option
76K0099C
PAGE 27
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-128A 136A AUTO FLIGHT - Pitch Bias All S-76A helicop- 76070-55040-013 12/10/01 22-20-00
Actuator System - Op- ters without AFCS
tional Removal of Phase III option
installed, includ-
ing those powered
by Rolls-Royce Al-
lison 250-C30 and
Turbomeca Arriel 1S
and 1S1 engines.
76-129 137 NAVIGATION — Pilot and S-76 SS Nos prior 76070-60008-011 04/24/84 34-22-00
Copilot Vertical Gyro - to 760250 with op-
Fast Erect Switch - In- tion 76K0051 (Dual
stallation of Remote Reference
System) installed
76-130 122 ICE AND RAIN PROTECTION - S-76 SS Nos 76003, None 06/20/83 30-43-00
Windshield Wiper System 76005 thru 76007,
Improvements 760001 thru 760211
76-131 134 ROTORS - Tail Rotor Out- S-76 SS Nos 76003, None 01/12/84 65-21-00
board Retaining Plate - 76005 thru 76007,
Replacement of Liner and 760001 thru 760282
Snap Ring
76-132 114 HYDRAULIC POWER - Hydrau- S-76 SS Nos 76003, 76070-65008-011 03/11/83 29-10-04
lic Lines First Stage Hy- 76005 thru 76007,
draulic Pump Pressure 760001 thru 760255
Line - Replacement of
PAGE 28
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-133A 123A FLIGHT CONTROLS - Tail S-76 SS Nos 76003, 76070-40006-013 11/10/83 67-20-00
Rotor Controls Centering 76005 thru 76007,
Quadrant - Incorporation 760001 thru 760305
of (Supersedes basic No-
tice and Amend. No. 1)
76-134A 117A LANDING GEAR - Main Land- S-76 SS Nos prior 76070-25004-011 01/10/84 32-10-05
ing Gear Structural Im- to 760308
provements — Incorpora-
tion of (Revises basic
CSN)
76-135B 120B FUSELAGE - Access Panels All S-76A and S-76B 76070-20066-011 09/19/86 53-30-02
- Vertical Stabilizer - Models SS Nos 76003 or -012
Modification of (Revises thru 76007, 760001
Revision A) thru 760314
76-136B 161B FUSELAGE - Access Covers S-76A series prior 80F04-8-1AA 11/11/96 53-10-05
— Electronics Compartment to and including SS 80F04-8-2AA
Access Panels - Fasteners No. 760309; S-76B
- Replacement of (Super- series prior to and
sedes Revision A) including SS No.
760352
PAGE 29
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-138B 131B LANDING GEAR - Nose Land- S-76 SS Nos 76003, 76070-65010-011 03/11/85 32-30-07
ing Gear Shutoff Valve - 76005 thru 76007, (Part 1 for
Installation of (Revises 760001 thru 760332 shutoff valve in
Revision A) tail cone);
76070–65011–011
(Part 2 for he-
licopters with
electronics op-
tions in tail
cone)
76-140 169 FUSELAGE - Forward Fair- S-76A series prior None 07/25/91 53-20-02
ing Assembly Access Door to and including SS
- Modification of No. 760298; S-76B
series prior to and
including SS No.
760352
PAGE 30
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-141C 133C STABILIZERS - Vertical Refer to CSN for Refer to CSN 08/26/99 55-30-00
Stabilizer — Forward and effectivity and Mod.
Aft Spars - Reinforcement Kit applicability
of (Revises Revision A)
76-142C 126C FLIGHT CONTROLS - Station All S-76 Models. Refer to CSN 09/14/93 67-00-00
215 Pulley Bracket - Refer to CSN for
Cable Inspection Slot and effectivity
Holes - Incorporation of;
Stabilizer Fitting and
Access Door Flange —
Modification of (Revises
Revision B)
76-143B 132B LANDING GEAR - Nose Land- S-76A prior to SS None 02/13/87 32-30-04
ing Gear Actuator - Down- No. 760284. Compo-
lock Keys — Replacement nent: 1944E200A and
of (Revises Revision A) 1944F200 series
nose gear actuators
76-144 155 POWERTRAIN - Goodyear Ro- All S-76A helicop- 76070-35006-011 04/10/87 66-50-02
tor Brake and Hydraulic ters with Goodyear
Power Unit - Removal of; rotor brakes
Goodrich Rotor Brake &
Hydraulic Power Unit -
Installation of
PAGE 31
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-146B 150B ROTORS - Main and Tail S-76 series prior 76070-10016-012 09/06/89 65-00-00
Rotor Heads — Bonding to and including SS and -013
Jumpers - Addition of No. 760341
(Supersedes Revision A)
76-147 142 DOORS - Left and Right All S-76A helicop- 76070-20044-011 07/11/84 52-10-04
Sliding Doors — Latching ters with right
and Locking Mechanisms — and/or left sliding
Modification of; Access door delivered
Hole — Incorporation of prior to 9/30/84
76-148B 154B FUEL - Stainless Steel *S-76A and S-76B Refer to CSN 05/06/88 28-20-02
Fuel Supply Lines (Inte- Models — See CSN
gral Fuel Tanks) — Incor- for Mod. Kit effec-
poration of (Supersedes tivity
Revision A)
76-149 141 ELECTRICAL POWER - Auxil- All S-76A delivered 76070-55046-011 07/02/84 24-00-00
iary DC Power to Essen- prior to issue date
tial Bus — Incorporation of this CSN
of (Supplemental Instruc-
tions are included)
PAGE 32
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-150 143 FUSELAGE - Upper Fuselage S-76 SS Nos 76003, 76070–20511–013, 09/13/84 53-00-00
Longeron Station 188 - 76005 thru 76007, Part 1;
225 Left Side — Rein- 760001 thru 760088 76070–20511–012,
forcement of (Incorpora- — Part 1; SS Nos Part 2
tion of this CSN cancels 760089 thru 760328
requirement of ASB No. — Part 2
76–53–18)
76-151 140 FUSELAGE - Doubler In- S-76 (without Mod 76070-20072-011 06/28/84 53-00-00
stallation — Station 215, Kit 76070-20511-012
Left Side or -013 or CSN No.
76-150 incorpo-
rated)
76-152C 146C FLIGHT CONTROLS - Collec- All S-76A, S-76B SS 76070-40010-012 05/22/89 67-00-00
tive to Cyclic Coupling Nos. prior to and
Limiter - Installation of including SS No.
(Revises Revision B) 760324
76-153A 160A STABILIZERS - Vertical S-76A series prior 76070-20094-012 09/15/97 55-00-00
Stabilizers — Aft Spar - to and including SS
Reinforcement of (Super- No. 760298
sedes CSN No. 76-153)
PAGE 33
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-154 162 ICE AND RAIN PROTECTION - S-76A and S-76B se- Refer to CSN 09/26/88 30-42-00
Precipitation 9P9 Static ries prior to and
Discharge Protection — including SS No.
Windshield Heat System - 760343 with heated
Harness Assembly - Incor- glass windshields
poration of (76206-01001 se-
ries) Option
76K0003
76-155A 149A LANDING GEAR - Emergency All S-76A and S-76B 76070-25005-011 03/18/87 32-70-00
Flotation Gear - Addi- *with flotation kit
tional Protection for option 76K0027 or
(Revises basic CSN) 76K0027P installed
76-156 144 POWERTRAIN - Rotor Brake S-76 SS Nos 76003, None 01/04/85 66-50-00
- Hydraulic Lines - Re- 76005 thru 76007,
placement of SS Nos 760001 thru
760239
76-157A 158A FUSELAGE - Water Integ- All S-76A delivered 76070-20076-011 05/31/90 53-00-00
rity - Drain Grommets & prior to issue date
Valves - Installation of; of this CSN
Additional Drainage Vents
and Holes - Incorporation
of (Revises basic CSN)
PAGE 34
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-158 145 FUSELAGE - Fuselage - S-76A (Refer to Refer to CSN 02/05/85 53-00-00
Mounted Engine Contain- CSN)
ment Plate Installation -
Removal of; Installation
of Doublers on Engine
Deck and Center Firewalls
(Addendum dated 02/05/85
Attached)
PAGE 35
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-160 163 LANDING GEAR - Emergency S-76A Series 76070-25007-011 02/22/89 32-70-03
Flotation - Main Landing equipped with op-
Gear Float Cover - Scuff tion 76K0027 (Emer-
Pad - Installation of gency Flotation)
and 14 ply tires
(145K41–1); S-76B
SS Nos 760262,
760269, 760299,
760303, 760310 thru
760317; Note: This
modification is not
required on S-76A
helicopters
equipped with stan-
dard 12 ply tires
(145K21–1)
76-162B 159B POWERTRAIN - Main Gear S-76A series with 76070-35008-011 07/15/88 66-00-00
Box - Shaft and Spur Pin- main gear box as-
ion - Bearing Retainer sembly Part No.
Nut - Replacement of (Su- 76351–09500–041;
persedes Revision A) S-76B series with
main gear box as-
sembly part No.
76351–09600–041
PAGE 36
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-165A 164A ROTORS - 5P Upper Bifilar S-76A equipped with 76070-10019-011 03/12/90 65-13-00
Assembly — Optional Re- Turbomeca Arriel
moval of (Supersedes ba- Engines; S-76B
sic CSN)
76-166A 166A FUSELAGE/LANDING GEAR - S-76 (Refer to CSN 76070-20100-011, 11/22/02 53-00-00
Upper Fuselage Longerons for Mod Kit appli- -016, -017
and Landing Gear Modifi- cations and effec-
cation Requirements to tivity)
Increase Takeoff Gross
Weight to 10,800 Lb with
Arriel 1S Engines
76-167B 168B ROTORS - Main Rotor Blade All S-76 Model main 76070-15003-011 05/25/93 65-11-00
- Tip Retention Modifica- rotor blade assem-
tion (Revises basic No- blies except P/N
tice) 76150-09100–053 and
subsequent (Refer
to ASB for affected
Component part Nos
and RS markings)
PAGE 37
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-168 176 ENGINE INDICATING - No. 1 All Arriel powered None 12/07/93 77-10-01
and 2 Engine Gas Genera- S-76A and S-76C
tor N1 Indicator System — models prior to and
Outside Air Temperature including SS No.
(OAT) Probe Wiring - Re- 760417 Note: Not
sistance Check of applicable to S-76C
models equipped
with Rogerson Kra-
tos Integrated In-
strument Display
System
76-170 173 FUSELAGE - Left and Right All S-76 models 76070-20101–011 10/06/93 53-20-01
Cabin Floor Assemblies - prior to and in- and/or —012
Seat and Cargo Tiedown cluding SS No. and/or —013 (See
Pan Assemblies - Replace- 760382 CSN for applica-
ment of bility)
76-172A 165A FUSELAGE - E-bay Security All S-76 models None 06/25/90 53-40-00
Access Doors - Plate Re- prior to SS No.
tainer - Replacement of 760369 with secu-
(Supersedes CSN) rity retainer in-
stallation on the
E-bay access doors
PAGE 38
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76–173 184 FLIGHT CONTROLS — Main All configurations None 11/02/95 67–15–00
Rotor Servo Actuator As- 76650–09805 main
sembly — Modification of rotor servo actua-
Anti-Rotation Lugs; In- tor assemblies (HR
stallation of Sacrificial Textron part No.
Washers; Servo Support 30006760)
Bracket Assembly — In-
spection of
76-175 172 POWERTRAIN - Rotor Brake All S-76A models None 09/09/93 66-10–00
Assembly — Modification equipped with rotor 66–50–01
of; Main Gear Box Rear brake assemblies
Cover Housing - Rework of (76363-09101 se-
ries) (ABS P/N
4000476-9 or -10)
76-176 171 FUSELAGE/DOORS - Incorpo- All S-76 models None 05/13/93 52-10-02
ration of New Seals for
Crew and Passenger Doors
76-177A 193A FUSELAGE/DOORS - Incorpo- All S-76 Models Refer to CSN 01/20/00 52-10-02
ration of New Design prior to serial
V-Shaped Seals for Crew number 760441 with
and Passenger Doors hinged passenger
door(s)
PAGE 39
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76-178 174 FIRE PROTECTION - Engine All S-76 models None 10/12/93 26-11-00
Fire Detection System - prior to and in-
Control Amplifiers — In- cluding SS No.
corporation of Additional 760425
Ground
76-182 202 FUSELAGE - External Hoist S-76A/S-76B Models 33776-84780-011 04/24/98 53-00-00
Cable Guard - Installa- with plug sliding
tion of right cabin door
and external util-
ity hoist
76–183 183 FLIGHT CONTROLS — Main All S-76 Models None 11/02/95 67–00–00
Rotor Servo Actuator As- with 76650–09805
sembly — Inspection for (30006760) main ro-
Possible Missing Outer tor servo actuator
Spring 30006822 in Main assemblies
Rotor Servo Actuator As-
sembly 30006760
76-184A 177A DOORS - Right Sliding All S-76 Models None 09/27/94 52-10-03
Door Assembly. Door prior to SS No.
Handle Guard Assembly, 760428 with 76207-
Installation of (Super- 03033 series right
sedes basic CSN) sliding door and
rescue hoist op-
tions.
PAGE 40
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76–185A 181A FUSELAGE — Removable En- All S-76A models None 06/11/96 53–00–00
gine Deck Access Covers — equipped with Ar-
Installation of (Super- riel engines; All
sedes basic CSN) S-76B Models prior
to and including SS
No. 760382; S-76C
Models SS Nos
760375 thru 760378
76–187A 179A FUSELAGE — Lightweight S-76A and S-76C None 10/31/95 53–20–03
Aft Engine Cowling — For- Models with light-
ward Cross Beam Brackets weight aft engine
— Replacement of (Super- cowlings
sedes basic CSN) (76303–07800–101),
Serial Nos 101 thru
116 only
76–188 182 FIRE PROTECTION — Fire All S-76 Models None 11/01/95 26–11–01
Detection — Flame Detec- (Refer to CSN)
tors — Installation of
Interfacial Seal
76–189A 180A POWERTRAIN - Tail Gear Refer to CSN None 12/19/95 66-30-00
Box Assembly - Output
Shaft Assembly - Reiden-
tification of (Supersedes
basic CSN)
PAGE 41
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76–191A 191A POWERTRAIN - Tail Rotor All S-76 Models None 09/10/96 66-40–00
Drive Shaft Installation prior to and in-
- Viscous Damped Bearing cluding SS No.
Support Housing - Inspec- 760445 and also in-
tion for Corrosion; Re- cluding SS No.
placement of Attaching 762976
Washers (Supersedes basic
CSN)
76–192 198 POWERPLANT - Purge Fuel S-76A and S-76C He- Refer to CSN for 9/19/97 71-00-00
Recovery Kit - Installa- licopters with Tur- parts required
tion of bomeca Arriel
1S/1S1 Engines In-
stalled
76–193 186 FUSELAGE — Lightweight S-76A+ and S-76C 8444-1174/6130 01/30/96 53–20–03
Aft Engine Cowling — Up- Models with light-
grade of Phase 1 Cowlings weight aft engine
to Phase 2 Standard cowlings
(76303–07800–101),
Serial Nos 101 thru
116 only
PAGE 42
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76–194A 187A FUSELAGE — Lightweight S-76A+ and S-76C 8444- 09/05/96 53–20–03
Aft Engine Cowling — Fire Models with light- 1174/6140A(Part
Blanket Repair and Im- weight aft engine A); 8444-
proved Internal Clearance cowlings 1174/6140B (Part
(Supersedes basic CSN (76303–07800–101), B)
Serial Nos 101 thru
116 only
76–195A 188A FUSELAGE — Lightweight S-76A+, S-76C, and 8444-1174/6150 09/05/96 53–20–03
Aft Engine Cowling — Fire S-76C+ Models with
Blanket Repair and Im- lightweight aft en-
proved Internal Clearance gine cowlings
(Supersedes basic CSN (76303–07800–101),
Serial Nos 117 thru
144 only
76–196 189 FUSELAGE — Lightweight S-76A+ and S-76C 8444-1174/6160 01/30/96 53–20–03
Aft Engine Cowling — Fire Models with light-
Blanket Repair weight aft engine
cowlings
(76303–07800–101),
Serial Nos 101 and
subsequent
PAGE 43
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76–197 190 AIR CONDITIONING - Keith All S-76 Helicop- Refer to at- 03/26/96 21–00–00
Products VaporCycle Air ters with Keith tached Keith
Conditioning System - Products, Inc. Air Products Service
Compressor Drive Motor Conditioning System Letter TR-697,
Brushes - Inspection of installed per STC Revision B.
SH5778SW and that
have the following
Serial No. compres-
sor drive motors:
All motor Serial
Nos prior to S/N
132 (exclusive) ex-
cept Serial Nos
120, 127, and 129.
76–199A 197A FUSELAGE - Aft Cabin Up- All S-76 Models Refer to CSN for 02/18/98 53–00–00
per Fuselage Panel Assem- prior to serial parts required
bly - Station 188 thru number 760482
Station 215 - Replacement
of
76–200A 195A STRUCTURES - Tailcone All S-76 Models Refer to CSN for 11/18/98 51–00–00
Longeron; Station 380 to prior to serial parts required
Station 470 - Replacement number 760383
of
PAGE 44
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76–205 196 POWERTRAIN - Main Gear Refer to CSN Refer to CSN for 07/16/97 66–10–00
Box Assembly - Removal of parts required
Unused Accessory Drive
Assembly
76–207C 207B STABILIZERS - Vertical Refer to CSN Refer to CSN for 12/22/03 55-30–00
Stabilizer (VS) - Leading parts required
Edge Skin - Installation
of Inspection Port
76–211 HYDRAULIC POWER - First Refer to CSN Refer to CSN for 05/30/02 29-20-04
and Secord Stage Hydrau- parts required
lic Pressure Hoses - Re-
placement of
76–213 AIRFRAME - Accelerometer Refer to CSN Refer to CSN for 02/20/03 76-18-10
- Relocation of parts required
76–214 FIRE PROTECTION - Halon Refer to CSN Refer to CSN for 03/17/03 26-20-00
1211 Portable Fire Extin- parts required
guisher - Recall of
PAGE 45
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76–215 FUSELAGE/DOORS - Incorpo- Refer to CSN Refer to CSN for 03/24/03 76-56-30
ration of New Design Dual parts required
Seal and Tapered shim -
Installation of
76–219 ROTORS - Main Rotor Refer to CSN Refer to CSN for 03/17/05 65-11-00
Blades - Addition of parts required
Sealing Compound to Root
End Gusset
76–220A STABILIZERS - Tail Rotor Refer to CSN Refer to CSN for 02/08/06 53-00-00
Pylon - Aft Spar - Modi- parts required
fication of
76–223A UTILITY - Hoist Wiring Refer to CSN Refer to CSN for 05/03/06 25-57-00
for use during Single En- parts required
gine Operations - Modifi-
cation of
76–235 FUSELAGE — Engine Air In- Refer to CSN Refer to CSN for 01/08/09 53–20–03
let and Aft Engine Cowl parts required
Unlatched Sensor System,
Installation of
PAGE 46
S-76A
CUSTOMER SERVICE NOTICE INDEX
CSN NO. SEQ. NO. TITLE EFFECTIVITY KIT NUMBER DATE ATA NO.
76–236B NAVIGATION - Attitude and Refer to CSN Refer to CSN for 08/13/10 34–25–00
Heading - Attitude Head- parts required
ing and Reference System
(AHRS), Modification of
76–238B AUTO FLIGHT — Flight Di- Refer to CSN Refer to CSN for 6/09/10 22–00–00
rector Decouple Warning parts required
System (FDDWS), Installa-
tion of
76–239 NAVIGATION — Attitude, Refer to CSN Refer to CSN for 6/7/10 34–25–00
Heading, and Reference parts required
System (AHRS) Unit(s) —
LCR-100 Part Number (P/N)
76070–60019–101 (LITEF
P/N 145130–7100 Mod Sta-
tus 18) AHRS Unit(s) —
One-Time Replacement of
PAGE 47
S-76A
CSN/ATA CROSS REFERENCE INDEX
GENERAL
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
General 76-4 5 General - Removal of Sikorsky All helicopters delivered as None 06/13/79
Aircraft Yellow 9Unqualified of issue date of this CSN
Part Labels
General 76-18 17 ROTORS - Main Rotor Blade Lim- All helicopters delivered as None 12/20/79
its - Rotor Stopped of issue date of this CSN
GENERAL
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
General 76-52A 39A ICE AND RAIN PROTECTION - Op- All S-76 helicopters equipped None 07/12/82
eration in Falling and Blowing with snow protection kits
Snow (Supersedes basic CSN and
provides cancelling informa-
tion)
General 76-54A 43A In-Flight Operation Check Pro- S-76 None 02/12/81
cedures in Falling and Blowing
Snow (Rescinds CSN upon compli-
ance with CSB No. 76-30-6)
GENERAL
PAGE 2
S-76A
CSN/ATA CROSS REFERENCE INDEX
GENERAL
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
General 76-87A 77A ENGINES - CAA In-Flight Power All S-76 helicopters (CAA Cer- None 08/18/82
Assurance (Supersedes basic tified)
CSN.)
General 76-88A 78A ENGINES - FAA In-Flight Power All S-76 helicopters (FAA Cer- None 08/18/82
Assurance (Supersedes basic tified)
CSN.)
GENERAL
PAGE 3
S-76A
CSN/ATA CROSS REFERENCE INDEX
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
5–00–00 76–91 70 ELECTRICAL POWER - Wire Har- All S-76 helicopters delivered None 01/14/82
nesses - Inspection for Chafing before issue date of CSN
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
8–00–00 76–85A 82A LEVELING AND WEIGHING - Level Refer to CSN None 01/12/83
Plate - Inspection for Proper
Location (Supersedes basic CSN)
21 - AIR CONDITIONING
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
21–22–04 76–70 66 EQUIPMENT/FURNISHINGS - Head- SS Nos prior to and including 76070- 12/15/81
liner Support and ECS Dual Duct 760269 (With utility hard in- 20031-
Assemblies - Modification to Im- terior ceiling panels and dual 011
prove Accessibility for Beam ECS duct system installed); SS
Inspection Nos prior to and including
760356 (With VIP interior and
dual ECS duct system in-
stalled.)
21–21–01 76–89B 79B AIR CONDITIONING - Heat/Vent All S-76 helicopters (With None 10/30/95
Blower - Inspection of Brushes heating and ventilation sys-
and Rotor Assembly Commutator tem)
(Supersedes Revision A)
21–50–00 76–114A 102A AIR CONDITIONING - Environmen- S-76A, S-76B 76070- 10/10/82
tal Control System (ECS) - 20055-
Modifications of (Revises Revi- 011
sion A)
21–50–00 76–127 135 AIR CONDITIONING - Cockpit and SS Nos prior to 760230 (With 76070- 01/20/84
Cabin Ventilation - Improvement utility soft blanket interior, 20053-
of Option 76K0099A); SS Nos prior 011
to 760197 (With utility hard
panel trim interior, Option
76K0099B)
21 - AIR CONDITIONING
PAGE 1
S-76A
CSN/ATA CROSS REFERENCE INDEX
21 - AIR CONDITIONING
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
21–00–00 76–197 190 AIR CONDITIONING - Keith Prod- All S-76 Helicopters with None 03/26/96
ucts Vapor Cycle Air Condition- Keith Products, Inc. Air Con-
ing System - Compressor Drive ditioning System installed per
Motor Brushes - Inspection of STC SH5778SW and that have the
following Serial No. compres-
sor drive motors: All Motor
Serial Nos prior to S/N 132
(exclusive) except Serial Nos
120, 127, and 129)
21 - AIR CONDITIONING
PAGE 2
S-76A
CSN/ATA CROSS REFERENCE INDEX
22 - AUTO FLIGHT
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
22–20–04 76–83A 71A AUTO FLIGHT - Pitch Bias Actua- SS Nos prior to and including 76070- 05/19/82
tor (PBA) Wiring - Modification SS No. 760231 55027-
of (Supersedes basic CSN) 011
22–20–04 76–102A 116A AUTO FLIGHT - Pitch Bias Actua- SS Nos. 76003, 76005 thru 76070- 12/13/99
tor Servo Assembly - Replace- 76007, 760001 thru 760260 55029-
ment of 011
22–20–00 76–128 136 AUTO FLIGHT — Flight Director All S-76A helicopters with Refer to 02/22/10
Decouple Warning System (FD- SPZ-7600 DAFCS installed CSN for
DWS), Installation of parts
required
22–20–00 76–128 136 AUTO FLIGHT - Pitch Bias Actua- All S-76A helicopters without 76070- 02/21/84
tor System - Optional Removal AFCS Phase III option in- 55040-
of stalled 013
22 - AUTO FLIGHT
PAGE 1
S-76A
CSN/ATA CROSS REFERENCE INDEX
23 - COMMUNICATIONS
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
23 - COMMUNICATIONS
PAGE 1
S-76A
CSN/ATA CROSS REFERENCE INDEX
24 - ELECTRICAL POWER
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
24–22–00 76–30A 30A ELECTRICAL POWER - AC Generator S-76 SS Nos 76003, 76005 thru None 04/30/81
Cooling duct, Addition of Drain 76007, 760001 thru 760090
Hole; AC Generator Mounting
Pad, Removal of Drain Plug (Su-
persedes basic CSN)
24–31–02 76–53 41 ELECTRICAL POWER - No. 1 and S-76 SS Nos 76003, 76005 thru None 12/12/80
No. 2 DC Generator Control 76007, 760001 thru 760054
Panel Assemblies - Replacement
of
24–22–01 76–72A 81A POWERTRAIN - Main Gear Box - S-76 SS Nos 76003, 76005 thru None 01/12/83
Upper and Lower Housings - AC 76007, 760001 thru 760090
Generator Mounting flange - In-
spection for Corrosion; Incor-
poration of Oil Cooler Blower
Pad Drain Hole; Improved AC
Generator Mounting Procedure
(Revises basic CSN)
24 - ELECTRICAL POWER
PAGE 1
S-76A
CSN/ATA CROSS REFERENCE INDEX
24 - ELECTRICAL POWER
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
24 - ELECTRICAL POWER
PAGE 2
S-76A
CSN/ATA CROSS REFERENCE INDEX
25 - EQUIPMENT/FURNISHINGS
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
25–53-01 76–76 61 UTILITY HOIST - Replacement of All model S-76 utility hoist None 10/28/81
Cable Cutter Squib Assembly cable cutter squibs delivered
prior to October 9, 1981
25–53–00 76–125 138 EQUIPMENT/FURNISHINGS - Utility SS Nos prior to 760246 With 76070- 04/26/84
Hoist System - Wiring Modifica- utility hoist provisions (Op- 55026-
tion tion 76K0038P) or hoist Option 011
76K0038)
25–10–00 76–216 EQUIPMENT/FURNISHINGS - Martin- All S-76 helicopters equipped None 04/05/04
Baker Aircrew Seats, Modifica- with Seat Aircrew S-76 Part
tion of No. MBCS3310-1
25 - EQUIPMENT/FURNISHINGS
PAGE 1
S-76A
CSN/ATA CROSS REFERENCE INDEX
26 - FIRE PROTECTION
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
26–11–00 76–178 174 FIRE PROTECTION - Engine Fire All S-76 Models prior to and None 10/12/93
Detection System - Control Am- including SS No. 760425
plifiers - Incorporation of Ad-
ditional Ground
26–11–01 76–188 182 FIRE PROTECTION - Fire Detec- All S-76 Models (Refer to CSN) None 11/01/95
tion - Flame Detectors - In-
stallation of Interfacial Seal
26 - FIRE PROTECTION
PAGE 1
S-76A
CSN/ATA CROSS REFERENCE INDEX
28 - FUEL
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
28–21–00 76–46 103 OIL/ENGINE CONTROLS/ELECTRICAL SS Nos prior to 760200; SS Nos None 09/30/82
POWER - Chafing Protection of prior to 760242; SS Nos prior
Oil and Hydraulic Lines to 760219 (Refer to CSN)
28–10–03 76–55 45 FUSELAGE - Fuel Filler Cap Re- S-76 None 01/27/81
ceptacle Ring - Removal of
Paint
28–10–04 76–90 94 FUEL - Fuel Tank Sump Drain SS Nos 76003, 76005 thru None 06/08/82
Valve Installation - Improved 76007, 760001 thru 760200
Sealing of
28–20–02 76–148B 154B FUEL - Stainless Steel Fuel S-76A SS Nos 76003 thru 76007, 76070- 05/06/88
Supply Lines (Integral Fuel 760001 thru 760345 30028-
Tanks) - Incorporation of (Su- 026
persedes Revision A)
28 - FUEL
PAGE 1
S-76A
CSN/ATA CROSS REFERENCE INDEX
29 - HYDRAULIC POWER
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
29–10–04 76–5 6 HYDRAULIC LINES - Proper Clear- All S-76 helicopters delivered None 06/19/79
ance as of issue date of this CSN
29–10–00 76–16B 13B HYDRAULIC SYSTEMS - Recommended All S-76 helicopters delivered None 03/21/80
Maintenance Procedures (Super- as of issue date of this CSN
sedes Revision A)
29–10–04 76–56 74 HYDRAULIC POWER - Lines Instal- All S-76 delivered as of issue None 02/05/82
lation - Improved Clamping date of this CSN
29–10–01 76–80 83 HYDRAULIC POWER - First and SS Nos 76003, 76005 thru 76070- 04/21/82
Second Stage Hydraulic Pumps - 76007, 760001 thru 760255 65005-
Replacement of 011
29–10–04 76–99 152 HYDRAULIC POWER - Tail Rotor S-76A SS Nos 76003 thru 76007, None 10/06/86
Servo Hydraulic Line Restric- 760001 thru 760244
tors - Removal of
29–10–04 76–104B 106B HYDRAULIC POWER - First and S-76A SS Nos 76003 thru 76007, 76070- 08/12/87
Second Stage Hydraulic Lines - 760001 thru 760241 65008-
Replacement of (Supersedes Re- 011
vision A)
29–10–04 76–132 114 HYDRAULIC POWER - Hydraulic S-76A SS Nos 76003, 76005 thru 76070- 03/11/83
Lines - First Stage Hydraulic 76007, 760001 thru 760255 65008-
Pump Pressure Line - Replace- 011
ment of
29 - HYDRAULIC POWER
PAGE 1
S-76A
CSN/ATA CROSS REFERENCE INDEX
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
30–43–00 76–34 46 WINDOWS - Inspection of Wind- All S-76A helicopters deliv- None 02/03/81
shield and Windshield Wiper; ered as of issue date of this
Replacement of Windshield Wiper CSN
Blade Assembly
30–43–00 76–84A 99A ICE AND RAIN PROTECTION - En- SS Nos prior to 760206 (With NPN 822 07/14/83
gine Inlet Snow Protection Sys- snow protection system in-
tem - Incorporation of Shields stalled)
(Supersedes basic CSN) (Compli-
ance with this CSN and CSN No.
70-40A cancels CSN No. 76-52.)
30–20–00 76–126 147 ICE AND RAIN PROTECTION - Snow S-76A With engine inlet snow 76070- 03/08/85
Protection Shield Support Clips protection kit, Option 76K0063 30025-
and Bracket - Replacement of 011
30–43–00 76–130 122 ICE AND RAIN PROTECTION - Wind- SS Nos 76003, 76005 thru NPN 834 07/14/83
shield Wiper System Improve- 76007, 760001 thru 760211
ments
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
30–43–00 76–154 162 ICE AND RAIN PROTECTION - Pre- S-76A and S-76B Series prior 76070- 09/26/88
cipitation 9P9 Static discharge to and including SS No. 760343 55057-
Protection - Windshield Heat with heated glass windshields 011 and
System - Harness Assembly - In- (76206-01001 series) Option -012 or
corporation of 76K0003 76070-
55057-
013 and
-014
(See
CSN)
32 - LANDING GEAR
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
32–30–05 76–25 21 LANDING GEAR - Nose and Main S-76 main landing gear elec- None 03/20/80
Electrical Wiring Harness - Re- trical wiring harness sensor
moval of Clear Heat-Shrink Tub- switches date-etched before
ing; Main Electrical Wiring 2:80 on elbow connector
Harness - Moisture Protection
of Sensor Switches
32–10–02 76–28 26 LANDING GEAR - Main - Elimina- All S-76 helicopters delivered None 07/22/80
tion of Interference Between as of issue date of this CSN
Strut and Airframe Upper At-
tachment Fitting
32–31–05 76–32 80 LANDING GEAR - Main and Nose SS Nos 76003, 76005 thru None 03/22/82
Landing Gear Actuators - Im- 76007, 760001 thru 760143
proved Shuttle Valve - Retrofit
Program
32–30–05 76–35A 24A LANDING GEAR - Emergency Flota- S-76 SS Nos 76005 thru 76007, None 06/25/81
tion System - Main Landing Gear 760001 thru 760200 Equipped
Door Link and flotation Bottles with emergency flotation system
- Inspection of Cartridge Re-
ceptacles and Harness Plugs
(Supersedes basic CSN Msg CST-
SPT-80-358)
32–70–03 76–58 57 LANDING GEAR - Emergency Float All S-76 helicopters delivered None 08/27/81
Support Cables - Installation as of issue date of this CSN
of Protective Sleeves
32 - LANDING GEAR
PAGE 1
S-76A
CSN/ATA CROSS REFERENCE INDEX
32 - LANDING GEAR
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
32–30–02 76–93A 113A LANDING GEAR - Landing Gear SS Nos 76003, 76005 thru 76070- 07/11/83
Control Panel - Modification of 76007, 760001 thru 760259 55018-
(Supersedes basic CSN) 011
32–30–05 76–103 124 LANDING GEAR - Nose and Main SS Nos 76003, 76005 thru 76070- 07/06/83
Landing Gear - Proximity sensor 76007, 760001 thru 760255 55041-
Cable Assemblies - Replacement 011
of
32–30–05 76–134A 117A LANDING GEAR - Main Landing SS Nos prior to 760308 76070- 01/10/84
Gear - Structural Improvements 25004-
- Incorporation of (Revises ba- 011
sic CSN)
32–30–07 76–138B 131B LANDING GEAR - Nose and Main SS Nos 76003, 76005 thru 76070- 03/11/85
Electrical Wiring Harness - Re- 76007, 760001 thru 760332 65010-
moval of Clear Heat-Shrink Tub- 011 or
ing; Main Electrical Wiring 76070-
Harness - Moisture Protection 65011-
of Sensor Switches (Revises Re- 011 (See
vision A) CSN)
32–30–04 76–143B 132 LANDING GEAR - Nose Landing S-76A prior to SS No. 760284; None 02/13/87
Gear Actuator - Downlock Keys - Component 1944E200A and
Replacement of (Revises Revi- 1944F200 series nose gear ac-
sion A) tuators
32 - LANDING GEAR
PAGE 2
S-76A
CSN/ATA CROSS REFERENCE INDEX
32 - LANDING GEAR
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
32–70–00 76–155A 149A LANDING GEAR - Emergency Flota- All S-76A and S-76B with flo- 76070- 03/13/87
tion Gear - Additional Protec- tation kit Option 76K0027 or 25005-
tion for (Revises basic CSN) 76K0027P 011
32–70–03 76–160 163 LANDING GEAR - Emergency Flota- S-76A Series equipped with Op- 76070- 02/22/89
tion - Main Landing Gear float tion 76K0027 (Emergency Flota- 25007-
cover - Scuff Pad - Installation tion) and 14 ply tires 011
of (145K41-1)
32 - LANDING GEAR
PAGE 3
S-76A
CSN/ATA CROSS REFERENCE INDEX
33 - LIGHTS
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
33–20–00 76–33 31 LIGHTS - Executive Interior - S-76 SS Nos 760009, 760016, None 09/25/80
Replacement of Wiring and Light 760019, 760028, 760032,
Bulb Connectors 760040, 760053, and 760063
33–10–02 76–95A 91A LIGHTS - Instrument Panel - S-76 SS Nos 76003, 76005 thru NPN 823 09/01/84
Dimmer Control Unit - Modifica- 76007, 760001 thru 760201 (Grimes
tion of (Supersedes basic CSN) Kit P/N
70-
0269-1)
33–50–00 76–101 139 LIGHTS - Emergency Exit Light- S-76 SS Nos 76003, 76005 thru 76070- 06/05/84
ing - Modification of 76007, 760001 thru 760253 55042-
011
33–40–03 76–107 97 LIGHTS - Anti-Collision Light S-76 SS Nos 76003, 76005 thru Grimes 07/06/82
System - Strobe Power Supply - 76007, 760001 thru 760227 Kit P/N
Modification for Improved Water 60-
Integrity 3808-1
33 - LIGHTS
PAGE 1
S-76A
CSN/ATA CROSS REFERENCE INDEX
34 - NAVIGATION
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
34–00–00 76–73 109 NAVIGATION - Horizontal Situa- SS Nos 76003, 76005 thru 76070- 12/09/82
tion Indicators - Incorporation 76007, 760001 thru 760114 55020-
of separate Circuit Breakers 011
34–11–02 76–81 86 NAVIGATION - Tail Cone Pitot SS Nos 76003, 76005 thru 76070- 05/05/82
System - External Drain Provi- 76007, 760001 thru 760198 45002-
sions - Incorporation of 011
34–22–00 76–129 137 NAVIGATION - Pilot and Copilot SS Nos prior to 760250 With 76070- 04/24/84
Vertical Gyro - Fast Erect Option 76K0051 (dual remote 60008-
Switch - Installation of Reference System) installed 011
34 - NAVIGATION
PAGE 1
S-76A
CSN/ATA CROSS REFERENCE INDEX
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
39–00–00 76–20 90 ELECTRICAL PANELS AND COMPO- All S-76 helicopters with None 05/19/82
NENTS - Instrument Panel Har- weather radar system delivered
nesses - Installation Inspec- prior to date of this CSN
tion
39–30–02 76–37 27 ELECTRICAL POWER - Inspection S-76 SS Nos 76003, 76005 thru None 08/01/80
of DC Junction Box Assembly 76007, 760001 thru 760061,
760063 thru 760071
39–10–01 76–43A 40A ELECTRICAL PANELS AND COMPO- S-76 SS Nos 76003, 76005 thru None 02/02/81
NENTS - Replacement of Copi- 76007, 760001 thru 760107
lot’s Vne Placard (Supersedes
basic CSN)
39–40–06 76–119 128 ELECTRICAL PANELS AND COMPO- SS Nos 76003, 76005 thru 76070- 10/10/83
NENTS - No. 1 Relay Panel - Ad- 76007, 760001 thru 760011, 55039-
dition of Stiffener 760016 thru 760083 011
51 - STRUCTURES
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
51–01–00 76–71 88 FUSELAGE - Transmission and En- Refer to CSN for SS No. and Refer to 05/11/82
gine Compartment Structure and Kit applicability CSN
Electronics Compartment Access
Doors - Sealing for Water In-
tegrity (Includes Errata Sheet,
dated 06/07/82)
51–00–00 76–200A 195A STRUCTURES - Tailcone Longeron; All S-76 Models prior to se- Refer to 11/18/98
Station 380 to Station 470 - rial number 760383 CSN for
Replacement of parts
required
51 - STRUCTURES
PAGE 1
S-76A
CSN/ATA CROSS REFERENCE INDEX
52 - DOORS
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
52–10–01 76–77A 63A DOORS - Crew and Passenger SS Nos 76003, 76005 thru Refer to 12/05/83
Doors - Modification of Lock 76007, 760001 thru 760145 (Re- CSN
Mechanism (Supersedes basic fer to CSN)
CSN)
52–10–03 76–78 65 DOORS - Right Sliding Door - SS Nos 76004 thru 76009, 76070- 11/19/81
Incorporation of Door Open Sup- 760011, 760016 thru 760018, 20015-
ports and Provisions for Im- 760020 thru 760026, 760033, 011 (SS
proved Operation 760036 thru 760040, 760042 Nos
thru 760044, 760046, 760049, 760036
760051, 760052, 760056, and sub-
760057, 760059, 760064 se-
quent);
76070-
20015-
012 (SS
No.
760033
and
prior)
52–80–01 76–115 130 DOORS - Main Landing Gear - SS Nos prior to 760247 None 11/02/83
Door-to-Link Fitting Assembly
Attaching Hardware - Replace-
ment of
52 - DOORS
PAGE 1
S-76A
CSN/ATA CROSS REFERENCE INDEX
52 - DOORS
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
52–10–04 76–147 142 DOORS - Left and Right sliding All S-76A helicopters with 76070- 07/11/84
Doors - Latching and Locking right sliding door (Option 20044-
Mechanisms - Modification of; 76K0005) and/or left sliding 011
Access Hole - Incorporation of door (Option 76K0005A) deliv- (Right
ered prior to September 30/84. Door);
76070-
20044-
012
(Left
Door)
52–10–02 76–176 171 FUSELAGE/DOORS - Incorporation All S-76 Models None 05/13/93
of New Seals for Crew and Pas-
senger Doors
52–10–02 76–177A 193A FUSELAGE/DOORS - Incorporation All S-76 models prior to se- Refer to 02/05/97
of New Design V-Shaped Seals rial number 760441 with hinged CSN for
for Crew and Passenger Doors passenger door(s) parts
required
52–10–03 76–184A 177A DOORS - Right Sliding Door As- All S-76 Models prior to SS None 09/27/94
sembly - Door Handle Guard As- No. 760428 with 76207-03033
sembly - Installation of (Su- series right sliding door and
persedes basic CSN) rescue hoist options
52 - DOORS
PAGE 2
S-76A
CSN/ATA CROSS REFERENCE INDEX
53 - FUSELAGE
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
53–10–01 76–6 7 FUSELAGE - Rework of Canopy to S-76 SS Nos 76005 and 76006, None 07/17/79
Improve Airflow for Windshield 760001 thru 760017
Defogging
53–20–03 76–7 3 FUSELAGE - Sealing of Engine All S-76 helicopters delivered None 05/18/79
Compartment Deck from Fluid as of issue date of this CSN
Leaks
53–20–03 76–19 16 FUSELAGE - Engine Air Inlet All S-76 helicopters delivered 12/18/79
Cowl Latches - Adequate Clear- as of issue date of this CSN
ance Inspection
53–20–03 76–27 22 FUSELAGE - Inspection of Engine All S-76 helicopters delivered None 04/14/80
Air Inlet Screen Assemblies - as of issue date of this CSN
Inspection and Replacement or
Repair of
53–40–01 76–57 84 FUSELAGE - Cockpit Door Striker All S-76 helicopters delivered None 08/27/80
Fittings-Provisions for Inspec- as of issue date of this CSN
tion - Incorporation of (With 76209-10002-047 cockpit
door striker fitting assembly
installed)
53 - FUSELAGE
PAGE 1
S-76A
CSN/ATA CROSS REFERENCE INDEX
53 - FUSELAGE
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
53–00–00 76–75 87 FUSELAGE - Transmission Deck S-76 SS Nos 76003, 76005 thru 76070- 05/06/82
Drip Panel - Access Covers - 76007, 760001 thru 760224 20035-
Incorporation of 011
53–20–03 76–109A 87 FUSELAGE - Aft Engine Cowl - S-76 SS Nos 76003, 76005 thru 76070- 11/05/82
Latch Modification - Spring As- 76007, 760001 thru 760282 30018-
sist Opening Installation (Re- 011
vises basic CSN)
53–00–00 76–111C 100C FUSELAGE - Engine Compartment - S-76 SS Nos 76003, 76005 thru 76070- 03/06/91
Center Firewall - Modification 76007, 760001 thru 760382 20057-
of (Revises Revision B) 011
53–10–00 76–123 111 FUSELAGE - Baggage Compartment S-76 SS Nos 76005 thru 76007, 76070- 12/16/82
Shroud Assemblies - Modification 760001 thru 760255 20056-
of 011
53–30–02 76–135B 120B FUSELAGE - Access Panels - Ver- S-76A and S-76B SS Nos 76003 76070- 09/19/86
tical Stabilizer - Modification thru 76007, 760001 thru 760314 20066-
of (Revises Revision A) 011
53–10–05 76–136B 161B FUSELAGE - Access Covers - S-76A Series prior to and in- Refer to 11/11/96
Electronic Compartment Access cluding SS No. 760309 CSN for
Panels - Fasteners - Replace- supplier
ment of (Supersedes Revision A) kits re-
quired.
53 - FUSELAGE
PAGE 2
S-76A
CSN/ATA CROSS REFERENCE INDEX
53 - FUSELAGE
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
53–20–02 76–140 169 FUSELAGE - Forward Fairing As- S-76A Series prior to and in- Refer to 07/25/91
sembly - Access Door - Modifi- cluding SS No. 760298 CSN for
cation of parts
re-
quired.
53–00–00 76–150 143 FUSELAGE - Upper Fuselage Long- SS Nos 76003, 76005 thru Refer to 09/13/84
eron - Station 188 - 225 Left 76007, 760001 thru 760088 (Kit Effec-
Side - Reinforcement of 76070-20511-013); SS Nos tivity
760089 thru 760328 (Kit 76070-
20511-012)
53–00–00 76–151 140 FUSELAGE - Doubler Installation S-76 (Without Mod. Kit 76070- 76070- 06/28/84
- Station 215, Left Side 20511-012 or 013, or CSN No. 20072-
76-150 incorporated) 011
53–00–00 76–157A 158A FUSELAGE - Water Integrity - All S-76A Refer to 05/31/90
Drain Grommets and Valves - In- CSN for
stallation of; Additional supplier
Drainage Vents and Holes - In- kits re-
corporation of (Revises basic quired.
CSN)
53 - FUSELAGE
PAGE 3
S-76A
CSN/ATA CROSS REFERENCE INDEX
53 - FUSELAGE
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
53–00–00 76–166 166 FUSELAGE/LANDING GEAR - Upper SS Nos 76003, 76005 thru Refer to 06/12/90
Fuselage Longerons and Landing 76007, 760001 thru 760088 (Kit Effec-
Gear Modification Requirements 760070-20100-017 without CSN tivity
to Increase Takeoff Gross Weight No. 76-150 incorp.); SS Nos
to 10,800 Lb with Arriel 1S En- 760089 thru 760304 (Kit 76070-
gines 20100-011 without CSN No. 76-
150 incorp.); SS Nos 76003,
76005 thru 76007, 760001 thru
760088 (Kit 760070-20100-016
with CSN No. 76-150 incorp.)
53–20–01 76–170 173 FUSELAGE - Left and Right Cabin All S-76 Models prior to and Refer to 10/06/93
floor Assemblies - Seat and including SS No. 760382 CSN
Cargo Tiedown Pan Assemblies -
Replacement of
53–40–00 76–172A 165A FUSELAGE - E-Bay Security Ac- All S-76 models prior to SS Refer to 06/25/90
cess Doors - Plate Retainer - No. 760369 with security re- CSN for
Replacement of (Supersedes ba- tainer installation on E-bay parts
sic CSN) access doors required
53 - FUSELAGE
PAGE 4
S-76A
CSN/ATA CROSS REFERENCE INDEX
53 - FUSELAGE
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
53–00–00 76–182 202 FUSELAGE - External Hoist Cable S-76A/S-76B Models with plug 33776- 04/24/98
Guard - Installation of sliding right cabin door and 84780-
external utility hoist 011
53–00–00 76–185A 181A FUSELAGE - Removable Engine All S-76A Models equipped with Refer to 06/11/96
Deck Access Covers - Installa- Arriel engines CSN for
tion of (Supersedes basic CSN) parts
required
53–20–01 76–187A 179A FUSELAGE - Lightweight Aft En- S-76A and S-76C Models with Refer to 10/31/95
gine Cowling - Forward Cross lightweight aft engine cowl- CSN for
Beam Brackets - Replacement of ings (76303-07800-101), serial parts
(Supersedes basic CSN) Nos 101 thru 116 only required
53–20–03 76–193 186 FUSELAGE - Lightweight Aft En- S-76A+ and S-76C Models with 8444- 01/30/96
gine Cowling - Upgrade of Phase lightweight aft engine cowl- 1174/6130
1 Cowlings to Phase 2 Standard ings (76303-07800-101), serial
Nos 101 thru 116 only
53–20–03 76–194A 187A FUSELAGE - Lightweight Aft En- S-76A+ and S-76C Models with 8444- 09/05/96
gine Cowling - Fire Blanket Re- lightweight aft engine cowl- 1174/6140A
pair and Improved Internal ings (76303-07800-101), serial (Part
Clearance (Supersedes basic Nos 101 thru 116 only A);
CSN) 8444-
1174/6140B
(Part B)
53 - FUSELAGE
PAGE 5
S-76A
CSN/ATA CROSS REFERENCE INDEX
53 - FUSELAGE
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
53–20–03 76–195A 188A FUSELAGE - Lightweight Aft En- S-76A+, S-76C, and S-76C+ Mod- Refer to 10/06/93
gine Cowling - Fire Blanket Re- els with lightweight aft en- CSN
pair and Improved Internal gine cowlings (76303-07800-
Clearance (Supersedes basic 101), serial Nos 117 thru 144
CSN)
53–20–03 76–196 189 FUSELAGE - Lightweight Aft En- S-76A+ and S-76C Models with 8444- 01/30/96
gine Cowling - Fire Blanket Re- lightweight aft engine cowl- 1174/6160
pair ings (76303-07800-101), serial
Nos 101 and subsequent
53–00–00 76–199A 197A FUSELAGE - Aft Cabin Upper Fu- All S-76 Models prior to se- Refer to 02/18/98
selage Panel Assembly - Station rial number 760482 CSN for
188 thru Station 215 - Replace- parts
ment of required
53–20–03 76–202 201 FUSELAGE - Lightweight Aft En- Refer to CSN 8444- 04/20/98
gine Cowling - Fire Blanket Re- 1174/6170
placement and Installation of
Support Members
53–20–03 76–235 FUSELAGE - Engine Air Inlet and All S-76A Refer to 01/08/09
Aft Engine Cowl Unlatch Sensor CSN for
System - Installation of parts
required
53 - FUSELAGE
PAGE 6
S-76A
CSN/ATA CROSS REFERENCE INDEX
55 - STABILIZERS
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
55–30–00 76–8 8 STABILIZERS - Vertical Stabi- S-76A series prior to and in- 76070- 09/15/97
lizers - Aft Spar - Reinforce- cluding SS No. 760298 20094-
ment of (Supersedes CSN No. 76- 012
153
55–30–00 76–141B 133B STABILIZERS - Vertical Stabi- SS Nos prior to 760052 (Kit Refer to 01/15/85
lizer - Forward and Aft Spars - 76070-20070-011); SS Nos Effec-
Reinforcement of (Revises Revi- 760052 thru 760332 (Kit 76070- tivity
sion A) 20070-012 or -015); SS Nos
prior to 760199 (Kits 76070-
20070-013 and -014); SS Nos
760199 thru 760263 (Kit 76070-
20070-013)
55–00–00 76–153A 160A STABILIZERS - Vertical Stabi- S-76A Series prior to and in- 76070- 09/15/97
lizer - Aft Spar - Reinforce- cluding SS No. 760298 20094-
ment of (Supersedes CSN No. 76- 012
153)
55 - STABILIZERS
PAGE 1
S-76A
CSN/ATA CROSS REFERENCE INDEX
56 - WINDOWS
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
56–30–01 76–96A 85A WINDOWS - Pilot’s Door - Open- S-76 SS Nos 76003, 76005 thru 76070- 12/05/83
able Window - Doubler and 76007, 760001, thru 760246 20054-
Washer Installation (Supersedes 011
basic CSN)
56 - WINDOWS
PAGE 1
S-76A
CSN/ATA CROSS REFERENCE INDEX
65 - ROTORS
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
65–21–01 76–3 4 ROTORS - Tail Rotor Blades - All S-76 helicopters delivered Refer to 06/13/79
Proper Installation Procedures as of issue date of this CSN CSN for
for Tail Rotor Boots parts
and ma-
terial
required
65–14–00 76–9 11 ROTORS - Swashplate Assembly - All S-76 helicopters delivered Refer to 09/14/79
Replacement of Bearing Shield as of issue date of this CSN CSN for
with Main Rotor Head Installed parts
and ma-
terial
required
65 - ROTORS
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
65–11–00 76–49 38 ROTORS - Main Rotor Blade - Re- All S-76 helicopters delivered Refer to 12/05/80
placement of Root End Seal as of issue date of this CSN CSN for
Plate parts
and ma-
terial
required
65–12–06 76–50 73 ROTORS - Pitch Control Rod In- SS Nos 76003, 76005 thru Refer to 02/01/82
stallation - Replacement of 76007, 760001 thru 760239 CSN for
Aluminum Washers with Steel parts
Washers required
65–12–09 76–59A 72A ROTORS - Main Rotor Head - SS Nos 76003, 76005 thru 76070- 12/16/82
Damper Attachment Bolts and 76007, 760001 thru 760231 10013-
Nuts - Replacement of (Super- 011
sedes basic CSN)
65 - ROTORS
PAGE 2
S-76A
CSN/ATA CROSS REFERENCE INDEX
65 - ROTORS
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
65–12–09 76–92 76 ROTORS - Main Rotor Head - SS Nos 76003, 76005 thru Refer to 02/24/82
Anti-Flap Cam Assembly - Re- 76007, 760001 thru 760245 CSN for
placement of parts
re-
quired.
65–11–00 76–100 107 ROTORS - Main Rotor Blades - All S-76 helicopters (with Refer to 11/10/82
Sealing of Root End 76150-09000-045 thru -050, and CSN for
76150-09100-041 thru -050 main material
rotor blade assemblies prior required
to and including SN A086-01053
65–12–06 76–105A 92A ROTORS - Main Rotor Head and SS Nos 76003, 76005 thru 76070- 11/17/83
Tail rotor Pitch Control Rod 76007, 760001 thru 760240 10014-
Bearings - Replacement of (Su- 011 and
persedes basic CSN) -012
65–21–01 76–117 129 ROTORS - Tail Rotor Blades - Component: 76101-05101-041 and Refer to 10/31/83
Balance Brackets - Installation 76101-05001-044 and -045 tail CSN for
of rotor blade assemblies prior parts
to SN A173-00501 required
65 - ROTORS
PAGE 3
S-76A
CSN/ATA CROSS REFERENCE INDEX
65 - ROTORS
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
65–21–00 76–118A 127A ROTORS - Tail Rotor Blades - Component: 76101-05001-044 and 76070- 11/10/83
Reinforcement of Trailing Edge -045, and 76101-05101-041 tail 10012-
(Revises basic CSN) rotor blade assemblies prior 011
to SN A137-00560
65–14–01 76–122 104 ROTORS - Main Rotor Hub Subas- Part I - SS Nos 76003, 76005, Part I - 10/07/82
sembly and Rotating Scissors and 76006, 760001 thru 760106, 76070-
Assembly - Modification of 760108 thru 760142, 760146 10005-
thru 760150, 760152 thru 015;
760161, 760163 thru 760177, Part II
760179 thru 760209, 760211 - 76070-
thru 760229; Part II SS Nos 10005-
76007, 760107, 760143 thru 016
760145, 760151, 760162,
760178, and 760210
65–21–00 76–131 134 ROTORS - Tail Rotor Outboard SS Nos 76003, 76005 thru Refer to 01/12/84
Retaining Plate - Replacement 76007, 760001 thru 760282 CSN for
of Liner and Snapring parts
re-
quired.
65–00–00 76–146B 150B ROTORS - Main and Tail Rotor S-76 Series prior to and in- 76070- 09/06/89
Heads - Bonding Jumpers - Addi- cluding SS No. 760341 10016-
tion of (Supersedes Revision A) 012 and
-013
65 - ROTORS
PAGE 4
S-76A
CSN/ATA CROSS REFERENCE INDEX
65 - ROTORS
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
65–00–00 76–165A 164A ROTORS - 5P Upper Bifilar Assem- S-76 A (Equipped with TUR- 76070- 03/12/90
bly - Optional Removal of (Su- BOMECA ARRIEL Engines) 10019-
persedes basic CSN) 011
65–11–00 76–167B 168B ROTORS - Main Rotor Blade - Tip All S-76 model main rotor 76070- 05/25/93
Retention Modification (Revises blade assemblies except part 15003-
Revision A) No. 76150-09100-053 and subse- 011,
quent (Refer to CSN for compo- -012,
nent part Nos. and -013
65 - ROTORS
PAGE 5
S-76A
CSN/ATA CROSS REFERENCE INDEX
66 - POWERTRAIN
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
66–11–07 76–22 44 POWERTRAIN - Main Gear Box Oil S-76 main gear box oil cooler Refer to 01/27/81
Cooler Blower - Rework of blower (99D30-2, and -3) CSN for
parts
re-
quired.
66–10–00 76–24A 20A POWERTRAIN - Main Gear Box - S-76 main gear boxes prior to Refer to 05/08/80
Corrosion Protection of Main and including SN A081-00074 CSN for
Rotor Shaft (Supersedes basic material
CSN) re-
quired.
66–50–02 76–51C 64C POWERTRAIN - Rotor Brake - All S-76 helicopters NPN 833 10/06/82
Modification and Reactivation
(Revises Revision No. 2)
66–50–02 76–79B 69B POWERTRAIN - Rotor Brake Access SS Nos 76003, 76005 thru 76070- 02/07/84
Door - Incorporation of (Re- 76007, 760001 thru 760307 30015-
vises Revision A) 011
66 - POWERTRAIN
PAGE 1
S-76A
CSN/ATA CROSS REFERENCE INDEX
66 - POWERTRAIN
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
66–11–07 76–86 101 POWERTRAIN - Main Gear Box Oil SS Nos 76003, 76005 thru 76070- 09/08/82
Cooler Blower - Impeller - Re- 76007, 760001 thru 760227 35005-
placement of 013
66–30–00 76–94 75 POWERTRAIN/FLIGHT CONTROLS - SS Nos 76003, 76005 thru Refer to 02/22/82
Tail Gear Box - Pitch Control 76007, 760001 thru 760229 CSN for
Shaft Assembly QCU - Replace- parts
ment of re-
quired.
66–50–00 76–113 121 POWERTRAIN - Rotor Brake System SS Nos 76003, 76005 thru 76070- 06/01/83
- Circuit Breaker and Diodes - 76007, 760001 thru 760249 55033-
Installation of 012
66–50–00 76–121 125 POWERTRAIN - Main Gear Box - SS Nos 76003, 76005 thru 76070- 07/14/83
Harness Relocation of Discon- 76007, 760001 thru 760076 55038-
nect Points 011
66–50–02 76–144 155 POWERTRAIN - Goodyear Rotor All S-76A helicopters with 76070- 04/10/87
Brake and Hydraulic Power Unit Goodyear rotor brakes 35006-
- Removal of; Goodrich Rotor 011
Brake and Hydraulic Power Unit
- Installation of
66 - POWERTRAIN
PAGE 2
S-76A
CSN/ATA CROSS REFERENCE INDEX
66 - POWERTRAIN
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
66–50–00 76–156 144 POWERTRAIN - Rotor Brake - Hy- SS Nos 76003, 76005 thru Refer to 01/04/85
draulic Lines - Replacement of 76007, 760001 thru 760239 CSN for
parts
re-
quired.
66–00–00 76–162B 159B POWERTRAIN - Main Gear Box - S-76A Series With main gear 76070- 07/15/88
Shaft and Spur Pinion - Bearing box assembly part No. 76351- 35008-
Retainer Nut - Replacement of 09500-041 011
(Supersedes basic CSN)
66–10–00 76–175 172 POWERTRAIN - Rotor Brake Assem- All S-76A models equipped with None 09/09/93
bly - Modification of; Main Gear rotor brake assemblies (76363-
Box Rear Cover Housing - Rework 09101 series) (ABS P/N
of 4000476-9 or -10)
66–30–00 76–189A 180A POWERTRAIN - Tail Gear Box As- S-76A SS Nos 760364, 760366, None 12/19/95
sembly - Output Shaft Assembly 760369, 760370, 760371,
- Reidentification of (Super- 760373, 760374
sedes basic CSN)
66 - POWERTRAIN
PAGE 3
S-76A
CSN/ATA CROSS REFERENCE INDEX
66 - POWERTRAIN
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
66–40–00 76–191A 191A POWERTRAIN - Tail Rotor Drive All S-76A models prior to and Refer to 04/30/96
Shaft Installation - Viscous including SS No. 760445 and CSN for
Damped Bearing Support Housing also including SS No. 762976 parts
- Inspection for Corrosion; Re- and ma-
placement of Attaching Washers terial
(Supersedes basic CSN) re-
quired.
66–10–00 76–205 196 POWERTRAIN - Main Gear Box As- Refer to CSN Refer to 07/16/97
sembly - Removal of Unused Ac- CSN for
cessory Drive Assembly parts
required
66 - POWERTRAIN
PAGE 4
S-76A
CSN/ATA CROSS REFERENCE INDEX
67 - FLIGHT CONTROLS
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
67–00–00 76–38 51 FLIGHT CONTROLS - Longitudinal S-76 SS Nos 76005 thru 76007, None 03/19/81
and Lateral Systems - Inspec- 760001 thru 760073
tion for Minimal Clearance
67–21–00 76–42 34 FLIGHT CONTROLS - Tail Rotor S-76 SS Nos 76005, 76006, Refer to 10/23/80
servo Actuator - Inspection of 760001 thru 760054, 760056 CSN
Ground Link and Input Lever As- thru 760071, 760073, 760075,
semblies 760076, 760078 thru 760080,
760082 and 760084
67–14–00 76–44 36 FLIGHT CONTROLS - Support As- S-76 SS Nos 76003, 76005 thru None 10/30/80
sembly - Modification of Shim 76007, 760001 thru 760099
67–15–00 76–47 42 FLIGHT CONTROLS - Main Rotor Main rotor servo actuators SN Refer to 12/18/80
Servo Actuators - Inspection of 017 thru 0443, less actuators CSN and
Right Hand Manifold with manifold serial numbers attached
described in Hydraulic Re- HR SB
search Service Bulletin FMTC No.
No. 256 30006760-67-02
67 - FLIGHT CONTROLS
PAGE 1
S-76A
CSN/ATA CROSS REFERENCE INDEX
67 - FLIGHT CONTROLS
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
67–30–00 76–94 75 POWERTRAIN/FLIGHT CONTROLS - SS Nos 76003, 76005 thru Refer to 02/22/82
Tail Gear Box - Pitch Control 76007, 760001 thru 7600229 CSN for
Shaft Assembly QCU - Replace- parts
ment of re-
quired.
67–21–00 76–112 105 FLIGHT CONTROLS - Tail Rotor All S-76 helicopters With Refer to 10/28/82
Servo Actuator - Input Crank 76650-05801 (30006840 ) series attached
Assembly Adjusters - Addition tail rotor servo actuator HR Tex-
of Lockwire prior to SN 0441 tron SB
No.
30006840-67-03
67–20–00 76–120A 96A FLIGHT CONTROLS - Tail Rotor All S-76 helicopters Refer to 10/29/82
Control System - Reassembly of CSN for
Tail rotor Control Cable System parts
(Supersedes basic CSN Msg CST- required
SPT-82-288)
67–20–00 76–124 112 FLIGHT CONTROLS - Tail Rotor S-76 SS Nos 76003, 76005 thru NPN 835 01/11/83
Control System - Station 215 76007, 760001 thru 7600238
Pulley Installation - Modifica-
tion of
67 - FLIGHT CONTROLS
PAGE 2
S-76A
CSN/ATA CROSS REFERENCE INDEX
67 - FLIGHT CONTROLS
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
67–20–00 76–133A 123A FLIGHT CONTROLS - Tail Rotor S-76 SS Nos 76003, 76005 thru 76070- 11/10/83
Controls Centering Quadrant - 76007, 760001 thru 760305 (SS 40006-
Incorporation of (Supersedes Nos 760004, 760009, 760016, 013
basic CSN) 760018, 760036, and 760046,
have been modified with a two-
piece ramp configuration and
self-centering quadrant assem-
bly)
67 - FLIGHT CONTROLS
PAGE 3
S-76A
CSN/ATA CROSS REFERENCE INDEX
67 - FLIGHT CONTROLS
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
67–00–00 76–142C 126C FLIGHT CONTROLS - Station 215 S-76A SS Nos 76003, 76005 thru Refer to 09/14/93
Pulley Bracket - Cable Inspec- 76007, 760001 thru 760238 Effec-
tion Slot and Holes - Incorpo- (Mod. Kit 76070-40005-011); tivity
ration of; Stabilizer Fitting S-76A SS Nos 76003, 76005 thru
and Access Door Flange - Modi- 76007, 760001 thru 760238 (Mod
fication of 76070-40011/Additional Pulley
Bracket Cutout-No kit re-
quired); All S-76 Models SS
Nos 76003, 76005 thru 76007,
and 760001 thru 760423 (Mod to
main gear box access door
flanges. No kit required)
67–00–00 76–152C 146C FLIGHT CONTROLS - Collective to All S-76A 76070- 05/22/89
Cyclic Coupling Limiter - In- 40010-
stallation of (Revises Revision 012
B)
67–15–00 76–173 184 FLIGHT CONTROLS - Main Rotor All configurations 76650-09805 Refer to 11/02/95
Servo Actuator Assembly - Modi- main rotor servo actuator as- CSN and
fication of Anti-Rotation Lugs; semblies (HRTextron part No. attached
Installation of Sacrificial 30006760) HRTex-
Washers; servo Support Bracket tron SB
Assembly - Inspection of No.
30006760-67-06
67 - FLIGHT CONTROLS
PAGE 4
S-76A
CSN/ATA CROSS REFERENCE INDEX
67 - FLIGHT CONTROLS
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
67–00–00 76–183 184 FLIGHT CONTROLS - Main Rotor All S-76 Models with 76650- Refer to 11/02/95
Servo Actuator Assembly - In- 09805 (30006760) main rotor attached
spection for Possible Missing servo actuator assemblies HRTex-
Outer Spring 30006822 in Main tron SB
rotor Servo Actuator Assembly No.
30006760 30006760-6707
67 - FLIGHT CONTROLS
PAGE 5
S-76A
CSN/ATA CROSS REFERENCE INDEX
71 - POWERPLANT
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
71–00–00 76–106A 93A POWERPLANT - Engine Chip Detec- SS Nos 76003, 76005 thru 76070- 06/01/82
tor Retention Plate - Installa- 76007, 760001 thru 760282 30022-
tion of (Revises CSN) 011
71–00–00 76–192 198 POWERPLANT - Purge Fuel Recov- S-76A and S-76C Helicopters Refer to 09/19/97
ery Kit - Installation of With Turbomeca Arriel 1S/1S1 CSN for
Engines Installed parts
required
71 - POWERPLANT
PAGE 1
S-76A
CSN/ATA CROSS REFERENCE INDEX
76 - ENGINE CONTROLS
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
76–10–01 76–46 103 OIL/ENGINE CONTROLS/ELECTRICAL SS Nos prior to 760200; SS Nos Refer to 09/30/82
POWER - Chafing Protection of prior to 760242; SS Nos prior CSN for
Oil and Hydraulic Lines to 760219 parts
required
76 - ENGINE CONTROLS
PAGE 1
S-76A
CSN/ATA CROSS REFERENCE INDEX
77 - ENGINE INDICATING
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
77–20–01 76–48B 37B ENGINE INDICATING - T5 Indicat- S-76 SS Nos prior to 76003, Refer to 04/23/81
ing System - Improvement of 76005 thru 76007, 760001 thru CSN for
Connector Pin Isolation (Re- 760166 (Not applicable to he- material
vises Revision A) licopters equipped with ECU) required
77–10–01 76–168 176 ENGINE INDICATING - No. 1 and All Arriel powered S-76A and None 12/07/93
No. 2 Engine Gas Generator N1 S-76C Models prior to and in-
Indicator System - Outside Air cluding SS No. 760417
Temperature (OAT) Probe Wiring
- Resistance Check of
77 - ENGINE INDICATING
PAGE 1
S-76A
CSN/ATA CROSS REFERENCE INDEX
79 - OIL
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
79–10–02 76–10 59 OIL - Engine Oil Cooler Blower SS Nos 76005 thru 76007, None 10/01/81
- Drain Hole - Incorporation of 760001 thru 760282
79–10–00 76–46 103 OIL/ENGINE CONTROLS/ELECTRICAL SS Nos prior to 760200; SS Nos Refer to 09/30/82
POWER - Chafing Protection of prior to 760242; SS Nos prior CSN for
Oil and Hydraulic Lines to 760219 parts
required
79–10–01 76–69A 56A OIL - Engine Oil Cooler - Addi- SS Nos 76003, 76005 thru Refer to 03/15/82
tion of Thermostat Poppet End 76007, 760001 thru 760212 attached
(Supersedes basic CSN) Supplier
Service
Bulletin
79-10-
01-1
79–10–01 76–82A 67A OIL - Engine Oil Cooler and SS Nos 76003, 76005 thru 76070- 08/02/83
Reservoir Vent Lines - Replace- 76007, 760001 thru 760210 30016-
ment of (Supersedes basic CSN) 011
79–00–00 76–110A 119A OIL - Engine Supplementary Oil SS Nos prior to 760327 without Refer to 06/01/84
Filtration (Supersedes basic EAPS or EAPS provisions (Mod. CSN
CSN) Kit 76070-30019-011) ; SS Nos
prior to 760327 with EAPS or
EAPS provisions (Mod. Kit
76070-30019-015
79 - OIL
PAGE 1
S-76A
CSN/ATA CROSS REFERENCE INDEX
79 - OIL
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
79–10–03 76–116 98 OIL - Oil Cooler SS Nos 76003, 76005 thru 76070- 07/07/82
Ducting/Forward Transverse Wall 76007, 760001 thru 760299 30013-
- H Seal Retainers - Incorpora- 011
tion of
79 - OIL
PAGE 2
S-76A
CSN/ATA CROSS REFERENCE INDEX
80 - STARTING
ATA NO. CSN NO. SEQ. TITLE EFFECTIVITY KIT NO. DATE
NO.
80–10–00 76–40B 68B STARTING - No. 1 and No. 2 Re- SS Nos prior to 760206 With 76070- 02/16/84
lay Panels - Overhead Control snow protection system in- 55024-
Panel - Continuous Ignition - stalled 013
Installation of Relays (Super-
sedes Revision A)
80 - STARTING
PAGE 1
S-76A
ALERT SERVICE BULLETIN INDEX
76-21-4A 295A AIR CONDITIONING SYSTEM - All S-76 helicop- None 02/24/98
Aero Aire Conditioning ters with Aero Aire
System - Soft-Start As- Air Conditioning
sembly - Inspection of System S-76A-1-2
installed
76–21 AIR CONDITIONING
PAGE 1
S-76A
ALERT SERVICE BULLETIN INDEX
76-21-5A 329A AIR CONDITIONING – Auto- All S-76 helicop- None 03/20/02
matic Cabin Temperature ters with Automatic
(C4) System — Cabin Temperature
Blower/Evaporator Module (C4) System deliv-
Assembly - Inspection ered prior to issue
Retrofit of date of this ASB.
76-22-3A 221A AUTO FLIGHT - SPZ-7000 S-76A and S-76B None 10/12/90
Digital Automatic Flight prior to and in-
Control System Air Data cluding SS No.
Sensor - Incorporation of 760339 with Sperry
Filter Assembly (Revises SPZ-7000 DAFCS ex-
basic ASB) cept SS Nos 760291,
760294 thru 760298,
760300 thru 760302
and 760304 (ASB is
not applicable to
S-76A with Tur-
bomeca Arriel en-
gines delivered
from Sikorsky)
76-22-4 240 AUTO FLIGHT - SPZ-7000 S-76A and S-76B None 09/26/88
Digital Automatic Flight prior to and in-
Control System (DAFCS) - cluding SS No.
Clevis Assembly Clamp — 760342 with Sperry
Replacement of SPZ-7000 DAFCS
76-22-5 244 AUTO FLIGHT - No. 1 and S-76A and S-76B Se- 76070-55060-011 12/01/88
No. 2 Automatic Flight ries prior to and
Control System (AFCS) including SS No.
Pitch and Roll Actuators 760367 with Hamil-
- Harnesses — Removal of ton Standard AFCS
Clamps - Installation of actuators
Tiedown Straps
76-22-6A 293A AUTO FLIGHT - AFCS Yaw All S-76 prior to None 07/08/97
Actuators - Wiring Har- and including SS
ness Clamping - One-Time No. 760469
Insp of (Supersedes Basic
ASB)
76–23 COMMUNICATIONS
76-23-2A 71A COMMUNICATIONS - ICS Sys- S-76 SS Nos 76003, 76070-60001-041 02/12/81
tem — Incorporation of 76005 thru 76007,
Separate Ground Wires 760001 thru 760107
(Supersedes basic CSB)
76–23 COMMUNICATIONS
PAGE 1
S-76A
ALERT SERVICE BULLETIN INDEX
76-24-6 131 ELECTRICAL POWER - Har- S-76 SS Nos prior None 11/02/81
ness Connector Wire In- to 760200
serts — Inspection for
Security
76-24-11 257 ELECTRICAL POWER - Lower S-76A Series and None 07/02/90
Circuit Breaker Panel As- S-76A Series
sembly - Load Shed Wiring Equipped with Tur-
Modification bomeca Arriel en-
gines with CAA con-
version kit option
76K0501
76–25 EQUIPMENT/FURNISHINGS
76–25 EQUIPMENT/FURNISHINGS
PAGE 1
S-76A
ALERT SERVICE BULLETIN INDEX
76–25 EQUIPMENT/FURNISHINGS
76–25 EQUIPMENT/FURNISHINGS
PAGE 2
S-76A
ALERT SERVICE BULLETIN INDEX
76–25 EQUIPMENT/FURNISHINGS
76–25 EQUIPMENT/FURNISHINGS
PAGE 3
S-76A
ALERT SERVICE BULLETIN INDEX
76–26–3 286D FIRE PROTECTION — DC Es- All S-76A, S-76B, None 01/15/96
sential Bus Circuit and S-76C Series
Breaker Panel — Addition prior to SS No.
of Diodes to Decrease 760441, Affects SS
Voltage to Fire Detector No. 762976 also.
Control Amplifiers
(Printed copy of Msg CBT-
TP-070, Rev 2)
76–28 FUEL
76-28-1 79 FUEL - Bonding Jumper As- S-76 SS Nos 76003, 76070-30004-011 10/30/80
semblies — Replacement 76005 thru 76007,
of; and Bonding Ground 760001 thru 760107
Check of Fuel Tank Supply
Lines
76-28-2B 201B FUEL - Vent Lines - Check S-76A prior to and 76070-30029-011 10/06/87
Valves — Installation of including SS No. (S-76A Part I);
(Supersedes Revision A) 760309, S-76B SS 76070–30029–013
Nos. 760262, (S-76B Part II)
760269, 760299,
760303, 760310 thru
760337
76–28 FUEL
PAGE 1
S-76A
ALERT SERVICE BULLETIN INDEX
76-29-2A 85A HYDRAULIC POWER - First S-76 SS Nos 76003, None 11/25/80
and Second Stage Pumps - 76005 thru 76007,
Replacement of (Revises 760001 thru 760111
basic CSB) and 760113
76-29-4 100 HYDRAULIC POWER - First S-76 SS Nos 76005 76070-65004-011 03/23/81
and Second Stage Hydrau- thru 76007, 760001
lic Modules — Installa- thru 760131
tion of Improved Pressure
Switch
76-29-5 111 HYDRAULIC POWER - Second SS Nos 76003, 76005 76070-65003-011 06/05/81
Stage Hydraulic Lines and thru 76007, 760001
First Stage Return Mani- thru 760156
fold - Replacement of;
Pressure Hoses - Left
Lateral Servo — Inter-
changing of
76-29-6A 237A HYDRAULIC POWER - Tail All S-76A and S-76B 76070-65003-011, 01/23/89
Rotor Servo Solenoid prior to and in- 76076-55035-012
Shutoff Valve - Incorpora- cluding SS No.
tion of (Revises basic 760352
ASB)
76-29-7 200 HYDRAULIC POWER - Second All S-76A, All None 11/18/86
Stage Hydraulic Lines - S-76B
Inspection of
76-29-8 247 HYDRAULIC POWER - Yaw S-76A and S-76B se- None 02/13/89
Control System - Pedal ries prior to and
Damper/Trim Actuator Tube including SS No.
Assembly - Inspection of 760348 with pedal
damper/trim actua-
tor
76-29-9A 252A HYDRAULIC POWER - Tail All S-76A and S-76B 76070-65003-011 09/01/89
Rotor Servo Solenoid helicopters prior
Shut-Off Valve System — to and including
Inspection of (Msg CBT- 760354 with tail
TP-89–119 supersedes ba- rotor servo sole-
sic Bulletin Msg CBT-TP- noid valve (Mod Kit
89-116) 76076-65003-011)
installed by Sikor-
sky Aircraft
76-29-10A 289A HYDRAULIC POWER - ABEX All S-76A Models ABEX Kit No. 03/20/97
Hydraulic Pump Assembly - with 76650-09808- 60829
External Drive Shaft 101 hydraulic pump
Modification - Incorpora-
tion of (Supersedes Basic
ASB)
76-30-4 104 ICE AND RAIN PROTECTION - S-76 SS Nos 76003, 76070-20029-011 04/23/81
Windshield Wiper Motor - 76005 thru 76007,
Installation of Electri- 760001 thru 760117,
cal Grounding Jumper As- 760120 thru 760131
sembly and 760134
76-30-5 86 ICE AND RAIN PROTECTION - S-76 (Refer to Bul- 76076-30006-012 11/19/80
Engine Inlets Snow Pro- letin for SS Nos)
tection System - Incorpo-
ration of Latest Configu-
ration
76-30-6 92 ICE AND RAIN PROTECTION - All S-76 helicop- 76070-55015-011, 02/12/81
Engine Inlets Snow Pro- ters with snow pro- —012 and E093451
tection System - Replace- tection system in-
ment of Thermal Switches stalled as of issue
date of this CSB
76-32-4 41 LANDING GEAR - Second S-76 SS Nos 76005 NPN 779 02/04/80
Stage Hydraulic System - thru 76007, 760001
Relocation of Return thru 760046
Check Valve
76-32-5A 66A LANDING GEAR - Extension S-76 SS Nos 76003, 76070-55006-011 01/27/81
and Retraction System - 76005 thru 76007, 76070-55011-011
Incorporation of Time- 760001 thru 760107
Delay System (Supersedes
basic CSB)
76-32-6A 50A LANDING GEAR - Control S-76 SS Nos 76003, None 12/18/81
Valve — Replacement of 76005 thru 76007,
(Supersedes basic CSB) 760001 thru 760071,
760073 thru 760149,
760151 thru 760163,
760166 thru 760169,
760174, 760176,
760177, 760187,
760189, 760196,
760201 thru 760244
76-32-7 103 LANDING GEAR - Main Flo- S-76 SS Nos prior 76070-25002-011 04/21/81
tation Gear — Incorpora- to 760117 equipped
tion of Tiedown Ring with emergency flo-
Spring Guards tation system
76-32-8 108 LANDING GEAR - Main — S-76 SS Nos prior None 05/13/81
(P) Flotation Gear — Replace- to 760199
ment of Landing Gear Door
Explosive Links
76-32-9A 128A LANDING GEAR - Main S-76A SS Nos 76007, 76070-20032-011 10/27/81
Floats - Flotation System 760001 thru 760109 (Modifies SS No.
Attachment Cable Fit- With emergency flo- 760109 and
tings, Straps, and Dou- tation system or prior); 76070-
blers - Inspection for provisions in- 20032-012 (Modi-
Proper Location; Instal- stalled (Inspection fies SS No.
lation of Exterior Dou- for mislocated sup- 760110 thru
blers (Revises basic CSB) port structure and 760198)
installation of ex-
terior doubler re-
quired); SS Nos
760110 thru 760198
With emergency flo-
tation system or
provisions in-
stalled (Installa-
tion of exterior
doubler required)
76-32-10A 140A LANDING GEAR - Main Land- All Model S-76 he- None 12/17/85
ing Gear Positioning Rod licopters prior to
and Lower Drag Brace Rod SS No. 760308 not
End Assemblies - One-Time modified per CSN 76-
Inspection of (Revision A 134 (Latest Revi-
Msg CST—SPT—82–654 super- sion)
sedes basic ASB Msg CST-
SPT—82–635)
76-32-12B 124B LANDING GEAR - Extension S-76 SS Nos prior None 01/07/82
and Retraction System - to 760215
Modification of Electrical
Circuit (Supersedes Revi-
sion A)
76-32-14 144 LANDING GEAR - Nose Land- All S-76 helicop- None 03/15/83
ing Gear Actuator - In- ters delivered as
spection for Chips and of the date of this
Worn Locking Keys with ASB
End Cap Removed
76-32-17B 158B LANDING GEAR - Nose and All S-76 helicop- None 06/01/98
Main Gear Actuators - ters delivered
Shuttle Valve - Replace- equipped with com-
ment of (Supersedes Revi- ponents listed in
sion A) ASB
76-32-18 169 LANDING GEAR - Nose Land- S-76A SS Nos 76003, Refer to ASB 09/10/85
ing Gear Shutoff Valve - 76005 thru 76007,
Installation of 760001 thru 760332
(This ASB is not
applicable is CSN
No. 76–138 and ap-
plicable revisions
has been complied
with)
76-32-19A 170B LANDING GEAR - Emergency All installed S-76 None 12/02/85
Flotation System - Popout nose and main emer-
Floats - Inspection of gency floats part
(Supersedes basic ASB Msg Nos 76251-01101 se-
CBT-TP-85–099 and Amend- ries and 76251-
ment No. 1 Msg CBT-TP- 01102 series
85–107)
76–32 LANDING GEAR
PAGE 5
S-76A
ALERT SERVICE BULLETIN INDEX
76-32-20A 191A LANDING GEAR - Life Limi- S-76A, Component None 01/10/95
tations Parts, Serializa- 1944 and 1945 se-
tion and Log Card Entry ries landing gear
(Supersedes basic ASB
76-32-21 177 LANDING GEAR - Emergency S-76A SS Nos 76003 76070-65014-011 04/22/86
Extension System - Mount- thru 76007, 760001
ing Bracket and Cable thru 760320; S-76B
Clamp - Installation of SS Nos 760262,
760269, 760299,
760303, 760310 thru
760317
76–32–24 281 LANDING GEAR — Braking All S-76 Models, None 11/23/94
System — Wheel Brakes Component:
Master Cylinder — Removal 76250–01101–103
of Check Valve from Vent wheel braking sys-
Caps tem master cylinder
76–32–25A 290A LANDING GEAR — Main Land- All S-76 Models, None 1/12/98
ing Gear Aft Jury Brace - Component: 1945E-72
Inspectin and Repair or and 1945E-72A aft
Replacement of jury brace
76-32-26A 316A LANDING GEAR - Main Land- All S-76 Models Refer to BFGoo- 09/20/00
ing Gear Positioning Rod prior to and in- drich SB No.
and Side Brace Rod End - cluding 760513. In- 76A-32-03 Revi-
Inspection and Repair of cluding Spares. sion 1
76-32-27 LANDING GEAR - Brake As- All S-76 helicop- None 04/30/02
sembly - Rotating Disc - ters with brake as-
Inspection of semblies 5007555,
and 5007555-1, de-
livered prior to
issue date of this
ASB.
76-32-28 LANDING GEAR - Brake As- All S-76 helicop- None 05/17/02
sembly - Rotating Disc - ters with brake as-
Inspection of semblies 5007555-2,
delivered prior to
issue date of this
ASB.
76-33-1 296 LIGHTING SYSTEM - Landing Refer to ASB Refer to ASB for 1/12/98
Light Circuitry - Modifi- parts required
cation of
76-33-2 301 LIGHTS - Belly Mounted Refer to ASB Refer to ASB for 11/25/98
Anti-Collision Light - parts required
Inspection and Modifica-
tion of Wiring; Inspec-
tion of Helicopter Tub
and Light Lens Drain
Holes for Obstructions
76-33-3 309 ELECTRICAL SYSTEMS - SX - All S-76 Models Refer to ASB for 03/08/00
16 and SX - 5 Nightsun equipped with SX-16 parts required
Searchlight - One-Time and SX-5 Nightsun
Inspection of Searchlight.
76-33-4 LIGHTING SYSTEM - Rotor All S-76 helicop- Refer to ASB for 10/04/03
Disc Light - Installation ters with Rotor parts required
of Disc Light Instal-
lation 33776-84938.
76–34 NAVIGATION
76-34-4 214 NAVIGATION - Tail Cone S-76A series with 76070-20095-011 06/30/87
Heated Static Port In- heated static ports
stallations - Modification P/N A021-1 in-
of stalled (Note:
Sperry DDAFCS
—equipped helicop-
ters have this
heated static port)
76-34-5 235 NAVIGATION - Dual Alter- S-76A prior to and None 06/15/88
nate Static Source In- including 760298;
stallation - Inspection S-76B prior to and
of (Msg CBT-TP-88–055) including 760338
with
33776–84052–011
Dual Alternate
Static Source In-
stallation
76–34 NAVIGATION
PAGE 1
S-76A
ALERT SERVICE BULLETIN INDEX
76–34 NAVIGATION
76-34-11 NAVIGATION - LCR-100 At- All S-76 model he- 76070–60019–011 05/17/10
titude, Heading, and Ref- licopters equipped
erence System - Inspec- with No. 1 and No.
tion of 2 LRC-100 AHRS
units, including
all spare LCR-100
AHRS units in stock
76–34 NAVIGATION
PAGE 2
S-76A
ALERT SERVICE BULLETIN INDEX
76–52 DOORS
76-52-3 88 DOORS - Crew and Hinged S-76 SS Nos 76003, NPN 797 01/16/81
Passenger Doors - Instal- 76005 thru 76007,
lation of Retention 760001 thru 760047,
Plates and Cockpit Canopy 760049 thru 760061,
Drain Tube Extension 760063 thru 760080
76–52 DOORS
PAGE 1
S-76A
ALERT SERVICE BULLETIN INDEX
76–52 DOORS
76-52-6 152 DOORS - Left and Right All S-76 helicop- None 12/22/83
Sliding Doors — Secondary ters with left
Locking Mechanism — Check and/or right slid-
for Proper Adjustment ing doors delivered
prior to issue date
of this ASB
76-52-7A 178A DOORS - Left and Right S-76A and S–76B 76070-20084-011 10/03/86
Sliding Doors — Latching With right sliding (Left Sliding
and Locking Mechanisms — door (option Door);
Modification of; Access 76K0005) and/or 76070–20084–012
hole — Incorporation of left sliding door (Right Sliding
(Revises basic ASB and (Option 76K0005A) Door)
incorporates Amend. No. 1
Msg CBT-TP-86–053)
76-52-8 172 DOORS - Left and Right All Model S-76 he- None 12/11/85
Sliding Doors — Inspec- licopters with
tion of Door Track At- sliding doors de-
tachment Screws for Secu- livered prior to
rity this ASB
76-52-9C 197C DOORS - Cockpit and Pas- All S-76 series None 08/18/89
senger Door Support Pins prior to and in-
- Replacement of (Super- cluding SS No.
sedes Revision B) 760350
76–52 DOORS
PAGE 2
S-76A
ALERT SERVICE BULLETIN INDEX
76–52 DOORS
76-52-10A 212A DOORS - Left and Right All S-76A and S-76B None 08/27/87
Passenger Doors - Elec- helicopters
trical Door Locking Ac- equipped with elec-
tuators - Temporary Re- trical door locks,
moval of (Supersedes Option 76K0066
basic ASB Msg CBT-TP- (Mod. 76088-20016)
87–046)
76-52-11 239 DOORS - Left and Right S-76A and S-76B se- 76070-20097-011 07/15/88
Passenger Doors - Elec- ries helicopters
trical Door Locks — Lever with electrical
Assembly - Replacement door lock actuator,
of; Electrical Actuator - GM Cadillac Divi-
Reinstallation of sion P/N 22020256,
removed per ASB No.
76—52–10A
76-52-12 229 DOORS - Window Frame In- All S-76A and S-76B None 01/29/88
spection — Trim Option - series
Modification (Msg CBT-TP-
88–012)
76-52-13A 297A DOORS - Sliding Door Es- All S-76 prior to Refer to ASB for 07/15/98
cape Hatch Assembly Jet- 760479 parts required
tison Mechanism - Modifi-
cation of
76–52 DOORS
PAGE 3
S-76A
ALERT SERVICE BULLETIN INDEX
76–53 FUSELAGE
76–53 FUSELAGE
76–53 FUSELAGE
PAGE 2
S-76A
ALERT SERVICE BULLETIN INDEX
76–53 FUSELAGE
76-53-13 49 FUSELAGE - Engine Air In- S-76 SS Nos 76003, 76070-30002-011 03/14/80
let Cowl and Aft Cowl 76005 thru 76007,
Latch Assemblies - Modi- 760001 thru 760047
fication of
76–53 FUSELAGE
PAGE 3
S-76A
ALERT SERVICE BULLETIN INDEX
76–53 FUSELAGE
76-53-16 82 FUSELAGE - Engine Air In- S-76 SS Nos 76003, None 11/12/80
let Screen Assembly — Re- 76005 thru 76007,
placement of 760001 thru 760144
76–53 FUSELAGE
PAGE 4
S-76A
ALERT SERVICE BULLETIN INDEX
76–53 FUSELAGE
76-53-20 118 FUSELAGE - Fire Extin- S-76 SS Nos 76005 76070-30006-011 07/16/81
(P) guishing Containers Sup- thru 76007, 760001
port Bracket — Replace- thru 760178
ment of
76-53-21 114 FUSELAGE - Engine Aft S-76 SS Nos 760058 76070-30011-011 06/15/81
Cowl - Modification of thru 760183
Forward Support Struts —
Replacement of Aft Sup-
port Strut Brackets
76–53 FUSELAGE
PAGE 5
S-76A
ALERT SERVICE BULLETIN INDEX
76–53 FUSELAGE
76-53-22 117 FUSELAGE - Heating and S-76 SS Nos prior 76070-20041-011 06/26/81
Venting Sealing of Duct- to 760230
ing and Installation of
Access Cover
76-53-25 161 FUSELAGE - Engine Com- All S-76A helicop- None 09/26/84
partment Center Firewall ters with CSN No.
- Inspection and Modifi- 76-111 installed
cation of Forward Section
Center Firewall
76–53 FUSELAGE
PAGE 6
S-76A
ALERT SERVICE BULLETIN INDEX
76–53 FUSELAGE
76-53-26 166 FUSELAGE - Doubler In- S-76A (Note: This None 05/28/85
stallation — Station 215, Bulletin is not ap-
Left Side plicable, if CSN
No. 76–150 (Mod.
Kit 76070–20511–012
or —013) or CSN No.
76–151 (Mod. Kit
76070–20072–011)
has been complied
with.)
76-53-27 179 FUSELAGE - Upper Fuselage S-76A SS Nos 76003 76070-20085-011 05/14/86
— Station 300 - Left Side thru 76007, 760001
- Stainless Steel Straps thru 760338
- Installation of
76-53-30A 227A FUSELAGE - Vertical Sta- S-76A series, S-76B 76070-20092-012 10/05/88
bilizer — Access Cover series prior to and
and Removable Intermedi- including SS No.
ate Gear Box Inlet Fair- 760369
ings — Incorporation of
(Revises basic ASB)
76–53 FUSELAGE
PAGE 7
S-76A
ALERT SERVICE BULLETIN INDEX
76–53 FUSELAGE
76–53–35A 280A FUSELAGE — Engine Com- S-76A series prior 76070–30031–011 02/21/95
partment — Center Fire- to and including SS
wall Assemblies — Modifi- No. 760382 with Al-
cation of (Revises basic lison Model 250C30
ASB) engines
76-53-37 265 FUSELAGE - Aft Engine S-76A equipped with None 10/16/91
Cowling — Forward and Aft Turbomeca Arriel 1S
Latches - Inspection for engines prior to &
Security (Msg CBT-TP- including SS No.
91–214) 760373
76-53-39A 294A FUSELAGE - Main Rotor Py- All S-76 prior to 76071-21000-011 10/13/97
lon Forward Fairing and SS No. 760476
Tail Gear Box Fairing -
Rework to Prevent (DAFCS)
Electro-Magnetic Inter-
ference (EMI) (Supersedes
Basic ASB)
76–53 FUSELAGE
PAGE 8
S-76A
ALERT SERVICE BULLETIN INDEX
76–55 STABILIZERS
76–55 STABILIZERS
PAGE 1
S-76A
ALERT SERVICE BULLETIN INDEX
76–55 STABILIZERS
76–55 STABILIZERS
PAGE 2
S-76A
ALERT SERVICE BULLETIN INDEX
76–55 STABILIZERS
76-55-11A 167A STABILIZERS - Vertical S-76A (This Bulle- Refer to CSN 76- 08/22/85
Stabilizer — Forward and tin is not appli- 141
Aft Spars - Reinforcement cable if CSN No.
of (Supersedes basic ASB) 76-141 (latest re-
vision) has been
complied with)
76–55 STABILIZERS
PAGE 3
S-76A
ALERT SERVICE BULLETIN INDEX
76–55 STABILIZERS
76–55 STABILIZERS
PAGE 4
S-76A
ALERT SERVICE BULLETIN INDEX
76–55 STABILIZERS
76–65 ROTORS
76-65-1A 11A ROTORS - Main Rotor Head S-76 SS Nos. 76005 None 07/29/80
- Inspection of Attach- and 76007, SS Nos
ment Bolts at Inboard End 760001 thru 760051
of Damper Assemblies and
at Lower End of Pitch
Control Rods (Supersedes
basic CSB)
76-65-3B 20B ROTORS - Pitch Control S-76 SS Nos 76005 NPN 768 03/05/80
Rod Assemblies - Inspec- and 76006, 760001
tion for Proper Assembly; thru 760054
Installation of Nylon
Washer Bumpers (Revises
Revision A)
76–65 ROTORS
PAGE 1
S-76A
ALERT SERVICE BULLETIN INDEX
76–65 ROTORS
76-65-6A 23A ROTORS - Main Rotor Head S-76 SS Nos. 76003, None 03/25/80
- Inspection and Replace- 76005 and 76006,
ment of Bifilar-to-Spacer 760001 thru 760015
Attachment Bolts and Nuts
(Supersedes basic CSB)
76–65 ROTORS
PAGE 2
S-76A
ALERT SERVICE BULLETIN INDEX
76–65 ROTORS
76–65 ROTORS
PAGE 3
S-76A
ALERT SERVICE BULLETIN INDEX
76–65 ROTORS
76-65-16 76 ROTORS - Main Rotor Head S-76 — All damper None 10/13/80
- Inspection of Damper assemblies prior to
Cylinder Assembly End Cap Serial No. A061-
Attachment Bolts 00286
76-65-17B 78B ROTORS - Main Rotor Hub S-76 SS Nos 76003, *76070-10005- 02/10/81
Subassembly and Rotating 76005 thru 76007; 011; **76070-
Scissors Assembly - Modi- *SS Nos. 760001 10005-012
fication of (Revises Revi- thru 760135; **SS
sion A) Nos. 760001 thru
760174 (*With hub
subassembly
76103–08010–043
installed)(**With
rotating scissors
assembly
76104–08020–044 in-
stalled)
76–65 ROTORS
PAGE 4
S-76A
ALERT SERVICE BULLETIN INDEX
76–65 ROTORS
76–65 ROTORS
PAGE 5
S-76A
ALERT SERVICE BULLETIN INDEX
76–65 ROTORS
76-65-23A 102A ROTORS - Main Rotor Blade S-76 — All in- 76080-15002-011 08/11/81
- Modification of Balance stalled and spare
Weights; Replacement of main rotor blades
Tip Plate Assembly Bolts part No. 76150-
(Supersedes basic ASB) 09000 series and
76150-09100-041,
-042 and -043 de-
livered as of issue
date of this CSB
76-65-25 119 ROTORS - Bifilar Vibration S-76 SS Nos. 76005 76070-10009-011 07/16/81
Absorber - Replacement of thru 76007, 760001
Spacer thru 760198
76–65 ROTORS
PAGE 6
S-76A
ALERT SERVICE BULLETIN INDEX
76–65 ROTORS
76-65-30 133 ROTORS - Main Rotor Ro- S-76 SS Nos. 76005 76070-10005-013 11/13/81
tating Scissors Assembly thru 76007, 760001 and -014
- Incorporation of Im- thru 760214
proved Scissors Assembly
76-65-33 138 ROTORS - Tail Rotor In- All S-76 helicop- None 06/15/82
stallation — Retaining ters delivered as
Washer - Inspection and of issue date of
Replacement of this ASB
76-65-34A 142A ROTORS - Main Rotor Blade S-76A and S-76B se- None 01/31/91
- Inspection of Spar Tip ries
End
76–65 ROTORS
PAGE 7
S-76A
ALERT SERVICE BULLETIN INDEX
76–65 ROTORS
76-65-36B 165B ROTORS - Main Rotor Blade All S-76A main ro- None 12/23/85
- Tip Block Assembly Bolt tor blades prior to
Holes & Tip End Assembly Serial No. A086-
- Inspection of (Revises 01461 with 76150-
Revision A) 09016-041 or -042
tip block (C-block)
assembly installed
76-65-37 193 ROTORS - Tail Blade - In- S-76A tail rotor None 09/12/86
spection of (Msg CBT-TP- blade assemblies
86–063) P/N
76101–05001–044,
—045,
76101–05101–041;
S-76B tail rotor
blade assemblies
P/N
76101–05501–041,
—042
76–65 ROTORS
PAGE 8
S-76A
ALERT SERVICE BULLETIN INDEX
76–65 ROTORS
76-65-38 195 ROTORS - Tail Blade - In- S-76A tail rotor None 09/18/86
spection of blade assemblies
P/N 76101-05001-
044, -045, 76101-
05101-041; S-76B
tail rotor blade
assemblies P/N
76101-05501-041,
-042
76-65-40A 217A ROTORS - Tail Rotor All S-76A series, None 03/18/88
Blades — Computed Tomo- All S-76B series
graphic (CT) Inspection
of Spar (Revises basic
and includes Amend. No.
1)
76–65 ROTORS
PAGE 9
S-76A
ALERT SERVICE BULLETIN INDEX
76–65 ROTORS
76-65-41A 249A ROTORS - Tail Rotor Blade S-76A series heli- None 11/14/89
Assemblies — Serializa- copters with
tion Marking of Pitch 76101–0501 and
Change Horn Assemblies 76101–05101 tail
(Supersedes basic Bulle- rotor blade assem-
tin) blies, prior to and
including tail ro-
tor blade S/N
A137–00826; S-76B
series helicopters
with 76101–05501
tail rotor blade
assemblies, prior
to and including
tail rotor blade
S/N A245–00126
76-65-42B 260B ROTORS - Main Rotor Blade S-76A and S-76B se- None 03/11/91
- Tip Plate Retention ries — All main ro-
Bolts - One-Time Inspec- tor blade assem-
tion of (Revises Revision blies prior to and
A) including S/N
A086–01800
76–65 ROTORS
PAGE 10
S-76A
ALERT SERVICE BULLETIN INDEX
76–65 ROTORS
76-65-43B 275B ROTORS - Tail Rotor Blade All S-76 models None 07/14/93
Assemblies — Bumper and prior to SS No.
Bumper Pad Installation — 760414
One-Time Inspection for
Proper Gap (Msg CBT-TP-
93-067 Rev. 2 supersedes
ASB No. 76–65-43A (Msg
CBT-TP-93–067 Rev. 1)
76-65-44 276 ROTORS - Tail Rotor Blade All S-76 models None 07/26/93
Assembly — Horn Assem- prior to SS No.
blies - Inspection of; 760414
Fiberglass Fairing Assem-
blies — Modification of
76-65-45A 278A ROTORS - Tail Rotor Con- All S-76 Models None 06/08/94
trol Rod Assemblies - Rod prior to and in-
Ends - Inspection for cluding SS No.
Cracks (Supersedes basic 760402, excluding
ASB) SS Nos 760385 and
760386
76-65-46 288 ROTORS - Tail Rotor All S-76 Models None 08/09/96
Blades - One-Time Inspec-
tion of
76–65 ROTORS
PAGE 11
S-76A
ALERT SERVICE BULLETIN INDEX
76–65 ROTORS
76-65-47 299 ROTORS - Swashplate As- All S-76 Models None 07/31/98
sembly - Uniball Bearing prior to SS No.
Retainer Bolts - One-Time 760488
Inspection and Replace-
ment of
76-65-48 305 ROTORS - Main Rotor Blade Refer to ASB None 03/17/99
- Leading Edge
Strip/Skin; One-Time
Coin-Tap and Visual In-
spection
76-65-49A 310A ROTORS - Main Rotor Hub All S-76 None 05/19/00
One-Time Inspection for Component: Main Ro-
Main Rotor Hub to Horn tor Hub Part Number
Contact 76103-08010-049
Serial Numbers
A027-01071 thru
A027-01116
76-65-50 311 ROTORS - Main Rotor Blade S-76 main rotor None 05/25/00
- Root End Pocket Inspec- blades
tion
76–65 ROTORS
PAGE 12
S-76A
ALERT SERVICE BULLETIN INDEX
76–65 ROTORS
76-65-51 315 ROTORS - Main Rotor Blade S-76A, S-76B, and None 07/28/00
- Main Rotor Spar - In- S-76C including
spection spares.
76150-09000 ans
76150-09100 series
main rotor blades.
76-65-52 321 ROTORS - Main Rotor All S-76 Except se- None 07/24/01
Spindle Assemblies - One- rial numbers
Time Inspection of 760501, 760506,
Spindle Attachment Bolts thru 760515
Component: Main Ro-
tor Spindle Attach-
ment NAS626-9 Bolts
76-65-54A ROTORS - Main Rotor Head All S-76 helicop- None 05/03/02
Damper Piston Rod ters delivered
Assembly- One Time Check prior to the issue
of date of this ASB
76–65 ROTORS
PAGE 13
S-76A
ALERT SERVICE BULLETIN INDEX
76–65 ROTORS
76-65-55A ROTORS - Main Rotor Blade All S-76 helicop- None 07/25/02
- Lightning Strike Re- ters
moval from Service Component: All S-76
main rotor blades
76-65-56 ROTORS - Main Rotor Blade All S-76 helicop- None 08/09/02
- One-Time Inspection of ters
Main Rotor Blades 9Two- Component: All S-76
Piece Titanium Leading main rotor blades
Edge Sheath9 with a two piece
titanium sheath
76-65-57 ROTORS - Main Rotor Blade S-76 Main Rotor None 12/23/02
- Leading Edge Strip/Skin Blades 76150-09000
- Visual Inspection of and 76150-09100 se-
ries
76-65-59 ROTORS - Main Rotor Hub, All S-76A and S-76B None 11/19/03
Spindle, Swashplate, and model helicopters.
Tail Rotor Outboard Re-
taining Plate Assemblies
- Reidentification of
76–65 ROTORS
PAGE 14
S-76A
ALERT SERVICE BULLETIN INDEX
76–65 ROTORS
76-65-62 ROTORS - Main Rotor As- All S-76 Model he- None 12/14/04
sembly - Lower Bifilar licopters with
Support - One-Time In- bifilar support with
spection of a total time
greater than 1500
flight hours as of
the issue date of
this ASB.
76-65-63B ROTORS - Main Rotor Hub S-76 MRHs including None 04/21/05
(MRH) - One-Time Check spares.
and Recurring Daily Vi-
sual 10X Magnification In-
spection
76–65 ROTORS
PAGE 15
S-76A
ALERT SERVICE BULLETIN INDEX
76–65 ROTORS
76–65 ROTORS
PAGE 16
S-76A
ALERT SERVICE BULLETIN INDEX
76–66 POWERTRAIN
76-66-5A 67A POWERTRAIN - Main Gear S-76 SS Nos 76005 None 02/20/81
Box Oil Cooler Blower - thru 76007, 760001
Addition of Screen (Re- thru 760100
vises basic CSB)
76–66 POWERTRAIN
PAGE 1
S-76A
ALERT SERVICE BULLETIN INDEX
76–66 POWERTRAIN
76-66-6B 73B POWERTRAIN - Main Gear S-76 SS Nos 76003, None 07/07/81
Box Oil Cooler Blower - 76005 thru 76007,
Replacement of Impeller 760001 thru 760142
(Supersedes Revision A)
76-66-8A 112A POWERTRAIN - Rotor Brake S-76 SS Nos 76005 76070-55023-013 09/30/81
- Addition of Shield As- thru 76007, 760001
semblies (Supersedes ba- thru 760191
sic CSB)
76-66-9A 109A POWERTRAIN - Rotor Brake S-76 SS Nos. 76005 None 06/19/81
- Inspection for Clear- thru 76007, 760001
ance Between Pucks and thru 760170
Disc (Supersedes basic
ASB)
76-66-10B 113B POWERTRAIN - Rotor Brake S-76 SS Nos 76003, 76070-55023-011 11/25/81
System — Installation of 76005 thru 76007,
Warning Relay (Revises 760001 thru 760189
Revision A)
76–66 POWERTRAIN
PAGE 2
S-76A
ALERT SERVICE BULLETIN INDEX
76–66 POWERTRAIN
76-66-11 219 POWERTRAIN - Main Gear S-76A and S-76B None 08/17/87
Box Lower Housing - Jet
Port Liners - Inspection
for Proper Stake Pinning
76-66-15B 132B POWERTRAIN - Rotor Brake All S-76 helicop- None 10/29/82
— Temporary Deactivation ters delivered as
(Supersedes Revision A) of issue date of
this CSB with
76363-09101-101 ro-
tor brake assem-
blies
76–66 POWERTRAIN
PAGE 3
S-76A
ALERT SERVICE BULLETIN INDEX
76–66 POWERTRAIN
76-66-18A 156A POWERTRAIN — Tail Gear All S-76 helicop- None 03/28/84
Box - Pitch Change Shaft ters with 76000-
Assembly — Check for 05100-043 or -045
Axial Play (Msgs CBT-TP- pitch change shaft
84–027 and CBT-TP-84–033) assembly QCU
76–66 POWERTRAIN
PAGE 4
S-76A
ALERT SERVICE BULLETIN INDEX
76–66 POWERTRAIN
76-66-20 168 POWERTRAIN - Tail Drive Bearing support as- None 07/25/85
Shaft Bearing Support As- sembly bearings,
sembly — Inspection of P/N SB1138–101,
Bearing (Msg CBT-TP- manufactured by
85–080) MRC, installed that
have accumulated
less than 100 flight
hours and all spare
bearing shipped
prior to July 25,
1985
76–66 POWERTRAIN
PAGE 5
S-76A
ALERT SERVICE BULLETIN INDEX
76–66 POWERTRAIN
76-66-23B 246B POWERTRAIN - Main Gear All S-76A series None 02/21/91
Box — Tail Takeoff Flange with main gear box
Locknut — Inspection of assembly P/N
(Revises Revision A) 76351–09500 series
except for assem-
blies with rear
cover assembly P/N
76351–09050–047 and
subsequent; S-76B
series with main
gear box assembly
P/N 76351–09600 se-
ries prior to and
including S/N
A231–00038
76–66 POWERTRAIN
76-66-26 267 POWERTRAIN - Tail Rotor All S-76 models None 01/09/92
Drive Shaft — Bearing
Support Assemblies - Re-
placement of
76-66-27 266 POWERTRAIN - Tail Gear All S-76A, S-76B, None 01/08/92
Box Assembly Output Shaft and S-76C series
- One Time Inspection of prior to and in-
cluding SS No.
760390
76-66-28 268 POWERTRAIN - Tail Gear All S-76A models None 03/16/92
Box Output Housing Assem-
bly - Inspection for
Presence of Lubrication
Hole (Msg CBT-TP-92–053)
76–66 POWERTRAIN
PAGE 7
S-76A
ALERT SERVICE BULLETIN INDEX
76–66 POWERTRAIN
76–66–29A 279A POWERTRAIN, Main Gear Box All S-76 models None 07/10/95
— No. 1 Input Bevel Pin- prior to and in-
ion Housing Assembly — cluding SS No.
Inspection and Incorpora- 760430 with
tion of Improvements (Su- 76351–09600 series
persedes basic Bulletin) main gear box as-
sembly Serial No.
prior to and in-
cluding A231–00147
76–66–30A 312A POWERTRAIN, Main Gear Box All S-76 models None 06/16/00
Installation — Barrel Nut Component: LH2577-
Inspection 080 barrel nuts
with lot 06 or 09
markings
76–66–31B 318B POWERTRAIN, Main Gear Box All S-76 models None 11/07/00
- One-Time and Repetitive Component: 76351-
Non Destructive Inspec- 09000 Series, 09500
tion (NDI) of the Main Series, 09600 Se-
Rotor Shaft Assembly ries Main Gear Box
Assembly. Contain-
ing 76351-09030 Se-
ries and 76351-
09630 Series Main
Rotor Shaft Assem-
bly.
76–66 POWERTRAIN
PAGE 8
S-76A
ALERT SERVICE BULLETIN INDEX
76–66 POWERTRAIN
76–66–32A 319A POWERTRAIN, Main Gear Box All S-76 models None 01/17/01
- Removal from Service
and Repetitive Non De-
structive Inspection
(NDI) Certain Serial Num-
ber Main Rotor Shafts.
76–66–33 322 POWERTRAIN, Main Gear Box All S-76 models None 07/27/01
- One-Time Visual Inspec-
tion of the Main Gear Box
Support Beam Barrel Nut
Bore
76–66–34 326 POWERTRAIN, Main Gear Box All S-76 models None 11/02/01
- Rotor Brake Disc - One-
Time Visual Inspect of
76–66 POWERTRAIN
PAGE 9
S-76A
ALERT SERVICE BULLETIN INDEX
76–66 POWERTRAIN
76–66–38 POWERTRAIN - Tail Rotor All S-76 model he- None 02/27/03
Drive Shaft Viscous licopters
Damper Bearing Calendar
Replacement
76–66–39 POWERTRAIN - Tail Gear- All S-76A model he- None 11/20/03
box, Output Flange, Out- licopters.
put Shaft, and Main Gear-
box Housing assemblies -
Reidentification of
76–66 POWERTRAIN
76–66–43 POWERTRAIN - Main Gear All S-76A model he- None 04/20/06
Box (MGB) - Main Gear Box licopters including
Rear Cover Assembly - those with Arriel
One-Time Visual Inspec- 1S and 1S1 engines
tion for Chafing Damage (including spares
and spares in the
overhaul cycle)
76–66 POWERTRAIN
PAGE 11
S-76A
ALERT SERVICE BULLETIN INDEX
76–66 POWERTRAIN
76–66 POWERTRAIN
PAGE 12
S-76A
ALERT SERVICE BULLETIN INDEX
76–66 POWERTRAIN
76–66–49A POWERTRAIN - Main Gear All S-76 model he- None. 09/17/09
Box (MGB) - One-Time Oil licopters delivered
Analysis of prior to the re-
lease date of this
Alert Service Bul-
letin (ASB).
Component: MGB
76351–09000,
76351–09500, and
76351–09600 series,
76–66 POWERTRAIN
PAGE 13
S-76A
ALERT SERVICE BULLETIN INDEX
76-67-8A 80A FLIGHT CONTROLS - Main S-76 SS Nos 76003, 76070-65001-011 10/14/81
and Tail Rotor Servo Ac- 76005 thru 76007,
tuators - Installation of 760001 thru 760115
Improved Pressure
Switches (Supersedes ba-
sic CSB)
76-67-10A 55A FLIGHT CONTROLS - Upper S-76 SS Nos 76003, 76070-40003-011 09/02/80
Deck - Tail Rotor Con- 76005 thru 76007,
trols - Forward Quadrant 760001 thru 760075
— Installation of Shims
Under Torque Tube Upper
and Lower Bearing Sup-
ports (Revises basic CSB)
76-67-14B 125B FLIGHT CONTROLS - Main All installed and None 06/25/82
Rotor Servo — One Time spare S-76 main ro-
Check for Presence of tor servo actuators
Passage in Balance Tube prior to S/N 0743
Return Fluid Circuit (Su- (See ASB for excep-
persedes Revision A) tions)
76-67-16 150 FLIGHT CONTROLS - Tail All model S-76 he- None 07/20/83
Rotor Control Cable and licopters delivered
Collar Installation — In- as of issue date of
spection of this Bulletin
76-67-17 157 FLIGHT CONTROLS - Tail All S-76 helicop- None 03/22/84
Rotor Control Cable Turn- ters delivered
buckles - Inspection of prior to issue date
of this ASB
76-67-18A 173A FLIGHT CONTROLS - Viscous S-76A series prior 76070-40009-011 10/26/87
Damper Assemblies - In- to and including SS
corporation of (Super- No. 760298 except
sedes basic ASB) for SS Nos *760136
and *760199 (See
note in ASB)
76-67-19 171 FLIGHT CONTROLS - Tail S-76A SS Nos 76003, None 12/05/85
Rotor Control System - 76005 thru 76007,
Pulley Guard Pins — Re- 760001 thru 760309;
placement of S-76B SS Nos
760262, 760269,
760299 and 760303
76-67-22A 186A FLIGHT CONTROLS - Yaw All S-76A, S-76AU, None 07/07/86
Control Rod Assembly - and S-76B helicop-
Inspection of (Msg no. ters
CBT-TP-86–051)
76-67-23C 189C FLIGHT CONTROLS - HR Tex- All S-76A and S-76B None 08/08/88
tron Main Rotor Servo Ac- with subject compo-
tuator Assemblies - Bal- nent installed (Re-
ance Tube Inspection/Test fer to ASB)
(Supersedes Revision B)
76-67-26 196 FLIGHT CONTROLS - Pilot All S-76A, S-76B None 10/08/86
and Copilot Cyclic Con-
trol Sticks - Check for
Lateral Play - Resafety
of Stop Pins
76-67-28A 211A FLIGHT CONTROLS - Forward S-76A series prior None 11/11/87
and Aft Servo Control Rod to and including
Assemblies - Drain Hole — 760298; S-76B se-
Addition of (Supersedes ries prior to and
basic ASB and Amend. No. including 760340
1)
76-67-30A 250A FLIGHT CONTROLS - Tail S-76A series prior None 01/11/91
Rotor Control Cables Rub- to and including SS
bing Strips - Mod of (Re- No. 760373
vises basic ASB)
76-67-31 273 FLIGHT CONTROLS - Control All S-76 series None 11/23/92
Rod Assemblies — Conduc-
tivity Inspection of
76-67-35 238 FLIGHT CONTROLS - Main All S-76A, All See HR Textron 07/12/88
Servo Actuator Assemblies S-76B SB No. SB 257,
- Replacement of Piston Revision 3
and Balance Tube Seals;
Inspection of Balance
Tubes, Pistons, Rod End
Assemblies and Input Le-
ver Assembly
76-67-36 243 FLIGHT CONTROLS - Tail S-76A and S-76B se- None 10/18/88
Rotor Centering Quadrant ries prior to and
- Retaining Washers — In- including SS No.
stallation of 760350
76-67-37 245 FLIGHT CONTROLS - Expand- S-76A and S-76B None 12/05/88
able Pin Attachment of prior to and in-
Servo Actuator to Sta- cluding SS No.
tionary Swashplate - In- 760361
spection of (Msg CBT-TP-
88–103)
76-67-38A 248A FLIGHT CONTROLS - Sta- S-76A and S-76B se- None 12/08/89
tionary Swashplate - Re- ries prior to and
dundant Retention Feature including SS No.
for Expandable Pin - In- 760367
corporation of (Revises
basic Bulletin)
76-67-39 261 FLIGHT CONTROLS - Servo S-76A and S-76B se- None 11/02/90
Actuator to Stationary ries prior to and
Swashplate Attachments — including SS No.
Expandable Pins — One 760369
Time Inspection of
76-67-40B 272B FLIGHT CONTROLS - Main All S-76 models See HR Textron 08/18/98
Rotor Servo Actuator As- equipped with main Bulletin No.
sembly - Inspection of rotor servo actua- 30006760-67-05,
Pistons, Rod End Assem- tor assemblies Rev. 1
blies and Feedback Link- 30006760 (76650-
age Bearings on Actuator 09805) series
30006760 (Supersedes ba-
sic Bulletin)
76–67–41A 282A FLIGHT CONTROLS — Arkwin All S-76 models None 07/08/96
Industries Pedal prior to SS No.
Damper/Trim Actuator — 760453 with
Relief Valve Override 76900–01810 series
Test (Supersedes basic pedal damper/trim
Bulletin) actuators
76–67–43A 298A FLIGHT CONTROLS — Main All main and tail None 08/18/98
and Tail Rotor Servo Ac- rotor servo actua-
tuator Pressure Switches tors
- One-Time Inspection and
Replacement of
76-67-44 308 FLIGHT CONTROLS - Pilot’s All S-76 Models None 10/26/99
Cyclic Stick Torque Tube
Support Assembly - One-
Time FOD Inspection;
Modification of
76-67-45 328 FLIGHT CONTROLS - Main All S-76 Models None 12/19/01
Rotor Servo Input Control manufactered prior
Pushrods - One-Time In- to January 1, 1992
spection of as determined by
the date of manu-
facture on the data
plate, without re-
gurd to flight time
accrued.
76-67-46 FLIGHT CONTROLS - Main All S-76 series he- None 09/05/02
Rotor Servo Input Control licopters. Compo-
Pushrods - 10 Year Re- nent: 76400-00034-
placement Interval 056 main rotor
servo input control
pushrods (hollow
tube construction).
76–71 POWERPLANT
76–71 POWERPLANT
PAGE 1
S-76A
ALERT SERVICE BULLETIN INDEX
76–71 POWERPLANT
76-71-7 162 POWERPLANT - Demountable All S-76A helicop- Refer to CSB 11/09/84
Power Package - Fuselage ters delivered as
Mounted Engine Contain- of issue date of
ment Installation Re- this ASB
placement of; Allison Ex-
ternal Energy Absorbing
Ring - Installation of
76–71 POWERPLANT
PAGE 2
S-76A
ALERT SERVICE BULLETIN INDEX
76–71 POWERPLANT
76-71-9 209 POWERPLANT - Engine and S-76A series prior None 05/13/87
Compartment Drains - Com- to and including SS
bustion Chamber and Ex- No. 760298
haust Casing Lower Drain
Lines - Replacement of
76–71 POWERPLANT
PAGE 3
S-76A
ALERT SERVICE BULLETIN INDEX
76-73-1 271 ENGINE FUEL AND CONTROL - All S-76A models None 06/03/92
No. 1 and No. 2 Engine equipped with Alli-
(Electronic) N2 Overspeed son 250–C30 or 250-
Control Systems - Deacti- C30S engines
vation of
76-75 AIR
76-75-1 105 AIR - No. 2 Engine Ther- S-76 SS Nos 76003, 76070-30005-011 04/23/81
mal Switch (T1 Tempera- 76005 thru 76007,
ture Sensor) — Relocation 760001 thru 760139
of
76-75-2 116 AIR - Engine Air Particle S-76 SS Nos 760012 76070-30008-001 06/25/81
Separator — Gasket Re- thru 760015,
tainer for Scavenge Air 760089, 760103 thru
Check Valve - Installa- 760107 with EAPS
tion of installed
76-75-3 121 AIR - Engine Air Particle S-76 SS Nos 76005 76070-55013-011, 07/23/81
Separator (EAPS) System - thru 76007, 760001 -012, and -013
Installation of thru 760011, 760016
Provisions/Conversion to thru 760088
Operational Status
76-75 AIR
PAGE 1
S-76A
ALERT SERVICE BULLETIN INDEX
76-76-2 151 ENGINE CONTROLS - Collec- All S-76 helicop- None 09/16/83
tive Bias Control Cable ters delivered as
System Emergency Travel - of issue date of
Inspection/Modification of this Bulletin
76-76-3 232 ENGINE CONTROLS - Power S-76A Series heli- None 04/06/88
Turbine Speed Trim Con- copters with Alli-
trol Actuators — Attach- son Model 250–C30/S
ment Bolt — Inspection of engines
(Msg CBT-TP-88–031)
76-77-1 122 ENGINE INDICATING - Power S-76 SS Nos 76003, 76070-55014-011 07/30/81
Turbine Inlet Temperature 76005 thru 76007,
Indicating Harness - Re- 760001 thru 760154
placement and Relocation
of
76-77-2 115 ENGINE INDICATING - En- S-76 SS Nos 76003, 76070-55023-012 06/23/81
gine Torque Indicating 76005 thru 76007,
System - Replacement of 760001 thru 760199
Hose Assemblies
76-78 EXHAUST
76-78 EXHAUST
PAGE 1
S-76A
ALERT SERVICE BULLETIN INDEX
76-79 OIL
76-79-7 OIL - Engine Supplemen- S-76A series prior See ASB 08/31/05
tary Oil Filtration - In- to S/N 760327
stallation of
76-79 OIL
PAGE 1
S-76A
ALERT SERVICE BULLETIN INDEX
76-80 STARTING
76-80 STARTING
PAGE 1