I
INSTALLATION and OPERATING
>
@
as
Remove the
slide
Fest
tool post
nd upper
swivel by loosening
SEU eds 3
Gilat. Wo. 500A
MILLING ATTACHMENT
INSTALLATION
mpound
@ Remove the two mounting
lock screws from the
Milling Attachment,
the two swivel lock screws
about 1/2!
then 1ift slide
Slide attachment over
a) beveled pilot on the
Cross slide and lock in
place with the plunger pins
and lock screws, When in-
serting plunger pins make
sure bevel matches the
bevel on the pilot.
OPERATION
5008
MILLING
ATTACHMENT
JANUARY, 1976
Tae susiiee artucnnent can be anivel=
wa to hold work at any tage bY
Stine is controled byt handehee!
Uiel ateconetor treduated coliure tise
When attachment is in position, and
work is clamped in the vise, tighten
the gibs on the carriage, cross slide
and attachment dovetail ways.
~ Se
Melling a Keyvey
coon Milling a stot
A holding collet (Atlas No. 945) is
recommended for holding the milling
cutter - headstock chucks should not be
used ae the cutter would slip during
the milling operation, Complete operat-
ing instructions are furnished with the
holding collet.
When feeding the work, take light cats,
and feed in evenly and slowly - get the
feel of how fast the cutter will handle
the work, NEVER force the work into the
cutter too fast. Depth of cut should be
about 1/16" or less, A few milling
operations are illustrated on this
page.
The cutting speeds should be approxi-
mately 2/3 of the speed for general
turning, Table of cutting speeds for
milling on the lathe can be found on
page 187 of the Manual of Lathe opera-
tions,REPAIR PARTS
Glas, No. 500A MILLING ATTACHMENT
For 10-inch Metal Working Lathe
ORDER REPAIR PARTS vex at tor ————— | ——____ 2104
FROM wet
CLAUSING SERVICE CENTER
2206 EISENHOWER DRIVE mo23
GOSHEN, INDIANA 46526 vw
ORDERING INFORMATION
on
IMPORTANT ~ ora po by PE i
Wot nd WA eda oa -
screws, washers, belts and nuts shown without | 82" 4, mens" cour
ort numbers, should be purchased locally,
(We reserve the right to make changes in design
_and specifications without notice. mae
fame.
3 wooonure key —
9.5068
sie sce
|__348.077
987 527-026
ose rons
ace o——
aoee,
ATLAS PRESS CO., KALAMAZOO, MICHIGAN, U.S. A.
a ‘oa
2