Professional Documents
Culture Documents
2. 3.
SH60157 Fig. 1 B
SHI.7327 NE 01.09
6.
Place the setting gauge on the back bottom roller with the small fitting tongue on the setting EliTube at the front. Suspend the two 90 offset legs at the back bottom roller, so that the small fitting tongue at the front is located between the two pins of the setting EliTube. (A, Fig. 2) (In case of 6 spindles per box length, the setting gauge is placed with the recessed openings on the bottom roller bearings, reaching into the adjacent roller stand section over 2 spinning positions.)
8. 9.
Remove the setting gauge, as well as the setting EliTube, and reinstall the original EliTube. Repeat steps 3-8 at the remaining roller stand sections of the machine.
ADVICE
If the machine is equipped with roller stand sections with 4 spindles at the beginning or at the end, the roving guides must be set without the setting gauge, using a square and your sense of proportion.
7.
Push the roving guides clipped on the roving guide bar to the 4 setting tongues on the gauge until they stop on the left and on the right of the tongues respectively. As a result, the correct spinning position of 8 roving guides is set at a time. Use the torx TX20 screwdriver to fasten the screw of each roving guide. (B, Fig. 3)
SH60157 Fig. 2 A
SH60158 Fig. 3 B
Spindelfabrik Suessen GmbH Donzdorfer Strasse 4, D-73079 Sssen, Germany Phone +49 (0) 716 15-0Fax +49 (0) 7162 15-367 e-mail: mail@suessen.comhttp://www.suessen.com