Professional Documents
Culture Documents
Description
A Primary CPICH enters the reporting range A primary CPICH leaves the reporting range A non-active primary CPICH becomes active better than an active primary CPICH Change of best cell A Primary CPICH becomes better than an absolute threshold A Primary CPICH becomes worse tha an than absolute threshold A non-active E DCH but active DCH active E-DCH primary CPICH becomes better than an active E-DCH primary CPICH -DCH
Description
Transport Channel Traffic Volume becomes larger than an absolute threshold Transport Channel Traffic Volume becomes smaller than an absolute threshold
Event 4 4B
Quality Measurements
Event
Event 5A
Description
A predefined number of bad CRCs is exceeded
UE Internal Measurements
Event
Event 6A Event 6B Event 6C Event 6D Event 6E Event 6F
Description
The UE Tx power becomes larger than an absolute threshold The UE Tx power becomes less than an absolute threshold The UE Tx power reaches its minimum power value The UE Tx power reaches its maximum value The UE RSSI reaches the UE's dynamic receiver range The UE Rx Tx time difference for a RL Rx-Tx included in the active set becomes larger than an absolute threshold
Description
Change of best frequency frequenc The estimated quality of the currently used frequency is below a certain threshold and the estimated quality of a non-used frequency is above a certain used threshold The estimated quality of a non-used quality non used frequency is above a certain threshold The estimated quality of the currently used frequency is below a certain threshold The estimated quality of a non-used stimated non used frequency is below a certain threshold The estimated quality of the currently used frequency is above a certain threshold
Event 2C C Event 2D D
Event 2E E Event 2F F
Description
The UE position changes more than an absolute threshold SFN-SFN SFN SFN measurement changes more than an absolute threshold GPS time and SFN time have drifted apart more than an absolute threshold
Description
The estimated quality of the currently used UTRAN frequency is below a certain threshold and the estimated quality of the other system is above a certain system threshold The estimated quality of other system is below a certain threshold The estimated quality of other system is above a certain threshold Change of best cell in other system
Important Parameters
Parameter
Ec/No
Description
Energy per chip (Ec) divided by the noise and inter ence power spectral interference density ( (No). Measure of the absolute received primary CPICH signal. Received power measured within the relevant relevant channel bandwidth measured on a GSM BCC carrier CCH