Professional Documents
Culture Documents
802
Welcome to
Thank you for purchasing the Einstein Remote Education Collar from E-Collar Technologies, Inc. We have made every attempt to provide you with the most technologically advanced product using the most stringent quality and manufacturing standards. We are confident you will be pleased with the results you will attain with the ET-800 / ET-802. Please remember you will get better results with the use of lower stimulation combined with consistent training techniques. The use of high levels of stimulation should only be used as a last resort and in life-threatening situations. Good luck with your training and please feel free to contact us should you have any questions. 1-855-326-5527 or 1-855-ecollar
02
Characteristics
CHARACTERISTICS
Range : Up to 800 yards Momentary and Continuous Stimulation Buttons Warning Tone Button Employs Ni-MH Rechargeable Batteries Convenient Intensity Dial for Quick Adjustment Stimulation Levels Adjustable from 0 to 100 Collar Receiver Light for Night Tracking Lock and Set Stimulation Feature
Contents
CONTENTS
Transmitter Collar Receiver
03
Battery Charger Battery Charger and Splitter Cable (For ET-800 Only) (For ET-802 Only)
Lanyard
Owners Manual
Test Light
800
802
04
Table of Contents
TABLE OF CONTENTS
05 06 08 10 11 12 15 18 19 20 21 22 23 24
Turning Your Einstein On/Off The LCD Display Features Button Functions
Replacing the Contact Points Correctly Fitting the Collar Warranty Contact Information
05
International Standards and Guidelines for human exposure to radio frequency electromagnetic energy. interference (EMI) if inadequately shielded or designed without precautions to EMI. Technologies, Inc. comply with Article 15 of the FCC rules and operate under Part 95 of FCC regulations.
1. To avoid Electromagnetic Interference and/or compatibility conflicts, please turn off your transmitter and collar receiver in any facility where posted notices instruct you to do so. Never use your equipment in close proximity of a Hospital or Health Care Facility or enter the facility without turning off both units. 2. An FCC license is not needed to operate Einstein E-Collar transmitters. However, any change or modification made to the transmitter, including the supplied antenna, without the expressed written approval of E-Collar Technologies, Inc. could void your authority to operate.
Einstein Owner's Manual ET-800 / ET-802
IMPORTANT NOTICE
06
Getting Started
TRANSMITTER PARTS
Antenna Stimulation Level Dial Momentary Button Continuous Button LCD Display Tone Button Light and On/Off Button
1 DOG SYSTEM
2 DOG SYSTEM
Getting Started
07
08
Indicator Light will blink Green under normal operation. It will flicker Red when stimulation is applied and will blink Red when recharging is required. We recommend you fully charge your Einstein every six months when not in use to maintain battery life.
Battery Charger (For ET-800 Only) Battery Charger and Splitter Cable (For ET-802 Only)
Charging Cable
Wall Outlet
Charging Cable
Wall Outlet
09
The indicator light will turn solid red during the 10 to 12 hour
ET-800
charge cycle and stay red even though the unit is fully charged.
ET-802
10
Red Dot
Position the red dot on the Transmitter close to the red dot on the Collar Receiver. Two beeps will confirm the collar receiver has been turned on and a single beep will confirm the unit has been turned off. Push the tone button to assure the unit is on and properly functioning.
To turn the Transmitter On or Off :
Press the L light button for more than 2 seconds. If L light button is pressed less than 0.5 seconds, it will turn On/Off Tracking lights of Collar Receiver.
11
Indicates that stimulation level for 1D is locked Displays the Stimulation Level : 0means no stimulation and HI means the highest level (100 ) Indicates that stimulation level for 2D is locked (For ET-802 Only)
Press down on the Stimulation Level Knob or press any button to
wake up the LCD display. Please note that if the collar receiver is on, pressing the stimulation buttons and/or the tone button will trigger the collar receiver.
12
Button Functions
BUTTON FUNCTIONS(ET-800)
Button Functions
The ET-800 transmitter is equipped with four control buttons, LCD display, and an adjustable dial. For long range use hold the transmitter up like the Statue of Liberty and never allow the antenna to touch anything as it will decrease the range. Power lines and foliage will also reduce the range. Momentary Button M - Sends a short pulse of stimulation to the collar receiver. Continuous Button C - Sends stimulation to the collar receiver for the duration of the button being pressed. - After 10 seconds the Over-Stimulation feature will stop the stimulation until the button is released and pressed again. Tone Button T - Sends warning tone to the collar receiver.
13
Light Button L - When pressed less than 0.5 seconds, it will turn On or Off the high intensity night tracking light which is good for finding your dog after dark. - When pressed for more than 2 seconds, it will turn On or Off the transmitter.
Einstein Owner's Manual ET-800 / ET-802
14
Button Functions
BUTTON FUNCTIONS(ET-802)
Toggle switch on the backside of the transmitter allows the user to switch between Dog 1 and Dog 2.
LCD Display
Tone Button
15
16
For example, if you want your dog to come to you and heel, you can hold the button down until your dog comes and heels or if jumping is an issue, you can hold the button down anytime their front paws are off the ground. Setting the Corrective stimulation level is a little more difficult due to the wide differences in temperaments and stimulation tolerance among the many breeds of dogs. On average, it is normally 20 to 40 levels higher than the Conditioning level. This higher level will only be used in Momentary mode as not to over-stimulate your dog. This mode is used for stopping unwanted behaviors such as chewing, digging, street-running, excessive barking, and aggressiveness, etc. It is important to apply the Momentary stimulus at the exact time of the unwanted behavior. Additional pulses may be used to reinforce the command if compliance is not immediate.
17
18
Dog 2
How to Lock/Unlock the Stimulation Level This feature is useful when controlling two dogs (ET-802) simultaneously and you want to have different stimulation levels for each dog. With the toggle switch in 1-D position, set the desired stimulation level and then push down on the top of the stimulation dial until you see 1D light up on the top portion of the LCD display. If the stimulation level doesnt change when you rotate the stimulation knob, you have successfully locked the stimulation level of Dog 1. Flip the toggle switch to the 2-D position and repeat the previous step. The 2D light on the bottom portion of the LCD display will light up when you have successfully locked the stimulation level on Dog 2. To unlock the stimulation level simply press the stimulation knob again and it will unlock the stimulation level of the dog specified by the toggle switch.
Einstein Owner's Manual ET-800 / ET-802
Indicator Light
INDICATOR LIGHT
19
TRANSMITTER INDICATOR LIGHT Battery Charge level is signified by the light going from green (ready for use) to amber (need to charge soon) and then to red (charge immediately). When any of the function buttons are pressed the indicator light will turn red to signify activation.
Battery Charge level is signified by the light going from green (ready for use) to amber (need to charge soon) and then to red (charge immediately). When any of the function buttons of the transmitter are pressed, the indicator light on the collar receiver will flicker red indicating a control signal has been successfully received.
20
Snap the test light onto the contact points as shown in the above figure. With both units on and green lights flashing press the continuous stimulation button while turning the stimulation up and down, the test should brighten as you go higher in stimulation. The collar receiver light will flicker red while the stimulation is on. Next, push the tone button to test the tone feature. Your Einstein E-Collar is ready to use.
21
1. Loosen both contact points by rotating the contact point counter-clockwise using the contact point tool.
2. Install the 3/4 contact points onto the bolt and tighten the contact points by rotating them clockwise with the contact point tool.
Einstein Owner's Manual ET-800 / ET-802
22
Too tight poses the risk of skin irritation and discomfort. Too loose and the contact points will not be able to administer the stimulation reliably. The optimal position for the collar receiver is on either side of the dogs windpipe. IMPORTANT NOTICE To prevent the occurrence of skin irritations the Collar Receiver should never be worn for more than 12 hours per day. Should your dog experience skin irritations from over exposure to the contact points remove the collar receiver unit immediately and stop using your e-collar until all skin irritations are totally healed. Antibiotic ointment will aid in the healing process. Some dog breeds have very thick fur that requires special contact points, please contact our customer service or visit www.ecollar.com for more information.
Warranty
WARRANTY
23
To Register for the Limited Lifetime Warranty : To register your Einstein product, please log onto our website at www.ecollar.com, click on the warranty registration link and fill out the required information. Please register your product within 30 days of your purchase. If you do not have access to a computer, please call our toll free number of 1-855-326-5527 and one of our customer service representatives will register your product for you. In the event the product is not properly registered proof of purchase will be needed to obtain warranty work. Product returns without proper registration and proof of purchase will be subject to a warranty start date estimated by your units serial number. Misuse, improper maintenance, lost units are not covered by this warranty. Limited Lifetime Warranty : Your Limited Lifetime Warranty begins the date of the original purchase. For the first two years both parts and labor are covered 100%. The rechargeable batteries have a one year replacement warranty. After the two year replacement warranty has expired the Limited Lifetime Warranty will cover the material to repair your e-collar system not including the accessories and antennas. The labor and shipping costs are not included and are the responsibility of the customer. Labor fees will be calculated based on the extent of the work performed. The Limited Lifetime Warranty will expire 5 years from the date the model is discontinued by E-Collar Technologies, Inc. Any attempt by the user to repair or open the e-collar including battery replacement will void the warranty.
Einstein Owner's Manual ET-800 / ET-802
24
Contact Information
CONTACT INFORMATION
E-Collar Technologies, Inc. 2120 Forrest Park Drive Garrett, IN 46738 Toll-Free 1-855-326-5527 Toll-Free Fax 1-855-226-5527 www.ecollar.com sales@ecollar.com customerservice@ecollar.com
Einstein Owner's Manual ET-800 / ET-802
www.ecollar.com
Patents Pending 2011 E-Collar Technologies, Inc.