You are on page 1of 41

This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws.

f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 1 of 41




Acura 8ecurity, Remote 8tart, Keyless Entry & Navigation
Wire Colors Version 7.0.1









PLEASE NOTE

The information contained is accurate to the best of our knowledge. 12 Volt Resource LLC
makes no representation or warranty with respect to the information contained in this
document including its accuracy or completeness. 12 Volt Resource LLC disclaims all
liability or responsibility for errors or omissions therein or any decision made by the
recipient in reliance thereon.

nstallations should be attempted by experienced installers only. Proper installation
remains the responsibility of the installer. t is the installer's responsibility to test and verify
all circuitry with the proper test equipment prior to installation.


Additional nformation:

This information is sorted alphabetically by vehicle model. f there are multiple
years for a particular vehicle model, then the oldest year comes first.

The installation notes referenced below and the full installation guide are located
in the nstall nstructions & Notes folder.


This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 2 of 41

Make: Model: Year:
Acura CL (2.2 & 3.0) 1997-2000


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS *
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/BLACK GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE GNTON COL **
Parking Lights: RED/BLACK (+) AT HEADLGHT SWTCH
Headlights: BLUE OR BLACK/WHTE
(-)
AT HEADLGHT SWTCH
Diesel Glow Plug: N/A N/A
Clutch Bypass Wire: BLACK/GREEN (-) AT SWTCH ABOVE CLUTCH PEDAL.

NOTES: * 1998+ Model vehicles have a transponder based theft system See nstallation Note
#144 - Bypassing Transponder Type Theft Systems. ** On the 4 cyl. 2.2L engine the ignition coil
is located on the right side of the engine near the distributor, on the 6 cyl. 3.0L engine the ignition
coil is on the right rear of the engine.

Acura CL (2.2 & 3.0) 1997-2000
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: RED/YELLOW (-) AT ANT-THEFT MODULE UNDER PASS.
SEAT
Dome
Lights/Superv:
LT. BLUE (-) AT ANT-THEFT MODULE UNDER PASS.
SEAT
OEM Horn: LT. GREEN/BLUE (-) N STEERNG COLUMN HARNESS
Power Lock: RED/YELLOW (-) AT ANT-THEFT MOD UNDER PASS. SEAT**
Power Unlock: RED/BLUE (-) AT ANT-THEFT MOD UNDER PASS. SEAT**
Trunk Release: BLUE/RED (-) AT ANT-THEFT MOD. UNDER PASS.
SEAT***
Alarm nput Wire: LT. BLUE (-) AT ANT-THEFT MODULE UNDER PASS.
SEAT

NOTES: ** See Note #201 - Negative Pulse Door Lock Diagram. *** See Note #232 - Negative
Pulse Trunk Release Diagram.



This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 3 of 41
Make: Model: Year:
Acura 3.2 CL & Type S 2001-2004


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS*
gnition #2: WHTE/BLACK GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: YELLOW GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) OR
WHTE BLACK
SEE NOTE BELOW***
Tach Signal: BLUE
N 2-PN CONNECTOR NEAR PASS SHOCK
TOWER
Parking Lights: RED/BLACK (+) DRVER'S KCK, LEFT OF COLUMN OR
SECURTY MODULE **
Headlights: RED/YELLOW (+) N 14 PN BROWN CONNECTOR N
DRVER'S KCK PANEL
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A

NOTES: * This vehicle is equipped with a transponder immobilizer system. Use a universal alarm
bypass module. ** Security Module s Located Underneath The Passenger Seat. *** Use
Green/White for 2001-2002, use White/Black for 2003.

Acura 3.2 CL & Type S 2001-2004
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: BLUE (-) AT SECURTY MODULE **
Dome
Lights/Superv:
BLACK/WHTE (-) PASSENGER FUSE PANEL OR SECURTY
MODULE
OEM Horn: LT. GREEN/BLUE (-) STEERNG COLUMN HARNESS
Power Lock: BLACK/BLUE (-) PASSENGER FUSE PANEL ***
Power Unlock: ORANGE (-) PASSENGER FUSE PANEL ***
Trunk Release: BLUE/RED (+) OR
WHTE (+)
SEE NOTE BELOW**
Alarm nput Wire: BLACK/WHTE (-) PASSENGER FUSE PANEL OR SECURTY
MODULE

NOTES: ** BLU/RED (2001-2002) located at Security Module underneath the passenger seat,
White (2003) locate behind the glove box in MUX module. *** See nstallation Note #201 -
Negative Pulse Door Locks Diagram. Alternate Wires Are Red/Yellow (-) For Lock And Red/Blue
(-) For Unlock Located At The Security Module Underneath The Passenger Seat.

This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 4 of 41

Make: Model: Year:
Acura EL 2002-2006


FUNCTON COLOR LOCATON
Start: Black/White gnition Switch Harness*
gnition #1: Black/Yellow gnition Switch Harness
gnition #2: N/A not needed
gnition #3: N/A
Accessory: Black/Red ign
Brake Light: White/Black At Brake Switch
Tach Signal: Blue At Coil Pack
Parking Lights: Red/Yellow or Blue At Light Switch***
Headlights: N/A not recommended
Diesel Glow Plug: N/A Not Applicable
Clutch Bypass Wire: No Color Available Please call with information

NOTES: *Equipped with transponder-anti-theft system - Use a universal alarm bypass module.
*** Must test parking lights. May be positive or negatice depending on the location you are
attaching to the wire.

Acura EL 2002-2006
FUNCTON COLOR LOCATON
Constant +12 Volts: White gnition Switch Harness*
OEM Alarm Disarm: White/Red At Module Near Drivers Kick Panel
Dome
Lights/Superv:
No color available Please call with information
OEM Horn: No Color Available Please call with information
Power Lock: White/Blue At Module Near Drivers Kick Panel**
Power Unlock: White/Green At Module Near Drivers Kick Panel
Trunk Release: Yellow/Green At Module Near Drivers Kick Panel
Alarm nput Wire: No color available Please call with information

NOTES: *Use constant power only for alarm or keyless modules, never remtoe start. ** Horn can
also be found as an Orange in the Steering Column Harness. Note: Factory hood pin is
Green/Black at module near Driver Kick Panel.


This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 5 of 41

Make: Model: Year:
Acura Integra 1986-1988


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/RED GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT COL
Parking Lights: RED/BLACK (+) AT HEADLGHT SWTCH
Headlights: RED/BLUE (H) AND RED/YELLOW (MOTOR)(+) @ HEADLGHT
SW.
Diesel Glow Plug: N/A N/A
Clutch Bypass Wire: N/A N/A

NOTES:

Acura Integra 1986-1988
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE & WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A N SCHEMATCS
Dome
Lights/Superv:
GREEN/RED (-) AT PN SWTCH
OEM Horn: BLUE/RED OR BLACK STEERNG COLUMN HARNESS
Power Lock: GREEN/WHTE DRVER'S KCK
Power Unlock: GREEN/RED PANEL*
Trunk Release: N/A
Alarm nput Wire: GREEN/RED (-) AT PN SWTCH

NOTES: * See Note #201- Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 6 of 41

Make: Model: Year:
Acura Integra 1989


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: BLACK/YELLOW OR BLUE/WHTE AT GNTON SWTCH
gnition #3: N/A
Accessory: WHTE/RED GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT COL
Parking Lights: RED/BLACK (+) AT HEADLGHT SWTCH
Headlights: RED/BLUE (H) OR RED/YELLOW (MOTOR) @ HEADLGHT
SW.(+)
Diesel Glow Plug: N/A N/A
Clutch Bypass Wire: N/A N/A

NOTES:

Acura Integra 1989
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE/BLACK GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
GREEN/RED (-) AT PN SWTCH
OEM Horn: BLUE/RED OR BLACK (-
)
STEERNG COLUMN HARNESS
Power Lock: ]REEN/WHTE DRVER'S KCK
Power Unlock: GREEN/RED PANEL*
Trunk Release: N/A
Alarm nput Wire: GREEN/RED (-) AT PN SWTCH

NOTES: * See Note #201- Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 7 of 41

Make: Model: Year:
Acura Integra 1990-1991


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: BLUE/WHTE GNTON SWTCH HARNESS
Accessory: WHTE/RED GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT COL
Parking Lights: RED/GREEN (+) AT HEADLGHT SWTCH
Headlights: RED/YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug: N/A N/A
Clutch Bypass Wire: N/A N/A

NOTES:

Acura Integra 1990-1991
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE/BLACK GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A N SCHEMATCS
Dome
Lights/Superv:
GREEN/RED (-) PASSENGER PN SWTCH
OEM Horn: BLUE/RED (-) STEERNG COLUMN HARNESS
Power Lock: GREEN/WHTE DRVER'S KCK
Power Unlock: GREEN/RED PANEL*
Trunk Release: N/A
Alarm nput Wire: GREEN/RED (-) PASSENGER PN SWTCH

NOTES: * See Note #201- Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 8 of 41

Make: Model: Year:
Acura Integra 1992-1993


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: BLUE/WHTE GNTON SWTCH HARNESS
Accessory: WHTE/RED GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) SWTCH ON BRACKET ABOVE BRAKE
PEDAL
Tach Signal: BLUE AT DSTRBUTOR ASSEMBLY
Parking Lights: RED/BLACK BLUE CONNECTOR (+) AT FUSE BOX
Headlights: RED/YELLOW (LOW) RED/BLUE (H) AT HEADLGHT SWTCH (+)
Diesel Glow Plug: N/A N/A
Clutch Bypass Wire: N/A N/A

NOTES:

Acura Integra 1992-1993
FUNCTON COLOR LOCATON
Constant +12 Volts: WHT/BLK AND WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
GREEN/RED (-) RED CONNECTOR AT FUSE BOX
OEM Horn: BLUE/RED (-) STEERNG COLUMN HARNESS-NEGATVE
ONLY
Power Lock: GREEN/WHTE AT RELAYS TO LEFT OF
Power Unlock: GREEN/RED STEERNG COLUMN*
Trunk Release: N/A
Alarm nput Wire: GREEN/RED (-) RED CONNECTOR AT FUSE BOX

NOTES: *See Note #201- Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 9 of 41

Make: Model: Year:
Acura Integra 1994-1995


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/BLACK GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT DSTRBUTOR*
Parking Lights: RED/BLACK (+) GREEN CONNECTOR AT FUSE BOX**
Headlights: RED/WHTE (LO) RED/BLUE (H) AT HEADLGHT SWTCH (+)
Diesel Glow Plug: N/A N/A
Clutch Bypass Wire: N/A N/A

NOTES: * Distributor Located On Passenger Side Of Engine. Tach Test Connector s a 2 Pin
GRAY Connector Located On Driver Rear Of Engine On Strut Tower. Tach Wire Also Located n
16 Pin GRAY Connector Above Fuse Block Behind Driver Dash.

Acura Integra 1994-1995
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
LGHT GREEN/RED (-) BLUE CONNECTOR AT FUSE BOX
OEM Horn: BLUE/GREEN (-) AT RELAY ON LEFT SDE OF FUSE BLOCK
Power Lock: BLACK/WHTE N LARGER OF 2 GRAY CONNECTORS***
Power Unlock: BLACK/RED BEHND CRUSE MOD N DRVER KCK
PANEL
Trunk Release: N/A
Alarm nput Wire: LGHT GREEN/RED (-) BLUE CONNECTOR AT FUSE BOX

NOTES: ** RED/BLACK (+) n 18 Pin BROWN Connector n Driver Kick Panel Can Also Be
Used For Parking Lights. *** See Note #201- Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 10 of 41

Make: Model: Year:
Acura Integra 1996-2001


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS*
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/BLACK GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT DSTRBUTOR OR TACH TEST CONN. **
Parking Lights: RED/GREEN (+) AT HEADLGHT SWTCH
Headlights: RED/WHTE (+) AT HEADLGHT SWTCH
Diesel Glow Plug: N/A N/A
Clutch Bypass Wire: BLUE/BLACK (-) AT SWTCH ABOVE CLUTCH PEDAL

NOTES: * This Vehicle May Be Equipped With A Transponder Type Theft System. Use a
universal alarm bypass module. ** Distributor Located On Passenger Side Of Engine. Tach Test
Connector s a 2 Pin GRAY Connector Located On Driver Rear Of Engine On Strut Tower. Tach
Wire Also Located n 16 Pin GRAY Connector Above Fuse Block Behind Driver Dash.

Acura Integra 1996-2001
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE/BLACK GNTON SWTCH HARNESS
OEM Alarm Disarm: BLUE (-) AT SECURTY CONTROL MODULE *****
Dome
Lights/Superv:
L GREEN/RED (-) 14 PN GRAY CONN. N DR. KCK PANEL
OEM Horn: BLUE/GREEN (-) STEERNG COLUMN HARNESS
Power Lock: BLACK/WHTE 14 PN GRAY CONNECTOR N DRVER'S
KCK
Power Unlock: BLACK/RED PANEL***
Trunk Release: N/A CABLE OPERATED
Alarm nput Wire: L GREEN/RED (-) 14 PN GRAY CONN. N DR. KCK PANEL

NOTES: ** RED/BLACK (+) n 18 Pin BROWN Connector n Driver Kick Panel Can Also Be
Used For Parking Lights. *** See Note #201- Negative Pulse Door Lock Diagram. **** Security
Control Module Located on Driver's Side Of Vehicle Right Of Steering Column.


This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 11 of 41

Make: Model: Year:
Acura Legend Coupe 1987


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: BLUE/WHTE GNTON SWTCH HARNESS
Accessory:
Brake Light: GREEN/WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT COL
Parking Lights: RED/BLACK (+) AT HEADLGHT SWTCH
Headlights: RED/YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Acura Legend Coupe 1987
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE/BLACK OR
WHTE
GNTON SWTCH HARNESS
OEM Alarm Disarm: BLUE/YELLOW (-) DRVER'S KCK PANEL
Dome
Lights/Superv:
BLACK/WHTE (-) DRVER KCK PANEL OR DOME LGHT
OEM Horn: BLUE/RED (-) STEERNG COLUMN HARNESS
Power Lock: GREEN/WHTE DRVER'S KCK PANEL
Power Unlock: GREEN/RED DRVER'S KCK PANEL*
Trunk Release: WHTE/BLACK (+) AT TRUNK RELEASE SWTCH **
Alarm nput Wire: BLACK/WHTE (-) DRVER KCK PANEL OR DOME LGHT

NOTES: * See Note #201- Negative Pulse Door Lock Diagram. ** See Note #232 - Negative
Pulse Trunk Release Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 12 of 41

Make: Model: Year:
Acura Legend Coupe 1994


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SW. HARNESS (HEAT/AC & ABS)
gnition #3: N/A
Accessory: WHTE/RED GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT TACH TEST CONNECTOR OR PCM *
Parking Lights: RED/BLACK (+) 20 PN BROWN CONN. N DR. KCK PANEL
Headlights: BLUE (-) 24 PN GRN CONN. LEFT OF STEER. COL
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Tach Test Connector (2 Pin White Plug) Located On Passenger Strut Tower.
Powertrain Control Module (PCM) Located Under Passenger Front Floor Board.

Acura Legend Coupe 1994
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: GREEN/RED (-) TO RGHT OF STEERNG COLUMN
Dome
Lights/Superv:
BLACK/WHTE (-) (LS) 8 PN GREEN CONN. N DR. KCK PANEL **
OEM Horn: BLUE/RED (-) STEERNG COLUMN HARNESS
Power Lock: GREEN/WHTE AT POWER DOORLOCK CONTROL UNT
Power Unlock: GREEN/RED TO RGHT OF STEERNG COLUMN***
Trunk Release: WHTE/BLACK (+) 20 PN GREEN CONN. N DR. KCK ****
Alarm nput Wire: BLACK/WHTE (-) (LS) 8 PN GREEN CONN. N DR. KCK PANEL **

NOTES: ** BLACK/WHTE (-) Wire On ""LS"" Models Only. WHTE/BLACK (-) On ""L"" Models n
Same LOCATON. *** See Note #201- Negative Pulse Door Lock Diagram. **** See Note #232 -
Negative Pulse Trunk Release Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 13 of 41

Make: Model: Year:
Acura Legend Coupe 1995


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/RED GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) ABOVE BRAKE PEDAL BRACKET
Tach Signal: BLUE AT TACH TEST CONNECTOR *
Parking Lights: RED/GREEN (+) 14 PN GRAY/GREEN CON ON DRVER STEERNG
COL
Headlights: GREEN (+) AT HEADLGHT SWTCH
Diesel Glow Plug: N/A N/A
Clutch Bypass Wire: N/A

NOTES: * Tach Test Connector (2 Pin White Plug) s Located On Passenger Rear Of Engine
Compartment On Passenger Strut Tower.

Acura Legend Coupe 1995
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: GREEN/RED (-) DRVER SDE STEERNG COLUMN
Dome
Lights/Superv:
WHTE/BLACK (-) DRVER KCK PANEL
OEM Horn: BLUE/RED(-)@
SECURTY
CONTROL UNT-DRVER SDE STEERNG
COL
Power Lock: GREEN/WHTE DRVER'S KCK
Power Unlock: GREEN/RED PANEL**
Trunk Release: WHTE/BLACK (+) 20 PN CONN. N DR. KCK PANEL***
Alarm nput Wire: WHTE/BLACK (-) DRVER KCK PANEL

NOTES: ** See Note #201- Negative Pulse Door Lock Diagram. *** See Note #232 - Positive
Pulse Trunk Release Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 14 of 41

Make: Model: Year:
Acura Legend Sedan 1986-1987


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH
gnition #3:
Accessory:
Brake Light: GREEN/WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT COL
Parking Lights: RED/BLACK (+) AT HEADLGHT SWTCH
Headlights: RED/YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Acura Legend Sedan 1986-1987
FUNCTON COLOR LOCATON
Constant +12 Volts: BLACK YELLOW AND
WHTE
GNTON SWTCH HARNESS
OEM Alarm Disarm: BLUE/YELLOW (-) PANEL
Dome
Lights/Superv:
BLACK/WHTE (-) DRVER KCK PANEL
OEM Horn: BLUE/RED (-) STEERNG COLUMN HARNESS
Power Lock: GREEN/WHTE DRVER KCK PANEL
Power Unlock: GREEN/RED DRVER KCK PANEL*
Trunk Release: WHTE/BLACK (+) AT TRUNK RELEASE SWTCH
Alarm nput Wire: BLACK/WHTE (-) DRVER KCK PANEL

NOTES: * See Note #201- Negative Pulse Door Lock Diagram. See Note #232 - Positive Pulse
Trunk Release Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 15 of 41

Make: Model: Year:
Acura Legend Sedan 1988-1990


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: BLUE/WHTE GNTON SWTCH HARNESS
Accessory: WHTE/RED GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE(+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT COL
Parking Lights: RED/BLACK (+) AT HEADLGHT SWTCH
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Acura Legend Sedan 1988-1990
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE AND
WHTE/BLACK
GNTON SWTCH HARNESS
OEM Alarm Disarm: GREEN/RED (-) DRVER KCK PANEL
Dome
Lights/Superv:
BLACK/WHTE (-) DRVER KCK PANEL OR DOME LGHT
OEM Horn:
Power Lock: GREEN/WHTE DRVER'S KCK
Power Unlock: GREEN/RED PANEL*
Trunk Release: WHTE/RED (-) AT RELEASE SWTCH **
Alarm nput Wire: BLACK/WHTE (-) DRVER KCK PANEL OR DOME LGHT

NOTES: * See Note #201- Negative Pulse Door Lock Diagram. ** See Note #232 - Negative
Trunk Release Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 16 of 41

Make: Model: Year:


Acura Legend Sedan 1991-1993


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/RED GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) SWTCH ON BRAKE PEDAL BRACKET
Tach Signal: BLUE AT TACH TEST CONNECTOR *
Parking Lights: RED/BLACK (+) DRVER KCK PANEL
Headlights: BLUE/RED (-) HEADLGHT SWTCH OR AT RELAY
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Tach Test Connector (2 Pin White Plug) s Located On Passenger Rear Of Engine
Compartment On Passenger Strut Tower.

Acura Legend Sedan 1991-1993
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: GREEN/RED (-) SECURTY MODULE UNDER DRVER'S
DASH
Dome
Lights/Superv:
BLACK/WHTE (-) DRVER ""B"" POST
OEM Horn: BLUE/RED (-) PN #8 OF 22 PN CONN. OF SECURTY
MOD
Power Lock: GREEN/WHTE (-) AT DOOR LOCK MODULE BEHND
DRVER'S
Power Unlock: GREEN/RED (-) DASH TO RGHT OF STEERNG COLUMN**
Trunk Release: WHTE/BLACK/GOLD
DOTS
(+) DRVER'S KCK ***
Alarm nput Wire: BLACK/WHTE (-) DRVER ""B"" POST

NOTES: ** See Note #201- Negative Pulse Door Lock Diagram. *** See Note #232 Positive
Pulse Trunk Release Diagram

This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 17 of 41

Make: Model: Year:


Acura Legend Sedan 1994


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SW. HARNESS (HEAT/AC & ABS)
gnition #3: N/A
Accessory: WHTE/RED GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT TACH TEST CONNECTOR OR PCM *
Parking Lights: RED/BLACK (+) 20 PN BROWN CONN. N DR. KCK PANEL
Headlights: BLUE (-) 20 PN ORANGE CONN. ABOVE FUSE
BOX**
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Tach Test Connector (2 Pin White Connector) Located On Passenger Strut Tower.
Powertrain Control Module (PCM) Located Under Passenger Front Floor Board. ** Fuse Box
Located n Driver Kick Panel.

Acura Legend Sedan 1994
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: GREEN/RED (-) MODULE TO RGHT OF STEERNG
COLUMN
Dome
Lights/Superv:
WHTE/BLACK (-) 8 PN GREEN CONN. ABOVE FUSE
BLOCK****
OEM Horn: BLUE/RED (-) STEERNG COLUMN HARNESS
Power Lock: GREEN/WHTE AT DOOR LOCK CONTROL UNT TO
Power Unlock: GREEN/RED RGHT OF STEERNG COLUMN***
Trunk Release: WHTE/BLACK (+) 20 PN GRN CONN. N DR. KCK PANEL ***
Alarm nput Wire: WHTE/BLACK (-) 8 PN GREEN CONN. ABOVE FUSE
BLOCK****

NOTES: *** See Note #201- Negative Pulse Door Lock Diagram. **** See Note #232 - Positive
Pulse Trunk Release Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 18 of 41

Make: Model: Year:
Acura Legend Sedan 1995


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/RED GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT BRAKE PEDAL SWTCH
Tach Signal: BLUE AT TACH TEST CONNECTOR *
Parking Lights: RED/GREEN (+) 14 PN GRAY/GRN CON-STEERNG COL
HARN
Headlights: GREEN (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Tach Test Connector (2 Pin White Plug) s Located On Passenger Rear Of Engine
Compartment On Passenger Strut Tower.

Acura Legend Sedan 1995
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: GREEN/RED (-) DASH TO RGHT OF STEERNG COLUMN
Dome
Lights/Superv:
WHTE/BLACK (-) 8 PN GREEN CONNECTOR-DR. KCK
PANEL
OEM Horn: BLUE/RED (-) STERNG COLUMN HARNESS
Power Lock: GREEN/WHTE AT DOOR LOCK CONTROL UNT BEHND
Power Unlock: GREEN/RED DASH TO RGHT OF STEERNG COL.**
Trunk Release: WHTE/BLACK (+) 20 PN GRN CONN. DR. KCK PANEL ***
Alarm nput Wire: WHTE/BLACK (-) 8 PN GREEN CONNECTOR-DR. KCK
PANEL

NOTES: ** See Note #201- Negative Pulse Door Lock Diagram. *** Please See Note #232
positive trigger trunk release


This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 19 of 41

Make: Model: Year:
Acura MDX 2001-2006


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS*
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/BLACK GNTON SWTCH HARNESS
Brake Light: WHTE/BLACK (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE
AT 2-PN TEST CONNECTOR ON THE
DRVER'S FENDER
Parking Lights: RED/BLACK (+) DRVER'S KCK PANEL
Headlights: BLUE/GREEN (-) AT HEADLGHT SWTCH
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A

NOTES: * This vehicle may be equipped with a transponder immobilizer system. Use a universal
alarm bypass module.

Acura MDX 2001-2006
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: BLUE (-) NSDE DRVER'S DOOR COMNG OFF OF
LOCK CYLNDER
Dome
Lights/Superv:
BLACK/WHTE (-) AT NTEROR LGHT SWTCH
OEM Horn: LT. GREEN/BLUE (-) STEERNG COLUMN HARNESS
Power Lock: BLACK/ORANGE (-) AT PASSENGER MULTPLEX UNT **
Power Unlock: BLUE/ORANGE (-) AT PASSENGER MULTPLEX UNT **
Trunk Release: N/A
Alarm nput Wire: BLACK/WHTE (-) AT NTEROR LGHT SWTCH

NOTES: ** The Passenger Mux Unit s Located n The Passenger Kick Panel And t s Attached
To The Passenger Fuse Panel. See Note #201- Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 20 of 41

2007-2009 Acura MDX
Security

FUNCTON COLOR LOCATON
Battery White (+) gnition switch harness
gnition 1 Pink (+) gnition switch harness
Starter 1 Yellow (+) gnition switch harness
All door trigger
Use each door trigger and diode isolate each door
Domelight super Pink (-) At vehicle fuse box
n green 39 pin connector in fuse box
Lf latch Green (-) n harness in driver kickpanel
Also in green 16 pin connector on rear of fuse box
Rf latch Light green (-) n harness in passanger kickpanel
Also in green 14 pin connector on rear of fuse box
Lr latch Green (-) At vehicle fuse box
n green 14 pin plug facing the rear of the vehicle
Rr latch Gray (-) At vehicle fuse box
n green 14 pin plug facing the rear of the vehicle
Trunk trigger Light green (-) At vehicle rear fuse box
Rear fuse box is located in drivers side rear quarter panel
Hood trigger Green (-) At hood pin switch
Alarm disarm Blue (-) At drivers door key cylinder
Test this wire while turning key in drivers door
Alarm arm Light blue (-) At drivers door key cylinder
Test this wire while turning key in drivers door
Parking lights Gray (+) n harness in driver kickpanel
All hazrd lights Green (+) At hazard switch
Parking brake Orange (-) At vehicle fuse box
n white 45 pin harness in fuse box
Fuel dr release Pink (-) At gas door release switch in drivers door
Seat mem 1 Green (-) At switch in drivers door
Seat mem 2 Red (-) At switch in drivers door
Battery White (+) gnition switch harness
gnition 1 Pink (+) gnition switch harness
Accessory 1 Orange (+) gnition switch harness
Accessory 2 Red (+) gnition switch harness
Starter 1 Yellow (+) gnition switch harness
Anti-theft type Universal immobilizer
Anti-theft descript
The key sends an RF signal to the BCM module through an antenna located around the
ignition cylinder

Key sense Pink (-) gnition switch harness

This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 21 of 41
Speed sense Blue (ac)
At pcm module under hood on passenger
fender

Parking lights Gray (+) n harness in driver kickpanel
Brake lights Light green (+) At vehicle fuse box
Reverse lights Brown (+) n harness in driver kickpanel
Horn Orange (-) n harness at steering column
Power unlock Red (+) At doorlock switch in drivers door
Powerlock Pink (+) At doorlock switch in drivers door

This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 22 of 41

Make: Model: Year:
Acura NSX 1991-2001


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS *
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: BLUE/WHTE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/RED GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GREEN AT TACH TEST CONNECTOR
Parking Lights: RED/BLACK (+) AT GRAY MOLEX
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * 1998 and newer vehicles are equipped with a transponder type theft system. See
installation Note #144 - Bypassing Transponder Theft Systems.

Acura NSX 1991-2001
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: YELLOW (-) DRVER KCK PANEL
Dome
Lights/Superv:
BLACK/WHTE (-) AT LGHT
OEM Horn: GREEN/WHTE (-) STEERNG COLUMN HARNESS
Power Lock: GREEN/WHTE MODULE BEHND GLOVE BOX
Power Unlock: WHTE/YELLOW MODULE BEHND GLOVE BOX *
Trunk Release: WHTE/BLACK (+) AT RELEASE SWTCH **
Alarm nput Wire: BLACK/WHTE (-) AT LGHT

NOTES: * See Note #201- Negative Pulse Door Lock Diagram. ** See Note #232 - Positive
Pulse Trunk Release Diagram


This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 23 of 41

Make: Model: Year:
Acura NSX 2002-2005


FUNCTON COLOR LOCATON
Start: Black/White gnition Switch Harness
gnition #1: Black/Yellow gnition Switch Harness*
gnition #2: color not available may not needed
gnition #3: N/A ****
Accessory: Yellow gnition Switch Harness
Brake Light: Green/White (-) At Brake Switch
Tach Signal: Green Left of Steering Column
Parking Lights: Red/Black (+) Gray Plug n Drivers Side Of Dash
Headlights: Blue/Red(+) At Anti-Theft Module Below Glove Box**
Diesel Glow Plug: N/A Not Applicable
Clutch Bypass Wire: color not available Please Call f You Have Color nformation

NOTES: *May have transponder - Use Universal Alarm Bypass Module. **Headlights are NOT
recommended. ***Alarm disarms with unlock. ****All DesignTech remote starters except the
2xx22 have an ignition 3 output - it is the white/black in the 'control harness.' This wire will
typically be used to control an anti-theft bypass, if needed.

Acura NSX 2002-2005
FUNCTON COLOR LOCATON
Constant +12 Volts: White or White/Black gnition Switch Harness*
OEM Alarm Disarm: Green/Red(-) n Drivers Door***
Dome
Lights/Superv:
Green/Blue (Driver) Green/Red (Pass) - Alarm module Below
GloveBox**
OEM Horn: Green/White n steering Column Harness
Power Lock: Green/White (-) These Wires Only Found***
Power Unlock: White/Yellow (-) nside Drivers Door or Pass Door***
Trunk Release: White/Black At Trunk Release Switch
Alarm nput Wire: Green/Blue (Driver) Green/Red (Pass) - Alarm module Below
GloveBox**

NOTES: *Constant power at the ignition switch should ONLY be used to power alarm or keyless
units. **For door trigger, these two wires must be isolated with 1N4001 diodes. Connect the
""band side"" of one diode towards the vehicle on each Dome-Light wire. Join the ends of the
diode without the band together with the alarm input wire of your unit. For domelight supervision
eithe wire may be used. *** See Note #201- Negative Pulse Door Lock Diagram.



This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 24 of 41
Make: Model: Year:
Acura NSX-T 1997-2001


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS *
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: BLUE/WHTE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/RED GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GREEN
LEFT OF COLUMN N GREEN PLUG BY
CLUSTER
Parking Lights: RED/BLACK (+) GRAY PLUG UNDER DRVER'S DASH
Headlights: BLUE/RED (+) AT ANT-THEFT MOD. BELOW GLOVEBOX
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * 1998 and newer vehicles are equipped with a transponder type theft system. See
installation Note #144 - Bypassing Transponder Theft Systems.

Acura NSX-T 1997-2001
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: YELLOW (-) DRVER'S KCK PANEL
Dome
Lights/Superv:
GREEN/BLUE &
GREEN/RED
(-) AT MODULE BELOW GLOVEBOX, DODE
SOLATE
OEM Horn: GREEN/WHTE (-) AT ANT-THEFT MOD. BELOW GLOVEBOX
Power Lock:
Power Unlock:
Trunk Release:
Alarm nput Wire: GREEN/BLUE &
GREEN/RED
(-) AT MODULE BELOW GLOVEBOX, DODE
SOLATE

NOTES: * See Note #201- Negative Pulse Door Lock Diagram. ** See Note #232 - Positive
Pulse Trunk Release Diagram


This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 25 of 41

Make: Model: Year:
Acura NSX-T 2002


FUNCTON COLOR LOCATON
Start: Black/White gnition Switch Harness
gnition #1: Black/Yellow gnition Switch Harness*
gnition #2: N/A
gnition #3: N/A See Notes****
Accessory: Yellow gnition Switch Harness
Brake Light: Green/White (+) At Brake Switch
Tach Signal: Green Left of Steering Column
Parking Lights: Red/Black (+) Gray Plug n Drivers Side Of Dash
Headlights: Blue/Red(+) At Anti-Theft Module Below Glove Box**
Diesel Glow Plug: N/A
Clutch Bypass Wire: Color not available Please Call f You Have Color nformation

NOTES: *May have transponder - Use Universal Alarm Bypass Module. **Headlights are NOT
recommended. ***Alarm disarms with unlock.****All DesignTech remote starters except the
2xx22 have an ignition 3 output - it is the white/black in the 'control harness.' This wire will
typically be used to control an anti-theft bypass, if needed.

Acura NSX-T 2002
FUNCTON COLOR LOCATON
Constant +12 Volts: White gnition Switch Harness
OEM Alarm Disarm: Green/Red(-) n Drivers Door***
Dome
Lights/Superv:
Green/Blue (Driver) Green/Red (Pass) - Alarm module Below
GloveBox**
OEM Horn: Green/White Steering Column Harness
Power Lock: Green/White (-) These Wires Only Found***
Power Unlock: White/Yellow (-) nside Drivers Door or Pass Door***
Trunk Release: White/Black At Trunk Release Switch
Alarm nput Wire: Green/Blue (Driver) Green/Red (Pass) - Alarm module Below
GloveBox**

NOTES: *Constant power at the ignition switch should ONLY be used to power alarm or keyless
units. **For door trigger, these two wires must be isolated with 1N4001 diodes. Connect the
""band side"" of one diode towards the vehicle on each Dome-Light wire. Join the ends of the
diode without the band together with the alarm input wire of your unit. For domelight supervision
eithe wire may be used. ** See Note #201- Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 26 of 41

2007-2009 Acura RDX


FUNCTON

COLOR



LOCATON


Battery White (50a) (+) gnition switch harness
gnition 1 Blue (+) gnition switch harness
Starter 1 Yellow (+) gnition switch harness
All door trigger Must use latch wires and diode isolate each.
Domelight super Pink (-) Driver kick rear of fuse box 8 pin plug
Lf latch Green (-)
Driver kick or 42 pin plug top of fuse box
pin 37

Rf latch Green (-)
Driver kick or 42 pin plug top of fuse box
pin 3

Lr latch Brown (-)
Driver kick or 42 pin plug top of fuse box
pin 17

Rr latch Blue (-)
Driver kick or 42 pin plug top of fuse box
pin 2

Trunk trigger Blue (-) Driver kick or 42 pin plug top of fuse box
Hood trigger Yellow/red or gray (-) Pin switch or fuse box mid 21 pin plug.
Alarm disarm Brown (-) Driver's kick or micu pin 31 of 34 pin plug
Also in the drivers door boot
Alarm arm Pink (-) Driver's kick or micu pin 32 of 34 pin plug
Also in the drivers door boot.
Parking lights Red (+) Driver's kick or fuse box top plug
Low crr pk lights Gray (-) At switch or micu,20 pin plug pin 13
Headlights-lo Green (-) Switch or micu pin 13 of 20 pin plug
All hazrd lights Purple (+) Switch or 16 pin plug on rear of fuse box
Wipers-lo White (-) Switch or micu pin 20 of 20 pin plug
Trnk release Pink (-) Driver's kick or fuse box top plug
Battery White (50a) (+) gnition switch harness
gnition 1 Blue (+) gnition switch harness
Accessory 1 Orange (+) gnition switch harness
Accessory 2 Red (+) gnition switch harness
Starter 1 Yellow (+) gnition switch harness
Anti-theft type Universal immobilizer

This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 27 of 41
Anti-theft descript
The key sends an rf signal to the bcm module through an antenna located around the
ignition cylinder

Key sense Pink (-) gnition switch harness
Tachometer Use fuel injector (ac) Brown/w. Stripe any injector
Speed sense Blue (ac) Radio harness
Parking lights Red (+) Driver's kick or fuse box top plug
Low crr. Pk lights Gray (-) At switch or micu,20 pin plug pin 13
Brake lights Lt.green (+) Driver's kick or fuse box
Reverse lights Lt. Blue (+) Driver's kick or fuse box
Horn Orange (-) Switch or rear of fuse box 16 pin plug
Module 1
Multiplex integrated control unit or (micu) is part of the fuse/realay box under dash on
driver side.

Power unlock Gray (-) Driver's kick or micu pin 27 of 34 pin plug
Also in the drivers boot
Powerlock Blue (-) Driver's kick or micu pin 28 of 34 pin plug
Also in the drivers door boot
Driver mtr unlock Lt. Blue (rev) Driver kick or rear of fuse box
Driver mtr lock Gray (rev) Driver kick or rear of fuse box
Pas mtr unlock Yellow (rev) Pass kick or 10 pin plug rear of fuse box
Lf window up Lt.blue
Lf window dn Red
Rf window up Yellow
Rf window dn Red
Lr window up Blue
Lr window dn Red
Rr window up Blue
Rr window dn Red


This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 28 of 41

Make: Model: Year:


Acura 3.5 RL 1996-1997


FUNCTON COLOR LOCATON
Start: WHTE/RED GNTON SWTCH HARNESS *
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BLACK/WHTE GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE GNTON SWTCH HARNESS
Tach Signal: BLUE TEST CONN. RGHT REAR ENGNE COMP.
Parking Lights: RED/GREEN (-) GRAY 20 PN CONN. LEFT OF COLUMN
Headlights: BLUE/RED (-) GRAY 20 PN CONN. LEFT OF COLUMN
Diesel Glow Plug: N/A N/A
Clutch Bypass Wire: N/A N/A

NOTES: *This vehicle may be equipped with a transponder immobilizer system. Use a universal
alarm bypass module.

Acura 3.5 RL 1996-1997
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: GREEN/RED (-) MPX UNT N PASSANGER KCK PANEL**
Dome
Lights/Superv:
GREEN/RED (-) MPX UNT N PASSANGER KCK PANEL**
OEM Horn: ORANGE (-) GRAY 20 PN CONN. LEFT OF COLUMN
Power Lock: GREEN/RED (-) WRESFOUND N MPX UNT N
PASSANGER
Power Unlock: GREEN/WHTE (-) KCK PANEL ***
Trunk Release: PNK/BLUE (-) MPX UNT N PASSANGER KCK PANEL
Alarm nput Wire: GREEN/RED (-) MPX UNT N PASSANGER KCK PANEL**

NOTES: ** Multiplex Unit in Passanger's Kick Panel has many wires that are the same color.
Please check each wire for proper reading prior to connecting. *** See Note #201- Negative
Pulse Door Lock System. **** See Note #232 - Negative Pulse Trunk Release Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 29 of 41

Make: Model: Year:
Acura 3.5 RL 1998-2003


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS *
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/BLACK GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE GNTON SWTCH HARNESS
Tach Signal: BLUE TEST CONN. RGHT REAR ENGNE COMP.
Parking Lights: RED/GREEN (-) OR
RED/BLACK
GRAY 18 PN CONN. LEFT OF COLUMN OR
DRVERS KCK PANEL
Headlights: GREEN/YELLOW (-) GRAY 20 PN CONN. LEFT OF COLUMN
Diesel Glow Plug: N/A N/A
Clutch Bypass Wire: N/A N/A

NOTES: * This Vehicle May Be Equipped With A Transponder Type Theft System. Use a
universal alarm bypass module.

Acura 3.5 RL 1998-2003
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: GREEN/RED (-) NSDE OF DRVER'S DOOR
Dome
Lights/Superv:
BLUE/RED (-) MPX UNT N PASSANGER KCK PANEL**
OEM Horn: ORANGE (-) GRAY 20 PN CONN. LEFT OF COLUMN
Power Lock: GREEN/RED (-) GRAY 22 PN PLUG N PASS KCK***
Power Unlock: GREEN/WHTE (-) GRAY 22 PN PLUG N PASS KCK***
Trunk Release: PNK/BLUE (-) OR
WHTE/BLACK
MODULE N PASSANGER KCK PANEL****
Alarm nput Wire: BLUE/RED (-) MPX UNT N PASSANGER KCK PANEL**

NOTES: ** Multiplex Unit in Passanger's Kick Panel has many wires that are the same color.
Please check each wire for proper reading prior to connecting. ***See nstallation Note #201 -
Negative Pulse Door Locks Diagram. ****See nstallation Note #232. For Negative Pulse Trunk
Release.


This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 30 of 41

Acura 3.5 RL 2004-2008

FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS *
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: YELLOW GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) LEFT OF COLUMN GREY
PLUG

Tach Signal: BLUE
GREEN PLUG PASSENGER
KCK
PANEL

Parking Lights: RED/GREEN (-) LEFT OF COLUMN GREY
PLUG

Headlights: N/A
OEM Alarm
Disarm:
DSARMS WTH UNLOCK
OEM Alarm Arm: ARMS WH LOCK
Diesel Glow Plug: N/A
Clutch Bypass
Wire:
N/A
Notes: * This Vehicle May Be Equipped With A Transponder Type
Theft System. Use a universal alarm bypass module.

Acura 3.5 RL 2004-2008

FUNCTON COLOR LOCATON
Constant +12
Volts:
WHTE GNTON SWTCH HARNESS
Starter Kill: BLACK/WHTE GNTON SWTCH HARNESS *
gnition +12 Volts: BLACK/YELLOW GNTON SWTCH HARNESS
Dome
Lights/Superv:
LT. GREEN/BLACK (-) GREY PLUG PASSENGER
KCK PANEL

OEM Horn: ORANGE (-) LEFT OF COLUMN GREY
PLUG

Power Lock: GREEN/WHTE (-) GREY PLUG PASSENGER
KCK PANEL**

Power Unlock: GREEN/RED (-) GREY PLUG PASSENGER
KCK PANEL

Trunk Release: WHTE/BLACK (+) LEFT OF COLUMN GREY
PLUG

Alarm nput Wire: LT. GREEN/BLACK (-) GREY PLUG PASSENGER
KCK PANEL

Notes:
**See nstallation Note #201 - Negative Pulse Door Locks
Diagram.

This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 31 of 41

Make: Model: Year:
Acura RSX 2002-2003


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS*
gnition #2: BLACK/RED GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/RED GNTON SWTCH HARNESS
Brake Light: WHTE/BLACK AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE
AT TEST CONNECTOR BEHND DRVER'S
HEADLGHT
Parking Lights: RED/BLACK (+) AT FUSE BOX
Headlights: BLUE/RED (-) AT HEADLGHT SWTCH
Diesel Glow Plug: N/A
Clutch Bypass Wire:

NOTES: * This Vehice s Equipped With A Transponder Type Theft Systems. Use a universal
alarm bypass module.

Acura RSX 2002-2003
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: WHTE (-) AT SECURTY MODULE ***
Dome
Lights/Superv:
GREEN AND LT.
GREEN/RED (-)
AT SECURTY MODULE **
OEM Horn: ORANGE (-) STEERNG COLUMN HARNESS ***
Power Lock: WHTE/BLUE (-) DRVER'S OR PASSENGER KCK PANEL
****
Power Unlock: WHTE/GREEN (-) DRVER'S OR PASSENGER KCK PANEL
****
Trunk Release: N/A
Alarm nput Wire: GREEN AND LT.
GREEN/RED (-)
AT SECURTY MODULE **

NOTES: ** Securtiy Module s Located To The Left Of The Steering Column. Green s Driver's
Door And Lt. Green/Red s Passenger Door. Use Both Wires For Alarm nput and Diode solate
Both. Use Only One Wire For Dome Light Supervision. *** Security Module s Located To The
Left Of The Steering Column. **** Wires Can Also Be Found n A 13 Pin Plug At The Multiplex
Control Unit Located At The Back Of The Fuse Box. See Note #201- Negative Pulse Door Lock
Diagram.

This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 32 of 41


Acura RSX 2004-2006

FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS*
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: BLACK/RED GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/RED GNTON SWTCH HARNESS
Brake Light: WHTE/BLACK (+) AT SWTCH ABOVE BRAKE
PEDAL

Tach Signal:
Parking Lights: BLUE (-) HEADLGHT SWCH
Headlights:
OEM Alarm
Disarm:
WHTE (-) LEFT OF STEERNG COLUMN
OEM Alarm Arm:
Diesel Glow Plug: N/A
Clutch Bypass
Wire:

Notes: * This Vehice s Equipped With A Transponder Type
Theft Systems. Use a universal alarm bypass module.

Acura RSX 2004-2006

FUNCTON COLOR LOCATON
Constant +12
Volts:
WHTE GNTON SWTCH HARNESS
Starter Kill: BLACK/WHTE GNTON SWTCH HARNESS*
gnition +12 Volts: BLACK/YELLOW GNTON SWTCH HARNESS
Dome
Lights/Superv:
SEE NOTE** SECURTY UNT LEFT OF
STEERNG COLUMN

OEM Horn: ORANGE (-) STEERNG COLUMN
Power Lock: WHTE/BLUE (-) DRVER'S KCK PANEL***
Power Unlock: WHTE/GREEN (-) DRVER'S KCK PANEL
Trunk Release: N/A
Alarm nput Wire: SEE NOTE** SECURTY UNT LEFT OF
STEERNG COLUMN

Notes:
** GREEN (LEFT), LT.GREEN/RED (RGHT) use both and
diode isolate. *** See Note #201- Negative Pulse
Door Lock Diagram.



This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 33 of 41

Make: Model: Year:
Acura SLX 1996-1997


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS *
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: BLACK/RED GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BLUE GNTON SWTCH HARNESS
Brake Light: GREEN/YELLOW (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLACK/RED AT POWERTRAN CONTROL MODULE **
Parking Lights: GREEN (-) AT HEADLGHT SWTCH ***
Headlights: RED/BLACK (-) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * BLACK/WHTE Changes Color To WHTE/GREEN At Base Of Steering Column. **
Powertrain Control Module Located n Front Of Center Console. BLACK/RED Wire Also Located
n 18 Pin Connector High n Driver Kick Panel.

Acura SLX 1996-1997
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE/BLACK (2) GNTON SWTCH HARNESS
OEM Alarm Disarm: ORANGE/BLACK (-) 18 PN WHTE CONN. N PASS. KCK
Dome
Lights/Superv:
GRAY/GREEN (-) AT FUSE BLOCK ****
OEM Horn: BLACK/ORANGE (-) STEERNG COLUMN HARNESS
Power Lock: L GREEN/RED ETHER KCK
Power Unlock: L GREEN/BLUE PANEL*****
Trunk Release: N/A
Alarm nput Wire: GRAY/GREEN (-) AT FUSE BLOCK ****

NOTES: *** GRAY/BLUE (-) At Fuse Block Or At Security Control Unit Above Gas Pedal will
Catch All Doors And Hatch. **** Output From Parking Light Relay To Parking Lights:
GREEN/RED (+) ***** See Note #201 - Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 34 of 41

Make: Model: Year:
Acura SLX 1998-2000


FUNCTON COLOR LOCATON
Start: WHTE/GREEN GNTON SWTCH HARNESS*
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: BLACK/RED GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BLUE GNTON SWTCH HARNESS
Brake Light: GREEN/YELLOW AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLACK/RED AT PCM **
Parking Lights: YELLOW (-) AT HEADLGHT SWTCH
Headlights: RED (-) AT HEADLGHT SWTCH
Diesel Glow Plug: N/A
Clutch Bypass Wire:

NOTES: ** This Vehicle May Be Equipped With A Transponder Type Theft System. Use a
universal alarm bypass module. ** PCM Located Behind Front Console.

Acura SLX 1998-2000
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE/BLACK GNTON SWTCH HARNESS
OEM Alarm Disarm: SEE UNLOCK NOTE ***
Dome
Lights/Superv:
GRAY/RED OR
GRAY/GREEN (-)
AT SECURTY MODULE **
OEM Horn: LT. GREEN (-) STEERNG COLUMN HARNESS
Power Lock: LT. GREEN/RED &
ORANGE/BLACK(-)
DRVER'S KCK PANEL ***
Power Unlock: BLUE/YELLOW &
ORANGE/BLACK(-)
DRVER'S KCK PANEL ***
Trunk Release:
Alarm nput Wire: GRAY/RED OR
GRAY/GREEN (-)
AT SECURTY MODULE **

NOTES: ** Security Module And Relay Unit Located Above Passenger Kick Panel. *** The
Orange/Black Wire s The Door Key Lock/Unlock Detection Wire. When Pulsed With Either The
Lock Or Unlock Wire. t Will Arm And Disarm The Factory Alarm System. Diode solate Each
Wire With Bands Facing The Remote Start/Alarm Module. UNLOCK REQURES A DOUBLE
PULSE!! See nstallation Note #201 - Negative Trigger Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 35 of 41


Acura 2.5 TL 1995-1997


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW (HEAT/AC) GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/BLACK GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT TACH TEST CONNECTOR *
Parking Lights: RED/BLACK (+) 16 PN GREEN CONN. AT FUSE BLOCK **
Headlights: BLUE/RED (-) 18 PN GRAY CONN. BELOW DR. DASH
Diesel Glow Plug: N/A N/A
Clutch Bypass Wire: N/A N/A

NOTES: * Tach Test Connector s A 2 Pin White Plug Located On Passenger Strut Tower. BLUE
Tach Wire Also Located n 16 Pin GREEN Connector On Top Of Fuse Block n Driver Kick
Panel.

Acura 2.5 TL 1995-1997
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: GREEN/BLACK (-) N PASS. KCK PANELggf
Dome
Lights/Superv:
BLACK/WHTE (-) 20 PN BLUE CONN. N PASS. KCK PANEL
OEM Horn: BLUE/RED (-) STEERNG COLUMN HARNESS
Power Lock: BLACK/WHTE 10 PN GRAY CONN.
Power Unlock: BLACK/RED N DRVER'S KCK PANEL***
Trunk Release: N/A CABLE OPERATED
Alarm nput Wire: BLACK/WHTE (-) 20 PN BLUE CONN. N PASS. KCK PANEL

NOTES: ** RED/GREEN (-) At Headlight Switch Can Also Be Used For Parking Lights.*** See
Note #201- Negative Pulse Door Lock Diagram.




This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 36 of 41
Make: Model: Year:
Acura 3.2 TL 1996-1997


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW (HEAT/AC) GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/BLACK GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE
TEST CONN. RGHT REAR OF ENGNE
COMP.
Parking Lights: RED/BLACK (+) 5 PN GREEN CONN. AT FUSE BLOCK **
Headlights: BLUE/RED (-) STEERNG COLUMN HARNESS
Diesel Glow Plug: N/A N/A
Clutch Bypass Wire: N/A N/A

NOTES:

Acura 3.2 TL 1996-1997
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: GREEN/ORANGE (-) 20 PN GRAY CONN. N DR. KCK PANEL
Dome
Lights/Superv:
BLACK/WHTE (-) 20 PN BLUE CONN. N PASS. KCK PANEL
OEM Horn: BLUE/GREEN (-) STEERNG COLUMN HARNESS
Power Lock: GREEN/WHTE DRVER'S KCK PANEL
Power Unlock: GREEN/RED DRVER'S KCK PANEL ***
Trunk Release: N/A CABLE OPERATED
Alarm nput Wire: BLACK/WHTE (-) 20 PN BLUE CONN. N PASS. KCK PANEL

NOTES: ** Fuse Block Located n Driver Kick Panel. *** See Note #201- Negative Pulse Door
Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 37 of 41

Make: Model: Year:
Acura 3.2 TL 1998


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS *
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/BLACK GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT TACH TEST CONNECTOR **
Parking Lights: RED/BLACK (+) AT HEADLAMP SWTCH
Headlights: BLUE/RED (-) AT HEADLAMP SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * This vehicle is equipped with a transponder immobilizer system. See nstallation Note
#144 - Bypassing Transponder Theft Systems.

Acura 3.2 TL 1998
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: GREEN/BLACK (-) AT SECURTY CONTROL MODULE ****
Dome
Lights/Superv:
BLACK/WHTE (-) AT KEYLESS CONTROL MODULE ***
OEM Horn: BLUE/RED (-) STEERNG COLUMN HARNESS
Power Lock: GREEN/WHTE (-) AT KEYLESS CONTROL MODULE *****
Power Unlock: GREEN/RED (-) AT KEYLESS CONTROL MODULE *****
Trunk Release: N/A
Alarm nput Wire: BLACK/WHTE (-) AT KEYLESS CONTROL MODULE ***

NOTES: *** Keyless Entry Control Module Located Behind Glove Box. **** Security Control
Module Located Behind Right Side Of Dash. ***** See nstallation Note #201 - Negative Pulse
Door Lock Diagram. Keyless Entry Control Module Located Behind Glove Box.


This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 38 of 41

Make: Model: Year:
Acura 3.2 TL 1999-2003


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS*
gnition #2: WHTE/BLACK GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: YELLOW GNTON SWTCH HARNESS
Brake Light: WHTE/BLACK AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE 2-PN WHTE PLUG ON PASS STRUT
Parking Lights: RED/BLACK 5-PN GREEN PLUG AT FUSE BOX DR.
KCK
Headlights: BLUE/RED (-) STEERNG COLUMN HARNESS
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A

NOTES: *This vehicle may be equipped with a transponder immobilizer system. Use a universal
alarm bypass module. ** The security module is located underneath the passenger seat.

Acura 3.2 TL 1999-2003
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: BLUE (-) LOCATED AT SECURTY MODULE **
Dome
Lights/Superv:
BLACK/WHTE (-) 4-PN PLUG ON FUSE PANEL
OEM Horn: LT.GREEN/BLUE(-) STEERNG COLUMN HARNESS
Power Lock: BLACK/BLUE (-) PASSENGER FUSE BOX ***
Power Unlock: ORANGE (-) PASSENGER FUSE BOX ***
Trunk Release: BLUE/RED (+) OR
WHTE/RED (+)
SEE NOT BELOW**
Alarm nput Wire: BLACK/WHTE (-) 4-PN PLUG ON FUSE PANEL

NOTES: ** Use Blue/Red on 1999 - 2002, use White/Red on 2003. The MUX module is located
behind the glove box. *** See nstallation Note #203 - Negative Pulse Door Locks Diagram.
Alternate Wires Are Red/Yellow (-) For Lock And Red/Blue (-) For Unlock Located At The
Security Module Underneath The Passenger Seat.


This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 39 of 41

Acura 3.2 TL 2004-2008

FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS*
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: WHTE/RED GNTON SWTCH HARNESS
gnition #3: RED/WHTE (-) KEYSENSE WRE
Accessory: BLACK/RED GNTON SWTCH HARNESS
Brake Light: WHTE/BLACK (+) AT SWTCH ABOVE BRAKE
PEDAL

Tach Signal:
Parking Lights: RED/WHTE (+) ABOVE FUSE BOX BG WHTE
PLUG

Headlights:
OEM Alarm
Disarm:
WHTE (-) DRVER'S DOOR MODULE N
DOOR

OEM Alarm Arm:
Diesel Glow Plug: N/A
Clutch Bypass
Wire:
N/A
Notes: *This vehicle may be equipped with a transponder
immobilizer system. Use a universal alarm bypass module.

Acura 3.2 TL 2004-2008

FUNCTON COLOR LOCATON
Constant +12
Volts:
WHTE GNTON SWTCH HARNESS
Starter Kill: BLACK/WHTE GNTON SWTCH HARNESS*
gnition +12 Volts: BLACK/YELLOW GNTON SWTCH HARNESS
Dome
Lights/Superv:
GREEN/WHTE (-) BEHND FUSE BOX GREEN
PLUG

OEM Horn: GREEN/YELLOW (-) STEERNG COLUMN
HARNESS

Power Lock: PNK/BLACK (-) LEFT SDE OF FUSE BOX
GREEN PLUG**

Power Unlock: PNK/BLUE (-) LEFT SDE OF FUSE BOX
GREEN PLUG

Trunk Release: YELLOW/GREEN (+) DRVER'S KCK PANEL
Alarm nput Wire: GREEN/WHTE (-) BEHND FUSE BOX GREEN
PLUG

Notes:
** See nstallation Note #203 - Negative Pulse Door
Locks Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 40 of 41

Acura TSX 2004-2008

FUNCTON COLOR LOCATON
Start: Black/White GNTON SWTCH HARNESS *
gnition #1: Black/Yellow GNTON SWTCH HARNESS
gnition #2: Black/Red GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: White/Red GNTON SWTCH HARNESS
Brake Light: White/Black (+) SWTCH ON BRAKE PEDAL
BRACKET

Tach Signal: Blue Power Control Module
Parking Lights: Red/Black (+) At the fuse box
Headlights: N/A
OEM Alarm
Disarm:
White (-) n Drivers door at the door lock
module

OEM Alarm Arm: White/Red (-) n Drivers door at the door lock
module

Diesel Glow Plug: N/A
Clutch Bypass
Wire:
N/A
Notes: *This car is equipped with a Transponder Anti-Theft
Security System. Use a universal alarm bypass
module.

Acura TSX 2004-2008

FUNCTON COLOR LOCATON
Constant +12
Volts:
White gnition Switch Harness
Starter Kill: Black/White GNTON SWTCH HARNESS *
gnition +12 Volts: Black/Yellow GNTON SWTCH HARNESS
Dome
Lights/Superv:
Green/Red (-) Green Plug Behind the fuse
panel

OEM Horn: Green/Yellow (-) Below the steering column
Power Lock: Pink/Black (-) Green Plug Behing the fuse
panel

Power Unlock: Pink/Blue (-) Green Plug Behing the fuse
panel

Trunk Release: Yellow/Green (+) At Hatch Release Switch
Alarm nput Wire: Green/Red (-) Green Plug Behind the fuse
panel

Notes:





This document is the intellectual property of 12 Volt Resource LLC and is protected under United States Copyright laws. f you
acquired this document or CD-ROM from anywhere other than www.12voltresource.com or eBay user 12v-resource, then it is an
illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Acura - Copyright 2004-2009 - 12 Volt Resource LLC Page 41 of 41

Make: Model: Year:
Acura Vigor 1991-1994


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW OR
BLUE/WHTE
GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/BLACK OR
YELLOW
GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT SWTCH ON BRAKE PEDAL BRACKET
Tach Signal: BLUE AT GNTON COL *
Parking Lights: RED/BLACK (+) BLUE CONNECTOR AT FUSE BOX ***
Headlights: BLUE/RED (-) 12 PN GRAY CONNECTOR
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * gnition Coil Located On Passenger Side Of Engine Compartment.

Acura Vigor 1991-1994
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: GREEN/BLACK (-) MODULE LOCATED BEHND GLOVE BOX
Dome
Lights/Superv:
GREEN/RED (-) RED CONNECTOR AT FUSE BOX **
OEM Horn: BLUE/RED (-) STEERNG COLUMN HARNESS
Power Lock: GREEN/WHTE AT DOOR LOCK CONTROL UNT TO
Power Unlock: GREEN/RED RGHT OF STEERNG COLUMN ****
Trunk Release: N/A
Alarm nput Wire: GREEN/RED (-) RED CONNECTOR AT FUSE BOX **

NOTES: ** 1993-94 Door Trigger s BLACK/WHTE (-) To Left Of Steering Column. *** 1994
RED/BLACK (+) Wire Located n GREEN 16 Pin Connector On Back Of Fuse Block. **** See
Note #201 - Negative Pulse Door Lock Diagram

You might also like