Professional Documents
Culture Documents
Convert (1010)2 to its 8421 BCD equivalent 00001010 00010000 10100000 none of these
The logic realized by the circuit shown in the fig<img src='figures/setI/I.12.GIF' width='450' align='center'> AC + B'C' BC + B'C' AB + A'C BC + A'C None of these
In the figure shown below, assuming the flip flop was initially cleared and then clocked for 6 pulses, the sequence at the Q output will be<img src='figures/setM/M.14.GIF' width='300' align='center'> 010000 011001 010010
Identify the logic function being realized by the given CMOS gate <img src='figures/setA/A.24.GIF' width='300' align='center'> ((D.A)' +(B.C)')' (D+A.(B+C))' ((D+A).(B+C))' (D +A.B.C)
Determine the power supplied by the 2-amp current source in the circuit shown in the below figure <img src='figures/setC/C.10.GIF' width='525' align='center'> 25.33 W 35.33 W 45.33 W 55.33 W None of these
In the following circuit, for what condition is the output independent of frequency? <img src='figures/setH/H.11.GIF' width='450' align='center'>
In the given circuit, if μnCox (W/L)n = μpCox (W/L)p= 1mA/V2 & Vtn = –Vtp = 1V & λ = 0, find Vo for Vl = 0 <img src='figures/setB/B.2.GIF' width='375' align='center'> 0V 1.25V 2.5V 5V
The maximum resistor ratio required by a 12-bit D/A converter utilizing a binary-weighted resistor network is 1024 512 2048
The state diagram given below can be reduced to<img src='figures/setD/D.13.GIF' width='450' align='center'> figure a figure b figure c None of these
An FM wave having modulation index 6 and modulating frequency 1 kHz has frequency deviation D. If D is the Nyquist rate of signal m(t) which amplitude modulates a carrier of frequency 1 MHz, then the upper sideband (USB) in AM wave extends upto _____. 100.3 kHz
The Nyquist rate for sampling a band-limited analog signal is 10 kHz. The highest frequency present in the signal is _____. 20 kHz greater than 20 kHz 5 kHz greater than 5 kHz
If R, G, L and C implies resistance, conductance, inductance and capacitance per unit length respectively, then which of the following represents the equivalent circuit of a transmission line? R, G in series and L, C in parallel R, C in series and L, G in parallel G, C in series and L, R in parallel R, L in series and C, G in parallel
In an antenna array, field from the array is maximum in a direction for which the progressive phase difference is _____.
A hybrid-T is to be used as duplexer. Which of the following represents the correct connections of microwave source, antenna, transmitter and matched load? Source and load on collinear ports, antenna on E-arm and transmitter on H-arm. Transmitter and load on collinear ports, antenna on H-arm and source on E-arm. Source and transmitter on collinear ports, load on H-arm and antenna on E-arm. Source and load on collinear ports, antenna on H-arm and transmitter on E-arm.
The boundary conditions at the interface between two dielectrics in an electric field are _____.
The net magnetic flux emerging from any closed surface is _____. Constant Zero Unity Infinity
A planar LED is fabricated from GaAs with nx = 3.5. If the transmission factor at crystal-air interface is 0.7, determine the optical power emitted as a percentage of internal optical power. 0.71% 1.43% 7.10% 14.30%
Higher frequencies are preferred in radars because _____. they produce better echoes smaller targets can be detected smaller antennas can be used all of the above