You are on page 1of 2

ISO : 9001-2008 F/IF-SAT.

4/01/06 SUBDIVSAT
STANDARD OPERATING PROCEDURE LICENSE FOR TRANSMIT - TELKOM's SATELLITE Network Operator Information
Company Address Contact Person Email Phone Fax Transponder / Satellite Operational Frequency RF Transmit Band Width Power Modulation Data Rate Coding Earth Station Tx Antenna Diameter Longitude (E/W) Latitude (N/S) Manufacturer Address : Rx Antenna Diameter Address : : PT Metrasat : JL KH Saleh Iskandar KM 6 - Semplak Bogor - Jawa Barat : Lasahido : nccmetra@gmail.com / noc@metra.net.id : 0251-7543536/08111666727/08119699869/081111114235 : 0251-7542998

Network Configuration
: 5V/Telkom 1 : : : : : 2 Mbps : 3/4 MHz 1 MHz -15 dBW For 2 or more frequencies, check this box, leave this section blank and write down the information in ANNEX-1 For TDMA and or DA (Demand Assignment), check this box (You still have to fill columns of "Operational Frequency" and "Bandwidth" )

16 QAM

: 3,8 Meter : E deg : S deg : Prodelin : BTS Mori Atas : 4.5 Meter Palu For multipoints receive system, write down the smallest antenna size

Measurement Result (filled by TELKOM)


Specification Transmit X-pol Isolation at test freq >30 dB EIRP density of modulated carrrier at T1 <= - 36 dBW/Hz, Operational Freq. T2 <= - 36 dBW/Hz Result : : dB dBm/Hz OK OK NOK NOK

C/N Broadcaster Interference Spurious Adjacent Satellite Interference Level

>28 dB

: : : : : : : : :

dB dB dB

OK OK OK

NOK NOK NOK

Satellite-1 : ASIASAT-3S at 105.5 deg E For Telkom 1 Satellite-2 : SINOSAT-5 at 110.5 deg E For Telkom 1 Satellite-3 : Chinasat-6B at 115.5 deg E For Telkom 2

dB dB dB

OK OK Status OK

NOK NOK NOK

Conclusion
Remarks Date Network Operator,

Approved
08-May-12 Telkom,

Not Approved

( Firman )

Imam MPB Helpdesk Assistant Manager Helpdesk Officer

Please fax this form to TELKOM's MCS at +62-21-8231000 ext. 185 or to helpdesk_satelit@yahoo.co.id to proceed Licence for Transmit. For any question or assistance, simply call to +62-21-8235500 or +62-21-82491700 or send your email to : helpdesk_satelit@yahoo.co.id. Issue Date : October 1st, 2011 Revision : 01

ANNEX-1 FREQUENCY LIST (Only used if the number of carrier is more than one carrier) NO Transmit Frequency (MHz) 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 Satellite Xpdr Name Diameter (meter) Manufacturer Address ANTENNA TRANSMIT RECEIVE Xpol Isolation ASI (I/N) Other Intrfrncy EIRP Density Diameter Manufacturer (dB) OK/NOK (dB) OK/NOK OK/NOK dBW/Hz OK/NOK (meter)

Address

You might also like