You are on page 1of 81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

Senthil4us Weblog
What You Give is What You Get Posted by: senthil4u | September 8, 2009

BHEL Model question paper(Answers Updated)


1. For ELECTRICAL & ELECTRONICS with answers(bolded words) 2. When a inductive coil connected to a 200 V, 50Hz ac supply with 10A current flowing through it dissipates 1000 watts then which of the following will have least value in ohms a.) Resistanceb.) Reactance c.) Impedance d.) None

3. Oscillator crystal are made of a.) Silicon b.) Germanium c.) Quartz d.) None 4. For small size, high frequency coils, the most common core material is-a. )Airb. )Ferrite c.) Powdered ion d.) Steel 5. If we have a parallel plate capacitor of plate area A and plate separatoin t and having a capacity C and a metallic plate r of area A and of negligible thickness is introduced in the capacitor at a distance from either of the two plates as shown in the given figure then the capacity of the capacitor will become

senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/

1/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

a.) b.) C c.) 2C d.) 4C 6. A superconductor is a a.) A material showing perfect conductivity and Meissner effect below a critical temperature b.) A conductor having zero resistance c.) A perfect conductor with highest di-magnetic susceptibility d.) A perfect conductor which becomes resistance when the current density through it exceeds a critical value

7. When an inductor tunes at 200 KHz with 624 pF capacitor and at 600 KHz with 60.4 pF capacitor then the self capacitance of the inductor would be a) 8.05 pF b) 10.05pF c.) 16.01pF d.) 20.01pF 8. Sparking occur when a load is switched off because the circuit has high a.) Inductance b.) Capacitance c.) Resistance d.) None
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 2/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

9. Sparking between contacts can be reduced by inserting a a.) Resistance in the line b.) Capacitor in series with contacts c.) Capacitor in parallel with contacts d.) None 10. RF amplifier of an A.M. receiver is normally biased in a.) Class A b.) Class b c.) Class C d.) None 11. The value of gate voltage for the operation of enhancement of only N channel MOSFET has to be a.) High positive b.) High negative c.) Low positive d.) Zero 12. The input gate current of a FET is a.) a few microamperes b.) negligibly small c.) a few milliamperes d.) a few amperes 13. In the following fig. with R = 30k, the value of current through 2 K resistor is

senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/

3/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

a.) 25 mA b.) 40 mA c.) 25/16 mA d.) 10 mA 14. A step recovery diode a.) has on extremely short recovery time b.) conducts equally well in both directions c.) is mainly used as a harmonic generator d.) is an ideal rectifiers of high frequency signals 15. In order to get maximum undistorted output signal from CE amplifier with VCC 10V, the value of VCE (Q) should be approximatelya.) 0.1V b.) 5V c.) 10V d) V

16. In a FET the electrode, which corresponds to collector in bipolar transistor, is a.) source b.) drain c.) gate d.) none
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 4/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

17. The device which acts like an NPN and a PNP transistor connected base to base and emitter to collector is a.) Triacb.) UJT c.) Diac d.) SCR 18. A typical optical fibre has a.) High refractive index core and low refractive index cladding b.) Low refractive index core and high refractive index cladding c.) Both a and b d.) None 19. In the following figure circuit diagram of an op-amp based is shown. The ratio is equal to

a.) 9 b.) 11 c.) 10 d.) 21 20. When a loud speaker is connected across the terminals A and B of the network shown in the fig.

then its impedance to obtain maximum power dissipation in it will be a.) 3 j1 b.) 3 + j9 c.) 7.5 + j 2.5 d.) 7.5 j 2.5 21. In the lattice network, the value of R for the maximum power transfer to the load

senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/

5/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

b.) 6.5 c.) 8 d.) 9

a.) 5

22. For a lossy transmission line short circuited at the receiving end, the input impedance is given by (Z0 is the characteristic impedance, is the propagation constant and l is the length of the line-a.) Z0 cot h lb.) Z0 cot l c.) Z0 tan h. l d.) Z0 tan l 23. The approximate thickness of the radome wall should be a.) lb.) l/4 c.) l/2 d.) l/8 24. A relatively permanent information is stored in a. ) ROM b.) RAM c.) PROM d.) Volatile memory

25. The rise time of the RC network shown in the given figure is approximately equal to

b.) RC c.) 2RC d.) 4RC 26. If in the network shown in the fig. initially a steady state is attained by closing the switch s and then if the switch is opened at t = 0, then the current i(t) through the inductor will be
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 6/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

b.) 2A c.) 2cos100tA d.) 2sin50tA

a.) cos50tA

27. When the p network of figure I and T-network of figure II are equivalent then the values of

R1, R2 and R3 will be respectively b.) 6W, 6W and 9W c.) 9W, 6W and 9W d.) 6W, 9W and 6W

a) 9W, 6W and 6W

28. When the impedance matrices of a two port networks are given by and , then if these two networks are connected in series then the impedance matrix of the resulting two-port network will be

d.) indeterminate 29. Joule/coulomb is the unit of - a.) Electric field potential b.) Potential c .) Charge d.) None of the above 30. The electric field line and equipotential linesa.) Are parallel to each other b.)Are one and same c.) Cut each other orthogonally d.)Can be inclined to each other at any angle 31. For a lossy transmission line short circuited at the receiving end, the input impedance is given by
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 7/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

(When Z0 is the characteristic impendence g is the propagation constant and L is the length of the line

32. When two equal positive point charges are placed along X- axis at X1 and X1 respectively then the electric field vector at a point P on the positive Y-axis will be directeda.) In the +x direction b.) In the x direction c. ) In the +y direction d.) In the y direction 33. The directions of propagation area.) Both and b.) c.) d. ) is and and in TEM mode transmission line with respect to the direction of

are transverse to the direction of propagation

are transverse and h has a component in the direction of propagation has a component in the direction of propagation has a component in the direction of propagation

is entirely transverse and is entirely transverse and

34. The lowest TM mode in a rectangular waveguide of cross section a x b with a>b will bea.) TM01 b.)TE10 c.) TM112 d.)TE11

35. When a transmitter in a free space radiates a mean power of p watts uniformly in all directions then at a distance d sufficiently far from the source in plane the electric field E should be related to p and d as

36. . When a dipole antenna was radiating with some excitation in free space radiating a certain
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 8/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

amount of the power v if then this antenna is immersed in a lake where water is non-dissipative but has a dielectric constant of 81, then the radiated power with the same excitation will be a.) Decrease to finite non-zero value b.)Remain the same c. )Increase d.)Decrease to zero 37. When a (75 j40)W load is connected to a coaxial line of Z0 = 75 W at 6MHz then the load matching on the line can be accomplished by connectinga.) A short circuited stub at the load b.)An inductance at the load c. )A short circuited stub at a specific distance from the load d.)none of the above 38. As compared to analog multimeters, digital multimeters are a.) less accurateb.) more accurate c.) equally accurate d.) none. 39. When a signal of 10 mV at 75 MHz is to be measured then which of the following instruments can be used a.) VTVMb.) Cathode ray oscilloscope c.) Moving iron voltmeter d.) Digital multimeter 40. Which of the following statement is true about two wattmeter method for power measurement in three phase current ?a.) power can be measured using two wattmeter method only for star connected three phase circuits.b.) when two meter show indentical readings, in the power factor is 0.5. c.) when power factor is unit, one of the wattmeter reads zero d.) when the reading of the two wattmeters are equal but of opposite sign, then the power factor is zero 41. When a capacitance transducer has two plates of area 5cm2 each, separated by an air gap of 2mm than the displacement sensitivity in pf/cm due to gap change would be a.) 11.1b.) 44.2 c.) 52.3 d.) 66.3 42. The Q of a radio coil a.) is independent of frequencyb.) increases monotonically as frequency increases
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 9/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

c.) decreases monotonically as frequency increases d.) increases upto a certain frequency and then decreases beyond that frequency 43. When a generator of internal impedance and operating at 1GHz feeds a load via a coaxial line of characteristic impedance 50 ohm then the voltage wave ratio on the feed line is a.) 0.5b.) 1.5 c.) 2.5 d.) 1.75 44. The coding system typically used in digital telemetry is a.) PPM (pulse position modulation)b.) PAM (pulse amplitude modulation) c.) PCM (pulse code modulation) d.) PDM (pulse duration modulation) 45. Radiation pyrometers are used for the measurement of temperature in the range of a.) -2000C to 5000C b.) 00C to 5000C c.) 5000C to 12000C d.) 12000C to 25000C 46. In the given figure band structure is shown. It is of

a.) Gallium Avesenide (GaAs) b.) Silicon (Si) c.) Copper (Cu) d.) Germanium (Ge) 47. When anode is positive with respect to cathode in an SCR, the numbers of blocked p-n junction is a.) 1 b.) 2
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 10/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

c.) 3 d.) 4 48. The circuit symbol for a GTO is

a.

b.

c.

d.

49. In the given fig. mark out the type of Cyclo converters

a.) 1 phase to 1 phase with continuous conduction b.) 1 phase to 1 phase with discontinuous conduction c.) step up device d.) 3 phase to 1 phase device

In the given fig. A-1, C=5, m H and C=20 m F, C is initially charged to 200 V. After the switch. S is closed at t = 0 the maximum value of current and the time at which it reaches this value are respectively.

senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/

11/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

a.) 400 A, 15.707 mS 50. b.) 50 A, 30 mSc.) 100 A, 62.828 mSd.) 400 A, 31.414 mS 51. 50. In the given circuit the maximum current in the main SCR M can be-

a.) 200 A b.) 170.7 A c.) 141.4 A d.) 70.7 A

52. The transfer function of an amplifier is given by frequency of the amplifier will approximately a.) 5850 KHZ b.)585 KHZ c.) 5850 HZ d.)585HZ

The high 3-db

53. In comparison to full wave rectifier with two diodes the four divide bridge rectifier has the dominant advantage of a). Higher current carrying
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 12/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

b.)Lower ripple factor c.) Higher efficiency d.)Lower peak increase voltage require

54. Power output increase in a class-c amplifiera.) If the conduction angle decrease b).If the conduction angle increase c.) Are not governed by the conduction angle d.)None of the above 55. A transistor with hie = 1.5 k and hfe = 75 is used in an emitter follower circuit where R1 and R2 are used for normal biasing . Approximate value of its current amplification is- a.)75b.)76 c.)75/76 d.)-75 56. Amplifier of class B has high theoretical efficiency of 78.5 percent becausea.) It is biased almost to saturation b.)Its quiescent current is low c.)Its output is an exact replica of its input d.)It is biased well below cut off 57. The coupling that produces minimum interference with frequency response isa.) Direct coupling b.)Impedance coupling c.) R C coupling d.)Transformer coupling

58. In the circuit shown in the given figure Rf provides


senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 13/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

a.) Current series feedback b.)Current shunt feedback c.) Voltage series feedback d.)Voltage shunt feedback 59. Mark the correct relation for the junction transistor

60. Data in the serial form can be converted into parallel form by using a.) PISO shift registerb.) SOIP shift register c.) SIPO shift register d.) POIS shift register 61. PROMs are used to store-a.) bulk informationb.) information to be accessed rarely c.) sequence information d.) relatively permanent information 62. The horizontal axis in a 3 bit unipolar D/A converter represents-a.) Output bit combinationb.) analog output voltage c.) input bit combination d.) none of the above 63. Not allowed condition in NAND gate SR flip flop is a.) s = 0, R = 0b.) s = 1, R = 1 c.) s = 0, R = 1 d.) s = 1, R = 0 64. Name the fastest logic family-a) TTLb.) RTL c.) DCTL d.) ECL 65. Equation corresponding to De Morgans theorem in Boolean Algebra is a.) (A+B) (A+B) = AA + AB + BA + BB c.) A + AB = A d.) None of the above
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 14/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

66. In the given fig find radix of the system

a.) 2 b.) 4 c.) 6 d.) 8

67. Modems are used for data transmission telephone lines to a.) increase the transmission capacityb) improve noice performance c.) incorporate error control coding d.) eliminate dc component in the transmitted signal 68. The figure of a control system is shown. The maximum value of gain K for which the system is

stable isb.) 3 c.) 4 d.) 5

a.)

69. Identify the example of open-loop system-a.) A windscreen wiperb.) Aqualung c.) Respiratory system of an animal d.) A system for controlling Anti-rocket missiles. 70. Consider the following expressions indicating the step or impulse response of an initially relaxed control system-1. (5 4e-2+) u(t)2. (e-2t +5) (u(t)) 3 .V(t) + 8e-2t u(t)

4 . V(t) + 4e-2t 4(t) Those which correspond to the step and impulse response of the same system includea.) 1&3
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 15/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

b.) 1&4 c.) 2&4 d.) 1&4

71. A system is described by

To test its stability by Lyapunovs method the following V functions are considered.

Mark the most suitable V-function in this casea.) Only V1 b.) Only V2 c.) Both V1 and V2 d.) Neither V1 nor v2

72. Identity the polar plot of a typical type zero system with open loop transfer function

senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/

16/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

73. The scattering matrix of a magic tee shown in the given figure is-

74. Which is the following relate to rational transfer function of a system-1. Ratio of Fourier transform of output to input with zero initial conditions.2. Ratio of Laplace transform of output to input with zero initial conditions. 3. Laplace transform of system impulse response.
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 17/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

4. Laplace transform of system unit step response select the correct answer using the codes given below. Codes a.) 1 and 4 b.) 2 and 3 c.) 1 and 3 d.) 2 and 4 75. For the signal g (t) 10 cos (50 pt) cos2 (150at)The Nyquist sampling state in t seconds isa.) 150 samples per second b.) 200 samples per second c.) 300 samples per second d.) 350 samples per second 76. In the case of a 70 MHz 1F carries for a transponder band width of 36 MHz; energy must lie between MHz.a.) 34 and 106b.) 52. And 88 c.) 106 and 142 d.) 34 and 142 77. Radar used to eliminate clutter in navigational application is a.) Pulse radarb.) Tracking radar c.) MTI radar d.) Mono pulse radar 78. The 1.55 mm windows is not yet in use with fiber optic systems because a.) The attenuation is higher than at 0.85 mm b) The attenuation is higher than at 1.3mm c.) Suitable laser devices have not yet been developed d.) It does not lend itself to wavelength multiplexing 79. Pre-emphasis in FM systems involves-a.) Compression of the modulating signalb.) Expansion of the modulating signal c.) Amplification of lower frequency components of the modulating signal. d.) Amplification of higher frequency components of the modulating signal. 80. In a terrestrial microwave system transmission of signals is achieved through-a.) reflection from the ionosphereb.) line of sight mode c) reflection from the ground
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 18/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

d.) diffraction from the stratosphere.

81. Casse grain feed is used with a parabolic reflector toa.) increase the gain of the systemb). increase the bandwidth of the system c.) reduce the size of the main reflector d.) allow the feed to be placed at a convenient point.

82. In most microwave communication link rain drop attenuation is caused due to-a.) scattering of microwaves by water drops of specific size.b) scattering of microwaves by a collection of droplets acing as a single body. c.) absorption of microwaves by water and consequent heating of the liquid d.) absorption of the microwaves by water vapor in the atmosphere.

83. Circuit in the given figure represents. multivibrator b.) A monostable multivibrator c.) Voltage controlled oscillator d.) Ramp generator

a.) an astable

84. . . D = r is-a.) Maxwells 1st equationb.) Maxwells II equation c.) Maxwells III equation d.) Maxwells IV equation

85. In a rectangular wave-guide which TM mode exists-a.) TM00b.) TM01 c.) Tm10
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 19/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

d.) TM11

86. In directional coupler a portion of power two velliry fram port 1) to port 2) is coupled to.a). port 4b). port 3 c.) port 2. d.) port 3 & 4.

87. For high power i.e. 10 w to 50 kw measurement a.) Barometer are used b.) Thermisters are used c.) Calorimetric technique d.) Calorimetric watt meter technique used 88. The difference between TWT & klystron is a.) In TWT electrons are in contact with RF field for long time & in klystron for short time b.) In klystron electrons are in contact with RF field for long time & in TWT for short time c.) In klystron there is no contact in RF field & electrons while in TWT there is contact d.) In TWT phase is no contact is RF field & electrons while in klystron there is contact 89. Which one is most suitable for transmission through wave guidea.) Hown antennas b.) Bioconical antennas c.) helical antenna d. )Discone 90. The skip distance of microwave is given by
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 20/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

a.)

b. ) c.)

d.) 91. How many general purpose registers 8085mpa.) 4 b.) 6 c.) 8 c.) 10 92. 8085 mP has no. of addressing modesa.) 2 b.) 3 c.) 4 d.) 5 93. What will be status of z and c y flag after execution of SUB A instruction a.) z = 0, cy = 0 b.) z = 0, cy = 1 c.) z = 1, cy = 0 d.) z = 1, cy = 1

94. Microprocessor accept interrupt only if. a.) interrupt flip flop disabled. b.) when INTA signal is low.
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 21/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

c. ) interrupt flip flop enabled. d.) none of above. 95. Microprogramming is a technique a.) for programming the microprocessor b.) for writing small programs efficiently c.) for programming the control steps of computer d.) for programming o/p / i/p 96. High level programs like C are converted into machine language with the help ofa.) interpreterb.) compiler c.) operating d.) system 97. (10110011)2 = (?)8a.) 253b.) 263 c.) 273 d.) 283 98. A Not gate at the output of AND gate converts AND gate into-a.) NANDb.) NOR c.) AND d.) NOPE. 99. The O/P of a logic gate is c.) NAND d.) X-OR the gate must be-a.) ANDb.) OR

100. A symbol of JK flip flop is-

senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/

22/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

101. A demultiplener-a.) has multiple i/p and single o/pb.) has multiple i/p and multiple o/p c.) has multiple i/p and multiple o/p d.) has single i/p and single o/p 102. . Which of the following best describes the authour`s attitude toward fairy tales ?a.) fascinationb.) open approval. c.) Indulgent tolerance. d.) Scornful. 103. What type of sentence is this ?Hurray! We won the matcha.) Exclamatory b.) assertive c.) Negative d.) Affirmative 104. Before which of the following word will you put aa.) hourb.) M. A. c.) Umbrella d.) Man 105. The noun form of fresh is a.) freshlyb.) freshen c.) fresheners d.) fresh itself 106. The word clang is an example of a.) Simileb.) inversion c.) onomatopoeia d.) irony 107. The Forbes magazine acclaimed Azim Premji as richest Indias is the chairman of-a.) Pentafour softwareb) Infosys c.) IBM d.) Wipro 108. Bharat Ratna award for the year 2001 goes to-a.) Lata Mangeshkar and Zakeer Hussainb.) Zakeer Hussain and Bismillah Khan
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 23/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

c.) Bismillah Khan and Lata Mangeshkar d.) Lata Mangeshkar and Ustad Amzad Ali Khan 109. Mr. George W-Bush takes over as President of the united states of America succeeding Mr. Bill Clinton-a.) 42nd b.) 43rd c.) 40th d.) 45th 110. New Chief Minister of Pondicherry is-a.) T. Venkat Naidub.) K. Hari Harh c.) N. Rengaswany d.) M. Mudliar 111. No court has the jurisdiction to interfere with the election process once set in motion by the Election commission. This is enshrined in Article-a.) 311b.) 329 c.) 356 d.) 365 112. Ostrich is a-a.) Running birdb.) Flying bird c) Swimming bird d.) Migratory bird 113. The main atmospheric gas responsible for green house is-a.) Oxygenb.) Nitrogen c.) Ozone d.) Carbon-dioxide 114. Which of the following is not a Kharif Crop-a.) Riceb.) groundnut c.) Sugarcane d.) gram 115. The function of World Bank is to-a.) Help in reconstruction and development of world economyb.) Facilitate poor countries to trade on concessional rates c.) Promote growth of international trade and equilibrium in balance of payments d.) Ease trade barriers and establish rule of fair trade 116. Speed of sound is maximum in-a. )Waterb.) Air c.) Steel d.) Vacuum
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 24/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

117. Long years ago we made a trust with destiny. Whose words are these-a.) Subhash Chandra Boseb.) Jawaharlal Nehru c.) Lajpat Rai d.) Bhagat Singh 118. Durand cup is associated with-a.) Hockeyb.) Tennis c.) Football d.) Badminton 119. Rabindranath Tagore was awarded the Nobel Prize in literature in the year.a.) 1908b.) 1910 c.) 1913 d.) 1914 120. India successfully conducted its first underground nuclear experiment at Pokhran in Rajas than on-a.) May 18, 1975b.) May 20, 1974 c) May 17, 1974 d.) May 17, 1974 121. An emergency loan of $ 500 million to help reconstruct infrastructure in earth quake devastated Gujarat approved by-a.) Asian development Bankb.) World Bank c.) Swiss Bank d.) Reserve Bank of India

Book Your Air Ticket


Round Trip One Way Leaving from: Going to:
Mumbai Bangalore

Passengers:
1

Depart Date:

19

May

2012

Return Date:

*Conditions apply

ADVERTISEMENT Posted in Uncategorized | Tags: bhel, bhel electrical model test paper, bhel engineer trainee 2008 quetion paper, bhel engineer trainee exam, bhel engineer trainee exam model paper, bhel engineer trainee exam model question paper, bhel engineer trainee exam paper, bhel engineer trainee model question paper for electrical, bhel engineer trainee model question paper for telecom, BHEL latest model question paper, bhel latest question paper, bhel mechanical model question paper, bhel model question paper, bhel question paper, book for bhel engineer trainee electrical, book for bhel engineer
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 25/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

trainee telecom, books for bhel engineer trainee exam, electronics, engineer trainee exam paper, mechanical 1. hai da By: prabu on September 10, 2009 at 1:57 pm Reply Respected Sir, I am in need of previous years question papers with fully solved for ENGINEER TRAINEE ELECTRICAL looking forward for your mail.I am applying BHEL exam(3/09/2010) so please kindly help me sir.(88rajarajan@gmail.com). By: S.Rajarajan on September 7, 2010 at 1:06 pm Reply Sir I also want the previous years solved question papers of BHEL ENGINEER TRAINEEELECTRICAL since i applied for the bhel exam in 2010.Kindly forward me the question papers ti my mail id (elic1989@gmail.com) By: ELIZABATH on September 22, 2010 at 8:23 am 2. send model question By: shangar on September 11, 2009 at 8:13 am Reply 3. Hi friend i need answers for the above apptitude question paper please if u have that please send me By: Padmanaban on September 18, 2009 at 6:08 am
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 26/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

Reply Sure, answers ll be posted on sunday.. By: senthil4u on September 18, 2009 at 6:53 am Reply could you plz send me the ans of above ques . on my mail id er.arvinderbhatia@gmail.com (mailto:er.arvinderbhatia@gmail.com) By: Arvinder Singh on November 2, 2009 at 4:11 am r u got a answer this question plz frnd sent me my emil-id quetions and answer,plz send u know the techincal questions also plz i am waiting for ur mail By: balaji on October 12, 2009 at 10:32 am Reply Pl Send model question and answer for supervisor traniee in diploma mechincal engg By: R.Baskar on December 4, 2009 at 5:36 pm Reply 4. Thank you senthil. Do you have more questions?. if you have it please post it. By: P.KARUPPIAH on September 18, 2009 at 9:21 am Reply @Maheswaran & Karuppiah Sure friends, answers for this questions and new papers will be posted on sunday. Thanks for ur visit and tell ur friends too. Keep tracking for updated news and events.. By: senthil4u on September 18, 2009
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 27/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

at 12:58 pm Reply frd i need ans of above ques could u send me on my mail.. It help me a lot By: Arvd on November 2, 2009 at 4:14 am thanks a lot for your precious guidline for the appearing students. sir if u have u know about paper pattern and 4m which field max question asked tell me is there question put up 4m material, digital and microprocessor and 4m which field in quant and apti question asked. pls. reply me on my emailid By: manpreet singh on October 18, 2010 at 1:37 pm 5. Thanks Senthil..Its very useful for me for my prepation By: Maheswaran on September 18, 2009 at 11:50 am Reply 6. THANKS A LOT! KINDLY IF U HAVE A MORE QUESTION PAPER FOR BHEL OR ANY OTHER CORE LECTRICAL BRANCH PLZ SEND IT TO ME By: KRISHNENDU on September 19, 2009 at 2:49 pm Reply hai frnd plz send electrical question papers in bhel By: balaji on October 12, 2009 at 10:33 am Reply 7. Hi senthil, thanks for doing this.. Please post more questions with answers if you have..!
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 28/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

By: prabukumar on September 20, 2009 at 11:05 am Reply 8. HI Senthil, Could you please post some electronics stream questions too. Thanks for this post. By: inin on September 23, 2009 at 5:23 am Reply Hi, Please can u forward those questions if get them. I belong to Electronics stream By: ramesh on September 16, 2010 at 4:31 pm Reply 9. Hi Senthil, If you have answer for the above questions pls Forward. My e-id = ersudhakar08@gmail.com (mailto:ersudhakar08@gmail.com). Anf if u have some more question for EEE forward. By: Sudhakar on September 24, 2009 at 6:15 am Reply 10. sir if u ve model qst.ppr for mechanical (supervisor trainee) pls forward it to my mail id.. mailkrish.slm@rediffmail.com (mailto:mailkrish.slm@rediffmail.com) By: navaneeth on September 27, 2009 at 5:12 am Reply 11. This is nice blog
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 29/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

visit this blog for more question papers http://modelquestionpaperss.blogspot.com (http://modelquestionpaperss.blogspot.com) By: anandharaja on September 28, 2009 at 11:28 am Reply 12. Sir plz send elecrical question and answer paper for BHEL By: deepa on September 29, 2009 at 1:59 am Reply 13. difference between KVA and HP why ???REASon plz?explain the ans By: deepa on September 29, 2009 at 2:02 am Reply 14. Thankyou Senthil By: Pravin on October 1, 2009 at 6:28 am Reply 15. Thank u very much my dear By: m.selvam on October 1, 2009 at 9:46 pm Reply 16. Hi Senthil, Good job. Could you plz give me the Engineer trainee Mechanical q.papers to my mail. Thanks in Advance By: Ravi on October 6, 2009 at 7:14 am
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 30/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

Reply 17. hi senthil sir, wonderful job u did..thank you so much for electrical questions..i need some more..would you send me to my mail.. thank you in advance By: victor on October 11, 2009 at 3:03 pm Reply 18. Hi senthil sir nice job kindly send me the answer i will wait for ur answer By: Gouri sankar deep on October 16, 2009 at 5:29 am Reply 19. Hi senthil, can you send or post Model question paper or previous year papers for Mech discipline. It will very helpful for many of us. Can you pleas.. By: uthuman on October 16, 2009 at 8:06 am Reply 20. Hi senthil very nice job . Please send previous model questionpapers for ELECTRONICS discipline By: venkateswarlu on October 20, 2009 at 5:34 am Reply 21. sir please send model question papers on my gmail. By: ashish gupta on October 23, 2009 at 7:59 am Reply 22. hello sir, u did good job sir. i need the previous model questionpapers for ELECTRONICS
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 31/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

discipline. sir pls send to my mail.thank u sir By: premkumar.V on October 25, 2009 at 9:31 am Reply 23. I need solutions for it sir. please do so. By: Mohammed ali on November 3, 2009 at 4:30 pm Reply 24. hi sir can you send the model questions paper for engineer trainee (ELECTRONICS) with answers.please forward to mail. thank u. By: Deena dhayalan on November 7, 2009 at 7:56 am Reply i need the previous model questionpapers for ELECTRONICS discipline. sir pls send to my mail.thank u sir. By: k.prabha on November 12, 2009 at 1:01 pm Reply 25. Good job dude By: Ashwitha on November 7, 2009 at 5:20 pm Reply 26. Hi Senthil, Greetings! Your service is great to the young generation.
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 32/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

Please send me the model question papers for the following id anandsmm29@yahoo.co.in (mailto:anandsmm29@yahoo.co.in) By: Anand M on November 8, 2009 at 5:50 am Reply 27. thanks a lot . can u plz send me the answers on my mail id. jagdishcnikam@gmail.com (mailto:jagdishcnikam@gmail.com) By: jagdish on November 8, 2009 at 2:30 pm Reply 28. i want bhel model question papers for diploma electronics By: vinoth on November 9, 2009 at 6:55 am Reply 29. hi senthil,could you give me some tips to prapare the Supervisor trainee exam in BHEL for electronics and communication how can i see the answers for teh above questions..thanks vijay By: vijay on November 9, 2009 at 1:29 pm Reply 30. Sir plz send elecrical question and answer paper for BHEL If you have answer for the above questions pls Forward. My e-id = vittal.255@gmail.com (mailto:vittal.255@gmail.com) Anf if u have some more question for EEE forward By: vittal on November 9, 2009 at 4:51 pm
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 33/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

Reply 31. I AM ITI OLDER By: NAGENDRA CG on November 9, 2009 at 6:13 pm Reply 32. Hi , I want the answer for above questions, Also if you have more question for EEE,plz forward to my mailid. By: Sunita on November 10, 2009 at 4:22 am Reply 33. hi senthil please send more questions in electrical for BHEL preparation.my id is ramsai216@gmail.com (mailto:ramsai216@gmail.com) By: sai raghu on November 10, 2009 at 7:39 am Reply 34. hai please send model question paper to below mail id sharanaiah.chm@gmail.com (mailto:sharanaiah.chm@gmail.com) if u have answer means please forward thank u By: sharanaiah on November 10, 2009 at 2:21 pm Reply 35. Hi da, I guess you might be real busy but it will be very kind of you, if you can send me all the Mechanical question papers that you have on my mail id. By: Rahul Kshatriya on November 10, 2009 at 7:57 pm Reply
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 34/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

36. mail Id is: rahul_28186@yahoo.co.in (mailto:rahul_28186@yahoo.co.in) By: Rahul Kshatriya on November 10, 2009 at 7:58 pm Reply 37. sir, i need previous year paper for engineer trainee in the stream of electronics. pls send to my email id as soon as possible By: muthamizh on November 11, 2009 at 5:51 am Reply 38. sir, i need previous year paper for engineer trainee in the stream of electronics. pls send to my email id as soon as possible. my mail id is muthamizhece@gmail.com (mailto:muthamizhece@gmail.com) By: muthamizh on November 11, 2009 at 5:53 am Reply 39. i need model question papers for engineer trainees!! it ll b more helpful for me if u sent it as early as possible as im gonna write exam on nov 29!! send it to my email id: sindhu9369@gmail.com (mailto:sindhu9369@gmail.com) thanks!! By: sindhu on November 12, 2009 at 6:13 am Reply Dear sir, i need previous exams model question in supervisor trainee in electronics & communication. so please send to my e-nail id. my mail is santoshgouda88@gmail.com (mailto:santoshgouda88@gmail.com) By: santosh on October 8, 2010 at 2:46 pm
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 35/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

Reply 40. i need the previous model questionpapers for ELECTRONICS discipline. sir pls send to my mail.thank u sir By: k.prabha on November 12, 2009 at 1:17 pm Reply 41. sir i need bhel model ques papers for electronics(engineer trainee) By: k.prabha on November 12, 2009 at 1:19 pm Reply 42. i need electronics model ques paprs for bhel engineer trainee By: k.prabha on November 12, 2009 at 1:21 pm Reply 43. Sir, I want answers for this questions. Pls forward to my ID saru.madu@gmail.com (mailto:saru.madu@gmail.com) By: Saruvanan on November 12, 2009 at 3:38 pm Reply 44. Dear sir please send electrical &janaral qustion&answer in bhelwritten test By: Ashoka h n on November 13, 2009 at 5:54 am Reply 45. Hi senthil,
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 36/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

Thanks U Very much., By: N.A.Karthick on November 14, 2009 at 5:45 am Reply 46. thanks 4 these questions could u plz send me the answers on my mail id. and some more questions on Electronics with answers. Thnaks By: Monojit DAs on November 15, 2009 at 3:07 pm Reply 47. hello sir i want to know the ans for the above appti ques.. pls sent me 2 my mail id sir thank u.. By: vidhya on November 16, 2009 at 8:14 am Reply 48. sir, Sir please send elecrical question and answer paper for BHEL If you have answer for the above questions pls Forward. My mail id shivamoorthyd@gmail.com (mailto:shivamoorthyd@gmail.com) Anf if u have some more question for EEE forward By: shivasankaramoorthy on November 16, 2009 at 8:49 am Reply 49. please send the answers to my email, and also any electronics questions if you have. By: sai on November 16, 2009 at 9:30 am
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 37/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

Reply 50. sir please sir..send answer sir..otherwise i ll commit suicide sir. please post the answer By: zitizensiva on November 17, 2009 at 12:47 pm Reply 51. sir can you pls send me the ans for the above qts to my mail i.d? By: anwar on November 17, 2009 at 2:40 pm Reply 52. where is the answer? By: P servarmuthu on November 19, 2009 at 5:59 am Reply 53. thanks 4 questions,can u pls send me the answers to this i.d pandiduraibe@yahoo.com (mailto:pandiduraibe@yahoo.com) By: pandidurai on November 20, 2009 at 8:52 am Reply 54. Respected Sir, I want bhel model question paper and its syallabus for ET(electronics) exam in my ID pradeepkumarece@rediffmail.com (mailto:pradeepkumarece@rediffmail.com) By: pradeep on November 21, 2009 at 7:59 am Reply 55. hi sir can u please send me electrical question and answer for bhel paper and also the answers of above questions.my id is ankita101@rediffmail.com (mailto:ankita101@rediffmail.com)
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 38/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

By: ankita on November 23, 2009 at 2:40 pm Reply 56. very useful.plz give the answers also By: vaisakh on November 24, 2009 at 12:19 pm Reply 57. send me bhel model paper answers By: bayareddy on November 24, 2009 at 5:49 pm Reply 58. really very useful info regrading written.testcan u ppl provide some more bhel papers in electrical for ET-2009 By: prathibha on November 25, 2009 at 8:12 am Reply 59. pls send model question papers in mechanical engg for bhel examination. immedietly sir pls. By: ksavan on November 27, 2009 at 5:18 am Reply 60. please send the answers for the electrical questions By: A.VIJAYANAND on November 29, 2009 at 1:34 pm Reply 61. sir pl send model question and answer for supervisor traniee in diploma mechinecal engg
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 39/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

By: R.Baskar on December 4, 2009 at 5:19 pm Reply 62. really nice way to get strength, confidence for exam to see ur paper pattern good for all student keep it up bye By: pravin on January 16, 2010 at 4:17 pm Reply 63. Dear Sir, Can you please send some model questions on electrical trade and Machinist trade -ITI based Thank You joelb1995@gmail.com (mailto:joelb1995@gmail.com) By: Joel on May 9, 2010 at 5:45 pm Reply 64. sir please send me bhel question papers along with the answers key in my id swati.imthebest@gmail.com (mailto:swati.imthebest@gmail.com) By: swati on August 3, 2010 at 10:24 am Reply 65. SIR OF EE BRANCH By: swati on August 3, 2010 at 10:26 am Reply 66. can u send the solutions .please. By: navdeep on August 30, 2010 at 5:40 pm
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 40/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

Reply 67. my email id is navdeepjatian@yahoo.com (mailto:navdeepjatian@yahoo.com) By: navdeep on August 30, 2010 at 5:42 pm Reply 68. hi senthil, hey cud u plz snd me bhel ETS qps tnk q plzzzzzzzzzzzzzzzzzzzzz my id emmi.arun@gmail.com (mailto:emmi.arun@gmail.com) tnqqqqqqqqqqq By: emmi on August 31, 2010 at 6:26 am Reply 69. senthil, By: emmi on August 31, 2010 at 6:27 am Reply 70. Respected Sir, I want bhel previous question paper for electrical department By: Elambirai on September 1, 2010 at 3:22 am Reply 71. sir plz send me the que paper nd its ans(electrical nd elecronics) on my id By: meenakewat on September 1, 2010 at 7:31 am Reply 72. sir,

senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/

41/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

By: aruna on September 1, 2010 at 11:34 am Reply 73. hai,please any one tell me which books to refer for bhel exam 4 both appti and technical as im preparing 4 engineers trainee exam,im an electrical and electronic student By: shylaja on September 1, 2010 at 2:17 pm Reply 74. sir it would b a great help if u cud mail me some model questions in addition to those posted here appended with answersmy mail id(sourabhjuneja@gmail.com) By: sourabh on September 2, 2010 at 6:37 am Reply 75. Pl Send model question and answer for supervisor trainee in diploma mechanical engg By: kanchan kumar nonia on September 2, 2010 at 3:06 pm Reply 76. sir pl send model question and answer for supervisor trainee in diploma mechanical engg.my email id is kanchanmech_2007@rediffmail.com (mailto:kanchanmech_2007@rediffmail.com). By: kanchan kumar nonia on September 2, 2010 at 3:13 pm Reply 77. Thanks a lot Mr.senthil4uI think it will be very useful for methanks again By: Immanuel.C.V on September 2, 2010 at 3:30 pm Reply 78. Respected Sir,
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 42/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

I am in need of previous years question papers with fully solved for ENGINEER TRAINEE ELECTRICAL looking forward for your mail By: kanimozhi on September 3, 2010 at 2:26 am Reply 79. sir, kindly send me previous years papers of bhel and some important questions By: priyanka on September 3, 2010 at 2:31 pm Reply 80. sir pl send model question &answer for general engg & give me some modal paper for electrical engg in sandesh4vishal@yahoo.co.in (mailto:sandesh4vishal@yahoo.co.in) By: vishal on September 3, 2010 at 4:58 pm Reply 81. dear sir send me previous question papers&answers for ME to my mail address yssjcet324@gmail.com (mailto:yssjcet324@gmail.com) By: Rajasekhar Reddy on September 4, 2010 at 11:09 am Reply 82. sample question paper of bhel for supervisor trainee By: raghvendra singh on September 5, 2010 at 7:05 am Reply 83. Respected Sir, I am in need of previous years question papers with fully solved for supervisur TRAINEE mechanical looking forward for your mail
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 43/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

By: rakesh ranjan on September 5, 2010 at 8:37 am Reply 84. Respected Sir can u please send me electrical question and answer for bhel paper and also the answers of above questions.my id is meenakewat@yahoo.com (mailto:meenakewat@yahoo.com) By: meena kewat on September 6, 2010 at 1:48 pm Reply 85. respected sir, can u please send me electrical questions and answers for bhel paper and also the answers of above questions.my id is p.usha.235@gmail.com (mailto:p.usha.235@gmail.com) By: usha on September 7, 2010 at 7:03 am Reply 86. hai sir I am in need of previous years question papers with fully solved for supervisur TRAINEE ELECTRICAL thanking u sir By: tagore on September 7, 2010 at 9:12 am Reply 87. hai sir I am in need of previous years question papers with fully solved for supervisur TRAINEE ELECTRICAL this is my id tag2082@gmail.com (mailto:tag2082@gmail.com) thanking u sir
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 44/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

By: tagore on September 7, 2010 at 9:16 am Reply 88. Hi Senthil, if you have more question papers for BHEL or any core electrical company please send me those to my email id..my discipline is Electrical. Regards Soumi Chaki By: Soumi Chaki on September 7, 2010 at 12:52 pm Reply 89. hello sir can u please send me the electronics previous model paper so that it will help to many of us. kindly Awaiting for the response pls sir By: avinash on September 7, 2010 at 2:45 pm Reply 90. SEND ME SOME MODEL QUESTION PAPERS FOR THE REQUIREMENTS OF BHEL FOR DIPLOMA IN ELECTRONICS IN 2010SEPTEMBER PLZ By: MAHESH on September 7, 2010 at 3:44 pm Reply 91. hi senthil , thanks for ur valuable post . send me more model Q-papers for ET(electrical) my id: varung46@gmail.com (mailto:varung46@gmail.com) By: varun on September 7, 2010 at 4:33 pm Reply 92. thanx brother
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 45/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

By: sujin on September 7, 2010 at 6:51 pm Reply 93. i want mech ques papers . I am appearing for ET of BHEL.So kindly mail me to the mentioned email id. By: karthi on September 7, 2010 at 9:54 pm Reply 94. Hi Senthil, Good job. Could you plz give me the Engineer trainee MECHANICAL q.papers to my mail. (thiban87@gmail.com) Waiting for your reply . . (VERY URGENT) By: parthiban on September 8, 2010 at 10:48 am Reply 95. pls any body send me bhel syllabus for electronics my email id is maelect_12@yahoo.com (mailto:maelect_12@yahoo.com) By: mamta on September 8, 2010 at 11:19 am Reply 96. sir, i want bhel electreical question papers with answers.can u mail me By: neha on September 8, 2010 at 12:49 pm Reply 97. sir will u send me bhel electrical question papers By: neha on September 8, 2010
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 46/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

at 12:52 pm Reply Sir, please send me a BHEL question papers. By: Puneet Gupta on September 14, 2010 at 11:38 am Reply 98. Please anybody send me bhel previous question papers for electronics my email ID is inr_kumari@yahoo.com (mailto:inr_kumari@yahoo.com) By: kumari on September 9, 2010 at 5:28 am Reply 99. Respected Sir i want electronics discipline question papers fully solved pls send to my id rjlakshmi28@gmail.com (mailto:rjlakshmi28@gmail.com) By: rajalakshmi on September 9, 2010 at 11:05 am Reply 100. Hi Senthil, Thanks a lot for your valuable comments and the Q paper. Can u pls send me more ET (Electrical) question papers with answers to my mail id mail_to_sibi@yahoo.com (mailto:mail_to_sibi@yahoo.com) Regards, Sibi By: sibi on September 10, 2010 at 11:21 am Reply 101. sir, plz mail me previous question papers of bhel of mechanical engineer for supervisor trainee. with regards
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 47/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

By: jasvir kumar on September 10, 2010 at 3:56 pm Reply 102. can any one send bhel electronics previous papers and topics to study and books to refer By: kiran on September 10, 2010 at 7:01 pm Reply 103. hello sir,u did really a grt job..kindly send me the answers pls.. By: karthika on September 11, 2010 at 4:34 am Reply 104. Sir, I am on my preparation for the Bhel exam On 31 Oct for Engineer trainee, the above questions were useful, it will be useful for me if u could forward some more question templates for my preparation. zulfihar.05@gmail.com (mailto:zulfihar.05@gmail.com) By: A Zulfihar on September 11, 2010 at 8:00 am Reply 105. Hello Sendil Sir, I am preparing for BHEL Entrance examination for supervisor trainee could you kindly consider my request for question papers of mechanical engineering. By: Madhav on September 12, 2010 at 3:06 pm Reply 106. sir i am preparing for BHEL supervisor trainee exams 2010commencing on oct24th. kindly send me the model question papers for electrical engg instrumentation and controls with solved answers .thank you. my email id is janakiraman.69@gmail.com
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 48/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

(mailto:janakiraman.69@gmail.com) By: K Janakiraman on September 12, 2010 at 3:36 pm Reply 107. SIR, i hav applied for ENGINEER TRAINEE in BHEL. i want to prerare wel for the exam. pl tel me the syllabus and also from where i can get the model question paper and other necessary information. i hav finished BE in Electricals and Electronics. pls do reply. i am waitin for it thank u.. By: LAVANYA on September 13, 2010 at 7:03 am Reply 108. Can any one send BHEL previous year question paper with answer,main topic to study and reference book. my emeail id is ashishchopra1988@gmail.com (mailto:ashishchopra1988@gmail.com) By: Ashsih Chopra on September 13, 2010 at 8:30 am Reply 109. Hello Senthil Sir, I am preparing for BHEL Entrance examination for supervisor trainee could you kindly consider my request for previous or model question papers of mechanical engineering. By: n.venkateswara rao on September 13, 2010 at 10:11 am Reply 110. sir, I have completed BE in E&C. Please send me the syllabus and model question paper to prepare for BHEL test. Or let me know where i can get that.. my e-mail : rahul.se87@gmail.com (mailto:rahul.se87@gmail.com) Thanks in advance.. By: rahul on September 14, 2010 at 8:52 am
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 49/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

Reply 111. Sir, please send me a BHEL question papers..its a request. By: Puneet Gupta on September 14, 2010 at 11:40 am Reply 112. sir plz send me the answers of above questions with ful explanation. By: sushma on September 14, 2010 at 7:12 pm Reply 113. my id is sushmachinnu07@gmail.com (mailto:sushmachinnu07@gmail.com). pls send me d answers n send me some more prev papers sir bcoz first time im attending dis xam.. pls tel me d syllabus n pattern. By: sushma on September 14, 2010 at 7:17 pm Reply 114. plz send bhel st model question By: arul on September 15, 2010 at 6:03 am Reply 115. great morning..sir., dis is hari prasad.. im attending.the xam.1 time. on oct 24th..for supervisor trainee. so please.provide.me with previous question papers..and answers.sir. my id .. chinna013@gmail.com (mailto:chinna013@gmail.com) By: hari prasad on September 15, 2010 at 6:49 am Reply 116. i want some more question.thanx.
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 50/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

By: rohini piplewar on September 15, 2010 at 9:19 am Reply 117. www By: mahalakshmi on September 16, 2010 at 5:11 am Reply 118. RESPECTED SIR i am preparing for BHEL superviser trainee examination. so plz send me a solved question paper for CIVIL displine. my email id sonuguptaiert@rediffmail.com (mailto:sonuguptaiert@rediffmail.com) thank you sir By: sonu kumar gupta on September 16, 2010 at 10:20 am Reply 119. sar iam attending the supervisr posts please send me previous model papers By: gopi sagar on September 16, 2010 at 1:22 pm Reply 120. Dear sir, i am on my preparation for the BHEL exam on 31st oct 2010 for engineer trainee can u send me some more question and syllabus for engineer trainee BHEL because i have just finished my engg. from ELECTRICAL AND ELECTRONICS and i want to do well preparation.so i am waitin plz send me the questions with answers on my email ID:rammanohar1605@gmail.com By: RAM MANOHAR on September 16, 2010 at 1:44 pm Reply 121. sir please send me the sample paper and model question paper for mechanical.kindly send me this.
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 51/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

By: yazar on September 16, 2010 at 5:22 pm Reply 122. my id is yazar1988@gmail.com (mailto:yazar1988@gmail.com) By: yazar on September 16, 2010 at 5:22 pm Reply 123. hi,i am a BE(ECE) graduate.Ineed model question papers for bhel.plz send it to my email.idsaranyaa.sudar@gmail.com.Also (mailto:email.id-saranyaa.sudar@gmail.com.Also) send me many electronics related questions ,it will be very useful for me to prepare.Thanks in advance By: saranyaa on September 17, 2010 at 11:02 am Reply 124. i am applying for bhel 2011 please can u send me the previous question for electrical and electronics By: kaushik on September 17, 2010 at 11:40 am Reply 125. am a electrical student, plz send model papers related electrical enggnering to may mail of any competetion exam. please sirrr By: giridhar kumar on September 17, 2010 at 1:54 pm Reply 126. Dear sir im going to appear for engineer trainee for BHEL 2010 to be held on october.I want previous year question pattern with answers and also some sample paper.My branch is E&C.. Looking forward for reply. Plz reply to my email-robina.laishram@gmail.com (mailto:email-robina.laishram@gmail.com)
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 52/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

By: robina on September 17, 2010 at 6:56 pm Reply 127. Sir im going to appear supervisor trainee mechanical engg. 2010. So i need old question papers for preparing so you have to do a concern of me. Please sir send me old question papers & syllabus. pksaini111@gmail.com (mailto:pksaini111@gmail.com) By: Pankaj saini on September 18, 2010 at 3:40 am Reply 128. hi,i am a BE(Electrical) graduate.I need model question papers for bhel.plz send it to my email.id-riteshsingh116@gmail.com (mailto:email.id-riteshsingh116@gmail.com) or riteshsingh116@yahoomail.com.Also (mailto:riteshsingh116@yahoomail.com.Also) send me many electrical related questions ,it will be very useful for me to prepare.Thanks in advance. By: ritesh singh pal on September 18, 2010 at 8:40 am Reply 129. Hi I am a BE(Electrical) graduate. I need model test question papers for bhel exam. Plz send it to my email.id-riteshsingh116@gmail.com (mailto:email.id-riteshsingh116@gmail.com) or riteshsingh116@yahoomail.com (mailto:riteshsingh116@yahoomail.com). Thanks in advance. By: ritesh singh pal on September 18, 2010 at 8:46 am Reply 130. Sir plz send elecrical question and answer paper for BHEL By: Vibhuti Dhyani on September 18, 2010 at 12:32 pm Reply
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 53/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

131. Sir i m preparing for bhel 2010 so plz send elecrical question and answer paper for BHEL By: Vibhuti Dhyani on September 18, 2010 at 12:35 pm Reply 132. sir, pls send me electrical supervisor trainee model question papers to my e-mail id. thanks. By: Mohamed siddhik on September 18, 2010 at 2:12 pm Reply 133. sir, please send me bhel super trainee ELECTRICAL AND ELECTRONICS model question papaer By: suleman on September 19, 2010 at 12:26 am Reply 134. Sir i am mechanical diploma holder preparing for Bhel ST exam.if u can pls sent previous Qustion papaers it s very good to me By: Rakesh on September 19, 2010 at 6:01 am Reply 135. I REQUIRE D PREVIOUS QUESTION PAPER FOR BHEL MECHANICAL ENGINEER TRAINEE PLZ SRND ON MY MAIL By: ANKUR BANSAL on September 19, 2010 at 1:57 pm Reply 136. Hi Senthil, Good job. Could you plz give me the Engineer trainee MECHANICAL q.papers to my mail. (bala143341@gmail.com)
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 54/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

Waiting for your reply . . (VERY URGENT) By: balaji on September 19, 2010 at 4:01 pm Reply 137. HI SIR, thank u.i am an ece student.i want previous pattern with solution.and also some sample papres.plz reply me sir. By: Aarthi on September 20, 2010 at 7:54 am Reply 138. I m going to appear for electrical engineer trainee 2010 so pls send me previous year quesion papers By: ANKITA on September 20, 2010 at 11:28 am Reply my id is ankitajaiin@gmail.com (mailto:ankitajaiin@gmail.com) By: ANKITA on September 20, 2010 at 11:30 am Reply 139. sir can u sent me d pattern of questions & question papers for EEE wid ans key? waiting for the reply Plz reply to my mail id grrakhi@gmail.com (mailto:grrakhi@gmail.com) By: Rakhi on September 20, 2010 at 2:23 pm Reply 140. Hi sir, Ur service to the young generation is great.
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 55/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

Sir, am going to appear for the BHEL test (2010). So can u please kindly send me the solutions for the previous q. papers to my mail i.d. revanth1989@yahoo.in (mailto:revanth1989@yahoo.in) Thank you sir, Waiting for your mail. Have a great day sir. By: Revanth Kumar on September 20, 2010 at 2:37 pm Reply 141. sir, me applied supervisor trainee. so please send me the sample paper and model question paper for mechanical .kindly send me this. By: VINOD KUMAR M on September 20, 2010 at 4:34 pm Reply 142. HI SIR, I am an ece student and have applied for engineet trainee in BHEL . please help me as i want previous pattern with solution.and also some sample papres.plz reply me on my mail id : garv.me.bisht@gmail.com (mailto:garv.me.bisht@gmail.com) By: GAURAV BISHT on September 21, 2010 at 6:22 am Reply 143. sir, i write the examination for BHEL ,i humble requiste please send me the sample paper and model question paper for electronics .kindly send me this. By: prasath on September 21, 2010 at 8:08 am Reply 144. Could you plz give me the Engineer trainee MECHANICAL q.papers to my mail. (thiganbe@gmail.com) By: thigan on September 21, 2010
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 56/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

at 4:51 pm Reply 145. dear sir iam going to appear for Bhel engineer trainee 2010.my branch is E&C.could u plz send me previous years questions with answer to my gmail accountrobina.laishram@gmail.com (mailto:account...robina.laishram@gmail.com) By: robina on September 22, 2010 at 10:10 am Reply 146. i need some model question papers and syllabus for st in electronics. 24 Oct 2010 By: Nanjundamoorthy.P on September 22, 2010 at 11:46 am Reply 147. i am going to appear for electrical engineer trainee 2010 so pls send me previous year quesion papers By: sonish on September 22, 2010 at 12:25 pm Reply 148. hi sirkindly send me the model question papers for BHEL in mechanical engg. email id: getajitesh2k6@gmail.com (mailto:getajitesh2k6@gmail.com) By: ajitesh das on September 22, 2010 at 1:20 pm Reply 149. im going to apppear in BHEL Engineer trainee 2010 exam. my branch is ECE. so send me the model Q&P.my id is ervinodh@rediffmail.com (mailto:ervinodh@rediffmail.com) thanks By: vinodh on September 22, 2010 at 1:21 pm Reply
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 57/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

150. Sir I want the previous years solved question papers of BHEL ENGINEER TRAINEE- ELECTRICAL since i applied for the bhel exam in 2010.Kindly forward me the question papers to my mail id (musthafa879@gmail.com) By: mohd musthafa k on September 23, 2010 at 7:51 am Reply 151. HiGood job.. By: Mrssa on September 23, 2010 at 10:22 am Reply 152. Hi, Hi sir can you please inform which is the best book for BHEL preparation for Electrical trainees??? Waiting for your reply. Thanks in advance HARIKRISHNA K V By: Haikrishna k v on September 23, 2010 at 10:52 am Reply 153. Hi sir, at the same time if you dont mind can you please send me the previous year question papers in electrical stream for BHEl??? By: Haikrishna k v on September 23, 2010 at 11:01 am Reply 154. I require the previous question paper for bhel electronics engineer trainee. plz send it to my email shwetasingh135@gmail.com (mailto:shwetasingh135@gmail.com)& shwetasingh135@yahoo.com (mailto:shwetasingh135@yahoo.com) By: Shweta on September 23, 2010
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 58/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

at 11:37 am Reply Hai Shwetha, I need the last year Model question paper and any keyword of BHEL Model question paper.Pls send to the my mail-id. By: sasikumar on September 28, 2010 at 6:32 am Reply 155. im going to apppear in BHEL Engineer trainee 2010 exam. my branch is ECE. so send me the model Q&P.my id is rohit_gat05@yahoo.co.in (mailto:rohit_gat05@yahoo.co.in) By: rohit sharma on September 23, 2010 at 12:33 pm Reply 156. hello senthil sir, i applied for bhel et exam.my discipline is electronics engg.plssend me prev year que paper of ece dept my mail id sudharaj_13e@yahoo.in (mailto:sudharaj_13e@yahoo.in) By: SUDHA on September 23, 2010 at 12:58 pm Reply 157. HELLO SENTHIL SIR THANKS FOR SENDING THE PAPER BUT IAM NOT EEE BRANCH. I WANT MODEL PAPER FOR ELECTRONICS AND COMMUNICATION DEPARTMENT.PLS SEND ALL PREVIOUS YEAR PAPERS OF ECE FOR ET EXAM OF BHEL. By: SUDHA on September 23, 2010 at 3:13 pm Reply 158. Sir,I have applied BHel ET,2010 please send me last year solved exam

senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/

59/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

By: Iqbal on September 24, 2010 at 11:18 am Reply 159. hi Senthil, It would be a very great help if u can guide us regarding ECE paper. Thanks in advance By: Priyanka on September 24, 2010 at 1:36 pm Reply 160. sir please send me previous qwetion papers of bheland answers also By: narayana on September 24, 2010 at 4:24 pm Reply 161. my emil id narayana.470@gmail.com.sir (mailto:narayana.470@gmail.com.sir) send me ECE bhel previous papers By: narayana on September 24, 2010 at 4:27 pm Reply 162. sir iam gong to appear exam for mechanical supervisour trinee on 24/10/2010 so please send previous question and modal paper to my gmail account bhupathivijay@gmail.com (mailto:bhupathivijay@gmail.com) By: Bhupathi Vijay Goutam on September 25, 2010 at 6:03 am Reply 163. thank you.. till now i dont know the actual standard of bhel elecrical paper. i got it now.. please send me syllabus , model papers for electrical(both engineer trainee, supervisor trainee). please tell me how should i prepare? By: krishna p on September 25, 2010 at 8:42 am
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 60/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

Reply 164. sir i am preparing for BHEL supervisor trainee exams 2010commencing on oct24th. kindly send me the model question papers for electrical engg. with solved answers .thank you. my email id is chattarajdeb6@gmail.com (mailto:chattarajdeb6@gmail.com) By: Debbrata Chattaraj on September 25, 2010 at 2:08 pm Reply 165. hi sir, thanks for ur questions please send engineer trainee ece papers, if you can to my email id rajeshvissamsetty@gmail.com (mailto:rajeshvissamsetty@gmail.com) By: RAJESH on September 26, 2010 at 12:40 pm Reply 166. Hi Senthil, I applied for BHEL ET post. Plz send me old question papers for EEE branch.My Id is ramsai216@gmail.com (mailto:ramsai216@gmail.com). By: sai on September 26, 2010 at 1:50 pm Reply 167. plz send all available questions in electronics to my id shanavas222@gmail.com (mailto:shanavas222@gmail.com) By: shanavas on September 26, 2010 at 6:39 pm Reply 168. Can you pls. send BHEL Supervisor trainee model question paper ? By: D.SURESH on September 27, 2010 at 9:11 am Reply
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 61/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

169. Sir, Im preparing for bhel 2010 engineer trainee exam in ELECTRICAL stream so pls send me previous years solved question papers to my mail. Mail id: asugan4@gmail.com (mailto:asugan4@gmail.com) By: sugan a on September 27, 2010 at 1:42 pm Reply 170. i want bhel model question paper to my id By: gunasekaran on September 27, 2010 at 7:47 pm Reply 171. i am going to write engineer trainee exam in bhel. but i was 2006 passed out student.so i am very nevous to attend the exam.becoz technical part is very difficult so anybody can help me in preparation.send ur opinion to keerthi28@gmail.com (mailto:keerthi28@gmail.com) By: keerthi on September 28, 2010 at 9:24 am Reply 172. plz send ECE previous quetion papers By: keerthi on September 28, 2010 at 9:25 am Reply 173. plz send ECE previous quetion papers to keerthi28@gmail.comand (mailto:keerthi28@gmail.comand) suggetions about preparation and everything By: keerthi on September 28, 2010 at 9:27 am Reply 174. Hi Senthil, I applied for BHEL ST in Electronics branch.Please send previous question paper.Exam is commensing on 24 OCT 2010.My id is
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 62/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

sgskumar_uma@yahoo.cm (mailto:sgskumar_uma@yahoo.cm) By: S G Senthilkumar on September 28, 2010 at 9:49 am Reply 175. Hi, Can you send me few question papers for BHEL-Electronics. I will be very helpful for me By: Muthu on September 28, 2010 at 3:59 pm Reply 176. i applied bhel for the post of supervisor trainee please send me the privious years question paper for ece to id is rajaselva.be@gmail.com (mailto:rajaselva.be@gmail.com) By: rajesh on September 29, 2010 at 11:42 am Reply 177. hi senthil thanks for question paper publish in website , it is very usefull for me , pls do this type of work, we want more question paper By: hema on September 29, 2010 at 11:44 am Reply 178. thnks sir its very helpful to me, can u send previous electrical paper of BHEL please email id is amitvivek1989@gmail.com (mailto:amitvivek1989@gmail.com) By: amit on September 29, 2010 at 2:34 pm Reply 179. hello sir, i have applied for bhel et exam 2010 .My discipline is electrical engg. Please send me prev year que paper of eee dept. My mail id ashanka25@gmail.com (mailto:ashanka25@gmail.com)
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 63/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

regards, ashanka By: ashanka singh on September 29, 2010 at 3:35 pm Reply 180. Respected sir, please send or advise me 4 sup tr.(mech.) solved question paper By: DHIRENDRA on September 30, 2010 at 1:42 am Reply 181. Sir, It would be a great help if you send me the model question paper for BHEL (Mechanical) for ENGINEER TRAINEE. My exam is on 31st oct. By: AMIYA KUMAR MANDAL on September 30, 2010 at 7:09 am Reply 182. plz Can you send me few question papers for BHEL-Electronics. I will be very helpful for me By: sandeep on September 30, 2010 at 7:28 am Reply 183. plz Can you send me few question papers for ET BHEL-Electronics. I will be very helpful MY mail id batlisandeep@gmail.com (mailto:batlisandeep@gmail.com) By: sandeep on September 30, 2010 at 7:40 am Reply 184. Hi Sir, Hats off! I appreciate the kind of initiative you have taken.Could you please mail me the previous bhel question paper or any links to bhel question papers. my mail id is ruk_eee35@yahoo.co.in (mailto:ruk_eee35@yahoo.co.in)
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 64/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

Thank u By: Rukmani on September 30, 2010 at 1:40 pm Reply 185. Hi Sir, My discipline is Electricals. I have applied for ET in BHEL By: Rukmani on September 30, 2010 at 1:43 pm Reply 186. i have applied for electronics n tele. can u send me paper on my mail id is shrikant.tayade1988@gmail.com (mailto:shrikant.tayade1988@gmail.com) By: SHRIKANT on October 1, 2010 at 6:55 am Reply 187. RESPECTED SIR i am preparing for BHEL superviser trainee examination. so plz send me solved question papers for Electrical displine. my email id nikeshpv@yahoo.com (mailto:nikeshpv@yahoo.com) By: Nikesh pv on October 1, 2010 at 10:08 am Reply 188. Sir, Im preparing for bhel 2010 supervisor trainee exam in ELECTRICAL stream so pls send me previous years solved question papers to my mail. Mail id: vinojce@gmail.com (mailto:vinojce@gmail.com) By: vinothkumar on October 2, 2010 at 7:18 am Reply 189. hii i am preparing for bhel exam pls send me more questions if its possible for u
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 65/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

By: khakre durga shivdas on October 2, 2010 at 7:36 am Reply 190. sir pls send me more questions related to electrical branch my email id is dkhakre@yahoo.co.in (mailto:dkhakre@yahoo.co.in) By: khakre durga shivdas on October 2, 2010 at 7:39 am Reply 191. sir, i am applied for the post of supervisor trainee in bhel.my discipline is electronic.please send me some previous year solved papers. thanks. By: Vikrant kumar on October 2, 2010 at 8:14 am Reply 192. sir, i am applied for the post of supervisor trainee in bhel.my discipline is electronics.please send me some previous year solved papers. thanks. By: Vikrant kumar on October 2, 2010 at 8:14 am Reply 193. plz Can you send me few question papers for ET BHEL-Electronics. I will be very helpful MY mail id By: shailender on October 2, 2010 at 9:35 am Reply 194. it is possible
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 66/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

By: bibin on October 3, 2010 at 10:54 am Reply 195. sir , send bhei previos papers ,subject wise marks By: lakshmi on October 4, 2010 at 3:03 pm Reply 196. sir, send BHEL previous papers and subject wise hw many questions wil com?.. By: lakshmi on October 4, 2010 at 3:05 pm Reply 197. ece papers.. By: lakshmi on October 4, 2010 at 3:08 pm Reply 198. Can you send mechanical engineer last year questions for supervisor trainee. By: M.karthick on October 4, 2010 at 8:55 pm Reply 199. Hi i am applied for the post of supervisor trainee in bhel.my discipline is electronic.please send me some previous year solved papers ,if you have. thanks, Regards Kamlesh By: kamlesh kumar on October 5, 2010 at 4:27 am
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 67/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

Reply 200. Dear Sir, I have completed diploma mechnical engg and i need BHEL supervisor trainee questions paper and answers.so kindly send me as soon as possible. Thanks, By: Singu on October 5, 2010 at 5:38 am Reply 201. Dear Sir, I have completed diploma mechnical engg and i need BHEL supervisor trainee questions paper mechnical engg) and answers.so kindly send me as soon as possible. By: Singu on October 5, 2010 at 5:40 am Reply 202. hi senthil thank u for this can u send me more bhel paper of electronics engineering i By: Ankit on October 5, 2010 at 2:27 pm Reply Hi Senthil , This month i am appearing for the (tech+app) test for the selection of engineer trainee at BHEL.Kindly send me the previous year papers for the electrical and electrical discipline as soon as possible.Also kindly suggest me some valuable tips for clearing this test. Abhilash Kannan By: Abhilash Kannan on October 7, 2010 at 11:58 am Reply 203. Dear Sir,
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 68/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

I am preparing for Bhel st exam- Mechanical.. Would you please send me mechanical papers to my mail,.. These papers would help me a lot.. By: Srivatsav on October 6, 2010 at 3:57 pm Reply 204. HELLO SIR, it was really good work from ur side.sir can u plz send the question paper of elctronics of BHEL for me.my email id is jitu005@gmail.com (mailto:jitu005@gmail.com) By: jitendra kumar on October 6, 2010 at 8:22 pm Reply 205. hi senthil, pls send me bhel model question paper for mechanical engg. By: Gaurav Kumar on October 7, 2010 at 4:14 am Reply 206. pls send me bhel model question paper for mechanical engg. By: Gaurav Kumar on October 7, 2010 at 4:17 am Reply 207. hi friend could please send the previous yrs question papers of BHEL its urgent because I have applied for the Post of Supervisor Trainee in bhel could you please help me its use full for me and also my friend its my request Yours Firend RamaKrishna
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 69/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

By: RamaKrishna on October 7, 2010 at 9:22 am Reply 208. Plz send me the BHEL syllabus(2010) and previoous Question Papers.. Thanks By: kanika on October 7, 2010 at 4:21 pm Reply 209. nice website for preperin for exams. By: Rajeswari on October 8, 2010 at 9:06 am Reply 210. hello sir.. could please send the previous yrs question papers of BHEL,I have applied for the Post of Engineer Trainee in Electronics in bhel. My ID:ravali1217@gmail.com By: Ravali Maroju on October 8, 2010 at 3:13 pm Reply 211. sir may i get bhel mechanical sample paper for et recruitment? By: kiran on October 9, 2010 at 7:23 am Reply 212. sir may i get bhel mechanical sample paper for et recruitment? plz send to kiranvarmasct@gmail.com (mailto:kiranvarmasct@gmail.com) By: kiran on October 9, 2010 at 7:24 am Reply
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 70/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

213. Dear sir, i am preparing BHEL ST . pl send modal question paper. By: sudharsan on October 9, 2010 at 10:19 am Reply 214. Sir, Please send me previous years question papers and model test papers for Elecrtonics- Engineer Trainee. Kind regards. By: Pratha on October 10, 2010 at 9:13 am Reply 215. hai senthil can u please send diploma mechanical engineering supervisor trainee sample question papers. By: karthick m on October 10, 2010 at 12:30 pm Reply 216. Please send me electrical BHEL paper. sumitkulshrestha09@gmail.com (mailto:sumitkulshrestha09@gmail.com) By: sumit on October 10, 2010 at 5:07 pm Reply 217. I need the previous year model questionpapers for ELECTRONICS discipline for supervisor trainee. sir pls send to my mail.thank u sir. Arunagiri.B@allsectech.com (mailto:Arunagiri.B@allsectech.com) By: ARUNAGIRI on October 10, 2010 at 6:03 pm Reply
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 71/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

218. Hi, I applied for BHEL 2010 i need model mechanical engg question paper. Plz help me Thanks, P.A.prabu By: P.A.Prabhu on October 11, 2010 at 5:30 am Reply 219. Pl Send model question and answer for supervisor traniee in diploma mechincal engg By: pawan kumar on October 11, 2010 at 10:51 am Reply 220. DEAR SIR, I AM REQUIRED MODEL QUESTION PAPER BOOKLET or Book for Electronics. So MAil or where it will be available. please intimate through mail. Kindly help me. By: VINOTH on October 11, 2010 at 12:01 pm Reply 221. hi friend could please send the previous yrs question papers of BHEL its urgent because I have applied for the Post of Supervisor Trainee-MECHANICAL in bhel could you please help me its use full for me and also my friend its my request Yours Firend baluvelmurugan@yahoo.com (mailto:baluvelmurugan@yahoo.com) By: balu on October 11, 2010 at 3:18 pm Reply
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 72/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

222. hello sir, i have applied for bhel et exam 2010 .My discipline is electrical engg. Please send me prev year que paper of eee dept. My mail id santu.parimi@gmail.com (mailto:santu.parimi@gmail.com) regards, santhosh By: santhosh on October 11, 2010 at 4:18 pm Reply 223. hai ia am prakesh By: kash on October 11, 2010 at 4:53 pm Reply 224. Dear sir, I am applying for the post of supervisor trainee-electrical. Can you please send the some more questions and the exam pattern. The exam to be held on 24th october 2010. plz sir its my request yours Loka krishna By: krishna on October 12, 2010 at 2:25 am Reply 225. am preparing for Bhel st exam- Mechanical.. Would you please send me mechanical papers to my mail,.. These papers would help me a lot.. By: chandran on October 12, 2010 at 10:17 am Reply 226. i need the previous model questionpapers for ELECTRONICS discipline. sir pls send to my mail.thank u sir
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 73/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

By: pankaj on October 12, 2010 at 11:38 am Reply 227. hello Senthil i m waiting for bhel engineering trainee exam on 31st of this month. i m searching for the model questions and answers too and i found Ur site. thats fabulous site for ours who want to attend exams like this. so i need more questions and answers to my mail. i hope u do mail for me to my mail id. muraliguru99@gmail.com (mailto:muraliguru99@gmail.com) By: Balaguru on October 12, 2010 at 1:47 pm Reply 228. hello senthil sir, i applied for bhel st exam.my discipline is electronics engg.plssend me prev year que paper of ece dept my mail id . By: P.Radha on October 13, 2010 at 8:30 am Reply 229. pls send me model question paper for diploma trainee.I have applied for the post of supervisor trainee. By: pankaj kumar prajapati on October 13, 2010 at 2:25 pm Reply 230. plz send me previous year paper on my id is sharma.amit2009@yahoo.com (mailto:sharma.amit2009@yahoo.com). for supervisor trainee electrical engg. as soon as possible. thank u. By: amit kumar on October 13, 2010 at 3:49 pm
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 74/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

Reply 231. hai, 1st i need to thank you, for u r tremendous job, i had applied 4 engineer trainee ELECTRICAL plz do send me the previous year question paper By: VINOD on October 14, 2010 at 12:11 pm Reply 232. please send me the bhel supervisor trainee civil question papers By: sayeed on October 14, 2010 at 2:14 pm Reply 233. i want prasar bharati previou question paper By: shakil on October 15, 2010 at 5:18 am Reply 234. sir,plz send previous question papers i am electrical back ground and also give me guidence By: roja on October 15, 2010 at 12:39 pm Reply 235. Civil qustions paper By: Dhinesh on October 16, 2010 at 4:55 am Reply 236. hi guys, examcrazy.com is offering BHEL test series with 2 full length model test papers. you can appear in the tests like actual exam, see your performance section wise, get detailed solutions of questions and tips to solve them also.
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 75/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

link is http://examcrazy.com/products/online-BHEL-Mock-Test-Series.asp (http://examcrazy.com/products/online-BHEL-Mock-Test-Series.asp) By: priya on October 17, 2010 at 6:20 am Reply 237. Dear Sir i am manoj,i like your model paper about bhel,sir pls send me bhel trichi mechnical fitter model paper with answer and some tricks & tips about exam By: Manoj on October 18, 2010 at 6:15 am Reply 238. I want bhel mechnical fitter model paper my id manoj25786@gmail.Com (mailto:manoj25786@gmail.Com) By: Manoj on October 18, 2010 at 6:24 am Reply 239. thanks a lot for the precious guidlinefor the appearing students if u know about paper pattern and 4m which field max question asked tell me is there question put up 4m material, digital and microprocessor and 4m which field in quant and apti question asked. thanks a lot reply me on my email id if anyone know about paper pattern By: manpreet singh on October 18, 2010 at 1:41 pm Reply 240. hi sir.. can u send some electronics questions with answer.. By: tamilmaran on October 19, 2010 at 10:58 am Reply
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 76/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

241. Dear sir I want guess papers for Supervisors Trainee in BHEL exam on24 Oct2010. By: NAND LAL SINGH on October 19, 2010 at 4:04 pm Reply 242. MODEL qUESTION OF SUPERVISOR TRAINEE IN BHEL OF MECHANICAL ENGG. By: NAND LAL SINGH on October 19, 2010 at 4:06 pm Reply 243. sir plz can any 1 send engineer trainee prev papers of electronics stream..plz plz plz By: srinivas on October 20, 2010 at 6:25 pm Reply 244. sir plz can any 1 send engineer trainee prev papers of electronics stream..plz plz plz to rella_srinivas@yahoo.com (mailto:rella_srinivas@yahoo.com) By: srinivas on October 20, 2010 at 6:26 pm Reply 245. Plz send me bhel Q paper .sir By: raju ghosh on October 20, 2010 at 8:48 pm Reply 246. sir i need old paper of BHEL exam ,,my email id is jitendragupta4u@gmail.com (mailto:jitendragupta4u@gmail.com). i will highly thankful to u. By: jitendra on October 21, 2010
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 77/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

at 12:50 am Reply 247. sir,plz send previous question papers i am electronics back ground and also give me guidence By: satheeshkumar s c on October 21, 2010 at 10:28 am Reply 248. Dear all, plz send me the question papers for BHEL super visor trainee recruitment writen exam for electronics. Plz send me by mail if possible By: Vinod Rastogi on October 21, 2010 at 3:30 pm Reply 249. Hi Senthil, Good job. Could you plz give me the Engineer trainee Mechanical q.papers to my mail. Thanks in Advance By: ganesh prabhu on October 26, 2010 at 5:49 am Reply 250. very bad. By: jake on October 26, 2010 at 6:21 am Reply 251. more questions for ETC branch By: Pravanjan Das on October 27, 2010 at 2:48 am
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 78/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

Reply 252. hi sir i need papers for et exam for ece students By: lakshmi on October 27, 2010 at 11:03 am Reply 253. hi senthil please send more questions in electronics&communication for BHEL preparation.my id is mohanrajh01@gmail.com (mailto:mohanrajh01@gmail.com) By: mohan raj on October 27, 2010 at 12:07 pm Reply 254. bhel domt ask g.k By: hitler on October 27, 2010 at 3:23 pm Reply 255. dear senthil sir, thank u for ur hints it will be help to attend exam By: mubarak on October 28, 2010 at 4:45 pm Reply 256. hi sentil, pls could u send me the bhel previous question papers to my mail thodupunoorichandu10@gmail.com (mailto:thodupunoorichandu10@gmail.com) plssssssssssssssssssssss By: chandu on October 28, 2010 at 7:56 pm Reply
senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/ 79/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

257. dear sir Can i get equivalent ratiing of micro farad for 1200pF single phase capacitor thanks By: rajkumar s on October 29, 2010 at 12:17 pm Reply 258. 18. A typical optical fibre has a.) High refractive index core and low refractive index cladding b.) Low refractive index core and high refractive index cladding c.) Both a and b d.) None MY FRND.. U HAVE GIVEN THE ANSWER AS b.) Low refractive index core and high refractive index cladding BUT ITS WRONG.. THE CORRECT ANSWER IS.. a.) High refractive index core and low refractive index cladding ONLY IF THE CORE HAS HIGHER R.INDEX,ONLY THEN TOTAL INTERNAL REFLECTION WILL TAKE PLACE.. By: JYOTIRMOY CHATTERJEE on October 30, 2010 at 1:58 pm Reply 259. hi. sir im satish here i want fitter model question paper pls suggest me By: satish on November 11, 2010 at 5:45 am Reply

senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/

80/81

5/19/12

BHEL Model question paper(Answers Updated) Senthil4us Weblog

Categories
Cinema Mumbai blasts Sports Today's Tips Uncategorized

Blog at WordPress.com. | Theme: Ocean Mist by Ed Merritt.

senthil4u.wordpress.com/2009/09/08/bhel-modern-question-paper/

81/81

You might also like