Professional Documents
Culture Documents
Now in its 20th year, the annual GPS World Receiver Survey provides the longest running, most comprehensive database of GPS and GNSS equipment available in one place. With information provided by 58 manufacturers on more than 483 receivers, the survey assembles data on the most important equipment features. Manufacturers are listed alphabetically. Footnotes and Abbreviations below supply additional information to guide you through the survey. We have made every effort to present an accurate listing of receiver information, but GPS World cannot be held responsible for the accuracy of information supplied by the companies or the performance of any equipment listed. In some cases, data had to be abbreviated or truncated to fit the space available. Contact the manufacturers directly with questions about specific units. To be listed in the 2013 Receiver Survey, e-mail gpsworld@gpsworld.com.
SPONSORED BY:
www.novatel.com
NOTES
1
ABBREVIATIONS
2
User environment and applications: A C D G H L M Met N O P R S T V 1 2 = = = = = = = = = = = = = = = = = aviation recreational defense survey/GIS handheld land marine meteorology navigation other other position reporting real-time DGPS ref. space timing vehicle/vessel tracking end-user product board/chipset/module for OEM apps
Where three values appear, they refer to autonomous (code), real-time differential (code), and post-processed differential; where four values appear, they refer to autonomous (code), real-time differential (code), realtime kinematic, and post-processed differential. Cold start: ephemeris, almanac, and initial position and time not known. For a warm start, the receiver has a recent almanac, current time, and initial position, but no current ephemeris Reacquisition time is based on the loss of signal for at least one minute. E = provision for an external antenna R = antenna is removable
apps: ARINC: async: bps: CP: CEP: diff: ext.: m, min: na or NA: nr: opt.: par.: prog.: ppm: RMS: s: SBAS: typ.: VRS: WP: WR:
applications Aeronautical Radio, Inc. standard asynchronous bits per second carrier phase circular error probable differential external / int. = internal minutes not applicable no response optional parallel programmable parts per million root mean square seconds Satellite-Based Augmentation System typical Virtual reference station waterproof water resistant
ADVERTORIAL
Jason Hamilton (JH): Finding the right component for your system is critical to the success of your product. With a wide variety of GNSS products on the market, the choice can be confusing so it is very important to clearly understand what technologies are available. In addition to the technical aspects of a GNSS receiver, some of the factors to consider include: the functionality your application requires; the suitability of the vendor to your needs as an originial equipment manufacturer (OEM); and the ease of product integration.
Lets start with the technical aspects.
JH: Much depends on the application and the kind of end-user product into which the receiver will be integrated. Some of the specifications to keep in mind are listed in the survey, but the importance of these and the trade-offs between them can be complex. For example, trade-offs between size and accuracy may need to be weighed. Finding the best fit for your product requires understanding what is good enough for your application. A receiver that is under-featured will not suit your applications needs, and an overfeatured product will not meet the cost targets for your market.
What differentiates receivers?
products that offer multi-frequency support and differential positioning modes. These products tend to be at the board level, and are differentiated by their physical dimensions (size, weight, temperature range), interface options (UART, USB, Ethernet) and signal tracking capabilities. In addition, precision receivers are differentiated by the quality and robustness of their positioning algorithms. This is something that is not possible to evaluate in the receiver survey, and highlights the importance of evaluating any product before you commit. These differences can have a significant impact on the performance of the receiver in your application, especially if the receiver has not been used in a specific application segment before. Given the complexity of GNSS products, the reputation of the vendor, plus the support provided in terms of technical integration, documentation and customer support, can almost be as important as the product itself.
What drives the accuracy of a GNSS receiver solution?
JH: There is a wide array of receiver options available on the market today. Single-frequency offerings are available at low cost, and provide accuracy appropriate for many commercial and consumer applications. Low-cost offerings are available at the chip or receiver board level, depending on the needs of the application. There are many vendors to choose from for a lowaccuracy receiver. If precise positioning is needed, look for
2 GPS World | January 2012
JH: Understanding the accuracy requirements of your application is critical to choosing the right receiver. Accuracy of the solution output by the receiver is dominated by a few key factors: What satellite signals are tracked. Code-only receivers are limited to meter-level accuracy, whereas higher-end receivers that provide accurate carrier-phase measurements allow for cm-level, real-time or post-processed position determination. How precisely the receiver measures the satellite signals. The code and carrier measurement accuracy directly correlates to the accuracy of the final solution. How well the receiver mitigates the effects of multipath. Manufacturers have patented techniques to mitigate the effect of multipath on the satellite measurements. A good example is NovAtels Pulsed Aperture Correlator (PAC) technology.
www.gpsworld.com
ADVERTORIAL
What, if any, correction sources the receiver can accept. The highest end of receivers accept locally generated as well as network RTK corrections, to achieve accuracy levels in the cm range. Also make sure to check inter-operability of your selected receiver to make sure it operates with corrections from other manufacturers. Not everyone will make the same receiver selection as you, so make sure your selected receiver is as inter-operable as possible. Manufacturers like NovAtel offer convenient upgrade of functionality in the field, so that users can upgrade their position accuracy when needed by changing the receiver firmware.
How important is being future-proof?
The number of channels is a comparison point, but its not the complete story.
track all frequencies and signals planned for the coming years, but there are differences among the manufacturers and trade-offs to be considered. For example, the number of channels is a comparison point, but its not the complete story. Its more crucial to find out how configurable the receivers channels are, because that defines how many satellites can be tracked simultaneously and how suitable a receiver will be to operate in the upcoming complex mix of satellite constellations. The number of simultaneously tracked satellites will improve solution availability, so it should also be considered. Some manufacturers have channels that can be dynamically configured for increased flexibility to handle evolving satellite constellations. For example, the channels on NovAtels OEM615 and OEM628 receivers are highly configurable, so that they can adapt as new global and local satellites systems emerge in the future. In the future, products will need to have this flexibility to adapt to whatever satellites are available in the part of the world in which the receiver is being used. Another point to consider: An increased number of channels can increase power consumption and physical size, so if you have a power-sensitive or size-constrained application, this trade-off should be examined carefully between products.
JH: There are many exciting developments coming in the future for GNSS navigation. Modernized signals for GPS, the increased investment in GLONASS, the upcoming deployment of new constellations like GALILEO and COMPASS, and new localized satellite positioning systems will dramatically increase the options for receiver manufacturers and increase capability for users. New signals broadcast from space will result in signal combinations that will provide more robust positioning. More satellites to track at one time will improve the availability of precise GNSS positioning in challenging conditions where satellite signal blockage occurs. You should ensure that your receiver choice is field software upgradeable (as is NovAtels OEM6 series of receivers, for example) so new signals can be used as they launch. This will allow your customers the opportunity to take advantage of new signals without interruption of operation. Many manufacturers are working toward receivers that
www.gpsworld.com
75 par.
7.48 x 2.28 x 6.3in 2.93 lb with Width with mounting mounting brackets: 8.72 in brackets 7.48 x 2.28 x 6.3in 3.13 lb with Width with mounting mounting brackets: 8.72 in brackets 8.5 x 3.75 x 7.7in 108 x 57mm 95 x 42 x 168mm 4.3 x 3.3 x 0.6in 8.8 x 16.9 x 2.5cm 9 x 19 x 4.3cm 5.7 x 2.5 x 1.1in 3.5 x 7.7 x 1.8in 4.125 lb 2.3 oz 19 oz 3.8 oz 0.38 kg 0.63 kg 0.49 lb 1.01 lb
nr
0.05s
2 x 75 par.
nr
0.05s
ADU5 3D Attitude Sensor DG14 GPS + SBAS Board DG14 Sensor SkyNav GG12W GPS + SBAS - FAA Certifiable Board MobileMapper 10 MobileMapper 100 MobileMapper 6 MobileMapper CX
56 par. / 2 beacon 12 GPS + 2 WAAS 12 GPS + 2 WAAS 12 par. 20 channels 45 paralell channels 12 parallel channels 14 parallel channels 75 par.
L1 only, C / A-code and carrier, SBAS, Beacon 12GPS + 2 SBAS as above as above L1 only, C / A-code and carrier (GPS and SBAS) GPS L1 C / A, SBAS as above as above as above 20
GPS, GLONASS, L1 C / A, P(Y), L2 P(Y), L2C, 12GPS / 12Glonass SBAS code & carrier / 3SBAS L1 only, C / A code, WAAS, EGNOS, MSAS 12 L1 only, C / A code, WAAS, EGNOS, MSAS 14
ProFlex Lite
75 par.
2 x 75 par.
GPS L1 C / A L1 / L2 P-code, L2 C, L1 / L2 full wavelength carrier GLONASS L1 C / A, L2 C / A and L2 P-code, L1 / L2 full wavelength carrier SBAS code & carrier GPS L1 C / A L1 / L2 P-code, L2 C, L1 / L2 full wavelength carrier GLONASS L1 C / A, L2 C / A and L2 P-code, L1 / L2 full wavelength carrier SBAS code & carrier Dual board enclosure. Same specs. as ProFlex Lite x 2 GPS L1 C / A code GPS L1 C / A code GPS L1, SBAS, QZSS GPS L1, SBAS GPS L1, GLONASS, SBAS GPS L1, SBAS
AGLMNOPR1
21.5 x 20 x 7.6cm
2,1 kg
3m / <0.8m / 10 mm / 3 mm + 1ppm nr
0.05s
12 GPS, 12 GLONASS, AGLMNOPR1 3 SBAS Dual board enclosure. Same specs. as ProFlex Lite x 2 user define user define 12 12 12 12 AMNOPR1
7.48 x 2.28 x 6.3in 2.93 lb with Width with mounting mounting brackets: 8.72 in brackets 7.48 x 2.28 x 6.3in 3.13 lb with Width with mounting mounting brackets: 8.72 in brackets na 0.7 x 0.7cm 3 x 2.9mm 4.28 x 4.28mm 4.28 x 3.83mm 13 x 13 x 1.2mm na < 1g < 1g < 1g < 1g <1g
3m / 25cm + 1ppm / 1cm + 1ppm / 0.3cm + 0.5ppm 3m / 25cm + 1ppm / 1cm + 1ppm / 0.3cm + 0.5ppm, Heading: 0.2 / baseline in meter, Pitch or Roll: 0.4 / baseline in meter ~5 m ~5 m 2m / 1m / na / na (CEP) 2m / 1m / na / na (CEP) 2m / 1m / na / na (CEP) 2m / 1m / na / na (CEP)
nr
0.05s
nr
0.05s
na na 50 50 50 50
500Hz 500Hz 1 1 1 1
BCM47511
18
18
NHC2
2.85 x 3.02mm
<1g
2m / 1m / na / na (CEP)
50
12
GPS L1, SBAS GPS L1 C / A GPS L1 C / A GPS L1 C / A GPS L1 C / A GPS L1 C / A, GLONASS G1 GPS, GLONASS, GALILEO, COMPASS GPS L1 C / A code & CP L1, L2, L5, G1 & G2 carrier phase, C / A, P1, P2, L2C, L5, G1 & G2 code, C-Nav Correction Service, SBAS (WAAS, EGNOS, MSAS, GAGAN), Galileo E1, E5a (via software upgrade) GPS L1 C / A, SBAS GPS L1 C / A, SBAS GPS L1 C / A, SBAS GPS L1 C / A, SBAS GPS L1 C / A, SBAS GPS L1 C / A, SBAS, Glonass, Galileo, Compass GPS L1 C / A, SBAS, Glonass, Galileo, Compass GPS L1 C / A, SBAS GPS L1 C / A, SBAS L1 full cycle CP, C / Acode, L2 full cycle CP, P2 or L2C code, SBAS, option: GLONASS L1, full cycle CP, C / Acode, L2 full cycle and L2 C / A code. as above as above as above L1 full cycle CP, C / Acode, L2 full cycle CP, P2 or L2C code, SBAS, option: GLONASS L1, full cycle CP, C / Acode.
12 All in View All in View All in View All in View All in View All in View All-in-View 65 GNSS & 2 SBAS + C-Nav Correction Service (RTG) All in View 24 24 All in View All in View All in View All in View All in View All in View 18 or more depending on config 20 or more depending on config 20 or more depending on config 20 or more depending on config 20 or more depending on config 20 or more depending on config 16; 32 in future f / w
11 x 11 x 1.2mm 5.0 x 5.0 x 0.9mm 13.0 x 16.0 x 1.97mm 5.0 x 5.0 x 0.9mm na na 5.0 x 5.0 x 0.9mm 73 x 37 x 116mm 11.7 x 6.0 x 16.4cm
2m / 1m / na / na (CEP) 3m, 3m, 3m, 5m 3m, 3m, 3m, 5m 3m, 3m, 3m, 5m 3m, 3m, 3m, 5m 3m, 3m, 3m, 5m na 5m / <1m / n.a. / n.a. Code: 7.5cm DGPS (RTG Dual): + / -10cm (H) + / -15cm (V) RTK (<40km): + / -1cm + 0.5ppm (H) + / -2cm + 1ppm (V) (RMS) 10 m / nr / nr / nr (95%) 10 m / nr / nr / nr (95%) 10 m / nr / nr / nr (95%) 10 m / nr / nr / nr (95%) 10 m / nr / nr / nr (95%) 10 m / nr / nr / nr (95%) 10 m / nr / nr / nr (95%) 10 m / nr / nr / nr (95%) 10 m / nr / nr / nr (95%) 1.5m / <1m / 1cm / <1cm (RMS)
80 ch. Up to 16 SV ACLYS-M GPS / AGPS 80 ch. Up to Module 16 SV CLIOX-C GPS / AGPS + 3D 80 ch. Up to Electronic Compass IC 16 SV CGsnap GPS / AGPS 80 ch. Up to Baseband IP 16 SV CGsnap Pro GNSS / 192 ch. Up to A-GNSS Baseband IP 30 SV ACLYS-L RF Front End All in View TinyBrother GPS C-Nav3050 24 67 par.
CSR www.csr.com
BC7830 GSD4t GSD4e SiRFPrima SiRFPrima Automotive SiRFPrimaII SiRFPrimaII Automotive SiRFAtlasIV SiRFAtlasV Toughman
All in view 48 48 Up to 64 Up to 64 Up to 64 Up to 64 Up to 64 Up to 64 336 or more depending on config 336 or more depending on config 336 or more depending on config 336 or more depending on config 336 or more depending on config 336 or more depending on config
HN2 CHNV2 CHNV2 CHNV2 CHNV2 CHNV2 CHNV2 CHNV2 CHNV2 GLMNOVR1
3.2 x 3.6 x 0.6mm 3.4 x 2.7 x 0.6mm 3.5 x 3.2 x 0.6mm 16 x 16 x 1.1mm 16 x 16 x 1.1mm 17 x 17 x 1.1mm 17 x 17 x 1.1mm 12 x 12 x 1.1mm 10 x 13 x 1.2mm 20 x 8.5 x 3.5cm
na na na na na na na na na 600g
nr nr nr nr nr nr nr nr nr <35
Variable Variable Variable Variable Variable Variable Variable Variable Variable 1,1 / 2,1 / 5, 1 / 10 1,1 / 2,1 / 5, 1 / 10 1,1 / 2,1 / 5, 1 / 10 1,1 / 2,1 / 5, 1 / 10 1,1 / 2,1 / 5, 1 / 10, standard, higher rates optional. as above
1.5m / <1m / 1cm / <1cm (RMS) 1.5m / <1m / 1cm / <1cm (RMS) 1.5m / <1m / 1cm / <1cm (RMS) 1.5m / <1m / 1cm / <1cm (RMS)
DGRx-GNSS (OEM)
DeLorme www.delorme.com
Earthmate PN-60w
L1 full cycle CP, C / Acode, L2 full cycle CP, P2 or L2C code, SBAS, GLONASS L1, full cycle CP, C / Acode, option: L2 full cycle and L2 C / A code. 32 / correlators & GPS L1 C / A code on all channels custom Kalman filter
AHGLMOVRT2
90 x 60 x 12mm
<60 g
<35
CGHLMN1
6.70 oz (without <2m (50% CEP), <15m (2DRMS) batteries) / WAAS: <0.5m (50% CEP), <3m (95% 2DRMS)
www.gpsworld.com
Sponsored by
Cold start 3 <45s <45s 45s 90s Warm start 4 <15s <15s 35s 35s Reacquisition No. of ports
5
Port type 2 RS-232, 1 Bluetooth, 1 TNC 2 RS-232, 1 Bluetooth, 1 TNC RS-232, RS-232, USB 2.0 RS-232, LV-TTL, USB 2.0
<1s <1s 3s 3s
4 4 3 3
Power source INT / EXT (9-18 V DC) INT / EXT (9-18 V DC) external external
Power consumption (Watts) 7W 7W < 0.8W in GPS L1 < 0.95W in GPS L1 / L2 or GPS + GLONASS L1 1.9W (GPS only), 2.4W (GPS + GLONASS)
1 RS232 up to 921.6 kbits 40 to + 85 / sec (RxD, TxD, CTS and RTS signals) RS232 up to 460.8 kbps; 30 to + 70 LV-TTL up to 5Mbps; USB 2.0 up to 12 Mbps 2 RS232 up to 921.6 kbits / -30 to + 60 sec 1 USB Serial Port up to 12Mbits / sec 2 RS232 up to 921.6 kbits / -30 to + 60 sec 1 USB Serial Port up to 12Mbits / sec 300115,200 300115,200 300115,200 300115,200 na RS232: 2400-115200 na na 20 to + 55 30 to + 70 30 to + 60 30 to + 70 -10 to + 60 -20 to + 60 -20 to + 60 -10 to + 60
90s
35s
3s
external 9-36 VDC input external 9-36 VDC input external external external external Int. / ext. Int. / ext. Ext. / int. Ext. / int.
3.5W with GNSS antenna External active antenna depending Rugged and Compact High-end GNSS Sensor. BLADE on application: Geodetic Survey Technology inside. Antenna, Machine or Marine 6.5W with 2 GNSS antennas 6 1.2 1.3 3 0,5 W with GPS on 2,6 W with GPS on na na External active antenna depending Dual GNSS Sensor for RTK, Heading and Relative on application: Geodetic Survey Positioning. BLADE Technology inside. Antenna, Machine or Marine Patch with ground plane (ER) Microstrip GPS / beacon Microstrip GPS / beacon Patch, active (ER) Internal and External Internal and External Patch and external Patch and external Precise heading, pitch, roll, and 3D position Uses SBAS signals for sub-meter differential positioning RAIM algorithm to detect and correct errors For aviation; designed to FAA / RTCA specifications Affordable and easy-to-use, GPS / GIS handheld Built-in GPS + Glonass, integrated communications and RTK capabilities Affordable and easy-to-use, GPS / GIS handheld Easy-to-use handheld GPS for high-accuracy mapping / GIS
90s
35s
3s
2 3 3 2 2 3 2 7
RS-232 RS-232 RS-232 RS-230 USB, Bluetooth RS232, USB, Bluetooth USB, Bluetooth - Protocol: NMEA 0183 v 3.0 - RTCM SC-104 version 2.3 (9.2 & 1.2) 1 RS232 / RS422, 2 RS232, USB, Bluetooth, Ethernet, GSM / GPRS, Earth terminal RS-232, RS-232, USB 2.0
90s
35s
3s
90s
35s
3s
RS232 / 422: up to 921.6 -30 to + 65 kbits / sec USB 2.0 host & device Bluetooth 2.0 + EDR Class 2, SPP profile 2 RS232 up to 921.6 kbits / -30 to + 60 sec 1 USB Serial Port up to 12Mbits / sec 2 RS232 up to 921.6 kbits / -30 to + 60 sec 1 USB Serial Port up to 12Mbits / sec na na Up to 1 / 32 of reference clock UART: 4M UART: 4M UART: 4M na TBD 30 to + 85 -30 to + 85 -30 to + 85 -40 to + 85 C
Int. / ext.
External 9-36 VDC input External 9-36 VDC input na 3.3 1.5-3.6 V 1.2V - 5.5V 1.2V - 5.5V Core: 1.2v, I / O: 3.3V, Audio 3V
External active antenna depending Flexible Rugged High-Performance GNSS Receiver on application: Geodetic Survey Antenna, Machine, Marine or Choke Ring 3.5W with GNSS antenna External active antenna depending Rugged and Compact High-end GNSS Sensor. BLADE on application: Geodetic Survey Technology inside. Antenna, Machine or Marine 6.5W with 2 GNSS antennas na TBD 13 mW 10mW 10mW 300mW @ 700MHz External active antenna depending Dual GNSS Sensor for RTK, Heading and Relative on application: Geodetic Survey Positioning. BLADE Technology inside. Antenna, Machine or Marine na na na na na na SW based GPS receiver RFIC module Single-chip, single-die baseband and RF tuner Single chip, single die, GPS + Bluetooth + FM (RX / TX) Single chip, single die, GPS + GLONASS + Bluetooth + FM (RX / TX) Highly intergrated ARM11 Apps Processor + VFPU + GPU + GPS Baseband + RF + LNA
90s
35s
3s
2ms 2ms 1s 1s 1s 1s
na 2 3 3 3 96
na Serial / Parallel I2C, SPI, UART UART, SDIO, SPI,I2C,PCM, I2S UART, SDIO, SPI,I2C,PCM, I2S GPIO (x96), HS UART (x3), SPI, I2C, SDIO / MMC (x3), PCM, I2S UART, I2C
30s
30s
1s
UART: 4M
-30 to + 85
1.5-3.6 V
13mW
na
Single chip, single die, GPS + GLONASS baseband and RF tuner Highly intergrated ARM11 Apps Processor + VFPU + GPS Baseband + RF + LNA with support of DDR2 Single die GPS / AGPS baseband and RF front end GPS / AGPS Module Two dies solution. GPS / AGPS baseband and RF front end + electronic compass GPS / AGPS baseband IP for integration with hostprocessor system GPS / AGPS baseband IP for integration with hostprocessor system Single die GPS RF front-end
96 1 1 1 1 1 1 2 2, 1, 1, 1, 1, 1
GPIO, HS UART (x4), SPI, I2C, UART: 4M SDIO / MMC (x3), PCM, I2S SPI 2 Mbps SPI SPI APB APB Serial RS-232 RS-232, RS-422, Ethernet, USB, 1PPS, Bluetooth 2 Mbps 2 Mbps 2 Mbps 8 Mbps 12-26 Msps 19200-115200 9,600-115,200
Core: 1.2V, I / O: 3.3V, Audio 3V Single 1.8v supply Single 1.8v supply Single 1.8v supply na na Single 1.8v supply int LiPo / ext 9-30V 9-32 VDC ext.
300mW @ 700MHz 20mW average 20mW average 20mW average na na 30mW max 5W 6W
na na na na na na na active, external Multi-band GNSS (ER) (GPS L1, L2, L2C, L5 / Galileo E1, E5a / GLONASS G1, G2 / C-Nav Correction Service L-band and SBAS E E E E E E E E E L1 / L2 (E)
A survey-grade, high accuracy receiver that uses C-Navs global set of corrections for precise marine / offshore positioning and navigation. Wheelmark & USCG Type Approved. Single GPS + Bluetooth + FM chip Single die tracker Single die engine SOC: Apps Processor + GPU + GPS SOC: Apps Processor + GPU + GPS SOC: Apps Processor + GPU + video + GPS SOC: Apps Processor + GPU + video + GPS SOC: Apps Processor + GPS SOC: Apps Processor + GPS GPS L1 / L2 carrierphase and data collection. WR
< 38s <35s <35s <35s <35s <35s <35s <35s <35s <40s
<36s <34s <34s <34s <34s <34s <34s <34s <34s 36s
<3s <1s <1s <1s <1s <1s <1s <1s <1s <1s
na 2 2 na na na na na na 1, 1, 1, 1
na user selectable user selectable user selectable user selectable user selectable user selectable user selectable user selectable 1,200115,200 bps
Ext Ext Ext Ext Ext Ext Ext Ext Ext int., ext., LiIonP.
nr 0.008 0.008 ~ 0.7 to 0.9 ~ 0.7 to 0.9 ~ 0.7 to 1.5 ~ 0.7 to 1.5 ~ 0.55 to 0.9 ~ 0.55 to 0.9 2.2
2, 1, 1, 1 1,1 1 2
30 to + 70 -40 5o + 85 -40 5o + 85 40 to + 85
int., ext, ., LiIonP. 3.2 ext. ext. ext. 1.5 1.5 1.5
RTK,VRS, Precision post-procecssing, Precision GIS, GSM modem opt. WR RTK,VRS, Precision post-procecssing, Precision GIS, GSM modem opt. WR RTK,VRS, Precision post-procecssing, Precision GIS, GSM modem opt. WR Based on easy-to-upgrade / modify FPGA design
<40s
<36 s
<1s
Serial
1,200115,200 bps
40 to + 85
ext.
1.5
L1 / L2 GNSS (E)
as above
<60s
<45s
<1s
USB 2.0
-20 to + 75
450mW (avg)
Custom
TFT high contrast color display; IPX7 waterproof; impact resistant; 32GB SDHC support; Barometer; Compass / Accelerometer; Wireless communication
www.gpsworld.com
Earthmate LT-40
16
GLN1
Fastrax www.fastraxgps.com
Fastrax IT600 Fastrax IT520 Fastrax IT500 Fastrax UP501 Fastrax IT430 Fastrax UC430 Fastrax IT300 Fastrax IT310 Fastrax UP300 Fastrax IT03 Fastrax IT03-02 Fastrax IT900 Fastrax SW GPS Fastrax Accelerated SW GPS FM03 FMP04 FMP04-TLP FMP04-RLP FMP04-ULP FM06-TLP FM11 FGM-RLP FGM-ULP FSP04-TLP
32 22 22 22 48 48 20 20 20 12 12 fully configurable fully configurable fully configurable 22 22 22 22 22 22 22 22 22 48 12 12 12 GPS, 2 SBAS 12 GPS, 2 SBAS 12 12 GPS, 2 SBAS 12 12 12 GPS, 2 SBAS 12 GPS, 2 SBAS 12 GPS, 2 SBAS 12 GPS, 2 SBAS 12 12 12 12 12 12 12 15 15 15 All in view All in view All in view 14 14 12 66
ACHLMNTV2 ACHLMNTV2 ACHLMNTV2 ACHLMNTV2 ACHLMNRTV2 ACHLMNRTV2 ACHLMNRTV2 ACHLMNRTV2 ACHLMNTV2 ACHLMNRTV2 ACLMNRTV2 ACDGHLMMetNOPRSTV2 as above as above ACHLMNRTV2 ACHLMNRV2 ACHLMNRV2 ACHLMNRV2 ACHLMNRV2 ACHLMNRTV2 ACHLMNRTV2 ACLMNRV2 ACLMNRV2 ACHLMNRV2 Navigation Automotive / Navigation Navigation Navigation Navigation Navigation Timing / CDMA / Wi-MAX / LTE Timing / CDMA / Wi-MAX / LTE Timing / CDMA / Wi-MAX / LTE / Femto Timing / CDMA / Wi-MAX / LTE Automotive / Navigation / Timing Navigation 10MHz 10MHz 10MHz DGLMNR1 DGHLMNR1 DGHLMNR1 DGHLMNR1 DGLMNR1 DGHLMNR1 DGHLMNR1 DGLNRV1
16.2 x 18.8 x 2.2mm 10.4 x 14 x 2.3mm 16.2 x 18.8 x 2.2mm 22 x 8 x 22mm 9.6 x 9.6 x 1.85mm 9.6 x 14.0 x 1.95mm 16.2 x 18.8 x 2.2mm 13.1 x 15.9 x 2.3mm 19 x 27 x 7.2mm 22 x 2.8 x 23mm 26 x 4.7 x 26mm 8 x 8 x 2.2mm --11.5 x 13.0 x 2.15mm 26 x 26 x 11.7mm 26 x 26 x 11.7mm 26 x 26 x 11.7mm 26 x 26 x 11.7mm 16 x 16 x 6.7mm 11 x 11 x 2.15mm 30 x 34.1 x 8mm 30 x 34.1 x 8mm 26 x 26 x 11.7mm 22.0 x 22.0 x 3.0mm 25.4 x 25.4 x 3mm 18.0 x 21.5 x 3.0 mm 22.0 x 22.0 x 7.4mm 15.0 x 64.0mm 18.0 x 21.5 x 3.0 mm 33.8 x 20.8 x 6.3mm 40.0 x 60.0mm 18.0 x 21.5 x 3.0 mm 40.0 x 60.0mm 9.0 x 9.0mm 6.0 x 6.0mm 51 x 51 x 16mm 51 x 51 x 19mm 207 x 327 x 98.5mm 8.5 x 3.5 x 11.2cm 8.0 x 4.7 x 14.1cm 8.0 x 5.6 x 14.1cm 8.0 x 5.6 x 14.1cm 8.5 x 3.5 x 11.2cm 8.0 x 4.7 x 14.1cm 8.0 x 5.6 x 14.1cm 25 Cubic inches 25 Cubic inches 25 Cubic inches
15ns RMS 50ns RMS 50ns RMS 50ns RMS 1us 1us 1us 1us 1us 20 20 20 20 20 < 100ns RMS < 100ns RMS < 100ns RMS < 100ns RMS < 100ns RMS < 100ns RMS < 100ns RMS < 100ns RMS < 100ns RMS
1, use def to 10Hz 1, use def to 10Hz 1, use def to 10Hz 1, use def to 10Hz 1, use def to 5Hz 1, use def to 5Hz 1 1 1 1, user def to 8Hz 1, user def to 8Hz full configurability full configurability full configurability 1Hz default, max up to 10Hz by user define 1Hz default, max up to 10Hz by user define 1Hz default, max up to 10Hz by user define 1Hz default, max up to 10Hz by user define 1Hz default, max up to 10Hz by user define 1Hz default, max up to 10Hz by user define 1Hz default, max up to 10Hz by user define 1Hz default, max up to 10Hz by user define 1Hz default, max up to 10Hz by user define 1Hz
fully configurable L1, C / Acode and CP fully configurable L1, C / Acode and CP fully configurable L1, C / Acode and CP 22 tracking + 66 acquisition 22 tracking + 66 acquisition 22 tracking + 66 acquisition 22 tracking + 66 acquisition 22 tracking + 66 acquisition 22 tracking + 66 acquisition 22 tracking + 66 acquisition 22 tracking + 66 acquisition 22 tracking + 66 acquisition 48 32 32 32 32 32 32 16 12 32 32 32 32 16 / par. 16 / par. 16 / par. 12 channel 12 channel 12 channel 12 channel 51 channel 51 channel 51 channel All in view All in view All in view 28 par. 14 par. 12 par. 66 Channels All in View Tracking GPS L1 C / A code, SBAS GPS L1 C / A code, SBAS GPS L1 C / A code, SBAS GPS L1 C / A code, SBAS GPS L1 C / A code, SBAS GPS L1 C / A code, SBAS GPS L1 C / A code, SBAS GPS L1 C / A code, SBAS GPS L1 C / A code, SBAS GPS L1 C / A code, SBAS L1 only, C / Acode, SBAS L1 only, C / Acode, SBAS L1 only, C / Acode, SBAS L1 only, C / Acode, SBAS L1 only, C / Acode L1 only, C / Acode, SBAS L1 only, C / Acode, SBAS L1 only, C / Acode L1 only, C / Acode, SBAS L1 only, C / Acode, SBAS L1 only, C / Acode, SBAS L1 only, C / Acode, SBAS L1 only, C / Acode L1 only, C / Acode, SBAS L2 only, C / Acode L1 C / A code & phase, SBAS L1 C / A code & phase, SBAS L1 C / A code & phase, SBAS, OmniSTAR VBS L1 C / A code & phase, SBAS, DGPS Beacon L1 / L2 / (L2C) C / A code, P code, CP, SBAS L1 / L2 / (L2C) C / A code, P code, CP, SBAS L1 / L2 / (L2C) C / A code, P code, CP, SBAS, OmniSTAR VBS / XP / HP GPS L1 C / A code, 24 GPS; (L2 optional) GPS L1 C / A code, 24 GPS; (L2 optional) GPS L1 C / A code, 24 GPS; (L2 optional) L1, C / A CP smoothed, Glonass L1, SBAS, Beacon L1, C / A CP smoothed, Glonass L1, SBAS, Beacon L1, C / A GPS L1 C / A code
Furuno www.furuno.com
GN8421 GN-8425 GN85 GH85 GV84H GV85 GT8031F GT8036 GT85 GT8536 eRideOPUS 5SD eRide OPUS5FS GF180TC GF8052 GF-8048 SXBlue GPS SXBlue II GPS SXBlue II-L GPS SXBlue II-B GPS SXBlue GPS L1 / L2 SXBlue III GPS SXBlue III-L GPS
1 1ms (Max) 5Hz 1ms (Max) 5Hz 1 5Hz 1 1 1 1 5Hz 5Hz 1 1 1 1 to 10Hz, optional 20Hz 1 to 10Hz, optional 20Hz 1 to 10Hz, optional 20Hz 1 to 10Hz, optional 20Hz 1Hz, optional 10 & 20Hz 1Hz, optional 10 & 20Hz 1Hz, optional 10 & 20Hz 1 sec up to 5Hz 1 sec up to 5Hz 1 sec up to 5Hz 1Hz 1Hz
.6 lb 1 lb (w / batt.) 1 lb (w / batt.) 2 lb (w / batt.) .6 lb 1 lb (w / batt.) 1 lb (w / batt.) 1.5 lbs 15.8 oz 15.8 oz 0,35 kg 1.2 kg 0.15 kg Weight: < 6g
2.5m / 60cm / 3cm / 1cm , 95% 2.5m / 60cm / 3cm / 1cm , 95% 2.5m / 80cm / 3cm / 1cm , 95% 2.5m / 60cm / 3cm / 1cm , 95% 2.5m / 60cm / 3cm / 1cm , 95% 2.5m / 60cm / 3cm / 1cm , 95% 2.5m / 60cm / 3cm / 1cm , 95% < 1m CEP < 1m CEP ` 1,5 m / 0.4 m / nr / nr RMS 3 m / 0.5 m / nr / nr RMS 5 m / 1 m / nr / nr CEP Without aid: 3.0 m (50% CEP) DGPS (SBAS(WAAS,EGNOS,MSAS)): 2.5 m (50% CEP)
www.gpsworld.com
Sponsored by
Cold start 3 <60s Warm start 4 <45s Reacquisition No. of ports
5
Baud rate
<45s
<40s
<35s
<1s
USB 1.1
-40 to + 85
450mW (USB)
Custom
33s 33s 33s 33s 35s 35s 32s 32s 32s 35s 35s 35s 35s 35s <35s <35s <35s <35s <35s <35s <35s <35s <35s <35s 38s 33s 38s 38s 45s 38s 44.9s 52s 70s 70s 33s 32s
33s 33s 33s 33s 35s 35s 32s 32s 32s 33s 33s 33s 33s 33s <34s <34s <34s <34s <34s <34s <34s <34s <34s 35s 33s 33s 33s 33s 34s 33s 36s 37s 70s 70s 30s 30s
<1s <1s <1s <1s <1s <1s <1s <1s <1s <1s <1s <1s <1s <1s <1s <1s <1s <1s <1s <1s <1s <1s <1s <1s 2s 1s 2s 3s 2s 2s 8.4s 9s 5s 5s 1s 1s
3xUART,I2C / CAN, SPI UART UART UART SPI, UART or I2C SPI, UART or I2C UART UART UART UART UART SPI fully configurable fully configurable UART UART UART RS232 USB UART UART UART / RS232 USB UART NMEA NMEA NMEA NMEA NMEA NMEA NMEA M12 (Motorola) compatible NMEA M12 (Motorola) compatible NMEA NMEA NMEA NMEA NMEA Bluetooth, RS-232 (all independent) Bluetooth, USB, RS-232 (all independent) Bluetooth, USB, RS-232 (all independent) Bluetooth, USB, RS-232 (all independent) Bluetooth, RS-232 (all independent) Bluetooth, USB, RS-232 (all independent) Bluetooth, USB, RS-232 (all independent) Serial, Ethernet, RF link TDMA Serial, Ethernet, RF link TDMA Serial, Ethernet RS-232, USB, BT RS-232, USB, BT 4 digital, 3 analog UART
115200 configurable 9600 configurable 9600 configurable 9600 configurable 4800 configurable 4800 configurable 4800,9600, 57600 configurable 4800,9600, 57600 configurable 4800,9600, 57600 configurable 600 - 921600 600 - 921600 4-16 MSPS fully configurable fully configurable 4800115200 4800115200 4800115200 4800115200 4800115200 4800115200 4800115200 4800115200 4800115200 4800 / 9600 9600 9600 4800-115200 4800-115200 9600 115200 4800 9600 4800-115200 4800-115200 4800-115200 4800-115200 9600 9600 9600 4,800 - 57,600 4,800 - 57,600 4,800 - 57,600 4,800 - 57,600 4,800 - 115,200 4,800 - 115,200 4,800 - 115,200 172 Kbps
-40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 na na -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 40 to + 85 40 to + 85 40 to + 85 30 to + 85 30 to + 85 40 to + 85 30 to + 80 40 to + 85 40 to + 85 40 to + 85 40 to + 85 40 to + 85 40 to + 85 20 to + 80 20 to + 60 -40 to + 70 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 70 -40 to + 85 -40 to + 85
ext. ext. ext. ext. ext. ext. ext. ext. ext. ext. ext. ext. ext. ext. ext ext / built-in backup battery ext / built-in backup battery ext / built-in backup battery ext / built-in backup battery ext ext ext ext ext / built-in backup battery ext ext ext ext ext ext ext ext ext ext ext
150-230mW tupical 75 mW at 3.0 V 75 mW at 3.0 V 75 mW at 3.0 V 56 or 68 mW at 1.8 V 68 mW at 1.8 V 75 mW at 3.0 V 75 mW at 3.0 V 84 mW at 3.3 V 95 mW at 2.7 V 95 mW at 2.7 V 42m at 3.0 V
ext., active or passive ext., active or passive ext., active or passive int, passive patch ext., active or passive internal chip antenna ext., active or passive ext., active or passive int., passive patch w optional external ext antenna ext., active or passive ext., active or passive ext., active or passive
Uses any mix of GPS, Glonass, QZSS and SBAS and in the future also Galielo and Compass signals. Increased accuracy with Dead Reckoning. Extremely sensitive and small size GPS module using MTK 3329 chipset, Extremely sensitive and small size GPS module with Fastrax Multiplatform compatible footprint using MTK 3329 chipset, Extremely sensitive module with integrated patch antenna using MTK 3329 chipset. Alternative versions are UP501B, UP501D. NEW!! Miniature module with low power consumption and additional power saving modes based on SiRF Star IV chipset. NEW! Minature module with integrated chip antenna based on SiRF StarIV chipset Fastrax IT Multiplatform compatible. High performing and reliable small, low power. SiRFstar III Sensitive patch antenna module w optional ext antenna, SiRFstarIII Programmable with iSuite SDK, CR output. Includes extensive expert features Programmable with iSuite SDK, CR output.Includes extensive expert features RF front end for Fastrax SW GPS and Accelerated SW GPS Pure SW GPS receiver with low resource requirements for MIDs and digital cameras SW GPS with HW correlators for low end CPUs MT3329 chipset, very high senstivity at -165dBM as above as above as above as above as above as above Smart antenna model, multi type connector and various cable length availavle Smart antenna model, multi type connector and various cable length availavle SiRF / CSR Star IV chipset GSD4e
Depend on configurations ext., active or passive Depend on configurations ext., active or passive 30mA at 3.3V 36mA at 3.3v 24mA at 3.3V 24mA at 3.3V 31mA at 3.3V 24mA at 3.3V 19mA at 3.3V 37mA at 3.3V 37mA at 3.3V 24mA at 3.3V ext., active or passive active internal antenna active internal antenna active internal antenna active internal antenna active internal antenna ext., active or passive active internal antenna active internal antenna active internal antenna Passive Passive or Active Passive or Active Passive Passive Passive or Active Active Active Passive or Active Active Passive or Active Passive or Active Active Active Active L1 Active L1 Active L1 / LBand Active Combined L1 / DGPS Beacon L1 / L2 Active L1 / L2 Active L1 / L2 / LBand Active External (user provided); will support active or passive External (user provided); will support active or passive External (user provided); will support active or passive L1 GNSS (E ) Beacon L1 GNSS (E ) Beacon L1 (E) Ceramic Patch Antenna
Antenna directly mounted High performance Dead Reckoning, Antenna directly mounted High performance Dead Reckoning
60s 60s 60s 60s 60s 60s 60s <<34s <<34s <<34s 60s 40s 45s <<35s
35s 35s 35s 35s 35s 35s 35s <33s <33s <33s 35s 15s 38s <33s
<1s <1s <1s <1s <1s <1s <1s <1s <1s <1s 0.5s 2s 1s <1s
1 1 8 2 3 3 3 2 3 3 2 2 3 2 2 7 1
ext ext ext ext Ext (5V, 12V 3.2 W or 24V) Integrated battery 2.0 W Integrated battery 2.9 W Integrated battery 2.7 W Ext (5V, 12V 3.6 W or 24V) Integrated battery 3.6 W Integrated battery 3.6 W 39ma
Built-in flash TCXO oscillator OXCO oscillator Ribidium oscillator The SXBlue series make optimal use of SBAS signals for ground users to provide submeter realtime positioning all the time Worldwide Portable OmniSTAR receiver (VBS Service). Integrated Battery. Portable DGPS Beacon receiver. Integrated battery. Dual Frequency (external power) Dual Frequency RTK. Integrated battery. Dual Frequency, Worldwide decimeter with OmniSTAR HP service. Integrated battery. Ruggedized for dismounted soldeir operations and low dynamic vehicle Real-time navigation system for dynamic platforms High-accuracy, real-time heading system for dynamic platforms based on GPS antennae mounted on a platform to compute precise heading and pitch information. SBAS and / or beacon and / or GSM SBAS and / or beacon and / or GPRS, PDA-unit SBAS, GPRS modem, SD card MTK (MediaTek) 3339 chipset, low power consumption, advanced software supported
-20 to + 60 (batttery) ext / int (LIPO) -20 to + 60 (batttery) Input power 10-30 volts DC -20 to + 60 (batttery) Input power 10-30 volts DC
9.600 - 115.200 38,400 19,200 4800 / 9600 / 14400 / 19200 / 38400 / 57600 / 115200 bps Avaliable
40 to + 85 40 to + 85 10 to + 85 40 to + 85
1 1 0.2 66 mW
www.gpsworld.com
FGPMMOSL3C Hemisphere GPS www.hemispheregps.com MBX4 SBX4 (OEM) A100 R100 R110 R120 R131 P100 (Crescent (OEM)) H101 (Crescent Vector II ) H102 V101 VS101 P200 (miniEclipse II (OEM)) P201 (miniEclipse II (OEM)) PA200 P300 P301 P320 (Eclipse II (OEM)) H320 R320 S320 V102 V103 IFEN GmbH www.ifen.com SX-NSR
as above 2 ind. 2 par. 12 par. 12 par. 12 par. 12 par. + 1 12 par. + 1 12 par. 12 par. (x2) 12 par. (x2) 12 par. (x2) 12 par. (x2) 117 par 117 par 117 par 117 par 117 par 117 par. + 1 117 par. (x2) + 1 117 par. + 1 117 par. + 1 12 par. (x2) 12 par. (x2) user-defined Multi- & vectorcorrelator 120 par. Narrow correlator 16ch 16ch 16ch 12 dedicated or multiplexed 12 dedicated 12 dedicated or multiplexed 24 dedicated
GPS L1 C / A code RTCM SC104 RTCM SC104 L1 only, C / Acode & CP (SBAS) L1 only, C / Acode & CP (SBAS) L1 only, C / Acode & CP (SBAS) and Beacon L1 only, C / Acode & CP (SBAS), L-Band L1 only, C / Acode & CP (SBAS), Beacon and L-Band L1 only, C / Acode & CP (SBAS) L1 only, C / Acode & CP (SBAS) L1 only, C / Acode & CP (SBAS) L1 only, C / Acode & CP (SBAS) L1 only, C / Acode & CP (SBAS) L1 / L2, C / A & P code & CP, (SBAS) L1 / L2, C / A & P code & CP, (SBAS) L1 / L2, C / A & P code & CP, (SBAS) L1 / L2, C / A & P code & CP, (SBAS) and GLONASS L1 / L2, C / A & P code & CP, (SBAS) and GLONASS L1 / L2, C / A & P code & CP, (SBAS), L-Band and GLONASS L1 / L2, C / A & P code & CP, (SBAS), L-Band and GLONASS L1 / L2, C / A & P code & CP, (SBAS), L-Band and GLONASS L1 / L2, C / A & P code & CP, (SBAS), L-Band and GLONASS L1 only, C / Acode & CP (SBAS) L1 only, C / Acode & CP (SBAS)
66 na na 12 12 12 12 + 1 12 + 1 12 12 12 12 12 15 15 15 27 27 27 + 1 27 + 1 27 + 1 27 + 1 12 12
ACDGHLMMetNPRSTV2 GLMNPV1 GLMNPV2 AGLMNPRV1 AGLMNPRV1 AGLMNPRV1 AGLMNPRV1 AGLMNPRV1 AGLMNPRV2 AGLMNPV2 AGLMNPV2 AGLMNPV1 AGLMNPV1 AGLMNPRV2 AGLMNPRV2 AGLMNPRV2 AGLMNPRV2 AGLMNPRV2 AGLMNPRV2 AGLMNPV2 AGLMNPRV1 AGLMNPRV1 AGLMNPV1 AGLMNPV1 LNP1
11.5 x 13 x 2.1mm 4.9 x 2.0 x 5.9in 2.0 x 0.54 x 3.0in 5.1 x 2.2in 4.5 x 1.8 x 6.3in 4.5 x 1.8 x 6.3in 4.5 x 1.8 x 6.3in 4.5 x 2.8 x 7.4in 1.6 x 0.5 x 2.8in 2.8 x 1.1 x 4.3in 14.8 x 4.1 x 1.0in 23.6 x 6.3 x 7.1in 4.5 x 2.8 x 7.4in 1.6 x 0.5 x 2.8in 1.6 x 0.5 x 2.85in 3.2 x 3.2 x 0.9in 1.6 x 0.5 x 2.8in 1.6 x 0.5 x 2.85in 2.8 x 0.5 x 4.3in 2.8 x 0.5 x 6.0in 4.5 x 1.8 x 6.3in 4.5 x 7.8in 16.4 x 6.2 x 2.7in 8.2 x 5.7 x 26.1in 15.7 x 6.9 x 18.0cm
Weight: < 2g 1.4 lb 0.06 lb 1.4 lb 1.2 lb 1.2 lb 1.2 lb 1.9 lb 0.06 lb 0.12 lb 8.8 oz 3.30 lb 1.9 lb <0.7 oz <0.7 oz <4.7 oz <0.7 oz <0.7 oz <2.5 oz <3.0 oz 1.4 lb 3.3 lb 3.3 lb 5.4 lb 3.5 lb
NavX-NTR ikeGPS www.ikeGPS.com ike100 ike300 ike1000 Interstate Electronics Corporation www.iechome.com TruTrak for projectile TruTrak Locator TruTrak Munitions TruTrak Evolution DS
up to 4 (8 with 2nd RF front-end)) signal chains user-defined tracked in real-time in parallel GPS L1 C / A, L2 P, L2C, L5 Galileo E1, E5a, E5b, E6, GLONASS G1 C / A, G2 C / A GPS L1 C / A, L2 P, L2C, L5, Galileo E1, E5ab, 60 E6, GLONASS G1 C / A & P GPS L1 C / A code, CP 16 GPS 16 GPS L1 C / A code, CP 16 GPS GPS L1 C / A code, CP 16 GPS 16 16
19.8 lb
<10 ns na na na 100 100 100 Data available upon request as above 1us 1us 1us 1us 1us 1us 1us 1us 1us
10Hz PVT 1Hz PVT 1Hz PVT 1Hz PVT 0.5 1 0.5 or 1 Data available upon request as above 1Hz PVT 1Hz PVT 1Hz PVT 1Hz PVT 5Hz PVT 1Hz PVT 1Hz PVT 1Hz or 5Hz PVT 1Hz or 5Hz PVT
L1 only, L2 optional C / A and Pcode, Ycode 12 L1 / L2 C / A and P(Y) L1 / L2 C / A and P(Y) L1 / L2 C / A and P(Y) 12 12 12
4.0 x 2.3 (flares to <0.25 lb 2.65) x 0.495in 3.42 x 3.42 x 0.495in <0.25 lb 1.75 x 2.45in 35g
TruTrak Evolution SS Inventek Systems www.Inventeksys.com ISM300F2-C4.1 ISM300F2-C5.1-V0002 ISM300F2-C5.1-V0003 ISM300F2-C5.1-V0004 ISM300F2-C5.0-V0005 EZ-GPS ISM420 ISM470 ISM480 ITT Exelis www.exelisinc.com Jackson Labs Technologies, Inc. www.jackson-labs.com MSN Receiver EGR 2500 CSAC (Chip Scale Cesium Atomic Clock) GPSDO FireFly-IIA 10MHz GPSDO FireFly-IIB 10MHz GPSDO Fury2-HS 10MHz GPSDO Fury2-LC 10MHz GPSDO FireFly-1A 16MHz GPSDO FireFly-1A 10MHz GPSDO FireFly-II 10MHz GPSDO FireFly-IIA Ruggedized, low-g 10MHz GPSDO ULN-2550 25MHz / 100MHz / 10MHz GPSDO
12 dedicated 20 par Channel (200,000 correlators) 20 par Channel (200,000 correlators) 20 par Channel (200,000 correlators) 20 par Channel (200,000 correlators) 20 par Channel (200,000 correlators) 20 par Channel (200,000 correlators) 48 Track verification channels 48 Track verification channels 48 Track verification channels 12 12 50 par. 50 par. 50 par. 12 par. 12 par. 50 par. 50 par. 50 par. 50 par. 50 par.
L1 C / A and P(Y) GPS L1 C / A code, 24 GPS GPS L1 C / A code, 24 GPS GPS L1 C / A code, 24 GPS GPS L1 C / A code, 24 GPS GPS L1 C / A code, 24 GPS GPS L1 C / A code, 24 GPS GPS L1 C / A code, 48 GPS GPS L1 C / A code, 48 GPS GPS L1 C / A code, 48 GPS GPS L1 / L2; CA and P(Y) GPS L1 / L2; CA and P(Y) L1, C / A, WAAS, EGNOS, SBAS L1, C / A, WAAS, EGNOS, SBAS L1, C / A, WAAS, EGNOS, SBAS L1, C / A L1, C / A L1, C / A, WAAS, EGNOS, SBAS L1, C / A, WAAS, EGNOS, SBAS L1, C / A, WAAS, EGNOS, SBAS L1, C / A, WAAS, EGNOS, SBAS L1, C / A, WAAS, EGNOS, SBAS
12 12 12 12 12 12 12 24 24 24 12 12 50 50 50 12 12 50 50 50 50 50
D ACDGHLMNO ACDGHLMNO ACDGHLMNO ACDGHLMNO ACDGHLMNO ACDGHLMNO ACDGHLMNO ACDGHLMNO ACDGHLMNO D D ADLMMETNOTV2 ADLMMETNOTV2 ADLMMETNOTV2 ADLMMETNOT2 ADLMMETNOT2 ADLMMETNOTV2 ADLMMETNOTV2 ADLMMETNOTV2 ADLMMETNOTV2 ADLMMETNOTV2
3.07 x 0.93in with tabs to 1.49in 18 x 18 x 3.1mm 18 x 18 x 3.1mm 18 x 18 x 3.1mm 18 x 18 x 3.1mm 18 x 18 x 3.1mm 18 x 18 x 12mm 9.5 x 10.5 x 2.5mm 12.5 x 15.0 x 2.5mm 16.5 x 16.5 x 7.0mm
Data available upon request 5 m, 2DRMS 5 m, 2DRMS 5 m, 2DRMS 5 m, 2DRMS 5 m, 2DRMS 5 m, 2DRMS 5 m, 2DRMS 5 m, 2DRMS 5 m, 2DRMS
18 x 19 x 5.25 inches 30 lbs 2.45 x 1.76 x 0.38 in 3 x 2.5 x 0.5in 1.5 x 3 x 1in 1.5 x 3 x 1in 10.0 x 10.0 x 2.6cm 10.0 x 10.0 x 2.6cm 1.0 x 2.5 x 0.5in 1.0 x 2.5 x 0.5in 1.5 x 3.0 x 0.8in 1.5 x 3.0 x 0.8in 1.5 x 3.5 x 0.8in 31 grams <2 Oz 1.74 Oz 1.74 Oz 0.25lb 0.25lb 0.64 Oz 0.64 Oz 1.74 Oz 2 Oz 1.8 Oz <10 m <2m RMS <2m RMS <2m RMS <5m RMS <5m RMS <2m RMS <2m RMS <2m RMS <2m RMS <2m RMS <30 ns <15ns RMS <30ns RMS <30ns RMS <2ns RMS <2ns RMS <30ns RMS <30ns RMS <30ns RMS <30ns RMS <30ns RMS 1Hz 1Hz 1Hz 1Hz 1Hz 1Hz 1Hz 1Hz 1Hz 1Hz 1Hz
www.gpsworld.com
Sponsored by
Cold start 3 <<35s <<35s Warm start 4 <33s <33s Reacquisition No. of ports
5
<1s <1s
2 1
<<35s <60s <60s 60s 60s 60s 60s 60s 60s 60s 60s 60s 60s 60s 60s 60s 60s 60s 60s 60s 60s 60s 60s 60s <55s
<33s <2s 30s 30s 30s 30s 30s 30s 30s 30s 30s 30s 30s 30s 30s 30s 30s 30s 30s 30s 30s 30s 30s 30s <10s
<1s 2s <10s <10s <10s <10s <10s <10s <10s <10s <10s <10s <10s <10s <10s <10s <10s <10s <10s <10s <10s <10s <10s <10s <1s
2 1 2 2 3 3 3 3 4 4 2 3 2 4 4 2 4 4 5 5 4 6 2 2 1 (2)
UART RS-232 or RS-422 3.3 V HCMOS RS-232 RS-232, USB RS-232, USB RS-232, USB RS-232, USB 3.3 V HCMOS 3.3 V HCMOS RS-232 RS-232 and RS-422 RS-232 3.3 V HCMOS, USB 3.3 V HCMOS, USB LVDS - Serial 3.3 V HCMOS, USB 3.3 V HCMOS, USB 3.3 V HCMOS, USB 3.3 V HCMOS, USB RS-232, USB RS-232 (Multi-Use), RS-232, Bluetooth, USB, Bluetooth, SD RS-232 RS-232 1 USB 2.0 (2 USB 2.0 with 2nd RF front-end) 1 Ethernet USB, RS232 USB, RS232 USB, RS232 RS-422, TTL
as above 4,8009,600 4,800115,2000 4,800115,2000 4,800115,2000 4,800115,2000 4,800115,2000 4,800115,2000 4,800115,2000 4,800115,2000 4,800115,2000 4,80038,400 4,800115,2000 4,800115,200 4,800115,200 4,800115,200 4,800115,200 4,800115,200 4,800115,200 4,800115,200 4,800115,200 4,800115,200 4,800115,2000 4,80038,400 480 Mbps USB
40 to + 85 30 to + 70 30 to + 70 30 to + 70 30 to + 70 30 to + 70 30 to + 70 30 to + 70 30 to + 70 30 to + 70 30 to + 70 30 to + 70 30 to + 70 40 to + 85 40 to + 85 30 to + 70 30 to + 70 30 to + 70 40 to + 85 30 to + 70 40 to + 70 30 to + 70 30 to + 70 30 to + 70 0 to + 50
ext External External External External External External External External External External External External External External External External External External External External Internal w / Option of External External External external
50 mW 2.5 <0.25 <2 <3 <3 <3 <3 <1.0 <1 <3 <5 <5 <1.35 <1.35 <1.65 <1.9 <1.9 <2.5 <3.25 <4.3 Rover: 4.4 Base Tx UHF: 7 <3 <5
<7.5W (<15W with 2nd RF Active, external front-end) 90W na na na 3 (typ) 3 (typ) 3 (typ) Data available upon request as above 100 mW acquisition, 65 mW tracking 25 mA tracking 25 mA tracking 25 mA tracking 25 mA tracking 25 mA tracking 10 mW trickle mode 10 mW trickle mode 10 mW trickle mode Active, external Internal Patch Internal Patch Internal Patch E E E Two active
<1s <5s <5s <5s 5s 5s 5s Data available upon request as above 100ms 100ms 100ms 100ms 100ms 100ms 100ms 100ms 100ms
1 1 1 1 2 2 2 3
10 / 100 Mbps
ext (AC / DC) int int int ext ext ext Input power 3.3 VDC as above 3.0-5V dc 3.0-5V dc 3.0-5V dc 3.0-5V dc 3.0-5V dc 3.0-5V dc 1.8 V dc 1.8 V dc 1.8 V dc ext
153.6k (nominal)
42 to + 85 20 to + 70 40 to + 85 Data available upon request as above 40to + 85 40to + 85 40to + 85 40to + 85 40to + 85 40to + 85 35 to + 85 35 to + 85 35 to + 85
Data available Data upon request available upon request as above <<35 <<35s <<35s <<35s <<35s <<35s <<35s <<35s <<35s as above <<35 <<35s <<35s <<35s <<35s <<35s <<8s <<8s <<8s
Serial RS-232 Serial TTL - CDU 9,600 (nominal) (debug) Serial RS-422 Serial TTL - CDU 153.6k (nominal) (debug) COM1 ( either RS-232 or Data available upon request CMOS), COM2 (CMOS), DS101 / 102, TOD and 1PPS 1 x RS 232 and 2 x CMOS serial ports, DS-101,TOD and 1-10PPS UARTS up to 115200 Kbps UART NMEA 57600 SBAS enabled NMEA 4800, Sirf Binary 57600 MID41 only Sirf Binary 57600, NMEA 4800, High Altitude Build 42000 meters Sirf Binary 115200, NMEA 57600, 5Hz outpu UART NMEA 4800 SPI,UART,I2C SPI,UART,I2C SPI,UART,I2C as above 4800 NMEA and 57,600 SiRF Binary 4800 NMEA and 57,600 SiRF Binary 4800 NMEA and 57,600 SiRF Binary 4800 NMEA and 57,600 SiRF Binary 4800 NMEA and 57,600 SiRF Binary 4800 NMEA and 57,600 SiRF Binary 4800 NMEA, 57,600 OSP, ROM 4800 NMEA, 57,600 OSP - Prog. 4800 NMEA, 5,7600 OSP - Prog.
3 2 1 2 2 2 1 1 1 1
Passive Active direct connect via U.FL or Pin 1 trace Active direct connect via U.FL or Pin 1 trace Active direct connect via U.FL or Pin 1 trace Active direct connect via U.FL or Pin 1 trace Active direct connect via U.FL or Pin 1 trace SMA tp actoive antennna Ext. passive antenna, surface mount device Ext. passive antenna, surface mount device Integrated ceramic Antenna external, active
as above Standard Firmware with -159 dBm tracking mode. Standard Firmware with -159 dBm tracking mode. MID41 only High Altitude for Balloons True 5Hz output USB dongle with external GPS Integrated LNA, Low Cost ROM based. Integrated LNA, Flashed based,SGEE and CGEE capability 12 pin connector, fully integrated stand alone GPS with anti jamming, SGEE and CGEE
<40s <45s <45s <45s <150s <150s <45s <45s <45s <45s <45s
<38s <1s <1s <1s <40s <40s <1s <1s <1s <1s <1s
<3s <1s <1s <1s <1s <1s <1s <1s <1s <1s <1s
4 2 1 1 1 1 1 1 1 1 1
RS-232, CMOS RS-232, USB, Alarm, 10MHz, 5MHz, 1PPS RS-232, Alarm, 10MHz, 1PPS RS-232, Alarm, 10MHz, 1PPS RS-232, Alarm, 10MHz, 1PPS RS-232, Alarm, 10MHz, 1PPS RS-232, Alarm, 16MHz, 1PPS RS-232, Alarm, 10MHz, 1PPS RS-232, Alarm, 10MHz, 1PPS RS-232, Alarm, 10MHz, 1PPS RS-232, Alarm, 10 / 25 / 50 / 100MHz, 1PPS
9,600 - 115,200 9,600 - 115,200 9,600 - 115,200 9,600 - 115,200 9,600 - 115,200 9,600 - 115,200 9,600 - 115,200 9,600 - 115,200 9,600 - 115,200 9,600 - 115,200
-40 to + 85 -45 to + 85 -20 to + 85 -20 to + 85 -20 to + 85 -20 to + 85 -20 to + 85 -20 to + 85 -20 to + 85 -20 to + 85 -20 to + 85
ext 8.0-36.0 V 11.0-14.0 V 11.0-14.0 V 11.0-14.0 V 11.0-14.0 V 8.0-14.0 V 8.0-14.0 V 11.0-14.0 V 11.0-14.0 V 11.0-14.0 V
<1W <1.4W <3.5W <3.5W <4.5W <4.5W <1.4W <1.4W <3.5W <3.5W <3.5W
SAASM Chip Scale Cesium Atomic Clock with GPS Disciplining, two NMEA and SCPI ports, and Distribution Amplifier with 5 isolated outputs Built-In 10MHz Distribution Amplifier, 3-Axis Accelerometer, low-g option Built-In 4-channel 10MHz Distribution Amplifier, low vibration sensitivity Rubidium Oscillator Replacement Better than 1E-012 stability Ultra small and light, 16MHz output Ultra small and light 3D velocity, stability: <1E-011 Mil rugged, stability <1E-011, <3E-010 per-g sensitivity Adds four 25MHz LVDS outputs (50MHz option), a 100MHz output, and a 10MHz output
www.gpsworld.com
DROR Airborne GPS 50 par. Position, Time, and Frequency Reference Rubidium Replacement EuroCan GPSOCXO 10MHz 50 par. / 16MHz EuroCan GPSTCXO 10MHz 50 par. / 16MHz USB GPSTCXO 10MHz M9107 GPSDO 10MHz JAVAD GNSS www.javad.com TRIUMPH-1 50 par. 50 par. 216
L1, C / A, WAAS, EGNOS, SBAS L1, C / A, WAAS, EGNOS, SBAS L1, C / A, WAAS, EGNOS, SBAS L1, C / A, WAAS, EGNOS, SBAS GPS CA / P1 / P2 / L2C / L5 Galileo E1 / E5A / E5B GLONASS CA / P1 / P2 / L2C / L3 SBAS L1 / L5 QZSS CA / SAIF / L2C / L5 / L1C Compass E1 / E5B GPS CA / P1 / P2 / L2C / L5 Galileo E1 / E5A / E5B GLONASS CA / P1 / P2 / L2C / L3 SBAS L1 / L5 QZSS CA / SAIF / L2C / L5 / L1C Compass E1 / E5B GPS CA / P1 / P2 / L2C / L5 Galileo E1 / E5A / E5B GLONASS CA / P1 / P2 / L2C / L3 SBAS L1 / L5 QZSS CA / SAIF / L2C / L5 / L1C Compass E1 / E5B 4x GPS CA / P1 / P2 / L2C / L5 4x Galileo E1 / E5A 4x SBAS L1 / L5 4x QZSS CA / SAIF / L2C / L5 / L1C 4x Compass E1 GPS CA Galileo E1 GLONASS CA SBAS L1 QZSS CA / SAIF / L1C Compass E1 GPS CA / P1 / P2 / L2C / L5 Galileo E1 / E5A SBAS L1 / L5 QZSS CA / SAIF / L2C / L5 / L1C Compass E1 GPS CA / P1 / P2 / L2C / L5 Galileo E1 / E5A GLONASS CA / P1 / P2 / L2C SBAS L1 / L5 QZSS CA / SAIF / L2C / L5 / L1C Compass E1 GPS CA Galileo E1 GLONASS CA SBAS L1 QZSS CA / SAIF / L1C Compass E1 GPS CA Galileo E1 SBAS L1 QZSS CA / SAIF / L1C Compass E1 GPS CA / P1 / P2 / L2C / L5 Galileo E1 / E5A SBAS L1 / L5 QZSS CA / SAIF / L2C / L5 / L1C Compass E1 GPS CA / P1 / P2 / L2C / L5 Galileo E1 / E5A GLONASS CA / P1 / P2 / L2C SBAS L1 / L5 QZSS CA / SAIF / L2C / L5 / L1C Compass E1 GPS CA / P1 / P2 / L2C / L5 Galileo E1 / E5A SBAS L1 / L5 QZSS CA / SAIF / L2C / L5 / L1C Compass E1 GPS CA / P1 / P2 / L2C / L5 Galileo E1 / E5A / E5B GLONASS CA / P1 / P2 / L2C / L3 SBAS L1 / L5 QZSS CA / SAIF / L2C / L5 / L1C Compass E1 / E5B GPS CA / P1 / P2 / L2C / L5 Galileo E1 / E5A / E5B GLONASS CA / P1 / P2 / L2C / L3 SBAS L1 / L5 QZSS CA / SAIF / L2C / L5 / L1C Compass E1 / E5B 2x GPS CA 2x Galileo E1 2x SBAS L1 2x QZSS CA / SAIF / L1C 2x Compass E1 2x GPS CA / P1 / P2 / L2C 2x Galileo E1 2x SBAS L1 2x QZSS CA / SAIF / L2C / L1C 2x Compass E1 2x GPS CA / P1 / P2 / L2C 2x Galileo E1 2x Glonass CA / P1 / P2 / L2C 2x SBAS L1 2x QZSS CA / SAIF / L2C / L1C 2x Compass E1 4x GPS CA / P1 / P2 / L2C 4x Galileo E1 1x Glonass CA / P1 / P2 / L2C 4x SBAS L1 4x QZSS CA / SAIF / L2C / L1C 4x Compass E1 GPS CA / P1 / P2 / L2C / L5 Galileo E1 / E5A SBAS L1 / L5 QZSS CA / SAIF / L2C / L5 / L1C Compass E1
50 50 50 50 all in view
1.07 x 1.42 x 0.5in 1.07 x 1.42 x 0.5in 3 x 2 x 0.5in 0.97x0.97x0.5 178 x 96 x 178mm
<2m RMS <2m RMS <2m RMS <2m RMS <2m / <0.5m / 1 cm + 1 ppm / 0.3cm + 0.5 ppm <2m / <0.5m / 1 cm + 1 ppm / 0.3cm + 0.5 ppm <2m / <0.5m / 1 cm + 1 ppm / 0.3cm + 0.5 ppm <2m / <0.5m / 0.6 cm + 1 ppm / 0.3cm + 0.5 ppm
TRIUMPH-VS
216
all in view
1GHLMTNPROMet
1700 g
100Hz
TRIUMPH-NT
216
all in view
1GHLMTNPROMet
1700 g
100Hz
TRUIMPH-4X Alpha G3 Alpha G2T Alpha G3T Alpha2-G3 Alpha2-G2 Alpha2-G2T Alpha2-G3T Delta G2T Delta G3T
216 216 216 216 216 216 216 216 216 216
all in view all in view all in view all in view all in view all in view all in view all in view all in view all in view
1AGLMTNPROMet 1AGLMTNPROMet 1AGLMTNPROMet 1AGLMTNPROMet 1AGLMTNPROMet 1AGLMTNPROMet 1AGLMTNPROMet 1AGLMTNPROMet 1AGLMTNPROMet 1AGLMTNPROMet
178 x 93 x 178mm 148 x 85 x 35mm 148 x 85 x 35mm 148 x 85 x 35mm 148 x 85 x 35mm 148 x 85 x 35mm 148 x 85 x 35mm 148 x 85 x 35mm 109 x 35 x 169mm 109 x 35 x 169mm
1850 g 430 g 435 g 448 g 430 g 415 g 435 g 448 g 394 g 401 g
20Hz 100Hz 100Hz 100Hz 100Hz 100Hz 100Hz 100Hz 100Hz 100Hz
<2m / <0.5m / 1.5cm + 2 ppm / 3 0.5cm + 1.5ppm <2m / <0.5m / 1cm + 1 ppm / 0.3cm 3 + 0.5ppm <2m / <0.5m / 1 cm + 1 ppm / 0.3cm + 0.5 ppm <2m / <0.5m / 1.5 cm + 2 ppm / 0.5cm + 1.5 ppm <2m / <0.5m / 1.5 cm + 2 ppm / 0.5cm + 1.5 ppm <2m / <0.5m / 1 cm + 1 ppm / 0.3cm + 0.5 ppm <2m / <0.5m / 1 cm + 1 ppm / 0.3cm + 0.5 ppm <2m / <0.5m / 1 cm + 1 ppm / 0.3cm + 0.5 ppm <2m / <0.5m / 1 cm + 1 ppm / 0.3cm + 0.5 ppm <2m / <0.5m / 1 cm + 1 ppm / 0.3cm + 0.5 ppm <2m / <0.5m / 1.5 cm + 2 ppm / 0.5cm + 1.5 ppm <2m / <0.5m / 1 cm + 1 ppm / 0.3cm + 0.5 ppm <2m / <0.5m / 1 cm + 1 ppm / 0.3cm + 0.5 ppm <2m / <0.5m / 1 cm + 1 ppm / 0.3cm + 0.5 ppm <2m / <0.5m / 1 cm + 1 ppm / 0.3cm + 0.5 ppm <2m / <0.5m / 1 cm + 1 ppm / 0.3cm + 0.5 ppm <2m / <0.5m / 1 cm + 1 ppm / 0.3cm + 0.5 ppm <2m / <0.5m / 1.5 cm + 2 ppm / 0.5cm + 1.5 ppm <2m / <0.5m / 1 cm + 1 ppm / 0.3cm + 0.5 ppm <2m / <0.5m / 1 cm + 1 ppm / 0.3cm + 0.5 ppm <2m / <0.5m / 1 cm + 1 ppm / 0.3cm + 0.5 ppm <3m / <0.5m / 1.5 cm + 2 ppm / 0.7cm + 1.5 ppm <2m / <0.5m / 1.5 cm + 2 ppm / 0.5cm + 1.5 ppm <2m / <0.5m / 1.5 cm + 2 ppm / 0.5cm + 1.5 ppm <2m / <0.5m / 1 cm + 1 ppm / 0.3cm + 0.5 ppm <2m / <0.5m / 1 cm + 1 ppm / 0.3cm + 0.5 ppm <2m / <0.5m / 1 cm + 1 ppm / 0.3cm + 0.5 ppm 3 3 3 3 3 3 3
Delta-G3TAJ
216
all in view
1AGLMTNPROMet
109 x 35 x 169mm
401 g
100Hz
Delta D-G2 Delta D-G2D Delta D-G3D Delta Q-G3D Sigma G2T
all in view all in view all in view all in view all in view
109 x 35 x 169mm 109 x 35 x 169mm 109 x 35 x 169mm 109 x 35 x 169mm 132 x 61 x 190mm
3 3 3 3 3
Sigma G3T
216
Sigma G3TAJ
216
Sigma D-G2
216
GPS CA / P1 / P2 / L2C / L5 Galileo E1 / E5A all in view / E5B GLONASS CA / P1 / P2 / L2C / L3 SBAS L1 / L5 QZSS CA / SAIF / L2C / L5 / L1C Compass E1 / E5B GPS CA / P1 / P2 / L2C / L5 Galileo E1 / E5A all in view / E5B GLONASS CA / P1 / P2 / L2C / L3 SBAS L1 / L5 QZSS CA / SAIF / L2C / L5 / L1C Compass E1 / E5B 2x GPS CA 2x Galileo E1 2x SBAS L1 2x all in view QZSS CA / SAIF / L1C 2x Compass E1 2x GPS CA / P1 / P2 / L2C 2x Galileo E1 2x SBAS L1 2x QZSS CA / SAIF / L2C / L1C 2x Compass E1 2x GPS CA / P1 / P2 / L2C 2x Galileo E1 2x Glonass CA / P1 / P2 / L2C 2x SBAS L1 2x QZSS CA / SAIF / L2C / L1C 2x Compass E1 4x GPS CA / P1 / P2 / L2C 4x Galileo E1 1x Glonass CA / P1 / P2 / L2C 4x SBAS L1 4x QZSS CA / SAIF / L2C / L1C 4x Compass E1 GPS CA Galileo E1 GLONASS CA SBAS L1 QZSS CA / SAIF / L1C Compass E1 GPS CA Galileo E1 SBAS L1 QZSS CA / SAIF / L1C Compass E1 GPS CA Galileo E1 GLONASS CA SBAS L1 QZSS CA / SAIF / L1C Compass E1 GPS CA / P1 / P2 / L2C / L5 Galileo E1 / E5A SBAS L1 / L5 QZSS CA / SAIF / L2C / L5 / L1C Compass E1 GPS CA / P1 / P2 / L2C / L5 Galileo E1 / E5A GLONASS CA / P1 / P2 / L2C SBAS L1 / L5 QZSS CA / SAIF / L2C / L5 / L1C Compass E1 GPS CA / P1 / P2 / L2C / L5 Galileo E1 / E5A SBAS L1 / L5 QZSS CA / SAIF / L2C / L5 / L1C Compass E1 all in view
1AGLMTNPROMet
132 x 61 x 190mm
1277 g
100Hz
1AGLMTNPROMet
132 x 61 x 190mm
1270 g
100Hz
1AGLMTNPROMet
132 x 61 x 190mm
1290 g
100Hz
Sigma D-G2D
216
1AGLMTNPROMet
132 x 61 x 190mm
1290 g
100Hz
Sigma D-G3D
216
all in view
1AGLMTNPROMet
132 x 61 x 190mm
1290 g
100Hz
Sigma Q-G3D
216
all in view
1AGLMTNPROMet
132 x 61 x 190mm
1330 g
100Hz
all in view all in view all in view all in view all in view all in view
303 g 21 g 34 g 34 g 47 g 70 g
3 3 3 3 3 3
TRE-G3T
216
TRE-G3TAJ
216
GPS CA / P1 / P2 / L2C / L5 Galileo E1 / E5A / E5B GLONASS CA / P1 / P2 / L2C / L3 SBAS L1 / L5 QZSS CA / SAIF / L2C / L5 / L1C Compass E1 / E5B GPS CA / P1 / P2 / L2C / L5 Galileo E1 / E5A / E5B GLONASS CA / P1 / P2 / L2C / L3 SBAS L1 / L5 QZSS CA / SAIF / L2C / L5 / L1C Compass E1 / E5B
all in view
2AGLMTNPROMet
100 x 80 x 14mm
77 g
<2m / <0.5m / 1 cm + 1 ppm / 0.3cm 3 + 0.5 ppm <2m / <0.5m / 1 cm + 1 ppm / 0.3cm 3 + 0.5 ppm
100Hz
all in view
2AGLMTNPROMet
100 x 80 x 14mm
77 g
100Hz
10
www.gpsworld.com
Sponsored by
Cold start 3 <45s <45s Warm start 4 <1s <1s Reacquisition No. of ports
5
Port type RS-232, Alarm, 10 / 100MHz, 1PPS RS-232, Alarm, 10MHz, 1PPS
<1s <1s
1 1
1 1 1 1 2111111
5V 5V 5V 5V I/E
TTL NMEA-0183, SCPI, 10MHz 9,600 - 115,200 RS232; USB; Ethernet; Wi-Fi; 460.8 kbps, 480 Mbps 10 / Bluetooth; 1PPS; Event Marker 100 Mbps 54 Mps 2 Mbps USB OTG; USB; Ethernet; Wi-Fi; Bluetooth; 1PPS; Event Marker / Ext. Freq In / Out USB OTG; USB; Ethernet; Wi-Fi; Bluetooth; 1PPS; Event Marker or Ext. Freq In / Out RS232; USB; Ethernet; Wi-Fi; Bluetooth
<35s
<5s
<1s
1111111
480 Mbps 480 Mbps 10 / 100 -35 to + 75 Mbps 54 Mps 2 Mbps 480 Mbps 480 Mbps 10 / 100 -35 to + 75 Mbps 54 Mps 2 Mbps 480 Mbps 480 Mbps 10 / 100 -35 to + 75 Mbps 54 Mps 2 Mbpsove -35 to + 75 -35 to + 75 -35 to + 75 -35 to + 75 -35 to + 75 -35 to + 75 -35 to + 75 -35 to + 75 -35 to + 75
ext / int
I/E
<35s
<5s
<1s
1111111
ext / int
7.5
<35 s
<5 s
<1 s
ext / int ext / int ext / int ext / int ext ext ext ext ext ext
6.2 1.8 1.9 2.6 1.6 1.4 1.7 2.4 2.5 3.4
I/E E E E E E E E E E
RS232 USB / RS232 Bluetooth 460.8 kbps 12 Mbps 2 Mbps 1PPS / IRIG Event Marker RS232 USB / RS232 Bluetooth 460.8 kbps 12 Mbps 2 Mbps 1PPS / IRIG Event Marker RS232 USB / RS232 Bluetooth 460.8 kbps 12 Mbps 2 Mbps 1PPS / IRIG Event Marker RS232 USB / RS232 Bluetooth 460.8 kbps 12 Mbps 2 Mbps 1PPS / IRIG Event Marker RS232 USB / RS232 Bluetooth 460.8 kbps 12 Mbps 2 Mbps 1PPS / IRIG Event Marker RS232 USB / RS232 Bluetooth 460.8 kbps 12 Mbps 2 Mbps 1PPS / IRIG Event Marker RS232 USB / RS232 Bluetooth 460.8 kbps 12 Mbps 2 Mbps 1PPS / IRIG Event Marker RS232; RS422; USB; Ethernet; CAN; 1PPS; Event Marker; IRIG / Ext. Freq In / Out RS232; RS422; USB; Ethernet; CAN; 1PPS; Event Marker; IRIG / Ext. Freq In / Out 460.8 kbps, 460.8 kbps, 480 Mbps, 10 / 100 Mbps, 1 Mps 460.8 kbps, 460.8 kbps, 480 Mbps, 10 / 100 Mbps, 1 Mps
<35 s
<5 s
<1 s
<35s <35s
<5s <5s
<1s <1s
31111221 31111221
<35s
<5s
<1s
31111221
RS232; RS422; USB; Ethernet; 460.8 kbps, 460.8 kbps, 480 CAN; 1PPS; Event Marker; Mbps, 10 / 100 Mbps, 1 Mps IRIG / Ext. Freq In / Out RS232; RS422; USB; Ethernet; CAN; 1PPS; Event Marker; IRIG / Ext. Freq In / Out RS232; RS422; USB; Ethernet; CAN; 1PPS; Event Marker; IRIG / Ext. Freq In / Out RS232; RS422; USB; Ethernet; CAN; 1PPS; Event Marker; IRIG / Ext. Freq In / Out RS232; RS422; USB; Ethernet; CAN; 1PPS; Event Marker; IRIG / Ext. Freq In / Out RS232; RS422; USB; Ethernet; Bluetooth; CAN; 1PPS; Event Marker; IRIG / Ext. Freq In / Out RS232; RS422; USB; Ethernet; Bluetooth; CAN; 1PPS; Event Marker; IRIG / Ext. Freq In / Out RS232; RS422; USB; Ethernet; Bluetooth; CAN; 1PPS; Event Marker; IRIG / Ext. Freq In / Out RS232; RS422; USB; Ethernet; Bluetooth; CAN; 1PPS; Event Marker; IRIG / Ext. Freq In / Out RS232; RS422; USB; Ethernet; Bluetooth; CAN; 1PPS; Event Marker; IRIG / Ext. Freq In / Out RS232; RS422; USB; Ethernet; Bluetooth; CAN; 1PPS; Event Marker; IRIG / Ext. Freq In / Out RS232; RS422; USB; Ethernet; Bluetooth; CAN; 1PPS; Event Marker; IRIG / Ext. Freq In / Out Bluetooth RS232; USB; CAN; 1PPS; Event Marker; IRIG RS232; RS422; USB; CAN; 1PPS; Event Marker; IRIG RS232; RS422; USB; CAN; 1PPS; Event Marker; IRIG RS232; RS422; USB; CAN; 1PPS; Event Marker; IRIG RS232; RS232 / RS422; USB; CAN; 1PPS; Event Marker; IRIG; Ethernet; Ext. Freq In / Out RS232; RS232 / RS422; USB; CAN; 1PPS; Event Marker; IRIG; Ethernet; Ext.Reference; Frequency input RS232; RS232 / RS422; USB; CAN; 1PPS; Event Marker; IRIG; Ethernet; Ext. Freq In / Out 460.8 kbps, 460.8 kbps, 480 Mbps, 10 / 100 Mbps, 1 Mps 460.8 kbps, 460.8 kbps, 480 Mbps, 10 / 100 Mbps, 1 Mps 460.8 kbps, 460.8 kbps, 480 Mbps, 10 / 100 Mbps, 1 Mps 460.8 kbps, 460.8 kbps, 480 Mbps, 10 / 100 Mbps, 1 Mps 460.8 kbps, 460.8 kbps, 480 Mbps, 10 / 100 Mbps, 2 Mbps, 1 Mps 460.8kbps, 460.8kbps, 480Mbps, 10 / 100 Mbps, 2 Mbps, 1Mps 460.8 kbps, 460.8 kbps, 480 Mbps, 10 / 100 Mbps, 2 Mbps, 1 Mps 460.8 kbps, 460.8 kbps, 480 Mbps, 10 / 100 Mbps, 2 Mbps, 1 Mps 460.8kbps, 460.8kbps, 480Mbps, 10 / 100 Mbps, 2 Mbps, 1Mps 460.8 kbps, 460.8 kbps, 480 Mbps, 10 / 100 Mbps, 2 Mbps, 1 Mps 460.8 kbps, 460.8 kbps, 480 Mbps, 10 / 100 Mbps, 2 Mbps, 1 Mps 2 Mbps 460.8 kbps, 12 Mbps 1 Mps 460.8 kbps, 460.8 kbps 12 Mbps 1 Mps 460.8 kbps, 460.8 kbps 12 Mbps 1 Mps 460.8 kbps, 460.8 kbps 12 Mbps 1 Mps 460.8 kbps, 460.8 kbps 480 Mbps 1 Mps 10 / 100 Mbps
-35 to + 75
ext
4.1
E E E E E
2048MB memory 2048MB memory 2048MB memory 2048MB memory 2048MB memory UHF / FH radio GSM / GPRS / EDGE modem 2048MB memory UHF / FH radio GSM / GPRS / EDGE modem 2048MB memory UHF / FH radio GSM / GPRS / EDGE modem In Band Interference Rejection 2048MB memory UHF / FH radio GSM / GPRS / EDGE modem 2048MB memory UHF / FH radio GSM / GPRS / EDGE modem 2048MB memory UHF / FH radio GSM / GPRS / EDGE modem 2048MB memory UHF / FH radio GSM / GPRS / EDGE modem GSM / GPRS modem 256MB memory 256MB memory 256MB memory 256MB memory 2048MB memory
<35s
<5s
<1s
211111221
-35 to + 75
ext / int
4.2
<35s
<5s
<1s
211111221
-35 to + 75
ext / int
4.9
<35s
<5s
<1s
211111221
-35 to + 75
ext / int
<35s
<5s
<1s
211111221
-35 to + 75
ext / int
<35s
<5s
<1s
211111221
-35 to + 75
ext / int
4.7
<35s
<5s
<1s
211111221
-35 to + 75
ext / int
I E E E E E
<35s
<5s
<1s
221222111
460.8 kbps, 460.8 kbps 480 Mbps 1 Mps 10 / 100 Mbps 460.8 kbps, 460.8 kbps 480 Mbps 1 Mps 10 / 100 Mbps
-35 to + 75
ext
3.4
2048MB memory
<35s
<5s
<1s
221222111
-35 to + 75
ext
4.1
www.gpsworld.com
11
55 GNSS + 1 StarFire L-band with RTK, DGPS, Omnistar and SBAS positioning modes Total 120 channel: L1, L2 (L2C), L5 GPS; L1, L2 GLONASS;E1 / E5a / E5b / Alt-BOC Galileo; Compass; 4 SBAS 16 L1, 16 L2 GPS, 4 SBAS Total 120 channel: L1, L2 (L2C), L5 GPS; L1, L2 GLONASS;E1 / E5a / E5b / Alt-BOC Galileo; Compass; 4 SBAS as above as above
55 GNSS + 1 StarFire 32
WP, LNOPR1, Precision Ag 22.3 x 16.5 x 22.3 ADGLMNPV2R1 15.24 x 16.76 x 8.89cm
nr
10Hz (0.1 sec) RTK (2 cm + 1PPM), DGPS (.5 m), Single Point (1.8 m)
GX1230 + GNSS
GPS:L1, L2 (L2C), L5 C / A code and CP, P-Code,; GLONASS: L1,L2 C / A code and CP, P-Code; Galileo:E1,E5a / E5b Code and CP, Alt-BOC Code and CP; SBAS
48
AGLMNR1
166 x 79 x 212mm
1.2 kg
<100
0.05
GPS: L1, L2 (L2C), C / A code and CP, P-Code,; SBAS GPS: L1, L2 (L2C), L5 C / A code and CP, P-Code,; GLONASS: L1,L2 C / A code and CP, P-Code; Galileo:E1,E5a / E5b Code and CP, Alt-BOC Code and CP; SBAS
20 48
AGLMetORT1 AGLMetORT1
1.25 kg 1.25 kg
5 m / 25cm / na / na 5 m / 25cm / na / na
<100 <100
0.05 0.05
GR10 GR25
as above as above
60 60
AGLMetORT1 AGLMetORT1
1.50 kg 1.84 kg
5 m / 25cm / na / na 5 m / 25cm / na / na
<100 <100
0.05 0.05
GMX901 GMX902 GG
12 L1 (GPS) 14 L1, 14 L2 (GPS), 12 L1, 12 L2 (GLONASS) (72 total) 120 channel; L1, L2 (L2C), L5 GPS; L1, L2 GLONASS; E1 / E5a / E5b / Alt-BOC Galileo; Compass; 4 SBAS 14 L1, 14 L2 (GPS), 2 SBAS, 12 L1, 12 L2 (GLONASS) (72 total) as above 14 L1, 14 L2 (GPS), 12 L1, 12 L2 (GLONASS) (72 total) 120 channel; L1, L2 (L2C), L5 GPS; L1, L2 GLONASS; E1 / E5a / E5b / Alt-BOC Galileo; Compass; 4 SBAS as above as above as above
12 26
MetOP1 MetOP1
0.7 kg 0.8 kg
na / na / na / na na / na / na / na
<100 <100
1 0.05
GMX902 GNSS
GPS: L1, L2 (L2C), L5 C / A code and CP, P-Code; GLONASS: L1,L2 C / A code and CP, P-Code; Galileo: E1,E5a / E5b Code and CP, Alt-BOC Code and CP; SBAS
48
MetOP1
0.8 kg
na / na / na / na
<100
0.05
PowerAntenna
26
AGLMNOR1
D 186 x H 90mm
1.6 kg
<100
0.05
PowerBox GS08
26 26
AGLMNOR1 AGLMNR1
2.7 kg
5m / 25cm / 10mm + 1ppm / 5mm + 0.5 ppm 2-3m / 25cm / 10mm + 1ppm / 3mm + 0.5ppm 2-3m / 25cm / 10mm + 1ppm / 3mm + 0.1ppm
<100 <100
0.05 0.2
GS12
GPS: L1, L2 (L2C), L5 C / A code and CP, P-Code; GLONASS: L1,L2 C / A code and CP, P-Code; Galileo: E1,E5a / E5b Code and CP, Alt-BOC Code and CP; SBAS
60
AGLMNR1
<100
0.2
60 60 60
2-3m / 25cm / 10mm + 1ppm / 3mm + 0.1ppm 2-3m / 25cm / 10mm + 1ppm / 3mm + 0.1ppm 2-3m / 25cm / 10mm + 1ppm / 3mm + 0.1ppm
Sapphire
66 par.
66 GNSS + 1 StarFire
DAGLMNPRTV2
2m / 45cm + ppm / 1cm + 0.5ppm / 13ns 1cm + 0.5ppm) (1PPS) as above 13ns (1PPS) 13ns (1PPS) nr nr nr nr nr nr nr nr nr nr nr nr nr
1Hz 100Hz (user programmable) 1Hz 100Hz (user programmable) 1Hz 100Hz (user programmable) 1 1 1 1 1 1 1 1 1 1 1 1 1
SF-3050M
66 par.
66 GNSS + 1 StarFire
DAGLMNPRTV1
SF-3040
66 par.
66 GNSS + 1 StarFire
DAGLMNPRTV1
8 x 4.36in
3.2lb
as above
JF2-B3: GPS-Module JF2-C1: GPS-Module JF2-C0: GPS-Module JN3-B3: GPS-Module JN3-C1: GPS-Module JN3-C0: GPS-Module J3,0000,00; GPS-Module AAA0053071-G, GPS Module AAA005202-G; GPS Module J3-ATT0-00-350.14; Antenna Module JS-3M; Antenna Module AA003041-G; GPS Module AA003049-G; Dead Reckoning GPS Module
48 48 48 48 48 48 20 20 20 20 20 20 20
L1 C / A code, SBAS L1 C / A code, SBAS L1 C / A code, SBAS L1 C / A code, SBAS L1 C / A code, SBAS L1 C / A code, SBAS L1 C / A code, SBAS L1 C / A code, SBAS L1 C / A code, SBAS L1 C / A code, SBAS L1 C / A code, SBAS L1 C / A code, SBAS L1 C / A code
48 48 48 48 48 48 20 20 20 20 20 20 20
CDHLMMetNPV2 CDHLMMetNPV2 CDHLMMetNPV2 CDHLMMetNPV2 CDHLMMetNPV2 CDHLMMetNPV2 CDHLMMetNPV2 CDHLMMetNPV2 CDHLMMetNPV2 CDHLMMetNPV2 CDHLMMetNPV2 CDHLMMetNPV2 CDHLMMetNPV2
11 x 11 x 2.2mm 11 x 11 x 2.2mm 11 x 11 x 2.2mm 11 x 11 x 2.2mm 16 x 12.2 x 2.4mm 16 x 12.2 x 2.4mm 16 x 12.2 x 2.4mm 25.4 x 25.4 x 3mm
1g 1g 1g 1g 1g 1g 1g 2g
2.5m / nr / nr / nr 2.5m / nr / nr / nr 2.5m / nr / nr / nr 2.5m / nr / nr / nr 2.5m / nr / nr / nr 2.5m / nr / nr / nr 2.5m / nr / nr / nr 2.5m / nr / nr / nr 2.5m / nr / nr / nr 2.5m / nr / nr / nr 2.5m / nr / nr / nr 2.5m / nr / nr / nr 2.5m / nr / nr / nr
17.0 x 15.0 x 2.7mm 4g 30.0 x 30.0 x 8.0mm 16g 49.0 x 41.0 x 14.1mm 40.6 x 71.1 x 11.5mm 40.6 x 71.1 x 11.5mm 96g 25g 25g
12
www.gpsworld.com
Sponsored by
Cold start 3 <35s <35s <35s <35s Warm start 4 <5s <5s <5s <5s Reacquisition No. of ports
5
Port type RS232; RS232 / RS422; USB; CAN; 1PPS; Event Marker; IRIG; Ethernet RS232; RS232 / RS422; USB; CAN; 1PPS; Event Marker; IRIG; Ethernet RS232; RS232 / RS422; USB; CAN; 1PPS; Event Marker; IRIG; Ethernet RS232; RS232 / RS422; USB; CAN; 1PPS; Event Marker; IRIG; Ethernet; Ext. Freq In / Out 1xCAN / 3xRS232 TNC
Baud rate 460.8 kbps, 460.8 kbps 480 Mbps 1 Mps 10 / 100 Mbps 460.8 kbps, 460.8 kbps 480 Mbps 1 Mps 10 / 100 Mbps 460.8 kbps, 460.8 kbps 480 Mbps 1 Mps 10 / 100 Mbps 460.8 kbps, 460.8 kbps 480 Mbps 1 Mps 10 / 100 Mbps Up to 115.2 k 100Hz
<60s 5s
<50s 5s
<20s <1 s
4 1
Internal dipole, Ext Single-enclosure GPS / IMU integrating KVHs FOG-based IMU with NovAtels OEMV GPS precision receiver AS10 / AR10 triple frequency or AR25 choke ring
Integrated 6-axis terrain compensation, proprietary RTKExtend operating mode, compatibility with space-based differential corrections network (StarFire) KVH CNS-5000 combines 2 complimentary technologies - highly accurate GPS receiver and a fiber optic gyro (FOG) based IMU within a single enclosure. CNS-5000 provides low-cost, small form factor solution for 3D positioning, velocity and attitude measurement. Triple frequency geodetic and RTK GNSS receiver
45s
35s
1s
2,400115,200
40 to + 65
ext / int
3.2
45s 45s
35s 35s
1s 1s
5 5
2,400115,200 2,400115,200
40 to + 65 40 to + 65
AR10 / AS10 triple frequency or AR25 choke ring AR10 / AS10 triple frequency or AR25 choke ring
Permanent dual frequency GPS receiver w / Ethernet Permanent triple frequency GNSS receiver w / Ethernet
45s 45s
35s 35s
1s 1s
5 7
<120s * 45s
<45s* 35s
<10s
1 2
2 power, 1 RS-232, UART, USB, TNC, Ethernet, ext osc 1(2 port) power, 2 RS-232, 2 USB, 1 Ethernet, 1 bluetooth (plus TNC, PPS, event, Oscillator) 1 LEMO-1 connector, 8 pin 2 RS-232, 2 Power, 1 TNC, 1 PPS output 2 RS-232, 2 Power, 1 TNC, 1 PPS output
2,400115,200 2,400115,200
40 to + 65 40 to + 65
AR10 / AS10 triple frequency or AR25 choke ring AR10 / AS10 triple frequency or AR25 choke ring
Permanent triple frequency GNSS receiver w / Ethernet Permanent triple frequency GNSS receiver w / Ethernet
40 to + 65 40 to + 65
ext ext
1.7 1.7
Integrated Leica AT501 microstrip Single frequency GPS smart antenna for structural antenna with built-in groundplane monitoring AR10, AS10 triple frequency or Dual frequency GNSS receiver for structural monitoring AR25 choke ring AR10, AS10 triple frequency or AR25 choke ring Triple frequency GNSS receiver for structural monitoring
45s
35s
2,400230,400
40 to + 65
ext
1.7
45s
35s
1s
2,400115,200
40 to + 65
ext / int
3.8
Internal
Dual frequency RTK GNSS receiver for site survey and machine navigation
45s 45s
35s 35s
1s 1s
5 1 Hw / 1 BT
2 RS-232, 1 Power / RS-232, 1 RS232 / RS422, 2 CAN, 1 TNC Combined (RS-232, Power, USB), 1 Bluetooth Combined (RS-232, Power, USB), 1 Bluetooth
2,400115,200 2,400115,200
40 to + 65 40 to + 65
3.8 1.8
MNA1202 GG Internal
Dual frequency RTK GNSS machine navigation receiver Dual frequency geodetic and RTK GNSS receiver
45s
35s
1s
1 Hw / 1 BT
2,400115,200
40 to + 65
ext / int
1.8
Internal
1s 1s 1s
4 4 8
<60s
<50s
<20s
<60s
<50s
<20s
2 RS-232, 1 Combined (RS232, USB), 1 Power, 1 TNC, 1 Bluetooth 1 RS-232, 1 combined (RS232, Power, USB), 1 UART &USB, 1 Bluetooth 2 RS-232, 1 Combined (RS232, USB), 1 UART &USB, 1 PPS, 2 Event, 1 Mini USB, 1 Power, 1 TNC, 1 Bluetooth 2 x RS232 (1 configurable to RS422); 1 x USB 2.0 (host or device); 1 x Ethernet (10T / 100T); 1 x Bluetooth as above
40 to + 65 40 to + 65 40 to + 65
AR10, AS10 triple frequency or AR25 choke ring Internal AR10, AS10 triple frequency or AR25 choke ring Crossed dipole (ER)
Triple frequency geodetic and RTK GNSS receiver Triple frequency geodetic and RTK GNSS receiver Triple frequency geodetic and RTK GNSS receiver
<60s
<50s
<20s
as above
<33s <33s <33s <33s <33s <33s <33s <33s <33s <33s <33s <33s <33s
<31s <31s <31s <31s <31s <31s <31s <31s <31s <31s <31s <31s <31s
<1s <1s <1s <1s <1s <1s <1s <1s <1s <1s <1s <1s <1s
4 4 4 4 4 4 2 2 2 2 1 2 2
UART, SPI, I2C UART, SPI, I2C UART, SPI, I2C UART, I2C UART, I2C UART, I2C UART UART UART UART RS232 (USB / RJ11) UART UART
RS232: 9.6kbps 115kbps; USB: up to 12Mbps; Ethernet: up to 100Mbps; Bluetooth: up to 230.4kbps RS232: 9.6kbps 115kbps; USB: up to 12Mbps; Ethernet: up to 100Mbps; Bluetooth: up to 230.4kbps RS232: 9.6kbps 115kbps; USB: up to 12Mbps; Ethernet: up to 100Mbps; Bluetooth: up to 230.4kbps 4.800 - 115.200 4.800 - 115.200 4.800 - 115.200 4.800 - 115.200 4.800 - 115.200 4.800 - 115.200 4.800 - 115.200 4.800 - 115.200 4.800 - 115.200 4.800 - 115.200 4.800 - 115.200 4.800 - 115.200 4.800 - 115.200
-40 to + 85
ext
4W typical
-40 to + 70
ext
5.6W
Integrated StarFire / RTK Extend multi-frequency receivers Integrated StarFire / RTK Extend multi-frequency receivers JF2 Flash JF2 EEPROM JF2 ROM JN3 Flash JN3 EEPROM JN3 ROM J-3 J30xLP J32xLP J3-A w. integrated Antenna , Micro Battery GPS Smart Antenna, IPX7 J31 J31DR
-40 to + 70
hot swappable batteries 1.75 to 1.9V 1.75 to 1.9V 1.75 to 1.9V 2.85 to 3.6V 2.85 to 3.6V 2.85 to 3.6V 3.0 to 3.6 V 3.0 to 3.6 V 3.0 to 3.6 V 3.0 to 3.6 V 4.75 to 5.25 V 3.2 to 3.6 V 5.0 to 6.0 V
5.6W
-40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -10 to + 60 -30 to + 85 -40 to + 85 -40 to + 85
8 mW, ATP, 1.8 V 8 mW, ATP, 1.8 V 8 mW, ATP, 1.8 V 8 mW, ATP, 3.3 V 8 mW, ATP, 3.3 V 8 mW, ATP, 3.3 V 56 mW, ATP, 3.3 V 56 mW, ATP, 3.3 V 56 mW, ATP, 3.3 V 75mW, ATP 170mW at 5V 80 mW, ATP, 3.3 V 300mW at 5V
passive / active passive / active passive / active passive / active passive / active passive / active passive / active passive / active passive / active On-Module patch On-Module patch passive / active, external passive / active
www.gpsworld.com
13
Arch. dependent, Dual frequency: L1 / E1 / B1 / L1OC or L1OF Arch. Dependent configurable plus L5 / E5A / B2 or E5B / L3OC or E6 / B3 or L2C / L2OC or L2OF Arch. dependent, L1 / E1 / B1 / L1OC, L1OF, L5 / E5A / B2, E5B / Arch. Dependent configurable L3OC, E6 / B3, L2C / L2OC, L2OF Fully configurable L1, L5, L2C, L1OF, L2OF, E1, E5A, E5B Fully configurable
Fully configurable L1 120 GPS: L1, L2, L2C, GLONASS: L1, L2 Galileo: E1 GIOVE-A / GIOVE-B (test) Compass SBAS
ACDGHLMMetNOPRSTV2 ADGHLMMetNOPRTV2
na 46 x 71 x 11mm
na 24 g
~10m / na / na 1.2m / 0.4m DGPS / 0.6m SBAS / 0.01m + 1ppm RT-2 / 5 mm + 1 ppm post processed (All values in Horiz. RMS) 1.2m / 0.4m DGPS / 0.6m SBAS / 0.6m VBS / 0.15m XP / 0.1m HP / 0.01m + 1ppm RT-2 / 5 mm + 1 ppm post processed (All values in Horiz. RMS) 1.5m / 0.5m DGPS / 0.7m SBAS /
~50 ns 20
OEM628
120
GPS: L1, L2, L2C, L5 GLONASS: L1, L2 Galileo: E1, E5 GIOVE-A / GIOVE-B (test) Compass SBAS L-band GPS: L1 GLONASS: L1 SBAS
ADGLMMetNOPRTV2
60 x 100 x 9.1mm
37 g
20
100Hz max
OEMStarTM
14
OEMV-1
36
14 channels configurable between GPS, GLONASS & SBAS 14 GPS L1 1 L-band 2 SBAS 14 GPS L1 12 GLO L1 2 SBAS
ADGLMMetNOPRTV2
46 x 71 x 13mm
18 g
20
10Hz max
ADGHLMMetNOPRTV2
46 x 71 x 13mm
21.5 g
OEMV-1G
36
ADGHLMMetNOPRTV2
46 x 71 x 13mm
21.5 g
OEMV-1DF
36
14 GPS L1 14 GPS L2 2 SBAS 14 GPS L1, 14 GPS L2, 12 GLONASS L1, 12 GLONASS L2, 2 SBAS 14 GPS L1, 14 GPS L2, 6 GPS L5, 12 GLONASS L1, 12 GLONASS L2, 2 SBAS, 1 L-band 14 channels configurable between GPS, GLONASS & SBAS 14 GPS L1 1 L-band 2 SBAS 14 GPS L1 12 GLO L1 2 SBAS 14 GPS L1, 14 GPS L2, 12 GLONASS L1, 12 GLONASS L2, 2 SBAS Flexible configuration: 120 L1, 60 L1 / L2 14 GPS L1, 14 GPS L2, 6 GPS L5, 12 GLONASS L1, 12 GLONASS L2, 2 SBAS, 1 L-band 14 GPS L1, 14 GPS L2, 6 GPS L5, 12 GLONASS L1, 12 GLONASS L2, 2 SBAS, 1 L-band 14 GPS L1, 14 GPS L2, 6 GPS L5, 12 GLONASS L1, 12 GLONASS L2, 2 SBAS, 1 L-band 60 L1 / L2
ADGHLMMetNOPRTV2
46 x 71 x 13mm
21.5 g
OEMV-2
72
ADGLMMetNOPRTV2
60 x 100 x 13mm
56 g
OEMV-3
72
ADGLMMetNOPRTV2
85 x 125 x 13mm
75 g
FlexPak-G2-StarTM
14
ADGLMMetNOPRTV12
45 x 147 x 113mm
313 g
1.5m / 0.4m DGPS / 0.6m SBAS / 0.6m VBS / 0.20m RT-20 / 5mm + 1 ppm post processed (All values in Horiz. RMS) 1.5m / 0.4m DGPS / 0.6m SBAS / 0.2m RT-20 / 0.02m + 1ppm RT-2 L1TE / 5mm + 1 ppm post processed (All values in Horiz. RMS) 1.2m / 0.4m DGPS / 0.6m SBAS / 0.01m + 1ppm RT-2 / 5 mm + 1 ppm post processed (All values in Horiz. RMS) 1.2m / 0.4m DGPS / 0.6m SBAS / 0.01m + 1ppm RT-2 / 5 mm + 1 ppm post processed (All values in Horiz. RMS) 1.2m / 0.4m DGPS / 0.6m SBAS / 0.6m VBS / 0.15m XP / 0.1m HP / 0.01m + 1ppm RT-2 / 5 mm + 1 ppm post processed (All values in Horiz. RMS) See OEMStar model
20
50Hz max
20
50Hz max
20
50Hz max
20
50Hz max
20
50Hz max
20
10Hz max
36 36 72
GPS: L1 SBAS L-band GPS: L1 GLONASS: L1 SBAS GPS: L1, L2, L2C GLONASS: L1, L2 SBAS
20 20 20
FlexPak6
120
GPS: L1, L2, L2C, L5 GLONASS: L1, L2 Galileo: E1, E5 GIOVE-A / GIOVE-B (test) Compass SBAS L-band GPS: L1, L2, L2C, L5 GLONASS: L1, L2 SBAS L-band
ADGLMMetNOPRTV12
45 x 147 x 113mm
337 g
20
100Hz max
ProPak-V3
72
ADGLMMetNOPRTV12
1.0 kg
20
50Hz max
DL-V3
72
ADGLMMetNOPRTV12
1.3 kg
20
50Hz max
SE
72
ADGLMMetNOPRTV12
3.4 kg
20
20Hz max
GPStation-6
120
GPS: L1, L2, L2C, L5 GLONASS: L1, L2 Galileo: E1, E5 GIOVE-A / GIOVE-B (test) Compass SBAS GPS: L1 GLONASS: L1 SBAS
ALMetOT12
1.4 kg
1.2m
20
50Hz max
SMART-AG
36
ADGLMMetNOPRTV12
500 g
SMART-V1
36
ADGLMMetNOPRTV12
575 g
1.2m / 0.4m DGPS / 0.8m SBAS / 0.2m RT-20 / 0.02m + 1ppm RT-2 L1TE / 5mm + 1 ppm post processed (All values in Horiz. RMS) See OEMV-1 model
20
20Hz max
20
20Hz max
SMART-V1G
36
ADGLMMetNOPRTV12
575 g
20
20Hz max
SMART-MR10
72
SMART-MR15
72
14 GPS L1, 14 GPS L2, ADGLMMetNOPRTV12 12 GLONASS L1, 12 GLONASS L2, 2 SBAS, 1 L-band 14 GPS L1, 14 GPS L2, ADGLMMetNOPRTV12 12 GLONASS L1, 12 GLONASS L2, 2 SBAS, 1 L-band 14 GPS L1, 14 GPS ADGLMMetNOPRTV12 L2, 6 GPS L5, 12 GLONASS L1, 12 GLONASS L2, 2 SBAS, 1 L-band 14 GPS L1, 14 GPS ADGLMMetNOPRTV12 L2, 6 GPS L5, 12 GLONASS L1, 12 GLONASS L2, 2 SBAS, 1 L-band
1.9 kg
20
20Hz max
2.1 kg
20
20Hz max
SPAN-CPT
72
2.36 kg
20
20Hz max GNSS only, 100Hz max GNSS + INS 20Hz max GNSS only, 200Hz max GNSS + INS
SPAN-SE
72 max
3.4 kg
20
14
www.gpsworld.com
Sponsored by
Cold start 3 15mn mx 15mn mx 0 <40s <40s <40s Warm start 4 <20s <20s 0 <35s <35s <35s Reacquisition No. of ports
5
Port type RS-232, 10 / 100 Base-T RS-232, 10 / 100 Base-T Customizable IP, USB IP, USB, LVDS Fully configurable
Power consumption (Watts) 240W(2A@120V nr 17 mJ per fix Arch. dependent Arch. dependent na
<40s 50s
<35s 35s
<2s 0.5s
Fully configurable 6
na 3.3 V DC
na 1W (typical)
na Active (E)
50s
35s
0.5s
300 to 921,600 bps; 300 to 921,600 bps; 1 Mbps; 12 Mbps; 10 / 100 Mbps 300 to 230,400 bps; 12 Mbps
-40 to + 85
3.3 V DC
1.3W (typical)
Active (E)
RoHS-compliant; RT-20, RT-2, OmniSTAR VBS / HP / XP, GL1DE, PDP, RAIM, and ALIGN software features available for this model. Raw measurements please refer to Note 2 below. RoHS-compliant; GL1DE and PDP software features available for this model. Raw measurements please refer to Note 4 below. RoHS-compliant; RT-20, OmniSTAR VBS, and GL1DE software features available for this model. Raw measurements please refer to Note 5 below. RoHS-compliant; RT-20, RT-2 L1TE, GL1DE, and ALIGN software features available for this model. Raw measurements please refer to Note 6 below. RoHS-compliant; RT-20, RT-2, GL1DE, PDP, ALIGN, and SPAN software features available for this model. Raw measurements please refer to Note 7 below. RoHS-compliant; RT-20, RT-2, GL1DE, PDP, ALIGN , and SPAN software features available for this model. Raw measurements please refer to Note 3 below. RoHS-compliant; RT-20, RT-2, OmniSTAR VBS / HP / XP, GL1DE, PDP, ALIGN, and SPAN software features available for this model. Raw measurements please refer to Note 3 below. RoHS-compliant; GL1DE and PDP software features available for this model. Raw measurements please refer to Note 4 below. RoHS-compliant; RT-20, OmniSTAR VBS, and GL1DE software features available for this model. Raw measurements please refer to Note 5 below. RoHS-compliant; RT-20, RT-2 L1TE, GL1DE, and ALIGN software features available for this model. Raw measurements please refer to Note 6 below. RoHS-compliant; RT-20, RT-2, GL1DE, PDP, and ALIGN software features available for this model. Raw measurements please refer to Note 3 below. RoHS-compliant; RT-20, RT-2, OmniSTAR VBS / HP / XP, GL1DE, PDP, and ALIGN software features available for this model. Raw measurements please refer to Note 2 below. RoHS-compliant; RT-20, RT-2, OmniSTAR VBS / HP / XP, GL1DE, PDP, ALIGN, and SPAN software features available for this model. Raw measurements please refer to Note 3 below. RoHS-compliant; RT-20, RT-2, OmniSTAR VBS / HP / XP, GL1DE, PDP, and ALIGN software features available for this model. Raw measurements please refer to Note 3 below. RoHS-compliant; RT-20, RT-2, OmniSTAR VBS / HP / XP, GL1DE, PDP, and ALIGN software features available for this model. Raw measurements please refer to Note 3 below. Multi-frequency multi-constellation GNSS Ionospheric Scintillation and TEC Monitor (GISTM) receiver. Provides 50Hz phase and amplitude scintillation measurements (S4, ), TEC and TEC phase. Raw measurements please refer to Note 2 below. RoHS-compliant; RT-20, RT-2 L1TE, GL1DE, and ALIGN software features available for this model. Raw measurement accruacy: 18cm GPS L1C / A / 18cm GLONASS L1C / A / 1.5mm GPS L1 Carrier Phase / 1.5mm GLONASS L1 Carrier Phase RoHS-compliant; RT-20, OmniSTAR VBS, and GL1DE software features available for this model. Raw measurement accruacy: 18cm GPS L1C / A / 1.5mm GPS L1 Carrier Phase RoHS-compliant; RT-20, RT-2 L1TE, GL1DE, and ALIGN software features available for this model. Raw measurement accruacy: 18cm GPS L1C / A / 18cm GLONASS L1C / A / 1.5mm GPS L1 Carrier Phase / 1.5mm GLONASS L1 Carrier Phase RoHS-compliant; RT-20, RT-2, OmniSTAR VBS / HP / XP, GL1DE, PDP, and ALIGN software features available for this model. Raw measurements please refer to Note 3 below. RoHS-compliant; RT-20, RT-2, OmniSTAR VBS / HP / XP, GL1DE, PDP, and ALIGN software features available for this model. Raw measurements please refer to Note 3 below. RoHS-compliant; RT-20, RT-2, OmniSTAR VBS / HP / XP, GL1DE, PDP, ALIGN and SPAN software features available for this model. Raw measurements please refer to Note 3 below. RoHS-compliant; RT-20, RT-2, OmniSTAR VBS / HP / XP, GL1DE, PDP, ALIGN and SPAN software features available for this model. Raw measurements please refer to Note 3 below.
65s
35s
<1.0s
-40 to + 85)
3.15 to 5.25 VDC 0.36W GPS 0.45W GLONASS 3.3 V DC 1.0W (typical)
Active (E)
60s
35s
0.5s
300 to 921,600 bps; 300 to 230,400 bps; 1 Mbps; 5 Mbps 300 to 921,600 bps; 300 to 230,400 bps; 1 Mbps; 5 Mbps
-40 to + 85
Active (E)
60s
35s
0.5s
-40 to + 85
3.3 V DC
1.0W (typical)
Active (E)
60s
35s
0.5s
1 x LV-TTL;2 x LV-TTL; 2 x CAN; 1 x USB1.1 1 x RS-232 or RS-422, 2 x LVTTL, 1 x CAN, 1 x USB1.1 1 x RS-232 or RS-422; 1 x RS-232 or LV-TTL; 1 x LV-TTL; 2 x CAN, 1 x USB1.1 1 x RS-232; 1 x RS-232 or RS-422, 1 x USB1.1 1 x RS-232; 1 x RS-232 or RS-422, 1 x USB1.1 1 x RS-232; 1 x RS-232 or RS-422, 1 x USB1.1 1 x RS-232; 1 x RS-232 or RS-422, 1 x USB1.1 1 x RS-232, 1 x RS-232 or RS-422, 1 x USB2.0, 1 x CAN, 1 x Ethernet 3 x RS-232 or 2 x RS-422 plus 1 x RS-232; 1 x USB1.1
300 to 921,600 bps; 300 to 230,400 bps; 1 Mbps; 5 Mbps 300 to 921,600 bps; 300 to 230,400 bps; 1 Mbps; 5 Mbps 300 to 921,600 bps; 300 to 921,600 bps; 300 to 230,400 bps; 1 Mbps; 5 Mbps 300 to 921,600 bps; 300 to 230,400 bps; 12 Mbps 300 to 921,600 bps; 300 to 230,400 bps; 12 Mbps 300 to 921,600 bps; 300 to 230,400 bps; 12 Mbps 300 to 921,600 bps; 300 to 230,400 bps; 12 Mbps 300 to 921,600 bps; 300 to 921,600 bps; 12 Mbps; 1 Mbps; 10 / 100 Mbps 300 to 921,600 bps; 300 to 230,400 bps; 300 to 230,400 bps; 5 Mbps 300 to 921,600 bps; 300 to 230,400 bps; 300 to 230,400 bps; 5 Mbps, 10 / 100 Mbps 300 to 921,600 bps; USB-A; USB-B; RJ-45
-40 to + 85
3.3 V DC
1.1W (typical)
Active (E)
60s
35s
0.5s
-40 to + 85
3.3 V DC
1.2 W (typical)
Active (E)
60s
35s
0.5s
-40 to + 85
4.5 to 18 VDC
2.1W (typical)
Active (E)
65s
35s
<1.0s
-40 to + 85)
6 to 18 V DC
0.6W (typical)
Active (E)
3 3 3
6 to 18 V DC 6 to 18 V DC 6 to 18 V DC
50s
35s
0.5s
-40 to + 75
6 to 36 V DC
1.8W (typical)
Active (E)
60s
35s
0.5s
-40 to + 75
6 to 18 V DC 9 to 18 V DC (SPAN) 9 to 28 V DC
2.8 W typical
Active (E)
60s
35s
0.5s
3 x RS-232 or 2 x RS-422 plus 1 x RS-232; USB1.1, Ethernet, Bluetooth, Compact Flash card drive 4 x RS-232 or RS-422; 1 x UART COM Port; 1 x USB 2.0 Host; 1 x USB 2.0 Device; 1 x Ethernet; 1 x SD card drive; 1 x IMU Connection 3 x RS-232 or RS-422, 1 x USB2.0
-40 to + 75
3.5 W typical
Active (E)
60s
35s
0.5s
10
-40 to + 65
9 to 28 VDC
10W (typical)
60s
35s
0.5s
-40 to + 65
4.5 to 18 V DC
6W (typical)
Active (E)
60s
35s
0.5s
-40 to + 75
8 to 36 V DC
2.5W (typical)
Patch
60s
35s
0.5s
2 x RS-232 or RS-422; 1 x CAN 300 to 921,600 bps; 1 Mbps; or USB1.1 5 Mbps 2 x RS-232 or RS-422; 1 x USB1.1 300 to 921,600 bps; 5 Mbps
-40 to + 75
9 to 28 VDC
1.8W (typical)
Patch
60s
35s
0.5s
-40 to + 75
9 to 28 VDC
1.8W (typical)
Patch
65s
35s
0.5s
-40 to + 70
9 to 36 VDC
3.7W (typical)
Pinwheel
65s
35s
0.5s
60s
35s
0.5s
1 x RS-232 or RS-422; 1 x 300 to 230,400 bps; 1 Mbps; RS-232; 1 x CAN NMEA2000; 1 x Bluetooth; 1 x Ground speed output, 1 x GPRS / HSDPA or CDMA radio 2 x RS-232 UART COM Port; 1 300 to 921,600 bps; 1 Mbps; x CAN; 1 x USB1.1 5 Mbps
-40 to + 65
9 to 36 VDC
4.5W (typical)
Pinwheel
-40 to + 65
9 to 18 VDC
15W (max)
Active (E)
60s
35s
0.5s
10
4 x RS-232 or RS-422; 1 x UART COM Port; 1 x USB 2.0 Host; 1 x USB 2.0 Device; 1 x Ethernet; 1 x SD card drive; 1 x IMU Connection
-40 to + 65
9 to 28 VDC
10W (typical)
www.gpsworld.com
15
NV08C-CSM
32 par., Allin-view
GPS L1 C / A code, GLONASS L1, SBAS L1, GALILEO E1, COMPASS (Beidou) L1
32
A, C, G, H, L, M, N, R, T, V, 2 20 x 26 x 2.5mm
5g
RMS:<2.5m / <1m / na
15 ns
1, 2, 5, 10Hz
GS-101
GPS L1 C / A code
12
1 lb
<100ns
1 second
* GPS L1 frequency, C / A Code or 1 PPS (LVCMOS) GPS L1 frequency, C / A Code or 1 PPS (LVCMOS) GPS L1 frequency, C / A Code GPS L1 frequency, C / A Code and / or GLONASS L1-range (1592-1610 MHz), CTcode or 1 PPS (LVCMOS) GPS L1 frequency, C / A Code GLONASS L1-range (1592-1610 MHz), CT-code or 1PPS / 5MHz / 10MHz / 2.048MHz / E1
16 16 12 24 24
135 x 23.8 x 60mm 135 x 20.4 or 17.9 x 60mm 482.6 x 44.5 x 220mm or 482.6 x 44.5 x 245mm 135 x 14.3 to 25 x 96mm 482.6 x 44.5 x 220mm (19x1.75x8.7) or 482.6 x 44.5 x 245mm (19x1.75x9.7) 482.6 x 44.5 x 220mm (19x1.75x8.7) or 482.6 x 44.5 x 245mm (19x1.75x9.7) 482.6 x 44.5 x 250mm or 482.6 x 44.5 x 245mm (19x1.75x9.7) 482.6 x 44.5 x 250mm or 482.6 x 44.5 x 245mm (19x1.75x9.7) 19 x 1.75 x 12in 19 x 3.5 x 12in 19 x 1.75 x 12in
< 300gr (<0.661lbs) < 300gr (<0.661lbs) < 2kg (< 4.40lbs) < 300gr (<0.661lbs) < 2kg (< 4.40lbs)
na na na na na
na na na na na
16-channel
GPS L1 frequency, C / A Code GLONASS L1-range (1592-1610 MHz), CT-code or 1PPS / 5MHz / 10MHz / 2.048MHz / E1
24
T1
100ns
na
GPS L1 frequency, C / A Code or 1PPS / NMEA 12 / 10MHz / 2.048MHz GPS L1 frequency, C / A Code GLONASS L1-range (1592-1610 MHz), CT-code or 1PPS / NMEA / 10MHz / 2.048MHz / E1 / DS1 L1, C / A L1, C / A L1, C / A 12
T1
< 2kg (< 4.40lbs) < 2kg (< 4.40lbs) <10 lb <10 lb <10 lb
na
100ns
na
T1
na
100ns
na
12 12 12
12 12 12
20 20 60
1 1 1
3203A SAASM 3203A WiMax 3223A NetTyme 3225A NetTyme 3207A GlobalTyme 3208A GlobalTyme Racelogic www.labsat.co.uk LabSat RLLSR01 LabSat RLLSR02-GNL1 Raytheon www.raytheon.com Anti-jam GPS Receiver (AGR) Miniature Airborne GPS Receiver MAGR 2000 RAPToR Common Weapon Navigator Digital Anti-jam Receiver (DAR) MPES, Miniature Precision Lightweight GPS Receiver (PLGR) Engine (SAASM) MPES, Miniature Precision Lightweight GPS Receiver (PLGR) Engine (SAASM) Type II Polaris Link, miniature GPS receiver engine (SPS) NavStorm + , Integrated GPS-AJ System w / Digital Nulling, Gun Hard, SAASM-Based NavStrike-24Munitions GPS Embedded Module, SAASM-Based IGAS, Integrated GPS-AJ System w / Digital Nulling and Beam-forming, SAASM-Based DAGR (Defense Adv. GPS Receiver) SAASM-Based
12 12 12
12 12 12 12 12 + 12(opt) 12 + 12(opt) All in View All in View 8 All in View All in View All in View 12 12
LOT1 LOT1 LOT1 LOT1 LOT1 LOT1 ACDGHLMNOTV1 ACDGHLMNOTV1 DO1 AD1 DHLMNOPV2 ADO1 ADLMNTV2 ADLMNTV2
19 x 1.75 x 12in 19 x 1.75 x 12in 19 x 1.75 x 12in 7 x 1.75 x 9in 19 x 1.75 x 12in 19 x 3.5 x 12in 17.0 x 12.8 x 3.8cm 17.0 x 12.3 x 4.6cm 6.5 x 2.2 x 9.0in
<25 m / nr / nr / nr <25 m / nr / nr / nr <25 m / nr / nr / nr <25 m / nr / nr / nr <25 m / nr / nr / nr <25 m / nr / nr / nr 1.5 m / na / na 1.5 m / na / na <16 m / na / na / na <16 m / na / na / na <16 m / na / na / na <16 m / na / na / na <4 m CEP (WAGE), <2 m (SDGPS) <4 m CEP (WAGE), <2 m (SDGPS)
12 L1, C / A 12 + 12(optional) L1, C / A 12 + 12(optional) L1, C / A All in View All in View 24 / Continuous 24 / Continuous 24 / Continuous 24 / Continuous 12 channels parallel, dual frequency 12 channels parallel, dual frequency 12 channels l 12 / 24 par. GPS L1 C / A Code GPS L1 C / A Code & GLONASS L1 C / A, P / (Y) C / A, P / (Y) C / A, P / (Y) C / A, P / (Y) L1, C / A and P or Y Code L2, P or Y Code L1, C / A and P or Y Code L2, P or Y Code
3.21 x 6.78 x 12.82in 11.0 lb 3.45 x 0.59 x 3.45in 8.6 2.27 13.0in 2.45 x 0.6 x 3.4in 100 g 11.0 lb 2.5 oz
12 all in view
ADLMNTV2 ADLNO2
2.5 oz <0.5 lb
<100 30
1 125 dependent on aiding 125 dependent on aiding 125 dependent on aiding 1 1 1 125 dependent on aiding
12 / 24 par. 24 par.
as above as above
ADNS2 ADNS2
<0.5 lb <2 lb
na / 3.7 m / nr na / 2 m typ. / nr
30 30
Micro DAGR (Defense Adv. GPS Receiver) SAASM Based Polaris Guide handheld GPS 12 Channel receiver (SPS) GPS Embedded Module (GEM) Genius 1 MINI Genius 1MAXI Genius USB AsteRx-m OEM AiRx2 AsteRx3 OEM 12 / 24 12 par. 12 par. 12 par. 136 par. 64 par 136 par.
as above L1, C / A and P or Y code L1, C / A L1, C / A, P or Y code, L2, Pcode or Ycode L1 only, C / Acode L1 only, C / Acode L1 only, C / Acode GPS + GLONASS L1, C / A and P-code & CP; L2, P-code & CP; WAAS / EGNOS GPS L1; (GPS L5 and GAL L1-E5a ready) GPS L1, C / A L2, P-code & CP; L2C; L5 code & CP, GALILEO L1 code & CP; E5abAltBOC code & CP; GLONASS L1L2L2CA, P-Code; COMPASS, QZSS, WAAS / EGNOS as above GPS + GLONASS L1, C / A and P-code & CP; L2, P-code & CP; WAAS / EGNOS
all in view all in view all in view all in view 12 12 12 All in view (GPS / GLONASS) All in view GPS (GAL ready) All in View GPS + GLONASS + GALILEO as above 14
6.4 x 3.5 x 1.6in, 25cu in 3.9 x 2.6 x 1.4in 6.4 x 3.5 x 1.6in, 25cu in 5.88 x 5.7 x 0.57 75 x 75 x 1mm 132 x 132 x 22mm 75 x 75 x 18mm 70x48mm 61 x 100 x 13.5 mm 60 x 90mm
15 oz. with batteries 6.5 oz with L91 batteries 15 oz. w / batteries <0.8 lb 100 g 300 g 100 g 40g <100gr 60 gr
<5.1m Horiz 95% (WAGE), <2.4m Horiz 95% (DGPS) <18.1m Horiz 95% <2.4m Horiz 95% (DGPS) na / 2 m typ. / nr <6m CEP / nr / nr / nr <6m CEP / nr / nr / nr <6 m CEP / nr / nr / nr 1.5 m (1s) / 0.6 m (1s) / 1 cm + 1 ppm / 5 mm + 1 ppm 5m (95%) / 3m (95%) 1.5 m (1s) / 0.6 m (1s) / 1 cm + 1 ppm / 5 mm + 1 ppm 1.5 m (1s) / 0.6 m (1s) / 1 cm + 1 ppm / 5 mm + 1 ppm 1.3 m (1s) / 0.6 m (1s) / 1 cm + 1 ppm / 5 mm + 1 ppm / 0.3-0.6 / m
ADGLMMetNOPRTV1 ADGLMMetNOPRTV2
510 gr 90 gr
10 10
25Hz 20Hz
16
www.gpsworld.com
Sponsored by
Cold start 3 30s Warm start 4 30s Reacquisition No. of ports
5
<1s
150mW (GNSS) / 100mW Active & Passive (auto-switching (GPS) / 20mW (GNSS) current detector) / 16mW (GPS) / 5mW (Sleep mode) 180mW (GNSS) / 120mW Active (GPS) / 24mW (GNSS) / 18mW (GPS) / 5mW (Sleep mode) 30 mw active
30s
30s
<1s
-40 to + 85 C
ext.
Fleet mgmt, Telematics & anti-theft, in-car & PNDs, asset and personal tracking, surveillance & security / LTE, WiMAX, Wi-Fi & cell. base station timimg / A-GNSS, dead reckning, raw data output / Flash memory + power mgmt Small portable GPS Receiver providing IRIG time, pulse rates, event capture and position over serial and USB ports. Can be portable with optional battery. Holdover PPS of 10 s up to 24h. Outputs: 1x 1PPS; 1x 10MHz sine; 1x 10MHz TTL; 1x NMEA0183 Holdover PPS of 10 s up to 8h Outputs: as above Holdover PPS of 10 s up to 24h Outputs: 4x 1PPS; 4x 10MHz sine; 1x NMEA0183 Holdover PPS of 10 s up to 24h Outputs: 4x 1PPS; 4x 10MHz sine; 1x 10MHz TTL; 1x NMEA0183 Holdover PPS of 10 s up to 24h Outputs: 4x 1PPS; 4x 10MHz; 1x E1; 1x 2.048MHz; 1x NMEA0183
<20min
<1min
<1s
2 serial / 1 USB
0 to 50
external
1s 1s 2s 2s 2s
1 1 1 1 1
-20 to 65C -30 to 85C on request -20 to 65C -30 to 85C on request -5 to + 55C -5 to + 55C -30 to 85C on request -5 to + 55C
power-up 12W steadystate 6W power-up 12W steadystate 6W power-up 12W steadystate 8W power-up 12W steadystate 6W power-up 12W steadystate 8W
Active Antenna Active Antenna Active Antenna Active Antenna Active Antenna
90s
2s
9600
-5 to + 55C
Active Antenna
32s
32s
1s
RS-233 / TCP / P
-5 to 45C
48VDC or 60 to 240 VAC 48VDC or 60 to 240 VAC Internal 90264 AC Internal 90264 AC Internal 90264 AC Internal 20 - 70VDC (optional) Internal 90264 AC Internal 90264 AC 20 - 70VDC (optional) Internal 90264 AC 15V DC Internal 90264 AC Internal 90264 AC 8V to 30V DC 8V to 30V DC 28 V DC 115 V / 400Hz 3.3 V DC 115 V ac, 28 or 270 V dc ext ext
power-up 20W steadystate 12W power-up 20W steadystate 12W <10 <10 <10
Active Antenna
Holdover PPS of 10 s up to 24h Outputs: 1x IEEE 1588 v2; 1x 1PPS; 1x 10MHz; 1x 2.048MHz; 1x NMEA0183 Holdover PPS of 10 s up to 24h Outputs: 2x IEEE 1588 v2; 1x 1PPS; 1x 10MHz; 1x E1; 2x 2.048MHz / E1 / DS1; 1x NMEA0183 Multiple frequency outputs, IRIG B, Low phase noise as above Multiple frequency outputs, IRIG B, Low phase noise
90s
2s
RS-233 / TCP / P
-5 to 45C
Active Antenna
1s 1s 1s
2 2 2
0 to + 50 0 to + 50 0 to + 50
<20min <20min <20min <20min <20min <20min na na nr <6min nr nr <100s typical <100s typical
<5min <5min <5min <5min <5min <5min na na 150s 24s 60s nr <60s typical <60s typical
5s 1s 1s 1s 1s 1s na na 20s 1s 10s nr <8s for <10s typical <8s for <10s typical
RS-232, 100baseT RS-232, 100baseT RS-232, 100baseT RS-232, 100baseT RS-232, 100baseT RS-232, 100baseT 2 x SMA , 1 x USB 3 x SMA , 2 x USB nr 1553 / RS-232 / RS-422 / ARINC429 RS-232 / RS-422 / CMOS 1553 / RS-232 / RS-422 / ARINC429 RS-232, CMOS, Crypto (DS-101 and DS-102), HVQK, 1PPS, NMEA, ant. RS-232, CMOS, Crypto (DS-101 and DS-102), HVQK, 1PPS, NMEA, ant. RS-232, CMOS, HVQK, 1PPS, NMEA, ant. DS-101, 1PPS, 10PPS input, antenna(s) RS-422, RS-232, DS-102, DS101, HVQK, 1PPs, antenna RS-422, DS-102, DS-101, HVQK, 1PPs, antenna (4) RS-232, RS-422; radio, crypto, HVQK, 1 PPS, 10 PPS, SINCGARS, ant. RS-232, keyfill, external power RS-232, RS-422; radio, HVQK, 1 PPS, 10 PPS, SINCGARS, ant. RS-232, RS-422, DS-102, DS-101, HVQK, 1PPs RS-232, TTL RS-232 or TTL USB Virtual Serial Port RS232, USB, event marker, PPS out RS232 or RS422 (ARINC ready) RS232, Ethernet, USB, event marker, PPS out as above RS-232, Ethernet, USB, event marker, PPS out, Ref in / out
0 to + 50 0 to + 50 0 to + 50 0 to + 50 0 to + 50 0 to + 50 0 to + 50 0 to + 50 55 to 71 54 to 85
<10 <10 <10 <10 <10 <10 5.8W (Max) 7.0W (Max) 28 W 24 W
35 dBi, 5 V DC 35 dBi, 5 V DC 35 dBi, 5 V DC 35 dBi, 5 V DC 35 dBi, 5 V DC 35 dBi, 5 V DC Active Active 5 element L1 / L2 CRPA L1 / L2 FRPA or CRPA
Multiple frequency outputs, IRIG B, Low phase noise 3x10MHz sine (low phase noise) + 3 x 1PPS TTL outputs, 1PPS, IRIG B, NTP 1PPS, NTP Multiple frequency outputs, IRIG B, Low phase noise, Multiple input options, dual receiver engines (optional) as above RF Record and Replay for GPS L1 C / A Code RF Record and Replay for GPS L1 & GLONASS L1 Tomahawk Block IV Anti-Jam Receiver Standard GPSW aircraft receiver LRU Multiple Raytheon Missile System applications High Anti-Jam aircraft receiver system U.S. Army standard; GB-GRAM; backward compatible U.S. Army standard; GB-GRAM; backward compatible
32 to 70 nr 40 to + 85 40 to + 85
<4.5 W max,<1 W nominal L1 / L2 <80 W 0.7 W operating, 4 mW keepalive 0.7 W operating, 4 mW keepalive 0.7 W operating, 4 mW keepalive <2W L1 / L2 CRPA active remote (E) active remote (E)
nr nr
Variable 9,600230,400
40 to + 85 54 to + 85
ext ext
SPS version of MPE-S / GB-GRAM; backward compatible 2-card GPS-AJ system with 2-element digital nulling; 20k-Gee hardened, Deep Integration capable Updated NavStrike GPS receiver using same form-factor, interfaces 2-card integrated GPS-AJ system with 4-element RF interface SAASM-based, small, light-weight, portable 12-channel all-in-view SAASM-based, small, light-weight, portable 12-channel allin-view, with commercial style graphical user interface Small, light-weight, portable 12-channel all-in-view GPS receiver GRAM-S (SEM-E) module
<60s <60s
<8s <8s
<15s <15s
nr nr
9,600230,400 9,600230,400
54 to + 85 54 to + 85
ext ext
<100s Unverified as of this date <100s <60s 50s typ. 50s typ. 50s typ. <45s <75s <45s
<70s <25s <70s <10s 35s 35s 35s <15s (after reset)
<15s for <15min Unverified as of this date <15s for <15min <15s 8s 8s 8s <1s <3s
3 1 3 nr 1, 2, 1, 2 1 3,1,1,1 4 4,1, 1, 2, 1
Variable Variable Variable Variable 2,400115,200 2,400115,200 2,40038,400 300230,400; 19.2 kbps - 115.2 kbps 300230,400; 1-2 Mbps
ext 932 V < 0.7 W tracking, < 1.5 W DC / intl 4 AA acquisition batteries Intl 2 AA batteries Unverified as of this date ext 932 V DC / intl 4 AA batteries ext external external USB 3.3V DC 3 - 5.5 VDC 35.5 V DC < 0.7 W tracking, < 1.5 W acquisition <3 W 0.4 W @ 12 V dc 0.4 W @ 12 V dc 0.4 W @ 12 V dc 500mW 3W max 2.5W typ
active integral or active remote (E) integral active integral or active remote (E) active or passive Int. low noise passive Int. / Ext. Active Int. low noise passive (E) (E) (E)
Compact low-power dual frequency GPS / GLONASS OEM receiver FAA TSO certifiable aviation receiver (BETA-3) Tripple frequency high accuracy GPS / GLONASS / GALILEO OEM receiver . Tripple frequency high accuracy GPS / GLONASS / GALILEO receiver in a versatile waterproof high-impact plastic housing. Single-board, dual-antenna / heading GPS / GLONASS / SBAS receiver board
<1s
<45s <45s
<1s <1s
3, 1,1, 2, 1 4, 1,1, 2, 1, 2
-40 to + 60 40 to + 85
930 V DC 5 V DC
3W typ 4W typ
(E) (E)
www.gpsworld.com
17
GPS + GLONASS L1, C / A & CP; L2, P-code & as above CP; L2C; WAAS / EGNOS as above as above GPS L1, C / A L2, P-code & CP; L2C; L5 code & CP, GALILEO L1 code & CP; E5a code & CP; WAAS / EGNOS; GLONASS L1 L2 L2 CA, P, COMPASS, QZSS GPS L1, C / A L2, P-code & CP; L2C; L5 code & CP, GALILEO L1 code & CP; E5a code & CP; WAAS / EGNOS; GLONASS L1 L2 L2 CA, P, COMPASS, QZSS GPS L1, C / A L2, P-code & CP; L2C; L5 code & CP, GALILEO L1 code & CP; E5abAltBOC code & CP; WAAS / EGNOS, COMPASS, QZSS L1, C / A and P-code & CP; L2, P-code & CP; WAAS / EGNOS as above L1 GPS, SBAS L1 GPS, SBAS L1 GPS, SBAS L1 GPS, SBAS L1 GLONASS / GPS, SBAS L1 GLONASS / GPS, SBAS GPS: L1 C / A, L2C, L2 P(Y); GLONASS: L1 / L2 code and carrier SBAS GPS L1 C / A Glonass L1 C / A SBAS GPS L1 C / A L1 / L2 P-code, L2C Glonass L1 C / A GPS L1C / A, L2C, L2P, L5 GLONASS L1C / A, L1P, L2C / A, L2P SBAS L1C / A, L5 Galileo GIOVE-A and GIOVE-B GPS L1 C / A L1 / L2 P-code, L2 C, L5, L1 / L2 / L5 full wavelength carrier GLONASS L1 C / A and L2 C / A, L1 / L2 full wavelength carrier GALILEO E1 and E5 (including GIOVE-A / GIOVE-B test satellites) SBAS code and carrier GPS L1 C / A L1 / L2 P-code, L2 C, L1 / L2 full wavelength carrier GLONASS L1 C / A, L2 C / A and L2 P-code, L1 / L2 full wavelength carrier SBAS code & carrier L1, C / A-code L1, C / A-code L1, C / A-code L1, C / A-code L1, C / A-code L1, C / A-code L1, C / A-code L1, C / A-code L1, C / A-code L1, C / A-code GPS & GLONASS, C / A, L1, WAAS / EGNOS GPS & GLONASS, C / A, L1 GPS, Gallileo, GLONASS, C / A, L1 GPS & GLONASS, C / A, L1 GPS / Galileo (L1), SBAS GPS / Galileio (L1), SBAS GPS (L1), SBAS GPS (L1), SBAS GPS / Galileio / Glonass QZSS (L1), SBAS GPS / Galileio / Glonass QZSS (L1), SBAS L1 L1 GPS L1 C / A GPS L1 C / A GPS L1 C / A GPS L1 C / A GPS L1 C / A GPS L1 C / A GPS L1 C / A, L2C L1 only, C / A-code L1 only, C / A-code L1 only, C / A-code L1 only, C / A-code L1 only, C / A-code L1 only, C / A-code L1 / L2 L1 only, C / A-code L1 only, C / A-code L1 / L2 All in View
PolaRx4TR PRO
264 par.
as above
DGLMetOPRTV1
980 gr
10
50Hz
PolaRxS PRO
136 par.
All in View GPS + GLO + GALILEO 9 + 1 SBAS; 16; 12 9 + 1 SBAS; 16; 12 12 12 12 12 24 24 36 All-in-view All-in-view 44 All-in-view
DGLMetOPRTV1
300 x 140 x 37 mm
980 gr
10
100Hz
PolaRx2e@ OEM PolaRx2e@ PRO SkyTraq Technology, Inc. www.skytraq.com.tw Venus628LP Venus638LPx Venus638FLPx S2525DR S1722G2F S2532G2DR GRX1 ProMark 100 ProMark 200 Epoch 50 ProMark 800
48 par. 48 par. 65 65 65 65 88 88 72 Universal Tracking Channels 45 par. 45 par. 220 120 par.
ADGLMMetNOPRTV2 ADGLMMetNOPRTV1 ACHLMNTV2 ACHLMNTV2 ACHLMNTV2 ACHLMNTV2 ACHLMNTV2 ACHLMNTV2 GL1 HGLN1 HGLN1 GHLPR1 GL1
160 x 100mm (Eurocard) 280 x 140 x 37mm 7 x 7 x 0.75 mm 10 x 10 x 1.3 mm 10 x 10 x 1.3 mm 25 x 25 x 2.3 mm 17 x 22 x 2.3 mm 25 x 32 x 2.3 mm 184 () x 95 mm 9.0 x 19.0 x 4.3 cm 9.0 x 19.0 x 4.3 cm 19.0 x 10.7 x 20.0 cm
10Hz 10Hz 1/2/4/5/8/ 10 / 20Hz 1/2/4/5/8/ 10 / 20Hz 1/2/4/5/8/ 10 / 20Hz 1Hz 1Hz 1Hz 0.05 0.05s 0.05s 1s 0.05s
3m / 30cm + 1ppm / 1cm + 1ppm / 100 0.5 cm + 1 ppm 3m / 25cm + 1ppm / 1cm + 1ppm / 100 0.5 cm + 1 ppm 15m / 25cm + 1ppm / 1cm + 1ppm 100 / 3mm + 0.1 ppm 3m / 25cm + 1ppm / 1cm + 1ppm / 3mm + 0.5ppm nr
ProFlex 500
75 par.
12GPS / 12Glonass / 3SBAS + low signal acquisition engines 12 or 16 12 or 16 12 or 16 12 or 16 12 or 16 12 or 16 12 or 16 12 or 16 16 16 All in view All in view All in view All in view 32 32 13 13 32 32 na na >12 >12 12 12 12 12 >12 8 8 8 8 12 12 12 12 12 12
AGLMNOPR1
21.5 x 20 x 7.6cm
2.1 kg
3m / 25cm + 1ppm / 1cm + 1ppm / 3mm + 0.5ppm 2.5 m / 2.0 m CEP 2.5 m / 2.0 m CEP 2.5 m / 2.0 m CEP 2.5 m / 2.0 m CEP 2.5 m / 2.0 m CEP 2.5 m / 2.0 m CEP 2.5 m / 2.0 m CEP 2.5 m / 2.0 m CEP 2.5 m / 2.0 m CEP 2.5 m / 2.0 m CEP 3 m / 1 m (CEP) 3 m / 1 m (CEP) na 3 m (CEP) 2m / 1.5m / na / na 2m / 1.5m / na / na 2m / 1.5m / na / na 2m / 1.5m / na / na 2m / 1.5m / na / na 2m / 1.5m / na / na na na <10 m / - / - / 1 m (95%) <10 m / - / - / 1 m (95%) <10 m / - / - / 1 m (95%) <10 m / - / - / 1 m (95%) <10 m / - / - / 1 m (95%) 50 m / - / - / 10 m (95%) 10 m / - / - / <1 m (95%) nr / nr / 25 m
nr
0.05s
Custom Time / Frequency Modules TM-4 TM-4D TM-4M, TM4-M + , TM4-M / D TM-4MR TM4-MRII TM-4OEM TM4-PC / 104 TM4-SN, TM4-S TM5-OEM
12 or 16 par. 12 or 16 par. 12 or 16 par. 12 or 16 par. 12 or 16 par. 12 or 16 par. 12 or 16 par. 12 or 16 par. 16 par. 16 par. 24. / 24 24 / 24 na 32 32 32 16
ADGLMMetOPT12 DGLMMetNOPT1 DGLMetOPT1 DGLMMetOPT1 DGLMMetOPT1 DLMetOPT1 ADGLMMetOPT2 ADGLMMetOPT2 ADGLMNOPT2 ADGLMNOPT2 ALNORTV2 ALNORTV2 ALNOV2 ALNOV2 ACDGLHMNPTV ACDGLHMNPTV ACDGLHMNPTV2 ACDGLHMNPTV2 ACDGLHMNPTV2 ACDGLHMNPTV2 ACDGLHMNPTV2 ACDGLHMNPTV2 NS1 NOS1 NS1 NS2 NS2 NS1 NS1 ADLMMetNPRT12 (dd) ADLMMetNPRT12 (dd) ADLMMetNPRT12 (dd) ADLMMetNPRT12 (dd) ADLMMetNT1 ADLMMetNT1 ADLMMetNT1 ADLMMetNT1 ADLMMetNT1 ADLMMetNT1
Various 4.0 x 1.5 x 4.125in Rack Brax avail. 19.0 x 1.75 x 8.0in 9.5 x 1.75 x 9.0in 9.5 x 3.5 x 12.0in Rack Mountable 19.0 x 3.5 x 8.0in 3.875 x 1.0 x 4.00in 3.775 x 0.497 x 3.55in 5.1 x 1.0 x 1.6in 60 x 114 x 16mm 40 x 30 x 6mm 160 x 100 x 18mm 18 x 42 x 4mm na 15 x 15 x 1.2mm 16 x 16 x 1.2mm RF 5x5mm BB 10x10mm 11 x 7 x 1.4mm 9x9x1.2 7x7x1 5 x 5 x 1.0mm 5 x 5 x 1.0mm 160 x 50 x 160mm 160 x 50 x 160mm 120 x 47 x 76mm 70 x 10 x 70mm 70 x 10 x 45mm 120 x 50 x 120mm 300 x 40 x 200mm PCI Express Low Profile Single-width (4.2 x 6.875in) Single-width 3U (3.94 x 6.3in) Std (2.91 x 5.86in) height 10mm 17 x 1.75 x 15.4in 17 x 1.75 x 15.4in 17 x 1.75 x 15.4in 17 x 1.75 x 15.4in 17 x 1.75 x 15.4in 17 x 1.75 x 15.4in
Various 1 lb 6.5 lb 4 lb 7.5 lb 6 lb 0.5 lb 0.5 lb 0.5 lb 0.5 lb 10 g 140 g 10 g na na na na na na na na na 1 kg 1 kg 450g 60 g 30 g 2.5 kg 1 kg
10 15 10 10 5 5 10 10 15 10 50 (RMS) 50 (RMS) na na <50(rms) <50(rms) 50 (rms) 50 (rms) <50(rms) <50(rms) na na 500 500 500 500 500 1000 500 170 170 1000 1000 <30 <30 <30 <100 <100 <100
1 1 1 1 1 1 1 1 1 1 0.2 0.1 na 1 1Hz 1Hz 1Hz 1Hz 1Hz / 5Hz / 10Hz 1Hz / 5Hz / 10Hz na na 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
Duo Star-2000 DuoStar-1000 GNSS Sampler Super-Sensitive Software GNSS-Receiver Cartesio PLUS (STA2064) Cartesio PLUS (STA2065) Teseo Chipset
STMicroelectronics www.st.com/gps
Teseo MCM (STA8058) 16 TeseoII SOC (STA8088EXG) 32 TeseoII SAL (STA8088FG) RF Front-End (STA5620) RF Front-End (STA5630) SGR-10 SGR-20 SGR-07 SGR-05P SGR-05U SGR-GEO SGR-ReSI Symmetricom www.symmetricom.com bc637PCIe bc637PCI-V2 bc637CPCI bc637PMC XLi XL-GPS XLi SAASM GB-GRAM SyncServer S250 SyncServer S350 SyncServer S350 SAASM 32 na na 24 24 12 12 12 12 24 8 par. 8 par. 8 par. 8 par. 12 par 12 par 12 par 12 par 12 par 12 par
module = 5.8 oz nr / nr / 25 m module = 5.7 oz nr / nr / 25 m module = 3.4 oz nr / nr / 25 m 10 lb 8 lb 10 lb 9 lb 9 lb 9 lb Autonomous Autonomous Autonomous Autonomous Autonomous Autonomous
18
www.gpsworld.com
Sponsored by
Cold start 3 <45s <45s <45s <45s <45s <45s Warm start 4 <15s (after reset) <15s (after reset) <15s (after reset) <15s (after reset) <15s (after reset) <15s (after reset) <15s (after reset) <15s (after reset) <20s (after reset) <20s (after reset) 28s 28s 28s 1s 28s 1s <20s 15s 15s 30s 30s Reacquisition No. of ports
5
Port type as above RS232, USB, event marker, PPS out as above RS232, Ethernet, USB, event marker, PPS out, Ref in RS232, Ethernet, USB, event marker, PPS out RS232, Ethernet, USB, event marker, PPS out, Ref in RS232, Ethernet, USB, event marker, PPS out, Ref in, PPS in, Ref out
Baud rate 300230,400, 10 Mbps 300230,400; 1-2 Mbps 300230,400; 1-2 Mbps 300230,400; 1-2 Mbps 300230,400; 1-2 Mbps 300230,400; 1-2 Mbps
Power consumption (Watts) 5W typ 2W IMU incl 2.5W IMU incl 1.5W typ 2W typ 6W typ
<45s
<1s
2, 1, 1, 2, 1, 1, 1, 1
-40 to + 60
930 V DC
6W typ
(E)
Multi-frequency GNSS reference receiver for highly accurate timing and frequency transfer Scintillation monitoring receiver
<45s
<1s
4, 1, 2, 1, 2
RS232, Ethernet, event marker, 300230,400; 1-2 Mbps PPS out, Ref out RS-232, Ethernet, event marker, PPS out, Ref in / out RS-232, Ethernet, event marker, PPS out, Ref in UART UART 2 UART, 2 SPI, I2C UART UART UART RS-232, Ext Power RS232, USB, Bluetooth RS232, USB, Bluetooth 2 x RS232, Bluetooth 300230,400, 10 Mbps 300230,400, 10 Mbps 4800 / 9600 / 38400 / 115200 4800 / 9600 / 38400 / 115200 4800 / 9600 / 38400 / 115200 4800 / 9600 / 38400 / 115200 4800 / 9600 / 38400 / 115200 4800 / 9600 / 38400 / 115200 460800 2,400115,200 2,400115,200 up to 115200
-40 to + 70
930 V DC
6W typ
(E)
<90s <90s 29s 29s 29s 1s 29s 1s <40s 90s 90s 60s 110s
<2s <2s <1s <1s <1s <1s <1s <1s <1s 15s 15s 15s 3s
4, 1, 2, 1, 2 4, 1, 2, 1, 1 1 1 5 1 1 1 2 3 3 3 4
5 V DC 930 V DC ext ext ext ext ext ext ext. / int. Ext. / int. Ext. / int. Int. / ext. Int. / ext.
Application-dependent Application-dependent 0.067 0.06 0.067 0.13 0.2 0.25 4 3 3 4.4 4.5
(E) (E) active or passive active or passive active or passive active active active int. Patch internal, patch active (ER) ext. Patch internal, patch active (ER) ext. Internal patch (ER) Internal patch active. GPS / GLO / GAL L1 / L2 / L5
Single-board, triple-antenna / attitude GPS / SBAS receiver board Versatile and high precision attitude GPS / SBAS receiver ROM GPS chipset ROM GPS module Flash GPS module Dead-Reckoning GPS module GLONASS / GPS module Dead-Reckoning GLONASS / GPS module Int 1 W UHF radio; 20Hz; Bluetooth; Available in L1 Only configuration as well Versatile GNSS solution with exceptional post-processing All-in-one solution for network RTK Survey-grade GNSS receiver capable of high accuracy positioning The Full GNSS Productivity GNSS Centric Z-Blade
90s
35s
3s
<35s <35s <35s <35s <35s <35s <35s <35s <35s <35s 45 s (typ) 45 s (typ) na 30 s (typ) 35s 35s 39s 39s 35s 35s na na 3.5min 3.5min 9m / 2m 9m / 2m 9min TBC 3 / 2min
<38s <38s <38s <38s <38s <38s <38s <38s <38s <38s 35 s (typ) 35 s (typ) na 4 s (typ) 34s 34s 34s 34s 34s 34s na na 60s 60s 60s 60s 60s TBC 60s
<1s <1s <1s <1s <1s <1s <1s <1s <1s <1s 1s 1s na 1s <1s <1s <1s <1s <1s <1s na na nr nr nr nr nr nr nr
Various 2, 9 24, 9 6, 9 6, 9 6, 9 2, 9 3, 9 2, 5 2, 8 2 2 1 1 17 22 10 9
1 RS232 / RS422, 2 RS232, RS232 / 422: up to 921.6 USB, Bluetooth, Ethernet, GSM kbits / sec USB 2.0 host & / GPRS, Earth terminal device Bluetooth 2.0 + EDR Class 2, SPP profile sine, 1PPS, RS-232, TTL, IRIG Selectable to 115,200 B, NTP, various as above Selectable to 115,200 as above as above as above as above as above 10 MHz sine(x2), 1PPS, RS-232, TTL, IRIG B, NTP, various 10 MHz LVDS, 1PPS LVDS, TTL, Custom sine, 1PPS, TTL, various UART RS-232 USB 2.0 Virtual COM port UART, SPI, I2C, USB, CAN, SD / MMC, I2S / TDM, SPDIF, GPIOs UART, SPI, I2C, USB, CAN, USB, SD / MMC, I2S / TDM, SPDIF, SmartCard, GPIOs UART, SPI, I2C, USB and CAN UART, SPI, I2C, USB and CAN UART, SPI, SQI, 2C, USB, CAN, , SD / MMC, I2S, FSMC, GPIOs UART, SPI, SQI, 2C, USB, CAN, ,GPIOs na na RS-422, CAN bus RS-422, CAN bus RS-422, CAN bus TTL, RS422, CAN UART TTL RS-422, CAN bus RS-422, CAN bus Selectable to 115,200 Selectable to 115,200 Selectable to 115,200 Selectable to 115,200 Selectable to 115,200 Selectable to 115,200 Selectable to 115,200 Selectable to 115,200 115,200 bps max. 115,200 bps max. na 57,600 bps 4800-115500 4800-115500 4800-115500 4800-115500 4800-115500 4800-115500 na na 9,60038,400 9,60038,400 9,60038,400 9,60038,400 9,60038,400 9,60038,400 9,60038,400
-30 to + 65
Int. / ext.
with UHF and GNSS antenna < 5 Various 3.2 4 3.2 < 12 <12 Various to under 2 W as above as above 3.2 600 mW 3.5 W na na Variable (inquire) Variable (inquire) Variable (inquire) Variable (inquire) Variable (inquire) Variable (inquire) 40mW 29mW <6 <7 <2 1.5 1 5 <6
-40 to + 85 -20 to + 70 -20 to + 70 -20 to + 70 0 to + 70 0 to + 70 -20 to + 70 or -40 to + 85 -20 to + 70 or -40 to + 85 -40 to + 85 -20 to + 70 or -40 to + 85 40 + 85 40 + 80 40 + 80 na -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 20 to + 50 20 to + 50 20 to + 50 20 to + 50 20 to + 50 20 to + 50 20 to + 50
ext ext ext Universal AC Universal AC Universal AC ext ext ext ext 3.3 V 5V na na 1.25V 1.25V ext / int ext / int 1.2V / 1.8V 1.2V / 1.8V 2.56 - 3.3V 1.62-1.98V External External External External External External External
External active antenna depending Flexible Rugged High-Performance GNSS Receiver on application: Geodetic Survey Antenna, Machine, Marine or Choke Ring ext. Customizable time / frequency platform ext. ext. ext. ext. ext. ext. ext. ext. ext. E (active & passive) E (active & passive) E (active & passive) na E (passive & active) E (passive & active) E (passive & active) E (passive & active) E (passive & active) E (passive & active) na na 2 patch + LNAs 4 patch + LNAs 1 patch + LNA 1 Quadrifilar / patch + LNA 1 Quadrifilar + LNA High gain patch + LNA Four spiral array, plus standard patches Time / Frequency reference instrument. IRIG-B Time / Frequency instrument with integrated Distribution Amplifier. IRIG-capable. Time / Frequency instrument with internal UPS Time / Frequency instrument with Rubidium oscillator and integrated UPS Time / Frequency instrument with Rubidium oscillator. Rack Mount Board level module, Time / Frequency, IRIG-B Board level module, Time / Frequency, IRIG-B, PC / 104 compliant Board level module, Time / Frequency, MGRS, WAAS, High Sensitivity, Fully Shielded Board level module, Time / Frequency, high sensitivity, WAAS, Fully Shielded Compact GPS + GLONASS OEM receiver with low BOM cost, Eurocard-sized GPS + GLONASS OEM receiver Navigation signal sampler Sensitivity: cold start -157 dBm; hot start -164 dBm; tracking -170 dBm Infotainment application processor with embedded GPS Infotainment application processor with embedded GPS Embedded Flash + EMI Embedded Flash Multiconstellation Sistem On Chip Multiconstenstellatin Stand-Alone Fully integrated RF Front-end Low power GPS-Galileo RF Front-end Heritage space receiver Spacecraft att. determ. Packaged SGR-05P Rdcd-size OEM w TMR University-grade space OEM GEO, MEO, HEO space Remote Sensing Capability (Reflection & RO)
na na 2 2 2 2 1 2 2
na na na 2 2 2 3
Register-based interface Register-based interface Register-based interface RS-232 / RS-422 Ethernet RS-232 / RS-422 Ethernet RS-232 / RS-422 Ethernet Ethernet
0 to + 70 0 to + 70 0 to + 70 0 to + 50 0 to + 50 0 to + 50 0 to + 50
5V dc 900 mA + 12 V DC @ 100 mA + 5 V DC @ 350 mA 10-70 watts 10-30 watts 10-70 watts 25-45 watts
L1 (ER / WR) L1 (ER / WR) L1 (ER / WR) L1 (ER / WR) L1 (ER / WR) L1 / L2 (ER / WR) L1 (ER / WR)
PCIbus Universal signaling time / frequency processor Compact PCIbus GPS time / frequency processor PCI mezzanine card GPS time / frequency processor Modular, plug-&-play GPS time and frequency Modular, plug-&-play Network Time Server
www.gpsworld.com
19
GNSS 1000S, SAASM24 par. Based GNSS 100-2, SAASM-Based 24 par. GNSS 100-3, SAASM-Based 24 par. TOPSTAR 200NG 12 Topcon www.topconpositioning.com GR-5 216 Universal Tracking Channels 72 Universal Tracking Channels 144 Universal Tracking Channels 72 72 Universal Tracking Channels 72 Universal Tracking Channels 72 Universal Tracking Channels 72 Universal Tracking Channels 144
36 >50
GL1 GLR1
1.1 kg 3.0 kg
23 m / 30 cm / 10 mm / 3 mm 23 m / 30 cm / 10 mm / 3 mm
10 10
0.05 0.01
36 20 36 20 20 >50
23 m / 30 cm / 10 mm / 3 mm 23 m / 30 cm / 10 mm / 3 mm 23 m / 30 cm / 10 mm / 3 mm 23 m / 30 cm / 10 mm / 3 mm 23 m / 30 cm / 10 mm / 3 mm 23 m / 30 cm / 10 mm / 3 mm
10 10 10 10 10 10
G3 160T
20
na
23 m / 30 cm / 10 mm / 3 mm
10
0.05
Trimble www.trimble.com
Trimble AP10 Board Set Trimble AP20 Board Set Trimble AP40 Board Set Trimble AP50 Board Set BD910 GNSS Receiver BD920 GNSS Receiver BD982 GNSS Heading Receiver BD970 GNSS Receiver BD960 GNSS Receiver
ADGLMNOPR2 ADGLMNOPR2 ADGLMNOPR2 ADGLMNOPR2 DGLMNPRTV2 DGLMNPRTV2 DGLMNPRTV2 DGLMNPRTV2 GLMNPRTV2 GLMNPRTV2 GLMNPRTV2 DGLMNPRTV2 DGLMNPRTV2 DGLMNPRTV2 MNPRTV1 LMNPRTV1 MNPRTV1
167 x 100 x 45mm (including IMU) 130 x 100 x 39mm (not including IMU) 130 x 100 x 39mm (not including IMU) 130L x 100W x 39H mm (not including IMU) 41 x 41 x 7mm 51 x 41 x 7mm
0.68 kg (including IMU) 0.35 kg (not including IMU) 0.35 kg (not including IMU) 0.35 kg (not including IMU) 0.7 oz
1.5 3m / 0.25- 1m / 0.02 - 0.05m / 0.02 - 0.05m 1.5 3m / 0.5 - 2m / 0.02 - 0.05m / 0.02 - 0.05m 1.5 3m / 0.5 - 2m / 0.02 - 0.05m / 0.02 - 0.05m 1.5 3m / 0.5 - 2m / 0.02 - 0.05m / 0.02 - 0.05m
100 100 100 100 100 100 100 100 100 100 100 100 100 100 100 100 100
BD950 L1 / L2 GPS Receiver 24 BD950 L1 GPS Receiver BX960 GNSS Receiver BX960-2 GNSS Heading Receiver BX982 GNSS Heading Receiver SPS351 Beacon / DGPS SPS852 SPS461 Heading receiver 24 72 72 x 2 220 36 par + 2 SBAS + 2 MSK 220 72 + 4 SBAS + 2 MSK 220 12 12 na 12 12 12 22 22 22 22 22 8 14 12 12 12 440
15m / 0.25m + 0.5ppm / 8mm + 1ppm / 3mm + 0.1 ppm 15m / 0.25m + 0.5ppm / 8mm + 1ppm / 3mm + 0.1 ppm 100 x 84.9 x 11.6mm 3.2 oz 15m / 0.25m + 0.5ppm / 8mm + 1ppm / 3mm + 0.1 ppm 100 x 60 x 11.6mm 2.2 oz 15m / 0.25m + 0.5ppm / 8mm + 1ppm / 3mm + 0.1 ppm 100x106.7x12.7mm 5.3 oz 15m / 0.25m + 0.5ppm / 8mm + 1ppm / 3mm + 0.1 ppm 100 x 80 x 17mm 2.3 oz 15m / 0.25m + 0.5ppm / 10mm + 1ppm / 5 100 x 80 x 17mm 2.3 oz <1 m DGPS, 5 mm + 1 ppm pp 261 x 140 x 55mm 1.6 kg 15m / 0.25m + 0.5ppm / 8mm + 1ppm / 3mm + 0.1 ppm 261 x 140 x 55mm 1.9 kg 15m / 0.25m + 0.5ppm / 8mm + 1ppm / 3mm + 0.1 ppm 262 x 140 x 55mm 1.6 kg 15m / 0.25m + 0.5ppm / 8mm + 1ppm / 3mm + 0.1 ppm 9.4 in x 4.7 in x 1.9in 1.35 kg (3.00 lb) 1-5 m / <1 m / na 0.85 oz 240 x 120 x 5mm 24 cm (9.4 in) x 12 cm (4.7 in) x 5 cm (1.9 in) including connectors 19.0 () x 11.2cm 3.74 D, 2.85in H 5 x 6.12in 3.05 x 2.61 32 x 66 x 8.5mm 26 x 26 x 6mm 2.54 H x 19 W x 19 L 10 x 10 x 2mm 16 x 12.2 x 2.13mm 17 x 22.4 x 2.13mm 19 x 19 x 2.54mm 26 x 26 x 6mm 1.02 x 1.02 x 0.24in 19 x 19 x 2.54mm 1.25 x 0.33 x 2.61in 123.27 x 30.07 5Lx4wx2h 26.5 x 13.0 x 5.5cm 1.35 kg (3.00 lb) 15m / 0.25m + 0.5ppm / 8mm + 1ppm / 3mm + 0.1ppm 1.35 kg (3.00 lb) 15m / 0.25m + 0.5ppm / 8mm + 1ppm / na 1.35 kg (3.00 lb) 15m / 0.25m + 0.5ppm / 8mm + 1ppm / 3mm + 0.1ppm 5.4 oz 40 m CEP; velocity 0.25 m / s CEP 12.8 oz 6.0 oz na 0.2 oz 0.7 oz 0.364 grams 0.544 grams 0.953 grams 1.74 grams 6.486 grams 0.2 oz 1.8 oz 0.4 na na 2m 10 / 2m 3m <2.5 <2.5 <2.5 <2.5 <2.5 <6 m (50%) na <6m 50%,<9m 90% na na 15m / 0.25m + 0.5ppm / 8mm + 1ppm / 3mm + 0.1 ppm
SPS882 Acutime Gold GPS Smart Antenna Acutime Gold GPS Starter Kit Bullet III GPS Antenna Lassen DR GPS module Lassen iQ Copernicus II GPS Condor C1011 Condor C1216 Condor C1722 Condor C1919 Condor C2626 Lassen-SQ Resolution SMT Embedded GPS Timing Board Resolution T Mini-T GPS Disp Clock Board Thunderbolt E Disciplined Clock Trimble NetR9
L1 / L2 / L5,GLONASS L1 / L2, GIOVE, SBAS L1 only, C / A-code L1 only, C / A code L1 L1 only, C / A code L1 only, C / A-code L1, C / A code L1, C / A code L1, C / A code L1, C / A code L1, C / A code L1, C / A code L1 only, C / A code L1 only, C / A code L1 only, C / A code L1 only C / A code L1 only C / A code GPS: L1 C / A, L2C, L2E (Trimble method for tracking L2P), L5 GLONASS: L1 C / A and unencrypted P code, L2 C / A2 and unencrypted P code Galileo GIOVE-A and GIOVE-B, additional tracking pending commercial authorization SBAS: L1C / A, L5 L-Band OmniSTAR VBS, HP and XP Expandable for future signals pending ICD releases.
44 8 8 na 12 12 12 22 22 22 22 22 8 14 12 12 12 88
GLVPRT1 LMPST1 LMPST1 TI LNV2 GLMNRSTV2 AGHLMMETNPV AGHLMMETNPV AGHLMMETNPV AGHLMMETNPV AGHLMMETNPV AGHLMMETNPV GLMNRSTV2 T2 T2 T2 T2 GLMMetNVPRT1
100 50 50 na 50 50 50
1,2,5,10,20Hz 1 1 na up to 10Hz 1 1 1Hz 1Hz 1Hz 1Hz 1Hz 1 1Hz 1 1Hz 1Hz 50Hz
20
www.gpsworld.com
Sponsored by
Cold start 3 <39s <39s <39s <39s <39s <60s GPS : 200 s GLO : 290 s <60s <60s <60s <210s <30s Warm start 4 <34s <34s <34s <34s <34s 20s GPS : 50 s GLO : 60 s 20s 20s 20s 75s <5s Reacquisition No. of ports
5
Port type 1 RS-232, 2 digital inputs 1 RS-232, differential 1PPS (RS-242) 1 RS-232, differential 1PPS (RS-242) RS232 & opt USB 1 RS-232, 1 CMOS, opt 1PPS RS 422, DPRAM, DS-101, DS102, HVQK, 1PPS In / Out RS 422, DPRAM RS 422, DPRAM, DS-101, DS102, HVQK, 1PPS In / Out 1553 or ARINC 429, RS422, NMEA, DS-101, DS-102, HVQK, 1PPS In / Out RS 422, HVQK, 1PPS In / Out ARINC 429, RS 232, Time Mark Pulse; discrete RS-232, USB, Ext Pwr
Baud rate Configurable to 115.2kb Configurable to 115.2kb Configurable to 115.2kb Configurable to 115.2kb Configurable to 115.2kb 115 200 115 200 115 200 4800, 115 200 115200 100 000, 19200 460800
<1s <1s <1s <1s <1s <5s <15s <5s <5s <5s <10s <1s
1 1 1 1 1 4, 1, 1, 1, 2 3, 1 4, 1, 1, 1, 2 1 or 2, 2, 1, 1, 1, 1, 2 4, 1, 2 8,1, 3, 3 3
Operating temperature (degrees Celsius) -45C, + 85C -45C, + 85C -45C, + 85C -45C, + 85C -45C, + 85C -46C to + 101C -46C to + 92C -46C to + 101C -46C to + 71C -45C to + 82C -40C to + 70C 30 to + 70
Power source 12 V ext 5V or 12V ext 5V or 12 V ext 5v or 12V ext 3.3V ext External External External 28 V dc 28 V dc 28 V dc ext. / int.
Power consumption (Watts) 1W 1W 1W 1W 0.25W < 10W 14 W < 10W < 25 W < 20 W < 18 W 3.3
<40 <30s
<20s <5s
<1s <1s
2 8
RS-232, Ext Power 4 RS-232, 1 USB, 2 Power, 1 Ethernet RS-232, USB, Ethernet 1 common port for 2xRS-232 and Power, 2 ext antenna Mini USB, Power, Mini Serial 3 RS-232, 1 USB, 2 CAN 4 RS-232 4 RS-232, 1 Ethernet, 1 USB
460800 460800
40 to + 65 40 to + 65C
4 < 4.5
int. ext.
4 3 3 6 4 6
40 to + 60 40 to + 75 40 to + 60 30 to + 85 40 to + 75 40 to + 65C
ext. ext. int. / ext. int. / ext. int. / ext. int. / ext.
<60s
<10s
<1s
460800
40 to + 75
ext
int. / ext.
<60s <60s <60s <60s <45s <45s <60s <60s <60s <60s <60s <60s <60s <60s <60s <60s <60s
<30s <30s <30s <30s <30s <30s <30s <30s <30s <30s <30s <30s <30s <30s <30s <30s <30s
<15s <15s <15s <15s <2s <2s <15s <15s <15s <15s <15s <15s <15s <15s <12s <12s <12s
1,4,1,5 1,4,1,5 1,4,1,5 1,4,1,5 4,1,1 4,1,2 4,1,1,1 3,1,1,1 3,1 4 4 2,1 3,1 3,1,1,1 3,1,3 3,1,3 2,1,3
Ethernet, RS232, 1PPS, Event Ethernet, RS232, 1PPS, Event Ethernet, RS232, 1PPS, Event Ethernet, RS232, 1PPS, Event RS-232, Ethernet, USB RS-232, Ethernet, USB RS-232, Ethernet, USB, CAN RS-232, Ethernet, USB, CAN RS-232, Ethernet RS-232 RS-232 RS-232, Ethernet RS-232, Ethernet RS-232, Ethernet, USB, CAN RS-232, Ethernet, Bluetooth RS-232, Ethernet, Bluetooth RS-232, Ethernet, Bluetooth
2,400115,200 2,400115,200 2,400115,200 2,400115,200 115,200 RS-232, 10 / 100Mbps Ethr 115,200 RS-232, 10 / 100Mbps Ethr 460,800 RS-232, 10 / 100Mbps Ethr 115,200 RS-232, 10 / 100Mbps Ethr as above 115200 115200 115,200 RS-232, 10 / 100Mbps Ethr as above 460,800 RS-232, 10 / 100Mbps Ethr 2,400115,200 Max 115,200 RS232,10 / 100Mbps Ethr 2,400115,200
-40 to + 75 C -40 to + 75 C -40 to + 75 C -40 to + 75 C -40 to + 85 -40 to + 85 -40 to + 75 -40 to + 75 40 to + 74 40 to + 75 40 to + 75 40 to + 74 40 to + 74 -40 to + 75 -40 to + 65 -40 to + 65 -40 to + 65
ext ext ext ext ext ext ext ext ext ext ext ext ext ext ext Internal Li-Ion and ext ext
< 20 Watts (incl IMU and ant) < 20 Watts (incl ant, not incl IMU) < 20 Watts (incl ant, not incl IMU) < 20 Watts (incl ant, not incl IMU) 1.1W 1.3W 2.1 W 1.5W 2.1 W 1.5 W 1.0 W 3.7 W 8.8 W 4.1 W 4.5 6W 6.0 W in rover mode with internal receive radio < 3.1W in RTK mode <1.5 <1.5 <20 mA - 3V 30 mA - 5V 190 mW 0.009 44 mA @3.0 V <37 mA typical 20C <37 mA typical 20C <37 mA typical 20C <37 mA typical 20C <37 mA typical 20C 110 mW @3.3 V 330 mW 350 mW @3.3 V na na 3.8W (setting dependant)
Zephyr Model 2 / Trimble AV37 Aviation Zephyr Model 2 / Trimble AV37 Aviation Zephyr Model 2 / Trimble AV37 Aviation Zephyr Model 2 / Trimble AV37 Aviation nr nr
GNSS + Inertial for continuous positioning during satellite blockage GNSS + Inertial for continuous positioning during satellite blockage and high accuracy orientation for mobile mapping GNSS + Inertial for continuous positioning during satellite blockage and high accuracy orientation for mobile mapping GNSS + Inertial for continuous positioning during satellite blockage and high accuracy orientation for mobile mapping
nr nr nr nr nr nr
GA530 GPS / MSK Hfield Zephyr Model 2 GA530 GPS / MSK Hfield
Beacon, SBAS, DGPS. DGPS base mode RTK Rover and Base station. Location RTK options, Optional internal radio Precise GPS Heading with Beacon, SBAS, DGPS rover, Location RTK and Precision RTK rover modes.
<60s <60s <60s na 50s <55 38s 38s 38s 38s 38s 38s <170s 90% na <50s (90%) na na <60s
<30s <2s <2s na 38s <38 35s 35s 35s 35s 35s 35s <45s (90%) na <45s (90%) na na <30s
RS232, Bluetooth RS-422 / 485 or RS-232 RS-422 na 3.3 V TTL-Gryro- speed input TTL TTL serial serial & usb serial & usb serial serial TTL TTL TTL CMOS RS232 D9 Serial, 7 pin Lemo, Mini USB, RJ45 (Ethernet - HTTP, HTTPS, FTP, TCP / IP, UDP, NTRIP Caster, NTRIP Server, NTRIP Client), Bluetooth
38,400 (Port 1 115,200 (Port 2) 9600 9600 na 9600 9600 38400 9600
40 to + 65 40 to + 85 40 to + 85 40 to + 85 40 to + 85 40 to + 85 40 to + 85 40 to + 85 40 to + 85 40 to + 85 40 to + 85 40 to + 85 40 to + 85 40 to + 85 40 to + 85 0 - + 60 0 - + 60 40 to + 65
Internal Zephyr 2 Patch Patch na SMB or Fakra Micropatch (ER) Micropatch (ER)
Micropatch (ER) Active / external External active External active 5v External active 5v Zephyr Geodetic II GNSS Choke Ring
www.gpsworld.com
21
na / <1 m / 50 cm Post-proc (1cm na with carrier) na / <1 m / 10-30cm Post-proc (1cm na with carrier) na / 2 - 5 m / 1 - 3 m Post-proc na / 2 - 5 m / 1 - 3 m Post-proc na / 2 - 5 m / 1 - 3 m Post-proc na / 2 - 5 m / 2 - 5 m Post-proc na / 30cm / 10cm / 10cm 1-5 m / na / na / 5mm + 0.5ppm 15m / 0.25m + 0.5ppm / 8mm + 1ppm / 3mm + 0.1 ppm 15m / 0.25m + 0.5ppm / 8mm + 1ppm / 3mm + 0.1 ppm 15m / 0.25m + 0.5ppm / 8mm + 1ppm / 3mm + 0.1 ppm 15m / 0.25m + 0.5ppm / 8mm + 1ppm / 3mm + 0.1 ppm 15m / 0.25m + 0.5ppm / 8mm + 1ppm / 3mm + 0.1 ppm 15m / 0.25m + 1ppm / 13mm + 1ppm / 5mm + 0.5 ppm na na na na na 100 100 100
72 72
24 24
GLMNVPR1 GLMMetNVPRT1
1.35 kg 1.5 kg
100 100
Trimble R8 GNSS
220
44
GLMNVPR1
19.0 () x 11.2cm
1.35 kg
100
1Hz RTK
GeoXR
220
44
GHLN1
0.925 kg
100
1Hz RTK
u-blox www.u-blox.com
Placer Gold APU and DRU Plus UBX-G6010-ST u-blox 6 GPS single chip; Standard Grade UBX-G6010-SA u-blox 6 GPS single chip; Automotive Grade UBX-G6010-SA(ST)-DR u-blox 6 GPS single chip with Dead Reckoning; Automotive & Standard Grade UBX-G6010-NT u-blox 6 GPS single chip; Standard Grade UBX-G6010-ST-TM GPS receiver single chip with Precision Timing
12 All in view (GPS, GALILEO or SBAS) All in view (GPS, GALILEO or SBAS) All in view (GPS, GALILEO or SBAS) All in view (GPS, GALILEO or SBAS) All in view (GPS, GALILEO or SBAS) All in view (GPS, GALILEO or SBAS) All in view (GPS, GALILEO or SBAS) All in view (GPS, GALILEO or SBAS) All in view (GPS, GALILEO or SBAS) All in view (GPS, GALILEO or SBAS) All in view (GPS, GALILEO or SBAS) All in view (GPS, GALILEO or SBAS) All in view (GPS, GALILEO or SBAS) All in view (GPS, GALILEO or SBAS) All in view (GPS, GALILEO or SBAS) All in view (GPS, GALILEO or SBAS) All in view (GPS, GALILEO or SBAS) All in view (GPS, GALILEO or SBAS) All in view (GPS, GALILEO or SBAS) All in view (GPS, GALILEO or SBAS) All in view (GPS, GALILEO or SBAS) 16
11 oz na na na
1 5 5 5
50 par
CDHLMMetNPTV2 CDHLMMetNPTV2
na
50 (RMS) 50 (RMS)
5 5
UBX-G6000-BA + UBX50 par G0010-QA u-blox 6 GPS Chipset (RF + Baseband) UBX-G0011 RF Frontend for Capture & Process AMY-6M GPS Module 50 par NEO-6M GPS Module NEO-6Q GPS Module NEO-6G GPS Module NEO-6P GPS Module NEO-6V GPS Module MAX-6G GPS Module MAX-6Q GPS Module LEA-6A GPS Module LEA-6H GPS Module LEA-6S GPS Module LEA-6T GPS Timing Module LEA-6R Dead Reckoning GPS Module LEA-6N GPS / GLONASS Module VGI Solutions / OnPOZ Precision Positioning SubX www.onpoz.com 50 par 50 par 50 par 50 par 50 par 50 par 50 par 50 par 50 par 50 par 50 par 16 par. 50 par 16 par.
CDHLMMetNPTV2 CDHLMMetNPTV2 CDHLMMetNPV2 CDHLMMetNPV2 CDHLMMetNPV2 CDHLMMetNPV2 CDHLMMetNPV2 CDHLMMetNPV2 CDHLMMetNPV2 CDHLMMetNPV2 CDHLMMetNPV2 CDHLMMetNPV2 CDHLMMetNPV2 CDHLMMetNPV2 DLNPV2 CDHLMMetNPV2 GIS Mapping
BB: 9 x 9mm RF: 4 x 4mm 4 x 4 x 0.9 mm 6.5 x 8 x 1.2mm 12.2 x 16.0 x 2.4mm 12.2 x 16.0 x 2.4mm 12.2 x 16.0 x 2.4mm 12.2 x 16.0 x 2.4mm 12.2 x 16.0 x 2.4mm 9.7 x 10.1 x 2.5mm 9.7 x 10.1 x 2.5mm 17 x 22.4 x 3mm 17 x 22.4 x 3mm 17 x 22.4 x 3mm 17 x 22.4 x 3mm 17 x 22.4 x 3mm 17 x 22.4 x 3mm 12 x 6.5 x 4cm
na
50 (RMS) na 50 (RMS) 50 (RMS) 50 (RMS) 50 (RMS) 50 (RMS) 50 (RMS) 50 (RMS) 50 (RMS) 50 (RMS) 50 (RMS) 50 (RMS) 50 (RMS) 50 (RMS) 50 (RMS)
5 na 4 5 5 5 5 5 5 5 5 5 5 5 1 5 1Hz
0.8 g 1.6 g 1.6 g 1.6 g 1.6 g 1.6 g 1.4 g 1.4 g 2.1 g 2.1 g 2.1 g 2.1 g 2.1 g 2.1 g 0.67 lb
<2.5 m / <2 m / na / na (CEP) <2.5 m / <2 m / na / na (CEP) <2.5 m / <2 m / na / na (CEP) <2.5 m / <2 m / na / na (CEP) <2.5 m / <2 m / na / na (CEP) <2.5 m / <2 m / na / na (CEP) <2.5 m / <2 m / na / na (CEP) <2.5 m / <2 m / na / na (CEP) <2.5 m / <2 m / na / na (CEP) <2.5 m / <2 m / na / na (CEP) <2.5 m / <2 m / na / na (CEP) <2.5 m / <2 m / na / na (CEP) <2.5 m / <2 m / na / na (CEP) <2.5 m / <2 m / na / na (CEP) 2.5 m / 2 m / na / 0.01 cm (CEP)
22
www.gpsworld.com
Sponsored by
Cold start 3 <60s <60s <60s 60s typ. 60s typ. 60s typ. 60s typ. 60s typ. 60s typ. 60s typ. 60s typ. 60s typ. 60s typ. 60s typ. <90s <60s <60s Warm start 4 <2s <2s <2s 30s typ. 30s typ. 30s typ. 40s typ. 30s typ. 30s typ. 40s typ. 40s typ. 40s typ. 40s typ. 30s typ. <30s <30s <30s Reacquisition No. of ports
5
Port type RS-232, RS-422 RS-232, RS-422, DP-RAM ARINC-429, RS-422, RS-232 RS-232 / Integrated virtual com ports / USB (via support module) / Bluetooth as above as above RS-232 / Bluetooth / USB (selected model or via separate accessory) Bluetooth / RS-232 Bluetooth / RS-232 Bluetooth / USB Bluetooth / USB Bluetooth / USB Bluetooth / USB / RS232 / ExpressCard / SDIO Bluetooth / RS232 RS-232 / USB / 2 Compact Flash / GPS antenna / Power 2 x RS232, Bluetooth, Radio coms RS232, radio antenna, GNSS antenna, Compact Flash 2 x RS232, Bluetooth, Radio coms RS232, radio antenna, GNSS antenna, Compact Flash, Bluetooth 2 x RS232, Bluetooth, Radio coms USB, Bluetooth, WiFi, 3.5G
Baud rate variable variable variable 110 - 115,000 110 - 115,000 110 - 115,000
<2s <2s <2s <5s typ. <5s typ. <5s typ. <5s typ. <5s typ. <5s typ. <5s typ. <5s typ. <5s typ. <5s typ. <5s typ. <15s <15s <15s
3 4 4 1,3,1,2 1,3,1,2 1,3,1,2 2,1,1 2, 2 2, 2 1,1 1,1 1,1 1,2,1,1,1 2,2 6 3,1,1 3,1,1,1
Power source ext ext ext int / opt ext int / opt ext int / opt ext int / opt ext int / opt. ext int / opt. ext int / opt. ext int / opt. ext int / opt. ext int / opt. ext int / opt. ext ext / int ext / int ext / int
Power consumption (Watts) <4W <7.5W <7.5W 2.7 - 3.7 2.7 - 3.7 2.7 - 3.7 1.3 w / typical use <1 <1 0.2 - 0.3 0.2 - 0.3 (without modem active) 0.2 - 0.3 (without modem active)
110 - 115,000 110 - 115,000 110 - 115,000 110 - 115,000 110 - 115,000 110 - 115,000 110 - 115,000
4.4W 0.6 W receiver and antenna < 3.1W in RTK mode 4w Fast Static 5.9 w / radio, BT RTK < 3.1W in RTK mode 4w Fast Static 5.9 w / radio, BT RTK < 3.1W in RTK mode
Ext antenna external TRIMBLE A3 Internal Zephyr 2 Zephyr 2, Z Geodetic 2 w / Stealth GP, GNSS Choke Ring Internal Zephyr 2 Zephyr 2, Z Geodetic 2 w / Stealth GP, GNSS Choke Ring Internal Zephyr 2
115,200 (RS 232); USB 1Mbp 30 to + 60 38,400 (Port 1 115,200 (Port 2) 115,200 (Port 13); USB 1 Mbps 38,400 (Port 1 115,200 (Port 2) 115,200 (Port 13); USB 1 Mbps 38,400 (Port 1 115,200 (Port 2) 40 to + 65 40 to + 65
<60s <60s
<30s <30s
<15s <15s
3,1,1 3,2,1,1,1,1
40 to + 65 40 to + 65
as above as above
<60s
<30s
<15s
3,1,1
40 to + 65
ext / int
Trimble R-Track technology for GLONASS support, Galileo Support, Advance Maxwell survey GNSS chip Trimble R-Track technology for GPS and GLONASS support, advanced Maxwell survey GNSS chip
<60s
<30s
<15s
1,1,1,1
140s 26 s (1 s hot and aided starts) 26 s (1 s hot and aided starts) 26 s (1 s hot and aided starts) 26 s (1 s hot and aided starts) 26 s (1 s hot and aided starts) 26 s (1 s hot and aided starts) na 26 s (1 s hot and aided starts) 26 s (1 s hot and aided starts) 26 s (1 s hot and aided starts) 26 s (1 s hot and aided starts) 32 s (<3 s hot and aided starts) 27 s (<3 s hot and aided starts) 29 s (1 s hot and aided starts) 29 s (1 s hot and aided starts) 26 s (1 s hot and aided starts) 26 s (1 s hot and aided starts) 26 s (1 s hot and aided starts) 26 s (1 s hot and aided starts) 27 s (2 s hot and aided starts) 26 s (1 s hot and aided starts) <<34s
2 4 4 4
RS-232C, DCE / DTE 1 x UART, 1 x USB, 1 x SPI, 1 x I2C 1 x UART, 1 x USB, 1 x SPI, 1 x I2C 1 x UART, 1 x USB, 1 x SPI, 1 x I2C 1 x UART, 1 x USB, 1 x SPI, 1 x I2C 1 x UART, 1 x USB, 1 x SPI, 1 x I2C 2 x UART, 1 x USB, 1 x SPI, 1 x I2C SPI 1 x USB, 1 x UART, 1x SPI, 1x I2C 1 x USB, 1 x UART, 1x SPI, 1x I2C 1 x USB, 1 x UART, 1x SPI, 1x I2C 1 x USB, 1 x UART, 1x SPI, 1x I2C 1 x USB, 1 x UART, 1x SPI, 1x I2C 1 x USB, 1 x UART, 1x SPI, 1x I2C 1 x UART, 1 x I2C 1 x UART, 1 x I2C 1 x USB, 1 x UART, 1x I2C 1 x USB, 1 x UART, 1x I2C 1 x USB, 1 x UART, 1x I2C 1 x USB, 1 x UART, 1x I2C 1 x UART, 1 x USB, 1 x SPI 1 x USB, 1 x UART, 1x I2C 1 BT
USB 2.0, Bluetooth 2.1 + -20 to + 50 EDR, WiFi 802.11b / g, UMTS / HSDPA 850 / 900 / 2100 MHz, GPRS / EDGE 850 / 900 / 1800 / 1900 MHz 4800 NMEA, 9600 TAIP 40 to + 80 4,800 - 115,200 bps; USB: 12 Mb / s 4,800 - 115,200 bps; USB: 12 Mb / s 4,800 - 115,200 bps; USB: 12 Mb / s 4,800 - 115,200 bps; USB: 12 Mb / s 4,800 - 115,200 bps; USB: 12 Mb / s as above 5.4 MSPS as above as above as above as above as above as above 4,800 - 115,200 4,800 - 115,200 4,800 - 115,200 bps; USB: 12 Mb / s 4,800 - 115,200 bps; USB: 12 Mb / s 4,800 - 115,200 bps; USB: 12 Mb / s 4,800 - 115,200 bps; USB: 12 Mb / s 4,800 - 115,200 bps; USB: 12 Mb / s 4,800 - 115,200 bps; USB: 12 Mb / s 57600 -40 to + 85 -40 to + 85 -40 to + 85
ext / int
2.7W - 3.7W
ext 1.75 - 2.0 V 2.5 - 3.6 V 1.75 - 2.0 V 2.5 - 3.6 V 1.75 - 2.0 V 2.5 - 3.6 V 1.75 - 2.0 V 2.5 - 3.6 V 1.75 - 2.0 V 2.5 - 3.6 V 1.75 - 2.0 V 2.5 - 3.6 V 2.7 - 3.6 V 1.75 - 2.0 V 2.5 - 3.6 V 2.7 - 3.6 V 2.7 - 3.6 V 1.75 - 2.0 V 1.75 - 2.0 V 1.75 - 2.0 V 1.75 - 2.0 V 2.7 - 3.6 V 2.7 - 3.6 V 2.7 - 3.6 V 2.7 - 3.6 V 2.7 - 3.6 V 2.7 - 3.6 V 2.7 - 3.6 V internal battery
55mA@13.8 V DC < 30 mW PSM, 1Hz < 30 mW PSM, 1Hz < 30 mW PSM, 1Hz
Patch (E) E (passive & active) E (passive & active) E (passive & active)
Dead Reckoning available when connected to a vehicle speed signal High performance GPS with over 2 million correlators Cost and size effective High level of design flexibility AEC-Q100 qualified Standard Grade Capture & Process mode Galileo ready Automotive Grade Capture & Process mode Galileo ready Embedded Automotive Dead Reckoning Capture & Process mode Galileo ready Standard Grade Smallest chip profile Capture & Process mode Precision Timing: 2 timepulse outputs (up to 10 MHz), Output timepulse with at least one satellite in view, Stationary mode for GPS timing operation, Time mark of external event inputs as above plus flash memory support RF front end dedicated to Capture & Process Worlds smallest stand-alone GPS module Standard crystal TCXO TCXO Precision Point Positioning Integrated Dead Reckoning Similar to NEO-6G, smaller package and fewer interfaces Similar to NEO-6Q smaller package and fewer interfaces Integrated antenna supply and supervisor Integrated antenna supply and supervisor Integrated antenna supply and supervisor Precision timing receiver, version with flash available GPS module with embedded stand-alone Automotive Dead Reckoning (ADR) GPS and GLONASS modes
26s 26s
<1s <1s
4 4
-40 to + 85 -40 to + 85
26s na 26s 26s 26s 26s 32s 29s 29s 29s 26s 26s 26s 26s 27s 26s <33s
<1s na <1s <1s <1s <1s <1s <1s <1s <1s <1s <1s <1s <1s <1s <1s <1s
4 na 4 5 4 4 4 4 2 2 3 3 3 3 3 3 1
-40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 -40 to + 85 20 to + 50
76 mW <50 mW PSM, 1Hz <50 mW PSM, 1Hz <50 mW PSM, 1Hz <50 mW PSM, 1Hz <50 mW PSM, 1Hz <50 mW PSM, 1Hz <50 mW PSM, 1Hz <80 mW PSM, 1Hz <80 mW PSM, 1Hz <80 mW PSM, 1Hz <80 mW PSM, 1Hz < 30 mW PSM, 1Hz <80 mW PSM, 1Hz Internal battery last 10 hours / charge
E (passive & active) E (passive & active) E (passive & active) E (passive & active) E (passive & active) E (passive & active) E (passive & active) E (passive & active) E (passive & active) E (passive & active) E (passive & active) E (passive & active) E (passive & active) E (passive & active) Active, 27 db
www.gpsworld.com
23