You are on page 1of 3

Question Paper for STU Training

Name:

Date:6/08/11

1. What is the change in the Injectors of the BSIII diesel engine to the BSII?
a) Side mounted b) Central mounted with adapters in the side c) Electronic injectors d) None of these 2. a) b) c) d) Valve cover of Cummins BSII engine is one piece two piece six piece none of these

3. Valve setting limit in Cummins BSII for intake and exhaust is


a) b) c) d) 4. a) b) c) 0.25 and 0.51 mm 0.35 and 0.51 mm 0.25 and 0.61mm 0.15 and 0.61 mm In BSIII Diagnostic software where do you click to check faults present in the engine? Read DTC Read Parameter values Read data packets

5. What is the type of FIP used in 697 Diesel BSIII Engine a) Electronic FIP b) Rotary FIP c) Inline FIP d) None of these

6. a) b) c) d)

What is the oil and filter change interval for Allison automatic Transmission? 150000,250000 Km 234000,117000 Km 342000,490000 Km 17500,50000 Km

7. What is the Initial and Refill Oil quantity of the gearbox oil? a) 23, 14 Litres b) 27, 18 Litres c) 25,17 Litres d) 26,15 Litres 8. What is the pressure in the CNG Cylinders? a) 350 bars b) 400bars c) 250 bars d) 200 bars

9. What is the function of levelling Valve? a) To maintain a constant ride height b) To maintain a constant velocity of vehicle c) To Maintain the optimum performance of vehicle d) None of Above 10) Where does air go from port no 21 in system protection valve. a) To front brake tank b) To rear brake tank c) To retarder d) To doors 11) What is the function of concept unit in the brake circuit? a) To remove oil from air b) To remove moisture from brake circuit c) To remove dirt from air circuit d) To maintain constant pressure in the system 12) What does the first position in retarder hand lever indicate? a) Constant velocity b) Full brakes c) 33% brakes d) 66% brakes 14) Which CAN line connects all ECU a) P- CAN b) M CAN c) I CAN d) C CAN 15) Where are CBCU and MUX 2B located in the vehicle a) CBCU front and MUX 2B rear b) MUX 2B front and CBCU rear c) Both in the front d) Both in the rear 16) Where is the compressor for AC located in the bus? a) On the roof b) In the engine compartment c) Under the Side panels d) None of these 17) What is the function of 3 retarder switches in the brake circuit? a) To sense the pressure and apply retarder brake proportionally b) To open the exhaust ort of retarder c) To give signal to the ECU of gearbox d) None of these 18) E Learning can be used for the purpose a) Learn about various aggregates of various models b) Self Assessment c) Both of above

d) None of these

You might also like