Professional Documents
Culture Documents
Analysis Approaches
Master/Slave Boundaries
Modes Calculator
Domain Decomposition
Overview
How It Works!!!
How It Works!!!
How It Works!!!
How It Works!!!
Embedded Element
Patterns
CST Microwave
Studio
Outline
Antenna simulation
Online demo
A small selection...
Antenna Simulation
Transient Solver
Frequency Solver
Antenna Arrays
Small Arrays
Multiple Element
Excitation
Large Arrays
Infinite Array
Infinite Array
FarfieldArray
Infinite Array
Summary
HFSS
HFSS
Create Array
If you have
Visible enabled, you
Command
can see any changes.
There is no change in the GUI for setting up the adaptive simulation for
designs with an array. However, the solution quantities of the virtual
cells will be available for convergence setup (In both adaptive and
interpolating sweep). There are no changes in the way convergence
information is presented on the Convergence tab of the Solution Display
panel.
If your design contains a virtual array, the setup can have some
differences.
Enable Solver Domains should not be checked (these are UI defined
domains, not solver defined domains).
Setup the distributed processor pool. Designs with arrays require HPC
licenses.
General Setup for Virtual Array Simulation for Matrix Convergence, if
you choose Selected Entries.
Interpolating Sweep Advanced Options for Array Simulation
Fast sweep is not supported.
Interpolating Sweep
Advanced Options for
For an Interpolating Sweep
Arrays
Advanced Options, if you select
Use Selected Entries,
Array Visualization
You can also create animations of field plots. If the plotted geometry is
controlled by a swept variable (such as plane angle or a point location) the
animation displays the correct values whereever they intersect the array
based on the designations as active cells, passive cells, or padding cells.
For post processing fields information for arrays, you can select
an arbitrary cell and do fields post processing on that cell.
The unit cell mesh from position (1,1) will be translated to the
user selected cell and fields will be plotted in the user selected
cell.